3
@ IJTSRD | Available Online @ www ISSN No: 245 Inte R Method Development of by U Nikhil Departmen Prin. K. M. Kundnani Colle ABSTRACT A simple, precise, accurate, cost effe indicating UV Spectrophotometric met developed for the estimation of Metho highest λmax at 303nm. Beer's l response) was found over a concentratio 10 μg /mL with good correlation coe 0.9987 and the values of standard d satisfactory low and the recovery studies 100%. The Proposed spectrophotometri validated as per the ICH Q1A (R2) guid this method can be safely be employed quality control analysis of Methotrexate. Keywords: Methotrexate, Method Deve Visible Spectroscopy INTRODUCTION Methotrexate is an antineoplastic a IPUAC name 2S)-2-[(4-{[(2, diam 1(methyl)](methyl) amino} phenyl) form drug for the treatment of certain type and psoriatic arthritis. It may also be us immune system related inflammatory drug acts as a selective i nhibitor of the acid reductase and inhibits DNA s cellular replication. It is abbreviated M official in Indian Pharmacopoeia, USP, B Figure.1 Structure of Methotr w.ijtsrd.com | Volume – 2 | Issue – 4 | May-Jun 56 - 6470 | www.ijtsrd.com | Volum ernational Journal of Trend in Sc Research and Development (IJT International Open Access Journ f Methotrexate in Phosphate B UV-Visible Spectroscopy l Rajnani, Dr. Nalini Satish Kurup nt of Pharmaceutics, University of Mumbai, ege of Pharmacy, Cuffe Parade, Mumbai, Mahara ective stability thod has been otrexate shows law (linearity on range of 2- efficient (r2 = deviation were s were close to ic method was delines. Hence for the routine . elopment, UV- antimetabolite, minopteridin-6- m amide]} is a es of psoriasis seful for other diseases. The e enzyme folic synthesis and MTX and it is BP rextae MATERIALS AND METHO Materials: Methotrexate pure drug was by Neon Laboratories Mumba UV Spectrophotometer (Jasco Selection of detection wavele To determine the optimum λm /mL of working standard so Phosphate Buffer Solution wavelength range of 200 - blank. It was observed th maximum absorbance at 303 n the detection wavelength f Methotrexate. Preparation of stock and solution: Methotrexate 10 μg/ mL stan done by transferring precise Methotrexate to 10 ml volume in Phosphate Buffer Solution. up to the mark with Phosphat this solution 1 ml was precise volumetric flask and volume w with Phosphate Buffer Solutio ml was precisely transferred flask and volume was made Phosphate Buffer Solution to 10 μg/mL. Figure 2 shows th Methotrexate. n 2018 Page: 1213 me - 2 | Issue 4 cientific TSRD) nal Buffer Solution ashtra, India ODS procured as gift sample ai. Drug was analyzed on o V630) ength:- max, Methotrexate 10 µg olution was prepared in and scanned in UV 400 nm utilizing as a hat the drug showed nm which was chosen as for the estimation of working standard ndard stock solution was ely weighed 10 mg of etric flask and dissolved . The volume was filled te Buffer Solution. From ely transferred into 10ml was made up to the mark on. From this solution 1 d into 10ml volumetric e up to the mark with obtain concentration of he overlain spectrum of

Method Development of Methotrexate in Phosphate Buffer Solution by UV-Visible Spectroscopy

  • Upload
    ijtsrd

  • View
    5

  • Download
    0

Embed Size (px)

DESCRIPTION

A simple, precise, accurate, cost effective stability indicating UV Spectrophotometric method has been developed for the estimation of Methotrexate shows highest max at 303nm. Beers law linearity response was found over a concentration range of 2 10 µg mL with good correlation coefficient r2 = 0.9987 and the values of standard deviation were satisfactory low and the recovery studies were close to 100 . The Proposed spectrophotometric method was validated as per the ICH Q1A R2 guidelines. Hence this method can be safely be employed for the routine quality control analysis of Methotrexate. Nikhil Rajnani | Dr. Nalini Satish Kurup "Method Development of Methotrexate in Phosphate Buffer Solution by UV-Visible Spectroscopy" Published in International Journal of Trend in Scientific Research and Development (ijtsrd), ISSN: 2456-6470, Volume-2 | Issue-4 , June 2018, URL: https://www.ijtsrd.com/papers/ijtsrd14256.pdf Paper URL: http://www.ijtsrd.com/pharmacy/analytical-chemistry/14256/method-development-of-methotrexate-in-phosphate-buffer-solution-by-uv-visible-spectroscopy/nikhil-rajnani

