Upload
others
View
8
Download
0
Embed Size (px)
Citation preview
1
GCEP Energy WorkshopApril 27, 2004, Alumni Center, Stanford University
Biomass Energy
GCEP Energy WorkshopApril 27, 2004, Alumni Center, Stanford University
Biomass Energy
Photosynthesis, Algae, CO2 and Bio-Hydrogen
John R. BenemannInstitute for Environmental Management, Inc. (Not for profit)
Palo Alto and Walnut Creek, California [email protected]
3
200,000 ton Anaerobic Bioreactor LandfillDavis, N. California (IEM, Inc. and Yolo County, 2004)200,000 ton Anaerobic Bioreactor LandfillDavis, N. California (IEM, Inc. and Yolo County, 2004)
4
Photosynthesis, Microalgae and H2 ProductionPhotosynthesis, Microalgae and H2 Production
Photosynthesis drives a carbon cycle that is 1 to 2 orders of magnitude greater than the fossil C cycle.
Microalgae have been studied for over 50 years as potential sources of foods, feeds, fertilizers and fuels, based in large part on their reputed ability to efficiently convert solar energy into chemical energy, either CO2 into biomass or even directly into hydrogen.
THIS TALK ADDRESSES THE HOPE AND THE HYPE.
6
Light-induced electron-transfer steps in PS II (Red arrows: when the central pigments are excited by
light they share the excitation (Science, March 04)
Light-induced electron-transfer steps in PS II (Red arrows: when the central pigments are excited by
light they share the excitation (Science, March 04)
Water Splitting and O2 producing Mn Center
8
Effect of high light intensity on pigment Content
Effect of high light intensity on pigment Content
Dunaliella salina
High Lighton left (yellow)
Low Light on right (green)
10
-20
0
20
40
60
80
100
0 400 800 1200 1600 2000 2400 2800 3200
Light-saturation Curves of PhotosynthesisLight-saturation Curves of Photosynthesis
Oxy
gen
evol
utio
nm
mol
O 2(m
ol C
hl)-1
S-1
WT
Chl def.Chl b-less
Chlamydomonas reinhardtii Mutants, Dr. J. Polle, Brooklyn College
Light Intensity, µE m-2 s-1
11
Next Step: Outdoor TestingDr. J. C. Weisaman, SeaAg, Inc. Vero Beach, FL
Next Step: Outdoor TestingDr. J. C. Weisaman, SeaAg, Inc. Vero Beach, FL
WT Mutant CM2
Generation mutants of strains that can grow outdoors (Prof. Polle)Diatom Cyclotella
15
Microalgae Production Plantin Hawaii (Cyanotech Corp).
Red ponds for Haematococcus production, others cultivate the cyanobacterium Spirulina (known to produce H2 and candidate for indirect biophotolysis process)
Microalgae Production Plantin Hawaii (Cyanotech Corp).
Red ponds for Haematococcus production, others cultivate the cyanobacterium Spirulina (known to produce H2 and candidate for indirect biophotolysis process)
16
International Network on Biofixation of CO2 andGreenhouse Gas abatement with Microalgae
EPRI EPRI Rio TintoRio Tinto
TERI (India)TERI (India)PNNLPNNL
Arizona Public ServicesArizona Public Services
ENEL Produzione ENEL Produzione RicercaRicercaGas Technology InstituteGas Technology Institute
20
.
Antenna Size and Photosynthetic Efficiency
Photosynthetic Electron-Transport Chain
200 Chl 20 20 20 20 20 20 20 20 20 20
Photosynthetic Electron-Transport Chains
21
SOLAR EFFICIENCY TRAIN FOR PHOTOSYNTHESIS SOLAR EFFICIENCY TRAIN FOR PHOTOSYNTHESIS
.
