Upload
said-mohamed-ghanem
View
232
Download
0
Embed Size (px)
Citation preview
8/6/2019 Golden Rules Pics_1BP
1/12
Golden Rule Lifting Operations & Working at Heights
Look what happened ..while lowering this mast the supervisordecided to climb up the mast ladders to reposition some cables, a bolt
snapped and the mast slipped, the man fell 4m, broke a leg and lost3 fingers
8/6/2019 Golden Rules Pics_1BP
2/12
Golden Rule Driving Safely (Loads must be secured)
Look what happened .. A20 section of poly-propylene pipe slips off theback of a lorry. The pipestacking configuration
meant that the pipe on thetop in the middle had verylittle force from therestraining strops to hold itin place, this is the pipe that
slipped
8/6/2019 Golden Rules Pics_1BP
3/12
Golden Rule Lifting Operations
Look what happened .. A banksman places himself inthe line of fire when a load is being lowered in thisrestricted area. He gets killed when the load suddenly
slips
8/6/2019 Golden Rules Pics_1BP
4/12
Golden Rule Pre-Job Risk Assessment
Look what happened ..
In order to remove thecrane hook, a man placeshimself between twocontainers on the deck of
a supply boat, when theboat rolled the containersslid and crushed hispelvis in three places
8/6/2019 Golden Rules Pics_1BP
5/12
Golden Rule Energy Isolations (Electrical)
Look what happened .a man trying tocommit suicide reaches out for a 16,000 V
un-isolated conductor cable above him
8/6/2019 Golden Rules Pics_1BP
6/12
Golden Rule Energy Isolations (Process) & PPE
Look what happened .when service testing a gas lift compressor to1050 psi, a 3 flexible hose burst injuring the technician with metalfragments, the flex pipe was not rated to the system working
pressure. The Technician was wearing safety glasses whichprotected him from sustaining eye injuries
8/6/2019 Golden Rules Pics_1BP
7/12
Golden Rule Permit to Work
Look what happened here . This whole floating platformsank when an explosion ripped through its ballast tanksystem, believed to have been caused by a failure in thePermit to Work System
8/6/2019 Golden Rules Pics_1BP
8/12
Golden Rule Energy Isolations (Hydraulic)
Look what happened
.scaffold was builtaround a large powerfulpiece of machinery topaint it.
The machinery alreadyhad a small hydraulicleak, during the job itdescended crushing the
scaffold below andpushing the scaffold infront, nearly knockingtwo men off from about 4meters height
8/6/2019 Golden Rules Pics_1BP
9/12
Golden Rule Driving Safely (Mobile Phones)
Look what happened ..
a man using his mobilephone while driving on a
motorway is not
concentrating on the road
and slams straight into astationary recovery truck,
killing himself, his wife and
his young daughter
instantly
8/6/2019 Golden Rules Pics_1BP
10/12
Golden Rule Emergency Response Plans
Look what happened .. A section of a graving dry dock collapses lettingthe ocean pour in, many men drown over the next hour as the boats theyare working in overturn, crush them against the sides of the dock and
decapitate those standing around the dock side as the mooring wiressnapped
8/6/2019 Golden Rules Pics_1BP
11/12
Golden Rule Driving Safely (Fatigue & seatbelts)
Look what happened here, a man fell asleep whiledriving because he was too tired HE WASWEARING HIS SEAT BELT AND SURVIVED THISACCIDENT
.IF YOU FEEL SLEEPY - STOP.
It is recommended that the following guidelinesare adopted:
1. Take a 5 min break every hour of driving. Getout of the vehicle, walk around the vehicle a
couple of times, do some gentle stretching,windmilling of your arms, have a drink of water.
2. Every couple of hours, stop for some lightrefreshment (food snack and drink/water), astretch and a little exercise. (30 minutes as aguide)
3. Stop and eat your meals as you normally would.Breakfast at breakfast time, lunch at lunchtimeand dinner at dinnertime as per your usual routinevs driving on to get to the destination.
4. In any 24hr period, you must have at least an 10hr break involving sleep.
Take water and snacks with you in your vehicle.
5. Be on the alert for signs of weariness and ifdetected, pull over and stop. Have a powernap, 15minutes of shut eye could be all the difference
between getting to your destination 15 minuteslate and not getting there at all.
8/6/2019 Golden Rules Pics_1BP
12/12
Golden Rule Driving Safely (Speed)
Look what happened this man was simplydriving too fast, lost control of the vehicle androlled the car