Hilux Elecrical Ewd307f

This Wiring Diagram Manual has been prepared to provide information onthe Electrical System of the HILUX.

Applicable models: RZN: 142, 144, 147, 148, 149, 1 54, 168,169,173,174,193 Series

LN: 141.145,146,147,150,152, 165,166,167,170,171,172, 191 Series

For service specifications and repair procedures of the above models otherthan those listed in this manual, refer to the following manuals;

Manual Name Pub. No.

HILUX Chassis and Body Repair Manual RM585E

1RZ, 1RZ-E, 2RZ-FE, 3RZ-F, 3RZ-FEEngine Repair Manual Supplement RM584E

2L, 2L-T, 3L, 5L Engine Repair Manual RM582E

HILUX New Car Features NCF140E

All information in this manual is based on the latest product information atthe time of publication. However, specifications and procedures are subjectto change without notice.

BACK TO MAIN MODEL IND VIEW THE MAIN INDEXEWD307Back To Electrical Index

Pages From ManualTO MODEL INDEX

FOREWORD

NOTICEWhen handling supplemental restraint system components (removal, installation orinspection, etc. ), always follow the direction given in the repair manuals listed above toprevent accidents and supplemental restraint system malfunction.

All rights reserved. This CD may not bereproduced or copied, in whole or in part,without the written permission of ToyotaMotor Corporation.

TOYOTA MOTOR CORPORATION

1997 TOYOTA MOTOR CORPORATION

3HOW TO USE THIS MANUAL B ... 4ABBREVIATIONS C ... 7RELAY LOCATIONS D ... 26ELECTRICAL WIRING ROUTING E ... 38ELECTRICAL WIRING DIAGRAM F ... 166

Pages From Manual

INTRODUCTIONNo.

A ...

Section Page

MAIN INDEX: HILUX

AUGUST 1997

TO MODEL INDEXEWD307FBACK TO MAIN FOREWORD & Electrical Index

ELECTRICAL WIRING DIAGRAM

A: INTRODUCTION

This manual consists of the following 6 sections:

Information

on connectors in the SYSTEM CIRCUITS may be looked up in the SYSTEM CIRCUITSCONNECTORS.

3

No. Section Description

INDEXA

INTRODUCTIONBrief explanation of each section.

B HOW TO USE THISMANUAL

Instructions on how to use this manual.

C ABBREVIATIONSDefines the abbreviations used in this manual.

D RELAY LOCATIONS

Shows position of the Electronic Control Unit, Relays, Relay Block, etc. This sectionis closely related to the system circuit.

E ELECTRICAL WIRINGROUTING

Describes position of the Parts Connectors, Ground points, etc. This section isclosely related to the system circuit.

INDEXIndex of the system circuits.

SYSTEM CIRCUITS Electrical circuits of each system are shown from the powersupply to the ground points, and the connection methods between related systemare shown

ELECTRICAL WIRINGDIAGRAM

F

SYSTEM CIRCUIT CONNECTORS All connector shapes, terminals and colorsincluded in the wiring diagrams are shown here, grouped according to the respectivewiring diagrams. (See the illustration below.)


BACK TO MAIN INDEX

Index of the contents of this manual.

TO MODEL INDEXEWD307F

B: HOW TO USE THIS MANUAL

F ELECTRICAL WIRING DIAGRAM (SYSTEM CIRCUITS)

4


BACK TO MAIN INDEX EWD307F

A: The same code occurring on the next page indicates that the wire harness is continuous.B: Number of the section of the system circuit (S);C: System TitleD: Indicates the wiring color. Wire colors are indicated by an alphabetical code.

B = Black L = Blue R = RedBR - Brown LG - Light Green V = VioletG = Green 0 = Orange W - WhiteGR = Gray P = Pink Y - Yellow

The first letter indicates the basic wire color and thesecond letter indicates the color of the stripe.Example: L - Y

E: Represents a part. The position of the parts is the same as shown in the system circuits and wiring routing.

F: Indicates the pin number of the connector. The numbering system is different for female and male connectors.

Example: Numbered in order Numbered in order from upper left to from upper right to lower riqht lower left

G: Indicates a Relay Block. No shading is used and only the Relay Block No. is shown to distinguish it from the J/B.

Example: CD Indicates Relay Block No. 1.

H: When 2 parts both use one connector in common, the parts connector name used in the wire routing section is shown in square brackets [ ].

- HINT:

I: Junction Block (The number in the circle is the J/B No. and the connector code is shown beside it). Junction Blocks are shaded to clearly separate them from other parts.

Example:3B indicatesthat it is insideJunction BlockNo. 3.

J: Indicates related system.

K: The left number is the number of the page and the right number is the number of the section on the system circuit.

L: Indicates the wiring harness and wiring harness connector. The wiring harness with male terminal is shown with arrows (^). Outside numerals are pin numbers.

M: ( ) is used to indicate different wiring and connector, etc. when the vehicle model, engine type, or specification is different.

N: Indicates a shielded cable.

O: Indicates a ground point.

P: Page No.

Junction connector (code: J 1 to J23) in this manual include ashort terminal which is connected to a number of wireharnesses. Always perform inspection with the short terminalinstalled. (When installing the wire harnesses, the harnessescan be connected to any position within the short terminalgrouping. Accordingly, in other vehicles, the same position inthe short terminal may be connected to a wire harness from adifferent part.) Wire harness sharing the same short terminalgrouping have the same color.

5


BACK TO CHAPTER INDEXB

EWD307F

B HOW TO USE THIS MANUALShown on this page are the connectors (wire harness side) for parts shown in the system circuits. An explanation isgiven for each item on the page.

Part code No. and Part name The part codeNo. and part name are given as in the systemcircuit, arranged in alphabetical order.The position of the parts is the same as shownin the system circuits and wiring routing.

The location indicated is the location of theapplicable part within the system circuit. (Theleft number is the number of the page and theright number is the number of the section on thesystem circuit.)

SYSTEM CIRCUIT CONNECTORS

Indicates the pin number of the connector.

Connector color These indicate that the part has more(connectors with the color not than one connector.indicated are milky white in color.)

6


BACK TO CHAPTER INDEX EWD307F

C: ABBREVIATIONS ABBREVIATIONS

The following abbreviations are used in this manual.

ABS = Anti-Lock Brake SystemA/C = Air ConditionerADD = Automatic Disconnecting DifferentialA/T = Automatic TransmissionCOMB. = CombinationDIFF. = DifferentialDLC3 = Data Link Connector3ECT = Electronically Controlled TransmissionECU = Electronic Control UnitEFI = Electronic Fuel InjectionEGR = Exhaust Gas RecirculationEVAP = Evaporative EmissionG.C.C. = Gulf Cooperation CouncilIIA = Integrated Ignition AssemblyISC = Idle Speed ControlLH = Left-HandLHD = Left-Hand DriveM/T = Manual TransmissionO/D = OverdriveRH = Right-HandRHD = Right-Hand DriveSW = SwitchTEMP. = TemperatureVSV = Vacuum Switching Valvew/ = Withw/o = Without2WD = Two Wheel Drive Vehicles4WD = Four Wheel Drive Vehicles

7


BACK TO MAIN INDEX EWD307F

D: RELAY LOCATIONS ENGINE COMPARTMENT: Pg26 1.LHD Pg26 INSTRUMENT PANEL Pg26 1.LHD Pg26 ENGINE COMPARTMENT: Pg27 1.RHD Pg27 INSTRUMENT PANEL Pg27 1.RHD Pg27 DRIVER SIDE J/B LOWER FINISH PANEL Pg28 1.LHD Pg28 DRIVER SIDE J/B INNER CIRCUIT LHD Pg29 DRIVER SIDE J/B LOWER PANEL FINISH Pg30 RHD Pg30 DRIVER SIDE J/B INNER CIRCUIT RHD Pg31 CENTER J/B NEAR THE STEERING COLUMN TUBE Pg32 RHD AUSTRALIA Pg32 CENTER J/B CIRCUIT Pg33 ENGINE ROOM R/B RHD DIESEL: ENGINE COMPARTMENT RIGHT Pg34 EXCEPT RHD DIESEL: ENGINE COMPARTMENT LEFT Pg34 ENGINE ROOM R/B RHD NO.2 DIESEL: ENGINE COMPARTMENT RIGHT Pg35 R/B NO.5 RHD: NEAR THE BRAKE MASTER CYLINDER Pg35 R/B NO.6 RADIATOR SUPPORT RH Pg36 RHD w/ DIM-DIP LIGHT Pg36


BACK TO MAIN INDEX

PASSENGER SIDE R/B COWL SIDE PANEL LH Pg36 RHD 3RZ-FE, 1RZ-E Pg36

EWD307F

D: RELAY LOCATIONS[Engine Compartment](LHD)

26


BACK TO CHAPTER INDEX

Link Continues

EWD307F

To: ST-11 ST-14 To: Sup. 2L,2L-T,3L,5L

D[Engine Compartment](RHD)

27



Link Continues

EWD307F

To: ST-11 ST-14 To: Sup. 2L,2L-T,3L,5L

D RELAY LOCATIONSDriver Side J/B Lower Finish Panel (See Page 26)



Link Continues

EWD307F

D

[Driver Side J/B Inner Circuit] [LHD]

29


BACK TO CHAPTER INDEX EWD307F

Link Continues

D RELAY LOCATIONS

Driver Side J/B (See Page 27) Lower Finish Panel



Link Continues

EWD307F

D[Driver Side J/B Inner Circuit] [RHD]

