Engine Room Platform 2

Engine Room Platform

2Vocabular

y2

The Control RoomIn the control room there are many computers, monitors and keyboards to enable engineers to control the ships systems. It also allows engineers to monitor the condition of equipment and plan maintenance schedules which helps avoid __________.There are two telegraphs on board a ship. One is one the bridge and the other is in the engine control room. They are used to send messages about changes in the ship’s __________ while maneuvering. The main switch board ensures the non-stop distribution of __________ all over the ship.

Cylinder Head with Exhaust ValveCombustion gases leave the engine through exhaust valves. Every cylinder has an exhaust valve. They are in a valve housing. The valve housing is connected to the cylinder by 4 studs to prevent poisonous gases __________.Auxiliary Generator Sets

Auxiliary generators are designed for continuous operation. The system has engines connected to generators to __________electricity to the ship.

Exhaust Gas Boiler and Fresh Water Generator

Exhaust gas boilers make steam by using the high temperature of exhaust gases to __________ water and make steam.

The fresh water generator uses hot steam to _________ seawater which is then used in the ship.

Fresh Water Coolers reuse freshwater that has been used to cool the engine. The water is __________ around the engine. After this it goes back to the fresh water coolers where the temperature is __________ by seawater.

BoilersA boiler is used to ________ water to make steam. Most boiler units include, oil burners, pumps, and automatic controls.

Exhaust gas boilers __________ steam by using the high temperature of exhaust gases. The boiler raises the temperature of the steam in it’s own drum.

Fuel Oil Separators / Centrifugal PumpsMarine Fuel Oil is the oil that is left after all lighter fuels have been taken out of it. It often has catalyst fines in it which are very hard and can cause a lot of __________ to the engine. The way to remove the catalyst fines is by centrifugal separation.

Find the odd word in each rowMachine Engine Temperature Pump

Piston Cylinder Shaft Petrol

Power Force Physics Energy

Combustion Ignition Burning Petrol

Expanding Rotating Turning Circular

propelling Burning Driving moving

Put the words in the correct boxEngine Parts Engine Operation

Connecting rod

Combustion Power Crankshaft

Piston Energy Propulsion CompressionDrive Piston top Rod end Cylinder

Thank You