72
The Steam and Condensate Loop 13.1.1 Heat Exchangers and Stall Module 13.1 Block 13 Condensate Removal Module 13.1 Heat Exchangers and Stall

SpiraxSarco-B13-Condensate Removal

  • Upload
    danenic

  • View
    856

  • Download
    3

Embed Size (px)

Citation preview

Page 1: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop 13.1.1

Heat Exchangers and Stall Module 13.1Block 13 Condensate Removal

Module 13.1Heat Exchangers and Stall

Page 2: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop13.1.2

Heat Exchangers and Stall Module 13.1Block 13 Condensate Removal

Heat Exchangers and StallForeword

This Block discusses the removal of condensate from heat exchange equipment supplied bysaturated steam and fitted with:

o A temperature control valve on the steam line to the heat exchanger.

o A steam trapping device on the condensate line from the heat exchanger.

The primary side of the heat exchanger will be referred to as the ‘steam space’, and the steamtrapping device will be referred to as the ’trap’. The ‘trap’ can be a ‘steam trap’, a ‘pump trap’, ora ‘steam trap and pump’ fitted in combination.

On these installations, a control sensor monitors the temperature of the outgoing heated fluid inthe secondary circuit. The control valve endeavours to maintain a temperature determined bythe controller, regardless of variations in heat load. The valve achieves this by opening or closingto alter the flowrate of steam, thereby varying the steam space pressure.

The discharge from the steam trap may be subject to a lift and /or pressure in the condensateline, or may fall to an open end where it is subjected only to atmospheric pressure. This Blockwill refer to condensate pressure as ‘backpressure’.

The heat exchange equipment can be almost anything that meets the above criteria. Examplesinclude:

o Shell and tube heat exchangers.

o Plate heat exchangers.

o Air heating coils or batteries in ductwork.

o Pipe runs or pipe coils in process equipment, tanks, vats etc.

For brevity, this Block will refer to all such devices as ‘heat exchangers’ or ‘heaters’, and thepassage of fluid being heated by the heat exchanger will be referred to as passing through the‘secondary’ side of the heat exchanger.

The performance of steam heat exchangers is often reduced due to condensate flooding thesteam space and waterlogging. The two main causes of waterlogging are:

o Fitting the wrong type of trap.

o Stall.

Important noteSome systems aim to achieve control of temperature by positively encouraging partial floodingof the steam space of the heat exchanger. In these cases, the modulating action of the controlvalve at the condensate outlet varies the condensate level in the steam space. This changes thearea of heating surface exposed to steam, and the effect is to change the heat transfer rate so asto control the secondary outlet temperature.

With systems of this type, it is important that the heat exchangers be designed and manufacturedspecifically to withstand the effects of flooding. Where this is not done, the presence of condensatein the heat exchanger will have an adverse effect on operating performance and will reduceservice life.

This method of control can have certain benefits if the system is designed correctly. One is thatthe condensate sub-cools in the heat exchanger before it is discharged. This can considerablyreduce the amount of flash steam in the condensate pipework, which may improve theperformance of the condensate system and also reduce heat losses.

The main operational disadvantage is that systems of this type are slow to respond to variationsin heat load.

Page 3: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop 13.1.3

Heat Exchangers and Stall Module 13.1Block 13 Condensate Removal

Fig. 13.1.1 An air heater battery suffering the effects of stall

Steam in

The control valve is throttlingto meet a reduced heat load

Steam inthe top ofthe heater

Fresh air in

Air ducting

Waterlogged condensate inthe bottom of the heater

The steam trap goes cool or cold

Cooler air comingoff the bottom

of the heater

Hot air comingoff the top of

the heater

Condensate return

Lift and /or backpressure

What is meant by stall?

Stall is the reduction or the cessation of condensate flow from the heat exchanger, and occurswhen the pressure in the heat exchanger is equal to, or less than, the total backpressure imposedon the steam trap.

Lower than expected pressure in a heat exchanger may occur as a result of any of the followingcircumstances:

o The secondary fluid inlet temperature rising as a result of a falling heat load.

o The secondary fluid flowrate falling as a result of a falling heat load.

o The secondary fluid outlet temperature falling due to a lowering of the set point.

As the control valve reduces the steam pressure to meet a falling heat load, the lack of differential pressureacross the steam trap causes condensate to waterlog the steam space, as shown in Figure 13.1.1.

Due to applied safety factors and because heat exchangers are sold in pre-determined sizes, theyoften have more heating area than required. This has the effect of increasing the heat transfercapability of the exchanger above that required. It also means that the operating steam pressurewill be lower than in a comparable heat exchanger perfectly sized for the same duty. The result isthat less steam pressure is available to push out the condensate than may be expected. The steampressure in the heat exchanger is important because it influences the stall condition, which in turnaffects trap selection.

Before any trap selection and sizing can take place, it is necessary to determine whether or not stallwill occur, and if it does, to what degree. If this is not done, it is likely that the heat exchanger willsuffer from waterlogging for some or all of its operating life. This, when it occurs, may not beimmediately recognised by the observer or operator, as operating performance might not be reducedin an oversized heat exchanger. However, waterlogging can have severe financial consequences,short and long term, unless the heat exchanger is designed to operate this way.

Short-term problemsConsider an oversized heater battery operating as a frost coil and fitted with the wrong type (orsize) of trap, as in Figure 13.1.1.

In this example, the frost coil is preheating chilled air before it passes on to the main heater battery.Though the frost coil is fulfilling its thermal expectations (because it is oversized for the duty), it willdo so with the bottom half of its coils waterlogged. Incoming cold air approaching 0°C (typicallyflowing at 3 m/s) passing over the coils can easily cause the water in them to freeze. This results inhaving to repair or replace the heater battery, either causing inconvenience or unexpected outlay.

Waterlogging and freezing will not arise if the application is correctly designed.

Page 4: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop13.1.4

Heat Exchangers and Stall Module 13.1Block 13 Condensate Removal

Long-term problemsTraps that are undersized will sometimes show no immediate adverse effects on heaterperformance if the heater is oversized.

Ironically, the wrong type of trap fitted to a heat exchanger can often exaggerate a superficialimprovement elsewhere in the condensate system. For instance, a thermostatic or fixed orificefitted to any heat exchanger will hold back condensate so that it sub-cools below the steamsaturation temperature. This will have the effect of reducing flash steam from any natural outletsuch as a condensate receiver vent. The casual observer can interpret this as a way to saveenergy and can easily be tempted to fit these devices. Unfortunately, the situation is not asstraightforward as it seems. The reality is that holding back condensate until it sub-cools implieswaterlogging to some degree. Condensate that continually floods the steam space will causecorrosion with costly results. The service life of the heat exchanger is reduced, and the overalllifetime costs of the installation will increase.

The effects suffered by a waterlogged heat exchanger depend upon the circumstances of theparticular installation.

The symptoms and effects of stall are itemised later in this Module.

How does stall occur?To understand stall it is necessary to appreciate that saturated steam is a condensing vapour,which gives up its heat as it condenses to water. This condensation always occurs at a constanttemperature when the pressure in the steam space remains constant.

For example, saturated steam at atmospheric pressure has a temperature of 100°C and will alsocondense back into water at 100°C, whereas at a gauge pressure of 1 bar, saturated steam has atemperature of 120°C and will condense back into water at 120°C. Steam can also exist insideheat exchangers at below atmospheric pressure i.e. steam at 0.5 bar below atmospheric pressurehas a temperature of about 82°C, and will also condense back to water at 82°C. The pressureand temperature relationship of saturated steam is entirely predictable and is documented insteam tables.

Basic heat exchanger theory states that the higher the steam temperature above that of thesecondary fluid being heated, the greater the potential heat transfer rate. To vary the transfer ofheat from condensing steam, the temperature (and thus the pressure) of the steam in the steamspace is varied.

For example, if a heat exchanger uses steam at 160°C at maximum load, and the load is reducedby 50%, steam at a lower temperature is required. To achieve this, the steam pressure must bereduced, and, in many cases, becomes less than the backpressure.

Example:A heat exchanger running at full-load uses saturated steam at 1 bar g (120°C) to heat water from40°C to 60°C. Full-load therefore occurs when the water temperature rises by 20°C, and themean water temperature is:

The difference between the steam temperature and the mean water temperature is termed theArithmetic Mean Temperature Difference or AMTD, and the heat transfer rate is proportional tothis. The full-load AMTD in this example is 120°C - 50°C = 70°C.

Consider the situation where the process load falls to 2/3 load.

At full- load, the water temperature rise is 20°C.

If the load falls to 2/3 full- load, and the outlet water temperature remains constant at 60°C, thismeans that the temperature rise must be 2/3 of 20°C

Therefore:At 2/3 load, temperature rise = 2/3 of 20°C = 13.3°Cand the inlet temperature = 60°C - 13.3°C = 46.7°C

40 C 60 CMean water temperature at full-load = 50 C

2+ =° ° °

Page 5: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop 13.1.5

Heat Exchangers and Stall Module 13.1Block 13 Condensate Removal

At 2/3 load, the heat transfer needed will be 2/3 of that at full-load, and equally the AMTD willbe 2/3 of that at full-load, i.e.

As the temperature of saturated steam at atmospheric pressure is 100°C, this means that thepressure in the steam space is now atmospheric. Consequently, there is no steam pressure availablein the steam space to push the condensate through a steam trap. Even if the condensate line fellto an open-ended steam trap, the condensate might not drain out of the exchanger. Thecondensate will ‘back-up’ the drain line and waterlog the heat exchanger unless proper precautionsare taken.

If condensate backs up into the exchanger, the surface area available to condense steam isreduced, the heat flow drops and the temperature of the outgoing heated water begins to fall.When the temperature sensor detects this, the controller opens the control valve a little moreand the inflow of steam increases. This raises the pressure in the steam space above atmospheric(in this case) and soon becomes high enough to push condensate through the trap. The condensatelevel falls, but now the steam space pressure is higher than the atmospheric pressure needed tojust heat the water to 60°C. The water temperature then climbs. When the sensor detects this,the controller closes down the control valve. The steam space pressure falls to atmospheric - andthe flooding begins again.

The result is a continual cycling of the water temperature above and below 60°C. If thesecondary medium were other than water this could, in many cases, affect its quality.

What are the symptoms and effects of stall?One or more of the following symptoms may be evident:

In summary:1. Cold or cool steam trap.

2. Hunting control valve.

3. Fluctuating outlet temperature.

4. Stratified heater temperatures.

5. Waterhammer.

6. Reduced heat output.

7. Reduced product quality.

8. Corroding heat exchangers.

9. Leaking heat exchangers.

10. Failing heat exchangers.

In detail:o The steam trap goes cold, or is noticeably cooler than the temperature of the steam pipe inlet

to the heat exchanger.o The control valve is prone to ‘hunting’, i.e. it cycles regularly somewhere between its open

and closed positions.

It follows that the steam temperature at 2/3 load has to be the mean water temperature at 2/3 loadplus the AMTD at 2/3 load, i.e.

Consequently at 2 /3 load, the return water temperature will have risen to 46.7°C, and so themean water temperature is now:

2 2AMTD at load = x 70°C = 46.7°C

3 3

2Steam temperature at load = 53.3°C + 46.7°C = 100°C

3

2 46.7°C + 60 CMean water temperature at load= = 53.3 C

3 2°

°

Page 6: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop13.1.6

Heat Exchangers and Stall Module 13.1Block 13 Condensate Removal

o The temperature of the secondary fluid flowing from the heat exchanger is less accurate thanis expected or required.

o There is stratification of temperature on the output side of the heat exchanger. This will bemore apparent on heater batteries and unit heaters.

