AIR CONDITIONING COOLING - Air Cargo Carriers 21/21-50.pdf · AIR CONDITIONING COOLING SYSTEM INSTALLATION (MOD A8145) 21-50 FIG 0010 PAGE 0 MAY 01/08. Fig Item Part number Nomenclature

AIR CONDITIONING

COOLING

0001 AIR CONDITIONING COOLING SYSTEM INSTALLATION

AIR CONDITIONING COOLING SYSTEM INSTALLATION 21-50FIG 0001

PAGE 0JUL 01/12

FigItem Part number

Nomenclature

123456

Effect

From To

Unitperassy

0001

-001 AIR CONDITIONING SYSTEM INST -

COOLING010 -SEPARATR WATER INST RF

-(REF 21-70-0001)-020 -ARRNGMNT COOLING (SD3 06 6029XA) -

-(SD3 74 6005XJ)030 BAS160 3 3.5 --SLEEVE PT NO BAS160 3.3 3.5 3.0 BAP 01

Attaching Part040 BAS243M5 --CLIP BAP 02

* * *050 SD3 74 0429XA --FLANGE VEE 01060 SD3 74 0348XB --DUCT SEPARATOR OUTLET 01

Attaching Part070 BA26116 1 --CLAMP BAP 01080 SP152D --WASHER 08090 AS8600D --NUT STIFF 10-32 UNF 08100 SD3 74 0356XA --GASKET 02120 A102 1D --BOLT HEX HD 10-32 UNF 06130 SP152D --WASHER 06140 AS8600D --NUT STIFF 10-32 UNF 06150 SD3 74 0357XA --GASKET 01

* * *-160 --FAN EMERGENCY INST -

--(SD3 74 0269XA)170 SD3 74 0270XA ---BRACKET MTG 01180 2430 75 460 ---STRAP AQP 01190 2430 75 460S ---STRAP AQP1 01

Attaching Part200 SP4Y B18 ---PIN STEEL 01210 SP121C ---COLLAR 01220 SP90C6 ---PIN SPLIT 01

* * *230 DTD762 ---JOINTING CORK AR240 751929 1 ---FAN VENTILATION HSD 01

- ITEM NOT ILLUSTRATED 21-50FIG 0001

PAGE 1JUL 01/12

FigItem Part number

Nomenclature

123456

Effect

From To

Unitperassy

0001

250 SD3 74 0358XA --ADAPTOR 01Attaching Part

260 A102 1D --BOLT HEX HD 10-32 UNF 06270 SP152D --WASHER 06280 AS8600D --NUT STIFF 10-32 UNF 06290 SD3 74 0357XA --GASKET 01

* * *300 B00A214106A --VALVE ASSY SHUT-OFF HYM 001026 01

--PRE MOD 7175-300A AV17B1246ISS G --VALVE ASSY SHUT-OFF ITT 027028 01

--PRE MOD 7175-300B B00A214106A --VALVE ASSY SHUT-OFF HYM 029031 01

--PRE MOD 7175-300C AV17B1246ISS G --VALVE ASSY SHUT-OFF ITT 032032 01

--PRE MOD 7175305 AV17B1246ISS H --VALVE ASSY SHUT-OFF MOD 7175 ITT 01

Attaching Part310 BA26117 1 --CLAMP BAP 01320 69494J245 --SEAL O RING HSD 01

* * *325 HTE9083 ---ACTUATOR MOTOR PRE MOD 7175 FRL 001032 01

-325A 107796A135 ---ACTUATOR MOTOR MOD 7175 ITT 01330 BAS160 3.3 4.25 --SLEEVE PT NO BAS160 3.3 4.25 3.0 BAP 01

Attaching Part340 BAS243M5 --CLIP BAP 02

* * *-350 --FAN PLENUM INLET INST -

--(SD3 74 0268XA)360 SD3 74 0261XA ---TOP HAT ASSY 02370 AS8603D ----NUT ANCHOR 10-32 UNF 02380 SD3 74 0278XA ---GUSSET DIAPHRAGM 01390 SD3 74 0259XA ---MEMBER SUPPORT 01


PAGE 2JUL 01/12

FigItem Part number

Nomenclature

123456

Effect

From To

Unitperassy

0001

400 SD3 74 0260XA ---MEMBER SUPPORT 01Attaching Part

410 A102 1D ---BOLT HEX HD 10-32 UNF 02420 SP148D ---WASHER 02

* * *430 SD3 74 0262XA ---CHAMBER PLENUM 01

-440 --STUD TERMINAL E50 RF--(REF 39-30-0210)

-450 E610 142B --RELAY WEIGHT SWITCH DRI RF--(REF 32-30-0040)--ALTERNATIVE TO ITEM 455

-450A E610 E2CD --RELAY WEIGHT SWITCH (MOD A8775) DRI RF R--(REF 32-30-0040)--ALTERNATIVE TO ITEM 450

-455 HDS14S F2B60 --RELAY WEIGHT SWITCH HDL RF--(REF 32-30-0040)--ALTERNATIVE TO ITEM 450

460 --HARNESS ASSY PANEL 2D RF--(REF 39-10-0100)

470 D7271 8 5 ---BREAKER CIRCUIT CB211 TI 01480 D7271 8 25 ---BREAKER CIRCUIT CB212 TI 01490 --HARNESS ASSY PANEL 2C RF

--(REF 39-10-0050)500 7CZ97508 1 ---RELAY PLY1 01

Attaching Part510 A116 3B ---BOLT PAN HD 6-32 UNC 02520 SP148B ---WASHER 02

* * *530 --HARNESS ASSY PANEL 9P RF

--(REF 39-10-0030)540 2TL1 10A ---SWITCH HMS 01550 99 630 ---BODY INDICATOR AOI 01560 14 104 ---FILAMENT AOI 04570 99XXX6D3 0034 ---CAP AOI 01