Standard / Optimistic assumptions re. losses in photosynthesis
Incident Solar RadiationPercent Percent
Factors Limiting Photosynthesis Lost Remaining
Restricted to Visible Radiation 55 45Losses to reflection, inactive absorption 20 / 10 36/40Efficiency of primary reactions of PS 75 / 70 9 / 12 Respiration and dark metabolism 33 / 15 6 / 10
Light saturation and photoinhibition 50 / 10* 3 / 9* 10% Loss assumes overcoming these limitations (see next slides)
1% Efficiency is about 33 t/ha/yr dry weight biomass production.Maximum is about 100 (higher plants) to 300 (microalgae?) t/ha-yr
22
Solar energy is diffuse, its energy content is low!!
At a very favorable location:5 kWh/m2/day = 6.6 GJ/year
Under optimistic assumptions:•10% conversion efficiency•$15 per GJ --> $10 H2/m2/year
A AA more realistic assumptions:• 3 % conversion efficiency•$5 per GJ (based on current $30/barrel crude oil)
→ $1 H2/m2/year
23
INTRODUCTION TO PHOTOBIOLOGICAL H2 PRODUCTIONINTRODUCTION TO PHOTOBIOLOGICAL H2 PRODUCTION
Many different photobiological H2 production processes –both direct and indirect, single and two stage, microalgae or photosynthetic bacteria, have been studied for 30+ years.
No practical applications have resulted. Some processes even lack a laboratory demonstration of the proposed reaction. For one example: “direct biophotolysis”, which produces H2 directly from H2O without intermediate CO2 fixation.
Direct biophotolysis is the “Holy Grail” of H2 production, due to its perceived high efficiencies. Major projects ongoing at several National Labs, GCEP /Stanford U., UC Berkeley, TCAG/IBEA, others in U.S. and abroad.
24
March 2004, National Academy Sciences: “The Hydrogen Economy: Opportunities, Costs Barriers and R&D Needs”
Advanced Direct Photobiological H2 Production
March 2004, National Academy Sciences: “The Hydrogen Economy: Opportunities, Costs Barriers and R&D Needs”
Advanced Direct Photobiological H2 Production
“H2 production by direct cleavage of H2O mediated by photosynthetic microorganisms, without intermediate biomass formation, [direct biophotolysis] is an emerging technology at the early exploratory stage… theoretically more efficient than biomass gasification by 1 or 2 orders of magnitude.”
“…bioengineering efforts on the light harvesting complex and reaction center chemistry could improve efficiency several-fold... into the range of 20 -30 percent” (solar to hydrogen)
...“substantial fundamental research needs to be undertaken…”
This presentation addresses the realism of these projectionswhich are typical of claims and publicity for such processes.
26
FROM Benemann et al (1973): H2 EVOLUTION BY A CHLOROPLAST-FERREDOXIN-HYDROGENASE REACTION
(IN VITRO DIRECT BIOPHOTOLYSIS REACTION]
FROM Benemann et al (1973): H2 EVOLUTION BY A CHLOROPLAST-FERREDOXIN-HYDROGENASE REACTION
(IN VITRO DIRECT BIOPHOTOLYSIS REACTION]
_____________________________________________________________________________Assay Contents umoles H2/15 min
________________________________________________________ Basic System (spinach chloroplasts, ferredoxin, Hase) 0.25
" " + DCMU (inhibitor of O2 evolution) 0.00
" " - Light (dark) 0.00
" " + glucose + glucose Oxidase (O2 absorber) 1.21
" " + glucose + glucose oxidase + DCMU 0.00
Heated Chloroplasts 0.01_______________________________________________________________CONCLUSIONS: Reaction is very short lived (<20 min) and VERY sensitive to even the small amounts of O2 produced in the process (with O2 absorber reaction runs >hours)
27
PROBLEM #1 OF DIRECT BIOPHOTOLYSIS:O2 produced by PS inhibits H2 production
PROBLEM #1 OF DIRECT BIOPHOTOLYSIS:O2 produced by PS inhibits H2 production
The data from Benemann et al., 1973, shows that the O2produced by photosynthesis strongly inhibits H2production, at well below 0.1% O2 (< 30 ppb O2 ) This is at least 1,000-fold below what is required!
