MM15M3

page 1 of 7

MODEL NUMBER : USB868PR(3.5W/2BAND)MP8628PR RF ( 1.5 W/2BAND) CUSTOMERS MODEL NUMBER: BRAND: TYPE OF SET : MUSIC CENTER DATE: 2007.08.25

STANDARD TEST CONDITIONS SUPPLY VOLTAGE: DC : V, AC : 230 V 50 Hz REFERENCE OUTPUT POWER : 50 Mw INTO 4 OHM LOAD AM ANTENNA : IRE LOOP ANT. AM STANDARD SIGNAL : 400 Hz , 30% MODULATION FM ANTENNA : 75 OHMS , UN BALANCED FM STANDARD SIGNAL MONO : 1 KHz , 22.5 KHz DEVIATION FM STANDARD SIGNAL (STEREO): 1 KHz , 75 KHz DEVIATION

1 UV= 0 dB FOR RADIO FREQUENCY 1 V = 0 dB FOR AUDIO FREQUENCY

ELEC ENCR: APPROVER: MANAGER:

page 2 of 7 AM PERFORMANCE SPECIFICATIONS (MW)No. Test Items Unit Nominal Limit Remark1

1 Intermediate frequency KHz 450 +/-5

2 Tuning range KHz 522-16203 Dial calibration 603KHz KHz

1404KHz KHz

603KHZ uV/M

4 uV/M

1404KHz uV/M

uV/M 1000 1500

5 uV/M 1000 1200

uV/M 1000 1200

6 dB 45 35

7 dB 35 30

8 S/N ratio 5mV/M input dB 40 30

9 AGC figure of merit 100mV/M dB

10 A.C.A at 20dB S/N +/-10KHz dB

11 -6dB band width at 20 dB S/N KHz 8 5-1012 T.H.D 5mV/M 30% mod % 1 3

100m/V/M 80% mod % 3 5

13 Modulation hum 100mV/M dB 40 35

14 Frequency response -6dB low Hz 60 100

400 Hz=0dB, 5mV/M high Hz 2200 1800

15 Output power %mod, 5mV/M W

16 10% THD power 80% mod, 5mV/M W

17 Hum & Noise level VR min mV 1 3

18 Whistle at 5mV/M IFX2, FIX3 %

19 Spurious response at 1400 KHz

2.5 MHz - 10MHz dB

20 AM signal meter 5mV/M %

21 Record beat 5mV/M %

22 FAIL OUT VOLTAGE (DC) V

(AC) %

603 KHz dB 93 96

23 AUTO STOP SENS 999 KHZ dB 93 96

1404KHZ dB 93 96

page 3 of 7

Max sensitivity 999KHz

20 dB quieting 603KHz

999KHz

sensitivity 1404KHz

IF rejection 603KHz

Image rejection 1404KHz

FM PERFORMANCE SPECIFICATIONS

No. Test Items Unit Nominal Limit Remark1

1 Intermediate frequency MHz 10,7

2 Tuning range MHz 87.5-1083 KHz

KHz

uV

4 uV

uV

uV 10 20

5 uV 10 20

uV 10 20

6 dB 50 45

7 S/N ratio1mV input 22.5 KHz dev dB 50 45

8 3 dB limiting sensitivity dB 10 20

9 T.H.D 22.5 KHz dev % 0,65 1

10 AM suppression dB 32 26

11 Modulation hum100mv 22.5KHz dev dB 40 35

12 AFC hold rang - 3 dB l mV KHz

13 Frequency response -6dB Hz 60 100

with usec pre-emphasis KHz 3 2,5

14 Overload break mV

15 Output power 32 KHz dev 1mV W

16 10% THD power 40KHz dev. 1mV W 1,5 1,5

17 Hum & Noise level VR MIN mV 1 3

18 Spurious response dB

19 Muting on level uV

20 Muting bandwidth KHz

21 Alternate channel selectivity 0.1 mV

input +/- KHz dB

22 Capture ration 1mV dB

23 FAIL OUTPUT VOLTAGE (DC) V

(AC) % 80 85

90.1MHz dB 20 2624 AUTO STOP SENS 98.1MHz dB 20 26

106.1MHz dB 20 26

page 4 of 7FM PERFORMANCE SPECIFICATIONS

NO. Test items Unit Norminal Limit Remark1

+/-0.1

Dial calibration 90.1MHz

106.1MHz

90.1KHZ

Max sensitivity IHF 98.1MHz

106.1MHz

30 dB quieting 90.1MHz

98.1MHz

sensitivity 106.1MHz

IF rejection 90.1MHz

25 MPX indicator sens. uV 10 20

100Hz dB W/Z 19KHz

26 MPX separation 1k Hz dB 30 20 FILTER

10K Hz dB

27 MPX T.H.D. Main 400 Hz % 1,5 3 W/Z 19KHz L. or R. 1K Hz % 1,5 3 FILTER

4 MAX 50dB quieting

28 Sensitivity 98MHz dB

28 MPX S/N ratio dB 36 30 W/Z 19KHzFILTER

30 FM signal meter %

31 SCA Signanl Suppression dB

page 5 of 7 CASSTETTE ( MAGNET ERASE )NO. Test items Unit Nominal Limit Remark1

1 Tape speed B-111N % 3000Hz +3,-22 Wow & Flutter WRMS JIS B-111N % 0,1 0,353 Distortion B-118N % 1 34 S/N ratio B-112S dB 45 355 Cross talk B-121N dB 35 286 Separation B-141N dB 30 257 Hum & noise VR Max mV 30 708 Hum & noise VR min mV 1 3

Frequency response 125 Hz dB 09 1000 Hz dB 0 0

Play Back (B-257C) 8000 Hz dB 010 Output level mV11 10% THD power B-112BN W 2 1,812 Max power B-112BN W