For example, it is almost certain to be detectable on the air heater battery depicted inFigure 13.1.1. The design is such that the face of the heat exchanger surface is usually accessible,often via an access panel or door in the side of the ducting. If stall is happening, the top of thebattery closest to the steam inlet will be very hot, whereas lower down, it will be much cooleror even cold, and the trap will be cool or cold. The temperature of the air flowing through thetop of the battery will be noticeably higher than that flowing through the bottom.

o The heat exchanger makes crackling, banging or thumping noises either continuously orintermittently. Sometimes these noises are associated with severe waterhammer that can causephysical damage to the heat exchanger and any equipment fitted to it. The hot steam condensinginto the waterlogged condensate causes the waterhammer and resulting noises, especiallywhen the waterlogging level varies with changes in load.

o In process applications, the result of one or more of the above symptoms may be poor orunreliable product quality.

o Increased corrosion. The waterlogged condensate cools to temperatures much lower than thesteam temperature at the inlet to the steam space. Carbon dioxide and oxygen dissolve muchmore readily into cooler water.

o Carbon dioxide is a common by-product of incorrect boiler water treatment and is carriedover into the heat exchanger with the steam. When it dissolves into water it forms carbonicacid, which causes corrosion.

Oxygen is present in raw water, and if not completely removed by the water treatment process,it too will get carried over with the steam. Its presence in water, especially cool water in whichit will readily dissolve, also aggravates corrosion.

Corrosion rates are greatly accelerated when both gases are present.

The degree of corrosion will depend upon the heat exchanger material. Copper, carbon steel,and stainless steel will each be affected differently.

o Mechanical stress.

The hot steam in the top of the steam space will cause the heat exchanger to expand there,while the cool water in the bottom of the steam space has the reverse effect. This unevenexpansion / contraction can cause mechanical stress to the heat exchanger structure, notablyto the soldered, brazed, welded or expanded joints in ‘plate’ and ‘shell and tube’ heatexchangers, and air heater batteries. The most common result is leakage of steam to thesurroundings in the former, or into the secondary airflow in the latter. The stress tends to beworse if the waterlogging level continually varies, especially if it varies quickly. The level ofwaterlogging will vary as the load changes, and as a result; the control valve and steam trapwill struggle to achieve stable control.

It should be said that a properly engineered plate heat exchanger with gasket joints suitablydesigned for steam will be very resilient to such stress.

The ultimate effect of stall is increased maintenance and shorter service life of the heatexchanger and associated equipment. This increases overall running costs.

Page 7: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop 13.1.7

Heat Exchangers and Stall Module 13.1Block 13 Condensate Removal

Do all heat exchangers suffer from stall?

No. The conditions may be such that there will always be sufficient positive pressure upstreamof the steam trap to clear the condensate so stall cannot occur.

As a general rule, the higher the secondary temperature above 100°C, and the more stable therunning load, (especially if near to the maximum output of the heat exchanger), the less likelyfor stall to occur. However, each application is unique and will require individual consideration.The only ways to determine the dynamics of the installation are to either plot the applicationtemperatures on a chart or to perform a mathematical calculation. This is explained inModule 13.2, ‘Condensate Removal from Heat Exchangers’.

Some applications can appear to operate with partial waterlogging, and show little effect ofwaterhammer. These tend to be steady load applications, or where the load changes only slightlyand very slowly, and /or applications that employ very robust heat exchange equipment.

One such example would be large bore corrosion resistant heating coils inside tanks correctlyarranged to have a positive fall towards the trapping points.

Even in applications of this type, if the installation is designed or corrected to eliminate stall,improved operation, improved reliability, and reduced lifetime costs are virtually guaranteed.

Page 8: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop13.1.8

Heat Exchangers and Stall Module 13.1Block 13 Condensate Removal

Questions

1. What is the prime cause of stall in heat exchangers?

a| Not enough steam pressure upstream of the control valve ¨

b| The heat exchanger pressure is equal to or less than the backpressure ¨

c| The heat exchanger is undersized ¨

d| The condensate discharges to atmosphere ¨

2. What effects will waterlogging cause in some heat exchangers?

a| None at all ¨

b| It increases the steam pressure in the heat exchanger ¨

c| It can cause swings in the temperature of the heated fluid and corrode theheat exchanger? ¨

d| It increases the thermal performance ¨

3. In a heat exchanger at full-load, steam temperature is 140°C,inlet temperature is 20°C, and the outlet temperature is 80°C, what is the AMTD?

a| 40°C ¨

b| 120°C ¨

c| 60°C ¨

d| 90°C ¨

4. In the same heat exchanger at half load, what is the secondary mean temperature?

a| 65°C ¨

b| 50°C ¨

c| 80°C ¨

d| 45°C ¨

5. In the same heat exchanger at half load, what is the steam temperature?

a| 70°C ¨

b| 100°C ¨

c| 110°C ¨

d| 95°C ¨

6. If, for the same duty, a larger heat exchanger were used, what would be expectedof the steam temperature at full-load?

a| It would be higher than 140°C ¨

b| It would be lower than 140°C ¨

c| It would also be at 140°C ¨

d| It would be at 100°C, i.e. atmospheric pressure ¨

1:b, 2: c, 3:d, 4: a, 5: c, 6: b Answers

Page 9: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop 13.2.1

Block 13 Condensate Removal The Heat Load, Heat Exchanger and Steam Load Relationship Module 13.2

Module 13.2The Heat Load, Heat Exchangerand Steam Load Relationship

Page 10: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop13.2.2

Block 13 Condensate Removal The Heat Load, Heat Exchanger and Steam Load Relationship Module 13.2

The Heat Load, Heat Exchangerand Steam Load Relationship

Saturated steam is used to provide primary heat to a process fluid in a heat exchanger. The termheat exchanger is used to describe all types of equipment where heat transfer is promoted fromone fluid to another. For convenience, this broad definition will be applied to the term heatexchanger. While shell and tube heat exchangers and plate heat exchangers will be principallyreferred to, stall may also be relevant to applications including air heater batteries, submergedtank coils, jacketed vessels and storage calorifiers.

Temperature controlled applications

In a temperature control application, the inlet temperature of the secondary fluid to the heatexchanger may change with time. This means that in order to maintain a consistent secondaryfluid outlet temperature, the heat supplied to the heat exchanger must also vary. This can beachieved by using a control valve on the inlet to the primary side of the heat exchanger, as shownin Figure 13.2.1.

Fig. 13.2.1 Typical temperature control of a steam /water shell and tube heat exchanger

Shell and tubeheat exchanger

Coldwaterin 10°C

Hot water out 60°C

Temperaturesensor

P1

Steam trapping

P2

Steam in

Controlvalve

Temperature controllerset at 60°C

Steam pressure intoheat exchanger

To condensate main

A control valve is used to vary the flowrate and pressure of the steam so that the heat input to theheat exchanger can be controlled. Modulating the position of the control valve then controls theoutlet temperature of the secondary fluid. A sensor on the secondary fluid outlet monitors itstemperature, and provides a signal for the controller. The controller compares the actualtemperature with the set temperature and, as a result, signals the actuator to adjust the positionof the control valve.

For a constant heating area and heat transfer coefficient, the rate at which heat is transferredfrom the steam to the secondary fluid for a particular heat exchanger is determined by the meantemperature difference between the two fluids. A larger difference in mean temperatures willcreate a large heat transfer rate and vice versa. On partially closing the control valve, the steampressure and the temperature difference fall. Conversely, if the control valve is opened so thatthe steam mass flow and hence pressure in the heat exchanger rise, the mean temperaturedifference between the two fluids increases.

Altering the steam pressure will also slightly affect the amount of heat energy available in thecondensing steam as the enthalpy of evaporation actually falls with increasing pressure. Thismeans that the latent heat available per kg of steam reduces as the steam pressure increases. Ifsteam flow accuracy is required, this must be accounted for.

Page 11: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop 13.2.3

Block 13 Condensate Removal The Heat Load, Heat Exchanger and Steam Load Relationship Module 13.2

Example 13.2.1A manufacturer is to design a heat exchanger in which the specification calls for steam at 4 bar gto heat secondary water from 10°C to 60°C. The water flow is to be constant at all loads at 1.5 L /s.It is assumed that 1 litre of water has a mass of 1 kg, so the mass flowrate = 1.5 L/ s x 1 kg/L = 1.5 kg/ s.The manufacturer uses a heat transfer coefficient ‘U’ for the heat exchanger of 2 500 W /m2°C.Take the specific heat of water as 4.19 kJ /kg °C.

Determine:

(A) The design heat load.(B) The corresponding steam flowrate.

(C) The minimum heating area required.

Also, if the customer’s minimum heat load occurs when the inlet water temperature rises to30°C, determine:(D) The minimum heat load.(E) The corresponding steam pressure in the heat exchanger.

(F) The corresponding steam flowrate.

Calculations:(A) Find the design heat load using the heat transfer flowrate equation (Equation 2.6.5):

Equation 2.6.5p= c T∆Q m

Equation 2.8.1Load in kW x 3600

Steam flowrate (kg h)h at operating pressure

=fg

314.25 x 3600Steam flowrate ( ) = kg /h

2 108.1Sm

Where:Q = Mean heat transfer rate (kW)

m = Mean secondary fluid flowrate (kg)cp = Specific heat capacity of the secondary fluid (kJ / kg K) or (kJ / kg °C)

�T = Temperature rise of the secondary fluid (K or °C)

Q = 1.5 kg/s x 4.19 kJ / kg °C x (60 -10)°C

Q = 314.25 kW

(B) Find the corresponding steam flowrate at 4 bar g, saturation temperature (Ts) is 152°C,and hfg = 2 108.1 kJ / kg (from steam tables). Calculate the required steam flow at the designcondition using Equation 2.8.1:

Steam flowrate (ms) = 536.6 kg /h

Page 12: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop13.2.4

Block 13 Condensate Removal The Heat Load, Heat Exchanger and Steam Load Relationship Module 13.2

(C) Find the minimum heating area to meet the requirement using Equation 2.5.5. Note; themanufacturer uses the Logarithmic Mean Temperature Difference (�TLM) to calculate theminimum amount of heating area to satisfy the design rating:

Equation 2.5.5

T - TT =

T - TIn

T - T

∆� �� �� �

2 1LM

s 1

s 2

60 - 10T =

152 - 10In

152 - 60

∆� �� �� �

LM

Where:�TLM = Logarithmic Mean Temperature Difference (LMTD)Ts = Steam temperature (°C)T1 = Secondary fluid in temperature (°C)T2 = Secondary fluid out temperature (°C)ln = The mathematical function known as ‘natural logarithm’

Equation 13.2.1

50T =

142In

92

∆� �� �� �

LM

50T =

0.434∆ LM

By re-arranging the general heat transfer equation (Equation 2.5.3: Q = U x A x �T)Equation 13.2.1 can be formulated, where �T can be represented by the mean value �TM.

A = U T∆ M

Q

�TLM = 115.2°C

Equation 2.6.5p= c T∆Q m

= 1.5 kg / s x 4.19 kJ/ kg C x (60 - 30) Cmin ° °Q

2

314 250 WA =

2 500 W/m C x 115.2 C° °

A = 1.09 m²

For the purpose of this example it will be assumed that the heat exchanger is designed to haveexactly this area of 1.09 m².

(D) Find the minimum heat load, when the inlet water temperature is 30°C, using the heattransfer flowrate equation (Equation 2.6.5) as used in Part ‘A’ of these calculations:

Qmin = 188.5 kW

Where:A = Heating area (m²)Q = Mean heat transfer rate (W)U = Heat transfer coefficient (W/m² °C)�TM = Mean Temperature Difference. Note: �TM may be either �TLM (LMTD) or �TAM (AMTD).

Page 13: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop 13.2.5

Block 13 Condensate Removal The Heat Load, Heat Exchanger and Steam Load Relationship Module 13.2

To calculate the corresponding steam flowrate, it is first necessary to determine the steamtemperature at the minimum load condition.

It is possible to use the �TLM design figures to accurately predict the steam temperature for anyload condition, but this requires the use of logarithmic calculations. However, once the exchangersize is fixed and the design temperatures are known, it is much easier to predict operatingtemperatures using what could be termed a heat exchanger Temperature Design Constant (TDC).The TDC method does not require logarithmic calculations. Please note: TDC cannot be usedon those applications where the secondary flowrate varies or where control is achieved by varyingthe condensate level in the steam space.

Note: When sizing a heat exchanger it is normal for heat exchanger manufacturers to use the�TLM method. Once sized, by knowing the heating area and the full-load operating temperatures,TDC can be used to accurately predict all operating temperatures resulting from changes in load,as can be seen in the following text.

Operating temperatures can also be predicted graphically by using what is termed a ‘Stall Chart’.This method is discussed in Modules 13.5, 13.6, and 13.7.