PAGE 3JUL 01/12

FigItem Part number

Nomenclature

123456

Effect

From To

Unitperassy

0001

-580 SD3 81 6029 -CABLE ASSY AIR CONDITIONING 001061 RF-MAIN AND RAM AIR CONTROL-(REF 91-10)

-580A SD3 81 6029 -CABLE ASSY AIR CONDITIONING 063065 RF-MAIN AND RAM AIR CONTROL-(REF 91-10)

-581 SD3 81 7358XA -CABLE HARNESS 9P-S1,FF-S1, 1HM4 062062 RF-AND 2HM4 (REF 91-15)

-581A SD3 81 7358XA -CABLE HARNESS 9P-S1,FF-S1, 1HM4 066070 RF-AND 2HM4 (REF 91-15)

-582 SD3 81 7358XB -CABLE HARNESS 9P-S1,FF-S1, 1HM4 071085 RF-AND 2HM4 (REF 91-15)

-583 SD3 81 7358XC -CABLE HARNESS 9P-S1,FF-S1, 1HM4 085115 RF-AND 2HM4 (REF 91-15)

-584 SD3 81 7358XD -CABLE HARNESS 9P-S1,FF-S1, 1HM4 116999 RF-AND 2HM4 (REF 91-17)


PAGE 4JUL 01/12

0005 AIR CONDITIONING COOLING SYSTEM INSTALLATION CONTINUED

AIR CONDITIONING COOLING SYSTEM INSTALLATION CONTINUED 21-50FIG 0005

PAGE 0MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0005-001 AIR CONDITIONING SYSTEM INST -

COOLING CONTD-010 -FAN INST FLIGHT COMPARTMENT -

-LEFT (SD3 06 6022XB)-(SD3 81 1201XA)

-020 -FAN INST FLIGHT COMPARTMENT -

-RIGHT (SD3 06 6022XB)-(SD3 81 1202XA)

026 99 034 00 000 --FAN ASSY VENTILATING BEHR 01Attaching Part

028 NAS602 10 --SCREW PAN HD 8-32 UNC 02030 SP148C --WASHER 02

* * *032 41 100 19 004 ---BLADE ASSY RUBBER BEHR 01

---ALTERNATIVE TO ITEM 033033 90 413 01 452 ---BLADE ASSY RUBBER BEHR 01

---ALTERNATIVE TO ITEM 32034 41 100 19 117 ----BLADE BEHR 03-060 --STUD TERMINAL E185 RF

--(REF 39-30-0201)-070 --STUD TERMINAL E186 RF

--(REF 39-30-0201)-080 --BLOCK TERMINAL TB125 RF

--(REF 39-30-0010)-090 --BLOCK TERMINAL TB126 RF

--(REF 39-30-0010)100 --HARNESS ASSY PANEL 2D RF

--(REF 39-10-0100)110 D7271 8 5 ---BREAKER CIRCUIT CB225 TI 001160 01

---PRE MOD A8334115 D7271 8 5 ---BREAKER CIRCUIT CB208 TI 01

---MOD A8334120 --HARNESS ASSY PANEL 1D RF

--(REF 39-10-0090)


PAGE 1MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0005130 D7271 8 5 ---BREAKER CIRCUIT CB75 TI 001160 01

---PRE MOD A8334140 1TP12 3 --SWITCH LEFT 1HL2 HMS 01150 1TP12 3 --SWITCH RIGHT 2HL2 PRE MOD 7217 HMS 001022 01152 SD3 81 7005XB --PANEL EXTENSION 10P MOD 7217 023999 RF

--(REF 39-10-0005)154 1TL1 3 ---SWITCH RIGHT 2HL2 MOD 7217 HMS 023999 01-160 SD3 81 6022 --CABLE ASSY PILOTS FANS 001061 RF

--(REF 91-10)-160A SD3 81 6022 -CABLE ASSY PILOTS FANS 063065 RF

-(REF 91-10)-161 SD3 81 7428XL --WIRE ASSY PANEL 1D LOCALS 062062 RF

--(REF 91-15)-161A SD3 81 7428XL --WIRE ASSY PANEL 1D LOCALS 066076 RF

--(REF 91-15)-162 SD3 81 7428XM --WIRE ASSY PANEL 1D LOCALS 077084 RF

--(REF 91-15)-163 SD3 81 7428XN --WIRE ASSY PANEL 1D LOCALS 085085 RF

--(REF 91-15)-164 SD3 81 7428XR --WIRE ASSY PANEL 1D LOCALS 086111 RF

--(REF 91-15)-165 SD3 81 7428XU --WIRE ASSY PANEL 1D LOCALS 112115 RF

--(REF 91-15)-166 SD3 81 7428XY --WIRE ASSY PANEL 1D LOCALS 116120 RF

--(REF 91-17)-167 SD3 81 7428XZ --WIRE ASSY PANEL 1D LOCALS 121140 RF

--(REF 91-17)-168 SD3 81 7428XAA --WIRE ASSY PANEL 1D LOCALS 141143 RF

--(REF 91-17)-168A SD3 81 7428XAB --WIRE ASSY PANEL 1D LOCALS 144160 RF

--(REF 91-17)-168B SD3 81 7428XAD --WIRE ASSY PANEL 1D LOCALS 161999 RF

--(REF 91- )-169 SD3 81 7430XJ --WIRE ASSY PANEL 2D LOCALS 062062 RF

--(REF 91-15)