S/N Recording/P.B. Normal dB 30 2513 at -62 dbv, 1k Hz Cro2 dB

CD PLAY, SONY 3 - 16 Matal dBErase ratio Normal dB 30 25

14 at -59 dbv, 1k Hz Cro2 dBCD PLAY, SONY 3 - 16 Matal dBRec/P.B. Level Normal dB 0 REF:B-212

15 at -66 dbv, 1k Hz Cro2 dBCD PLAY, SONY 3 - 18 Matal dB

16 Line input sensitivity dB17 Mic input sensitivity dB18 Peak level 1 dB

Peak level 2 dBFrequency response Rec./P. 125 Hz dB 0

19 FM 98 MHZ 22.5 KHZ 1000Hz dB 0 075 USEC PRE-EMPHASIS 6300Hz dB 0Rec./ P.B. distorion Normal % 5 8

20 -66 dBV, 1K Hz Cr02 %CD PLAY, SONY 3-18 Metal %

21 AlC Rec. /P.B. distortion -56 dbv % 6 10input 1K Hz CD PLAY, SONY 3-14

22 FAIL OUTPUT VOLTAGE (DC) V (AC) % 80 85

(CD BUIDE IN) (TEST AT SPKD OUTPUT)

+/-4

+/-4

+/-3

+/-6

+/-6

page 6 of 7 COMPACT DISC PALYER

NO. Test items Unit Nominal Limit Remark1

1 LEVEL 0dB TRACK 1.4,11 dB 0,5 +/-4

FREQUENCY RESPONSE 40 - 20KHz dB

2 LEVEL 0dB TRACK 30,34 dB 40 30 JIS A NET IN

CHANNEL SEPARATION 1KHz

3 LEVEL 0dB TRACK 14 % 0,2 0,5 JIS A NET IN

TOTAL HARMONNIC DISTORTION

4 LEVEL 0dB TRACK 1, 23 dB 55 50 JIS A NET IN

S/N RATIO

5 LEVEL 0dB Verm

OUT PUT LEVEL

6 LEVEL 0dB TRACK 1 dB 0

UNBALANCE L/R

7 10% THD POWER SONY 3 TRACK 1 W 1,5 1,5

8 CD SAME VOL dB

PLAYABILITY

NO TEST ITEMS TEST

DISC

1 DEFECT DISC INTERRUPTION PHILIPS PLAYABLE WITHOUT ANY

5A AUDIBLE ERROR

INFORMATION LAYER 600um

2 PHILIPS PLAYABLE WITHOUT ANY

BLACK DOT AT READ OUT SIDE 5A AUDIBLE ERROR

500um

3 PHILIPS

SIMULATED FINGERPRINT 5A PLAYABLE WITHOUT ANY

TRACK AUDIBLE ERROR

18/19

ACCESS TIME PHILIPS

START - UP 1ST TRACK </= 5SEC

SHORT ACCESS TIME TR 1< - >2 </= 3 SEC

LONG ACCESS TIME TR 1 < - > UNIT </= 10 SEC

TEST DISC TYPE 3 (SONY YEDS - )

2 X OVERSAMPLING, 16 BIT D/A CONVERTERpage 7 of 7

AUDIO LEVEL BALANCE

No. Unit Norminal Limit Remark1

dB 0

+/-3

FM 1000uV 22.5K DEV. +6

dB 0

dB 0

dB 0

FM FUNC.1mV AM 5mV/M30%MOD +/-322.5KHz DEV TAPE - 10dB 1KHz MTT-118 +/-3(FM LEVEL 0dB) CD-10 dB RECORDING LEVEL +/-3

TAPE.sch-1 - Fri Jun 06 09:35:42 2008

UC8628PRS RADIO.sch-1 - Fri Jun 06 09:27:48 2008

1008-MCU.sch-1 - Fri Jun 06 09:32:52 2008

LN

LN

LN

LN

Sheet2

第5页

LN

Sheet2

第6页

LN

Sheet2

第7页

LN

PAGE:9/20Print:23/07/2009

PACIFIC TECH ELECTRONIC LTD.Bills Of Material

MP/USB/UC8628PRS 1.5W (光星高频头+CMC+MTK方案) 料单制作日期：2007-08-25

PART NO QTY DESCRIPTION

004-862800-01 1

(7132 00-M-0PbF FM/AM/RDS)

158-8628801-01 1 8628PR MB ASS’Y133-202025-67 1 IC2133-02313L-00 1 I.C PT2313 IC7133-517805-61 1 KA78L05AZTA IC9131-240882-67 1 PS B882P Q4

131-220772-84 1 TRANSISTOR 772 Q3

131-240363-67 1 TRANSISTOR 2HB363(TO-126) Q20.

131-449014-03 1 TRANSISTOR JE 9014C Q16

131-520945-25 4 TRANSISTOR 2SC945 Q10.11.12.17.

131-448050-35 4 TRANSISTOR 2SD8050 Q7.202.203.19

131-448550-03 2 Q5.21.

130-134148-00 3 D11.14.15.

130-410082-00 2 DZ2.ZD4

130-410010-00 1 ZD1

130-314002-00 4 D5.6..12.13

182-222000-00 1 FUSE T2AL 250V(5*20MM) F 2

733-005020-00 2 FUSE HOLDER (5*20 MM) FOR F2

105-100101-05 1 L6

160-102255-01 1 PIN SOCKET 2PIN 2.5MM CN3.

160-104255-01 1 PIN SOCKET 4 PIN 2.5MM CN301

160-216106-02 1 Connector-FFC R/A type 16PIN 1.0mm CN403

160-212125-02 1 FFC/FPC Connector S/T type 12PIN 1.25mm CN401

718-020040-00 3 BRASS EYELET DIA 2*4mm

C16-005000-00 25 JUMPER WIRE 40*0.5MM

113-220005-12 1 CAR RESISTOR 22 OHM1/16W +/-5% R22

113-101005-12 1 CAR. RESISTOR 100 OHM 1/16W +/-5% R1

113-151005-12 2 CAR. RESISTOR 150 OHM 1/16W +/-5% R28.38.

113-331005-12 2 CAR. RESISTOR 330 OHM 1/16W +/-5% R91.92.

