RE

NR

8216

20 P

ag

e

RENR8216July 2006

D8R Series II Track-Type TractorElectrical SystemAKA1-4886YZ1-773

©2006 CaterpillarAll Rights Reserved

Printed in U.S.A.

Failure Mode Identifiers (FMI)1

FMI No. Failure Description0 Data valid but above normal operational range.1 Data valid but below normal operational range.2 Data erratic, intermittent, or incorrect.3 Voltage above normal or shorted high.4 Voltage below normal or shorted low.5 Current below normal or open circuit.6 Current above normal or grounded circuit.7 Mechanical system not responding properly.8 Abnormal frequency, pulse width, or period.9 Abnormal update.10 Abnormal rate of change.11 Failure mode not identifiable.12 Bad device or component.13 Out of calibration.14 Parameter failures.15 Parameter failures.16 Parameter not available.17 Module not responding.18 Sensor supply fault.19 Condition not met.20 Parameter failures.

1 The FMI is a diagnostic code that indicates what type of failure has occurred.

Service Mode NumberHour Meter 0

Harness Code Display 1

Parameter Display 2

Service Mode 3

Digital Tattletale 4

US/SI 5

Calibration 6

Calibration 7

Calibration 8

Charging 9

Monitoring System Service Modes

Machine CodeD8R 15

Machine Codes

Related Service ManualsForm Number

Alternator: 3E-7577 (75A) RENR1252 Alternator: 165-5140 (100A) SENR7508

Electric Starting Motor: 6V-0890 SENR3860Caterpillar Monitoring System: RENR2014

Engine ECM: SENR5003

Title

Number Error DescriptionE017 High Engine Coolant TemperatureE027 High Intake Air TemperatureE035 Loss Of Coolant Flow WarningE100 Low Engine Oil PressureE190 Engine OverspeedE265 User Defined ShutdownE272 Inlet Air Restriction

Engine Event Codes

Off Machine Switch SpecificationPart No. Function Actuate Deactuate Contact Position134-6054 Coolant Flow Switch 362 ± 29 mN

(1.3 ± 0.1 oz)303 mN

(1.1 oz MIN) Normally Open

114-5333 A/C (High / Low) Pressure 275 to 1750 kPa1

(39.9 to 253.8 psi)--

Normally Open2

105-9152 Pre Lube Oil Pressure 30±7 kPa1

(39.9 to 253.8 psi)30±7 kPa1

(39.9 to 253.8 psi) Normally Closed

1 With increasing pressure the closed condition can be maintained up to 2800 kPa (406 psi), with decreasing pressure the closed condition

2 Contact position at the contacts of the connector.

can be maintained down to 170 kPa (25 psi).

Resistor, Sender and Solenoid SpecificationsPart No. Component Description Resistance (Ohms)1

3E-1906 Solenoid: A/C Clutch 17.6 ± 0.6

3E-7842 Resistor: Starter Motor 150 ± 7.5

3E-8575 Solenoid: Ripper Pin 24.9 ± 0.4

4W-9972 Sender: XMSN Oil Temperature 560 to 716 @ 54°C (130°F)

72 to 82 @ 110°C (230° F)

116-6203 Resistor: Resistor 20 ± 1.0

125-3716 Solenoid: Hyd. Fan 3

136-1679 Solenoid: ECPC Pump 31 ± 3

Forward Clutch

Reverse Clutch

160-8408 Solenoid: First Gear Clutch 8.7 ± 0.4

Second Gear Clutch

Third Gear Clutch

172-2392 Solenoid: Park Brake Dump 41.9 ± 2.1

172-2392 Solenoid: Service Brake Dump 41.9 ± 2.1

174-4909 Solenoid: Left Brake 8.7 ± 0.4

1 At room temperature unless otherwise noted.

Component LocationComponent Schematic

LocationMachine Location Component Schematic

LocationMachine Location

Alarm - Action C-10 A Relay - Condensor (ROPS) F-15 42

Alarm - Backup A-15 15 Relay - Main H-9 38

Alternator H-2 11 Relay - Start H-9 38

Assembly - Receptacle F-7 32 Relay - Start Aid I-2 8

Auxiliary Start I-3 14 Resistor (Starter) I-3 1

Battery - 12 V 1 I-9 22 Resistor (Dash) D-9 A

Battery - 12 V 2 H-10 22 Resistor - Blower E-10 A

Battery - 12 V 3 I-10 22 Sender - Direction H-15 C

Battery - 12 V 4 H-10 22 Sensor - Atmospheric Pressure E-1 37

Breaker - Alternator H-9 38 Sensor - Brake Position B-9 35

Breaker - Converter 1 F-8 32 Sensor - Coolant Temperature F-1 13

Breaker - Converter 2 F-8 32 Sensor - Engine Oil Pressure E-1 37

Breaker - Drive Train I-8 38 Sensor - Engine Speed F-4 4

Breaker - Engine ECM Switched I-8 38 Sensor - Fuel Level E-14 26

Breaker - Engine ECM Unswitched I-8 38 Sensor - Fuel Temperature E-1 37

Control - ADEM Engine E-2 1 Sensor - Hydraulic Oil Temperature A-13 50

Control - ECB G-13 C Sensor - Inlet Air Temperature F-1 37

Converter - 10 A F-7 32 Sensor - Powertrain Oil Temperature F-4 19

Converter - 20 A G-8 32 Sensor - Primary Speed Timing F-2 8

Deceleration Pedal Position B-9 35 Sensor - Transmission Input Speed F-4 4

Diode A/C G-3 3 Sensor - Transmission Temperature G-4 18

Electronic Monitoring System C-9 A Sensor - Turbo Inlet Pressure E-4 47

Exciter Coil - MSS C-10 A Sensor - Turbo Outlet Pressure E-1 37

Fuse - 24 V- 12V Converter H-8 38 Solenoid - AC Clutch G-3 3

Fuse - AC Condensor H-8 38 Solenoid - ECPC Pump G-4 48

Fuse - Aux 1 H-8 38 Solenoid - First Gear Clutch I-14 17

Fuse - Aux 2 H-8 38 Solenoid - Forward Clutch I-14 17

Fuse - Aux 3 H-8 38 Solenoid - Injector 1 G-1 37

Fuse - Aux 4 H-8 38 Solenoid - Injector 2 G-1 37

Fuse - Blowers H-8 38 Solenoid - Injector 3 G-1 37

Fuse - Converter H-8 38 Solenoid - Injector 4 G-1 37

Fuse - EMS 11 H-8 38 Solenoid - Injector 5 G-1 37

Fuse - Fender Floods H-8 38 Solenoid - Injector 6 G-1 37

Fuse - Forward Horn H-8 38 Solenoid - Left Brake H-11 49

Fuse - Front Floods H-8 38 Solenoid - Parking Brake Dump I-11 49

Fuse - Key H-8 38 Solenoid - Reverse Clutch I-14 17

Fuse - MSS Product Link H-8 38 Solenoid - Ripper Pin B-15 16

Fuse - Priming Pump H-8 38 Solenoid - Second Gear Clutch I-14 17

Fuse - Rear Floods H-8 38 Solenoid - Service Brake Dump I-11 49

Fuse - Ripper Pin/Seat/Winch H-8 38 Solenoid - Start Aid I-1 8

Fuse - Service Brake H-8 38 Solenoid - Third Gear Clutch I-14 17

Fuse - Winch H-8 38 Solenoid - Winch B-15 16

Fuse - Wipers H-8 38 Suppressor - Arc 1 C-15 16

Gage Cluster C-9 A Suppressor - Arc 2 B-15 16

Ground - Alternator H-2 11 Switch - 4 Speed Blower D-11 A

Ground - Engine E-3 1 Switch - AC C-11 A

Ground - Engine Block H-2 1 Switch - Auto Downshift C-10 A

Ground - Frame H-3 39 Switch - Bi-Directional Mode C-10 A

Ground Frame H-10 40 Switch - Coolant Flow F-1 11

Ground - Headliner B-13 30 Switch - Disconnect H-10 22

Ground - Module I-6 40 Switch - Downshift G-15 C

Horn - Forward (SW) B-11 B Switch - Front Wiper C-13 30

Horn - Forward High I-1 7 Switch - Hydraulic Filter Bypass I-9 22

Horn - Forward Low I-1 7 Switch - Implement Lockout 2 A-8 B

Module - Lamp Gear C-9 A Switch - Key Start D-10 A

Motor - Blower 1 E-10 A Switch - Lamp B-11 A

Motor - Blower 2 D-10 A Switch - Left Wiper C-13 30

Motor - Condensor 1 A-15 41 Switch - Operator Monitor C-10 A

Motor - Condensor 2 A-15 41 Switch - Parking Brake F-15 C

Motor - Condensor Rops 1 F-14 42 Switch - Power Train Filter Pressure 1 A-13 29

Motor - Condensor Rops 2 E-14 42 Switch -Power Train Filter Pressure 2 A-13 29

Motor - Front Washer D-11 34 Switch - Prelube Oil Pressure I-4 51

Motor - Front Wiper C-12 43 Switch - Rear Wiper D-13 30

Motor - Left Wiper C-12 44 Switch - Refrigerant G-3 3

Motor - Rear Wiper D-12 46 Switch - Reverse G-15 C

Motor - Right Wiper C-12 45 Switch - Right Wiper C-13 30

Motor - Left Washer E-11 34 Switch - Ripper Flood C-11 A

Motor - Rear Washer D-11 34 Switch - Ripper Pin Pull A-11 B

Motor - Right Washer D-11 34 Switch - Service Brake Pedal B-9 35

Motor - Seat E-12 9 Switch - Start Aid D-10 A

Motor - Starter I-3 1 Switch - Throttle B-10 B

Outlet - 12 V 1 F-13 23 Switch - Upshift G-15 C

Outlet - 12 V 2 F-13 23 Switch - Winch A-12 B

ACC Power CONN - Switched E-7 38 Switch - Implement Lockout 1 A-8 B

ACC Power CONN - Unswitched F-7 38 Thermostat D-10 A

Prelube Starter I-3 1 Timer - Prelube I-5 8

Relay - Condensor (Fender) A-15 41

Machine locations are repeated for components located close together.

A = Located on dash.

B = Located inside of right console.

C = Located inside of left console.

D = Located around headliner.

A

3

4

56

8

910

11

1214

15

13

16

BC

D

1

2

17

18

19

20

21 2223

24 25

26

27

28 29

30

31

32

37

35

33

34

36

38

7

39

40

41

42

43

4445

46

47

48

A

3

4

5

6

8

9

10

11

12

14

15

13

16

B

C

D

1

2

17

18

19

20

21

22

23

24

25

262728 29

30

31

32

37

35

33

34

36

38

739

40

41

42

43

44

45

4647

48

Machine Harness Connector And Component Locations

27

4949

4949

50

50

51

51

39

Connector Location

Connector Number SchematicLocation

Machine Location

CONN 1 E-15 24CONN 2 E-14 25CONN 3 E-14 26CONN 4 D-14 27CONN 5 B-14 16CONN 6 B-14 16CONN 7 A-14 16CONN 8 A-14 28CONN 9 A-13 29CONN 10 C-13 30CONN 11 D-13 16CONN 12 D-13 16CONN 13 Datalink Service Connector E-13 23CONN 14 Monitor Service Connector E-13 23CONN 15 H-13 31CONN 16 I-13, F-10 31CONN 17 I-12, F-8 31CONN 18 H-12 20CONN 19 H;F-12 32CONN 20 Product Link I-13;F-10 33CONN 21 D-12 24CONN 22 B-12 ACONN 23 A-12 28CONN 24 A-12 29CONN 25 A-11 BCONN 26 D-11 ACONN 27 I-10 22CONN 28 A-9 BCONN 29 B-9 BCONN 30 E-9 ACONN 31 E-9 A

CONN 33 A-7 BCONN 34 B,C,D-7 ACONN 35 G-7 32CONN 36 G-7 4CONN 37 H,I-7 32CONN 38 E-6 10CONN 39 B-4 2CONN 40 C-4 4CONN 41 D-4 4CONN 42 D-3 3CONN 44 C-2 3CONN 45 G-2 4CONN 47 H-2 3CONN 48 I-2 3CONN 49 F-1 5CONN 50 Starting/Charging Analyzer I-7 32

The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart.

1

2

T

This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine.

This indicates that the component has a wire connected to it that is connected to ground.

105-9344

T

Normally open switch that will close with an increase of a specific condition (temp-press-etc.).The circle indicates that the component has screw terminals and a wire can be disconnected from it.

Pin SocketFuse

ComponentPart Number

Pin or Socket Number

Receptacle

Plug

Wire, Cable, or Harness Assembly Identification

Normally closed switch that will open with an increase of a specific condition.No circle indicates that the wire cannot be disconnected from the component.

Single Wire GroundConnectionConnector

PressureSymbol

TemperatureSymbol

LevelSymbol

FlowSymbol

Circuit BreakerSymbol

Reed Switch - A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

Sender - A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.

Relay (Magnetic Switch) - A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

Solenoid - A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.

Harness And Wire Symbols

Electrical Schematic Symbols And Definitions

1 12 2

Typical representation of aSure-Seal connector. The plugand receptacle containboth pins and sockets.

Typical representation ofa Deutsch connector. Theplug contains all socketsand the receptacle containsall pins.

325-A135 PK-14

AG-C4111-7898

L-C123E-5179

C-C4130-6795

** * *

*

CircuitNumberIdentification

WireColor

WireGauge

AG-C3130-6795

Harness identification letter(s) and aserializing code. The "C" stands forconnector and the number indicateswhich connector in the harness.

200-L32 BK-14

325-A135 PK-14

Part Number For Connector Assembly

Harness identification codeThis example indicateswire 135 in harness "AG".

Wire DescriptionWire

NumberWire Color Description Wire

NumberWire Color Description

Power Circuits Control Circuits (Continued)101 RD Battery (+) D791 YL Injector Common 5 & 6102 RD Front Flood Power E707 GN Display +V103 RD Aux Ckt E708 PK SPI Clock104 YL Aux Ckt E735 PU Cat Mon Sys Operator Switch105 RD Key Switch Power E793 BU ATA Datalink -106 PU Aux Ckt E794 YL ATA Datalink +110 GN Aux Ckt E795 YL Crankcase Press111 YL Aux Ckt E799 BR Solenoid Return112 PU Main Power Relay Output F700 BU Demand Fan Actuator113 OR Monitor Panel Power F701 BR Unused114 RD Warning Horn Power F702 GN Decelerator Pedal115 RD Aux Ckt F703 GY Fan Speed116 BR Rear Flood Power F704 OR Unused122 BU Aux Ckt F705 PK Unused124 GN A/C and Blower Power F706 PU Unused130 GN Auxiliary Power F707 WH Unused140 BU Powertrain Control Power F708 YL Unused150 RD Engine Control Power F709 BU Unused158 BR Remote A/C Condenser Power F710 BR Start Aid Relay160 RD Aux Ckt F711 GN Unused176 YL Seat Power F712 GY Unused184 BU Attachment Power F713 OR Unused186 RD Power Outlet Power F714 PK Turbo Inlet Pressure197 GN Implement Control Power F715 PU Throttle Switch (Low Idle)198 RD Secondary Brake Power F716 WH Throttle Switch (Low Idle Parity)

Ground Circuits F717 YL Throttle Switch (High Idle)200 BK Main Chassis Ground F718 BU Throttle Switch (High Idle Parity)201 BK Operator Monitor Return F719 BR Crank w/o Inject (N.O.)202 BK XMSN Ctrl F720 GN Crank w/o Inject (N.C.)203 BK Chassis Ground Diagnostic F721 GY Start Aid Switch205 BK Instr F722 OR Demand Fan A/C Status207 BK Starter Ground Diagnostic F723 PK TDC Probe +229 BK Engine Control Ground F724 PU TDC Probe -270 BK Cat Mon Sys Ident Code 0 F725 WH Unused271 BK Cat Mon Sys Ident Code 1 F732 PK Backup Camshaft Speed/Timing272 BK Cat Mon Sys Ident Code 2 F780 PK Parking Brake SW273 BK Cat Mon Sys Ident Code 3 F782 OR Reverse Sw N.O.274 BK Cat Mon Sys Ident Code 4 F783 GN Upshift SW N.O.275 BK Cat Mon Sys Ident Code 5 F784 YL Downshift SW N.O.276 BK XMSN Ctrl Indent Code 0 F785 WH Upshift SW N.C.277 BK XMSN Ctrl Indent Code 1 F786 GY Reverse Sw N.C.278 BK XMSN Ctrl Indent Code 2 F788 PU Left Steer Clutch279 BK XMSN Ctrl Indent Code 3 F789 YL Right Steer Clutch280 BK XMSN Ctrl Indent Code 4 F790 BR Service Brake Pedal290 BK Cat Mon Sys Service F791 BU Right Brake Solenoid

A234 BK J1939 Shield Ground F792 WH Left Brake SolenoidBasic Machine Circuits G703 GN Quick Drop Valve

301 BU Starter No. 1 Solenoid G730 PK EPTC II - Park Brake Sol302 OR Starter No. 1 Resistor to Diagnostic G731 GY EPTC II - Secondary Serivce Brake Sol304 WH Starter Relay No. 1 Output J702 BK Engine Retarter Sol Cyl 1, 2, 5, 6306 GN Starter Relay to Neutral Start SW or Key SW M732 OR +V Crank Driver Rtm (MSS)307 OR Key Switch to Neutral Start Switch M733 PK +V Sw On Driver Rtn (MSS)308 YL Main Power Relay Coil 828 WH Left Steer EDC Sol To Right Steer EDC Sol310 PU Start Aid Switch to Start Aid Solenoid 830 OR Propel Balance Pot. To EDC Sol Resistor321 BR Backup Alarm 851 WH Diode To Right Flow Gate SW322 GY Warning Horn (Forward) 892 BR CAT Data Link (-)337 WH Prelube Pushbutton Switch to Prelube Timer 893 GN CAT Data Link (+)374 PK Neutral Start SW To Park Brake SW F842 BU Implement Lockout SW 2

