SURVEYOR TRASSI .MR JYOTINDRA TRASSI USALLY WEAR POLO CAP.. HE IS USUALLY AN EXTERNAL EXAMINER. TYPICAL QUESTIONS ANSWER THEM AND PASS.MAY BE IN MMD OR IN DGS.

MMD SURVEYOR: MR DATTADGS:BAREKH MEHROTRA BANERJI BHONSLEYOLD MMD: NAYAR WITH ONE EXTERNEL USUALLY MR JK DHAR.

1.WHAT IS AIR LOCK.DRAW PLAN VIEW OF AIR LOCK2.DISCHARGE SAFETY IN LPG CARRIER.3.DEFINE LPG AS PER IGC CODE.4.DIFFERENCE BETWEEN IBC AND IGC CODE.5.TYPES OF PUMPUSED IN LPG CARRIERS.HOW VIBRATION IS PREVENTED IN DEEPWELL PUMPS.6.TALK ABOUT ALL THE HEAT EXCHANGER ON LPG TANKERS.7.SMEEP. WHAT IS THIS IN RALATION TO LPG CARRIERS.IMOship energy efficiency management plan

8.TYPES OF TANKS AS PER IGC CODE.

9.LPG RELIQUIFICATION PLANTS TELL ME COMPLETE.

10. TYPES OF CHEMICAL TANKERS .11.HAZARDS ON CHEMICAL TANKERS12.COATING USED IN TANKS FOR CHEMICAL TANKERS.Plz refer folder on chemical parcel coatings13.BALLAST TANK COATING SCHEME.14.BALLAST WATER MANAGEMENT COMPLETE15.OVERHAULING OF RECIPROCATING BIL.GE PUMP.E.16CALIBRATION OF COMBUSTION GAS DETECTORS.17.DRAW FIGURE TO SHOW HOW TO TAKE POKER GAUGE READINGS.18.HOW STERN TUBE IS ATTACHED TO THE HULL.19.BOTTOM END BEARING REMOVAL SURVEY DEFECTS.20.BROKEN TIE ROD.21.ADJUSTING TIMING OF THE FUEL PUMP(ENGINE SPECIFIC)22.MAXIMUM SIZE OF THE TANK ON A VLCC.

MARPOL ANNEX 1 REG 27CENTRE TANK: 50000 M CUBESIDE TANK: 40000 M CUB23.EXPLAIN TYPES OF DECK SEAL.DRAW SEMI DRY TYPE.24.DRAW CROSS SECTION OF SCRUBBER AND EXPALIN.25.TRIPS IN IG SYSTEM .ALSO THE ALARMS.26.COPT ALARMS AND TRIPS HOW TO TEST THESE TRIPS.27.TELL ME WAT MAJOR OVERHAUL U DID. 28.DEFEAT DEVICES AS PER MARPOL ANNEX 6.29.CHARGING AND OVERHAUL OF 9L FOAM AND DCP EXTINGUISHER.30.CO2 BOTTLES CALCULATION.31.ALPHA LUBRICATOR PRINCIPLE.32.LEMDA CONTROLLER.33.HOW U WILL COME TO KNOW THAT AIR IS THERE IN REFER SYSTEM.HOW TO TAKE OUT AIR FROM THE SYSTEM.34.F.O.HEATER EXPANSION DEVICE.35.PARCEL CHEMICAL TANKER DISCHARGE REGULATION.36.MEPC LATEST AMENDMENT.37.WT BOILER INTERNAL INSPECTION.38.DRESSOR COUPLING.39.KIND OF TAPS USED IN REFER CONNECTION, HOW IT IS DIFFERENT FROM NORMAL TAPS.40.TYPES OF DIES 41.TYPES OF TAPS.42.TYPES OF THREADS.43.MATERIAL OF SHIP SIDE VALVES.44.L.P. CO2 SYSTEM FOR PASSENGER SHIP.45 Heat exchanger on LPG deck 46 Seemp in IMO47 Leakage detection in b/w v/v body and mating face in fuel valve 48 Action in case of air compr bursting disc leakage during manouevering 49 Safety of navigational lights and checks for same 50 Trimetal bearing in sulzer Xhead in recent sulzer engine trimetal is used in place of white metal why51 Venting of tanks in tankers52 Why igg system not used on LPG 53 Checks for fuel pump timing SULZER

54 Arrangements on pipes to compensate for thermal expansion 55 Safeties for ESB 56 Pupm room lightings tyes and specialities 57 What is CGI HOW TO CALIBRATE58 Checks on ALTERNATOR 59 HOW TO CHECK LEAKY AIR STARTING VALVES.60.ALL THE MAIN ENGINE BEARINGS CLEARENCES.61.how to test an overload trip,undervoltage,reverse power trip,?