Temperature Design Constant (TDC)For any type of steam-heated exchanger with the secondary liquid flowing at a constant rate,TDC can be calculated from the test figures quoted by the manufacturer for full-load. If thesedata sets are not available and the heat exchanger is already installed in service, TDC can becalculated by observing the steam pressure (and finding the steam temperature from steamtables) and the corresponding secondary inlet and outlet temperatures at any load.

TDC is the ratio of the steam to water temperatures at the inlet and outlet; and is shown inEquation 13.2.2.

Equation 13.2.2T - T

TDC = T - T

s 1

s 2

Where:TDC = Temperature Design Constant

Ts = Steam temperatureT1 = Secondary fluid inlet temperature

T2 = Secondary fluid outlet temperature

In Example 13.2.1 at full-load conditions:

The steam pressure = 4 bar g

The inlet water temperature (T1) = 10°C

The outlet water temperature (T2) = 60°C

Steam temperature at 4 bar g (Ts) = 152°CT - T

TDC = T - T

152 - 10TDC =

152 - 60142

TDC = 92

s 1

s 2

TDC = 1.543 5 for this particular heat exchanger

Page 14: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop13.2.6

Block 13 Condensate Removal The Heat Load, Heat Exchanger and Steam Load Relationship Module 13.2

Equation 2.8.1

Equation 13.2.4

For any heat exchanger with a constant secondary flowrate, the operating steam temperaturecan be calculated for any combination of inlet temperature and outlet temperature.

In Example 13.2.1 the secondary outlet temperature remains at 60°C, and minimum load occurswhen the inlet temperature is 30°C. What is the steam temperature at minimum load?

Inlet temperature = 30°C

Outlet temperature = 60°C

Using Equation 13.2.3:

62.61T =

0.5435s

(60 x 1.5435) - 30T =

0.5435s

The TDC equation can be transposed to find any one variable as long as the other three variablesare known. The following equations are derived from the TDC equation (Equation 13.2.2).

To find the steam temperature at any load use Equation 13.2.3:

Equation 13.2.3(T x TDC) - T

T = TDC - 1

2 1s

To find the secondary fluid inlet temperature at any load use Equation 13.2.4:

To find the secondary fluid outlet temperature at any load use Equation 13.2.5:

Equation 13.2.5

[ ]T = T - TDC (T - T ) 1 s s 2

T - TT = T -

TDC� �� �� �

S 12 S

(E) Find the corresponding heat exchanger steam pressure and enthalpy at minimum load

From steam tables:

A steam temperature of 115.2°C corresponds with a steam pressure of 0.7 bar g.

The specific enthalpy of evaporation at 0.7 bar g (hfg) = 2 215 kJ / kg

(F) Find the steam flowrate at minimum load:

From (D) the minimum heat load is 188.5 kW.

From (E) the hfg is 2 215 kJ /kg.

Using Equation 2.8.1:

kW rating x 3 600Steam flowrate (kg /h)

h at operating pressure=

fg

188.5 x 3 600Steam flowrate ( ) = kg /h

2 215Sm

Steam temperature (Ts) = 115.2°C

Steam flowrate (ms) = 306.4 kg /h at minimum load

Page 15: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop 13.2.7

Block 13 Condensate Removal The Heat Load, Heat Exchanger and Steam Load Relationship Module 13.2

Questions

1. What determines the rate of heat transfer for any given heat exchanger?

a| The heat transfer coefficient ¨

b| The mean temperature difference between the two fluids ¨

c| The heating surface area ¨

d| All of the above ¨

2. How is the temperature of steam controlled in a heat exchanger?

a| By a steam trap ¨

b| By changing the steam pressure upstream of the control valve ¨

c| By controlling the steam flow and pressure in the steam space ¨

d| By an adjustable safety valve ¨

3. What is LMTD?

a| Logarithmic Maximum Temperature Difference ¨

b| Latent Mean Temperature Difference ¨

c| Logarithmic Mean Temperature Difference ¨

d| Lowest Minimum Temperature Difference ¨

4. What is the basic difference between LMTD and TDC?

a| None ¨

b| LMTD is used to accurately calculate a required heating surface areawhile TDC can be used to easily predict operating temperatures ¨

c| LMTD is easier to use ¨

d| Using TDC is more accurate than using LMTD ¨

5. What effect does lowering the steam pressure have?

a| The steam temperature rises ¨

b| It has no effect on the temperature but increases the latent heat ¨

c| The steam temperature falls ¨

d| The total heat in steam increases ¨

6. Knowing the heat load, what other factor has to be known to accurately determine thesteam mass flowrate to any piece of equipment?

a| The temperature of steam ¨

b| The total heat in the steam ¨

c| The enthalpy of evaporation of the steam at the evaporating pressure ¨

d| The specific volume of the steam ¨

1: d 2: c, 3: c, 4: b, 5: c, 6: c Answers

Page 16: SpiraxSarco-B13-Condensate Removal

The Steam and Condensate Loop13.2.8

Block 13 Condensate Removal The Heat Load, Heat Exchanger and Steam Load Relationship Module 13.2

Page 17: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������ ��������� ���������������� �����������������

�������������������� ���������

Page 18: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

������������ ��������� ���������������� �����������������

������������

������������ ���������

������������������ �������������������

������������ ��� ���������������� �������� �������� ������ ������ ���������������������������� ����� �� �������������������� ���������������� ���� �������� ������ ������ ��� ��� ���������������� �

������������� ����!�� ������ ������ ��������������������������������� �� � ��������� ����"����������������������� �������� ��� ���� �������� ������ ����#����� ������!�� ��� ��� �� ������� ������ ��� ������ ��������� ���� ��������� ������ ��� ��$�������������� ������ ������ ������ ���� ����� � ���� �� ���������������

������� ����� ��������� � ������� ��� %� �����������"� & ��� '()"� � �������� ������������ ��%� ������������� � �������*+���������,������� ����� �� ��� ���������������������

-�,������� ����� �� ����� ��� �����������./�� ��%� �����������"�& ���'()�������������������������� ����� �� ����%� ����������������������./�0��*+��1����*2�� �

������������������ ������� �� ������� ������ �� �� ��� ����� �� ��������� "������������� �� �� ���� ����� �� ��� �����.+� ���� �� �� ��,������$� � ������� ����� �� � ��,����� ������� ���������� ��� ���� � ����� �� �� ������ � ��"� ������ ����� ����� ���� ��� ���������� ��� ������������ ������ �������������������������� ����� ��� ��

$�� ���� ��� ���������� ��� ����"� ���� ��� �� ������ ���� ��� ����"� ��� ���� �� �� ���� ����� 3��4�3� ���������� �������� ����4���������������� �����������

������������������� �������� �������������������������"������������������� � ���������������3��4���������������� ������� ����� �� ������%� �������������

�������������������� ���������� ���5 �� ������%, ������������������%, ����������

������������������ �∆ �

� ������

∆ ��

6����7

��� 1 �� �������� ����������������8��7������ �����������������3��4����������$��4�

� 1 �� ���� ���� ������� ����6�

9 1 :� ���� ������������������6;� �(�

$ 1 :� ����� �� ��� �

������ � ��� ��������� �

����� �� �����������∆ � � �

��

Page 19: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������ ��������� ���������������� �����������������

�������������

� ����� �

� �������

� ����

� ���

� �

� �

�����������������������������

��������� � ������������� �������� 1��.�(

��������� � ������������ �������� 1�<.�(

����������� ��������������� ����� ������������������������%, ������*�*7

6����7

����1 /*�/*�(

�� 1 �.�(

�� 1 <.�(

�� 1 =�� �������� �����(

� ���� �����

� ��� ��� =

� ������� ������

� ��� =

> �� !���� ��������������������������, ���������

������� ����

� ���

=�

� ������ �

� ���=�

� ������� ������ ���� � �� �

������ ��� � ��� � ����� ������������ �

����� �� ���� ������

������������� �� ���� � ��

������

����������� ���������������� ���� ��������������/*�� �����6���������� ������ ������ ��������� �������������������"�������� ����������� ��2�� ����� #��������� ����"������ ��� ����� ������.+���������"�������� �������������*�+������

8���� ��������� ����������� ����������������� ���������5� ���������"����������������� ��� ���������� ������ �����5� ��

�������������

� ����� �

� ����

������������������� !����"

Page 20: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

������������ ��������� ���������������� �����������������

����������#���������� ������ ���

��������� !����"�# �$%� �$ ����&�!����#�&!�''(!�

=���

������������� ���������� �� ����� �� ��

�������� �

�������������� ����� ������� �������� � ���

������� ������� ��*�<�<�!� ;����������������� ��������� ������ ������%� ������������"������� ����������� �� ������ ��� ���������������*+�� ���� ��� ���� ��������� �������� ������� ��� ����� ������� �� ��������� �� ����� �� ������������ ������� ������ ���������������������������

�� ������� ����������� ������������� ����������8���� ��������� �������� ����� ������������������������������������ ������ ��������������3��4��, ����?%, ������*�*@�"������������������������������4("������%, �����������

> ������%, ������A��������������� ������ ��� ������������ ��� ������2��*�!6���$����/*�� ���"��� ��� ������� ����� ���������� �� ����� �� �������� �<2�<�!B ;!��

�������������� ����

����� ����� �

� �

6����7

�4( 1 ������ ����4������(��� ��

�� 1 ������(

�� 1 �.�(

�� 1 <.�(

�� ��������������

�� ����������

�������������

����

$��%��������%��������6���� ������ ������ ������ ���������� � ������ ���%� ������������ ���� ��� �������� ����� ���*���(� ��������������� ��� �����AA�*�!6�

>�� ��� ���� ��������� �� �� ���� ����� ��� ����� �� ����� ��� ��� �.+� � ����"� ���� ��� ������� ��������� ����������� ��������������� ��� ���������������� ��� ����� �������� ��� �����%� ������������ ���������������������� � ������������� �������������.�(�

C���%, ����������7

�������������

�&"!�'#(

�� �������������� ���

���������� �

6����7

�� 1 =�� �������� �����( 1 ������(

�� 1 =���� � ������������������ �����( 1 �.�(

�� 1 =���� � ����������������� �����( 1 <.�(

�4( 1 ������ ����4������(��� �� 1 ��<A2

Page 21: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������ ��������� ���������������� �����������������

������������������� �� ���

��������������

����� ���

� ��

(�� �������������� ������ ������ ���������� �"�������� �������� ����� ��������������*���(���������������� ��������� ������ ��������.��A�(������������������� ������ �����

C������ ��� ����"��������� �������� ������������������� ���� ������������ ���.��*�� ���" �������1����2D�!B ; !���������� ������������������������� ����������� ������ ����*���(��� �.�D�� ����

> ������%, ������A��"� ��� ����������� �� ����� ���� ��� �� ���� �� ������������� �� � ����AA�*�!6�

��!)��#�"

�������������� ������� ���.<�!� ;����������������� ��������� ������ ������%� �����������"������ ������������ ����������� �� ���� ���������� ������������������������� ������ ����� �������������� ��� ����������������������� ��� ����� �������� �� ��������� �� ����� �� ����������� ������� ������ ���������������������������

����� �������������� ���� ���� �������������� ������������ ���������$��������� ���������������� �� ����������� ���� ��������� �������������� � �����"���������������������� ���� ����(����� ���� ������������������������������ ������ ����"� �������� ���� ���� �"��������� ��� ������� ������������ ���� ���������� ����������������� ������������ ������ �����

#�������� ������ ������ ������������������ �� ��������������� �������������� ���������������� ���� ��"� ������� ����������������� ������������ ���� �������� ������ ������ ����� �������� ��� ������������� �����$� �� ������������������� ���� ����������������������������� �������� ��� �� "� ��������� ���� ��������,��������� ����� ���������� ������������ ����������������� ������ ��� ������� �� �����������

����� � ��� ��� ���� ��� �� �� ����������������� ���� � ��"� ����������� ����� ��� �������������� ��������� ���������4��������� ��������������������������� ����������������� �������������� �"� ������������������������������������ ������������������� ������ ����"� �������� �!���������������������������������� ��� ����������� ���� �����

#��������� ���� ���� ����� ��� ��� ��� � ������� �������������� �������������� �������������� ��������"� ����� �!�������� �������� ��� ��� �� �����������*���� �%�+� ,��������+� �%����������������++������+�-��.,%���,��+����/0������+�%�.��.����++������%�%�����,%��.���

#�"�������"���������� ������ ����������� ��� ��������������� ������� ���������"��������� ������� ��������������������"������������������������������ � �������� ��"������ �!��������� "� �������"������ ������ ������������������������ ���� ����6�������������"��������������� ���������� ���������� �������������� ������������������ �'��� ��������������� ���������)�������� ��� � ��� ����������

����������#�

� ����������� ���������� �� ������ ��� ��

�������

��������1������� ! �)�2.3%�����������

��������� ������ ������������ !����"�# �$%� �

$ ����&�!����#�&!�''(!�=

���

Page 22: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

������������ ��������� ���������������� �����������������

(������"��������� ���� ��� � ��� ��� ���C�����������"� �48�*���E��C��252�*�� ����� ����� ��� ���#��� ������������ ����������� ���A*.�!� ;�� �� ����������� ��������������/*�� ���#��� � ���������� �� �� �� ����������� �� ���������� .��*�� �� �������� � ��� ����D.�!� ;��� #�� ����� �� ����"�������� ���� �� �� ������� �� ��������������� �� ���� ����� ����� ������� � �� ��� � �� � ������������ �����������"� ��������������C������������

���������������� �� ��"�������� ���� ��� ������� ��������������� ���� �����������������5� �� ����������� �����������

$��� ����������������� ����� ��� ����"�������� ������������� � ��� ������ ���������������� � ��������� ������������ � �����������$�� ����� � ��� ��� ������� ���� ������������������������� ���������"������������ ���� ��������������� ���������� ���� �!������������������� � ��� ���������� ���� �� �� ����������$���������������� ����������������"������ � ��� ��������� ���� �������� ����&��������������������� ��������������������� ���������� ���� ������������� ��������������������������"�� ���������� ������� ���� ������������������������

��-��.�%�+������������%��4��+�-��%�����,%��.����������������� �������������� ���� ��7

� C��5� ��7 *���!� ;�� ����/*�� �������������� ���� ��

� �������� �7 �.��!� ;�� ��.��*�� �������������� ���� ��

� > �!�������7 $�������������������.�� ����

������������������ ������������� � ��� �������� ������������

�����������

���� �

���������

�����������

�������� �

���������

����������������

������� �������� �������������

��� �������������������������� ��

���������

Page 23: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������ ��������� ���������������� �����������������

��� ��� ��� ��� � � � � � �� ����

��

��

��

���

���

���

���

���

����

����

����������

�� ���

�������

������ ���

�������

�������

���������

�������

���������

������

����� ��

���������

������

����� ��

���������

����������!�

�"�#�$ %%��� ���������&��'

�"���� � �������&�� ����'

�"����� �������& �(����'

)������ ���� �(�������

�� ����%��*

)������ ������ �������

� � ����%��*

��������������������������� ����������������������������� !��� �������

$������������ ���� �!����������� �������������������� ����"��������������� ���� ������������.��*�� ���� ��� �� ��������� �� �� ����� �!��������� #�� � ����� ����� ���� ����� � ��� ��� ���C��������������� �������� ��� �������� � ��� � ������������� ���� ������ ��"������48�*���E��C��252�*�� ����� ����� ���� ��������������

#�"�������"����������� ����"������ �!���������������������� ���������������� �����������.��*�� ���"������ ����������� �������������������������� ����� ������ ���������������� ���,���� ��������F��������� ����*�������� ����������� ����� ����������$�������� "������� ������ ����������������� �������������������������� ������� �!���������6����� ���� �������� �!������������ ���������� � ������� ����5 �� ��

$��������������������������������� ����� ��� ������ �������������������������2�

Page 24: SpiraxSarco-B13-Condensate Removal

��������������� �������������

������������ ��������� ���������������� �����������������

���������

� 5%/�+���+�����������4��+�-��%�����,%��.��6

G #��� �������������������� �� �� �

�G #��� ����������������������������� �

�G >�� ������������� ����������������������� �

�G $��������� ��� �

�� �%��4��+�-����,%��.��%���0����)7����%�����.�����%���%���������,��/+�-����������������5%��1�+�%����,����.�������+�������++������%�+����������%�������6

G $���DA+��������������� �

�G $����2+��������������� �

�G $����.+��������������� �

�G ������� ������������� ���������� ������� ����� ������ ���� �

�� ����%�+���%����������1�%�����,%��.��+�1%/�+�%���++���1������+������1�/+��++���%���,%��.��1��%.������%�����.+����,�6

G >�� �������������� ��������� ���� �

�G ������� ������������������ ������������� �� ����� �� ���������� �

�G >�� ������������������ ����� �� ��������������������� ���� �

�G ������� ������������������ ������������ ��������������� �

(� 5%���+�%�����,���%�.%��0�,2���++������+��������6

G 8����� ������ �

�G #���������������� ������������������� ������ ���� �

�G #�������������� � ��� ��� ���� ���� � �

�G #������� ������������������ ���������� ������������ ���� � �

�� 5%������,����+���1����.+�������++���%�4�6

G ������� �������� ��������� �

�G #��� ����������������������� ������������ ��������� ������� � �

�G ������� �������� ����� ��� �

�G ������ ���� �������� ������� ��� �

'� 8����������������%�0�,2���++���1����0��.�1%��+�-�+%�����%�����0�6

G 3 ������� ���H �

�G �H �

�G $����5�� ������������� �

�G �H �

������������������������������� ������

Page 25: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������� ��������� ����������������� �����������������

���������������������� ���������

Page 26: SpiraxSarco-B13-Condensate Removal

��������������� ��������

������������� ��������� ���������

������

�������� �����������������

������������� ���������

������������ ����������������������������� �������������������������������� ����������� ������������������������������� ������ ��������� � ������� � ����������� ����!�� "�� # �����$� ������$����%&'��()�*�������� �� ����� �������� � �������� ���$�����������+�,���� ��� ��������� ���$)�*� �� ���������������� ���������� � ��� ������ ������ ���$� �����)�*�������� ���������$� ������# $�������������)�*�������� ��� ������� ��� �� ���������������� ��-

� .���� ��/01��������# $���������������� �������� ����������%���"���/21�#��������%�3���(��� � ��$�$������'3���(���������� ���� ���������������������$�� ��������������������� � �)

� .���� ��/41� ������������# $���������������� ��������������� ������������� �����������$� ����������$����%&'��("���������� ���� ���������������������$�� �������������������� � �)�*��/21�#���� ��% 3���(��� � )

� *�����������������$������ ��� ���� ���3��������������$������������ ������������������������#��$��� #�"���$���# ��������������������������)3������)��������������������������������$���������� ���������� �������������������������������������������������� ���������5������)�������)������ ��� ��������$�����$ �������� ��� ����������������� ��� ���$���������������������$�������$� ������ �"� ���$$ � ���������������� �������$���������)

6�� ������������$��� ��������������� ������$ � ��������������$�� 7���������������������$��������#����������������������������$���������� ������$����$ � ��)

������� ����������������������� �������������������������������

��� ( ���������������$�� ��������������� ��8

��� �����������$�� ��������������8

����������� ��� ����������$�������$� ������$ � ��)

9������������������������������� ����:���� ���%)+)3�-

�������!"#"$� �� � � ∆�� ��

��;��)3��� � �������)�&��< � ���� ������!���=����

%������������������ & !'()*�!'( +++*�

,���������������-./��'3���(�������������� �����%������� ������)

*�� �����������������������������������������������������0

6�� ��� ��������������$��� ������>*?���*����������%������� ������)

9����:���� ����')%)�-

�������1("!"1������ �∆ �

��� ���� ���

� �� � ������ ��

� �� �

��� �� ���

� �� � ���������� � ���

�*� & $2"#�,

Page 27: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������� ��������� ����������������� �����������������

�������!"$"$

� ����� �

� �������

� ����

� ���

� �

� �

*�������$� ������������������������������$"���������:���� ���%)3)3-

��� ��� �����

� � ���

� ���

� � �� ����� ����

� ��� ��

� � ����� ���� �����

� ���

@���� ������ �������������� $������������ ��-

������ � ��

��� �����

� � ������

� ����

����� �����������

*� ��������� ������������ ���� #��������������������������)�3������)�*� ��������� ��������������)3�����������������"���$���������� �����������������)

6���� �����"� ����������������������������� ��$"����$���������$��������������$��������������"� ��� �#����$���� ��� ���� #� ��� ������� �� ���$)�A���� �������������� ���������� ������������������$������������������� �����$������������"���$���������������� ������ �����������$����������� ��)

6���������� ��������������� �����$�����������$ � ���"������������������������ ������������� �������� ������ ��� ��"���$�������=����������$���� ��$� ����$)

� �� �� ������ � ������ �

3������������������� & 11+�,

(��-�*�� ; 3!)+� *� ; ��� *� ; !�� *� ; .��������������

Page 28: SpiraxSarco-B13-Condensate Removal

��������������� ��������

������������� ��������� ���������

������

�������� �����������������

�������!"$"$

� ����� �

� �������

� ����

� ���

� �

� �

���������� �

�����������

���������

��

��� �

� ��

��

��� �

��� ���∆ ��

����

� � ���������� ��

@��� ���:���� ����')%)������ � ������� �����������������$��� �$����������� �����%&'��()

�������1("!"1

������������ ��������

��� ������

� ��������

�������� �∆ �

9���� � �� ����$��$� ����"� ����� �� /41� ���� ���# $� �� ����� ���� �������� ��������� ����� � ��� ���� �������� �����������)�&!���)�*� �� ���#�� 7$����������3,����$������������� ���������������������������������������=���$������ ������$ � ��)

6������� �"����������������� � ����������� � $���� �������,��#������� �)� 6�� �� ���� �� �������������������� ���������������������������$������������ ����������������$������������� ��$���������� �����$�� 7 ���������������� ���$# �)�*��������������������������$���� �� �������������� �� ������� ��"���"��������"������� ������"����/21�#���"���$�������������)�9������ ��$���"�������$��>*?���������������$"�������� ����������� �������������������$)

,���������������-4/9��� ��������������� ��� � 7� ������ ��� ���� ���������������� ���$� ��� ���$ � ��"� �� ������������ �$����� � ������� ������������� ������ ����������� �������=���$)�6�� ��� �������������$��� ��������$��>*?��������������������� ���������������������� ����������*��;��3%� �)

9����:���� ���%)3)3-

(��-�*�� ; �>*?*� ; ��� *� ; !�� *� ; �3%�

(��-� ; B�� ������������ ; B�����������������(�*� ; B��������������� � ����(��� � ��*� ; �*��

Page 29: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������� ��������� ����������������� �����������������

*������� ������������������������=���$���������������$���������:���� ���%)3)3-

�������!"$"$

� ����� �

� �������

� ����

� ���

� �

� �

�������1("!"1�������� �∆ �

� ����

∆ ��

��� ������ �

������ ��� ���������∆ �

� �� �

�� � ����� �

(��-�*�� ; &C)!� *� ; ��� *� ; !�� *� ; .�������������

@���� ������ �������������� $������������ ��-

��� ���������

� � ���

� ���

� � �� ����� ����

� ��� ���

� � ����� ���� �����

� ���

���� � � ��

��� �����

� � ���� �����

� ����

� �� �� ��� ��� ���� ������ �

�������� �� ��� � ���������

*� ��������� ������������ ���� #�������������������������')��������������$� ������$ � ��)����� ��������� ������������������������)3�����������������"���������� �������������������=���$)

9 �$�����>*?��������������������� �������� �����������)�&!���-

Page 30: SpiraxSarco-B13-Condensate Removal

��������������� ��������

������������� ��������� ���������

������

�������� �����������������

�����������

������

����������� �������

��

���������������������������"����������� ���������������� ������������)3�����������������)

*��������� ������������������������)3������� �����)+� )