Citation preview

Page 1: Method Development of Methotrexate in Phosphate Buffer Solution by UV-Visible Spectroscopy

@ IJTSRD | Available Online @ www.ijtsrd.com

ISSN No: 2456

InternationalResearch

Method Development of Methotrexate in Phosphate Buffer Solution by UV

Nikhil RajnaniDepartment of Pharmaceutics

Prin. K. M. Kundnani College of Pharmacy

ABSTRACT A simple, precise, accurate, cost effective stability indicating UV Spectrophotometric method has been developed for the estimation of Methotrexate shows highest λmax at 303nm. Beer's law (linearity response) was found over a concentration range of 210 μg /mL with good correlation coefficient (r2 = 0.9987 and the values of standard deviation were satisfactory low and the recovery studies were close to 100%. The Proposed spectrophotometric method was validated as per the ICH Q1A (R2) guidelines. Hence this method can be safely be employed for the routine quality control analysis of Methotrexate. Keywords: Methotrexate, Method Development, UVVisible Spectroscopy INTRODUCTION Methotrexate is an antineoplastic antimetabolite, IPUAC name 2S)-2-[(4-{[(2, diaminopteridin1(methyl)](methyl) amino} phenyl) form amide]} is a drug for the treatment of certain types of psoriasis and psoriatic arthritis. It may also be useful for other immune system related inflammatory diseases. The drug acts as a selective inhibitor of the enzyme folic acid reductase and inhibits DNA synthesis and cellular replication. It is abbreviated MTX and it is official in Indian Pharmacopoeia, USP, BP

Figure.1 Structure of Methotrextae

@ IJTSRD | Available Online @ www.ijtsrd.com | Volume – 2 | Issue – 4 | May-Jun 2018

ISSN No: 2456 - 6470 | www.ijtsrd.com | Volume

International Journal of Trend in Scientific Research and Development (IJTSRD)

International Open Access Journal

Method Development of Methotrexate in Phosphate Buffer Solution by UV-Visible Spectroscopy

Nikhil Rajnani, Dr. Nalini Satish Kurup Department of Pharmaceutics, University of Mumbai,

K. M. Kundnani College of Pharmacy, Cuffe Parade, Mumbai, Maharashtra,

A simple, precise, accurate, cost effective stability indicating UV Spectrophotometric method has been developed for the estimation of Methotrexate shows highest λmax at 303nm. Beer's law (linearity response) was found over a concentration range of 2-

/mL with good correlation coefficient (r2 = 0.9987 and the values of standard deviation were satisfactory low and the recovery studies were close to 100%. The Proposed spectrophotometric method was validated as per the ICH Q1A (R2) guidelines. Hence

method can be safely be employed for the routine quality control analysis of Methotrexate.

Methotrexate, Method Development, UV-

Methotrexate is an antineoplastic antimetabolite, diaminopteridin-6-

1(methyl)](methyl) amino} phenyl) form amide]} is a drug for the treatment of certain types of psoriasis

may also be useful for other immune system related inflammatory diseases. The

nhibitor of the enzyme folic acid reductase and inhibits DNA synthesis and

is abbreviated MTX and it is official in Indian Pharmacopoeia, USP, BP

Figure.1 Structure of Methotrextae

MATERIALS AND METHODS

Materials:

Methotrexate pure drug was procured as gift sample by Neon Laboratories Mumbai. Drug was analyzed on UV Spectrophotometer (Jasco V630)

Selection of detection wavelength:

To determine the optimum λmax, Methotrexate 10 µg

/mL of working standard solution was prepared iPhosphate Buffer Solution and scanned in UV wavelength range of 200 - blank. It was observed that the drug showed maximum absorbance at 303 nm which was chosen as the detection wavelength for the estimation ofMethotrexate. Preparation of stock and working standard solution: Methotrexate 10 μg/ mL standard stock solution was done by transferring precisely weighed 10 mg of Methotrexate to 10 ml volumetric flask and dissolved in Phosphate Buffer Solution. The volume was filled up to the mark with Phosphate Buffer Solution. From this solution 1 ml was precisely transferred into 10ml volumetric flask and volume was made up to the mark with Phosphate Buffer Solution. From this solution 1 ml was precisely transferred into 10ml volumetric flask and volume was made up to the mark with Phosphate Buffer Solution to obtain concentration of 10 μg/mL. Figure 2 shows the overlain spectrum ofMethotrexate.