113-471005-12 4 CAR. RESISTOR 470 OHM 1/16W +/-5% R7.8.17.18.

113-102005-12 4 CAR. RESISTOR 1K 1/16W +/-5% R5.82.83.103.

113-103005-12 2 CAR. RESISTOR 10K 1/16W +/-5% R95.96

113-222005-12 2 CAR. RESISTOR 2.2K 1/16W +/-5% R35.75

113-272005-12 2 CAR. RESISTOR 2.7K 1/16W +/-5% R79.81.

113-332005-12 2 CAR. RESISTOR 3.3K 1/16W +/-5% R6.13.

113-392005-12 1 CAR. RESISTOR 3.9K 1/16W +/-5% R3

113-472005-12 8 CAR. RESISTOR 4.7K 1/16W +/-5% R10.12.27.34.85.87.106.107.

113-562005-12 3 CAR. RESISTOR 5.6K 1/16W +/-5% R20.109.110

113-682005-12 2 CAR. RESISTOR 6.8K 1/16W +/-5% R.89.90

113-103005-12 6 CAR. RESISTOR 10K 1/16W +/-5% R25.26.33.86.93.97.

113-123005-12 2 CAR. RESISTOR 12K 1/16W+/-5% R31.32.

113-183005-12 2 CAR. RESISTOR 18K 1/16W+/-5% R78.80

113-393005-12 2 CAR. RESISTOR 39K 1/16W+/-5% R84.88.

113-104005-12 4 CAR. RESISTOR 100K 1/16W +/-5% R16.19.36.74.

KST-MP104MA1-3 20060125 光星高频头

IC. TEA2025B(质量要好)

TRANSISTOR 2SD8550(STS/C8550禁用）DIODE 1N4148 （带式）ZENER DIODE 8.2V（带式）ZENER DIODE 10V（带式）DIODE 1N4002 （带式）

CHOKE COIL 10UH(色环电感）（带式）

PAGE:10/20Print:23/07/2009




113-334005-12 2 CAR. RESISTOR 330K 1/16W +/-5% R94.98.

123-501340-13 2 C.CAP 500PF NPO +/-5% 50V C.77.78.

123-272350-16 2 C.CAP 2700PF +/-10% 50V C123.124.

126-153071-01 2 C118.119.

123-203350-16 4 C.CAP 0.02UF +/-20% 50V C3.4.5.6.

123-104350-16 11 C.CAP 0.1UF +/-20% 50V C10.13.51.122.125.126.127.128.129.130.131.

126-224071-01 2 MYLAR CAP 0.22UF +/-20% 50V C24.25

127-225078-31 6 ELE.CAP 2.2UF/50V MINI-SIZE +80-20% C45.46.47.48.62.63

127-475078-31 10 ELE.CAP 4.7UF/50V MINI-SIZE +80-20% C14.19.31.43.44.53.60.61.73.75.

127-476078-31 1 ELE.CAP 47UF/50V MINI-SIZE +80-20% C27

127-226048-31 1 ELE.CAP 22UF/16V MINI-SIZE +80-20% C.41

127-476048-31 1 ELE.CAP 47UF/16V MINI-SIZE +80-20% C.9

127-107048-31 8 ELE.CAP 100UF/16V MINI-SIZE +80-20% C18.20.28.29.32.42.49.74.

127-227058-01 1 ELE.CAP 220UF/25V +80/-20% C57.

127-477058-01 5 ELE.CAP 470UF/25V +80/-20% C16.17.34.50.59.

127-108058-01 1 ELE.CAP 1000UF/25V +80/-20% C71.

127-338058-01 1 ELE.CAP 3300UF/25V +80/-20% C23.

190-862801-01 1

158-862801-03 1 UC8628PR DISPLAYER PCB ASS’Y(MTK)133-808628-18 1 CMCTEK CPU QFP44PINS (UC8628PR) U1133-024C02-1A 1 U3

137-169344-30 1 X1

130-134148-00 1 D101

1 ZD1

130-314002-00 1 D3

130-311N60-00 1 D.2

130-520523-01 1 LED EL204 HD RED 3MM D4

8

131-449014-1A 2 TRANSISTOR 9014 SMT

160-W1016-21 1 CONNECTOR-FFC R/A TYPE 16PIN 1.0mm CN2

135-092601-03 1 LCD DISPLAY H043933-03

187-410868-00 1

147-110143-00 12 TACT SWITCH H:4.3MM/4 TERMINAL SW12.13.14.15.16.17.18.19.20.21.22.23.

136-316038-00 1 OPTIC R/C REC MORULE FM-6038LM-5A

113-331005-12 1 CAR. RESISTOR 330OHM 1/16W +/-5% R57

113-102005-12 4 CAR. RESISTOR 1K 1/16W +/-5% R4.5.6.60.

113-332005-12 1 CAR. RESISTOR 3.3K 1/16W +/-5% R.75

113-513005-12 2 CAR. RESISTOR 51K 1/16W +/-5% R29.31.

C16-005000-00 22 JUMPER WIRE 40*0.5MM

127-105048-31 1 ELE.CAP 1UF/16V MINI-SIZE +80-20% CE6

127-106048-31 1 ELE.CAP 10UF/16V MINI-SIZE +80-20% CE4

127-476048-31 1 ELE.CAP 47UF/16V MINI-SIZE +80-20% CE1.

