McQuay Reciprocating Chiller - Daikin Appliedsalesportal.daikinapplied.com/bizlit/DocumentStorage/AirCooled...McQuay Reciprocating Chiller ALR 010-205 ... 37, 38 Components 060C 39,

Replacement Parts List No. 057114900Revision Z 10/2016

McQuay

Reciprocating ChillerALR

010-205Vintage C

Last Manufactured: 1995

To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.DaikinApplied.com

Reciprocating Chiller: ALR 010 - 205 Vint. C Rev. Z 10/2016 RPL 571149 Page 2

Page(s) Heading Description2, 3 Contents4 Parts List Revision History

5-7 Nomenclature Serial Number, Stock & Unit Model Number

8-23 Compressor8 Information Arrangements, Power

Factor Correction Capacitors

9 Components Unloaders, Motor Protectors, Oil Equalization Kits

10 Unit Compressors 010C - 018C11 Unit Compressors 022C - 025C12 Unit Compressors 030C - 035C13 Unit Compressors 040C - 060C14 Unit Compressors 065C - 075C15 Unit Compressors 085C - 095C16 Unit Compressors 105C17 Unit Compressors 115C18 Unit Compressors 125C19 Unit Compressors 145C20 Unit Compressors 155C21 Unit Compressors 175C22 Unit Compressors 195C, 205C23 Mounting

ComponentsAll Sizes

24 - 26 Control & Power Panel24 Diagram 010C - 018C

25, 26 Components 010C - 018C27 - 66 Power Panel

27 Diagram 022C - 035C28, 29 Components 022C-030C30, 31 Components 035C

32 Diagram 040C - 095C33, 34 Components 040C35, 36 Components 050C37, 38 Components 060C39, 40 Components 065C41, 42 Components 075C43, 44 Components 085C45, 46 Components 095C

47 Diagram 105C - 205C

Page(s) Heading Description Control & Power Panel (Continued)

48, 49 Components 105C50, 51 Components 115C52, 53 Components 125C54 - 56 Components 145C57 - 59 Components 155C60 - 62 Components 175C63 - 65 Components 195C/205C

66 Components On/Off Switch, Alarm Bell, Signal Converter Compo-nents

67 - 80 Control Panel67 Volt/Amp

MeterComplete Assembly and Components 040C-205C

68 Diagram Electromechanical Panel 022C - 035C

69 Components Electromechanical Panel 022C - 035C

70 Diagram Electromechanical Panel 040C - 095C, Left Side

71 Components Electromechanical Panel 040C - 095C, Left Side

72 Diagram Electromechanical Panel 040C - 095C, Right Side

73, 74 Components Electromechanical Panel 040C - 095C, Right Side

75 Diagram Electromechanical Panel 105C - 205C, Left Side

76 Components Electromechanical Panel 105C - 205C, Left Side

77 Diagram Electromechanical Panel 105C - 205C, Right Side

78, 79 Components Electromechanical Panel 105C - 205C, Right Side

80 Main Capacity Controller

Electromechanical Panel 040C - 205C, Barber Colman Controller CP1


Electromechanical Panel 022C - 205C, Honeywell Controller W7100


Electromechanical Panel 022C - 205C, Johnson Controls Controller UNT

83 Diagram MicroTech Panel 040C - 095C, Left Side

84 Components MicroTech Panel 040C - 095C, Left Side

Contents


Page(s) Heading DescriptionControl Panel (Continued)

85 Diagram MicroTech Panel 040C - 095C, Right Side

86 Components MicroTech Panel 040C - 095C, Right Side

87 Components MicroTech Panel 040C - 095C, Key-pad, Start Counters, Hour Meters

88 Diagram MicroTech Panel 105C - 205C, Left Side

89 Components MicroTech Panel 105C - 205C, Left Side

90 Diagram MicroTech Panel 105C - 205C, Right Side

91 Components MicroTech Panel 105C - 205C, Right Side

92 Components MicroTech Panel 105D - 205C, Key-pad, Start Counters, Hour Meters

93 Cables, Sensors, Wells

MicroTech Panel, 040C - 205C

94 Gauges94 Components All Sizes

95 - 97 Condenser Fan Section95 Diagram 010C - 018C96 Components 010C - 018C97 Diagram 022C - 205C97 Components 022C - 205C

98 - 103 Cabinet98 Components 010C - 018C99 Components 022C - 035C100 Components 040C - 105C101 Coil Guards 040C - 105C102 Components 115C - 205C103 Coil Guards 115C - 205C

Contents

Page(s) Heading Description104 - 116 Piping Components

104 Basic Information Circuiting Diagrams and Notes

105 Components 010C - 015C106 Components 018C - 022C107 Components 025C - 030C108 Components 035C109 Components 040C - 050C110 Components 060C111 Components 065C - 075C112 Components 085C - 095C113 Components 105C - 115C114 Components 125C - 145C115 Components 155C116 Components 175C - 205C

117 - 120 Evaporator117 Complete

AssembliesAll Sizes

118 Diagram 040C - 195C119 Components 040C - 195C120 Plate Exchangers Insulation,

Thermostat, Heaters121 - 124 Condenser

121 Condenser Coils All Sizes- Part Numbers and Locations

122 Desuperheater Complete Assy123 Water-Cooled

VesselsAll Sizes- Heat Recovery

124 Water-Cooled Vessels

All Sizes- Heat Recovery Components

125 Vibration Isolators125 Part Numbers,

LocationsAll Sizes

126 Stock Units126 Nomenclature 018C - 095C126 Kits, Accessories

127-136 Critical Parts List127 Critical Parts List 010 - 018C

128 - 129 Critical Parts List 022 - 035C130 - 132 Critical Parts List 040 - 095C133 - 136 Critical Parts List 105 - 205C


A - W Revision History 1997-2007 Archived. X 07/15 Update format from txt to indd. All pages re-created. Page 6-7: Add Model Code to Nomenclature. CPL1-10: Add Critical Parts List. Y 07/15 Pages 28-30: Corrected description for Ref #8 to M5, was M1. Page 32: Added bubble 104. Page 33,35,37,39,41,43,45: Corrected Ref #106 to be Qty=1 for all voltages. Page 47: Added bubble 104. Page 48,50,52,54,57,60,63: Corrected Ref #106 to be Qty=1 for all voltages. Page 71, 76: Added Ref. #28 Terminal Block. Page 84, 89: Corrected Ref #902 MCB1, was 065487311. Added quantity to Ref #260 & 906. Page 91: Added quantity to Ref #260 & 325. Page 95: Corrected Ref # for Nut to 727, was 717. Page 99: Added info to description for Ref #889 Latch and Ref #895 Door Latch Handle. Page 100: Added info to description for Ref #889 Latch and Ref #895 Door Latch Handle. Added Ref #876 Support. Page 102: Added info to description for Ref #889 Latch and Ref #895 Door Latch Handle. Added Ref #887 Panel. Page 118: Corrected bubble number to 353, was 355. Z 10/2016 Page 111: Corrected part # for 075C Expansion Valve, was 030569201.

Rev. Date Description

Parts List Revision History

Daikin Applied, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330


Nomenclature

Serial Number Until 19945 ZA 12345 00

Factory5= Staunton,VA

Serial Number

Engineering Revision

Year and Month of Manufacture: Year MonthS= 1987 A= JanT= 1988 B= Feb.U= 1989 C= Mar V= 1990 D= Apr.W= 1991 E= MayX= 1992 F= JunY= 1993 G= JulZ= 1994 H= Aug J= Sep. K= Oct. L= Nov. M= Dec.

ALR 040 CUnit Model Number

Unit Type: ALR= Air- Cooled Accessible Hermetic Compressor Chiller

Nominal Tonnageex. 040 = 40 Tons

Vintage

Stock Unit Model Number

ALR 040 C 12

Vintage

Nominal Tonnageex. 040 = 40 Tons

Unit Type: ALR= Air- Cooled Accessible Hermetic Compressor Chiller

Voltage12 = 208/230V27 = 460V42 = 208/230V

Serial Number1995- Current5 5A 12345 00

Factory5= Staunton,VA

Serial Number

Year and Month of Manufacture: Year Month5= 1995 A= Jan. G= Jul6= 1996 B= Feb. H= Aug7= 1997 C= Mar. J= Sep. D= Apr. K= Oct. E= May L= Nov. F= Jun M= Dec.

Engineering Revision


Nomenclature

Code 01= Unit TypeALR= Air Cooled Water Chiller (Reciprocating Chiller)

Code 02= Unit Size/Vintage010C= 10 Tons Nominal015C= 15 Tons Nominal018C= 18 Tons Nominal022C= 22 Tons Nominal025C= 25 Tons Nominal030C= 30 Tons Nominal035C= 35 Tons Nominal040C= 40 Tons Nominal050C= 50 Tons Nominal060C= 60 Tons Nominal065C= 65 Tons Nominal075C= 75 Tons Nominal085C= 85 Tons Nominal095C= 95 Tons Nominal105C= 105 Tons Nominal115C= 115 Tons Nominal125C= 125 Tons Nominal145C= 145 Tons Nominal155C= 155 Tons Nominal175C= 175 Tons Nominal195C= 195 Tons Nominal

Code 03= Unit Arrangement1= Water Condenser Circuit # 12= Water Condenser Circuit # 23= Water Condenser Circuits # 1 & 2Y= None

Code 04= Electric Power Supply- Voltage12= 208/60/3 28= 380/50/327= 460/60/3 44= 415/50/329= 230/60/3 37= 575/60/342= 208-230/60/3

Code 05= Starting OptionAL= Across LinePW= Part Winding

Code 06= Power ConnectionD= Disconnect SwitchP= Power BlockM= Multipoint

Code 07= Compressor Circuit ProtectionC= Circuit BreakersY= None

Code 08= Capacity Control01= 1 Step Capacity Control02= 2 Step Capacity Control03= 3 Step Capacity Control04= 4 Step Capacity Control06= 6 Step Capacity Control08= 8 Step Capacity Control

Code 09= Hot Gas Bypass1= Capacity Control Circuit # 12= Capacity Control Circuits # 1 & 2 (with lead lag)Y= None

Code 10= Control Circuit TransformerA= With TransformerY= None

Code 11= Control Thermostat1 A 1

Degree of Reset 1= 10 Degrees 5= 30 Degrees 2= 15 Degrees 6= 35 Degrees 3= 20 Degrees 7= 40 Degrees 4= 25 Degrees 8= 45 Degrees Y= None

Type of Reset A= Outside Air

R= Return Air Y= None

Type of Control 1= Standard 2= Low Temperature 8= Non-Wired for W7100G 9= Leaving Water- W7100G C= Non-Wired for System 350 D= System 350 with out Display E= System 350 with Display M= MicroTech Controller Y= None

Code 12= Phase/Voltage FailureP= With phase, Under voltage monitor controlV= With phase, Under/Over voltage monitor controlD= With phase, Under/Over voltage monitor control w/LEDY= None

Code 13= High Return Water/High Ambient UnloaderR= With High Return UnloaderA= With High Ambient UnloaderB= Both R & AL= Low Water Temp CutoutY= None

Code 14= GaugesA= Suction, Discharge and Oil Pressure GuagesY= None

Code 15= Heat Recovery Desuperheaters1= Desuperheater Circuit # 1 2= Desuperheater Circuit # 23= Desuperheater Circuits # 1 & 2Y= None

ALR 010C 3 12 AL D C 01 1 A DA1 P R A 1 S1 A F 11 1 A TCode 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21 22

Model Number


Nomenclature

Code 16= EvaporatorsS1= Standard- Copper Plate Type

Code 17= Protective GuardA= Base Frame Guard (Compressors & Horizontal Coil)C= Base Frame Guard (Compressors only)F= Condenser Coil Fin Guard- LargeG= Condenser Coil Fin Guard- SmallY= None

Code 18= Head Pressure ControlF= FantrolL= Fantrol with low ambient start (Std. for MicroTech)S= Speedtrol with low ambient start

Code 19= Condenser Coil11= Aluminum Fin Material/Copper Tube21= Copper Fin Material/Copper Tube

Code 20= Condenser Fan Motors1= Open Housing with Cooling Vents2= Totally Enclosed

Code 21= Indicator PackageA= Cycle Counter & Hour Meter for each CompressorB= Indicator Light PackageC= Both A & BY= None

Code 22= Expansion ValveT= Thermostatic E= Electronic w/o MicroTechM= Electronic with MicroTech

Code 23= Warranty

Code 24= Approval Listing

Code 25= Packaging

Code 26= MicroTech OptionsE M A

Sensor Option A= Water & Air Temp Sensor Option B= Refrigerant Temp Sensor Option C= A + B options D= Unit Amps Package E= A + B + C options Y= None

Modem M= Modem

Y= None

Unit of Measure M= Metric E= English Y= None

Nomenclature

Model Number- Continued


CompressorArrangements

Compressor Chart Abbreviations

ALR 105- 205C - Top View

Control Box

Compressor # 1

Compressor # 3

Compressor # 2

Compressor # 4

ALR 040- 095C - Top View

Control Box

Compressor # 2

Compressor # 1

ALR 010- 035C

One Compressor Units

Power FactorCorrection Capacitors

20 HP Compressor1.0 KVAR- 208/230V Units -------- 0479385342.5 KVAR- 460V AL Units ---------- 04793851625 HP Compressor1.0 KVAR- 208/230V Units -------- 0479385342.0 KVAR- 460V PW Units -------- 0479385153.0 KVAR- 460V AL Units ---------- 04793851730/35 HP Compressor3.0 KVAR- 460V PW Units -------- 0479385176.0 KVAR- 460V AL Units ---------- 04793852040 HP Compressor5.0 KVAR- 208/230V Units -------- 0479385055.0 KVAR- 460V PW Units -------- 04793851910.0 KVAR- 460V AL Units -------- 04793852350 HP Compressor10.0 KVAR- 208/230V Units------- 04793850910.0 KVAR- 460V ------------------- 04793852360 HP Compressor7.5 KVAR- 460V --------------------- 047938521

AL = Across-the-Line Start Option

PW = Part Winding Start Option

Cap. Ctl. = Capacity Control

# OF UL = Banks of Unloading

Compressor # 1


CompressorsComponents and Accessories

040C - 205C

UnloadersComplete KitTo Add to a New Replacement CompressorKit includes: Cylinder Head, Piston Ass'y, Valve Plate, Gaskets, and Unloader Valve and Coil. p/n: 046745201To Replace an Unloader on an Existing CompressorKit includes: Unloader Valve , Coil and Valve Gasket. p/n: SG9980212-02

Coils120VFor 4D and 6D Compressors. p/n: 027677200

Crankcase Heaters120V100W- Used on 20 - 35 H.P. Compressors p/n: 735041245120V200W- Used on 40 - 60 H.P. Compressors p/n: 049767901

Motor Protectors120VUsed on all Compressors p/n: 044691500

Oil Equalization -applies to ALR 105C - ALR 205C All Units manufactured after November, 1987 (5SLXXXXX) were manufactured with oil equalization lines between the parallel piped compressors. If a unit built prior to that date requires retrofit, the following kit is available: Kit p/n. 350011801

Flange Assembly for Oil Equalization p/n: 049122701

300 PSI Relief ValveAll Sizes p/n: 735045850


UnitVoltage

StepsCap Ctl

Part Number

# OfUL

208 1 049264001 0

208 2 049264002 0

230 1 049264001 0

230 2 049264002 0

460 1 049264003 0

460 2 049264004 0

380/415 1 049264003 0

380/415 2 049264004 0

575 1 049264005 0

575 2 049264006 0

ALR 010C CompressorsCompressor # 1HP= 10

UnitVoltage

StepsCap Ctl

Part Number

# OfUL

208 1 049264007 0

208 2 049264008 0

230 1 049264007 0

230 2 049264008 0

460 1 049264009 0

460 2 049264010 0

380/415 1 049264009 0

380/415 2 049264010 0

575 1 049264011 0

575 2 049264012 0


UnitVoltage

StepsCap Ctl

Part Number

# OfUL

208 1 049264013 0

208 2 049264014 0

230 1 049264013 0

230 2 049264014 0

460 1 049264015 0

460 2 049264016 0

380/415 1 049264015 0

380/415 2 049264016 0

575 1 049264017 0

575 2 049264018 0


Compressors ALR 010, 015, 018C


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 2 AL 049267100 0

208 2 PW 049267100 0

230 2 AL 049267100 0

230 2 PW 049267100 0

460 2 AL 049267100 0

460 2 PW 049268600 0

380/415 2 AL 049267100 0

380/415 2 PW 049268600 0

575 2 AL 047131100 0

575 2 PW 047131100 0

208 3 AL 046496500 1

208 3 PW 046496500 1

230 3 AL 046496500 1

230 3 PW 046496500 1

460 3 AL 046496500 1

460 3 PW 046496600 1

380/415 3 AL 046496500 1

380/415 3 PW 046496600 1

575 3 AL 047131100 1

575 3 PW 047131100 1


UnitVoltage

StepsCap Ctl

StartOption Part Number

# OfULa

208 2/3 AL 046496700 1

208 2/3 PW 046496700 1

230 2/3 AL 046496700 1

230 2/3 PW 046496700 1

460 2/3 AL 046496700 1

460 2/3 PW 046496800 1

380/415 2/3 AL 046496700 1

380/415 2/3 PW 046496800 1

575 2/3 AL 047131200 1

575 2/3 PW 047131200 1


a Unloaders not included with this compressor. If unloader is required see "Compressor Components and Accessories" section.

Compressors ALR 022, 025C


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 2 AL 049267200 1

208 2 PW 049267200 1

230 2 AL 049267200 1

230 2 PW 049267200 1

460 2 AL 049267200 1

460 2 PW 049267400 1

380/415 2 AL 049267200 1

380/415 2 PW 049267400 1

575 2 AL 049267600 1

575 2 PW 049267600 1

208 3 AL 046496900 2a

208 3 PW 046496900 2a

230 3 AL 046496900 2a

230 3 PW 046496900 2a

460 3 AL 046496900 2a

460 3 PW 046497000 2a

380/415 3 AL 046496900 2a

380/415 3 PW 046497000 2a

575 3 AL 047131300 2a

575 3 PW 047131300 2a



UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 2 AL 049267700 1

208 2 PW 049267700 1

230 2 AL 049268100 1

230 2 PW 049268100 1

460 2 AL 049268100 1

460 2 PW 049267900 1

380/415 2 AL 049268100 1

380/415 2 PW 049267900 1

575 2 AL 047131400 1

575 2 PW 047131400 1

208 3 AL 044462700 2a

208 3 PW 044462700 2a

230 3 AL 044462800 2a

230 3 PW 044462800 2a

460 3 AL 044462800 2a

460 3 PW 044462900 2a

380/415 3 AL 044462800 2a

380/415 3 PW 044462900 2a

575 3 AL 047131400 2a

575 3 PW 047131400 2a




UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4 AL 046496300 1

208 4 PW 046496300 1

230 4 AL 046496300 1

230 4 PW 046496300 1

460 4 AL 046496300 1

460 4 PW 046496400 1

380/415 4 AL 046496300 1

380/415 4 PW 046496400 1

575 4 AL 047131000 1

575 4 PW 047131000 1


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4 AL 046496500 1

208 4 PW 046496500 1

230 4 AL 046496500 1

230 4 PW 046496500 1

460 4 AL 046496500 1

460 4 PW 046496600 1

380/415 4 AL 046496500 1

380/415 4 PW 046496600 1

575 4 AL 047131100 1

575 4 PW 047131100 1

Compressor # 2HP= 25

UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4 AL 046496500 1

208 4 PW 046496500 1

230 4 AL 046496500 1

230 4 PW 046496500 1

460 4 AL 046496500 1

460 4 PW 046496600 1

380/415 4 AL 046496500 1

380/415 4 PW 046496600 1

575 4 AL 047131100 1

575 4 PW 047131100 1


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4 AL 046496700 1

208 4 PW 046496700 1

230 4 AL 046496700 1

230 4 PW 046496700 1

460 4 AL 046496700 1

460 4 PW 046496800 1

380/415 4 AL 046496700 1

380/415 4 PW 046496800 1

575 4 AL 047131200 1

575 4 PW 047131200 1


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4 AL 046496700 1

208 4 PW 046496700 1

230 4 AL 046496700 1

230 4 PW 046496700 1

460 4 AL 046496700 1

460 4 PW 046496800 1

380/415 4 AL 046496700 1

380/415 4 PW 046496800 1

575 4 AL 047131200 1

575 4 PW 047131200 1


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4 AL 049267200 1

208 4 PW 049267200 1

230 4 AL 049267200 1

230 4 PW 049267200 1

460 4 AL 049267200 1

460 4 PW 049267400 1

380/415 4 AL 049267200 1

380/415 4 PW 049267400 1

575 4 AL 049267600 1

575 4 PW 049267600 1



Compressors ALR 040, 050, 060C


UnitVoltage

StepsCap Ctl


# OfUL

208 4 AL 049267200 1

208 4 PW 049267200 1

230 4 AL 049267200 1

230 4 PW 049267200 1

460 4 AL 049267200 1

460 4 PW 049267400 1

380/415 4 AL 049267200 1

380/415 4 PW 049267400 1

575 4 AL 049267600 1

575 4 PW 049267600 1

208 6 AL 046496900 2a

208 6 PW 046496900 2a

230 6 AL 046496900 2a

230 6 PW 046496900 2a

460 6 AL 046496900 2a

460 6 PW 046497000 2a

380/415 6 AL 046496900 2a

380/415 6 PW 046497000 2a

575 6 AL 047131300 2a

575 6 PW 047131300 2a


UnitVoltage

StepsCap Ctl


# OfUL

208 4 AL 049267200 1

208 4 PW 049267200 1

230 4 AL 049267200 1

230 4 PW 049267200 1

460 4 AL 049267200 1

460 4 PW 049267400 1

380/415 4 AL 049267200 1

380/415 4 PW 049267400 1

575 4 AL 049267600 1

575 4 PW 049267600 1

208 6 AL 046496900 2a

208 6 PW 046496900 2a

230 6 AL 046496900 2a

230 6 PW 046496900 2a

460 6 AL 046496900 2a

460 6 PW 046497000 2a

380/415 6 AL 046496900 2a

380/415 6 PW 046497000 2a

575 6 AL 047131300 2a

575 6 PW 047131300 2a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267700 1

