service manual elecrical wiring diagrams

Embed Size (px)

Citation preview

  • 8/13/2019 service manual elecrical wiring diagrams

    1/76

    SERVICE MANUAL

    ELECTRICAL WIRING DIAGRAMS

    Supplement

    http://cover.pdf/
  • 8/13/2019 service manual elecrical wiring diagrams

    2/76

    LANCER

    EVOLUTION VIII

    MR

    FOREWARD

    This manual contains information about the mainchanges in the 2004 Lancer Evolution VIII MR.It only covers those points that are different from theprevious model. Therefore, when inspecting orrepairing electrical parts, this manual should be used inconjunction with the related documents listed on thefollowing pages, if necessary.This manual contains various different types of wiringdiagrams and circuit diagrams, but it should beremembered that these may not always coincide withthe exact specifications of each individual vehicle.This manual is based on the vehicle specifications as ofFebruary 2004.Please note that future vehicles may not match thecontents of this manual completely, due to changes inspecifications, or the like.The units shown in this manual are the standardinternational SI units. Conventional units are notincluded.

    February 2004

    MITSUBISHI MOTOR CORPORATION

    General

    Wiring Diagrams

    Component Installation Positions

    Circuit Diagrams

    1

    2

    3

    0

    This manual is printed on recycled paper

    Any opinions, requests, or questions concerning thismanual, should be written on the Servicing Comments

    Form at the end, and sent to us by fax.

    CONTENTS

  • 8/13/2019 service manual elecrical wiring diagrams

    3/76

    Related documentation

    Cautionary Note regarding servicing of vehicles fitted with SRS airbags and/or seatbelts withpre-tensioner systems.Warnings:1. Incorrect inspection or servicing of a component part of the SRS airbag system or seatbelt pre-tensioner system, or

    a part relating to these systems, may cause accidental operation (deployment) of the SRS airbag or seatbelt pre-tensioners, or may cause these systems to be disabled, leading in either case the risk of serious injury.

    2. If parts may be affected by heat during painting operations, then those parts must be removed in advance. Thisapplies to the SRS-ECU, airbag modules (drivers sear and front passengers seat), clock springs, front impactsensors, side impact sensors, and pre-tensioner seatbelts. 93C or above : SRS-ECU, airbag modules (drivers sear and front passengers seat), clock springs, front impact

    sensors, side impact sensors 90C or above : Pre-tensioner seatbelts

    3. The component parts of the SRS airbag system or seatbelt pre-tensioner system, and parts relating to thesesystems, must always be inspected and serviced by a Mitsubishi dealer.

    4. Service personnel must read the relevant service manuals (particularly, Section 52B SRS Airbags) carefully andthoroughly, before inspecting or servicing the component parts of the SRS airbag system or seatbelt pre-tensionersystem, and parts relating to these systems.

    Title of Document No. Date ofIssue

    Title of Document No. Date ofIssue

    Body Manuals (Service Manual) Mirage, Lancer (supplement) Lancer Cedia Lancer Cedia (supplement) Lancer Evolution VII(supplement) Lancer Cedia (supplement) Lancer (supplement) Lancer Evolution VIII MR(supplement)

    1036F521036K501036K51

    1036K521036K531036K54

    1036K55

    Aug 1996May 2000July 2000

    May 2001Oct 2001Feb 2003

    Feb 2004

    Electrical Wiring DiagramsService Manual Lancer Evolution VIII 1036K77 Jan 2003

    New Vehicle Manuals Mirage, Lancer Mirage, Lancer Mirage, Lancer Mirage, Lancer Mirage Mirage, Lancer Lancer Lancer Lancer Cedia Lancer Cedia Lancer Evolution VII Lancer Cedia Lancer Cedia Lancer Evolution VII Lancer Cedia Lancer Evolution VIII

    Lancer Lancer Lancer Evolution VIII MR

    1036F301036F311036F321036F331036F341036F351036F361036F371036K301036K311036K321036K331036K341036K351036K361036K37

    1036K381036K391036K40

    Oct 1995Jan 1996Aug 1996Jul 1997Jan 1998Oct 1998Jan 1999Dec 1999May 2000July 2000Jan 2001May 2001Oct 2001Jan 2002May 2002Jan 2003

    Feb 2003Dec 2003Feb 2004

    Engine Service Manual

    4G6 Engine 4G6 Engine (supplement)

    1039G461039G63

    Jan 2001Jan 2003

    Service Manuals Lancer Cedia Lancer Cedia (supplement) Lancer Evolution VII(supplement) Lancer Cedia (supplement) Lancer Cedia (supplement) Lancer Evolution VII(supplement)

    Lancer Cedia (supplement) Lancer Evolution VIII(supplement) Lancer (supplement) Lancer (supplement) Lancer Evolution VIII MR(supplement)

    1036K001036K011036K02

    1036K031036K041036K05

    1036K061036K07

    1036K081036K091036K10

    May 2000July 2000Jan 2001

    May 2001Oct 2001Jan 2002

    May 2002Jan 2003

    Feb 2003Dec 2003Feb 2004

    Transmission Service Manual W5M51 Manual Transmission W5M51 Manual Transmission(supplement) W6MAA Manual Transmission

