Parts Manual - shop.ransomes-jacobsen.eushop.ransomes-jacobsen.eu/shop/web/proxy/ransomes/rte/file/Ersatzteil... · Ransomes Jacobsen Limited reserves the right to make design changes

GBUnitedKingdom

When Performance Matters.™

Parts Manual

Jacobsen GP400™ Ride on Reel Mower

GP400 GasolineSeries: GZProduct code: USAG004 & 62706

GP400 Diesel Tier 3 (Not USA)Series: GYProduct code: USAD004

GP400 Diesel Tier 4Series: GY4Product code: USAD004

WARNING

WARNING: If incorrectly used this machine can cause severe injury. Those who use and maintain this machine should be trained in its proper use, warned of its dangers and should read the entire manual before attempting to set up, operate, adjust or service the machine.

25005G-GB-Rev.4

RJL 100 February 2014

© 2014, Ransomes Jacobsen Limited. All Rights Reserved

Ransomes Jacobsen Limited reserves the right to make design changes without obligation to make these changes on units previously sold and the information contained in this manual is subject to change without notice.

TABLE OF CONTENTS

Parts - 3

CHASSIS ....................................................................................................... 8

ROPS ISO21299 .......................................................................................... 10

ENGINE (DIESEL) ........................................................................................ 12

AIR FILTER .................................................................................................. 14

RADIATOR OIL COOLER (DIESEL) ........................................................... 16

ENGINE (GAS) ............................................................................................. 18

OIL COOLER, GAS ...................................................................................... 20

FUEL SYSTEM (DIESEL) ............................................................................. 22

FUEL SYSTEM GASOLINE - NONE EPA AND CARB

COMPILIANTE.............................................................................................. 24

FUEL SYSTEM GASOLINE - EPA AND CARB COMPILIANTE .................. 26

CARBON CANISTER ................................................................................... 28

FUEL TANK DIESEL..................................................................................... 30

FUEL TANK GASOLINE - NONE EPA AND CARB

COMPILIANTE.............................................................................................. 32

FUEL TANK GASOLINE - EPA AND CARB COMPILIANTE ....................... 34

CARGO NET ASSEMBLY ............................................................................ 36

TRANSMISSION PUMP ............................................................................... 38

TRANSMISSION PUMP ............................................................................... 40

TRANSMISSION PUMP CONTROL............................................................. 42

CUTTING MOTORS ..................................................................................... 44

LIFT / STEER RAMS .................................................................................... 46

FILTER & COOLER ...................................................................................... 48

FRONT MOTORS......................................................................................... 50

BACKLAP VALVE......................................................................................... 52

BACKLAP VALVE BREAKDOWN ................................................................ 54

CUTTER LIFT VALVE................................................................................... 56

UTTER / LIFT VALVE BREAKDOWN........................................................... 58

PUMP STACK............................................................................................... 60

HYDRAULIC TANK CONNECTIONS ........................................................... 62

BULKHEAD FITTINGS ................................................................................ 64

CLAMPS ....................................................................................................... 66

CUTTING CIRCUIT....................................................................................... 68

TRANSMISSION CIRCUIT ........................................................................... 70

LIFT CIRCUIT ............................................................................................... 72

STEERING CIRCUIT .................................................................................... 74

TANK FILTER COOLER CIRCUIT ............................................................... 76

HYDRAULIC TANK DIESEL AND NON EPA AND CARB

COMPLIANT GASOLINE.............................................................................. 78

HYDRAULIC TANK GASOLINE EPA AND CARB COMPLIANT

GASOLINE.................................................................................................... 80

CONTROL ARM............................................................................................ 82

HANDBRAKE ............................................................................................... 84

REAR WHEEL .............................................................................................. 86

FOOTPEDAL ................................................................................................ 88

SEAT (MILSCO)............................................................................................ 90

SEAT (GRAMMER) ...................................................................................... 92

INSTRUMENT CONTROL ........................................................................... 94

INSTRUMENT PANEL (DIESEL) ................................................................. 96

INSTRUMENT PANEL (GAS) ...................................................................... 98

BATTER....................................................................................................... 100

TOOLBOX/STEP ......................................................................................... 102

FRONT LIFT GROUP .................................................................................. 104

REAR SWING ARM..................................................................................... 106

REAR SWING ARM..................................................................................... 108

CLASSIC XP MOTOR MOUNTING............................................................. 110

CLASSIC XP CUTTING HEAD.................................................................... 112

CLASSIC XP REAR ROLLERS ................................................................... 114

VERTICUT HEAD ........................................................................................ 116

REAR ROLLER & SCRAPER VERTICUT................................................... 118

ACCESSORY - ROTARY REAR BRUSH ................................................... 120

CLASSIC XP FRONT & REAR ROLLS....................................................... 122

CLASSIC XP FRONT ROLL 2" SMOOTH & SCRAPER............................. 124

TRUE SET OUTER REEL ........................................................................... 128

TRUE SET INNER REEL ............................................................................ 130

TRUE SET REAR ROLLER......................................................................... 132

TRUE SET MACHINED GROOVED ROLLER............................................ 133

TRUE SET SOLID FRONT ROLLER .......................................................... 134

TRUE SET 22" GROOVED STEEL DISC FRONT ROLLER....................... 135

TRUE SET 22" SEGMENTED GROOVED FRONT ROLLER..................... 136

TRUE SET MOTOR ADAPTER KIT ............................................................ 137

TURF GROOMER ....................................................................................... 138

TURF GROOMER DRIVE ASSEMBLY....................................................... 140

TURF GROOMER DRIVEN ASSEMBLY .................................................... 142

TURF GROOMER BLADE ASSEMBLY...................................................... 144

TURF GROOMER ROLLER ASSEMBLY ................................................... 146

TURF GROOMER QUICK HEIGHT ADJUSTER ........................................ 148

GRASS CATCHER...................................................................................... 150

DECALS ...................................................................................................... 152

LMAC415 DEW WHIP HOLDER................................................................ 154

LMAC412 PADDLE KIT.............................................................................. 156

LMAC 418 3 WHEEL DRIVE KIT ............................................................... 158

Parts- 4

PARTS MANUAL-GP 400

C D

E

KgA

F

West RoadRansomes EuroparkIpswich IP3 9TTEngland

B

Kg KwKg Kg


A B C D EF GH J

PRODUCT IDENTIFICATION_______________________________________________ _

Machine Serial PlateA Maximum front axle load in Kg (for machines being

driven on the highway)B Gross weight (mass) in KgC Maximum rear axle load in Kg (for machines being driven

on the highway)D Power in KwE Date codeF Machine type (Designation)G Product codeH Product nameJ Serial number

Serial Plate Location

The serial plate is located on the chassis at the rear of the machine.

Chassis Stamping

The Serial number and date code (A) are stamped on the chassis rear axle support plate.

ROPS Serial PlateA Weight of ROPSB Date CodeC Standard UsedD Part NumberE Used on ProductF Serial Number

ROPS Serial Plate Location

The serial plate is located on the ROPS cross beam between the seat and engine cover.

Kg KwKg Kg


A B C D EF GH J

Kg KwKg Kg


A 565 C 13.2 ABCD

RIDE ON REEL MOWER USAD004GP400 DIESEL GY000301

GY000301ABCD

A

CD E

KgA

F

West RoadRansomes EuroparkIpswich IP3 9TTEnglandB

C D

E

KgA

F


B

Parts- 5

PARTS MANUAL-GP 400

SPARES STOCKING GUIDE

To keep your equipment fully operational and productive, Ransomes suggests you maintain a stock of the more commonly used maintenance items. We have included part numbers for the additional support materials and training aids.

SERVICE SUPPORT MATERIAL

Part No. Description Part No. Description

97898-72020Kubota Diesel Engine Parts Manual

MS-2263Briggs & Stratton Gasoline Engine Parts Manual

IG689-8916-1Kubota Diesel Engine Operators Manual

MS-5156-5/03Briggs & Stratton Gasoline Engine Operators Manual

SERVICE PARTS

Part No. Description Part No. Description

5002644 Engine Oil Filter Diesel 492932S Engine Oil Filter Gas

840352 Air Filter Element Diesel 5000441 Air Filter Element Gas

550489 Fuel Filter Element Diesel 272490S Air Pre Cleaner Gas

25000GSafety, Ops and Maintenance Manual

4199061 Hydraulic Oil Filter Element

Parts- 6

PARTS MANUAL-GP 400

HOW TO USE THE PARTS MANUAL

ITEM NUMBEREach part which is identified in the illustrations has an item number. Parts which do not have an item number may not be readily identified in the illustration but are usually closely associated with the immediately adjacent part.

ASSEMBLIESA complete assembly, e.g. a wheel motor or hydraulic motor or roll assembly, is listed as a complete item with subsequent individual components listed separately.The assembly is listed under it’s part number with component parts being listed offset to the right, e.g:-

ITEM PART NO. DESCRIPTION QTY REMARKS4295 MBG2504 Bracket 14296 MBG3848 Latch 24298 450865 Screw, M8 X 20, Sckt Csk Hd 24300 450378 Nut, M8 Nyloc 24301 Wl001 Set Of Wheels 14301.1 008162130 • Wheel & Hub Assy 1 (Rear)4301.2 008170390 • • Tyre 14301.3 008161830 • • Rim 14301.4 008169140 • • Hub Assy. 14301.5 008169150 • • Cap 14301.6 002993010 • • Lubricator 14301.7 008161990 • Wheel & Tyre 2 (Front)4301.8 008170780 • • Tyre 2

It may not be possible to illustrate every item. With certain items purchased from outside suppliers some component parts may not be available from Ransomes and may need to be specially ordered from the supplier.

QUANTITIESQuantities shown are for one assembly or sub-assembly.

USING THE PARTS LISTDetermine the function and application of the part required. Turn to the main index page and select the appropriate section. Locate the part on the illustration and parts list and read off the quantity from the appropriate MODEL column.

NUMERICAL INDEXThis is a summary of all part numbers used in the manual arranged in numerical sequence and show-ing the page and item number under which the parts appear.

ORDERING OF SPARE PARTSWhen ordering replacement parts, it is most important to quote the SERIAL NUMBER of the machine, PART NUMBER, DESCRIPTION and QUANTITY required.

Any arbitrary modifications carried out on this machine may relieve the manufacturer of liability for any resulting damage or injury.

ABBREVIATIONSN/A Not AvailableARAs Required

Parts- 7

PARTS MANUAL-GP 400

GUIDELINES FOR THE DISPOSAL OF SCRAP PRODUCTS

DURING SERVICE LIFE

Used oil, oil filters and engine coolant are hazardous materials and should be handled in a safe and environmentally responsible way.In the event of a fluid leak, contain the spill to prevent it entering the ground or drainage system. Local legislation will dictate how such spills are to treated.Following the maintenance procedures laid out in this manual will ensure that the impact the machine has on the local environment is controlled.

When it has been identified that a turf care product has no further functional value and requires disposal, the following actions should be taken.

END OF SERVICE LIFE

These guidelines should be used in conjunction with applicable Health, Safety and Environmental legislation and use of approved local facilities for waste disposal and recycling.

• Position the machine in a suitable location for any necessary lifting equipment to be used.• Use appropriate tools and Personal Protective Equipment (PPE) and take guidance from the technical

manuals applicable to the machine.• Remove and store appropriately:

1. Batteries2. Fuel residue3. Engine coolant4. Oils

• Disassemble the structure of the machine referring to the technical manuals where appropriate. Special attention should be made for dealing with ‘stored energy’ within pressurised elements of the machine or tensioned springs.

• Any items that still have a useful service life as second hand components or can be re-serviced should be separated and returned to the relevant centre.

• Other worn out items should be separated into material groups for recycling and disposal consistent with available facilities. More common separation types are as follows:

• Steel• Non ferrous metals

• Aluminium• Brass• Copper

•Plastics•Identifiable• Recyclable• Non recyclable• Not identified

• Rubber• Electrical & Electronic Components

• Items that cannot be separated economically into different material groups should be added to the ‘General waste’ area.

• Do not incinerate waste.

Finally update machinery records to indicate that the machine has been taken out of service and scrapped. Provide this serial number to Ranmsomes Jacobsen Warranty department to close off relevant records.

