Charmec SF 605 DA(V) 09.06 - Normet · 3rd gear 25 km/h Max. tractive effort 90 kN ... Esp / Ita Toolbox and maintenance tools 2 wheel chocks with brackets Reversing camera Spare

1/10

Technical data sheet10005575009.06.2015

Normet OyAhmolantie 6FI-74510 IISALMI, FINLAND

Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606

[email protected] www.normet.com

Normet reserves the right to change this specification without further notice.

Charmec SF 605 DA(V)

FeaturesCharmec SF 605 DA ANFO charger with diesel hydraulic drive is designed for face and produc-tion charging in underground mines and tunnels up to 65 m2 cross sections where max face height is 8.4 m.

Standard 500 L ANFO vessel (optional 360 / 720 liters) provides enough explosive storage vol-ume for charging without need for refilling. Ready designed place for stick powder boxes, prim-ers and detonators makes it possible to bring all the needed materials to the workplace at once and eliminates the need for an additional explosive service vehicle. Optional hydraulic driven compressor eliminates the need for external pressure air supply.

The liquid cooled turbo charged Deutz 96 kW or MB 90 kW or air cooled Deutz 86.5 kW TIER 3 approved engines provides clean and efficient operation and gives maximum speed of 25 km/h and 6 km/h in upward 1:7 inclined tunnel.

The FOPS /ROPS approved safety canopy / cabin provides comfortable compartment for the driver and his assistant. The enclosed cabin provides noise level < 75 dB.

Self-extinguishing marine type wire harness with tinned wires and water tight conduits are spe-cially designed for safe and reliable operation in tough underground conditions. All daily checks can be done from the ground level.

Pictured machine may include options and additional equipment.

2/10



Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606




CHARGING SYSTEM

One ANFO vessel and work stand, one charging operator500 liter stainless steel ANFO kettlePressure max. 7 barExtra air for chargingPneumatic hand and foot control for charging and blowingCharging hose 19 x 25 mm, 30 mEarth straps front and rear

NBB3S BASKET BOOM

Short 2-men square tube basketLifting capacity 500 kgBoom lift -18º...+ 60ºMax. Lifting height (basket floor) 6.4 mMax. Vertical reach 8.4 mBoom slew 20°/ 30°Automatic levelling of basketDiesel start/stop from basketBattery operated emergency pump for lowering the boom

ENGINE

Liquid cooled turbo charged Deutz TCD 2012 L4, 96 kW/2200 rpm, TIER 3 approved

EXHAUST SYSTEM

Catalytic exhaust gas purifier and muffler

TRANSMISSION

Dana 20 000 series power shift with pump drive group3 speeds forward and reverse4-wheel drive

AXLES

Planetary typeDana 112Load end axle fixedEngine end axle oscillation +/- 10°

TYRES

10.00 - 20 PR 16

PERFORMANCE

1st gear max.5 km/h2nd gear 12 km/h3rd gear 25 km/hMax. tractive effort 90 kNMax speed in upward 1:7 inclined tunnel 12 km/hPerformance curve 4800031

BRAKES

Service brake: hydraulically powered two-circuit oil immersed multidisc brakes in both axlesSafety/Parking brake: spring applied hydraulically released fail-safe -type brake. Brake test possibility in cabin

STEERING

Hydraulic frame steeringOrbitrol typeFrame articulation +/- 40°

FUEL TANK

Capacity 112 L

HYDRAULIC SYSTEM

Variable displacement pump systemPressure setting 190 bar, 95 L/min/2200 rpmHydraulic oil tank capacity 115 LReturn oil filtration 10 μmIndication of level, filtration and temperature

24 VDC ELECTRICAL SYSTEM

Exposed components are min IP 65 standardBattery 2 x 115 AhAlternator 100 AHalogen driving lights (4 + 2 pcs) 70 WHalogen work lights (2 + 2 pcs) 70 WLED parking, brake and indicator lightsLED side lights; amberSide reversing halogen lights 70 W Rotating beacon; amberWire harness (self extinguishing) with tinned wires and water tight conduits

DRIVER’S COMPARTMENT

Open 2-man cabin FOPS/ROPS approvedAir suspended driver’s seatSeats with retractable lap seat beltForward and side seating for the driver with twosets of pedals (brake and accelerator)MID 070 S Multifunctional Display with: • Meters; e.g. speed, RPM, operating hours • Status indicators; e.g. fluid levels, temperatures,

pressures, alarms, faults

GREASING SYSTEM

Centralized grease fittings for the carrier

OTHER

12 kg hand held fire extinguisherStandard symbol labelsHydraulic support legs on rear frame

Technical specification

3/10



Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606




CHARGING SYSTEM

ANFO vessel size:• 360 L• 720 LRadio controlled charging and blowing in basketANFO hose diameter: • For manual hose feeding 22 x 28 / 26.5 x 33.5 / 41.5 x 51 mm