A346 BU +V Crank Driver Out (MSS) F843 YL Inching Pedal SensorA347 GN +V SW On Driver Out (MSS) F846 PU MSS LED

Monitoring Circuits F847 YL Aux Ckt403 GN Alternator (R) Term. F848 OR Bi Directional Mode SW410 WH Action Alarm F849 WH Bi Directional Mode SW411 PK Master Fault Lamp F850 PK Amp Signal To Recording Module412 BU Engine Coolant Flow G808 BU Vehicle Speed+/TDC Service Probe+419 YL Opr Mon Parking Brake G833 PK Engine Temperature Sensor Common426 BR Powertrain Oil Filter Differential Pressure G848 GN LED Driver 2442 GY Hydraulic Oil Temperature G849 BR Engine Inj Actuation Pressure443 YL Powertrain Oil Temperature G850 BU Inlet Air Heater447 PK Fuel Level G854 PK Inj Actuation Press Cont Valve450 YL Engine Speed G855 PU IAP Cont Valve Common451 BR Tach Sender (=) G856 WH TDC Probe +

A447 PK Engine Oil Prelube Pressure Switch G857 YL TDC Probe -C413 YL SPI Data 900 PU XMSN Shift Sol No. 5 Or 4C414 BU SPI Load 973 BR CST Autoshift - Auto/Manual SW 2

Accessory Circuits 975 WH CST Autoshift - Sol Return500 BR Wiper - Front (Park) 977 YL CST Autoshift - Slow Mode SW 1501 GN Wiper - Front (Low) 993 BR Engine Control Analog Sensor Common502 OR Wiper - Front (HI) 994 GY Engine Control Oil Pressure (Filtered)503 BR Wiper - Rear (Park) 995 BU Engine Control Coolant Temperature504 YL Wiper - Rear (Low) 996 GN Engine Speed/Timing Sensor Power505 BU Wiper - Rear (HI) 997 OR Engine Control Analog Sensor Power (+ 5V)506 PU Washer - Front 998 BR Engine Digital Sensor Return507 WH Washer - Rear 999 WH Engine Primary Camshaft Speed/Timing508 PU Radio Speaker - Left C967 BU Inlet Air Temperature509 WH Radio Speaker - Left (Common) C987 RD +Battery511 BR Radio Speaker - Right C991 PK Fuel Filter Monitor512 GN Radio Speaker - Right (Common) E900 WH ECPC Trans Output SPD +513 GN A/C Compressor/Refrigerant Pressure Switch E901 GN ECPC Trans Output SPD -515 GY Blower Motor (HI) E902 PU ECPC Trans Intermediate SPD +516 GN Blower Motor (Medium) E903 YL ECPC Trans Intermediate SPD -517 BU Blower Motor (Low) E904 BR ECPC Trans Intermediate SPD Q+521 YL A/C Switch to Refrigerant Switch E905 BU ECPC Trans Intermediate SPD Q-522 WH A/C Clutch to Thermostat Switch E906 OR ECPC Trans Output SPD Q+523 BR Wiper - Left (Park) E907 GY ECPC Trans Output SPD Q-524 BU Wiper - Left (Low) E908 BR ECPC Trans Input SPD +525 GY Wiper - Left (HI) E909 WH ECPC Trans Input SPD -526 YL Wiper - Right (Park) E963 BK Engine Speed/Timing A-527 GN Wiper - Right (Low) E964 WH Engine Speed/Timing A+528 PK Wiper - Right (HI) E965 BU Engine Speed/Timing B-529 WH Washer Left E966 YL Engine Speed/Timing B+530 OR Washer Right G939 PK Reverse Switch Return567 WH A/C SW Jumper J992 YL Unused592 BU DC/DC Converter Output J993 PK Unused593 GN Condenser Fan Relay to Motors J994 GY Unused

A513 PK DC/DC Converter Memory Output J995 PU UnusedC568 WH Blower Motor (MAX) K977 PK ECPC Trans Oil Temp Sensor

Lighting Circuits K978 BU ECPC Pump Sol600 BR Dash Lamp Basic L983 WH Injector Common 1 & 2608 GN Flood Lamp - Rear L984 OR Injector Common 3 & 4609 YL Flood Lamp - Side L985 YL Injector Common 5 & 6610 OR Flood Lamp - Front N931 GY Hydraulic Pump Pressure630 GY Flood Lamp - Rear Ripper N940 BU Engine Analog Sensor Power (+5V) 663 GY Gage Lamps - Cat Mon Sys N941 YL Engine Analog Sensor Return

Control Circuits N942 OR Flexxaire Fan709 OR Sensor Power Supply N943 BR Unused751 GN XMSN Shift Sol No. 1 Or 3 N944 PU Engine Digital Sensor Return752 YL XMSN Shift Sol No. 2 T901 YL MSS Exciter Coil In754 BU XMSN Shift Sol No. 3 Or 1 T902 PK MSS Exciter Coil Out755 OR XMSN Shift Sol No. 4 Or 5 T920 YL Digital Sensor 5A779 WH Ripper Pin Engage Solenoid T945 GY Brake Return 1780 PU Ripper Pin Disengage Solenoid T946 PU Brake Return 2

A700 OR Engine Control Digital Sensor Power (+8V) T947 YL Brake Return 3A701 GY Injector #1 T948 BR Brake Return 4A702 PU Injector #2 T949 BU Brake Return 5A703 BR Injector #3 T950 GN Brake Return 6A704 GN Injector #4 T951 YL Inj 1 High SideA705 BU Injector #5 T952 BR Inj 2 High SideA706 GY Injector #6 T953 BU Inj 3 High SideA745 WH Fuel Pressure T954 GY Inj 4 High SideA746 PK Turbo Outlet Pressure T955 GN Inj 5 High SideA747 GY Atmospheric Pressure T956 GY Inj 6 High SideA751 YL Fuel Temperature T957 PU Inj 1 ReturnD786 BR Engine Retarder Sol Cyl 1, 2, 5 , 6 T958 YL Inj 2 ReturnD787 GN Engine Retarder Sol 3, 4 T959 BR Inj 3 ReturnD788 BK Engine Retarder Sol Common T960 BU Inj 4 ReturnD789 WH Injector Common 1 & 2 T961 GN Inj 5 ReturnD790 OR Injector Common 3 & 4 T962 WH Inj 6 Return

CONN 32 E-6 8

Component Identifiers (CID¹)Module Identifier (MID²)

Caterpillar Monitoring System(MID No. 030)

CID Component0096 Fuel Level Sender0177 Torque Converter Oil Temperature Sensor0248 Data Link0263 Sensor Power Supply0271 Action Alarm0324 Action Lamp0600 Hydraulic Oil Temperature Sensor0819 Display Data Link0821 Display Power Supply

Engine Control System(MID No. 036)

CID Component0001 Injector Cylinder 10002 Injector Cylinder 20003 Injector Cylinder 30004 Injector Cylinder 40005 Injector Cylinder 50006 Injector Cylinder 60091 Throttle Position0100 Oil Pressure0110 Coolant Temperature0168 Battery Voltage0172 Intake air Temperature0174 Fuel Temperature0190 Engine Speed0248 CAT Data Link Communications0253 Personality Module0254 ECM Fault0261 Engine Timing Calibration0262 Analog Sensor0263 Digital Sensor Supply Short0264 Deceleration Throttle Output0266 Crank Without Inject Inputs0268 Program Parameters/ECM Fault0273 Turbo Out Pressure0274 Atmospheric Pressure0275 Turbo Inlet Air Pressure0545 Start Aid0799 Service Tool

Transmission Control System(MID No. 113)

CID Component0070 Parking Brake Switch0075 Steering Oil Temperature Sensor0168 Electrical System Voltage0177 Transmission Temperature Sensor0190 Engine Speed Sensor0248 CAT Data Link0254 Power Train ECM0269 Steering Temperature Sensor0298 Service Brake0299 Transmission Direction Selector0368 Transmission Auto/Manual Switch0468 Brake Pedal Position Sensor0490 Implement Lockout0573 Inching Pedal Position Sensor0618 Park Brake Switch0621 Downshift Switch0622 Upshift Switch0623 Directional Switch0650 Harness Code0668 Transmission Lever Position Sensor0671 Transmission Output Speed Sensor0672 Torque Converter Speed Sensor0673 Transmission Speed Sensor0674 Transmission Intermediate Speed Sensor0675 Transmission Intermediate Speed Sensor0676 Left Steering Position Sensor0677 Right Stering Position Sensor0689 Left Steering Brake Solenoid0690 Right Steering Brake Solenoid0691 Reverse Clutch Solenoid0692 Forward Clutch Solenoid0693 Third Gear Clutch Solenoid0694 Second Gear Clutch Solenoid0695 First Gear Clutch Solenoid0697 Priority Valve Solenoid0698 Left Steering Clutch Solenoid0699 Right Steering Clutch Solenoid0718 Third Gear Sensor0722 Secondary Brake Solenoid1327 Left Brake Pedal Attachment1328 Right Service Brake Position Sensor1329 Left Brake Pedal Switch1330 Right Brake Pedal Switch1488 Implement Detent1870 Position Thumb Lever Blade Control1933 Left Blade Angle Solenoid1934 Right Blade Angle Solenoid

¹ The CID is a diagnostic code that indicates which circuit is faulty.

² The MID is a diagnostic code that indicates which electronic control modulediagnosed the fault.