    1039M171039M22

    1039M23

    Jan 2001Jan 2003

    Jan 2003

  • 8/13/2019 service manual elecrical wiring diagrams

    4/76

    0-1

    SECTION 0

    GENERAL INFORMATIONCONTENTS

    Vehicle Identification ..............................0-2

    Implementation Code .............................0-2

    Details of Changes .................................0-2Wiring Diagrams ................................................0-2Component Installation Positions ......................0-2Circuit Diagrams ................................................0-3

    List of Circuit Diagrams.........................0-5

  • 8/13/2019 service manual elecrical wiring diagrams

    5/76

    GENERAL INFORMATION - VEHICLE IDENTIFICATION0-2

    Modelcode

    Classcode

    2004code

    Grade Engine model Transmissionmodel

    Fuelsupplysystem

    GH-CT9A SNDFZ ! RS W5M51(4WD, 5M/T)

    SJDFZ ! RSSJGFZ ! GSR

    4G63 (2000DOHC 16-valve

    intercooler turbo) W6MAA(4WD, 6M/T)

    MPI

    ConnectorCode

    Name Page Details of Change

    B Engine transmission p.1-2 Due to changes in the engine control system, thename of the wastegate solenoid valve (B-30) hasbeen changed to wastegate solenoid valve 1, andan additional wastegate solenoid valve 2 (B-32) hasbeen added. The 4WD-ECU (C-37, 38) has been moved fromthe instrument panel harness to the control harness. With the removal of the DVD-MMCS, the followingconnectors have been removed. Multi-centre display (C-11, 12) Navigation unit (C-47)The immobiliser ECU (C-54) has also been removed,due to changes in the engine immobiliser system.

    C Instrument panel p.1-4

    With the removal of the DVD-MMCS, the followingconnectors have been removed. Audio unit (C-102) Hazard switch (C-105)

    F Boot interior p.1-6 Spare connector (F-28) added.

    Changed part Page Details of changeECU p.2-2 With changes in the engine immobiliser system, the

    installation position of the immobiliser ECU has beenchanged.

    Solenoid valve p.2-2 With the addition of the wastegate solenoid valve 2, anew installation point has been provided.

    VEHICLE IDENTIFICATIONM3000000100845

    Note: denotes a continued model

    IMPLEMENTATION CODEM3000001000584

    GH-CT9A ; CT9A-0300001 ~

    DETAILS OF CHANGESWiring diagrams

    M3000003000159

    Component installation positionsM3000004000141

  • 8/13/2019 service manual elecrical wiring diagrams

    6/76

    GENERAL INFORMATION - DETAILS OF CHANGES 0-3

    Main circuit Name of circuit Page Details of changeJ/C - p.3-2 Partial changes to circuit and

    destination system names in J/C(1) (6)

    - With the introduction of manual air conditioning, the circuit used by the

    fusible link No.2 has been changed. Wastegate solenoid valve 2 added to

    load of special fuse No.3. Rating of special fuse No.10 changed

    from 15A to 20A.Power supply - p.3-10 Partial changes to destination system

    names. Earth No.13 added. Rating of special fuse No.10 changed

    from 15A to 20A. Partial changes to circuit details, due

    to removal of sunroof.Engine control - p.3-16 Rating of special fuse No.10 changed

    from 15A to 20A. Earth No.13 added. Some changes to circuit, due to

    addition of wastegate solenoid valve2 (B-32).

    Partial changes, due to removal of DVD-MMCS

    Lighting Interior lights, boot interior light, ignition key cylinder illumination light, door notclosed indicator light

    - Change to terminal number in J/C(2)(C-119) on line linking ETACS anddiagnosis connector. (No.1 " No.5)

    Reversing lights - Change to terminal number in J/C(2)(C-119) on line linking reversing lightand rear combination light (LH).

    (No.18 " No.19)

    Signal

    Stop lights p.3-24 Spare connector (F-28) added, andcircuit partially changed.

    Meters / Gauges -MetersRemaining fuel warninglight, oil pressure warninglight, brake warning light,seatbelt warning light

    - Change to terminal number in J/C(1)

    (C-07) on line inking J/B (general fuseNo.18) and combination meter. (No.4" No.8)

    Change to terminal number in J/C(4)(C-110) on line linking combinationmeter and fuel gauge unit (sub).(No.20 " No.21)

    Door openingcontrol

    Electric windows - Change to terminal number in J/C(2)(C-119) on line linking power windowmain switch and diagnosis connector.(No.12 " No.14)

    Fully automatic air conditioning

    - Change to terminal number in J/C(1)(C-07) on line linking J/B (generalfuse No. 18) and A/C-ECU. (No.6 "No.4)

    Change to terminal number in J/C(5)(C-06) on line linking A/C-ECU anddiagnosis connector. (No.8 " No.9)

    Air conditioning

    Manual air conditioning p.3-26 With the adoption of manual air conditioning, a new circuit has beeninstalled.

    Windscreen wipers andwashers

    -Safety andvisibility

    Electric retractable remotecontrol door mirrors -

    Change to terminal number in J/C(2)(C-119) on line linking ETACS and

    diagnosis connector. (No.1 " No.5)

    Circuit diagramsM3000004500157

  • 8/13/2019 service manual elecrical wiring diagrams

    7/76

    GENERAL INFORMATION - DETAILS OF CHANGES0-4

    Main circuit Name of circuit Page Details of changeSpare Audio connectors - Change to terminal number in J/C(1)

    (C-07) on line inking J/B (general fuseNo.18) and spare audio connector.(No.3 " No.7)

    Accessories

    Clock - Change to terminal number in J/C(1)(C-07) on line inking J/B (general fuseNo.18) and clock. (No.2 " No.6)

    SpecialEquipment

    ABS p.3-32

    ACD (Vehicles not fitted with AYC)

    p.3-40

    Circuit changed due to change inbranching point of connector for 4WD-ECU (C-37) (C-38) (frominstrument panel harness to controlharness).