PAGE 2MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0005-169A SD3 81 7430XJ --WIRE ASSY PANEL 2D LOCALS 066076 RF

--(REF 91-15)-170 SD3 81 7430XK --WIRE ASSY PANEL 2D LOCALS 077084 RF

--(REF 91-15)-171 SD3 81 7430XL --WIRE ASSY PANEL 2D LOCALS 085085 RF

--(REF 91-15)-172 SD3 81 7430XS --WIRE ASSY PANEL 2D LOCALS 086102 RF

--(REF 91-15)-173 SD3 81 7430XT --WIRE ASSY PANEL 2D LOCALS 103115 RF

--(REF 91-15)-174 SD3 81 7430XZ --WIRE ASSY PANEL 2D LOCALS 116140 RF

--(REF 91-17)-174A SD3 81 7430XAA --WIRE ASSY PANEL 2D LOCALS 141143 RF

--(REF 91- )-174B SD3 81 7430XAB --WIRE ASSY PANEL 2D LOCALS 144160 RF

--(REF 91- )-174C SD3 81 7430XAC --WIRE ASSY PANEL 2D LOCALS 161999 RF

--(REF 91-17)-175 SD3 81 7548XAM --WIRE ASSY NOSE FUSELAGE 062062 RF

--(REF 91-15)-175A SD3 81 7548XAM --WIRE ASSY NOSE FUSELAGE 066070 RF-176 SD3 81 7548XAP --WIRE ASSY NOSE FUSELAGE 071075 RF

--(REF 91-15)-177 SD3 81 7548XAR --WIRE ASSY NOSE FUSELAGE 076076 RF

--(REF 91-15)-178 SD3 81 7548XAS --WIRE ASSY NOSE FUSELAGE 077084 RF

--(REF 91-15)-179 SD3 81 7548XAT --WIRE ASSY NOSE FUSELAGE 085085 RF

--(REF 91-15)-180 SD3 81 7548XAY --WIRE ASSY NOSE FUSELAGE 086089 RF

--(REF 91-15)-181 SD3 81 7548XAW --WIRE ASSY NOSE FUSELAGE 090095 RF

--(REF 91-15)-182 SD3 81 7548XBA --WIRE ASSY NOSE FUSELAGE 096100 RF

--(REF 91-15)


PAGE 3MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0005-183 SD3 81 7548XBC --WIRE ASSY NOSE FUSELAGE 101115 RF

--(REF 91-15)-184 SD3 81 7548XBE --WIRE ASSY NOSE FUSELAGE 116120 RF

--(REF 91-17)-185 SD3 81 7548XBG --WIRE ASSY NOSE FUSELAGE 121135 RF

--(REF 91-17)-186 SD3 81 7548XBH --WIRE ASSY NOSE FUSELAGE 136140 RF

--(REF 91-17)-187 SD3 81 7548XBL --WIRE ASSY NOSE FUSELAGE 141999 RF

--(REF 91-17)


PAGE 4MAY 01/08

0010 AIR CONDITIONING COOLING SYSTEM INSTALLATION (MOD A8145)

AIR CONDITIONING COOLING SYSTEM INSTALLATION (MOD A8145) 21-50FIG 0010

PAGE 0MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0010-001 AIR CONDITIONING SYSTEM INST 116999 -

COOLING MOD A8145-010 -COOLING INST AVIONICS -

-(SD3 06 6351XC)-015 --FAN IMN3 INST (SD3 82 6753XA) -

020 508 037 ---FAN RSC 01Attaching Part

030 A102 10C ---BOLT HEX HD 8-32 UNC 04040 SP148C ---WASHER 04050 AS8600C ---NUT STIFF 8-32 UNC 04

* * *060 SD3 82 5806XA --DUCT 01

Attaching Part070 A102 10C --BOLT HEX HD 8-32 UNC 04080 SP148C --WASHER 04090 AS8600C --NUT STIFF 8-32 UNC 04

* * *-100 --EARTH POINT E233 (REF 39-30- RF-110 --THERMSTT INST AVIONICS -

--COOLING (SD3 81 8171XB)120 SD3 81 5664XA ---THERMSTT POTTED 01

Attaching Part130 A116 0.5B ---BOLT PAN HD 6-32 UNC 02140 SP148B ---WASHER 02150 AS8600B ---NUT STIFF 6-32 UNC 02

* * *


PAGE 1MAY 01/08

0015 FREON AIR CONDITIONING SYSTEM (MOD A8121)

FREON AIR CONDITIONING SYSTEM (MOD A8121) 21-50FIG 0015

PAGE 0MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0015-001 AIR CONDITIONING SYSTEM FREON 117999 -

MOD A8121 (SD3 00 6844XA)-010 -COMPRSSR MOUNTING INST 117999 -

-(360 1100 (S) XB)020 360 300 21 --PALLET AAR 117999 01

Attaching Part030 AN4 13A --BOLT HEX HD 0.25 IN UNF 117999 04040 AN970 4 --WASHER 117999 04050 NAS684A4 --NUT ANCHOR 0.25IN UNF 117999 04

* * *060 360 311 3 --TRACK COMPRESSOR MOUNTING AAR 117999 04

Attaching Part070 AN509 10R16 --SCREW CSK HD 10-32 UNF 117999 02080 AN960 10 --WASHER 117999 02090 A3135SS020 27 --WASHER DIMPLE 117999 02100 AN365 1032 --NUT STIFF 10-32 UNF 117999 02

