Embed Size (px)
Citation preview
97101915E
SERVICE PARTS MANUAL
SNOW PLOW AND SPREADER CONTROLS
©2017 Sno-Way® International
1
TABLE OF CONTENTS
PagePARTS LIST INTRODUCTION ................................................................................... 2
PARTS - SNOW PLOW CONTROLS
Legacy Control System Transmitter (Straight Blades Only).......................... 3
Legacy Control System Transmitter (V-Plow Only) ........................................ 5
ProControl Transmitter (All Plows) .................................................................. 7
ProControl II Transmitter (All Plows) ............................................................... 9
PARTS -SPREADER CONTROLSVariable Control (Spreaders: 4, 6 & 9 cu. ft.) ..................................................11
On/Off Control (Spreaders: 4, 6 & 9 cu. ft.).................................................... 13
ProControl II Transmitter (Spreaders: 4, 6 & 9 cu. ft.) .................................. 15
CAB Control (Spreader: Gas V-Box) .............................................................. 17
On/Off Control (Spreader: Electric V-Box)..................................................... 19
Dual Variable Control (Spreader: Electric V-Box) ......................................... 21
Dual Variable Control (Spreaders: PDE Series) ............................................ 23
PDE Control (Spreaders: PDE Series) ........................................................... 25
NUMERICAL INDEX ................................................................................................. 27
2
PARTS LIST INTRODUCTIONOur dealership network stands by to provide you with any assistance you may require, including genuine Sno-Wayservice parts. All parts should be obtained from or ordered through your dealer. Give complete information about thepart(s) at time of order, and include the Model and applicable Serial Numbers of your machine.
NOTE: The Model and all Serial number information should be recorded on page two of your Installation and Owner’s Manual for ease of reference. The location of these numbers on the machine is detailed in the manual as well."Right" and "Left" are determined from a position sitting on the Operators seat of the vehicle.
We reserve the right to make changes or improvements in the design or construction of any part without incurring theobligation to install such changes in any unit previously delivered.
A sample parts listing is shown below:
• The "ITEM" in column one is the number used in the corresponding illustration.• The "PART NO." in column two is the number used to order replacement parts. If a number does not appear in the
column the part is only available by ordering the complete assembly.• The "DESCRIPTION" in column three is the name of the replacement part. At times the name may be indented,
this means that the indented parts are part of the preceding assembly.• The "QTY." in column four is the quantity needed to service the assembly illustrated, not the complete product.
USING THIS PARTS LIST
1 96100083 O-ring 12 96001529 Elbow 33 98100036 Capscrew, Hex.,3/8"-16NC x 7/8" 9
ITEM PART NO. DESCRIPTION QTY.
PART DESCRIPTION ABBREVIATIONS
Our Part Descriptions use common industry standard abbreviations in the naming conventions for many individual items.The list below details the abbreviations commonly used throughout this manual. If a specific abbreviation is not listed,contact any Sno-Way Dealer for clarification.
ABBREV. DESCRIPTION ABBREV. DESCRIPTION
BRKT BRACKET HW HARD WIRED
CB CARRIAGE BOLT HWH HEX WASHER HEAD
CLP CLEVIS PIN LN LOCK NUT
COTP COTTER PIN LW HELICAL LOCK WASHER
DP DOWN PRESSURE PS PASSENGER SIDE
DS DRIVER SIDE PW PLAIN FLAT WASHER
EB EYE BOLT SHCS SOCKET HEAD CAP SCREW
GR GRADE SLT SLOTTED
HDWE HARDWARE SS STAINLESS STEEL
HHCS HEX HEAD CAP SCREW ST SELF-THREADING
HN HEX NUT UB U-BOLT
HNILN HEX NYLON INSERT LOCKNUT WL WIRELESS
CONTROL SYSTEM WIRING
3
6
12
3
5
7
8
9
10
1134
5
12 13 14
15
1617
1819
20
3 21
13
2222
CONTROL SYSTEM WIRING
4
1 96105083 Module, Wired Control ......................................................................12 96105487 Harness Repair Kit ............................................................................13 96105709 Clamp, Cable ....................................................................................34 96105418 Connector, Plug.................................................................................15 96105370 Contact, Signal Socket ......................................................................66 96105131 Harness, Solenoids - Gravity Down ..................................................1
96108247 Harness, Solenoids - Down Pressure ...............................................17 96105081 Bag, Harness Controls ......................................................................18 96105300 Cap, Screw-On..................................................................................19 96105284 Cap, 1/2” ...........................................................................................110 96104893 Grommet, 5/16" ID ............................................................................111 Strap, Plastic Tie ...............................................................................512 96105101 Harness, Vehicle ...............................................................................113 96105416 Contact, Signal Pin............................................................................614 96105710 Connector, Receptacle, Flanged .......................................................115 96105419 Boot, Cable .......................................................................................116 96105420 Grip, Cable ........................................................................................117 96105708 Connector, Plug, Unsealed ...............................................................118 96107354 Controller Assembly, Wired ...............................................................119 96107356 Touch Pad, Straight Blade.................................................................120 96105299 Housing, Controller, Complete ..........................................................121 96105417 Connector, Receptacle ......................................................................122 96106533 Coupling Ring....................................................................................223 96105325 Insertion Tool for Circular Connectors (Not shown)...........................124 96105404 Extraction Tool for Circular Connectors (Not shown) ........................125 96105877 Kit, Connector Repair (Not shown)