31



Link Continues

EWD307F

D RELAY LOCATIONSCenter J/B Near The Steering Column Tube (See Page 27)

[RHD Australia]

32



Link Continues

EWD307F

D[Center J/B Inner Circuit]

33


Link Continues


EWD307F

D RELAY LOCATIONSRHD Diesel : Engine Compartment Right (See Page 27)

(2) Engine RoomR/B Except RHD Diesel : Engine Compartment Left (See Page 26, 27)

34



Link Continues

EWD307F

LHD Diesel : Engine Compartment Left (See Page 26)( 4 ) Engine Room R/B No.2

RHD Diesel : Engine Compartment Right (See Page 27)

LHD: Front Right Fender Apron (See Page 26)( 5 ) R/B No.5 RHD: Near The Brake Master Cylinder (See Page 27)

35



Link Continues

DEWD307F

D RELAY LOCATIONS ( 6 ) : R/B No.6 Radiator Support RH (See Page 27)

(RHD w/ Dim-Dip Light)

( 7 ) : P assenger Side R/B Cow l Side Panel LH (See Page 27)(RHD 3RZ-FE, 1RZ-E)

36



LINK BACK 173 177 181 185 191 193 197 201 205 209 213 217 221 225 229 233 237 241 245 249253 257 263 265 269 273 279 281 285 289 293 297 303 305 309 313 317 321 325 329 333337 341 345 351 353 357 361 365 369 373 377 383 387 391 397 401

EWD307F

E: ELECTRICAL WIRING ROUTING PAGE 1 OF 3

POSITION OF PARTS IN ENGINE COMPARTMENT: 1. LHD: 2RZ-FE Pg38 2. LHD: 3RZ-F Pg42 3. LHD: 1RZ Pg46 4. LHD: 2L-T Pg50 5. LHD: 3L, 2L Pg54

POSITION OF PARTS IN INSTRUMENT PANEL: 1. LHD: INSTRUMENT PANEL 1 Pg58 2. LHD: INSTRUMENT PANEL 2 Pg62

POSITION OF PARTS IN BODY: 1. LHD: REGULAR CAB Pg66 2. LHD: DOUBLE CAB Pg70 3. LHD: EXTRA CAB Pg74

POSITION OF PARTS IN ENGINE COMPARTMENT: 1. RHD: 3RZ-FE Pg78 2. RHD: 3RZ-F Pg82 3. RHD: 1RZ-E Pg86 4. RHD: 1RZ Pg90 5. RHD: 5L Pg94 6. RHD: 2L-T Pg98 7. RHD: 3L, 2L Pg102

POSITION OF PARTS IN INSTRUMENT PANEL: 1. RHD: INSTRUMENT PANEL 1 Pg106 2. RHD: INSTRUMENT PANEL 2 Pg110

POSITION OF PARTS IN BODY: 1. RHD: REGULAR CAB Pg114 2. RHD: DOUBLE CAB Pg118 3. RHD: EXTRA CAB Pg122

LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg126 LOCATION OF GROUND POINTS Pg126 1. LHD: 2RZ-FE Pg126

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg127 LOCATION OF CONNECTOR JOINING WIRE HARNESS Pg128 LOCATION OF GROUND POINTS Pg128 1. LHD: 3RZ-F Pg128

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg129 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg130 LOCATION OF GROUND POINTS Pg130 1. LHD: 1RZ Pg130

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg131 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg132 LOCATION OF GROUND POINTS Pg132 1. LHD: 2L-T Pg132

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg133 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg134 LOCATION OF GROUND POINTS Pg134 1. LHD: 3L, 2L Pg134

BACK TO MAIN INDEXTO MODEL INDEX

Pages From ManualEWD307F

CONTINUED

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg135 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg136 1. LHD Pg136

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg137 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg138 1. LHD Pg138

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg139 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg140 LOCATION OF GROUND POINTS Pg140 1. LHD: DOUBLE CAB Pg140

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg141 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg142 LOCATION OF GROUND POINTS Pg142 1. LHD: REGULAR CAB Pg142

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg143 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg144 LOCATION OF GROUND POINTS Pg144 1. RHD: 3RZ-FE Pg144

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg145 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg146 LOCATION OF GROUND POINTS Pg146 1. RHD: 3RZ-F Pg146

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg147 LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg148LOCATION OF GROUND POINTS Pg1481. RHD: 1RZ-E Pg148

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg149LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg150LOCATION OF GROUND POINTS Pg1501. RHD: 1RZ Pg150

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg151LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg152LOCATION OF GROUND POINTS Pg1521. RHD: 5L Pg152

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg153LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg154LOCATION OF GROUND POINTS Pg1541. RHD: 2L-T Pg154

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg155LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg156LOCATION OF GROUND POINTS Pg1561. RHD: 3L, 2L Pg156

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg157LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg158

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg159LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg1601. RHD Pg160

Pages From ManualBACK TO CHAPTER INDEXTO MODEL INDEX

PAGE 2 OF 3

1. RHD Pg158LOCATION OF GROUND POINTS Pg158

EWD307F

CONTINUED

E: ELECTRICAL WIRING ROUTING

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg161LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg162LOCATION OF GROUND POINTS Pg1621. RHD: DOUBLE CAB Pg162

Pages From ManualBACK TO CHAPTER INDEXTO MODEL INDEX

PAGE 3 OF 3

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg163LOCATION OF CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg164LOCATION OF GROUND POINTS Pg164

1. RHD: REGULAR CAB Pg1642. RHD: EXTRA CAB Pg164

CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS Pg165

EWD307F

E: ELECTRICAL WIRING ROUTING

E ELECTRICAL WIRING ROUTINGPosition of Parts in Engine Compartment

[LHD:2RZ-FE] *1 : w/o ABS*2 : w/ ABS*3: Europe*4: Except Europe

38



Link Continues

EWD307F

Position of Parts in Engine Compartment

39

Code EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 8 ADD Indicator SWA 9 Air Flow MeterA 10 AlternatorA 11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWC 1 Camshaft Position SensorC 3 Check ConnectorC 4 Crankshaft Position SensorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)F 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 5 Front Turn Signal Light and Clearance Light LHF 6 Front Turn Signal Light and Clearance Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHH 1 Headlight Beam Level Control Actuator LHH 2 Headlight Beam Level Control Actuator RHH 3 Headlight Cleaner Motor and Washer MotorH 4 Headlight Cleaner RelayH 5 Headlight LHH 6 Headlight RHH 7 Heated Oxygen Sensor (Bank 1 Sensor 1)H 8 Heated Oxygen Sensor (Bank 1 Sensor 2)H 9 HornI 2 Ignition Coil and Igniter No.1I 3 Ignition Coil and Igniter No.2I 10 Injector No.1I 11 Injector No.2I 12 Injector No.3I 13 Injector No.4I 15 ISC ValveJ 1 Junction ConnectorJ 2 Junction ConnectorK 1 Knock SensorN 2 Noise Filter0 1 Oil Pressure SWS 2 StarterS 3 StarterT 1 Throttle Position SensorV 4 VSV (2WD, ADD)V 5 VSV (4WD, ADD)V 7 VSV (EGR)V 8 VSV (EVAP)

W 1 Washer MotorW 2 Water Temp. SenderW 3 Water Temp. SensorW 4 Wiper Motor



Link Continues

EEWD307F


[LHD:2RZ-FE] *1 : w/o ABS*2.: w/ ABS*3: Europe*4: Except Europe

40



Link Continues

EWD307F


Code EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 8 ADD Indicator SWA 9 Air Flow MeterA 10 AlternatorA11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWC 1 Camshaft Position SensorC 3 Check ConnectorC 4 Crankshaft Position SensorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)F 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 5 Front Turn Signal Light and Clearance Light LHF 6 Front Turn Signal Light and Clearance Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHH 1 Headlight Beam Level Control Actuator LHH 2 Headlight Beam Level Control Actuator RHH 3 Headlight Cleaner Motor and Washer MotorH 4 Headlight Cleaner RelayH 5 Headlight LHH 6 Headlight RHH 7 Heated Oxygen Sensor (Bank 1 Sensor 1)H 8 Heated Oxygen Sensor (Bank 1 Sensor 2)H 9 HornI 2 Ignition Coil and Igniter No.1I 3 Ignition Coil and Igniter No.2I 10 Injector No.1I 11 Injector No.2I 12 Injector No.3I 13 Injector No.4I 15 ISC ValveJ 1 Junction ConnectorJ 2 Junction ConnectorK 1 Knock SensorN 2 Noise FilterO 1 Oil Pressure SWS 2 StarterS 3 StarterT 1 Throttle Position SensorV 4 VSV (2WD, ADD)V 5 VSV (4WD, ADD)V 7 VSV (EGR)V 8 VSV (EVAP)W 1 Washer MotorW 2 Water Temp. SenderW 3 Water Temp. SensorW 4 Wiper Motor

41



Link Continues

EEWD307F


[LHD:3RZ-F]

42



Link Continues

EWD307F

EPosition of Parts in Engine Compartment

Code EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 10 AlternatorA 11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWC 2 CarburetorC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)F 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 5 Front Turn Signal Light and Clearance Light LHF 6 Front Turn Signal Light and Clearance Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHH 5 Headlight LHH 6 Headlight RHH 9 HornI 1 IgniterI 4 Ignition Coil No.1I 5 Ignition Coil No.2J 1 Junction ConnectorJ 2 Junction ConnectorO 1 Oil Pressure SWS 2 StarterS 3 StarterV 9 VSV (Throttle Position Control)W 1 Washer MotorW 2 Water Temp. SenderW 4 Wiper Motor

