S P E C I F I C A T I O N P R O P O S A L - Alt Fuel …altfueltrucks.com/files/StockCNG TRACTORS.pdf003 -001 LH PRIMARY STEERING LOCATION General Service AA1-001 TRACTOR/TRAILER CONFIGURATION

Prepared by: James Blakely

LOS ANGELES FTL - WST 2429 PECK ROAD

WHITTIER, CA 90601

Application Version 8.3.312 Data Version PRL-02M.021 Stock CNG TRACTORS

Tender # 2 Fairings shipped 01/18/2012 11:57 AM

Page 1 of 40

S P E C I F I C A T I O N P R O P O S A L

Data Code

Description

Weight Front

Weight Rear

Price Level

PRL-02M M2 PRL-02M (EFF:07/19/11)

Data Version

DRL-021 SPECPRO21 DATA RELEASE VER 021

Vehicle Configuration

001-175 M2 112 CONVENTIONAL CHASSIS 8,035 6,120

004-212 2012 MODEL YEAR SPECIFIED

002-002 SET BACK AXLE - TRACTOR 20

003-001 LH PRIMARY STEERING LOCATION

General Service

AA1-001 TRACTOR/TRAILER CONFIGURATION

AA6-003 DOMICILED, CANADA (OTHER THAN QUEBEC)

