TECHNICAL DATA SHEET

Tel: +1 (813) 649-8899Fax: +1 (813) 425-9007

sales@htm-lighting.com www.htm-lighting.com

Rev V0616

HTM Lighting Solutions6420 Benjamin Road,Tampa, FL 33634

LED Retrofit Kits |

Benefits

Specifications

Application Notes

• Up to 75% More Efficient than HID Equivalent• Longer life and lower maintenance cost• Active fan heat exchange cooling• Mercury and ead free, as well as UV and IR free• Instant on, no warm up or start time• Cree XTE / Philips SMD Chip: High Lumen Output• Meanwell HLG Driver w/ Temp. Control System To

Reduce Heat Output• 5 Years HTM Lighting Warranty

Equivalent 100-1000 Watts HID

Average Rated Life 50,000+ HoursHousing Die Cast AluminumBase Custom Mounting System For HID FixturesPower 100-277 VAC (Higher Upon Demand)Dimmable Non-DimmableBeam 110°Color (K) 3000K-5700K

This device complies with Part 15 of the FCC Rules and has been tested and found to comply with the limits for a Class B digital device

35W / 45W / 65W / 80W / 100W / 120W / 150W / 200W / 320W

1. High Ouput Retrofit Kit For Outdoor-Pole/Arm Mounted Area & Roadway Luminaires2. Operating temperature range between -20°C and 45°C (-4°F and 113°F)3. Storage temperature range between -30°C and 80°C (-22°F and 176°F)4. Not for use with emergency light fixtures ot exit lights5. Suitable for indoor/damp locations and sheltered outdoor use (IP40)6. Requires HD ballast bypass, see htm-lighting.com for instructions

TECHNICAL DATA SHEET

Tel: +1 (813) 649-8899Fax: +1 (813) 425-9007

sales@htm-lighting.com www.htm-lighting.com

Rev V0616

HTM Lighting Solutions6420 Benjamin Road,Tampa, FL 33634

Application Info

LED Retrofit Kits | 35W / 45W / 65W / 80W / 100W / 120W / 150W / 200W / 320W

TECHNICAL DATA SHEET

Tel: +1 (813) 649-8899Fax: +1 (813) 425-9007

sales@htm-lighting.com www.htm-lighting.com

Rev V0616

HTM Lighting Solutions6420 Benjamin Road,Tampa, FL 33634

Instructions

LED Retrofit Kits | 35W / 45W / 65W / 80W / 100W / 120W / 150W / 200W / 320W

1. Fix the U bracket on the installation bracket with screws, see Figure 12. Fix the lamp body on the bracket with screws, see Figure 23. Adjust the length, height, etc. of the lamp body and bracket as per your specific requirements. see Figure 34. Take down all screw bases and ballasts in the fixtures before installation.5. Fix the driver on the fixture of the lamp with screws, then fix the products with fixed bracket on the fixture6. Connect correctly the input wire of the lamp body and the output wire of the driver, see Fixture 47. If the lamps are installed vertically, take highbay fixtures for example see Figure 5.8. Connect the driver with local electric supply, insulation measures are needed when connecting the wires9. Turn on the power after the product is properly installed, then it can work normally.

Notice:1. When there is only one group of red and black wire in the lamp body, just connect the only driver with it.2. When there are two groups of red and black wire on the lamp body, we equip the lamp with the same two

drivers, please connect each driver with either one group of red and black wire.3. When there are three groups of red and black wire on the lamp body, we equip the lamp with the same three

drivers, please connect each driver with either one group of red and black wire.Warning: LED Chips should not be touched by hands or any other installation tools. Please use the protective cover while installing the retrofit.

TECHNICAL DATA SHEET

Tel: +1 (813) 649-8899Fax: +1 (813) 425-9007

sales@htm-lighting.com www.htm-lighting.com

Rev V0616

HTM Lighting Solutions6420 Benjamin Road,Tampa, FL 33634

Ordering Info

Part # Watts Replaces Voltage CCT Lumens Length Width Height

HTM-RKNUS-LED-35WV1 35W 100W HID 100-277VAC 3000-

5700K 3,600 4.7’’(Round)

4.7’’(Round) 1.7’’

HTM-RKNUS-LED-45WV1 45W 150W HID 100-277VAC 3000-

5700K 4,800 4.7’’(Round)

4.7’’(Round) 1.7’’

HTM-RKNUS-LED-65WV1 65W 200W HID 100-277VAC 3000-

5700K 6,800 4.7’’(Round)

4.7’’(Round) 1.7’’

HTM-RKPUS-LED-80WV2 80W 250W HID 100-277VAC 3000-

5700K 9,700 4.7’’ 4.7’’ 1.7’’

HTM-RKPUS-LED-100WD2 100W 320W HID 100-277VAC 3000-

5700K 10,500 6.8’’ 4.9’’ 1.2’’

HTM-RKPUS-LED-120WD2 120W 400W HID 100-277VAC 3000-

5700K 15,600 6.8’’ 4.9’’ 1.2’’

HTM-RKPUS-LED-150WD2 150W 500W HID 100-277VAC 3000-

5700K 19,300 10.4’’ 6.3’’ 2.4’’

HTM-RKPUS-LED-200WD2 200W 600W HID 100-277VAC 3000-

5700K 21,000 10.4’’ 6.3’’ 2.4’’

HTM-RKPUS-LED-300WD2 300W 1,000W HID 100-277VAC 3000-

5700K 36,000 12.6’’ 9.3’’ 3’’

HTM-RKNUS-LED-320WV1 320W 1,000W HID 100-277VAC 3000-

5700K 32,600 12.6’’ 9.3’’ 3’’

LED Retrofit Kits | 35W / 45W / 65W / 80W / 100W / 120W / 150W / 200W / 320W