Parts- 8

PARTS MANUAL-GP 400

CHASSIS

Illustration Number: 4226480

Parts- 9

PARTS MANUAL-GP 400

ITEM PART NO. DESCRIPTION QTY. REMARKS

1 002953420 Grommet-25.4 x 44.5 x 9.9 12 4122840 Headlight Assembly 23 4136290 Rubber Buffer 24 4185100 Plate-Non Foot Brake 15 4187240 Knob, M8 1 .6 4218440 Wldmt-Chassis GP400 17 4243242 Valve Bracket 18 4239702 Wldmt-Foot Plate 19 4241282 Shim Plate 110 450191 Scrw-Hex M8 x 20 211 450199 Scrw-Hex M8 x 60 112 450324 Nut-Hex M8 413 450377 Nut-Hex M6 Nyloc 214 450378 Nut-Hex M8 Nyloc 215 450389 Wshr-M6 x 12.5 x 1.8 416 450390 Wshr-M8 x 17 x 1.8 217 450411 Lockwshr- M8 x 12.75 x 2 118 450543 Scrw-Pan HD M6 x 25 219 450553 Scrw-Pan HD M8 x 25 1520 843404.06 Bracket-Fitting Mount 121 843886.07 Cover 122 843887 Strap, Cover 1

* Not Illustrated

Parts- 10

PARTS MANUAL-GP 400

ROPS ISO21299



Parts- 11

PARTS MANUAL-GP 400

1 4218224 Wldmt-Rear Strut LH Rops 12 4218225 Wldmt-Rear Strut RH Rops 13 4225282 Rops-GPlex IV ISO21299 14 450041 Bolt-Hex M10 x 100 45 450391 Wshr-M10 x 21 x 2.2 46 450412 Lock Washer-M10 x 15.9 x 2.5 187 450737 CapScrw-Sckt M10 x 20 88 450541 Scrw-Pan HD M6 x 16 29 450357 M6 Nutsert 210 450410 Lock Washer-M6 x 9.6 x 1.5 211 450389 Wshr-M6 x 12.5 x 1.8 212 450738 Capscrw-Sckt M10 x 25 6

* Not Illustrated

Parts- 12

PARTS MANUAL-GP 400

ENGINE (DIESEL)

Illustration Number: 4226481_B

Parts- 13

PARTS MANUAL-GP 400


1 4232841 Bracket, Mounting Fuel Filter 12 4220841 Bracket-Engine Mount 13 839972 Bracket - Mount Throttle Cable 14 MBF0942 Cable Clamp 15 450723 Cap screw - Socket M8 x 20 56 450725 Cap screw - Socket M8 x 30 47 4176383 Bell Housing & Coupling AY 1

4172804 • Coupling 14172801 • Bell Housing 1

8 4123644 Exhaust Adapter 19 4123646 Exhaust Support 110 006822150 Fan Spacer-10 mm 111 4124496 Gasket 212 844496 Hub 113 4228480 Hydro Mount XS 414 450412 Lock washer- M 10 x 15.9 x 2.5 1215 450411 Lock washer - M8 x 12.75 x 2 1816 4124180 Manifold 117 4220840 Mount-Engine Leg (Hyd Mount) 218 450376 Nut-Hex M5 Nyloc 119 450377 Nut-Hex M6 Nyloc 820 001339050 Nut-Hex M8 Staytite 221 469021633 P-Clip 122 450865 Screw - Socket Countersunk M8 X 20 323 450213 Screw - Hex M10 x 20 424 006820550 Screw - Hex M10-1.25 x 30 825 450149 Screw - Hex M5 x 12 126 450151 Screw - Hex M5 x 16 127 450171 Screw - Hex M6 x 20 828 450191 Screw - Hex M8 x 20 129 450192 Screw - Hex M8 x 25 630 450193 Screw - Hex M8 x 30 231 450194 Screw - Hex M8 x 35 132 4124181 Silencer-Kubota 133 4150739 Throttle Cable 134 W022372 B&S Cable Clamp 135 001990399 U Clamp, 1.3/8" 136 452000326 Washer - 3/8 x 3/4 x 0.072 237 450391 Washer - M10 X 21 X 2.2 438 450388 Washer - M5 X 10 X 1.1 139 450389 Washer - M6 X 12.5 X 1.8 1640 450390 Washer - M8 X 17 X 1.8 441 006911490 Housing, Hydro, Diesel Plex 142 4174100 Engine - D722-E3B 1 Tier 342 4303997 Engine - D722-E4B 1 Tier 4

* Not Illustrated

Parts- 14

PARTS MANUAL-GP 400

AIR FILTER



Parts- 15

PARTS MANUAL-GP 400

1 893182 Filter AY, Air 12 4123046 • Vacuator Valve 13 N/A • Filter Body 14 0840352 • Air Filter 15 4277671 • Filter Cap 16 840346 Adaptor-Gauge 17 819028 Mounting Band-5" Plastic 18 4132265 Rain Cap 19 4237802 Moulded-Air Intake Hose 110 888036 Gauge, Restriction 111 001925570 Hose Clamp, 34-57 212 4132266 Sleeve 113 450390 Wshr-M8 x 17 x 1.8 214 450411 Lockwshr-M8 x 12.75 x 2 215 450191 Scrw-Hex M8 x 20 2

* Not Illustrated

Parts- 16

PARTS MANUAL-GP 400

RADIATOR OIL COOLER (DIESEL)


Parts- 17

PARTS MANUAL-GP 400


1 001399240 Nut-Isolation M8 132 001925400 Hose-Clamp, 19-40 43 009121760 Pipe (Radiator Top) 14 15111-72181 Bushing-Rubber 25 15111-72191 Bushing-Rubber 26 15111-72202 Washer 47 2198084 Latch - Swell 68 840176 Bottle, Overflow 19 4144045 Radiator, Aluminium 110 4232680 Wldmt - Radiator 111 4233300 Wldmt- Radiator Shroud 112 4236583 Wldmt- Expansion Tank Bracket 113 450199 Bolt-Hex M8 x 60 4* 450378 M8 Nyloc 114 450034 Bolt-Hex M10 x 60 215 450390 Wshr-M8 x 17 x 1.8 1316 450394 Wshr-M20 x 37 x 3.3 217 450552 Scrw-Pan HD M8 x 20 1018 815058 Clamp 119 839501 Block,Mtg - Oil Cooler 420 839953 Hose. Radiator Lower 121 841160.06 Bracket - Radiator 222 842916 Cooler,Oil 123 835805 Hose, overflow 4’ (1 .2M) . As Req’d24 4246190 Panel-Bug Screen 1* 523930 Foam 1 For item 8* PF24-113 Turbine Housing Seal 2* 002989380 Trim Seal 0.6* 002989470 Foam-Closed Cell, Bulk 1.5

* Not Illustrated

Parts- 18

PARTS MANUAL-GP 400

ENGINE (GAS)


Parts- 19

PARTS MANUAL-GP 400


1 4128424 U-Clamp, 32mm 12 4228560 Bracket-Rear Engine 13 4228561 Plate-Engine Mount 14 4233860 Cover-Exhaust 15 450017 Bolt-Hex M8 x 45 46 450171 Screw-Hex M6 x 20 87 450213 Screw-Hex M10 x 20 48 450377 Nut-Hex M6 Nyloc 89 450378 Nut-Hex M8 Nyloc 410 450379 Nut-Hex M10 Nyloc 211 450389 Wshr-M6 x 12.5 x 1.8 812 450391 Wshr-M10 x 21 x 2.2 813 450412 Lockwshr-M10 x 15.9 x 2.5 814 452200168 Lockwshr-1/2 x 0.763 x 0.116 215 452692 Screw-Hex M6 x 12 Taptite 116 456110448 Screw-Hex 3/8-16 x 1-1/4 417 800770 Capscrw-Sckt 1/2-13 x 1-3/4 218 4239256 GP400 Choke Cable 119 894103 Pump-Assy, Hydraulic 120 4236602 Briggs & Stratton Carb 1 5702HV 18 Vangaurd

492932S • Oil Filter 121 4228480 Mount-Engine AMC Hydro 40 Shore 422 2701768.8 Tailpipe HBK 123 4117098 Muffler, Exhaust 124 4123676 Shield, Heat 125 2702239 Housing AY, Coupler & Adapter 1

4197800 • Coupling 11-T Spline 14197802 • Spider 14197803 • Coupling 1.00 Inch Bore 1

26 Chassis 1 Reference Part Only* 4128424 Exhaust Clamp 32mm ( 1.25") 1* 4150738 Throttle Cable - Gas G-PLEX 1

* Not Illustrated

Parts- 20

PARTS MANUAL-GP 400

OIL COOLER, GAS


Parts- 21

PARTS MANUAL-GP 400


1 452436 Nut-Hex M8 Flange Nyloc 22 4123550 Angle Cover 43 4123563 Angle, Screen 24 4140585 Cover, Air Intake 15 450199 Bolt-Hex M8 x 60 4* 450378 M8 Nyloc 16 450193 Screw-Hex M8 x 30 17 450369 M8 Nutsert 18 450377 Nut-Hex M6 Nyloc 89 450389 Wshr-M6 x 12.5 x 1.8 810 450390 Wshr-M8 x 17 x 1.8 511 450411 Lockwshr-M8 x 12.75 x 2 112 839501 Mounting Block 413 4140587 Frame AY, Cooler 114 842916 Oil Cooler 115 002953320 Grommet 216 001496044 Rivet-Pop 4.8 X 12 117 835039 Fastener-Snap 118 843823 Screen, Cooler 119 4142825 Seal, Cooler 1* 002989380 Trim Seal 0.8 (For Item 14)* 001925400 Hose-Clamp, 19-40 6* 469021633 Hose Clip Large 3* PF24-113 Turbine Housing Seal 2

* Not Illustrated

Parts- 22

PARTS MANUAL-GP 400

FUEL SYSTEM (DIESEL)


Parts- 23

PARTS MANUAL-GP 400


1 001399032 Nut-Hex 1/2-20 Nyloc 22 001399171 Star Ring, 8 mm 13 001925160 Hose Clamp, 6-16 114 002497040 Breather 15 12581-43012 In Line Fuel Filter 16 4126806 Electric Fuel Pump 17 4150179 Fuel Hose (8mm) 100mm8 4150179 Fuel Hose (8mm) 200mm 9 4150179 Fuel Hose (8mm) 680mm 10 4150179 Fuel Hose (8mm) 800mm11 4150180 Fuel Hose (6mm) 520mm 12 4150180 Fuel Hose (6mm) 720mm13 4168131 Grommet, .402 OD X .205 ID 114 4246810 Valve, Rollover 115 4219180 Wldmt-Support Rear Tank Fixing 116 4219200 Bracket-Stay Tank 117 4219220 Stay-Tank 118 4229020 Fuel Tank Assembly 119 4238022 Snorkel-Diesel Breather 120 4244183 Wldmt-Tank Plate 121 450022 Bolt-Hex M8 x 70 122 450168 Scrw-Hex M6 x 12 123 450378 Nut-Hex M8 Nyloc 224 450389 Wshr-M6 x 12.5 x 1.8 1225 450390 Wshr-M8 x 17 x 1.8 726 450392 Wshr-M12 x 24 x 2.7 427 450409 Lock Washer-M5 x 8.55 x 1.5 128 450410 Lock Washer-M6 x 9.6 x 1.5 1229 450411 Lock Washer- M8 x 12.75 x 2 330 450526 Scrw-Pan HD M5 x 12 131 450539 Scrw-Pan HD M6 x 12 1232 450551 Scrw-Pan HD M8 x 16 233 469016509 P-Clip 134 469016517 P-Clip 235 838225 Spring Clip 136 892488 Filter Assembly, Fuel 1* 550489 • Element 137 J366877 Nyliner Bearing 4

* Not Illustrated

Parts- 24

PARTS MANUAL-GP 400

FUEL SYSTEM GASOLINE - NONE EPA AND CARB COMPLIANT


Parts- 25

PARTS MANUAL-GP 400


1 001399032 Nut-Hex 1/2-20 Nyloc 22 001399171 Star Ring, 8 mm 13 001925160 Hose Clamp 6-16 74 4168131 Grommet, .402 OD X .205 ID 15 4199280 Fuel Hose (6mm) 0.37M6 4199280 Fuel Hose (6mm) 1.30M7 4199281 Fuel Hose (8mm) 1.15M8 4219180 Wldmt-Rear Tank Fixing 19 4219200 Bracket-Stay Tank 110 4219220 Stay Tank 111 4220480 Wldmt-Control Panel 112 4229100 Assy-Fuel Tank (Gas) 113 4236602 Briggs and Stratton Carb Engine 114 4244183 Wldmt-Tank Plate 115 4245650 Wldmt-Swanneck 116 4265550 Tank-Vent 117 4246810 Rollover Valve 118 450378 Nut-Hex M8 Nyloc 119 450389 Washer-M6 x 12.5 x 1.8 1120 450390 Washer-M8 x 17 x 1.8 321 450392 Washer-M12 x 24 x 2.7 422 450409 Lock Washer-M5 x 8.55 x 1.5 123 450410 Lock Washer-M6 x 9.6 x 1.5 1124 450411 Lock Washer-M8 x 12.75 x 2 125 450526 Screw-Pan Hd M5 x 12 126 450539 Screw-Pan Hd M6 x 12 1127 450551 Screw-Pan Hd M8 x 16 128 469016517 P-Clip 129 838225 Spring Clip 130 J366877 Nyliner Bearing 4

