Sharp AR-164 Service Manual

This document has been published to be used forafter sales service only.The contents are subject to change without notice.

Parts marked with “ “ are important for maintaining the safety of the set.

Be sure to replace these parts with specified ones for maintaining the safety and performance of the set.

SHARP CORPORATION

DIGITAL COPIER

AR-162SMODEL AR-164

CODE : 00ZAR162S/A1E

[1] INTRODUCTION

The AR-162S and AR-164 are minor change models of the AR-162 and AR-163 digital copier. Therefore this manual describes only the differences from the AR-162/163 and supplements.For the other items, refer to the following Service documentation.•AR-162/163 Service Manual : 00ZAR162//A1E Parts Guide : 00ZAR162//P1/•AR-SP2 Service Manual : 00ZARSP2//A1E Parts Guide : 00ZARSP2//P2/•AR-EB3 Service Manual : 00ZAREB3//A1E Parts Guide : 00ZAREB3//P1/

[2] LIST OF DIFFERENCES FROM AR-162/163

*Depending on the destination

AR-162 AR-162S AR-163 AR-164 Note

Copy Speed 16 sheets / minutes 16 sheets / minutes 16 sheets / minutes 16 sheets / minutes A4 or Letter / 100%

Standard tray 1 tray+MB 1 tray+MB 1 tray+MB 1 tray+MB 1 tray : 250 sheetsMB : 100 sheets

Option tray 1 tray or 2 tray Not Available 1 tray or 2 tray 1 tray or 2 tray

Duplex Not Available Not Available Not Available Not Available

Shifter Not Available Not Available Standard Standard

Scan Once Print Many Not Available Not Available Standard * Standard 1 Page memory : 10MB

Original size detection Not Available Not Available Not Available Not Available

SPF OPTION OPTION OPTION SPF Standard Option : AR-SP2

RSPF Not Available Not Available Not Available Not Available

Original cover Standard Standard Standard Not Available

E-sort OPTION Not Available OPTION Standard Option : AR-EB3

Fax OPTION Not Available OPTION OPTION Option : AR-FX2

Job Separator (Paper exit full detection)

OPTION Not Available OPTION OPTION Option : AR-TR2

Printer expansion Kit (PCL6) OPTION Not Available OPTION OPTION Option : AR-PB8

PS2 expansion Kit OPTION Not Available OPTION OPTION Option : AR-PS1

LCD Panel OPTION Not Available OPTION OPTION Option : AR-PA1

NIC card OPTION Not Available OPTION OPTION Option : AR-NC3D

��

AR-162S SPECIFICATIONS 3-1

[3] SPECIFICATIONS1. Copy modeA. Type

B. Machine composition

(1) Option

C. Copy speed

(1) Scan Once Print many

Condition : Copy speed in the normal copy from all the paper feed portsincluding the manual paper feed port.

(2) Continuous copy speed (Sheets/min)

D. First copy time

(1) Basic speed

E. Document

(1) SPF / R-SPF

F. Paper feed

(1) Paper feed section of the copier

(2) Manual paper feed section

Type Desk-top

AR-162S 16-CPM option (Limited function model)AR-164 16-CPM standard model (with shifter)

Machine Model Note

250 sheets paper feed unit AR-DE5 AR-162S cannot be installed.

250 sheets x 2 paper feed unit AR-DE6 AR-162S cannot be installed.

SPF AR-SP2 AR-164 standard

RSPF AR-RP1 Not available

Original cover AR-VR1 AR-162S standardAR-164 cannot be installed.

Electronic sorting kit AR-EB3 AR-164 standardAR-162S cannot be installed.

Printer expansion kit AR-PB8 AR-162S cannot be installed.

Facsimile extension kit AR-FX2 AR-162S cannot be installed.

LCD panel kit (20 digits x 2 lines)

AR-PA1 AR-162S cannot be installed.

Job separator tray AR-TR2 AR-162S cannot be installed.

PS2 expanstion kit AR-PS1 AR-162S cannot be installed.

Extension memory for FAX (2MB)

AR-MM5 AR-162S cannot be installed.





AR-162S Not availableAR-164 Available

Paper size Normal Enlargement (200%) Reduction (50%)

AB system

A3 9 9 9

B4 10 10 10

A4 16 16 14

A4R 12 12 12

B5 16 16 16

B5R 14 14 14

Paper size Normal Enlargement (200%) Reduction (50%)

Inch system

11" x 17" 9 9 9

8.5" x 14" 10 10 10

8.5" x 13" 11 11 11

8.5" x 11" 16 16 14

8.5" x 11"R 12 12 12

8.5" x 5.5" 16 16 16

First copy time 7.2sec (A4, 8.5" x 11" / 1st tray / with OC)

Max. document size A3, 11" x 17"Document reference position Left side centerDetection (Platen) AR-162S None

AR-164Detection size A3, B4, A4, A4R, B5, B5R, A5,

11" x 17", 8.5" x 14",8.5" x 13",8.5" x 11",8.5" x 11"R, 8.5" x 5.5"(8.5" x 13" is detected by key input.)