• For Mechanical hose feeding 26.5 x 33.5 / 30 x 38 mm

ANFO hose length: • 30 / 60 m

DRIVER’S CABIN

Enclosed cabinAir suspended T-back seat for driver and passenger

ENGINE

Liquid cooled turbo charged MB OM 904 LA, 90 kW/2200 rpm, TIER 3 approved:1st gear max. 5 km/h2nd gear 10 km/h3rd gear 25 km/hMax. tractive effort 90 kNMax speed in upward 1:7 inclined tunnel 12 km/hPerformance curve 4800032Air cooled Deutz D 914 L06 86.5 kW/2300 rpm TIER 3 approvedPerformance curve 100021199

OTHER

LED driving lights (4 + 2 pcs) 18 WLED work lights on cabin (2 + 2 pcs) 43 WWarning lights, 1 unit: • Rotating beacon; red • Rotating beacon; blue

CHARGING SYSTEM

Additional pneumatic charging controls: For toeholes and ground level charging work Mechanical ANFO hose feeding for productioncharging (no reel available)Water for ANFO system: 35 L container

HIGH VOLTAGE ELECTRICS

Electro hydraulic drive 15 kW: Includes 50 m of cable and hydraulically operated cable reel:• 400 V / 50 Hz , 440 V / 60 Hz , 690 V / 50 Hz,

1000 V / 50 HzPilot wire with extra slip ring unit

SUSPENSION

Front axle suspension• Hydraulic front support legs

AIR COMPRESSOR

4 m3 hydraulically driven compressor on front rack4 m3 electrically driven compressor on front rack (requires electro-hydraulic drive)

FOR ENCLOSED CABIN

CD/Radio systemCabin ventilation:• Cabin heating • Air conditioning• Not available with D914 engine

FOR NBB BASKET BOOM

Safety barSafety roof with hydraulic lift:• 400 kg = 240 kg + 2 personsSafety roof with hydraulic lift and slide:• 300 kg = 140 kg + 2 personsLED working lights on safety roof / safety bar (2 pcs) 43 WBoom suspension

FIRE SUPPRESSION SYSTEM

Fogmaker: Manually or automatically actuated Ansul: Manually or automatically actuatedTempus: Manually actuated (Non CE)

GREASING SYSTEM

Automatic lubrication system (Lincoln) for:Carrier or carrier and lifter

Optional equipment Additional equipment

4/10



Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606




OTHER

Fast fuel filling system: WigginsOil evacuation kit with sample pointsExtra hand held fire extinguisher (12 kg) Hydraulic front support legsExtra warning lights, 1 unit: Rotating beacon amber, red or blue or strobe light; whiteText labels in: Fin / En / Por / Swe / Rus / Nor / Ger / Fra / Esp / ItaToolbox and maintenance tools2 wheel chocks with bracketsReversing cameraSpare wheel with tyreWLAN connection

SPARE PARTS

Spare parts package A: Available for 1000 h of use*. Include periodical service, most common wearing parts and most critical safety parts. Spare parts package B: Available for 3000 h of use*. Include periodical service, most common wearing parts and most critical safety parts. * Recommendations are based on average hours - can vary a lot depending on work site conditions.

TRAINING SERVICES

Available before delivery, at start up and after deliveryProduct training: Operation and MaintenanceNorSmartFoundation of electrics, hydraulics and mechanicsAuditProcess training:Concrete sprayingChargingProcess audit

AUDIT SERVICES

To improve performance of the machinesTo improve the performance of your processesTo help improve the quality of maintenance operations

SERVICE CONTRACTS

Spare parts supply programmesScheduled inspection programmesSupervision programmesPeriodic maintenance programmesMachine usage programmes

LINK ONE

Link One electronic spare part manuals

WARRANTY SERVICES

Extended warranty

LTC servicesAdditional equipment

5/10



Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606




DIMENSIONS

Length 9050 mmWidth 2150 mmHeight 2450 mmWheel base 3650 mmTrack 1650 mmGround clearance as shown 320 mm

TURNING RADIUS

Outer 7360 mmInner 3930 mm

WEIGHT

Operating 11 000 kg

SIDE VIEW

Basic machine

SIDE VIEW

Machine with enclosed cabin

Dimensions

6/10



Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606




Dimensions

TOP VIEW

BOOM REACH

7/10



Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606




Dimensions

TURNING RADIUS

8/10



Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606




Dimensions

BOOM REACH

9/10



Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606




Tractive efforts

DEUTZ TCD 2012 L4 96 kWPerformance curve 4800031

MERCEDES-BENZ OM 904 LA 90 kWPerformance curve 4800032

10/10



Tel +358 (0) 17 83 241Fax +358 (0) 17 823 606




Tractive efforts

DEUTZ D914 L6 86,5 kWPerformance curve 100021199

Documents

Charmec SF 605 DA(V) 09.06 - Normet · 3rd gear 25 km/h Max. tractive effort 90 kN ... Esp / Ita Toolbox and maintenance tools 2 wheel chocks with brackets Reversing camera Spare