(includes: (3) #3, (1) #4, (6) #5, (6) #13, (1) #14, (1) #15,(1) #16, (1) #17, (1) #21, (1) #24, (1) #25 ...................................1
ITEM PART NO. DESCRIPTION QTY
CONTROL SYSTEM WIRING
5
12
6
11
8
9
10 12
20
19
18
7
3
4
5
13 143
515
16
17
3 2113
6
1 96105083 Module, Wired Control ......................................................................12 96105487 Harness Repair Kit ............................................................................13 96105709 Clamp, Cable ....................................................................................34 96105418 Connector, Plug.................................................................................15 96105370 Contact, Signal Socket ......................................................................66 96108295 Harness, Solenoids, DP ....................................................................1
96108294 Harness, Solenoids, Gravity..............................................................17 96105081 Bag, Harness Controls ......................................................................18 96105300 Cap, Screw-On..................................................................................19 96105284 Cap, 1/2" ...........................................................................................110 96104893 Grommet, 5/16" ID ............................................................................111 Strap, Plastic Tie ...............................................................................512 96105101 Harness, Vehicle ...............................................................................113 96105416 Contact, Signal Pin............................................................................614 96105710 Connector, Receptacle, Flanged .......................................................115 96105419 Boot, Cable .......................................................................................116 96105420 Grip, Cable ........................................................................................117 96105708 Connector, Plug, Unsealed ...............................................................118 96104890 Controller Assembly ..........................................................................119 96104681 Touch Pad, V-Plow ............................................................................120 96105299 Housing, Controller (Complete).........................................................121 96105417 Connector, Receptacle ......................................................................122 96105325 Insertion Tool for Circular Connectors (not shown) ........................ 123 96105404 Extraction Tool for Circular Connectors (not shown) .........................124 96107194 Controller, Joystick, V, Wired (not shown).........................................125 96105877 Kit, Connector Repair (not shown)
(includes (3) #3, (1) #4, (6) #5, (6) #13, (1) #14, (1) #15,(1) #16, (1) #17, (1) #21, (1) #22 & (1) #23 .................................1
ITEM PART NO. DESCRIPTION QTY
CONTROL SYSTEM WIRING
PROCONTROL SYSTEM WIRING
7
6
1
3
9
4
5
8
7
2
10
11
6
10
12
13*
14
15
1617
18
19
20
21
PROCONTROL SYSTEM WIRING
8
1 Clip, Dash Mount...............................................................................12 98100463 Screw ...........................................................................................................2
3 96112246 Transmitter, Wired .............................................................................196112244 Transmitter, Wireless.........................................................................1
4 96112998 Module, Receiver, Wired, Universal ..................................................196112260 Module, Receiver, Wireless, Universal..............................................1
5 96112913 Harness, Vehicle ...............................................................................16 96112193 Harness, Control, Solenoid, Down Pressure (Straight Blades) .........1
96112191 Harness, Control, Solenoid, Down Pressure(29R - S.N. Before 29R100604 & MBR)......................................1
96114393 Harness, Control, Solenoid, Down Pressure(26R, 29R - S.N. After 29R100604, RevHD)...............................1
Harness, Control, Solenoid, Gravity Down(Order Kit #96112955).................................................................1
96112192 Harness, Control, Solenoidn (29VHD & MBV) ..................................17 96112419 Rubber Grommet ..............................................................................18 96112300 Connector, Female 4 Way APEX ......................................................2
96108662 Terminal, Female, 18/20 AWG (Qty: Four per connector; Not shown) ........................................4
9 96112301 Connector, Male 4 Way APEX ..........................................................296108661 Terminal,Male,18/22 AWG
(Qty: Four per connector; Not shown) .........................................410 96112496 Fuse, 10 AMP (Not shown - In holder) ..............................................1
96112497 Fuse, 20 AMP (Not shown - In holder)(Used in 96112192 only) .............................................................1
11 96112931 Kit, Module Harness Repair, ProControl Wired (Not shown).............112 96112840 Strain Relief .......................................................................................113 96112955* Kit Upgrade, Solenoid Harness, ProControl
(Includes Harness, Decal & Instructions) ....................................196113731* Kit Upgrade, Solenoid Harness, ProControl (28V only)
(Includes Harness, Decal & Instructions) ....................................114 Decal, DP System, ProControl ..........................................................115 96112258 Battery, Wireless ...............................................................................116 96113316 Wall Charger, ProControl, 120VAC ...................................................117 96112376 Car Charger, ProControl, 12VDC......................................................118 96112985 Cap, Silicone .....................................................................................119 96112872 Cap, Storage, Male ...........................................................................120 96112871 Cap, Storage, Female .......................................................................121 96112229 Harness, Power Unit, 4-Way
(29R -S.N. Before 29R100604, 29VHD, MBV, MBR)..................196114394 Harness, Power Unit, 4-Way
(26R, 29R -S.N. After 29R100604, RevHD)................................1
*Kit will upgrade Legacy DP or Gravity units. A ProControl system package must also be ordered to use this kit.