* Not Illustrated

Parts- 26

PARTS MANUAL-GP 400

FUEL SYSTEM GASOLINE - EPA AND CARB COMPLIANT

Illustration Number: 4291371_fuel_tank_EPA-CARB_2013

Parts- 27

PARTS MANUAL-GP 400


1 J366877 Nyliner Bearing 4

2 001399032 Nut - Hex 1/2 - 20 Nyloc 23 452000237 Washer - 1/4 X 3/4 X .064 64 450410 Lock Washer - M6 X 9.6 X 1.5 65 450541 Screw - Pan Hd M6 - 1.0 X 16 66 450392 Washer - M12 X 24 X 2.7 47 4291331 Weldment - Tank Plate 18 450411 Lock washer - M8 X 12.75 X 2 810 4166085 Fuel Line (8mm) 111 4283232 Jubilee Hose Clamp, 9.5 - 12mm 512 4245650 Weldment - Swan neck 113 4220480 Weldment - Control Panel 114 4246810 Valve, Rollover 115 4150180 Fuel Line (6mm) 216 4150180 Fuel Line (6mm) 117 4247950 Clip - Fuel Hose 318 469016509 P - Clip 219 009072070 Washer - M8 X 22 X 3 820 450190 Screw - Hex M8 - 1.25 X 16 1021 4282951 Tank, fuel EPA / CARB Compliant 122 001599246 Washer 25/64 223 4258312 AV Washer 8.7 x 13.5 x 2.5 2

Parts- 28

PARTS MANUAL-GP 400

CARBON CANISTER


Parts- 29

PARTS MANUAL-GP 400


1 001925160 Hose Clamp, 6-16 72 4150180 Fuel Line (6mm) 0.78M3 4150180 Fuel Line (6mm) 0.8M4 4246911 Fuel Line (10mm) 0.1M5 4246912 Fuel Line Adaptor 16 4236602 Briggs and Stratton Carb Engine 17 4246810 Valve, Rollover 18 4247032 Wldmt-Carbon Canister 19 4246910 Delphi-Carbon Canister 110 450168 Screw-Hex M6 x 12 411 450410 Lockwsher-M6 x 9.6 x 1.5 4

* Not Illustrated

Parts- 30

PARTS MANUAL-GP 400

FUEL TANK DIESEL


Parts- 31

PARTS MANUAL-GP 400


1 4229120 Kelch - Non Vented Fuel Cap 12 4219901 Fitting - Barb STR, 5/16" Fuel Hose 13 4219900 Fitting - Barb STR, 1/4" Fuel Hose 14 2218147 Grommet - Gauge 15 4248170 Gauge - Fuel Level 16 4222224 Tank 1

* Not Illustrated

Parts- 32

PARTS MANUAL-GP 400

FUEL TANK GASOLINE - NONE EPA AND CARB COMPLIANT


1 2

3

11

5

4

Parts- 33

PARTS MANUAL-GP 400


1 2218147 Grommet - Gauge 12 4248170 Gauge - Fuel Level 13 4219900 Fitting - Barb STR, 1/4" Fuel Hose 14 4222223 Tank 15 4229120 Kelch - Non Vented Fuel Cap 1

Parts- 34

PARTS MANUAL-GP 400

FUEL TANK GASOLINE - EPA AND CARB COMPLIANT


Parts- 35

PARTS MANUAL-GP 400


1 4287174 Kelch Cap 12 4291015 Grommet, Pick Up Tube 23 4291031 Barb, Hose Ftg 1/4 Straight 14 4291014 Tube, Fuel Pick Up 15 4291012 Gauge, Fuel Level 16 4282952 Tank - Fuel EPA/CARB Comp 1

Parts- 36

PARTS MANUAL-GP 400

CARGO NET ASSEMBLY


Parts- 37

PARTS MANUAL-GP 400


1 4239247 Cargo Net Assembly 14239246 • Cargo Net 1 Not available as a spare 4239248 • Cargo Net Clips 6 Not available as a spare

2 4249850 Cargo net access retainer clip 13 450389 WSHR-M6 x 12.5 x 1.8 64 450410 Lock Washer-M6 x 9.6 x 1.5 6 5 450541 Scrw-pan HD M6 x 16 6 6 450542 Scrw-pan HD M6 x 20 1

* Not Illustrated

Parts- 38

PARTS MANUAL-GP 400

4922322

19A

20320

426

2620

420

2

35

5510

5428

6

7

4

4A

4B

43

46

36 47

15

18

200

No

te:

Item

200

incl

ud

es it

ems

202,

203

an

d 2

04

2173

B

232460

53

53A

11

50209

4414

C

1616

A

2572

A

72

69

169A

169

30

27

1727

38

3433

8786

85

57

100

8988

12

9191

A

9191

A1

4C83

TRANSMISSION PUMP


Parts- 39

PARTS MANUAL-GP 400


894103 Transmissiom Pump 1 series 15-23231 End cap 34 Cylinder block kit 14A Piston assembly 94B Slipper retainer 14C Cylinder block 16 Swashplate 17 Thrust plate 110 Ball bearing 112 Shaft 115 Roller bearing 116 Plug 116A O-ring 117 Trunnion control shaft 118 Screw 425 Check valve poppet 226 Washer 227 Retaining ring 228 Spring coiled pin 430 Trunnion shaft 133 O-ring 134 Back up ring 135 Pipe plug 236 O-ring 238 Bypass valve 143 Valve plate 146 Gasket 147 Pin 153 Plug 153A O-ring 154 Retaining ring 155 Retaining ring 157 O-ring 258 Adapter flange 169 Spring 272 Plug assembly 272A O-ring 283 Coupling 186 Washer 287 Screw 288 pad seal 189 Cover plate 191 Plug 191A O-ring 1100 Screw 2169 Plug 1169A O-ring 1

* Not Illustrated

Parts- 40

PARTS MANUAL-GP 400

TRANSMISSION PUMP


4922322

19A

20320

426

2620

420

2

35

5510

5428

6

7

4

4A

4B

43

46

36 47

15

18

200

No

te:

Item

200

incl

ud

es it

ems

202,

203

an

d 2

04

2173

B

232460

53

53A

11

50209

4414

C

1616

A

2572

A

72

69

169A

169

30

27

1727

38

3433

8786

85

57

100

8988

12

9191

A

9191

A1

4C83

Parts- 41

PARTS MANUAL-GP 400


200 Housing assembly 1202 Needle bearing 1203 Needle bearing 1204 Lip seal 2A Implement relief kit 12 • Implement relief spring 119 • Plug 122 • O ring 123 • Shim kit 149 • Charge relief cone 1B Charge relief kit 121 • Plug 124 • Charge relief spring 160 • Charge relief cone 173 • O ring 176 • Shim kit 1C Charge pump kit 19 • Charge pump housing 111 • Lip seal 114 • O-ring 120 • Screw 444 • Gerotor assembly 150 • Needle bearing 1

Parts- 42

PARTS MANUAL-GP 400

TRANSMISSION PUMP CONTROL


Parts- 43

PARTS MANUAL-GP 400


1 344545 Brg-Ball 1/2" x 1-1/8" x 3/8" 12 2701711 Pump, Hydraulic (Cyl) 13 3000693 Spring Extension 14 4143627 Wldmt-Neutral Control 15 361108 Bushing 26 408851 Scrw-Hex 1/4 x 3/4 37 001393222 Nut-Hex 5/16-18 Staytite 18 4143669 Wldmt-Pump Neutral 19 4144586 Bushing, Flange 110 001399082 Nut-Hex 1/4-28 Nyloc 111 452436 Nut-Hex M8 Flng Nyloc 112 461387 Pin-Roll 1/4" x 1" 113 894103 Pump Assy, Hydraulic 114 4159640 Rod End 115 452200134 Lockwshr-3/8" x 0.063 x 0.094 216 3009733 Eccentric Bolt 117 3009734 Roller Arm 118 4239242 Control Cable 1

* Not Illustrated

Parts- 44

PARTS MANUAL-GP 400

Illustration Number: 4221480-1

CUTTING MOTORS

5

4

2

1

5

1

3

5

1

1

Parts- 45

PARTS MANUAL-GP 400

Parts- 45

PARTS MANUAL-GP 400


1 W158007-02 90-m/m 13/16 ORS X 3/4 SAE 42 2701710 Motor, Hydraulic Reel Drive 3* 2702706 • Service Kit 13 158059-03 45-m/m 11/16 ORFS X 9/16 SAE 14 158006-05 Fitting-13/16 ORFS X 3/4 SAE 15 002515000 Fitting-9/16 ORS X 7/16 SAE 3* 4310053 Rear Plate Screw Hex 4

Parts- 46

PARTS MANUAL-GP 400

REAR LIFT CYLINDER

LEFT AND RIGHTFRONT LIFT CYLINDER

STEERING RAM

STEER VALVE

11

5

2

3

6

5

7

89

10

12

3

3

5

5

5

13

14

1516

16

17

18

19

8

5

LIFT / STEER RAMS

Illustration Number: 4221480_2

LIFT STEER RAMS

Parts- 47

PARTS MANUAL-GP 400


2 4244283 Steering Cylinder Rod 1* 4288991 Seal Kit for 42442833 4183641 Ram-hydraulic 35 002525010 90-m/m 9/16 ORS X 9/16 SAE 66 158006-01 Fitting-m/m 11/16 ORS X 9/16 SAE 17 158007-01 90-m/m 11/16 ORS X 9/16 SAE 18 452101285 Washer-1/2 X 1-1/8 X .104 29 001399032 Nut-hex 1/2-20 Nyloc 110 831877 Bushing- .51" X .7485/.7480" X 1.438" 111 800800 Washer-1/2 X 1.1/2 X 2.5mm 112 451030667 Bolt-hex 1/2-20 X 2-1/2 113 4239255 Steering Unit 114 158006-01 Fitting-m/m 11/16 ORS X 9/16 SAE 115 W158059-04 45-m/m 11/16 ORFS X 9/16 SAE 116 839846 45-m/m 9/16 ORFS X 9/16 SAE 217 450389 Washer-M6 X 12.5 X 1.8 418 450410 Lock Washer-M6 X 9.6 X 1.5 419 450170 Screw-hex M6 X 16 4

Parts- 48

PARTS MANUAL-GP 400

FILTER

DIESEL OIL COOLER ARRANGEMENT

1

1

2

3

4

4

4

4

4

5

6

7

8

PETROL OIL COOLER ARRANGEMENT

Illustration Number: 4221480 - 3

FILTER & COOLER

Parts- 49

PARTS MANUAL-GP 400

Parts- 49

PARTS MANUAL-GP 400


1 842916 Cooler, Oil 12 158006-11 Fitting-m/m 1 ORS X 1-1/16 SAE 13 158010-02 Tee-m/f/m 1 ORS 14 158007-06 90-m/m 1 ORS X 1-1/16 SAE 35 4252570 Filter-hyd, (Argo) 7 Bar 1* 4199061 • Element 10 mm Absolute 16 450389 Washer-m6 X 12.5 X 1.8 47 450410 Lock Washer-M6 X 9.6 X 1.5 48 450170 Screw-hex M6 X 16 4

Parts- 50

PARTS MANUAL-GP 400

FRONT LH WHEEL MOTOR

FRONT RH WHEEL MOTOR

1

2

2

3

4

5

7

2

8

9


FRONT MOTORS

Parts- 51

PARTS MANUAL-GP 400

Parts- 51

PARTS MANUAL-GP 400


1 4115024 Front Right Wheel Motor 1* 891910 Service Kit 1* 800777 Key 1* 800778 Nut 12 158006-07 Fitting - ORB/ ORS 33 158007-01 Fitting - 90 ORS/orb 14 69068-01 Orifice Disk 0.052" 15 892381 Front Left Wheel Motor 1* 891910 Service Kit 1* 800777 Key 1* 800778 Nut 17 002535010 45-m/m 1 ORS X 7/8 SAE 18 450413 Lock Washer-M12 X 17.9 X 2.5 89 450054 Bolt-hex M12 X 70 8

Parts- 52

PARTS MANUAL-GP 400

BACKLAP VALVE

1

2

3

4

3

5

6

7


BACKLAP VALVE

Parts- 53

PARTS MANUAL-GP 400


1 4221020 Backlap Valve 12 158006-11 Fitting-m/m 1 Ors X 1-1/16 SAE 13 158006-06 Fitting-m/m 13/16 Ors X 7/8 SAE 24 158007-03 90-m/m 13/16 Ors X 7/8 SAE 15 450213 Screw-hex M10 X 20 46 450412 Lock Washer-M10 X 15.9 X 2.5 47 450391 Washer-M10 X 21 X 2.2 4* 4294754 Coil 1* 4294760 Switch 1

Parts- 54

PARTS MANUAL-GP 400

2

3

4

1

5

BACKLAP VALVE BREAKDOWN

4221020-Backlap_valve

Parts- 55

PARTS MANUAL-GP 400


4221020 Backlap Valve 11 4250130 • Cartridge Valve 12 4238263 • Adjustable Flow Control Valve 13 4238262 • 2 Position Pilot Valve 14 4238264 • 3 Position 4 Way Cartridge Valve 15 4238265 • 2 Position Solenoid Relief Valve 1

* Not Illustrated

Parts- 56

PARTS MANUAL-GP 400

CUTTER LIFT VALVE

12

5

2

3

3

4

67

7

8

9


CUTTER LIFT VALVE


Parts- 57

PARTS MANUAL-GP 400

1 4221040 Cutter / Lift Valve 12 158056-02 Fitting-ORS/O-ring Tee 23 158006-05 Fitting-ORS/ORB 24 002498490 Tee-m/f/m 13/16 ORS 15 002498400 Tee-m/f/m 11/16 ORS 16 002600230 Reducer-f/m 13/16 X 11/16 ORS 17 450389 Washer-M6 X 12.5 X 1.8 48 450377 Nut-hex M6 Nyloc 29 450005 Bolt-hex M6 X 50 2

