View
2
Download
0
Category
Preview:
Citation preview
© Lumen North America | sales@lumen-northameric.com FI15079 • issue 2.0 • 1/26
Ford Ranger
Kit Part No: VKB3Z-13E754-A
Bed LightingFitting Time: 45 minutes
July 19, 2019
Fitting instruction Instrucciones de montajeEN ESFR Consignes de montage
© Lumen North America | sales@lumen-northamerica.com 2/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
PRE-INSTALLATION CAUTIONS / NOTES
B1
B
G
H I KJ
C D FE
A5
A4
A3
A6
A1
A2
A
corrosioninhibitor
inhibitEUr D’corrosion
INHIBIDOR DEOXIDO
x 4
x 4 x 1 x 1
x 1
x 35
x 8 x 8
x 8 x 8
x 8
x 8
x 2
x 2 x 2 x 2
Ø 3/16’’Ø 5/16’’
B2
C1 C2
L
M N P QO
alcohol
10mm
Quick reference guide
IntroductionThe Ford Ranger Bed Light System consists of (4) LED Lamps, linked together and activated via a capacitive touch switch integrated into the lens of each lamp. An external Switch is NOT required. The harness is designed to source constant 12 Volt power direct from the vehicle’s battery.
General OperationThe system is activated by touching the lens of ANY of the connected lamps. This will illuminate all (4) lamps simultaneously. Proper operation calls for two finger contact for 1.5 to 2 seconds. This helps prevent unwanted activation and false triggers caused by rain, water or other debris.
BY
CAPACITIVE TOUCH BED LIGHTING
THIS ACCESSORY IS A FORD LICENSED ACCESSORY AND IS COVERED BY THE FORD EXPRESS PARTS AND ACCESSORIES WARRANTY | PART NUMBER VKB3Z-13E754-A
VKB3Z-13E754-A | 25-02-2019 | ISSUE 1.1
© Lumen North America | sales@lumen-northamerica.com 3/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
PRE-INSTALLATION CAUTIONS / NOTES
EN FR ES
Position/Location Flèche de Position Flecha de posición
Movement Flèche indiquant sens du vouvement Flecha de moviemiento
Disconnect Déconnecter Desconecte
Connect Connecter Conecte
Left & right side of the vehicle Côté gauche et droit du véhicule El lado izquierdo y derecho del vehículo
See workshop manual Voir Manuel d’atelier Consulte el manual de taller
Attention / important advice Attention / indication importante Atención / indicación importante
Look at page nr. ... Se référer à la page n° ... Mirar en la página nº...
Present / occupied / OK Disponible / occupé / OK Presente / ocupado / OK
Not present / not occupied / not OK Pas disponible / pas occupé / pas OK Non presente / non ocupado / non OK
Ground or Earth (31) Masse (31) Masa (31)
Positive connection battery terminal lug Borne „plus” de la batterie Conexión positiva de batería
Ground connection battery terminal lug Borne „moins” de la batterie Conexión negativa de batería
Audible Click Signalisation acoustique Señalización acústica
Option Option Opcion
Vehicle Forward Direction Véhicule à traction avant Dirección frontal del vehículo
Skip to step... Santer à étape... Brincar a paso...
Torque Couple Par de torsión
V F D
L R
pg. ...
© Lumen North America | sales@lumen-northamerica.com 4/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
A2
A1
EC2
1
+
+ +
+
+ +
+
+
D
B1 B1
D
E
B2
A4 A6
B2
C2
C1 C1A3 A5
© Lumen North America | sales@lumen-northamerica.com 5/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
option b - spRay in bed LineRoption b - doubLuRe de caisse puLvéRiséeopcion b - cubieRta de caja Rociada
option c - dRop in bed LineRoption c - doubLuRe de caisse en pLastiqueopcion c - cubieRta de caja
option a - no bed LineR option a - sans doubLuRe de caisseopcion a - sin cubieRta de caja
2
2
4
© Lumen North America | sales@lumen-northamerica.com 6/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
2
L
I II
R
R RL L
3
0 10 20 30 40 50 60 70 80 90 100
CHECK SIZE
Print 100%Check with Rulers before use.