ITEM PART NO. DESCRIPTION QTY
PROCONTROL II SYSTEM WIRING
9
6
1
3
9
4
5
8
7
2
1011
12
13
19
15
18
20
18
17
14
19
21
22
PROCONTROL II SYSTEM WIRING
10
1 96114035 Transmitter, Wired .............................................................................196114036 Transmitter, Wireless.........................................................................1
2 98009172 Screw ...........................................................................................................2
3 96116052 Holder, Pro Control II.........................................................................14 96115976 Battery, Wireless ...............................................................................15 96115774 Charger, 120VAC ..............................................................................16 96115772 Charger, 12VDC................................................................................17 96115773 Cable, Charger..................................................................................18 96112840 Strain Relief .......................................................................................19 96112301 Connector, Male, 4 Way APEX1
96108661 Terminal, Male, 18/20 AWG (Not shown) ....................................110 96114863 Harness, Splitter (If equipped with a Sno-Way
Plow and Spreader).....................................................................111 96112300 Connector, Female, 4 Way APEX1
96108662 Terminal, Female, 18/20 AWG (Not shown) ................................112 96112419 Rubber Grommet ..............................................................................113 96112913 Harness, Vehicle ...............................................................................114 96112871 Cap, Storage, Female .......................................................................115 96112872 Cap, Storage, Male ...........................................................................116 96112931 Kit, Module Harness Repair, ProControl WIred (Not shown) ............117 96114031 Module, Reveiver, Wired, Universal ..................................................1
96114032 Module, Receiver, Wireless, Universal..............................................118 96112193 Harness, Control, Solenoid, Down Pressure (Straight Blades) .........1
96112191 Harness, Control, Solenoid, Down Pressure(29R - S.N. Before 29R100604 & MBR)......................................1
96114393 Harness, Control, Solenoid, Down Pressure(26R, 29R - S.N. After 29R100604, RevHD)...............................1
Harness, Control, Solenoid, Gravity Down (Order Kit #96112955).................................................................1
96112192 Harness, Control, Solenoidn (29VHD & MBV) ..................................196114890 Harness, Control, UTV ......................................................................196116267 Harness, Control, Solenoid, UTV-V...................................................1
19 96112496 Fuse, 10 AMP (Not shown - In holder) ..............................................196112497 Fuse, 20 AMP (Not shown - In holder)
(Used in 96112192 only) .............................................................120 Decal, DP System .............................................................................121 96112955* Kit Upgrade, Solenoid Harness, ProControl
(Includes Harness, Decal & Instructions) ....................................196113731* Kit Upgrade, Solenoid Harness, ProControl (28V only)
(Includes Harness, Decal & Instructions) ....................................122 96112229 Harness, Power Unit, 4-Way
(29R -S.N. Before 29R100604, 29VHD, MBV, MBR)..................196114394 Harness, Power Unit, 4-Way
(26R, 29R -S.N. After 29R100604, RevHD)................................196116273 Harness, Control, 4-Way, UTV-V.......................................................1
*Kit will upgrade Legacy DP or Gravity units. A ProControl system package must also be ordered to use this kit.