113-00005-63 2 CAR RESISTOR 0 OHM 0603 R74.77

113-100005-63 1 CAR RESISTOR 10 OHM 0603 R47

MYLAR CAP 0.015UF +/-20% 50V

UC8628PR PLL MB PCB 94V0料

I.C ATC24LC02 (贴片型)

CRYSTAL 16.9344MHz +/-5PPM(两脚矮体)

DIODE 1N4148（带式）130-410036-00 ZENER DIODE 3.6V（带式）

DIODE 1N4002 （带式）DIODE 1N60 （带式）

131-448550-1A TRANSISTOR 2SD8550 SMT (KEC.BKD33) Q1.2.3.4.5.6.7.8. (注:用质量好的)

Q9.10 ( 注:用质量好的)

(与UC926PRMTK用同一款LCD)

FH-0144-B 蓝色背光源(颜色按生产细则定料) D5(与UC926PRMTK用同一款背光源)

REM1 注: 用 5V

(有Ｅ３标志）

PAGE:11/20Print:23/07/2009




113-330005-63 5 CAR RESISTOR 33 OHM 0603 R37.38.39.52.59

113-221005-63 1 CAR RESISTOR 220 OHM 0603

113-331005-63 6 CAR RESISTOR 330 OHM 0603 R46.53.54.56.67.68.

113-471005-63 1 CAR RESISTOR 470 OHM 0603 R.49

113-102005-63 1 CAR. RESISTOR 1K 0603 R8.

113-122005-63 1 CAR. RESISTOR 1.2K 0603 R10

113-152005-63 1 CAR. RESISTOR 1.5K 0603 R43

113-272005-63 1 CAR. RESISTOR 2.7K 0603 R9

113-332005-63 4 CAR. RESISTOR 3.3K 0603 R2.48.70.71.

113-472005-63 1 CAR. RESISTOR 4.7K 0603 R73

113-512005-63 1 CAR. RESISTOR 5.1K 0603 R3

113-682005-63 1 CAR. RESISTOR 6.8K 0603 R65

113-103005-63 10 CAR. RESISTOR 10K 0603 R1.7.40.41.44.45.50.51..58.72.

113-123005-63 1 CAR. RESISTOR 12K 0603 R66

113-333005-63 1 CAR. RESISTOR 33K 0603 R55.

113-513005-63 6 CAR. RESISTOR 51K 0603 R.30.32.33.34.35.36.

113-104005-63 21 CAR. RESISTOR 100K 0603 R11.12.13.14.15.16.17.18.19.20.21.22.23.

R24-28.42.61

113-204005-63 2 CAR. RESISTOR 200K 0603 R63.64.

123-200340-63 2 C.CAP 20PF NPO 50V 0603 C2.3

123-101340-63 9 C.CAP 100PF NPO 50V 0603 C10.11.12.13.14.15.16.21.22.

123-104350-63 6 C.CAP 0.1UF 50V 0603 C1.9.17.18.20.23.

190-862801-03 1 UC8628PR KEY PCB ASS’Y

158-862801-02 1 UC8628PR USB+CARD

160-004100-02 1 USB1

127-476048-31 1 ELE. CAP 47UF/16V MINI-SIZE +80-20% C11

184-350613-00 4 FERRITE BEAD 3.5*6*1.3MM

127-476048-31 1 ELE. CAP 47UF/16V MINI-SIZE +80-20% C76

004-130408-01 1 3N1 MEMORY CONNECT FOR SDMS CARD SD1

190-862801-02 1 UC8628PR USB+CARD

158-005671-00 1 MTK MP USB SD PCB ASS‘Y133-005671-8B 1 U3

133-304004-1C 1 GM71C17400CJ6(4*4M) U5.133-302510-8B 1 U1

133-001469-67 1 MM1469 (DC OUT 3.3V) U2

133-507805-15 1 Q9130-134148-00 2 D1.4

130-314002-00 1 D2

131-448050-03 1 TRANSISTOR JE8050C Q1.131-448550-03 2 TRANSISTOR 8550 Q6.8.

R69(用于蓝色背光源,颜色按生产细则要求)

USB.SD 用料

有USB 卡用料USB A TYPE FEMALE CONNECTOR (贴板式)

有SD 卡用料

SDCARD 座与USB 801同款式

M5671 （CPU IC）

P10-50GCP （同CPU配套发料）

78M05 (粘片型)

DIODE IN4148 （带式）DIODE IN4002（带式）

PAGE:12/20Print:23/07/2009



PART NO QTY DESCRIPTION137-169344-30 1 Y1105-330101-05 2 CHOKE COIL 33UH (NEW) L1. 7 184-354708-05 6 CHOKE COIL RH 3.5*4.7*0.8-T52 L.2.3.4.5.6.8160-102205-01 1 PIN SOCKET 2PIN 2.0MM CN8160-102255-01 1 PIN SOCKET 2PIN 2.5MM CN3.160-104205-01 1 PIN SOCKET 4PIN 2.0MM (RED COLOUR) CN9160-104205-01 1 PIN SOCKET 4PIN 2.0MM CN6.160-105205-01 1 PIN SOCKET 5PIN 2.0MM CN7160-106205-01 1 PIN SOCKET 6PIN 2.0MM CN2

160-216106-02 1 Connector-FFC R/A type 16PIN 1.0mm CN1113-109005-12 1 CARBON RESISTOR 1 OHM 1/16W R48.113-109105-12 1 CARBON RESISTOR 1 OHM 1/4W R24.113-150005-12 1 CARBON RESISTOR 15 OHM 1/16W R50.113-330005-12 1 CARBON RESISTOR 33 OHM 1/16W R57113-331005-12 1 CARBON RESISTOR 330 OHM 1/16W R43113-471005-12 1 CARBON RESISTOR 470 OHM 1/16W R25113-102005-12 2 CARBON RESISTOR 1K 1/16W R36.J47113-472005-12 3 CARBON RESISTOR 4.7K 1/16W R23.35.61113-512005-12 1 CARBON RESISTOR 5.1K 1/16W R37.113-682005-12 3 CARBON RESISTOR 6.8K 1/16W R72.73.74113-103005-12 13 CARBON RESISTOR 10K 1/16W R.2.3.4.9.16.17.18.20.21.22.46.49.51.113-223005-12 1 CARBON RESISTOR 22K 1/16W R28.113-333005-12 1 CARBON RESISTOR 33K 1/16W R44.113-104005-12 3 CARBON RESISTOR 100K 1/16W R7.53.107.123-220340-13 2 C.CAP 22PF C26.27.123-560340-13 3 C.CAP 56PF C50.52.53123-102350-16 4 C.CAP 0.001UF C8.14.55.56123-103350-16 2 C.CAP 0.01UF C5.10113-103005-12 1 CARBON RESISTOR 10K 1/16W123-47350-16 1 C.CAP 0.047UF C18123-104350-16 30 C.CAP 0.1UF C1.2.3.4.6.7.11.12.13.15.16.17.19.20.23.24.25.