RCE-00V VARIABLE CANADIAN EXCHANGE

A85-002 PICKUP AND DELIVERY/SHORT HAUL SERVICE

A84-1GF GENERAL FREIGHT BUSINESS SEGMENT

AA4-001 GENERAL FREIGHT COMMODITY

AA5-002 TERRAIN/DUTY: 100% (ALL) OF THE TIME, IN TRANSIT, IS SPENT ON PAVED ROADS

AB1-008 MAXIMUM 8% EXPECTED GRADE

AB5-001 SMOOTH CONCRETE OR ASPHALT PAVEMENT - MOST SEVERE IN-TRANSIT (BETWEEN SITES) ROAD SURFACE

995-1AD FREIGHTLINER LEVEL I WARRANTY

A66-99D EXPECTED FRONT AXLE(S) LOAD : 12000.0 lbs

A68-99D EXPECTED REAR DRIVE AXLE(S) LOAD : 40000.0 lbs

A63-99D EXPECTED GROSS VEHICLE WEIGHT CAPACITY : 52000.0 lbs

A70-99D EXPECTED GROSS COMBINATION WEIGHT : 80000.0 lbs



WHITTIER, CA 90601



Page 2 of 40

Data Code

Description

Weight Front

Weight Rear

GVWR RATED MAXIMUM VEHICLE CAPACITY - GVWR : 52000.0 lbs

Tractor Service

AA2-001 VAN TRAILER

AH6-001 SINGLE (1) TRAILER

Engine

101-2J7 CUM ISL G 320 HP @ 2000 RPM, 2200 GOV, N-GAS, 1000 LB/FT @ 1300 RPM

-850 -70

Electronic Parameters

79A-065 65 MPH ROAD SPEED LIMIT

79B-005 CRUISE CONTROL SPEED LIMIT 2 MPH LOWER THAN ROAD SPEED LIMIT

79K-007 PTO MODE ENGINE RPM LIMIT - 1100 RPM

79M-001 PTO MODE BRAKE OVERRIDE - SERVICE BRAKE ONLY ENABLED

79P-002 PTO RPM WITH CRUISE SET SWITCH - 700 RPM

79Q-003 PTO RPM WITH CRUISE RESUME SWITCH - 800 RPM

79S-001 PTO MODE CANCEL VEHICLE SPEED - 5 MPH

79U-007 PTO GOVERNOR RAMP RATE - 250 RPM PER SECOND

80G-002 PTO MINIMUM RPM - 700

Engine Equipment

99C-010 2010 EPA/CARB EMISSION CERTIFICATION

99D-010 NO 2008 CARB EMISSION CERTIFICATION

105-001 ENGINE MOUNTED OIL CHECK AND FILL

133-004 ONE PIECE VALVE COVER

014-099 SIDE OF HOOD AIR INTAKE WITH FIREWALL MOUNTED DONALDSON AIR CLEANER

124-1DJ DR 12V 160 AMP 36-SI BRUSHLESS QUADRAMOUNT PAD ALTERNATOR WITH REMOTE BATTERY VOLT SENSE

292-1D8 (2) ALLIANCE MODEL 1131, GROUP 31, 12 VOLT MAINTENANCE FREE 1850 CCA THREADED STUD BATTERIES

-50 -20

290-017 BATTERY BOX FRAME MOUNTED

282-005 LH BATTERY BOX MOUNTED AS FAR AFT AS POSSIBLE

291-017 WIRE GROUND RETURN FOR BATTERY CABLES WITH ADDITIONAL FRAME GROUND RETURN

289-001 NON-POLISHED BATTERY BOX COVER



WHITTIER, CA 90601



Page 3 of 40

Data Code

Description

Weight Front

Weight Rear

107-032 CUMMINS 18.7 CFM AIR COMPRESSOR WITH INTERNAL SAFETY VALVE

108-002 STANDARD AIR COMPRESSOR GOVERNOR

131-013 AIR COMPRESSOR DISCHARGE LINE

152-041 ELECTRONIC ENGINE INTEGRAL SHUTDOWN PROTECTION SYSTEM

016-013 SINGLE HORIZONTAL MUFFLER WITH HORIZONTAL TAILPIPE EXHAUST, RH MOUNTED

-160 -80

239-001 STANDARD EXHAUST SYSTEM LENGTH

237-052 RH STANDARD HORIZONTAL TAILPIPE

23U-998 NO DIESEL EXHAUST FLUID TANK -35 -35

23Y-998 NO DEF SYSTEM - TANK & ROUTING

43X-998 NO DIESEL EXHAUST FLUID TANK LOCATION

273-018 HORTON DRIVEMASTER ON/OFF FAN DRIVE

276-001 AUTOMATIC FAN CONTROL WITHOUT DASH SWITCH, NON ENGINE MOUNTED

110-017 CUMMINS SUPPLIED FLEETGUARD COALESCING FILTER (LOW PRESSURE) CNG

118-008 COMBINATION FULL FLOW/BYPASS OIL FILTER

266-017 1300 SQUARE INCH ALUMINUM RADIATOR -20

103-004 ANTIFREEZE TO -34F, NOAT EXTENDED LIFE COOLANT

171-007 GATES BLUE STRIPE COOLANT HOSES OR EQUIVALENT

172-001 CONSTANT TENSION HOSE CLAMPS FOR COOLANT HOSES

360-998 NO FRONT ENGINE PTO

138-011 PHILLIPS-TEMRO 1000 WATT/115 VOLT BLOCK HEATER

4

141-998 NO COOLANT HEATER - GAS/DSL

140-053 BLACK PLASTIC ENGINE HEATER RECEPTACLE MOUNTED UNDER LH DOOR

134-001 ALUMINUM FLYWHEEL HOUSING

155-058 DELCO 12V 38MT HD STARTER WITH INTEGRATED MAGNETIC SWITCH

Transmission

342-580 ALLISON 3000 HS AUTOMATIC TRANSMISSION, NO PTO PROVISION

-130 -40

Transmission Equipment

343-144 WTEC CALIBRATION - 6 SPEED HS (PACKAGE 200)



WHITTIER, CA 90601



Page 4 of 40

Data Code

Description

Weight Front

Weight Rear

341-018 MAGNETIC PLUGS, ENGINE DRAIN, TRANSMISSION DRAIN, AXLE(S) FILL AND DRAIN

345-003 PUSH BUTTON ELECTRONIC SHIFT CONTROL, DASH MOUNTED

97G-001 TRANSMISSION PROGNOSTICS - ENABLED

370-015 WATER TO OIL TRANSMISSION COOLER, IN RADIATOR END TANK

15

346-003 TRANSMISSION OIL CHECK AND FILL WITH ELECTRONIC OIL LEVEL CHECK

35T-001 SYNTHETIC TRANSMISSION FLUID (TES-295 COMPLIANT)