ITEM PART NO. DESCRIPTION QTY
VARIABLE CONTROL4, 6 & 9 cu. ft. Spreaders
11
1
23
45
6
7
89
10
1112
13
14
15
16
17
18
19
4
2
Includes:6711
121314
151920
VARIABLE CONTROL4, 6 & 9 cu. ft. Spreaders
12
1 96102293 Harness, Variable Control .................................................................12 96114755 Seal ...................................................................................................83 96102442 Terminal, Male ..................................................................................44 96102418 Lock, Secondary ...............................................................................45 96102441 Connector, Male ................................................................................26 96101846 Seal, Neoprene .................................................................................17 96002077 Grommet, 3/4" ...................................................................................18 96104104 Controller, Variable (Controller SN 010175 & later shown
SEE NOTE) .......................................................................................19 96102362 Wire, Power.......................................................................................110 98100037 Screw, Self Tapping #10 x 1".............................................................211 96102344 Breaker, Circuit, 40A .........................................................................112 96002085 Terminal, 1/4", Female Push-On .......................................................1
96101845 Connector, Female............................................................................113 96002083 Tap, 1/4", ATC/ATO Fuse ..................................................................1
96101832 Tap, 1/4", Mini Fuse...........................................................................114 Motor (See Spreader Service Parts Manual - 97101927) .................115 96102347 Terminal, Female...............................................................................416 96102346 Connector, Female............................................................................217 96102417 Cap, Storage .....................................................................................118 Tie, Cable ..........................................................................................519 96102310 Bag of Parts (Variable Control)..........................................................1
NOTE: Variable Controllers with serial numbers before 010175 were not equipped with disconnect protectionor cigarette lighter adapter power connection. Variable Controllers with these improvements are backwardscompatible and can be purchased as service replacements for older controllers.
ITEM PART NO. DESCRIPTION QTY
ON/OFF CONTROL4, 6 & 9 cu. ft. Spreaders
13
1
2 3
8
9
7
65
4
14
15
16
17
18
19
13
11
10
20
421
622
23
24
25
Includes:
1518 23
121619
1417
12
2
24
ON/OFF CONTROL4, 6 & 9 cu. ft. Spreaders
14
1 96105890 Harness, On/Off Control....................................................................12 96114982 Relay, 70A.........................................................................................13 96115061 Kit, Relay (Includes 70A Relay, Connector, Terminals and Seal)......14 96114755 Seal ...................................................................................................45 96102442 Terminal, Male...................................................................................26 96102418 Lock, Secondary ...............................................................................27 96102441 Connector, Male ................................................................................18 96105940 Connector, Male ................................................................................19 96105942 Terminal, Male Pin.............................................................................310 96105941 Connector, Female............................................................................111 96105943 Terminal, Female...............................................................................212 Strip, Hook and Loop Fastener .........................................................113 96105793 Controller, On/Off ..............................................................................114 96104893 Grommet, 1/2" O.D............................................................................115 96102362 Wire, Power.......................................................................................116 98100037 Screw, Self Tapping #10 x 1".............................................................217 96105893 Breaker, Circuit, 25A .........................................................................118 96002085 Terminal, 1/4", Female Push-On .......................................................1
96101845 Connector, Female............................................................................119 96002083 Tap, 1/4", ATC/ATO Fuse ..................................................................1
96101832 Tap, 1/4", Mini Fuse...........................................................................120 Motor (See Spreader Service Parts Manual - 97101927) .................121 96102347 Terminal, Female...............................................................................222 96102346 Connector, Female............................................................................123 96102417 Cap, Storage .....................................................................................124 Tie, Cable ..........................................................................................525 96105908 Bag of Parts (On/Off Control) ............................................................1
ITEM PART NO. DESCRIPTION QTY
PROCONTROL II AND VARIABLE SPEED CONTROL4, 6 & 9 cu. ft. Spreaders
15
1
2
7
8
9
10
18
4
3
5
6
11
18
1514
16
21
20
17
22
12
13
15
1716
14
14
14
2425
2627
2829
15
1519
19
23
PROCONTROL II AND VARIABLE SPEED CONTROL4, 6 & 9 cu. ft. Spreaders
16
1 96114035 Transmitter, Wired (Plow & Spreader)...............................................196114036 Transmitter, Wireless (Plow & Spreader) ..........................................196116049 Transmitter, Wired, Variable Speed (Spreader Only) ........................196116050 Transmitter, Wireless, Variable Speed (Spreader Only) ....................1
2 98009172 Screw ...........................................................................................................2
3 96116052 Holder, Pro Control 2.........................................................................14 96112840 Strain Relief .......................................................................................15 96112301 Connector, Apex Male, 4-Way...........................................................3
96108661 Terminal, Male, 18/20 AWG (Not shown) ..................................126 96114863 Harness, Splitter (If equipped with Sno-Way Plow & Spreader)........17 96112300 Connector, Apex Female, 4-Way ......................................................2
96108662 Terminal, Female, 18/20 AWG(QTY: Four per connector; Not shown) .....................................12