C28.29.30.31.32.33.34.35.36.39.49.SS3.54. 123-104350-30 5 C40.41.42.43.C*127-105078-01 3 E.CAP 1UF/50V C22.TC5.6.127-225078-01 2 E.CAP 2.2UF/50V TC2.4127-106048-01 4 E.CAP 10UF/16V TC3.9.10.17.127-476048-01 1 E.CAP 47UF/16V TC11127-107048-01 6 E.CAP 100UF/16V TC8.12.13.14.15.16127-227048-31 3 E.CAP 220UF/16V MINI-SIZE +80-20% TC1..18.33127-477048-31 2 E.CAP 470UF/16V MINI-SIZE +80-20% TC.7.9

113-561005-12 1 CARBON RESISTOR 560 OHM 1/16W R75130-410043-00 1 ZENER DIODE 4.3V ZD1

131-448050-03 1 TRANSISTOR JE8050C Q18127-227048-01 1 E.CAP 220UF/16V TC20

有ＵＳＢ卡用料

CRYSTAL 16.9344MHZ (矮体铁壳)

由R23原接复位脚的一端到PD8

C.CAP 0.1UF (加长脚 L=30MM)

有USB SD时用料

PAGE:13/20Print:23/07/2009



PART NO QTY DESCRIPTION113-330005-12 3 CARBON RESISTOR 33 OHM 1/16W R1.27.29.113-102005-12 2 CARBON RESISTOR 1K 1/16W R93.96. 113-472005-12 1 CARBON RESISTOR 4.7 K 1/16W R68113-103005-12 4 CARBON RESISTOR 10K 1/16W R26.85.91.100113-103005-12 1 CARBON RESISTOR 10K 1/16W R69.123-150340-13 2 C.CAP 15PF C51.46.123-104350-16 4 C.CAP 0.1UF C21.38.44.45.127-474078-01 1 E.CAP 0.47UF/50V TC22.127-227048-01 3 E.CAP 220UF/16V TC21.23.. C47.184-354708-05 1 CHOKE COIL RH 3.5*4.7*0.8-T52 L8

131-448050-03 1 TRANSISTOR JE8050C Q14.131-220764-04 1 TRANSISTOR 2SB764D Q11.

C01-010000-00 1 UL PVC TUBING 1.0*15mm FOR Q11137-240044-30 1 Y2

133-000000-8B 1 CH374S U8160-105205-02 1 PIN SOCKET 5PIN 2.0MM (RED COLOUR) CN5

3 R64.65.66.113-102005-12 1 CARBON RESISTOR 1K 1/16W R55113-472005-12 3 CARBON RESISTOR 4.7K 1/16W R54.86.87.113-103005-12 1 CARBON RESISTOR 10K 1/16W R31123-101340-13 3 C.CAP 100PF NPO C57-59127-227048-01 1 E.CAP 220UF/16V TC19

131-448050-03 1 TRANSISTOR JE8050C Q15.160-110205-01 1 PIN SOCKET 10PIN 2.0MM CN4

184-090503-00 1 FERRITE BEAD 9*5*3MM +CHOKE COIL FOR T101

C16-005000-00 72 40*0.5MM J1-58.R8.11.13.19.38.43.47.52.56.120.102.013.

C01-010000-00 10 UL PVC TUBING 1.0*15mm FOR C40.41.42.43.Q11C01-010010-00 1 UL PVC TUBING 1.0*10MM190-005671-00 1 MTK MP3

158-990803-01 1 CASSETTE PCB MIC 9908 ASS'Y133-207312-11 1 IC AN7312 IC201131-448050-03 1 TRANSISTOR SS8050 Q201

130-134148-00 2 DIODE 1N4148 D201-02

102-819908-01 1 BIAS COIL 21364-230 T201

102-819908-02 1 BIAS COIL 1A1630R T201

144-062040-05 1 REC SW 6P2T PS62D04 NON-SHORTING

160-104255-01 2 PIN SOCKET 4 PIN 2.5MM CN201-02



113-100105-12 1 CAR. RESISTOR 10 OHM1/4W +/-5% R215

113-220105-12 1 CAR. RESISTOR 22 OHM1/4W+/-5% R216

CRYSTAL 24.00MHZ (矮体铁壳）

有SD 卡用料113-561005-12 CARBON RESISTOR 560 OHM 1/16W

注：CE认证用,不做CE认证时扦铁线 x 2pcs

SW 201

PAGE:14/20Print:23/07/2009




113-470105-12 2 CAR. RESISTOR 47 OHM1/4W+/-5% R207 209

113-101105-12 1 CAR. RESISTOR 100 OHM1/4W+/-5% R214

113-472105-12 2 CAR. RESISTOR 4.7K1/4W+/-5% R211 213

113-562105-12 2 CAR. RESISTOR 5.6K1/4W+/-5% R210 212

113-103105-12 2 CAR. RESISTOR 10K1/4W+/-5% R201-02

113-273105-12 1 CAR. RESISTOR 27K1/4W+/-5% R217

113-473105-12 4 CAR. RESISTOR 47K1/4W+/-5% R203.204.205.206

113-684105-12 1 CAR. RESISTOR 680K1/4W+/-5% R208

123-223350-16 2 C. CAP 0.022UF +/-10% 50V+/-20% C218 222

123-101340-13 2 CERAMIC CAP 100P +/-5% 50V C 1.2

126-102071-01 1 MYLAR CAP 0.001uF +/-10%50V C223.