Front Axle and Equipment

400-1A6 AF-12.0-3 12,000# FF1 71.5 KPI/3.74 DROP SINGLE FRONT AXLE

402-049 MERITOR 16.5X5 Q+ CAST SPIDER CAM FRONT BRAKES, DOUBLE ANCHOR, FABRICATED SHOES

60

403-043 2011-FMVSS 121 FRONT BRAKE LINING

419-023 CONMET CAST IRON FRONT BRAKE DRUMS

409-021 SKF SCOTSEAL PLUS XL FRONT OIL SEALS

408-001 VENTED FRONT HUB CAPS WITH WINDOW, CENTER AND SIDE PLUGS - OIL

416-022 STANDARD SPINDLE NUTS FOR ALL AXLES

405-002 MERITOR AUTOMATIC FRONT SLACK ADJUSTERS

536-050 TRW THP-60 POWER STEERING

539-003 POWER STEERING PUMP

534-015 2 QUART SEE THROUGH POWER STEERING RESERVOIR

40T-002 SYNTHETIC 75W-90 FRONT AXLE LUBE

Front Suspension

620-1F0 12,000# DUAL TAPERLEAF FRONT SUSPENSION 42

619-005 MAINTENANCE FREE RUBBER BUSHINGS - FRONT SUSPENSION

410-001 FRONT SHOCK ABSORBERS

Rear Axle and Equipment

420-1K3 MT-40-14X 40,000# R-SERIES TANDEM REAR AXLE WITHOUT PUMP

-40

421-614 6.14 REAR AXLE RATIO

424-003 IRON REAR AXLE CARRIER WITH OPTIONAL HEAVY DUTY AXLE HOUSING

30



WHITTIER, CA 90601



Page 5 of 40

Data Code

Description

Weight Front

Weight Rear

386-073 MXL 17T MERITOR EXTENDED LUBE MAIN DRIVELINE WITH HALF ROUND YOKES

30 30

388-073 MXL 17T MERITOR EXTENDED LUBE INTERAXLE DRIVELINE WITH HALF ROUND YOKES

878-019 (1) INTERAXLE LOCK VALVE FOR TANDEM OR TRIDEM DRIVE AXLES

87A-001 BLINKING LAMP WITH EACH MODE SWITCH, INTERAXLE UNLOCK DEFAULT WITH IGNITION OFF

423-085 MERITOR 16.5X8.62 Q+ CAST SPIDER HEAVY DUTY CAM REAR BRAKES, DOUBLE ANCHOR, FABRICATED SHOES

55

433-043 2011-FMVSS 121 REAR BRAKE LININGS

434-005 BRAKE CAMS AND CHAMBERS ON FORWARD SIDE OF DRIVE AXLE(S) WITH AUXILIARY SUPPORT BRACKETS

451-023 CONMET CAST IRON REAR BRAKE DRUMS

440-021 SKF SCOTSEAL PLUS XL REAR OIL SEALS

426-075 HALDEX GOLDSEAL LONGSTROKE 2-DRIVE AXLES SPRING PARKING CHAMBERS

428-002 MERITOR AUTOMATIC REAR SLACK ADJUSTERS

41T-002 SYNTHETIC 75W-90 REAR AXLE LUBE

Rear Suspension

622-005 AIRLINER 40,000# REAR SUSPENSION 30

621-007 AIRLINER HIGH POSITION RIDE HEIGHT

431-001 STANDARD U-BOLT PAD

624-016 51 INCH AXLE SPACING

910-001 SINGLE AIR REAR SUSPENSION LEVELING VALVE

623-002 TRANSVERSE CONTROL RODS

439-005 REAR SHOCK ABSORBERS - TWO AXLES (TANDEM) (AIR RIDE SUSPENSION)

Brake System

018-002 AIR BRAKE PACKAGE

490-100 WABCO 4S/4M ABS WITHOUT TRACTION CONTROL

871-001 REINFORCED NYLON, FABRIC BRAID AND WIRE BRAID CHASSIS AIR LINES

904-001 FIBER BRAID PARKING BRAKE HOSE

412-001 STANDARD BRAKE SYSTEM VALVES

46D-002 STANDARD AIR SYSTEM PRESSURE PROTECTION SYSTEM



WHITTIER, CA 90601



Page 6 of 40

Data Code

Description

Weight Front

Weight Rear

413-002 STD U.S. FRONT BRAKE VALVE

432-003 RELAY VALVE WITH 5-8 PSI CRACK PRESSURE, NO REAR PROPORTIONING VALVE

480-047 BW AD-IS (DRM) BRAKE LINE AIR DRYER WITH SHIELD, HEATER AND INTEGRAL RESERVOIR

479-014 AIR DRYER RESERVOIR MOUNTED

460-048 STEEL AIR BRAKE RESERVOIRS MOUNTED IN CAB ENTRY STEPS WHEN POSSIBLE

477-004 PULL CABLES ON ALL AIR RESERVOIR(S)

Trailer Connections

481-003 12 FOOT STRAIGHT TRAILER AIR HOSE 10

476-057 36 INCH STAINLESS STEEL SLIDE BAR WITH (2) 16 INCH SPRING TYPE AIR HOSE HANGERS

2

919-998 NO OPTIONAL CHASSIS AIR SYSTEM PIPING, VALVES, OR AIR UNLOADER SYSTEM

484-006 COMBINATION DUMMY GLAD HANDS AND LIGHT PLUG HOLDER

296-010 PRIMARY CONNECTOR/RECEPTACLE WIRED FOR SEPARATE STOP/TURN, CENTER PIN POWERED THROUGH IGNITION

297-008 SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE BRACKET MOUNTED LH DECK BACK OF CAB

335-004 UPGRADED CHASSIS MULTIPLEXING UNIT

32A-002 UPGRADED BULKHEAD MULTIPLEXING UNIT

310-002 12 FOOT DETACHABLE STRAIGHT PRIMARY TRAILER ELECTRICAL CABLE WITH SAE J560 CONNECTOR

10

Wheelbase & Frame

545-462 4625MM (182 INCH) WHEELBASE

546-100 11/32X3-1/2X10-3/16 INCH STEEL FRAME (8.73MMX258.8MM/0.344X10.19 INCH) 120KSI

210 -10

552-012 1450MM (57 INCH) REAR FRAME OVERHANG

55W-005 FRAME OVERHANG RANGE: 51 INCH TO 60 INCH

AC8-99D CALC'D BACK OF CAB TO REAR SUSP C/L (CA) : 116.45 in

AE8-99D CALCULATED EFFECTIVE BACK OF CAB TO REAR SUSPENSION C/L (CA) : 103.84 in

AE4-99D CALC'D FRAME LENGTH - OVERALL : 269.12 in

AM6-99D CALC'D SPACE AVAILABLE FOR DECKPLATE : 74.43 in

FSS-0LH FRAME SPACE LH SIDE : 95.81 in

FSS-0RH FRAME SPACE RH SIDE : 116.2 in



WHITTIER, CA 90601



Page 7 of 40

Data Code

Description

Weight Front

Weight Rear

553-002 FLANGED TAPERED END OF FRAME

550-001 FRONT CLOSING CROSSMEMBER

559-001 STANDARD WEIGHT ENGINE CROSSMEMBER

562-001 STANDARD MIDSHIP #1 CROSSMEMBER(S)