Scale: 1:1Paper format: Letter
L/R SIDE TEMPLATES
Ø 1/8’’ Ø 1/8’’
Ø 1/8’’Ø 1/8’’
Ø 1/8’’Ø 1/8’’
Ø 15/16’’ Ø 15/16’’
60mm60mm 60mm
J
a,b
a,b
pg. 19
L R
© Lumen North America | sales@lumen-northamerica.com 7/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
III
V
IV
VI
RL
RL
RL
RL
Ø 5/16’’
Ø 5/16’’Ø 5/16’’
Ø 15/16’’
°360
3
Ø 15/16’’
a,b
K
1 2
+corrosion
inhibitor
inhibitEUr D’corrosion
INHIBIDOR DEOXIDO
© Lumen North America | sales@lumen-northamerica.com 8/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
R
RR
R L
LL
L
RLRL
XIIXI
°360
3
Ø 5/16’’
Ø 5/16’’Ø 5/16’’
a,b
Ø 1/8’’
Ø 1/8’’
Ø 1/8’’
Ø 15/16’’
0 10 20 30 40 50 60 70 80 90 100
CHECK SIZE
Print 100%Check with Rulers before use.
Scale: 1:1Paper format: Letter
56mm
Ø 1/8’’
Ø 1/8’’
Ø 1/8’’
Ø 15/16’’
56mm
L/R SIDE TEMPLATES
K
~49”/1250mm ~49”/1250mm
pg. 21
1
2
6
L
VII
IX X
VIII
R
+Ø 15/16’’
corrosioninhibitor
inhibitEUr D’corrosion
INHIBIDOR DEOXIDO
© Lumen North America | sales@lumen-northamerica.com 9/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
5
4
RL
I
II
RL
RL
0 10 20 30 40 50 60 70 80 90 100
CHECK SIZE
Print 100%Check with Rulers before use.
Scale: 1:1Paper format: Letter
L/R SIDE TEMPLATES
Ø 1/8’’ Ø 1/8’’
Ø 1/8’’Ø 1/8’’
Ø 1/8’’Ø 1/8’’
Ø 15/16’’ Ø 15/16’’
60mm60mm 60mm
III RL
Ø 3/16’’
Ø 3/16’’Ø 3/16’’
c
c pg. 23
© Lumen North America | sales@lumen-northamerica.com 10/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
RL VIV
Ø 15/16’’
Ø 15/16’’
RLRL
Ø 1/8’’
Ø 1/8’’
Ø 1/8’’
Ø 15/16’’
0 10 20 30 40 50 60 70 80 90 100
CHECK SIZE
Print 100%Check with Rulers before use.
Scale: 1:1Paper format: Letter
56mm
Ø 1/8’’
Ø 1/8’’
Ø 1/8’’
Ø 15/16’’
56mm
L/R SIDE TEMPLATES
~49”/1250mm ~49”/1250mm
L
VI VII
R
5
c
pg. 25
© Lumen North America | sales@lumen-northamerica.com 11/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
RR LL
RLX
6
Ø 3/16’’
Ø 3/16’’Ø 3/16’’
VIII IX
Ø 15/16’’
150mm
Note 1: Follow existing vehicle under body routing from LH Rear corner (see start point ) to front and engine compartment.
Note 1: suivre le passage du véhicule existant sous lacarrosserie du coin (voir début ) arrière gauche vers l’avant et le compartiment moteur
Nota 1: Iniciando en la parte posterior y izquierdo (por laestrella ), sigue el ruteo del cableado vehicular hacia elarea del motor
Caution: Stay clear of moving parts and brake and fuel lines.
Prudence: Restez à l’écart des pièces mobiles,des freins et des conduites de carburant
Precaucion: Evite que el ruteo se acercao alos tubos de freno y combustible.
