MM15M3

MODEL NUMBER : USB868PR(3.5W/2BAND)MP8628PR RF ( 1.5 W/2BAND) CUSTOMERS MODEL NUMBER: BRAND: TYPE OF SET : MUSIC CENTER DATE: 2007.08.25

STANDARD TEST CONDITIONS SUPPLY VOLTAGE: DC : V, AC : 230 V 50 Hz REFERENCE OUTPUT POWER : 50 Mw INTO 4 OHM LOAD AM ANTENNA : IRE LOOP ANT. AM STANDARD SIGNAL : 400 Hz , 30% MODULATION FM ANTENNA : 75 OHMS , UN BALANCED FM STANDARD SIGNAL MONO : 1 KHz , 22.5 KHz DEVIATION FM STANDARD SIGNAL (STEREO): 1 KHz , 75 KHz DEVIATION

1 UV= 0 dB FOR RADIO FREQUENCY 1 V = 0 dB FOR AUDIO FREQUENCY

ELEC ENCR: APPROVER: MANAGER:

of 7 AM PERFORMANCE SPECIFICATIONS (MW)No. Test Items Unit Nominal Limit Remark1

1 Intermediate frequency KHz 450 +/-5

2 Tuning range KHz 522-16203 Dial calibration 603KHz KHz

1404KHz KHz

603KHZ uV/M

4 uV/M

1404KHz uV/M

uV/M 1000 1500

5 uV/M 1000 1200

uV/M 1000 1200

6 dB 45 35

7 dB 35 30

8 S/N ratio 5mV/M input dB 40 30

9 AGC figure of merit 100mV/M dB

10 A.C.A at 20dB S/N +/-10KHz dB

11 -6dB band width at 20 dB S/N KHz 8 5-1012 T.H.D 5mV/M 30% mod % 1 3

100m/V/M 80% mod % 3 5

13 Modulation hum 100mV/M dB 40 35

14 Frequency response -6dB low Hz 60 100

400 Hz=0dB, 5mV/M high Hz 2200 1800

15 Output power %mod, 5mV/M W

16 10% THD power 80% mod, 5mV/M W

17 Hum & Noise level VR min mV 1 3

18 Whistle at 5mV/M IFX2, FIX3 %

19 Spurious response at 1400 KHz

2.5 MHz - 10MHz dB

20 AM signal meter 5mV/M %

21 Record beat 5mV/M %

22 FAIL OUT VOLTAGE (DC) V

(AC) %

603 KHz dB 93 96

23 AUTO STOP SENS 999 KHZ dB 93 96

1404KHZ dB 93 96

Max sensitivity 999KHz

20 dB quieting 603KHz

999KHz

sensitivity 1404KHz

IF rejection 603KHz

Image rejection 1404KHz

FM PERFORMANCE SPECIFICATIONS

No. Test Items Unit Nominal Limit Remark1

1 Intermediate frequency MHz 10,7

2 Tuning range MHz 87.5-1083 KHz

uV 10 20

5 uV 10 20

uV 10 20

6 dB 50 45

7 S/N ratio1mV input 22.5 KHz dev dB 50 45

8 3 dB limiting sensitivity dB 10 20

9 T.H.D 22.5 KHz dev % 0,65 1

10 AM suppression dB 32 26

11 Modulation hum100mv 22.5KHz dev dB 40 35

12 AFC hold rang - 3 dB l mV KHz

13 Frequency response -6dB Hz 60 100

with usec pre-emphasis KHz 3 2,5

14 Overload break mV

15 Output power 32 KHz dev 1mV W

16 10% THD power 40KHz dev. 1mV W 1,5 1,5

17 Hum & Noise level VR MIN mV 1 3

18 Spurious response dB

19 Muting on level uV

20 Muting bandwidth KHz

21 Alternate channel selectivity 0.1 mV

input +/- KHz dB

22 Capture ration 1mV dB

23 FAIL OUTPUT VOLTAGE (DC) V

(AC) % 80 85

90.1MHz dB 20 2624 AUTO STOP SENS 98.1MHz dB 20 26

106.1MHz dB 20 26

of 7FM PERFORMANCE SPECIFICATIONS

NO. Test items Unit Norminal Limit Remark1

+/-0.1

Dial calibration 90.1MHz

106.1MHz

90.1KHZ

Max sensitivity IHF 98.1MHz

106.1MHz

30 dB quieting 90.1MHz

98.1MHz

sensitivity 106.1MHz

IF rejection 90.1MHz

25 MPX indicator sens. uV 10 20

100Hz dB W/Z 19KHz

26 MPX separation 1k Hz dB 30 20 FILTER

10K Hz dB

27 MPX T.H.D. Main 400 Hz % 1,5 3 W/Z 19KHz L. or R. 1K Hz % 1,5 3 FILTER

4 MAX 50dB quieting

28 Sensitivity 98MHz dB

28 MPX S/N ratio dB 36 30 W/Z 19KHzFILTER

30 FM signal meter %

31 SCA Signanl Suppression dB

of 7 CASSTETTE ( MAGNET ERASE )NO. Test items Unit Nominal Limit Remark1

1 Tape speed B-111N % 3000Hz +3,-22 Wow & Flutter WRMS JIS B-111N % 0,1 0,353 Distortion B-118N % 1 34 S/N ratio B-112S dB 45 355 Cross talk B-121N dB 35 286 Separation B-141N dB 30 257 Hum & noise VR Max mV 30 708 Hum & noise VR min mV 1 3

Frequency response 125 Hz dB 09 1000 Hz dB 0 0

Play Back (B-257C) 8000 Hz dB 010 Output level mV11 10% THD power B-112BN W 2 1,812 Max power B-112BN W

S/N Recording/P.B. Normal dB 30 2513 at -62 dbv, 1k Hz Cro2 dB

CD PLAY, SONY 3 - 16 Matal dBErase ratio Normal dB 30 25

14 at -59 dbv, 1k Hz Cro2 dBCD PLAY, SONY 3 - 16 Matal dBRec/P.B. Level Normal dB 0 REF:B-212