Standard / Option OptionSPF; AR-SP2 (AR-164 standard)RSPF; Not available

Document load capacity 30 sheets (56 ~ 90g/m² equivalent)(15 ~ 23.9 lbs.)

Document size (Max. ~ Min.)

A3 ~ A511" x 17" ~ 8.5" x 5.5" (8.5" x 5.5", duplex is inhibited.)

Document replacement speed 16 sheets / min (A4 x 8.5" x 11" normal copy)

Document set / Paper feed direction

Face up, Center reference, Paper feed from the top

Document weight 56 ~ 90g/m², 15 ~ 23.9 lbsDocument size detection On the document feed trayDocument mixture Copy mode : Not Available

Copy size (Max. ~ Min.)

(A3 ~ A6) 11" x 17" ~ 8.5" x 5.5"

Paper feed system AR-162S 1 cassette + Multi manual paper feedAR-164

Paper feed capacity

AR-162S 250 x 1 (Paper feed tray) +100 (Multi bypass feed tray)AR-164

Remaining quantity detection

Cassette section Empty detection available, size detection by key input

Manual tray Only empty detection available

Paper feed size A3, B4, A4, A4R, B5, B5R, A5,11" x 17", 8.5" x 14", 8.5" x 13", 8.5" x 11", 8.5" x 11"R, 8.5" x 5.5" (For A5 and 8.5" x 5.5", only No. 1 tray available.)

Side front FrontPaper feed capacity

250 sheets (56 ~ 80g/m² equivalent) (15 ~ 21 lbs.)

Detection Paper empty detection available,size detection (by key input)

Weight 56 ~ 80g/m² (15 lbs. ~ 21 lbs.)Special paper Recycled paper

Paper feed size A3 ~ A6, 11" x 17" ~ 8.5" x 5.5"Paper feed capacity

100 sheets

Detection Size detection not available, paper empty detection available

Weight 56 ~ 128g/m² (15 ~ 34 lbs.)Special paper Recycled paper, OHP film, labelsPaper feed Single except for recycled paper

�� !"#$�%


(3) Option paper feed unit (for AR-164)

G. Job speed

Condition : With SPF

H. Multi copy

I. Warmup time

* May vary depending on the surrounding temperature.

J. Copy magnification ratio

K. Print density

L. Void width

M. Auto duplex

N. Paper exit/finishing

(1) Electronic sort board (AR-164 standard)

O. Additional functions

O : AvailableX : Not available

P. Other specifications

Q. Package form

1-step paper feed unit 2-step paper feed unit

Model AR-DE5 AR-DE6

Paper feed size A3, B4, A4, A4R, B5, B5R,11" x 17", 8.5" x 14", 8.5" x 13", 8.5" x 11", 8.5" x 11"R

Capacity (56 ~ 80g/m²) About 250 sheets x 1 step

About 250 sheets x 2 steps

Paper weight 56 ~ 80g/m² (15 ~ 21 lbs.)

Moisture preserving heater

None

Detection Paper empty detection, size detection(by key input)

Paper size setting User setting (by key input)

External dimensions(W x D x H)

590 x 471 x 88 mm 590 x 471 x 173.5 mm

Weight About 5kg About 10kg

Special paper Recycled paper

Power Supplied from the machine

S-S (1st step) 100% (document replacement rate)

Max. number of multi copy 99 sheets

Warmup time Approx. 35 sec *Pre-heat Available

Fixed magnification ratio AB system : 50, 70, 81, 86, 100, 115, 122, 141, 200%Inch system: 50, 64, 77, 95, 100, 121, 129, 141, 200%

Zooming 50 ~ 200%Independent zooming/vertical Available (50 ~ 200%)Independent zooming (horizontal)

Available (50 ~ 200%)

Density mode Auto / Manual / PhotoNo. of manual adjustment 5 steps (Manual / Photo)Toner save mode Set by the user program

Void area Lead edge 1 ~ 4mm, rear edge 4mm or less , both sides 4mm or less

Image loss Max. 4mm in total of lead edge and rear edge, max. 4mm in total of right and left edges (Normal copy)

Standard / Option Not available

Paper exit section capacity

Face down 250 sheets

Job separator Job separator, option (AR-TR2 : for AR-164),Not available for AR-162SUpper : FAX/Printer, Lower : CopierUpper : 100sheets, Lower : 150sheets

Full detection Available (Job separator upper step)Finishing Electronic sort board:AR-164 Standard

Not available for AR-162SElectronic sort capacity

A4 (8.5" x 11") standard document 60 sheets

Offset function AR-162S NoneAR-164 Available (by the shifter)

Staple function None

Electronic sort Sorting 60 sheets of A4 standard documentsGrouping 60 sheets of A4 standard documents

Rotation copy If there is paper of same size as the document, the image is rotated to copy even though the paper is set in different direction from the document direction.