* * *110 360 300 23 --BLOCK WEDGE AAR 117999 04

Attaching Part120 AN509 10R20 --SCREW CSK HD 10-32 UNF 117999 01130 A3135SS020 27 --WASHER DIMPLE 117999 01140 AN960 10 --WASHER 117999 01150 AN365 1032 --NUT STIFF 10-32 UNF 117999 01

* * *160 360 300 25 --BLOCK WEDGE AAR 117999 04

Attaching Part170 AN3H10A --BOLT HEX HD 10-32 UNF 117999 01180 AN960 10 --WASHER 117999 01190 MS51941 1032 --NUT ANCHOR 10-32 UNF 117999 01

* * *-200 -FAIRING INST (360 1107 (S) XB) 117999 RF

-(REF 53-30-0036)210 360 1107 1 --FAIRING ASSY MF (SD3 14 6009) AAR 117999 RF

--(REF 53-30-0036)220 360 307 25 ---PANEL ACCESS (REF 53-30-0036) AAR 117999 RF


PAGE 1MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0015230 360 307 27 ---PLATE BLANKING (REF 53-30-0036) AAR 117999 RF-240 -EVAPORTR FREON FWD HOSE AND 117999 -

-TUBE INST (360 1109 (S) XB)250 AN833 6D --ELBOW 117999 01

Attaching Part260 AN960 1016 --WASHER 117999 01270 AN924 6D --NUT 117999 01

* * *280 360 209 23 --TUBE PRESSURE AAR 117999 01290 AN824 6D --TEE 117999 01300 6 4TRTX5 --ADAPTOR AAR 117999 01310 NAS814 6A --CAP BLANKING 117999 01320 360 209 19 --TUBE PRESSURE AAR 117999 01330 AN815 4B --PLUG 117999 01340 360 209 17 --TUBE SUCTION AAR 117999 01350 NAS815 10B --CAP BLANKING 117999 01360 AN824 8D --TEE 117999 01370 NAS814 8A --CAP BLANKING 117999 01380 360 209 11 --TUBE SUCTION AAR 117999 01390 MS21919DG20 --CLAMP 117999 01

Attaching Part400 AN3 4A --BOLT HEX HD 10-32 UNF 117999 01410 AN960 10 --WASHER 117999 01420 AN365 1032 --NUT STIFF 10-32 UNF 117999 01

* * *430 MS21919DG20 --CLAMP 117999 01440 MS21919DG6 --CLAMP 117999 01


* * *


PAGE 2MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0015480 MS21919DG6 --CLAMP 117999 01


* * *520 MS21919DG20 --CLAMP 117999 01530 MS21919DG4 --CLIP P 117999 01


* * *570 NP77 --INSULATN 117999 AR580 360 309 5 --TUBE FORWARD DRAIN AAR 117999 01590 QS800M4H --CLAMP 117999 01600 NAS814 6A --CAP BLANKING 117999 01-610 -EVAPORTR FORWARD MOUNTING 117999 -

-INST (360 1104 (S) (XB)620 360 304 17 --INTRCSTL AAR 117999 02

Attaching Part630 A102 19C --BOLT HEX HD 8-32 UNC 117999 04640 A102 18C --BOLT HEX HD 8-32 UNC 117999 RF

--(REF 76-10-0055)650 360 304 39 --SHIM AAR 117999 01660 SP149C --WASHER (REF 76-10-0055) 117999 RF670 AS8600C --NUT STIFF 8-32 UNC 117999 08

--(REF 76-10-0055)* * *


PAGE 3MAY 01/08

0020 FREON AIR CONDITIONING SYSTEM CONTINUED (MOD A8121)

FREON AIR CONDITIONING SYSTEM CONTINUED (MOD A8121) 21-50FIG 0020

PAGE 0MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0020-001 AIR CONDITIONING SYSTEM FREON 117999 -

MOD A8121 CONTD (SD3 00 6844XA)-010 -EVAPORTR FREON AFT HOSE AND 117999 -

-TUBE INST (360 1109 (S) XB)020 360 209 7 --HOSE PRESSURE AAR 117999 01030 NAS814 6A --CAP BLANKING 117001 01040 360 209 31 --TUBE PRESSURE AAR 117001 01050 AN833 6D --ELBOW 117999 01

Attaching Part060 AN960PD916 --WASHER 117999 01070 AN924 6D --NUT 117999 01

* * *080 AN833 8D --ELBOW 117999 01

Attaching Part090 AN960PD1216 --WASHER 117999 01100 AN924 8D --NUT 117999 01

* * *110 360 209 29 --TUBE SUCTION AAR 117999 01120 360 209 9 --HOSE SUCTION AAR 117999 01130 NAS814 8A --CAP BLANKING 117999 01140 MS21919DG12 --CLIP P 117999 04150 MS21919DG10 --CLIP P 117999 04


* * *190 MS21919DG12 --CLIP P 117999 12200 MS21919DG10 --CLIP P 117999 12


* * *240 AAR SD5 19 --CLIP AAR 117999 01


PAGE 1MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0020250 AAR SD5 3 --CLIP AAR 117999 05260 MS21919DG8 --CLAMP 117999 06270 MS21919DG6 --CLAMP 117999 06


* * *310 AS3360B8B --LEAD BONDING 117999 01320 AS3360B4B --LEAD BONDING 117999 01330 MS21103D8 --CLAMP 117999 01

Attaching Part340 AN526 632R8 --SCREW MUSH HD 6-32 UNC 117999 01350 AN960 6 --WASHER 117999 01360 AN365 632 --NUT STIFF 6-32 UNC 117999 01