8 96112419 Grommet, Rubber .............................................................................19 96114862 Harness, Vehicle, Spreader...............................................................110 96112871 Cap, Storage, Female .......................................................................111 96112872 Cap, Storage, Male ...........................................................................112 96112931 Kit, Module Harness Repair, ProControl Wired (Not shown).............113 96114033 Module, Receiver, Wired, Spreader ..................................................1
96114034 Module, Receiver, Wireless, Spreader ..............................................114 96102418 Lock, Secondary ...............................................................................415 96114755 Seal ...................................................................................................416 96102442 Terminal, Male...................................................................................417 96102441 Connector, Male, 2-Pin......................................................................218 96102346 Connector, Female, 2-Pin .................................................................219 96102347 Terminal, Female...............................................................................420 Motor, Spinner (See Note).................................................................121 Vibrator (Optional Accessory) ...........................................................122 96115356 Harness, Power, Spreader ................................................................123 96115358 Terminal. Ring, 3/8" ...........................................................................224 96115709 Bag, Power Harness Parts ................................................................125 96115706 Cable, Power.....................................................................................126 96115666 Fuse, 100 Amp..................................................................................127 96115667 Fuse Holder.......................................................................................128 96001227 Strap, Tie Plastic ...............................................................................229 98100037 Screw, Self-tapping, #10-16 x 1" .......................................................2
NOTE: See Spreader Service Parts Manual - 97101927
ITEM PART NO. DESCRIPTION QTY
CAB CONTROLV-Box Gas Spreaders
17
1
2
3
4
5
6
7
8
9
11
12 13(RED) (BLACK)
1410
CAB CONTROLV-Box Gas Spreaders
18
1 99100555 Controller Assembly ..........................................................................12 96108645 Harness, Main Section, 15 Feet ........................................................13 96106025 Harness, Cigarette Lighter Lead .......................................................14 96105926 Switch, On/Off/Starter, Illuminated ....................................................15 96107113 Switch, Throttle, Intermittent .............................................................16 96102480 Switch, Clutch, Intermittent ...............................................................17 96106095 Cover, Plastic Housing ......................................................................18 Screw ................................................................................................19 96106846 Kit, Micro-Relay.................................................................................110 96109135 Kit, Connector Repair (includes connectors and terminals) ..............111 96108646 Harness, Spreader, 8 Feet ................................................................112 96107143 Positive Lead, Battery-Starter, Honda ...............................................1
96107144 Positive Lead, Battery-Starter, Briggs................................................113 96107142 Negative Lead, Battery......................................................................114 96105042 Start Solenoid ....................................................................................1
* If Harness Has Molded Connectors, Purchase Connector Repair Kit (#10) For Connector or Terminal Repair.
ITEM PART NO. DESCRIPTION QTY
ON/OFF CONTROLV-Box Spreaders
19
1
23
4
5 9
11
12
13
14
15
10
8
7
6
1618
21
Includes:
1114
81215
1013
2
20
20
1719
22
MOTOR DUTY CYCLE:Motor is not a continuous duty cycle motor. If the motor becomes hot to the touch, the motor is approaching heat limits. Be sure to allow adequate cooling of motor before using the spreader again.
ON/OFF CONTROLV-Box Spreaders
20
1 96106630 Harness, On/Off Control....................................................................12 96114892 Relay, 70A.........................................................................................13 96115061 Kit, Relay (Includes Relay, Connector, Terminals and Seals.............14 96105940 Connector, Male ................................................................................15 96105942 Terminal, Male Pin.............................................................................36 96105941 Connector, Female............................................................................17 96105943 Terminal, Female...............................................................................28 Strip, Hook and Loop Fastener .........................................................19 96105793 Controller, On/Off ..............................................................................110 96104893 Grommet, 1/2” O.D............................................................................111 96106728 Wire, Power.......................................................................................112 98100037 Screw, Self Tapping #10 x 1".............................................................213 96102344 Breaker, Circuit, 40A .........................................................................114 96002085 Terminal, 1/4", Female Push-On .......................................................1
96101845 Connector, Female............................................................................115 96002083 Tap, 1/4", ATC/ATO Fuse ..................................................................1
96101832 Tap, 1/4", Mini Fuse...........................................................................116 96111764 Motor, Electric, 1/2 HP (See Note) ....................................................117 96106374 Boot, Cable (use with ring terminal connection)................................118 96106628 Harness, Motor..................................................................................119 96105082 Cap Cover, Harness End ..................................................................120 Tie, Cable ..........................................................................................521 96106729 Bag of Parts (On/Off Control) ............................................................122 99100621 Package, Electric Spreader Harness ................................................1
NOTE: See Spreader Service Parts Manual: 97100701 - V-Box Gas & Electric Spreader Units 97101235 - V-Box Electric 16 Gauge Spreader Units
ITEM PART NO. DESCRIPTION QTY
DUAL VARIABLE CONTROLV-Box Electric Spreaders
21
12 3
45 11
12
14
136
7
8 10
97
16
15
22
21
2
1918
17
4
32 20
6
16
23
25
24
26 30
28
29
27
33
31
31
34
MOTOR DUTY CYCLE:
Motors (#21 and #23) are notcontinuous duty cyclemotors. If a motor becomeshot to the touch, the motor isapproaching heat limits. Besure to allow adequatecooling of motor before usingthe spreader again.
DUAL VARIABLE CONTROLV-Box Electric Spreaders
22
1 96115024 Control, Dual Electric, V-Box.............................................................12 96105082 Cap Cover, Harness End ..................................................................23 96113421 Harness, Battery, DEVBX..................................................................14 96114755 Seal ...................................................................................................85 96102442 Terminal, Male...................................................................................46 90102441 Connector, Male ................................................................................27 96108142 Plug, Cavity .......................................................................................28 96108661 Terminal, Male...................................................................................39 96112301 Connector, Male, 4-Way....................................................................110 96112300 Connector, Female, 4-Way................................................................111 96108662 Terminal, Female...............................................................................312 96113111 Connector, Flat Blade, Female, 1/4" .................................................113 96002083 Tap, ATC/ATO Fuse, 1/4" ..................................................................1
96101832 Tap, Mini Fuse, 3/16".........................................................................114 96115368 Vibrator Light Kit................................................................................115 96112872 Cap, Apex, 4-Way, Male....................................................................116 96102346 Connector, Female. 2-Pin .................................................................217 96102418 Secondary Lock ................................................................................218 96102347 Terminal, Female...............................................................................419 96115129 Cap, Metri Pack, 2-Way, Male ...........................................................120 96114865 Harness, Main DEV...........................................................................121 96113295 Motor, Electric, 1/3 HP (See Note) ....................................................122 96115130 Cap, Metri Pack, 2-Way, Female.......................................................123 96111764 Motor, Conveyor Feed, 1/2 HP (See Note) .......................................124 Tie, Cable ........................................................................................1025 96104893 Grommet ...........................................................................................126 96115623 Bag, Power Harness Parts ................................................................127 96109143 Fuse Holder.......................................................................................128 96109141 Fuse, 150 Amp..................................................................................129 98100037 Screw, Self-Tapping, #10-16 x 1" ......................................................230 96115624 Cable, Power.....................................................................................131 96115720 Connector, 2 pin ................................................................................232 96115721 Cap, Connector .................................................................................133 96115718 Terminal, Harness, 8 Ga. ..................................................................234 96115719 Terminal, Controller, 10/12 Ga. .........................................................2
NOTE: See Spreader Service Parts Manual: 97100701 - V-Box Gas & Electric Spreader Units 97101235 - V-Box Electric 16 Gauge Spreader Units
ITEM PART NO. DESCRIPTION QTY
DUAL VARIABLE CONTROLPDE Series Spreaders
23
12 3
4
106
11
79
38
8
5
19
2627
29
30
28
32
20
31
19
39
2
3735
812
14
17
15
18
16
5
2
1221
23
9
22
24 25
2828
28
2929
29
19
31
33
36
34
40
44
42
43
41
46
47
45
45
48
13
DUAL VARIABLE CONTROLPDE Series Spreaders
24
1 96115022 Control, PDE, V-Box..........................................................................12 96105082 Cap, Protective..................................................................................33 96113421 Harness, Battery, DEVBX..................................................................14 Tie, Cable, Black, 11" ........................................................................55 96114755 Seal ...................................................................................................86 96102442 Terminal, Male...................................................................................47 90102441 Connector, Male ................................................................................28 96108142 Plug, Cavity .......................................................................................29 96108661 Terminal, Male...................................................................................310 96112301 Connector, Male, 4-Way....................................................................111 96112300 Connector, Female, 4-Way................................................................112 96108662 Terminal, Female...............................................................................513 96002085 Terminal, Female, Push On, 1/4" ......................................................114 96101832 Tap, Fuse ..........................................................................................115 96112872 Cap, Apex, 4-Way, Male....................................................................116 96102346 Connector, Female. 