126-152071-01 2 MYLAR CAP 0.0015UF +/-20% 50V C205-06

113-681105-12 2 CAR. RESISTOR 680 OHM 1/4W +/-5% R218-19

126-222071-01 2 MYLAR CAP 0.0022UF +/-20% 50V C205-06

113-102105-12 2 CAR. RESISTOR 1K 1/4W +/-5% R218-19

126-332071-01 2 MYLAR CAP 0.0033uF +/-10%50V C201-02

126-392071-01 1 MYLAR CAP 0.0039uF +/-10%50V C224

126-223071-01 2 MYLAR CAP 0.022UF +/-10%50V C210.211.

127-105078-01 1 ELE. CAP 1UF/50V+/-10% C207

127-335078-01 2 ELE. CAP 3.3UF/50V+/-10% C216.217

127-475078-01 2 ELE. CAP 4.7UF/50V+/-10% C212.213

127-106048-01 1 ELE. CAP 10UF/16V+/-10% C214

127-226048-01 2 ELE. CAP 22UF/16V+/-10% C208.209

127-107048-01 1 ELE. CAP 100UF/16V+/-10% C215

127-227048-01 1 ELE. CAP 220UF/16V+/-10% C221

123-301340-13 1 C. CAP 300PF +/-10% 50V C219

126-152071-01 1 MYLAR CAP 0.0015uF +/-5%50V C220

160-102205-01 1 CN204

126-182071-01 1 MYLAR CAP 0.0018uF+/-10%50V C219

126-472071-01 1 MYLAR CAP 0.0047uF+/-10%50V C225

126-103071-01 1 MYLAR CAP 0.01UF+/-10%50V C220

C16-005000-00 4 JUMPER WIRE 40*0.5MM J***

184-350613-00 4 FERRITE BEAD 3.5*6*1.3MM

190-990803-01 1 CASSETTE PCB 9908PC1

158-073308-01 1 REMOTE HANDSET ASS'Y 113-229005-12 1 CARBON RESISTOR 2.2 OHM1/16W +/-5% R1

113-682005-12 1 CARBON RESISTOR 6.8K1/16W +/-5% R2

123-101340-13 2 CERAMIC CAP 100P +/-5% 50V C 2.3

127-476038-31 1 E .CAP 47UF/10V MINI-SIZE +80-20% C1.

107-200455-24 1 CERAMIC RESONATOR ZTB 455KHZ X1

130-134148-00 2 DIODE IN4148 D1. 2

131-232001-12 1 TRANSISTOR 2SC2001L Q1

130-600012-04 1 INFRARED DIODE KL-IL2 (KODENSHI) TD1

配KEAP4211磁头用料

配T21V1磁头用料

PIN SOCKET 2 PIN 2.0MM

J1.2.3.4.(非CE认证时插铁线)

PAGE:15/20Print:23/07/2009




133-809243-14 1 I.C TC9243F REMOTE 20PINS IC1

C16-005000-00 3 JUMPER WIRE 40*0.5MM J1-3

190-073308-01 1 REMOTE PCB 733PR1

441-030801-25 1 DECK 21 SH2045 (H) 9V

441-030801-51 1 DECK (H) 9V AC ERASE E2183

444-012000-11 1 按生产细则定料444-010001-04 1 按生产细则定料161-991000-00 1 RCA JACK 2 HOLE SPEAKER OUT RCA JACK

147-110102-01 1 LEAF SW ITCH QAS-1229-4

145-022420-07 1 SWITCH SS22 F25-G7

171-660072-00 1 VDE LINE CORD APP.W/O END(KEMA)

171-442072-70 1 AC LINE CORD BS6500 APPROVED

171-230072-00 1

171-210078-00 1171-998078-70 1 AC LINE CORD JAPAN CGE

171-550078-20 1 LINE CODE SAA W/END APPROVED

101-411168-35 1 TRANSFORMER EI-41 230V 50Hz





101-411168-1A 1 TRANSFORMER EI-41 110/220V 60/50Hz





147-120328-00 1 VOLTAGE SELECTOR SWITCH 此开关带机丝螺牙C01-030100-01 3 UL 10MM SHRINK TURE (L=25MM)

C01-030200-00 1 UL 20MM SHRINK TUBE <L=50MM>

172-422018-52 1 UL1672#22AWG RED 180MM VOLTAGE SW. TO AC CORD

194-079030-10 2 CLOSE END CONNECTOR KS.CE2

C01-030200-00 1 UL 20MM SHRINK TUBE <L=50MM>

C01-030100-01 2 UL 10MM SHRINK TUBE(L=35MM)

C08-000020-03 7

C01-010010-00 8 UL PVC TUBING 1.0*10mm FOR DIODE

C01-020010-00 8 FOR DIODE

(依生产细则配料)

CD DECK SANYO 波子头CD DECK 青雅　　波子头

( 按生产细则） ( 按生产细则）

UL CORD SPT-1 W/O END （有极性） ( 按生产细则） UL CORD SPT-1 W/O END NO-POLAR （无极性) ( 按生产细则）