572-020 INVERTED U TRACTOR CROSSMEMBER

565-001 STANDARD SUSPENSION CROSSMEMBER

Chassis Equipment

674-001 LH BACK OF CAB ACCESS 5 5

592-054 21 INCH (525MM) DECK PLATE FLUSH MOUNTED BETWEEN RAILS

6 6

556-1AR THREE-PIECE 14 INCH CHROMED STEEL BUMPER WITH COLLAPSIBLE ENDS

558-033 REMOVABLE FRONT TOW HOOKS STORED ON THE CHASSIS FRAME

25

574-001 BUMPER MOUNTING FOR SINGLE LICENSE PLATE

585-042 BETTS B-25 PAINTED MUDFLAP BRACKETS 15

590-001 BLACK MUDFLAPS 15

586-024 FENDER AND FRONT OF HOOD MOUNTED FRONT MUDFLAPS

551-007 GRADE 8 THREADED HEX HEADED FRAME FASTENERS

583-058 PLASTIC QUARTER FENDERS WITHOUT LOGO 35

605-095 DRILLING PREP FOR ALONG SIDE RAIL CNG TANKS

Fifth Wheel

578-1CG JOST JSK37 SERIES 24.0 INCH AIR SLIDE FIFTH WHEEL - 2 INCH SLIDE INCREMENTS

30 540

A01-99D REQUESTED MIN UNLADEN 5TH WHEEL HEIGHT : 46.0 in

A02-99D REQUESTED MAX UNLADEN 5TH WHEEL HEIGHT

577-508 FIFTH WHEEL 508MM (20.0 INCHES) AHEAD OF SUSPENSION CENTERLINE

582-014 197MM (7.75 INCH) FIFTH WHEEL HEIGHT

570-001 OUTBOARD ANGLE - FIFTH WHEEL MOUNTING

890-001 DASH MOUNTED CONTROL VALVE AND PLUMBING FOR FIFTH WHEEL

579-005 LH FIFTH WHEEL RELEASE

Fuel Tanks

206-201 CNG PONY TANK TEMPORARILY MOUNTED FOR TRANSPORT PURPOSES ONLY



WHITTIER, CA 90601



Page 8 of 40

Data Code

Description

Weight Front

Weight Rear

230-801 CUSTOMER FURNISHED AND INSTALLED CNG FUEL TANK PACKAGE

212-800 FUEL TANK BRACKET 03-23715-000, STEPS AND BANDS SHIPPED TO DEALERSHIP SEPARATELY FOR LH AND RH CUSTOMER INSTALLED CNG FUEL SYSTEM

664-001 PLAIN STEP FINISH

216-801 CNG, LNG, OR PROPANE INCOMPLETE FUEL LINES FOR TRANSPORT PURPOSES ONLY

202-020 STAINLESS STEEL TUBING AND SYNTHETIC RUBBER FLEXIBLE FUEL LINES - CNG SERVICE

Tires

093-1U3 GOODYEAR G662 RSA FUEL MAX 295/75R22.5 14 PLY RADIAL FRONT TIRES (MATCH MARKED)

16

094-2BB GOODYEAR G572 LHD FUEL MAX 295/75R22.5 14 PLY RADIAL REAR TIRES

200

Hubs

418-045 CONMET PRE-SET BEARING IRON FRONT HUBS

450-045 CONMET PRE-SET BEARING IRON REAR HUBS

Wheels

502-506 ACCURIDE 29644A 22.5X8.25 10-HUB PILOT ALUMINUM DISC FRONT WHEELS

-62

505-717 ACCURIDE 50408 ACCU-LITE 22.5X8.25 10-HUB PILOT 2-HAND STEEL DISC REAR WHEELS

-80

524-001 POLISHED FRONT WHEELS; OUTSIDE ONLY

496-011 FRONT WHEEL MOUNTING NUTS

497-011 REAR WHEEL MOUNTING NUTS

Cab Exterior

829-072 112 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CAB

784-007 AIRSHIELD ROOF FAIRING WITH TRIM TABS; FAIRING AND TRIM TABS SHIPPED TO DEALER UNLESS ADVISED OTHERWISE; DEALER PAINTED AND INSTALLED

90 60

783-001 CAB/SLEEPER SIDE EXTENDERS 25 20

650-008 AIR CAB MOUNTS

648-002 NONREMOVABLE BUGSCREEN MOUNTED BEHIND GRILLE

754-998 NO FENDER EXTENSION

678-002 LH GRAB HANDLE

646-023 HOOD MOUNTED CHROMED PLASTIC GRILLE

65X-003 CHROMED HOOD MOUNTED AIR INTAKE GRILLE



WHITTIER, CA 90601



Page 9 of 40

Data Code

Description

Weight Front

Weight Rear

644-004 FIBERGLASS HOOD

690-002 TUNNEL/FIREWALL LINER

727-1AH SINGLE 14 INCH ROUND POLISHED AIR HORN ROOF MOUNTED

4

726-002 DUAL ELECTRIC HORNS

728-001 SINGLE HORN SHIELD

657-1CV DOOR LOCKS AND IGNITION SWITCH KEYED THE SAME WITH (4) KEYS

575-001 REAR LICENSE PLATE MOUNT END OF FRAME

312-038 INTEGRAL HEADLIGHT/MARKER ASSEMBLY WITH CHROME BEZEL

302-047 LED AERODYNAMIC MARKER LIGHTS

311-003 DAYTIME RUNNING LIGHTS WITH ROCKER/TOGGLE MOMENTARY INTERRUPTER SWITCH

294-042 FREIGHTLINER LED FLANGE MOUNTED STOP/TAIL/TURN LIGHTS WITH SEPARATE INCANDESCENT BACKUP LIGHTS

5

300-015 STANDARD FRONT TURN SIGNAL LAMPS

318-002 (1) SWIVEL UTILITY LIGHT ROOF MOUNTED 3

744-1BM DUAL WEST COAST BRIGHT FINISH HEATED MIRRORS

797-001 DOOR MOUNTED MIRRORS

796-001 102 INCH EQUIPMENT WIDTH

743-204 LH AND RH 8" BRIGHT FINISH CONVEX MIRRORS MOUNTED UNDER PRIMARY MIRRORS

74B-005 RH VELVAC 8 INCH BRIGHT FINISH HOOD MOUNTED CONVEX MIRROR WITH SWING ARM BRACKET, DUAL VIEW

4

729-001 STANDARD SIDE/REAR REFLECTORS

73A-002 REAR REFLECTIVE DEVICE

764-010 COMPOSITE EXTERIOR SUN VISOR 10

768-043 63X14 INCH TINTED REAR WINDOW

661-004 TINTED DOOR GLASS LH AND RH WITH TINTED OPERATING WING WINDOWS

654-011 RH AND LH ELECTRIC POWERED WINDOWS 4

663-013 TINTED WINDSHIELD

659-019 2 GALLON WINDSHIELD WASHER RESERVOIR WITHOUT FLUID LEVEL INDICATOR, FRAME MOUNTED

647-001 WHITE WINTERFRONT 2

Cab Interior



WHITTIER, CA 90601



Page 10 of 40

Data Code

Description

Weight Front

Weight Rear

707-1AM OPAL GRAY CLOTH INTERIOR

706-026 MOLDED PLASTIC DOOR PANEL WITHOUT VINYL INSERT WITH ALUMINUM KICKPLATE LOWER DOOR

708-013 MOLDED PLASTIC DOOR PANEL

772-006 BLACK MATS WITH SINGLE INSULATION

785-001 DASH MOUNTED ASH TRAYS AND LIGHTER

691-008 FORWARD ROOF MOUNTED CONSOLE WITH UPPER STORAGE COMPARTMENTS WITHOUT NETTING

742-007 (2) CUP HOLDERS LH AND RH DASH

680-007 GRAY/CHARCOAL WING DASH

720-003 5 LB. FIRE EXTINGUISHER 10

71T-002 METHANE DETECTION SYSTEM WITH (1) SENSOR IN CAB AND (1) SENSOR IN ENGINE COMPARTMENT

10

700-002 HEATER, DEFROSTER AND AIR CONDITIONER

701-008 STANDARD HVAC DUCTING WITH SNOW SHIELD FOR FRESH AIR INTAKE

703-005 MAIN HVAC CONTROLS WITH RECIRCULATION SWITCH

170-019 STANDARD HEATER PLUMBING WITH BALL SHUTOFF VALVES

130-033 DENSO HEAVY DUTY AIR CONDITIONER COMPRESSOR

702-002 BINARY CONTROL, R-134A

739-028 EXTREME CLIMATE THERMAL CAB AND SLEEPER INSULATION

285-013 SOLID-STATE CIRCUIT PROTECTION AND FUSES

280-007 12V NEGATIVE GROUND ELECTRICAL SYSTEM

324-011 DOME DOOR ACTIVATED LH AND RH, DUAL READING LIGHTS, FORWARD CAB ROOF

655-005 LH AND RH ELECTRIC DOOR LOCKS

284-023 (1) 12 VOLT POWER SUPPLY IN DASH

722-002 TRIANGULAR REFLECTORS WITHOUT FLARES 10

756-243 BOSTROM T910 HIGH BACK AIR SUSPENSION DRIVER SEAT WITH AIR LUMBAR

40

760-1C6 HIGH BACK NON SUSPENSION PASSENGER SEAT WITH FORE AND AFT ADJUSTMENT

759-009 INBOARD DRIVER SEAT ARMREST, NO PASSENGER SEAT ARMREST

2

711-004 LH AND RH INTEGRAL DOOR PANEL ARMRESTS

758-025 GRAY MORDURA CLOTH DRIVER SEAT COVER



WHITTIER, CA 90601



Page 11 of 40

Data Code

Description

Weight Front

Weight Rear

761-025 GRAY MORDURA CLOTH PASSENGER SEAT COVER

763-032 3 POINT FIXED D-RING RETRACTOR DRIVER AND PASSENGER SEAT BELTS

532-002 ADJUSTABLE TILT AND TELESCOPING STEERING COLUMN

10

540-015 4-SPOKE 18 INCH (450MM) STEERING WHEEL

765-002 DRIVER AND PASSENGER INTERIOR SUN VISORS

Instruments & Controls

732-004 GRAY DRIVER INSTRUMENT PANEL

734-004 GRAY CENTER INSTRUMENT PANEL

870-001 BLACK GAUGE BEZELS

486-001 LOW AIR PRESSURE LIGHT AND BUZZER

840-002 2 INCH PRIMARY AND SECONDARY AIR PRESSURE GAUGES

198-025 INTAKE MOUNTED AIR RESTRICTION INDICATOR WITHOUT GRADUATIONS

721-001 97 DB BACKUP ALARM 2

149-017 ELECTRONIC CRUISE CONTROL WITH SWITCHES ON AUXILIARY GAUGE PANEL (B DASH PANEL)

156-007 KEY OPERATED IGNITION SWITCH AND INTEGRAL START POSITION; 4 POSITION OFF/RUN/START/ACCESSORY

811-011 ODOMETER/TRIP/HOUR/DIAGNOSTIC/VOLTAGE DISPLAY: 1X7 CHARACTER, 26 WARNING LAMPS, DATA LINKED, ICU3

160-025 DIAGNOSTIC INTERFACE CONNECTOR, 9 PIN, SAE J1939, LOCATED BELOW DASH

844-001 2 INCH ELECTRIC FUEL GAUGE

148-003 PROGRAMMABLE RPM CONTROL - ELECTRONIC ENGINE

856-001 ELECTRICAL ENGINE COOLANT TEMPERATURE GAUGE

864-001 2 INCH TRANSMISSION OIL TEMPERATURE GAUGE

867-002 PANASONIC INSIDE/OUTSIDE TEMPERATURE GAUGE WITH BLACK BEZEL AND LCD FAHRENHEIT DISPLAY

830-017 ENGINE AND TRIP HOUR METERS INTEGRAL WITHIN DRIVER DISPLAY

852-002 ELECTRIC ENGINE OIL PRESSURE GAUGE

746-1A2 AM/FM/WB RADIO WITH FRONT AUXILIARY INPUT

10



WHITTIER, CA 90601



Page 12 of 40

Data Code

Description

Weight Front

Weight Rear

747-001 DASH MOUNTED RADIO

750-002 (2) RADIO SPEAKERS IN CAB

753-001 AM/FM ANTENNA MOUNTED ON FORWARD LH ROOF

2

748-001 POWER AND GROUND STUDS IN/UNDER DASH

810-028 ELECTRONIC KPH SPEEDOMETER WITH SECONDARY MPH SCALE, WITHOUT ODOMETER

817-001 STANDARD VEHICLE SPEED SENSOR

812-001 ELECTRONIC 3000 RPM TACHOMETER

813-998 NO MPH AND/OR RPM GRAPH

162-002 IGNITION SWITCH CONTROLLED ENGINE STOP

482-001 BW TRACTOR PROTECTION VALVE

883-001 TRAILER HAND CONTROL BRAKE VALVE

836-015 DIGITAL VOLTAGE DISPLAY INTEGRAL WITH DRIVER DISPLAY

660-008 SINGLE ELECTRIC WINDSHIELD WIPER MOTOR WITH DELAY

304-003 MARKER LIGHT/HEADLIGHT SWITCH WITH SEPARATE INTERRUPTER FOR CLEARANCE LIGHTS

882-004 TWO VALVE PARKING BRAKE SYSTEM WITH WARNING INDICATOR

299-013 SELF CANCELING TURN SIGNAL SWITCH WITH DIMMER, WASHER/WIPER AND HAZARD IN HANDLE

298-039 INTEGRAL ELECTRONIC TURN SIGNAL FLASHER WITH HAZARD LAMPS OVERRIDING STOP LAMPS

Design

065-000 PAINT: ONE SOLID COLOR

Color

980-5F6 CAB COLOR A: L0006EB WHITE ELITE BC

986-020 BLACK, HIGH SOLIDS POLYURETHANE CHASSIS PAINT

966-970 VENDOR WHITE REAR WHEELS/RIMS (PW, TKWHT21, W, TW)

976-995 SUNVISOR PAINTED SAME AS CAB COLOR A

Certification / Compliance

996-002 CANADA CMVSS CERTIFICATION

Secondary Factory Options

998-001 CORPORATE PDI CENTER IN-SERVICE ONLY



WHITTIER, CA 90601



Page 13 of 40

T O T A L V E H I C L E S U M M A R Y

Weight Summary

Weight

Front

Weight

Rear

Total

Weight

Factory Weight+ 7449 LBS 6793 LBS 14242 LBS

Dealer Installed Options 700 LBS 800 LBS

Total Weight+ 8149 LBS 7593 LBS 15742 LBS

I T E M S N O T I N C L U D E D I N A D J U S T E D L I S T P R I C E

Other Factory Charges

P7A-100 TOW ONLY CHARGE X EXCHANGE RATE

DELIVERY & ORDER PROCESSING CHARGE

Extended Warranty

WAG-056 TOWING EXTENDED/ROADSIDE SERVICE WARRANTY, 5 YEAR/UNLIMITED MILES/KM, $550 CAP

Dealer Installed Options

Weight

Front

Weight

Rear

Price

DS80 80 DGE SIDE FRAME MOUNTED INTEGRATED CNG FUEL TANK SYSTEM 3600 PSI SINGLE FILL PORT AND FUEL MANAGEMENT MODUL

700 800

Total Dealer Installed Options 700 LBS 800 LBS

(+) Weights shown are estimates only.

If weight is critical, contact Customer Application Engineering.