Parts- 58

PARTS MANUAL-GP 400

1

2

UTTER / LIFT VALVE BREAKDOWN

Illustration Number: 4221040-Cutter-Lift_Valve

Parts- 59

PARTS MANUAL-GP 400


4221040 Cutter / Lift Valve 11 4238266 • Relief Valve 12 4238267 • 3 Position Solenoid Cartridge Valve 1

* Not Illustrated

Parts- 60

PARTS MANUAL-GP 400

PUMP STACK

1

2

2

3

4

5

7

8

10

10

9 6


PUMP STACK

Parts- 61

PARTS MANUAL-GP 400


1 2701711 Pump, Hydraulic Gear 1* 2702707 Service Kit 12 158056-01 Fitting - ORS/O-RING TEE 13 4186000 Cross-M/M/M/F 11/16 ORS 14 158007-01 Fitting - 90 ORS/ORB 15 839820 Adapter, 90 EL 1.44-12 x 1.06-12 16 158059-01 Fitting - 45 ORS/ORB ADJ 17 158006-07 Fitting- ORS/ORB 18 158006-13 Connector,Straight THD 19 4231440-01 Fitting -F/M 13/16 ORFS 1* 002449048 Test Point-1/8 BSPP x M16 110 002568030 13/16" - CAP 2

Parts- 62

PARTS MANUAL-GP 400

1

2

34

5

6

HYDRAULIC TANK CONNECTIONS


Parts- 63

PARTS MANUAL-GP 400


1 4229000 Tank-hydraulic 12 4229260 Fitting-1 5/16"SAE-1 3/16"ORFS 13 158006-05 Fitting-13/16 ORFS X 3/4 SAE 14 4246090 Hydraulic Hose 15 4234040 Hydraulic Hose 16 4231840 Hydraulic Hose 1

* Not Illustrated

Parts- 64

PARTS MANUAL-GP 400

12

1

3

2

2

2

5

6

7

8

4

BULKHEAD FITTINGS


Parts- 65

PARTS MANUAL-GP 400


1 008012590 Needle Valve 32 002590690 Fitting-11/16 ORS X 1/4 BSP 63 002590090 11/16" Tee-Bulkhead 14 843915 45-M/M 11/16 ORFS Bulkhead 15 4136396 Tee-M/M/Bulkhead 11/16 ORS 16 4218440 Weldment-Chassis 17 4136395 90 Bulkhead-M/M 13/16 ORS 18 158067-04 Fitting-Bulkhead M/M 13/16 ORS 2

* Not Illustrated

Parts- 66

PARTS MANUAL-GP 400

67

89

1314

34

15

2

1

3

45

1

128

78 6

7

16

14

7

8

9

x 2

x 2

x 3

10 178

6 x 2

8

10 118

6

8

CLAMPS


Parts- 67

PARTS MANUAL-GP 400


1 2208139 5/8 Bore Hose Clamp 22 009079310 Top Plate-tube Clamp 13 450390 Washer-M8 X 17 X 1.8 24 450411 Lock Washer-M8 X 12.75 X 2 25 450019 Bolt-hex M8 X 55 16 450377 Nut-hex M6 Nyloc 87 4150297 Single Clamp 12 mm 68 450389 Washer-m6 X 12.5 X 1.8 159 450175 Screw-hex M6 X 40 510 450173 Screw-hex M6 X 30 411 4240222 Clamp-double 12mm 312 450007 Bolt-hex M6 X 60 113 837735 Hose Clamp Bottom - 5/8" Bore 214 837737 Clamp Plate 215 837736 Clamp Plate 116 450196 Screw-hex M8 X 45 117 844219 Clamp-double 10mm 2

* Not Illustrated

Parts- 68

PARTS MANUAL-GP 400

1

23

7

8

9

710

13 11

12

15

4 5

6

14

1617

18

CUTTING CIRCUIT


Parts- 69

PARTS MANUAL-GP 400


1 4147136 Hose, RH Motor Rear 12 4147137 Hose, RH Motor Drain 13 4147135 Hose, RH Motor Front 14 4147139 Hose, LH Motor Front 15 4147140 Hose, LH Motor Drain 16 4147138 Hose, LH Motor Rear 17 4226741 Hydraulic Tube 18 4226744 Hydraulic Tube 19 843913 Hose, Hydraulic .25 ID X 76.00" Long 110 4227600 Hydraulic Tube 111 843921 Hose, Hydraulic .50 ID X 47.50" Long 112 843922 Hose, Hydraulic .50 ID X 43.25" Long 113 843911 Hose, Hydraulic .25 ID X 47.50" Long 114 4202181 Hydraulic Tube 115 4231640 Hydraulic Tube 116 4231840 Hydraulic Tube 117 4234040 Hydraulic Tube 118 4232180 Hydraulic Tube 1

* Not Illustrated

Parts- 70

PARTS MANUAL-GP 400

1

2

3

4

5

7

6

8

TRANSMISSION CIRCUIT


Parts- 71

PARTS MANUAL-GP 400


1 4239822 Hydraulic Tube 12 4239722 Hydraulic Tube 13 4239723 Hydraulic Tube 14 4226742 Hydraulic Tube 15 4303496 Hydraulic Tube 16 4245192 Hydraulic Tube 17 843926 Hose, Hydraulic .50 Id X 16.75" Long 18 4234040 Hydraulic Tube 1

* Not Illustrated

Parts- 72

PARTS MANUAL-GP 400

2

3 4

5

6

7

8

19

11

8

10

LIFT CIRCUIT


Parts- 73

PARTS MANUAL-GP 400


1 843908 Hose, Hydraulic .25 ID X 10.62" Long 32 839837 Hose, Hydraulic .25 ID X 10.50"Long 13 4226780 Hydraulic Tube 14 4226740 Hydraulic Tube 15 4226781 Hydraulic Tube 16 4227880 Hydraulic Tube 17 4227881 Hydraulic Tube 18 4147141 Hose, Rear Lift RAM 29 4231640 Hydraulic Tube 110 4232180 Hydraulic Tube 1

* Not Illustrated

Parts- 74

PARTS MANUAL-GP 400

1

32

2

STEERING CIRCUIT


Parts- 75

PARTS MANUAL-GP 400

Parts- 75

PARTS MANUAL-GP 400


1 839842 Hose, Hydraulic .25ID X 77" Long 12 843919 Hose, Hydraulic .38 ID X 72.50" Long 23 4237263 Hydraulic Hose 1

* Not Illustrated

Parts- 76

PARTS MANUAL-GP 400

DIESEL ARRANGEMENT

GAS ARRANGEMENT

1

2

3

4

2

3

TANK FILTER COOLER CIRCUIT


Parts- 77

PARTS MANUAL-GP 400


1 4250913 Hydraulic Hose 12 4232140 Hydraulic Hose 13 4246090 Hydraulic Hose 14 4232120 Hydraulic Hose 1

* Not Illustrated

Parts- 78

PARTS MANUAL-GP 400


HYDRAULIC TANK DIESEL AND NON EPA AND CARB COMPLIANT GASOLINE

Parts- 79

PARTS MANUAL-GP 400


1 2218147 Grommet-Gauge 12 4153597 Strainer-Suction, 125 Micron 13 4240922 Breather / Filler 1 * • 4292311 Bretaher/Filler seal Metal 1 * • 4292312 Bretaher/Filler seal O ring 14 4238062 Gauge-Hyd Level 15 4222225 Tank-Hydraulic 1

* Not Illustrated

Parts- 80

PARTS MANUAL-GP 400

HYDRAULIC TANK GASOLINE EPA AND CARB COMPLIANT GASOLINE

Illustration Number: 4282955_A_hyd_tank

Parts- 81

PARTS MANUAL-GP 400


1 4240922 Breather/fill-hyd Oil 12 4291051 Gauge,oil Level 13 4282956 Tank-hydraulic 14 4153597 Strainer-suction, 125 Micron 1

Parts- 82

PARTS MANUAL-GP 400

CONTROL ARM


Parts- 83

PARTS MANUAL-GP 400


1 4239251 Acoustic-Steer Cover Top 12 001399032 Nut-Hex 1/2-20 Nyloc 1 .4 2811364 Steering Wheel 15 4134028 Nut-Lug M6 66 4208220 Wldmt - Steering Arm (Danfoss) 17 4213400 Cover-Steering Column Top 18 4213401 Bottom Cover 19 4246371 Boss - Steering Arm Lock 111 4246372 Handle 112 4239249 Acoustic-Steering Cover Bottom 113 450170 Screw-Hex M6 x 16 414 001021090 Screw 1/2" UNC x 3/4 115 450389 Washer-M6 x 12.5 x 1.8 417 450410 Lock Washer-M6 x 9.6 x 1.5 418 450542 Screw-Pan HD M6 x 20 619 451031477 Bolt-Hex 1/2-20 x 4-1/2 120 452101285 Washer-1/2 x 1-1/8 x 0.104 221 800845 CBolt, 0.5-13 1.50 YS G5 (KC) 122 450413 Lock Washer-M12 x 17.9 x 2.5 123 38404-01/02 Handle Grip 124 800800 Washer-1/2 x 1.1/2 x 2.5mm 125 4239255 Steering Unit 1

* Not Illustrated

Parts- 84

PARTS MANUAL-GP 400

6

ab

c

d

e

f gh

i 7

HANDBRAKE


Parts- 85

PARTS MANUAL-GP 400


* 4205283 Kit-Handbrake GP400 Includes part no 1, 3, 4, 5.1 4187540 • Handbrake H29 10:1 1* 4209180 • Switch Assy 1* 4209181 • E-Clip 1* 4209182 • M2 Stainless Nut 2* 4209183 • Pin 1* 4209184 • R-Clip 1* 4209185 • Screw SSM2 CH Hd 2* 4209186 • M2 Stainless Washer 42 4189460 Boss-Handbrake 1 .3 4203580 • Cable Assy-Equaliser 14 4204342 • Cable-Brake, Short 15 4204440 • Cable-Brake, Long 16 4210540 Assm-Brake Caliper Ccw (Long Lever) 1a 4207120 Lever-Brake Caliper Rh 1b 2188147-02 • Pad-Cam Side 1c 2188147-03 • Pad-Support 1d 2188147-04 • Spring-Lever Retainer 1e 2188147-05 • Housing 1f 2188147-06 • Cam 1g 2188147-07 • Pin-Pivot 1h 503660 • Pad-Carrier Side 1i 2188147-09 • Pad-Support 17 4210541 Assm-Brake Caliper Cw (Long Lever) 1a 4207121 Lever-Brake Caliper Lh 1b 2188147-02 • Pad-Cam Side 1c 2188147-03 • Pad-Support 1d 2188147-04 • Spring-Lever Retainer 1e 2188147-05 • Housing 1f 2188147-06 • Cam 1g 2188147-07 • Pin-Pivot 1h 503660 • Pad-Carrier Side 1i 2188147-09 • Pad-Support 18 4218440 Wldmt-Chassis GP400 19 450032 Bolt-Hex M10x50 110 450215 Scrw-Hex M10x30 111 450379 Nut-Hex M10 Nyloc 212 450391 Wsher M10 x 21 x 2.2 413 843160 Hub, Wheel & Disc 214 4237062 Wheel Assy Complete 2

4222722 • Rim-10x8.50 14233900 • Tyre 20x10-10-2 Ply OTR Smooth 14220940 • Tubeless Tyre Valve Assy - TR412 1

15 64220-01 Bolt-Wheel 1/2-20x.88 60d 8 Torque 95 - 108NM

* Not Illustrated

Parts- 86

PARTS MANUAL-GP 400

19

19.1

19.2

19.3

19.4

19.5

REAR WHEEL


Parts- 87

PARTS MANUAL-GP 400


1 002036070 Brg-Ball 35 x 72 x 17 22 002993063 Lubricator-M6 x 45 13 310854 Nut-Hex JAM 1-14 24 450020176 Nut-Hex 5/8-18 25 450020354 Nut-Hex 3/4 -16 Thin 16 450425 Lockwshr-M16 x 27.3 x 3.7 28 452000562 Wshr-3/4 x 1-1/2 x 0.128 19 452000627 Wshr-1 x 1-7/8 x 0.160 110 452101293 Wshr-5/8 x 1-3/8 x 0.128 411 836719 Nut, Bearing ADJ 112 892171.07 Hub ASM-Wheel 113 892913.06 Fork W/Assy 114 889859 Cone Ay, Bearing 2

830000441 • Brg-Tpr 0.75 x 1.781 x 0.61 1809229 • Wshr, 0.75 1.07 0.05 Ns Flat 1836621 • Seal-11223 1

15 4237062 Wheel Assy Complete 14222722 • Rim-10x8.50 14233900 • Tyre 20x10-10-2 Ply OTR Smooth 14220940 • Tubeless Tyre Valve Assy - TR412 1

16 889843 Axle Ay, Front Wheel 117 450990638 Nut - Whl 7/16-20 x 60 Deg 4 Torque 54 - 68NM18 4210100 Steering Joint, Treated 1* 831877 Bushing 1* 809268 Ring, Brg Backing 219 4240122 Rear Axle Weight 119.1 64220-01 • Bolt-Whl 1/2-20 x 0.88 60D 419.2 4126604 • Outer Rear Axle Weight 119.3 4236482 • Wldmt-Wheel Hub 119.4 450412 • Lock Washer-M10 x 15.9 x 2.5 419.5 450213 • Scrw-Hex M10 x 20 4

.