15 at -66 dbv, 1k Hz Cro2 dBCD PLAY, SONY 3 - 18 Matal dB

16 Line input sensitivity dB17 Mic input sensitivity dB18 Peak level 1 dB

Peak level 2 dBFrequency response Rec./P. 125 Hz dB 0

19 FM 98 MHZ 22.5 KHZ 1000Hz dB 0 075 USEC PRE-EMPHASIS 6300Hz dB 0Rec./ P.B. distorion Normal % 5 8

20 -66 dBV, 1K Hz Cr02 %CD PLAY, SONY 3-18 Metal %

21 AlC Rec. /P.B. distortion -56 dbv % 6 10input 1K Hz CD PLAY, SONY 3-14

22 FAIL OUTPUT VOLTAGE (DC) V (AC) % 80 85

(CD BUIDE IN) (TEST AT SPKD OUTPUT)

of 7 COMPACT DISC PALYER

NO. Test items Unit Nominal Limit Remark1

1 LEVEL 0dB TRACK 1.4,11 dB 0,5 +/-4

FREQUENCY RESPONSE 40 - 20KHz dB

2 LEVEL 0dB TRACK 30,34 dB 40 30 JIS A NET IN

CHANNEL SEPARATION 1KHz

3 LEVEL 0dB TRACK 14 % 0,2 0,5 JIS A NET IN

TOTAL HARMONNIC DISTORTION

4 LEVEL 0dB TRACK 1, 23 dB 55 50 JIS A NET IN

S/N RATIO

5 LEVEL 0dB Verm

OUT PUT LEVEL

6 LEVEL 0dB TRACK 1 dB 0

UNBALANCE L/R

7 10% THD POWER SONY 3 TRACK 1 W 1,5 1,5

8 CD SAME VOL dB

PLAYABILITY

NO TEST ITEMS TEST

1 DEFECT DISC INTERRUPTION PHILIPS PLAYABLE WITHOUT ANY

5A AUDIBLE ERROR

INFORMATION LAYER 600um

2 PHILIPS PLAYABLE WITHOUT ANY

BLACK DOT AT READ OUT SIDE 5A AUDIBLE ERROR

3 PHILIPS

SIMULATED FINGERPRINT 5A PLAYABLE WITHOUT ANY

TRACK AUDIBLE ERROR

ACCESS TIME PHILIPS

START - UP 1ST TRACK </= 5SEC

SHORT ACCESS TIME TR 1< - >2 </= 3 SEC

LONG ACCESS TIME TR 1 < - > UNIT </= 10 SEC

TEST DISC TYPE 3 (SONY YEDS - )

2 X OVERSAMPLING, 16 BIT D/A CONVERTERpage 7 of 7

AUDIO LEVEL BALANCE

No. Unit Norminal Limit Remark1

FM 1000uV 22.5K DEV. +6

FM FUNC.1mV AM 5mV/M30%MOD +/-322.5KHz DEV TAPE - 10dB 1KHz MTT-118 +/-3(FM LEVEL 0dB) CD-10 dB RECORDING LEVEL +/-3

TAPE.sch-1 - Fri Jun 06 09:35:42 2008

UC8628PRS RADIO.sch-1 - Fri Jun 06 09:27:48 2008

1008-MCU.sch-1 - Fri Jun 06 09:32:52 2008

Sheet2

第5页

Sheet2

第6页

Sheet2

第7页

PAGE:9/20Print:23/07/2009

PACIFIC TECH ELECTRONIC LTD.Bills Of Material

MP/USB/UC8628PRS 1.5W (光星高频头+CMC+MTK方案) 料单制作日期：2007-08-25

PART NO QTY DESCRIPTION

004-862800-01 1

(7132 00-M-0PbF FM/AM/RDS)

158-8628801-01 1 8628PR MB ASS’Y133-202025-67 1 IC2133-02313L-00 1 I.C PT2313 IC7133-517805-61 1 KA78L05AZTA IC9131-240882-67 1 PS B882P Q4

131-220772-84 1 TRANSISTOR 772 Q3

131-240363-67 1 TRANSISTOR 2HB363(TO-126) Q20.

131-449014-03 1 TRANSISTOR JE 9014C Q16

131-520945-25 4 TRANSISTOR 2SC945 Q10.11.12.17.

131-448050-35 4 TRANSISTOR 2SD8050 Q7.202.203.19

131-448550-03 2 Q5.21.

130-134148-00 3 D11.14.15.

130-410082-00 2 DZ2.ZD4

130-410010-00 1 ZD1

130-314002-00 4 D5.6..12.13

182-222000-00 1 FUSE T2AL 250V(5*20MM) F 2

733-005020-00 2 FUSE HOLDER (5*20 MM) FOR F2

105-100101-05 1 L6

160-102255-01 1 PIN SOCKET 2PIN 2.5MM CN3.

160-104255-01 1 PIN SOCKET 4 PIN 2.5MM CN301

160-216106-02 1 Connector-FFC R/A type 16PIN 1.0mm CN403

160-212125-02 1 FFC/FPC Connector S/T type 12PIN 1.25mm CN401

718-020040-00 3 BRASS EYELET DIA 2*4mm

C16-005000-00 25 JUMPER WIRE 40*0.5MM

113-220005-12 1 CAR RESISTOR 22 OHM1/16W +/-5% R22

113-101005-12 1 CAR. RESISTOR 100 OHM 1/16W +/-5% R1

113-151005-12 2 CAR. RESISTOR 150 OHM 1/16W +/-5% R28.38.

113-331005-12 2 CAR. RESISTOR 330 OHM 1/16W +/-5% R91.92.

113-471005-12 4 CAR. RESISTOR 470 OHM 1/16W +/-5% R7.8.17.18.

113-102005-12 4 CAR. RESISTOR 1K 1/16W +/-5% R5.82.83.103.

