FRIEDRICH

Service & Parts Manual - 2012

PortableAirConditioner Models PH14B

Portable Air Conditioner-2012 Svc-Parts (01/2012)

Important points on service, and flow chart for inspecting and repairing the unit ...............2 Troubleshooting .............................................2 Appearance and unit dimensional...................3 Operation .................................................... 4-5 Technical specifications.............................. 6 Refrigerator system and schematic wiring diagrams ........................................................ 7 Exploded view and Parts Lists ....................8-10

98081402 00

Only a qualified professional should perform any repair service(s).

When replacing any electrical components they should be OEM factory components.Be sure that any electrical components are properly wired and secured.

POWER BREAKER/FUSE TRIPPED

SUPPLY CORD NOT PLUGGED IN OR IS LOOSE IN POWER RECEPTACLE

REPLACE SUPPLY CORD IF RESETTING DOES NOT CORRECT

UNIT'S POWER CORD TRIPPED

3 MINUTE TIME DELAY IS ACTIVATED

ELECTRICAL COMPONENT COMPR ISED

RE-TEST UNIT

TROUBLESHOOTING THE SEALED SYSTEM COMPONENTS

TEMPERATURE SETTING IS NOT BELOW ROOM TEMPERATURE

SET TEMPERATURE SETTING ABOVE (HEATING MODE) OR BELOW (COOLING MODE) ROOM TEMPERATURE

REPAIR OR REPLACED ALL COMPROMISED SEALED SYSTEM COMPONENTS

WEIGH IN UNIT'S SPECIFIC REFRIGERANT CHARGE

TROUBLESHOOT ELECTRICAL COMPONENTS AND REPAIR OR REPLACE

PLUG IN SECURELY THE SUPPLY CORD

RESET SUPPLY CORD'S LCDI

WAIT FOR THREE MINUTES

FLOW CHART FOR TROUBLESHOOTING OF THE UNIT

---2---

Conditioned Supply Air Louvers

Continuous Drain Pump Outlet

Static WaterDrain Outlet

Return Air Grille

Room Air Filter

Outside Air Inlet

Exhaust Air Outlet

Power Supply CordWheel Casters

19.50 inches

33.6

inch

es

15.5 inches

---3---

less than 80 F.60 F

unit

60 F - 90 F.

75 degrees F

unit

turn unit ON

Timer Setting

exhaust hoses

two

air exchange hoses left vented to the outsidearea will provide some cooling.

Timer (12 Hour Timer - 1 setting On or Off)

to the outside.

80 F

---4---

OFF

3 feet

---5---

inches

PH14B

19.5 x 33.6 x 15.5

3.8 pints/H

207

115/60

115/60volts/hz

volts/hz

volts/hz

inches .086 OD x .039 ID x 27.5 in

115/60

115/60

27.5 ounces

80

oz

lbs

volts/hz

140 sq ft - 204 sq ft

115/60

ft

P

---6---

---7---

Accessory Items

---8---

PARTS LIST PH14B

NO PART# PARTS NAME QUANTITY1 67904000 BASEPAN 12 67904001 CASTERS (WHEELS) 43 67904002 DRAIN PLUG 14 67900404 DRAIN BUCKET COVER-B 15 67904100 MICRO SWITCH 37 67900405 FLOAT 18 67900406 FLOAT 19 67904300 PUMP FAN MOTOR 1

10 67900409 PUMP FAN WHEEL 111 67900410 PUMP HOUSING 119 67904301 4-WAY REVERSING VALVE ASS'Y 126 67904017 CONDENSER BLOWER HOUSING 127 67904018 CONDENSER BLOWER WHEEL 128 67904020 CONDENSER SHROUD 129 67904302 CONDENSER MOTOR 130 67904303 TERMINAL BLOCK 131 67904067 CAPACITOR (55uF/300V)(FOR COMPRESSOR (12) 132 67904021 CAPACITOR (9uF/250V)(FOR FAN MOTOR (29) 133 67904033 CONTROL BOARD HOUSING 134 67904305 CONTROL BOARD 135 67904031 COVER 136 67904023 TOP PLATE FOR EVAPORTATOR ASSLY 138 67904027 EVAPORATOR MOTOR 139 67904025 EVAPORATOR BLOWER HOUSING 141 67904028 EVAPORATOR SHROUD 142 67904304 EVAPORATOR BLOWER WHEEL 143 67904030 CAPACITOR (8uF/250V)(FOR FAN MOTOR (38) 144 67904078 POWER SUPPLY CORD COMPLETE 145 67904036 FRONT PANEL 146 67904306 REAR PANEL 147 67904039 AIR FILTER 148 67904037 HANDLE 249 67904040 SUPPLY AIR LOUVER CONNECTOR 150 67904041 SUPPLY AIR LOUVERS 5

---9---

PARTS LIST PH14B

NO PART# PARTS NAME QUANTITY51 67904307 PC DISPLAY BOARD 152 67904046 DISPLAY BOARD MOUNTING PLATE 153 67904308 DISPLAY BOARD OVERLAY 154 67904042 COVER 155 67904043 DISCHARGE GRILLE 159 67904310 INDOOR AIR SENSOR 160 67904175 FIXTURE SUPPORT 161 67904311 FREEZE PROTECTION SENSOR 162 67904034 FIXTURE SUPPORT 163 67904053 EXHAUST & INTAKE HOUSES 264 67904054 EXHAUST & INTAKE AIRE HOSE CONNECTOR 465 67904055 FIXTURE 266 67904056 COVER 268 67904058 EXHAUST & INTAKE FIXTURE PLATE 169 67904059 EXTENSION FILLER PLATE 170 67904309 REMOTE CONTROL ASS'Y 171 67904312 CONNECTOR 172 67904313 DRAIN PIPE 175 67904101 DRAIN PUMP 176 67904102 QUICK CONNECTOR 177 67904107 FIXTURE 178 67904103 PUSH BUTTON SWITCH 1

---10---