Transmission: SENR8367

RE

NR

8216

20 P

ag

e

200-M219 BK-18

307-E4 OR-18

307-E4 OR-18

105-E5 RD-18

105-E5 RD-18

F849-E13 WH-18 F849-E13 WH-18

F848-E14 OR-18

F848-E14 OR-18

F848-E14 OR-18

201-E15 BK-18

200-E16 BK-14

G939-E17 PK-18

G939-E17 PK-18

977-E18 YL-18

977-E18 YL-18

G939-E19 PK-18

G939-E19 PK-18

201-E21 BK-18

201-E21 BK-18

E735-E23 PU-18

E735-E23 PU-18

E735-E22 PU-18

E735-E24 PU-18

E735-E24 PU-18

124-E30 GN-14

124-E30 GN-14

124-E30 GN-14

C568-E25 WH-14

C568-E25 WH-14

515-

E26

GY-

14

515-E26 GY-14

516-E27 GN-14

516-E27 GN-14

517-

E28

BU

-14

517-E28 BU-14567-E29 WH-14

567-E29 WH-14

609-E31 YL-14

609-E31 YL-14

608-E32 GN-14

608-E32 GN-14

610-E33 OR-14

610-E33 OR-14

116-E35 RD-14

103-E36 RD-14

410-E37 WH-18

410-E37 WH-18

201-E38 BK-18

201-E38 BK-18

C414-E40 BU-18

C414-E40 BU-18C414-E41 BU-18

C414-E41 BU-18

C414-E39 BU-18

C414-E39 BU-18

C413-E43 YL-18

C413-E43 YL-18C413-E42 YL-18

C413-E42 YL-18

C413-E44 YL-18

E708-E46 PK-18

E708-E46 PK-18E708-E45 PK-18

E708-E47 PK-18

E707-E49 GN-18

E707-E49 GN-18E707-E48 GN-18

E707-E48 GN-18

E707-E50 GN-18

113-E74 OR-18

113-E74 OR-18

201-E52 BK-18

201-E52 BK-18

201-E52 BK-18

201-E52 BK-18

201-E53 BK-18

201-E53 BK-18

201-E54 BK-18

E707-E50 GN-18

201-E53 BK-18

E708-E47 PK-18

C413-E44 YL-18

E708-E45 PK-18

113-E74 OR-18

977-E18 YL-18

F848-E14 OR-18

F849-E13 WH-18

307-E4 OR-18

124-E30 GN-14

200-E16 BK-14

201-E15 BK-18

201-E53 BK-18

G939-E17 PK-18

201-E21 BK-18

G939-E19 PK-18

201-E38 BK-18

977-E18 YL-18

F849-E13 WH-18

105-E5 RD-18

307-E4 OR-18

124-E30 GN-14

113-E74 OR-18

113-E74 OR-18

E735-E23 PU-18

630-E73 GY-16

630-E73 GY-16

630-E73 GY-16

630-E73 GY-16

505-HA2 BU-18

504-HA3 YL-18

504-HA3 YL-18

503-HA4 BR-18

503-HA4 BR-18

526-HA9 YL-18

526-HA9 YL-18

528-HA7 PK-18

528-HA7 PK-18

527-HA8 GN-18

527-HA8 GN-18

108-HA6 BU-16

108-HA6 BU-16

108-

HA

29B

U-1

610

8-H

A28

BU

-16

108-

HA

27B

U-1

6

528-H9 PK-18

528-H9 PK-18

527-H8 GN-18

527-H8 GN-18526-H7 YL-18

526-H7 YL-18

523-HA14 BR-18

523-HA14 BR-18 523-H12 BR-18

523-H12 BR-18525-H14 GY-18

525-H14 GY-18525-HA12 GY-18

525-HA12 GY-18

524-HA13 BU-18

524-HA13 BU-18 524-H13 BU-18

524-H13 BU-18

502-HA15 OR-18

502-HA15 OR-18 502-H19 OR-18

502-H19 OR-18

501-H18 GN-18

501-H18 GN-18501-HA16 GN-18

501-HA16 GN-18

500-HA17 BR-18

500-HA17 BR-18 500-H17 BR-18

500-H17 BR-18

108-H32 BU-16

108-H28 BU-16

108-H28 BU-16

108-H10 BU-16

108-H10 BU-16108-H15 BU-16

108-H15 BU-16

108-H20 BU-16

108-H20 BU-16

108-H22 BU-16

108-E56 BU-16

108-E56 BU-16

108-E56 BU-16

108-E56 BU-16

200-H6 BK-16

200-H6 BK-16200-H11 BK-16

200-H11 BK-16

200-H16 BK-16

200-H16 BK-16

200-H33 BK-16200-HA25 BK-16

200-HA26 BK-16

200-HA25 BK-16200-HA5 BK-16

103-HA24 RD-18

103-HA24 RD-18 103-H21 RD-18

103-H21 RD-18103-E55 RD-18

103-E55 RD-18

200-

H31

BK

-14

447-E61 PK-18

447-E61 PK-18

447-E61 PK-18

447-E61 PK-18

447-E61 PK-18

442-E62 GY-18

442-E62 GY-18

442-E62 GY-18

442-E62 GY-18

442-E62 GY-18

443-E68 YL-18

443-E68 YL-18

443-E68 YL-18

443-E68 YL-18

443-E68 YL-18

403-E69 GN-18

403-E69 GN-18

403-E69 GN-18

403-E69 GN-18

403-E69 GN-18

426-E66 BR-18

426-E66 BR-18

426-E66 BR-18

426-E66 BR-18

426-E66 BR-18

201-E57 BK-18

201-E57 BK-18

201-E57 BK-18

201-E57 BK-18

200-E72 BK-14

270-E70 BK-18

270-E70 BK-18271-E58 BK-18

271-E58 BK-18

272-E63 BK-18

272-E63 BK-18273-E67 BK-18

273-E67 BK-18

274-E65 BK-18

274-E65 BK-18275-E60 BK-18

275-E60 BK-18

201-E71 BK-18

201-E71 BK-18

893-E59 GN-18

893-E59 GN-18

893-E59 GN-18

893-E59 GN-18

893-E59 GN-18892-E64 BR-18

892-E64 BR-18

892-E64 BR-18

892-E64 BR-18

892-E64 BR-18

291-E75 BK-18

291-E75 BK-18

291-E75 BK-18

291-E75 BK-18

291-E75 BK-18290-E76 BK-18

290-E76 BK-18

290-E76 BK-18

290-E76 BK-18

290-E76 BK-18

A513-E77 PK-18

A513-E77 PK-18

A513-E77 PK-18

A513-E77 PK-18

592-E78 BU-18

592-E78 BU-18

592-E78 BU-18

592-E78 BU-18

411-E79 PK-18

411-E79 PK-18

201-E99 BK-18

201-E99 BK-18

200-H27 BK-18

508-H26 PU-18

511-H30 BR-18

511-H30 BR-18

512-H29 GN-18

512-H29 GN-18

509-H25 WH-18

509-H25 WH-18

508-H26 PU-18

592-H24 BU-18A513-H23 PK-18

A513-H23 PK-18592-H24 BU-18

509-HA10 WH-18

509-HA10 WH-18508-HA11 PU-18

508-HA11 PU-18

511-HA18 BR-18

511-HA18 BR-18

512-HA19 GN-18

512-HA19 GN-18

507-HA20 WH-18

507-HA20 WH-18

530-HA21 OR-18

530-HA21 OR-18529-HA22 WH-18

529-HA22 WH-18

506-HA23 PU-18

506-HA23 PU-18

200-HA5 BK-16

517-E28 BU-14

516-

E27

GN

-14

515-E26 GY-14

C56

8-E

25W

H-1

4200-HH5 BK-18

200-HH5 BK-18

200-HH8 BK-18

200-HH7 BK-18200-HH6 BK-18

507-H1 WH-18

507-H1 WH-18 507-HH1 WH-18

507-HH1 WH-18

530-H2 OR-18

530-H2 OR-18 530-HH2 OR-18

530-HH2 OR-18

506-HH4 PU-18

506-HH4 PU-18506-H4 PU-18

506-H4 PU-18

529-H3 WH-18

529-H3 WH-18 529-HH3 WH-18

529-HH3 WH-18

200-H5 BK-18

200-H5 BK-18

522-

EE

5W

H-1

4

522-EE5 WH-1420

0-E

E10

BK

-14

200-EE10 BK-14

200-EE9 BK-14

200-EE2 BK-14200-EE11 BK-14

515-EE7 GY-14

515-EE8 GY-14

515-EE1 GY-14

515-

EE

1G

Y-14

C56

8-E

E12

WH

-14

C568-EE12 WH-14

516-

EE

3G

N-1

4

516-EE3 GN-14

517-EE4 BU-14

517-

EE

4B

U-1

4

201-E71 BK-18

200-E105 BK-18

200-E105 BK-18

200-E105 BK-18

200-E105 BK-18200-E104 BK-18

200-E104 BK-18

200-E104 BK-18

200-E104 BK-18

663-E103 GY-18

663-E103 GY-18663-E101 GY-18

663-E101 GY-18

663-E101 GY-18

663-E101 GY-18

663-E102 GY-18

663-E102 GY-18

663-E102 GY-18

663-E102 GY-18

522-

E92

WH

-14

522-E92 WH-14

522-E92 WH-14

522-E92 WH-14

522-E92 WH-14

521-E85 YL-14

521-E85 YL-14

521-E85 YL-14

521-E85 YL-14

521-E84 YL-18

600-E90 BR-18

200-E93 BK-14

200-

E93

BK

-14

200-E82 BK-18

200-E82 BK-18

200-E83 BK-18

200-E88 BK-18200-E88 BK-18

200-E87 BK-18

200-E87 BK-18

600-E81 BR-18

600-E81 BR-18

600-E86 BR-18

200-H27 BK-18

600-E91 BR-18600-E94 BR-18

600-E94 BR-18

600-E98 BR-18

600-E98 BR-18

600-E96 BR-18

600-E96 BR-18

200-E95 BK-18

N931-E80 GY-18

N931-E80 GY-18

N931-E80 GY-18

N931-E80 GY-18

N931-E80 GY-18

200-EE9 BK-14

515-EE7 GY-14515-EE8 GY-14

200-EE2 BK-14

515-EE6 GY-14

140-M3 BU-14

140-M3 BU-14

140-M5 BU-14

140-M5 BU-14140-M6 BU-14

140-M6 BU-14

F790-M57 BR-18

F790-M57 BR-18

892-M8 BR-18

893-M9 GN-18

140-M58 BU-18

140-M58 BU-18

G731-KK1 GY-18198-KK2 RD-18

198-M71 RD-18

198-M71 RD-18

198-M71 RD-18

600-RA12 BR-18

600-RA11 BR-18

200-RA9 BK-18

200-RA8 BK-18

998-RA10 BR-18

998-RA13 BR-18

998-M70 BR-18

F721-E107 GY-18

F721-E107 GY-18

F721-E107 GY-18

F721-E107 GY-18

200-G3 BK-14

200-G1 BK-14200-G2 BK-14322-G6 GY-14

322-G5 GY-14

322-G4 GY-14

200-G2 BK-14

322-G6 GY-14322-G5 GY-14

200-G1 BK-14

610-G7 OR-14610-G10 OR-14

610-G10 OR-14

610-G11 OR-14610-G11 OR-14

200-G9 BK-14

200-G9 BK-14

200-G9 BK-14

200-G8 BK-14

200-G8 BK-14

322-M90 GY-18

114-M72 RD-18

114-M72 RD-18

114-M72 RD-18

140-M58 BU-18

140-M6 BU-14140-M3 BU-14

114-M72 RD-18

201-M91 BK-18

113-M75 OR-18

113-M75 OR-18

113-M75 OR-18

103-M77 RD-14

103-M77 RD-14

103-M77 RD-14310-M84 PU-18

CB

L-A

R1

BK

-00

304-M96 WH-8

116-M88 RD-14

116-M88 RD-14

116-M88 RD-14

116-M88 RD-14

108-M100 BU-16

108-M100 BU-16

108-M100 BU-16

186-M92 WH-18

186-M92 WH-18

A513-M94 PK-18

A513-M94 PK-18

A513-M94 PK-18

186-M92 WH-18

200-M105 BK-18200-M105 BK-18

124-M104 GN-14

124-M104 GN-14

124-M104 GN-14

124-M104 GN-14

124-M104 GN-14

176-M112 YL-14

977-M113 YL-18

977-M113 YL-18

F848-M117 OR-18

F848-M117 OR-18

F849-M118 WH-18

F849-M118 WH-18

308-E3 YL-18

308-E3 YL-18

308-E3 YL-18

308-E3 YL-18

140-M58 BU-18G731-M59 GY-18

411-E1 PK-18

411-E1 PK-18

411-E1 PK-18 411-M89 PK-18

G939-E2 PK-18

G939-E2 PK-18 G939-M121 PK-18F846-E6 PU-18

F846-E6 PU-18

F846-E6 PU-18

F846-E6 PU-18G848-E108 GN-18

G848-E108 GN-18

G848-E108 GN-18

G848-E108 GN-18

T901-E109 YL-18

T901-E109 YL-18

T901-E109 YL-18

T901-E109 YL-18

T902-E110 PK-18

T902-E110 PK-18

T902-E110 PK-18

T902-E110 PK-18

426-M101 BR-18

442-M126 GY-18 F848-M117 OR-18

A513-M94 PK-18

113-M75 OR-18

592-M128 BU-18

592-M128 BU-18

200-M130 BK-18

113-M135 OR-18

113-M135 OR-18

106-M134 RD-18

106-M134 RD-18

106-M134 RD-18

106-M134 RD-18

A513-M94 PK-18

426-M101 BR-18

F849-M118 WH-18977-M113 YL-18592-M95 BU-18

108-M100 BU-16

103-M77 RD-14

F848-M117 OR-18

124-M104 GN-14

893-M111 GN-18

893-M111 GN-18892-M122 BR-18

892-M123 BR-18

892-M123 BR-18893-M124 GN-18

893-M124 GN-18

E735-M140 PU-18

E735-M140 PU-18

E735-M140 PU-18

290-M139 BK-18

290-M139 BK-18

290-M139 BK-18

291-M141 BK-18

291-M141 BK-18

201-M142 BK-18

201-M142 BK-18

201-M147 BK-18

201-M147 BK-18

E735-M140 PU-18

E735-M140 PU-18

290-M139 BK-18291-M141 BK-18

290-M139 BK-18291-M141 BK-18

337-M138 WH-18

337-M137 WH-18337-M136 WH-18

337-M136 WH-18

337-M136 WH-18

105-M98 RD-18

105-M98 RD-18

105-M98 RD-18

105-M98 RD-18

105-M98 RD-18

608-M155 GN-14

608-M155 GN-14

608-M155 GN-14

608-M155 GN-14

447-M150 PK-18

447-M150 PK-18

447-M150 PK-18

447-M150 PK-18

201-M151 BK-18

200-M153 BK-14

201-M154 BK-18

201-M154 BK-18

207-M156 BK-18

207-M156 BK-18302-M157 OR-18

103-M77 RD-14

186-M92 WH-18

103-M77 RD-14

158-M144 BR-14

521-M159 YL-14

521-M159 YL-14

158-M144 BR-14

521-M159 YL-14

610-G11 OR-14

403-M162 GN-18

322-R1 GY-18

322-R1 GY-18114-R2 RD-18

201-R7 BK-18

201-R7 BK-18411-R8 PK-18

F715-RA1 PU-18F715-RA1 PU-18

F718-RA4 BU-18 F718-RA4 BU-18

F716-RA2 WH-18

F716-RA2 WH-18

F717-RA3 YL-18

F717-RA3 YL-18

600-RA6 BR-18

600-RA6 BR-18

998-RA5 BR-18

998-RA5 BR-18200-RA7 BK-18

426-M101 BR-18

442-M126 GY-18

600-M51 BR-18

411-M89 PK-18

114-M72 RD-18322-M90 GY-18

307-CF1 OR-16

307-CF1 OR-16

116-CF2 BR-16

116-CF2 BR-16

337-CF3 WH-16

337-CF3 WH-16

A447-CF7 PK-16

A447-CF7 PK-16200-CF4 BK-16

200-CF5 BK-16

200-CF6 BK-16

200-CF6 BK-16

101-CF9 RD-4

301-CF8 BU-4

101-CF9 RD-4

301-CF8 BU-4

200-CF6 BK-16

FOR ENGINE PRELUBEPLUG CF-C1 INTO M-C32

108-M65 BU-16

108-M65 BU-16108-M65 BU-16108-M100 BU-16108-M83 BU-16

108-M83 BU-16200-CE1 BK-0

521-M68 YL-14

521-M67 YL-14

521-M67 YL-14

779-M170 WH-18779-M170 WH-18

779-M170 WH-18

779-M170 WH-18

780-M171 PU-18

780-M171 PU-18

780-M171 PU-18

610-M186 OR-14

610-M186 OR-14

609-M187 YL-14

609-M187 YL-14

609-MT2 YL-14609-M189 YL-14

609-M189 YL-14

200-M179 BK-14

200-M179 BK-14 200-MT1 BK-14

200-MR2 BK-14200-M63 BK-14609-MR1 YL-14609-M191 YL-14

609-M191 YL-14

998-M55 BR-18

521-M67 YL-14

322-M90 GY-18

998-M82 BR-18

310-M84 PU-18

108-M65 BU-16

302-M157 OR-18

F715-M1 PU-18

F715-M1 PU-18

F718-M2 BU-18

F718-M2 BU-18F717-M53 YL-18

F717-M53 YL-18

F717-M53 YL-18F716-M52 WH-18

F716-M52 WH-18

F716-M52 WH-18

F702-M56 GN-18

F702-M56 GN-18

A700-M54 OR-18

A700-M54 OR-18F721-M60 GY-18

F721-M60 GY-18

F721-M60 GY-18F721-M60 GY-18

F721-M60 GY-18

102-M61 RD-14

102-M61 RD-14

102-M61 RD-14

102-M61 RD-14150-M62 RD-14

150-M62 RD-14

150-M62 RD-14

150-M62 RD-14

150-M62 RD-14

302-M157 OR-18

310-M84 PU-18

310-M84 PU-18

310-M84 PU-18

592-M128 BU-18

592-M128 BU-18

200-M105 BK-18

200-KA2 BK-16

630-M64 GY-16

630-M64 GY-16

630-M64 GY-16

630-M64 GY-16

200-M160 BK-10

200-M160 BK-10

158-M144 BR-14

892-M182 BR-18

893-M174 GN-18

893-M174 GN-18

893-M174 GN-18

892-M182 BR-18

630-KA1 GY-16

521-M180 YL-14

521-M180 YL-14

780-R4 PU-18

780-R4 PU-18

779-R9 WH-18

779-R9 WH-18

176-R5 YL-18

176-R5 YL-18

176-M112 YL-14

176-M183 YL-14

176-M183 YL-14176-M184 YL-18

176-M184 YL-18

176-M184 YL-18

176-M184 YL-18

CBL-AY1 BK-00

CB

L-AV

1B

K-0

0

403-M162 GN-18

158-M144 BR-14158-M192 BR-14

158-M192 BR-14

158-M185 BR-14

158-M185 BR-14

158-M185 BR-14

200-M190 BK-14

200-M190 BK-14

411-R8 PK-18

114-R2 RD-18

200-RA7 BK-18 200-M22 BK-18

201-M28 BK-18

201-M26 BK-18

102-M61 RD-14

592-M129 BU-14

592-M129 BU-14

200-M131 BK-14

522-M193 WH-14

522-M193 WH-14

522-M193 WH-14

522-M193 WH-14

522-M193 WH-14201-M28 BK-18 G939-M12 PK-18

322-M90 GY-18

200-M14 BK-14

200-M80 BK-16

200-M178 BK-14

176-RW1 YL-18779-RW3 WH-18

779-RW4 WH-18

780-RW6 PU-18

779-RW5 WH-18176-RW1 YL-18

ATTACH WINCH SW

780-KW1 PU-18

780-KW3 PU-18

780-KW2 PU-18779-KW4 WH-18

200-M22 BK-18

200-M14 BK-14

201-M154 BK-18

521-M159 YL-14

447-M150 PK-18

158-M144 BR-14200-M153 BK-14

608-M155 GN-14

630-M64 GY-16

779-M170 WH-18780-M171 PU-18

200-M80 BK-16

779-M170 WH-18

176-M112 YL-14

176-M112 YL-14

200-M131 BK-14

200-M131 BK-14

200-M172 BK-10

200-M63 BK-14

200-M63 BK-14

201-M151 BK-18

201-M151 BK-18

893-M111 GN-18

893-M111 GN-18

893-M9 GN-18

893-M9 GN-18893-M124 GN-18

304-M96 WH-8

892-M122 BR-18

892-M122 BR-18

892-M122 BR-18200-M130 BK-18

200-M178 BK-14

108-H22 BU-16108-H32 BU-16

411-E113 PK-18

521-E84 YL-18

521-E100 YL-18

521-E100 YL-18

G731-M59 GY-18F790-M57 BR-18

592-M95 BU-18

113-M75 OR-18

198-M71 RD-18

998-M82 BR-18998-M70 BR-18998-M55 BR-18

610-M186 OR-14

610-M186 OR-14

E735-E22 PU-18

105-E5 RD-18

893-M174 GN-18

893-M111 GN-18

892-M8 BR-18

892-M122 BR-18892-M182 BR-18

892-M182 BR-18

892-M123 BR-18

893-M124 GN-18

521-M68 YL-14

609-M191 YL-14609-M189 YL-14

201-M154 BK-18

114-M72 RD-18

158-M185 BR-14

322-M90 GY-18

780-M171 PU-18

176-M184 YL-18

200-M130 BK-18

200-M130 BK-18

442-M126 GY-18

411-M89 PK-18

521-M67 YL-14

114-M72 RD-18

322-M90 GY-18

158-M185 BR-14

780-M171 PU-18

779-M170 WH-18

176-M184 YL-18

521-M180 YL-14

426-M101 BR-18

442-M126 GY-18

411-M89 PK-18

200-M190 BK-14

200-M22 BK-18

201-M28 BK-18201-M26 BK-18

201-M26 BK-18

198-M71 RD-18

G939-M12 PK-18

200-M179 BK-14

G731-M59 GY-18F790-M57 BR-18

140-M58 BU-18

201-M91 BK-18

201-M127 BK-18

201-M127 BK-18

200-M149 BK-10

200-M74 BK-10

201-M151 BK-18

998-M55 BR-18F702-M56 GN-18

998-M70 BR-18

F715-M1 PU-18F716-M52 WH-18

F718-M2 BU-18

A700-M54 OR-18

F718-M2 BU-18998-M70 BR-18

F717-M53 YL-18

F716-M52 WH-18

600-M51 BR-18

F718-M2 BU-18

998-M70 BR-18

F715-M1 PU-18

F717-M53 YL-18

F716-M52 WH-18

A700-M54 OR-18

F717-M53 YL-18

F715-M1 PU-18F702-M56 GN-18

F718-M2 BU-18

A700-M54 OR-18

200-M105 BK-18

200-M14 BK-14200-M80 BK-16

290-M139 BK-18

E735-M140 PU-18

291-M141 BK-18

106-M134 RD-18

892-M123 BR-18

200-M131 BK-14

176-M112 YL-14

201-M154 BK-18

447-M150 PK-18521-M159 YL-14

608-M155 GN-14

630-M64 GY-16

780-M171 PU-18

200-M153 BK-14

291-M141 BK-18

592-M129 BU-14

893-M124 GN-18

200-M172 BK-10

998-M55 BR-18

F702-M56 GN-18

600-M51 BR-18

998-E111 BR-18

998-E111 BR-18

998-E111 BR-18

998-E111 BR-18

998-M102 BR-18

998-M102 BR-18

998-M102 BR-18

998-M102 BR-18

E794-M158 YL-18

E794-M158 YL-18

E794-M158 YL-18

E794-M158 YL-18

E794-M158 YL-18E793-M167 BU-18

E793-M167 BU-18

E793-M167 BU-18

E793-M167 BU-18

E793-M167 BU-18

176-M115 YL-18

176-M115 YL-18

176-M115 YL-18

116-M88 RD-14

113-M99 OR-18

197-M86 RD-14

197-M86 RD-14

197-M86 RD-14

104-M78 YL-14

104-M78 YL-14

104-M78 YL-14

104-M78 YL-14

200-M97 BK-14

200-M97 BK-14

200-M97 BK-14

116-M88 RD-14

113-M99 OR-18

113-M99 OR-18

113-M99 OR-18

113-M99 OR-18

200-M18 BK-12

200-M18 BK-12

200-M18 BK-12

200-M18 BK-12

403-M194 GN-18

403-M194 GN-18

403-M194 GN-18

403-M194 GN-18

403-M194 GN-18

403-M162 GN-18

403-M162 GN-18

592-M188 BU-12

304-M96 WH-8

F715-M1 PU-18

592-M129 BU-14

200-TC3 BK-14

200-TC8 BK-14200-TC9 BK-14

200-TC3 BK-14

200-TC8 BK-14

200-TC9 BK-14200-TC4 BK-14

158-TC1 BR-14

158-TC1 BR-14

593-TC6 GN-14

593-TC6 GN-14

593-TC7 GN-14

593-TC7 GN-14593-TC5 GN-14

521-TC2 YL-14

521-TC2 YL-14200-TC4 BK-14

158-TF1 BR-14

200-TF3 BK-14521-TF2 YL-14

ROPS A/C

ROPS A/C

TRANSMISSION

TRANSMISSION

DRIVE TRAIN CONTROL

OPERATOR PLATFORM

OPERATOR PLATFORM

OPERATOR PLATFORM

OPERATOR PLATFORM

OPERATOR PLATFORM

OPERATOR PLATFORM

N931-M133 GY-18

N931-M133 GY-18

N931-M133 GY-18

N931-M133 GY-18

201-M145 BK-18

201-M145 BK-18

201-M145 BK-18

203-AG1 BK-18

203-AG1 BK-18

203-AG1 BK-18203-AG1 BK-18

CYLINDER/SWEEP LIGHTING

201-M142 BK-18

201-M142 BK-18

201-M142 BK-18

201-M147 BK-18

201-M147 BK-18

201-M147 BK-18

505-HA2 BU-18108-HA1 BU-16

108-HA1 BU-16

CAB

CAB

CAB

CAB

CAB

105-M98 RD-18

334-MF1 BU-18

334-MF5 BU-18334-MF6 BU-18

975-MF3 WH-18

975-MF7 WH-18

200-M149 BK-10

200-M74 BK-10

200-M149 BK-10

200-M149 BK-10

200-M74 BK-10

201-M91 BK-18

201-M127 BK-18

G939-M121 PK-18

201-M127 BK-18

201-M151 BK-18

201-M91 BK-18

200-M74 BK-10

200-M160 BK-10

200-M178 BK-14

200-M178 BK-14

200-M107 BK-10

200-M107 BK-10

200-M152 BK-14 200-M152 BK-14

200-M152 BK-14

200-M152 BK-14

200-M152 BK-14

302-M157 OR-18

302-M157 OR-18

304-M96 WH-8

304-M96 WH-8

F842-MF8 BU-18

200-M107 BK-10

200-M172 BK-10

975-M168 WH-18

975-M168 WH-18

975-M168 WH-18

975-M168 WH-18

334-M200 BU-18

334-M200 BU-18

334-M200 BU-18

334-M200 BU-18

F842-M199 BU-18

F842-M199 BU-18

F842-M199 BU-18

G939-M181 PK-18

G939-M181 PK-18

321-ME1 BR-18975-ME2 WH-18

306-M109 GN-18

306-M109 GN-18

306-M109 GN-18

306-M109 GN-18

975-MF10 WH-18

334-MF1 BU-18

975-MF4 WH-18

158-M185 BR-14

610-M186 OR-14

600-M51 BR-18600-E114 BR-18

600-E114 BR-18

892-M123 BR-18

130-M176 GN-18

130-M176 GN-18

130-M176 GN-18

130-M176 GN-18

130-M176 GN-18

592-M188 BU-12

592-M188 BU-12

592-M188 BU-12

592-MG3 BU-12200-MG2 BK-12

PLUG M-C25 HEREWHEN 20A CONV IS USED

186-M85 WH-14

186-M85 WH-14

186-M85 WH-14

186-M85 WH-14

186-MG1 WH-14

410-E37 WH-18

160-M201 PU-18

160-M201 PU-18

160-M201 PU-18

160-M201 PU-18

160-M201 PU-18

160-M201 PU-18

140-M202 BU-18

140-M202 BU-18

140-M202 BU-18

140-M202 BU-18

140-M202 BU-18140-MF9 BU-18

F842-MF8 BU-18

140-MF9 BU-18

N931-M133 GY-18

201-M145 BK-18

N931-M133 GY-18

201-M145 BK-18

WINCH FREE SPOOL(ON D7 & D8)