2 in 1, 4 in 1 Copies of 2 pages or 4 pages are integrated into one surface. Divided by solid lines, (Selectable by the user program.)

Edge erase The edges of the document are erased when copying. (Adjustable in 0 ~ 20mm by the user program.)

Center erase The image at the center is erased when copying. (Adjustable in 0 ~ 20mm by the user program.)

Margin shift Binding margin is made at the left edge of the set documents.

Memory for electronic sort

16MB

Memory expansion SIMM x 3 slots (Max. 32MB x 3 slots)

AR-162S AR-164 Note

APS X O APS not available by flowing in during use of SPF<AR-164 only available>

AMS O O AMS not available by flowing in during use of SPF

Duplex X X

Document count X X

Sorter X O Electrical sort / Offset

Independent zooming

O O Vertical / Horizontal : 50 ~ 200%

1 set 2 copy O O Enlargement inhibited, inhibited during the use of SPF

Binding margin X O Shift width 9mm

Edge erase X O Width 5mm (Adjustable 0 ~ 20mm)

Black-white reverse

O O Whole surface only

2 in 1, 4 in 1 X O

Rotation copy X O

Memory copy X O AR-164 only available

Pre-heat function O O Conditions set by the user program

Auto power shut off function

O O Conditions set by the user program

Auto tray switching X O

Message display X O FAX / Printer extension

User program O O

Total counter O O

Photoconductor type OPC (Organic Photo Conductor)Photoconductor drum diameter 30mmCopy lamp Xenon lampDeveloping system Dry 2-component magnetic brush

developmentCharging system Saw teeth chargingTransfer system (+) DC corotronSeparation system ( -) DC corotronFusing system Heat rollerCleaning system Contact blade

Body Body / Accessories

�� & �� !"#$�%


R. External view

S. Power source

T. Power consumption

* EnergyStar standard (The 2nd level conformity)

U. Digital performance

External dimensions(W x D x H)

590 x 531 x 470 mm (AR-162S)590 x 531 x 570 mm (AR-164)

Occupying area (W x D)

590 x 531mm(When the manual tray is installed.)

Weight About 32kg (AR-162S)About 35.5kg (AR-164)

Voltage AC120V ± 15%Frequency 50/60Hz common

Max. power consumption About 1.3KWh

Pre-heat About 60WhAuto power shut off

0wh about 4.8wh (when FAX or the printer expansion kit is installed)

Resolution Reading 400 dpiWriting 600 dpi

Gradation Reading 256 gradationsWriting Binary

[4] CONSUMABLE PARTS1. Supply system tableA. USA/CANADA

2.Environment conditionsA.Transport condition

(1)Transport conditions

(2)Storage conditions (packed conditions)

B.Use conditions

C.Life (packed conditions)

Photoconductor drum (36 months from the production month)Developer, toner (24 months from the production month)

NO Name Content Life Model name Remark1 Toner cartridge (Black)

<With IC>Toner x 1(Toner: Net Weight 475g) Vinyl bag x 1

13K AR-201NT(AR-201-J*1)

Life setting by A4 6% document<Not compatible with the AR-160/200/205>

2 Developer Developer x 1(Developer: Net Weight 400g) Vinyl bag x 1

30K AR-201ND <Not compatible with the AR-160/200/205>

3 Drum kit Drum x 1Drum fixing plate x 1

30K AR-201DR The AR-201 DR/DM can be used instead of the AR-200 MR/LR/CR.

Temperature

Hum

idity

(%

)

Temperature

Hum

idity

(%

)

Hum

idity

(%

)

Temperature

Use envi-ronment conditions

�� !"#$�%


3.Production number identification

[5] SIMULATIONMain code

Sub code

Contents Details of operationInitial value

Set range

26 10 Model name setting Used to set the model name of the machine used with the following numbers. After entering the set value, press the start key and the set value is stored.

0 0 ~ 34

*:Destination

Division No.EX production 1Option 2Same pack 3

1

The end digit of production year

January

SeptemberOctoberNovemberDecember

1

90XY

Factory

Production month

~ ~

Ver. A

The end digit of production yearVer.No.(ANS sequence)

January

SeptemberOctoberNovemberDecember

1

90XY

Indicates production in China.

Productionday.

Productionmonth.