* Not Illustrated

Parts- 88

PARTS MANUAL-GP 400

FOOTPEDAL


Parts- 89

PARTS MANUAL-GP 400


1 450325 Nut-Hex M10 12 450219 Scrw-hex M10 x 50 13 W022372 Throttle Clamp 14 002920280 Sprng-Disc 6.2 x 12.5 x 0.5 25 450389 Wshr-M6 x 12.5 x 1.8 36 4149979 Mow Speed Bush 17 450170 Scrw-Hex M6 x 16 18 MBF0942 Cable Clamp 19 450192 Scrw-hex M8 x 25 110 450324 Nut-Hex M8 111 450378 Nut-Hex M8 Nyloc 112 4150697 Wldmt, Mow Speed Lever 113 450553 Scrw-Pan HD M8 x 25 114 450390 Wshr-M8 x 17 x 1.8 215 J366877 Nyliner Bearing 316 456110024 Scrw- Hex 1/4 x 1 217 001399121 Nut-Hex 1/4-28 Nyloc 318 831518 Rod End 119 MBG6994 Bush-Steel 220 450376 Nut-Hex M5 Nyloc 121 450151 Scrw-Hex M5 x 16 122 002920501 Sprng-Disc 8.2 x 16 x 0.9 123 450377 Nut-Hex M6 Nyloc 224 450542 Scrw-Pan HD M6 x 20 225 4149978 Mow Speed Bracket 126 4144026 Footpedal 127 839388 Bracket, MTG, Pivot 128 4239242 Transmission Cable 129 840003 Tread, Control Pedal 2

* Not Illustrated

Parts- 90

PARTS MANUAL-GP 400

SEAT (MILSCO)


Parts- 91

PARTS MANUAL-GP 400


1 4215580 Mount Seat- MILSCO XB200 12 4197500 MILSCO Seat XB200 1

4197520 • Seatbelt - 2" - with fixing kit 14198020 • Seat Switch - Delta 20068 1

* Not Illustrated

Parts- 92

PARTS MANUAL-GP 400

SEAT (GRAMMER)

9


Parts- 93

PARTS MANUAL-GP 400


1 002953320 Diaphragm Grommet 12 4218740 Assy - M10 Bolt with Lanyard 2

002720296 • Lanyard 1002720297 • Ring-Crimp 14139693 • Seat Plate Stud 1451498 • Pin-Spirol 8 x 50 1

3 4239250 Acoustic-Seat Plate 14 4244584 Seat Plate - MILSCO / MSG65 15 450192 Scrw-Hex M8 x 25 66 450378 Nut-Hex M8 Nyloc 107 450390 Wshr- M8 x 17 x 1.8 178 823332 Bushing 2* 4244917 MSG 65 - Hardware + Stop Kit 19 4180700 Seat & Suspension Grammer 1* 450411 Lock Washer-M8 X 12.75 X 2 4* 450390 Washer-M8 X 17 X 1.8 8* 450377 Nut - Hex M6 Nyloc 1* 450190 Screw - Hex M8 X 16 4* 4243182 MSG 65 - Slide Rail Set 1* 4140867 Harness 1* 452101510 Washer - 3/8 X 1-1/2 X .104 2* 450412 Lock Washer - M10 X 15.9 X 2.5 2* 450219 Screw - Hex M10 X 50 2

Parts- 94

PARTS MANUAL-GP 400

1

2

3

456

R4R3R2

R2 - GASR3 - DIESEL ONLYR4 - DIESEL & GAS

INSTRUMENT CONTROL

Illustration Number: 4212480g

Parts- 95

PARTS MANUAL-GP 400


1 N/a Relay Base Single 22 008238350 Fuse Holder 1

008233164 • Fuse 10 Amp 1 Air Seat (Red)008233180 • Fuse 20 Amp 1 Plus +1 Controller (Yellow)008233164 • Fuse 10 Amp 1 PTO Switch (Red)008233164 • Fuse 10 Amp 1 Accessory Socket (Red)008233172 • Fuse 15 Amp 1 Working Lights (Blue)

3 009072070 Washer - M8 X 22 X 3 24 4138885 Accessory Socket - Large 15 4142655 Horn 16 4263076 Plus+1 Controller 1 C/w GP400 Generic Program7 4150739 Throttle Cable - Diesel 18 4197063 Inductive Sensor 19 4212483 Weldment - Cradle Frame 110 4245050 Instrument Cover 111 4245052 Weldment - Control Panel Aux Socket 112 4226883 Panel - Instrument Assembly (Gas) 113 4228541 Shoulder Bolt 214 450175 Screw - Hex M6-1.0 X 40 215 450191 Screw - Hex M8-1.25 X 20 616 450376 Nut - Hex M5-0.8, Nyloc 1017 450377 Nut - Hex M6-1.0, Nyloc 218 450378 Nut - Hex M8-1.25, Nyloc 419 450389 Washer - M6 X 12.5 X 1.8 720 450390 Washer - M8 X 17 X 1.8 1021 450411 Lockwasher - M8 X 12.75 X 2 222 450526 Screw - Pan Hd M5-0.8 X 12 923 450529 Screw - Pan Hd M5-0.8 X 20 424 4175078 Relay (20/40 Amp Change Over) 2 Diesel* 4175078 Relay (20/40 Amp Change Over) 1 Gas25 4154600 40 Amp Maxi Fuse 1 Orange26 4226881 Panel-instrument Assembly (Diesel) 127 840002-1 Timer 1 Diesel Only28 001394016 Nut-speed M6 129 4227280 Cable-mow / Transport Selector 130 4250730 Plate - Sensor Retainer 131 450528 Screw - Pan Hd M5-0.8 X 16 432 4250630 Bracket - Mode Sensor 133 450388 Washer - M5 X 10 X 1.1 1234 4161528 Conduit Clamp-28mm 135 4167144 Conduit Clamp-20mm 236 4161527 Conduit Clamp-16mm 137 450323 Nut - Hex M6-1.0 138 450539 Screw - Pan Hd M6-1.0 X 12 139 450322 Nut - Hex M5-0.8 140 450410 Lockwasher - M6 X 9.6 X 1.5 141 450541 Screw - Pan Hd M6-1.0 X 16 142 450527 Screw - Pan Hd M5-0.8 X 14 243 4175079 Micro Relay 15/25 Amp 1 Gas

* Not Illustrated

Parts- 96

PARTS MANUAL-GP 400

INSTRUMENT PANEL (DIESEL)


Parts- 97

PARTS MANUAL-GP 400


1 008289120 Ignition Switch 1* 4191900 • key 12 008298544 Push Switch (Horn) 1 .3 1004290 Joystick 14 4142708 Hourmeter 1 To S/N GY000709 & GY0007124 4274659 Hourmeter 1 From S/N GY000710 & GY000713* 4274930 Adapter for new Hour Meter 15 4152717 Gauge-Temp 16 4159102 Mow / Reel Switch (Yellow) 17 4212121 Cut Active Indicator Led 18 4226884 Inst-Panel GP400 19 4230900 Filter Block Indicator Led 210 4237083 Switch (Black) 111 450376 Nut-Hex M5 Nyloc 412 450388 Wshr-M5 x 10 x 1.1 413 450528 Scrw-Pan HD M5 x 16 4

Harnesses/Leads - Diesel* 4263150 Main Harness-GP400 Common 1* 4227640 Worklamp Harness 1* 4227642 Engine Harness 1* 4230901 Lead Battery Positive 1* 4230902 Lead Battery Negative 1* 4175141 Rubber Boot - Black 1

* Not Illustrated

Parts- 98

PARTS MANUAL-GP 400

INSTRUMENT PANEL (GAS)


Parts- 99

PARTS MANUAL-GP 400


1 4212121 Cut Active Indicator LED 12 4230900 Filter Block Indicator LED 13 4230903 Grommet 14 4142708 Hourmeter 1 To S/N GZ000355 & 62706004804 4274659 Hourmeter 1 From S/N GZ000356 & 6270600481* 4274930 Adapter for new Hour Meter 1 5 008289120 Ignition Switch 1* 4191900 • key 16 4226884 Inst-Panel GP 400 17 1004290 Joystick 18 4159102 Mow / Reel Switch (Yellow) 19 450376 Nut-Hex M5 Nyloc 410 008298544 Push Switch (Horn) 111 450528 Scrw-Pan HD M5 x 16 412 4237083 Switch (Black) 113 450388 Wshr-M5 x 10 x 1.1 4

Harnesses/Leads - Gas* 4239262 Main Harness-GP400 Common 1* 4227640 Worklamp Harness 1* 4227641 Engine Harness 1* 4230901 Lead Battery Positive 1* 4230902 Lead Battery Negative 1* 4175141 Rubber Boot - Black 1

* Not Illustrated

Parts- 100

PARTS MANUAL-GP 400

BATTERY


Parts- 101

PARTS MANUAL-GP 400


1 4214680 Wldmt-Battery Tray 12 4232840 Hinge Plate Batt.Cov. 13 008230310 Battery-Type 093 14 4217384 Hinge-Storage Box 45 450170 Scrw-Hex M6 x 16 46 450172 Scrw-Hex M6 x 25 27 450191 Scrw-HexM8 x 20 18 450377 Nut-Hex M6 NYLOC 29 450378 Nut-Hex M8 NYLOC 110 450389 Wshr-M6 x 12.5 x 1.8 811 450390 Wshr-M8 x 17 x 1.8 212 450410 Lockwshr-M6 x 9.6 x 1.5 413 450593 Scrw-CSK M4 x 10 1214 452717 Nut-Hex M4 Nyloc 615 4215221 Battery Cover 116 4132871 Battery Clamp 117 002920501 Sprng-Disc 8.2 x 16 x 0.9 218 450552 Scrw Pan-HD M8 x 20 2

* Not Illustrated

Parts- 102

PARTS MANUAL-GP 400

TOOLBOX/STEP


Parts- 103

PARTS MANUAL-GP 400


1 001496044 Rivet-Pop 4.8 x 12 12 4164620 Toolbox-Base 13 450120021 Nut-Hex 5/16-18 24 450191 Scrw-Hex M8 x 20 25 450377 Nut-Hex M6 NYLOC 46 450390 Wshr-M8 x 17 x 1.8 67 450411 Lockwshr-M8 x 12.75 x 2 48 450539 Scrw-Pan HD M6 x 12 49 523224 Bumper-Rubber 210 523169 Tread, Toolbox 111 835039 Fastner-Snap 112 840171.07 Cover-Box 113 840172 Hinge 115 450378 Nut-Hex M8 Nyloc 216 MBG4795 Pad-Step LH 117 4238889 Wldmt-Foot Step 118 450192 Scrw-Hex M8 x 25 2

* Not Illustrated

Parts- 104

PARTS MANUAL-GP 400

FRONT LIFT GROUP


Parts- 105

PARTS MANUAL-GP 400


1 001290379 Screw - Set 1/4-20 x 1/4 22 001399105 Nut-Hex 3/8-24 Nyloc 23 4143905 Front Bumper Bracket 24 4183344 Pin-Lynch 0.375" x 2.75" 25 4218440 Wldmt-Chassis GP400 16 4237382 Cylinder Pivot 47 450020265 Nut-Hex 3/8-24 Thin 28 451225 Split Pin - 2.5 x 20 49 452000326 Wshr-3/8 x 3/4 x 0.072 1410 454000297 Split Pin - 1/8 x 1-1/4 811 548168 Washer 1412 548173 Wshr-1 x 1-3/4 x 0.1 413 4137197 Oilite Bush 814 001490870 Pin-Spirol 1/4" x 1-3/4" 215 814499 Spring, Parking Brake 416 839181 Pin, Rod Connecting 217 841203 Pin, Rod Connecting 218 002993013 Lubricator-M6 Straight 419 842471 Rod Threaded 38-24 220 892175 Pivot - Fronthead Steering 221 893787 ArmAY, Link 222 893857.07 Arm AY, LH Front Lift 123 893858.07 Arm AY, RH Front Lift 124 MBF0654A Set Collar 225 4154140 Frame AY, Head Steering 226 450390 Washer-M8 x 17 x 1.8 427 456110189 Screw-Hex 5/16-18 x 3/4 428 523126 Bumper, Rubber 429 001393222 Nut-Hex 5/16-18 Nyloc 430 450378 Nut-Hex M8 Nyloc 431 4126779 Cap 232 841466.06 Bracket-Bumper Frt 233 002993160 Lubricator-M6 x 90 Deg 234 450193 Screw-Hex M8 x 30 435 454000572 Split Pin-3/16 x 1 3/4 236 001593072 Wshr-Thrust 1 x 1.562 x 0.030/0.032 437 001393010 Nut-Hex 5/16-18 Whiz 4