113-103005-12 2 CAR. RESISTOR 10K 1/16W +/-5% R95.96

113-222005-12 2 CAR. RESISTOR 2.2K 1/16W +/-5% R35.75

113-272005-12 2 CAR. RESISTOR 2.7K 1/16W +/-5% R79.81.

113-332005-12 2 CAR. RESISTOR 3.3K 1/16W +/-5% R6.13.

113-392005-12 1 CAR. RESISTOR 3.9K 1/16W +/-5% R3

113-472005-12 8 CAR. RESISTOR 4.7K 1/16W +/-5% R10.12.27.34.85.87.106.107.

113-562005-12 3 CAR. RESISTOR 5.6K 1/16W +/-5% R20.109.110

113-682005-12 2 CAR. RESISTOR 6.8K 1/16W +/-5% R.89.90

113-103005-12 6 CAR. RESISTOR 10K 1/16W +/-5% R25.26.33.86.93.97.

113-123005-12 2 CAR. RESISTOR 12K 1/16W+/-5% R31.32.

113-183005-12 2 CAR. RESISTOR 18K 1/16W+/-5% R78.80

113-393005-12 2 CAR. RESISTOR 39K 1/16W+/-5% R84.88.

113-104005-12 4 CAR. RESISTOR 100K 1/16W +/-5% R16.19.36.74.

KST-MP104MA1-3 20060125 光星高频头

IC. TEA2025B(质量要好)

TRANSISTOR 2SD8550(STS/C8550禁用）DIODE 1N4148 （带式）ZENER DIODE 8.2V（带式）ZENER DIODE 10V（带式）DIODE 1N4002 （带式）

CHOKE COIL 10UH(色环电感）（带式）

PAGE:10/20Print:23/07/2009

113-334005-12 2 CAR. RESISTOR 330K 1/16W +/-5% R94.98.

123-501340-13 2 C.CAP 500PF NPO +/-5% 50V C.77.78.

123-272350-16 2 C.CAP 2700PF +/-10% 50V C123.124.

126-153071-01 2 C118.119.

123-203350-16 4 C.CAP 0.02UF +/-20% 50V C3.4.5.6.

123-104350-16 11 C.CAP 0.1UF +/-20% 50V C10.13.51.122.125.126.127.128.129.130.131.

126-224071-01 2 MYLAR CAP 0.22UF +/-20% 50V C24.25

127-225078-31 6 ELE.CAP 2.2UF/50V MINI-SIZE +80-20% C45.46.47.48.62.63

127-475078-31 10 ELE.CAP 4.7UF/50V MINI-SIZE +80-20% C14.19.31.43.44.53.60.61.73.75.

127-476078-31 1 ELE.CAP 47UF/50V MINI-SIZE +80-20% C27

127-226048-31 1 ELE.CAP 22UF/16V MINI-SIZE +80-20% C.41

127-476048-31 1 ELE.CAP 47UF/16V MINI-SIZE +80-20% C.9

127-107048-31 8 ELE.CAP 100UF/16V MINI-SIZE +80-20% C18.20.28.29.32.42.49.74.

127-227058-01 1 ELE.CAP 220UF/25V +80/-20% C57.

127-477058-01 5 ELE.CAP 470UF/25V +80/-20% C16.17.34.50.59.

127-108058-01 1 ELE.CAP 1000UF/25V +80/-20% C71.

127-338058-01 1 ELE.CAP 3300UF/25V +80/-20% C23.

190-862801-01 1

158-862801-03 1 UC8628PR DISPLAYER PCB ASS’Y(MTK)133-808628-18 1 CMCTEK CPU QFP44PINS (UC8628PR) U1133-024C02-1A 1 U3

137-169344-30 1 X1

130-134148-00 1 D101

130-314002-00 1 D3

130-311N60-00 1 D.2

130-520523-01 1 LED EL204 HD RED 3MM D4

131-449014-1A 2 TRANSISTOR 9014 SMT

160-W1016-21 1 CONNECTOR-FFC R/A TYPE 16PIN 1.0mm CN2

135-092601-03 1 LCD DISPLAY H043933-03

187-410868-00 1

147-110143-00 12 TACT SWITCH H:4.3MM/4 TERMINAL SW12.13.14.15.16.17.18.19.20.21.22.23.

136-316038-00 1 OPTIC R/C REC MORULE FM-6038LM-5A

113-331005-12 1 CAR. RESISTOR 330OHM 1/16W +/-5% R57

113-102005-12 4 CAR. RESISTOR 1K 1/16W +/-5% R4.5.6.60.

113-332005-12 1 CAR. RESISTOR 3.3K 1/16W +/-5% R.75

113-513005-12 2 CAR. RESISTOR 51K 1/16W +/-5% R29.31.

C16-005000-00 22 JUMPER WIRE 40*0.5MM

127-105048-31 1 ELE.CAP 1UF/16V MINI-SIZE +80-20% CE6

127-106048-31 1 ELE.CAP 10UF/16V MINI-SIZE +80-20% CE4

127-476048-31 1 ELE.CAP 47UF/16V MINI-SIZE +80-20% CE1.

113-00005-63 2 CAR RESISTOR 0 OHM 0603 R74.77

113-100005-63 1 CAR RESISTOR 10 OHM 0603 R47

MYLAR CAP 0.015UF +/-20% 50V

UC8628PR PLL MB PCB 94V0料

I.C ATC24LC02 (贴片型)

CRYSTAL 16.9344MHz +/-5PPM(两脚矮体)

DIODE 1N4148（带式）130-410036-00 ZENER DIODE 3.6V（带式）

DIODE 1N4002 （带式）DIODE 1N60 （带式）

131-448550-1A TRANSISTOR 2SD8550 SMT (KEC.BKD33) Q1.2.3.4.5.6.7.8. (注:用质量好的)

Q9.10 ( 注:用质量好的)

(与UC926PRMTK用同一款LCD)

FH-0144-B 蓝色背光源(颜色按生产细则定料) D5(与UC926PRMTK用同一款背光源)

REM1 注: 用 5V

(有Ｅ３标志）

PAGE:11/20Print:23/07/2009

113-330005-63 5 CAR RESISTOR 33 OHM 0603 R37.38.39.52.59

113-221005-63 1 CAR RESISTOR 220 OHM 0603

113-331005-63 6 CAR RESISTOR 330 OHM 0603 R46.53.54.56.67.68.

113-471005-63 1 CAR RESISTOR 470 OHM 0603 R.49

113-102005-63 1 CAR. RESISTOR 1K 0603 R8.

113-122005-63 1 CAR. RESISTOR 1.2K 0603 R10

113-152005-63 1 CAR. RESISTOR 1.5K 0603 R43

113-272005-63 1 CAR. RESISTOR 2.7K 0603 R9

113-332005-63 4 CAR. RESISTOR 3.3K 0603 R2.48.70.71.

113-472005-63 1 CAR. RESISTOR 4.7K 0603 R73

113-512005-63 1 CAR. RESISTOR 5.1K 0603 R3

113-682005-63 1 CAR. RESISTOR 6.8K 0603 R65

113-103005-63 10 CAR. RESISTOR 10K 0603 R1.7.40.41.44.45.50.51..58.72.

113-123005-63 1 CAR. RESISTOR 12K 0603 R66

113-333005-63 1 CAR. RESISTOR 33K 0603 R55.

113-513005-63 6 CAR. RESISTOR 51K 0603 R.30.32.33.34.35.36.

113-104005-63 21 CAR. RESISTOR 100K 0603 R11.12.13.14.15.16.17.18.19.20.21.22.23.

R24-28.42.61

113-204005-63 2 CAR. RESISTOR 200K 0603 R63.64.

123-200340-63 2 C.CAP 20PF NPO 50V 0603 C2.3

123-101340-63 9 C.CAP 100PF NPO 50V 0603 C10.11.12.13.14.15.16.21.22.

123-104350-63 6 C.CAP 0.1UF 50V 0603 C1.9.17.18.20.23.

190-862801-03 1 UC8628PR KEY PCB ASS’Y

158-862801-02 1 UC8628PR USB+CARD

160-004100-02 1 USB1

127-476048-31 1 ELE. CAP 47UF/16V MINI-SIZE +80-20% C11

184-350613-00 4 FERRITE BEAD 3.5*6*1.3MM

127-476048-31 1 ELE. CAP 47UF/16V MINI-SIZE +80-20% C76

004-130408-01 1 3N1 MEMORY CONNECT FOR SDMS CARD SD1

190-862801-02 1 UC8628PR USB+CARD

158-005671-00 1 MTK MP USB SD PCB ASS‘Y133-005671-8B 1 U3

133-304004-1C 1 GM71C17400CJ6(4*4M) U5.133-302510-8B 1 U1

133-001469-67 1 MM1469 (DC OUT 3.3V) U2

133-507805-15 1 Q9130-134148-00 2 D1.4

130-314002-00 1 D2

131-448050-03 1 TRANSISTOR JE8050C Q1.131-448550-03 2 TRANSISTOR 8550 Q6.8.

R69(用于蓝色背光源,颜色按生产细则要求)

USB.SD 用料

有USB 卡用料USB A TYPE FEMALE CONNECTOR (贴板式)

有SD 卡用料

SDCARD 座与USB 801同款式

M5671 （CPU IC）

P10-50GCP （同CPU配套发料）

78M05 (粘片型)

DIODE IN4148 （带式）DIODE IN4002（带式）

PAGE:12/20Print:23/07/2009

PART NO QTY DESCRIPTION137-169344-30 1 Y1105-330101-05 2 CHOKE COIL 33UH (NEW) L1. 7 184-354708-05 6 CHOKE COIL RH 3.5*4.7*0.8-T52 L.2.3.4.5.6.8160-102205-01 1 PIN SOCKET 2PIN 2.0MM CN8160-102255-01 1 PIN SOCKET 2PIN 2.5MM CN3.160-104205-01 1 PIN SOCKET 4PIN 2.0MM (RED COLOUR) CN9160-104205-01 1 PIN SOCKET 4PIN 2.0MM CN6.160-105205-01 1 PIN SOCKET 5PIN 2.0MM CN7160-106205-01 1 PIN SOCKET 6PIN 2.0MM CN2

160-216106-02 1 Connector-FFC R/A type 16PIN 1.0mm CN1113-109005-12 1 CARBON RESISTOR 1 OHM 1/16W R48.113-109105-12 1 CARBON RESISTOR 1 OHM 1/4W R24.113-150005-12 1 CARBON RESISTOR 15 OHM 1/16W R50.113-330005-12 1 CARBON RESISTOR 33 OHM 1/16W R57113-331005-12 1 CARBON RESISTOR 330 OHM 1/16W R43113-471005-12 1 CARBON RESISTOR 470 OHM 1/16W R25113-102005-12 2 CARBON RESISTOR 1K 1/16W R36.J47113-472005-12 3 CARBON RESISTOR 4.7K 1/16W R23.35.61113-512005-12 1 CARBON RESISTOR 5.1K 1/16W R37.113-682005-12 3 CARBON RESISTOR 6.8K 1/16W R72.73.74113-103005-12 13 CARBON RESISTOR 10K 1/16W R.2.3.4.9.16.17.18.20.21.22.46.49.51.113-223005-12 1 CARBON RESISTOR 22K 1/16W R28.113-333005-12 1 CARBON RESISTOR 33K 1/16W R44.113-104005-12 3 CARBON RESISTOR 100K 1/16W R7.53.107.123-220340-13 2 C.CAP 22PF C26.27.123-560340-13 3 C.CAP 56PF C50.52.53123-102350-16 4 C.CAP 0.001UF C8.14.55.56123-103350-16 2 C.CAP 0.01UF C5.10113-103005-12 1 CARBON RESISTOR 10K 1/16W123-47350-16 1 C.CAP 0.047UF C18123-104350-16 30 C.CAP 0.1UF C1.2.3.4.6.7.11.12.13.15.16.17.19.20.23.24.25.

C28.29.30.31.32.33.34.35.36.39.49.SS3.54. 123-104350-30 5 C40.41.42.43.C*127-105078-01 3 E.CAP 1UF/50V C22.TC5.6.127-225078-01 2 E.CAP 2.2UF/50V TC2.4127-106048-01 4 E.CAP 10UF/16V TC3.9.10.17.127-476048-01 1 E.CAP 47UF/16V TC11127-107048-01 6 E.CAP 100UF/16V TC8.12.13.14.15.16127-227048-31 3 E.CAP 220UF/16V MINI-SIZE +80-20% TC1..18.33127-477048-31 2 E.CAP 470UF/16V MINI-SIZE +80-20% TC.7.9

113-561005-12 1 CARBON RESISTOR 560 OHM 1/16W R75130-410043-00 1 ZENER DIODE 4.3V ZD1

131-448050-03 1 TRANSISTOR JE8050C Q18127-227048-01 1 E.CAP 220UF/16V TC20

有ＵＳＢ卡用料

CRYSTAL 16.9344MHZ (矮体铁壳)

由R23原接复位脚的一端到PD8

C.CAP 0.1UF (加长脚 L=30MM)

有USB SD时用料

PAGE:13/20Print:23/07/2009

PART NO QTY DESCRIPTION113-330005-12 3 CARBON RESISTOR 33 OHM 1/16W R1.27.29.113-102005-12 2 CARBON RESISTOR 1K 1/16W R93.96. 113-472005-12 1 CARBON RESISTOR 4.7 K 1/16W R68113-103005-12 4 CARBON RESISTOR 10K 1/16W R26.85.91.100113-103005-12 1 CARBON RESISTOR 10K 1/16W R69.123-150340-13 2 C.CAP 15PF C51.46.123-104350-16 4 C.CAP 0.1UF C21.38.44.45.127-474078-01 1 E.CAP 0.47UF/50V TC22.127-227048-01 3 E.CAP 220UF/16V TC21.23.. C47.184-354708-05 1 CHOKE COIL RH 3.5*4.7*0.8-T52 L8

131-448050-03 1 TRANSISTOR JE8050C Q14.131-220764-04 1 TRANSISTOR 2SB764D Q11.

C01-010000-00 1 UL PVC TUBING 1.0*15mm FOR Q11137-240044-30 1 Y2

133-000000-8B 1 CH374S U8160-105205-02 1 PIN SOCKET 5PIN 2.0MM (RED COLOUR) CN5

3 R64.65.66.113-102005-12 1 CARBON RESISTOR 1K 1/16W R55113-472005-12 3 CARBON RESISTOR 4.7K 1/16W R54.86.87.113-103005-12 1 CARBON RESISTOR 10K 1/16W R31123-101340-13 3 C.CAP 100PF NPO C57-59127-227048-01 1 E.CAP 220UF/16V TC19

131-448050-03 1 TRANSISTOR JE8050C Q15.160-110205-01 1 PIN SOCKET 10PIN 2.0MM CN4

184-090503-00 1 FERRITE BEAD 9*5*3MM +CHOKE COIL FOR T101

C16-005000-00 72 40*0.5MM J1-58.R8.11.13.19.38.43.47.52.56.120.102.013.

C01-010000-00 10 UL PVC TUBING 1.0*15mm FOR C40.41.42.43.Q11C01-010010-00 1 UL PVC TUBING 1.0*10MM190-005671-00 1 MTK MP3

158-990803-01 1 CASSETTE PCB MIC 9908 ASS'Y133-207312-11 1 IC AN7312 IC201131-448050-03 1 TRANSISTOR SS8050 Q201

130-134148-00 2 DIODE 1N4148 D201-02

102-819908-01 1 BIAS COIL 21364-230 T201

102-819908-02 1 BIAS COIL 1A1630R T201

144-062040-05 1 REC SW 6P2T PS62D04 NON-SHORTING

160-104255-01 2 PIN SOCKET 4 PIN 2.5MM CN201-02

113-100105-12 1 CAR. RESISTOR 10 OHM1/4W +/-5% R215

113-220105-12 1 CAR. RESISTOR 22 OHM1/4W+/-5% R216

CRYSTAL 24.00MHZ (矮体铁壳）

有SD 卡用料113-561005-12 CARBON RESISTOR 560 OHM 1/16W

注：CE认证用,不做CE认证时扦铁线 x 2pcs

SW 201

PAGE:14/20Print:23/07/2009

113-470105-12 2 CAR. RESISTOR 47 OHM1/4W+/-5% R207 209

113-101105-12 1 CAR. RESISTOR 100 OHM1/4W+/-5% R214

113-472105-12 2 CAR. RESISTOR 4.7K1/4W+/-5% R211 213

113-562105-12 2 CAR. RESISTOR 5.6K1/4W+/-5% R210 212

113-103105-12 2 CAR. RESISTOR 10K1/4W+/-5% R201-02

113-273105-12 1 CAR. RESISTOR 27K1/4W+/-5% R217

113-473105-12 4 CAR. RESISTOR 47K1/4W+/-5% R203.204.205.206

113-684105-12 1 CAR. RESISTOR 680K1/4W+/-5% R208

123-223350-16 2 C. CAP 0.022UF +/-10% 50V+/-20% C218 222

123-101340-13 2 CERAMIC CAP 100P +/-5% 50V C 1.2

126-102071-01 1 MYLAR CAP 0.001uF +/-10%50V C223.

126-152071-01 2 MYLAR CAP 0.0015UF +/-20% 50V C205-06

113-681105-12 2 CAR. RESISTOR 680 OHM 1/4W +/-5% R218-19

126-222071-01 2 MYLAR CAP 0.0022UF +/-20% 50V C205-06

113-102105-12 2 CAR. RESISTOR 1K 1/4W +/-5% R218-19

126-332071-01 2 MYLAR CAP 0.0033uF +/-10%50V C201-02

126-392071-01 1 MYLAR CAP 0.0039uF +/-10%50V C224

126-223071-01 2 MYLAR CAP 0.022UF +/-10%50V C210.211.

