TC52 hv comfort e - Unicat · Expedition vehicle TC52 hv comfort / ... Bendix antilock brake system, 4-channel ... Stainless steel lifting and locking device

Expedition vehicle TC52 hv comfort /

International 7400 4x4

Unique opportunity …

Ideal for all kinds of expeditions or adventure trips for 3-4 people

Proven, very well maintained vehicle, only 40,000 miles ( 64,000 km)

You don’t need to be an experienced expedition traveler.

We will support you to whatever level you want.

Offer UNICAT expedition vehicle TC52 hv comfort / International 7400 4x4 1 / 27

Chassis

International 7400 4x4

Extended cab - Overall length – 372”, width – 98”, height – 144”

Wheelbase – 213” (5410 mm)

DT570 50-state, 310 hp, 950 lb-ft torque @ 1200 rpm, #2 bell housing

8 mpg @ 60 mph

Engine block heater – Phillips 120v/1250w

Air compressor – Bendix TU-FLO 550, 13.2 cf quick connects front and rear

Allison 3000 RDS P close ratio, 6-speed w/overdrive

Transfer case – Meritor T-4210, 2-speed, 10,000 lb w/provision for PTO

All wheel drive, engageable

Driver controlled main locking differential

Air brake ABS – Bendix antilock brake system, 4-channel

Exhaust brake – D Logic, electronically activated

Air dryer – Bendix AD-IP with heater

Alcoa 22.5” aluminium wheels

Michellin XZL 445/65 R22.5

Fuel tanks – 2 X 100 gal w/ 9mm skid plates (approximately 1,600 mi range)

Racor fuel prefilters w/ water separators/heaters

SS roof rack – Wired for sat com, storage compartment, generator cooling

system, work lights, and 4 X Hella 2100 HID lights

SS wire mesh head lights brush & stone guards

Winches – hydraulic 15,000 lb front & rear w/15 gal reservoir and PTO pump

Rear bumper - SS fold-down under-ride protection

Water fording - all breather tubes raised to minimum 5’, positive pressure in

generator compartment, sealed storage compartments

2” tow hitch receivers at front and rear

Upgraded cab - leather & wood trim, additional insulation

SS fire extinguisher

Seats - adjustable air suspension front

Cab air suspension

Power windows & doors w/remote control

Full gauges & instrumentation

Cobra CB radio

Alpine CDA-9857 AM FM XM CD Ipod stereo system

GPS – Garmin 7500 w/rear view camera


Body

Outer dimensions of the cabin

Length 5200 mm (205”), width 2480 mm (98”), height 2105 mm (83”)

Inner dimension of the cabin

Length 5080 mm (200”), width 2360 mm (92.9”), height 1950 mm (76.8”)

Frame assembly

3-point kinematic attachment with main and flex mounts for stress-free body

coupling to the torsion elastic chassis frame

Body unit construction

Self supporting UNICAT sandwich plate panels of fiberglass composite

Panel connections made by adhesive bond to custom extrusions eliminates

metallic heat conduction paths

Matched thermal coefficients of expansion prevent distortion with changes in

temperature

Wall thickness 60 mm (2.36”) with polyurethane foam insulation, 3 mm (0.12”)

FRP outer surface, 2 mm (0.08”) FRP inner surface

Insulation rating 0.44 W/sqm K (0.078 btu/ft h degF)

Floor panel with integrated welded steel frame and FRP surfaces

Slope at rear to improve slope angle

Slanted front of body for better aerodynamics and appearance

Access to drivers cab

Highly flexible waterproof bellows coupling

Access closable

Entrance door and storage compartment doors

Entrance door and storage compartment door constructed of fiberglass

composite panels and frames

Thickness of doors 60 mm (2.36”)

Double sealed doors with heavy duty locks with seal compression

Stainless steel hinges throughout

Additional retractable bolts at top and bottom of doors

Safety cylinder locks all keyed alike

Mosquito net for entrance door


Windows

Burglarproof, scratchproof top-hinged windows with fiberglass frames

Double insulated thermal window glass

Double seals with heavy duty lock

Stainless steel hinges throughout

Stainless steel lifting and locking device

Black-out and mosquito blinds

Fixed windows in the front

Skylights

MaxxVent roof fans in bath and kitchen

4-step switchable fan for ventilation and exhaust

Stairs

Hydraulic powered entrance stairs


Interior layout

Seating area

Seating area for 2-4 persons, with adjustable swiveling table on pedestal in the

front of the cabin

Seating unit converts to additional bed

Bed

Queen-size bed with suspension, ventilation and comfortable mattress in the

rear on pedestal

Size: 1500 x 2000 mm (60” x 80”)

