928-0233 I6 200910 - skilledcrafting.com Onan GGDB (spec A-E... · 1 Introduction This parts catalog applies to the Cummins Power Generation standard generator model GGDB as listed

Parts Manual

Generator Set

GGDB (Spec AE)

with Detector/2-Wire Remote Control

English 102009 9280233 (Issue 6)

The following symbols are used in Cummins PowerGeneration manuals to alert users to the potentiallydangerous conditions relating to maintenance ofequipment and replacement of parts. Please readand observe.

This symbol warns of immediatehazards which will result in severepersonal injury or death.

This symbol refers to a hazard orunsafe practice which can resultin severe personal injury or death.

This symbol refers to a hazard orunsafe practice which can resultin severe personal injury or prod-uct or property damage.

To avoid errors or delay in filling your parts order, al-ways give the MODEL, SPEC NO. and SERIAL NO.from the Cummins Power Generation nameplate.

For handy reference, insert your nameplate in-formation in the spaces below.

MODEL AND SPEC NO.

SERIAL NO.

DIGITAL CONTROL SOFTWARE VERSIONAND DATE (IF APPLICABLE)

Contact with USED ENGINE OILS has been identified by a United States federal agency and some USAstate agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engineoils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.

Contact with ASBESTOS has been identified by a United States federal agency and some USA state agen-cies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all neces-sary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilationand wear protective gloves, masks and clothing!

Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified bya United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVETOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all nec-essary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation andwear protective gloves, masks and protective clothing!

PSP-1

Service and repair of Cummins Power Generation equipment must be performed by trained, experiencedpersonnel only. Improper service or repair may result in property damage, severe personal injury ordeath. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANTSAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on.

1

IntroductionThis parts catalog applies to the Cummins Power Generation standard generator model GGDB as listed in the Gener-ator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a referencenumber corresponding with the same reference number in the parts list. Parts illustrations are typical. Throughout thiscatalog left and right sides are determined by facing the engine end (front) of the set.

Engine parts that have been modified or added by Cummins Power Generation are identified in this catalog. All otherengine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturersnameplate and supplying all available information. Contact your nearest engine parts distributor for assistance in or-dering replacement parts.

Replacement Engine

Cummins Power GenerationGenerator Model

Ford Engine Model

GGDB LRG425I6005A

Replacement engines cannot be ordered from Cummins Power Generation. Order from your nearest Ford Distributor.

Generator Set Data Table

Model/Specification

Electrical Data BatteryVoltageWatts Volts Hertz Wire Phase

16.0GGDB* 16,000 # 50 4,6,12 1 or 3 12 VDC

20.0GGDB* 20,000 # 60 4,6,12 1 or 3 12 VDC

* The specification number denotes customer requested options or deviations from the Standard model. The specification letter advances with major manufacturing changes.

# Broad Range Reconnectible.

Index

2

AAdapter, Duct, 26

Adapter, Generator, 9

Ammeter, AC Sets With Detector Control, 49

Armature, Starter, 36

BBaffle, Air Generator Begin Spec E, 45

Baffle, Air Generator Spec AD, 43

Battery, Hold Down Begin Spec E, 31

Battery, Hold Down Skid Spec AD, 30

Bearing, Starter (Commutator End), 36

Bearing, Starter (Pinion End), 36

Bell, End Generator Begin Spec E, 45

Bell, End Generator Spec AD, 43

Block, Terminal Control Box Sets With 2Wire Con-trol, 51

Block, Terminal Control Box Sets With DetectorControl, 49

Block, Terminal Control Harness Sets With 2WireControl , 51

Block, Terminal Control Housing Sets With DetectorControl, 39

Block, Terminal Engine to Control Wiring Harness Sets With Detector Control Begin Spec D, 55

Block, Terminal Engine to Control Wiring Harness Sets With Detector Control Spec AC, 53

Board, Connection Generator Begin Spec E, 45

Board, Connection Generator Spec AD, 43

Board, Printed Circuit Engine Monitor Sets With De-tector Control, 49

Board, Printed Circuit Overspeed Sets With 2WireControl, 41

Board, Printed Circuit Sensor Board Sets With De-tector Control, 49

Board, Printed Circuit Voltage Regulator, 60

Box, Control Sets With 2Wire Control, 51

Box, Control Sets With Detector Control, 49

Brace, Radiator Begin Spec B, 29

Brace, Radiator Spec A, 28

Bracket, Air Cleaner Muffler, 22

Bracket, Battery Guard, 9

Bracket, Control Saddle, 39

Bracket, Coolant Tank, 23

Bracket, Front Engine Mounting Skid, 30

Bracket, Heater Coolant Heater, 24

Bracket, Mounting Circuit Breaker Sets With 2WireControl, 51

Bracket, Mounting Circuit Breaker Sets With Detec-tor Control, 63

Bracket, Overspeed Sets With 2Wire Control, 41

Bracket, Overspeed Switch Sets With Detector Con-trol, 40

Breaker, Circuit Control Box Sets With 2Wire Con-trol, 51

Breaker, Circuit UL Listed Begin Spec B, 65

Breaker, Circuit UL Listed Spec A, 64

Breaker, Circuit UL Listed, IEC Conformity BeginSpec B, 65

Breaker, Circuit UL Listed, IEC Conformity Spec A,64

Breaker, Circuit Voltage Regulator, 60

Breather, Air Cleaner Spec A, B, 12

CCable, Battery, 9

Cable, Heater Control, 47

Cap, Radiator Begin Spec B, 29

Cap, Radiator Spec A, 28

Cap, Tank Coolant Tank, 23

Cleaner, Air Begin Spec C, 13

Cleaner, Air Spec A, B, 12

Clutch, Starter, 36

Contact, Auxiliary Switch Begin Spec B, 65

Index

3

Contact, Auxiliary Switch Spec A, 64

Contact, Dry Begin Spec B, 59

Control, 2Wire, 51

Control, Detector, 49

Cord, Heater Generator Heater, 46

Cover, Air Cleaner Spec A, B, 12

Cover, Battery Begin Spec E, 31

Cover, Circuit Breaker Sets With 2Wire Control, 51

Cover, Circuit Breaker Sets With Detector Control, 63

Cover, Control Box Sets With 2Wire Control, 51

Cover, Control Door Sets With Detector Control Be-gin Spec E, 62

Cover, Control Housing Sets With Detector Control,39

Cover, End Bell, 46

Cushion, Mounting Skid, 30

Cushion, Vibration Isolation Skid, 30

DDisk, Rotor Drive Generator Begin Spec E, 45

Disk, Rotor Drive Generator Spec AD, 43

Door, Control Sets With Detector Control, 49

Drain, Radiator, 25

EElement, Air Cleaner Begin Spec C, 13

External Engine Parts, 9

FFan, Engine Begin Spec B, 29

Fan, Engine Spec A, 28

Fan, Generator Begin Spec E, 45

Fan, Generator Spec AD, 43

Filter, Air Spec A, B, 12

Filter, Oil, 9

Frame, Starter (Commutator End), 36

Fuel System, Natural Gas, 15

Fuel System, Natural Gas With Low Fuel PressureWarning Switch Begin Spec B, 18

Fuel System, Natural Gas/Propane Liquid With LowPressure Switch and Automatic Changeover, 21

Fuel System, Natural Gas/Propane Vapor With LowPressure Switch and Automatic Changeover, 20

Fuel System, Propane Liquid, 17

Fuel System, Propane Vapor, 16

Fuel System, Propane Vapor With Low Fuel PressureWarning Switch Begin Spec B, 19

Fuse Control Box Sets With 2Wire Control, 51

Fuse Control Box Sets With Detector Control, 49

GGasket, Air Cleaner Spec A, B, 12

Gauge, Oil Pressure Sets With 2Wire Control En-gine Mounted, 14

Gauge, Oil Pressure Sets With Detector Control Control Mounted, 49

Gauge, Water Temperature Sets With 2Wire Control Engine Mounted, 14

Gauge, Water Temperature Sets With Detector Con-trol Control Mounted, 49

Generator (Assembly) Begin Spec E, 45

Generator (Assembly) Spec AD, 43

Governor Begin Spec D, 38

Governor Spec AC, 37

Grille, Air Outlet Engine, 9

Guard, Alternator Belt Radiator Begin Spec B, 29

Guard, Alternator Belt Radiator Spec A, 28

Guard, Alternator Belt Remote Radiator, 27

Guard, Belt Remote Radiator, 27

Guard, Fan Radiator Begin Spec B, 29

Index

4

Guard, Fan Radiator Spec A, 28

Guard, Radiator Begin Spec B, 29

Guard, Radiator Spec A, 28

HHanger, Tank Coolant Tank, 23

Harness, Wiring AC Auxiliary Sets With DetectorControl Begin Spec D, 55

Harness, Wiring AC Auxiliary Sets With DetectorControl Spec AC, 53

Harness, Wiring AC Control Door Sets With Detec-tor Control, 49

Harness, Wiring Control Box Sets With 2Wire Con-trol, 51

Harness, Wiring DC Control Door Sets With Detec-tor Control, 49

Harness, Wiring Dry Contact Begin Spec B, 59

Harness, Wiring Dual Fuel Natural Gas/PropaneVapor With Low Pressure Switch and AutomaticChangeover, 20

Harness, Wiring Dual Fuel Natural Gas/Propane Liq-uid With Automatic Changeover, 21

Harness, Wiring Engine to Control Sets With 2WireControl Begin Spec D, 58

Harness, Wiring Engine to Control Sets With 2WireControl Spec AC, 57

Harness, Wiring Engine to Control Sets With Detec-tor Control Begin Spec D, 55

Harness, Wiring Engine to Control Sets With Detec-tor Control Spec AC, 53

Harness, Wiring Ignition, 9

Harness, Wiring Terminal Block Sets With DetectorControl, 49

Harness, Wiring Vacuum Switch, 61

Heater, Control, 47

Heater, Engine Coolant, 24

Heater, Generator, 46

Hose, Air Cleaner Begin Spec C, 13

Hose, Breather Air Cleaner Spec A, B, 12

Hose, Engine Coolant Radiator Begin Spec B, 29

Hose, Engine Coolant Radiator Spec A, 28

Hose, Radiator Begin Spec B, 29

Hose, Radiator Remote Radiator, 27

Hose, Radiator Spec A, 28

Hose, Radiator Drain, 25

Housing, Air Cleaner Spec A, B, 12

Housing, Control Detector Control, 39

Housing, Generator Set Quiet Site Second Stage Begin Spec B, 35

Housing, Generator Set Standard Weather Protective,33

Housing, Starter, 36

IIsolator, Vibration Control Box Sets With 2Wire

Control, 51

Isolator, Vibration Control Box Sets With DetectorControl, 49

JJoint, Ball Governor Begin Spec D, 38

Joint, Ball Governor Spec AC, 37

KKit, Starter Brush, 36

LLever, Governor Begin Spec D, 38

Lever, Governor Spec AC, 37

Light, Indicator Sets With Detector Control, 49

MMeter, Frequency Sets With Detector Control, 49

Meter, Hour Sets With 2Wire Control, 51

Index

5

Meter, Hour Sets With Detector Control, 49

Module, Ignition Begin Spec D, 11

Module, Ignition Spec A, B, 9

Module, Ignition Spec C, 10

Mount, Radiator Begin Spec B, 29

Mount, Radiator Spec A, 28

Muffler, Critical, 22

OOverspeed, Electronic Sets With 2Wire Control, 41

PPaint, 7

Panel, Control Box Sets With 2Wire Control, 51

Panel, Control Housing Sets With Detector Control,39

Pickup, Magnetic Governor Begin Spec D, 38

Pickup, Magnetic Governor Spec AC, 37

Point, Overspeed Sets With Detector Control, 40

Potentiometer Voltage Regulator, 60

RRadiator Begin Spec B, 29

Radiator Spec A, 28

Radiator, Remote, 27

Rectifier Control Harness Sets With 2Wire Control,51

Rectifier Generator Begin Spec E, 45

Rectifier Generator Spec AD, 43

Rectifier, Power Control Heater, 47

Regulator, Voltage Sets With 2Wire Control, 51

Regulator, Voltage Sets With Detector Control, 60

Relay Control Box Sets With 2Wire Control, 51

Relay Control Harness Sets With 2Wire Control,51

Relay Dry Contact Begin Spec B, 59

Relay Engine to Control Wiring Harness Sets WithDetector Control Begin Spec D, 55

Relay Engine to Control Wiring Harness Sets WithDetector Control Spec AC, 53

Relay, Timer Sets With 2Wire Control, 51

Rotor, Exciter Begin Spec E, 45

Rotor, Exciter Spec AD, 43

Rotor, Generator Begin Spec E, 45

Rotor, Generator Spec AD, 43

Rotor, Ignition Overspeed Sets With 2Wire Con-trol, 41

SSealant, Thread, 7

Sender, Oil Pressure Sets With Detector Control, 9

Sender, Water Temperature Sets With Detector Con-trol, 9

Shield, Exhaust Engine, 9

Shield, Heat Muffler, 22

Shroud, Fan Radiator Begin Spec B, 29

Shroud, Fan Radiator Spec A, 28

Skid, 30

Starter, 36

Stator, Exciter Begin Spec E, 45

Stator, Exciter Spec AD, 43

Stator, Generator Begin Spec E, 45

Stator, Generator Spec AD, 43

Strap, Electrical Engine, 9

Strap, Ground Control Box Sets With Detector Con-trol, 49

Switch, Low Coolant Level, 23

Switch, Oil Pressure Sets With 2Wire Control, 9

Switch, Overspeed Sets With Detector Control, 40

Index

6

Switch, Rocker Control Box Sets With 2Wire Con-trol, 51

Switch, Rocker Control Box Sets With DetectorControl, 49

Switch, Starter, 36

Switch, Vacuum, 61

TTank, Coolant, 23

Thermostat Sets With 2Wire Control, 9

Trip, Shunt Begin Spec B, 65

Trip, Shunt Spec A, 64

Tube, Exhaust Muffler, 22

VVoltmeter, AC Sets With Detector Control, 49

Voltmeter, DC Sets With Detector Control, 49

7

Abbreviations

Some of the following abbreviations may be used throughout this Parts Catalog:

AC Alternating CurrentAmp AmpereA/R As RequiredAVR Automatic Voltage RegulatorAWG American Wire GaugeDeg DegreeDC Direct CurrentEFC Electronic Fuel ControlET External ToothEIT External/Internal ToothGFI Ground Fault InterrupterID Inside DiameterIT Internal ToothIEC International Electrotechnical CommissionkW KilowattLPG Liquid Petroleum GasLT LeftM(meter Number) Meter

mm MillimeterMOH Mobile Off HighwayNFS Not For SaleNPT National Pipe ThreadOD Outside Diameteroz. OuncePMG Permanent Magnet GeneratorPh PhasePC Printed CircuitRFI Radio Frequency InterferenceRT RightSpec SpecificationThk ThickUL Underwriters Laboratories Inc.UNC Union National CoarseUNF Union National FineVAC Volts Alternating CurrentVDC Volts Direct CurrentW/(ET, IT, EIT) With

Paint and Thread Sealant

REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

Onan Green Enamel(Non-Metallic)

5250305 12 oz. PressurizedSpray Can

5250306 Quart Can5250304 Gallon Can

5180601 Sealant, Thread (6 ml. Tube)

8

External Engine Parts

H570,H559,H560

1

23

4

5

5

5

55

5

56

6

6

7 89101112

13

13

13

13

13

14

15

15

16

17

17

17

1820

19

21

22232425

2627282930

3132

33

343536

37

38

39

40

13

41

42

4344 45

46

47

48

9

External Engine Parts


1 1010823 1 Plate, Engine Rear2 1041951 1 Flywheel (Includes Ring Gear)3 1041944 1 Gear, Ring4 1552984 1 Tube, Exhaust5 8502010 14 Washer, Lock Spring6 8002086 9 Screw, Cap Hex Head (M10 x

1.25 x 25mm)7 2310386 1 Adapter, Generator8 102105401 1 Adapter, Oil Drain9 5040011 1 Valve, Shut Off (1/2 x 1/2)

10 5050827 1 Barb, Hose (1/2 x 3/4 Hose)11 5030098 Hose (3/4 ID) Bulk (Order by

the Foot 1 Foot Required)12 5030197 1 Clamp, Hose13 5262120 10 Washer, Flat (M10)14 8002088 2 Screw, Cap Hex Head (M10 x

1.5 x 35mm)15 3322634 3 Clamp, J16 8560010 2 Washer, Lock ET (M10)17 8002089 2 Screw, Cap Hex Head (M10 x

1.5 x 40mm)18 8002093 2 Screw, Cap Hex Head (M10 x

1.5 x 60mm)19 4161046 1 Cable, Battery (Negative)20 4160549 1 Cable, Battery (Positive)21 3370090 1 Strap, Electrical22 1553242 1 Shield, Exhaust23 2323441 4 Washer, End Bell24 1552715 2 Clamp, Muffler (1.75 OD Tube)25 Fitting, Water Temperature

3090662 1 Thermostat Generator Sets With 2-Wire Control

1930477 1 Sender, Water Temperature Generator Sets WithDetector Control

26 5050007 1 Bushing, Reducer (1/4 to 1/8)

27 Fitting, Oil Pressure309064119 1 Switch, Oil Pressure

Generator Sets With 2-Wire Control (S1)

1930448 1 Sender, Oil Pressure Generator Sets With Detector Control (Includes Parts Marked +) (E1)

28 3231549 1 + Connector, Receptacle 4 Place

29 3231548 1 + Wedge, Receptacle30 3231492 4 + Socket, Contact31 2340665 1 Grille, Air Outlet32 8030032 2 Screw, Set Socket Head

(1/420 x 1/4) Spec AD33 5050110 1 Plug, Pipe34 8002015 2 Screw, Cap Hex Head

(M5 x .8 x 45mm) SpecAD

35 8502005 2 Washer, Lock Spring (M5) Spec AD

36 8602006 2 Nut, Hex (M5 x .8) Spec AD37 4161019 1 Boot, Battery Red38 4161045 1 Bracket, Battery Guard39 Fitting

5050054 1 Plug, Square (1/4) Spec A, B

1 Fitting, Vacuum Ford Part Number P&A E7TZ9A474C Spec CD

40 8702055 1 Nut, Hex Flange41 5050395 1 Bushing, Reducer (3/8 x 1/8)

Begin Spec B42 5260179 2 Washer, Flat (#10) Spec AD43 5040198 1 Vent, Air Begin Spec B44 5040028 1 Cock, Drain Spec A45 1660845 1 Module, Ignition Spec A, B

(Spec C Ignition Moduleshown on page 10 BeginSpec D Ignition Moduleshown on page 9)

46 Harness, Wiring Ignition1660844 1 Spec A, B1660868 1 Spec C3384288 1 Begin Spec D

47 4161084 1 Boot, Starter Red BeginSpec E

48 LF3501 1 Filter, Oil

+ Parts Included In 1930448 Oil Pressure Sender

10

Ignition ModuleSpec C

1

2

34

5

6


1 1660867 1 Module, Ignition2 815079303 3 Screw, Hex Flange Head

Thread Forming (M5 x 0.8 x 12)

3 8502005 1 Washer, Lock Spring (M5)

4 8602006 1 Nut, Hex (M5 x 0.8)5 5032159 Hose, Vacuum6 8002010 1 Screw, Cap Hex Head

(M5 x 0.8 x 20)

11

Ignition ModuleBegin Spec D

7

8

9

10


7 166088401 1 Module, Ignition8 8002011 3 Screw, Hex Flange Head

Thread Forming (M5 x 0.8 x 25)

9 8502005 1 Washer, Lock Spring (M5)10 8602006 1 Nut, Hex (M5 x 0.8)

12

Air CleanerSpec A, B

1

2

3

4

5

6

7

8

9

10


1 140319802 1 Housing, Air Cleaner2 140319902 1 Cover, Air Cleaner3 5201014 1 Stud (1/420 x 3.12)4 1403147 1 Filter, Air5 8650006 1 Nut, Wing (1/420)6 8650020 1 Nut, Wing (1/420)

7 1403146 1 Breather, Air Cleaner8 5170289 1 Plug, Hole9 1403202 1 Gasket, Air Cleaner

10 5031606 Hose, Breather Bulk (OrderBy The Foot 2 FeetRequired)

13

Air CleanerBegin Spec C

1

23

45

6


1 140338701 1 Cleaner, Air2 1403147 1 Element, Air Cleaner3 5031606 Hose, Air Cleaner Bulk (Order

By The Foot 2 FeetRequired)

4 5030446 1 Clamp, Hose5 5032247 1 Hose, Air Reducing6 503187005 2 Clamp, Hose

14

Engine GaugesGenerator Sets With 2-Wire Control

3

4

5

2

1

3

H563


1 5050071 1 Nipple, Pipe (1/4 X 2)2 5050184 1 Tee, Pipe3 5050007 2 Bushing, Reducer (1/4 x 1/8)

4 1930451 1 Gauge, Oil Pressure5 1930463 1 Gauge, Water Temperature

15

Fuel SystemNatural Gas

1

2

3

4

567

7

9

8

10

11

12

13

14

15

C002

16

17

18


1 150281102 1 Bracket, Mounting Carburetor2 1481104 1 Carburetor3 5201028 2 Stud (M8 x 1.25 x 48)4 8702055 2 Nut, Lock Flange

(M8 x 1.25)5 5050002 1 Nipple, Pipe (1/2 NPT x 3.0)6 5050021 1 Bushing, Reducer (3/4 NPT)7 5050132 2 Elbow, Pipe (90) (3/4)8 5050085 1 Nipple, Pipe (3/4 NPT x 2.0)9 5050102 1 Nipple, Close (3/4 x 11/4)

10 1480597 1 Regulator, Natural Gas11 5050754 1 Nipple, Pipe (3/4 NPT x 6.0)12 307031201 1 Valve, Solenoid13 1551256 1 Clamp, Muffler14 5262100 2 Washer, Flat (M8)15 821600303 2 Screw, Hex Head (M8 x 25)16 3322634 1 Clamp, J17 1450724 2 Gasket, Carburetor18 5170094 1 Plug, Hole

16

Fuel SystemPropane Vapor

C099

1

2

3

4

567

7

8

9

10

11

12

13

14

15

16

17

18



(M8 x 1.25)5 5050002 1 Nipple, Pipe (1/2 NPT x 3.0)6 5050021 1 Bushing, Reducer (3/4 NPT)7 5050132 2 Elbow, Pipe (90) (3/4)8 5050085 1 Nipple, Pipe (3/4 NPT x 2.0)9 5050102 1 Nipple, Close (3/4 x 11/4)

10 5050754 1 Nipple, Pipe (3/4 NPT x 6.0)11 307031201 1 Valve, Solenoid12 1480637 1 Regulator, LPG Vapor13 1551256 1 Clamp, Muffler14 5262100 2 Washer, Flat (M8)15 821600303 2 Screw, Hex Head (M8 x 25)16 1450724 2 Gasket, Carburetor17 5170094 1 Plug, Hole18 3322634 1 Clamp, J

17

Fuel SystemPropane Liquid

C053

1

2

34

6

6

6

7

8

5

5

4910

10

11

12

13

14

16

17

18

19

20

15

21

22

23

24



(M8 x 1.25)5 5050002 2 Nipple, Pipe (1/4 x 3)6 5050040 3 Elbow, Pipe 90 (1/2)7 5050099 1 Nipple, Pipe (1/4 x .88)8 5050210 1 Nipple, Pipe (1/2 x 2)9 5262100 2 Washer, Flat (M8)

10 821600303 4 Screw, Hex Head (M8 x 25)11 1480737 1 Regulator12 307026801 1 Valve, Solenoid13 5020942 2 Connector, Hose (90)

14 5030131 4 Clamp, Hose15 5030386 Hose, Flex Bulk (Order by the

Foot 4 Feet Required) (5/8)16 5050106 1 Nipple, Short (1/2 x 1.5)17 5050158 1 Cap, Pipe (1/2)18 526039913 2 Washer, Flat (1/4)19 1492622 1 Bracket, Support20 3383654 1 Harness, LPG21 5030386 Hose, Flex Bulk (Order by the

Foot 4 Feet Required) (5/8)22 1450724 2 Gasket, Carburetor23 3322634 1 Clamp, J24 5050078 1 Nipple, Pipe (1/2 x 2-1/2)

18

Fuel SystemNatural Gas

With Low Fuel Pressure Warning SwitchBegin Spec B

1

23

4

54

6

6

7

8

9

1011

12

13

14

15

16

17

18

19

H569,C002

2021

22


1 150281102 1 Bracket, Governor2 5050002 1 Nipple, Pipe (1/2 x 3.00)3 5050021 1 Bushing, Reducer (3/4 x 1/2)4 5050132 2 Elbow, Pipe5 5050085 1 Nipple, Pipe (3/4 x 2.00)6 5050102 2 Nipple, Close (3/4)7 1480597 1 Regulator, Natural Gas8 5050754 1 Nipple, Pipe (3/4 x 6.00)9 307031201 1 Valve, Solenoid (12V)

10 5051496 1 Tee, Reducing11 5050007 1 Bushing (1/4 x 1/8)12 3090669 1 Switch, Pressure (12V)

13 5050051 1 Elbow, Street 90 (3/4)14 5170094 1 Plug, Hole15 5201028 2 Stud (M8 x 1.25)16 8702055 2 Nut, Lock Flanged17 821600303 2 Screw, Hex Head (M8 x 1.25 x

25)18 1551256 1 Clamp, Muffler (1.5)19 5262100 2 Washer, Flat (M8)20 1481104 1 Carburetor21 1450724 2 Gasket, Carburetor22 3383740 1 Harness, Fuel Alarm

19

Fuel SystemPropane Vapor

With Low Fuel Pressure Warning SwitchBegin Spec B

1

34

5

4

6

7

8

9

19

18

15

611

10

14

13

17

12

16

2 20

H569,C099

22

21


1 150281102 1 Bracket, Governor2 5050002 1 Nipple, Pipe (1/2 x 3.00)3 5050021 1 Bushing, Reducer (3/4 x 1/2)4 5050132 2 Elbow, Pipe5 5050085 1 Nipple, Pipe (3/4 x 2.00)6 5050102 2 Nipple, Close (3/4)7 1480637 1 Regulator, LPG Vapor8 5050754 1 Nipple, Pipe (3/4 x 6.00)9 307031201 1 Valve, Solenoid (12V)

10 5051496 1 Tee, Reducing11 5050007 1 Bushing (1/4 x 1/8)12 3090669 1 Switch, Pressure (12V)

13 5050051 1 Elbow, Street 90 (3/4)14 5050094 1 Plug, Hole15 5201028 2 Stud (M8 x 1.25)16 8702055 2 Nut, Lock Flanged17 821600303 2 Screw, Hex Head (M8 x 1.25 x

25)18 1551256 1 Clamp, Muffler (1.5)19 5262100 2 Washer, Flat (M8)20 1481104 1 Carburetor21 1450724 2 Gasket, Carburetor22 3383740 1 Harness, Fuel Alarm

20

Fuel SystemNatural Gas / Propane Vapor With Low Pressure Switch and Automatic

Changeover

C065

1

2

3

4

56

6

7

7

8

9

10

10

11

12

13

14

14

15

16

17

18

19

2021

2021

22

23

24

9

6

6

26

25

27

28

29



(M8 x 1.25)5 5050002 1 Nipple, Pipe (1/2 x 3)6 5050132 4 Elbow, Pipe (90) (3/4)7 5050102 5 Nipple, Close (3/4 x 13/8)8 1480597 1 Regulator, Natural Gas9 5050754 2 Nipple, Pipe (3/4 NPT x 6.0)

10 307031201 2 Valve, Solenoid11 1480637 1 Regulator, LPG Vapor12 5050167 1 Tee, Reducing13 5050150 1 Union, Ground Joint (1/2 NPT)14 5050084 2 Nipple, Pipe (3/4 NPT x 2.5)15 5040171 1 Valve (3/4)16 5050332 1 Nipple, Pipe (3/4 NPT x 3.0)

17 5051496 1 Tee, Reducing18 5050210 1 Nipple, Pipe (1/2 NPT x 2.0)19 1492617 1 Bracket, Support20 1551256 2 Clamp, Muffler21 5262100 4 Washer, Flat (M8)22 821600303 2 Screw, Hex Head,

(M8 x 1.25 x 25)23 Harness, Dual Fuel Includes

Relay3383698 1 Spec A, B3383816 1 Begin Spec C

24 307281701 1 Relay (12 Volt) (K99)25 3322634 1 Clamp, J26 1450724 2 Gasket, Carburetor27 5170094 2 Plug, Hole28 309066901 1 Switch, Low Pressure29 5050007 1 Bushing, Reducer (1/4 x 1/8)

21

Fuel SystemNatural Gas / Propane Liquid With Low Pressure Switch and Automatic

Changeover

C0901

2

34

5

6

4

7

8

9

101112

13

14

14

14

15

16

17

18

19

20

2122

23

24

25

26

28

29

30

31

32

7

22721

33

27

34

35

36

37

26

26

38

39



(M8 x 1.25)5 5050002 2 Nipple, Pipe (1/2 NPT x 3.0)6 5050021 1 Bushing, Reducer (3/4 NPT)7 5050132 4 Elbow, Pipe (90) (3/4)8 5050102 4 Nipple, Close

(3/4 NPT x 13/8)9 1480597 1 Regulator, Natural Gas

10 5050754 1 Nipple, Pipe (3/4 NPT x 6.0)11 307031201 1 Valve, Solenoid12 5050167 1 Tee, Reducing13 5050150 1 Union, Ground Joint

(1/2 NPT)14 5050084 3 Nipple, Pipe (3/4 NPT x 2.5)15 5040171 1 Valve (3/4)16 5051496 1 Tee, Reducing17 5050099 1 Nipple, Pipe (1/4 NPT x .88)18 5050210 2 Nipple, Pipe (1/2 NPT x 2.0)19 1492617 1 Bracket, Support20 1551256 1 Clamp, Muffler21 5262100 4 Washer, Flat (M8)

22 821600303 4 Screw, Hex Head (M8 x 1.25 x 25)

23 1480737 1 Regulator24 307026801 1 Valve, Solenoid25 5020942 2 Connector, Hose (90)26 5030131 4 Clamp, Hose27 5030386 1 Hose, Flex Bulk (Order by the

Foot 4 Feet Required) (5/8)28 5050158 1 Cap, Pipe (1/2 NPT)29 526039913 2 Washer, Flat (1/4)30 1492622 1 Bracket, Support31 Harness, Dual Fuel Includes

Relay3383698 1 Spec A, B3383816 1 Begin Spec C

32 307281701 1 Relay (12 Volt) (K99)33 3383654 1 Harness, LPG34 5030386 1 Hose, Flex Bulk (Order by the

Foot 4 Feet Required) (5/8)35 1450724 2 Gasket, Carburetor36 5170094 1 Plug, Hole37 3322634 1 Clamp, J38 309066901 1 Switch, Low Pressure39 5050007 1 Bushing, Reducer (1/4 x 1/8)

22

MufflerHoused Sets

1

2

3

4

5

6

7

8

9

A076


1 5050043 1 Elbow, 90 (11/2)2 1550927 1 Tube, Exhaust3 5050462 1 Elbow, Street 90

(11/2)4 1400078 2 Bracket, Air Cleaner5 155036001 1 Muffler, Critical

6 8212050 4 Screw, Lock (M8 x 1.25 x 40)

7 8702055 4 Nut, Lock (M8 x 1.25)8 1551924 1 Shield, Heat Muffler9 1551926 4 Spacer, Muffler

23

Low Coolant Level Switch

1

2

3

4

5

6

7

H389,H527

8

9

10

11

12


1 1303570 1 Tank, Coolant2 1303571 1 Hanger, Tank3 1304846 1 Bracket, Coolant Tank4 1930468 1 Switch, Low Coolant Level

(S7)5 821600303 2 Screw, Hex Head

(M8 x 1.25 x 20)6 8212034 2 Screw, Self-Locking Flange

Head (M6 x 1 x 20)7 3321389 A/R Tie, Cable

8 3383594 1 Harness, Pigtail (Includes Parts Marked *)

9 3231765 1 *Housing, Connector (4 Pin)10 3231709 4 *Socket, Contact11 3231708 4 *Seal, Cable12 1303572 1 Cap, Tank

* Parts Included in 3383594 Pigtail Harness

24

Coolant Heater

1

2

3

4

5

6

7

8

910

5

5

5

5

5


1 3330624 1 Bracket, Heater2 Heater, Engine Coolant

333058801 1 120 Volt333058802 1 208/240 Volt

3 5030386 Hose, Engine Coolant Bulk(Order by the Foot 1 FootRequired)

4 5020870 1 Tee5 5030183 6 Clamp, Hose6 821600203 Screw, Hex Head (M6 x 1 x 16)

7 8212060 1 Screw, Self-Locking HexWasher Head (M10 x 1.5 x20)

8 5030386 Hose, Engine Coolant Bulk(Order by the Foot 1 FootRequired)

9 5020613 1 Adapter, Hose10 5030386 Hose, Engine Coolant Bulk

(Order by the Foot 1 FootRequired)

25

Radiator Drain

E089

1

2


1 5030685 1 Clamp, Hose 2 5031274 1 Hose, Radiator Drain (24)

26

Duct Adapter

1

2

3

4

F013


1 1304835 2 Adapter, Duct Side2 1304834 2 Adapter, Duct Top and

Bottom

3 821600302 4 Screw, Hex Head SEMS (M8 x 1.25 x 20)

4 818023102 4 Rivet, Pop

27

Remote Radiator

E043

1

3

2

4

4

5

5

6

7


1 191226802 1 Guard, Alternator Belt2 8212032 2 Screw, Lock (M6 x 1 x 12)3 1912263 1 Guard, Belt4 5030869 2 Hose, Radiator

5 5031138 4 Clamp, Hose6 8002056 4 Screw, Cap Hex Head

(M8 x 1.25 x 16)7 8502008 4 Washer, Lock (M8)

28

RadiatorSpec A

1

2

3

4

5

6

7

8

9

10

11

12

12

1212

13

1415

16

17

19

20

21

22

23

24

25 18

18

2627

E074,E082,F001


1 1303552 1 Radiator2 8160152 2 Bolt, Carriage (3/8 x 2)3 1304796 1 Mount, Radiator4 1304856 1 Shroud, Fan5 1304839 1 Guard, Fan6 1301793 1 Brace, Radiator (LH)7 1301798 1 Brace, Radiator (RH)8 1304792 1 Fan, Engine9 130477003 1 Spacer, Fan

10 8002071 4 Screw, Hex Head Cap (M8 x 1.25 x 90)

11 5032085 1 Hose, Radiator Inlet (Top)12 5030429 4 Clamp, Hose13 5032092 1 Hose, Radiator Outlet (Bottom)14 1304833 1 Guard, Radiator

(Unhoused Sets only)15 130372101 1 Cap, Radiator 15 PSI

16 Screw, Hex Head ThreadCutting (#1032 x 3/8)

8150194 6 Housed Sets8150194 12 Unhoused Sets

17 191226801 1 Guard, Alternator Belt18 821600302 7 Screw, Hex Head

(M8 x 1.25 x 20)19 8700257 1 Nut, Self-Locking (5/1618)20 5260141 2 Washer, Flat (15/32)21 8700281 2 Nut, Hex (3/816)22 5030386 Hose, Engine Coolant Bulk

(Order by the Foot 3 FeetRequired)

23 5030183 2 Clamp, Hose24 3322634 1 Clamp, J25 8212033 1 Screw, Flange (M6 x 1 x 12)26 8502008 4 Washer, Lock (M8)27 5020153 1 Plug, 1/4 Hex Head Pipe

29

RadiatorBegin Spec B

1

2

3

4

5

6

7

8

9

10

11

12

12

1212

13

1415

16

17

19 20

21

22

23

24

25

26

18

18

2728

E074,F173,F184

29

30

31

32

18

18

18 (Unhoused)33 (Housed)


1 1303552 1 Radiator2 8160152 2 Bolt, Carriage (3/816 x 2)3 1304796 1 Mount, Radiator4 130500302 1 Shroud, Fan5 130495902 1 Guard, Fan (LH)6 1301793 1 Brace, Radiator (LH)7 1301798 1 Brace, Radiator (RH)8 1304792 1 Fan, Engine9 130477003 1 Spacer, Fan

10 8002071 4 Screw, Cap Hex Head(M8 x 1.25 x 90)

11 5032085 1 Hose, Radiator Inlet (Top)12 5030429 4 Clamp, Hose13 5032092 1 Hose, Radiator Outlet (Bottom)14 1304833 1 Guard, Radiator

(Unhoused Sets)15 130372101 1 Cap, Radiator 15 PSI16 Screw, Hex Head

(M8 x 1.25 x 20)8150194 6 Housed Sets8150194 12 Unhoused Sets

17 191227602 1 Guard, Alternator Belt18 Screw, Hex Head

(M8 x 1.25 x 20)821600302 7 Housed Sets821600302 8 Unhoused Sets

19 8700257 1 Nut, Self-Locking (5/1618)20 5260141 2 Washer, Flat (15/32)21 8700281 2 Nut, Hex (3/816)22 503218501 1 Hose, Engine Coolant23 5030183 2 Clamp, Hose24 3322634 1 Clamp, J25 8212033 1 Screw, Flange (M6 x 1 x 12)26 818023102 2 Rivet, Pop (3/16)27 8502008 4 Washer, Lock (M8)28 5020153 1 Plug, 1/4 Hex Head Pipe29 130495802 1 Guard, Fan (RH)30 130511602 1 Brace, Radiator31 130511702 1 Brace, Radiator32 5030977 1 Clamp33 821600702 1 Screw, Hex Head (M8 x 1.25 x

20)

30

Skid

1

2

34

4

5

678

87

9

910

10

11

12

12

12

131415

16

16

1718

19

20

21

F179,C002,C099,C053,C065,C090


1 Base, Skid4034254 1 Spec AD403504101 1 Begin Spec E

2 4020285 2 Cushion, Vibration Isolation(Engine End) (23/4 x 211/32)

3 4020286 2 Cushion, Vibration Isolation(Generator End) (23/4 x 211/32)

4 4020290 4 Bushing, Spacer5 4034255 1 Bracket, Front Engine

Mounting6 4031830 2 Spacer7 4020282 4 Cushion, Mounting Rubber

(11/2 x 1/4)8 5260014 4 Washer, Flat (7/16)9 8500055 4 Washer, Lock (7/16)

10 8000081 4 Screw, Cap Hex Head(7/1614 x 3.5)

11 4033795 1 Spacer, Engine Support12 5260174 4 Washer, Flat (3/8)13 5260122 1 Washer, Flat (5/16)14 8002057 1 Screw, Cap Hex Head

(M8 x 1.25 x 20)15 8002086 2 Screw, Cap Hex Head (M10 x

1.5 x 25.4)16 8002095 2 Screw, Cap Hex Head (M10 x

1.5 x 70)17 8560009 2 Washer, Lock EIT (5/16)18 8700257 1 Nut, Lock (5/1618)19 4160961 2 Battery, Hold Down Spec

AD20 8002040 2 Screw, Cap Hex Head

(M6 x 1 x 50) Spec AD21 8502056 2 Washer, Lock (M6) Spec AD

31

Battery CoverBegin Spec E

1

2

3


1 4161164 1 Cover, Battery2 416116502 2 Hold Down, Battery

3 821600204 2 Screw, Hex Head (M6 x 1 x 20)

32

This Page Intentionally Left Blank.

33

HousingStandard Weather Protective

12

3

4

5

6

7

7

9

13

1415

16

17

18

19

20

21

22

23

2

F001,F184

24

10

1112

26

2827

8

25

29

30

31

32

33


1 4056097 1 Panel, Front Housing2 4056167 2 Post, Corner3 4056168 1 Roof, Housing4 8700258 6 Nut, Weld Stud5 4056164 6 Catch, Housing Door6 8210010 6 Screw, Lock Head

(1/420 x 1/2)7 4056162 2 Door, Housing (Side)8 4056163 1 Door, Housing (Rear)9 4060615 6 Latch, Door

10 4060614 6 Bracket, Door11 8120084 6 Screw, Machine Round Head

(#832 x 1)12 8700221 6 Nut (#832)13 4054932 6 Bumper, Housing14 4056169 2 Bracket, Housing15 4056170 1 Bracket, Housing16 821600302 22 Screw, Hex Head

(M8 x 1.25 x 20)

17 821600102 12 Screw, Hex Head (M5 x .8 x 12)

18 818023102 12 Rivet, Pop19 517013809 2 Plug, Hole20 4051872 6 Clip, Door21 8180150 12 Rivet, Drive22 5260003 12 Washer, Flat (3/16)23 128015402 1 Insulation, Foam24 8950387 4 Seal, Weather (18.5)25 4056202 1 Panel, Housing26 5050025 1 Bushing, Reducer

(11/2 x 11/4)27 5050032 1 Coupling, Pipe (11/2)28 4051889 1 Shield, Rain29 098790202 2 Label, Logo30 0984500 2 Label, Prototype Tested31 0985429 1 Label, Coolant Fill32 0984730 1 Label, Warning33 0984732 1 Label, Warning

34

HousingQuiet Site Second Stage

Begin Spec B

F173

1

2

2

3

4

45 6

7

8

9

10 11

11

12

1313

14

15

1516

17

18

1919

2021

22

23

23

2425

26 27

28

29

30

31

3233

34

35

3637

3837

3639

40

41

41

35

40

42

43

44

46

35

HousingQuiet Site Second Stage

Begin Spec B


1 4056097 1 Panel, Front Housing2 4056167 2 Post, Corner3 4056202 1 Panel, Housing4 4056195 2 Panel, Insulation5 405620102 1 Support, Insulation6 4056199 1 Panel, Insulation7 4056168 1 Roof, Housing8 8700258 6 Nut, Weld9 4056164 6 Catch, Housing Door

10 8210010 6 Screw, Self-Locking HexWasher Head (1/420 x .50)

11 4056162 2 Door, Housing12 4056163 1 Door, Housing13 4060615 6 Latch, Door14 4054932 6 Bumper, Housing15 4056169 2 Bracket, Housing16 4056170 1 Bracket, Housing17 821600302 14 Screw, Hex Head (M8 x 1.25 x

20)18 821600102 12 Screw, Hex Head (M5 x 0.8 x

12)19 517013809 2 Plug, Hole20 4051872 6 Clip, Door21 8180150 12 Rivet, Drive (5/32)22 5260003 12 Washer, Flat (3/16)23 818023102 58 Rivet, Pop24 098790202 2 Label, Logo

25 0984500 2 Label, Prototype26 0985429 1 Label, Coolant Fill27 0984730 1 Label, Warning28 0984732 2 Label, Warning29 8950387 4 Seal, Weather30 4056196 1 Panel, Insulation31 4056197 1 Panel, Insulation32 4051889 1 Shield, Rain33 5050032 1 Coupling, Pipe34 5050025 1 Bushing, Reducer (1-1/4 x

1-1/2)35 405622902 2 Duct, Air Outlet36 405623102 2 Duct, Air Outlet37 4056236 2 Panel, Insulation38 405622802 1 Duct, Air Outlet39 4056235 1 Panel, Insulation40 405620002 12 Support, Insulation41 0987451 3 Label, Caution42 821600702 20 Screw, Hex Head (M8 x 1.25 x

20)43 130511602 1 Brace, Radiator44 130511702 1 Brace, Radiator45 5030977 1 Clamp (Used with Item 44 and

Radiator Brace NotIllustrated)

46 0987868 1 Label

36

Starter

2

3

4

5

6

7

8

1

CP01


1912213 1 Starter Complete (1.4kW) (B1)1 1912215 1 Kit, Starter Brush2 1912216 1 Switch3 1912217 1 Clutch4 1912218 1 Armature

5 1912219 1 Frame, Commutator End6 1912220 1 Housing7 1912221 1 Bearing, Commutator End8 1912222 1 Bearing, Pinion End

37

GovernorSpec AC

1

234

2 5

6

7

89

10

11

12

A366

13


1 150269201 1 Governor (Includes Lever)(A12)

2 5260018 5 Washer, Flat (1/4)3 8500040 4 Washer, Split Lock (1/4)4 8000602 4 Screw, Cap Hex Head

(1/428 x .75)5 8000008 1 Screw, Cap Hex Head

(1/420 x 1_1/4)

6 8700212 1 Nut, Locking (1/420)7 1500939 2 Joint, Ball8 1502694 1 Stud, Governor Link9 8700131 4 Nut, W/ET (#1032)

10 1502620 1 Lever, Governor11 1502651 1 Pickup, Magnetic (P1)12 3321554 1 Clamp, Loop (Insulated)13 1502550 1 Spring

38

GovernorBegin Spec D

1

2

3345

6

78

910

14

11

13

1017

15

12

16


1 150281102 1 Bracket, Governor2 150269201 1 Governor (Includes Lever)

(A12)3 5260018 3 Washer, Flat (1/4)4 8500040 4 Washer, Split Lock (1/4)5 8000602 4 Screw, Cap Hex Head

(1/428 x .75)6 8000008 1 Screw, Cap Hex Head

(1/420 x 1_1/4)7 8700212 1 Nut, Locking (1/420)8 1500939 2 Joint, Ball

9 1502694 1 Stud, Governor Link10 8700131 6 Nut, W/ET (#1032)11 1502620 1 Lever, Governor12 1502651 1 Pickup, Magnetic (P1)13 3321554 1 Clamp, Loop (Insulated)14 1502550 1 Spring15 1930545 1 Map, Sensor Ignition16 503215901 1 Hose, Vacuum17 8130107 2 Screw, Machine Round Head

(#1032 x 1-1/4)

39

Control HousingDetector Control

1

2

3

3

3

4

5

6

67

8

9

10

11

4

8

4

4


1 3193313 1 Panel, Control Housing2 3193312 1 Panel, Control Housing Top3 Cover, Control Housing

3193316 2 Sets W/Circuit Breaker3193316 3 Sets W/O Circuit Breaker

4 Screw, Hex Head (M6 x 1 x 16)

821600203 25 Sets W/Circuit Breaker821600203 29 Sets W/O Circuit Breaker

5 Bracket, Control Saddle4056098 1 Spec AC319497002 1 Begin Spec D

6 8560008 6 Washer, Lock W/IT (5/16)

7 8150236 4 Screw, Thread Cutting (5/1618x 5/8)

8 8210014 4 Screw, Locking (5/1618 x 1/2)

9 508030502 Edging Bulk (Order By TheFoot 1 Foot Required)

10 3323249 2 Block, Terminal11 821600103 2 Screw, Hex Head

(M5 x 0.8 x 16)12 8560006 1 Washer, Lock W/EIT (1/4)

Used With Engine Harness(Not Illustrated)

40

Overspeed SwitchDetector Control

1

7 2

3

4

5

6

8

9

10

11

H560,H559


1 8210010 2 Screw, Lock (1/420 x 1/2)2 1500716 1 Switch, Overspeed3 8150823 1 Screw, Cap Hex Head (832

x 3/8)4 8000051 1 Screw, Cap Hex Head

(3/816 x 11/4)5 5260077 2 Washer, Flat (13/32)

6 8560010 1 Washer, Lock EIT (3/8)7 1501445 1 Bracket, Overspeed Switch8 8530013 1 Washer, Lock ET (1/4)9 8620001 2 Nut, Hex (1/420)

10 8700250 1 Nut, Insulation (1/420)11 1500723 1 Point, Overspeed

41

Electronic Overspeed2-Wire Control

1

2

3

4

4

5

6

7

8

9

1011

11

H562


1 3193384 1 Bracket, Overspeed2 3004324 1 Board, Printed Circuit

Overspeed3 5260077 1 Washer, Flat (3/8)4 5260124 2 Washer, Flat (3/8)5 1660767 1 Rotor, Ignition6 8500050 1 Washer, Lock Spring (3/8)7 8000051 1 Screw, Cap Hex Head

(3/816 x 1.25)

8 815086513 2 Screw, Pan Head Slotted (M4x 45)

9 8502004 2 Washer, Lock Spring (M4)10 8602005 2 Nut, Hex (M4)11 821500204 2 Screw, Hex Head

(1/420 x 5/8)

42

GeneratorSpec AD

1

2

3

4

5

67

89

8

10

11

12

1314

15

16

17

18

19

2021

22

23

2425

26

27

28

29

3031

B274,B346,B256,B328,B340,B268,B304

43

GeneratorSpec AD


1 Stator, Generator220456406 1 4 Lead220456506 1 6 Lead220456306 1 12 Lead220456307 1 12 Lead, Full Output on

Single Phase2 Rotor Assembly, Generator

(Includes parts marked *)201357306 1 149mm Stack Length201357307 1 181mm Stack Length

3 2012151 1 * Rotor Assembly, Exciter(Includes Parts Marked #)

4 3580069 1 *# Rectifier Assembly Positive

5 3580070 1 *# Rectifier Assembly Negative6 8530008 4 *# Washer, Lock ET (#10)7 8130100 4 *# Screw, Round Head

Machined (#1032 UNF x1/2)

8 5260008 10 *# Washer, Flat (#10)9 8700131 6 *# Nut, Hex W/ET (#1032)

10 2322826 A/R * Disk, Rotor Drive11 2050258 1 * Fan, Generator12 5100112 1 * Bearing, Ball13 526039911 2 * Washer, Flat (#10)14 870013101 2 * Nut, Hex W/ET (#10)15 526039942 6 * Washer, Flat (.38 Hardened)16 8000519 6 * Screw, Cap Hex Head

(.37516 x .75) (Special)

17 211025602 1 Bell, End18 2202009 1 Stator, Exciter19 5090094 1 Seal, O-Ring20 8150194 2 Screw, Hex Head Thread

Cutting W/ET (#1032 x3/8)

21 2322417 1 Board, Connection22 3321355 2 Terminal, Tab23 8180006 2 Rivet24 8020038 4 Screw, Cap Socket Head

(1/420 x 1.5)25 8500040 4 Washer, Lock (1/4)26 Stud

5200799 4 149mm Stack Length5200800 4 181mm Stack Length

27 2340519 1 Baffle, Air28 8050015 6 Bolt, Place

(.3816 UNC x .75)29 8210010 4 Screw, Lock

(.2520 UNC x .50)30 850011407 4 Washer, Lock (.38)31 862002607 4 Nut, Hex (.3816)

* Parts Included in Generator Rotor Assembly

# Parts Included in Exciter Rotor Assembly

44

GeneratorBegin Spec E

1

2

3

4

5

67

89

8

10

11

12

1314

15

16

17

18

19

2021

22

23

2425

26

27

28

29

3031

B274,B346,B256,B328,B340,B268,B304

45

GeneratorBegin Spec E


1 Stator, Generator220461406 1 4 Lead220461506 1 6 Lead220461306 1 12 Lead220461307 1 12 Lead, Full Output on

Single Phase2 Rotor Assembly, Generator

(Includes parts marked *)201360206 1 149mm Stack Length201360207 1 181mm Stack Length

3 201351502 1 * Rotor Assembly, Exciter(Includes Parts Marked #)

4 3580069 1 *# Rectifier Assembly Positive5 3580070 1 *# Rectifier Assembly Negative6 8530008 4 *# Washer, Lock ET (#10)7 8130100 4 *# Screw, Round Head

Machined (#1032 UNF x1/2)

8 5260008 10 *# Washer, Flat (#10)9 8700131 6 *# Nut, Hex W/ET (#1032)

10 2322826 A/R * Disk, Rotor Drive11 2050258 1 * Fan, Generator12 5100112 1 * Bearing, Ball13 5260008 2 * Washer, Flat (#10)14 8700131 2 * Nut, Hex W/ET (#10)15 526039942 6 * Washer, Flat (.38 Hardened)16 8000519 6 * Screw, Cap Hex Head

(.37516 x .75) (Special)

17 211025602 1 Bell, End18 2202309 1 Stator, Exciter19 5090094 1 Seal, O-Ring20 8150194 2 Screw, Hex Head Thread

Cutting W/ET (#1032 x3/8)

21 2322417 1 Board, Connection22 3321355 2 Terminal, Tab23 8180006 2 Rivet24 802004001 4 Screw, Cap Socket Head

(1/420 x 2)25 850011405 4 Washer, Lock (1/4)26 Stud

5200799 4 149mm Stack Length5200800 4 181mm Stack Length

27 2340519 1 Baffle, Air28 8050015 6 Bolt, Place (.3816 UNC x .75)29 8210010 4 Screw, Lock (.2520 UNC x

.50)30 850011407 4 Washer, Lock (.38)31 862002607 4 Nut, Hex (.3816)

* Parts Included in Generator Rotor Assembly

# Parts Included in Exciter Rotor Assembly

46

Generator Heater

A222

1

3

2

4

5

6


1 3330184 1 Heater, Generator (IncludesHeater Cord)

2 3330228 1 Cord, Heater3 3310041 2 Nut, Lock (1/2)4 Cover, End Bell

2340993 1 Sets With Generator Heater2340498 1 Sets Without Generator

Heater

5 8500040 2 Washer, Lock Split (1/4)6 8120167 2 Screw, Round Head

(1/420 x 6)

47

Control Heater

10

15

16

17

1

2

3

4

18

5

6

7

8

9

11

12

13

14

9

A362


1 3322420 2 Mount, Tie Cable2 0986195 1 Label, Caution3 333055001 1 Heater, Control

120 Volt4 898119501 A/R Sleeving, Convoluted5 3570114 1 Rectifier, Power6 3321992 1 Terminal, Receptacle7 3322430 1 Terminal, Tab8 8980860 A/R Tubing, Heat Shrink9 3321789 2 Splice, Window (18 Gauge)

10 3350173 1 Cable, Heater Control(Includes Parts Marked *)

11 3350110 1 * Cable12 3322697 1 * Terminal, Ring13 3321992 1 * Terminal, Receptacle14 3322430 1 * Terminal, Tab15 3320942 3 Tie, Cable16 8000024 1 Screw, Cap Hex Head

(5/1618 x 3/4)17 8700257 1 Nut, Hex Self Locking

(5/1618)18 8560008 2 Washer, Lock EIT (5/16)

* Parts Included In 3350173 Control Heater Cable

48

Detector Control

6

7

8

12

14 15

17

18

20

2122

23

24

26

2739

29

31

34

35

937

38

3940

44

46

47

4849

50

51

52

40

54

56

55

41

42

43

12

2

3

4

5

10 11 34

34

19

3

H559,560

32

33

36

57

592530

60

53

15

13

58

37

28

45

1661

34

62

49

Detector Control


1 3193030 1 Box, Control2 4020527 4 Isolator, Vibration3 8500045 4 Washer, Lock Spring (5/16)4 5080051 1 Grommet (Fits 2 Hole)5 4060332 2 Receptacle, Fastener6 4060333 2 Stud, Fastener7 4060334 2 Washer, Stud Retainer8 3320052 2 Clip, Wire9 8700131 1 Nut, Hex W/ET (#1032)

10 8710015 1 Nut, Hex (1/420)11 5260018 1 Washer, Flat (1/4)12 3370049 1 Strap, Ground13 8000024 1 Screw, Cap Hex Head

(5/1618 x 1/2)14 815090508 1 Screw, Pan Head Cross

Recessed (#1032 x 7/8)15 8560008 2 Washer, Lock EIT (5/16)16 8210004 3 Screw, SelfLocking Hex

Washer Head (#1032 x5/16)

17 301905401 1 Door, Control AC18 3382278 1 Harness, Wiring AC Control

Door (Includes TerminalBlock) (19 Wire, 26) (TB21,GND to GND, M21,22,23,S21, DS21,22)

19 3320607 1 Block, Terminal (12 Place)(TB21)

20 3220363 1 Light, Indicator Upper/LowerScale (DS21,22)

21 Voltmeter, AC (M21)3021148 1 0300/6003021753 1 00750

22 3021473 Ammeter AC (M22)23 3021968 1 Meter, Frequency (M23)24 8530008 1 Washer, Lock ET (#10)25 3081052 1 Switch, Rotary

Voltmeter/Ammeter (IncludesHandle) (S21)

26 3322723 1 Strip, Marker27 815090106 2 Screw, Cross Recessed

Thread Forming (#632 x5/8)

28 3550189 1 Capacitor Voltmeter (.1 Mfd.,500 WVDC) (C21)

29 8700183 2 Nut, Hex W/ET (#632)30 815087502 3 Screw, Machine Round Head

(M4 x 8mm)31 3383429 1 Harness, Wiring Terminal

Block (9 Wire, 11) (IncludesConnector Plug and Sockets)(P2 to TB21)

32 323164402 1 Plug, Connector (P2)

33 3231648 9 Socket, Contact34 8000045 4 Screw, Cap Hex Head

(5/1618 x 3/8)35 8701220 6 Nut, Hex (#440)36 821500005 1 Screw, SelfLocking Hex

Washer Head (#1032 x 1/2)37 8150388 8 Screw, Pan Head (Cross

Recessed (#632 x 1/2)38 301905501 1 Door, Control DC39 8150385 4 Screw, Machine Round Head

(#632 x 1/2)40 8700183 4 Nut, Hex W/ET (#632)41 3383252 1 Harness, Wiring DC Control

Door (Includes ConnectorHousing and Contact Pins)(22 Wire, 32) (A11J4 to GND,M11,12,13,14, S11,12, DS11)

42 3231308 1 Housing, Connector (J4)43 3231302 11 Pin, Contact44 3004296 1 Board Assembly, Printed Circuit

Engine Monitor (IncludesFuses) (A11)

45 Fuse321030703 2 5 Amp (Tan) (F4, F5)321030706 1 15 Amp (Light Blue) (F3)321030707 2 20 Amp (Yellow) (F1, F2)

46 322036001 1 Light Assembly, Indicator(Includes Wiring Harness andConnector Housing) (A12)

47 322036901 1 Light, Indicator Replacement48 3220361 1 Light, Panel (DS11)49 3220004 1 Bulb, Panel Light

Replacement50 1930466 1 Gauge, Oil Pressure (M11)51 1930351 1 Gauge, Water Temperature

(M12)52 3021641 1 Voltmeter, DC (M13)53 3022002 1 Meter, Hour (M14)54 5170131 1 Plug, Hole (Fits 7/8 Hole)55 3081010 1 Switch, Rocker Lamp

Test/Reset Panel Lamp (S11)56 3081011 1 Switch, Rocker

Run/Stop/Remote (S12)57 8530008 1 Washer, Lock ET (#10)58 3005098 1 Board, Printed Circuit Sensor

Board (A27)59 5170302 1 Plug, Hole (Fits 21/4 Hole)

(Quantity Used As Required)60 5170301 1 Plug, Hole (Fits 2 Hole)

(Quantity Used As Required)61 3081082 1 Handle, Rotary Switch62 322043110 1 Lens, Replacement Check

Engine (DS19 or DS20)

50

2-Wire Control

1

2

3

4

56

7

8

9

10

11

12

13

14

15

16

17

1819

23

2425

26

27

28

29

30

30

31

32

35

3632

36

36

15

37

33

34

H562

202122

51

2-Wire Control


1 3193321 1 Box, Control2 3193322 1 Panel, Control Front3 3193326 1 Cover, Control4 3193324 1 Plate, Control Sets Without

Circuit Breaker5 3210175 1 Holder, Fuse6 3210353 1 Fuse (20 Amp)7 3072871 1 Relay, Timer8 3022002 1 Meter, Hour9 3323249 2 Block, Terminal

10 3050982 1 Regulator, Voltage (VR21)11 307267703 1 Relay (20 Amp) (K21)12 3081011 1 Switch, Rocker13 821600103 2 Screw, Hex Head

(M5 x 0.8 x 16)14 5081127 1 Bushing, Nylon15 821600203 10 Screw, Hex Head (M6 x 1 x 16)16 870206401 12 Nut, Lock Nylon (M4)17 5170133 1 Plug, Hole18 815092501 4 Screw, Slotted Flat Head

Thread Forming (M4 x 0.7 x20)

19 Harness, Control3383680 1 Spec A (Includes Parts

Marked *)3383733 1 Begin Spec B (Includes Parts

Marked #)20 3323564 1 *# Block, Terminal (TB1)21 3570030 1 *# Rectifier (6 Amp) (CR4)

(Mounted on K11 Relay)22 307281701 4 *# Relay (K11K14)23 Breaker, Circuit

3201941 1 2 Pin320182402 1 4 Pin

24 8602057 5 Nut, Hex (M6)25 8560006 5 Washer, Lock EIT (1/4)26 4020669 4 Isolator, Vibration27 Bracket, Control Saddle

4056098 1 Spec AC319497002 1 Begin Spec D

28 8560008 4 Washer, Lock EIT (5/16)29 8150236 4 Screw, Cap Hex Head

Thread Forming (5/1618 x5/8)

30 8702054 8 Nut, Locking Hex FlangeHead (M6)

31 3323573 1 Strip, Marker32 Cover, Circuit Breaker

319332501 1 Used With 2 Pole Circuit Breaker

3193339 1 Used With 3 Pole Circuit Breaker Spec A

319382401 1 Used With 3 Pole Circuit Breaker 480V Begin Spec B


33 Bracket, Mounting CircuitBreaker Used With 3 PoleCircuit Breaker

3193338 1 Spec A319382301 1 480V Begin Spec B3193646 1 600V Begin Spec B

34 870206401 4 Nut, Lock (M4) Used With 2Pole Circuit Breaker

35 8003042 4 Screw, Hex Head (M4 x 0.7 x10) Used With 2 PoleCircuit Breaker

36 Screw, Hex Head (M6 x 1 x 16)



37 Lead226477801 2 Used With 2 Pole Circuit

Breaker226477801 3 Used With 40100 Amp

Circuit Breaker226477803 3 Used With 1530 Amp

Circuit Breaker

* Parts Included in 3383680 Control Harness# Parts Included in 3383733 Control Harness

52

Wiring HarnessGenerator Sets With Detector Control

Spec AC

1

3

4

6

7

8

9

1011

14

16

19

2021

22

23

24

2526

33

34

35

5

12

13

15

17

18

2

5

9

1412

15

13

3

4

6

7

8

11

16

17

18

19

22

23

24

25

27

28

29

30 31

32

53


Spec AC


1 3383670 1 Harness, Wiring Engine toControl (Includes PartsMarked +) Spec A, B

2 3383796 1 Harness, Wiring Engine toControl (Includes PartsMarked *) Spec C

3 3231306 1 *+ Housing, Connector 8 Place(J1)



6 *+ Relay (K4)307281701 1 *+ Spec A, B307281701 2 *+ Spec C

7 3231200 12 *+ Socket, Contact (Used in J1,J2)8 3500980 1 *+ Resistor (510 Ohms) (Located

in Harness Sleeving at P7and P8 End)

9 3570030 1 *+ Rectifier, Silicon (6 Amp)10 351159942 1 + Resistor (24 Ohms) (Used on

TB1)11 3231492 3 *+ Socket, Contact (Used on E1)12 319200601 1 *+ Bracket, Terminal Mounting13 3320604 1 *+ Block, Terminal 5 Place (T26)14 3321043 4 *+ Jumper (T26)15 8150538 2 *+ Screw, Machine Round Head

Cross Recessed W/IT(832 x .50)

16 3231591 1 *+ Plug, Connector (Used in E1)

17 3231548 1 *+ Wedge, Plug (Used in E1)18 3231546 1 *+ Plug (Used in E1)19 3231302 11 *+ Pin, Contact (Used in J3)20 1660860 1 + Connector 2 Place (P8)21 1660849 1 + Wedge, Connector (Used in

P8)22 1912176 1 *+ Connector 1 Place (P7)23 1912181 3 *+ Socket, Contact (Used in P6)24 1912178 1 *+ Connector 3 Place (P6)25 1912177 1 *+ Socket, Contact (Used in P7)26 1660850 2 + Socket, Contact (Used in P8)27 3231765 1 * Housing, Connector 4 Pin

(S7)28 3231712 4 * Seal29 3231708 10 * Seal, Cable (S7) (P8)30 3231710 1 * Connector 10 Pin (P8)31 3231707 6 * Socket, Contact (Used in P8)32 3231719 1 * Housing, Lock (P8)33 3383682 1 Harness, Wiring AC Auxiliary

(Includes Parts Marked #)34 323164401 1 # Housing, Plug (J2)35 3231647 9 # Pin, Contact (Used in J2)

* Parts Included in 3383796 Engine to Control Wiring Harness

+ Parts Included in 3383670 Engine to Control Wiring Harness

# Parts Included in 3383682 AC Auxiliary Wiring Harness

54


Begin Spec D

34

35

36

4

9

1816

19

17

2

3

6

9

15

21

2223

25

28

29

30

3110

12

14

26

32

1

5

7

8

11

13

20

24

2733

55


Begin Spec D


1 338429801 1 Harness, Wiring Engine toControl (Includes PartsMarked *)

2 3231306 1 * Housing, Connector 8 Place(J1)