9����:���� ����')%)����� �����������������������$-

�������1("!"5[ ]� ���� ��� ������� ���� ��� � � �

(��-*? ; *��������?� ��� �������*� ; ��� *� ; !�� *� ; ��C�

(��-*� ; 6�������������� *� ; !�� *� ; ���)+� *? ; %)��3

� ������������ ���

�� ����������������

[ ]� ���� ��� ����������� �������

*�������6,06�� ����������������� �$�����������$������ ������������ ��������)�6����$�����$����"� �� �����������������������*? ������� ����������������������$� ������$ � ���)

9����:���� ����')%)%-

�������1("!"!� ����

������� ����� �

� �

�������!"2"1������������� �

��������������� �! "#" �����$������!�$��%%&��

=��

��������� ������ ��! "

� �����

���������������� � ������� ��������������� �

*�������������� ��������������7����0*��������������������� ���$��$�������������������������"��� ��� ��')��������������=���$"�� ����������������#������ ������% �%%��< � ��)

9����:���� ��)�%)!)�-

Page 31: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������� ��������� ����������������� �����������������

*��������������������09������������������������������� ����:���� ���%)+)3�-

�������!"#"$� � �∆�� ��

��������� �������� ������ ��������������� �� ��

������������������ ���� ������� �� �������

�������=���$� ��%&'��("���������������������$ ������ �������������������� � ������

*������ �������������� ���$# ��� ���$��$�������������� � �����������$� ��� ����������������������������$)

*��� � �������$� ������$����� ���+�,�����������=���$����%&'��("�������-

> � �������$ ;��)+���%&'��( ;��C+��(

.��������$ ;��'!��(

������� � �������$� �������������������������$"���������� ����#�������)�6�� �������������� ������� ������������������������"��������� ���������������� � #�$ ����� ����������������� �)

B��#�"����������������������������������� 7$���������������������=���$���$����� � ������$"���$� �� �� �������������� ������������ ��� ����� ��������$� �����������$ ��� ����������������������������$ � ���)

�������1("5"1[ ]� ��� �� ���� �������� ����� � � �

(��-*� ; *������$��� ����������������������$��������/�1*� ; *������$��� ��������������������=���$*� ; *������$�������������������������=���$� ; *�����$�������)

9��������D����� � �����������$����+�,� ���� #�������������$������������)+

[ ]������ ��� �� ����� ��������� ����� � �

[ ]������ ��� � ������������������ ����

[ ]������ ��� ���������� ����

������ ���������

6�� ��� ������������������������������$��� �������������������� � �������$)�*� ���������$ ��$���������:���� ����')�)�-

Page 32: SpiraxSarco-B13-Condensate Removal

��������������� ��������

������������� ��������� ���������

�����

�������� �����������������

��� �������������� ��$�������� �������� ������������"������������������������ ���� ����)�6�� ������������ ��� � 7� ������� ������ ����� ����� ��������� ������ ��� ������ ���� �����$ ����� ������������')3�������$������)�)�)

�� �������=���$�����&!��� ���� �����$ ����� �������������')��������=��)3�������;�%)&������)

�� ���� � �������$����%!!��� ���� �����$ ����� ��������������)��������=��)3�������;��)3������)

6����������������������������������������� 7 ����������9 �����')�)����������?E%3���F��9*��=�)3� ������ ������������������$ � ���"���$�����$�������$)�B��#�"� ������ � �����������$������������������������$"�����������=���������$���#����������$)

*������$��������� �������� ���$# �������������$ �����$� ��>�$����')!"�/5���� ��������$������#�� ��������1)

�������1("!"(

��������������������������9����:���� ����')%)'-

�� ������������ ����

�������� �

(��-

*? ; %)��3

*� ; !��

*� ; '!� *� ; .��������������

�������� ����������� ����

���������

���� ����

�����

������������������� ��������������������

*� �� �� �������������������� ���� � �������$�����C+��("���$� ���� #����� ��������������������)�������)��*�����$������������ ���)3������)�*��$ ����� �������������������������������������������� � �������$���������������)��������=��)3�������;��)3����)

*�������������� �������������������������������18#)*0*��� � ������������������ ���$��$�������������������������"��� ��� ���)�������� ����������������#������ ������% %��)���< � ��)

9����:���� ���%)!)�-

�'������� ������ ��! "

� ��(���

���������������� ��� ����� �� ������������������������������������

�������!"2"1������������� �

��������������� �! "#" �����$������!�$��%%&��

=��

Page 33: SpiraxSarco-B13-Condensate Removal

��������������� �������� �����

������������� ��������� ����������������� �����������������

��� ��� ��� ��� � � � � � �� ����

��

��

��

���

���

���

���

���

����

����

����������

�� ���

�������

������ ���

�������

�������

���������

�������

���������

������

����� ��

���������

������

����� ��

���������

������������

����������������������������

������������������������

������������������ �����

!���"���"��#���� ������

$���������%

!���"���"��#�����������

$���������%

��������������������� ������������������������������� �����������������

Page 34: SpiraxSarco-B13-Condensate Removal

��������������� ��������

������������� ��������� ���������

�������

�������� �����������������

���������

1" 9�������:������������������-./���������������1�����������!��; �� �������������<=�6�����������������>����7��������������0

�G '')+� �

�G %&)'� �

�G ��C)%� �

$G ��C� �

!" 9�������:������������������-./���������������1�����������!��; �� ����������������������������������������������!'()*0

�G 33� �

�G ���� �

�G ��C)%� �

$G �+3)C� �

(" 9�������:������������������-./���������������1�����������!��; �������>�������������������������������!'()*0

�G 4�"��������������������� ��� ����������������������� �

�G E�"��������������=���$�������� ��+)������� �

�G E�"����������� ��������� ������� ������#�� 7$������������ �

$G *�������������� �����"�������������������� �����$� � �

5" *���������������������)�����������������������������0

�G E�������#� �

�G 6���$������������������� ���������������� �

�G 6���$��������������������������������� � �

$G 6�� ����������$ ����� ����������������� � �

$" *�������������������>����:������ �����������0

�G 6�������������������������������������������#��# �

�G :�����������$�����$ ������������������� �������� �

�G ������������������� �����$�� ����������������� ���$# � �

$G 6���������� 7������������������ ����� �

#" 3�������������������:���������������������+"2����"*�����������������������������������������������������������)����������+"1����0

�G H�)C���� �

�G =�)C���� �

�G H�)&���� �

$G =�)'���� �

���������������������������� ��� �����

Page 35: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

����������������� ��� ������������� ��� ������������� ����������������� � �� ������������

������������������������� ��� ����������� ��������� ��� ���������������� ��� ������������������

Page 36: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

����������������� ��� ������������� ��� ������������� ����������������� � �� ������������

�������������

�������������� ����������������������� ������������������� ����� �������������� ������� ����������� ��� �����������

���������� ���� ����������� �� ������� ���� ���� ������������������� ��!������������������ �� ��� �� �� ��� ���� ������ ��������������� ���"�� � ��� ��� ��������!�������������� ���� �� �����"�"������������ �#� ����� �$��%���"���������������� ���� ������������������������ ���� ���������� ��� ����������

&�������������� �� �������� ��������� ������� ��������������� ������ ��������������� ������������ ��� ������������ �� �������� ������������������������ �� ������'�������� ��� ������ �������� ������ ����������������� ��� �� ��������������� ��������� ��� ����������������

����������������� �������������������������������������%�������������� ����� �������������� ������� �� ������������ ������� ������ �������������������� ����" ����������� ���������� �� ��

&�����(� ��������������� ������������ ����������)��� ���� ������� ����������������� ����� ������ ������������������� �� �������� ����������������� �����������!���� ���� �� � �� ������� ��� �� �� ����� ���� ��� ��� ����� ����� ���� �� ���� �� ��� �� � �� �� ������ ��� ������� ��� ����� ����� ���� � � ��� ��� ����������� � �� �������

*���������(� ������������������� ��������������������������� �� �������� ����������������� �����+�"���������������(� ���������������������� ����� ����������� �� ������� �������������������� �������� ����� ����������� ����������������������������,������������� ����� �� ������ � � �-./� � �� ���� ����� ��������������� ���-./��� ��� ������" ����

0�������� ���������������������� ��������� ����������� ������� ����� ��� ����������� �����������������&�����(� ����������� ���������� � ����������� ��������� ����������������� � �� �������&��(� �������������"������ ��������������������� ��������� �����������������,���

&����� ��� ����� �������������0���������-�1��%���������� ��� ������� �������1.�+��� ��� ���� ������������� ���� �������1.�+��2.�+��3��� ������ ������� �������1.�+��� ���"��� ������������� ��4

� %�� �������� ���� �������5�!6����������������� ���������� ���� ���������������� ������� ������������� �������� ����� �������� ��� �� �

� !����� ���� ������������� �����������"������������� ��� ����������� ����� ���� ���

0������������ ������� ������������ ����� ���������������(� ����������78����9����� ���������������"���� �� ����������� ����� �����0���������-�1��'������������������������ ������������ ����� ���� ���� ����� �� ��� ����� "���� �� ���� 78����9�� !��� ����� ��� ������ ��������� ����78����9� �����(� ���������� ��������������"���� �� ����

�������������� �� ����������� ��������������������������������������������������

������������������

��� ����� ��������������������������������

����������������� ��������� ����� ������������� ������������ ���

����� �������

������ ������

������ ���

�����

Page 37: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

����������������� ��� ������������� ��� ������������� ����������������� � �� ������������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

%�� ��� �������������:�������������� ��������������������������������������� ������� ��� �������� �"����� ���������� �� ���'���� �������� ��� ���������:�������������� ����������������������������������� ���������������� �������������� ��������� ������� �� ��" �����

������������������ ��� ���� ���!�" ������������������ �����#�� ����

%�������������� ���� ��� ����,� ������������������������" ������ ��� �� �������� �������������� ��� ������������!��������� �������������� ���������������"���� �� ����� ������������0���������-���78����9��&��� ������������������������ ���������������������������� �������� �������������"���� �� ���� �������

������������������ ��� ���� ���!�" ������������������ �����#�� ����

!��������� ��� ����������� ������� ����������������������������� ������������� ��� ������������� �� ���������� ����������������� ������� ������������������������� ����� ������&�������������������������� ���������� ����� ��������������� ����!�������������������� ��#� ������$��������������������������������� ��

�������������������

���

��

���

���

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

�������������������

���

��

���

���

Page 38: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

����������������� ��� ������������� ��� ������������� ����������������� � �� ������������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

���� ��������

����������$��� ���� ��� ���%� �����������

&����������������� ��������� ���������������������������� ���������� ������������������� ������ �����.��8 ���.���� ����7 �� ����;�2.<�<-��8 ���.�.;2�.<<�-�� �9�&������������������� ������� ����������������������� �� ������������������������������ ��������������������� ������� ������������������������ ��������

!������,� ��������������������������������������������������� �"��������������� ��!�������������������������������������� �������������������#� ������$������������ ����������� ������� ����������� ������� ����%�������������������� �"��������������������� ��������� ���������� ������������7%��" ����������� ������������������������ ���� ���..�+��������� �� �������������������������������� �������������������� ��� � ����� �� �9��&�"���� ��������������������������������������� �������!������� �����������"���� �����������������������,� �� ����78����9�� ������������� ��� ���� ����� �"������������� �� ���!��������� ���� ���� ��� �� ��������������� ���� ��������=�� ������-���

�������������������� �� �����

�������

)����4& > !����� ������� ������������ ���� ��� �����(� �� > !�������� ������������������ ���6 > !���� ���������������" ����� �� ����� ������� ���

!���"���� �������������������� ���������������������� �����������������������%�� ����,� ����������� ���������������������������������"���� �� ��������������� ����������� ������������ ���� �������� ���������78����9�

�������������!����� �������������� ��� ����� ����� �����(� ���������"�������?�� �����+����� ���������������� ����� ����������� ����� �������� �����.����&�����(� ����������� �������������������� ���� ����� �1-�+� ����� "�������� ����� ����� �2.�+�

�� )� ������������� ����� �� �� �� ��@�� )� ������������ ������������� ���� �� ��@

!��� � �� ��� ����� ���� �� � �� ��� �� �� � ?� � �� �� ��� �?.�+�� !�������� ��� �� ������ ������������ ����� ����� �����(� ������?.�+��!����� �������������� ����������0���������-� 4