BLADE FLOAT

K978-M17 BU-18

K978-M17 BU-18

K978-M17 BU-18

K977-M16 PK-18

K977-M16 PK-18

E909-M13 WH-18

E909-M13 WH-18

E909-M13 WH-18

E908-M11 BR-18

E908-M11 BR-18

975-M69 WH-18

975-M69 WH-18

975-M69 WH-18

709-M15 OR-18

709-M15 OR-18

709-M15 OR-18

450-M175 YL-18

450-M175 YL-18201-M93 BK-18

201-M93 BK-18

201-M93 BK-18

201-M93 BK-18

443-M10 YL-18443-M10 YL-18

443-M10 YL-18

443-M10 YL-18

443-M10 YL-18

G939-M196 PK-18

G939-M196 PK-18

G939-M196 PK-18

G939-M196 PK-18G939-M197 PK-18

G939-M197 PK-18

G939-M197 PK-18

G939-M197 PK-18

200-E93 BK-14

200-E97 BK-18

600-E81 BR-18

600-E81 BR-18

200-E87 BK-18

200-E87 BK-18

200-E88 BK-18

200-E88 BK-18

115-M205 RD-14

115-M205 RD-14

115-M205 RD-14

115-M205 RD-14

115-M205 RD-14

115-M205 RD-14115-E8 RD-14

115-E8 RD-14

103-E55 RD-18

103-E7 RD-18

200-E93 BK-14

200-E93 BK-14

200-E97 BK-18

200-E95 BK-18200-E83 BK-18200-E82 BK-18

200-E83 BK-18200-E82 BK-18

200-E83 BK-18

116-E35 RD-14

103-E36 RD-14

103-E55 RD-18

103-E7 RD-18

608-E32 GN-14

600-E94 BR-18

410-E37 WH-18

A513-E77 PK-18

592-E78 BU-18

108-E56 BU-16

108-E56 BU-16 A513-E77 PK-18

592-E78 BU-18

600-E86 BR-18

600-E86 BR-18600-E90 BR-18

610-E33 OR-14

609-E31 YL-14

600-E91 BR-18

115-E8 RD-14

592-MG4 BU-12 592-MG5 BU-12592-MG6 BU-12

592-MG7 BU-14

186-MG1 WH-14

186-M208 WH-14

186-M208 WH-14

200-M207 BK-14

200-M207 BK-14

609-M204 YL-14

609-M204 YL-14609-M204 YL-14

609-M204 YL-14

609-M204 YL-14

600-E114 BR-18

200-M207 BK-14

200-M207 BK-14

200-M207 BK-14

200-M203 BK-18

200-M203 BK-18

200-M203 BK-18

200-M203 BK-18

200-M203 BK-18

200-M166 BK-14

200-M166 BK-14

200-M166 BK-14

200-M166 BK-14

200-M166 BK-14

200-M206 BK-14

200-M206 BK-14

200-M206 BK-14

200-M206 BK-14

200-M206 BK-14

207-M156 BK-18

207-M156 BK-18

207-M156 BK-18

592-MG7 BU-14

592-MG3 BU-12

200-MG2 BK-12

592-MG6 BU-12

592-MG5 BU-12

200-MG2 BK-12186-MG1 WH-14

200-MJ37 BK-18

200-MJ37 BK-18

403-MJ45 GN-18

403-MJ45 GN-18

893-MJ49 GN-18

893-MJ49 GN-18

892-MJ47 BR-18

106-MJ32 RD-18

106-MJ32 RD-18

200-MJ38 BK-18

200-MJ38 BK-18

205-MJ36 BK-18

205-MJ36 BK-18

308-MJ41 YL-18

308-MJ41 YL-18308-MJ42 YL-18

308-MJ42 YL-18

307-MJ39 OR-18

307-MJ39 OR-18307-MJ40 OR-18

307-MJ40 OR-18

403-MJ46 GN-18403-MJ46 GN-18

893-MJ50 GN-18

893-MJ50 GN-18

892-MJ48 BR-18

892-MJ48 BR-18

MACHINE SECURITY SYSTEM / PRODUCT LINK

106-MJ33 RD-18

308-MJ1 YL-18

308-MJ1 YL-18

A347-MJ2 GN-18

A347-MJ2 GN-18

307-MJ3 OR-18307-MJ3 OR-18A346-MJ4 BU-18

A346-MJ4 BU-18

A346-MJ4 BU-18 200-MJ5 BK-18

200-MJ5 BK-18

M732-MJ6 OR-18

M732-MJ6 OR-18

M732-MJ6 OR-18

M733-MJ8 PK-18

M733-MJ8 PK-18

M733-MJ8 PK-18

106-MJ9 RD-18

106-MJ9 RD-18

T901-MJ10 YL-18

T901-MJ10 YL-18

T901-MJ10403-MJ11 GN-18

403-MJ11 GN-18893-MJ12 GN-18

893-MJ12 GN-18

892-MJ13 BR-18

892-MJ13 BR-18

T902-MJ14 PK-18

T902-MJ14 PK-18

T902-MJ14 PK-18

F846-MJ15 PU-18

F846-MJ15 PU-18

F846-MJ15 PU-18

G848-MJ16 GN-18

G848-MJ16 GN-18

G848-MJ16 GN-18

E900-MJ17 WH-18

E900-MJ17 WH-18975-MJ30 WH-18

975-MJ30 WH-18 975-MJ31 WH-18975-MJ31 WH-18

E901-MJ18 GN-18E901-MJ18 GN-18

751-MJ25 GN-18751-MJ25 GN-18

E902-MJ19 PU-18E902-MJ19 PU-18

900-MJ29 PU-18900-MJ29 PU-18

E903-MJ20 YL-18E903-MJ20 YL-18

752-MJ26 YL-18752-MJ26 YL-18

E904-MJ21 BR-18E904-MJ21 BR-18E905-MJ22 BU-18E905-MJ22 BU-18

754-MJ27 BU-18754-MJ27 BU-18

E906-MJ23 OR-18E906-MJ23 OR-18

755-MJ28 OR-18

755-MJ28 OR-18E907-MJ24 GY-18E907-MJ24 GY-18

308-M169 YL-18

308-M169 YL-18

308-M169 YL-18

A347-M146 GN-18

A347-M146 GN-18

A347-M146 GN-18

A347-M146 GN-18

106-M79 RD-18

106-M79 RD-18

106-M79 RD-18

403-M177 GN-18

403-M177 GN-18

403-M177 GN-18

M732-M119 OR-18

M732-M119 OR-18

M732-M119 OR-18

M732-M119 OR-18M733-M173 PK-18

M733-M173 PK-18

M733-M173 PK-18

M733-M173 PK-18

307-M143 OR-18

307-M143 OR-18

307-M143 OR-18

307-M143 OR-18

A346-M4 BU-18

A346-M4 BU-18

A346-M4 BU-18

F846-M103 PU-18

F846-M103 PU-18

F846-M103 PU-18

F846-M103 PU-18G848-M106 GN-18

G848-M106 GN-18

G848-M106 GN-18

G848-M106 GN-18

T901-M108 YL-18

T901-M108 YL-18

T901-M108 YL-18

T901-M108 YL-18T902-M163 PK-18

T902-M163 PK-18

T902-M163 PK-18

T902-M163 PK-18

205-MJ36 BK-18A347-MJ2 GN-18

308-MJ7 YL-18

308-MJ7 YL-18308-MJ7 YL-18

374-MJ34 PK-18

374-MJ34 PK-18

374-MJ34 PK-18

205-E9 BK-18

205-E9 BK-18

205-E9 BK-18

205-E9 BK-18

205-M213 BK-18

205-M213 BK-18

205-M213 BK-18

205-M213 BK-18

630-E10 GY-18

630-E10 GY-18

630-E11 GY-14

630-E11 GY-14

WHEN USED PLUG INTO M-C44

20A CONVERTER

308-M132 YL-18

308-M132 YL-18

308-M215 YL-18

308-M215 YL-18

308-M215 YL-18308-M216 YL-18

308-M216 YL-18

308-M216 YL-18

308-M216 YL-18

G939-M12 PK-18G939-M181 PK-18

K977-M16 PK-18

E908-M11 BR-18

450-M175 YL-18

892-M8 BR-18

G731-M59 GY-18

F849-M118 WH-18

977-M113 YL-18

F842-M199 BU-18

308-M169 YL-18

A347-M146 GN-18

307-M143 OR-18

A346-M4 BU-18

M732-M119 OR-18

106-M79 RD-18

403-M177 GN-18

T901-M108 YL-18

F846-M103 PU-18

E901-P1 GN-18

E901-P1 GN-18

E902-P2 PU-18

E902-P2 PU-18

E903-P3 YL-18

E903-P3 YL-18

E904-P4 BR-18

E904-P4 BR-18

E905-P5 BU-18

E905-P5 BU-18

E906-P6 OR-18

E906-P6 OR-18

E907-P7 GY-18

E907-P7 GY-18

E900-P12 WH-18

E900-P12 WH-18

975-P14 WH-18

975-P14 WH-18

975-P15 WH-18

975-P15 WH-18

975-P16 WH-18

975-P16 WH-18

975-P18 WH-18

975-P18 WH-18

975-P17 WH-18

975-P17 WH-18975-P19 WH-18

975-P19 WH-18

975-P20 WH-18 975-P20 WH-18

900-P13 PU-18

900-P13 PU-18

900-P13 PU-18

755-P8 OR-18

755-P8 OR-18

755-P8 OR-18

754-P11 BU-18

754-P11 BU-18

754-P11 BU-18

752-P10 YL-18

752-P10 YL-18

752-P10 YL-18

751-P9 GN-18

751-P9 GN-18

751-P9 GN-18

E901-PP1 GN-18

E901-PP1 GN-18E900-PP2 WH-18

E900-PP2 WH-18E903-PP3 YL-18

E903-PP3 YL-18

E902-PP4 PU-18

E902-PP4 PU-18

E905-PP5 BU-18

E905-PP5 BU-18E904-PP6 BR-18

E904-PP6 BR-18E907-PP7 GY-18E907-PP7 GY-18E906-PP8 OR-18E906-PP8 OR-18

202-M198 BK-18

202-M198 BK-18

202-M198 BK-18

202-M198 BK-18

202-M198 BK-18

103-E55 RD-18

103-E7 RD-18

115-E8 RD-14

608-E32 GN-14

609-E31 YL-14610-E33 OR-14

E735-E22 PU-18

E735-E23 PU-18

201-E99 BK-18201-E71 BK-18

411-E1 PK-18663-E103 GY-18

198-E12 RD-18

198-E12 RD-18

G731-E20 GY-18

G731-E20 GY-18

140-E34 BU-18

140-E34 BU-18

202-E89 BK-18

202-E89 BK-18

F790-E106 BR-18

F790-E106 BR-18

998-E116 BR-18

998-E116 BR-18A700-E115 OR-18

A700-E115 OR-18

F702-E117 GN-18

F702-E117 GN-18

975-M110 WH-18

975-M110 WH-18

975-M110 WH-18

975-M110 WH-18321-M7 BR-18

321-M7 BR-18

321-M7 BR-18

321-M7 BR-18

116-F1 RD-14

116-F1 RD-14

113-F2 OR-18

113-F2 OR-18

108-F4 BU-16

108-F4 BU-16

114-F6 RD-18

114-F6 RD-18

109-F38 RD-18

109-F38 RD-18

114-F6 RD-18

108-F4 BU-16

113-F2 OR-18

116-F1 RD-14

109-F38 RD-18

124-F14 GN-14

124-F14 GN-14

M732-F16 OR-18

306-F20 GN-18

306-F20 GN-18

304-F30 WH-8

304-F30 WH-8304-F21 WH-18

304-F21 WH-18

105-F23 RD-18

105-F23 RD-18

105-F23 RD-18

198-F5 RD-18

198-F5 RD-18

158-F25 BR-14

158-F25 BR-14

158-F25 BR-14

176-F27 YL-14

176-F27 YL-14

176-F27 YL-14

150-F29 RD-14

150-F29 RD-14

150-F29 RD-14

105-F41 RD-18

198-F5 RD-18

184-F7 BU-14

184-F7 BU-14

184-F7 BU-14

112-F32 PU-14

106-F35 RD-18

106-F35 RD-18

106-F35 RD-18

203-F15 BK-18

203-F15 BK-18

105-F41 RD-18

306-F10 GN-18

306-F10 GN-18

105-F41 RD-18

109-F38 RD-18

302-F36 OR-18

302-F36 OR-18

302-F36 OR-18 302-F36 OR-18

207-F37 BK-18

207-F37 BK-18

207-F37 BK-18

207-F37 BK-18

310-F39 PU-18

310-F39 PU-18

310-F39 PU-18

310-F39 PU-18

306-F40 GN-18

306-F40 GN-18

306-F40 GN-18105-F41 RD-18

124-F14 GN-14

304-F21 WH-18

304-F21 WH-18

A347-F8 GN-18

A347-F8 GN-18

A347-F9 GN-18

A347-F9 GN-18

A347-F9 GN-18

103-F18 RD-14

103-F18 RD-14

203-F15 BK-18

FUSE PANEL

FUSE PANEL

304-F30 WH-8M732-F16 OR-18

M732-F16 OR-18

130-F43 GN-18

130-F43 GN-18

130-F43 GN-18

186-F44 WH-14186-F44 WH-14

186-F44 WH-14

160-F28 PU-18

160-F28 PU-18

160-F28 PU-18

140-F26 BU-14

140-F26 BU-14

140-F26 BU-14

102-F33 RD-14

102-F33 RD-14 102-F33 RD-14

197-F13 RD-14

197-F13 RD-14

197-F13 RD-14

104-F31 YL-14

104-F31 YL-14

104-F31 YL-14

115-F46 RD-14

115-F46 RD-14

115-F46 RD-14

N931-F47 GY-18

N931-F47 GY-18

N931-F47 GY-18201-F48 BK-18

201-F48 BK-18

201-F48 BK-18

NOTE B

103-F18 RD-14

111-F3 YL-14

111-F3 YL-14

111-F3 YL-14

110-F45 GN-14110-F45 GN-14

110-F45 GN-14

101-F22 RD-14

101-F22 RD-14

101-F12 RD-14

101-F12 RD-14

101-F12 RD-14

101-F12 RD-14

101-F34 RD-18

101-F34 RD-18

101-F34 RD-18

112-F11 PU-14

112-F11 PU-14

112-F42 PU-18

112-F42 PU-18

112-F42 PU-18

112-F42 PU-18

M733-F17 PK-18

M733-F17 PK-18

M733-F17 PK-18

A347-F19 GN-18

A347-F19 GN-18

608-HE1 GN-14

608-HE4 GN-14

608-HE4 GN-14

608-HE3 GN-14

447-HE11 PK-18201-HE12 BK-18

200-HE10 BK-14

200-HE6 BK-14

200-HE6 BK-14

200-HE8 BK-14

521-HE14 YL-14

521-HE14 YL-14158-HE15 BR-14

158-HE15 BR-14

200-HE13 BK-14

200-HE13 BK-14

608-HE3 GN-14

200-HE8 BK-14

200-HE7 BK-14

200-HE7 BK-14

200-HE9 BK-14

200-HE9 BK-14

608-HE5 GN-14

608-HE5 GN-14608-HE2 GN-14

608-HE2 GN-14ROPS LIGHTING

608-RF1 GN-14608-RF3 GN-14200-RF2 BK-14200-RF4 BK-14