WHITTIER, CA 90601



Page 14 of 40



WHITTIER, CA 90601



Page 15 of 40

S T A R T A B I L I T Y

VEHICLE SPECIFICATIONS SUMMARY - STARTABILITY

Model ....................................................................................................................................................................................... M2112

Cab Size (829)................................................................................ 112 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CAB

Expected Front Axle(s) Load (lbs) ........................................................................................................................................... 12000.0

Expected Pusher Axle(s) Load (lbs) ................................................................................................................................................ 0.0



WHITTIER, CA 90601



Page 16 of 40

Expected Rear Axle(s) Load (lbs) ........................................................................................................................................... 40000.0

Expected Tag Axle(s) Load (lbs) ..................................................................................................................................................... 0.0

Expected GVW (lbs) .................................................................................................................................................................. 52000

Expected GCW (lbs) ............................................................................................................................................................... 80000.0

Engine (101) ......................................................... CUM ISL G 320 HP @ 2000 RPM, 2200 GOV, N-GAS, 1000 LB/FT @ 1300 RPM

Torque at Clutch Engagement (lbs-ft) ...................................................................................................................................... 550

Transmission (342) ........................................................... ALLISON 3000 HS AUTOMATIC TRANSMISSION, NO PTO PROVISION

Gear Ratio: Forward 1 ............................................................................................................................................................ 3.49



Gear Ratio: Reverse 1 ............................................................................................................................................................ 5.03

Gear Ratio: Reverse 2 ............................................................................................................................................................. N/A

Gear Ratio: Reverse 3 ............................................................................................................................................................. N/A

Low Gear Ratio ........................................................................................................................................................................ N/A

High Gear Ratio ....................................................................................................................................................................... N/A

Transfer Case (373)......................................................................................................................................... NO TRANSFER CASE

Low Gear Ratio ........................................................................................................................................................................ N/A


Rear Axle (420) ................................................................. MT-40-14X 40,000# R-SERIES TANDEM REAR AXLE WITHOUT PUMP

Number of Speeds ....................................................................................................................................................................... 1

Rear Axle Gear Ratio(s) ..........................................................................................................................6.14 REAR AXLE RATIO

Rear Tires (094) .................................................... GOODYEAR G572 LHD FUEL MAX 295/75R22.5 14 PLY RADIAL REAR TIRES

Revolutions per Mile ................................................................................................................................................................ 508

Vehicle Service (A85) .......................................................................................... PICKUP AND DELIVERY/SHORT HAUL SERVICE

Startability Factor ......................................................................................................................................................................... 8

Terrain (AA5) ......................................... TERRAIN/DUTY: 100% (ALL) OF THE TIME, IN TRANSIT, IS SPENT ON PAVED ROADS


Most Severe Grade Expected (AB1) ........................................................................................... MAXIMUM 8% EXPECTED GRADE


Road Surface (AB5). SMOOTH CONCRETE OR ASPHALT PAVEMENT - MOST SEVERE IN-TRANSIT (BETWEEN SITES) ROAD SURFACE


Suggested Torque Converter Stall Ratio ....................................................................................................................................... 1.98

Performance calculations are estimates only. If performance calculations are critical, please contact Customer Application Engineering.



WHITTIER, CA 90601



Page 17 of 40

S H I F T C H A R T

VEHICLE SPECIFICATIONS SUMMARY - SHIFT CHART

Model ....................................................................................................................................................................................... M2112


Desired Cruise Speed (mph) ........................................................................................................................................................ 55.0




WHITTIER, CA 90601



Page 18 of 40

RPM at Peak Torque ............................................................................................................................................................. 1300

Governed RPM ...................................................................................................................................................................... 2200


Gear Ratio: LL ......................................................................................................................................................................... N/A

Gear Ratio: L ........................................................................................................................................................................... N/A

Gear Ratio: 1 .......................................................................................................................................................................... 3.49

Gear Ratio: 2 .......................................................................................................................................................................... 1.86

Gear Ratio: 3 .......................................................................................................................................................................... 1.41

Gear Ratio: 4 ............................................................................................................................................................................... 1

Gear Ratio: 5 .......................................................................................................................................................................... 0.75

Gear Ratio: 6 .......................................................................................................................................................................... 0.65

Gear Ratio: 7 ........................................................................................................................................................................... N/A

Gear Ratio: 8 ........................................................................................................................................................................... N/A

Gear Ratio: 9 ........................................................................................................................................................................... N/A

Gear Ratio: 10 ......................................................................................................................................................................... N/A

Gear Ratio: 11 ......................................................................................................................................................................... N/A

Gear Ratio: 12 ......................................................................................................................................................................... N/A

Gear Ratio: 13 ......................................................................................................................................................................... N/A

Gear Ratio: 14 ......................................................................................................................................................................... N/A

Gear Ratio: 15 ......................................................................................................................................................................... N/A

Gear Ratio: 16 ......................................................................................................................................................................... N/A

Gear Ratio: 17 ......................................................................................................................................................................... N/A

Gear Ratio: 18 ......................................................................................................................................................................... N/A

Low Gear Ratio ........................................................................................................................................................................ N/A



Low Gear Ratio ........................................................................................................................................................................ N/A



Number of Speeds ....................................................................................................................................................................... 1




TABLE SUMMARY - SHIFT CHART



WHITTIER, CA 90601



Page 19 of 40




WHITTIER, CA 90601



Page 20 of 40

O P E R A T I N G R A N G E

VEHICLE SPECIFICATIONS SUMMARY - OPERATING RANGE

Model ....................................................................................................................................................................................... M2112






WHITTIER, CA 90601



Page 21 of 40


Governed RPM ...................................................................................................................................................................... 2200