A staRt point voiR début
punto de inicio
EN
FR
ES
5
c
© Lumen North America | sales@lumen-northamerica.com 12/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
VFD
150mm
A4
A3
A1 A2
A6
A5
7
8
9
L
AN
V F D
150mm
A1 A2
L
ANV F D
150mm
© Lumen North America | sales@lumen-northamerica.com 13/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
10
11
A1
A3
A2
12
17
A1 A2
c
a,b
+
+
+
-
A2
A1
13.5 Nm / 10 ft-lb
© Lumen North America | sales@lumen-northamerica.com 14/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
RL
optionaL / optionneL / opcionaL
~49”/1250mm
++ +P
I J
12
13
a,b
RL
A3 A5
+
+
V F D
a,b
a b
© Lumen North America | sales@lumen-northamerica.com 15/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
14
RL RL
H
H
C2
B2
I/J
I/J
15E
RLRL
D
RL A4B1 B1
A6
1 2
O
16
a,b
a,b
a,b
22
© Lumen North America | sales@lumen-northamerica.com 16/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
17
RLRL
G
G
F
FH
H
C2B2
18
RLRL
D E
19
A3A4 A5A6
++
++
c
c
c
© Lumen North America | sales@lumen-northamerica.com 17/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
RL
RL A3
A4
A5
A6B1
22
a,b
20
21
1 2
V F D
c
c
23C1
A
O
© Lumen North America | sales@lumen-northamerica.com 18/26 FI15079 • issue 2.0 • July 19, 2019
Ford RangerKit Part No: VKB3Z-13E754-A
INSTALLATION INSTRUCTIONS
23
24
25
1 2
3 4
RL
M
Q
A
L M
Note: Coil up excess harnessEN
Note: Two Finger TouchEN
Note: Enroulez l’excès de harnaisFR
Note: Deux doigts toucherFR
Nota: Embobina el cableado excesoES
Nota: Toque de dos dedos ES
Quick reference guide
IntroductionThe Ford Ranger Bed Light System consists of (4) LED Lamps, linked together and activated via a
capacitive touch switch integrated into the lens of each lamp. An external Switch is NOT required. The
harness is designed to source constant 12 Volt power direct from the vehicle’s battery.General OperationThe system is activated by touching the lens of ANY of the connected lamps. This will illuminate all (4)
lamps simultaneously. Proper operation calls for two finger contact for 1.5 to 2 seconds. This helps
prevent unwanted activation and false triggers caused by rain, water or other debris.
BY
CAPACITIVE TOUCH BED LIGHTINGTHIS ACCESSORY IS A FORD LICENSED ACCESSORY AND IS COVERED BY THE FORD EXPRESS PARTS AND ACCESSORIES WARRANTY | PART NUMBER VKB3Z-13E754-A
VKB3Z-13E754-A | 25-02-2019 | ISSUE 1.1
2s
© Lumen North America | sales@lumen-northamerica.com 19/26 FI15079 • issue 2.0 • July 19, 2019
Ø 5/16’’ Ø 5/16’’
Ø 5/16’’Ø 5/16’’
Ø 5/16’’Ø 5/16’’
Ø 15/16’’ Ø 15/16’’
60mm60mm 60mm
0 10 20 30 40 50 60 70 80 90 100
L/R TAIL TEMPLATESMODÈLES DE QUEUE
MODELO POSICION POSTERIOR
Print 100%Check with Rulers before use
Scale: 1:1Paper format: LetterPrint Setting: Actual Size
EN Tirer 100%Vérifiez avec les règles avant utilisation
Échelle: 1:1Format papier: LettreParamètre d’impression: Taille actuelle
FR Imprimir a 100%Checar con regla antes de usarlo
Escala: 1:1Formato de hoja: CartaParametro de empreso: Tamaño actual
ES
CHECK SIZE VÉRIFIER LA TAILLECHECAR TAMAÑO
EN
FR
ES
ALIGN WITH THESHEET METALFORMATION
ALIGNER AVEC LA FORMATION DE TÔLE
ALINEAR A LAFORMACION
a,b
© Lumen North America | sales@lumen-northamerica.com 20/26 FI15079 • issue 2.0 • July 19, 2019
This Page Is Intentionally Left Blank
Page Intentionnellement Laissée En Blanc