    J/C(6) (C-23) added between ABS-ECU and 7 th terminal of junctionconnector (C-20) between instrumentpanel harness and control harness.

    J/C(6) (C-23) added between ABS-ECU and 22 nd terminal of junctionconnector (C-22) between instrument

    panel harness and control harness. ACD, AYC p.3-48 Circuit changed due to change inbranching point of connector for 4WD-ECU (C-37) (C-38) (frominstrument panel harness to controlharness).

    Earth No.13 added J/C(6) (C-23) added between 4WD-

    ECU and 7 th terminal of junctionconnector (C-20) between instrumentpanel harness and control harness.

    J/C(6) (C-23) added between 4WD-ECU and 22 nd terminal of junctionconnector (C-22) between instrumentpanel harness and control harness.

    Intercooler water spray - Change to terminal number in J/C(1)(C-07). (No.12 " No.21).

    Engine immobiliser system p.3-58 Partial changes due to removal of DVD-MMCS.

    Partial changes to circuit, due tochange in installation point of immobiliser ECU.

    Spare general connectors - Change to terminal numbers in J/C(1)(C-07) on line linking J/B (generalfuse No.18) / special fuse No.15, and

    general spare connectors. (No.7 "No.5), (No.21 " No.12).

  • 8/13/2019 service manual elecrical wiring diagrams

    8/76

    GENERAL INFORMATION - LIST OF CIRCUIT DIAGRAMS 0-5

    Main circuit Name of Circuit Circuit DiagramJ/B - !J/C - #Central junction - #Power supply - #Start up - !Ignition - !Charging - !Engine control - #Coolant - !

    Headlights (excluding discharge type ) !Headlight ( discharge type) !Tail lights, side lights, licence plate lights, lighting monitor warning buzzer

    !

    Cabin lights, boot interior light, ignition key cylinder illumination light, door not closed indicator light *2

    !

    Fog lights !

    Lighting

    Headlight levelling system !Indicator lights, hazard warning lights !Reversing lights *2 !Stop lights #

    Signalling

    Horn !Meters / Gauges *2 !MetersRemaining fuel warning light, oil pressure warning light,brake warning light, seatbelt warning light *2

    !

    Electric windows *2 !Central door locking (vehicle not fitted with keyless entry) !

    Door opening control

    Central door locking (vehicle fitted with keyless entry) !Heater !Fully automatic air conditioning !

    Air conditioning

    Manual air conditioning #

    List of Circuit DiagramsM3000006000169

    Notes:1. This list of circuit diagrams indicates whether each circuit has been modified or added.2. The symbol indicates a circuit that has been modified or added. Diagrams for these circuits are included inthis supplement.3. The symbol indicates a circuit that is unchanged. Details of these circuits can be found in the existingElectrical Wiring Diagram manual (03-1 No.1036K77).4. The X symbol indicates a circuit that is unrelated to the vehicle referred to in this manual.5. The *1 symbol marks circuits whose names have been changed the previous names.6. The *2 symbol marks circuits whose J/C terminal numbers have changed. For more information, please referto the Details of Changes table above.

  • 8/13/2019 service manual elecrical wiring diagrams

    9/76

  • 8/13/2019 service manual elecrical wiring diagrams

    10/76

    1-1

    SECTION 1

    WIRING DIAGRAMSCONTENTS

    Engine transmission ..............................1-2 Instrument panel.....................................1-4

    Boot interior ............................................1-6

  • 8/13/2019 service manual elecrical wiring diagrams

    11/76

    WIRING DIAGRAMS - ENGINE TRANSMISSION1-2

    ENGINE TRANSMISSIONM3010000400494

    B-01 (1-black) Engine oil pressure switchB-02 (1) AlternatorB-03 (4-grey) AlternatorB-04 (1) StarterB-05 (1-black) StarterB-06 (4-black) Throttle position sensor

    B-07 (2-black) Purge control solenoid valveB-08 (7-black) Airflow sensorB-12 (5-grey) Windscreen wiper motorB-13X (1) Engine speed detection connectorB-14X (5) Starter relayB-17X (4) Ignition coil relay

    Connectorsymbol -

    B -01 -32

    AC311230AB

    Control harness

    Battery harness

  • 8/13/2019 service manual elecrical wiring diagrams

    12/76

    WIRING DIAGRAMS - ENGINE TRANSMISSION 1-3

    B-19X (4) Engine control relayB-20X (4) A/C compressor relayB-21 (10-black) Junction between control harness and

    battery harnessB-25 (4-black) O 2 sensorB-26 (2-black) Indicator 4B-27 (2-black) Indicator 3B-28 (2-black) Indicator 2B-29 (2-black) Indicator 1

    (2-grey) Wastegate solenoid valve 1B-31 (6-black) Junction between control harness andtransmission harness

    (2-grey) Wastegate solenoid valve 2

    Note : Boxed connector numbers indicateconnectors with changed names, or new,additional connectors.