200-RG2 BK-14200-RG4 BK-14608-RG1 GN-14608-RG3 GN-14

200-RC2 BK-14

200-RE2 BK-14

608-RC1 GN-14

608-RE1 GN-14

SWEEP LIGHTING

200-RF6 BK-14

200-RG6 BK-14

608-RF5 GN-14

608-RG5 GN-14

158-LN1 BR-14

158-LN1 BR-14

521-LN2 YL-14

521-LN2 YL-14

200-LN3 BK-14200-LN3 BK-14200-LN8 BK-14200-LN9 BK-14

200-LN4 BK-14

593-LN5 GN-14593-LN6 GN-14593-LN7 GN-14

593-LN6 GN-14200-LN8 BK-14

200-LN9 BK-14593-LN7 GN-14

FENDER A/C CONDENSOR

780-K1 PU-18 780-K1 PU-18

780-K2 PU-18

780-K2 PU-18

200-K8 BK-18 200-K8 BK-18

200-K6 BK-18

200-K6 BK-18200-K7 BK-18

200-K7 BK-18

200-K5 BK-18

200-K5 BK-18

779-K3 WH-18

779-K3 WH-18779-K4 WH-18

779-K4 WH-18

780-K9 PU-18

779-K10 WH-18

200-K11 BK-16

201-Y2 BK-18

201-Y2 BK-18

426-Y1 BR-18

442-Y3 GY-18

201-Y5 BK-18

201-Y4 BK-18

426-Y1 BR-18

442-Y3 GY-18

158-LC1 BR-14

200-LC3 BK-14521-LC2 YL-14158-LC1 BR-14

521-LC2 YL-14200-LC3 BK-14

426-Y6 BR-18

NOTE B

200-Y9 BK-14

158-Y7 BR-14521-Y8 YL-14

200-AH1

CONN 9

BK-18

200-RJ2 BK-14 200-RJ5 BK-14

200-RJ5 BK-14

200-RJ6 BK-14

200-RJ6 BK-14

610-RJ1 OR-14 610-RJ4 OR-14

610-RJ4 OR-14

610-RJ3 OR-14

610-RJ3 OR-14

CYLINDER LIGHTING

200-AK2 BK-14 200-AK5 BK-14

200-AK5 BK-14

200-AK6 BK-14

200-AK6 BK-14

610-AK1 OR-14 610-AK4 OR-14

610-AK4 OR-14610-AK3 OR-14

610-AK3 OR-14

CYLINDER LIGHTING

610-AJ1 OR-14 610-AJ4 OR-14610-AJ3 OR-14

200-AJ2 BK-14 200-AJ5 BK-14200-AJ6 BK-14

200-AJ5 BK-14610-AJ4 OR-14

610-AJ3 OR-14200-AJ6 BK-14

WASTE DISPOSAL LIGHTING

610-RH1 OR-14 610-RH4 OR-14610-RH3 OR-14

200-RH2 BK-14 200-RH5 BK-14200-RH6 BK-14

200-RH5 BK-14610-RH4 OR-14

610-RH3 OR-14200-RH6 BK-14

WASTE DISPOSAL LIGHTING

150-AE1 OR-14

150-AE1 OR-14

102-AE2 RD-16

102-AE2 RD-16

F700-AE3 BU-18F701-AE4 BR-18E799-AE5 BR-16892-AE6 BR-16

892-AE6 BR-16

893-AE7 GN-16

893-AE7 GN-16

A700-AE8 OR-16

A700-AE8 OR-16

998-AE9 BR-16

998-AE9 BR-16

F702-AE10 GN-16

F702-AE10 GN-16

F702-AE10 GN-16

F702-AE10 GN-16

F703-AE11 GY-16

F703-AE11 GY-16

F704-AE12 OR-16

F704-AE12 OR-16

F704-AE12 OR-16

F704-AE12 OR-16F705-AE13 PK-16

F705-AE13 PK-16

997-AE14 OR-16

997-AE14 OR-16

993-AE15 BR-16

993-AE15 BR-16

A234-AE16 BK-16

A234-AE16 BK-16

F711-AE17 GN-16

F711-AE17 GN-16

F712-AE18 GY-16

F712-AE18 GY-16

F714-AE20 PK-16

F714-AE20 PK-16

F714-AE20 PK-16

F714-AE20 PK-16

F710-AE21 BR-16

F710-AE21 BR-16

F709-AE22 BU-16

F709-AE22 BU-16

F708-AE23 YL-16

F708-AE23 YL-16

F707-AE24 WH-16

F707-AE24 WH-16

F706-AE25 PU-16

F706-AE25 PU-16

N943-AE26 BR-16

N943-AE26 BR-16F715-AE27 PU-16

F715-AE27 PU-16

F716-AE28 WH-16

F716-AE28 WH-16

F717-AE29 YL-16

F717-AE29 YL-16

F718-AE30 BU-16

F718-AE30 BU-16

E794-AE31 YL-16

E794-AE31 YL-16

E793-AE32 BU-16

E793-AE32 BU-16

F725-AE33 WH-16

F725-AE33 WH-16

450-AE34 YL-16

450-AE34 YL-16

451-AE35 BR-16

451-AE35 BR-16

F719-AE36 BR-16

F719-AE36 BR-16

N942-AE37 OR-16

N942-AE37 OR-16

F720-AE38 GN-16

F720-AE38 GN-16

F721-AE39 GY-16

F721-AE39 GY-16

F722-AE40 OR-16

F722-AE40 OR-16

A70

1-A

E41

GY-

16

A701-AE41 GY-16

A701-AE41 GY-16

A701-AE41 GY-16

A70

2-A

E42

PU

-16

A702-AE42 PU-16

A702-AE42 PU-16

A702-AE42 PU-16

A70

3-A

E43

BR

-16

A703-AE43 BR-16

A703-AE43 BR-16

A703-AE43 BR-16

A70

4-A

E44

GN

-16

A704-AE44 GN-16

A704-AE44 GN-16

A704-AE44 GN-16

A70

5-A

E45

BU

-16

A705-AE45 BU-16

A705-AE45 BU-16

A705-AE45 BU-16

A70

6-A

E46

GY-

16

A706-AE46 GY-16

A706-AE46 GY-16

A706-AE46 GY-16

E79

9-A

E47

BR

-16

E799-AE47 BR-16

E799-AE5 BR-16

E799-AE53 BR-16

E799-AE53 BR-16E799-AE53 BR-16

L985

-AE

48Y

L-16

L985-AE48 YL-16

L985-AE48 YL-16

L985-AE48 YL-16

F701

-AE

49B

R-1

6

F701-AE49 BR-16

L984

-AE

50O

R-1

6

L984-AE50 OR-16

L984-AE50 OR-16

L984-AE50 OR-16

L983-AE82 WH-16

L983-AE82 WH-16

L983-AE82 WH-16

L983

-AE

82W

H-1

6F7

00-A

E51

BU

-16

F700-AE51 BU-16

F701-AE4 BR-18

F701-AE54 BR-16

F701-AE54 BR-16

F701-AE54 BR-16

F700-AE3 BU-18 F700-AE55 BU-16

F700-AE55 BU-16

F700-AE55 BU-16

F700-AE3 BU-18

F700-AE55 BU-16F701-AE54 BR-16

F701-AE4 BR-18

E799-AE5 BR-16

E799-AE53 BR-16

N941-AE56 YL-16

N941-AE56 YL-16

N941-AE56 YL-16

N941-AE60 YL-16

N941-AE60 YL-16

N941-AE59 YL-16

N941-AE59 YL-16

N941-AE61 YL-16

N941-AE61 YL-16

N941-AE58 YL-16

N941-AE58 YL-16

N941-AE62 YL-16

N941-AE62 YL-16

N941-AE57 YL-16

N941-AE57 YL-16

N940-AE64 BU-16

N940-AE64 BU-16

N940-AE65 BU-16

N940-AE65 BU-16

N940-AE66 BU-16

N940-AE66 BU-16N940-AE67 BU-16 N940-AE67 BU-16

N940-AE68 BU-16

N940-AE68 BU-16N940-AE69 BU-16

N940-AE69 BU-16

N940-AE63 BU-16

N940-AE63 BU-16

N940-AE63 BU-16

C967-AE70 BU-16

C967-AE70 BU-16

C967-AE70 BU-16

C967-AE70 BU-16

995-AE71 BU-16995-AE71 BU-16

995-AE71 BU-16

995-AE71 BU-16

A746-AE72 PK-16

A746-AE72 PK-16

A746-AE72 PK-16

A746-AE72 PK-16

A747-AE73 GY-16

A747-AE73 GY-16

A747-AE73 GY-16

A747-AE73 GY-16

994-AE74 GY-16

994-AE74 GY-16

994-AE74 GY-16

994-AE74 GY-16

A751-AE75 YL-16

A751-AE75 YL-16

A751-AE75 YL-16

A751-AE75 YL-16

229-AE76 BK-14

E965-AE77 BU-16

E965-AE77 BU-16

E966-AE78 YL-16

E966-AE78 YL-16

E966-AE78 YL-16E965-AE77 BU-16

F724-AE79 PU-16

F724-AE79 PU-16

F724-AE79 PU-16

412-AE80 BU-16

412-AE80 BU-16

412-AE80 BU-16

412-AE80 BU-16

N944-AE81 PU-16N944-AE81 PU-16

N944-AE81 PU-16

N944-AE81 PU-16

F723-AE83 PK-16

F723-AE83 PK-16

F723-AE83 PK-16

F723-AE84 PK-16F724-AE52 PU-16

A70

1-N

R1

GY-

16

A701-NR1 GY-16

A701-NR1 GY-16

A70

2-N

R2

PU

-16

A702-NR2 PU-16

A702-NR2 PU-16

A70

3-N

R3

BR

-16

A703-NR3 BR-16

A703-NR3 BR-16

A70

4-N

R4

GN

-16

A704-NR4 GN-16

A704-NR4 GN-16

A70

5-N

R5

BU

-16

A705-NR5 BU-16

A705-NR5 BU-16

A70

6-N

R6

GY-

16

A706-NR6 GY-16

A706-NR6 GY-16

D78

9-N

R12

WH

-16

D789-NR12 WH-16D789-NR19 WH-16

D789-NR19 WH-16

D789-NR18 WH-16

D789-NR18 WH-16

D79

0-N

R10

OR

-16

D790-NR10 OR-16D790-NR21 OR-16

D790-NR21 OR-16

D790-NR20 OR-16

D790-NR20 OR-16D79

1-N

R8

YL-

16

D791-NR8 YL-16D791-NR23 YL-16

D791-NR23 YL-16

D791-NR22 YL-16

D791-NR22 YL-16

D78

6-N

R11

BR

-16

D786-NR11 BR-16D786-NR13 BR-16

D786-NR13 BR-16

D786-NR14 BR-16

D786-NR14 BR-16

D78

7-N

R9

GN

-16

D787-NR9 GN-16

D787-NR9 GN-16

D78

8-N

R7

BK

-16 D788-NR7 BK-16

D788-NR16 BK-16

D788-NR16 BK-16

D788-NR17 BK-16D788-NR17 BK-16

D788-NR15 BK-16

D788-NR15 BK-16

229-AE76 BK-14

NOTE C

NOTE C

NOTE C

E965-AE77 BU-16E966-AE78 YL-16

ENGINE

ENGINE

NOTE E

TDC PROBESERVICE ACCESS

N940-AE19 BU-16

N940-AE19 BU-16

N941-AE85 YL-16

N941-AE85 YL-16

A745-AE88 WH-16

A745-AE88 WH-16

A745-AE87 WH-16

A745-AE87 WH-16

A745-AE86 WH-16

A745-AE86 WH-16

A745-AE86 WH-16

THIS SCHEMATIC IS FOR THE D8R SERIES II TRACTOR(160-6230 CHG. 02)

COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLEMACHINE WITH THE KEY AND ENGINE OFF ANDTRANSMISSION SHIFTER IN NEUTRAL.

NOTE B: WILL BE CLOSED WHEN ENGINE IS OPERATING NORMALLY

IDENT PART NO CHG LOC DESCRIPTION NOTEHARNESS AS.E 193-8561 00 D-7 DASHF 175-7025 01 H-7 FUSE PANELG 183-3441 00 I-2 RADIATOR GUARDH 169-9635 02 C-12 ROOF ATCHK 164-4940 01 B-15 RIPPER PIN PULL ATCHM 199-9798 00 C-7/G-12/H-7 PLATFORMP 164-6853 01 I-13 BASIC TRANSMISSIONR 194-9380 00 A-9/A-11 RH CONSOLEW 160-5570 05 D-4 ENGINEX 167-7629 01 G-12 DIFF STEER DRIVETRAINY 160-5579 03 A-12 RH FENDERAE 145-3850 02 D-3 BASIC ENGINEAJ 151-4854 01 B-2 RH WASTE DISPOSAL LIGHTS ATCHAK 160-0265 01 C-2 RH CYLINDER LIGHTS ATCH CF 183-8374 00 E-6/I-5 PRELUBE ATCHCV 121-2844 01 C-4 CRANK W/O INJEE 172-9290 00 D-10 BLOWER ATCHHA 169-9636 02 C-13 HEADLINER ATCHHE 159-7614 02 E-13 FUEL TANKHH 186-4857 00 D-11 WASHER PUMP ATCHKA 160-8769 02 B-14 RIPPER FLOOD ATCHKK 164-9541 01 B-8 SERVICE BRAKEKW 170-4891 01 B-14 WINCH (REAR) ATCHLC 173-7148 00 A-12 FENDER A/C JUMPER ATCHLN 123-8329 05 A-14 FENDER A/C COND ATCHME 179-0787 00 A-14 BACKUP ALARM JUMPERMF 172-4859 01 A-8 IMPLEMENT LOCKOUTMG 185-5628 00 F-8 20A CONVERTER PIGTAIL ATCHMP 180-4191 00 I-12 XMSN JUMPERMR 132-6545 00 I-10 LH FENDER LIGHTS ATCHMT 132-6545 00 A-11 RH FENDER LIGHTS ATCHNR 122-1486 05 G-2 INJECTORPP 144-7872 00 H-13 TRANSMISSIONRA 160-5574 03 B-10 THROTTLE SWRC 160-1061 01 D-15 SWEEP LIGHTING ATCHRE 160-1061 01 C-15 SWEEP LIGHTING ATCH RF 159-7615 01 E-15 ROPS LIGHTINGRG 159-7615 01 D-15 ROPS LIGHTINGRH 151-4854 01 H-1 LH WASTE DISPOSAL LIGHTS ATCHRJ 160-0265 01 H-1 LH CYLINDER LIGHTS ATCHRM 194-1094 00 B-10 EROPS THROTTLE JUMPERRW 165-0107 01 A-12 WINCH RH CONSOLE ATCHTC 123-8329 05 E-15 ROPS AC ATCHTF 110-2915 00 E-15 FUEL TANK TO ROPS AC ATCH

CABLE AS.AF 164-8102 01 H-2/G-7AL 9U-1440 00 I-10AR 164-8128 01 H-10AY 2V-6166 01 H-3CE 185-6392 00 H-3FF 190-2840 00 I-3/G-7HC 9U-8746 01 B-12JJ 168-4629 00 I-10LL 9C-9743 00 I-10RR 191-8693 00 H-10

NOTE E: THE FOLLOWING WIRE PAIRS MUST BE TWISTED AT LEAST 1 TURN / 25 MILLIMETERS: (892-BR, 893-GN), (E902-PU, E903-YL), (E904-BR, E905-BU), (E900-WH, E901-GN), (E906-OR, E907-GY), (E908-BR, E909-WH), (450-YL, G939-PK), (E793-BU, E794-YL), (T901-YL, T902-PK)

NOTE C: TIE BACK TO HARNESS WITH STRAP (3S-2093)

WIRE AS.AG 171-7215 00 G-7/H-10AH 164-3744 01 A-13JF 184-8026 00 E-9JK 184-0870 00 H-12JN 195-8711 00 E-9CM 195-9354 00 H-10