�������������������

���

��

���

���

Page 39: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

����������������� ��� ������������� ��� ������������� ����������������� � �� ������������

�� ������������������ ������� !�������"!�������� ������������������ ������2.�+��������������� �����������0���������-� ��������������� ������������������� ���� �����(� ����1-�+��������������� ��������

!������������������� ����������.������ ��� �� ���������������� ������ ������������� ������������������������ ���������!������������ ��������� ��������������1�� �����&����� �� ��� ����� ������ �� �� �1�� �� �� �����-�+�� ������,� �� �������� ������������ ��� �������������� ����� ���������� ����

!��� � ��� �� �� ��� 0������ ���-� � ����� � � ��� ������ ��� �� � � �� � � ��� 78��� �9� �� ������ ����<�/���!���� ��� �� ��� ���� ���� �����" ��� ������������=�� ������-��4

���� ���������������

������������� �� ������������

)����4

& > !����� ������� ������������ ���� ��� �����(� � > �?.�+

� > !�������� ������������������ ��� > 2.�+

6 > !���� ���������������" ����� �� ����� ������� ��� > ��-�+

�������������������� �� �����

�������

����������������������� �� �����

����������

��������������� �� �����

��

������������������

�� �������������� �!�#�����������������������"!���� ����� �����0���������-� � �������� ���� �������������� ���� �� ���78����9���� �� <�+��� ?�+��!���� ��� �� ��� ���� ���� �����" ��� ������������=�� ������ ��4

���� �����$��[ ]� �� � ���� ��� ����� ����� � � �

)����4

!� > !�������� ������������� ���� � ���� ��� ���#�$

!� > !�������� ������������� ���� �����(� �

!� > !�������� ������������ ���� �����(� �

� > !���� ��� ���

0���� ����A�������������� �� ����<�/�� ���������" ����� �� ��� �����.�<�

[ ]� �� ��������������� ���������� �����������

[ ]� �� � ������ ������ ������� ���������� � � �

[ ]� �� �������� ����� �����������

������� ������

Page 40: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

����������������� ��� ������������� ��� ������������� ����������������� � �� ������������

���������

�� �������������"

B !����� ������������������� ����������� ���������� �

�B !��������� ����������������� ������� ���������� �

�B !��������� ������������������� ������� �������� ���������� �

�B !����� ��� �������� �� �

�� ���������������� ������%��&��������������!���� �!�#�'��!������������������'��(� !"

B !������������������ ��� �

�B !������������������� �� �

�B !�����������������,�� �

�B !�������� ������������� ��������������� ������� ������� ��� �

�� ���������������������!�''�������%��&��������������!���� �!�#�'��!������������������)�*�� !"

B %����?-/����������� ��������������� �����(� � �

�B %����1-/����������� ��������������� �����(� � �

�B %���� � �������� �

�B %������ �������� �� �

$� �� ��������$��� &������%�+������������%�� �����& �!����������� !�%���'������ �!��������������&���� �������"

B �./ �

�B 11/ �

�B �./ �

�B 2./ �

�� ��� ,�&���& �!�%��������� �!�#����������������"

B 1-�+ �

�B -�+ �

�B --�+ �

�B <2�+ �

-� .',���'��(� !,������������������&������%�� �/��0��1������!� '�)�%�� ,&���& �!�%��������� ������������ !�' ������ ��������%�+�������"

B 1./ �

�B �./ �

�B ./ �

�B -./ �

���������������������������� ��� �������

Page 41: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������������ ���������������������������������� ����������������� �����������������

�������������������������� ���������������� ���������������������������������������������������

Page 42: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

������������������ ���������������������������������� ����������������� �����������������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

� �

�������������

������������ ���� ������ �� ���� ��� � � ������ ���

������������������� ��� �� ���� ��������� ������������������������� ����������������������������������� ������������������� �������� ��������������� ���������������������������� ����� �������������������� �������� ���������������������������������� ��� ��� ������������������������������������ ������ �������������������� ���������������������������� ��������������������������������������� ������������������� ������ �������������������� �� ��� ������������������������� ���!��� ������ ������������������������������� �� ��� �������������������������������� ��� ���!��� ���������������������������������������"����#��� ��$!�%�$&�

������������������������������ ����������������� ��������

���������� �

� ���������

���������������� �������������������� ������

������� �� ������

� ��������������� ���������������������� �������������������������

'����������� ������������������������������������ ��������������������������� ����������������������������� ������������������� ��������������� ��������'����������������� �����������

'����� ����� ���������������������� �������� ������������������(������$!�)�$���*���� ��� ������#��� ��$!�%�+����������������� ��� �������������������� ����� ���������������������",������&������������ ������������������ ����������'������� ��������� �������������������� ��� ������������������ ����������� ������� ���������",������&�

'��������� ������������������� ��� ��",������&������������������ ������������������ ���������'����� �-����������� �� ������������������������ ���� ����������������� �������������� ���'�������� ��� �������������� ����������� ������� ������������������������������ ��������������������������������������� ��� ���������������� ��������������������

���� �����������

�����������

���

�� �� ���

Page 43: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������������ ���������������������������������� ����������������� �����������������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

*���� ��� �������#��� ��$!�%�!������������ �������������������������� �������������������������������� �-��������������������������� ����� ������ ����� ����������)./������� �������������� ����������'���� �� ���������������������� ������������� ��� ���������������������������

'�������������� ������������� ��� ������������������������������������������������� ���������������������������� ��� ���������������������������� ����� ������������ �������������������

� ��������������� ����������������������� ������������������������

'������� ���� �� ������������������ � ���� ���� �������������������� ��������������������� ����� ����'���������������� ������������������������������������� ����������������������� ������������ ���� �������������� ���� ��� ����������������� ������������������ ������������ �������������������������������������������������������� ��

'������������������������ ���������� ������������������� �-����������",�����&���������� ������� ������������������������ ��������������� ��� ������������ ������������������������������ ����� ��������������������

'����� ��������������������������������������������(��������$!�%�$0

��� ���� ������

*�� �0

��1������������ ��� ��������������

2�1������� �������������������� ��� ��������������

3�1������� ������������������� ��� ��������������

4�1�(�������������� ���� ������������� ��� �

���� �����������

�����������

�� ����� � ��

��������� ����� ��������

�� ����� � ��

+

+

Page 44: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

������������������ ���������������������������������� ����������������� �����������������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

� ��������!��" � ���������������������#�����$�������� ��

��� ������������������������� �������������������������� ��� ����� ���������������� ���� ��� ����� ��� �� ��� ��������� ������� ��� ������ ����� ��� �� �� � ������� ���� � ����� ��� ����������������������������������������#��� ��$!�%�5��'�������������� ��� ������������������������������ ����������������������#��� ��$!�%�)�� �������������������������� ������ ������������������������� ������ ����#��� ��$!�%�5����� ����������������������

6��� �������#��� ��$!�%�5��������������������������������������������������� ��� �����������������������!7/����7.�3�� ��� ���������� ������������������������� ��� ������� ����������������������#��� ��$!�%�)��������������� ������������������������������������������� ��� �������������������-���� ���� � �������������

������������� ���� ������ ��� ������������������������������������� ����������������� ��� ���������������������������� ��� �������������'������ �����7.�3���������������� ���#��� ��$!�%�5��������� �� ���������������������������������������

� ��������%��&$����������������������������������������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

���� �����������

�����������

���� �����������

�����������

Page 45: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������������ ���������������������������������� ����������������� �����������������

��������������'���������� ���� �� �������������������� ���������� ����������� ������ ������� ���������� ��8��� ��������� ���� ���������������������������.�)��� ����������� ���������������7���� ������� ����� ������� ����������� ���������� �� ���������� �� ��������������� ����!.�3����� ������� �������������� ����9.�3������������ �������!�%5�: ; ��

*������������� �������������������������������������������� ������ ������ �������������������� ��������<

'������� ����������� ��� ������������������8��� ������$7)�3���'�� ��� ����������������� ��� ������������������� �����������������$7)�3���'�����������������������������������������#��� ��$!�%�%�

'��������� �������������������� ��� �����9.�3����������������������������������������������� ������������������ ��� �����!.�3������������������������������

� ������������������$��������'��� �����������������������������

'���������������������������������7��� ������������� �������� ���� �����.�7��� ��������������������.�)��� ���� ���� ��������������������������'�� ��� ������������������������ ���� �����$�+��� �������������� ����������� ��� ��������������$�+��� ������$+!�3�������� �-�������������� �� ���������������� ���� ������ ����������������� ��� �����#��� ��$!�%�%�

�������������������� ������������",�����&������� ���������))/��'������������������������� ������������ ��������� ��������))/������������������� ������ ������������ �����������))/���!�%5�: ; ��1�+�: ; ���'������������ ����������������������������(��������$!�%�$�

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

���� �����������

�����������

Page 46: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

������������������ ���������������������������������� ����������������� �����������������

���������������

��������� ����� ��������

���������������

����������������� ������� ��������

����������

��������� ������� ��������

���

�����������������

=���� ����� ������ � ������������ ����� ����� � ��� �� ����� ���� ���� � � �� ����� ����� ��� �� ����� ����������������������� �������=����������2����$!�

'�� ������������� ���������������������� ��������������� ����������������������� ��� �������������� ���������� ���� ���������������������������� ������������������ ��������� ��������������������� � ����������������������� ���������������������������������������������� ������� �������� �������������������������������������������� �������

*�� �0

��1������������ ��� �������������� 1 $7)�3

2�1������� �������������������� ��� �������������� 1 9.�3

3�1������� ������������������� ��� �������������� 1 !.�3

4�1�(�������������� ���� ������������� ��� � 1 $+!�3

�����������

�������� ������� ��������

�����������

��� ���� ������

Page 47: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

������������������ ���������������������������������� ����������������� �����������������

���� ����

�� �� ���� ���!�""����#��$� %���� ���#��� �� ���!�&����$���� ����#��� �'

�> ������� �

�> '��������������������� ���������� ����� �

> '������� ���� ������������������ ����� ���� �� �

�> '��������� �������������� ���������� ����� �

(� )"� ���$�#*�������������������+���� ����,��� ������ ���� ���������%�� �!���� ��������'

�> '������������������� ������ �

�> '������������������������������ �

> '������������������������������� �

�> '�������������� ����������� �

�� )"� ���$�#*�������������������%��� ����,��� ��� ���� ���������%�� �!���� ��������'

�> '������������������� ������ �

�> '�������������� ������������� �

> '������������������������������� �

�> '������������������������������ �

-� )"��������������������� ���#��!���� ��$�#*���������%����� ��������#��� �%�� ����#�� �+����!�%���!�� ������&���##����!'

