Notice:

Starting Jan 1 2015, all Tailift Trucks must be on a P.M.Maintenance Agreement (See Reverse Side).

If this is not in process, warranty may not be covered.

Tailift USAManagement

I was confirm this inspect, repair, or service based on my will, and have responsibility to the balance. I hereby acknowledge receipt of a copy of this list and that I have read and agreed to the above terms.

Customer Signatures:

Date:

REMARKS

1 VISUAL INSPECTION

FLUID LEAKS

CARRIAGE-ROLLERS/SLIDER BLOCKS

FORKS AND LOCKS

MAST-CHAINS/RETAINERS/ANCHORS

TIRES/CHECK PRESSURE

OVERHEAD GUARD/BACKREST

IMPROPER MODIFICATIONS

FORK WEAR

SEAT CONDITION

SAFETY DEVICES

NEUTRAL STARTING SWITCH

INSTRUMENTS/HORN/LIGHT

BREAKS/ PEDAL/ LINKAGE

PARKING BRAKE

SHIFT LEVELS

STEERING

MAST OPERATION

TILT CYL OPERATION

CLEAN FILTER CANISTER

CHECK FUEL LINES FOR LEAKS

CLEAN FUEL FILTER(S) OR REPLACE

CHECK COOLING SYSTEM (RADIATOR HOSES)

ADJUST BELTS

TIGHTEN ALL HOSE CLAMPS

CHECK/REPLACE AIR CLEANER

5 CHECK FLUID LEVELS

STEERING SYSTEM

HYDRAULIC SYSTEM

MASTER BRAKE CYLINDER

COOLANT AND CONDITIONER

TRANSMISSION

BATTERY ELECTROLYTE (FULL)

DRIVE AXLE

PLANETARIES

6 ELECTRICAL SYSTEM

CHECK WIRE CONNECTIONS & COND

CHECK SPARK PLUGS COND & GAP

CHECK DISTRIBUTOR CONTACTS GAP

CHECK DISTRIBUTOR ROTOR & CAM

CLEAN BATTERY CABLE CONNECTIONS

7 FUEL SYSTEM

CARBURETOR

CHECK LOW& HIGH IDLE

CHECK LP SYS. FOR LEAKS

CHECK FUEL LOCK0OFF

CLEAN WATER TRAP

8 CHECK HYDRAULIC SYSTEM

LINE LEAKS &COND

CONTROL VALVE LEAKS

LIFT CYLINDER

TILT CYLINDER

HYDRAULIC TANK

ATTACHMENT CYLINDERS

9 LUBRICATE

STEER AXLE/MECHANISM

MAST. CHAIN CARRIAGE & ATTACHMENT

CHECK ADJ & LUBE LINKAGE ON

BRAKES: Parking brake

CLUTCH PEDAL

ACCEL PEDAL

DIRECTION PEDAL HYDROSTATIC

LIFT * TILT CONTROL HINGES

SIDE PANEL HINGES

ELECTRICITY TRUCK ONLY

10. BATTERY

CHECK THE ELECTROLYTE AND REFILL PLUS DISTILLED WATER.

CLEAN THE TOP OF THE BATTERY

RECHARGE EVENLY

CHECK THE EXPOSED FOR INSULATION

11. MOTOR & CONTROLLER

CHECK THE COMMUTATOR & BRUSH WEAR

CHECK OPERATION

LEGEND: √ OK × URGENT PROBLEM ? POTENTIAL PROBLEMS 1 ADJUST 2 REPAIR OR REPLACE 3 REQUIRE SHOP REPAIR

4 ENGINE COMPARTMENT

CHECKLIST PM SERVICE - I.C. FORKLIFT

CHECK THE INSULATION FOR BEING EFFECTIVE

CHECK FOR POLLUTION

CONNECTION CORRECT AND GOOD

12. CIRCUIT AND TERMINALS

CHECK FOR WEARING

CHECK FOR LOOSENING

CHECK FOR GETTING DIRTY

3 CLEAN WITH COMPRESSED AIR

CLEAN WITH COMPRESSED AIR

2 OPERATIONAL CHECKS

Tailift USA CO., Inc. | 11778San Marino St. Rancho Cucamonga, CA 91731Tel : 909-930-9801 | Fax : 909-930-9739 | Web : www.tialift-usa.com

Doc. S/N :Edition :TAILIFT CARE SCHEDULED MAINTENANCE

Date: Meter Hours: Brand: Model: Serial#:

Contact: Tel: Address: City: State: Zip:

E-mail: