9PKE-16-2010-Rev00 - Power Line Carrier Equipment.pdf

CONSORTIUM

9PKE-16-2010-Rev00 - Power Line Carrier Equipment

Project Title Project FWEL-50 MW FOUNDATION WINDPOWER PLANT-II

Document Title SITE TEST REPORT FOR POWER LINECARRIER EQUIPMENT

Document Number 9PKE-16-2010-Rev00

FWEL ProjectNumber 8209

Revision Number 00

CONSORTIUM


QIP No. E1 (Installation checks wiring, termination and earthing checks.)

Installation checks [ ] O.K. [ ] N.A.Wiring checks [ ] O.K. [ ] N.A.Termination checks [ ] O.K. [ ] N.A.Earthing checks [ ] O.K. [ ] N.A.

QIP No. E2 (Interfacing to SAS, PABX, power supply)

QIP No. E3 (Checking unit and system functions as far as possible)

FILE: 1KHW002587AE Commissioning Report ETL600R4; TEMPLATE: TECHN_DOC_STAND_P.dot R0; SKELETON: ; SAVEDATE: 5/15/2012 11:55:00 AM

COMMISSIONING REPORT

Powerline Carrier Equipment: Series ETL600R4

Project : ..

ABB Order N : ..

Station : ..

Link : ..

Equipment N : ..

Frequency : Tx = kHz Rx = kHz

Direction : ..

Commissioning Report contains

SAFETY INSTRUCTIONS

Designations and abbreviations used:

Designation Meaning

REVISION

Rev.ind.

Page (p.)Chapter (c.)

Description DateDept./Init.

TestNo. Test procedure Test point

Permissiblevalue Units

Testresult

C.1. General

C.1.1 Checking the line of communication

r

C.1.2 Visual checks

C.2. Check power supply B5LD Left Right

C.2.1C.2.2C.2.3

C.3. Upload configuration

C.4. Change configuration, if necessary

C.4.1 Reducing output power, if necessary

r min r r min

red

r min

red r min

red



Testresult

C.5. Transmitter

C.5.1 Adjust Tx RF level

C.5.2 Adjust Tx alarm level

C.6. Receiver

C.6.1 Adjust Rx RF level

C.6.2 Connect RF cable and set alarmthresholds



Testresult

C.6.3 Check link alarms

C.6.4 Tune hybrid on E5TH

C.6.5 SNR pilot

C.7. Equalization

C.7.1 Measure frequency response

C.7.2 Select Equalizer

C.8. R1BC, if present

C.9. Configure Real time Clock (RTC)

C.9.1 Setting real time clock



Testresult

C.9.2 Test external real time clocksynchronization, if available



Testresult

C.10. NSD600 / G4AI, if present

C.10.1 NSD600 loop test

C.10.2 Command transmissiontime



Testresult

C.10.3 Reset counters

C.11. Testing of O4LE

C.11.1 Service Phone.

C.11.2 Hot line direct phone

C.11.3 Remote subscriber



Testresult

C.11.4 Pax 2-wire

C.11.5 Pax 4-wire

C.11.6 Pax 4/2-wire



Testresult

C.11.7 Transit mode for E&M wire

C.11.8 Testing the teleoperationports

C.11.9 Teleoperation AF1, if notused for telephony

C.11.10 Teleoperation AF2



Testresult



C.11.13 Teleoperation AF4 used forext. teleprotection

C.12. V.11 ports

C.12.1 V.11 Port 1

C.12.2 V.11 Port 2



Testresult

C.13. V.24 ports

C.13.1 V.24 Port 1

C.13.2 V.24 Port 2

C.13.3 V.24 Port 3

C.13.4 V.24 Port 4

C.14. Testing of LAN port

C.14.1 LAN Port 1

C.14.2 LAN Port 2

C.14.3 LAN Port 3



Testresult

C.14.4 LAN Port 4

C.14.5 HMI over LAN

C.15. Testing of O4CV

C.15.1 Slot positions of O4CVboards

C.15.2 Service Phone

C.15.3 Hot line direct phone



Testresult

C.15.4 Remote subscriber

C.15.5 Pax 2-wire

C.15.6 Pax 4-wire

C.16. Manual reset

C.17. Documentation

YES NO YES NO

Commissioning Approved: Exceptions Noted:

Pending Items List:

CONSORTIUM


Test InstrumentType

TestInstrumentNo.

Remarks:

Date:

Tested by: Witnessed by:

ABB DESCON

Witnessed by: Witnessed by:

FWEL LI

Documents

9PKE-16-2010-Rev00 - Power Line Carrier Equipment.pdf