* * *370 MS21103D6 --CLAMP 117999 01


* * *410 AS3360B4B --LEAD BONDING 117999 01420 MS21103D4 --CLIP BONDING 117999 01


* * *460 MS21103D8 --CLAMP 117999 01


* * *500 MS21919DG8 --CLAMP 117999 01


PAGE 2MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0020510 MS21103D6 --CLAMP 117999 01


* * *550 MS21103D8 --CLAMP 117999 01560 MS21103D6 --CLAMP 117999 01


* * *600 360 309 7 --TUBE AFT DRAIN AAR 117999 01610 QS800M4H --CLAMP 117999 01620 NAS814 6A --CAP BLANKING 117999 01-630 -ELECTRCL INST FREON AIR 117999 -

-CONDITIONING (360 0002 (S) XB)-(360 5500 (S) XB)

640 --HARNESS ASSY PANEL 1C 117999 RF--(REF 39-10-0045)

650 RL9809G1 ---RELAY "1C-CL" (REF 39-10-0045) HDL 117999 RF660 --BLOCK TERMINAL TB43 117999 RF

--(REF 39-30-0005)670 --HARNESS ASSY PANEL 2C 117999 RF

--(REF 39-10-0050)680 RL9809G1 ---RELAY "2C-CL" (REF 39-10-0050) HDL 117999 RF690 --BLOCK TERMINAL TB44 117999 RF

--(REF 39-30-0005)700 --EARTH POINT E220 (REF 39-30-0215) 117999 RF710 --EARTH POINT E308,E309, E310 117999 RF

--AND E311 (REF 39-30-0215)-720 --TRAY RELAY INST (360 5112 (S) XB) 117999 -

730 ---BLOCK TERMINAL TB209 AND TB210 117999 RF---(REF 39-30-0050)


PAGE 3MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

0020740 MS3120F16 26S ---RECEPTCL WALL-MOUNTED CAN 117999 RF

---(REF 39-30- )-750 --PANEL INSTSWITCH CO-PILOT 117999 -

--(360 5115 (S) XB)760 360 215 5 ---BRACKET ASSY AAR 117999 01

Attaching Part770 AN515 8R6 ---SCREW ROUND HD 8-32 UNC 117999 02780 AN960 8 ---WASHER 117999 02

* * *790 NAS696A08 ----NUT ANCHOR 8-32 UNC 117999 02800 DBC25S --CONNECTR CANNON CAN 117999 RF

--(REF 39- - )-810 --PANEL SWITCH INST ATTENDANT 117999 -

--(360 5115 (S) XB)820 360 215 5 ---BRACKET ASSY AAR 117999 01

Attaching Part830 AN515 8R6 ---SCREW ROUND HD 8-32 UNC 117999 02840 AN960 8 ---WASHER 117999 02

* * *850 NAS696A08 ----NUT ANCHOR 8-32 UNC 117999 02860 DBC25S --CONNECTR CANNON CAN 117999 RF

--(REF 39- - )-870 --GYRO RELOCATION INST 117999 -

--(360 5102 (S) XB)-880 360 5501(S)XB ---HARNESS EXTENSION AAR 117999 RF

---(REF 91- )890 MS3126F18 32P ---CONNECTR CANNON CAN 117999 RF

---(REF 39- - )900 MS3126F18 32S ---CONNECTR CANNON CAN 117999 RF

---(REF 39- - )-910 --CABLE HARNESS FREON AIR 117999 RF

--CONDITIONING (REF 91- )920 DBC25S --CONNECTR CANNON CAN 117999 RF

--(REF 39- - )


PAGE 4MAY 01/08

1001 FREON AIR CONDITIONING INSTALLATION (MOD A8122)

FREON AIR CONDITIONING INSTALLATION (MOD A8122) 21-50FIG 1001

PAGE 0MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1001-001 AIR CONDITIONING INST FREON 117999 -

MOD A8122 (SD3 00 6845XA)-010 -COMPRSSR INST FWD (360-150 (S) XB) 117999 -

020 1250400 20 --CONDENSR COMPRESSOR AAR 117999 01Attaching Part

030 40088 14 --STUD 117999 04040 AN960 616L --WASHER 117999 04050 MS21042 6 --NUT STIFF 0.375 IN UNF 117999 04

* * *060 360 209 3 --HOSE HP AAR 117999 01070 360 209 5 --HOSE LP AAR 117999 01080 UR3 68 --REDUCER AAR 117999 01090 MS21919DG6 --CLAMP 117999 01

Attaching Part100 AN526 632 --SCREW MUSH HD 6-32 UNC 117999 01110 AN960 632 --WASHER 117999 01120 AN365 632 --NUT STIFF 6-32 UNC 117999 01

* * *130 360 250 3 --GUARD AND CB ASSY AAR 117999 01140 360 350 29 ---GUARD AAR 117999 01150 360 350 33 ---COVER AAR 117999 01160 D7274 2 1 ---BREAKER CIRCUIT "B" TI 117999 01170 360 350 31 --ANGLE AAR 117999 01180 MS21919DG8 --CLAMP 117999 02

Attaching Part190 NAS221 9 --SCREW PAN HD 10-32 UNF 117999 01-195 MS27039 1 09 --SCREW PAN HD 10-32 UNF 117999 01

--ALTERNATIVE TO ITEM 190200 AN960 10 --WASHER 117999 01210 AN365 1032 --NUT STIFF 10-32 UNF 117999 01

* * *-220 -EVAPORTR AND BLOWER INST FWD 117999 -

-(360 154 (S) XB)