62.how checks in an alternator?

63.insulation resistance test/megger test?

64.safeties of MSB?

65.checks on a motor lying in w shop?

66.diff between sulzer and man b&w?all differences?

67.why is x –hd pressure of b&w less than sulzer?

68.problems in Daihatsu con rod?

69. Typs of boiler burner. Ovhal of rotary cup burner?

70.reasons of short cycling,HP trip,of refer comprsr?

71.anchor chain cable drawing?

72.marpol annex 1

73.COATINGS USED IN TYPE 2 CHEMICAL TANKERS

74.chaecks in a foam room?

75.contents of AFFF

76.foam regulations for oil,chemical tnkr?

77.ovhl of foam,dcp,portable extinguisher78.co2 regultions of ER

79.pressure testing of co2 bottles

80.fire fightinf medium of ro ro,oil ,chemical ,gas carriers and all their regulations.

81.hw much is the width of side tanks of the side tanks of chemical ,oil tanker.

82.checks on anchor chain cable

83.free surface effect?

84.IG trips

85.boiler trips

87.navigation lights powered frm where?how many nav lights are thr ?if one fails wat action to b taken?

88.in a ballastr voyage can u do thrust bearing ovhl of AE ?

89. types of fuses onboard?Wat is HRC fuse?\

90.hw will u check cartridge fuse wheter gone bad or not?

91.wat is propeller drop.how do u checxk it?

92.oil record book entries?9

9Wat is VOC( volatile Organic compounds)

93.what is BC code?

95.fixed fire fighting medium on oil,chemical,ro ro ,gas carrier for deck fire with regulations?

96.wat is foam expansion ratio?

97. diff betn foam used for oil and chemical tanker?

98. hw TG interlock function explain wth diagram?

99.hw many v/v are there on a refrigerant bottle?hw u ensure tht u r opening a correct v/v or not?

100.wat is CGI(combustible gas indiacator)

101. wat is static electricity.hw it is of significance on ships especially t7ankers?NECESSARY CONDITION FOR STATIC ELECTRICITY AND CHARGE ACCUMUMLATIONS.

102 how will check a motor for a short circuit or open circuit fault?\

103.VENTILATION in chemical tankers

104 wat is standard fire test?

oating of ballast tank?coating of cargo tanks in oil tankers?

105. wat is fuel pumpmlead. Hw do u measure fuel p/p lead?

106.Adjustment f thermodynamic steam trap?

107.colour code for Freon,acetylene,nitrogen,oxygen?

108.Parcel system in chemical tnkr?

11. Draw a plan view of a gas carrier showing an air lock 2. list the ESB safeties3. What the checks carried out on the navigational lights/panel?4. Differentiate between Intrinsically safe and explosion proof equipment.Name a few.5. Sketch a PV Breaker6. List the hazards on a chemical tanker 7. Fuel pump timing check for Sulzer RTA engine.8. Differences between ME and MC engines9.What troubles have you faced with M/E and A/Es?10. Explain the preparation for crosshead bearing and pin survey.11. Difference between submerged and deepwell pump12.How does an induction motor start?13.How will take Propeller drop?14.Air compressor bursting disc given way during manoeuvring, what action will you take as second engg?121.EXPLAIN HIGH EXPANSION FOAM122 CRUDE OIL TANK ENTRY 123.CERTIFICATE THAT IS SOLELY CARRIED ON CHEMICAL TANKER AND NO OTHER SHIP CARRY IT.

124.PORTABLE EQUIPMENTS ON CHEMICAL TANKERS FOR SAFETY CHECKS.125RND ENGINE AND BNW MAIN BEARING DIFFERENCE.126.RND FUEL PUMP AND RD FUEL PUMP DIFFERENCE.127.DIFFERENCE BETWEEN MC-C AND MC-B ENGINES129.FUNTIONING OF STATIC AVR.130.WHAT IS CAUSTIC EMBRITTLEMENT? HOW U WILL U RECOGNISE IN BOILERS THAT IT IS CAUSTIC EMBRITLEMENT.131 TIER SYSTEM IN REVISED ANNEX 6..132. EXPLAIN SIPWA.