A745-AE88 WH-16

150-W8 RD-14

150-W8 RD-14102-W22 RD-14

F715-W32 PU-18

F715-W32 PU-18F716-W33 WH-18F717-W34 YL-18

A700-W25 OR-18

F702-W27 GN-18

F721-W38 GY-18

322-W3 GY-18

200-W1 BK-14

200-W1 BK-14

610-W2 OR-14

610-W2 OR-14

310-W9 PU-18

310-W12 PU-18310-W7 PU-18

310-W7 PU-18

200-W11 BK-18

200-W10 BK-18

200-W6 BK-14

108-W13 BU-16

108-W13 BU-16

521-W15 YL-14

521-W15 YL-14

521-W15 YL-14

522-W16 WH-14

522-W16 WH-14522-W21 WH-14

522-W20 WH-14

513-W17 OR-14

513-W18 OR-14

513-W19 OR-14

522-W21 WH-14

522-W20 WH-14513-W19 OR-14

513-W17 OR-14

513-W18 OR-14

F720-W37 GN-18

F719-W36 BR-18

F710-W31 BR-18

F714-W30 PK-18

F714-W30 PK-18

F721-W38 GY-18

F717-W34 YL-18F716-W33 WH-18

F702-W27 GN-18

A700-W25 OR-18998-W26 BR-18

998-W14 BR-18

998-W35 BR-18

F718-W42 BU-18

F718-W42 BU-18

892-W43 BR-18

892-W43 BR-18893-W5 GN-18

893-W5 GN-18

403-W4 GN-18

403-W4 GN-18

301-W39 BU-18

997-W40 OR-18

F714-W30 PK-18

998-W26 BR-18

F710-W31 BR-18

E794-W52 YL-18

E794-W52 YL-18

F710-W31 BR-18

E793-W53 BU-18

E793-W53 BU-18

997-W40 OR-18

E794-W52 YL-18

E793-W53 BU-18

403-W4 GN-18

521-W15 YL-14

322-W3 GY-18

522-W16 WH-14

310-W7 PU-18

200-W6 BK-14

610-W2 OR-14

F715-W32 PU-18

F716-W33 WH-18F717-W34 YL-18F718-W42 BU-18

F702-W27 GN-18

F721-W38 GY-18892-W43 BR-18

893-W5 GN-18102-W22 RD-14

150-W8 RD-14

108-W13 BU-16

998-W35 BR-18

997-W40 OR-18

F714-W30 PK-18

993-W49 BR-18

993-W49 BR-18

993-W49 BR-18

102-W22 RD-14

610-W2 OR-14

322-W3 GY-18

200-W6 BK-14

310-W7 PU-18

F710-W31 BR-18

108-W13 BU-16

302-W45 OR-18

302-W45 OR-18

302-W45 OR-18

304-W50 WH-8

304-W50 WH-8

304-W50 WH-8

F719-W36 BR-18F720-W37 GN-18

200-W6 BK-14

322-W3 GY-18403-W4 GN-18

522-W16 WH-14

K978-W61 BU-18

K978-W61 BU-18

K978-W61 BU-18

K977-W64 PK-18

K977-W64 PK-18

K977-W64 PK-18

G939-W58 PK-18

G939-W58 PK-18

G939-W58 PK-18

G939-W57 PK-18

G939-W57 PK-18

G939-W57 PK-18

E909-W60 WH-18

E909-W60 WH-18

E909-W60 WH-18

975-W62 WH-18

975-W62 WH-18

975-W62 WH-18

E908-W59 BR-18

E908-W59 BR-18

E908-W59 BR-18

709-W63 OR-18

709-W63 OR-18

709-W63 OR-18

450-W56 YL-18

450-W56 YL-18

450-W56 YL-18

443-W54 YL-18

443-W54 YL-18

443-W54 YL-18201-W55 BK-18

201-W55 BK-18

201-W55 BK-18

997-W40 OR-18993-W49 BR-18

207-W28 BK-18

207-W28 BK-18

207-W28 BK-18

NOTE E

F708-W44 YL-16

F708-W44 YL-16

F708-W44 YL-16

F709-W29 BU-16F709-W29 BU-16

F709-W29 BU-16

N942-W51 OR-16

N942-W51 OR-16

N942-W51 OR-16

998-W65 BR-16

998-W65 BR-16

CBL-JJ1 BK-00

CB

L-R

R1

RD

-00

CBL-RR1 RD-00

CB

L-R

R2

RD

-00

CBL-GG2 BK-00

CBL-GG1 RD-00CB

L-LL

1R

D-0

0

CBL-FF1

CONN 50

CONN 37

CONN 36

CONN 35

CONN 17

RD-00

CBL-FF1 RD-00

CBL-FF1 RD-00

CBL-RR1 RD-00

CBL-RR1 RD-00

CBL-JJ2 BK-00CBL-JJ3 BK-00

CBL-AL1 RD-00

CBL-FF1 RD-00

E900-MP12 WH-18

E900-MP12 WH-18

E901-MP1 GN-18

E901-MP1 GN-18

E902-MP2 PU-18

E902-MP2 PU-18

E903-MP3 YL-18

E903-MP3 YL-18E904-MP4 BR-18

E904-MP4 BR-18

E905-MP5 BU-18

E905-MP5 BU-18

E906-MP6 OR-18

E906-MP6 OR-18

E907-MP7 GY-18

E907-MP7 GY-18

751-MP9 GN-18

751-MP9 GN-18

752-MP10 YL-18

752-MP10 YL-18

754-MP11 BU-18

754-MP11 BU-18

755-MP8 OR-18

755-MP8 OR-18

900-MP13 PU-18

900-MP13 PU-18975-MP14 WH-18

975-MP14 WH-18975-MP15 WH-18

975-MP15 WH-18

308-MP16 YL-18

307-MP17 OR-18

200-MP18 BK-18

200-MP19 BK-18

F842-M199 BU-18

977-M113 YL-18

F849-M118 WH-18

892-M8 BR-18

G939-M181 PK-18

G939-M12 PK-18

E908-M11 BR-18

450-M175 YL-18

K977-M16 PK-18

334-M200 BU-18

176-M115 YL-18

F848-M117 OR-18

F790-M57 BR-18

306-M109 GN-18

337-M136 WH-18

140-M3 BU-14

893-M9 GN-18

E909-M13 WH-18

709-M15 OR-18

K978-M17 BU-18

140-M6 BU-14

321-M7 BR-18

G848-M106 GN-18

F846-M103 PU-18

T902-M163 PK-18

T901-M108 YL-18

205-M213 BK-18

403-M177 GN-18

106-M79 RD-18

M733-M173 PK-18

M732-M119 OR-18

A346-M4 BU-18

307-M143 OR-18

A347-M146 GN-18

308-M209 YL-18

308-M209 YL-18

308-M210 YL-18

308-M210 YL-18

308-M211 YL-18

308-M211 YL-18

202-M198 BK-18

975-M69 WH-18

975-M168 WH-18

202-M198 BK-18

G848-M106 GN-18

T902-M163 PK-18

205-M213 BK-18

M733-M173 PK-18

334-M200 BU-18

977-M113 YL-18

F842-M199 BU-18

176-M115 YL-18

F848-M117 OR-18

F849-M118 WH-18

G731-M59 GY-18

F790-M57 BR-18321-M7 BR-18306-M109 GN-18337-M136 WH-18140-M3 BU-14

892-M8 BR-18

893-M9 GN-18

G939-M181 PK-18G939-M12 PK-18

E908-M11 BR-18

E909-M13 WH-18

450-M175 YL-18

709-M15 OR-18

K977-M16 PK-18

K978-M17 BU-18140-M6 BU-14

E900-M38 WH-18

E900-M38 WH-18

E900-M38 WH-18

E900-M38 WH-18

E901-M39 GN-18

E901-M39 GN-18

E901-M39 GN-18

E901-M39 GN-18

751-M46 GN-18

751-M46 GN-18

751-M46 GN-18

751-M46 GN-18

E902-M40 PU-18

E902-M40 PU-18

E902-M40 PU-18

E902-M40 PU-18

900-M50 PU-18

900-M50 PU-18

900-M50 PU-18

900-M50 PU-18

E903-M41 YL-18

E903-M41 YL-18

E903-M41 YL-18

E903-M41 YL-18

752-M47 YL-18

752-M47 YL-18

752-M47 YL-18

752-M47 YL-18

E904-M42 BR-18

E904-M42 BR-18

E904-M42 BR-18

E904-M42 BR-18

E905-M43 BU-18

E905-M43 BU-18

E905-M43 BU-18

E905-M43 BU-18

754-M48 BU-18

754-M48 BU-18

754-M48 BU-18

754-M48 BU-18

E906-M44 OR-18

E906-M44 OR-18

E906-M44 OR-18

E906-M44 OR-18

755-M49 OR-18

755-M49 OR-18

755-M49 OR-18

755-M49 OR-18

E907-M45 GY-18

E907-M45 GY-18

E907-M45 GY-18

E907-M45 GY-18

G731-M36 GY-18

G731-M36 GY-18

G731-M37 GY-18

G731-M37 GY-18

G730-M35 PK-18

G730-M35 PK-18

G730-M35 PK-18

F789-M116 YL-18

F789-M116 YL-18

F789-M116 YL-18

F788-M120 PU-18

F788-M120 PU-18

F788-M120 PU-18

F792-M20 WH-18

F792-M20 WH-18

F792-M20 WH-18

F791-M19 BU-18

F791-M19 BU-18

F791-M19 BU-18

202-M148 BK-14

202-M148 BK-14

202-M148 BK-14202-M148 BK-14

202-M76 BK-18

202-M76 BK-18

202-M76 BK-18

202-M76 BK-18

200-M114 BK-18

200-M114 BK-18

200-M114 BK-18 200-M114 BK-18

200-M195 BK-18

200-M195 BK-18

200-M195 BK-18200-M195 BK-18200-M81 BK-18

200-M81 BK-18

200-M81 BK-18

200-M81 BK-18

975-M32 WH-18975-M30 WH-18

975-M30 WH-18

975-M30 WH-18

975-M30 WH-18975-M29 WH-18

975-M29 WH-18

975-M29 WH-18

975-M29 WH-18

975-M33 WH-18

975-M33 WH-18

975-M34 WH-18

975-M34 WH-18

975-M31 WH-18975-M23 WH-18

975-M23 WH-18

975-M25 WH-18

975-M25 WH-18975-M66 WH-18

975-M27 WH-18

975-M27 WH-18

975-M164 WH-18

975-M164 WH-18975-M24 WH-18

975-M24 WH-18

975-M125 WH-18

975-M125 WH-18

200-M212 BK-18

200-M212 BK-18

200-M212 BK-18

200-M212 BK-18

892-M161 BR-18892-M161 BR-18

892-M161 BR-18

892-M161 BR-18

892-M161 BR-18893-M165 GN-18 893-M165 GN-18

893-M165 GN-18

893-M165 GN-18893-M165 GN-18

975-M110 WH-18

106-M134 RD-18158-M144 BR-14

176-M112 YL-14

200-M131 BK-14

200-M160 BK-10

892-M123 BR-18

893-M124 GN-18

E793-M167 BU-18

E794-M158 YL-18

201-M142 BK-18

201-M147 BK-18

200-M206 BK-14

201-M154 BK-18

290-M139 BK-18

291-M141 BK-18

447-M150 PK-18521-M159 YL-14

592-M129 BU-14608-M155 GN-14

630-M64 GY-16

779-M170 WH-18

780-M171 PU-18

E735-M140 PU-18

609-M204 YL-14

200-M166 BK-14

104-M78 YL-14

200-M97 BK-14

197-M86 RD-14

200-M87 BK-14

200-M87 BK-14

200-M87 BK-14

200-M87 BK-14

DRIVE TRAIN CONTROL

K978-X48 BU-18

K978-X48 BU-18

K978-X48 BU-18

K977-X47 PK-18

K977-X47 PK-18

K977-X47 PK-18

E908-X43 BR-18

E908-X43 BR-18

E908-X43 BR-18

E907-X20 GY-18

E907-X20 GY-18

E907-X20 GY-18

E906-X19 OR-18

E906-X19 OR-18

E906-X19 OR-18

E905-X18 BU-18

E905-X18 BU-18

E905-X18 BU-18

E904-X17 BR-18

E904-X17 BR-18

E904-X17 BR-18

E903-X16 YL-18

E903-X16 YL-18

E903-X16 YL-18

E901-X14 GN-18

E901-X14 GN-18

E901-X14 GN-18

E900-X13 WH-18

E900-X13 WH-18

E900-X13 WH-18

E902-X15 PU-18

E902-X15 PU-18

E902-X15 PU-18

E909-X44 WH-18

E909-X44 WH-18

E909-X44 WH-18

975-X50 WH-18

975-X50 WH-18

975-X50 WH-18

973-X7 BR-18973-X7 BR-18

973-X7 BR-18

G848-X9 GN-18

G848-X9 GN-18

G848-X9 GN-18

F847-X51 YL-18

F847-X51 YL-18

F847-X51 YL-18

F846-X8 PU-18

F846-X8 PU-18

F846-X8 PU-18

F843-X4 YL-18

F843-X4 YL-18

F843-X4 YL-18

G730-X42 PK-18

G730-X42 PK-18G730-X85 PK-18

G730-X85 PK-18

F792-X27 WH-18

F792-X27 WH-18

F792-X27 WH-18

F791-X26 BU-18

F791-X26 BU-18F791-X26 BU-18

F790-X31 BR-18

F790-X31 BR-18

F790-X31 BR-18754-X23 BU-18

754-X23 BU-18

754-X23 BU-18

709-X46 OR-18

709-X46 OR-18

709-X46 OR-18

450-X45 YL-18

450-X45 YL-18

450-X45 YL-18

334-X6 BU-18

334-X6 BU-18

334-X6 BU-18

321-X32 BR-18

321-X32 BR-18

321-X32 BR-18

977-X5 YL-18

977-X5 YL-18

977-X5 YL-18

977-X5 YL-18

975-X39 WH-18

975-X39 WH-18

975-X39 WH-18

975-X39 WH-18

900-X25 PU-18

900-X25 PU-18

900-X25 PU-18

900-X25 PU-18

F850-X12 PK-18

F850-X12 PK-18

F850-X12 PK-18

F850-X12 PK-18

F849-X11 WH-18

F849-X11 WH-18

F849-X11 WH-18

F849-X11 WH-18

F848-X10 OR-18

F848-X10 OR-18

F848-X10 OR-18

F848-X10 OR-18

F842-X3 BU-18

F842-X3 BU-18

F842-X3 BU-18

F842-X3 BU-18

893-X36 GN-18

893-X36 GN-18

893-X36 GN-18

893-X36 GN-18

892-X35 BR-18

892-X35 BR-18

892-X35 BR-18

892-X35 BR-18

G731-X30 GY-18

G731-X30 GY-18

G731-X30 GY-18

G731-X30 GY-18

F789-X29 YL-18

F789-X29 YL-18

F789-X29 YL-18

F789-X29 YL-18

F788-X28 PU-18

F788-X28 PU-18

F788-X28 PU-18

F788-X28 PU-18

755-X24 OR-18

755-X24 OR-18

755-X24 OR-18

755-X24 OR-18

752-X22 YL-18

752-X22 YL-18

752-X22 YL-18

752-X22 YL-18

751-X21 GN-18

751-X21 GN-18

751-X21 GN-18

751-X21 GN-18

280-X57 BK-18

280-X57 BK-18

280-X57 BK-18

280-X57 BK-18

279-X56 BK-18

279-X56 BK-18

279-X56 BK-18

279-X56 BK-18

278-X55 BK-18

278-X55 BK-18

278-X55 BK-18

278-X55 BK-18

277-X54 BK-18

277-X54 BK-18

277-X54 BK-18

277-X54 BK-18276-X53 BK-18

276-X53 BK-18

276-X53 BK-18

276-X53 BK-18

202-X52 BK-18

202-X52 BK-18

202-X52 BK-18

202-X52 BK-18

202-X41 BK-14

202-X41 BK-14

202-X41 BK-14

202-X41 BK-14

140-X37 BU-14

140-X37 BU-14

140-X37 BU-14

140-X37 BU-14

851-X76 WH-18

851-X76 WH-18

851-X76 WH-18

851-X76 WH-18

851-X76 WH-18851-X76 WH-18

306-X33 GN-18

306-X33 GN-18

306-X33 GN-18306-X33 GN-18

306-X33 GN-18

306-X33 GN-18

337-X34 WH-18

337-X34 WH-18

337-X34 WH-18337-X34 WH-18

337-X34 WH-18

337-X34 WH-18

G730-X86 PK-18

G730-X86 PK-18

G730-X86 PK-18

G730-X86 PK-18

G730-X86 PK-18

419-X66 YL-18

419-X66 YL-18

419-X66 YL-18

F780-X65 PK-18

F780-X65 PK-18

F780-X65 PK-18

F781-X75 BR-18

F781-X75 BR-18

F781-X75 BR-18

F782-X68 OR-18

F782-X68 OR-18

F782-X68 OR-18

F783-X1 GN-18

F783-X1 GN-18

F783-X1 GN-18

F784-X67 YL-18

F784-X67 YL-18

F784-X67 YL-18

F785-X62 WH-18

F785-X62 WH-18

F785-X62 WH-18

F786-X72 GY-18

F786-X72 GY-18

F786-X72 GY-18

140-X70 BU-18

140-X70 BU-18

140-X71 BU-18

140-X71 BU-18

140-X49 BU-18

140-X49 BU-18 140-X49 BU-18

140-X49 BU-18

140-X49 BU-18

140-X63 BU-18

140-X63 BU-18

140-X64 BU-18

140-X64 BU-18G939-X83 PK-18

G939-X83 PK-18

G939-X69 PK-18

G939-X69 PK-18

G939-X2 PK-18G939-X2 PK-18

G939-X38 PK-18

G939-X38 PK-18 G939-X38 PK-18

G939-X38 PK-18

G939-X38 PK-18

G939-X40 PK-18

G939-X40 PK-18

G939-X40 PK-18G939-X40 PK-18

G939-X40 PK-18

G939-X61 PK-18

G939-X60 PK-18

G939-X60 PK-18G939-X59 PK-18

G939-X59 PK-18

G939-X58 PK-18

G939-X58 PK-18 G939-X58 PK-18

G939-X58 PK-18

G939-X58 PK-18

G939-X74 PK-18G939-X74 PK-18G939-X73 PK-18

G939-X73 PK-18

200-JK1 BK-18200-JK2 BK-18200-JK3 BK-18

200-JK4 BK-18

201-JF1 BK-18201-JF2 BK-18201-JF3 BK-18

109-AF1 RD-0

109-AF1

CONN 48

CONN 47

CONN 47

RD-0

109-AF1 RD-0

109-AF1 RD-0

NOT USED ON THIS MODEL

NOT USED ON THIS MODEL

NOT USED ON THIS MODEL

RIPPER PIN PULL

975-MF4 WH-18

975-MF7 WH-18334-MF6 BU-18

975-MF3 WH-18334-MF5 BU-18

975-MF10 WH-18

F842-MF8 BU-18

140-MF9 BU-18

NOTE F: 173-6530 AM/FM RADIO (U.S.) 173-6532 AM/FM RADIO W/ CASSETTE (U.S.)