43



Link Continues

EWD307F


[LHD:3RZ-F]

44



Link Continues

EWD307F


Code EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 10 AlternatorA 11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWC 2 CarburetorC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)F 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 5 Front Turn Signal Light and Clearance Light LHF 6 Front Turn Signal Light and Clearance Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHH 5 Headlight LHH 6 Headlight RHH 9 HornI 1 IgniterI 4 Ignition Coil No.1I 5 Ignition Coil No.2J 1 Junction ConnectorJ 2 Junction Connector0 1 Oil Pressure SWS 2 Starters 3 Starterv 9 VSV (Throttle Position Control)w 1 Washer Motorw 2 Water Temp. Senderw 4 Wiper Motor

45



Link Continues

EWD307F

E ELECTRICAL WIRING ROUTING

Position of Parts in Engine Compartment[LHD:1RZ]

46



Link Continues

EWD307F


Code EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RH

A 10 AlternatorA 11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWC 2 CarburetorC3 Check ConnectorF1 Front Clearance Light LHF2 Front Clearance Light RHF3 Front Side Turn Signal Light LHF4 Front Side Turn Signal Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHH5 Headlight LHH6 Headlight RHH9 HornI6 IIAJ 1 Junction ConnectorJ 2 Junction ConnectorO1 Oil Pressure SWS 2 StarterS3 StarterV2 Vacuum SWV9 VSV (Throttle Position Control)

W 1 Washer MotorW2 Water Temp. SenderW4 Wiper Motor

47



Link Continues

EWD307F


[LHD:1RZ]

48



Link Continues

EWD307F


Code EnglishA1 A/C Dual Pressure SWA2 A/C Magnetic ClutchA4 ABS ActuatorA5 ABS ActuatorA6 ABS Speed Sensor Front LHA7 ABS Speed Sensor Front RHA10 AlternatorA11 AlternatorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWC2 CarburetorC3 Check ConnectorF1 Front Clearance Light LHF2 Front Clearance Light RHF3 Front Side Turn Signal Light LHF4 Front Side Turn Signal Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHH5 Headlight LHH6 Headlight RHH9 HornI6 IIAJ1 Junction ConnectorJ2 Junction ConnectorO1 Oil Pressure SWS2 StarterS3 StarterV2 Vacuum SWV9 VSV (Throttle Position Control) W1 Washer Motor W2 Water Temp. Sender W4 Wiper Motor

49



Link Continues

EWD307F


[LHD:2L-T]

50



Link Continues

EWD307F


Code EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 8 ADD Indicator SWA 10 AlternatorA 11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWB 3 Brake Vacuum Warning SWC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)E 2 Engine Oil Level Warning SWF 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHF 9 Fuel HeaterF 10 Fuel Sedimentary SWG 1 Glow PlugH 1 Headlight Beam Level Control Actuator LHH 2 Headlight Beam Level Control Actuator RHH 3 Headlight Cleaner Motor and Washer MotorH 4 Headlight Cleaner RelayH 5 Headlight LHH 6 Headlight RHH 9 HornI 9 Injection PumpJ 1 Junction ConnectorJ 2 Junction Connector0 1 Oil Pressure SWS 2 StarterS 3 StarterT 2 Turbo Pressure SWV 4 VSV (2WD, ADD)V 5 VSV (4WD. ADD)V 6 VSV (A/C Idle-Up)W 1 Washer MotorW 2 Water Temp. SenderW 3 Water Temp. SensorW 4 Wiper Motor

51



Link Continues

EWD307F



[LHD:2L-T]

52



Link Continues

EWD307F


Code EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 8 ADD Indicator SWA 10 AlternatorA11 AlternatorB 1 Back-Up Light SWB2 Brake Fluid Level Warning SWB 3 Brake Vacuum Warning SWC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)E 2 Engine Oil Level Warning SWF 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHF 9 Fuel HeaterF 10 Fuel Sedimentary SWG 1 Glow PlugH 1 Headlight Beam Level Control Actuator LHH 2 Headlight Beam Level Control Actuator RHH 3 Headlight Cleaner Motor and Washer MotorH 4 Headlight Cleaner RelayH 5 Headlight LHH 6 Headlight RHH 9 HornI 9 Injection PumpJ 1 Junction ConnectorJ 2 Junction Connector0 1 Oil Pressure SWS 2 StarterS 3 StarterT 2 Turbo Pressure SWV 4 VSV (2WD, ADD)V 5 VSV (4WD, ADD)V 6 VSV (A/C Idle-Up)W 1 Washer MotorW 2 Water Temp. SenderW 3 Water Temp. SensorW 4 Wiper Motor

53



Link Continues

EWD307F


[LHD:3L,2L]

54



Link Continues

EWD307F

Fuel Heater

G 1 Glow Plug

S 2 Starter

S 3 StarterST-50

ST-50

To: Sup. 2L,2L-T,3L,5L


Code EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 A 7 ABS Speed Sensor Front LH ABS Speed Sensor Front RHA 10 AlternatorA 11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWB 3 Brake Vacuum Warning SWC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)E 2 Engine Oil Level Warning SWF 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 5 Front Turn Signal Light and Clearance Light LHF 6 Front Turn Signal Light and Clearance Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHF 9F 10 Fuel Sedimentary SWG 1 Glow PlugH 1 Headlight Beam Level Control Actuator LHH 2 Headlight Beam Level Control Actuator RHH 3 Headlight Cleaner Motor and Washer MotorH 4 Headlight Cleaner RelayH 5 Headlight LHH 6 Headlight RHH 9 HornI 9 Injection PumpJ 1 Junction ConnectorJ 2 Junction Connector0 1 Oil Pressure SWP 1 Pick-Up SensorS 2 StarterS 3 StarterV 4 VSV (2WD, ADD)V 5 VSV (4WD. ADD)V 6 VSV (A/C Idle-Up)W 1 Washer MotorW 2 Water Temp. SenderW 3 Water Temp. SensorW 4 Wiper Motor

55



Link Continues

EWD307F

Fuel Heater


[LHD:3L,2L]

56



Link Continues

EWD307F


Code EnglishA1 A/C Dual Pressure SWA2 A/C Magnetic ClutchA4 ABS ActuatorA6 ABS ActuatorA6 ABS Speed Sensor Front LHA7 ABS Speed Sensor Front RHA10 AlternatorA11 AlternatorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWB3 Brake Vacuum Warning SWC3 Check ConnectorD1 Detection SW (Transfer 4WD Position)D2 Detection SW (Transfer L4 Position)E2 Engine Oil Level Warning SWF1 Front Clearance Light LHF2 Front Clearance Light RHF3 Front Side Turn Signal Light LHF4 Front Side Turn Signal Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHF9 Fuel HeaterF10 Fuel Sedimentary SWG1 Glow PlugH1 Headlight Beam Level Control Actuator LHH2 Headlight Beam Level Control Actuator RHH3 Headlight Cleaner Motor and Washer MotorH4 Headlight Cleaner RelayH5 Headlight LHH6 Headlight RHH9 HornI9 Injection PumpJ1 Junction ConnectorJ2 Junction ConnectorO1 Oil Pressure SWP1 Pick-Up SensorS2 StarterS3 StarterV4 VSV (2WD. ADD)V5 VSV (4WD, ADD)V6 VSV (A/C Idle-Up) W1 Washer Motor W2 Water Temp. Sender W3 Water Temp. Sensor W4 Wiper Motor

57



Link Continues

EWD307F

E ELECTRICAL WIRING ROUTINGPosition of Parts in Instrument Panel

[LHD: lnstrument Panel 1]

58

1 :2-Door



Link Continues

EWD307F

EPosition of Parts in Instrument Panel

Code EnglishA13 A/C AmplifierA 14 A/C SWA 15 A/C ThermistorA 16 A/C Volume SWA 17 ABS Deceleration SensorA 18 ABS ECUA 19 ABS ECUA 20 ADD Control RelayA 21 Airbag Sensor AssemblyA 22 Airbag Sensor AssemblyA 23 Airbag Sensor AssemblyA 24 Airbag Squib (Front Passenger's Airbag Assembly)A 25 Airbag Squib (Steering Wheel Pad)A 26 Ashtray IlluminationB 4 Blower MotorB 5 Blower ResistorB 6 Blower SWC 5 Cigarette LighterC 6 Cigarette Lighter IlluminationC 7 Circuit Opening RelayC 8 ClockC 9 Combination MeterC 10 Combination MeterC 11 Combination MeterC 12 Combination SWC 13 Combination SWC 14 Combination SWD 3 Daytime Running Light RelayD 4 Diff. Lock ECUD 5 Diff. Lock SWD 7 Diode (Door Courtesy)D 8 Diode (Glow Plug)D 10 DLC3D 11 Door Courtesy SW Front LHD 12 Door Courtesy SW Front RH

59



Link Continues

EWD307F


[LHD:lnstrument Panel 1]

60



Link Continues

EWD307F


Code EnglishA13 A/C AmplifierA 14 A/C SWA 15 A/C ThermistorA 16 A/C Volume SWA 17 ABS Deceleration SensorA 18 ABS ECUA 19 ABS ECUA 20 ADD Control RelayA 21 Airbag Sensor AssemblyA 22 Airbag Sensor AssemblyA 23 Airbag Sensor AssemblyA 24 Airbag Squib (Front Passenger's Airbag Assembly)A 26 Airbag Squib (Steering Wheel Pad)A 26 Ashtray IlluminationB 4 Blower MotorB 5 Blower ResistorB 6 Blower SWC 5 Cigarette LighterC 6 Cigarette Lighter IlluminationC 7 Circuit Opening RelayC 8 ClockC 9 Combination MeterC 10 Combination MeterC 11 Combination MeterC 12 Combination SWC 13 Combination SWC14 Combination SWD 3 Daytime Running Light RelayD 4 Diff. Lock ECUD 5 Diff. Lock SWD 7 Diode (Door Courtesy)D 8 Diode (Glow Plug)D10 DLC3D11 Door Courtesy SW Front LHD12 Door Courtesy SW Front RH