Sanitary room

Combined shower and toilet room with door to isolate from living area

Separated shower cabin with access from sanitary room, closed with a curtain

Cupboard with stainless steel wash basin

Wall cupboard with mirror above the basin

Also usable as dry storage due to its own radiator

Kitchen

Countertop with integrated stainless steel sink

LPG 3-flame stove with LPG oven

Microwave oven

2x 113 liters (2x 4 cubic foot) fridge with freezer

Kitchen cabinet with drawers on ball bearings

Shock-proof separation for tableware, cookware and kitchen appliances

Overhead cupboards above kitchen

Folding kitchen countertop

Storage

Wardrobe for hanging clothes, pull-out storage boxes

Overhead cupboards and storage space in bed area

Storage space in seating area

Large outside storage compartment under the bed pedestal

Stainless steel exterior storage boxes


Workmanship

All furniture is built to the highest cabinet making standard, made of wood core

plywood using heavy duty locks and hinges

White surfaces and teak edges

Lay out

Teak floor

Walls and ceiling are painted with multiple coats

Upholstery made of ALCANTARA


Technical equipment

Electrical equipment

Control panel for power management and monitoring of liquid levels

Battery main switch, fault current breaker, safety cut-out

DC power supplied by AGM battery bank

Battery capacity: 12 V – 840 Ah

Alternator with automatic I-U regulator, charge rate: 14V – 90A

AC-DC charger: 14V – 120A

Inverter 115 V AC, max output 3 kW

Power plugs for 12V DC and 115V AC

Solar power system 12V – 369W

Generator

Water-cooled Fischer-Panda diesel generator with 2-cylinder diesel engine

Performance: 5.5 kW / 6.9 kVA

Radiator for hot climates, with post-cooling

Pressurized cabinet, to protect against water entering, while fording

Audio-visual system

Alpine CDA-9857, CD changer, AM FM, XM sat radio, Ipod

Sharp 21” LCD HDTV/DVD players at bed and dining area

Brackets and wiring for outside speakers

Lighting

Low voltage XELOGEN ceiling lights above the table, kitchen, bed and shower

Reading lights in bed and seating area

Lights for outside storage compartment

Maglite flashlight with charger bracket

Water supply

425 liters (112 US gallons) freeze-proof drinking water tanks

22 liters (8 US gallons) hot water heat-exchanger

All plumbing is insulated to prevent freezing

Grey water tank, capacity 100 liters (25 US gallons), freeze-proof

Outside shower

Water filtration system


LPG supply

2 x 30 lb. LPG cylinders in sealed compartment

Quick connect for barbecue

Toilet

Sealand porcelain toilet with water flushing

Freeze-proof sewage holding tank, capacity 60 liters (15 US gallons)

Heating and A/C systems

Diesel powered warm water central heating (5kW) (17,000 btu)

High radiant heat share due to radiators in living area and sanitary room

Towel dryer type radiator, mounted in the shower

Additional heater in bed area

Antifrost system

2 roof-mount air conditioners, performance 3.9 kW (13,500 btu), powered by the

generator or shore power

Others

Fire, smoke and carbon monoxide detector/alarm

Stainless steel fire extinguisher

Spare - rear mounted w/manual hoist

Rear rack – manual hoist, adaptable for storage, inflatable boat/outboard,

bicycles or motorcycle

15’ Zodiac inflatable boat w/15hp Yamaha outboard

Front bumper mounted motorcycle rack w/Tomos Arrow Scooter

Portable 6 gph reverse osmosis unit (Spectra “Aquifer”)

Expedition grade first aid kit

Self extrication kit

Chassis/motor-specific expedition replacement parts kit

Generator expedition replacement parts kit

Emergency outside (DragonMax) lighting

International water connectors/adaptors and hoses kit

International electrical adaptors kit

International propane adaptors kit

Air fittings and hoses kit


General information

Weight and measures

GVWR: 33,000 lbs (15,000 kg), GCVWR - 80,000 lb

Dimensions: L 9449 mm (372”), W 2490 mm (98”), H 3658 mm (144”)

General condition

Year of manufacture: 2006

Mileage: approx. 40,000 mls ( 64,000 km)

First owner

Very well maintained

Available for your immediate use

Price

Asking price: $500,000

The vehicle is licensed in the USA

Selling on customer's order




















Documents

TC52 hv comfort e - Unicat · Expedition vehicle TC52 hv comfort / ... Bendix antilock brake system, 4-channel ... Stainless steel lifting and locking device