208 4 PW 049267700 1

230 4 AL 049268100 1

230 4 PW 049268100 1

460 4 AL 049268100 1

460 4 PW 049267900 1

380/415 4 AL 049268100 1

380/415 4 PW 049267900 1

575 4 AL 047131400 1

575 4 PW 047131400 1

208 6 AL 044462700 2a

208 6 PW 044462700 2a

230 6 AL 044462800 2a

230 6 PW 044462800 2a

460 6 AL 044462800 2a

460 6 PW 044462900 2a

380/415 6 AL 044462800 2a

380/415 6 PW 044462900 2a

575 6 AL 047131400 2a

575 6 PW 047131400 2a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267700 1

208 4 PW 049267700 1

230 4 AL 049268100 1

230 4 PW 049268100 1

460 4 AL 049268100 1

460 4 PW 049267900 1

380/415 4 AL 049268100 1

380/415 4 PW 049267900 1

575 4 AL 047131400 1

575 4 PW 047131400 1

208 6 AL 044462700 2a

208 6 PW 044462700 2a

230 6 AL 044462800 2a

230 6 PW 044462800 2a

460 6 AL 044462800 2a

460 6 PW 044462900 2a

380/415 6 AL 044462800 2a

380/415 6 PW 044462900 2a

575 6 AL 047131400 2a

575 6 PW 047131400 2a





UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4/6 AL 047137100 2

208 4/6 PW 047137100 2

230 4/6 AL 047137100 2

230 4/6 PW 047137100 2

460 4/6 AL 047137200 2

460 4/6 PW 047137200 2

380/415 4/6 AL 047137200 2

380/415 4/6 PW 047137200 2

575 4/6 AL 047137300 2

575 4/6 PW 047137300 2


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4/6 AL 047137100 2

208 4/6 PW 047137100 2

230 4/6 AL 047137100 2

230 4/6 PW 047137100 2

460 4/6 AL 047137200 2

460 4/6 PW 047137200 2

380/415 4/6 AL 047137200 2

380/415 4/6 PW 047137200 2

575 4/6 AL 047137300 2

575 4/6 PW 047137300 2


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4/6 AL 047352800 2

208 4/6 PW 047352800 2

230 4/6 AL 047352800 2

230 4/6 PW 047352800 2

460 4/6 AL 047352900 2

460 4/6 PW 047352900 2

380/415 4/6 AL 047352900 2

380/415 4/6 PW 047352900 2

575 4/6 AL 047353000 2

575 4/6 PW 047353000 2


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfULa

208 4/6 AL 047352800 2

208 4/6 PW 047352800 2

230 4/6 AL 047352800 2

230 4/6 PW 047352800 2

460 4/6 AL 047352900 2

460 4/6 PW 047352900 2

380/415 4/6 AL 047352900 2

380/415 4/6 PW 047352900 2

575 4/6 AL 047353000 2

575 4/6 PW 047353000 2





UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267300 0

208 4 PW 049267300 0

230 4 AL 049267300 0

230 4 PW 049267300 0

460 4 AL 049267300 0

460 4 PW 049267500 0

380/415 4 AL 049267300 0

380/415 4 PW 049267500 0

575 4 AL 049267600 0

575 4 PW 049267600 0

208 6/8 AL 049267200 1

208 6/8 PW 049267200 1

230 6/8 AL 049267200 1

230 6/8 PW 049267200 1

460 6/8 AL 049267200 1

460 6/8 PW 049267400 1

380/415 6/8 AL 049267200 1

380/415 6/8 PW 049267400 1

575 6/8 AL 049267600 1

575 6/8 PW 049267600 1


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267100 0

208 4 PW 049267100 0

230 4 AL 049267100 0

230 4 PW 049267100 0

460 4 AL 049267100 0

460 4 PW 049268600 0

380/415 4 AL 049267100 0

380/415 4 PW 049268600 0

575 4 AL 047131100 0

575 4 PW 047131100 0

208 6/8 AL 049267100 0

208 6/8 PW 049267100 0

230 6/8 AL 049267100 0

230 6/8 PW 049267100 0

460 6/8 AL 049267100 0

460 6/8 PW 049268600 0

380/415 6/8 AL 049267100 0

380/415 6/8 PW 049268600 0

575 6/8 AL 047131100 0

575 6/8 PW 047131100 0


UnitVoltage

StepsCap Ctl


# OfUL

208 4 AL 049267300 0

208 4 PW 049267300 0

230 4 AL 049267300 0

230 4 PW 049267300 0

460 4 AL 049267300 0

460 4 PW 049267500 0

380/415 4 AL 049267300 0

380/415 4 PW 049267500 0

575 4 AL 049267600 0

575 4 PW 049267600 0

208 6/8 AL 049267200 1

208 6/8 PW 049267200 1

230 6/8 AL 049267200 1

230 6/8 PW 049267200 1

460 6/8 AL 049267200 1

460 6/8 PW 049267400 1

380/415 6/8 AL 049267200 1

380/415 6/8 PW 049267400 1

575 6/8 AL 049267600 1

575 6/8 PW 049267600 1


UnitVoltage

StepsCap Ctl


# OfUL

208 4 AL 049267100 0

208 4 PW 049267100 0

230 4 AL 049267100 0

230 4 PW 049267100 0

460 4 AL 049267100 0

460 4 PW 049268600 0

380/415 4 AL 049267100 0

380/415 4 PW 049268600 0

575 4 AL 047131100 0

575 4 PW 047131100 0

208 6/8 AL 049267100 0

208 6/8 PW 049267100 0

230 6/8 AL 049267100 0

230 6/8 PW 049267100 0

460 6/8 AL 049267100 0

460 6/8 PW 049268600 0

380/415 6/8 AL 049267100 0

380/415 6/8 PW 049268600 0

575 6/8 AL 047131100 0

575 6/8 PW 047131100 0


Compressors ALR 105C


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267300 0

208 4 PW 049267300 0

230 4 AL 049267300 0

230 4 PW 049267300 0

460 4 AL 049267300 0

460 4 PW 049267500 0

380/415 4 AL 049267300 0

380/415 4 PW 049267500 0

575 4 AL 049267600 0

575 4 PW 049267600 0

208 6/8 AL 049267200 1

208 6/8 PW 049267200 1

230 6/8 AL 049267200 1

230 6/8 PW 049267200 1

460 6/8 AL 049267200 1

460 6/8 PW 049267400 1

380/415 6/8 AL 049267200 1

380/415 6/8 PW 049267400 1

575 6/8 AL 049267600 1

575 6/8 PW 049267600 1


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267100 0

208 4 PW 049267100 0

230 4 AL 049267100 0

230 4 PW 049267100 0

460 4 AL 049267100 0

460 4 PW 049268600 0

380/415 4 AL 049267100 0

380/415 4 PW 049268600 0

575 4 AL 047131100 0

575 4 PW 047131100 0

208 6/8 AL 049267100 0

208 6/8 PW 049267100 0

230 6/8 AL 049267100 0

230 6/8 PW 049267100 0

460 6/8 AL 049267100 0

460 6/8 PW 049268600 0

380/415 6/8 AL 049267100 0

380/415 6/8 PW 049268600 0

575 6/8 AL 047131100 0

575 6/8 PW 047131100 0


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267300 0

208 4 PW 049267300 0

230 4 AL 049267300 0

230 4 PW 049267300 0

460 4 AL 049267300 0

460 4 PW 049267500 0

380/415 4 AL 049267300 0

380/415 4 PW 049267500 0

575 4 AL 049267600 0

575 4 PW 049267600 0

208 6/8 AL 049267200 1

208 6/8 PW 049267200 1

230 6/8 AL 049267200 1

230 6/8 PW 049267200 1

460 6/8 AL 049267200 1

460 6/8 PW 049267400 1

380/415 6/8 AL 049267200 1

380/415 6/8 PW 049267400 1

575 6/8 AL 049267600 1

575 6/8 PW 049267600 1


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267300 0

208 4 PW 049267300 0

230 4 AL 049267300 0

230 4 PW 049267300 0

460 4 AL 049267300 0

460 4 PW 049267500 0

380/415 4 AL 049267300 0

380/415 4 PW 049267500 0

575 4 AL 049267600 0

575 4 PW 049267600 0

208 6/8 AL 049267300 0

208 6/8 PW 049267300 0

230 6/8 AL 049267300 0

230 6/8 PW 049267300 0

460 6/8 AL 049267300 0

460 6/8 PW 049267500 0

380/415 6/8 AL 049267300 0

380/415 6/8 PW 049267500 0

575 6/8 AL 049267600 0

575 6/8 PW 049267600 0

Compressor # 4HP=35



UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267300 0

208 4 PW 049267300 0

230 4 AL 049267300 0

230 4 PW 049267300 0

460 4 AL 049267300 0

460 4 PW 049267500 0

380/415 4 AL 049267300 0

380/415 4 PW 049267500 0

575 4 AL 049267600 0

575 4 PW 049267600 0

208 6/8 AL 049267200 1

208 6/8 PW 049267200 1

230 6/8 AL 049267200 1

230 6/8 PW 049267200 1

460 6/8 AL 049267200 1

460 6/8 PW 049267400 1

380/415 6/8 AL 049267200 1

380/415 6/8 PW 049267400 1

575 6/8 AL 049267600 1

575 6/8 PW 049267600 1


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267300 0

208 4 PW 049267300 0

230 4 AL 049267300 0

230 4 PW 049267300 0

460 4 AL 049267300 0

460 4 PW 049267500 0

380/415 4 AL 049267300 0

380/415 4 PW 049267500 0

575 4 AL 049267600 0

575 4 PW 049267600 0

208 6/8 AL 049267300 0

208 6/8 PW 049267300 0

230 6/8 AL 049267300 0

230 6/8 PW 049267300 0

460 6/8 AL 049267300 0

460 6/8 PW 049267500 0

380/415 6/8 AL 049267300 0

380/415 6/8 PW 049267500 0

575 6/8 AL 049267600 0

575 6/8 PW 049267600 0


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267300 0

208 4 PW 049267300 0

230 4 AL 049267300 0

230 4 PW 049267300 0

460 4 AL 049267300 0

460 4 PW 049267500 0

380/415 4 AL 049267300 0

380/415 4 PW 049267500 0

575 4 AL 049267600 0

575 4 PW 049267600 0

208 6/8 AL 049267200 1

208 6/8 PW 049267200 1

230 6/8 AL 049267200 1

230 6/8 PW 049267200 1

460 6/8 AL 049267200 1

460 6/8 PW 049267400 1

380/415 6/8 AL 049267200 1

380/415 6/8 PW 049267400 1

575 6/8 AL 049267600 1

575 6/8 PW 049267600 1


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267300 0

208 4 PW 049267300 0

230 4 AL 049267300 0

230 4 PW 049267300 0

460 4 AL 049267300 0

460 4 PW 049267500 0

380/415 4 AL 049267300 0

380/415 4 PW 049267500 0

575 4 AL 049267600 0

575 4 PW 049267600 0

208 6/8 AL 049267300 0

208 6/8 PW 049267300 0

230 6/8 AL 049267300 0

230 6/8 PW 049267300 0

460 6/8 AL 049267300 0

460 6/8 PW 049267500 0

380/415 6/8 AL 049267300 0

380/415 6/8 PW 049267500 0

575 6/8 AL 049267600 0

575 6/8 PW 049267600 0




UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267800 0

208 4 PW 049267800 0

230 4 AL 049268200 0

230 4 PW 049268200 0

460 4 AL 049268200 0

460 4 PW 049268000 0

380/415 4 AL 049268200 0

380/415 4 PW 049268000 0

575 4 AL 047131400 0

575 4 PW 047131400 0

208 6/8 AL 049267700 1

208 6/8 PW 049267700 1

230 6/8 AL 049268100 1

230 6/8 PW 049268100 1

460 6/8 AL 049268100 1

460 6/8 PW 049267900 1

380/415 6/8 AL 049268100 1

380/415 6/8 PW 049267900 1

575 6/8 AL 047131400 1a

575 6/8 PW 047131400 1a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4/6/8 AL 049267800 0

208 4/6/8 PW 049267800 0

230 4/6/8 AL 049268200 0

230 4/6/8 PW 049268200 0

460 4/6/8 AL 049268200 0

460 4/6/8 PW 049268000 0

380/415 4/6/8 AL 049268200 0

380/415 4/6/8 PW 049268000 0

575 4/6/8 AL 047131400 0

575 4/6/8 PW 047131400 0


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4 AL 049267800 0

208 4 PW 049267800 0

230 4 AL 049268200 0

230 4 PW 049268200 0

460 4 AL 049268200 0

460 4 PW 049268000 0

380/415 4 AL 049268200 0

380/415 4 PW 049268000 0

575 4 AL 047131400 0

575 4 PW 047131400 0

208 6/8 AL 049267700 1

208 6/8 PW 049267700 1

230 6/8 AL 049268100 1

230 6/8 PW 049268100 1

460 6/8 AL 049268100 1

460 6/8 PW 049267900 1

380/415 6/8 AL 049268100 1

380/415 6/8 PW 049267900 1

575 6/8 AL 047131400 1a

575 6/8 PW 047131400 1a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 4/6/8 AL 049267800 0

208 4/6/8 PW 049267800 0

230 4/6/8 AL 049268200 0

230 4/6/8 PW 049268200 0

460 4/6/8 AL 049268200 0

460 4/6/8 PW 049268000 0

380/415 4/6/8 AL 049268200 0

380/415 4/6/8 PW 049268000 0

575 4/6/8 AL 047131400 0

575 4/6/8 PW 047131400 0






UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 6/8 AL 071667601 1

208 6/8 PW 071667601 1

230 6/8 AL 071667701 1

230 6/8 PW 071667701 1

460 6/8 AL 071667701 1

460 6/8 PW 071667701 1

380/415 6/8 AL 071667701 1

380/415 6/8 PW 071667701 1

575 6/8 AL 047137300 1a

575 6/8 PW 047137300 1a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 6 AL 049267800 0

208 6 PW 049267800 0

230 6 AL 049268200 0

230 6 PW 049268200 0

460 6 AL 049268200 0

460 6 PW 049268000 0

380/415 6 AL 049268200 0

380/415 6 PW 049268000 0

575 6 AL 047131400 0

575 6 PW 047131400 0

208 8 AL 049267700 1

208 8 PW 049267700 1

230 8 AL 049268100 1

230 8 PW 049268100 1

460 8 AL 049268100 1

460 8 PW 049268100 1

380/415 8 PW 049267900 1

575 8 AL 047131400 1a

575 8 PW 047131400 1a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 6/8 AL 071667601 1

208 6/8 PW 071667601 1

230 6/8 AL 071667701 1

230 6/8 PW 071667701 1

460 6/8 AL 071667701 1

460 6/8 PW 071667701 1

380/415 6/8 AL 071667701 1

380/415 6/8 PW 071667701 1

575 6/8 AL 047137300 1a

575 6/8 PW 047137300 1a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 6 AL 049267800 0

208 6 PW 049267800 0

230 6 AL 049268200 0

230 6 PW 049268200 0

460 6 AL 049268200 0

460 6 PW 049268000 0

380/415 6 AL 049268200 0

380/415 6 PW 049268000 0

575 6 AL 047131400 0

575 6 PW 047131400 0

208 8 AL 049267700 1

208 8 PW 049267700 1

230 8 AL 049268100 1

230 8 PW 049268100 1

460 8 AL 049268100 1

460 8 PW 049267900 1

380/415 8 AL 049268100 1

380/415 8 PW 049267900 1

575 8 AL 047131400 1a

575 8 PW 047131400 1a





UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 6/8 AL 071667601 1

208 6/8 PW 071667601 1

230 6/8 AL 071667701 1

230 6/8 PW 071667701 1

460 6/8 AL 071667701 1

460 6/8 PW 071667701 1

380/415 6/8 AL 071667701 1

380/415 6/8 PW 047137300 1

575 6/8 PW 047137300 1a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 6 AL 071667801 0

208 6 PW 071667801 0

230 6 AL 071667901 0

230 6 PW 071667901 0

460 6 AL 071667901 0

460 6 PW 071667901 0

380/415 6 AL 071667901 0

380/415 6 PW 071667901 0

575 6 AL 047137300 0

575 6 PW 047137300 0

208 8 AL 071667601 1

208 8 PW 071667601 1

230 8 AL 071667701 1

230 8 PW 071667701 1

460 8 AL 071667701 1

460 8 PW 071667701 1

380/415 8 AL 071667701 1

380/415 8 PW 071667701 1

575 8 AL 047137300 1a

575 8 PW 047137300 1a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 6/8 AL 071667601 1

208 6/8 PW 071667601 1

230 6/8 AL 071667701 1

230 6/8 PW 071667701 1

460 6/8 AL 071667701 1

460 6/8 PW 071667701 1

380/415 6/8 AL 071667701 1

380/415 6/8 PW 071667701 1

575 6/8 AL 047137300 1a

575 6/8 PW 047137300 1a


UnitVoltage

StepsCap Ctl

StartOption

Part Number

# OfUL

208 6 AL 071667801 0

208 6 PW 071667801 0

230 6 AL 071667901 0

230 6 PW 071667901 0

460 6 AL 071667901 0

460 6 PW 071667901 0

380/415 6 AL 071667901 0

380/415 6 PW 071667901 0

575 6 AL 047137300 0

575 6 PW 047137300 0

208 8 AL 071667601 1

208 8 PW 071667601 1

230 8 AL 071667701 1

230 8 PW 071667701 1

460 8 AL 071667701 1

460 8 PW 071667701 1

380/415 8 AL 071667701 1

380/415 8 PW 071667701 1

575 8 AL 047137300 1a

575 8 PW 047137300 1a





UnitVoltage

StepsCap Ctl


# OfUL

208 6/8 AL 071668001 1

208 6/8 PW 071668001 1

230 6/8 AL 071668101 1

230 6/8 PW 071668101 1

460 6/8 AL 071668101 1

460 6/8 PW 071668101 1

380/415 6/8 AL 071668101 1

380/415 6/8 PW 071668101 1

575 6/8 AL 047353000 1a

575 6/8 PW 047353000 1a

ALR 195, 205C CompressorsCompressor # 1HP= 60

UnitVoltage

StepsCap Ctl


# OfUL

208 6 AL 071668201 0

208 6 PW 071668201 0

230 6 AL 071668301 0

230 6 PW 071668301 0

460 6 AL 071668301 0

460 6 PW 071668301 0

380/415 6 AL 071668301 0

380/415 6 PW 071668301 0

575 6 AL 047353000 0

575 6 PW 047353000 0

208 8 AL 071668001 1

208 8 PW 071668001 1

230 8 AL 071668101 1

230 8 PW 071668101 1

460 8 AL 071668101 1

460 8 PW 071668101 1

380/415 8 AL 071668101 1

380/415 8 PW 071668101 1

575 8 AL 047353000 1a

575 8 PW 047353000 1a


UnitVoltage

StepsCap Ctl


# OfUL

208 6/8 AL 071668001 1

208 6/8 PW 071668001 1

230 6/8 AL 071668101 1

230 6/8 PW 071668101 1

460 6/8 AL 071668101 1

460 6/8 PW 071668101 1

380/415 6/8 AL 071668101 1

380/415 6/8 PW 071668101 1

575 6/8 AL 047353000 1a

575 6/8 PW 047353000 1a


UnitVoltage

StepsCap Ctl


# OfUL

208 6 AL 071668201 0

208 6 PW 071668201 0

230 6 AL 071668301 0

230 6 PW 071668301 0

460 6 AL 071668301 0

460 6 PW 071668301 0

380/415 6 AL 071668301 0

380/415 6 PW 071668301 0

575 6 AL 047353000 0

575 6 PW 047353000 0

208 8 AL 071668001 1

208 8 PW 071668001 1

230 8 AL 071668101 1

230 8 PW 071668101 1

460 8 AL 071668101 1

460 8 PW 071668101 1

380/415 8 AL 071668101 1

380/415 8 PW 071668101 1

575 8 AL 047353000 1a

575 8 PW 047353000 1a





Compressors Mounting Components

606

Ref # 600 601 602 603 604 605 606

ALR 022- 205C

*Per Compressor Foot

DescriptionBolt: .62 x4.0Lock WasherFlat WasherVibration Pad- .31 x 2.0Compressor GrommetVibration Pad- .62 x 2 x 2Support

Qty. 1* 1* 1* 1* 1* 1* 1*

Part Number 735033955 048164812 040500312 041763400 019941000 041763300 055062301

Ref # 610 611 612 613 614

ALR 010- 018CDescriptionBoltFlat WasherRubber MountSleeveHex Nut

Qty. 1* 1* 1* 1* 1*

Part Number 040499035 041542301 035923500 035923601 040500002

*Per Compressor Foot612

Typical Compressor Foot(Four per Compressor)

610

611

614

613

ALR 010- 018C

603

Typical Compressor Foot(Four per Compressor)

601600

602

605

606

604

Compressor Foot

ALR 022- 205C


T1

2

CP1(D 350)

CP2

T 2

FB2

FB5 FB6 SC11

TD1

FS1

R 3

TD2 TD3

R 4 R 13

TD4 TD9

R 21

M 11 M 12

C12

C11

M1 M 5 M 9

TC10

23

24 25

19

8

18

22

20

21

16

17

1

1A

3

1312

76

9

1110

2726

5

TC11

17A

Control & Power Panel ComponentsALR 010 - 018CPanel Diagram


Ref. No. Part Description Part Number

Quantity/Unit Voltage

208V 460V 230V 380V & 415V 575V

CP1, CP2, D350- Main Controller1 Central Processor- Master A350 065497809 1 1 1 1 1 Sensor for A350 065497807 1 1 1 1 1 Display for A350 Processor 065497803 1 1 1 1 1

1A Central Processor- Slave (2-Speed Compr. Units Only) 065487302 1 1 1 1 1 T1, T2, T3-Transformers2 Main Power Transformer- T1: Units w/ Speedtrol 038253922 1 Main Power Transformer- T1: Units w/ Speedtrol 038253927 1

Main Power Transformer- T1: Units w/ Speedtrol 038253930 1Main Power Transformer- T1: Units w/o Speedtrol 038253935 1

Main Power Transformer- T1: Units w/o Speedtrol 038253924 1Main Power Transformer- T1: Units w/o Speedtrol 038253925 1

3 Control Transformer- T2 046738109 1 1 3 Control Transformer- T2 046738103 1 3 Control Transformer- T2 046738104 1

N/S Speedtrol Transformer- T3 038253922 1 Fuse- 1.3A Speedtrol Transformer 049759805 1

R3, R4, R13, R21- Relays5 Relay R3- Starting 026213000 1 1 1 1 1 6 Relay R4- Starting: 2-Speed Compressors Only 026213000 1 1 1 1 17 Relay R13- Low Ambient 047356704 1 1 1 1 18 Relay R21- Hi Ambient or Hi Water 047356702 1 1 1 1 1

TD1, TD2, TD3, TD4, TD9- Time Delays9 TD1- Starting (after 5/93) 028210120 1 1 1 1 110 TD2- Compressor Lockout (until 5/93) 028210124 1 1 1 1 1 TD2- Compressor Lockout (after 5/93) 028210119 1 1 1 1 111 TD3 (after 5/93) 028210134 1 1 1 1 112 TD4 (after 5/93) 028210135 1 1 1 1 113 TD9- Low Ambient 028210125 1 1 1 1 1

HP1, LP1, FS1, PC5, PC12, SC11- Pressure Controls N/S High Pressure Control- HP1 047356107 1 1 1 1 1N/S Low Pressure Control- LP1 047356103 1 1 1 1 116 Freezestat Control- FS1 (until 5/93) 001354800 1 1 1 1 1 Freezestat Control- FS1 (after 5/93) 071944601 1 1 1 1 1

N/S Hi-Ambient Unloader Pressure Control- PC5 047356104 1 1 1 1 1N/S Fantrol Pressure Control- PC12 047356101 1 1 1 1 118 Speedtrol Control- SC11 048445202 1 1 1 1 1

TC10, TC11- Thermostats17 Freezestat Temperature Control- TC10 065497809 1 1 1 1 1 Sensor for TC10 065497808 1 1 1 1 1

17A Hi Water Unloader Thermostat- TC11 023796408 1 1 1 1 1C11, C12- Capacitors

19 Fan Motor Capacitor 7.5MFD- C11, C12 037516404 2 2 2 2 2

Control & Power Panel ComponentsALR 010 - 018C

N/S= Not shown on diagram.