* Not Illustrated

Parts- 106

PARTS MANUAL-GP 400

REAR SWING ARM


Parts- 107

PARTS MANUAL-GP 400


1 839063 Bearing,Ball 1.38 OD X.63 ID 22 2208139 5/8 Bore Hose Clamp 13 4126779 Rubber Cap 14 4154140 Frame AY, Head Steering 15 4159561 Brkt-Latch Lock 16 4183344 Pin-Lynch 0.375" x 2.75" 27 4233921 Wldmt - Arm, Swing 18 4237343 Wldmt-Pivot Arm 19 4237382 Cylinder Pivot 110 450023 Bolt-Hex M8 x 75 211 450083 Bolt-Hex M16 x 150 112 456110016 Scrw-Hex 1/4-20 x 3/4 213 450378 Nut-Hex M8 Nyloc 214 450379 Nut-Hex M10 Nyloc 215 450382 Nut-Hex M16 Nyloc 116 450390 Wshr-M8 x 17 x 1.8 117 450391 Wshr-M10 x 21 x 2.2 118 450452 Nut-Hex M6 Verbus Ripp 219 452101285 Wshr-1/2 x 1-1/8 x 0.104 220 452586 Bolt-CRG M10 x 30 121 454000297 Split-Pin- 1/8 x 1-1/4 322 522840 Wshr-Thrust 1 x 1.281 x 0.083 123 524215 Bushing, Turf Guard 124 548168 Washer 725 548173 Wshr-1 x 1-3/4 x 0.1 226 4137197 Oilite Bush 427 001490870 Pin-Spirol 1/4" x 1-3/4" 128 832499 Brg-Ball 0.98 x 2.05 x 0.59 229 839410 Bushing, Spring Stop 130 4303533 Brkt - Unit Stop 131 842000044 Lubricator-1/4" STR 232 843181 Spacer, Bearing 133 843185 Bushing Pivot 134 843195 Spacer, Bearing 135 893856.07 Arm AY, Centre Lift 136 894141.06 Link ASM - Arm 137 517163 Spacer, .891 (23mm) 238 450019 Bolt-Hex M8 x 55 139 893859 Pivot AY, Rear Head (PLATED) 140 009079310 Top Plate-Tube Clamp 141 450192 Scrw-Hex M8 x 25 442 523126 Bumper, Rubber 143 450411 Lockwshr-M8 x 12.75 x 2 1

* Not Illustrated

Parts- 108

PARTS MANUAL-GP 400

REAR SWING ARM


Parts- 109

PARTS MANUAL-GP 400


44 4261950 Mount-LH Rear Frame Stop 145 001393222 Nut-Hex 5/16-18 Nyloc 1* 002993013 Lubricator-M6 Straight 1* 838476 Latch, Draw 1* 4265291 Control lever Grip - Red 1

Parts- 110

PARTS MANUAL-GP 400

CLASSIC XP MOTOR MOUNTING

Illustration Number: MOTOR _MOUNTING_KIT

1

3

4

56

2

Parts- 111

PARTS MANUAL-GP 400


894991 Reel Motor Adaptor Kit 11 800904 • Stud 22 001393010 • Nut, Hex 5/16 Whiz 23 4247911 • Coupling, Drive 14 845278 • Adaptor Plate 15 845279 • Seal, O Ring 1.49 ID x 0.07 16 845280 • Seal, O Ring 1.99 ID x 0.07 1

* Not Illustrated

Parts- 112

PARTS MANUAL-GP 400

CLASSIC XP CUTTING HEAD

Illustration Number: Cutting Head 067135-36-37

Parts- 113

PARTS MANUAL-GP 400


1 5003577 Frame, Reel 1 2 361877 • Decal, Danger 2 3 1000997 • Decal, Warning 1 4 5003053 7 Blade Reel 67037 Only 1 4 5001099 9 Blade Reel 67038 Only 14 5001101 11 Blade Reel 67024 Only 1 5 1004756 Bearing Housing 16 500534 • Bearing, Cup and Cone 17 336962 • Seal, Grease 18 471214 • Lubricator 19 471240 • Fitting, Vent 110 445795 • Locknut, 15/16-18 Spiralock 2 11 3010293 Stop, Mower 112 458013 Snap Ring 113 367164 Spacer 114 5000415 Bedknife Backing 115 5002771 Bedknife, Fairway 1 7 Blade

503477 Bedknife, High Profile 1 9 & 11 Blade503478 Bedknife, Low Profile 1 9 & 11 Blade503479 Bedknife, Tournament 1 9 & 11 Blade

16 3009138 Screw, 1/4-20 x 1/2” Flat Head 13 17 315298 Bolt, 7/16 x 3/4” 2 18 446136 Lock Washer 5/16" 819 443106 Nut, 5/16-18 Hex 8 20 453009 Flat Washer, 5/16 4 21 1000480 Bearing Housing 1

2000060 • Housing 122 500534 • Bearing, Cup and Cone 123 336962 • Seal, Grease 124 471214 • Grease Fitting 125 471240 • Vent Fitting 126 5002151 Spring, Compression 127 364900 Nut, Reel 128 453011 Flat Washer, 3/8 129 163892 Seal 130 400192 Screw, 5/16-18 x 1-1/2” Hex Head 8 31 446142 Lock Washer, 3/8 Heavy 132 304745 Washer 133 365246 Bolt, Shoulder 134 400294 Screw, 3/8-24 x 1” Hex Head 135 412503 Screw, 3/8-16 x 1-1/4” 4 Square Head36 400184 Screw, 5/16-18 x 3/4” Hex Head 2

* Not Illustrated

Parts- 114

PARTS MANUAL-GP 400

CLASSIC XP REAR ROLLERS

Illustration Number: Rear Rollers for 067135-36-37

Parts- 115

PARTS MANUAL-GP 400


1 1002224 Zerk Bolt 22 3005692 Knob, Front Roller Adjusting 23 441674 Carriage Bolt, 5/16-18 x 1-3/4” 24 446136 Lock Washer, 5/16" 25 443106 Nut 5/16-18 26 2000065 Casting, Counterweight 17 446130 Lock Washer, 1/4 Heavy 48 400110 Screw, 1/4-20 x 7/8” Hex Head 29 2810043 Shield, Reel 110 400018 Screw, 1/4-20 x 3/4" 211 443102 Nut, 1/4-20 Hex 412 453023 Washer, 1/4 213 343616 Stud 214 352737 Screw, 1/4-20 x 7/8” Square Head 215 3008438 Roller Bracket, Right Side 116 3008439 Roller Bracket, Left Side 117 1000770 Roller, Rear 1 7 Blade Reels18 3001654 • Shaft, Roller 119 3001655 • Tube, Roller 120 3001656 • Seal 221 5000625 • Bearing 222 300983 • Seal 223 3001762 • Sleeve 224 445718 • Locknut 5/16" 225 3000698 • Washer 226 162916 Roller, Rear 1 9 & 11 Blade Reels27 5002814 • Tube, Roller 128 345369 • Shaft, Roller 129 461359 • Pin,Roll, 1/8" x 3/4" 230 303558 • Bearing 231 305115 • Seal 232 1002226 Zerk Bolt 2

158568 Gauge, Bedknife (Not Swown) 1

* Not Illustrated

Parts- 116

PARTS MANUAL-GP 400

VERTICUT HEAD


Parts- 117

PARTS MANUAL-GP 400


1 5002577 Frame, reel 12 361877 • Decal, danger 23 351738 • Decal, caution 14 444742 Locknut, 3/4-16 hex jam 15 1004756 Housing, bearing 16 500534 • Bearing, cup and cone 17 336962 • Seal, grease 18 471214 • Fitting, grease 19 471240 • Fitting, vent 110 1003467 Seal 111 453009 Washer, 5/16" 412 458013 Ring, snap 113 400184 Screw, 5/16-18 x 3/4" 214 3010293 Stop, mower 115 400192 Screw, 5/16-18 x 1 1/2" 816 445795 Nut, 5/16-18 spiralock flange 217 446136 Lock Washer, 5/16" 818 443106 Nut, 5/16-18 819 1000480 Housing, bearing 1

2000060 • Housing 120 500534 • Bearing, cup and cone 121 336962 • Seal, grease 122 471214 • Fitting, grease 123 471240 • Fitting, vent 124 1002560 Vertical mower 125 131161 • Assembly, shaft and collar 126 335449 • Blade 2627 352221 • Spacer, blade 7728 352437 • Nut, blade clamp 129 443106 • Nut, 5/16-18 130 412017 • Screw, 5/16-18 x 3/4", square head 131 365246 Bolt, shoulder 232 894991 Kit, motor adapter 1 Must have to mount vertical mower33 103867 • Washer, 5/16 234 306325 • Lock Washer, 5/16 235 306501 • Screw, 5/16-18 x 1 1/2" 236 337370 • Coupling, drive 137 845278 • Adapter, motor 138 845279 • Seal, o-ring, 1.49 i.d. x .07 139 845280 • Seal, o-ring, 1.99 i.d. x .07 1

* Not Illustrated

Parts- 118

PARTS MANUAL-GP 400

REAR ROLLER & SCRAPER VERTICUT


Parts- 119

PARTS MANUAL-GP 400


1 1004990 Roller, rear 12 5002814 • Tube, roller 13 3010422 • Shaft 14 461359 • Pin, roll, 1/8 x 3/4" 25 3010712 • Bearing 26 3010286 • Seal 27 1002224 Zerk bolt 28 2000065 Casting, counterweight 19 400110 Screw, 1/4-20 x 7/8" 210 351520 Clip 311 102024 Scraper, front roller 112 407586 • Screw, 1/4-20 x 5/8", pan head 2 w/Lock Washer13 • Clamp 2 Not Serviced14 • Bar, scraper 2 Not Serviced15 446130 Lock Washer, 1/4" 416 404018 Screw, truss head, 1/4-20 x 3/4" 217 443102 Nut, 1/4-20 418 453023 Washer, 1/4 219 343616 Stud 220 1004991 Roller, front 121 • Tube, roller 1 Not Serviced22 3010621 • Shaft 123 461359 • Pin, roll, 1/8 x 3/4" 224 3010712 • Bearing 225 3010286 • Seal 226 471214 • Fitting, grease 227 3005692 Knob, front roller adjusting 228 441674 Bolt, carriage, 5/16-18 x 1 3/4" 229 446136 Lock Washer, 5/16 230 443106 Nut, 5/16-18 231 352737 Screw, square head, 1/4-20 x 7/8" 232 3008438 Bracket, roller 133 3008439 Bracket, roller 134 409020 Screw, #10 x 3/8", self tap, slotted 635 351521 Rod 136 460026 Pin, cotter 237 3009922.6 Shield, front grass 138 3005373.6 Shield, rear grass 139 351522 Scraper 140 351526 Retainer, scraper 141 400106 Screw, 1/4-20 x 5/8" 442 445260 Nut, speed 4

* Not Illustrated

Parts- 120

PARTS MANUAL-GP 400

ACCESSORY - ROTARY REAR BRUSH


Parts- 121

PARTS MANUAL-GP 400


1 3007975 Bracket, bearing housing 22 471514 Fitting, grease, 1/4-28 23 452006 Washer, 5/16" 44 365229 Bearing w/seal 25 338763 Seal 26 453011 Washer, 3/8" 27 363818 Spring 18 446142 Lock Washer, 3/8" 39 400258 Screw, 3/8-16 x 3/4" 210 340836 Pulley, brush shaft 111 363016 Key, 1/8 x 1/8 x 1/2", parallel 212 365294 Spacer, 1 1/8" long 113 5002463 Brush assembly 113A 340780 Brush replacement 114 365293 Spacer, 9/64" long 115 3008039 Nut, eccentric adjusting 216 1002228 Bolt, roller mounting 216 1002225 Bolt, roller mounting 2 Use with heavy duty rear roller17 415509 Screw, set, 1/4-20 x 1/4" 218 338758 Pulley, reel shaft 119 400188 Screw, 5/16-18 x 1" 120 443106 Nut, 5/16-18 221 400298 Screw, 3/8-24 x 1" 122 365295 Spacer, 27/32" long 1 Use with 5/8" dia. reel shaft22 365302 Spacer, pulley 1 Use with 1/2" dia. reel shaft23 364120 Belt 124 3005971 Spacer, short 1 Use with turf groomer25 1000997 Decal 126 5001067 Shield, belt 127 1002767 Brace, shield 1 Use with 5/8" dia. reel shaft28 1002768 Brace, shield 129 400108 Screw, 1/4-20 x 3/4" 330 446130 Lock Washer, 1/4 331 400194 Screw, 5/16-18 x 1 3/4" 132 453023 Washer, 1/4" 233 415522 Screw, set 5/16-18 x 3/8" 434 3005970 Spacer, long 135 446136 Lock Washer 5/16" 236 452008 Washer, 7/16 1 Use with turf groomer37 364124 Bracket 1 Use with 1/2" dia. reel shaft38 3004410 Spacer, medium 1 Use with 1/2" dia. reel shaft39 400112 Screw, 1/4-20 x 1" 1 Use with 1/2" dia. reel shaft40 443102 Nut, 1/4-20 1 Use with 1/2" dia. reel shaft