2-Pin .................................................................217 96102418 Secondary Lock ................................................................................218 96102347 Terminal, Female...............................................................................419 96115129 Cap, Metri Pack, 2-Way, Male ...........................................................320 96114865 Harness, Main DEV...........................................................................121 96112731 Connector Body, Female, 2-Way ......................................................122 96115131 Cap, Apex, 2-Way, Male....................................................................123 96112732 Connector Body, Male, 2-Way...........................................................124 96115133 Cap, Apex, 2-Way, Female ...............................................................125 96115347 Harness, Vibrator Loop (See Note 1) ................................................126 Vibrator, 200 LB/S (See Note 2)........................................................127 Motor, Auger Drive (See Note 2) .......................................................128 96113111 Flat Blade Connector, Female, 1/4" ..................................................829 96114970 Flat Blade Connector, Male 1/4"........................................................830 96115137 Harness, Auger Loop (See Note 1) ...................................................131 96115130 Cap, Metri Pack, 2-Way, Female.......................................................232 96115348 Harness, Spinner Loop (See Note 1) ............................................... 133 96114866 Harness, Spinner Motor (Chute) .......................................................134 Motor, Spinner (See Note 2)..............................................................135 96002083 Fuse ..................................................................................................136 96101846 Seal, Neoprene .................................................................................137 96002077 Grommet, Rubber, 3/4" .....................................................................138 96114958 Strain Relief, Small ............................................................................139 96114957 Strain Relief, Large............................................................................140 96115623 Bag, Power Harness Parts ................................................................141 96109143 Fuse Holder.......................................................................................142 96109141 Fuse, 150 Amp..................................................................................143 98100037 Screw, Self-Tapping, #10-16 x 1" ......................................................244 96115624 Cable, Power.....................................................................................145 96115720 Connector, 2 pin ................................................................................246 96115721 Cap, Connector .................................................................................147 96115718 Terminal, Harness, 8 Ga. ..................................................................248 96115719 Terminal, Controller, 10/12 Ga. .........................................................2
NOTE: 1) If items #25, 30 or 32 are replaced, the heat-shrinkable strain reliefs (#39 and 40) must also be replaced.2) See Spreader Service Parts Manual - 97101880.
ITEM PART NO. DESCRIPTION QTY
1
2
4
22
10
17
18
11
16
13
8
6
7
5
3
9
14
14
15
15
12
21
19
25
26
27
24
23
28
20
REVOLUTION SPREADER CONTROLRVB & PDE Series Spreaders
25
1 Transmitter, RS................................................................................. 12 Harness, Vehicle (Includes items 3, 4, 9, & 19)................................ 13 96116163 Cap, Apex, 4-Way, Male ................................................................... 14 Tie, Cable, Black, 11"........................................................................ 55 96109143 Fuse Holder ...................................................................................... 16 96109141 Fuse, 150 Amp ................................................................................. 17 98100037 Screw, Self-Tapping, #10-16 x 1"...................................................... 28 96115624 Cable, Power .................................................................................... 19 96115623 Bag, Power Harness Parts ............................................................... 110 96116630 Module, Receiver, RS....................................................................... 111 Vibrator, 200 LB/S (See Note 2) ....................................................... 112 Motor, Auger Drive (See Note 2) ...................................................... 113 Motor, Spinner (See Note 2) ............................................................. 114 96113111 Flat Blade Connector, Female, 1/4".................................................. 815 96114970 Flat Blade Connector, Male 1/4" ....................................................... 816 96114866 Harness, Spinner Motor (Chute)....................................................... 117 96115130 Cap, Metri Pack, 2-Way, Female ...................................................... 118 96116250 Cap, Vehicle Harness ...................................................................... 119 96116114 Cap, Spreader Harness .................................................................... 120 96116628 Wire, RVB 10 (Pins 6 & 13) .............................................................. 121 96116208 Cap ................................................................................................... 422 96116563 Harness, Spreader, PDE800 / RVB 1500, 2000, 2500 (shown)
(See Note 1) ..................................................................................... 196116562 Harness, Spreader, PDE600 / RVB 750 (See Note 1)...................... 196116561 Harness, Spreader, PDE500 / RVB 500 (See Note 1)...................... 1
23 96112394 Connector, 14-Pin, Male ................................................................... 124 96116251 Wire, E-Stop Loop (Pins 5 & 12) ...................................................... 125 96116161 Connector, 4-Pin, Female................................................................. 1
96108662 Terminal, Female, 18/20 AWG (Not shown) ............................... 426 96116113 Nut, Connector Retention. ................................................................ 127 96116209 Lock Washer, Connector .................................................................. 128 96116164 Connector, 4- Pin, Male .................................................................... 1
96108661 Terminal, Male, 18/20 AWG (Not shown).................................... 4
NOTE: 1) 1-1/2" Diameter hole is needed in cover for molded grommet on harness to fit.2) See Spreader Service Parts Manual - 97101880 (PDE), 97102062 (RVB).