61



Link Continues

EWD307F



62



Link Continues

EWD307F


Code EnglishE3 Emission Control ECUE4 Engine ECUE5 Engine ECUE6 Engine ECUG2 Glove Box LightH10 Hazard SWH11 Headlight Beam Level Control SWH12 Headlight Cleaner SWI16 Ignition Key Cylinder LightI17 Ignition SWI18 Integration RelayI19 Integration RelayJ3 Junction ConnectorJ4 Junction ConnectorJ5 Junction ConnectorJ6 Junction ConnectorJ7 Junction ConnectorJ8 Junction ConnectorJ9 Junction ConnectorJ10 Junction ConnectorJ11 Junction ConnectorJ12 Junction ConnectorJ13 Junction ConnectorJ14 Junction ConnectorJ15 Junction ConnectorJ16 Junction ConnectorJ17 Junction ConnectorJ18 Junction ConnectorJ19 Junction ConnectorJ20 Junction ConnectorJ21 Junction Connector

J22 Junction ConnectorJ23 Junction ConnectorP2 Parking Brake SWP3 Pre-Heating TimerR1 Radio and PlayerR3 Rear Fog Light SWR4 Rear Window Defogger SWS4 Stop Light SWU1 Unlock Warning SW

63



Link Continues

EWD307F



64



Link Continues

EWD307F


Code EnglishE 3 Emission Control ECUE 4 Engine ECUE 5 Engine ECUE 6 Engine ECUG 2 Glove Box LightH10 Hazard SWH11 Headlight Beam Level Control SWH 12 Headlight Cleaner SW16 Ignition Key Cylinder Light17 Ignition SW18 Integration Relay19 Integration RelayJ 3 Junction ConnectorJ 4 Junction ConnectorJ 5 Junction ConnectorJ 6 Junction ConnectorJ 7 Junction ConnectorJ 8 Junction ConnectorJ 9 Junction ConnectorJ 10 Junction ConnectorJ 11 Junction ConnectorJ 12 Junction ConnectorJ 13 Junction ConnectorJ 14 Junction ConnectorJ 15 Junction ConnectorJ 16 Junction ConnectorJ 17 Junction ConnectorJ 18 Junction ConnectorJ 19 Junction ConnectorJ 20 Junction ConnectorJ 21 Junction ConnectorJ 22 Junction Connector123 Junction ConnectorP 2 Parking Brake SWP 3 Pre-Heating TimerR 1 Radio and PlayerR 3 Rear Fog Light SWR 4 Rear Window Defogger SWS 4 Stop Light SWU 1 Unlock Warning SW

65



Link Continues

EWD307F


[LHD:Regular Cab]Position of Parts in Body

*1 : w/ Vent Window*2 : w/o Vent Window

66



Link Continues

EWD307F

EPosition of Parts in Body

Code EnglishA 28 ABS Speed Sensor Rear LHA29 ABS Speed Sensor Rear RHB 7 Buckle SWD 13 Detection SW (Rear Diff. Lock)D 16 Door Key Lock and Unlock SWD 17 Door Lock Control SWD 18 Door Lock Motor Front LHD 19 Door Lock Motor Front RHD 22 Door Speaker Front LHD 23 Door Speaker Front RHF 12 Fuel PumpF 13 Fuel Sender1 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 6 Power Window Control SW Front RHP 9 Power Window Master SWP 10 Power Window Motor Front LHP 11 Power Window Motor Front RHP 14 Pretensioner LHP 15 Pretensioner RHR 6 Rear Combination Light LHR 7 Rear Combination Light RHR 8 Rear Diff. Lock MotorR 9 Rear Fog LightR 12 Remote Control Mirror LHR 13 Remote Control Mirror RHR 14 Remote Control Mirror SW

67



Link Continues

EWD307F

E ELECTRICAL WIRING ROUTINGPosition of Parts in Body

[LHD:Regular Cab] *1 : w/ Vent Window*2 : w/o Vent Window

68



Link Continues

EWD307F


Code EnglishA 28 ABS Speed Sensor Rear LHA 29 ABS Speed Sensor Rear RHB 7 Buckle SWD13 Detection SW (Rear Diff. Lock)D 16 Door Key Lock and Unlock SWD17 Door Lock Control SWD18 Door Lock Motor Front LHD 19 Door Lock Motor Front RHD22 Door Speaker Front LHD23 Door Speaker Front RHF 12 Fuel PumpF 13 Fuel SenderI 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 6 Power Window Control SW Front RHP 9 Power Window Master SWP 10 Power Window Motor Front LHP 11 Power Window Motor Front RHP 14 Pretensioner LHP 15 Pretensioner RHR 6 Rear Combination Light LHR 7 Rear Combination Light RHR 8 Rear Diff. Lock MotorR 9 Rear Fog LightR 12 Remote Control Mirror LHR 13 Remote Control Mirror RHR 14 Remote Control Mirror SW

69



Link Continues

EWD307F


[LHD:Double Cab] *1 : General*2: Except General*3 : w/ Vent Window*4 : w/o Vent Window

70



Link Continues

EWD307F


Code EnglishA 28 ABS Speed Sensor Rear LHA 29 ABS Speed Sensor Rear RHB 7 Buckle SWD 11 Door Courtesy SW Front LHD 12 Door Courtesy SW Front RHD 13 Detection SW (Rear Diff. Lock)D 14 Door Courtesy SW Rear LHD 15 Door Courtesy SW Rear RHD 16 Door Key Lock and Unlock SWD 17 Door Lock Control SWD 18 Door Lock Motor Front LHD 19 Door Lock Motor Front RHD 20 Door Lock Motor Rear LHD 21 Door Lock Motor Rear RHD 22 Door Speaker Front LHD 23 Door Speaker Front RHF 12 Fuel PumpF 13 Fuel SenderI 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 4 Personal LightP 6 Power Window Control SW Front RHP 7 Power Window Control SW Rear LHP 8 Power Window Control SW Rear RHP 9 Power Window Master SWP 10 Power Window Motor Front LHP 11 Power Window Motor Front RHP 12 Power Window Motor Rear LHP 13 Power Window Motor Rear RHP 14 Pretensioner LHP 15 Pretensioner RHR 6 Rear Combination Light LHR 7 Rear Combination Light RHR 8 Rear Diff. Lock MotorR 9 Rear Fog LightR 10 Rear Window DefoggerR 11 Rear Window DefoggerR 12 Remote Control Mirror LHR 13 Remote Control Mirror RHR 14 Remote Control Mirror SWR 15 Reverse Warning BuzzerS 5 Seat Heater (Driver's Seat)S 6 Seat Heater (Front Passenger's Seat)S 7 Seat Heater SW (Driver's Seat)S 8 Seat Heater SW (Front Passenger's Seat)

71



Link Continues

EWD307F


[LHD:Double Cab]*1 : General*2 : Except General*3 : w/ Vent Window*4 : w/o Vent Window

72



Link Continues

EWD307F


Code EnglishA 28 ABS Speed Sensor Rear LHA 29 ABS Speed Sensor Rear RHB 7 Buckle SWD11 Door Courtesy SW Front LHD12 Door Courtesy SW Front RHD13 Detection SW (Rear Diff. Lock)D14 Door Courtesy SW Rear LHD15 Door Courtesy SW Raar RHD16 Door Key Lock and Unlock SWD17 Door Lock Control SWD18 Door Lock Motor Front LHD19 Door Lock Motor Front RHD20 Door Lock Motor Rear LHD21 Door Lock Motor Rear RHD22 Door Speaker Front LHD23 Door Speaker Front RHF 12 Fuel PumpF 13 Fuel Sender1 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 4 Personal LightP 6 Power Wndow Control SW Front RHP 7 Power Window Control SW Rear LHP 8 Power W ndow Control SW Rear RHP 9 Power W ndow Master SWP 10 Power W ndow Motor Front LHP 11 Power W ndow Motor Front RHP 12 Power W ndow Motor Rear LHP 13 Power W ndow Motor Rear RHP14 Pretensioner LHP 16 Pretensioner RHR 6 Rear Combination Light LHR 7 Rear Combination Light RHR 8 Rear Diff. Lock MotorR 9 Rear Fog LightR 10 Rear Window DefoggerR 11R 12

Rear Window Defogger Remote Control Mirror LH

R13 Remote Control Mirror RHR 14 Remote Control Mirror SWR 15 Reverse Warning BuzzerS 5 Seat Heater (Driver's Seat)S6 Seat Heater (Front Passenger's Seat)S 7 Seat Heater SW (Driver's Seat)S 8 Seat Heater SW (Front Passenger's Seat)