Jun 2018 Page: 1213

www.ijtsrd.com | Volume - 2 | Issue – 4

Scientific (IJTSRD)

International Open Access Journal

Method Development of Methotrexate in Phosphate Buffer Solution

Maharashtra, India

MATERIALS AND METHODS

pure drug was procured as gift sample by Neon Laboratories Mumbai. Drug was analyzed on UV Spectrophotometer (Jasco V630)

Selection of detection wavelength:-

To determine the optimum λmax, Methotrexate 10 µg

/mL of working standard solution was prepared in Phosphate Buffer Solution and scanned in UV

400 nm utilizing as a blank. It was observed that the drug showed maximum absorbance at 303 nm which was chosen as the detection wavelength for the estimation of

tion of stock and working standard

Methotrexate 10 μg/ mL standard stock solution was done by transferring precisely weighed 10 mg of Methotrexate to 10 ml volumetric flask and dissolved in Phosphate Buffer Solution. The volume was filled

he mark with Phosphate Buffer Solution. From this solution 1 ml was precisely transferred into 10ml volumetric flask and volume was made up to the mark with Phosphate Buffer Solution. From this solution 1 ml was precisely transferred into 10ml volumetric lask and volume was made up to the mark with

Phosphate Buffer Solution to obtain concentration of 10 μg/mL. Figure 2 shows the overlain spectrum of

Page 2: Method Development of Methotrexate in Phosphate Buffer Solution by UV-Visible Spectroscopy

International Journal of Trend in Scientific Research and Development (IJTSRD) ISSN: 2456-6470

@ IJTSRD | Available Online @ www.ijtsrd.com | Volume – 2 | Issue – 4 | May-Jun 2018 Page: 1214

Figure.1 UV Spectrum of Methotrexate in Phosphate Buffer Solution

Preparation of Calibration curve: A calibration curve was plotted over a concentration range of 2-10 μg/mL for Methotrexate. Calibration curve was done by plotting Methotrexate concentration on X-axis and their respective absorbance’s on Y-axis. Calibration data is shown in Table No. 1. And calibration curve is exhibit in Figure 3.

Table No. 1 Calibration Data of Methotrexate in Phosphate Buffer Solution

Figure.2 Calibration Curve of Methotrexate in Phosphate Buffer Solution

Precision The intra-day precision (repeatability) was evaluated by analyzing six replicates of methotrexate sample solutions (n

= 6), at test concentration (10 μg/mL). Similarly, the inter- day precision (reproducibility) was evaluated in two consecutive days (n = 12) and the relative standard deviation (RSD) was calculated. Precision data is shown in the Table No. 2.

Table No. 2 Precision data

Concentration Intraday Interday Standard Deviation

6 μg/ml 0.5821 0.5884 0.01 8 μg/ml 0.7895 0.7985 0.01

Accuracy Methotrexate standard solutions, at three different nominal levels (50%, 100% and 150%), At each level, solutions were prepared in triplicate and the recovery percentage was calculated. The mean percentage recovery of methotrexate at each level between 98 and 102% indicated the accuracy of the analytical method. Recovery data is shown in the table no. 3

Table No. 3 Recovery data

Nominal Theoretical Concentration

Experimental Concentration

% Recovery

50% 4.5 μg/ml 4.41 μg/ml 98.12 100% 6 μg/ml 6.07 μg/ml 101.24 150% 7.5 μg/ml 7.51 μg/ml 100.26

DISCUSSION: The UV spectra of Methotrexate was scanned in the region between 200-400 nm. Methotrexate show absorbed maximum at 303nm which was selected as the detection wavelength. The response of the Methotrexate was found to be linear in the ranges from 2-10 μg/mL with a good correlation. The values of standard deviation were satisfactory low and the recovery studies were close to 100%. Optical Parameters are shown in Table No. 4

Concentration (µg/ml)

