.SUDARSHAN ENGINEERING.

• Vacuum Compressor.• Refrigerated Air Dryers.• Heatless Air Dryers.

PRESENTATION ON….

Contact us : http://www.sudarshanengg.com

Vacuum Compressor• These Products Are Suitable For Use In Extreme

Environments Where Zero Leakage, Zero Contamination, High Reliability, And Long Life Are Required. We Are Able To Achieve This Superior Performance With Non-wearing Wetted Surfaces Fabricated From Corrosion Resistant Stainless Steels.

• Its Design & Construction Features Are : • Long Life – Capable Of A Minimum Of 10,000 Hours

Continuous Operation• Stainless Steel Construction – All Wetted Surfaces Are

Corrosion Resistant Stainless Steel Except For Valve Assembly Gaskets That Are Either Teflon Or Viton

Refrigerated Air Dryers• Refrigerated Air Dryers Remove The Moisture To A

Level Of 600 Ppm(w) By Using Energy Efficient Refrigeration System And Effective Heat Exchangers. The Wet Air Enters Into The Economizer (Pre Cooler) Of The Refrigerated Air Dryer And The Temperature Gets Reduced Significantly By The Outgoing Cold Air.

• This Medium Temperature Air Further Enters In To The Evaporator Of The Refrigerated Air Dryer And The Temperature Drops To 2oc By The Cold Refrigerant.

• At This Temperature The Moisture In The Vapour Form Condenses Into Liquid And The Same Is Separated By High Efficient Integral Moisture Separator And Automatic Drain Trap. All The Three Components Are Integrated Into One Single Unit.

Heatless Air Dryers• Wet Incoming Compressed Air Or Gas Is Passed

Through A Desiccant Bed; The Desiccant Adsorbs Its Moisture. After Some Time Of Operation, This Desiccant Gets Saturated And Needs Regeneration.

• Reactivation Or Regeneration Of Desiccant Is Then Necessary To Drive-off The Adsorbed Moisture And To Re-store Its Original Absorptive Capacity.

• This Is Accomplished Via Purging The Adsorbent By Dry Air Or Gas At Atmospheric Pressure And Temperature In Reverse Direction.

Its Salient Features • Low initial installation and operating cost.

• High performance and almost Zero maintenance cost. • Low temperature operation which reduces corrosion of towers.

• Only single phase electric power is required.

• Desiccant life around 3 – 5 years.

THANK YOUContact us :

http://www.sudarshanengg.com