Inhibition is not due to O2 inactivation of hydrogenase(Hase). Inhibition is due to the reaction of O2 with the electron transfer system (e.g. ferredoxin or in Hase).
Development by biotechnology of an O2 stable Hase reaction is NOT plausible (on thermodynamic and other grounds).
O2 absorbers (e.g. glucose-glucose oxidase) not practical –photosynthesis needed to produce the O2 absorbers.
28
DIRECT BIOPHOTOLYSIS: MECHANISM AND ISSUESSimultaneous, single-cell, single stage, H2 and O2 Production
DIRECT BIOPHOTOLYSIS: MECHANISM AND ISSUESSimultaneous, single-cell, single stage, H2 and O2 Production
O2
H2O PSII PSI Ferredoxin Hydrogenase H2
The fundamental problems of direct biophotolysis are:1. The strong inhibition by O2 (from water) of H2 evolution. 2. The high cost of photobioreactors (to capture light and H2).3. The production of highly explosive H2:O2 mixtures.4. The low practical efficiency of all photosynthetic processes.
There are no plausible solutions to problems 1 to 3 (discussed next, Problem 4 was discussed above)
30
PROBLEM #2 OF DIRECT BIOPHOTOLYSIS:High Cost of Photobioreactors.
PROBLEM #2 OF DIRECT BIOPHOTOLYSIS:High Cost of Photobioreactors.
Any process that uses light for H2 production must be contained inside a transparent photobioreactors
For direct biophotolysis the photobioreactor must cover the entire area of the process.
Photobioreactors are inherently expensive, due to major limitations in scale-up and unit sizes (< 100 m2).
Photobioreactor costs will be well above $100/ m2 (even without cost of the tubes or other glazing materials).
Photobioreactors are unaffordable even at the highest possible solar conversion efficiencies (10% solar to H2).
32
Tubular Photobioreactors in Hawaii designed for H2 Production (20 m long tube manifold, inclined at 5%)
34
ALTERNATIVE PHOTOBIOLOGICAL H2 PRODUCTION PROCESSES: INDIRECT BIOPHOTOLYSIS
ALTERNATIVE PHOTOBIOLOGICAL H2 PRODUCTION PROCESSES: INDIRECT BIOPHOTOLYSIS
The limitations of direct biophotolysis for H2 production led to proposals for “indirect biophotolysis” in which: 1. CO2 is first fixed into storage carbohydrates bymicroalgae (e.g. starch in green algae, glycogen incyanobacteria) growing in low-cost open ponds.
2. The accumulated polyglucose (starch, glycogen) is then converted to H2 in a second anaerobic stage in the light inphotobioreactors or in the dark in fermentation tanks.
Separating the O2 and H2 producing reactions avoids O2inhibition, greatly reduces the size of the photobioreactors(if any) and avoids production of explosive O2-H2 mixtures.
35
First Indirect Biophotolysis Process usedFirst Indirect Biophotolysis Process used
.
10
N2-FIXING CYANOBACTERIUM (NOSTOC)N2-FIXING CYANOBACTERIUM (NOSTOC)
36
Proposed Indirect Biophotolysis Process: Could use Spirulina, a mass cultured microalga
Proposed Indirect Biophotolysis Process: Could use Spirulina, a mass cultured microalga
38
C6H12O6 + 6 H2O 10 NADH + 2 FADH2 + 6 CO2
Photosynthesis(10% Solar Efficiency) 10 H2
Dark Fermentation(80-85% yield from Glu)
H2O + CO2
hν
For high yields will need genetically engineered algal cell withhigh photosynthetic efficiency in producing carbohydrates and also high yields of H2 production in the dark by fermentations. THESE ARE THE R&D CHALLENGES OF PHOTOBIOH2
Indirect Biophotolysis with Dark Fermentation as 2nd Stage with high H2 yield - Schematic