208V 460V 230V 380V & 415V 575V

FB2, FB5, FB6- Fuse Blocks and Fuses20 Fuseblock FB2- Cooler Heater 046500002 1 1 1 1 1 Fuse F2- Cooler Heater 046742220 1 1 1 1 121 Fuseblock FB5- Transformer 046500002 1 1 Fuse- F5 7.0A Units w/Speedtrol 042753117 1 1 Fuse- F5 0.8A Units w/ 2 Speed Compressor 042753104 1 1

Fuse- F5 10A Units w/ 2 Speed Compressor 042753120 122 Fuseblock FB6- Fan Motor 046500002 1 1 1 1 1

Fuse- F6 10A 042753120 1 1 1 1 1 M1, M5, M6- Compressor Contactors: ALR 010C

23 M1 Contactor: 3 Pole, 40FLA (until 5/93) 027514203 1 1M1 Contactor: 3 Pole, 50FLA (after 5/93) 027514204 1 1 1 M1 Contactor: 3 Pole, 25FLA 027514201 1 1 1

24 M5 Contactor: 3 Pole, 50FLA 049542102 1 1 1 1M5 Contactor: 3 Pole, 30FLA 049542101 1 1 1 1 1

25 M9 Contactor: 3 Pole, 20FLA 049542102 1 1 1M9 Contactor: 3 Pole, 30FLA 049542101 1 1 1M1, M5, M6- Compressor Contactors: ALR 015C

23 M1 Contactor: 3 Pole, 60FLA 027514205 1 1M1 Contactor: 3 Pole, 40FLA 027514203 1 1M1 Contactor: 3 Pole, 30FLA 027514202 1


25 M9 Contactor: 3 Pole, 20FLA 049542102 1 1 1 1M9 Contactor: 3 Pole, 30FLA 049542101 1 1 1 1 1M1, M5, M6- Compressor Contactors: ALR 018C

23 M1 Contactor: 3 Pole, 90FLA 027514207 1 1M1 Contactor: 3 Pole, 50FLA 027514204 1 1M1 Contactor: 3 Pole, 40FLA 027514203 1


25 M9 Contactor: 3 Pole, 50FLA 049542102 1 1 1 1M9 Contactor: 3 Pole, 30FLA 049542101 1 1 1 1 1M11, M12- Fan Motor Contactors

26 M11 Contactor: 17FLA- Units Without Speedtrol 034914200 1 1M11 Relay- Units Without Speedtrol 047356704 1 1 1M11 Relay- Units With Speedtrol 034914200 1 1 1 1 1

27 M12 Contactor: 17FLA- Units Without Speedtrol 034914200 1 1M12 Relay- Units Without Speedtrol 047356704 1 1 1M12 Relay- Units With Speedtrol 034914200 1 1 1 1 1

Control & Power Panel ComponentsALR 010 - 018C, Continued


T1

1

T 2

2

PVMM1

7M5

8

FB5FB6or

FB7

43

FB6

5

M12 M11

1110

M13

9 12

T10

C1

C2

C1

C2

C1

C2

6

Power Panel ComponentsALR 022 - 035CPanel Diagram




208V 460V 230V 380V & 415V 575V

T1- Power Transformer1 Transformer: .5KVA, 208/277/380P, 115/95S 038253911 1 1

Transformer: .5KVA,240/480P, 120S 038253902 1 1Transformer: .5KVA, 600P, 120/240S 038253931 1T2- Control Transformer

2 Transformer: 120P, 27S 029948300 1 1 1 1 1T3-Speedtrol Transformer

N/S Transformer 037533603 1N/S Transformer 037533629 1 1 1 1

FB5, FB6, FB7- Fuseblocks and Fuses3 FB5 Fuse Block- Control Circuit Transformer 046500002 1 1 1 1 1

F5 Fuse- Control Circuit Transformer 4 Amp 042753114 1 3.5 Amp 042753113 1 2 Amp 042753109 1 1.6 Amp 042753108 1 1.5 Amp 046742209 1

4 FB6 Fuseblock (Units without Speedtrol) orFB7 Fuseblock (Units with Speedtrol) 046500003 1 1 1 1 1

F6 or F7 Fuse- 15A 042753122 3 3 3 3 35 FB6 Fuseblock (Units with Speedtrol) 046500002 1 1 1 1 1

F6 Fuse- 15A (Units with Speedtrol) 042753122 2 2 2 2 2PVM- Phase Voltage Monitor

6 Phase Voltage Monitor 039444701 1Phase Voltage Monitor 039444702 1Phase Voltage Monitor 039444703 1Phase Voltage Monitor 039444704 1Phase Voltage Monitor, 60 HZ 039444706 1Phase Voltage Monitor, 50 HZ 039444707 1Phase Voltage Monitor, 415V 039444705 1M1, M5- Compr. Contactors: Across-The-Line Start

7 M1 Contactor: 3 Pole, 50FLA, Aux. Con. (ALR 022C) 027514404 1 1 1 1M1 Contactor: 3 Pole, 60FLA, Aux. Con. (ALR 022C) 027514405 1M1 Contactor: 3 Pole, 60FLA, Aux. Con. (ALR 025C) 027514405 1 1 1 1 1M1 Contactor: 3 Pole, 75FLA, Aux. Con. (ALR 030C) 027514406 1 1 1 1M1 Contactor: 3 Pole, 60FLA, Aux. Con. (ALR 030C) 027514405 1

8 M5 Contactor: 3 Pole, 50FLA (ALR 022C) 027514104 1 1M5 Contactor: 3 Pole, 60FLA (ALR 025C) 027514105 1 1M5 Contactor: 3 Pole, 75FLA (ALR 030C) 027514106 1 1

Power Panel ComponentsALR 022, 025, 030C



Power Panel ComponentsALR 022, 025, 030C Continued



208V 460V 230V 380V & 415V 575V

M1, M5- Compressor Contactors: Part Winding Start7 M1 Contactor: 3 Pole, 50FLA, Aux. Con. (ALR 022C) 027514404 1 1

M1 Contactor: 3 Pole, 25FLA, Aux. Con. (ALR 022C) 027514401 1 1M1 Contactor: 3 Pole, 30FLA, Aux. Con. (ALR 022C) 027514402 1M1 Contactor: 3 Pole, 60FLA, Aux. Con. (ALR 025C) 027514405 1 1M1 Contactor: 3 Pole, 30FLA, Aux. Con. (ALR 025C) 027514402 1 1M1 Contactor: 3 Pole, 40FLA, Aux. Con. (ALR 025C) 027514403 1M1 Contactor: 3 Pole, 75FLA, Aux. Con. (ALR 030C) 027514406 1 1M1 Contactor: 3 Pole, 40FLA, Aux. Con. (ALR 030C) 027514403 1 1 1

8 M5 Contactor: 3 Pole, 50FLA (ALR 022C) 027514104 1 1M5 Contactor: 3 Pole, 25FLA (ALR 022C) 027514101 1 1 M5 Contactor: 3 Pole, 30FLA (ALR 022C) 027514102 1M5 Contactor: 3 Pole, 60FLA (ALR 025C) 027514105 1 1M5 Contactor: 3 Pole, 30FLA (ALR 025C) 027514102 1 1 M5 Contactor: 3 Pole, 40FLA (ALR 025C) 027514103 1M5 Contactor: 3 Pole, 75FLA (ALR 030C) 027514106 1 1 M5 Contactor: 3 Pole, 40FLA (ALR 030C) 027514103 1 1 1M11, M12, M13- Fan Motor Contactors

9 M13 Contactor: 30FLA 041769601 1 1 1 1 110 M13 Contactor: 30FLA 041769601 1 1 1 1 111 M13 Contactor: 30FLA 041769601 1 1 1 1 1

T10- Speedtrol Motor Step Down Transformer12 T10 Transformer 046738109 1 112 T10 Transformer 046738103 112 T10 Transformer 046738104 1




208V 460V 230V 380V & 415V 575V

T1- Power Transformer1 Transformer: .5KVA, 208/277/380P, 115/95S 038253913 1 1

Transformer: .5KVA,240/480P, 120S 038253904 1 1Transformer: .5KVA, 600P, 120/240S 038253932 1T2- Control Transformer

2 Transformer: 120P, 27S 029948300 1 1 1 1 1T3-Speedtrol Transformer

N/S Transformer 037533603 1N/S Transformer 037533629 1 1 1 1

FB5, FB6, FB7- Fuseblocks and Fuses3 FB5 Fuse Block- Control Circuit Transformer 046500002 1 1 1 1 1

F5 Fuse- Control Circuit Transformer 4 Amp 042753114 1 3.5 Amp 042753113 1 1 3 Amp 042753111 1 1 Amp 046742208 1

4 FB6 Fuseblock (Units without Speedtrol) orFB7 Fuseblock (Units with Speedtrol) 046500003 1 1 1 1 1

F6 or F7 Fuse- 15A 042753122 3 3 3 3 35 FB6 Fuseblock (Units with Speedtrol) 046500002 1 1 1 1 1

F6 Fuse- 15A (Units with Speedtrol) 042753122 2 2 2 2 2PVM- Phase Voltage Monitor

6 Phase Voltage Monitor 039444701 1Phase Voltage Monitor 039444702 1Phase Voltage Monitor 039444703 1Phase Voltage Monitor 039444704 1Phase Voltage Monitor, 60 HZ 039444706 1Phase Voltage Monitor, 50 HZ 039444707 1Phase Voltage Monitor, 415V 039444705 1M1, M5- Compr. Contactors: Across-The-Line Start

7 M1 Contactor: 3 Pole, 90FLA, Aux. Con. 027514407 1 M1 Contactor: 3 Pole, 75FLA, Aux. Con . 027514406 1 1 1 M1 Contactor: 3 Pole, 60FLA, Aux. Con . 027514405 1

8 M5 Contactor: 3 Pole, 90FLA 027514107 1 M5 Contactor: 3 Pole, 75FLA 027514106 1

M1, M5- Compressor Contactors: Part Winding Start7 M1 Contactor: 3 Pole, 90FLA, Aux. Con. 027514407 1

M1 Contactor: 3 Pole, 75FLA, Aux. Con. 027514406 1M1 Contactor: 3 Pole, 40FLA, Aux. Con. 027514403 1 1 1

8 M5 Contactor: 3 Pole, 90FLA 027514107 1 M5 Contactor: 3 Pole, 75FLA 027514106 1M5 Contactor: 3 Pole, 40FLA 027514103 1 1 1

Power Panel ComponentsALR 035C



Power Panel ComponentsALR 035C Continued



208V 460V 230V 380V & 415V 575V

M11, M12, M13- Fan Motor Contactors9 M13 Contactor: 30FLA 041769601 1 1 1 1 110 M13 Contactor: 30FLA 041769601 1 1 1 1 111 M13 Contactor: 30FLA 041769601 1 1 1 1 1

T10- Speedtrol Motor Step Down Transformer12 T10 Transformer 046738109 1 112 T10 Transformer 046738103 112 T10 Transformer 046738104 1



103

FB 5

102

101

T 1

SeeBelow

FB 6

100

FB 7

100

FB 8

100

FB 9

100

FB 10

100

M11

M12

M14

M22

M24

M21

M13

M23

130typ.

PB 1107

CT 1 CT 3

DS 1108

CT 1 CT 3

or

Note:CT1 and CT3 are used only when a Volt/Amp

Meter Box is used. See the Control Box Volt/Amp Meter Components and Mounting page for trans-

former part numbers

CB 1 CB 5 CB 2 CB 6

M 1 M 5 M 2 M 6

113 114 115 116

117 118 119 120

PB1

PB2 PB3

105

105A

106

104




208V 460V 230V 380V & 415V 575V

FB6- FB10-Fan Motor Fuse Blocks & Fuses100 Fuse Block FB6: 2 Pole (Speedtrol Units Only) 046500002 1 1 1 1 1

Fuse Block FB7 - FB10: 3 Pole (Speedtrol Units Only) 046500003 4 4 4 4 4Fuse Block FB6 - FB10: 3 Pole (Speedtrol Units Only) 046500003 5 5 5 5 5Fuse F6 - F10 15 Amp 042753122 5 5 5 5Fuse F6 - F10 15 Amp 046742222 5T1- Control Transformer Assy.

101 Fuse Block FB5: 2 Pole, 30A, 600V 070971001 1 1 1 1 1102 Fuse 6.0A FNQR 049759812 2

Fuse 3.5A KLDR 049759820 2 2Fuse 3.0A FNQR 049759809 2Fuse 2.5A FNQR 049759808 2

103 Transformer: .5KVA, 208/277/380P, 115/95S 038253913 1 1Transformer: .5KVA,2 40/480P, 120S 038253904 1 1Transformer: .5KVA, 600P, 120/240S 038253932 1

104 Transformer Ground Screw 038990902 1 1 1 1 1PB1- Power Block Power System

107 PB1 Terminal Block: 3 Pole, 335A, 600V 030372706 1 1 1 1 1DS1- Disconnect Switch Power System

108 Molded Case Switch: 3PST, 240VAC, 225A 047442103 1 1 1Molded Case Switch: 3PST, 600VAC, 100A 047442102 2 1 1 1PB1,PB2, PB3- Multipoint Power System

105 PB2 & PB 3Terminal Block: 3 Pole, 310A, 600V 030372704 2 2PB2 & PB 3Terminal Block: 3 Pole, 175A, 600V 030372710 2 2 2

105A PB1 Terminal Block: 3 Pole, 95A 030372707 1 1 1 1 1106 Ground Terminal Lug: Single Connection 028798500 1 1 1 1 1

CB1-6 Circuit Breakers113 Circuit Breaker: 3 Pole, 100A, 240V 047359312 1 1

Circuit Breaker: 3 Pole, 50A, 480V 047359327 1 1Circuit Breaker: 3 Pole, 40A, 600V 047359341 1

115 Circuit Breaker: 3 Pole, 100A, 240V 047359312 1 1Circuit Breaker: 3 Pole, 60A, 480V 047359328 1 1Circuit Breaker: 3 Pole, 45A, 600V 047359342 1M1-6 Compr. Contactors: Across-The-Line Start

117 Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514403 1 1 1 1 1118 Contactor: 3 Pole, 40FLA,50 Res.A. 027514103 1 1119 Contactor: 3 Pole, 50FLA,60 Res.A, Aux. Con. 027514404 1 1 1 1

Contactor: 3 Pole, 30FLA,40 Res.A, Aux. Con. 027514405 1120 Contactor: 3 Pole, 50FLA, 60 Res.A. 027514104 1 1


1 The disconnect switch p/n does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch’s manufacturer is required to select the correct part number. The G.E. handle is p/n 330419202; The Cutler Hammer handle is p/n 073015201.2 The disconnect switch p/n does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch’s manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419201; The Cutler Hammer handle is p/n 073015201.




208V 460V 230V 380V & 415V 575V

M1-6 Compressor Contactors: Part Winding Start117 Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514403 1 1

Contactor: 3 Pole, 30FLA,30 Res.A, Aux. Con. 027514402 1 1 1118 Contactor: 3 Pole, 40FLA,50 Res.A. 027514103 1 1

Contactor: 3 Pole, 30FLA,30 Res.A. 027514102 1 1 1119 Contactor: 3 Pole, 50FLA,60 Res.A, Aux. Con. 027514404 1 1

Contactor: 3 Pole, 30FLA,30 Res.A, Aux. Con. 027514402 1 1 1120 Contactor: 3 Pole, 50FLA, 60 Res.A. 027514104 1 1

Contactor: 3 Pole, 30FLA,30 Res.A. 027514102 1 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 4 4 4 4 4





208V 460V 230V 380V & 415V 575V







107 Terminal Block: 3 Pole, 335A, 600V 030372706 1 1 1 1 1DS1- Disconnect Switch Power System


105 PB2 & PB 3 Terminal Block: 3 Pole, 310A, 600V 030372704 2 2PB2 & PB 3 Terminal Block: 3 Pole, 175A, 600V 030372710 2 2 2




114 Circuit Breaker: 3 Pole, 80A, 240V 047359310 1 1115 Circuit Breaker: 3 Pole, 80A, 240V 047359310 1 1 Circuit Breaker: 3 Pole, 100A, 480V 047359332 1 1

Circuit Breaker: 3 Pole, 70A, 600V 047359345 1116 Circuit Breaker: 3 Pole, 80A, 240V 047359312 1 1


1 The disconnect switch p/n does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch’s manufacturer is required to select the correct part number. The G.E. handle is p/n 330419202; The Cutler Hammer handle is p/n 073015201.2 The disconnect switch p/n does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch’s manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419201; The Cutler Hammer handle is p/n 073015201.




208V 460V 230V 380V & 415V 575V

M1-6 Compr. Contactors: Across-The-Line Start117 Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514403 1 1 1 1 1118 Contactor: 3 Pole, 40FLA, 50 Res.A. 027514103 1 1119 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1

Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1120 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1


Contactor: 3 Pole, 30FLA, 30 Res.A, Aux. Con. 027514402 1 1 1118 Contactor: 3 Pole, 40FLA, 50 Res.A. 027514103 1 1

Contactor: 3 Pole, 30FLA, 30 Res.A. 027514102 1 1 1119 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1


Contactor: 3 Pole, 40FLA, 50 Res.A. 027514103 1 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 4 4 4 4 4





208V 460V 230V 380V & 415V 575V








108 Molded Case Switch: 3PST, 240VAC, 400A 072937501 1 1 1Molded Case Switch: 3PST, 600VAC, 150A 047442102 2 1 1Molded Case Switch: 3PST, 600VAC, 100A 047442101 2 1PB1,PB2, PB3- Multipoint Power System

105 PB2 & PB 3Terminal Block: 3 Pole, 310A, 600V 030372704 2 2PB2 & PB 3Terminal Block: 3 Pole, 175A, 600V 030372710 2 2 2







1 The disconnect switch p/n does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419203; The Cutler Hammer handle is p/n 073015203.2 The disconnect switch p/ndoes not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419201; The Cutler Hammer handle is p/n 073015201.




208V 460V 230V 380V & 415V 575V

M1-6 Compr. Contactors: Across-The-Line Start117 Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1 1 1 1 1118 Contactor: 3 Pole, 60FLA, 75 Res.A. 027514105 1 1119 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1



Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514403 1 1Contactor: 3 Pole, 50FLA, 60 Res.A, Aux. Con. 027514404 1

118 Contactor: 3 Pole, 60FLA, 75 Res.A. 027514105 1 1Contactor: 3 Pole, 40FLA, 50 Res.A. 027514103 1 1 1Contactor: 3 Pole, 50FLA, 60 Res.A. 027514104

119 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514403 1 1 1

120 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1Contactor: 3 Pole, 40FLA, 50 Res.A. 027514103 1 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 6 6 6 6 6





208V 460V 230V 380V & 415V 575V


Fuse Block FB7 - FB10: 3 Pole (Speedtrol Units Only) 046500003 4 4 4 4 4Fuse Block FB6 - FB10: 3 Pole (Speedtrol Units Only) 046500003 5 5 5 5 5Fuse F6 - F10 15 Amp 042753122 5 5 5 5T1- Control Transformer Assy.


