Destination(*)

~ ~

B

*:Destination

Division No.Japan option 1Ex option 2Japan, same pack 6Ex, same pack 7

<Toner cartridge>The label on the toner cartridge shows the dateof production.

<Drum cartridge>The label on the drum cartridge shows the date of production.

Key operation / Display

0: AL-1600 11: AR-N200 24: AR-163/S163

1: AL-1610 12: AR-N205 25: AR-201S

2: AL-1620 13: AL-1621 26: AR-201/S201

3: AL-1640/AL-1641 14: AL-1650 27: AR-206/S206

4: AR-160/AR-S160 15: AL-1670 28: AR-207

5: AR-161/AR-S161 16: AR-F200 29: AR-F161

6: AR-200S 17: DM-2000 30: AR-F201

7: AR-200/AR-S200 18: DM-2005 31: AR-F161P

8: AR-205/AR-S205 19: DM-2010 32: AR-F201P

9: AR-F160 20: DM-2015 33: AR-162S

10: AR-F205 23: AR-162/S162 34: AR-164

�� ' �� !"#$�%


[6] MAINTENANCE1.Maintenance table

X : Check (Clean, adjust, or replace when required.) O : Clean : Replace : Adjust : Lubricate

*1: Recommendable replacement time: 30K (A4 (8.5" x 11"), 6% print)

2. Maintenance display system

*1:Installation of a new toner cartridge allows to display the remaining quantity.

Unit name Part name When calling or replacingthe kit

150k

Transfer section Charger unit O OTransfer paper guide O O

Optical section Lamp unit Reflector O OMirror O O

No. 2/3 mirror unit Mirror O OPulley X X

CCD peripheral Lens O OGlass Table glass O O

White plate O OOther Drive wire X X

Rail X XDocument cover O ODocument size sensor O O

LSU Dust-proof glass O OPaper feed section Multi paper feed

sectionTakeup roller O OPaper feed roller O OSpring clutch O O

Cassette section Paper feed roller O OSpring clutch O O

Paper transport section PS roller O OTransport (paper exit) rollers O OSpring clutch O O

Fusing section Upper heat roller OPressure roller O OPressure roller bearing X OUpper separation pawl X OLower separation pawl X O

Drive section Gears X XBelts X O

Paper exit section Ozone filter X X *1

Toner Life 13KRemaining quantity check *1 a. Press and hold the density adjustment LIGHT key for more than 5 sec, and the machine will enter

the user program mode. b. Press and hold the "%" key for more than 5 sec, and the remaining quantity will be displayed on

the copy quantity display in one of the following levels: (Remaining quantity display levels: 100%, 75%, 50%, 25%, 10%, LO)

c. Press the density adjustment LIGHT key to cancel.Remaining quantity NEAR EMPTY About 10% EMPTYLED ON FlashMachine Operation allowed Stop

Developer Life 30KLED ON at 30K of the developer count.Machine Selection is available between Not Stop and Stop by Service Simulation (SIM 26-37) Setup.

(If Stop is selected, the LED will flash and stop at 30K.) *Default: Not Stop *Clear: SIM 42-1

Maintenance LED Selection is available among 30K, 15K, 10K, 7.5K, 5K, and free (no lighting) with SIM 21-1. *Default: 30K*Clear: SIM 20-1

Machine Not stop.

�� ( �� !"#$�%


3.Note for replacement of consumable partsA.Toner cartridge

When a waste toner cartridge is removed from the machine, it must beput in a polyethylene bag to avoid scattering of toner.

B.DV cartridge

Do not shake or put up the developer cartridge. Otherwise developermay scatter.

[7] OTHER

1. MCU PWB Factory set-up

O : MountX : Not Mount

SOPMMemory

SPF Fax/PCL ERDHJP1 JP2 JP3 JP4 JP5 JP6 JP7 JP8

CN11 CN3 CN7

AB Series

AR-162 X O O O O O O O O O X O

AR-162S X O X X O O O O O O O O

AR-163 O O O O X O O X O O X O

AR-164 O O O O X O O X O O X O

Inch Series

AR-162 X O O O O O O O O X O O

AR-162S X O X X O O O O O O O O

AR-163 O O O O X O O X O X O O

AR-164 O O O O X O O X O X O O

�� !"#$%&

– 1 –

�� PARTS GUIDE[Note] This Parts Guide describes only the different points from the AR-162/163 Parts Guide (CODE: 00ZAR162//P1/).

For the automatic document feeder, refer to the AR-SP2 Parts Guide (CODE: 00ZARSP2//P2/).

1 Exteriors

2 Operation panel section

3 Side door uint

4 2nd,3rd mirror unit

5 Optical unit

5 Optical unit

NO. PARTS CODE PRICERANK

NEWMARK

PARTRANK DESCRIPTION

1 GCOVH0010QSZ4 BC C OC cover(AR162S)2 PSHEZ0058QSZ1 AU C OC sheet(AR162S)

10

CCAB-0012QS0Z BA N D Front exterior(AR164 USA)CCAB-0012QS1A BA N D Front exterior(AR164 CANADA)CCAB-0012QS0X BA N D Front exterior(AR162S USA)CCAB-0012QS0Y BA N D Front exterior(AR162S CANADA)

501 CCOVH0010RS51 BG N E OC cover unit(AR162S)502 CFIX-0008RS52 BC N E Table unit


NEWMARK


3HPNLH0021QSZ6 AV N D Main Deco. panel(AR162S USA)HPNLH0021QSZ5 AV N D Main Deco. panel(AR162S CANADA)

4HPNLH0022QSZ2 AL N D Special Deco. panel(AR162S USA)HPNLH0022QSZ1 AK D Special Deco. panel(AR162S CANADA)

17CPWBF0025QSE1 AY E ERDH operation PWB(AR164)CPWBF0025QSE3 AH E ERDH operation PWB(AR162S)

19 CPWBF0024QSE2 CE E COPY operation PWB


NEWMARK


10 LFRM-0016QSZ3 AQ C Right door inner N16 MSPRC0082QSZ1 AC C Pressure spring18 CHLDZ0030RS51 BA E TC unit


NEWMARK


4 NPLYZ0017QSZZ AE C W pulley9 CPLTM0156QS02 AH B Pulley fixing plate R

13 CPLTM0155QS02 AH B Pulley fixing plate F(Unit)

901 CMIR-0008QS32 BB E 2nd,3rd mirror unit


NEWMARK


2 CMIR-0008QS32 BB E 2nd,3rd mirror unit18 NPLYZ0016QSZZ AF C Pulley22 CPWBF1177DS63 AR E MHPS PWB81 DHAI-0200QSZZ AS C CL harness93 XEBSD30P06000 AA C Screw(3×6)96 LPLTM4715FCZ1 AF C Wire fixing plate97 TCAUH0933FCZZ AB D High temperature caution label

501 CREFL0004QS33 BL E Copy lamp unit

P R P 0 0 7 7 1

93

9396

96

97

– 2 –

6 Middle frame unit

7 Process unit

8 DV cartridge unit

8 DV cartridge unit


NEWMARK


2 CSW-M0007RS51 AQ B Iiter lock switch unit3 NCPL-0007QSZ1 AC C Hopper coupling7 DUNTK0041RS14 BG E LSU unit

10 CHAI-0109RS51 AN E BG-MCFB harness unit11 CHAI-0107RS51 AG E MC harness unit46 LFRM-0024QSZ3 BC D Middle frame51 LANGT0003QSZ1 AC C SRU fixing angle


NEWMARK


2 CHLDZ0035RS51 BH E MC holder unit3 UCLEZ0009QSZ1 AQ C Cleaning blade5 PSEL-0130QSZZ AF C Seal R6 PSEL-0129QSZZ AF C Seal F

501 CFRM-0021RS67 BK N E Process frame unit


NEWMARK


7 PSEL-0066QSZ1 AC C TG seal LDAR11 PCOVP0072QS12 AH D DV cover unit23 NGERH0145QSZ1 AD C DV gear27 LPLTM0002YSZ1 AP C Doctor reinforce plate31 RDTCM0001YSZZ AZ B ATC sensor36 LPLTM6022FCZZ AC C M4 plate45 PSEL-0105QSZZ AA C TN seal FR46 PSHEP0262QSZZ AC C DV UND sheet47 PSEL-0114QSZZ AC C DV seal F48 PSEL-0115QSZZ AD C DV seal F249 PSHEP0324QSZZ AC C DVB sheet FBR

A

AA

P R P 0 0 7 7 2

49

49

46

48

47

– 3 –

9 Fusing unit

9 Fusing unit

F Main drive unit

G Base plate unit 1

G Base plate unit 1


NEWMARK


5 PCOVP0029QSZ2 AT D Fusing cover32 MSPRT0089QSZ2 AC C Pressure spring33 MLEVP0018QSZ1 AF C Fusing pressure lever F34 MLEVP0019QSZ3 AE C Release lever F35 MLEVP0020QSZ3 AE C Release lever R36 MLEVP0017QSZ1 AF C Fusing pressure lever R57 TLABH0364QSZZ AA D Fusing label58 CPLTM0255QS01 AS C Felt fixing plate