PAGE 1MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1001230 1250290 3 --EVAPORTR LH AAR 117999 01

Attaching Part240 AN3 3A --BOLT HEX HD 10-32 UNF 117999 04250 AN3 5A --BOLT HEX HD 10-32 UNF 117999 02260 AN960 10 --WASHER 117999 06270 360 354 33 --ANGLE AAR 117999 01280 360 354 34 --ANGLE AAR 117999 01290 360 354 35 --BRACKET AAR 117999 01300 AN365 1032 --NUT STIFF 10-32 UNF 117999 04310 NAS1473A3 --NUT ANCHOR 10-32 UNF 117999 02

* * *320 1250290 2 --EVAPORTR RH AAR 117999 01

Attaching Part330 AN3 3A --BOLT HEX HD 10-32 UNF 117999 06340 AN960 10 --WASHER 117999 06350 360 354 33 --ANGLE AAR 117999 01360 360 354 34 --ANGLE AAR 117999 01370 360 254 7 --BRACKET ASSY AAR 117999 01380 360 354 36 ---BRACKET AAR 117999 01390 NAS680A3 ---NUT ANCHOR 10-32 UNF 117999 02400 AN365 1032 --NUT STIFF 10-32 UNF 117999 04

* * *410 360 254 3 --PLENUM ASSY LH AAR 117999 01420 360 254 4 --PLENUM ASSY RH AAR 117999 01430 360 354 49 ---SEAL MF S202VW AAR 117999 01440 360 354 51 ---SEAL AAR 117999 01450 1250270 14 --BLOWER LH AAR 117999 01460 1250270 14 --BLOWER RH AAR 117999 01

Attaching Part470 NAS220 10 --SCREW PAN HD 8-32 UNC 117999 04-475 MS27039 0810 --SCREW PAN HD 8-32 UNC 117999 04

--ALTERNATIVE TO ITEM 470480 AN960 8 --WASHER 117999 04

* * *-490 -COMPRSSR INST AFT (360 150 (S) XB) 117999 -


PAGE 2MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1001500 1250400 20 --CONDENSR COMPRESSOR AAR 117999 01

Attaching Part510 40088 14 --STUD 117999 04520 AN960 616L --WASHER 117999 04530 MS21042 6 --NUT STIFF 0.375IN UNF 117999 04

* * *540 MS21919DG10 --CLIP P 117999 01

Attaching Part550 NAS526 1032R --SCREW ROUND HD 10-32 UNF 117999 01

* * *560 AN960 10 --WASHER 117999 01

Attaching Part570 AN365 1032 --NUT STIFF 10-32 UNF 117999 01

* * *580 MS21919DG8 --CLAMP 117999 01

Attaching Part590 NAS221 9 --SCREW PAN HD 10-32 UNF 117999 01600 AN960 10 --WASHER 117999 01610 AN365 1032 --NUT STIFF 10-32 UNF 117999 01

* * *620 MS21919DG6 --CLAMP 117999 01

Attaching Part630 AN526 632 --SCREW MUSH HD 6-32 UNC 117999 01640 AN960 632 --WASHER 117999 01650 AN365 632 --NUT STIFF 6-32 UNC 117999 01

* * *660 360 250 3 --GUARD AND CB ASSY AAR 117999 01670 360 350 29 ---GUARD AAR 117999 01680 360 350 33 ---COVER AAR 117999 01690 D7274 2 1 ---BREAKER CIRCUIT "B" TI 117999 01-700 -CASE COMPRESSOR INST MOD A8394 117999 -

-(SD3 74 6292XB)710 SD3 74 6293XA --CASE COMPRESSOR 117999 01-720 SD3 74 6292C --TAPE FOAM SELF ADHESIVE 117999 AR-730 SD3 74 6292D --TAPE FOAM SELF ADHESIVE 117999 AR


PAGE 3MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1001-740 SD3 74 6292E --TAPE FOAM SELF ADHESIVE 117999 AR-750 TY525M --TIE CABLE T&B 117999 04-760 -EVAPORTR AND BLOWER INST AFT 117999 -

-(360 155 (S) XB)770 1250390 1 --EVAPORTR ASSY AAR 117999 01

Attaching Part780 360 355 3 --BRACKET LH (REF 25-20-1060) AAR 117999 RF790 360 355 4 --BRACKET RH (REF 25-20-1060) AAR 117999 RF800 360 355 5 --BRACKET (REF 25-20-1060) AAR 117999 RF

* * *810 360 155 3 --DUCT AAR 117999 02

Attaching Part820 QS100M44 --CLAMP 117999 02

* * *-830 1300L -CEMENT SCOTCHGRIP 3MUK 117999 AR


PAGE 4MAY 01/08

1005 FREON AIR CONDITIONING SYSTEM (MOD A8394)

FREON AIR CONDITIONING SYSTEM (MOD A8394) 21-50FIG 1005

PAGE 0MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1005-001 AIR CONDITIONING SYSTEM FREON -

MOD A8394 (REF 25-20-1060)010 -EVAPORTR INST FREON FLIGHT DECK -

-(SD3 74 6328XB)-020 AN824 6D --TEE (REF 21-50-0015) RF

--REMOVE AND REPLACE WITH ITEM 030030 AN827 6D --CROSS 01040 SD3 74 6312XA --HOSE PRESSURE 01050 NP77 --INSULATN AR-060 TY525M --TIE CABLE T&B AR-070 AN824 8D --TEE (REF 21-50-0015) RF