Absorbance

2 0.2001

4 0.3941

6 0.5786

8 0.7998

10 0.9663

Page 3: Method Development of Methotrexate in Phosphate Buffer Solution by UV-Visible Spectroscopy

International Journal of Trend in Scientific Research and Development (IJTSRD) ISSN: 2456-6470

@ IJTSRD | Available Online @ www.ijtsrd.com | Volume – 2 | Issue – 4 | May-Jun 2018 Page: 1215

Table No. 4 Optical Parameter

Parameter Value Absorbance 303nm Range 2-10µg /ml Correlation Coefficient 0.9987 Regression Equation 0.0967x+0.0063 % Recovery 98-101% Limit of Detection 0.439µg Limit of Quantification 1.33µg

CONCLUSION Simple, precise and economical UV-visible spectrophotometric method has been developed for the quantitative estimation of Methotrexate in its API form. Method is developed as per the ICH guidelines. The developed method can be used for the quantification of Methotrexate drug substances in routine analysis.

REFERENCES

1) Oliveira, A. R.; Caland, L. B.; Oliveira, E. G.; Egito, E. S. T.; Pedrosa, M. F. F.; Silva, A. A. Hplc-Dad And Uv-Vis Spectrophotometric Methods For Methotrexate Assay In Different Biodegradable Microparticles. J. Braz. Chem. Soc. 2015, 26 (4), 649–659.

2) Patil, P. D. Y. Auv-Spectrophotometric Determination Of Methotrexate In Tablet Dosage Form Patel Faijal *, Shelke Maroti And Suryawanshi Samrat. 2015, 5 (4), 641–644.

3) Ramacahandra, B.; N.V.S Naidu; P. Sugun; Kantipudi Rambabu. Validation of Uv – Visible Spectrophotometric Method For The Analysis Of Methotrexate In Pharmaceutical Formulations. İnternational J. Pharm. Pharm. Sci. Res. 2013, 3 (3), 108–114.

4) Ramachandra, B.; N.V.S.Naidu; Rambabu; Kantipudi; P.Sugun. Original Article Validation of Uv – Visible Spectrophotometric Method For The Analysis Of Methotrexate In Pharmaceutical Formulations. Int. J. Pharm. Pharm. Sci. Res. 2013, 3 (3), 108–114.

5) Suryawanshi, S.; Shinde, P.; Thamke, N.; Mohite, M.; Padm, D. Y. Spectrophotometric Determination of Methotrexate In Tablet Dosage Form. 2015, 2 (6), 153– 155.

6) Cristina Magalhães Santos, M.; Da Costa, V. M.; Pereira, A. D. F.; Silva-Cunha, A.; Ligório Fialho, S.; Pereira Santinho Gomes, A. J.; Gisele, R. D. S. Development And Validation Of Spectrophotometric Method For Determination Of Methotrexate Incorporated Into Plga Implants. Int. J. Drug Dev. Res. 2013, 5 (1), 154–160.

7) Subbarayan S., Karthikeyan V. Analytical method development and validation of layer by layer magnetic nanoparticles of methotrexate and melphalan.world journal of pharmacy and pharmaceutical sciences. 3(3): 1221-1253.

8) Maste M. M., Bhat A. R., Mohite M. and Patil D., Spectroscopic method for estimation of Methotrexate in bulk and tablet dosage form. 2011; 2(2): 47-50.

9) Jaroslaw C., Tomasz G. and Janusz B. methods for methotrexate determination in Macromolecular Conjugates Drug Carrier. Acta poloniae Pharmaceutical and Drug Research, 2012; 69(6): 1342n1346.

10) Alice R. Oliveira, Lilia B. Caland, Edilene G. Oliveira, Eryvaldo S. T. Egito, Matheus F. F. Pedrosa and Arnobio A. Silva Junior, HPLC-DAD and UV-Vis Spectrophotometric Methods for Methotrexate Assay in Different Biodegradable Microparticles, J. Braz. Chem. Soc., 2015; 26(4): 649-659.

11) ICH, Q2A, Text on Validation of Analytical Procedures, International Conference on Harmonization, Geneva, October 1994; 1.

12) ICH, Q2B, Validation of Analytical Procedures: Methodology, International Conference on

Harmonization, Geneva, November 1996; 1.

ACKNOWLEDGEMENT

We would like to thank Neon Laboratories for the gift sample of drug