73



Link Continues

EWD307F


[LHD:Extra Cab] *1 : w/ Vent Window*2 : w/o Vent Window

74



Link Continues

EWD307F


Code EnglishA28 ABS Speed Sensor Rear LHA29 ABS Speed Sensor Rear RHD16 Door Key Lock and Unlock SWD17 Door Lock Control SWD18 Door Lock Motor Front LHD19 Door Lock Motor Front RHD22 Door Speaker Front LHD23 Door Speaker Front RHF12 Fuel PumpF13 Fuel SenderI20 Interior LightL1 License Plate Light LHL2 License Plate Light RHP6 Power Window Control SW Front RHP9 Power Window Master SWP10 Power Window Motor Front LHP11 Power Window Motor Front RHP14 Pretensioner LHP15 Pretensioner RHR6 Rear Combination Light LHR7 Rear Combination Light RHR9 Rear Fog LightR10 Rear Window DefoggerR11 Rear Window DefoggerR12 Remote Control Mirror LHR13 Remote Control Mirror RHR14 Remote Control Mirror SWR15 Reverse Warning BuzzerS5 Seat Heater (Driver's Seat)S6 Seat Heater (Front Passenger's Seat)S7 Seat Heater SW (Driver's Seat)S8 Seat Heater SW (Front Passenger's Seat)

75



Link Continues

EWD307F


Position of Parts in Body

[LHD: Extra Cab] * 1 : w/ Vent Window*2 : w/o Vent Window

76



Link Continues

EWD307F


Code EnglishA28 ABS Speed Sensor Rear LHA29 ABS Speed Sensor Rear RHD16 Door Key lock and Unlock SWD17 Door Lock Control SWD18 Door Lock Motor Front LHD19 Door Lock Motor Front RHD22 Door Speaker Front LHD23 Door Speaker Front RHF12 Fuel PumpF13 Fuel SenderI20 Interior LightL1 License Plate Light LHL2 License Plate Light RHP6 Power Window Control SW Front RHP9 Power Window Master SWP10 Power Window Motor Front LHP11 Power Window Motor Front RHP14 Pretensioner LHP15 Pretensioner RHR6 Rear Combination Light LHR7 Rear Combination Light RHR9 Rear Fog LightR10 Rear Window DefoggerR11 Rear Window DefoggerR12 Remote Control Mirror LHR13 Remote Control Mirror RHR14 Remote Control Mirror SWR15 Reverse Warning BuzzerS5 Seat Heater (Driver's Seat)S 6 Seat Heater (Front Passenger's Seat)S 7 Seat Heater SW (Driver's Seat)S8 Seat Heater SW (Front Passenger's Seat)

77



LINK BACK 173 177 181 185 191 193 197 201 205 209 213 217 221 225 229 233 237 241 245 249253 257 263 267 269 273 279 281 285 289 293 297 303 305 309 313 317 321 325 329333 337 341 345 351 353 357 361 365 369 373 377 383 387 391 397 401

EWD307F


[RHD:3RZ-FE] *1 : w/ 2-4 Select SW*2 : w/o 2-4 Select SW

78



Link Continues

EWD307F


Code EnglishA1 A/C Dual Pressure SWA2 A/C Magnetic ClutchA3 A/T Fluid Temp. SWA4 ABS ActuatorA5 ABS ActuatorA6 ABS Speed Sensor Front LHA7 ABS Speed Sensor Front RHA8 ADD Indicator SWA9 Air Flow MeterA10 AlternatorA11 AlternatorA12 Auto Antenna MotorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWC1 Camshaft Position SensorC3 Check ConnectorC4 Crankshaft Position SensorD1 Detection SW (Transfer 4WD Position)D2 Detection SW (Transfer L4 Position)E1 ECT SolenoidF1 Front Clearance Light LHF2 Front Clearance Light RHF3 Front Side Turn Signal Light LHF4 Front Side Turn Signal Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHH5 Headlight LHH6 Headlight RHH9 HornI2 Ignition Coil and Igniter No.1I3 Ignition Coil and Igniter No.2I10 Injector No.1I11 Injector No.2I12 Injector No.3I13 Injector No.4I15 ISC ValveJ1 Junction ConnectorJ2 Junction ConnectorK1 Knock SensorN1 Neutral Start SWN2 Noise FilterO1 Oil Pressure SWS1 Speed Sensor (ECT)S2 StarterS3 StarterT1 Throttle Position SensorT3 2-4 Select MotorV3 Variable ResistorV4 VSV (2WD. ADD)V5 VSV (4WD ADD)V8 VSV (EVAP)W1 Washer MotorW2 Water Temp. SenderW3 Water Temp. SensorW4 Wiper Motor

79



Link Continues

EWD307F


Position of Parts in Engine Compartment[RHD:3RZ-FE] *1 : w/ 2-4 Select SW

*2 : w/o 2-4 Select SW

80



Link Continues

EWD307F


Code EnglishA 1 A/C Dual Pressure SW A2 A/C Magnetic Clutch A3 A/T Fluid Temp. SW A4 ABS Actuator A5 ABS Actuator A6 ABS Speed Sensor Front LH A7 ABS Speed Sensor Front RH A8 ADD Indicator SW A9 Air Flow MeterA10 AlternatorA11 AlternatorA12 Auto Antenna MotorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWC1 Camshaft Position SensorC3 Check ConnectorC4 Crankshaft Position SensorD1 Detection SW (Transfer 4WD Position)D2 Detection SW (Transfer L4 Position)E1 ECT SolenoidF1 Front Clearance Light LHF2 Front Clearance Light RHF3 Front Side Turn Signal Light LHF4 Front Side Turn Signal Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHH5 Headlight LHH6 Headlight RHH9 HornI2 Ignition Coil and Igniter No.1I3 Ignition Coil and Igniter No.2I10 Injector No.1I11 Injector No.2I12 Injector No.3I13 Injector No.4I15 ISC ValveJ1 Junction ConnectorJ2 Junction ConnectorK1 Knock SensorN1 Neutral Start SWN2 Noise FilterO1 Oil Pressure SWS1 Speed Sensor (ECT)S2 StarterS3 StarterT1 Throttle Position SensorT3 2-4 Select MotorV3 Variable ResistorV4 VSV (2WD, ADD)V5 VSV (4WD ADD)V8 VSV (EVAP)W1 Washer MotorW2 Water Temp. SenderW3 Water Temp. SensorW4 Wiper Motor

81



Link Continues

EWD307F



[RHD:3RZ-F]

82



Link Continues

EWD307F


Code EnglishA1 A/C Dual Pressure SWA2 A/C Magnetic ClutchA3 AlternatorA4 AlternatorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWC2 CarburetorD1 Detection SW (Transfer 4WD Position)F1 Front Clearance Light LHF2 Front Clearance Light RHF3 Front Side Turn Signal Light LHF4 Front Side Turn Signal Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHH5 Headlight LHH6 Headlight RHH9 HornI1 IgniterI4 Ignition Coil No.1I5 Ignition Coil No.2J1 Junction ConnectorJ2 Junction ConnectorO1 Oil Pressure SWS2 StarterS3 StarterV9 VSV (Throttle Position Control)W1 Washer MotorW2 Water Temp, SenderW4 Wiper Motor

83



Link Continues

EWD307F


[RHD:3RZ-F]

84



Link Continues

EWD307F


Code EnglishA1 A/C Dual Pressure SWA2 A/C Magnetic ClutchA10 AlternatorA11 AlternatorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWC2 CarburetorD1 Detection SW (Transfer 4WD Position)F1 Front Clearance Light LHF2 Front Clearance Light RHF3 Front Side Turn Signal Light LHF4 Front Side Turn Signal Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHH5 Headlight LHH6 Headlight RHH9 HornI1 IgniterI4 Ignition Coil No.1I5 Ignition Coil No.2J1 Junction ConnectorJ2 Junction ConnectorO1 Oil Pressure SWS2 StarterS3 StarterV9 VSV (Throttle Position Control)W1 Washer MotorW2 Water Temp. SenderW4 Wiper Motor

85



Link Continues

EWD307F


[RHD:1RZ-E]

88



Link Continues

EWD307F


Code EnglishA1 A/C Dual Pressure SWA2 A/C Magnetic ClutchA4 ABS ActuatorA5 ABS ActuatorA6 ABS Speed Sensor Front LHA7 ABS Speed Sensor Front RHA10 AlternatorA11 AlternatorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWC3 Check ConnectorF1 Front Clearance Light LHF2 Front Clearance Light RHF3 Front Side Turn Signal Light LHF4 Front Side Turn Signal Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHH5 Headlight LHH6 Headlight RHH9 HornI6 IIAI7 IIAI8 In-Air Temp. SensorI10 Injector No.1I11 Injector No.2I12 Injector No.3I13 Injector No.4J1 Junction ConnectorJ2 Junction ConnectorN2 Noise FilterO1 Oil Pressure SWS2 StarterS3 StarterT1 Throttle Position SensorV1 Vacuum SensorV3 Variable ResistorV6 VSV (A/C Idle-Up)W1 Washer MotorW2 Water Temp. SenderW3 Water Tamp. SensorW4 Wiper Motor

89



Link Continues

EWD307F


[RHD:1RZ]

90



Link Continues

EWD307F


Code EnglishA1 A/C Dual Pressure SWA2 A/C Magnetic ClutchA10 AlternatorA11 AlternatorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWC2 CarburetorF1 Front Clearance Light LHF2 Front Clearance Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHH5 Headlight LHH6 Headlight RHH9 HornI6 IIAJ1 Junction ConnectorJ2 Junction ConnectorO1 Oil Pressure SWS2 StarterS3 StarterV2 Vacuum SWV9 VSV (Throttle Position Control)W1 Washer MotorW2 Water Temp. SenderW4 Wiper Motor

91



Link Continues

EWD307F


[RHD:1RZ]