* Not Illustrated

Parts- 122

PARTS MANUAL-GP 400

CLASSIC XP FRONT & REAR ROLLS

Illustration Number: 068613-14 & 068580

Parts- 123

PARTS MANUAL-GP 400


FRONT ROLL

068613 Grooved Roll - Steel 1068614 Grooved Roll - Aluminium 1

1 3000012 • Shaft, rear roller 12 3000013 • Roller, grooved (steel) 12 3000394 • Roller, grooved (aluminum) 13 503378 • Bearing, ball, cup and cone 24 367029 • Locknut, 3/4-16 UNF 25 3000026 • Seal, grease 26 3000010 • Adapter, seal 2 Used with steel roller6 3000543 • Adapter, seal 2 Used with aluminum roller

REAR ROLL

068580 Grooved Roll 11 364135 • Bearing, double row 22 315298 • Bolt, wheel 2

* Not Illustrated

Parts- 124

PARTS MANUAL-GP 400

CLASSIC XP FRONT ROLL 2 INCH SMOOTH & SCRAPER


Parts- 125

PARTS MANUAL-GP 400


162917 Front roller assembly, complete 11 131426 • Roller, smooth (steel) 12 102030 • Shaft, front roller assembly 13 461359 • • Pin, roll 1/8 x 3/4 24 303558 • Bearing 25 305115 • Seal 26 471214 • Fitting, grease 27 102024 • Scraper blade assembly 1

Parts- 128

PARTS MANUAL-GP 400

TRUE SET OUTER REEL

Illustration Number: Outer Reel

1

2

2

7

8

8

9

910

10

10

11

11

11

11

12

13

14

14

15 15

15

16

16

17

17

181920 21

25

26

27

3

4

5

5

6

6

6

22

23

23

24

24

4127335

4181863

Parts- 129

PARTS MANUAL-GP 400


1 REF Inner Reel 1 See 6.12 1002224 Zerk Bolt 23 1004990 22” Rear Roller 1 See 7.14 2810043 Shield, Grass 15 4181863 Decal, Read Manual for Service 16 4127335 Decal, Danger 27 3010293 Stop, Reel 18 403782 Screw, 1/4-20 x 3/4” Truss Head 29 453023 Flat Washer, 1/4 210 446130 Lock Washer, 1/4 Heavy 411 443102 Nut, 1/4-20 Hex 412 3008438 Bracket, Right SIde Front Roller 113 3008439 Bracket, Left Side Front Roller 114 441674 Carriage Bolt, 5/16-18 x 1-3/4” 215 445795 Nut, 5/16-18 Spiralock Flange 416 343616 Stud, Front Roller Adjuster 217 3005692 Knob, Front Roller Adjuster 218 367164 Spacer 119 453011 Flat Washer, 3/8 120 446142 Lock Washer, 3/8 Heavy 121 400294 Screw, 3/8-24 x 1” Hex Head 122 REF Front Roller 1 Not included with reel.23 352737 Set Screw, 1/4-20 x 7/8” 224 365247 Shoulder Bolt 225 400184 Screw, 5/16-18 x 3/4” Hex Head 226 2000065 Casting, Counterweight 127 400110 Screw, 1/4-20 x 7/8” Hex Head 2

* Not Illustrated

Parts- 130

PARTS MANUAL-GP 400

Optional MagKnife BedknivesPart Number Description4131369 22” High Profile4131001 22” Low Profile4131370 22” Tournament4131003 22” Super Tournament

Standard Style Bedknives(Secured with screws)

Part Number Description

◆ 503478 22” Low Profile503477 22” High Profile

503479 22” Tournament

4234900 22” Championship

▲ 5003150 22” Medium Section

● 5002887 22” Super Tournament

▲ Standard Bedknife (7 Blade)◆ Standard Bedknife (9 Blade)● Standard Bedknife (11 and 15 Blade)

1

2

3

4

4

5

5

6

7

6

7

8

9

9

10

10

1112

13

13

14

1516

1718

20

21

22

23

24

24

25 26 27 28 29 30

31 32 33

34

19

35

35

TRUE SET INNER REEL

Illustration Number: Inner Reel

Parts- 131

PARTS MANUAL-GP 400


1 4256225 22” Reel Frame 12 5003053 Reel, 22” 7 Blade 12 5001099 Reel, 22” 9 Blade 12 5001101 Reel, 22” 11 Blade 12 4225505 Reel, 22” 15 Blade 13 1000480 Housing, Bearing 14 500534 Bearing, Cup and Cone 15 336962 Seal, Grease 16 471214 Grease Fitting 17 471240 Vent Fitting 18 1004756 Housing, Bearing 1 Includes Items 4~79 400104 Screw, 1/4-20 x 1/2” Hex Head 410 446130 Lock Washer, 1/4 Heavy 411 400192 Screw, 5/16-18 x 1-1/2” Socket Head 812 453009 Flat Washer, 5/16 413 445795 Nut, 5/16-18 Spiralock Flange 814 458013 Ring, Snap 115 5002151 Spring, Compression 116 304745 Washer, Reel Shaft 117 364900 Nut, 3/4-16 Reel 118 163892 Seal Assembly 119 4255754 Backing, 22” Bedknife 120 See Chart Bedknife 121 4252470 Screw, Bedknife AR Package of 100 Screws22 315298 Bolt, 7/16-20 x 3/4” Wheel 223 4256228 Rod, Bedknife Adjuster 224 4256227 Trunnion, Internal 225 4256229 Cradle, Tube Spring 226 4256231 Spring, Compression 227 400051 Washer, 1/2” Bellville 228 400050 Nut, 1/2-20 Hex Jam Nylock 229 4256233 Washer, Bedknife Adjustment 230 4256232 Trunnion Half 231 400052 Washer, 5/16 Bellville 232 400065 Washer, Shim AR33 400053 Nut, 5/16-24 Hex Slotted 234 460008 Cotter Pin, 5/64 x 3/4” 235 4256230 Spring, Detent 2

Parts- 132

PARTS MANUAL-GP 400

ITEM PART NO DESCRIPTION QTY REMARKS

TRUE SET REAR ROLLER

1004990 22” Rear Roller 11 3010422 Shaft, 22” Roller 12 5002814 Tube, 22” Roller 13 3010712 Bearing, Ball 24 3010286 Seal 2

1

2

3

3

4

4


Parts- 133

PARTS MANUAL-GP 400


1

2

3

3

4

45

5

68613 22” Machined Grooved Steel 168614 22” Machined Grooved Aluminum 1

1 3009725 Shaft, 22” Roller 12 5002815 Roller, 22” Grooved Steel 1 Used on 686132 3000394 Roller, 22” Grooved Aluminum 1 Used on 686143 503378 Bearing, Cup and Cone 24 367029 Locknut, 3/4-16 25 3010210 Adapter, Seal 2

TRUE SET MACHINED GROOVED ROLLER

Illustration Number: 63318-68613-68614-68616

Parts- 134

PARTS MANUAL-GP 400


TRUE SET SOLID FRONT ROLLER

1004991 22” Solid Front Roller (Light) 11004988 22” Solid Front Roller 1

1 3010621 Shaft, 22” Roller 12 5002814 Roller, 22” Solid (Light) 1 Used on 10049912 3007008 Roller, 22” Solid 1 Used on 10049883 3010712 Bearing, Ball 24 3010286 Seal 25 471214 Fitting, Grease 2

68530 22” Solid Front Roller with Scraper 1 Includes 100499168641 22” Solid Front Roller with Scraper 1 Includes 1004988

6 2500022 Scaper Assembly 17 352214 Clip 28 407586 1/4-20 Pan Head Screw 2

1

2

3

3

4

45

5

6

7

7

8

8

Illustration Number: 68530-68641-4108920

Parts- 135

PARTS MANUAL-GP 400


1

2

2

3

3

4

4

5

68527 22” Front Roller 11 3010621 Shaft 12 471214 Grease Fitting 23 3010712 Bearing, Ball 24 3010286 Seal 25 129806 Grooved Roller 1

TRUE SET 22" GROOVED STEEL DISC FRONT ROLLER


Parts- 136

PARTS MANUAL-GP 400


TRUE SET 22" SEGMENTED GROOVED FRONT ROLLER

68673 22” Segmented Grooved Front Roller 11 2810708 Shaft, Roller 12 4130417 Spacer, Bearing 33 4130418 Spacer, Bearing 24 4130419 Roller, Segmented Grooved 35 366707 Bearing, Ball 66 338773 Seal, Grease 67 4130428 Spacer, Bearing 28 445801 Nut, 5/8-18 Hex Jam Nylon Insert 2

1

2

2

2

3

3

4

4

4

5

5

5

5

5

5

6

6

6

6

6

6

7

78

8


Parts- 137

PARTS MANUAL-GP 400


894991 Greensplex Reel Motor Adapter Kit 11 103867 Flat Washer, 516 22 306325 Lock Washer, 5/16 23 306501 Screw, 5/16-18 x 1-1/2” 24 4247911 Coupling, Drive 15 845278 Adapter Plate 16 845279 Seal, O-Ring 1.49 I.D. x .07 17 845280 Seal, O-Ring 1.99 I.D. x .07 1

TRUE SET MOTOR ADAPTER KIT

Illustration Number: 894991_motor_adapter_kit

12

3

4

56

7

Note: This cutting head requires the Motor Adapter Kit 894991.

Check to make sure your Greensplex Greensmower has this MotorAdapter Kit before installing the cutting head.

If your Greensplex Greensmower does not have this Motor Adapter, youneed to order a Motor Adapter kit Part No. 894991.

Parts- 138

PARTS MANUAL-GP 400

TURF GROOMER


Parts- 139

PARTS MANUAL-GP 400


1 365226 Plate, cover 1132212 Pulley assembly 1

2 365228 • Pulley, 28 groove 13 365229 • Bearing, ball 24 458461 • Snap ring 15 365232 • Spacer 16 365256 Spacer, pulley 17 365239 Key, 1/8 x 1/8 x 7/16" 18 446142 Lock Washer, 3/8" 29 434030 Screw, 3/8-16 x 7/8", socket head 210 365237 Spacer, grass catcher 211 441672 Bolt, carriage, 5/16-18 x 2 1/2" 212 364441 Spacer, 5/16" 413 446136 Lock Washer, 5/16" 414 443106 Nut, 5/16-18 215 365246 Bolt, 3/8-16, nyloc shoulder 216 365341 Washer, special 217 434031 Screw, 1/4-20 x 3/4", socket head 218 365240 Decal, turf groomer 119 365343 Guide, wheel 220 400184 Screw, 5/16-18 x 3/4" 221 365409 Spacer, roller As

Req’d22 3005515 Spacer, driven assembly .02" As

Req’d“Clutch assembly 1

23 163776 • Pulley assembly 124 338768 • Seal, grease 125 365272 • Spring 226 365258 • Pin 227 365254 • Shaft, stub 128 241817 • Knob, clutch 129 363841 • Washer 130 446142 • Lock Washer, 3/8" 131 365257 • Bolt 132 471214 • Fitting, grease, 1/4-28 133 Drive assembly 1 See breakdown 34 Driven assembly 1 See breakdown35 Blade assembly 1 See breakdown36 Roller assembly 1 See breakdown37 365235 Belt, drive 1

* Not Illustrated

Parts- 140

PARTS MANUAL-GP 400

TURF GROOMER DRIVE ASSEMBLY

Illustration Number: TURF GROOMER DRIVE ASSEMBLY

Parts- 141

PARTS MANUAL-GP 400


1 3010708 Bracket, groomer roller 12 220302 Housing, belt 13 365260 Link, belt adjusting 14 367162 Eccentric, belt adjusting 15 446142 Lock Washer, 3/8" 16 434030 Screw, 3/8-16 x 7/8", socket head 17 132214 Cover, belt housing 18 338752 Seal, oil 19 446130 Lock Washer, 1/4" 310 434029 Screw, 1/4-20 x 1", socket head 211 434011 Screw, 1/4-20 x 5/8", socket head 112 365247 End, rod 113 446136 Lock Washer, 5/16" 114 434032 Screw, 5/16-18 x 1 3/4", socket head 115 365270 Bolt, micro adjusting 116 3003969 Pin, pivot 117 465006 Ball, 5/16 dia., steel 118 365291 Spring 119 471219 Fitting, grease, 1/8 NPT 120 445667 Nut, 1/2-20, hex nyloc 121 422502 Screw, set, 1/4-20 x 1/4" 122 3005108 Knob, micro adjuster 123 367166 Cam 124 453009 Washer, 5/16" 125 434024 Screw, 5/16-18 x 3/4" Socket head 126 400186 Screw, 5/16-18 x 7/8" 227 364061 Bracket, adjusting pivot 128 365344 Clamp, housing retaining 129 444718 Nut, 5/16-18 230 365233 Link, roller adjusting 131 Quick height adjuster 1 See parts breakdown