208V 460V 230V 380V & 415V 575V

M1-6 Compr. Contactors: Across-The-Line Start117 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1118 Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1119 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1

Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1

120 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1M1-6 Compressor Contactors: Part Winding Start


118 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1 Contactor: 3 Pole, 40FLA, 50 Res.A. 027514103 1 1 1



130 Contactor: 30FLA 041769601 8 8 8 8 8





208V 460V 230V 380V & 415V 575V







107 Terminal Block: 3 Pole, 840A, 600V 030372724 1 1 Terminal Block: 3 Pole, 335A, 600V 030372706 1 1 1DS1- Disconnect Switch Power System













208V 460V 230V 380V & 415V 575V

M1-6 Compr. Contactors: Across-The-Line Start117 Contactor: 3 Pole, 75FLA, 120 Res.A, Aux. Con. 027514407 1

Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1

118 Contactor: 3 Pole, 90FLA, 120 Res.A. 027514107 1Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1

119 Contactor: 3 Pole, 75FLA, 120 Res.A, Aux. Con. 027514407 1Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1

120 Contactor: 3 Pole, 90FLA, 120 Res.A. 027514107 1Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1M1-6 Compressor Contactors: Part Winding Start

117 Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514407 1Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514404 1 1 1

118 Contactor: 3 Pole, 90FLA, 120 Res.A. 027514107 1 1 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1 1

119 Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514407 1Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514404 1 1 1


130 Contactor: 30FLA 041769601 8 8 8 8 8





208V 460V 230V 380V & 415V 575V







107 Terminal Block: 3 Pole, 840A, 600V 030372724 1 1 1 Terminal Block: 3 Pole, 335A, 600V 030372706 1 1

DS1- Disconnect Switch Power System108 Molded Case Switch: 3PST, 240VAC, 400A 072937501 1 1 1

Molded Case Switch: 3PST, 600VAC, 150A 047442104 2 1 1 1PB1,PB2, PB3- Multipoint Power System



CB1-6 Circuit Breakers113 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1

Circuit Breaker: 3 Pole, 150A, 240V 047359314 1 Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1 Circuit Breaker: 3 Pole, 70A, 600V 047359345 1

114 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1 Circuit Breaker: 3 Pole, 150A, 240V 047359314 1Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1 Circuit Breaker: 3 Pole, 70A, 600V 047359345 1

115 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1 Circuit Breaker: 3 Pole, 150A, 240V 047359314 1

Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1 Circuit Breaker: 3 Pole, 70A, 600V 047359345 1


1 The disconnect switch part number does not include the through-the-door mechanism (handle).The installed switch may be either a G.E or a Cutler Hammer.The switches are interchangeable, but the associated handles are not.When replacing a handle, field verification of the switch’s manufacturer is required to select the correct partnumber.The G.E. handle is p/n 330419203;The Cutler Hammer handle is p/n 073015203. 2 The disconnect switch part number does not include the through-the-door mechanism (handle).The installed switch may be either a G.E or a Cutler Hammer.The switches are interchangeable, but the associated handles are not.When replacing a handle, field verification of the switch’s manufacturer is required to select the correct partnumber.The G.E. handle is p/n 330419205;The Cutler Hammer handle is p/n 073015205.




208V 460V 230V 380V & 415V 575V

116 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1 Circuit Breaker: 3 Pole, 150A, 240V 047359314 1Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1 Circuit Breaker: 3 Pole, 70A, 600V 047359345 1M1-6 Compr. Contactors: Across-The-Line Start

117 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1Contactor: 3 Pole, 90FLA, 120 Res.A. 027514407 1 1 1



120 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1Contactor: 3 Pole, 90FLA, 120 Res.A. 027514407 1 1 1M1-6 Compressor Contactors: Part Winding Start




120 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1Contactor: 3 Pole, 90FLA, 120 Res.A. 027514407 1 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 8 8 8 8 8





208V 460V 230V 380V & 415V 575V







107 Terminal Block: 3 Pole, 840A, 600V 030372724 1 1 Terminal Block: 3 Pole, 335A, 600V 030372706 1 1 1


Molded Case Switch: 3PST, 600VAC, 150A 047442104 2 1 1 1PB1,PB2, PB3- Multipoint Power System





114 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1 1Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1Circuit Breaker: 3 Pole, 70A, 600V 047359345 1




1 The disconnect switch part number does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419203; The Cutler Hammer handle is p/n 073015204.2 The disconnect switch part number does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419205; The Cutler Hammer handle is p/n 073015205.




208V 460V 230V 380V & 415V 575V

M1-6 Compr. Contactors: Across-The-Line Start113 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1

Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514407 1 1 1114 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1



Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514407 1 1 1M1-6 Compressor Contactors: Part Winding Start

113 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1 Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514407 1 1 1



116 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1 Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514407 1 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 10 10 10 10 10




FB 5

101

T 1

SeeBelow

FB 6

100

FB 7

100

FB 8

100

FB 9

100

FB 10

100

M11

M12

M14

M22

M24

M21

M13

M23

130typ.

PB 1107

CT 1 CT 3

DS 1108

CT 1 CT 3

or

Note:CT1 and CT3 are used only when a Volt/Amp

Meter Box is used. See the Control Box Volt/Amp Meter Components and Mounting page for trans-

former part numbers

CB 2 CB 6

M 2 M 6

109 110

117

PB1

PB2 PB3105B

105A

106

105

CB 4 CB 8

111 112

CB 2 CB 6

113 114

CB 4 CB 8

115 116

118

M 4 M 8

119 120 121 122 123 124

M 2 M 6 M 4 M 8

102103 104





208V 460V 230V 380V & 415V 575V



101 Fuse Block FB5: 2 Pole, 30A, 600V 070971001 1 1 1 1 1102 Fuse 9.0A KLDR 049759815 2

Fuse 8.0A KLDR 049759814 2Fuse 4.5A KLDR 049759819 2Fuse 5.0A FNQ-R5, 415V 049759811 2 2Fuse 3.5A FNQ-R3.5, 380V 049759820 2





105 PB2 Terminal Block: 3 Pole, 310A, 600V 030372704 1 1PB2 Terminal Block: 3 Pole, 175A, 600V 030372710 1 1 1

105B PB3 Terminal Block: 3 Pole, 310A, 600V 030372704 1 1PB3 Terminal Block: 3 Pole, 175A, 600V 030372710 1 1 1







1 The disconnect switch part number does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct part number. The G.E. handle is p/n 330419203; The Cutler Hammer handle is p/n 073015204. 2 The disconnect switch part number does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct part number. The G.E. handle is p/n 330419203; The Cutler Hammer handle is p/n 073015203.





208V 460V 230V 380V & 415V 575V


Circuit Breaker: 3 Pole, 40A, 600V 047359341 1M1-6 Compr. Contactors: Across-The-Line Start

117 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1

118 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1 119 Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514403 1 1 1 1 1120 Contactor: 3 Pole, 40FLA, 50 Res.A. 027514103 1 1121 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1

Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1122 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1 123 Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514403 1 1 1 1 1124 Contactor: 3 Pole, 40FLA, 50 Res.A. 027514103 1 1



Contactor: 3 Pole, 40FLA, 50 Res.A 027514103 1 1 1119 Contactor: 3 Pole, 50FLA, 60 Res.A, Aux. Con. 027514404 1 1






Contactor: 3 Pole, 30FLA, 30 Res.A. 027514102 1 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 10 10 10 10 10





208V 460V 230V 380V & 415V 575V










105B PB 3 Terminal Block: 3 Pole, 310A, 600V 030372704 1 1PB 3 Terminal Block: 3 Pole, 175A, 600V 030372710 1 1 1







1 The disconnect switch part number does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct part number. The G.E. handle is p/n 330419203; The Cutler Hammer handle is p/n 073015204.2 The disconnect switch part number does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct part number. The G.E. handle is p/n 330419205; The Cutler Hammer handle is p/n 073015205.





208V 460V 230V 380V & 415V 575V



M1-6 Compr. Contactors: Across-The-Line Start117 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1

Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1118 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1 119 Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514403 1 1 1 1 1120 Contactor: 3 Pole, 40FLA, 50 Res.A. 027514103 1 1121 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1

Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1122 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1 123 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1










Contactor: 3 Pole, 40FLA, 50 Res.A 027514103 1 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 10 10 10 10 10





208V 460V 230V 380V & 415V 575V








108 Molded Case Switch: 3PST, 600VAC, 600A 072937503 1 1 1Molded Case Switch: 3PST, 600VAC, 400A 072937502 2 1 1 Molded Case Switch: 3PST, 600VAC, 250A 047442104 3 1PB1,PB2, PB3- Multipoint Power System


105B PB 3Terminal Block: 3 Pole, 310A, 600V 030372704 1 1PB 3Terminal Block: 3 Pole, 175A, 600V 030372710 1 1 1





Circuit Breaker: 3 Pole, 70A, 600V 047359345 1

1 The disconnect switch part number does not include the through-the-door mechanism (handle).The installed switch may be either a G.E or a Cutler Hammer.The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct part number.The G.E. handle is p/n 330419203;The Cutler Hammer handle is p/n 073015204. 2 The disconnect switch part number does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct part number. The G.E. handle is p/n 330419203; The Cutler Hammer handle is p/n 073015203. 3 The disconnect switch part number does not include the through-the-door mechanism (handle).The installed switch may be either a G.E or a Cutler Hammer.The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct part number.The G.E. handle is p/n 330419205;The Cutler Hammer handle is p/n 073015205.





208V 460V 230V 380V & 415V 575V

112 Circuit Breaker: 3 Pole, 100A, 240V 047359312 1 1113 Circuit Breaker: 3 Pole, 80A, 240V 047359310 1 1




M1-6 Compr. Contactors: Across-The-Line Start117 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1 1













Contactor: 3 Pole, 40FLA, 50 Res.A 027514103 1 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 12 12 12 12 12





208V 460V 230V 380V & 415V 575V








108 Molded Case Switch: 3PST, 600VAC, 600A 072937503 1 1 1Molded Case Switch: 3PST, 600VAC, 400A 072937502 2 1 1 1Molded Case Switch: 3PST, 600VAC, 250A 047442104 3 1 1 1PB1,PB2, PB3- Multipoint Power System

105 PB2 Terminal Block: 3 Pole, 420A, 600V 030372713 1 1PB2 Terminal Block: 3 Pole, 310A, 600V 030372704 1 1PB2 Terminal Block: 3 Pole, 175A, 600V 030372710 1

105B PB2 Terminal Block: 3 Pole, 420A, 600V 030372713 1 1 PB2 Terminal Block: 3 Pole, 310A, 600V 030372704 1 1

PB2 Terminal Block: 3 Pole, 175A, 600V 030372710 1105A PB1 Terminal Block: 3 Pole, 95A 030372707 1 1 1 1 1106 Ground Terminal Lug: Single Connection 028798500 1 1 1 1 1



110 Circuit Breaker: 3 Pole, 125A, 240V 047359313 1 1

1 The disconnect switch p/n does not include the through-the-door mechanism (handle).The installed switch may be either a G.E or a Cutler Hammer.The switches are interchangeable, but the associated handles are not.When replacing a handle, field verification of the switch's manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419203;The Cutler Hammer handle is p/n 073015204. 2 The disconnect switch p/n does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the switch's manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419203; The Cutler Hammer handle is p/n 073015203.3 The disconnect switch p/n does not include the through-the-door mechanism (handle).The installed switch may be either a G.E or a Cutler Hammer.The switches are interchangeable, but the associated handles are not.When replacing a handle, field verification of the switch's manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419205;The Cutler Hammer handle is p/n 073015205.





208V 460V 230V 380V & 415V 575V


Circuit Breaker: 3 Pole, 80A, 600V 047359346 1112 Circuit Breaker: 3 Pole, 80A, 240V 047359313 1 1113 Circuit Breaker: 3 Pole, 80A, 240V 047359313 1 1




M1-6 Compr. Contactors: Across-The-Line Start117 Contactor: 3 Pole, 75FLA, 120 Res.A, Aux. Con. 027514407 1

Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1

118 Contactor: 3 Pole, 90FLA, 120 Res.A. 027514107 1 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1

119 Contactor: 3 Pole, 75FLA, 120 Res.A, Aux. Con. 027514407 1 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1 1 1Contactor: 3 Pole, 60FLA, 75 Res.A, Aux. Con. 027514405 1





124 Contactor: 3 Pole, 90FLA, 120 Res.A. 027514107 1 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1M1-6 Compressor Contactors: Part Winding Start

117 Contactor: 3 Pole, 75FLA, 120 Res.A, Aux. Con. 027514407 1 Contactor: 3 Pole, 75FLA, 90 Res.A, Aux. Con. 027514406 1Contactor: 3 Pole, 40FLA, 50 Res.A, Aux. Con. 027514404 1 1 1

118 Contactor: 3 Pole, 90FLA, 120 Res.A. 027514107 1 1 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1






208V 460V 230V 380V & 415V 575V




124 Contactor: 3 Pole, 90FLA, 120 Res.A. 027514107 1 1 Contactor: 3 Pole, 75FLA, 90 Res.A. 027514106 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 12 12 12 12 12






208V 460V 230V 380V & 415V 575V



101 Fuse Block FB5: 2 Pole, 30A, 600V 070971001 1 1 1 1 1102 Fuse 12.0A FNQ 042753121 2

Fuse 6.0A FNQR 049759812 2 2Fuse 10.0A KLDR 049759816 2Fuse 5.0A FNQ-R5 049759811 2

Transformer: 1.00KVA, 208/277/380P, 115/95S 038253915 1 1 (380V)

Transformer: 1.00KVA, 240/480P, 120S 038253906 1 1Transformer: 1.00KVA, 600P, 120/240S 038253929 1Transformer: 1.00 KVA, 208/277/380P, 115/95S 038253927 1 (415V)


107 Terminal Block: 3 Pole, 840A, 600V 030372724 1 1 Terminal Block: 3 Pole, 335A, 600V 030372706 1 1 1PB1,PB2, PB3- Multipoint Power System




DS1- Disconnect Switch Power System108 Molded Case Switch: 3PST, 600VAC, 400A 072937502 1 1 1 1

CB1-6 Circuit Breakers109 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1

Circuit Breaker: 3 Pole, 150A, 240V 047359314 1Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1Circuit Breaker: 3 Pole, 70A, 600V 047359345 1

110 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1Circuit Breaker: 3 Pole, 150A, 240V 047359314 1Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1Circuit Breaker: 3 Pole, 70A, 600V 047359345 1


1 The disconnect switch part number does not include the through-the-door mechanism (handle). The installed switch may be either a G.E or a Cutler Hammer. The switches are interchangeable, but the associated handles are not. When replacing a handle, field verification of the

switch’s manufacturer is required to select the correct p/n. The G.E. handle is p/n 330419203; The Cutler Hammer handle is p/n 073015203.





208V 460V 230V 380V & 415V 575V



114 Circuit Breaker: 3 Pole, 125A, 240V 047359313 1 1115 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1 Circuit Breaker: 3 Pole, 150A, 240V 047359314 1


116 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1 Circuit Breaker: 3 Pole, 150A, 240V 047359314 1

Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1Circuit Breaker: 3 Pole, 70A, 600V 047359345 1M1-6 Compr. Contactors: Across-The-Line Start

117 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514407 1 1





122 Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514107 1Contactor: 3 Pole, 75FLA, 120 Res.A, Aux. Con. 027514106 1


124 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514407 1 1M1-6 Compressor Contactors: Part Winding Start








208V 460V 230V 380V & 415V 575V




124 Contactor: 3 Pole, 120FLA, 120 Res.A, Aux. Con. 072288701 1 1Contactor: 3 Pole, 90FLA, 120 Res.A, Aux. Con. 027514407 1 1 1M11-24 Fan Motor Contactors

130 Contactor: 30FLA 041769601 12 12 12 12 12






208V 460V 230V 380V & 415V 575V






Transformer: 1.00KVA,2 40/480P, 120S 038253906 1 1Transformer: 1.00KVA, 600P, 120/240S 038253929 1Transformer: 1.00 KVA, 208/277/380P, 115/95S 038253927 1 (415V)







Molded Case Switch: 3PST, 600VAC, 400A 072937502 2 1CB1-6 Circuit Breakers








208V 460V 230V 380V & 415V 575V






Circuit Breaker: 3 Pole, 70A, 600V 047359345 1116 Circuit Breaker: 3 Pole, 175A, 240V 047359315 1 1 Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1

Circuit Breaker: 3 Pole, 70A, 600V 047359345 1M1-6 Compr. Contactors: Across-The-Line Start















208V 460V 230V 380V & 415V 575V






130 Contactor: 30FLA 041769601 14 14 14 14 14



Power Panel ComponentsALR 195C/205C



208V 460V 230V 380V & 415V 575V






Transformer: 1.00KVA,2 40/480P, 120S 038253906 1 1Transformer: 1.00KVA, 600P, 120/240S 038253929 1Transformer: 1.00 KVA, 208/277/380P, 115/95S 038253927 1 (415V)







Molded Case Switch: 3PST, 600VAC, 150A 072937502 2 1 1 1CB1-6 Circuit Breakers




Circuit Breaker: 3 Pole, 70A, 600V 047359345 1



Power Panel ComponentsALR 195C/205C Continued



208V 460V 230V 380V & 415V 575V





Circuit Breaker: 3 Pole, 80A, 480V 047359330 1 1Circuit Breaker: 3 Pole, 70A, 600V 047359345 1M1-6 Compr. Contactors: Across-The-Line Start



















208V 460V 230V 380V & 415V 575V


130 Contactor: 30FLA 041769601 14 14 14 14 14

Power Panel ComponentsALR 195C/205C Continued


On/Off Switch

Off

On

480

Looking at the Left Hand Side

of the Box from the Outside

Ref# Description Part Number480 On/Off Switch- 047659301 Rocker Type

Signal Converter Transformer and Resistors(MicroTech Units Only)

980

986987 Located in the Power Panel

next to the Main Power Block(s) or Disconnect Switch

Ref# Description Part Number980 Control Transformer 065499909986 Resistor- 15 OHM 735003223987 Insulation 070729101

Alarm Bell Assembly

Side View

Con

trol

Box

390391

Ref# Description Part Number390 Alarm Bell w/ Mounting Plate 017809400391 Screw (2) 038990701

Power Panel Components


Control Box Top

4 5

7

Power Blockor Disconnect Switch

CT1 CT3

9

Volt/Amp Meter Box

Control Box Power Panel Transformers

ALR 040C - 095C460V UnitsComplete Amp/Volt Meter Ass'y --------------070171601Ref # Description ---------------------------- Part Number 4 Amp Meter Only- 400A -----------------735006403 5 Amp Meter Only- 400A ----------------735006403 7 Rotary Switch -----------------------------735003923 9 Transformers (2) ------------------------735076505

208/230V UnitsComplete Amp/Volt Meter Ass'y --------------070171602Ref # Description ---------------------------- Part Number 4 Amp Meter Only- 400A -----------------735006403 5 Amp Meter Only- 200A ----------------735006405 7 Rotary Switch -----------------------------735003923 9 Transformers (2) ------------------------735076502

ALR 105C - 205C460V UnitsComplete Amp/Volt Meter Ass'y --------------070171612Ref # Description ---------------------------- Part Number 4 Amp Meter Only- 400A -----------------735006403 5 Amp Meter Only- 400A ----------------735006403 7 Rotary Switch -----------------------------735003923 9 Transformers (2) ------------------------735076511

208/230V UnitsComplete Amp/Volt Meter Ass'y -------------- 070171611Ref # Description ---------------------------- Part Number 4 Amp Meter Only- 400A -----------------735006403 5 Amp Meter Only- 200A ----------------735006405 7 Rotary Switch -----------------------------735003923 9 Transformers (2) ------------------------735076511

Control Panel ComponentsVolt/Amp Meter Mounting Location and Components

ALR 040C - 205C


FS1

1

OP1

2

TC13

3

TC11

6

TD9

9

R 21

8

R 13Or

7

Main Capacity Controller-

See Chart of Capacity Controllers at the end of Electromechanical Control

Components Section

TD110

TD5 11

R312 TD55 13

S115PS1

16

F1

F2

Control Panel ComponentsALR 022C - 035CPanel Diagram

1417


Ref # SchematicSymbol Part Description Part Number

1 FS1 Freezestat (until 5/93) 001354800FS1 Freezestat (5/93 & later) 071944601

2 OP1 Oil Pressure Control 0013549003 TC13 Thermostat- Fantrol 0326399006 TC11 Thermostat- Hi-Water Return Unloader 0237964067 R13 Relay- Low Ambient Start 1PDT 0325081018 R21 Relay- High Ambient & Hi Return Water Unloader 0325081019 TD9 Time Delay- Low Ambient 032358500

10 TD1 Time Delay- Compressor Lockout SPST 02821010811 TD5 Time Delay- Compressor Part Winding SPST 02821010112 R3 Relay- Limited Pumpdown 03250810113 TD55 Time Delay- Limited Pumpdown 02821013214 PS1 Pumpdown Switch 00135500015 S1 Control Stop Switch 02378030116 F1 Fuse- 10A Control Circuit 01896140017 F2 10A Control Circuit 018961400N/S SC11 Pressure Control- Speedtrol Option 048445202N/S HP1 High Pressure Control (Normally Closed) 047356107

HP1 High Pressure Control (Normally Open) 047356102N/S LP1 Low Pressure Control 047356103N/S C11 Capacitor- Speedtrol 30 MFD 037516429N/S PC5 Pressure Control- High Ambient Unloading 047356104N/S PC12 Pressure Control- Fantrol 047356101N/S TD4 Time Delay, 5 minute, 115V (until approx. 1993) 028210108

TD4 Time Delay, 5 minute, 115 (1993 & later) 735005944

Control Panel ComponentsALR 022C - 035C


RL RL

1

Wireway


See Chart of Capacity Controllers at the end of Electromechanical Control Components Section

TD1112

TB4 (110-124) (210-224)28

S2 PS1RS1TD1

1315 16

14

R5

R9

R1

TB5 (40 - 63)27

3

2 8TD17

R13 5

R21 6

9TD15

TD 9 10

TD 5 114

R3 7

PC 717

FS 123

OP 124

TC 1325

TC 1426

SC 11 20

Control Panel ComponentsElectromechanical Control Panel Diagram- Left Side

ALR 040C - 095C



1 RL White Indicator Lights: 125V,.33W (2 of 4) 0165083042 R5 Relay 3PDT- Safety 0308114003 R9 Relay 3PDT- Starting 0308114004 R1 Relay 2PDT- Alarm Bell 0165080025 R13 Relay 1PDT- Low Ambient 0325081016 R21 Relay 1PDT- Unloading 0262130007 R3 Relay 1PDT- Capacity Control 0325081018 TD17 Time Delay 20 sec.- Heat Recovery 0282101069 TD15 Time Delay 60 sec.- Freezestat 02821011410 TD9 Time Delay 165 sec.- Low Ambient 03235850011 TD5 Time Delay 1 sec.- Part Winding 02821010112 TD11 Time Delay 20 sec.- Compressor Sequencing 02821010613 TD1 Time Delay adjustable- Compressor Lockout 02821011514 S2 Lead Lag Switch 01918730015 RS1 Control Reset Switch 04735730316 PS1 Pumpdown Switch 00135500017 PC7 Pressure Control- Suction Unloader 020321700N/S PC12 Pressure Control- Fantrol 047356101N/S PC5 Pressure Control- High Ambient Unloader 047356104N/S SC11 Pressure Control- Speedtrol * 048445202N/S HP1 High Pressure Control 047356102N/S LP1 Low Pressure Control 04735610323 FS1 Freezestat (before 1988) 047356105 FS1 Freezestat (1988 and Later) **

24 OP1 Oil Pressure Control 04735760325 TC13 Thermostat- Fantrol 04176350026 TC14 Thermostat- Fantrol 04176350028 TB4 Terminal Block 022431230

N/S Optional Indicator Light Alarm Panel Red Light (Qty. 9) 016508303 White Light (Qty. 1) 016508304

Control Panel ComponentsElectromechanical Control Panel Components- Left Side

ALR 040C - 095C

* Speedtrol Control: If unit was built prior to May 1, 1989 (serial number 5UE00001) the speedtrol control was different and requires a retrofit. Please contact Daikin for wiring and installation information. In addition to the Pressure Control shown above, the retrofit will also require Transformer T10, part number: 046738109 for voltage 208-230; pn 046738103 for voltage 460; and pn 046738104 for voltage 575. ** The freezestat p/n 04356109 is no longer available. It is replaced using a retrofit kit p/n 330331701K which includes control p/n 330331701 and the mounting parts and instructions for the retrofit.N/S= Not Shown.