5 307281701 1 * Relay (K7)6 3231200 12 * Socket, Contact7 307296803 1 * Relay, Power (K4)8 307298202 1 * Bracket, Relay9 3500980 1 * Resistor (510 Ohms) (Located

in Harness Sleeving at P7End)

10 3231765 1 * Housing, Connector 4 Pin(S7)

11 8120079 2 * Screw, Machine Round Head(#832 x .50)

12 3231712 4 * Plug, Cavity (S7) (P8)13 8700221 2 * Nut, Hex W/ET (#832)14 3231708 10 * Seal, Cable (S7) (P8)15 3231492 3 * Socket, Contact16 319200601 1 * Bracket, Terminal Mounting17 3320604 1 * Block, Terminal 5 Place (T26)18 3321043 4 * Jumper (T26)

19 8150538 2 * Screw, Machine Pan Head Cross Recessed W/ET (832x .50)

20 332379201 1 * Cover, Terminal Block (IncludesSpring Clips)

21 3231591 1 * Plug, Connector (E1)22 3231548 1 * Wedge, Plug23 3231546 1 * Plug (4 Pin)24 3231709 3 * Socket, Contact (S7)25 3231302 11 * Pin, Contact26 3231710 1 * Connector 10 Pin (P8)27 3231719 1 * Housing, Lock (P8)28 1912176 1 * Connector 1 Place (P7)29 1912181 3 * Socket, Contact (P6)30 1912178 1 * Connector 3 Place (P6)31 1912177 1 * Socket, Contact (P7)32 3231707 7 * Socket, Contact (P8)33 416102102 1 * Boot34 3383682 1 Harness, Wiring AC Auxiliary

(Includes Parts Marked #)35 323164401 1 # Housing, Plug (J2)36 3231647 9 # Pin, Contact (J2)


# Parts Included in 3383682 AC Auxiliary Wiring Harness

56

Wiring HarnessGenerator Sets With 2-Wire Control

Spec AC

1

45

6

7

8

9

10

11

12

13

14

15

2

3

7

1410

8

9

15

1617

18

19

20

57


Spec AC


1 3383669 1 Harness, Wiring Engine toControl (Includes PartsMarked *) Spec A

2 3383734 1 Harness, Wiring Engine toControl (Includes PartsMarked ^) Spec B

3 3383795 1 Harness, Wiring Engine toControl (Includes PartsMarked +) Spec C

4 1660860 1 ^* Connector 2 Place (P8)5 1660849 1 ^* Wedge, Connector (Used in

P8)6 1660850 2 ^* Socket, Contact (Used in P8)7 1912177 1 +^* Socket, Contact (Used in P7)8 1912178 1 +^* Connector 3 Place (P6)9 1912181 3 +^* Socket, Contact (Used in P6)

10 1912176 1 +^* Connector One Place (P7)11 3231492 6 ^* Socket, Contact (Used in P2)12 3231541 1 ^* Plug, Connector 8 Place

(P2)

13 3231543 1 ^* Wedge, Plug (Used in P2)14 3500980 1 +^* Resistor (510 Ohms)

(Located in HarnessSleeving at P7 and P8 End)

15 3570030 1 +^ Rectifier, Silicon (6 Amp)(CR5)

16 3231710 1 + Connector 10 Pin (P8)17 3231707 6 + Socket, Contact (Used in P8)18 3231708 6 + Seal (P8)19 3231712 4 + Seal, Plug (P8)20 3231719 1 + Housing, Lock (P8)


^ Parts Included in 3383734 Engine to Control Wiring Harness

+ Parts Included in 3383795 Engine to Control Wiring Harness

58


Begin Spec D

5

139

6

8

14

24

10

11

1

3

712


1 338429901 1 Harness, Wiring Engine toControl (Includes theFollowing Parts)

2 3231710 1 Connector 10 Pin (P8)3 3231719 1 Housing, Lock (P8)4 3231707 7 Socket, Contact (P8)5 1912177 1 Socket, Contact (P7)6 1912178 1 Connector 3 Place (P6)

7 416102102 1 Boot8 1912181 3 Socket, Contact (P6)9 1912176 1 Connector One Place (P7)

10 3231708 7 Seal (P8)11 3231712 2 Seal, Plug (P8)12 307281701 1 Relay (K7)13 3500980 1 Resistor (510 Ohms)14 3570030 1 Diode (CR3)

59

Dry Contact2-Wire ControlBegin Spec B

6

8

710

9

1

23

4

5

11

12

H568


1 319360102 1 Panel, Relay2 307281701 2 Relay (K8, K9)3 821600102 2 Screw, Hex Head

(M5 x 0.8 x 12)4 821500005 4 Screw, Hex Head

(#1032 x 1/2)5 3383731 1 Harness, Wiring Control6 3383743 1 Harness, Wiring Dry Contact

(Includes Parts Marked #)

7 3231765 1 # Housing, Connector (4 Pin)8 3231712 A/R # Plug, Cavity9 3231709 A/R # Socket, Contact (Used in S7)

10 3231708 A/R # Seal, Cable11 8702204 4 Standoff, Hex (#1032)12 8700131 4 Nut, Hex W/ET (#1032)

# Parts Included in 3383743 Wiring Harness

60

Voltage RegulatorDetector Control

2

3

5

4

1

6

B240


1 3030261 1 Potentiometer (R21)2 3050982 1 Board, Printed Circuit Voltage

Regulator (Model SX460)(VR21)

3 3501222 1 Resistor (TB21)

4 815090508 4 Screw, Cross Recessed(#1032 x 7/8)

5 3322605 1 Jumper6 320168801 1 Breaker, Circuit (CB21)

61

Vacuum Switch

12

3

4

5

6

C059


1 5050011 1 Elbow, Street2 5050007 1 Bushing, Reducer

(1/4 NPT x 1/8 NPT)3 5050098 1 Nipple, Pipe (1/8 NPT x .75)

4 1481099 1 Switch, Vacuum5 3321794 A/R Tie, Cable6 3383667 1 Harness, Vacuum Switch

62

Control Door CoverGenerator Sets With Detector Control

Begin Spec E

1

2


1 300549802 A/R Cover, Control Door Meters 2 8700131 A/R Nut, Hex W/ET (#1032)

63

Circuit Breaker Mounting BracketDetector Control

1

2

3

4

5

6

KB16,17,KM03,04,05,06,07,08,09,10,11

7

8


1 Bracket, Mounting CircuitBreaker





2 818023102 4 Rivet, Pop3 Cover, Circuit Breaker





4 8003042 4 Screw, Hex Head (M4 x 0.7 x10) Used With 2 PoleCircuit Breaker

5 870206401 4 Nut, Lock (M4) Used With 2Pole Circuit Breaker

6 821600203 4 Screw, Hex Head (M6 x 1 x 16)

7 Lead226477802 2 Used With 2 Pole Circuit

Breakers226477802 3 Used With 40100 Amp

Circuit Breakers226477804 3 Used With 1530 Amp

Circuit Breakers8 508030502 Edging Bulk (Order By The

Foot 1 Foot Required) UsedWith 2 Pole Circuit Breakers

64

Circuit BreakerSpec A

1

3 4

2

KM03,04,05,06,07,08,09,10,11,KB16,KB17,K883,KL41


1 Breaker, Circuit2 Pole (UL)

320200603 1 90 Amp320200602 1 100 Amp

3 Pole (UL & IEC)320197509 1 * 30 Amp320197508 1 * 40 Amp320197507 1 * 45 Amp320197506 1 * 50 Amp320197505 1 * 60 Amp320197504 1 * 70 Amp320197503 1 * 80 Amp320197502 1 * 90 Amp320197501 1 * 100 Amp

2 320198604 1 Package, Hardware Circuit Breaker Mounting

(Includes Screws, Nuts and Lock Washers)

Accessories, Circuit Breaker: The following are used on 3201975XX Circuit

Breakers3 320197901 1 Contact, Auxiliary Switch4 320197902 1 Trip, Shunt (12V)

* Includes Mounting Hardware

65

Circuit BreakerBegin Spec B

1

3 4

2

KM34,KM33,KM32,KM31,KM95,KM94,KM93,KM92,K883,KL41,KB17,KB16


1 Breaker, Circuit2 Pole (UL)

320200603 1 90 Amp320200602 1 100 Amp

3 Pole (UL & IEC) (480V)320200910 1 * 20 Amp320200909 1 * 30 Amp320200908 1 * 40 Amp320200906 1 * 50 Amp320200905 1 * 60 Amp320200904 1 * 70 Amp320200903 1 * 80 Amp320200901 1 * 1000 Amp

3 Pole (UL & IEC) (600V)320195921 1 * 20 Amp320195920 1 * 30 Amp320195919 1 * 40 Amp320195918 1 * 50 Amp320195917 1 * 60 Amp320195910 1 * 70 Amp320195909 1 * 80 Amp320195908 1 * 90 Amp320195907 1 * 100 Amp

2 320198608 1 Package, Hardware Circuit Breaker Mounting (Includes Screws, Nuts and Lock Washers)

Accessories, Circuit Breaker: The following are used on 3201959XX Circuit

Breakers3 320198101 2 Switch Used as Auxiliary

Contact or Trip Alarm4 320198102 1 Trip, Shunt (12V)