    B-32

    B-32

    Earth cable

    Transmission harness

    AC311231AB

  • 8/13/2019 service manual elecrical wiring diagrams

    13/76

    WIRING DIAGRAMS - INSTRUMENT PANEL1-4

    INSTRUMENT PANEL

    C-01 (4) Register (vehicle not fitted with full autoA/C)

    C-02 (2-red) Front pass. seat airbag module (squib)C-03 (7) Internal / external air changeover damper

    motorC-04 (7) Junction between instrument panel

    harness and A/C harness (vehicle notfitted with full auto A/C)(13) Junction between instrument panel

    harness and A/C harness (vehicle fittedwith full auto A/C)

    C-05 (2) Air thermo sensor (vehicle fitted with fullauto A/C)

    C-06 (13) J/C (5)C-07 (22-grey) J/C (1)C-08 (6) Air mix door motor and potentiometer

    (vehicle with full auto A/C)C-09 (2) Heater water temperature sensor (vehicle

    with full auto A/C)C-10 (5) Blower outlet changeover damper motor

    & potentiometer (vehicle with full autoA/C)

    C-13 (4) ClockC-14 (4) Hazard switchC-15 (6) Blower switch

    (vehicle not fitted with full auto A/C)C-16 (12-black) Heater control unit

    (vehicle with heater) or A/C-ECU

    (vehicle with manual A/C)C-17 (20-black) A/C-ECU (vehicle with full auto A/C)C-18 (16-black) A/C-ECU (vehicle with full auto A/C)C-20 (22-blue) Junction between instrument panel

    harness and control harnessC-21 (10-grey) Junction between instrument panel

    harness and control harnessC-22 (25) Junction between instrument panel

    harness and control harness

    Connectorsymbol

    Front passengers side

    Instrument panel harness

    Tweeter sub-harness

    Frontharness (LH)

    Front doorharness (LH)

    Floor

    harness (LH)

    A/C harness

    Controlharness

  • 8/13/2019 service manual elecrical wiring diagrams

    14/76

    WIRING DIAGRAMS - INSTRUMENT PANEL 1-5

    C-23 (33) J/C (6)C-28 (2) Blower motor

    (Vehicle not fitted with full auto A/C)(6) Blower pulse controller

    (Vehicle fitted with full auto A/C)C-29 (13) Junction between instrument panel

    harness & floor harness (LH)C-30 (11-grey*) Junction between instrument panelharness & floor harness (LH)

    C-31 (25) Junction between instrument panelharness & front harness (LH)

    C-32 (3) Junction between instrument panelharness & front harness (LH)

    C-33 (16) Junction between instrument panelharness & front door harness (LH)

    C-34 (16) Junction between control harness & frontharness (LH)

    (22) 4WD-ECU

    (26) 4WD-ECUC-43 (1-grey) Junction between control harness and

    floor harness (LH)C-44 (2) Junction between instrument panel

    harness and tweeter sub-harnessC-45 (2) Tweeter (LH)

    C-49 (35-grey) Engine ECUC-50 (28-grey) Engine ECUC-51 (30-grey) Engine ECUC-55 (2) Spare connector

    Note : A connector colour marked * indicates the male connector.

    The female connector is black. Boxed connector numbers indicate connectors in harness

    routes that have been changed.

    C-38

    C-37

  • 8/13/2019 service manual elecrical wiring diagrams

    15/76

    WIRING DIAGRAMS - BOOT INTERIOR1-6

    BOOT INTERIOR

    F-01 (2) Boot interior lightF-02 (2-grey) High-mount stop lightF-05 (4) Rear wiper motorF-06 (2) Rear speaker (RH)F-07 (1) Demister (+)F-10 (6-black) Rear combination light (RH)F-11 (1) Book interior light switchF-12 (2-grey) Licence plate light (RH)F-13 (2-grey) Licence plate light (LH)F-14 (2-grey) Junction between floor harness (LH) &

    bumper harnessF-15 (6-black) Rear combination light (LH)F-16 (2) Rear speaker (LH)

    F-18 (1-black) Demister (-)F-19 (2) Windscreen washer motor

    F-20 (2-green) Rear washer motorF-21 (2-black) Electrical pumpF-22 (8-grey) Junction between floor harness (LH) and

    4WD harness (vehicle with AYC)F-23 (2-black) Directional valve (left) (vehicle with AYC)F-24 (2-black) Directional valve (right) (vehicle with AYC)F-25 (3-black) Proportional valve (for ACD)F-26 (3-black) Proportional valve (for AYC) (vehicle with

    AYC)F-27 (3-black) Pressure sensor

    (2) Spare connector

    Boxed connector numbers indicate newly added connectors.

    F-28

    Demister earth

    Floorharness (LH)

    4WDharness

    Bumperharness

    Floor harness(RH)

    Connectorsymbol

  • 8/13/2019 service manual elecrical wiring diagrams

    16/76

  • 8/13/2019 service manual elecrical wiring diagrams

    17/76

  • 8/13/2019 service manual elecrical wiring diagrams

    18/76

  • 8/13/2019 service manual elecrical wiring diagrams

    19/76

    COMPONENT INSTALLATION POSITIONS - J/C3-2

    J/C

    Note :In an actual vehicle, any of the terminals connected in the J/Cmay be used. Therefore, the terminal numbers given in thecircuit diagrams may not coincide with the terminal arrangementin the actual vehicle.