RL RL

3131

Wireway

PS245

R6

R10

R2

TB6 (70- 93)61

33

32 39TD18

R14 35

R22 36

40TD16

41

TD 6 4234

TD 10

R 1938

TD19 43

TB2 (1 - 16) TB3 (17 - 28)63

62

NB

T2PVM

6567

TD244RS2

46

68

F147

S1

69

F248

S5

R4 37

PC 849

FS 256

OP 255

TC 2357

TC 2458

TC 11

59

6460

Reset Control RRM

See Chart of Capacity Controllers at the end of

Electromechanical Control Components Section

Control Panel ComponentsElectromechanical Control Panel Diagram- Right Side

ALR 040C - 095C

T3 66



31 RL White Indicator Lights: 125V,.33W (2 of 4) 01650830432 R6 Relay 3PDT- Safety 03081140033 R10 Relay 3PDT- Starting 03081140034 R2 Relay 2PDT- Alarm Bell 01650800235 R14 Relay 1PDT- Low Ambient 03250810136 R22 Relay 1PDT- Unloading 02621300037 R4 Relay 1PDT- Capacity Control 03250810138 R19 Relay 2PDT- Heat Recovery 01650800239 TD18 Time Delay 20 sec.- Heat Recovery 02821010640 TD16 Time Delay 60 sec.- Freezestat 02821011441 TD10 Time Delay 165 sec.- Low Ambient 03235850042 TD6 Time Delay 1 sec.- Part Winding 02821010143 TD19 Time Delay 300 sec.- Heat Recovery 02821010644 TD2 Time Delay adjustable- Compressor Lockout 02821011545 PS2 Pumpdown Switch 00135500046 RS2 Control Reset Switch 04735730347 S1 Control Stop Switch 02378030148 S5 Heat Recovery Switch 00135500049 PC8 Pressure Control- Suction Unloader 020321700N/S PC22 Pressure Control- Fantrol* 047356101N/S PC6 Pressure Control- High Ambient Unloader 047356104N/S SC21 Pressure Control- Speedtrol * 048445202N/S HP2 High Pressure Control 047356102N/S LP2 Low Pressure Control 04735610355 OP2 Oil Pressure Control 04735760356 FS2 Freezestat (until 1988) 047356105

FS2 Freezestat (1988 & later) **57 TC23 Thermostat- Fantrol 04176350058 TC24 Thermostat- Fantrol 04176350059 TC11 Thermostat- High Water Return 02379640660 NB Neutral Block: 12 pole 03753070061 TB6 Terminal Block- 24 Terminals 01599812462 TB2 Terminal Block- 16 Terminals 02243121663 TB3 Terminal Block- 14 Terminals 02243121464 Transformer Ground Screw 03899090265 T2 Control Transformer 03041000066 T3 Speedtrol Transformer- Pre 1989 Control *

230/460V 037533605 380/415V 037533625 575V 037533619

Control Panel ComponentsElectromechanical Control Panel Components- Right Side

ALR 040C - 095C

* Speedtrol Control: If unit was built prior to May 1, 1989 (serial number 5UE00001) the speedtrol control was different and requires a retrofit. Please contact Daikin for wiring and installation information. In addition to the Pressure Control shown above, the retrofit will also require Transformer T10, part number: 046738109 ** The freezestat p/n 04356109 is no longer available. It is replaced using a retrofit kit p/n 330331701K which includes control p/n 330331701 and the mounting parts and instructions for the retrofit.N/S= Not Shown.



67 PVM Phase Voltage Monitor:Under Voltage Protection- 208/230V 070269951Under Voltage Protection- 460V 070269953Under Voltage Protection- 575V 070269960Under Voltage Protection- 380/415V 070269955Over and Under Voltage Protection- 208/230V 070269925Over and Under Voltage Protection- 460V 070269926Over and Under Voltage Protection- 380/415V 070269927Over and Under Voltage Protection w/LED Lights- 208/230V 070269963Over and Under Voltage Protection w/LED Lights- 460V 070269965Over and Under Voltage Protection w/LED Lights- 575V 070269966

68 F1 Fuse- Control Circuit 10A 01896140069 F2 Fuse- Cooler Heater 10A 018961400N/S Fuse Holder 018690600N/S Optional Indicator Light Alarm Panel

Red Light (Qty. 9) 016508303White Light (Qty. 1) 016508304


ALR 040C - 095C Continued


RL RL

1

Wireway


See Chart of Capacity Controllers at the end of Electromechanical Control Components Section

TD1112

TB4 (110-124) (210-224)28

S2 PS1RS1TD1 13 15 1614

R5

R9

R1

TB5 (40 - 63)

3

2 8TD17

R13 5

R21 6

9TD15

TD 9 10

TD 5 114

R3 7

PC 717

18PC 12

PC 519

FS 123 TC 13

25TC 14

26

LP 122

HP 121

LP 3

HP 3OP 1

OP 324

R11 3A

TD7 11A

TD3

SC 11 20

Control Panel ComponentsElectromechanical Control Panel Diagram- Left Side

ALR 105C - 205C

TD12 TD1312A

27



1 RL White Indicator Lights: 125V,.33W (2 of 4) 0165083042 R5-8 Relay 3PDT- Safety 0308114003 R9-12 Relay 3PDT- Starting 030811400

3A R11 Relay 3PDT- Starting 0308114004 R1, 2 Relay 2PDT- Alarm Bell 0165080025 R13, 14 Relay 1PDT- Low Ambient 0325081016 R21 Relay 1PDT- Unloading 0262130007 R3, 4 Relay 1PDT- Capacity Control 0325081018 TD17, 18 Time Delay 20 sec.- Heat Recovery 0282101069 TD15, 16 Time Delay 60 sec.- Freezestat 02821011410 TD9, 10 Time Delay 165 sec.- Low Ambient 03235850011 TD5, 6 Time Delay 1 sec.- Part Winding 028210101

11A TD7, 8 Time Delay 1 sec.- Part Winding 02821010112 TD11 Time Delay 20 sec.- Compressor Sequencing 028210106

12A TD12, 13 Time Delay 20 sec.- Compressor Sequencing 02821010713 TD1-4 Time Delay adjustable- Compressor Lockout 02821011514 S2 Lead Lag Switch 01918730015 RS1 Control Reset Switch 04735730316 PS1 Pumpdown Switch 00135500017 PC7 Pressure Control- Suction Unloader 020321700N/S PC12 Pressure Control- Fantrol 047356101N/S PC5 Pressure Control- High Ambient Unloader 047356104N/S SC11 Pressure Control- Speedtrol * 048445202N/S HP1, HP3 High Pressure Control 047356102N/S LP1, LP3 Low Pressure Control 04735610323 FS1 Freezestat (before 1988) 047356105 FS1 Freezestat (1988 and Later) **24 OP1, OP3 Oil Pressure Control 04735760325 TC13 Thermostat- Fantrol 04176350026 TC14 Thermostat- Fantrol 04176350028 TB4 Terminal Block 022431230

N/S Optional Indicator Light Alarm PanelRed Light (Qty. 9) 016508303White Light (Qty. 1) 016508304

Control Panel ComponentsElectromechanical Control Panel Components- Left Side

ALR 105C - 205C

* Speedtrol Control: If unit was built prior to May 1, 1989 (serial number 5UE00001) the speedtrol control was different and requires a retrofit. Please contact Daikin for wiring and installation information. In addition to the Pressure Control shown above, the retrofit will also require Transformer T10, part number: 046738109 for voltage 208-230; pn 046738103 for voltage 460; and pn 046738104 for voltage 575. ** The freezestat p/n 04356109 is no longer available. It is replaced using a retrofit kit p/n 330331701K which includes control p/n 330331701 and the mounting parts and instructions for the retrofit.N/S= Not Shown.


RL RL

3131

Wireway

PS245

R6

R10

R2

TB6 (70- 93)61

33

32 39TD18

R14 35

R22 36

40TD16

41

TD 6 4234

TD 10

R 1938

TD19 43

TB2 (1 - 16) TB3 (17 - 28)63

62

NB

T2PVM

6567

RS246

68

F147

S1

69

F248

S5

R4 37

PC 849

50PC 22

PC 651

FS 256 TC 23

66

T3

6460

Reset Control RRM

See Chart of Capacity Controllers at the end of

Electromechanical Control Components Section

57

TC 2458

TC 11

LP 254

HP 253

LP 4

HP 4OP 2

OP 455

59

R12 33A

TD8 42A

SC 21 52

TD244

TD4

Control Panel ComponentsElectromechanical Control Panel Diagram- Right Side

ALR 105C - 205C



31 RL White Indicator Lights: 125V,.33W (2 of 4) 01650830432 R6 Relay 3PDT- Safety 03081140033 R10 Relay 3PDT- Starting 030811400

33A R12 Relay 3PDT- Starting 03081140034 R2 Relay 2PDT- Alarm Bell 01650800235 R14 Relay 1PDT- Low Ambient 03250810136 R22 Relay 1PDT- Unloading 02621300037 R4 Relay 1PDT- Capacity Control 03250810138 R19 Relay 2PDT- Heat Recovery 01650800239 TD18 Time Delay 20 sec.- Heat Recovery 02821010640 TD16 Time Delay 60 sec.- Freezestat 02821011441 TD10 Time Delay 165 sec.- Low Ambient 03235850042 TD6 Time Delay 1 sec.- Part Winding 028210101

42A TD8 Time Delay 1 sec.- Part Winding 02821010143 TD19 Time Delay 300 sec.- Heat Recovery 02821010644 TD2, TD4 Time Delay adjustable- Compressor Lockout 02821011545 PS2 Pumpdown Switch 00135500046 RS2 Control Reset Switch 04735730347 S1 Control Stop Switch 02378030148 S5 Heat Recovery Switch 00135500049 PC8 Pressure Control- Suction Unloader 02032170050 PC22 Pressure Control- Fantrol* 04735610151 PC6 Pressure Control- High Ambient Unloader 04735610452 SC21 Pressure Control- Speedtrol * 04844520253 HP2, HP4 High Pressure Control 04735610254 LP2, LP4 Low Pressure Control 04735610355 OP2, OP4 Oil Pressure Control 04735760356 FS2 Freezestat (until 1988) 047356105

FS2 Freezestat (1988 & later) **57 TC23 Thermostat- Fantrol 04176350058 TC24 Thermostat- Fantrol 04176350059 TC11 Thermostat- High Water Return 02379640660 NB Neutral Block: 12 pole 03753070061 TB6 Terminal Block- 24 Terminals 01599812462 TB2 Terminal Block- 16 Terminals 02243121663 TB3 Terminal Block- 14 Terminals 02243121464 Transformer Ground Screw 03899090265 T2 Control Transformer 030410000


ALR 105C - 205C

* Speedtrol Control: If unit was built prior to May 1, 1989 (serial number 5UE00001) the speedtrol control was different and requires a retrofit. Please contact Daikin for wiring and installation information. In addition to the Pressure Control shown above, the retrofit will also require Transformer T10, part number: 046738109 ** The freezestat p/n 04356109 is no longer available. It is replaced using a retrofit kit p/n 330331701K which includes control p/n 330331701 and the mounting parts and instructions for the retrofit.N/S= Not Shown.



66 T3 Speedtrol Transformer- Pre 1989 Control *230/460V 037533605380/415V 037533625575V 037533619

67 PVM Phase Voltage Monitor:Under Voltage Protection- 208/230V 070269951Under Voltage Protection- 460V 070269953Under Voltage Protection- 575V 070269960Under Voltage Protection- 380/415V 070269955Over and Under Voltage Protection- 208/230V 070269925Over and Under Voltage Protection- 460V 070269926Over and Under Voltage Protection- 380/415V 070269927Over and Under Voltage Protection w/LED Lights- 208/230V 070269963Over and Under Voltage Protection w/LED Lights- 460V 070269965Over and Under Voltage Protection w/LED Lights- 575V 070269966

68 F1 Fuse- Control Circuit 10A 01896140069 F2 Fuse- Cooler Heater 10A 018961400N/S Fuse Holder 018690600N/S Optional Indicator Light Alarm Panel

Red Light (Qty. 9) 016508303White Light (Qty. 1) 016508304




650Control Sensor047441505

651Paste- (placed in Bulbwell before installation)735026315

652Sensor Well047441506651

652

650

Conduit

To CP1/CP2

Barber ColemanCP1, CP2, RRM

Left Side of Control BoxCP1 = Main Controller

CP2 = Satellite Controller(Used In 6 & 8 Stage

Applications)

CP1

R23 R24

4 Stage UnitsCP1 = 070312501Screws for Mounting: (4) 038990808Washers for Mtg: (4) 041542302

6 Stage UnitsCP1 = 070312501 CP2 = 047441502 Screws for Mounting: (8) 038990808Washers for Mtg: (8) 041542302

8 Stage UnitsCP1 = 070312501 CP2 = 047441503 Screws for Mounting: (8) 038990808Washers for Mtg: (8) 041542302

Remote Reset ModuleRRM = 047441510

Sensor Placement:ALR Control- insertedin evaporator nozzle.

CP2

Control Panel ComponentsElectromechanical Control Panel Components- Main Capacity Controllers


RRM

Right Side of Control BoxRRM = Remote Reset

Module(used with outside air

reset only)Relays= R23/R24


Honeywell- W7100LWC1, LWS1

LWC1

4 Stage Units

LWC1

4 Stage Units

LWC1LWS1

8 Stage Units

R23 R24

All Units

650Control Sensor-with 15 ft., 22 awg. cable 048442402Control Sensor-with 30 ft., 18 awg. cable048442405


652Sensor Well-070792601

4 Stage UnitsLWC1 = 048442401402 OHM Resistor: 044690101Screws for Mounting: (4) 038993407Bracket for Mtg: (1) 055150501Screw for Bracket: (4) 039990703

6 Stage UnitsLWC1 = 048442401Screws for Mounting: (4) 038993407Bracket for Mtg: (1) 055150501Screw for Bracket: (4) 039990703

8 Stage UnitsLWC1 = 048442401LWS1 = 042226900806 OHM Resistor: 044690108Screws for Mounting: (8) 038993407Bracket for Mtg: (2) 055150501Screw for Bracket: (8) 039990703

Relays- Unloader Control: 1PDTR23/R24 = 032508101

Miscellaneous W7100 Notes:1.Sensor is inserted in the Evaporator Leaving Water Nozzle

2. Put paste in bulbwell before inserting sensor.

3.When the W7100 is used the control panel dead door is mounted differently. It is dished in so that the sensor may be read through the door's latch hole.

4.Relays R23, and R24 are optional.

651

652

650

Conduit

To LWC




Johnson Controls- UNTCP1

Left Side of Control BoxLWC1 = Main Controller

CP1

R23 R24

2 & 4 Stage UnitsCP1 = 070312501

3 & 8 Stage UnitsS350 = 070312601

Relays-Unloader Control: 1PDTR23/R24 = 032508101

S350

650Control Sensor070312401


652Sensor Well047441506

651

652

650

Conduit

To LWS



Johnson 350 Controller# 065497809

Sensor# 065497807

Field Replacement of Honeywell W7100retrofitting to use the Johnson Controls- UNT

2 & 4 & 6 Stage UnitsKit = 057107307*(individulal control- pn: 070312101)

6 & 8 Stage UnitsKit = 057107308*(individual control LWC1- pn: 070312201)(individual control LWS1- pn: 070312301)

* Note: The kits will work with the existing sensor.


MHP1

Wireway

T4

TB4237

970

971

972

974

976902

904

NB 243

Replacement Fuses

346

TD5MHPR1

MPR1

R9

215

TB2231

Wireway

TB3 233

911

912

TB5235260

325OP1

920

905

326

906

Control Panel ComponentsMicroTech Control Panel Diagram- Left Side

ALR 040C - 095C



215 T4 Transformer- Control 046738114231 TB2 Terminal Block- 16 Terminals 022431216233 TB3 Terminal Block- 14 Terminals 022431214235 TB5 Terminal Block- 24 Terminals 022431224237 TB4 Terminal Block- 30 Terminals 022431230243 NB Neutral Block 037530700260 MHPR1, MPR1, R9 Relay- 1PDT (Qty= 3) 032508101325 OP1 Oil Pressure Control 001354900326 MHP1 High Pressure Control 047932301346 TD5 Time Delay- 1 Sec. Part Winding 028210101902 MCB1 MicroTech Controller M250 (must be programmed) 065487306

Input Power Fuse, 2A 065822001Comm. Port Fuse, .25A 065821901

904 ADI ADI Board 065816001905 Ribbon Cable 065499704906 34 Conductor Ribbon Cable (Qty= 2) 049265102911 Circuit Breaker Mounting Bracket 070745601912 CB Circuit Breaker 735073301920 Cable Clip (6) 049766201970 Modem- 14.4 Baud 063585005971 Modem Interface Cable 073372702972 Gasket 070199207974 Modem Bracket 073043505976 Modem Bracket- Vertical 073014701N/S Alarm Bell (Mounted on Outside of Control Box) 017809400

Control Panel ComponentsMicroTech Control Panel Components- Left Side

ALR 040C - 095C

N/S= Not Shown.


Wireway

TB7231 TB8 233

T2

213

326

MHP2

900

901 j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

346

TD6MHPR2

MPR2

R10

TB6260

SC

990

356

PVM

235907

325OP2

Wireway

Control Panel ComponentsMicroTech Control Panel Diagram- Right Side

ALR 040C - 095C



213 T2 Transformer- Control 060630801231 TB7 Terminal Block- 16 Terminals 022431216233 TB8 Terminal Block- 14 Terminals 022431214235 TB6 Terminal Block- 24 Terminals 022431224260 MHPR2, MPR2, R10 Relay- 1PDT 032508101325 OP2 Oil Pressure Control 001354900326 MHP2 High Pressure Control 047932301346 TD6 Time Delay- 1 Sec. Part Winding 028210101356 PVM Phase Voltage Monitor:

Under Voltage Protection- 208/230V 070269951Under Voltage Protection- 460V 070269953Under Voltage Protection- 575V 070269960Under Voltage Protection- 380/415V 070269955Over and Under Voltage Protection- 208/230V 070269925Over and Under Voltage Protection- 460V 070269926Over and Under Voltage Protection- 380/415V 070269927Over and Under Voltage Protection w/LED Lights- 208/230V 070269963

Over and Under Voltage Protection w/LED Lights- 460V 070269965Over and Under Voltage Protection w/LED Lights- 575V 070269966

900 Output Board 049265501Output Board Fuse, 5A 066402901

901 Output Board RelaysWater-Cooled Units4 Stages Cooling/Heating-Qty. 8 0492656016 Stages Cooling/Heating-Qty. 10 049265601Remote Condenser Units4 Stages Cooling/Heating-Qty. 14 0492656016 Stages Cooling/Heating-Qty. 16 049265601

907 Ribbon Cable- Output Board 049265201990 SC Signal Converter 049264901

Control Panel ComponentsMicroTech Control Panel Components- Right Side

ALR 040C - 095C


392391211212

391 392

952

959

955956960954

959

952

Control Panel ComponentsMicroTech Control Panel Diagram- Start Counters, Hour Meters, Keypad

ALR 040C - 095C


211 Fuse Holder 018690600212 F1 Fuse- Control Circuit 10A 018961400391 Start Counter (2) 735073204392 Hour Meter (2) 047930201952 Hinge- Keypad (2) 032457700954 Bracket- Keypad 071742103955 Label- Keypad 071742502956 Keypad Display 065497202959 Switch- 125V (3) 071995301960 Lamp- Red LED 065810801


243

T4

TB5235

215

TB2 TB3 233

TB4237

MHP1

326

MHP3

Wireway

911

912

970

971

972

974

976902

904

920

905

325OP1

325OP3

Wireway

MHPR1

MPR1 TD5 TD7

346

260

NB

231

Fuse P/N Check Voltage Device

MHPR3

MPR3

R9

906

Control Panel ComponentsMicroTech Control Panel Diagram- Left Side

ALR 105C - 205C



215 T4 Transformer- Control 046738114231 TB2 Terminal Block- 16 Terminals 022431216233 TB3 Terminal Block- 14 Terminals 022431214235 TB5 Terminal Block- 24 Terminals 022431224237 TB4 Terminal Block- 30 Terminals 022431230243 NB Neutral Block 037530700

260MHPR1, MPR1, R9

MHPR3, MPR3Relay- 1PDT (Qty= 5) 032508101

325 OP1, OP3 Oil Pressure Control (2) 001354900326 MHP1, MHP3 High Pressure Control (2) 047932301346 TD5, TD7 Time Delay- 1 Sec. Part Winding (2) 028210101902 MCB1 MicroTech Controller M250 (must be programmed) 065487306

Input Power Fuse, 2A 065822001Comm. Port Fuse, .25A 065821901

904 ADI ADI Board 065816001905 Ribbon Cable 065499704906 34 Conductor Ribbon Cable (Qty= 2) 049265102911 Circuit Breaker Mounting Bracket 070745601912 CB Circuit Breaker 735073301920 Cable Clip (6) 049766201970 Modem- 14.4 Baud 063585005971 Modem Interface Cable 073372702972 Gasket 070199207974 Modem Bracket 073043505976 Modem Bracket- Vertical 073014701N/S Alarm Bell (Mounted on Outside of Control Box) 017809400

Control Panel ComponentsMicroTech Control Panel Components- Left Side

ALR 105C - 205C

N/S= Not Shown.