�> $8/ �

�> +8/ �

> !)/ �

�> ))/ �

���������������������������

Page 48: SpiraxSarco-B13-Condensate Removal

��������������� �������������

������������������ ���������������������������������� ����������������� �����������������

Page 49: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

�������� ��������������� ������ ��������������� ������������� ������������� ���������

������������������������� ��� ����������� ��������� ��� ������������������� ������������������

Page 50: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

������ ��������������� ������������� ������������� ����������������� ���������������

���������������� ��� ���������������� ��������

���������

�������������������� �������� ������������������������������������������� ������������������������ ��� ����� � ��������� ���� ������� ��� ������������ ����������� ����� �������� �������������������������������������������� ����

��������������������������� �������� ������������������������������������������������������������ �������������� ������������������������������������

��� ���� ������� ����� ����������� ������������ ���� �������� ��� �������� ����� ���� ����� �� ��� ������������������������������� ���������������������������������������

������������� �������������������������������������������������������������������������� �������������������������!����������������������������������� ������������������������������������������������������������������������������������������������� �� ����������

������������������������������������������������"�#�$ % �����������������������������&'�(�������)������*'�(�����������)��)���� ����������������������������������������� ��������������������� ������������������������#�&�����������+�",'�(�������������������������������)���������)������ �����������������������������������������+�"''�(��

������������������ �����������������������������������������������������������������������������

������������������������������������������������������������������������������������������������������������������-(��������������.����� ���������������������������/�������"0�&�&1

��������������� ����

������� ����� �

� �

��������.���������������1�� + &'�(�� + *'�(�� + ",'��(����������� �����������#�&�������

���������1

���������

�������������

����� �

���������

�������������

������������������������!������������ �����������

2���������������������������������������������� �������*'�(

��������������������1�� + &'�(�� + *'�(�� + ",'�(������+ "''�(

Page 51: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

�������� ��������������� ������ ��������������� ������������� ������������� ���������

2������������������������������������������������������������������������/�������"0�#�"1

�����������"���������

����������������� ���������������

3����1� + ������������� ���������������.����������*'�(����� ��������4 + ��������������������������� ������������-+ �������! �����������)������������������������ ����������������

������������������������ ��������

�������

�������� ������������������ ��������

������� �

������������������� ��������

���������������� ����� �������� ����������

#�������������������$���

2���������������� + � � ����!3�2���������������� + "�# !� % ������5�"6�!7 % !��(������*'��.��&'���(

%�������������&�' ( ��)�*#

8���������������� + '�0000�����0"5�!3

���������������� ( ��"�*#

������������������������������� ������������������������ ����� ����������&�&#*�!7 % !��

������������������ +

+����������������� ( ��,�*!-����������������������$���

+�����.�������� ��������������������������� ���������������

������������� ��������������� ����������������������������/�������"0�&�01

������������ ��� �� ��������

���������������� ���������������

� ������������

� ��

3����1�� + ��������� ����������(��� + ������������������� ������� + ,'�(�-( + ��� ��������-�����(������� + "�###�� + ����������������� ������� + &'�(

��������������������� �����

������������

������������� �����

������

�� �������������� �� ������������������

Page 52: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

������ ��������������� ������������� ������������� ����������������� ���������������

����������������� �������,'�(���������������������������������������������������/�������"0�#�"1

3����1� + ������������� ���������������.����������,'�(����� ��������4 + ��������������������������� �����������'-+ �������! �����������)������������������������ ����������������

�����������"���������

����������������� ���������������

������������������������ ��������

�������

�������������������������� ��������

���������

������������������� ��������

����������������������������������� �������������

#�����������������������

2�������������� + � � ����!3�2�������������� + "�#�!� % ������5�"6�!7 %!��(������,'��.��&'���(

%�������������� ( �"��*#

8���������������� + '�####���&#"�!3

���������������� ( �)��*#

������������������������������� ������������������������ ����� ����������& &#*�!7 % !��

������������������ +

+����������������� ( ����*!-��������� ���������������������

������������ ��� �� ��������

���������������������������)�������������������������������� �����������������*'�(����,'�(�����������������������������",9�!� %�����&&0�!� %��

��� �� ���������� � ������� ����� �� ����� ������� �� ����� ����� �������� ����������� ������� ������ ����)���������������������������� ���� �� .��� ������������������������������������������������ ����

Page 53: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

�������� ��������������� ������ ��������������� ������������� ������������� ���������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

��

������������

���������������� ������������������������������������

�������������������������������������������������� �������������������!���������������������������������� ���������������������������������������������������� �� ����������

��������������2�����"0�*�&�������!�������������������������������� �����������,'�(�:����/���������������������������0�����������������/� ����������������������������������������10�

���������������������������������������������������������������������������������������������2�����"0�*�"����������������������� �������������0�������������� ��������������10���������� ��������/��� ���"0�*�"�������������������� �������*'�(�

��������������������������������������� ������� �������������

����������)�������������������������/���������������������������������������������"0&�(��:�����'����������������������� ��������������������� ���������������,'�(�������������������������������������������������/���� ����������������� ����������������������������������������� ������,'�(�

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

����������������

�������������

����������������

�������������

Page 54: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

������ ��������������� ������������� ������������� ����������������� ���������������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

��������������������� �����������"0&�(������������������������� �������������������������������/�������"0&�(����,'�(�������������������� �������������/������&'�(����,'�(������������������2�����"0�*�0���� �������������������������������������� ��������������������� ���������,';(���������������<���������������������������������������������������������� ����������,'�(�

��������������������������������������!������������ �������������

4���� ��� ������������! ���������������"''�(������ 2�������2�����"0�*�5��������� ���������� ���������������������������������� ������������� ������������������� �������,'�(�

����������������� ����������##=��:����%����������������� ������������������������������� ����������09�(��:����3��

����������"����#��$����� ����������������

����������������

�������������

����������������

�������������

Page 55: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

�������� ��������������� ������ ��������������� ������������� ������������� ���������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

� �

4����������2�����"0�*�"����2�����"0�*�0���������� ���������������)��������������������������������� �������������*'�(����,'�(�����������������������������������������������������2�����"0�*�#������� ������������������������������10��",'�(����*'�(������/��"0&�(����,'�(�����������������������������! �������������2 ������������������������������������ ����������������������������������������������������*'�(����� ��������������� ����������00=��:����%������������� ���������������������,'�(����� ��������������� ����������##=��:����%���

����������%�����������������������

��� �� � ������� ��� ��������� ����� �������)�� ����������� ������ ���������������� ������������.������������������� ����������*'�(������������������������������������������ ������/��� ���"0�*�"�������0"5�!3������������������������������������ ���������������,'�(����������������������������������&#"�!3�

% ��4����

#�������������������$���5

���������������0"5�!3���������������������00�00=������������

��������������������

#�����������������������1

���������������&#"�!3���������������������##�##=������������

��������������������

������������ ��� ������� ������ �������� ��������� �����������������

��������

����������� ��� ������� ������ ��� ���� ���� ���� �����������������

��������

����������������

�������������

����������)�������������������������������������������������� ������������

Page 56: SpiraxSarco-B13-Condensate Removal

��������������� �������������

������ ��������������� ������������� ������������� ����������������� ���������������

���� ������ ������ ��������� ���������� ���� ����� ��� ��������� ��������� ������ ��������������������������������������������������������������������������������� ����������������������������������2�����"0�*�,��������������������������������� ���������������������)�������������������������������

���������� �������������������������������� ��������������������������

3�������*'�(����� ���������������� �����������)��#0�(��:����3������� ��������������

3�������,'�(����� ���������������� �����������)��09�(��:����3������� ��������������

����)�������������������������������������������������������������������.�/�������"0�&�51

�������������)[ ]� ���� ��� ������� ���� ��� � � �

1��������!�� �������������+�*'�(

�� + "''�.�>"�###��"''�.�*'�?

�� + "''�.�>"�###��0'�?

�� + "''�.�5,�*

6� ( "�����

1��������� �������������+�,'�(

�� + "''�.�>"�###��"''�.�,'�?

�� + "''�.�>"�###��5'�?

6� + "''�.�,&�&

�� ( �$�,��

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

��

��

����������������

�������������

Page 57: SpiraxSarco-B13-Condensate Removal

��������������� �������� �����

�������� ��������������� ������ ��������������� ������������� ������������� ���������

���

���

���

���

���

���

��

��

��

��

���� �� �� �� �� �

����������������������������������)���������������������������������������������������������������������� �������������������������������������������������������������������������� ���������������������������������������! ������������������� ���������� ������������� ��������������������� ����������������������������������������� �������������������������������2�����"0�*�*��������������������������������� ���������������������������������������! ������������������������ ������"''�(���:����7��

���2�����"0�*�*����� ���������� ������������������� �����������"''=����������� ��@������������������ �����������������"''�(��:����7�� �������������������.��������������10��������������78���3����� �������� ������ ����78� ����� ���� ��������� ���� ����0�� ��� ����9�� ���� ��������� ��������������������)���������� ����������56�(������������� �������������������������56�(���������������� ��������������������� ���

���������������� ������������� ���������&������������'����()������������*���������)������!�"+������������������

�������������

�������������������������������������������@������� ������������� ����������������������� ���������������������������������������������������������� ����)������������ �������

����������������������� ����)���������������������������������������������

A��������������� + #50�!� %�������������� �������*'�(

������ ������������������ + #�&������

(������������! ������� + '������������� ����� ��������

���� ����������� ������� + #�&������������������������

��������������� + ",9�!� %��������������� ������*'�(

��������������� + &&5�!� %��������������� ������,'�(

-���������� ���������������� + '����

1�:���������������� ������:���������������������������������!����� ��� ���������.��!������������: ��������4��������$��5;�� ������� ������������.����������������#50�!� %�����#�&��������������� ��������� ������� ������������������������������&&5�!� %���������,'�(����� ���

Page 58: SpiraxSarco-B13-Condensate Removal

��������������� ���������������

������ ��������������� ������������� ������������� ����������������� ���������������

���������������������������������������������������������������������������������������� �����������������������������������������������! �������������������� ������������������������� ������������������������������������������������ �4��������������� �������������������������������������� �������������������� ������������������������

�������������������)������������������������������������������������������������� ���������������������������������� ������������������������� ���� ���������������������&&5�!� %����������������������������������������������������������������)����������!���������������������������������������������������)��)���2�����"0�*�9��

�����������������2�����"0�*�6��������-B&#��"C��2�"'."'��������������������� �����������������������������8���)����������� ��������������������5���������������)��������� �������� ������������������

��5������������������������)��������� ������������������������������ ���������������� ������D��������2�����"0�*�9�

2������� �� ��������/��� ���"0�*�"���������)���������������������&''���������������������������2�����"0�*�"'��������-B5'��"<C��2�"'."'��������������������� ����������������

����������,�����������-��������������������������

����������������������! ����������)������������������������� ����� ������������ ���� ����������������������� ���%����� ���������������������������������������<����������������������������-� ������ ��������������������! ������������������������)����������������<����������� ������� ��������������������������������������������

E���������������������������������������������� ������������ ��������������������������������������� �������������������� �� .��� �����������������������������������������������������������������������������������������������������������������

������������

������

����

�����������������

��

���������

��

�.�%�'�/*���������"������

�."��'�0/*�������������������

������������ ������

�������

Page 59: SpiraxSarco-B13-Condensate Removal

��������������� �������� �������

�������� ��������������� ������ ��������������� ������������� ������������� ���������

����������+

��� ��� ��� ��� � � � � � �� ����

��

��

��

���

���

���

���

���

����

����

������

� ��������

������

� ��������

�����

���������

� ��������

�����

���������

� ��������

������ ��

�������

���������

����� ��

�������

��� ���������

��� !""�����!����������#���$

������������ #%&'���$#'�������� $

�������!������ #(&)���$

*)(#+,$��+'�+%���������!�-��(&)�����

.��!������ ('/�� �

�������� ))'�� �

Page 60: SpiraxSarco-B13-Condensate Removal

��������������� ���������������

������ ��������������� ������������� ������������� ����������������� ���������������

�����

�����

�����

�����

���

���

���

���

���

��

�����

��� ��� ��� ��� ��� ��� �����

������ ���������

������� ��������

�������� ���������

������ ��������

������ ����������������� ����������

������� ������������������ ��������

������� ��������

���

������������

��� ���������

!""�����!����������#���&�&$

0��!������� )%%�������������

*'%#+�,$��+'�+%�����!�-

�������� ))'�� �

Page 61: SpiraxSarco-B13-Condensate Removal

��������������� �������� �������

�������� ��������������� ������ ��������������� ������������� ������������� ���������

���������

�� �������� ��������������������������������

�F �������������������������� �

�F �������������� ��������������� �

�F ������������ ������������ ���������������������� �

F ���������������� ��������������� �

�� �������� ���������������������������������������� ���� ��

�F �������������������� ������� �

�F �������������������������� �

�F ���������������������� ������� �

F ���������� ����������������������! ������� �

�� ����4��������$����������������������������������������������������� ��� ��:���������.������� ��� ����!������=����������

�F "''�( �

�F ""'�( �

�F "&'�( �

F 9'�( �

)� ����4��������$�����������������������������������������������:�������������� ��$�=�����������.�����������

�F G��������������� �

�F �������������� ���������������� �

�F B� �

F G��������������������������������*'= �

"� ��������4��������$������������������ �� ���������)���������������:������� 4��������������� ��� ������������������� ��� �� ����������������

�F ,,�( �

�F 5#�( �

�F ##�( �

F *,�( �

�� ��������4��������$������������������ �� ���������)���������������:������� 4��������������� ��� ������������������� ��� �� ����������

�F &9�( �

�F 09�( �

�F 59�( �

F #9�( �

�������������������������������� �����

Page 62: SpiraxSarco-B13-Condensate Removal

��������������� ���������������

������ ��������������� ������������� ������������� ����������������� ���������������

Page 63: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

�������� ��������������� �������� ���������������������� ���������

���������������������� ������������������

Page 64: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

�������� ���������������������� ����������������� ���������������

������������� �������������������

����������������� ���������������������� �������������� ����������������������������� ��������� ����������������

�� ��� ������������� ���� �������������������������� �� �������������� ���� ���� �������������������������� ������� ������������ ��������������������� ���

�� ����������������� ���� ��������������������������������������������� ���� ������� ���������� ������������� ����������������������������������� ���

�� ��� ������� ���� �������������������������������������� �������������� ���� ��������������������������������� ��� ���� ������������������� ��������������������

�������������� ������������ �

������������������� ���� ��� �������������� ��� ������� ������ � �������� ��������� ����� ���� ������������� ����� ���� ����������������������������������� ��������

������� ������������������������������������ ���������������������������� ������������� �������������� ���� ������� ������������ ������������� ��������������� �����������!���������������������"�� ������� ��������� ������ ���������������������� ����������������������������� ���������

��� ��� ������ ��� ��������������������������

� ���������� ���� ���������������������������������������������#����� ����� ������� �������

� ����� ����������������������������� ���������������������������#����� ������������������������������������������ ����������������� �$����������������������������������� ���������������������%�&���'�����������������������(������ �������� ��������������������������������� �� �� �������������������������������

����������������� ������������������������� ���������������� �����

�����������

���� �

���������

����������������

������������� �

���������

����������������

������� �������� �������������

��� �������������������� !����"��

���������

�����

Page 65: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

�������� ��������������� �������� ���������������������� ���������

���������������������� �������� ������������������������ �������� �������������������������������� ��� ������������������������������������ �� ���� �������) �������������������� ��������#���� �������� ������������������������ �������������������������� ���

*������ ���������������������� ���� ������ ������������� ���� ����������������� ������������������������������� ���������������������������� ����� ����������#���� ������� ��������� ���������������������������������������#����� �

���������������������� ���������������������������������������������������� ���� �$������������#���� ��� ��������������+������������������������������������������������'���������,���-�� �����������������������+�����������������������'&%���������������#���� �������������������

��� �� � ���������������������������� ��� ����� ��������������� �$�� ����������������������������� ����������������������#����� �������

������������������������������� ���������������� �����

�����������

���� ����������

����������������

������������� �

���������

� �����������������������"!������������ � ������

������� �������� �������������

��� ���������� � ��

����������� !����"��

�������� ������ ������ ��������������

#�� � ����������

�������

���������

� � ����"!����

Page 66: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

�������� ���������������������� ����������������� ���������������

�����������

������������������������� ��� ����� ���� ����� ��� ������� ���������� ����� ������ ���� �� ������ � � �� � ���� ���� � ���� ����� ��� ������� ��� �� ��������������� � ���

������ �� ����!������� �� ������������������ ���������������������� ������ ����� �� ����� ��� ����� � ��� ��������� �� ��������� ��� ��� ����� � ������� �� �����#����� ���������������������������������#�������'�&�.*�!�������/ &%%��� ) ���������"�

����������� ���� ��������� ����������������������������������������������������� ���� �������������� �������������� ���� �������������������������������� �

���� ����� ��� �� ���������� � ���� ����� ��� ������ �� ������ �� ��#���� �� ������ ��������������������������� ���� ������������������ ��������� ��������������������������� ����������������������� ���� ���������� �������������� ���� �������������������� ���������������������������� ������������������������������������ ���

��������������� ��� ���������������������� �� �����������(�� ��#������������������������� ����������0%���� �� ��

������������� ����������!��!������������!��� ���������������� �����

�����������

���� �

��������

���������������

������������ �

���������

$���������������

%���� ��� �

�������� ����� ��� �������������

����&�������� �����

'�����

�����

Page 67: SpiraxSarco-B13-Condensate Removal

��������������� �������� ������

�������� ��������������� �������� ���������������������� ���������

����������"��#��!$��!��� ���������������� �����

������ �� "��� ��������#�����������!�#���������������� ���������������$��������������������� ���/�"��������������� �������� ��������������#����� ��� ������������������������������������������������ ����#���������

����������#����� ������� ��������������� ��� ������ ��������������������������������� ���#������������ ���� �� �������� ���� ����� �� ������ ����� ���� ������� ���� ��������� ��������������������������� ��� ������������������������������������������������ ���� ���������������������������

������ �� "��� �#����� ����!�#���������������� ���������������%���������� ����� ������������������������������� ��������������#����� �����$���������������� ���� ��������� ���������������������������� ������������ ��� �������������������������� ���� ��������������� �������������� ���� �������������������������������� �

������������������������ �������������������� �� ���������������������������� ��������������������������

����1�� �#�1� ���2�'0��������������� � ��� ����������� ������������������������������������������������������#����� �����������������������������������'�&�.*�

�������������������������������������������� �������������/&��������������������� �������������0%������������ ����������

����������������������������3��� ��'4�5�0�

����������%��#��!$��!��� ���������������� �����

��

����������

���� �

���������������

��������

������������ �

$��������� ��

���

� ���� � �����&���

������

�������

#����� ����������

���������������

����������

���� �

����������������

�������

$��������� ��

���

� ���� � �����&���

������

�������

#����� ����������

�������

����������

������������ �

�������

�������

����������

Page 68: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

�������� ���������������������� ����������������� ���������������

������������������� ���� ��� ��� ����� ���� ���� ��������������������� � ������� ����� ������� ���� ������������� ����� ���� �������������������������� ��������

����&�������� �#������� ��������������������� ���������������� ���������������'������������ �$�� �������� ��� ���� �� ������� ��������������4�� ����#��� ����� ��������� �� ���� ����� ���� ���������� ������������� �� ����������#����� � ����������� �������� ���� ��!�����������������'��� ��"��������� ���� ���� ��������������������������������������������� ���� ������������#����� ������������� ������ ���� ��

������������������������ �������� ��������������������������������)�� ������ ������ ���� ��$��������������� ����������� �������������������������� ���� ���������������������� ����������$����� ��������

6�������������������������������������������������������������������������������� ������������������

����������&�� �����������!��������$������������!�������������

����������'�� �����������!��������$� ���������������������

��

����������

���� ��������

���������

��������

������������ �

$��������� ������

� ���� � �����&���

������

�������

��������������

��

�����������

���� �

���������������

$��������� ������

� ���� � �����&���

������

�������

��������

# �����

����&�������� ������������������������ �������������� ���������������(�7������� � ������ ��� ��������� ����� �� ��������� ������ �� ���� �������� � ��� ����� ������������������������������ ���������� ���� �������������������� ��� �������������������

8���� �������� �����!������������������"����� ������������������#����� ������� ���������������������� ���������������������������������������������������� ��������9���������������������������� ������

� ����������������������� ���������� ��������

� ����������#����� ����������������������������������������� ������

� ������������� ����������������� ��� �������������� ����������������������

�������

������������ �

��������������

�������

Page 69: SpiraxSarco-B13-Condensate Removal

��������������� �������� �����

�������� ��������������� �������� ���������������������� ���������

�!���������������������� ��� ������� ��� "����� ����)�������� ��� ���� ����������������������������������������������������� ��������� �����������������#�����������������������������*������������������� ���� ������������������������������#����� ������� ����������������������������� ���� ������� ������������������������� ���������������� ������������ ���� ��� ��������������� ����������� ���������������������#����� ������ ����������� ����������������������������� �$�� �������� ��� ����������������� �������� ��� ���� ������� ������ ������

� �� , ) ��-� �� �� ������� ��� ���������� ��� �� ��� ������ ������ ������ ��� �� � ������ ����� ��� �������������� ���������������������������������������������������������������������������������������� ��������������������������������� �������������������� � � ����� ����� ��� �� ���� �$�� ���� 1����� ���� ��� ������ ������� ��� ��� ��� ����� ���� ������������� ����,-� ����� ��� ��������� ��� ������������������ ����� ����� �$�� ��������� ��������� ��� �������������������� ��� ������������������ �� ������������

� �������������� ��������������� ���� ���������� ��� ���������������� ������������������ �������������������#����� ������������� ������ ������������ ����������

� ��������� ���������������� ���������������������������������� �������� ���� �������������� ����������������������������������������������������������������������� ��������������� ������������������ ��� ����������� ���������������������� ����� ���������������������#����� ����������� ���

:)����� ����� ������������������� �,����-� �,�����-������������#������� ����������������������� ������������������ � ���������������� ���������� ���������� ���� �������������� ������������������ ���!���������� ������������ ������� �"������ ������ ����� ����� ��� �� ��� ����� ���� � ���� ����� �#�� ������ ����� ��������� �������� ����� � ��#������������������� ������������� ������������������������� ������������#����� �

Page 70: SpiraxSarco-B13-Condensate Removal

��������������� ��������������

�������� ���������������������� ����������������� ���������������

����������������������������������������� ���� �������#�������$������������ ����������������������������������������������������������� ������������ ������������ ���� ���� �����

������ ���������������������������������� ��������� ����������������������������������������������������������� �������

� 1������

� 7�������������

� 7������

)��� ����*��������� �����������.������ �������������������� ���������������������������������� ���$�������������������������� �� ������������ ���������������������������#���������3��� ��'4�5�5������������������������������������������������2�'0��������������� ���

�������������(�����������������������!��!$��!��� �!���� ������ �����

��������������� ����������������������������������#�������������������������������+������������� � ������$������������������������������������������������������ ��������� ���������������������

�����.����������������������������������� ���� ����#�� ����������� ���������������� ���� �

� ����������� ��� ������ ����������������

� ����� �������������#�����

� ���������������������� ��������

� ����������������� �� �� ��������

�������� (� �������

�������� (� �� ���

�������� ���

������������

"�����

��� ��

������� ����������

��� �)*

'�����+,-

#$-".#����� ���������

��������� ������������������������������������������

�� ��������� /����������� ���������������� �

%���������������� �� �� ������������"�� ��� ������������������������0������� ��������� ����������#$-� ���

� � ���� ������ ������ 1������������������

Page 71: SpiraxSarco-B13-Condensate Removal

��������������� �������� �����

�������� ��������������� �������� ���������������������� ���������

�������

�� +�����!�����!��#�������� ��������� ������� �����������!!��� �!� ����,

�; 2 ������������� ��������������������������� ������������ � �

�; .����������������������� ���� ������������������������ ���� � �

�; ��� ���������� �������������������������� �� �

�; �������������� �

�� +���� ����������������������������!� �������� ����-�#�����!�����!��#������� �� ���������� ������������ �� ����� �������������#���� ������ �� ���,

�; �������������#���� ��������� �� �

�; < ���������������������������� � �

�; < ������������������������� ������ ���������� ��� ���� � �

�; =����������������� ������������������� ���� ����� �������������� �

�� +�����!�����!��#���!���� �� � ��������������������� �� "��� ,

�; 7���������� �

�; 3���������������� �� �

�; 2 ���� ����� ������� �

�; �������������� �

%� +��� ������� � ������ �� -� �������� ������ ������������������ ����� ����� ����,

�; ��������������#����� ����� ������� ���� ���������� ���� ������������ ���� � �

�; ���� ���������#����� ����� ������� ���� ���������� ���� ������������ ���� � �

�; ���������� ���� ������������ ������������������ �������� �� ����� �

�; �������������� �

$� +����� ��������������!� �������������������������������� ������������,

�; �������� ���������� ���� �������������� ��� ���������������������� �

�; �������������������������������������� �������������������� �

�; �������������� ������ ��������������� ��� �

�; 1��������� ������� ��� ����������������� ���� � �

'� +��� �����.!!������������ ����������������� �#��������� �������!������ �������#��� �����!�# �������������������������,

�; 2 ���������������� ������� �������������������� ������������������������� �

�; =������������������������������������������ ����� �

�; :)����� ���������� �������������� ���������� ��� � �

�; �������������� �

���������������������������� ��� ��� ��

Page 72: SpiraxSarco-B13-Condensate Removal

��������������� ���������������

�������� ���������������������� ����������������� ���������������