( 按生产细则） ( 按生产细则）











110/220V机增加材料

CABLE TIE "3"(扎线）

PVC 2.0MM TUBE （10MM）

SPEAKER ASS'Y 音箱组件

PAGE:16/20Print:23/07/2009




166-340540-22 2 4" INCH SPEAKER 4 OHM 5W

166-240315-32 2 1.5" INCH SPEAKER 4 OHM 3W

127-105078-21 2 NONPOLAR E.CAP 1UF/50V +80-20%

170-100027-02 2 BUZZER 27MM

172-126020-52 2 UL1007#26AWG RED 150MM

172-126020-50 2 UL1007#26AWG BLACK 150MM

188-920072-20 2 SPEAKER/LEAD WITH RCA PLUG #24

184-251512-00 1 FERRITE BEAD 25*15*12 FOR POWER AC LINE

184-181006-00 6 FERRITE BEAD 18*10*6

线材1 AM ANT

181-803000-19 1 UL1533#28AWG 1000MM AM ANT

172-126013-59 1 UL1007#26AWG 130MM 1PIN WHTE DECK MOTOR TO LEAF SW

172-126018-59 1 UL1007#26AWG 180MM 1PIN WHTE CD KNOB TO MB GND

720-032014-03 1 ANT WASHER 3.2*14*0.3 CD KNOB

172-122015-50 1 UL1007#22AWG 150MM 1PIN WHTE MP GND TO MB GND

181-803200-10 1 UL1533#28 S / S 200MM 2P 1H P=2.0MM TAPE PCB CN203 TO BEAT CUT SW

191-030230-00 1 UL1007#26AWG 230&180MM 2P 1H P=2.5MM MB CN3 TO MOTOR&LEAF SW

177-602151-02 1 UL2468#26AWG 150MM 2P 1H P=2.0MM MP PCB CN8 TO DOOR SW

177-602181-05 1 UL2468#26AWG 180MM 5P 4W 1H P=2.0MM CD PCB TO MB PCB CN2

177-800201-06 1 UL20080#28AWG 200MM 6P 2H P=2.0MM CD DECK TO MP PCB

177-289614-12 1 RADIO RF TO MB CN401

SIZE:1.25PH*12PIN*140MM

177-289612-16 1 CD DECK TO MP PCB

177-289615-16 1 DISPLAY PCB TO MB PCB

178-127150-20 1 UL 1007 #22 AWG 1500MM FM ANT181-813180-20 1 UL2547#28D/ S 180MM 3P 1H P=2.5 MM MB CN6 TO TAPE PCB CN205

191-020130-02 1 ULI007#22AWG 130MM 2P 1H P=2.5MM MAIN PCB CN12 TO MP PCB CN3

191-040160-00 1 UL2547#28D/S&1007#26AWG160MM 4P1H/2.5MMMB CN4 TO 9908PC1 CN202

C01-030100-01 1 UL 10MM SHRINK TUBE(L=40MM)

C01-030002-00 2 UL R=2MM SHRINK TUBE<L=25MM>

181-313160-30 1 UL2854#30T / S 160MM 4P 1H P=2.5MM R/P HEAD TO 9908PC1 CN2O1

191-040160-00 1 UL1007#22AWG 160MM 4PIN WHTE P=2.5mm MB CN301 TO SPEAKER JACK

191-040180-00 1 UL2547#28D/S 180MM 4PIN 1H P=2.0mm MB CN5 TO MP PCB CN6

177-602131-04 1 UL2468#26AWG 130MM 4P 1H P=2.0MM USB TO MP PCB CN5

（按客户要求定料）（按客户要求定料）（按客户要求定料）（按客户要求定料）（按客户要求定料）有蜂鸣片/用线材（按客户要求定料） SPEAKER CABLE（按客户要求定料）

做CE认证时用.按营业部通知配料

FOR (SP OUT * CD AUDIO)LINE; USB; 磁头线TAPE REC LINE (CE认证时用料）

172-126310-50 UL1007#26AWG 3100MM 1PIN WHTE

CD 钮电镀时用

12PIN AWM 2896 SUPER FLEX 12P 140MM (同向)

16PIN AWM 2896 SUPER FLEX16P 120MM(同向）16PIN AWM 2896 SUPER FLEX16P 150MM(同向）

非CE认证时用料

非CE认证时用料, 有USB用线材

做CE认证时用料

PAGE:17/20Print:23/07/2009




184-181006-00 4 FERRITE BEAD 18*10*6 TAPE REC LINE

181-313260-30 1 UL2854#30T / S 260MM 4P 1H P=2.5MM R/P HEAD TO 9908PC1 CN2O1

191-040280-00 1 UL1007#22AWG 280MM 4PIN WHTE P=2.5mm

191-040280-00 1 UL2547#28D/S 280MM 4PIN 1H P=2.0mm MB CN5 TO MP PCB CN6

177-602251-04 UL2468#26AWG 250MM 4P 1H P=2.0MM

177-602131-10 1 UL2468#26AWG 130MM 10P 1H P=2.0MM USB+ CARD PCB TO MP PCB CN4

结构部分METAL PARTS & OTHERS303-088101-00 2 REAR FOOT 17*6.5 MM

303-862801-01 2 FRONT FOOT 23*5 MM

303-201204-02 2 LCD SPONGE20*12*4MM

303-080825-00 1 REMOTE SPONGE8*8*2.5MM

703-099101-00 10 SCREW BRACKET

721-099101-00 1 CASS SPRING

740-060601-00 1 CD DOOR SPRING

308-003105-00 2 FOR CD DECK

308-003103-00 2 FOR CD DECK

714-038801-00 1 HEAT SINK FOR IC 7808C

1 HEAT SINK

701-05501-00 2 PCB BKT(A)301-410000-00 1 CD DOOR LOCK FIQ618807-862801-00 1 BACK BOARD

SCREW & WASHER500-031004-00 2 3*10BA501-020304-00 1 2*3TT RECORDING PLATE*1

501-020404-00 1 2*4TT

501-250604-00 1 2.5*6TT

501-020404-00 1 2*4TT PCB BKT(A)*1

501-260604-00 2 2.6*6TT CASS PCB*2

500-021202-00 1 2*12PA LEAF SWITCH*1

500-260802-00 6 2.6*8PA CD KEY PCB*6

500-030603-00 4 3*6BT SMALL PANEL*4

500-030805-00 1 3*8BTB IC7808 TO HEAT SINK*1

500-031002-00 16 3*10PA CD DAMPER GEAR*1,

USB PCB HOLDER*1

MAIN PCB HOLDER*6

CASS DECK*4 CD PCB*4

500-261004-00 1 2.6*10BA CASS DAMPER GEAR*1

500-031004-00 6 3*10BA SIDE BOARD*4

SPEAKER JACK*2

MB CN301 TO SPK OUT (穿3.5T)

做CE认证时用料, 有USB卡用线材USB TO MP PCB CN5 (穿3.5T)