SC

990

356

PVM

Wireway

TB6 235

Wireway

OP2325

OP4325

MHP2

326

MHP4

T2

213

TD8

346

TD6

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

TB7231 TB8 233

907

R10MHP4

MHPR4

MHP2

MHPR2

900

901

228

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

j;cxvjjdskgj

260

260

Control Panel ComponentsMicroTech Control Panel Diagram- Right Side

ALR 105C - 205C



213 T2 Transformer- Control 060630801231 TB7 Terminal Block- 16 Terminals 022431216233 TB8 Terminal Block- 14 Terminals 022431214235 TB6 Terminal Block- 24 Terminals 022431224

260MHPR2, MPR2, R10, MHPR4,

MPR4Relay- 1PDT (Qty= 5) 032508101

325 OP2, OP4 Oil Pressure Control (Qty= 2) 001354900326 MHP2, MHP4 High Pressure Control (2) 047932301346 TD6, TD8 Time Delay- 1 Sec. Part Winding (2) 028210101356 PVM Phase Voltage Monitor:

Under Voltage Protection- 208/230V 070269951Under Voltage Protection- 460V 070269953Under Voltage Protection- 575V 070269960Under Voltage Protection- 380/415V 070269955Over and Under Voltage Protection- 208/230V 070269925Over and Under Voltage Protection- 460V 070269926Over and Under Voltage Protection- 380/415V 070269927Over and Under Voltage Protection w/LED Lights- 208/230V 070269963Over and Under Voltage Protection w/LED Lights- 460V 070269965Over and Under Voltage Protection w/LED Lights- 575V 070269966

900 Output Board 049265501Output Board Fuse, 5A 066402901

901 Output Board Relays Water-Cooled Units 4 Stages Cooling/Heating-Qty. 8 049265601 Water-Cooled Units 6 Stages Cooling/Heating-Qty. 10 049265601 Remote Condenser Units 4 Stages Cooling/Heating-Qty. 14 049265601 Remote Condenser Units 6 Stages Cooling/Heating-Qty. 16 049265601

907 Ribbon Cable- Output Board 049265201990 SC Signal Converter 049264901

Control Panel ComponentsMicroTech Control Panel Components- Right Side

ALR 105C - 205C



211 Fuse Holder 018690600212 F1 Fuse- Control Circuit 10A 018961400391 Start Counter (4) 735073204392 Hour Meter (4) 047930201952 Hinge- Keypad (2) 032457700954 Bracket- Keypad 071742103955 Label- Keypad 071742502956 Keypad Display 065497202959 Switch- 125V (3) 071995301960 Lamp- Red LED 065810801

211212

391392

392391

391392

392391

952

959

955956960954

959

952

Control Panel ComponentsMicroTech Control Panel Diagram- Start Counters, Hour Meters, Keypad

ALR 105C - 205C


Part Description Part NumberPower Assembly 4-Pin Housing 049264502Power Assembly Female Pin 049264702

Control Assembly 6-Pin Housing 049264501Control Assembly Female Pin 049264702

Terminal Block, 9 Pole (ADI-DH2, J13, ADI-AH3) 065499909Terminal Block Cover, 9 Pole (ADI-DH2, J13, ADI-AH3) 065500009

Keypad Terminal Block, 2 Pole Locking 065488802Keypad Terminal Block Cover 065500002

High Pressure Transducer 350105401Low Pressure Transducer 350105301

Pressure Transducer Cable, 10’ (ADI-DH1, ADI-AH2) 074667501Pressure Transducer Cable, 15’ 074667502Pressure Transducer Cable, 20’ 074667503

Sensor with 20’ Cable (ADI-AH3, ADI-AH4) (Leaving Water) 073012002

Control Panel ComponentsMicroTech Control Panel Cables & Sensors

ALR 040C- 205C

Sensor Use Qty Well Part NumberWater 2 070809045Refrigerant 4 070228901 (Sensor Tube- No well used)Air 1 047441506Control 1 047441506

MicroTech Control Panel Sensor Wells


Gauges

414

416

414A

414

413

TYP.

Circuit 1 Circuit 2

Ref # Part Description Qty Part Number413 High Pressure Gauge, 0-800 PSI 2 040159300414 Low Pressure Gauge, -30.0” og Hg./ +150 PSI 2 017503500414A Oil Pressure Gauge, -30.0” og Hg./ +150 PSI 2 017503500415 Gauge Mounting Bracket 6 046742701416 Shut Off Valve- Wheel Operated 6 046742601

ALR 040C - 095C

Ref # Part Description Qty Part Number413 High Pressure Gauge, 0-800 PSI 2 040159300414 Low Pressure Gauge, -30.0” og Hg./ +150 PSI 2 017503500414A Oil Pressure Gauge, -30.0” og Hg./ +150 PSI 4 017503500415 Gauge Mounting Bracket 8 046742701416 Shut Off Valve- Wheel Operated 8 046742601

ALR 105C - 205C

Unit Size Kit NumberALR 040C 070769404ALR 050 - 065C 070769405ALR085 - 095C 070769406ALR105 - 145C 070769407ALR155 - 205C 070769408

Complete Gauge Kits

414A

413415TYP.


Condenser Fan SectionALR 010C - 018C

738

Ref # Part Description Qty Part Number658 Guard/Fan Enclosure 1 055492001700 Fan Motor, Standard- .5 HP 1 ph. (208/575V) 1 049267001

Fan Motor, Standard- .5 HP 1 ph. (460V) 1 049268701701 Fan Motor, Standard- .5 HP 1 ph. (208/575V) 1 049267001

Fan Motor, Standard- .5 HP 1 ph. (460V) 1 049268701704 Motor Mount 2 049266401708 Fan- 24” 2 048446003727 Nut 10-32 8 040499904726 Screw 5/16-18 X 1 8 040499039728 Washer, Flat- No. 10” 8 040500303729 Washer, Flat- 3/8” 8 040500308730 Washer- External Tooth 8 040500206738 Cap Plug 8 000121500

ALR 010C - 018C



707

700 701

708

731 733683

704710

709 705

Air

Flow

Control Box

Speedtrol Motors placed here(typical of all units 022 and up)


Ref # Part Description Qty Part Number683 Guard/Fan Enclosure ALR 022C- 035C 1 055356301

ALR 040C- 205C 1 058055401704 Motor Support

ALR 022C- 035C 2 037867400ALR 040C- 205C 2 046743101

705 Screw 5/16-18 X 2 4 040499035707 Slinger 1 027471200708 Fan- 26” ALR 022C- 035C 1 350075701 ** ALR 040C- 205C 1 043219300709 Washer 4 040500210710 Nut, 5/16-18 4 040499904731 Nut, 5/16-18 4 040499904733 Washer, Flat 5/16 4 040500307N/S Grille 1 047359201


** Effective 1990, this 4-blade Fan is a direct replacement for the original style Fan which was 3 or 4-blade.

Fan Components (Quantities are per fan)

Ref # Part Description Part Number700 Speedtrol Motor, 1 HP Franklin (until 1992) 034914500

Emerson (after 1992) 070989600 *Standard MotorOpen Drip- 1 HP 043219400Open Drip -1 HP, 575V C081

Optional Motor- Totally Enclosed460V- 1.5 HP 044694300208/230V- 1.5 HP 034244100575V- 1.5 HP 046744200

701 Standard MotorOpen Drip- 1 HP 043219400Open Drip -1 HP, 575V C081

Optional Motor- Totally Enclosed460V- 1.5 HP 044694300208/230V- 1.5 HP 034244100575V- 1.5 HP 046744200

Fan Motors

* The capacitor for this motor is 300002713

ALR 022C - 205CFan Quantities

Model Numbers Qty.ALR 022 - 035C 3ALR 040C 4ALR 050 - 060C 6ALR 065 - 095C 8ALR 105C 10ALR 115 -155C 12ALR 175 -205C 14

Motor QuantitiesUnits with Speedtrol

Model Numbers Qty.SpeedTrol Motors:ALR 022 - 035C 1ALR 040 - 205C 2

Standard Motors:ALR 022 - 040C 2ALR 050 - 060C 4ALR 065 - 095C 6ALR 105C 8ALR 115 -155C 10ALR 175 -205C 12

Motor QuantitiesUnits w/o Speedtrol

Model Numbers Qty.ALR 022 - 035C 3ALR 040C 4ALR 050 - 060C 6ALR 065 - 095C 8ALR 105C 10ALR 115 -155C 12ALR 175 -205C 14


CabinetALR 010 - 018C

Ref # Part Description Qty Part Number870 Side Panel- L.H. 1 055038001871 Side Panel- R.H.

Units With Gauges 1 055368101Units w/o Gauges 1 055368901

875 Rear Panel 1 055338201876 Center Support 1 055037501877 Baffle 1 055367801880 Front Panel- R. H. 1 055037401881 Valve Access Panel 1 055367301888 Top Panel- Front 1 055038101891 Front Panel- L.H. 1 055037301N/S Coil Guard Grille 2 049765501

N/S=Not shown

881

875

877888

870

891880

871

876



905

911

901

894891895

888

886

889890

899

902

900903

875

Ref # Part Description Qty Part Number875 End Panel-Compr. End 1 055361901888 Filler Panel 1 055492101889 Latch (non-moving) 1 037668301890 Dead Door

No Control- Wired for 350. 1 055053102No Control- Wired for W7100 1 055053202W7100 1 055493101350- 2 Step Capacity 1 055370901350- 3 Step Capacity 1 055370801

891 Control Panel Door 1 055055101894 Hinge 4 032457700895 Door Latch Handle (lift & turn) 1 047135602896 Lock, with 2 keys 1 001157200N/S Key only (for lock 001157200) 1 021993200899 Support- L.H. Control End 1 055062502900 Corner Support- R.H. 1 055361201901 Support- L.H. Control End 1 055062602902 Corner Support- L.H. 1 055054302903 Valve Panel 1 055361001905 Grille- Coil Guard 4 049119301911 Support- Coil Guard 2 055063801

N/S=Not shown



Ref # Part Description Qty Part Number870 Corner Support 1 058009702871 Corner Support 1 058009701875 Rear Panel 1 058009901876 Support 1 058011201880 Door- Right Hand 1 058046901882 Outer Baffle- L. H.

ALR 040C 1 073168701ALR 050 - 105C 1 058011602

883 Outer Baffle- R. HALR 040C 1 073168501

ALR 050 - 105C 1 058011702884 Inner Baffle- L. H.

ALR 040C 1 073168401ALR 050 - 105C 1 058011802

885 Inner Baffle- R. H.ALR 040C 1 073168601ALR 050 - 105C 1 058011601

888 Top Panel 1 058009301N/S=Not shown

Ref # Part Description Qty Part Number889 Latch (non-moving) 1 037668301890 Dead Doors

W7100/350/B.C. 1 058329604 MicroTech 1 071638705

891 Control Box Door- L. H. 1 058009401892 Support 2 058363401894 Hinge 8 032457700

895 Door Latch Handle(lift & turn) 4 047135602

896 Lock 1 001157200

N/S Key only (for lock 001157200) -

928 Label- Door Panel 2 038993600929 Nut- Push-On 2 039007900N/S Coil Support

ALR 040C 2 058046001ALR 050 - 105C 4 058029101

871

876

885884

929928

892

894895 880

896

891

894

890C.B. 882 883

888 870 875


ALR 105C

ALR 040C

ALR 065-095C

ALR 050C - 060C

CabinetCoil and Compressor Guards- ALR 040 - 105C

Ref # Part Description Qty Part Number899 Grille- Compressor Guard 2 046739501900 Grille- Coil Guard

ALR 040 2 046739401ALR 050 - 060 4 046739401ALR 065 - 105 6 046739401

901 Grille- End Panel 2 046739301

Coil and Compressor Guard Components



Ref # Part Description Qty Part Number

870 Corner Support 1 058043002871 Corner Support 1 058043001874 Wrap- Opp. End Cover 1 058042001875 Rear Panel 1 058042501876 Side Panel Wrap 1 058041604877 Side Panel Wrap 1 058041603878 Side Panel Wrap 1 058041804879 Side Panel Wrap 1 058041803890 Door- Right Hand 1 058046901883 Support Angle- Side 1 058040901884 Support Angle- Side 1 058040902885 Plate 2 058040801886 End Cover Panel 1 058040701887 Panel 1 071698801888 Control Box Panel 1 058040301

N/S=Not shown

Ref # Part Description Qty Part Number

890 Dead Doors W7100/350/B.C. 1 058329604 MicroTech 1 071638705

891 Control Box Door- L. H. 1 058009401892 Support 2 058363401894 Hinge 8 032457700

895 Door Latch Handle(lift & turn) 4 047135602

896 Lock 1 001157200928 Label- Door Panel 2 038993600929 Nut- Push-On 2 039007900N/S Door Latch (non-moving) 1 037668301

870

875

874

878

871876

877

879Opp.Side

Opp.Side

885883

892928929

894

895 880

891

896

929

928

892 884 890

888

887

886


901

904

900

899

903

ALR 115 - 155C

901

900

899

905

900

904

906

904903

ALR 175 - 205C

Ref # Part Description Qty Part Number899 Grille- Compressor Guard 2 046739501900 Grille- Coil Guard

ALR 115 - 155 6 046739401ALR 175 - 205 4 046739401

901 Grille- End Panel 2 046739301903 Grille- Fin Guard 2 047138701904 Grille- Coil Guard

ALR 115 - 155 6 047138601ALR 175 - 205 4 047138601

905 Grille- Fin GuardALR 175 - 205 only 4 047933601

906 Grille- Fin GuardALR 175 - 205 only 4 047933701

Coil and Compressor Guard Components

CabinetCoil and Compressor Guards- ALR 115 - 205C


Piping ComponentsBasic Information

The components on the following pages are the same on each circuit. For reference, the diagrams below illus-trate the circuit arrangements for each unit.

Each unit has three separate lines on each circuit: Suction, Discharge and Liquid. As an option, a unit may also have Hot Gas Bypass on just Circuit One, or On Both Circuits (never just on Circuit Two). The charts on the fol-lowing pages list only the primary replacement components. Because of the many possible piping arrangements we have not listed all of the individual tubes in these tables. If you require a tube, make sure that you have the UNIT serial number so that the part number can be properly determined.

Control BoxCircuit 1

Circuit 2

Comp. #1

Comp. #2


Piping ComponentsALR 010 - 015C

Discharge Line Qty Description Part Number 1 Check Valve- .875" 735040326 1 Shut- Off Valve- .875" 032193502Liquid Line Qty Description Part Number 1 Sight Glass 015997805 1 Filter Drier- Sealed Type 025938800 1 Shut Off Valve- .625" 036562903 1 Solenoid Valve- .625" 070301706 1 Expansion Valve- 10 Ton 072195005Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 024684104 1 Solenoid Valve 070301706

ALR 015C

Discharge Line Qty Description Part Number 1 Check Valve- 1.125" 070300704 1 Shut- Off Valve- 1.125" 019282100Liquid Line Qty Description Part Number 1 Sight Glass 015997805 1 Filter Drier- Sealed Type 025938800 1 Shut Off Valve- .625" 036562903 1 Solenoid Valve- .625" 070301706 1 Expansion Valve- 20 Ton 072195002Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 023072900 1 Solenoid Valve 043378602

ALR 010C

Quantities Reflect a PER CIRCUIT number. Each unit has two circuits of eachtype, except Hot Gas which, if present, may be used only on just circuit one oron both circuits one and two.



ALR 018C

Discharge Line Qty Description Part Number 1 Check Valve- 1.125" 070300704 1 Shut- Off Valve- 1.125" 019282100Liquid Line Qty Description Part Number 1 Sight Glass 015997805 1 Filter Drier- Sealed Type 025938800 1 Shut Off Valve- .625" 036562903 1 Solenoid Valve- .625" 070301706 1 Expansion Valve- 20 Ton 072195002Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 023072900 1 Solenoid Valve 043378602

ALR 022C

Discharge Line Qty Description Part Number 1 Muffler- 1.375" 047664304Liquid Line Qty Description Part Number 1 Sight Glass 015997805 1 Filter Drier- Sealed Type 025938900 1 Shut Off Valve- .875" 032193502 1 Solenoid Valve- .875" 025327500 1 Expansion Valve- 30 Ton 072195003Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 023072900 1 Solenoid Valve 025327500




ALR 022C





ALR 030C


ALR 025C




ALR 035C

Piping ComponentsALR 035C




Quantities Reflect a PER CIRCUIT number. Each unit has two circuits of each type, except Hot Gas which, if present, may be used only on just circuit one or on both circuits one and two.

Discharge Line Qty Description Part Number 1 Relief Valve 039441300Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 025329600 1 Charge Valve 038689900 1 Filter Drier Sealed Type 025938900 1 Shut Off Valve 032193502 1 Solenoid Valve 032189304 1 Expansion Valve- 20 Ton 030569101 ** (Prior to SN 5VEXXXXX Circuit One used a 15 Ton TXV. The 20 Ton listed here should be ordered if replacement of the 15 Ton TXV is required)Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 023072900 1 Solenoid Valve 025327500


Discharge Line Qty Description Part Number 1 Relief Valve 039441300Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 025329600 1 Charge Valve 038689900 1 Filter Drier- Sealed Type 025938900 1 Shut Off Valve 032193502 1 Solenoid Valve 032189304 1 Expansion Valve- 20 Ton 030569101Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 023072900 1 Solenoid Valve 025327500

ALR 040C


ALR 050C




Discharge Line Qty Description Part Number 1 Relief Valve 039441300Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 025329600 1 Charge Valve 038689900 1 Filter Drier- Sealed Type 025938900 1 Shut Off Valve 032193502 1 Solenoid Valve 032189304 1 Expansion Valve- 30 Ton 030569103 ** (Prior to SN 5VEXXXXX Circuit One used a 20 Ton TXV. The 30 Ton listed here should be ordered if replacement of the 20 Ton TXV is required).Hot Gas Bypass- Circuit #1 Qty Description Part Number 1 Hot Gas Bypass Valve 022973500 1 Solenoid Valve 025327600Hot Gas Bypass- Circuit #2 Qty Description Part Number 1 Hot Gas Bypass Valve 023072900 1 Solenoid Valve 025327500

ALR 060C







ALR 065C

ALR 075C




Discharge Line Qty Description Part Number 1 Relief Valve 039441300Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 025329600 1 Charge Valve 038689900 1 Filter Drier Sealed Type 021057426 1 Shut Off Valve 048169601 1 Solenoid Valve 025327600 1 Expansion Valve- 55 Ton 030569006Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 022973500 1 Solenoid Valve 025327600



ALR 085C

ALR 095C




Discharge Line Qty Description Part Number 1 Relief Valve 039441300 1 Muffler 047664305Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 022431100 1 Filter Drier Sealed Type 021057426 1 Shut Off Valve 048169601 1 Solenoid Valve 025327600 1 Charge Valve 038689900 1 Expansion Valve- 55 Ton 030569006Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 022973500 1 Solenoid Valve 025327600


Discharge Line Qty Description Part Number 1 Relief Valve 039441300 2 Muffler 047664304Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 022431100 1 Filter Drier Sealed Type 021057426 1 Shut Off Valve 048169601 1 Solenoid Valve 025327600 1 Charge Valve 038689900 1 Expansion Valve- 70 Ton 030569002 ** (Prior to SN 5VEXXXXX Circuit One used a 55 Ton TXV. The 70 Ton listed here should be ordered if replacement of the 55 Ton TXV is required).Hot Gas BypassHot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 022973500 1 Solenoid Valve 025327600

ALR 105C

ALR 115C




Discharge Line Qty Description Part Number 1 Relief Valve 039441300 2 Muffler 047664304Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 022431100 1 Filter Drier Sealed Type 021057426 1 Shut Off Valve 048169601 1 Solenoid Valve 025327600 1 Charge Valve 038689900 1 Expansion Valve- 70 Ton 030569002Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 022973500 1 Solenoid Valve 025327600