501 CPLTP0060RS52 BU E Release gate unit(Unit)

901 DUNTW0037RS23 BV E Fusing unit


NEWMARK


501 CGERH0011RS51 AE E MG gear unit


NEWMARK


24 CPWBF1177DS66 AR E Manual paper feeding sensor PWB34 CPWBF1177DS65 AR E Tray sensor PWB40 CPWBF1177DS67 AR E PS sensor PWB58 PCLR-0010QSZZ AC C Collar

A

B

A

B

57

P R P 0 0 7 7 3 57

58

P R P 0 0 7 7 4

58

– 4 –

H Base plate unit 2

H Base plate unit 2

I Manual paper feeding multi unit

J Delivery freme unit

K TC case unit

L 250 sheets tray unit

M Packing material & Accessories


NEWMARK


9 DUNTK0049RS16 BC N E AC switch unit(100V series)11 RDEN-0004QS12 BY E Composite power supply unit

! 18 QACCD741BQCZZ AS B AC cord30 CPLTM0071QS02 AL B Drive joint plate

37CPWBX0096QSE6 CE N E MCU PWB unit(AR164)CPWBX0096QSG2 CE N E MCU PWB unit(AR162S)

43 CPWBF0033QSE1 AP E RCU PWB unit78 DHAI-0124QSZ2 AY C SPF harness(AR164)

120 LPFTF0001QSZZ AC C Pulley flange501 DUNTK0050RS36 CC N E Power supply unit(120V)


NEWMARK


3 LPLTP0056QSZ3 AD C Stopper plate501 CFRM-0020RS51 BK E Manual paper feeding multi unit502 CSOU-0009QS32 AZ E Manual paper feeding tray unit


NEWMARK


3 CPWBF0018RS54 AZ E Delivery interface PWB(AR164)6 NROLM0037QSZ1 AS C Delivery roller C(AR164)

18 LBOSZ0048QSZ1 AC C Separator laver boss(AR164)29 CPWBF1177DS64 AS E Duplex P-out sensor PWB39 LFRM-0027QSZ1 AV D Delivery frame54 LSTPP0003QSZ1 AC C Shifter stopper(AR164)61 CPWBF1177DS68 AR E Shifter HP sensor PWB(AR164)


NEWMARK


13 LHLDZ0031QSZ2 AH C TC sheet(Unit)

901 CHLDZ0030RS51 BA E TC unit


NEWMARK


2 PSHEZ0054QSZ1 AC C Rotation plate sheet6 PTME-0022QSZZ AG C 250 Tray pawl F

10 PTME-0023QSZZ AG C 250 Tray pawl R20 PSPAZ0022QSZZ AC C Rotation plate S spacer

(Unit)901 CCASP0003RS52 BG D 250 Tray unit


NEWMARK


1SPAKC0415RSZZ AY N D Packing case(AR164)SPAKC0414RSZZ AY N D Packing case(AR162S)

4SPAKA0173RSZZ BA N D Top packing cushion(AR164)SPAKA0083RSZZ AD N D Top packing cushion OC(AR162S)

12 CCLEZ0005RS51 AQ D Charger cleaner unit15 CPAKA0084RS01 AF B Bottom add17 SPAKA0150RSZZ AA D Accessories protect packing cushion

PRP00775

120

– 5 –

M Packing material & Accessories

P MCU PWB unit

R Duplex P-out sensor PWB

S MHPS PWB

T Tray sensor PWB

U Manual paper feeding sensor PWB

V PS sensor PWB

W RCU PWB unit

. Delivery interface PWB

a Shifter HP sensor PWB


NEWMARK


20

TINSE0749QSZZ AW N D Operation manual COPY(AR164 USA)TINSE0750QSZZ AT N D Operation manual COPY(AR164 CANADA English)TINSF0751QSZZ AV N D Operation manual COPY(AR164 CANADA French)TINSE0744QSZZ AV N D Operation manual COPY(AR162S USA)TINSE0745QSZZ AT N D Operation manual COPY(AR162S CANADA English)TINSF0746QSZZ AV N D Operation manual COPY(AR162S CANADA French)

21 SPAKA0167RSZZ AA D Tray protect sheet


NEWMARK


1 VHI29F04008QS BB N B FLASH ROM(29F04008QS) [IC20]18 QCNCW7191RC1B AG C Connector(12Pin) [CN12]41 RCRSP0016QSZZ AD B Crystal(19.6608MHZ) [X1]42 RCRUB0009QSZZ AP B Crystal(22.0000MHZ) [X2]43 RCRUB0010QSZZ AP B Crystal(20.3094MHZ) [X3]

(Unit)

901CPWBX0096QSE6 CE N E MCU PWB unit(AR164)CPWBX0096QSG2 CE N E MCU PWB unit(AR162S)