--REMOVE AND REPLACE WITH ITEM 080080 AN827 8D --CROSS 01090 SD3 74 6313XA --HOSE SUCTION 01100 6 4TRTX5 --ADAPTOR AAR 01110 SD3 74 6311XA --TUBE SUCTION 01120 MS21919DG10 --CLIP P 01

Attaching Part130 A102 0.5D --BOLT HEX HD 10-32 UNF 01140 SP152D --WASHER 01150 AS8600D --NUT STIFF 10-32 UNF 01

* * *160 MS21919DG10 --CLIP P 02170 MS21919DG12 --CLIP P 02


* * *210 MS21919DG12 --CLIP P 01


* * *250 MS21919DG12 --CLIP P 01


PAGE 1MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1005260 MS21919DG5 --CLIP P 01

Attaching Part270 A102 1D --BOLT HEX HD 10-32 UNF 01280 SP152D --WASHER 01290 AS8600D --NUT STIFF 10-32 UNF 01

* * *300 MS21919DG10 --CLIP P 02


* * *340 MS21919DG12 --CLIP P 01


* * *380 MS21919DG10 --CLIP P 03


* * *420 MS21919DG12 --CLIP P 02


* * *460 MS21919DG4 --CLIP P 01


* * *


PAGE 2MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1005500 5 00005 1 --SLEEVE CHAFING RAL AR-510 TY525M --TIE CABLE T&B AR520 SD3 74 6325XA --ANGLE FORWARD 01

Attaching Part530 AN507 440R7 --SCREW CSK HD 4-40 UNC 01540 AN960 4 --WASHER 01550 AN365 440 --NUT STIFF 4-40 UNC 01

* * *560 SD3 74 6323XA --BRACKET 01


* * *600 SD3 74 6321XA --BRACKET 01


* * *640 1250200 11 --UNIT EVAPORATOR FLIGHT DECK AAR 01650 AN824 8D --TEE 01660 1250154 --SWITCH PRESSURE AAR 01670 AN929 8D --CAP BLANKING 01680 1250367 --ADAPTOR DUCTING AAR 01

Attaching Part690 BAS243N3 --CLIP HOSE BAP 01

* * *700 SD3 74 6238B --DUCTING HOSE 01

Attaching Part710 BAS243N1A --CLIP HOSE BAP 02

* * *720 SD3 74 6238A --DUCTING HOSE 01

Attaching Part730 BAS243N1A --CLIP HOSE BAP 02

* * *


PAGE 3MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1005-740 TY525M --TIE CABLE T&B AR750 834 --ADAPTOR HOSE AAR 02760 231 --LOUVRE AAR 02770 272 --BEZEL AAR 02775 SD3 74 6365XA --BRACKET 02

Attaching Part780 A113 5D --BOLT MUSH HD 10-32 UNF 02785 SP152D --WASHER 02790 AS8600D --NUT STIFF 10-32 UNF 02

* * *800 SD3 74 6328C --HOSE DRAIN 01


* * *820 SD3 74 6309XA --TUBE DRAIN 01830 AN832 6D --UNION 01

Attaching Part840 AN960PD916 --WASHER 01850 AN924 6D --NUT 01

* * *860 SD3 74 6310XA --TUBE DRAIN 01870 SD3 74 6328D --HOSE DRAIN 01


* * *885 SD3 74 0758XA --DUCT ASSY REAR RIGHT RF890 SD3 74 0760XA --DUCT FWD RIGHT RF

Attaching Part895 A113 5.5D --BOLT HEX HD 10-32 UNF 04900 ST1698D19 --PIECE DISTANCE 04905 AS8603D --NUT ANCHOR 10-32 UNF RF910 AS8604D --NUT ANCHOR 10-32 UNF RF

* * *


PAGE 4MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1005920 SD3 74 6314XB --BRACKET 01


* * *


PAGE 5MAY 01/08

1010 AVIONICS COOLING INSTALLATION (MODS A8116 AND A8291)

AVIONICS COOLING INSTALLATION (MODS A8116 AND A8291) 21-50FIG 1010

PAGE 0MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1010-001 COOLING INST AVIONICS 001115 -

MOD A8116 AND A8291(SD3 00 6822XA) (SD3 06 6351XE)

010 -HARNESS ASSY PANEL 1D 001115 RF-(REF 39-10-0091)

020 D7271 8 3 --BREAKER CIRCUIT CB96 TI 001115 01030 SD3 81 5664XA -THERMSTT POTTED 001115 01

Attaching Part040 A116 0.5B -BOLT PAN HD 6-32 UNC 001115 02050 SP148B -WASHER 001115 02060 AS8600B -NUT STIFF 6-32 UNC 001115 02

* * *-070 -FAN 1MN3 INST (SD3 82 6753XA) 001115 -

080 508 037 --FAN RSC 001115 01Attaching Part

090 A102 10C --BOLT HEX HD 8-32 UNC 001115 04100 SP148C --WASHER 001115 04110 AS8600C --NUT STIFF 8-32 UNC 001115 04

* * *120 SD3 82 5806XA --DUCT 001115 01

Attaching Part130 A102 10C --BOLT HEX HD 8-32 UNC 001115 04140 SP148C --WASHER 001115 04150 AS8600C --NUT STIFF 8-32 UNC 001115 04

* * *-160 -STUD EARTH E233 (REF 39-30- ) 001115 RF


PAGE 1MAY 01/08

1015 AIR CONDITIONING COOLING SYSTEM INSTALLATION (MOD A8384)

AIR CONDITIONING COOLING SYSTEM INSTALLATION (MOD A8384) 21-50FIG 1015

PAGE 0MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1015-001 AIR CONDITIONING SYSTEM 116999 -