127-105078-01 1 ELE. CAP 1UF/50V+/-10% C207

127-335078-01 2 ELE. CAP 3.3UF/50V+/-10% C216.217

127-475078-01 2 ELE. CAP 4.7UF/50V+/-10% C212.213

127-106048-01 1 ELE. CAP 10UF/16V+/-10% C214

127-226048-01 2 ELE. CAP 22UF/16V+/-10% C208.209

127-107048-01 1 ELE. CAP 100UF/16V+/-10% C215

127-227048-01 1 ELE. CAP 220UF/16V+/-10% C221

123-301340-13 1 C. CAP 300PF +/-10% 50V C219

126-152071-01 1 MYLAR CAP 0.0015uF +/-5%50V C220

160-102205-01 1 CN204

126-182071-01 1 MYLAR CAP 0.0018uF+/-10%50V C219

126-472071-01 1 MYLAR CAP 0.0047uF+/-10%50V C225

126-103071-01 1 MYLAR CAP 0.01UF+/-10%50V C220

C16-005000-00 4 JUMPER WIRE 40*0.5MM J***

184-350613-00 4 FERRITE BEAD 3.5*6*1.3MM

190-990803-01 1 CASSETTE PCB 9908PC1

158-073308-01 1 REMOTE HANDSET ASS'Y 113-229005-12 1 CARBON RESISTOR 2.2 OHM1/16W +/-5% R1

113-682005-12 1 CARBON RESISTOR 6.8K1/16W +/-5% R2

123-101340-13 2 CERAMIC CAP 100P +/-5% 50V C 2.3

127-476038-31 1 E .CAP 47UF/10V MINI-SIZE +80-20% C1.

107-200455-24 1 CERAMIC RESONATOR ZTB 455KHZ X1

130-134148-00 2 DIODE IN4148 D1. 2

131-232001-12 1 TRANSISTOR 2SC2001L Q1

130-600012-04 1 INFRARED DIODE KL-IL2 (KODENSHI) TD1

配KEAP4211磁头用料

配T21V1磁头用料

PIN SOCKET 2 PIN 2.0MM

J1.2.3.4.(非CE认证时插铁线)

PAGE:15/20Print:23/07/2009

133-809243-14 1 I.C TC9243F REMOTE 20PINS IC1

C16-005000-00 3 JUMPER WIRE 40*0.5MM J1-3

190-073308-01 1 REMOTE PCB 733PR1

441-030801-25 1 DECK 21 SH2045 (H) 9V

441-030801-51 1 DECK (H) 9V AC ERASE E2183

444-012000-11 1 按生产细则定料444-010001-04 1 按生产细则定料161-991000-00 1 RCA JACK 2 HOLE SPEAKER OUT RCA JACK

147-110102-01 1 LEAF SW ITCH QAS-1229-4

145-022420-07 1 SWITCH SS22 F25-G7

171-660072-00 1 VDE LINE CORD APP.W/O END(KEMA)

171-442072-70 1 AC LINE CORD BS6500 APPROVED

171-230072-00 1

171-210078-00 1171-998078-70 1 AC LINE CORD JAPAN CGE

171-550078-20 1 LINE CODE SAA W/END APPROVED

101-411168-35 1 TRANSFORMER EI-41 230V 50Hz

101-411168-1A 1 TRANSFORMER EI-41 110/220V 60/50Hz

147-120328-00 1 VOLTAGE SELECTOR SWITCH 此开关带机丝螺牙C01-030100-01 3 UL 10MM SHRINK TURE (L=25MM)

C01-030200-00 1 UL 20MM SHRINK TUBE <L=50MM>

172-422018-52 1 UL1672#22AWG RED 180MM VOLTAGE SW. TO AC CORD

194-079030-10 2 CLOSE END CONNECTOR KS.CE2

C01-030200-00 1 UL 20MM SHRINK TUBE <L=50MM>

C01-030100-01 2 UL 10MM SHRINK TUBE(L=35MM)

C08-000020-03 7

C01-010010-00 8 UL PVC TUBING 1.0*10mm FOR DIODE

C01-020010-00 8 FOR DIODE

(依生产细则配料)

CD DECK SANYO 波子头CD DECK 青雅　　波子头

( 按生产细则） ( 按生产细则）

UL CORD SPT-1 W/O END （有极性） ( 按生产细则） UL CORD SPT-1 W/O END NO-POLAR （无极性) ( 按生产细则）

( 按生产细则） ( 按生产细则）

(依生产细则配料)