ITEM PART NO. DESCRIPTION QTY
REVOLUTION SPREADER CONTROLRVB & PDE Series Spreaders
26
NUMERICAL INDEX
PART NO. PAGE ITEM PART NO. PAGE ITEM PART NO. PAGE ITEM
90102441 22 624 7
96001227 16 2896002077 12 7
24 3796002083 12 13
14 1920 1522 1324 35
96002085 12 1214 1820 1424 13
96101832 12 1314 1920 1522 1324 14
96101845 12 1214 1820 14
96101846 12 624 36
96102293 12 196102310 12 1996102344 12 11
20 1396102346 12 16
14 2216 1822 1624 16
96102347 12 1514 2116 1922 1824 18
96102362 12 914 15
96102417 12 1714 23
96102418 12 414 616 1422 1724 17
96102441 12 514 716 17
96102442 12 314 516 1622 524 6
96102480 18 696104104 12 896104681 6 19
27
96104890 6 1896104893 4 10
6 1014 1420 1022 25
96105042 18 1496105081 4 7
6 796105082 20 19
22 224 2
96105083 4 16 1
96105101 4 126 12
96105131 4 696105284 4 9
6 996105299 4 20
6 2096105300 4 8
6 896105325 4 23
6 2296105370 4 5
6 596105404 4 24
6 2396105416 4 13
6 1396105417 4 21
6 2196105418 4 4
6 496105419 4 15
6 1596105420 4 16
6 1696105487 4 2
6 296105708 4 17
6 1796105709 4 3
6 396105710 4 14
6 1496105793 14 13
20 996105877 4 25
6 2596105890 14 196105893 14 1796105908 14 2596105926 18 496105940 14 8
20 4
96105941 14 1020 6
96105942 14 920 5
96105943 14 1120 7
96106025 18 396106095 18 796106374 20 1796106533 4 2296106628 20 1896106630 20 196106728 20 1196106729 20 2196106846 18 996107113 18 596107142 18 1396107143 18 1296107144 18 1296107194 6 2496107354 4 1896107356 4 1996108142 22 7
24 896108247 4 696108294 6 696108295 6 696108645 18 296108646 18 1196108661 8 9
10 916 522 824 926 29
96108662 8 810 1116 722 1124 1226 26
96109135 18 1096109141 22 28
24 4226 6
96109143 22 2724 4126 5
96111764 20 1622 23
96112191 8 610 18
96112192 8 610 18
96112193 8 610 18
NUMERICAL INDEX
PART NO. PAGE ITEM PART NO. PAGE ITEM PART NO. PAGE ITEM
96112229 8 2110 22
96112244 8 396112246 8 396112258 8 1596112260 8 496112300 8 8
10 1116 722 1024 11
96112301 8 910 916 522 924 10
96112376 8 1796112394 26 2496112419 8 7
10 1216 8
96112496 8 1010 19
96112497 8 1010 19
96112731 24 2196112732 24 2396112840 8 12
10 816 4
96112871 8 2010 1416 10
96112872 8 1910 1516 1122 1524 15
96112913 8 510 13
96112931 8 1110 1616 12
96112955 8 1310 21
96112985 8 1896112998 8 496113111 22 12
24 2826 14
96113295 22 2196113316 8 1696113421 22 3,
24 396113731 8 13
10 2196114031 10 1796114032 10 17
96114033 16 1396114034 16 1396114035 10 1
16 196114036 10 1
16 196114393 8 6
10 1896114394 8 21
10 2296114755 12 2
14 416 1522 424 5
96114862 16 996114863 10 10
16 696114865 22 20
24 2096114866 24 33
26 1696114890 10 1896114892 20 296114957 24 3996114958 24 3896114970 24 29
26 1596114982 14 296115022 24 196115024 22 196115061 14 3
20 396115129 22 19
24 1996115130 22 22
24 3126 17
96115131 24 2296115133 24 2496115137 24 3096115347 24 2596115348 24 3296115356 16 2296115358 16 2396115368 22 1496115623 22 26
24 4026 9
96115624 22 3024 4426 8
96115666 16 2696115667 16 2796115706 16 2596115709 16 2496115718 22 33
24 47
96115719 22 3424 48
96115720 22 3124 45
96115721 22 3224 46
96115772 10 696115773 10 796115774 10 596115976 10 496116049 16 196116050 16 196116052 10 3
16 396116113 26 2796116114 26 2096116161 26 2696116163 26 396116164 26 2996116208 26 2296116209 26 2896116250 26 1996116251 26 2596116267 10 1896116273 10 2296116561 26 2296116562 26 2296116563 26 2296116628 26 2096116630 26 1098009172 10 2
16 298100037 12 10
14 1616 2920 1222 2924 4326 7
98100463 8 299100555 18 199100621 20 22
28
Hartford, WI 53027 USA Website: www.snoway.com©2017 Sno-Way® International
SNO-WAY® INTERNATIONAL, INC.