COOLING INST MOD A8384(SD3 00 6898XA)

-010 -COOLING INST AVIONICS 116999 -

-(SD3 06 6137XA) (SD3 10 6223XB)-(SD3 81 8395XA)

020 --HARNESS ASSY PANEL 1D 116999 RF--(REF 39-10-0091)

030 D7271 8 3 ---BREAKER CIRCUIT CB88 TI 116999 01040 --HARNESS ASSY PANEL 2D 116999 RF

--(REF 39-10-0101)050 D7271 8 3 ---BREAKER CIRCUIT CB182 TI 116999 01-060 --THERMSTT INST AVIONICS COOLING 116999 -

--(SD3 81 8401XA)070 SD3 81 5664XA ---THERMSTT POTTED 116999 03

---1MNA2 2MNA2 AND 3MNA2Attaching Part

080 A116 0.5B ---BOLT PAN HD 6-32 UNC 116999 02090 SP148B ---WASHER 116999 02100 AS8600B ---NUT STIFF 6-32 UNC 116999 02

* * *-110 --EARTH POINT E14 (REF 39-30-0205) 116999 RF-120 --EARTH POINT E16 (REF 39-30-0205) 116999 RF130 SD3 10 6225XA --LOUVRES ASSY AVIONICS COOLING 116999 01140 SD3 10 6229XA ---FAN ASSY 1MNA1 NO3 AVIONICS BAY 116999 01

Attaching Part150 A102 2D ---BOLT HEX HD 10-32 UNF 116999 04160 SP148D ---WASHER 116999 04180 MS21059L3 ---NUT ANCHOR 10-32 UNF 116999 04

* * *


PAGE 1MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1015190 508 037 ----FAN RSC 116999 01

Attaching Part200 A173 3D ----BOLT CSK HD 10-32 UNF 116999 04210 SD3 10 6229B ----PLATE MOUNTING 116999 01220 SP149D ----WASHER 116999 04230 AS8600D ----NUT STIFF 10-32 UNF 116999 04

* * *240 SD3 10 6224J ---FILTER 116999 01250 SD3 10 6224XA --DOOR ASSY ACCESS NO 6 116999 RF

--AVIONICS BAY (REF 53-20-1001)260 SD3 10 6229XA ---FAN ASSY 2MNA1 NO6 AVIONICS BAY 116999 01

Attaching Part270 A102 2D ---BOLT HEX HD 10-32 UNF 116999 04280 SP148D ---WASHER 116999 04290 SD3 10 6224C ---PAD STRESS 116999 02300 MS21059L3 ---NUT ANCHOR 10-32 UNF 116999 04

* * *310 508 037 ----FAN RSC 116999 01

Attaching Part320 A173 3D ----BOLT CSK HD 10-32 UNF 116999 04

* * *330 SD3 10 6229B ----PLATE MOUNTING 116999 01

Attaching Part340 SP149D ----WASHER 116999 04350 AS8600D ----NUT STIFF 10-32 UNF 116999 04

* * *360 SD3 10 6224J ---FILTER 116999 01-370 --FAN INST 3MNA1 NO3 AVIONICS BAY 116999 -

--(SD3 10 6226XB)372 SD3 10 6226A ---CHANNEL ASSY 116999 01

Attaching Part374 A102 2D ---BOLT HEX HD 10-32 UNF 116999 04376 SP148D ---WASHER 116999 04

* * *378 MS21059L3 ----NUT ANCHOR 10-32 UNF 116999 08


PAGE 2MAY 01/08

FigItem Part number

Nomenclature123456

EffectFrom To

Unitperassy

1015380 508 037 ---FAN RSC 116999 01

Attaching Part390 A102 2D ---BOLT HEX HD 10-32 UNF 116999 04400 SP148D ---WASHER 116999 04

* * *-420 --GRILLE VENTILATION INST 116999 -

--(SD3 10 6227XB)425 SD3 10 6227B ---SPONGE MOD A8453 116999 02430 SD3 10 6227A ---MESH GRILLE 116999 02440 SD3 10 6228A ---RETAINER GRILLE 116999 06

Attaching Part450 A113 6D ---BOLT MUSH HD 10-32 UNF 116999 06460 AS8600D ---NUT STIFF 10-32 UNF 116999 06

* * *-470 --HARNESS ASSY PANEL 9P 116999 RF

--(REF 39-10-0030)--MODIFIED BY SD3 80 6152XA

490 02 1841 ---BASE LAMP FKI 116999 02500 995 9182 ---FILAMENT ALTERNATIVE TO FKI 116999 02

---ITEM 502 AND 504-502 L1004 ---FILAMENT ALTERNATIVE TO FKI 116999 02

---ITEM 500 AND 504-504 ALBA327 ---FILAMENT ALTERNATIVE TO FKI 116999 02

---ITEM 500 AND 502510 80 10 0069WHITE ---CAP FKI 116999 02520 SD3 81 8170XA ---LABEL AVIONIC COOLING 116999 01-530 SD3 81 8394XA --CABLE ASSY AVIONICS COOLING 116999 RF

--(REF 91-27)-540 AY103 -ARALDITE 3MUK 116999 AR-550 HY951 -HARDENER 3MUK 116999 AR-560 PR1422 -ADHESIVE MOD A8453 116999 AR


PAGE 3MAY 01/08

Documents

AIR CONDITIONING COOLING - Air Cargo Carriers 21/21-50.pdf · AIR CONDITIONING COOLING SYSTEM INSTALLATION (MOD A8145) 21-50 FIG 0010 PAGE 0 MAY 01/08. Fig Item Part number Nomenclature