* Not Illustrated

Parts- 142

PARTS MANUAL-GP 400

TURF GROOMER DRIVEN ASSEMBLY

Illustration Number: TURF GROOMER DRIVEN ASSEMBLY

Parts- 143

PARTS MANUAL-GP 400


1 3010708 Bracket, groomer roller 12 338748 Bracket, groomer mounting 13 400186 Screw, 5/16-18 x 7/8" 14 365233 Link, roller adjusting 15 444718 Locknut, 5/16-18, center 26 453009 Washer, 5/16" 17 364061 Bracket, adjusting pivot 18 447212 Lock Washer 29 2000088 Block, pivot 110 365247 Rod end 111 434032 Bolt, 5/16-18 x 1 3/4" socket head 112 365270 Bolt, micro adjusting 113 465006 Ball, 5/16 dia., steel 114 365291 Spring 115 323016 Plug, pipe, 1/8 NPT, 905 116 422502 Screw, set, 1/4-20 x 1/4" 117 3005108 Knob, micro adjuster 118 445667 Nut, 1/2-20, hex nyloc 119 3003969 Pin, pivot 120 434024 Screw, 5/16-18 x 3/4" socket head 121 367166 Cam 122 400118 Screw, 1/4-20 x 1 3/4" socket head 223 Quick height adjuster 1 See parts breakdown

* Not Illustrated

Parts- 144

PARTS MANUAL-GP 400

TURF GROOMER BLADE ASSEMBLY

Illustration Number: TURF GROOMER BLADE ASSEMBLY

Parts- 145

PARTS MANUAL-GP 400


1 367029 Locknut, 3/4-16, hex nyloc 12 367165 Spacer, 7/8 x 17/32" 23 471214 Fitting, grease, 1/4-28 1

132211 Housing, driven bearing 14 241808 • Housing, bearing 15 365229 • Bearing, ball 16 458461 • Snap ring 27 336962 • Seal, grease 18 367164 Spacer, 7/8 x 1 13/16" 19 453011 Washer, 3/8" 210 446142 Lock Washer, 3/8" 211 400298 Screw, 3/8-24 x 1" 2

132210 Housing, drive bearing 112 241807 • Housing, bearing 113 365229 • Bearing, ball 114 458461 • Snap ring 215 336962 • Seal, grease 116 367163 Spacer, 7/8 x 7/8" 117 365227 Pulley, 16 groove 118 345556 Key, 1/8 x 1/8 x 31/32" 1

132215 Groomer shaft assembly, 1/4" spacing 1 Product No. 067871132213 Groomer shaft assembly, 1/2" spacing 1 Product No. 067873

19 390857 • Shaft, groomer 120 365234 • Spacer, 1 1/16 x 15/32" 221 365230 • Blade (1/4" spacing) 71 365230 is a package of

365230 • Blade (1/2" spacing) 40 50 Blades22 367029 • Locknut, 3/4-16, hex nyloc 123 364040 • Shim, groomer shaft As

Req’d24 367161 • Spacer, 1 x 3/4" 225 443832 • Nut, 3/4-16, jam 126 365236 • Spacer, 1/4" spacing 70 Product No. 06787126 365234 • Spacer, 1/2" spacing 39 Product No. 067873

* Not Illustrated

Parts- 146

PARTS MANUAL-GP 400

TURF GROOMER ROLLER ASSEMBLY

Illustration Number: TURF GROOMER ROLL

Parts- 147

PARTS MANUAL-GP 400


1 390899 Tube, roller, 1/4" spacing 1 Product No. 0678711 390900 Tube, roller, 1/2" spacing 1 Product No. 0678732 365330 Bearing, ball 23 338772 Shaft, roller 24 338773 Seal, grease 25 458113 Snap ring 26 446148 Lock Washer, 7/16" 27 443186 Nut, 7/16-20, jam 28 452008 Washer, 7/16" 29 443836 Nut, 7/8-14, jam 410 365345 Ring, nylos 211 471214 Fitting, grease, 1/4-28 2

* Not Illustrated

Parts- 148

PARTS MANUAL-GP 400

TURF GROOMER QUICK HEIGHT ADJUSTER

Illustration Number: TURF GROOMER QUICK HEIGHT ADJUSTER

Parts- 149

PARTS MANUAL-GP 400


1 422502 Screw, set, 1/4-20 x 1/4" 12 365265 Link, adjusting 1

163761 Knob assembly 13 365271 • Bolt 14 365268 • Spring 15 365267 • Plunger 16 365266 • Bolt, adjusting 17 365269 • Spring 18 444708 • Locknut, 1/4-20, center 19 271919 Knob, quick adjuster 1

Parts- 150

PARTS MANUAL-GP 400

GRASS CATCHER

Illustration Number: Grass-Box

Parts- 151

PARTS MANUAL-GP 400


1 4239563 Catcher Assy 12 4146935 Bracket, Catcher 23 4154140 Frame AY, Head Steering 14 400266 Screw 3/8-16 X 1-1/2 Hex 25 822474 Spacer,.38.75.50 YS 26 800619 Nut,.38-16 YS HX LT.WT.Stop 2

* Not Illustrated

Parts- 152

PARTS MANUAL-GP 400

DECALS

Illustration Number: ARRGT-DECALS

41

2

7

5 6

Pb8

91

1

20

21

1

X 1 =

X 3 =

X 2 =

1

10A 10A

12V

12V

2 2

Manufactured under one or more of the following U.S. Patents:

5,553,445; 5,970,690; 6,029,433; 6,889,491; 7,434,380

23

244

56 7

1819

3

2 5

USE LOW OR ULTRA-LOW SULPHUR FUEL ONLY

12

13

11

4

JAN

FEB

MA

R

APR

MAY

JUN

JUL

AU

G

SEP

OC

T

NO

V

DEC

®IMPORTANT EMISSIONS CONTROL INFORMATION

2013:

4286491

A T

EXTR

ON

CO

MPA

NYCARB EVAP EMISSIONS FAMILY: CC

EPA EVAP EMISSIONS FAMILY: DJBSPNHEQAAA

THIS EQUIPMENT CONFORMS TO 2013 U.S. EPAEVAP STANDARDS & 2013 CALIFORNIA EVP

REGULATIONS FOR SMALL OFF ROAD ENGINES.

EMISSION CONTROL SYSTEM (or ECS):EVAP CANISTER, FUEL HOSE, FUEL TANK, FUEL TANK CAP

Parts- 153

PARTS MANUAL-GP 400


1 009114380 Decal- Fasten Seat Belt 12 4240162 Decal- GP400 Jacobsen Logo 13 009034880 Decal- Fan 14 009034920 Decal- Hot 15 9034930 Decal- Hyd Press Leak 16 9114100 Decal- Battery 17 9114240 Decal- Petrol, Hazard 18 9039700 Decal- Parking Brake 19 4118415 Decal- Coolant Hazard 111 4244790 Decal- GP400 Name (CHASSIS) 212 4178900 Decal- Low Sulphur Fuel 113 4111407 Decal- 2" BioFluid 114 4240263 Decal- Group Instruction 115 4164860 Decal- Hydraulic Fluid 1

4241162 Decal- Set Of Decals 116 840065 Decal- Speed Control 117 4146700 Decal- Plus+1 Error Codes 118 009114300 Decal- Jacking Point 319 4144565 Decal- Engine Throttle 120 4247470 Decal- Centre Unit Sequence 121 009034770 Decal- Noise 105dB 122 4164660 Decal- Auxiliary Power Socket 12V 123 4241302 Decal- GP400 Patents 124 4286491 Decal- EPA GP400 Gas 125 009114340 Decal- Diesel, Hazard 1

* Not Illustrated

Parts- 154

PARTS MANUAL-GP 400

LMAC415 DEW WHIP HOLDER

Illustration Number: LMAC415

45

3

9

812

76

11213

1

10

LOWER BRACKET - SECURE TO TOOLBOX/ STEP

NOT SUPPLIED

UPPER BRACKET - SECURE TO ROPS FRAME

Parts- 155

PARTS MANUAL-GP 400


1 450376 Nut-Hex M5 Nyloc 12 450527 Scrw-Pan HD M5 x 14 13 450377 Nut-Hex M6 Nyloc 24 450389 Wshr-M6 x 12.5 x 1.8 45 450171 Scrw-Hex M6 x 20 26 452717 Nut-Hex M4 Nyloc 27 450387 Wshr-M4 x 9 x 0.9 28 450595 Scrw-CSK M4 x 14 29 4237602 Upper Whip Bracket 110 4237603 Lower Whip Bracket 111 Dew Whip 1 (Reference Only)12 3008369 Holder, Rake 213 450388 Wshr-M5 x 10 x 1.1 1

* Not Illustrated

Parts- 156

PARTS MANUAL-GP 400

LMAC412 PADDLE KIT

77

2

1212

2727

1414

24241

2424

22221818

2626

2424

4

2121

1717

2525

2323

16161919

1313

1111

1515

2020

9

5

1010

8

2828

Illustration Number: LMAC412_rev d

Parts- 157

PARTS MANUAL-GP 400


1 002910540 Sprg-Comp 14 x 1 x 25 1 2 008955190 Softex Grip 8mm ID 1 4 4197063 Inductive Sensor 1 5 4208220 Steering Arm 17 4235960 Top Cover Paddle 1 8 4235962 Bracket-Prox Switch 1 9 4235963 Plate-Joystick Blank 1 10 4236080 Wldmt-Pivot Hinge 1 11 4236083 Lever Arm-Paddle 1 12 4244970 Wldmt-Paddle Lever 1 13 450004 Bolt-Hex M6 x 45 1 14 450017 Bolt-Hex M8 x 45 1 15 450151 Scrw-Hex M5 x 16 2 16 450154 Scrw-Hex M5 x 302 17 450170 Scrw-Hex M6 x 16 4 18 450192 Scrw-Hex M8 x 25 2 19 450322 Nut-Hex M5 2 20 450376 Nut-Hex M5 Nyloc 2 21 450377 Nut-Hex M6 Nyloc 1 22 450378 Nut-Hex M8 Nyloc 1 23 450389 Wshr-M6 x 12.5 x 1.8 4 24 450390 Wshr-M8 x 17 x 1.8 4 25 450410 Lock Washer-M6 x 9.6 x 1.5 4 26 450411 Lock Washer-M8 x 12.75 x 2 2 27 4236822 Gaiter 128 Decal 1

Parts- 158

PARTS MANUAL-GP 400

LMAC 4183 WHEEL DRIVE KIT

Illustration Number: LMAC418 rev c

3

3

2

15 10

30

28

14

18

24 26

9 17

2023

12

23

21

1

11

16

27

135

7

1925

8

29

29

2224

9

CAP RH FRONTWHEEL MOTOR PORT

CAP TEE UNDERSEAT PLATE

TOP PORTON PUMP

BOTTOM PORTON PUMP

TO CROSSFITTINGON PUMP

BOTTOM TEECONNECTINGFRONT MOTORS

6

Parts- 159

PARTS MANUAL-GP 400


1 002498400 TEE-M/F/M 11/16 ORS 12 002540050 TEE-M/F/M 1” ORFS 13 002568020 CAP-11/16 ORS 24 008006930 MOTOR, HYD 15 158006-01 FTG-MM 11/16 ORS x 9/16 SAE 16 158006-06 FTG-MM 13/16 ORS x 7/8 SAE 27 158007-01 90-M/M 11/16 ORS x 9/16 SAE 18 158007-05 90-M/M 1 ORS x 7/8 SAE 29 158056-01 TEE-3/4 SAE - 13/16" ORFS 210 4147139 HYDRAULIC HOSE 111 4147141 HYDRAULIC HOSE 112 523213 CUSHIONED P-CLIP 113 4187320 3WD VALVE 1* 4187401 • P.O. Spool Valve 1 Torque 60Nm* 4187402 • Check Valve 1 Torque 60Nm* 4187901 • Oriface Plug 1 Torque 2.0 to 2.5 Nm* 4187900 • Oriface Plug 1 Torque 2.0 to 2.5 Nm* 4171447 • Blanking Plug 3/8" 1 Torque 20Nm14 4239842 BRACKET 3WD VALVE 115 4240303 HYDRAULIC HOSE 116 4240304 HYDRAULIC HOSE 117 4248590 BRACKET-3WD HOSE CLAMP 118 450019 BOLT-HEX M8 x 55 219 451110346 BOLT-HEX 1/2-13 x 2-3/4 420 450171 SCRW-HEX M6 x 20 121 450377 NUT-HEX M6 NYLOC 122 450378 NUT-HEX M8 NYLOC 223 450389 WSHR-M6 x 12.5 x 1.8 224 450390 WSHR-M8 x 17 x 1.8 425 452200176 LOCKWSHR-1/2 x .873 x .125 426 450738 CAPSCRW-SCKT M10 x 25 227 844082 TEE-13/16" ORFS 228 844679.6 WHHEL HUB 129 845274 HYDRAULIC HOSE 230 894728.6 WLDMT-3WD FORK 1 * 008155160 Wheel Stud 7/16-20 x 1-3/8 4 * 450990638 Wheel Nut 4

Europe & Rest of The World Except North & South America

Ransomes Jacobsen LimitedWest Road, Ransomes Europark, Ipswich, IP3 9TT

English Company Registration No. 1070731www.ransomesjacobsen.com

North & South America

Jacobsen, A Textron Company11108 Quality Drive, Charlotte,

NC 28273, USAwww.Jacobsen.com

Documents

Parts Manual - shop.ransomes-jacobsen.eushop.ransomes-jacobsen.eu/shop/web/proxy/ransomes/rte/file/Ersatzteil... · Ransomes Jacobsen Limited reserves the right to make design changes