NEWMARK


(Unit)901 CPWBF1177DS64 AS E Duplex P-out sensor PWB


NEWMARK


(Unit)901 CPWBF1177DS63 AR E MHPS PWB


NEWMARK


(Unit)901 CPWBF1177DS65 AR E Tray sensor PWB


NEWMARK


(Unit)901 CPWBF1177DS66 AR E Manual paper feeding sensor PWB


NEWMARK


(Unit)901 CPWBF1177DS67 AR E PS sensor PWB


NEWMARK


(Unit)901 CPWBF0033QSE1 AP E RCU PWB unit


NEWMARK


(Unit)901 CPWBF0018RS54 AZ E Delivery interface PWB(AR164)


NEWMARK


(Unit)901 CPWBF1177DS68 AR E Shifter HP sensor PWB(AR164)

– 6 –

� Index

PARTS CODE NO. PRICERANK

NEWMARK

PARTRANK

[C]CCAB-0012QS0X 1- 10 BA N DCCAB-0012QS0Y 1- 10 BA N DCCAB-0012QS0Z 1- 10 BA N DCCAB-0012QS1A 1- 10 BA N DCCASP0003RS52 16- 901 BG DCCLEZ0005RS51 17- 12 AQ DCCOVH0010RS51 1- 501 BG N ECFIX-0008RS52 1- 502 BC N ECFRM-0020RS51 13- 501 BK ECFRM-0021RS67 7- 501 BK N ECGERH0011RS51 10- 501 AE ECHAI-0107RS51 6- 11 AG ECHAI-0109RS51 6- 10 AN ECHLDZ0030RS51 15- 901 BA E

" 3- 18 BA ECHLDZ0035RS51 7- 2 BH ECMIR-0008QS32 4- 901 BB E

" 5- 2 BB ECPAKA0084RS01 17- 15 AF BCPLTM0071QS02 12- 30 AL BCPLTM0155QS02 4- 13 AH BCPLTM0156QS02 4- 9 AH BCPLTM0255QS01 9- 58 AS CCPLTP0060RS52 9- 501 BU ECPWBF0018RS54 14- 3 AZ E

" 36- 901 AZ ECPWBF0024QSE2 2- 19 CE ECPWBF0025QSE1 2- 17 AY ECPWBF0025QSE3 2- 17 AH ECPWBF0033QSE1 12- 43 AP E

" 27- 901 AP ECPWBF1177DS63 23- 901 AR E

" 5- 22 AR ECPWBF1177DS64 14- 29 AS E

" 22- 901 AS ECPWBF1177DS65 11- 34 AR E

" 24- 901 AR ECPWBF1177DS66 11- 24 AR E

" 25- 901 AR ECPWBF1177DS67 11- 40 AR E

" 26- 901 AR ECPWBF1177DS68 14- 61 AR E

" 37- 901 AR ECPWBX0096QSE6 12- 37 CE N E

" 20- 901 CE N ECPWBX0096QSG2 12- 37 CE N E

" 20- 901 CE N ECREFL0004QS33 5- 501 BL ECSOU-0009QS32 13- 502 AZ ECSW-M0007RS51 6- 2 AQ B

[D]DHAI-0124QSZ2 12- 78 AY CDHAI-0200QSZZ 5- 81 AS CDUNTK0041RS14 6- 7 BG EDUNTK0049RS16 12- 9 BC N EDUNTK0050RS36 12- 501 CC N EDUNTW0037RS23 9- 901 BV E

[G]GCOVH0010QSZ4 1- 1 BC C

[H]HPNLH0021QSZ5 2- 3 AV N DHPNLH0021QSZ6 2- 3 AV N DHPNLH0022QSZ1 2- 4 AK DHPNLH0022QSZ2 2- 4 AL N D

[L]LANGT0003QSZ1 6- 51 AC CLBOSZ0048QSZ1 14- 18 AC CLFRM-0016QSZ3 3- 10 AQ CLFRM-0024QSZ3 6- 46 BC DLFRM-0027QSZ1 14- 39 AV DLHLDZ0031QSZ2 15- 13 AH CLPFTF0001QSZZ 12- 120 AC CLPLTM0002YSZ1 8- 27 AP CLPLTM4715FCZ1 5- 96 AF CLPLTM6022FCZZ 8- 36 AC CLPLTP0056QSZ3 13- 3 AD CLSTPP0003QSZ1 14- 54 AC C

PARTS CODE NO. PRICERANK

NEWMARK

PARTRANK

[M]MLEVP0017QSZ1 9- 36 AF CMLEVP0018QSZ1 9- 33 AF CMLEVP0019QSZ3 9- 34 AE CMLEVP0020QSZ3 9- 35 AE CMSPRC0082QSZ1 3- 16 AC CMSPRT0089QSZ2 9- 32 AC C