Discharge Line Qty Description Part Number 1 Relief Valve 039441300 2 Muffler 047664304Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 022431100 1 Filter Drier Bolted Type 019190500 2 Filter Drier Core 001360800 1 Filter Drier Gasket 074783601 1 Shut Off Valve 048169601 1 Solenoid Valve 025327600 1 Charge Valve 038689900 1 Expansion Valve- 70 Ton 030569002Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 022973500 1 Solenoid Valve 025327600

ALR 125C

ALR 145C




Discharge Line Qty Description Part Number 1 Relief Valve 039441300 1 Muffler 047664304 1 Muffler 047664305Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 022431100 1 Filter Drier Bolted Type 019190500 2 Filter Drier Core 001360800 1 Filter Drier Gasket 074783601 1 Shut Off Valve 048169601 1 Solenoid Valve 025327600 1 Charge Valve 038689900 1 Expansion Valve- 90 Ton 030569008Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 022973500 1 Solenoid Valve 025327600



Discharge Line Qty Description Part Number 1 Relief Valve 039441300 2 Muffler 047664305Liquid Line Qty Description Part Number 1 Sight Glass 022427700 1 Sight Glass Saddle 022431100 1 Filter Drier Bolted Type 024881100 2 Filter Drier Core 001360800 1 Filter Drier Gasket 074783601 1 Shut Off Valve 048169601 1 Solenoid Valve 047931306 1 Charge Valve 038689900 1 Expansion Valve- 100 Ton 070976702Hot Gas Bypass Qty Description Part Number 1 Hot Gas Bypass Valve 022973500 1 Solenoid Valve 025327600

Piping ComponentsALR 175, 195, 205C


EvaporatorComplete Assemblies

Plate Exchangers- ALR 010C - ALR 035C

Unit Size Heat Exchanger Type Size Part Number010C Plate 4.5 X 20.5 065486401015C Plate 9.375 X 20.5 065486402018C Plate 9.375 X 20.5 065486403022C Plate 9.375 X 20.5 065486404025C Plate 9.375 X 20.5 065486405030C Plate 9.375 X 20.5 065486406035C Plate 9.375 X 20.5 065486407

Description Code Definition- Shell and Tube Evaporators

EV 10 08 188 CU A A RH

Hand Connection YY- Left Hand (std.) RH- Right Hand Baffle Spacing (A= Std.) Tube Wall (A= .020) Tube Material (CU= Copper) Tube Qty. Length- Feet Diameter- inches Evaporator

Unit Size Description Code Model Number Assembly Part Number040C EV1008092CUAAYY E1008092 070032703 *050C EV1008110CUAAYY E1008110 070032702 *060C/065C EV1008132CUAAYY E1008132 070032701 *075C EV1208166CUAAYY E1208166 070021603 *085C EV1208184CUAAYY E1208184 070021602 *095C EV1208196CUAAYY E1208196 070021601 *105C EV1410208CUAAYY E1410208 058153103 *115C/125C EV1410228CUAAYY E1410228 074336332 *145C EV1410242CUAAYY E1410242 074336331 *155C EV1610276CUAAYY E1610276 074336343 *175C EV1610298CUAAYY E1610298 074336342 *195C EV1610328CUAAYY E1610328 074336341 *

Shell and Tube Evaporators- ALR 040C - ALR 195C

* Assemblies listed are for standard, left-hand connection evaporators. ("Hand" is determined when facing the in-let end of the assembly.) To replace a right-hand evaporator, order the above assembly plus the evaporator head gaskets as shown on the next page. The evaporator heads will need to be removed and swapped in the field. The gaskets will be needed when reinstalling the heads in their proper positions.


Evaporator DiagramALR 040C - 205C

353


Ref # Description Part Number 040C 050C 060C 065C 075C 085C 095C207 Tube- 8' 070694702 092 110 132 132 166 184 196357 Baffle Assy- Inlet

10” Dia 058067301 1 1 1 112” Dia 070021101 1 1 1

356 Baffle Assy- Return10” Dia 058066901 1 1 1 112” Dia 070021201 1 1 1

351 Connection Head Assy10” Dia 058068012 110” Dia 058068002 1 1 112” Dia 070021302 1 1 1

350 Return Head10” Dia 058068201 1 1 1 112” Dia 070358401 1 1 1

355 Head Gaskets10” Dia 071363001 4 4 4 412” Dia 071363201 4 4 4

353 Head Bolts10” Dia 735033957 40 40 40 4012” Dia 735033957 40 40 40

Ref # Description Part Number 105C 115C 125C 145C 155C 175C 195C 205C207 Tube- 10' 070694706 208 228 228 242 276 298 328 420357 Baffle Assy- Inlet

14” Dia 058362901 1 1 1 116” Dia 058050401 1 1 118” Dia 070856401 1

356 Baffle Assy- Return14” Dia 058363101 1 1 1 116” Dia 058049801 1 1 118” Dia 070856301 1

351 Connection Head Assy14” Dia 058363201 1 1 1 116” Dia 058048401 1 1 118” Dia 070856101 1

350 Return Head14” Dia 058361001 1 1 1 116” Dia 058048901 1 1 118” Dia 072034701 1

355 Head Gaskets14” Dia 071363401 4 4 4 416” Dia 071363601 4 4 418” Dia 070412901 4

353 Head Bolts14” Dia 735033958 48 48 48 4816” Dia 735033959 56 56 5618” Dia 735033960 64

Evaporator ComponentsALR 040C - 205C


EvaporatorPlate Heat Exchanger Insulation, Thermostat, Heaters

5250

49

56

54

52

Ref # Part Description Qty Part Number49 Thermal Insulation

ALR 010C 1 055047101ALR 015-018C 1 055047601ALR 022-035C 1 055369701

50 Thermal Insulation- SideALR 010C 1 055047201ALR 015-018C 1 055047701ALR 022-035C 1 055369601

51 Thermal InsulationALR 010C 1 055047301ALR 015-018C 1 055047801ALR 022-035C 1 055369301

52 Thermal InsulationALR 010C 1 055047401ALR 015-018C 1 055047901ALR 022-035C 1 055369401

54 Heater- 80W, 230VALR 010-018C 1 065497301

Heater- 80W, 115VALR 010-018C 1 065497302ALR 010-018C 1 735079719ALR 010-018C 1 735079720

56 Thermostat- 1 Stage 1 019754700


Control Box

Coil Layout- Front ViewALR 010C - ALR 035C

CoilPosition

2Coil

Position 1

Control Box


CoilPosition

3Coil

Position 2

Control BoxCoil

Position 1


CoilPosition

1

Aluminum Fin Coils

Unit Size

PositionOne

Position Two

PositionThree

010C 055040069 055040069 ---015C 055040069 055040069 ---018C 055040069 055040069 ---022C 055371725 055371825 ---025C 055371725 055371825 ---030C 055371725 055371825 ---035C 055371745 055371745 ---040C 058020110 --- ---050C 058020120 --- ---060C 058020125 --- ---065C 058020130 --- ---075C 058020133 --- ---085C 058020133 --- ---095C 058020138 --- ---105C 058020140 --- ---115C 058020150 058368650 058368850125C 058020155 058368655 058368855145C 058020155 058368655 058368855155C 058020160 058368660 058368860175C 058020170 058368670 058368870195C 058020170 058368670 058368870205C 058020170 058368670 058368870

Copper Fin Coils

Unit Size

PositionOne

Position Two

PositionThree

010C 055040065 055040065 ---015C 055040065 055040065 ---018C 055040070 055040070 ---022C 055371715 055371815 ---025C 055371715 055371815 ---030C 055371735 055371835 ---035C 055371735 055371835 ---040C 049802211 --- ---050C 049802221 --- ---060C 049802226 --- ---065C 049802231 --- ---075C 049802234 --- ---085C 049802234 --- ---095C 049802239 --- ---105C 049802241 --- ---115C 049802251 049802451 049802651125C 049802256 049802456 049802656145C 049802256 049802456 049802656155C 049802261 049802461 049802661175C 049802271 049802471 049802671195C 049802271 049802471 049802671205C 049802271 049802471 049802671

Condenser CoilsAll Circuits


Unit Size CircuitNumber

AssemblyPart Number

040C 1 046748501040C 2 046743603

050C 1 046743603050C 2 046743604

060C 1 046743604060C 2 046743606

065C 1 046743606065C 2 046743606

075C/085C 1 046743608075C/085C 2 046743608

095C 1 046743609095C 2 046743609

105C/115C 1 048441301

125C/145C/155C 1 048441302

175C/195C/205C 1 048441303

Heat Recovery CondenserDesuperheater


Heat Recovery CondenserWater- Cooled Condenser Vessels

Unit Size Model Number Circuit Number Assembly Part Number040C C608 1 070083601040C C608 2 070083701050C C608 1 070083701050C C808 2 071519805060C C808 1 071519805060C C808 2 071519804065C C808 1 071519804065C C808 2 071519804075C/085C C808 1 071519803075C/085C C808 2 071519803095C C1008 1 071519705095C C1008 2 071519705105C/115C/125C C1010 1 071519604105C/115C/125C C1010 2 071519604145C C1010 1 071519603145C C1010 2 071519603155C/175C/195C C1010 1 071519602155C/175C/195C C1010 2 071519602

Description Code Definition

HR 08 08 024 CU A

Tube Wall (A= .020) Tube Material (CU= Copper) Tube Qty. Length- Feet Diameter- inches HR= Heat Recovery Condenser


Heat Recovery CondenserWater- Cooled Condenser Vessels Components

Ref # Description Part Number 040C 050C 060C 065C 075C 085C 095C207 Tube- 8' Circuit 1 735028341 22 26

Tube- 8' Circuit 2 735028341 26Tube- 8' Circuit 1 070181115 24Tube- 8' Circuit 2 070181115 24 30Tube- 8' Circuits 1 & 2 070181115 30 34 34 42

350 Return Head6” Dia 722371002 1 18” Dia 776431538 1 1 1 1 110” Dia 776431540 1

351 Connection Head Assy6” Dia 759428501 1 18” Dia 070021802 1 1 1 1 110” Dia 070034302 1

353 Head Bolts6” Dia 735033851 8 88” Dia 735033850 24 24 24 24 2410” Dia 735033849 24

355 Head Gaskets6” Dia 070974401 2 28” Dia 735082962 2 2 2 2 210” Dia 735082966 2

Ref # Description Part Number 105C 115C 125C 145C 155C 175C 195C 205C207 Tube- 10' Circuits 1 & 2 070181116 48 48 48 52 64 64 64 64350 Return Head

10” Dia 776431540 1 1 1 1 1 1 1 1351 Connection Head Assy

10” Dia 070034302 1 1 1 1 1 1 1 1353 Head Bolts

10” Dia 735033849 24 24 24 24 24 24 24 24355 Head Gaskets

10” Dia 735082966 2 2 2 2 2 2 2 2


Vibration IsolatorsPart Numbers- Location

Con

trol B

ox4 3

1 2

ALR 010C - 035C

Con

trol B

ox 4 6

1 3

ALR 040C - 205C

2

5

Ref # Part Description Qty Part

Number1 Spring Isolator

010C - 018C 1 047792724022C -035C 1 047792726Rubber-In-Shear Isolator010C - 018C 1 021639704022C -035C 1 021639701

2 Spring Isolator010C - 018C 1 047792724022C -030C 1 047739726035C 1 047739727Rubber-In-Shear Isolator010C - 018C 1 021639704022C -030C 1 021639701035C 1 021639703

3 Spring Isolator010C - 018C 1 047792724022C -030C 1 047739726035C 1 047739727Rubber-In-Shear Isolator010C - 018C 1 021639704022C -030C 1 021639701035C 1 021639703

4 Spring Isolator010C - 018C 1 047792724022C -035C 1 047739726Rubber-In-Shear Isolator010C - 018C 1 021639704022C -035C 1 021639701

Ref # Part Description Qty Part

Number1, 2 Spring Isolator

040C 1 047792728050C - 060C 1 047792731065C - 075C 1 047792732085C - 095C 1 047792927105C - 115C 1 047792928125C - 155C 1 047792931175C - 205C 1 047792932

3 Spring Isolator040C 1 047792728050C - 060C 1 047792731065C - 075C 1 047792732085C 1 047792926095C 1 047792927105C - 145C 1 047792931155C - 205C 1 047792932

4, 5 Spring Isolator040C 1 047792728050C - 060C 1 047792731065C - 075C 1 047792732085C - 095C 1 047792927105C - 115C 1 047792928125C - 155C 1 047792931175C - 205C 1 047792932

6 Spring Isolator040C 1 047792728050C - 060C 1 047792731065C - 075C 1 047792732085C - 095C 1 047792927105C - 115C 1 047792928125C - 155C 1 047792931175C - 205C 1 047792932


Stock UnitsNomeclature, Accessories, and Kits

Description Part NumberFlow Switch018C- 035C 017503300050C- 095C 017503300

Speedtrol Kit022C- 035C: 208V 055169501022C- 035C: 460V 055169503050C- 095C: 208V 055165201050C- 095C: 460V 055165203

Control Circuit Transformer (230V P)022C - 030C 038253902035C 038253904050C - 095C 038253906

Stock Unit Kits & Accessories

Nominal Tonnageex. 040 = 40 TonsStock Units Available in sizes 018 - 095C

ALR 040 C 12

Voltage12= 208/230V27= 460V42= 208/230V

Vintage

Stock UnitNomenclature

Unit Type:ALR= Air- Cooled Accessible HermeticCompressor Chiller

Call Your Local Daikin Applied Parts Distributor For All Your Parts Needs.To Locate A Distributor, Go To www.DaikinApplied.com or Call 1-800-37PARTS

Critical Daikin Applied OEM PartsAre What Your HVAC Unit Needs!

571149 Rev. Z 10/2016 CPL Page 1 of 10

McQuay Reciprocating ChillerALR

010, 015, 018 Vintage C

Critical Components UNIT SIZE Voltage Part Number

Control Controller A350 010 - 018C ALL 065497809Pressure Control High (HP1) 010 - 018C ALL 047356107Pressure Control Low (LP1) 010 - 018C ALL 047356103Pressure Control Freezestat (FS1) 010 - 018C ALL 071944601High Pr. Control- Ambient Unloading (PC5) 010 - 018C ALL 047356104Pressure Control Switch- Fantrol (PC12) 010 - 018C ALL 047356101Pressure Control- Speedtrol (SC11) 010 - 018C ALL 048445202Freezestat Temp Control (TC10) 010 - 018C ALL 065497809TSTAT 0-100 Adj (for TC10) 010 - 018C ALL 065497808TSTAT 30-270 Adj (TC11) 010 - 018C ALL 023796408

CompressorCMPR, 10HP, 1 Step Ctrl 010C 208-230/60/3 049264001CMPR, 10HP, 2 Step Ctrl 010C 208-230/60/3 049264002CMPR, 10HP, 1 Step Ctrl 010C 460/60/3 049264003CMPR, 10HP, 2 Step Ctrl 010C 460/60/3 049264004CMPR, 10HP, 1 Step Ctrl 010C 575/60/3 049264005CMPR, 10HP, 2 Step Ctrl 010C 575/60/3 049264006CMPR, 10HP, 1 Step Ctrl 015C 208-230/60/3 049264007CMPR, 10HP, 2 Step Ctrl 015C 208-230/60/3 049264008CMPR, 10HP, 1 Step Ctrl 015C 460/60/3 049264009CMPR, 10HP, 2 Step Ctrl 015C 460/60/3 049264010CMPR, 10HP, 1 Step Ctrl 015C 575/60/3 049264011CMPR, 10HP, 2 Step Ctrl 015C 575/60/3 049264012CMPR, 10HP, 1 Step Ctrl 018C 208-230/60/3 049264013CMPR, 10HP, 2 Step Ctrl 018C 208-230/60/3 049264014CMPR, 10HP, 1 Step Ctrl 018C 460/60/3 049264015CMPR, 10HP, 2 Step Ctrl 018C 460/60/3 049264016CMPR, 10HP, 1 Step Ctrl 018C 575/60/3 049264017CMPR, 10HP, 2 Step Ctrl 018C 575/60/3 049264018

Condenser Fan Section Motor 1/2 Hp ODP 010 - 018C 208-230/575/60/1 049267001Motor 1/2 Hp ODP 010 - 018C 460/60/1 049268701Fan Prop 24” 010 - 018C N/A 048446003

Filter DrierFilter Drier, Sealed, 5/8” Odf 010 - 018C ALL 025938800



571149 Rev. Z 10/2016 CPL Page 2 of 10


022, 025, 030, 035 Vintage C


Control Pressure Control High, Normally Open (HP1) 022 - 035C ALL 047356107Pressure Control High,Normally Closed (HP1) 022 - 035C ALL 047356102Pressure Control Low (LP1) 022 - 035C ALL 047356103Pressure Control Freezestat (FS1) 022 - 035C ALL 071944601Pr. Control- High-Ambient Unloading (PC5) 022 - 035C ALL 047356104Pressure Control Switch- Fantrol (PC12) 022 - 035C ALL 047356101Pressure Control- Speedtrol (SC11) 022 - 035C ALL 048445202Controller (Johnson 350) 022 - 035C ALL 065497809Sensor (for Johnson 350) 022 - 035C ALL 065497807Oil Pressure Control (OP1) 022 - 035C ALL 001354900Control Board, 4/6/8 Stage (LWC1) 022 - 035C ALL 048442401Control Board, 4/6 Stage (CP1) 022 - 035C ALL 070312501Control Board, 8 Stage (S350) 022 - 035C ALL 070312601Control Board, 8 Stage 022 - 035C ALL 042226900TSTAT Sensor (for LWS1) 022 - 035C ALL 070312401TSTAT Sensor, 30 ft. 022 - 035C ALL 048442405TSTAT- Fantrol (TC13) 022 - 035C ALL 032639900TSTAT 0-100 Adj 022 - 035C ALL 023796406

CompressorCMPR, 25HP, 2 Step Ctrl, AL, PW 022C 208-230/60/3 049267100CMPR, 25HP, 2 Step Ctrl, AL 022C 460/60/3 049267100CMPR, 25HP, 2 Step Ctrl, PW 022C 460/60/3 049268600CMPR, 25HP, 2 Step Ctrl, AL, PW 022C 575/60/3 047131100CMPR, 25HP, 3 Step Ctrl, AL, PW 022C 208-230/60/3 046496500CMPR, 25HP, 3 Step Ctrl, AL 022C 460/60/3 046496500CMPR, 25HP, 3 Step Ctrl, PW 022C 460/60/3 046496600CMPR, 25HP, 3 Step Ctrl, AL, PW 022C 575/60/3 047131100CMPR, 30HP, 2/3 Step Ctrl, AL, PW 025C 208-230/60/3 046496700CMPR, 30HP, 2/3 Step Ctrl, AL 025C 460/60/3 046496700CMPR, 30HP, 2/3 Step Ctrl, PW 025C 460/60/3 046496800CMPR, 30HP, 2/3 Step Ctrl, AL, PW 025C 575/60/3 047131200

Continued on next page




CMPR, 35HP, 2 Step Ctrl, AL, PW 030C 208-230/60/3 049267200CMPR, 35HP, 2 Step Ctrl, AL 030C 460/60/3 049267200CMPR, 35HP, 2 Step Ctrl, PW 030C 460/60/3 049267400CMPR, 35HP, 2 Step Ctrl, AL, PW 030C 575/60/3 049267600CMPR, 35HP, 3 Step Ctrl, AL, PW 030C 208/60/3 046496900CMPR, 35HP, 3 Step Ctrl, AL 030C 460/60/3 046496900CMPR, 35HP, 3 Step Ctrl, PW 030C 460/60/3 046497000CMPR, 35HP, 3 Step Ctrl, AL, PW 030C 575/60/3 047131300CMPR, 40HP, 2 Step Ctrl, AL, PW 035C 208/60/3 049267700CMPR, 40HP, 2 Step Ctrl, AL, PW 035C 230/60/3 049268100CMPR, 40HP, 2 Step Ctrl, AL 035C 460/60/3 049268100CMPR, 40HP, 2 Step Ctrl, PW 035C 460/60/3 049267900CMPR, 40HP, 2 Step Ctrl, AL, PW 035C 575/60/3 047131400CMPR, 40HP, 3 Step Ctrl, AL, PW 035C 208/60/3 044462700CMPR, 40HP, 3 Step Ctrl, AL, PW 035C 230/60/3 044462800CMPR, 40HP, 3 Step Ctrl, AL 035C 460/60/3 044462800CMPR, 40HP, 3 Step Ctrl, PW 035C 460/60/3 044462900CMPR, 40HP, 3 Step Ctrl, AL, PW 035C 575/60/3 047131400

Condenser Fan Section Motor 1 HP 022 - 035C 208-230/460V 070989600Motor 1.5 HP 022 - 035C 208-230V 034244100Motor 1.5 HP 022 - 035C 460V 044694300Motor 1.5 HP 022 - 035C 575V 046744200Fan Prop, 4-Blade, 26” 022 - 035C N/A 350075701

Filter DrierFilter Drier, Core Sealed, 7/8” ODF 022 - 035C N/A 025938900


022, 025, 030, 035 Vintage C(Continued)