92



Link Continues

EWD307F


Code EnglishA1 A/C Dual Pressure SWA2 A/C Magnetic ClutchA10 AlternatorA11 AlternatorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWC2 CarburetorF1 Front Clearance Light LHF2 Front Clearance Light RHF5 Front Turn Signal Light and Clearance Light LHF6 Front Turn Signal Light and Clearance Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHH5 Headlight LHH6 Headlight RHH9 HornI6 IIAJ1 Junction ConnectorJ2 Junction ConnectorO1 Oil Pressure SWS2 StarterS3 StarterV2 Vacuum SWV9 VSV (Throttle Position Control)W1 Washer MotorW2 Water Temp. SenderW4 Wiper Motor

93



Link Continues

EWD307F


[RHD:5L] *1 : w/ 2-4 Select SW*2 : w/o 2-4 Select SW

94



Link Continues

EWD307F


Code EnglishA 1 A/C Dual Pressure SWA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 8 ADD Indicator SWA 0 AlternatorA 1 AlternatorA 2 Auto Antenna MotorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWB 3 Brake Vacuum Warning SWC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)F 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 5 Front Turn Signal Light and Clearance Light LHF 6 Front Turn Signal Light and Clearance Light RHF' 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHF 10 Fuel Sedimentary SWG 1 Glow PlugH 5 Headlight LHH .6 Headlight RHH 9 HornI 9 Injection PumpI 14 Intake ShutterJ 1 Junction ConnectorJ 2 Junction Connector0 1 Oil Pressure SWS 2 StarterS 3 StarterT 3 2-4 Select MotorV 4 VSV (2WD. ADD)V 5 VSV (4WD, ADD)


95



Link Continues

EWD307F



[RHD:5L] *1 : w/ 2-4 Select SW*2 : w/o 2-4 Select SW

96



Link Continues

EWD307F


Code EnglishA 1 A/C Dual Pressure SWA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 8 ADD Indicator SWA 10 AlternatorA 11 AlternatorA 12 Auto Antenna MotorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWB 3 Brake Vacuum Warning SWC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)F 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 5 Front Turn Signal Light and Clearance Light LHF 6 Front Turn Signal Light and Clearance Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHF 10 Fuel Sedimentary SWG 1 Glow PlugH 5 Headlight LHH 6 Headlight RHH 9 Horn1 9 Injection PumpI 14 Intake ShutterJ 1 Junction ConnectorJ 2 Junction Connector0 1 Oil Pressure SWS 2 StarterS 3 StarterT 3 2-4 Select MotorV 4 VSV (2WD. ADD)V 5 VSV (4WD, ADD)W 1 Washer MotorW 2 Water Temp, SenderW 3 Water Temp. SensorW 4 Wiper Motor

97



Link Continues

EWD307F



[RHD:2L-T]

98



Link Continues

EWD307F


Code EnglishA 1 A/C Dual Pressure SWA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 10 AlternatorA 11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWB 3 Brake Vacuum Warning SWC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)D 2 Detection SW (Transfer L4 Position)E 2 Engine Oil Level Warning SWF 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHF 9 Fuel HeaterF 10 Fuel Sedimentary SWG 1 Glow PlugH 5 Headlight LHH 6 Headlight RHH 9 HornI 9 Injection PumpJ 1 Junction ConnectorJ 2 Junction Connector0 1 Oil Pressure SWS 2 StarterS 3 StarterT 2 Turbo Pressure SWW 1 Washer MotorW 2 Water Temp. SenderW 3 Water Temp. SensorW 4 Wiper Motor

99



Link Continues

EWD307F


Position of Parts in Engine Compartment[RHD:2L-T]

100



Link Continues

EWD307F


Code EnglishA1 A/C Dual Pressure SWA4 ABS ActuatorA5 ABS ActuatorA6 ABS Speed Sensor Front LHA7 ABS Speed Sensor Front RHA10 AlternatorA11 AlternatorB1 Back-Up Light SWB2 Brake Fluid Level Warning SWB3 Brake Vacuum Warning SWC3 Check ConnectorD1 Detection SW (Transfer 4WD Position)D2 Detection SW (Transfer L4 Position)E2 Engine Oil Level Warning SWF1 Front Clearance Light LHF2 Front Clearance Light RHF3 Front Side Turn Signal Light LHF4 Front Side Turn Signal Light RHF7 Front Turn Signal Light LHF8 Front Turn Signal Light RHF9 Fuel HeaterF10 Fuel Sedimentary SWG1 Glow PlugH5 Headlight LHH6 Headlight RHH9 HornI9 Injection PumpJ1 Junction ConnectorJ2 Junction ConnectorO1 Oil Pressure SWS2 StarterS3 StarterT2 Turbo Pressure SWW1 Washer MotorW2 Water Temp. SenderW3 Water Temp. SensorW4 Wiper Motor

101



Link Continues

EWD307F



[RHD:3L,2L]

102



Link Continues

EWD307F

Fuel Heater

G 1 Glow Plug

S 2: Starter

S 3: Starter

To: Sup. 2L,2L-T,3L,5L


Code EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 10 AlternatorA 11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWB 3 Brake Vacuum Warning SWC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)E 2 Engine Oil Level Warning SWF 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 5 Front Turn Signal Light and Clearance Light LHF 6 Front Turn Signal Light and Clearance Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHF 9 Fuel HeaterF 10 Fuel Sedimentary SWG 1 Glow PlugH 5 Headlight LHH 6 Headlight RHH 9 HornI 9 Injection PumpJ 1 Junction ConnectorJ 2 Junction Connector0 1 Oil Pressure SWS 2 StarterS 3 StarterV 6 VSV (A/C Idle-Up)


103



Link Continues

EWD307F


Position of Parts in Engine Compartment[RHD:3L,2L]

104



Link Continues

EWD307F

EPosition of Parts in Engine CompartmentCode EnglishA 1 A/C Dual Pressure SWA 2 A/C Magnetic ClutchA 4 ABS ActuatorA 5 ABS ActuatorA 6 ABS Speed Sensor Front LHA 7 ABS Speed Sensor Front RHA 10 AlternatorA11 AlternatorB 1 Back-Up Light SWB 2 Brake Fluid Level Warning SWB 3 Brake Vacuum Warning SWC 3 Check ConnectorD 1 Detection SW (Transfer 4WD Position)E 2 Engine Oil Level Warning SWF 1 Front Clearance Light LHF 2 Front Clearance Light RHF 3 Front Side Turn Signal Light LHF 4 Front Side Turn Signal Light RHF 5 Front Turn Signal Light and Clearance Light LHF 6 Front Turn Signal Light and Clearance Light RHF 7 Front Turn Signal Light LHF 8 Front Turn Signal Light RHF 9 Fuel HeaterF 10 Fuel Sedimentary SWG 1 Glow PlugH 5 Headlight LHH 6 Headlight RHH 9 HornI 9 Injection PumpJ 1 Junction ConnectorJ 2 Junction Connector0 1 Oil Pressure SWS 2 StarterS 3 StarterV 6 VSV (A/C Idle-Up)W 1 Washer MotorW 2 Water Temp. SenderW 3 Water Temp. SensorW 4 Wiper Motor

105



Link Continues

EWD307F


Position of Parts in Instrument Panel

[RHD:lnstrument Panel 1] *1 :2-Door

106



Link Continues

EWD307F

EPosition of Parts in Instrument PanelCode EnglishA 13 A/C AmplifierA 14 A/C SWA 15 A/C ThermistorA 16 A/C Volume SWA 17 ABS Deceleration SensorA 18 ABS ECUA 19 ABS ECUA 20 ADD Control RelayA 21 Airbag Sensor AssemblyA 22 Airbag Sensor AssemblyA 23 Airbag Sensor AssemblyA 24 Airbag Squib (Front Passenger's Airbag AssemblyA 25 Airbag Squib (Steering Wheel Pad)A 26 Ashtray IlluminationA 27 Auto Antenna Control RelayB 4 Blower MotorB 5 Blower ResistorB 6 Blower SWC 5 Cigarette LighterC 6 Cigarette Lighter IlluminationC 8 ClockC 9 Combination MeterC 10 Combination MeterC 11 Combination MeterC 12 Combination SWC 13 Combination SWC 14 Combination SWD 6 Dim-Dip Light RelayD 7 Diode (Door Courtesy)D 8 Diode (Glow Plug)D 9 Diode (Idle-Up)D 10 DLC3D 11 Door Courtesy SW Front LHD 12 Door Courtesy SW Front RH

107



Link Continues

EWD307F


Position of Parts in Instrument Panel[RHD:lnstrument Panel 1] *1 :2-Door

108



Link Continues

EWD307F


Code EnglishA13 A/C AmplifierA 14 A/C SWA 15 A/C ThermistorA 16 A/C Volume SWA 17 ABS Deceleration SensorA 18 ABS ECUA 19 ABS ECUA 20 ADD Control RelayA 21 Airbag Sensor AssemblyA 22 Airbag Sensor AssemblyA 23 Airbag Sensor AssemblyA 24 Airbag Squib (Front Passenger's Airbag Assembly)A 25 Airbag Squib (Steering Wheel Pad)A 26 Ashtray IlluminationA 27 Auto Antenna Control RelayB 4 Blower MotorB 5 Blower ResistorB 6 Blower SWC 5 Cigarette LighterC 6 Cigarette Lighter IlluminationC 8 ClockC 9 Combination MeterC 10 Combination MeterC 11 Combination MeterC 12 Combination SWC 13 Combination SWC 14 Combination SWD 6 Dim-Dip Light RelayD 7 Diode (Door Courtesy)D 8 Diode (Glow Plug)D 9 Diode (Idle-Up)D 10 DLC3D 11 Door Courtesy SW Front LHD 12 Door Courtesy SW Front RH