Esta Página Se Dejó En Blanco Intencionalmente
EN
FR
ES
© Lumen North America | sales@lumen-northamerica.com 21/26 FI15079 • issue 2.0 • July 19, 2019
Ø 5/16’’
Ø 5/16’’
Ø 5/16’’
Ø 15/16’’
56mm
Ø 5/16’’
Ø 5/16’’
Ø 5/16’’
Ø 15/16’’
56mm
0 10 20 30 40 50 60 70 80 90 100
L/R TAIL TEMPLATESMODÈLES DE QUEUE
MODELO POSICION POSTERIOR
Print 100%Check with Rulers before use
Scale: 1:1Paper format: LetterPrint Setting: Actual Size
ENTirer 100%Vérifiez avec les règles avant utilisation
Échelle: 1:1Format papier: LettreParamètre d’impression: Taille actuelle
FRImprimir a 100%Checar con regla antes de usarlo
Escala: 1:1Formato de hoja: CartaParametro de empreso: Tamaño actual
ES
CHECK SIZE VÉRIFIER LA TAILLECHECAR TAMAÑO
EN ALIGN WITH THESHEET METALFORMATION
FR ALIGNER AVEC LA FORMATION DE TÔLE
ES ALINEAR A LAFORMACION
EN ALIGN WITH THESHEET METALFORMATION
FR ALIGNER AVEC LA FORMATION DE TÔLE
ES ALINEAR A LAFORMACION
a,b
© Lumen North America | sales@lumen-northamerica.com 22/26 FI15079 • issue 2.0 • July 19, 2019
This Page Is Intentionally Left Blank
Page Intentionnellement Laissée En Blanc
Esta Página Se Dejó En Blanco Intencionalmente
EN
FR
ES
© Lumen North America | sales@lumen-northamerica.com 23/26 FI15079 • issue 2.0 • July 19, 2019
Ø 3/16’’
Ø 3/16’’
Ø 3/16’’Ø 15/16’’ Ø 3/16’’
Ø 3/16’’
Ø 3/16’’Ø 15/16’’
LEFT TEMPLATEMODÈLE GAUCHEMODELO IZQ UIERDO
RIGHT TEMPLATEBON MODÈLE
MODELO DERECHO
L/R TAIL TEMPLATESMODÈLES DE QUEUE
MODELO POSICION POSTERIOR
0 10 20 30 40 50 60 70 80 90 100
60mm 60mm
EN ALIGN WITH THEPLASTICFORMATION
FR ALIGNER AVEC LAFORMATIONPLASTIQUE
ES ALINEAR A LAFORMACION
Print 100%Check with Rulers before use
Scale: 1:1Paper format: LetterPrint Setting: Actual Size
EN Tirer 100%Vérifiez avec les règles avant utilisation
Échelle: 1:1Format papier: LettreParamètre d’impression: Taille actuelle
FR Imprimir a 100%Checar con regla antes de usarlo
Escala: 1:1Formato de hoja: CartaParametro de empreso: Tamaño actual
ES
CHECK SIZE VÉRIFIER LA TAILLECHECAR TAMAÑO
c
© Lumen North America | sales@lumen-northamerica.com 24/26 FI15079 • issue 2.0 • July 19, 2019
This Page Is Intentionally Left Blank
Page Intentionnellement Laissée En Blanc
Esta Página Se Dejó En Blanco Intencionalmente
EN
FR
ES
© Lumen North America | sales@lumen-northamerica.com 25/26 FI15079 • issue 2.0 • July 19, 2019
Ø 3/16’’
Ø 3/16’’
Ø 3/16’’
Ø 15/16’’
56mm
Ø 3/16’’
Ø 3/16’’
Ø 3/16’’
Ø 15/16’’
56mm
LEFT TEMPLATEMODÈLE GAUCHEMODELO IZQ UIERDO
RIGHT TEMPLATEBON MODÈLE
MODELO DERECHO
L/R TAIL TEMPLATESMODÈLES DE QUEUE
MODELO POSICION POSTERIOR
0 10 20 30 40 50 60 70 80 90 100
ENALIGN WITH THE PLASTICFORMATION
FRALIGNER AVEC LA FORMATIONPLASTIQUE
ESALINEAR A LAFORMACION
Print 100%Check with Rulers before use
Scale: 1:1Paper format: LetterPrint Setting: Actual Size
EN Tirer 100%Vérifiez avec les règles avant utilisation
Échelle: 1:1Format papier: LettreParamètre d’impression: Taille actuelle
FR Imprimir a 100%Checar con regla antes de usarlo
Escala: 1:1Formato de hoja: CartaParametro de empreso: Tamaño actual
ES
CHECK SIZE VÉRIFIER LA TAILLECHECAR TAMAÑO
c
© Lumen North America | sales@lumen-northamerica.com 26/26 FI15079 • issue 2.0 • July 19, 2019
This Page Is Intentionally Left Blank
Page Intentionnellement Laissée En Blanc
Esta Página Se Dejó En Blanco Intencionalmente
EN
FR
ES
Recommended