571149 Rev. Z 10/2016 CPL Page 3 of 10



571149 Rev. Z 10/2016 CPL Page 4 of 10


040- 095 Vintage C


Control Pressure Control Hi 0-300PSI (HP1,2) 040 - 095C ALL 047356102Pressure Control Low 35-60PSI (LP1,2) 040 - 095C ALL 047356103Pressure Control Freezestat (FS1) 040 - 095C ALL 047356105Pr. Control, Hi-Ambient Unloading (PC5,6) 040 - 095C ALL 047356104Pressure Control Switch Fantrol (PC12) 040 - 095C ALL 047356101Pressure Control, Speedtrol (SC11) 040 - 095C ALL 048445202Pressure Control 20-100PSI (PC7,8) 040 - 095C ALL 020321700Pressure Control Hi SPDT 300PSI (MHP1) 040 - 095C ALL 047932301Oil Pressure Control, 8-40 PSI (OP1,2) 040 - 095C ALL 047357603Oil Pressure Control (OP1,2) 040 - 095C ALL 001354900TSTAT Sensor, 30 FT Cable (for CP1) 040 - 095C ALL 047441505TSTAT Sensor, 30 FT Cable 040 - 095C ALL 048442405TSTAT Sensor, 30 FT Cable (for LWS1) 040 - 095C ALL 070312401TSTAT 0-100 Adj (TC11) 040 - 095C ALL 023796406TSTAT- Fantrol (TC13) 040 - 095C ALL 041763500Sensor Thermistor 20 FT Cable 040 - 095C ALL 073012002Tranducer Pressure High 040 - 095C ALL 350105401Tranducer Pressure Low 040 - 095C ALL 350105301Controller (Johnson 350) 040 - 095C ALL 065497809Sensor (for Johnson 350) 040 - 095C ALL 065497808Control Board, 4/6/8 Stage (CP1) 040 - 095C ALL 070312501Control Board, 3/8 Stage (S350) 040 - 095C ALL 070312601Control Board, 4/6/8 Stage (CP1) 040 - 095C ALL 047441501Control Board, 4/6/8 Stage (LWC1) 040 - 095C ALL 048442401Control Board, 6 Stage (CP2) 040 - 095C ALL 047441502Control Board, 8 Stage (CP2) 040 - 095C ALL 047441503Control Board, 8 Stage (LWS1) 040 - 095C ALL 042226900Control Board, Microtech M250 (MCB1) 040 - 095C ALL 065487306Control Board, ADI 040 - 095C ALL 065816001Control Board, 16 Pos Mod Rack 040 - 095C ALL 049265501Keypad Display 040 - 095C ALL 065497202





Control- ContinuedRibbon Cable, 26 Cond, 72” 040 - 095C ALL 065499704Ribbon Cable, 34 Cond, 9” 040 - 095C ALL 049265102Ribbon Cable, 50 Cond, 48” 040 - 095C ALL 049265201

CompressorCMPR #1, 20HP, 4 Step Ctrl, AL, PW 040C 208-230/60/3 046496300CMPR #1, 20HP, 4 Step Ctrl, AL 040C 460/60/3 046496300CMPR #1, 20HP, 4 Step Ctrl, PW 040C 460/60/3 046496400CMPR #1, 20HP, 4 Step Ctrl, AL, PW 040C 575/60/3 047131000CMPR #2, 25HP, 4 Step Ctrl, AL, PW 040C 208-230/60/3 046496500CMPR #2, 25HP, 4 Step Ctrl, AL 040C 460/60/3 046496500CMPR #2, 25HP, 4 Step Ctrl, PW 040C 460/60/3 046496600CMPR #2, 25HP, 4 Step Ctrl, AL, PW 040C 575/60/3 047131100CMPR #1, 25HP, 4 Step Ctrl, AL, PW 050C 208-230/60/3 046496500CMPR #1, 25HP, 4 Step Ctrl, AL 050C 460/60/3 046496500CMPR #1, 25HP, 4 Step Ctrl, PW 050C 460/60/3 046496600CMPR #1, 25HP, 4 Step Ctrl, AL, PW 050C 575/60/3 047131100CMPR #2, 30HP, 4 Step Ctrl, AL, PW 050C 208-230/60/3 046496700CMPR #2, 30HP, 4 Step Ctrl, AL 050C 460/60/3 046496700CMPR #2, 30HP, 4 Step Ctrl, PW 050C 460/60/3 046496800CMPR #2, 30HP, 4 Step Ctrl, AL, PW 050C 575/60/3 047131200CMPR #1, 30HP, 4 Step Ctrl, AL, PW 060C 208-230/60/3 046496700CMPR #1, 30HP, 4 Step Ctrl, AL 060C 460/60/3 046496700CMPR #1, 30HP, 4 Step Ctrl, PW 060C 460/60/3 046496800CMPR #1, 30HP, 4 Step Ctrl, AL, PW 060C 575/60/3 047131200CMPR #2, 35HP, 4 Step Ctrl, AL, PW 060C 208-230/60/3 049267200CMPR #2, 35HP, 4 Step Ctrl, AL 060C 460/60/3 049267200CMPR #2, 35HP, 4 Step Ctrl, PW 060C 460/60/3 049267400CMPR #2, 35HP, 4 Step Ctrl, AL, PW 060C 575/60/3 049267600CMPR #1 & 2, 35HP, 4 Step Ctrl, AL, PW 065C 208-230/60/3 049267200CMPR #1 & 2, 35HP, 4 Step Ctrl, AL 065C 460/60/3 049267200CMPR #1 & 2, 35HP, 4 Step Ctrl, PW 065C 460/60/3 049267400CMPR #1 & 2, 35HP, 4 Step Ctrl, AL, PW 065C 575/60/3 049267600CMPR #1 & 2, 35HP, 6 Step Ctrl, AL, PW 065C 208-230/60/3 046496900CMPR #1 & 2, 35HP, 6 Step Ctrl, AL 065C 460/60/3 046496900CMPR #1 & 2, 35HP, 6 Step Ctrl, PW 065C 460/60/3 046497000CMPR #1 & 2, 35HP, 6 Step Ctrl, AL, PW 065C 575/60/3 047131300


040- 095 Vintage C (Continued)


571149 Rev. Z 10/2016 CPL Page 5 of 10




Compressor- ContinuedCMPR #1 & 2, 40HP, 4 Step Ctrl, AL, PW 075C 208/60/3 049267700CMPR #1 & 2, 40HP, 4 Step Ctrl, AL, PW 075C 230/60/3 049268100CMPR #1 & 2, 40HP, 4 Step Ctrl, AL 075C 460/60/3 049268100CMPR #1 & 2, 40HP, 4 Step Ctrl, PW 075C 460/60/3 049267900CMPR #1 & 2, 40HP, 4 Step Ctrl, AL, PW 075C 575/60/3 047131400CMPR #1 & 2, 40HP, 6 Step Ctrl, AL, PW 075C 208/60/3 044462700CMPR #1 & 2, 40HP, 6 Step Ctrl, AL, PW 075C 230/60/3 044462800CMPR #1 & 2, 40HP, 6 Step Ctrl, AL 075C 460/60/3 044462800CMPR #1 & 2, 40HP, 6 Step Ctrl, PW 075C 460/60/3 044462900CMPR #1 & 2, 40HP, 6 Step Ctrl, AL, PW 075C 575/60/3 047131400CMPR #1 & 2, 50HP, 4/6 Step Ctrl, AL, PW 085C 208-230/60/3 047137100CMPR #1 & 2, 50HP, 4/6 Step Ctrl, AL, PW 085C 460/60/3 047137200CMPR #1 & 2, 50HP, 4/6 Step Ctrl, AL, PW 085C 575/60/3 047137300CMPR #1 & 2, 60HP, 4/6 Step Ctrl, AL, PW 095C 208-230/60/3 047352800CMPR #1 & 2, 60HP, 4/6 Step Ctrl, AL, PW 095C 460/60/3 047352900CMPR #1 & 2, 60HP, 4/6 Step Ctrl, AL, PW 095C 575/60/3 047353000

Condenser Fan Section ODP Motor 1 HP, Speedtrol 040 - 095C 208-230/460/60/1 070989600ODP Motor 1 HP 040 - 095C 208-230/460/60/3 043219400ODP Motor 1 HP 040 - 095C 575/60/1 C081Motor 1.5 HP, TEAO 040 - 095C 208-230/60/3 034244100Motor 1.5 HP, TEAO 040 - 095C 460/60/3 044694300Motor 1.5 HP 040 - 095C 575/60/3 046744200Fan Prop, 4 Blade, 26” 040 - 095C N/A 043219300

Filter DrierFilter Drier, Core Sealed, 7/8” ODF 040 - 075C N/A 025938900Filter Drier, Core Sealed, 1-1/8” ODF 085 - 095C N/A 021057426



571149 Rev. Z 10/2016 CPL Page 6 of 10



571149 Rev. Z 10/2016 CPL Page 7 of 10


105- 205 Vintage C


Control Pressure Control Hi 0-300PSI (HP1,2) 105 - 205C ALL 047356102Pressure Control Low 35-60PSI (LP1,2) 105 - 205C ALL 047356103Pressure Control Freezestat (FS1) 105 - 205C ALL 047356105Pr. Control, Hi-Ambient Unloading (PC5,6) 105 - 205C ALL 047356104Pressure Control Switch Fantrol (PC12) 105 - 205C ALL 047356101Pressure Control, Speedtrol (SC11) 105 - 205C ALL 048445202Pressure Control 20-100PSI (PC7,8) 105 - 205C ALL 020321700Pressure Control Hi SPDT 300PSI (MHP1) 105 - 205C ALL 047932301Oil Pressure Control, 8-40 PSI (OP1,2) 105 - 205C ALL 047357603Oil Pressure Control (OP1,2) 105 - 205C ALL 001354900TSTAT Sensor, 30 FT Cable (for CP1) 105 - 205C ALL 047441505TSTAT Sensor, 30 FT Cable 105 - 205C ALL 048442405TSTAT Sensor, 30 FT Cable (for LWS1) 105 - 205C ALL 070312401TSTAT 0-100 Adj (TC11) 105 - 205C ALL 023796406TSTAT- Fantrol (TC13) 105 - 205C ALL 041763500Sensor Thermistor 20 FT Cable 105 - 205C ALL 073012002Tranducer Pressure High 105 - 205C ALL 350105401Tranducer Pressure Low 105 - 205C ALL 350105301Controller (Johnson 350) 105 - 205C ALL 065497809Sensor (for Johnson 350) 105 - 205C ALL 065497808Control Board, 4/6/8 Stage (CP1) 105 - 205C ALL 070312501Control Board, 3/8 Stage (S350) 105 - 205C ALL 070312601Control Board, 4/6/8 Stage, (CP1) 105 - 205C ALL 047441501Control Board, 4/6/8 Stage (LWC1) 105 - 205C ALL 048442401Control Board, 6 Stage (CP2) 105 - 205C ALL 047441502Control Board, 8 Stage (CP2) 105 - 205C ALL 047441503Control Board, 8 Stage (LWS1) 105 - 205C ALL 042226900Control Board, Microtech M250 (MCB1) 105 - 205C ALL 065487306Control Board, ADI 105 - 205C ALL 065816001Control Board, 16 Pos Mod Rack 105 - 205C ALL 049265501Keypad Display 105 - 205C ALL 065497202





Control- Continued Ribbon Cable, 26 Cond, 72” 105 - 205C ALL 065499704Ribbon Cable, 34 Cond, 9” 105 - 205C ALL 049265102Ribbon Cable, 50 Cond, 48” 105 - 205C ALL 049265201

CompressorCMPR #1 & 2, 35HP, 4/6/8 Step Ctrl, AL, PW 105C 208-230/60/3 049267300CMPR #1 & 2, 35HP, 4/6/8 Step Ctrl, AL 105C 460/60/3 049267300CMPR #1 & 2, 35HP, 4/6/8 Step Ctrl, PW 105C 460/60/3 049267500CMPR #1 & 2, 35HP, 4/6/8 Step Ctrl, AL, PW 105C 575/60/3 049267600CMPR #3 & 4, 25HP, 4/6/8 Step Ctrl, AL, PW 105C 208-230/60/3 049267100CMPR #3 & 4, 25HP, 4/6/8 Step Ctrl, AL 105C 460/60/3 049267100CMPR #3 & 4, 25HP, 4/6/8 Step Ctrl, PW 105C 460/60/3 049268600CMPR #3 & 4, 25HP, 4/6/8 Step Ctrl, AL, PW 105C 575/60/3 047131100CMPR #1, 2 & 4 35HP, 4/6/8 Step Ctrl, AL, PW 115C 208-230/60/3 049267300CMPR #1, 2 & 4, 35HP, 4/6/8 Step Ctrl, AL 115C 460/60/3 049267300CMPR #1, 2 & 4, 35HP, 4/6/8 Step Ctrl, PW 115C 460/60/3 049267500CMPR #1, 2 & 4 35HP, 4/6/8 Step Ctrl, AL, PW 115C 575/60/3 049267600CMPR #1 & 2, 35HP, 6/8 Step Ctrl, AL, PW 115C 208-230/60/3 049267200CMPR #1 & 2, 35HP, 6/8 Step Ctrl, AL 115C 460/60/3 049267200CMPR #1 & 2, 35HP, 6/8 Step Ctrl, PW 115C 460/60/3 049267400CMPR #1 & 2, 35HP, 6/8 Step Ctrl, AL, PW 115C 575/60/3 049267600CMPR #3, 25HP, 4/6/8 Step Ctrl, AL, PW 115C 208-230/60/3 049267100CMPR #3, 25HP, 4/6/8 Step Ctrl, AL 115C 460/60/3 049267100CMPR #3, 25HP, 4/6/8 Step Ctrl, PW 115C 460/60/3 049268600CMPR #3, 25HP, 4/6/8 Step Ctrl, AL, PW 115C 575/60/3 047131100CMPR #4, 35HP, 6/8 Step Ctrl, AL, PW 115C 208-230/60/3 049267300CMPR #4, 35HP, 6/8 Step Ctrl, AL 115C 460/60/3 049267300CMPR #4, 35HP, 6/8 Step Ctrl, PW 115C 460/60/3 049267500CMPR #4, 35HP, 6/8 Step Ctrl, AL, PW 115C 575/60/3 049267600CMPR #1, 2, 3 & 4 35HP, 4 Step Ctrl, AL, PW 125C 208-230/60/3 049267300CMPR #1, 2, 3 & 4 35HP, 4 Step Ctrl, AL 125C 460/60/3 049267300CMPR #1, 2, 3 & 4 35HP, 4 Step Ctrl, PW 125C 460/60/3 049267500CMPR #1, 2, 3 & 4 35HP, 4 Step Ctrl, AL, PW 125C 575/60/3 049267600CMPR #1 & 2 35HP, 6/8 Step Ctrl, AL, PW 125C 208-230/60/3 049267200CMPR #1 & 2 35HP, 6/8 Step Ctrl, AL 125C 460/60/3 049267200CMPR #1 & 2 35HP, 6/8 Step Ctrl, PW 125C 460/60/3 049267400CMPR #1 & 2 35HP, 6/8 Step Ctrl, AL, PW 125C 575/60/3 049267600


571149 Rev. Z 10/2016 CPL Page 8 of 10






Compressor- ContinuedCMPR #3 & 4 35HP, 6/8 Step Ctrl, AL, PW 125C 208-230/60/3 049267300CMPR #3 & 4 35HP, 6/8 Step Ctrl, AL 125C 460/60/3 049267300CMPR #3 & 4 35HP, 6/8 Step Ctrl, PW 125C 460/60/3 049267500CMPR #3 & 4 35HP, 6/8 Step Ctrl, AL, PW 125C 575/60/3 049267600CMPR #1, 2, 3 & 4 40HP, 4 Step Ctrl, AL, PW 145C 208/60/3 049267800CMPR #1, 2, 3 & 4 40HP, 4 Step Ctrl, AL, PW 145C 230/60/3 049268200CMPR #1, 2, 3 & 4 40HP, 4 Step Ctrl, AL 145C 460/60/3 049268200CMPR #1, 2, 3 & 4 40HP, 4 Step Ctrl, PW 145C 460/60/3 049268000CMPR #1, 2, 3 & 4 40HP, 4 Step Ctrl, AL, PW 145C 575/60/3 047131400CMPR #1 & 2 40HP, 6/8 Step Ctrl, AL, PW 145C 208/60/3 049267700CMPR #1 & 2 40HP, 6/8 Step Ctrl, AL, PW 145C 230/60/3 049268100CMPR #1 & 2 40HP, 6/8 Step Ctrl, AL, PW 145C 460/60/3 049268100CMPR #1 & 2 40HP, 6/8 Step Ctrl, AL, PW 145C 575/60/3 047131400CMPR #3 & 4 40HP, 6/8 Step Ctrl, AL, PW 145C 208/60/3 049267800CMPR #3 & 4 40HP, 6/8 Step Ctrl, AL, PW 145C 230/60/3 049268200CMPR #3 & 4 40HP, 6/8 Step Ctrl, AL 145C 460/60/3 049268200CMPR #3 & 4 40HP, 6/8 Step Ctrl, PW 145C 460/60/3 049268000CMPR #3 & 4 40HP, 6/8 Step Ctrl, AL, PW 145C 575/60/3 047131400CMPR #1 & 2, 50HP, 6/8 Step Ctrl, AL, PW 155C 208/60/3 071667601CMPR #1 & 2, 50HP, 6/8 Step Ctrl, AL, PW 155C 230/60/3 071667701CMPR #1 & 2, 50HP, 6/8 Step Ctrl, AL 155C 460/60/3 071667701CMPR #1 & 2, 50HP, 6/8 Step Ctrl, PW 155C 460/60/3 071667701CMPR #1 & 2, 50HP, 6/8 Step Ctrl, AL, PW 155C 575/60/3 047137300CMPR #3 & 4 40HP, 6 Step Ctrl, AL, PW 155C 208/60/3 049267800CMPR #3 & 4 40HP, 6 Step Ctrl, AL, PW 155C 230/60/3 049268200CMPR #3 & 4 40HP, 6 Step Ctrl, AL 155C 460/60/3 049268200CMPR #3 & 4 40HP, 6 Step Ctrl, PW 155C 460/60/3 049268000CMPR #3 & 4 40HP, 6 Step Ctrl, AL, PW 155C 575/60/3 047131400CMPR #3 & 4 40HP, 8 Step Ctrl, AL, PW 155C 208/60/3 049267700CMPR #3 & 4 40HP, 8 Step Ctrl, AL, PW 155C 230/60/3 049268100CMPR #3 & 4 40HP, 8 Step Ctrl, AL 155C 460/60/3 049268100CMPR #3 & 4 40HP, 8 Step Ctrl, PW 155C 460/60/3 049267900CMPR #3 & 4 40HP, 8 Step Ctrl, AL, PW 155C 575/60/3 047131400

571149 Rev. Z 10/2016 CPL Page 9 of 10






Compressor- ContinuedCMPR #1 & 2, 50HP, 6/8 Step Ctrl, AL, PW 175C 208/60/3 071667601CMPR #1 & 2, 50HP, 6/8 Step Ctrl, AL, PW 175C 230/60/3 071667701CMPR #1 & 2, 50HP, 6/8 Step Ctrl, AL, PW 175C 460/60/3 071667701CMPR #1 & 2, 50HP, 6/8 Step Ctrl, AL, PW 175C 575/60/3 047137300CMPR #3 & 4 40HP, 6 Step Ctrl, AL, PW 175C 208/60/3 071667801CMPR #3 & 4 40HP, 6 Step Ctrl, AL, PW 175C 230/60/3 071667901CMPR #3 & 4 40HP, 6 Step Ctrl, AL, PW 175C 460/60/3 071667901CMPR #3 & 4 40HP, 6 Step Ctrl, AL, PW 175C 575/60/3 047137300CMPR #3 & 4 40HP, 8 Step Ctrl, AL, PW 175C 208/60/3 071667601CMPR #3 & 4 40HP, 8 Step Ctrl, AL, PW 175C 230/60/3 071667701CMPR #3 & 4 40HP, 8 Step Ctrl, AL 175C 460/60/3 071667701CMPR #3 & 4 40HP, 8 Step Ctrl, PW 175C 460/60/3 071667701CMPR #3 & 4 40HP, 8 Step Ctrl, AL, PW 175C 575/60/3 047137300CMPR #1 & 2, 60HP, 6/8 Step Ctrl, AL, PW 195 - 205C 208/60/3 071668001CMPR #1 & 2, 60HP, 6/8 Step Ctrl, AL, PW 195 - 205C 230/60/3 071668101CMPR #1 & 2, 60HP, 6/8 Step Ctrl, AL, PW 195 - 205C 460/60/3 071668101CMPR #1 & 2, 60HP, 6/8 Step Ctrl, AL, PW 195 - 205C 575/60/3 047353000CMPR #3 & 4 60HP, 6 Step Ctrl, AL, PW 195 - 205C 208/60/3 071668201CMPR #3 & 4 60HP, 6 Step Ctrl, AL, PW 195 - 205C 230/60/3 071668301CMPR #3 & 4 60HP, 6 Step Ctrl, AL, PW 195 - 205C 460/60/3 071668301CMPR #3 & 4 60HP, 6 Step Ctrl, AL, PW 195 - 205C 575/60/3 047353000CMPR #3 & 4 60HP, 8 Step Ctrl, AL, PW 195 - 205C 208/60/3 071668001CMPR #3 & 4 60HP, 8 Step Ctrl, AL, PW 195 - 205C 230/60/3 071668101CMPR #3 & 4 60HP, 8 Step Ctrl, AL, PW 195 - 205C 460/60/3 071668101CMPR #3 & 4 60HP, 8 Step Ctrl, AL, PW 195 - 205C 575/60/3 047353000

Condenser Fan Section ODP Motor 1 HP, Speedtrol 105 - 205C 208-230/460/60/1 070989600ODP Motor 1 HP 105 - 205C 208-230/460/60/3 043219400ODP Motor 1 HP 105 - 205C 575/60/1 C081Motor 1.5 HP, TEAO 105 - 205C 208-230/60/3 034244100Motor 1.5 HP, TEAO 105 - 205C 460/60/3 044694300Motor 1.5 HP 105 - 205C 575/60/3 046744200Fan Prop, 4 Blade, 26” 105 - 205C N/A 043219300

Filter DrierFilter Drier, Core Sealed, 1-1/8” ODF 105 - 125C N/A 021057426Filter Drier Core, 5.5 X 3.7” 145 - 205C N/A 001360800



571149 Rev. Z 10/2016 CPL Page 10 of 10

Documents

McQuay Reciprocating Chiller - Daikin Appliedsalesportal.daikinapplied.com/bizlit/DocumentStorage/AirCooled...McQuay Reciprocating Chiller ALR 010-205 ... 37, 38 Components 060C 39,