F843-M214 YL-18

F843-M214 YL-18

F843-M214 YL-18

F843-M214 YL-18

F843-M214 YL-18

F843-M214 YL-18F843-E118 YL-18

F843-E118 YL-18

G731-E20 GY-18198-E12 RD-18

F843-E118 YL-18

F790-E106 BR-18

A700-E115 OR-18

998-E116 BR-18

F702-E117 GN-18

202-E121 BK-18

202-E121 BK-18

202-E122 BK-18

202-E122 BK-18

140-E119 BU-18

140-E119 BU-18

140-E120 BU-18

140-E120 BU-18

158-M185 BR-14521-M180 YL-14200-M190 BK-14

426-M101 BR-18201-M26 BK-18

442-M126 GY-18

F715-RM1 PU-18F716-RM2 WH-18F717-RM3 YL-18F718-RM4 BU-18998-RM5 BR-18600-RM6 BR-18200-RM7 BK-18

EROPS THROTTLE JUMPERUSED ON EROPS MACHINES ONLY

WHEN USEDPLUG INTO

M-C1

WHEN USEDPLUG INTO

RA-C1

600-E98 BR-18200-E97 BK-18

600-E96 BR-18

200-E95 BK-18

F850-M217 PK-18

F850-M217 PK-18

F850-M217 PK-18

F850-M217 PK-18

F850-M217 PK-18

F850-M217 PK-18F850-MF11 PK-18

F850-MF11 PK-18

F850-MF11 PK-18

975-MF2 WH-18

975-MF2 WH-18

200-M131 BK-14

592-M129 BU-14

592-M73 BU-14

592-M73 BU-14

592-M73 BU-14

592-M73 BU-14

592-M73 BU-14

592-M73 BU-14

592-M73 BU-14592-M73 BU-14

592-M73 BU-14200-M21 BK-14 200-M21 BK-14

200-M21 BK-14

200-M21 BK-14

200-M21 BK-14

200-M21 BK-14

158-TF1 BR-14521-TF2 YL-14200-TF3 BK-14

200-HE8 BK-14608-HE3 GN-14

608-HE5 GN-14

200-HE7 BK-14

608-HE4 GN-14200-HE6 BK-14

608-HE2 GN-14200-HE9 BK-14

EEC CODE PLUG201-JN1 BK-18

201-JN3 BK-18

201-JN2 BK-18

H-1

H-1

H-2

H-2

H-3

H-3

H-4

CONN 27

H-4 H-4

H-4

H-4

H-5

H-5

H-6

H-6

H-6

H-7

H-7 H-7

H-7

H-8

H-8

H-8

H-9

H-9

H-9

H-10

H-10

H-11

H-11

H-11

H-12

H-12

H-13

H-1

3

H-6

H-13

H-14

H-1

4

H-15

H-15

H-15

H-16

H-1

6

H-1

7

H-1

7

H-18

H-1

8

H-19

H-1

9

H-20

H-2

0

H-20

H-21

H-2

1

H-22

H-22

H-23

H-23

CONN 33

H-24

H-24

H-25

H-25

H-26

H-26

H-26

NOTE E

CONN 34

106-M218 RD-18

106-M218 RD-18

NOTE E

NOTE E

NOTE E

NOTE E

CONN 15

CONN 17

CONN 16

CONN 18

CONN 19

A700-W25 OR-18

CB

L-JJ

1B

K-0

0

893-MP21 GN-18

893-MP21 GN-18892-MP20 BR-18

892-MP20 BR-18

403-MP22 GN-18

403-MP22 GN-18

308-MP23 YL-18

308-MP23 YL-18

200-MP24 BK-18

200-MP24 BK-18106-MP25 RD-18

106-MP25 RD-18

NOTE E

892-MJ47 BR-18

106-MJ33 RD-18

NOTE E

NOTE E

NOTE E

NOTE E

NOTE E

MACHINE SECURITY SYSTEM / PRODUCT LINK

200-CM1 BK-6

116-E35 RD-14

116-E35 RD-14

600-E51 BR-18

600-E51 BR-18600-E51 BR-18

J994-X77 GY-18

J994-X77 GY-18

J994-X77 GY-18

J994-X77 GY-18

J992-X78 YL-18

J992-X78 YL-18

J992-X78 YL-18

J992-X78 YL-18J993-X79 PK-18

J993-X79 PK-18

J993-X79 PK-18

J993-X79 PK-18

J995-X80 PU-18

J995-X80 PU-18

J995-X80 PU-18

J995-X80 PU-18

F786-RS1 GY-18F782-RS2 OR-18G939-RS3 PK-18

PRODUCT LINK CONNECTOR

(LOC l-15)

106-ML1 PU-18

106-ML1 PU-18

200-ML2 BK-18

200-ML2 BK-18

308-ML3 YL-18

308-ML3 YL-18

403-ML4 GN-18

403-ML4 GN-18

893-ML6 GN-18

893-ML6 GN-18892-ML5 BR-18

892-ML5 BR-18

ABCDEFGHJKL

P-C11086177

MNPRST

12345678

P-C23E3388

12

P-C31552269

12

P-C41552269

12

P-C51552269

12

P-C71552269

12

P-C61552269

BK-18BR-18YL-18

1234

AUTO DOWNSHIFT SW1339405

BK-18BR-18YL-18

1234

BI DIRECTIONAL MODE SW1339405

+V DISPLAYGROUND

CLOCKDATALOAD

HARNESS CODE

GAUGE CLUSTER1666928

OR-18BK-18GN-18WH-18YL-18BU-18

LAMP1239294

LAMP1239294

ACTION ALARM3E6328

BK-18RD-18

STONOFF

BSC

R

KEY START SW1428858

YL-16

OR-16BR-16

PU-16

1234

BK-18BR-18YL-18

1234

OPERATOR MONITOR SW1339405

BK

BR

GYGNBU

1

2

543

61

2

543

4 SPEED BLOWER SW1571361

WH6

+V DISPLAYGROUND

CLOCKDATALOAD

HARNESS CODE

LAMP GEAR MODULE1680369

OR-18BK-18GN-18WH-18YL-18BU-18

HARNESS CODE 5

21

7

OPERATOR SW INPUT

8 9

28

10

36

29

5

2019

24

18

11

38

34 35

14

23

6

16

22

12

3

32

40

31

37

30

1

HARNESS CODE 4

HARNESS CODE 3

HARNESS CODE 2

HARNESS CODE 1

HARNESS CODE 0

25SPI CLOCK

INSTRUMENT SUPPLY

CAT DATA LINK +

CAT DATA LINK -

HYD OIL TEMP

POWERTRAIN TEMP

ACTION LAMP

POWERTRAIN FILTER

FUEL LEVEL

SENSOR SUPPLY

ACTION ALARM

GROUND

ALTERNATOR

+ BATTERY

SERVICE

CLEAR

SPI LOAD

SPI DATA

33

13

26

4

2

39

27

17

15

CATERPILLAR MONITORING SYSTEM1847766

HYDRAULIC FILTER

165432

E-C2 CONN 261552273

12

E-C31552269

ABC

E-C281552267

E-C78T9834

ABC

E-C81552267

123456

E-C91552273

123456

E-C101552273

ABC

E-C111552267

ABC

E-C131552267

1 2 3 4 5 6

E-C

1415

5227

3

FRONT WIPER SW3T6655

LEFT WIPER SW3T6655

RIGHT WIPER SW3T6655

B

PL

B

W

H

B

PL

B

W

H

B

PL

B

W

H

B

PL

B

W

H

REAR WIPER SW3T6655

123456789101112

HA-C31552252

12

345

6

789101112

H-C21552252

12

345

6

789101112

HA-C23E5179

123456789101112

H-C13E5179

GND

B+ PT

MOTOR H

BR-16GY-16BK-16

OR-16

GN-16

REAR WIPER1477979

GND

B+ PT

MOTOR H

GND

B+ PT

MOTOR H

GND

B+ PT

MOTOR

L

H

BR-16GY-16BK-16

OR-16

GN-16

RIGHT WIPER1171881

BR-16GY-16BK-16

OR-16

GN-16

LEFT WIPER1171882

BR-16GY-16BK-16

OR-16

GN-16

FRONT WIPER1477976

H-C51552273

H-C61552273

12

3

4

5

6

12

3

4

5

6

12

3

4

5

6

H-C41552273

12

3

4

5

6

HA-C11552273

BK-16WH-16RD-16

DOME LAMP3E6389

HA-C41552267

ABC

HEADLINERGND

12345678

E-C173E3388

ANTENNA8E1118RIGHT SPEAKER

6T7695

-+

LEFT SPEAKER6T7695

-+

123456

HH-C13E3382

MOTOR

FRONT WASHER7T8891

MOTOR

LEFT WASHER7T8891

MOTOR

RIGHT WASHER7T8891

MOTOR

REAR WASHER7T8891

123456

H-C3CONN 21

CONN 22

CONN 10

CONN 11

1552273

THERMOSTAT3E5464

12

EE-C13E3364

12

EE-C21552269

MOTOR

BLOWER13E6387

BK-14WH/RD-14

BLOWER23E6386

MOTORBK-14WH/RD-14

BLOWER RESISTOR1259740

1 2 3 4 5 6 EE

-C3

3E33

82

E-C123T3158

E-C203T3158

RESISTOR1166203

RIPPER FLOOD SW3E7152

AB

DC

32

LIGHT PIPE1239294

E-C193T3158

E-C183T3158

LIGHT PIPE21239294

12

E-C151552269

HH-C23T4412

HH-C33T4412

HH-C43T4412

HH-C53T4412

THROTTLE SW3E9044

AB

DC

6

4

3

12

5

RA-C23E7996

AB

DC

5

21

3

4

6

23

C

E-C213E7996

AB

D

5

1

4

6

AC SW1259257

AB

DC

32

GROUND+BAT

SIGNAL

RD-18BK-18YL-18

DECEL PEDAL POSITION1602443

ABC

123456789

10111213141516171819202122232425262728293031323334353637383940

M-C33E6286

E-C223E7996

AB

DC

23

5

1

4

6

ANTENNA

GROUND

+B MEMORYLEFT SPKR -

RIGHT SPKR -GY/BK,PU/BK

WH/BK,GN/BKYLRD

BKWH/GN

+ BATTERY (12V)

LEFT SPKR +

NC

RIGHT SPKR +

12V RADIONOTE F

GY/PU

PP-C51552264

GROUND+BAT

SIGNAL

RD-18BK-18YL-18

BRAKE POSITION SNSR1471680

ABC

ABC

E-C271552267

12

M-C91552269

SERVICE BRAKE DUMP1722392

BK-18BK-18

PARK BRAKE DUMP1722392

BK-18BK-18

1234

M-C41552272

1234

M-C61552272

12

M-C121552269

12

M-C141552269

BK-18BK-18

XMSN INTER SPD 11932550

12

PP-C11552269

12

PP-C21552269

12

PP-C31552269

12

PP-C41552269

FORWARD HORN1586632

BK-18BK-18 2

1

SERVICE BRAKE PEDAL SW1327077

G-C13E3370

ABC

FWD HORN HI1747875

12

FWD HORN LO1747876

12

12

G-C31552269

12

G-C21552269

12V OUTLET

CONN 14

CONN 13

CONN 12

1172311

DISCONNECT SW7N0718

MODULE 2GROUND

123456

M-C251552273

1234

START AID SW1339405

YL-18BR-18BK-18

ABC

E-C241552267

REAR ACTION LAMP1151748

MSS KEY 31938550+ BATGND

+V CRANK DRIVER OUT

KEYSWITCH INALTERNATOR R TERMINAL IN

CAN DATA LINK ++V CRANK POSITION DRVR IN

+V CRANK POSITION IN

GND

SWITCH INPUT 1

CAN DATA LINK -

+V ON SWITCH DRIVER OUT

TIRIS INTERFACE SIG LINE+V ON SWITCH DRIVER IN

CAT DATA LINK +CAT DATA LINK -

CAT DATA LINK GND+V CRANK DRIVER GND RTN

LED SOURCING DRVR OUT SEG 1LED SOURCING DRVR OUT SEG 2

NEUTRAL START ENABLE INPUTSWITCH IN 2

TIRIS ANTENNA TAP 2TIRIS ANTENNA TAP 1

13579111318192426293140424547525358606264666870

TIRIS GND RETURN+V ON SW DRIVER GND RTN

MSS EXCITER COIL1950759

12

E-C41552269

E-C251182765

LAMP BASE1703461

21BK-16

BK-16

M-C189W1951

ABCDEFGHJ

DATALINK SERVICE CONNECTOR

12

M-C303E3375

34

MONITOR SERVICE CONNECTOR

+24 V BATTERY IN+24 V SWITCHED IN

GROUND+12 V MEMORY OUT

+12 V SWITCHED OUTGROUND

10A CONVERTER1591549

123456

12V OUTLET 21172311

BACKUP ALARM1236449

BK-18BK-18

1

2

CF-C21552273

3

4

5

6

BK-18BK-18

PRELUBE OIL PRESSSURE1059152

12

CF-C31552269

GROUND

12

MT-C11552269

12

MT-C2CONN 25

3E336412

M-C341552269

12

MR-C21552269

12

MR-C13E3364

12

M-C71552269

+BAT

RS-232C Rx Data

RS-232C Tx DATA

HDD GND

CAT Data Link -

RS-232C GND

PRODUCT LINK1532304

CAN Data Link -

CAN Data Link +CAN Link Shield

CAT Data Link +SENSOR SUPPLY

-BAT+BAT

ALTERNATOR INKEY SW INPUT

HDD INPUT-BAT

123456789101112131415161718192021222324

1

M-C151275485

ENGINEBLOCK

FRAMEGROUND

RIPPER FLOOD1470319

12

KA-C21552269

200-

BK

MOTOR

12

SEAT SUSPENSION1476523

12

M-C241552269

12

RA-C11552264

345678

12345678

M-C13E3388

12345678

M-C353E3388

12

R-C31552264

345678

12

M-C263T4412

MODULEGROUND

M-C193E3370

ABC

12

RW-C21552269

RW-C13E3370

ABC

LIGHT1260810

ABC

KW-C11552267

12

M-C81552269

12

M-C111552269

12

M-C211552269

UNSWITCHEDPWR OUTLET

12

M-C273E3364

SWITCHED PWROUTLET

MODULE 1GROUND

TC-C13E3370

ABC

12

TC-C21552269

12

TC-C31552269

30

86

87A87

85TC-C49X1054

TF-C21552267

ABC

MOTOR

ROPS COND1062721

BK-14WH/RD-14

MOTOR

ROPS COND 21062721

BK-14WH/RD-14

COND RLY3E5239

12

AG-C13E3364

12

M-C283E3364

12

KA-C11552269

12

H-C81552264

34

56

78

HCHC

1

2

H-C71552272

341

234

E-C163E3376

TF-C11552267

ABC

12

MF-C21552269

12

MF-C31552269

12

KW-C21552269

BK-18BK-18

WINCH SOL1529095

12

E-C231552272

34

1

M-C291275485

M-C321552267

ABC

CF-C13E3370

ABC

M-C333E3370

ABC

12

ME-C11552269

12

ME-C23E3364

12

KK-C13E3376

34

CV-C13E3370

200 BK-18

FOR NORMALOPERATING MODE

CV-C23E3370

201 BK-18

NOTE: USE ONLY FOR CRANK WITHOUT FUEL

INJECTION

ABC

ABC

12

M-C201779654

34

12

MG-C11779649

34

UNUSED+12V MEMORY OUT

UNUSEDUNUSED

+24V BATTERY INGROUND

20A CONVERTER1843579

+12V OUTPUT

+24V SWITCHED INUNUSED 1

23456

1234

12

G-C41552269

12

G-C51552269

123456789

101112131415161718192021222324

M-C223E6286

25262728293031323334353637383940

12

R-C51552269

12

R-C61552269

12

M-C133E3382

3456789101112

12

MF-C11552273

3456789101112

BK-18BK-18

WINCH SW1649450

12345678

M-C171552264

1

2

3

4

5

6

7

8

E-C51552264

12

E-C61552272

34

RED

GREEN

PU-18

GN-18BK-18

MSS LED1655655

E-C261552267

ABC

12

MG-C21779654

34

12345678

M-C231552264

4

3

1

2

B3

B2

B1

LAMP SW1753950

GY

BRPK

BUPU

YL

OR

MP-C11086259

123456789101112131415161718192021222324

ML-C27X6222

MJ-C31506766

AB

MJ-C41086259

CDEFGHJKLMNPRST

WHEN USEDPLUG INTO

P-C1(LOC I-13)