110/220V机增加材料

CABLE TIE "3"(扎线）

PVC 2.0MM TUBE （10MM）

SPEAKER ASS'Y 音箱组件

PAGE:16/20Print:23/07/2009

166-340540-22 2 4" INCH SPEAKER 4 OHM 5W

166-240315-32 2 1.5" INCH SPEAKER 4 OHM 3W

127-105078-21 2 NONPOLAR E.CAP 1UF/50V +80-20%

170-100027-02 2 BUZZER 27MM

172-126020-52 2 UL1007#26AWG RED 150MM

172-126020-50 2 UL1007#26AWG BLACK 150MM

188-920072-20 2 SPEAKER/LEAD WITH RCA PLUG #24

184-251512-00 1 FERRITE BEAD 25*15*12 FOR POWER AC LINE

184-181006-00 6 FERRITE BEAD 18*10*6

线材1 AM ANT

181-803000-19 1 UL1533#28AWG 1000MM AM ANT

172-126013-59 1 UL1007#26AWG 130MM 1PIN WHTE DECK MOTOR TO LEAF SW

172-126018-59 1 UL1007#26AWG 180MM 1PIN WHTE CD KNOB TO MB GND

720-032014-03 1 ANT WASHER 3.2*14*0.3 CD KNOB

172-122015-50 1 UL1007#22AWG 150MM 1PIN WHTE MP GND TO MB GND

181-803200-10 1 UL1533#28 S / S 200MM 2P 1H P=2.0MM TAPE PCB CN203 TO BEAT CUT SW

191-030230-00 1 UL1007#26AWG 230&180MM 2P 1H P=2.5MM MB CN3 TO MOTOR&LEAF SW

177-602151-02 1 UL2468#26AWG 150MM 2P 1H P=2.0MM MP PCB CN8 TO DOOR SW

177-602181-05 1 UL2468#26AWG 180MM 5P 4W 1H P=2.0MM CD PCB TO MB PCB CN2

177-800201-06 1 UL20080#28AWG 200MM 6P 2H P=2.0MM CD DECK TO MP PCB

177-289614-12 1 RADIO RF TO MB CN401

SIZE:1.25PH*12PIN*140MM

177-289612-16 1 CD DECK TO MP PCB

177-289615-16 1 DISPLAY PCB TO MB PCB

178-127150-20 1 UL 1007 #22 AWG 1500MM FM ANT181-813180-20 1 UL2547#28D/ S 180MM 3P 1H P=2.5 MM MB CN6 TO TAPE PCB CN205

191-020130-02 1 ULI007#22AWG 130MM 2P 1H P=2.5MM MAIN PCB CN12 TO MP PCB CN3

191-040160-00 1 UL2547#28D/S&1007#26AWG160MM 4P1H/2.5MMMB CN4 TO 9908PC1 CN202

C01-030100-01 1 UL 10MM SHRINK TUBE(L=40MM)

C01-030002-00 2 UL R=2MM SHRINK TUBE<L=25MM>

181-313160-30 1 UL2854#30T / S 160MM 4P 1H P=2.5MM R/P HEAD TO 9908PC1 CN2O1

191-040160-00 1 UL1007#22AWG 160MM 4PIN WHTE P=2.5mm MB CN301 TO SPEAKER JACK

191-040180-00 1 UL2547#28D/S 180MM 4PIN 1H P=2.0mm MB CN5 TO MP PCB CN6

177-602131-04 1 UL2468#26AWG 130MM 4P 1H P=2.0MM USB TO MP PCB CN5

（按客户要求定料）（按客户要求定料）（按客户要求定料）（按客户要求定料）（按客户要求定料）有蜂鸣片/用线材（按客户要求定料） SPEAKER CABLE（按客户要求定料）

做CE认证时用.按营业部通知配料

FOR (SP OUT * CD AUDIO)LINE; USB; 磁头线TAPE REC LINE (CE认证时用料）

172-126310-50 UL1007#26AWG 3100MM 1PIN WHTE

CD 钮电镀时用

12PIN AWM 2896 SUPER FLEX 12P 140MM (同向)

16PIN AWM 2896 SUPER FLEX16P 120MM(同向）16PIN AWM 2896 SUPER FLEX16P 150MM(同向）

非CE认证时用料

非CE认证时用料, 有USB用线材

做CE认证时用料

PAGE:17/20Print:23/07/2009

184-181006-00 4 FERRITE BEAD 18*10*6 TAPE REC LINE

181-313260-30 1 UL2854#30T / S 260MM 4P 1H P=2.5MM R/P HEAD TO 9908PC1 CN2O1

191-040280-00 1 UL1007#22AWG 280MM 4PIN WHTE P=2.5mm

191-040280-00 1 UL2547#28D/S 280MM 4PIN 1H P=2.0mm MB CN5 TO MP PCB CN6

177-602251-04 UL2468#26AWG 250MM 4P 1H P=2.0MM

177-602131-10 1 UL2468#26AWG 130MM 10P 1H P=2.0MM USB+ CARD PCB TO MP PCB CN4

结构部分METAL PARTS & OTHERS303-088101-00 2 REAR FOOT 17*6.5 MM

303-862801-01 2 FRONT FOOT 23*5 MM

303-201204-02 2 LCD SPONGE20*12*4MM

303-080825-00 1 REMOTE SPONGE8*8*2.5MM

703-099101-00 10 SCREW BRACKET

721-099101-00 1 CASS SPRING

740-060601-00 1 CD DOOR SPRING

308-003105-00 2 FOR CD DECK

308-003103-00 2 FOR CD DECK

714-038801-00 1 HEAT SINK FOR IC 7808C

1 HEAT SINK

701-05501-00 2 PCB BKT(A)301-410000-00 1 CD DOOR LOCK FIQ618807-862801-00 1 BACK BOARD

SCREW & WASHER500-031004-00 2 3*10BA501-020304-00 1 2*3TT RECORDING PLATE*1

501-020404-00 1 2*4TT

501-250604-00 1 2.5*6TT

501-020404-00 1 2*4TT PCB BKT(A)*1

501-260604-00 2 2.6*6TT CASS PCB*2

500-021202-00 1 2*12PA LEAF SWITCH*1

500-260802-00 6 2.6*8PA CD KEY PCB*6

500-030603-00 4 3*6BT SMALL PANEL*4

500-030805-00 1 3*8BTB IC7808 TO HEAT SINK*1

500-031002-00 16 3*10PA CD DAMPER GEAR*1,

USB PCB HOLDER*1

MAIN PCB HOLDER*6

CASS DECK*4 CD PCB*4

500-261004-00 1 2.6*10BA CASS DAMPER GEAR*1

500-031004-00 6 3*10BA SIDE BOARD*4

SPEAKER JACK*2

MB CN301 TO SPK OUT (穿3.5T)

做CE认证时用料, 有USB卡用线材USB TO MP PCB CN5 (穿3.5T)

有SD卡用线材

(高密度海绵)(高密度海绵)