有SD卡用线材

(高密度海绵)(高密度海绵)

CD RUBBER CUSHION （BIG） 35°C

CD RUBBER CUSHION （BIG） 30°C

714-050501-00

CASS PCB BKT*1 非天凯机芯使用CASS PCB BKT*1 天凯机芯使用

PAGE:18/20Print:23/07/2009




500-031204-00 5 3*12BA BACK*5

501-030802-00 8 3*8BM SIDE BOARD*6 BOTTOM*2

501-031002-00 2 3*6BM BACD TO CD BASE*2

509-261001-10 4 CD DECK*4

509-031001-08 3

POWER CORD*1

503-035160-10 1 FIBER WASHER 3.5*16*1 MM POWER CORD*1

503-030080-05 2 FIBER WASHER 3*8*0.5MM FOR CD DAMPER GEAR

503-030080-10 1 FIBER WASHER3*8*1.0MM FOR CD DAMPER GEAR*1

503-030080-05 3 FIBER WASHER3*8*0.5MM FOR CD KNOB PCB*3

303-080802-00 2 SPONGE 8*8*2.5MM FOR CASS DECK*2

后板功能根据生产细则要求选用以下物料500-031002-00 2 3*10BA AUX JACK*2

501-020602-00 2 2*6BM BEAT CUT/FM SWITCH TO BACK*2

PS-HCD993312 1

500-031002-00 2 3*10BM

501-030802-00 2 3*8BM

501-031002-00 2 3*10BM

508-030000-00 2 M3 NUT

PLASTIC PARTSPS-862801 1 PANEL

PS-862802 1 CD BASE

PS-862803 1 CD DOOR

PS-862805 1 SMALL PANEL PR

PS-862806 1 CASS KNOB DOOR

PS-862807 1 CASS DOOR

PS-862808 1 MAIN PCB HOLDER R

PS-862809 1 MAIN PCB HOLDER L

PS-862810 1 USB PCB HOLDER

PS-862811 1 DISPLAY LENS

PS-862812 1 CASS DOOR LENS

PS-862813 1 CD KNOB A

PS-862824 1 CD KNOB B

PS-862814 1 LOCK

PS-862821 1 CASS KNOB

PS-990854 1 DUST SHIECDING COVER

PS-990852 1 DUST SHIECDING COVER

PS-066103 1 SIDE-L

PS-066104 1

PS-099102-00 1 BOTTOM BOARD

PS-KS77006 1 CASS DAMPER GEAR

PS-CDK3309 1 CD DAMPER GEAR

PS-Z990844 1 SPEAKER LABEL BOTTOM*1

2.6*10PWA（W= 10）3*10PWA （W=8） TRANSFORMER*2 （底板改模后用量）

75 OHM插座盖

无75OHM JACK时选用此物料

三洋和青雅CD机芯使用

SIDE－R

PAGE:19/20Print:23/07/2009




PS-VCD99102 5 PLASTIC WASHER(2)

PS-VCD99101 2 PLASTIC WASHER (1)

PS-CDK52024 1 AM ANT.HOUSING

PS-088103 1 CASS HOLDER

REMOTE CONTROLLER

303-301505-00 1 PAD SPONGE 30*15*5 MM

311-026001-00 1 REMOTE RUBBER KEY

707-993301-00 1 BATTERY PLATE (- )

707-993302-00 1 BATTERY PLATE (+ )

707-993303-00 1

PS-RM26001 1 FRONT CABINET

PS-RM26002 1 BOTTOM CABINET

PS-RM26003 1 BATTERY DOOR

PS-RM29300 1 REMOTE INLAY

SPEAKERS

PS-862822 2 SPEAKER PANEL

PS-862823 8 SPEAKER GRILL

500-030804-00 12 3*8BA

SPEAKER GRILL*8500-041001-00 8 4*10PT 4" SPEAKER*8

PS-862822 2 SPEAKER PANEL

PS-862823 8 SPEAKER GRILL

500-030804-00 12 3*8BA

SPEAKER GRILL*88 3*10PWA(W=8) 4" SPEAKER*8

PS-088132 2 SPEAKER BACK CABINET

12 SPEAKER PANEL*12

PS-Z099139 2 SPEAKER LABEL

951-099102-00 4 RUBBER FOOT 85*8.5*3 MM SPEAKER BOX*4

LABELS642-862802-12 1 INSTRUCTION MANUAL

664-053211-02 1 DATE CODE LABEL

664-053211-05 1 THERMAL FUSE LABEL

664-053211-07 1 LASER BEAM LABEL

664-053211-08 1 LASER CAUTION LABEL

664-053211-10 2 SPEAKER BOX LABEL

664-053211-23 1 SERIAL LABEL

664-099100-05 1 CAUTION & SAFETY LABEL

BATTERY PLATE（+/-）

SPEAKERS 8628 塑胶面木音箱选用物料,根据生产细则要求选用

1.5"SPEAKER*4 (根据生产细则或有关文件有高音喇叭选用)

SPEAKERS 8628 全塑胶音箱选用物料,根据生产细则要求选用

1.5"SPEAKER*4 (根据生产细则或有关文件有高音喇叭选用)

500-031001-00

500-031203-00 3*12BT

PAGE:20/20Print:23/07/2009




664-099100-06 1 CLASS 1 LASER LABEL

664-066100-08 1 MODEL LABEL

622-091000-01 1 CD PAPER DISC

C07-3M8934-00 4 8934 3MFIIAMENT TAPE(60MM)

PACKING & LITERATURE 802-862801-00 2 TOP POLY FOAM

623-862821-21 1 CARTON

811-150180-73 1 POLY BAG 15"*18"*0.03MM

811-150180-73 2 POLY BAG 15"*18"*0.03MM

811-065100-73 1 POLY BAG 6.5"*10"*0.03MM

811-040090-73 1 POLY BAG 4"*9"*0.03MM

811-050100-73 1 POLY BAG 5" X 10" X 0.03MM

Documents

MM15M3