12345678910111213141516171819202122232425262728293031323334353637383940

MJ-C11130580

WHEN USEDPLUG INTOM-C5

(LOC I-12)

RH FENDER FLOOD1355549

WH-18BK-18

LH FENDER FLOOD1355549

WH-18BK-18

15A

CONV BRKR 13T2662

15A

CONV BRKR 23T2662

FORWARD CLUTCH1608408

REVERSE CLUTCH1608408

FIRST GEAR CLUTCH1608408

SECOND GEAR CLUTCH1608408

THIRD GEAR CLUTCH1608408

12345678910111213141516171819202122232425262728293031323334353637383940

MP-C21130580

M-C53E6286

BK-18BK-18

XMSN INTER SPD 21932550

BK-18BK-18

XMSN OUT SPD 11932550

BK-18BK-18

XMSN OUT SPD 21932550

123456789101112131415161718192021222324

M-C29X4391

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

123456789101112131415161718192021222324

E-C11030213

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

FUSE BLOCK 1901030

RPR PIN/SEAT/WINCH15A

BLOWERS20A

AUX 215A

AUX 110A

AUX 315A

AUX 410A

SERVICE BRAKE15A

KEY15A

EMS II10A

WIPERS10A

AC CONDENSOR20A

WINCH15A

FENDER FLOODS15A

FRONT FLOODS15A

MSS/PROD LINK15A

FORWARD HORN15A

BUSSPOINT 1

BUSSPOINT 2

19 20

17 18

15 16

13 14

8

5 6

3 4

1 2

7

CONVERTER10A

24V-12V CONVERTER20A

PRIMING PUMP5A

REAR FLOODS15A

11 12

9 10

135A

ALT BRKR1712213

BK-18BK-18

START RLY1251302

15AENG ECM SWITCHED

6T3643

15ADRIVETRAIN

6T3643

12

F-C31552269

123456789

10111213141516171819202122232425262728293031323334353637383940

F-C11130580

123456789101112

F-C41642336

1

F-C51275486

BLOCK AS1724863

12

F-C61552269

HYD FILTER BYPASS SW1647577

BK-18BK-18

12

F-C71552269

15AENG ECM UNSW

6T3643

BK-18BK-18

MAIN RLY1670138

12

F-C23E3364

BUSS BAR F

1757020

BU

SS

BA

R F

1757

020

BUSS BAR F

1757020

BU

SS

BA

R G

1757

022

BUSS BAR H

1757021

BUSS BAR H

1757021

BUSS BAR J1757024

BUSS BAR J1757024

BUSS BAR K1757023

BUSS BAR K1757023

FUEL LEVEL SNSR1601823

BK-18BK-18

12

HE-C21552269

12

HE-C31552269

12

HE-C51552269

HE-C4

CONN 2CONN 1

CONN 3

CONN 4

3E3370

ABC

12

HE-C73E3364

12

HE-C63E3364

12

HE-C13E3388

345678

12

RF-C21552269

12

RG-C21552269

ROPS FLD 21470319

ROPS FLD 41470319

12

RF-C31552269

12

RF-C11552269

12

RG-C11552269

12

RG-C31552269

ROPS FLD 11470319

ROPS FLD 31470319

12

RC-C11552269

12

RC-C21552269

12

RE-C11552269

12

RE-C21552269

SWEEP LIGHT 11532073

SWEEP LIGHT 21532073

REAR FLOOD 11470319

REAR FLOOD 21470319

LN-C1

CONN 8

CONN 5

CONN 6

CONN 7

3E3370

ABC

12

LN-C31552269

12

LN-C41552269

30

86

87A87

85LN-C29X1054

MOTOR

CONDENSOR1062721

BK-14WH/RD-14

MOTOR

CONDENSOR 21062721

BK-14WH/RD-14

COND RELAY3E5239

BK-18GN-18GN-18BK-18 1

234

RIPPER PIN SOL3E8575

ARC SUPPRESSOR 11068704

12

ARC SUPPRESSOR 21068704

12

1234

K-C21552272

12

K-C11552269

12

K-C31552269

ABC

K-C41552267

12

Y-C21552269

Y-C51552267

PTRAIN FILTER PRESSURE SW1647577

BK-18BK-18

12

Y-C31552269LC-C2

1552267

ABC

LC-C1

CONN 23

CONN 24

3E3370

ABC

12

Y-C41552269

PTRAIN FILTER PRESS SW 21647577

BK-18BK-18

12

Y-C13E3388

345678

T

HYD OIL TEMP SW4W9972

12

AH-C13E3364

12

RJ-C13E3364

12

RJ-C21552269

12

RJ-C31552269

CYLINDER FLD 31470319

CYLINDER FLD 41470319

12

AK-C1

CONN 44

CONN 44

3E3364 12

AK-C21552269

12

AK-C31552269

CYLINDER FLD 11470319

CYLINDER FLD 21470319

12

AJ-C13E3364 1

2

AJ-C21552269

12

AJ-C31552269

W/D FLOOD 11470319

W/D FLOOD 21470319

12

RH-C13E3364

12

RH-C21552269

12

RH-C31552269

W/D FLOOD 31470319

W/D FLOOD 41470319

BK-18BK-18

COOLANT FLOW SW1346054

12

123456789101112131415161718192021222324

AE-C39X1343

25262728293031323334353637383940

1 2

AE

-C4

1552

252

3 4 5 6 7 8 9 10 11 12

ENGINE CONTROL1457806

12345678910111213141516171819202122232425262728293031323334353637383940

1234567891011

12

1314151617

18

19202122232425262728293031323334353637383940

J1 (A KEY) J2 (B KEY)

ATA DATALINK -THROTTLE SW (LOW IDLE)CAT DATALINK -+BATTERY (UNSWITCHED)GROUND+BATTERY (SWITCHED)ATA DATALINK +THROTTLE SW (LOW IDLE PARITY)CAT DATALINK +

SPARE -

BACKUP SPD TIMING SNSR -

THROTTLE SW (HIGH IDLE)

BACKUP SPD TIMING SNSR +

START AID SWTHROTTLE SW (HIGH IDLE PARITY)

CRANK W/O INJECT (N.C.)CRANK W/O INJECT (N.O.)CAN SHIELD GROUND

DIGITAL SENSOR RETURNANALOG SENSOR RETURN

DIGITAL SENSOR +8VANALOG SENSOR POWER +5V

START AID RELAY

OPTIONAL ACTIVE S/T POWERTURBO INLET PRESSURE

INJECTOR COMMON 1 &2

3.5A DRVR & OPT SOL RTRN}ENGINE OIL PRESSURE

INLET AIR TEMP

FUEL PRESSURE

COOLANT FLOW SWITCHINJECTOR COMMON 3 & 4

OPTIONAL RETARDER SOL LO/HIATMOSPHERIC PRESSURE

TURBO OUTLET PRESSUREUSER SHUTDOWN

INJECTOR COMMON 5 & 6

ENGINE ANALOG SENSOR RETURNDECELERATOR PEDAL

ENGINE ANALOG SENS PWR +5VOPTIONAL ACTIVE S/T

BOTTOM S/T+ / TDC PROBE +

GROUND STRAP TIE POINT

COOLANT TEMPERATURE

COOLANT FLOW SW RETURN

CAN DATA LINK +

CAN DATA LINK -

INJECTOR 1

INJECTOR 2

INJECTOR 3

INJECTOR 4

INJECTOR 5

INJECTOR 6

BOTTOM S/T- / TDC PROBE -FUEL TEMPERATURE

HYD FAN (CAT PROP VALVE)

AE-C53E6287

AE-C63E6286

1 2 3 4 5 6 7 8 9 10 11 12

NR

-C1

3E89

69

AE-C73E336412

AE-C81552269

GROUND+5V

SIGNAL

OR-18BK-18WH-18

INLET AIR TEMPERATURE1078618

GROUND+5V

SIGNAL

OR-18BK-18WH-18

COOLANT TEMP SNSR1022240

ABC

ABC

AE-C111042921

GROUND+5V

SIGNAL

OR-18YL-18GN-18

TURBO OUTLET PRESSURE1619929

ABC

ABC

AE-C91042921

ABC

AE-C123E3370

GROUND+5V

SIGNAL

OR-18YL-18GN-18

ATMOSPHERIC PRESSURE1619925

ABC

ABC

AE-C133E3370

GROUND+5V

SIGNAL

OR-18YL-18GN-18

ENGINE OIL PRESSURE1619931

ABC

ABC

AE-C143E3370

GROUND+V

SIGNAL

OR-18BK-18WH-18

FUEL TEMP SNSR1022240

ABC

ABC

AE-C151042921

12

AE-C11552269

BACKUP (SECONDARY)SPEED TIMING SNSR

12

AE-C161552269

12

AE-C2

CONN 49

CONN 45

1552269PRIMARY SPEED

TIMING SNSR

NR-C27E6513

NR-C37E6513

NR-C47E6513

NR-C57E6513

NR-C67E6513

NR-C77E6513

ENGINEGROUND

AE-C103E3370

ABC

FUEL PRESSSENSOR

INJ SOL 11288510

INJ SOL 21288510

INJ SOL 31288510

INJ SOL 41288510

INJ SOL 51288510

INJ SOL 61288510

START AID VALVE3E6332

WH-18PU-18

START AID RLY3E5239

30

86

87A87

85W-C89X1054

GROUND+5V

SIGNAL

OR-18YL-18GN-18

TURBO INLET PRESS SNSR1619926

ABC

BK-18BK-18

ECPC PUMP SOL1361679

ECPC XMSN INPUT SPD1835011

BK-18BK-18

12

W-C161552269

12

W-C171552269

12

W-C181552269

GROUND+8V

SIGNAL

RD-18BK-18WH-18

XMSN TEMP SENS1187226

ABC

ABC

W-C131552267

ABC

W-C21552267

G S

MTR BAT

MOTORSTARTER

6V0890PRELUBE STARTER

1249780

RESISTOR 3E7842

12

W-C151552269

ALT+ R

ALTERNATOR (70A STD)1855294

ALTERNATOR (75A HD)3E7577

ALTERNATOR (100A)1655140

12

W-C41552269

BK-18BK-18

REFRIGERANT SWITCH 1145333

GN-18GN-18

A/C CLUTCH SOLENOID3E1906

DIODE1068704

12

W-C111552269

12

W-C91552269

12

W-C31552269

W-C101552267

ENGINE SPD SNSR6V2455

BK-18WH-18

12

W-C191552269

W-C63E3370

W-C121275486

W-C14

CONN 42

9X0141

W-C11130580

12

W-C20

CONN 40

CONN 39

CONN 41

1552272

34

FLEXXAIRE FAN

T

POWERTRAIN OIL TEMP SNSR1753088

BK-18BK-18

NEGPOS

12V BATTERY 33T5760

NEGPOS

12V BATTERY 43T5760

NEGPOS

12V BATTERY 23T5760

NEGPOS

12V BATTERY 13T5760

P N AUX START 1991192

HARNESS CODE 4

HARNESS CODE 3

HARNESS CODE 2

HARNESS CODE 1HARNESS CODE 0

ECPC PUMP SOLENOID

GROUND+ BATTERY

DATA LINK -

DATA LINK +

IMPL LOCKOUT SWITCH

SERVICE BRAKE POS

ENGINE SPEED SENSOR

REVERSE SW (N.O.)

REVERSE SW (N.C.)

FORWARD CLUTCH

SOLENOID RETURN

RIGHT STEER CLUTCHLEFT BRAKE SOLENOID

LEFT STEER CLUTCH

RIGHT STEER SENSOR

LEFT STEER SENSOR

DOWNSHIFT SW (N.O.)

+ V SENSORPARK BRAKE SW (N.C.)

PARK BRAKE SW (N.O.)

GROUND+ BATTERY

DOWNSHIFT SW (N.C.)UPSHIFT SW (N.O.)

DIRECTION SENSOR

BACK UP ALARM

SWITCH/SENSOR RETURNSWITCH/SENSOR RETURN

UPSHIFT SW (N.C.)

RIGHT BRAKE SOLENOID

SOLENOID RETURN

BI DIRECTION N.O.

AUTO DOWNSHIFT SW

TRANS OUT SPD Q -

TRANS OUT SPD Q +

TRANS OUT SPD -

TRANS INT SPD Q -

TRANS INT SPD Q +

TRANS INT SPD +

THIRD GEAR CLUTCH

SECOND GEAR CLUTCH

FIRST GEAR CLUTCH

REVERSE CLUTCH

TRANS INT SPD -

TRANS INPUT SPD +

TRANS OUT SPD +

TRANS INPUT SPD -

INCHING PEDAL SENSOR

IMPLEMENT DETENT

ECB CONTROL 1729389

UNUSED

IMPLEMENT LOCKOUT SW

SERV BRAKE DUMP VALVE

BI DIRECTION N.C.

UNUSED

UNUSED

UNUSEDUNUSED

AUTO DNSHIFT IND

UNUSED

UNUSEDSTEER OIL TEMP SNSR

UNUSEDUNUSEDUNUSED

2F 2R IND LAMPUNUSED

UNUSEDUNUSED

UNUSED2F 1R IND LAMP

UNUSED1F 2R IND LAMP

PARK BRAKE DUMP VALVE

YL-18BK-18RD-18+BAT

GROUNDSIGNAL

DIRECTION SENDER 1618979

GY-18OR-18GN-18BK-18BU-18

WH-18

YL-18PK-18RD-18

VI-18

BR-18

WH/BU-18

PARKING BRAKE SW 1180639

101134567812129

COM

REVERSE SW 1107882

NCNO

X-C81552267

ABC

123456

X-C71552273

123456789

10111213141516171819202122232425262728293031323334353637383940

X-C11010205

12345678910111213141516171819202122232425262728293031323334353637383940

X-C23E6287

12

3

45

6

X-C51552273

SHIFT CONTROL

4 32 1UPSHIFT SW

1327450GN-20PK-20WH-20

4 32 1DOWNSHIFT SW

1327419

YL-20RD-20BR-20

X-C61552252

JK-C13E3382

12345678

JF-C11552264

592 BU-14

1234

RECEPTACLE AS1855627

LEFT BRAKE SOL1744909

RIPPER PIN PULL SW1460240

ABC

RD-18WH-18

BK-18

IMPLEMENT LOCKOUT SW1890135

ABC

BK-18WH-18GN-18

MF-C41552267

ABC

WH-18BK-18RD-18+V

GROUNDSIGNAL

INCHING PEDAL POSITION1263741

USED ON PSDD MACHINES ONLY

12

E-C291552272

34

12

RM-C11552264

345678

12345678

RM-C21944253

123

4

MF-C53E3376

12

M-C313T4412

R-C21552267

ABC

BK-18WH-18GN-18

123

4

IMPLEMENT LOCKOUT SW 21913587

12345678

JN-C1CONN 30

CONN 31

1552264

ACTION LAMP1230304

GNBKBK

JACKET WATER HEATER1613617

423516

BK-16GN-16WH-16YL-16RD-16

PRELUBE TIMER1403108

PRESSURE SW (NC)GROUNDKEY SWITCH (START)CRANKING MOTOR CTRLKEY SWITCH (RUN)

PRELUBE RELAY1790006

12

FRAMEGROUND

123456789101112131415161718192021222324

M-C361030213

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

X-C99X4391

X-C33E3370

AB

C

RS-C11552267

12

MJ-C21552252

3456

12

MP-C31552252

3456

ML-C13E5179

CONN 29

CONN 28

789

101112

789101112

1212

308-M215 YL-18200-M219 BK-18

W-C401552269

MAIN PWR RLY FLYBCK1068704

200-M219 BK-18

200-M219 BK-18

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

E

F

G

H

I

A

B

C

D

9 8 7 6 5 4 3 2 115 14 13 12 11 10

A

B

C

D

E

F

G

H

I

SYMBOL DESCRIPTION

BLADE, SPADE, RING OR SCREW TERMINAL

CIRCUIT CONNECTED

CIRCUIT NOT CONNECTED

ELECTRICAL CONNECTION TO MACHINE STRUCTUREINTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT

CONNECTOR

ATCH WIRE, CABLE, COMPONENT

CIRCUIT CONNECTED

SPLICE

CIRCUIT GROUPING DESIGNATIONH#

STARTING CIRCUIT.

GAUGE CIRCUIT.

CATERPILLAR MONITORING SYSTEM CIRCUIT.

PANEL LAMP CIRCUIT.

WASHER/WIPER CIRCUIT.

HEATER AND AIR CONDITIONER CIRCUIT.

GROUND CIRCUIT.

MSS CIRCUIT.

ENGINE CONTROL CIRCUIT.

START AID CIRCUIT.

ECB CONTROL CIRCUIT.

ALL DASHED LINES ARE ATTACHMENTS.

WIRES THAT HAVE BATTERY VOLTAGE WHEN THE KEY SWITCH IS OFF.WIRES THAT HAVE BATTERY VOLTAGE WHEN THE KEY SWITCH IS ON.

NOTE E

NOTE E

NOTE E

NOTE E

NOTE E NOTE E

NOTE E

NOTE E

NOTE E

NOTE E

NOTE E

NOTE E

CONN 19

CONN 34

CONN 20

CONN 37

CONN 44

CONN 47

CONN 5

CONN 17

CONN 32

CONN 41

CONN 16

198-M71 RD-18197-M86 RD-14

CONN 20

FLEXXAIRE FAN