109



Link Continues

EWD307F


Position of Parts in Instrument Panel[RHD:lnstrument Panel 2]

110



Link Continues

EWD307F


Code EnglishE 3 Emission Control ECUE 4 Engine ECU (M/T) or Engine and ECT ECU (A/T)E 5 Engine ECU (M/T) or Engine and ECT ECU (A/T)E 6 Engine ECU (M/T) or Engine and ECT ECU (A/T)F 11 4WD Control ECUG 2 Glove Box LightH 10 Hazard SWI 16 Ignition Key Cylinder LightI 17 Ignition SWI 18 Integration RelayI 19 Integration RelayJ 3 Junction ConnectorJ 4 Junction ConnectorJ 5 Junction Conn ctorJ 6 Junction Conn ctorJ 7 Junction Conn ctorJ 8 Junction Conn ctorJ 9 Junction Conn ctorJ 10 Junction Conn ctorJ 11 Junction Conn ctorJ 12 Junction ConnectorJ 13 Junction ConnectorJ 14 Junction ConnectorJ 15 Junction ConnectorJ 16 Junction ConnectorJ 17 Junction ConnectorO 2 O/D Main SWP 2 Parking Brake SWP 3 Pre-Heating TimerR 1 Radio and PlayerR 2 Radio and PlayerR 3 Rear Fog Light SWR 4 Rear Window Defogger SWR 5 RheostatS 4 Stop Light SWT 4 2-4 Select SW

111



Link Continues

EWD307F


Position of Parts in Instrument Panel[RH D: Instrument Panel 2]

112



Link Continues

EWD307F


Code EnglishE3 Emission Control ECUE4 Engine ECU (M/T) or Engine and ECT ECU (A/T)E5 Engine ECU (M/T) or Engine and ECT ECU (A/T)E6 Engine ECU (M/T) or Engine and ECT ECU (A/T)F11 4WD Control ECUG2 Glove Box LightH10 Hazard SWI16 Ignition Key Cylinder LightI17 Ignition SWI18 Integration RelayI19 Integration RelayJ3 Junction ConnectorJ4 Junction ConnectorJ5 Junction ConnectorJ6 Junction ConnectorJ7 Junction ConnectorJ8 Junction ConnectorJ9 Junction ConnectorJ10 Junction ConnectorJ11 Junction ConnectorJ12 Junction ConnectorJ13 Junction ConnectorJ14 Junction ConnectorJ15 Junction ConnectorJ16 Junction ConnectorJ17 Junction ConnectorO2 O/D Main SWP2 Parking Brake SWP3 Pre-Heating TimerR1 Radio and PlayerR2 Radio and PlayerR3 Rear Fog Light SWR4 Rear Window Defogger SWR5 RheostatS4 Stop Light SWT4 2-4 Select SW

113



Link Continues

EWD307F


Position of Parts in Body

[RHD:Regular Cab]

114



Link Continues

EWD307F


Code EnglishA 28 ABS Speed Sensor Rear LHA 29 ABS Speed Sensor Rear RHD 16 Door Key Lock and Unlock SWD 17 Door Lock Control SWD 18 Door Lock Motor Front LHD 19 Door Lock Motor Front RHD 22 Door Speaker Front LHD 23 Door Speaker Front RHF 12 Fuel PumpF 13 Fuel SenderI 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 14 Pretensioner LHP 15 Pretensioner RHR 6 Rear Combination Light LHR 7 Rear Combination Light RHR 9 Rear Fog Light

115



Link Continues

EWD307F


Position of Parts in Body[RHD:Regular Cab]

116



Link Continues

EWD307F


Code EnglishA 28 ABS Speed Sensor Rear LHA 29 ABS Speed Sensor Rear RHD16 Door Key Lock and Unlock SWD 17 Door Lock Control SWD 18 Door Lock Motor Front LHD 19 Door Lock Motor Front RHD22 Door Speaker Front LHD23 Door Speaker Front RHF 12 Fuel PumpF 13 Fuel SenderI 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 14 Pretensioner LHP 15 Pretensioner RHR 6 Rear Combination Light LHR 7 Rear Combination Light RHR 9 Rear Fog Light

117



Link Continues

EWD307F


Position of Parts in Body[RHD:Double Cab] *1:General

*2:Except

118



Link Continues

EWD307F


Code EnglishA 28 ABS Speed Sensor Rear LHA 29 ABS Speed Sensor Rear RHD 11 Door Courtesy SW Front LHD 12 Door Courtesy SW Front RHD 14 Door Courtesy SW Rear LHD 15 Door Courtesy SW Rear RHD 16 Door Key Lock and Unlock SWD 17 Door Lock Control SWD 18 Door Lock Motor Front LHD 19 Door Lock Motor Front RHD 20 Door Lock Motor Rear LHD 21 Door Lock Motor Rear RHD 22 Door Speaker Front LHD 23 Door Speaker Front RHD 24 Door Speaker Rear LHD 25 Door Speaker Rear RHF 12 Fuel PumpF 13 Fuel SenderI 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 5 Power Window Control SW Front LHP 7 Power Window Control SW Rear LHP 8 Power Window Control SW Rear RHP 9 Power Window Master SWP 10 Power Window Motor Front LHP 11 Power Window Motor Front RHP 12 Power Window Motor Rear LHP 13 Power Window Motor Rear RHP 14 Pretensioner LHP 15 Pretensioner RHR 6 Rear Combination Light LHR 7 Rear Combination Light RHR 9 Rear Fog LightR 10 Rear Window DefoggerR 11 Rear Window DefoggerR 12 Remote Control Mirror LHR 13 Remote Control Mirror RHR 14 Remote Control Mirror SWR 15 Reverse Warning Buzzer

119



Link Continues

EWD307F


Position of Parts in Body[RHD:Double Cab] *1:General

*2:Except General

120



Link Continues

EWD307F

EPosition of Parts in BodyCode EnglishA 28 ABS Speed Sensor Rear LHA 29 ABS Speed Sensor Rear RHD 11 Door Courtesy SW Front LHD12 Door Courtesy SW Front RHD 14 Door Courtesy SW Rear LHD 15 Door Courtesy SW Rear RHD 16 Door Key Lock and Unlock SWD17 Door Lock Control SWD 18 Door Lock Motor Front LHD 19 Door Lock Motor Front RHD20 Door Lock Motor Rear LHD21 Door Lock Motor Rear RHD22 Door Speaker Front LHD23 Door Speaker Front RHD24 Door Speaker Front LHD25 Door Speaker Front RHF 12 Fuel PumpF 13 Fuel SenderI 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 5 Power Window Control SW Front LHP 7 Power Window Control SW Rear LHP 8 Power Window Control SW Rear RHP 9 Power Window Master SWP 10 Power Window Motor Front LHP 11 Power Window Motor Front RHP 12 Power Window Motor Rear LHP 13 Power Window Motor Rear RHP 14 Pretensioner LHP 15 Pretensioner RHR 6 ear Combination Light LHR 7 ear Combination Light RHR 9 ear Fog LightR 10 ear Window DefoggerR 11 ear Window DefoggerR 12 emote Control Mirror LHR 13 emote Control Mirror RHR 14 emote Control Mirror SWR 15 Reverse Warning Buzzer

121



Link Continues

EWD307F


Position of Parts in Body[RHD:Extra Cab]

122



Link Continues

EWD307F


Code EnglishA 28 ABS Speed Sensor Rear LHA 29 ABS Speed Sensor Rear RHD 16 Door Key Lock and Unlock SWD 17 Door Lock Control SWD 18 Door Lock Motor Front LHD 19 Door Lock Motor Front RHD 22 Door Speaker Front LHD 23 Door Speaker Front RHF 12 Fuel PumpF 13 Fuel SenderI 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 14 Pretensioner LHP 15 Pretensioner RHR 6 Rear Combination Light LHR 7 Rear Combination Light RHR 10 Rear Window DefoggerR 11 Rear Window Defogger

123



Link Continues

EWD307F


Position of Parts in Body[RHD:Extra Cab]

124



Link Continues

EWD307F


Code EnglishA 28 ABS Speed Sensor Rear LHA 29 ABS Speed Sensor Rear RHD 16 Door Key Lock and Unlock SWD17 Door Lock Control SWD 18 Door Lock Motor Front LHD 19 Door Lock Motor Front RHD22 Door Speaker Front LHD23 Door Speaker Front RHF 12 Fuel PumpF 13 Fuel SenderI 20 Interior LightL 1 License Plate Light LHL 2 License Plate Light RHP 14 Pretensioner LHP 15 Pretensioner RHR 6 Rear Combination Light LHR 7 Rear Combination Light RHR 10 Rear Window DefoggerR 11 Rear Window Defogger

125



LINK BACK 173 177 181 185 191 193 197 201 205 209 213 217 221 225 229 233 237 241 245 249253 257 263 265 269 273 279 281 285 289 293 297 303 305 309 313 317 321 325 329333 337 341 345 351 353 357 361 365 369 373 377 383 387 391 397 401

EWD307F


: Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points

[LHD:2RZ-FE]

126



Link Continues

EWD307F

EConnector Joining Wire Harness and Wire Harness

Code Joining Wire Harness and Wire Harness (Connector Location)

EA1 Engine Room No. 2 Wire and Engine Room Main Wire (Front Right Fender Apron)

EB1EB2

Engine No. 2 Wire and Engine Room Main Wire (Near the Engine Room R/B)

EC1 Engine No. 2 Wire and Differential Wire (Near the Starter)

127



Link Continues

EWD307F


: Location of Connector Joining Wire Harness and Wire Harness: Location of Ground Points