    Windscreen wiper& washer

    Indicator lights,

    hazard warninglights Tail lights, side

    lights, licenceplate lights,lightning monitorwarning buzzer

    Fog lights Headlights Headlight levelling

    system Rear wiper /washer

    Full autoA/C

    Generalspare

    connector

    Clock

    Spare audioconnector

    Warninglights

    Meter

    gauge

    ACD Engine

    control

    J/B

    General fuse( )18

    Generalspare

    connector

    Fog light

    Spare audioconnector

    Demister (Vehiclew/out full auto A/C)

    Demister, doormirror heatingelement (vehiclewith full auto A/C)

    Heater Full auto A/C

    Manual A/C

    Cigar lighterAshtray

    illuminationlight

    Clock

    ACD

    Headlightlevellingsystem

    Indicator lightHazard

    warning lights

    Intercoolerwater spray

    General fuse 15

    Meter gauge Tail lights, side

    lights, licenceplate lights,lighting monitorwarning buzzer

  • 8/13/2019 service manual elecrical wiring diagrams

    20/76

  • 8/13/2019 service manual elecrical wiring diagrams

    21/76

  • 8/13/2019 service manual elecrical wiring diagrams

    22/76

    CIRCUIT DIAGRAMS - J/C 3-5

    Electric retractableremote control door

    mirrors

    J/BGeneral

    fuse( )11

    J/BGeneral

    fuse( )13

    General spareconnector

    Spareaudio

    connector

    Clock

    Fog lights Spareconnectorfor fog lights

    Foglights

    Fog lights Spareconnectorfor fog lights

    SRS airbags,seatbelt pre-

    tensioners

    ABS ACD

    Engineimmobiliser

    systemEnginecontrol

    Diagnosisconnector

    Cabin lights,boot interiorlight, ignitionkey cylinderillumination

    light, door notproperly closedindicator light

    Central doorlocking(vehicle withkeyless entry)

    Cabin lights,boot interiorlight, ignitionkey cylinderilluminationlight, door not

    properlyclosedindicator light

    Warning lights Meter gauge

  • 8/13/2019 service manual elecrical wiring diagrams

    23/76

    CIRCUIT DIAGRAMS - J/C3-6

    J/C (contd)

    Diagnosisconnector

    Security

    alarm Security alarm Horn

    Full auto A/C ABS ACD

    Horn

    Ignition keyreminderbuzzer

    Windscreenwiper &washer

    Security alarm Central door

    locking

    Turn signallights, hazardwarning lights

    Tail lights,position lights,licence platelights, lightingmonitorwarningbuzzer

    Electricstowableremote controldoor mirrors

    Powerwindows

    Fog lamps Headlights Rear wiper /

    washer

    Cabin lights,boot interiorlight, ignitionkey cylinderilluminationlight, door notproperlyclosedindicator light

    Enginecontrol

    Enginecontrol

    Ignition

    Meter gauge Engine control Meter gauge Ignition

    Engine immobilisersystem

    Engine control Full auto A/C Cooling

    Enginecontrol

    Engineimmobilisersystem

    Enginecontrol

    Full auto A/C Cooling

    Engineimmobilisersystem

  • 8/13/2019 service manual elecrical wiring diagrams

    24/76

    CIRCUIT DIAGRAMS 3-7

    (Notes)

  • 8/13/2019 service manual elecrical wiring diagrams

    25/76

    CIRCUIT DIAGRAMS - CENTRAL JUNCTION3-8

    Central JunctionM3030000300552

    Fusible link (Relay box inside engine space)

    No. Circuit Type Housing colour Rated current (A)

    2 Full auto air conditioning;

    manual air conditioning;cooling

    Connector type Red 50

    Forwarddirection ofvehicle

  • 8/13/2019 service manual elecrical wiring diagrams

    26/76

    CIRCUIT DIAGRAMS - CENTRAL JUNCTION 3-9

    Fusible link (Relay box inside engine space)

    Power supply circuit Fuse No. Ratedcurrent (A)

    IDcolour

    Applied loads

    Battery / Alternator (fusiblelink No. 6)

    3 20 Yellow O2

    sensor, secondary arecontrol solenoid valve, idlespeed control servo, ignitioncoil 1, ignition coil 2, wastegate solenoid valve 1, wastegate solenoid valve 2, airflow sensor, engine ECU,engine control relay, camposition sensor, crank anglesensor, purge controlsolenoid valve, fuel pressuresolenoid valve, radiator fancontrol relay, register (forinjector)

    10 20 Yellow Fuel pump relay 3, fuel pumpregister, fuel pump & fuelgauge unit (main)

    Forwarddirection ofvehicle

  • 8/13/2019 service manual elecrical wiring diagrams

    27/76

    CIRCUIT DIAGRAMS - POWER SUPPLY3-10

    Power Supply

    Battery

    Fusible link

    Special fuse

    Starter

    Charging Full auto A/C Manual A/C Cooling

    Full auto A/C Manual A/C Cooling

    Enginecontrol

    Security alarm Central door

    locking(vehicles withkeyless entry)

    Turn signallights, hazardwarning lights

    Charging Full autoA/C

    ManualA/C

    Cooling

    ABS ACD Stop

    lights

    Heater Full auto

    A/C Manual

    A/C

  • 8/13/2019 service manual elecrical wiring diagrams

    28/76

  • 8/13/2019 service manual elecrical wiring diagrams

    29/76

    CIRCUIT DIAGRAMS - POWER SUPPLY3-12

    Power supply (contd)