[N]NCPL-0007QSZ1 6- 3 AC CNGERH0145QSZ1 8- 23 AD CNPLYZ0016QSZZ 5- 18 AF CNPLYZ0017QSZZ 4- 4 AE CNROLM0037QSZ1 14- 6 AS C

[P]PCLR-0010QSZZ 11- 58 AC CPCOVP0029QSZ2 9- 5 AT DPCOVP0072QS12 8- 11 AH DPSEL-0066QSZ1 8- 7 AC CPSEL-0105QSZZ 8- 45 AA CPSEL-0114QSZZ 8- 47 AC CPSEL-0115QSZZ 8- 48 AD CPSEL-0129QSZZ 7- 6 AF CPSEL-0130QSZZ 7- 5 AF CPSHEP0262QSZZ 8- 46 AC CPSHEP0324QSZZ 8- 49 AC CPSHEZ0054QSZ1 16- 2 AC CPSHEZ0058QSZ1 1- 2 AU CPSPAZ0022QSZZ 16- 20 AC CPTME-0022QSZZ 16- 6 AG CPTME-0023QSZZ 16- 10 AG C

[Q]QACCD741BQCZZ 12- 18 AS BQCNCW7191RC1B 20- 18 AG C

[R]RCRSP0016QSZZ 20- 41 AD BRCRUB0009QSZZ 20- 42 AP BRCRUB0010QSZZ 20- 43 AP BRDEN-0004QS12 12- 11 BY ERDTCM0001YSZZ 8- 31 AZ B

[S]SPAKA0083RSZZ 17- 4 AD N DSPAKA0150RSZZ 17- 17 AA DSPAKA0167RSZZ 17- 21 AA DSPAKA0173RSZZ 17- 4 BA N DSPAKC0414RSZZ 17- 1 AY N DSPAKC0415RSZZ 17- 1 AY N D

[T]TCAUH0933FCZZ 5- 97 AB DTINSE0744QSZZ 17- 20 AV N DTINSE0745QSZZ 17- 20 AT N DTINSE0749QSZZ 17- 20 AW N DTINSE0750QSZZ 17- 20 AT N DTINSF0746QSZZ 17- 20 AV N DTINSF0751QSZZ 17- 20 AV N DTLABH0364QSZZ 9- 57 AA D

[U]UCLEZ0009QSZ1 7- 3 AQ C

[V]VHI29F04008QS 20- 1 BB N B

[X]XEBSD30P06000 5- 93 AA C

– 9 –

MEMO

– 7 –

CAUTION FOR BATTERY REPLACEMENT

(Danish) ADVARSEL !Lithiumbatteri - Eksplosionsfare ved fejlagtig håndtering.

Udskiftning må kun ske med batteriaf samme fabrikat og type.

Levér det brugte batteri tilbage til leverandoren.

(English) Caution !Danger of explosion if battery is incorrectly replaced.

Replace only with the same or equivalent typerecommended by the manufacturer.

Dispose of used batteries according to manufacturer's instructions.

(Finnish) VAROITUSParisto voi räjähtää,jos se on virheellisesti asennettu.

Vaihda paristo ainoastaan laitevalmistajan suosittelemaantyyppiin. Hävitä käytetty paristo valmistajan ohjeiden

mukaisesti.

(French) ATTENTIONll y a danger d'explosion s'il y a remplacement incorrect

de la batterie. Remplacer uniquement avec une batterie dumême type on d'un type équivalent recommandé par

le constructeur. Mettre au rébut les batteries usagées conformément aux

instructions du fabricant.

(Swedish) VARNINGExplosionsfara vid felaktigt batteribyte.

Använd samma batterityp eller en ekvivalenttyp som rekornmenderas av apparattillverkaren.

Kassera använt batteri enligt fabrikantensInstruktion.

(German) AchtungExplosionsgefahr bei Verwendung inkorrekter Batterien.

Als Ersatzbatterien dürfen nur Batterien vom gleichen Typ odervom Hersteller empfohlene Batterien verwendet werden.Entsorgung der gebrauchten Batterien nur nach den vom

Hersteller angegebenen Anwerisugen.

CAUTION FOR BATTERY DISPOSAL

(For USA,CANADA)Contains lithium-ion battery. Must be disposed of properly.

Remove the battery from the product and contactfederal or state environmental

agencies for information on recycling and disposal options.

COPYRIGHT CCCC 2002 BY SHARP CORPORATIONAll rights reserved.

No part of this publication may be reproduced,stored in a retrieval system, or transmitted,

in any form or by any means,electronic, mechanical, photocopying, recording, or otherwise,

without prior written permission of the publisher.

SHARP CORPORATIONDigital Document Systems GroupProducts Quality Assuarance DepartmentYamatokoriyama, Nara 639-1186, Japan

2002 (February) t

Documents

Sharp AR-164 Service Manual