[LHD:3RZ-F]

128



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)EA1 Engine Room No. 2 Wire and Engine Room Main Wire (Front Right Fender Apron)EB1 Engine No. 2 Wire and Engine Room Main Wire (Near the Engine Room R/B)

129



Link Continues

EWD307F



[LHD:1RZ]

130



Link Continues

EWD307F



131



Link Continues

EWD307F



[LHD:2L-T]

132



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)EA1 Engine Room No. 2 Wire and Engine Room Main Wire (Front Right Fender Apron)EB2 Engine No. 2 Wire and Engine Room Main Wire (Near the Engine Room R/B)EC1 Engine No. 2 Wire and Differential Wire (Near the Starter)EE1 Engine Room Main Wire and Engine Wire (Near the Engine Room R/B)EF1 Engine Room Main Wire and Engine No. 4 Wire (Near the Alternator)

133



Link Continues

EWD307F



[LHD:3L,2L]

134



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)EA1 Engine Room No. 2 Wire and Engine Room Main Wire (Front Right Fender Apron)ED1 Cowl Wire and A/C Sub Wire (Front Right Fender Apron)EE1 Engine Room Main Wire and Engine Wire (Near the Engine Room R/B)EF1 Engine Room Main Wire and Engine No. 4 Wire (Near the Alternator)EF2 Engine No. 4 Wire and Engine Room Main Wire (Near the Alternator)

135



Link Continues

EWD307F



[LHD]

136



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)IA1IA2

Engine Room Main Wire and Cowl Wire (Cowl Side Panel LH)

IR1IB2

Front Door LH Wire and Cowl Wire (Lett Kick Panel)

IC1IC2

Cowl Wire and Cowl No. 3 Wire (Lett Kick Panel)

ID1 Cowl Wire and Cowl No. 4 Wire (Instrument Panel Reinforcement Left)IE1 Cowl Wire and Roof Wire (Instrument Panel Reinforcement Left)IF1 Cowl No. 4 Wire and Cowl Wire (Instrument Panel Brace RH)IG1 Cowl Wire and A/C Sub Wire (Near the A/C Unit)

137



Link Continues

EWD307F


: Location of Connector Joining Wire Harness and Wire Harness[LHD]

138



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)IH1 Cowl Wire and Cowl No. 4 Wire (Instrument Panel Brace RH)II1 Cowl Wire and Cowl No. 3 Wire (Behind the Ashtray)IJ1IJ2IJ3IJ4IJ5

Engine Wire and Cowl Wire (Behind the Glove Box)

IK1 Engine Room No. 2 Wire and Cowl No. 3 Wire (Behind the Glove Box)IL1IL2

Front Door RH Wire and Cowl Wire (Right Kick Panel)

IM1 Cowl Wire and Cowl No. 3 Wire (Cowl Side Panel RH)

139



Link Continues

EWD307F



[LHD:Double Cab]

140



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)BA1 Front Door LH Wire and Front Door LH Wire (Front LH Door Inside)BB1 Front Door RH Wire and Front Door RH Wire (Front RH Door Inside)BC1BC2

Frame Wire and Cowl Wire (Under the Front Passenger's Seat)

BD1 Frame Wire and Cowl No. 3 Wire (Under the Front Passenger's Seat)BE1 Frame Wire and Differential Wire (Near the No. 5 Cross Member)BF1 Frame Wire and Speed Sensor Wire (Near the No. 5 Cross Member)BGl Rear Door No. 2 Wire and Cowl Wire (Left Center Pillar)BH1 Rear Door No. 1 Wire and Cowl Wire (Right Center Pillar)

141



Link Continues

EWD307F

E ELECTRICAL WIRING ROUTING: Location of Connector Joining Wire Harness and Wire Harness: Location of Ground Points

[LHD:Regular Cab]

[LHD: Extra Cab]

142



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)BA1 Front Door LH Wire and Front Door LH Wire (Front LH Door Inside)BB1 Front Door RH Wire and Front Door RH Wire (Front RH Door Inside)BC1BC2

Frame Wire and Cowl Wire (Under the Front Passenger's Seat)

BD1 Frame Wire and Cowl No. 3 Wire (Under the Front Passenger's Seat)BE1 Frame Wire and Differential Wire (Near the No. 5 Cross Member)BF1 Frame Wire and Speed Sensor Wire (Near the No. 5 Cross Member)

143



LINK BACK 173 177 181 185 191 193 197 201 205 209 213 217 221 225 229 233 237 241 245 249253 257 263 265 269 273 279 281 285 289 293 297 303 305 309 313 317 321 325 329333 337 341 345 351 353 357 361 365 369 373 377 383 387 391 397 401

EWD307F



[RHD:3RZ-FE]

144



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)EA1 Engine Room No. 2 Wire and Engine Room Main Wire (Front Right Fender Apron)EB1 Engine No. 2 Wire and Engine Room Main Wire (Near the Engine Room R/B)EC1 Engine No. 2 Wire and Cowl Wire (Near the Engine Room R/B)ED1 Engine No. 2 Wire and Differential Wire (Near the Starter)

145



Link Continues

EWD307F



[RHD:3RZ-F]

146



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)EB1 Engine No. 2 Wire and Engine Room Main Wire (Near the Engine Room R/B)

147



Link Continues

EWD307F



[RHD:1RZ-E]

148



Link Continues

EWD307F



149



Link Continues

EWD307F



[RHD:1RZ]

150



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)EB1 Engine No. 2 Wire and Engine Room Main Wire (Near the Engine Room R/B)

151



Link Continues

EWD307F



[RHD:5L]

152



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)EA1 Engine Room No. 2 Wire and Engine Room Main Wire (Front Right Fender Apron)EB2 Engine Room Main Wire and Engine Wire (Near the Engine Room R/B)EC1 Engine No. 2 Wire and Cowl Wire (Near the Engine Room R/B)ED1 Engine No. 2 Wire and Differential Wire (Near the Starter)EF1 Engine No. 4 Wire and Engine Room Main Wire (Near the Alternator)

153



Link Continues

EWD307F



[RHD:2L-T]

154



Link Continues

EWD307F


ode Joining Wire Harness and Wire Harness (Connector Location)EA1 Engine Room No. 2 Wire and Engine Room Main Wire (Front Right Fender Apron)EB2 Engine Room Main Wire and Engine Wire (Near the Engine Room R/B)EF2 Engine Room Main Wire and Engine No. 4 Wire (Near the Alternator)

155



Link Continues

EWD307F



[RHD:3L,2L]

156



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)EA1 Engine Room No. 2 Wire and Engine Room Main Wire (Front Right Fender Apron)EB2 Engine Room Main Wire and Engine Wire (Near the Engine Room R/B)EE1 Engine Room Main Wire and A/C Sub Wire (Near the Battery)EF1 Engine No. 4 Wire and Engine Room Main Wire (Near the Alternator)EF2 Engine Room Main Wire and Engine No. 4 Wire (Near the Alternator)

157



Link Continues

EWD307F



[RHD]

158



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)IA1IA2

Cowl Wire and Cowl No. 3 Wire (Left Kick Panel)

IB1IB2

Front Door LH Wire and Cowl Wire (Left Kick Panel)

IC1IC2IC3IC4IC5IC6

Engine Wire and Cowl Wire (Behind the Glove Box)

ID1 Cowl Wire and A/C Sub Wire (Near the A/C Unit)

159



Link Continues

EWD307F


: Location of Connector Joining Wire Harness and Wire Harness[RHD]

160



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)IE1 Cowl No. 4. Wire and Cowl Wire (Instrument Panel Brace LH)IF1 Cowl Wire and Cowl No. 4 Wire (Instrument Panel Brace LH)IG1 Cowl Wire and Cowl No. 3 Wire (Behind the Ashtray)IH1 Cowl Wire and Roof Wire (Instrument Reinforcement Right)II1 Cowl Wire and Cowl No. 3 Wire (Instrument Reinforcement Right)IJ1 Engine Room Main Wire and Cowl Wire (Cowl Side Panel RH)

IK1 Engine Room No. 2 Wire and Cowl No. 3 Wire (Cowl Side Panel RH)

IL1 Cowl Wire and Cowl No. 3 Wire (Right Kick Panel)

IM1IM2

Front Door RH Wire and Cowl Wire (Right Kick Panel)

161



Link Continues

EWD307F



[RHD:Double Cab]

162



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)BA1 Frame Wire and Cowl Wire (Under the Driver's Seat)BB1 Frame Wire and Cowl No. 3 Wire (Under the Driver's Seat)BC1 Frame Wire and Speed Sensor Wire (Near the No. 5 Cross Member)BD1 Rear Door LH Wire and Cowl Wire (Left Center Pillar)BE1 Rear Door RH Wire and Cowl Wire (Right Center Pillar)

163



Link Continues

EWD307F



[RHD:Regular Cab]

[RHD:Extra Cab]

164



Link Continues

EWD307F


Code Joining Wire Harness and Wire Harness (Connector Location)BA1 Frame Wire and Cowl Wire (Under the Driver's Seat)BB1 Frame Wire and Cowl No. 3 Wire (Under the Driver's Seat)BC1 Frame Wire and Speed Sensor Wire (Near the No. 5 Cross Member)

165



LINK BACK 173 177 181 185 191 193 197 201 205 209 213 217 221 225 229 233 237 241 245 249253 257 263 265 269 273 279 281 285 289 293 297 303 305 309 313 317 321 325 329333 337 341 345 351 353 357 361 365 369 373 377 383 387 391 397 401

EWD

Documents

Hilux Elecrical Ewd307f