    Fusible link 4

    Ignitionswitch

    Specialfuse

    Intercoolerwater spray

    Engine control Starter

    ABS ACD SRS airbags, seat

    pre-tensioners Ignition key reminder

    buzzer Intercooler water

    spray Windscreen wiper /

    washer Warning lights Engine control Meter gauge Charging Security alarm

    Central door locking

    Turn signal lights,hazard warning lights

    Tail lights, positionlights, licence platelights, lighting monitorwarning buzzer

    Electric stowableremote control doormirrors

    Power windows General spare

    connectors Fog lamps Headlights Rear wiper / washer

    Cabin lights, bootinterior light, ignitionkey cylinderillumination light, doornot properly closedindicator lamp

    SRS airbags, seatbeltpre-tensioners

    Reversing lights Rear wiper / washer

    Engine controlIgnition

  • 8/13/2019 service manual elecrical wiring diagrams

    30/76

    CIRCUIT DIAGRAMS - POWER SUPPLY 3-13

    ABS ACD Intercooler water spray Windscreen wiper /

    washer Turn signal lights,

    hazard warning lights Tail lights, position

    lights, licence platelights, lighting monitorwarning buzzer

    Heater Fog lamps Full auto A/C Headlights Headlight levelling

    system Manual A/C Cooling

    ABS ACD

    Windscreenwiper / washer

    Cigar lighter,ashtrayillumination lamp

    Electricstowableremotecontrol doormirrors

    Spare audioconnector

    Clock General spare

    connector Cabin lights,

    boot interiorlight, ignitionkey cylinderilluminationlight, door notproperly closedindicator lamp

    Rear wiper/ washer

    Cabin lights,boot interiorlight, ignitionkey cylinderilluminationlight, doornot properlyclosedindicatorlamp

  • 8/13/2019 service manual elecrical wiring diagrams

    31/76

    CIRCUIT DIAGRAMS - POWER SUPPLY3-14

    Power Supply (contd)

    Fusiblelink 1

    Fusiblelink 5

    ABS ACD SRS airbags, seat pre-

    tensioners Ignition key reminder

    buzzer Windscreen wiper /

    washer Engine immobiliser

    system Engine control Security alarm Central door locking Turn signal lights,

    hazard warning lights Tail lights, position

    lights, licence platelights, lighting monitorwarning buzzer

    Electric stowable remotecontrol door mirrors

    Power windows Fog lamps Full auto A/C Headlights Rear wiper / washer Cabin lights, boot interior

    light, ignition key cylinderillumination light, doornot properly closedindicator lamp

    ACD Ignition key reminder

    buzzer Windscreen wiper /

    washer Warning lights Engine control Spare audio connector Clock Meter gauge Security alarm Central door locking Turn signal lights,

    hazard warning lights Tail lights, position lights,

    licence plate lights,lighting monitor warningbuzzer

    Electric stowable remotecontrol door mirrors

    Power windows General spare connector Fog lamps Full auto A/C Headlights Headlight levelling

    system Rear wiper / washer

    Cabin lights, bootinterior light, ignition keycylinder illuminationlight, door not properlyclosed indicator lamp

    Heater Full auto

    A/C Manual A/C

    Powerwindows

    J/BGeneral fuse( )5

    Demister relay

    Demister, door mirrorthermal element (vehiclewith full auto A/C)

    Demister (vehiclew/out full auto A/C)

    Demister, door mirrorthermal element

    (vehicle with full autoA/C)

    Demister (vehicle

    w/out full autoA/C) Demister, door

    mirror thermalelement (vehiclewith full autoA/C)

  • 8/13/2019 service manual elecrical wiring diagrams

    32/76

    CIRCUIT DIAGRAMS - POWER SUPPLY 3-15

    (Notes)

  • 8/13/2019 service manual elecrical wiring diagrams

    33/76

    CIRCUIT DIAGRAMS - ENGINE CONTROL3-16

    ENGINE CONTROLM3030000801516

    Battery

    Special fuse

    Enginecontrolrelay

    EngineECU

  • 8/13/2019 service manual elecrical wiring diagrams

    34/76

    CIRCUIT DIAGRAMS - ENGINE CONTROL 3-17

    Ignition switch

    Fuelpumprelay

    Fuelpumprelay

    Combinationmeter

    Windscreenwasher/wiper

    Turn signal lights / hazard warninglights

    Tail lights, positionlights, licenceplate lights,lighting monitorwarning buzzer

    Fog lights Headlights Rear

    washer/wiper

  • 8/13/2019 service manual elecrical wiring diagrams

    35/76

  • 8/13/2019 service manual elecrical wiring diagrams

    36/76

  • 8/13/2019 service manual elecrical wiring diagrams

    37/76

    CIRCUIT DIAGRAMS - ENGINE CONTROL3-20

    Engine Control (contd.)

    Ignition

    switch (ST) Engine control relay

    Starterrelay

    Idle speedcontrolservo Fuel

    pressuresolenoidvalve

    Wastegatesolenoidvalve

    Engine ECU

    Engine speeddetectionconnector

    Power steering fluidpressure switch

  • 8/13/2019 service manual elecrical wiring diagrams

    38/76

    CIRCUIT DIAGRAMS - ENGINE CONTROL 3-21

    Engine control relay

    Waste gatesolenoidvalve 2

    Purge controlsolenoidvalve

    Secondaryair controlsolenoidvalve

    Intercooler water spray

    Full auto A/C Manual A/C Cooler

    Heater Full auto A/C Manual A/C

  • 8/13/2019 service manual elecrical wiring diagrams

    39/76

    CIRCUIT DIAGRAMS - ENGINE CONTROL3-22

    Engine Control (contd.)