* Includes Mounting Hardware

Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

66

0984500, 33, 35

0984730, 33, 35

0984732, 33, 35

0985429, 33, 35

0986195, 47

0987451, 35

0987868, 35

098790202, 33, 35

1010823, 9

102105401, 9

1041944, 9

1041951, 9

128015402, 33

1301793, 28, 29

1301798, 28, 29

1303552, 28, 29

1303570, 23

1303571, 23

1303572, 23

130372101, 28, 29

130477003, 28, 29

1304792, 28, 29

1304796, 28, 29

1304833, 28, 29

1304834, 26

1304835, 26

1304839, 28

1304846, 23

1304856, 28

130495802, 29

130495902, 29

130500302, 29

130511602, 29, 35

130511702, 29, 35

1400078, 22

1403146, 12

1403147, 12, 13

140319802, 12

140319902, 12

1403202, 12

140338701, 13

1450724, 15, 16, 17, 18,19, 20, 21

1480597, 15, 18, 20, 21

1480637, 16, 19, 20

1480737, 17, 21

1481099, 61

1481104, 15, 16, 17, 18, 19,20, 21

1492617, 20, 21

1492622, 17, 21

1500716, 40

1500723, 40

1500939, 37, 38

1501445, 40

1502550, 37, 38

1502620, 37, 38

1502651, 37, 38

150269201, 37, 38

1502694, 37, 38

150281102, 15, 16, 17, 18,19, 20, 21, 38

155036001, 22

1550927, 22

1551256, 15, 16, 18, 19,20, 21

1551924, 22

1551926, 22

1552715, 9

1552984, 9

1553242, 9

1660767, 41

1660844, 9

1660845, 9

1660849, 53, 57

1660850, 53, 57

1660860, 53, 57

1660867, 10

1660868, 9

166088401, 11

1912176, 53, 55, 57, 58

1912177, 53, 55, 57, 58

1912178, 53, 55, 57, 58

1912181, 53, 55, 57, 58

1912200, 36

1912213, 36

1912215, 36

1912216, 36

1912217, 36

1912218, 36

1912219, 36

1912221, 36

1912222, 36

1912263, 27

191226801, 28

191226802, 27

191227602, 29

1930351, 49

1930448, 9

1930451, 14

1930463, 14

1930466, 49

1930468, 23

1930477, 9

1930545, 38

2012151, 43

201351502, 45

201357306, 43

201357307, 43, 45

201360206, 45

2050258, 43, 45

211025602, 43, 45

2202009, 43

2202309, 45

220456306, 43

220456307, 43

220456406, 43

220456506, 43

220461306, 45

220461307, 45

220461406, 45

220461506, 45

226477801, 51

226477802, 63

226477803, 51

226477804, 63

2310386, 9

2322417, 43, 45

2322826, 43, 45

2323441, 9

2340498, 46

2340519, 43, 45

2340665, 9

2340993, 46

3004296, 49

3004324, 41

3005098, 49

300549802, 62

301905401, 49

301905501, 49

3021148, 49

3021473, 49

3021641, 49

3021753, 49

3021968, 49

3022002, 49, 51

3030261, 60

3050982, 51, 60

307026801, 17, 21

307031201, 15, 16, 18,19, 20, 21

307267703, 51

307281701, 20, 21, 51,53, 55, 58, 59

3072871, 51

307296803, 55

307298202, 55

3081010, 49

3081011, 49, 51

3081052, 49

3081082, 49

309064119, 9

3090662, 9

3090669, 18, 19

309066901, 20, 21

319200601, 53, 55

3193030, 49

3193312, 39

Numerical Index


67

3193313, 39

3193314, 63

319331501, 63

319331502, 63

319331507, 63

319331509, 63

3193316, 39

3193321, 51

3193322, 51

3193324, 51

319332501, 51

3193326, 51

3193337, 63

3193338, 51

3193339, 51

3193384, 41

319360102, 59

3193646, 51

3193647, 51

3193648, 63

319382301, 51

319382401, 51

319390502, 63

319497002, 39, 51

320168801, 60

320182402, 51

3201941, 51

320195907, 65

320195908, 65

320195909, 65

320195910, 65

320195917, 65

320195918, 65

320195919, 65

320195920, 65

320195921, 65

320197501, 64

320197502, 64

320197503, 64

320197504, 64

320197505, 64

320197506, 64

320197507, 64

320197508, 64

320197509, 64

320197901, 64

320197902, 64

320198101, 65

320198102, 65

320198604, 64

320198608, 65

320200602, 64, 65

320200603, 64, 65

320200901, 65

320200903, 65

320200904, 65

320200905, 65

320200906, 65

320200908, 65

320200909, 65

320200910, 65

3210175, 51

321030703, 49

321030706, 49

321030707, 49

3210353, 51

3220004, 49

322036001, 49

3220361, 49

3220363, 49

322036901, 49

322043110, 49

3231200, 53, 55

3231302, 49, 53, 55

3231304, 53, 55

3231306, 53, 55

3231308, 49

323137412, 53, 55

3231492, 9, 53, 55, 57

3231541, 57

3231543, 57

3231546, 53, 55

3231548, 9, 53, 55

3231549, 9

3231591, 53, 55

323164401, 53, 55

323164402, 49

3231647, 53, 55

3231648, 49

3231707, 53, 55, 57, 58

3231708, 23, 53, 55, 57,58, 59

3231709, 23, 55, 59

3231710, 53, 55, 57, 58

3231712, 53, 55, 57, 58, 59

3231719, 53, 55, 57, 58

3231765, 23, 53, 55, 59

3310041, 46

3320052, 49

3320604, 53, 55

3320607, 49

3320942, 47

3321043, 53, 55

3321355, 43, 45

3321389, 23

3321554, 37, 38

3321789, 47

3321794, 61

3321992, 47

3322420, 47

3322430, 47

3322605, 60

3322634, 9, 15, 16, 17, 20,21, 28, 29

3322697, 47

3322723, 49

3323249, 39, 51

3323564, 51

3323573, 51

332379201, 55

3330184, 46

3330228, 46

333055001, 47

333058801, 24

333058802, 24

3330624, 24

3350110, 47

3350173, 47

3370049, 49

3370090, 9

3382278, 49

3383252, 49

3383429, 49

3383594, 23

3383654, 17, 21

3383667, 61

3383669, 57

3383670, 53

3383680, 51

3383682, 53, 55

3383698, 20, 21

3383731, 59

3383733, 51

3383734, 57

3383740, 18, 19

3383743, 59

3383795, 57

3383796, 53

3383816, 20, 21

3384288, 9

338429801, 55

338429901, 58

3500980, 55, 57, 58

3501222, 60

351159942, 53

3550189, 49

3570030, 51, 53, 57, 58

3570114, 47

3580069, 43, 45

3580070, 43, 45

4020282, 30

4020285, 30

4020286, 30

4020290, 30

4020527, 49

4020669, 51

Numerical Index


68

4031830, 30

4033795, 30

4034254, 30

4034255, 30

403504101, 30

4051872, 33, 35

4051889, 33, 35

4054932, 33, 35

4056097, 33, 35

4056098, 39, 51

4056162, 33, 35

4056163, 33, 35

4056164, 33, 35

4056167, 33, 35

4056168, 33, 35

4056169, 33, 35

4056170, 33, 35

4056195, 35

4056196, 35

4056197, 35

4056199, 35

405620002, 35

405620102, 35

4056202, 33, 35

405622802, 35

405622902, 35

405623102, 35

4056235, 35

4056236, 35

4060332, 49

4060333, 49

4060334, 49

4060614, 33

4060615, 33, 35

4160549, 9

4160961, 30

4161019, 9

416102102, 55, 58

4161045, 9

4161046, 9

4161084, 9

4161164, 31

416116502, 31

5020153, 28, 29

5020613, 24

5020870, 24

5020942, 17, 21

5030098, 9

5030131, 17, 21

5030183, 24, 28, 29

5030197, 9

5030386, 17, 21, 24, 28

5030429, 28, 29

5030446, 13

5030685, 25

5030869, 27

5030977, 29, 35

5031138, 27

5031274, 25

5031606, 12, 13

503187005, 13

5032085, 28, 29

5032092, 28, 29

5032159, 10

503215901, 38

503218501, 29

5032247, 13

5040011, 9

5040028, 9

5040171, 20, 21

5040198, 9

5050002, 15, 16, 17, 18,19, 20, 21

5050007, 9, 14, 18, 19, 20,21, 61

5050011, 61

5050021, 15, 16, 18, 19, 21

5050025, 33, 35

5050032, 33, 35

5050040, 17

5050043, 22

5050051, 18, 19

5050054, 9

5050071, 14

5050078, 17

5050084, 20, 21

5050085, 15, 16, 18, 19

5050098, 61

5050099, 17, 21

5050102, 15, 16, 18, 19,20, 21

5050106, 17

5050110, 9

5050132, 15, 16, 18, 19,20, 21

5050150, 20, 21

5050158, 17, 21

5050167, 20, 21

5050184, 14

5050210, 17, 20, 21

5050332, 20

5050395, 9

5050462, 22

5050754, 15, 16, 18, 19,20, 21

5050827, 9

5051496, 18, 19, 20, 21

5080051, 49

508030502, 39, 63

5081127, 51

5090094, 43, 45

5100112, 43, 45

5170094, 15, 16, 18, 19,20, 21

5170131, 49

5170133, 51

517013809, 33, 35

5170289, 12

5170301, 49

5170302, 49

5180601, 7

5200799, 43, 45

5200800, 43, 45

5201014, 12

5201028, 15, 16, 17, 18,19, 20, 21

5250304, 7

5250305, 7

5250306, 7

5260003, 33, 35

5260008, 43, 45

5260014, 30

5260018, 37, 38, 49

5260077, 40, 41

5260122, 30

5260124, 41

5260141, 28, 29

5260174, 30

5260179, 9

526039911, 43

526039913, 17, 21

526039942, 43, 45

5262100, 15, 16, 17, 18,19, 20, 21

5262120, 9

8000008, 37, 38

8000024, 47, 49

8000045, 49

8000051, 40, 41

8000081, 30

8000519, 43, 45

8000602, 37, 38

8002010, 10

8002011, 11

8002015, 9

8002040, 30

8002056, 27

8002057, 30

8002071, 28, 29

8002086, 9, 30

8002088, 9

8002089, 9

8002093, 9

8002095, 30

8003042, 51, 63

8020038, 43

802004001, 45

8030032, 9

8050015, 43, 45

Numerical Index


69

8120079, 55

8120084, 33

8120167, 46

8130100, 43, 45

8130107, 38

8150194, 28, 29, 43, 45

8150236, 39, 51

8150385, 49

8150388, 49

8150538, 53, 55

815079303, 10

8150823, 40

815086513, 41

815087502, 49

815090106, 49

815090508, 49, 60

815092501, 51

8160152, 28, 29

8180006, 43, 45

8180150, 33, 35

818023102, 26, 29, 33,35, 63

8210004, 49

8210010, 33, 35, 40, 43, 45

8210014, 39

8212032, 27

8212033, 28, 29

8212034, 23

8212050, 22

8212060, 24

821500005, 49, 59

821500204, 41

821600102, 33, 35, 59

821600103, 39, 51

821600203, 24, 39, 51, 63

821600204, 31

821600302, 26, 28, 29,33, 35

821600303, 15, 16, 17,18, 19, 20, 21, 23

821600702, 29, 35

8500040, 37, 38, 43, 46

8500045, 49

8500050, 41

8500055, 30

850011405, 45

850011407, 43, 45

8502004, 41

8502005, 9, 10, 11

8502008, 27, 28, 29

8502010, 9

8502056, 30

8530008, 43, 45, 49

8530013, 40

8560006, 39, 51

8560008, 39, 47, 49, 51

8560009, 30

8560010, 9, 40

8602005, 41

8602006, 9, 10, 11

8602057, 51

8620001, 40

862002607, 43, 45

8650006, 12

8650020, 12

8700131, 37, 38, 43, 45,49, 59, 62

870013101, 43

8700183, 49

8700212, 37, 38

8700221, 33, 55

8700250, 40

8700257, 28, 29, 30, 47

8700258, 33, 35

8700281, 28, 29

8701220, 49

8702054, 51

8702055, 9, 15, 16, 17, 18,19, 20, 21, 22

870206401, 51, 63

8702204, 59

8710015, 49

8950387, 33, 35

8980860, 47

898119501, 47

LF3501, 9

Cummins Power Generation1400 73rd Ave. NEMinneapolis, MN 55432 USA

Phone 1 763 574 5000Toll-free 1 800 888 6626Fax 1 763 574 5298Email [email protected], the C logo, and Our energy working for you.are trademarks of Cummins Inc.

2009 Cummins Power Generation, Inc. All rights reserved.

Documents

928-0233 I6 200910 - skilledcrafting.com Onan GGDB (spec A-E... · 1 Introduction This parts catalog applies to the Cummins Power Generation standard generator model GGDB as listed