CD RUBBER CUSHION （BIG） 35°C

CD RUBBER CUSHION （BIG） 30°C

714-050501-00

CASS PCB BKT*1 非天凯机芯使用CASS PCB BKT*1 天凯机芯使用

PAGE:18/20Print:23/07/2009

500-031204-00 5 3*12BA BACK*5

501-030802-00 8 3*8BM SIDE BOARD*6 BOTTOM*2

501-031002-00 2 3*6BM BACD TO CD BASE*2

509-261001-10 4 CD DECK*4

509-031001-08 3

POWER CORD*1

503-035160-10 1 FIBER WASHER 3.5*16*1 MM POWER CORD*1

503-030080-05 2 FIBER WASHER 3*8*0.5MM FOR CD DAMPER GEAR

503-030080-10 1 FIBER WASHER3*8*1.0MM FOR CD DAMPER GEAR*1

503-030080-05 3 FIBER WASHER3*8*0.5MM FOR CD KNOB PCB*3

303-080802-00 2 SPONGE 8*8*2.5MM FOR CASS DECK*2

后板功能根据生产细则要求选用以下物料500-031002-00 2 3*10BA AUX JACK*2

501-020602-00 2 2*6BM BEAT CUT/FM SWITCH TO BACK*2

PS-HCD993312 1

500-031002-00 2 3*10BM

501-030802-00 2 3*8BM

501-031002-00 2 3*10BM

508-030000-00 2 M3 NUT

PLASTIC PARTSPS-862801 1 PANEL

PS-862802 1 CD BASE

PS-862803 1 CD DOOR

PS-862805 1 SMALL PANEL PR

PS-862806 1 CASS KNOB DOOR

PS-862807 1 CASS DOOR

PS-862808 1 MAIN PCB HOLDER R

PS-862809 1 MAIN PCB HOLDER L

PS-862810 1 USB PCB HOLDER

PS-862811 1 DISPLAY LENS

PS-862812 1 CASS DOOR LENS

PS-862813 1 CD KNOB A

PS-862824 1 CD KNOB B

PS-862814 1 LOCK

PS-862821 1 CASS KNOB

PS-990854 1 DUST SHIECDING COVER

PS-990852 1 DUST SHIECDING COVER

PS-066103 1 SIDE-L

PS-066104 1

PS-099102-00 1 BOTTOM BOARD

PS-KS77006 1 CASS DAMPER GEAR

PS-CDK3309 1 CD DAMPER GEAR

PS-Z990844 1 SPEAKER LABEL BOTTOM*1

2.6*10PWA（W= 10）3*10PWA （W=8） TRANSFORMER*2 （底板改模后用量）

75 OHM插座盖

无75OHM JACK时选用此物料

三洋和青雅CD机芯使用

SIDE－R

PAGE:19/20Print:23/07/2009

PS-VCD99102 5 PLASTIC WASHER(2)

PS-VCD99101 2 PLASTIC WASHER (1)

PS-CDK52024 1 AM ANT.HOUSING

PS-088103 1 CASS HOLDER

REMOTE CONTROLLER

303-301505-00 1 PAD SPONGE 30*15*5 MM

311-026001-00 1 REMOTE RUBBER KEY

707-993301-00 1 BATTERY PLATE (- )

707-993302-00 1 BATTERY PLATE (+ )

707-993303-00 1

PS-RM26001 1 FRONT CABINET

PS-RM26002 1 BOTTOM CABINET

PS-RM26003 1 BATTERY DOOR

PS-RM29300 1 REMOTE INLAY

SPEAKERS

PS-862822 2 SPEAKER PANEL

PS-862823 8 SPEAKER GRILL

500-030804-00 12 3*8BA

SPEAKER GRILL*8500-041001-00 8 4*10PT 4" SPEAKER*8

PS-862822 2 SPEAKER PANEL

PS-862823 8 SPEAKER GRILL

500-030804-00 12 3*8BA

SPEAKER GRILL*88 3*10PWA(W=8) 4" SPEAKER*8

PS-088132 2 SPEAKER BACK CABINET

12 SPEAKER PANEL*12

PS-Z099139 2 SPEAKER LABEL

951-099102-00 4 RUBBER FOOT 85*8.5*3 MM SPEAKER BOX*4

LABELS642-862802-12 1 INSTRUCTION MANUAL

664-053211-02 1 DATE CODE LABEL

664-053211-05 1 THERMAL FUSE LABEL

664-053211-07 1 LASER BEAM LABEL

664-053211-08 1 LASER CAUTION LABEL

664-053211-10 2 SPEAKER BOX LABEL

664-053211-23 1 SERIAL LABEL

664-099100-05 1 CAUTION & SAFETY LABEL

BATTERY PLATE（+/-）

SPEAKERS 8628 塑胶面木音箱选用物料,根据生产细则要求选用

1.5"SPEAKER*4 (根据生产细则或有关文件有高音喇叭选用)

SPEAKERS 8628 全塑胶音箱选用物料,根据生产细则要求选用

1.5"SPEAKER*4 (根据生产细则或有关文件有高音喇叭选用)

500-031001-00

500-031203-00 3*12BT

PAGE:20/20Print:23/07/2009

664-099100-06 1 CLASS 1 LASER LABEL

664-066100-08 1 MODEL LABEL

622-091000-01 1 CD PAPER DISC

C07-3M8934-00 4 8934 3MFIIAMENT TAPE(60MM)

PACKING & LITERATURE 802-862801-00 2 TOP POLY FOAM

623-862821-21 1 CARTON

811-150180-73 1 POLY BAG 15"*18"*0.03MM

811-150180-73 2 POLY BAG 15"*18"*0.03MM

811-065100-73 1 POLY BAG 6.5"*10"*0.03MM

811-040090-73 1 POLY BAG 4"*9"*0.03MM

811-050100-73 1 POLY BAG 5" X 10" X 0.03MM

MM15M3

Documents

Chapter-01

(Tesla) - The Tesla Magnetic Car Engine

Tragic Heroes

Effective Parenting: Establishing Boundaries

Chapter 24

Personality Development

Basic Buffer Overflows Explained

Simple Functions in Haskell

Heidegger Kritik

The Dutch Republic In International Trade

Daniel Zanella and Alexander Weygers

Bhagavad Gita

xCDC14a

European Colinization of Latin America

United States Constitution

Improve the Color Quality Of Your Monitor

Rubik's cube solution

One Flew Over the Cuckoo's Nest

Physical Modelling Synthesis Overview

I Am a Holocaust Denier and I Am Unafraid