    J/BCommonfuse( )2

    Fusible link 1Engine ECU

    Vehiclespeedsensor

    Engineimmobilizer

    system

    Diagnosticsconnector

    Diagnosticsconnector

    Front view Front view

  • 8/13/2019 service manual elecrical wiring diagrams

    40/76

    CIRCUIT DIAGRAMS - ENGINE CONTROL 3-23

    Remarks* : Windscreen washer / wiper Meter gauges Electric retractable door mirrors Generic spare connectors Cabin lights, boot interior light,

    ignition key cylinderillumination light, door notproperly closed reminder light

    J/B(Fuel pump relay 2)

    Fuel pumprelay 3

    Fuel

    pumpregister

    Fuel pump& fuel gaugeunit (main)

    Back-uppower supply

    Engine ECU

  • 8/13/2019 service manual elecrical wiring diagrams

    41/76

    CIRCUIT DIAGRAMS - SIGNALLING3-24

    Signalling

    Stop lights

    Battery

    Generalfuse

    Stop lightswitch

    Rearcombinationlight (stop : LH)

    Rearcombinationlight (stop : RH)

    High-mountstop light

    Spareconnector

  • 8/13/2019 service manual elecrical wiring diagrams

    42/76

  • 8/13/2019 service manual elecrical wiring diagrams

    43/76

    CIRCUIT DIAGRAMS - AIR CONDITIONING3-26

    Air Conditioning

    Manual Air Conditioning

    Fusible

    link 1

    Ignition

    switch (IG2)

    Blowerrelay

    Blowerswitch

    Register

    Blowermotor

    Intercoolerwater spray

  • 8/13/2019 service manual elecrical wiring diagrams

    44/76

    CIRCUIT DIAGRAMS - AIR CONDITIONING 3-27

    J/B

    (general fuse) 5

    J/B (general

    fuse) 5

    Front ECU

    (tail light relay)Register

    Air thermo sensor

    Internal / external

    changeoverdamper motor

    Special fuse

    Tail lights, side lights,licence plate lights,lighting monitorwarning buzzer

    Meter gauge Tail lights, side

    lights, licence platelights, lightingmonitor warningbuzzer

    A/C switch, internal/external changeover damper motor, ILL

    Demister

  • 8/13/2019 service manual elecrical wiring diagrams

    45/76

    CIRCUIT DIAGRAMS - AIR CONDITIONING3-28

    Manual Air Conditioning (contd)

    Fusible link 2 Engine control relay

    Radiator fan

    control relay

    Radiator fan controller

    Input signalprocessor

    Temperaturedetection

    Drive circuit

    Currentdetection

    Equalizingcircuit

    Field effecttransistor circuit

    Radiator fanmotor

  • 8/13/2019 service manual elecrical wiring diagrams

    46/76

  • 8/13/2019 service manual elecrical wiring diagrams

    47/76

    CIRCUIT DIAGRAMS - AIR CONDITIONING3-30

    Manual Air Conditioning (contd)

    Battery J/C(2)(General fuse) 5 Radiator fancontroller

    A/Ccompressor

    relay

    General fuse

    A/Ccompressor

    Coolingtemperatureswitch

    Magneticswitch

    Dualpressureswitch

    Low pressure sideON OFF: 196kPaOFF ON: 221kPaHigh pressure sideON OFF: 3138kPaOFF ON: 2550kPa

    Engine ECU

  • 8/13/2019 service manual elecrical wiring diagrams

    48/76

    CIRCUIT DIAGRAMS 3-31

    (Notes)

  • 8/13/2019 service manual elecrical wiring diagrams

    49/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-32

    Special Equipment

    ABS

    Fusible link 3Ignition switch

    (IG2)

    Ignition switch

    (IG1)Battery

    Generalfuse

    Combinationmeter

    Stop light switch

    Stop lights

    Solenoid valvepower supply

    Motor powersupply

    Powersupply

  • 8/13/2019 service manual elecrical wiring diagrams

    50/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-33

    Note:* : Windscreen wiper / washer Engine control Meter gauge Indicator lights, hazard warning

    lights Tail lights, side lights, licence

    plate lights, lighting monitorwarning buzzer

    Electric retractable remotecontrol door mirror

    General spare connector Fog lights Headlights Rear wiper / washer Cabin lights, boot interior light,

    ignition key cylinder illuminationlight, door not properly closedindicator light

    Motor powersupply

    Motor

    Hydraulic unit

    Solenoid valve

  • 8/13/2019 service manual elecrical wiring diagrams

    51/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-34

    ABS (contd)

    Ignition switch (IG2)

    Front / rearG sensor

    Lateral Gsensor

  • 8/13/2019 service manual elecrical wiring diagrams

    52/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-35

    Brakewarning

    light

    Parking brakeswitch

  • 8/13/2019 service manual elecrical wiring diagrams

    53/76

  • 8/13/2019 service manual elecrical wiring diagrams

    54/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-37

    Front : LH Front : RH Rear : LH Rear : RH

    ABS sensors

  • 8/13/2019 service manual elecrical wiring diagrams

    55/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-38

    ABS (contd)

    Fusible link 1

    Diagnosisconnector

    Front view

  • 8/13/2019 service manual elecrical wiring diagrams

    56/76

    CIRCUIT DIAGRAMS 3-39

    (Notes)

  • 8/13/2019 service manual elecrical wiring diagrams

    57/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-40

    ACD (Vehicle not fitted with AYC)

    Fusible link 1Ignition switch

    (IG2) Battery

    General fuse

    Stop lightswitch

    Stop light

    Back-uppower supply

    Enginecontrol

    Powersupply

  • 8/13/2019 service manual elecrical wiring diagrams

    58/76

  • 8/13/2019 service manual elecrical wiring diagrams

    59/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-42

    ACD (Vehicle not fitted with AYC) (contd)

    Front ECU(tail light relay)

    Specialfuse

    Tail lights, sidelights, licenceplate lights,lighting monitoringwarning buzzer

    Meter gauges Tail lights, side

    lights, licence platelights, lightingmonitoring warningbuzzer

    ACDmodeswitch

    Ignition switch(IG1) Windscreen wiper /

    washer Engine control Meter gauge Indicator light, hazard

    lights Tail lights, side lights,

    licence plate lights,lighting monitoringwarning buzzer

    Electric retractableremote control doormirrors

    General spareconnectors

    Fog lights Headlights Rear wiper / washer Cabin lights, boot

    interior light, ignitionkey cylinder illuminationlight, door not properlyclosed indicator light

    Combinationmeter

  • 8/13/2019 service manual elecrical wiring diagrams

    60/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-43

    Engine ECU

    Throttle positionsensor

  • 8/13/2019 service manual elecrical wiring diagrams

    61/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-44

    ACD (Vehicle not fitted with AYC) (contd)

    Fusible link 7

    Electricpump

    Electric pumprelay

    Pressuresensor

    Proportionalvalve (forACD)

  • 8/13/2019 service manual elecrical wiring diagrams

    62/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-45

    Front : LH Front : RH Rear : LH Rear : RH

    ABS sensors

  • 8/13/2019 service manual elecrical wiring diagrams

    63/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-46

    ACD (Vehicle not fitted with AYC) (contd)

    Ignition switch(IG2)

    Intercooler waterspray

    Heater Full auto A/C Manual A/C

    Steering sensor

    Front view

  • 8/13/2019 service manual elecrical wiring diagrams

    64/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-47

    Fusible link 1

    Diagnosisconnector

  • 8/13/2019 service manual elecrical wiring diagrams

    65/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-48

    ACD, AYC

    Fusible link 1Ignition switch(IG2) Battery

    Enginecontrol

    Back-uppower supply

    Powersupply

    Specialfuse

    Stop lightswitch

    Stop lights

  • 8/13/2019 service manual elecrical wiring diagrams

    66/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-49

    Ignition switch(IG2)

    Front /Rear Gsensor Lateral G sensor

  • 8/13/2019 service manual elecrical wiring diagrams

    67/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-50

    ACD, AYC (contd)

    Front ECU (taillight relay)

    Specialfuse

    Tail lights, sidelights, licence platelights, lightingmonitor warningbuzzer

    Meter gauge Tail lights,

    side lights,licence platelights, lightingmonitorwarningbuzzer

    ACD modeswitch

    Ignition switch(IG1) Windscreen wiper &

    washer Engine control Meter gauge Indicator lights, hazard

    warning lights Tail lights, side lights,

    licence plate lights,lighting monitorwarning buzzer

    Electric retractableremote control doormirrors

    General spareconnectors

    Fog lights Headlights Rear wiper / washer Cabin lights, boot

    interior lights, ignitionkey cylinderillumination light,door not properlyclosed indicator light

    Combinationmeter

    Drive circuit

  • 8/13/2019 service manual elecrical wiring diagrams

    68/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-51

    Engine ECU

    Throttle position sensor

  • 8/13/2019 service manual elecrical wiring diagrams

    69/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-52

    ACD, AYC (contd)

    Brake warninglight

    Parking brakeswitch

  • 8/13/2019 service manual elecrical wiring diagrams

    70/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-53

    (Front : LH) (Front : RH) (Rear : LH) (Rear : RH)

    ABS sensors

  • 8/13/2019 service manual elecrical wiring diagrams

    71/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-54

    ACD, AYC (contd)

    Fusible link 7

    Electricpump

    Electric pumprelay

    Pressure sensor

  • 8/13/2019 service manual elecrical wiring diagrams

    72/76

  • 8/13/2019 service manual elecrical wiring diagrams

    73/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-56

    ACD, AYC (contd)

    Ignition switch(IG2)

    Intercooler waterspray

    Heater Full auto A/C Manual A/C

    Steering sensor

    Front view

  • 8/13/2019 service manual elecrical wiring diagrams

    74/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-57

    Fusible link 1

    Diagnosisconnector

  • 8/13/2019 service manual elecrical wiring diagrams

    75/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-58

    Engine Immobiliser System

    Front view

    Battery

    Specialfuse

    Enginecontrolrelay

    Engine control

    Powersupply

    Powersupply

    EngineECU

  • 8/13/2019 service manual elecrical wiring diagrams

    76/76

    CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-59

    Fusible link 1Engine ECU

    Immobiliser ECU

    Ignition key ringantenna

    ID

    card

    Transponder

    Diagnosisconnector

    Diagnosisconnector

    High-frequency circuit