Gear Ratio: LL ......................................................................................................................................................................... N/A

Gear Ratio: L ........................................................................................................................................................................... N/A

Gear Ratio: 1 .......................................................................................................................................................................... 3.49

Gear Ratio: 2 .......................................................................................................................................................................... 1.86

Gear Ratio: 3 .......................................................................................................................................................................... 1.41

Gear Ratio: 4 ............................................................................................................................................................................... 1

Gear Ratio: 5 .......................................................................................................................................................................... 0.75

Gear Ratio: 6 .......................................................................................................................................................................... 0.65

Gear Ratio: 7 ........................................................................................................................................................................... N/A

Gear Ratio: 8 ........................................................................................................................................................................... N/A

Gear Ratio: 9 ........................................................................................................................................................................... N/A

Gear Ratio: 10 ......................................................................................................................................................................... N/A

Gear Ratio: 11 ......................................................................................................................................................................... N/A

Gear Ratio: 12 ......................................................................................................................................................................... N/A

Gear Ratio: 13 ......................................................................................................................................................................... N/A

Gear Ratio: 14 ......................................................................................................................................................................... N/A

Gear Ratio: 15 ......................................................................................................................................................................... N/A

Gear Ratio: 16 ......................................................................................................................................................................... N/A

Gear Ratio: 17 ......................................................................................................................................................................... N/A

Gear Ratio: 18 ......................................................................................................................................................................... N/A

Low Gear Ratio ........................................................................................................................................................................ N/A



Low Gear Ratio ........................................................................................................................................................................ N/A



Number of Speeds ....................................................................................................................................................................... 1




TABLE SUMMARY - OPERATING RANGE



WHITTIER, CA 90601



Page 22 of 40




WHITTIER, CA 90601



Page 23 of 40

D I M E N S I O N S

VEHICLE SPECIFICATIONS SUMMARY - DIMENSIONS

Model ....................................................................................................................................................................................... M2112

Wheelbase (545) .......................................................................................................................... 4625MM (182 INCH) WHEELBASE

Rear Frame Overhang (552) .................................................................................... 1450MM (57 INCH) REAR FRAME OVERHANG

Fifth Wheel (578) ................................. JOST JSK37 SERIES 24.0 INCH AIR SLIDE FIFTH WHEEL - 2 INCH SLIDE INCREMENTS

Mounting Location (577) ................................. FIFTH WHEEL 508MM (20.0 INCHES) AHEAD OF SUSPENSION CENTERLINE

Maximum Forward Position (in) .................................................................................................................................................. 20

Maximum Rearward Position (in) ................................................................................................................................................ -4

Amount of Slide Travel (in) ......................................................................................................................................................... 24

Slide Increment (in) ...................................................................................................................................................................... 2

Desired Slide Position (in) ....................................................................................................................................................... 14.0



WHITTIER, CA 90601



Page 24 of 40


Sleeper (682) ................................................................................................................................ NO SLEEPER BOX/SLEEPERCAB

Exhaust System (016) ......................SINGLE HORIZONTAL MUFFLER WITH HORIZONTAL TAILPIPE EXHAUST, RH MOUNTED

TABLE SUMMARY - DIMENSIONS




WHITTIER, CA 90601



Page 25 of 40

G V W R

VEHICLE SPECIFICATIONS SUMMARY - GVWR

Model ....................................................................................................................................................................................... M2112






Expected GVW (lbs) .................................................................................................................................................................. 52000

Expected GCW (lbs) ............................................................................................................................................................... 80000.0

Front Axle (400) ........................................................................ AF-12.0-3 12,000# FF1 71.5 KPI/3.74 DROP SINGLE FRONT AXLE

Front Suspension (620) ..................................................................................... 12,000# DUAL TAPERLEAF FRONT SUSPENSION

Front Hubs (418) ............................................................................................... CONMET PRE-SET BEARING IRON FRONT HUBS

Front Disc Wheels (502) ................................... ACCURIDE 29644A 22.5X8.25 10-HUB PILOT ALUMINUM DISC FRONT WHEELS

Front Tires (093) .................. GOODYEAR G662 RSA FUEL MAX 295/75R22.5 14 PLY RADIAL FRONT TIRES (MATCH MARKED)

Front Brakes (402) ......... MERITOR 16.5X5 Q+ CAST SPIDER CAM FRONT BRAKES, DOUBLE ANCHOR, FABRICATED SHOES

Steering Gear (536) .......................................................................................................................TRW THP-60 POWER STEERING


Rear Suspension (622) ....................................................................................................... AIRLINER 40,000# REAR SUSPENSION

Rear Hubs (450) .................................................................................................. CONMET PRE-SET BEARING IRON REAR HUBS

Rear Disc Wheels (505) ............... ACCURIDE 50408 ACCU-LITE 22.5X8.25 10-HUB PILOT 2-HAND STEEL DISC REAR WHEELS


Rear Brakes (423) .................... MERITOR 16.5X8.62 Q+ CAST SPIDER HEAVY DUTY CAM REAR BRAKES, DOUBLE ANCHOR, FABRICATED SHOES

Pusher / Tag Axle (443) ......................................................................................................................... NO PUSHER OR TAG AXLE

Pusher / Tag Suspension (626) ............................................................................................... NO PUSHER OR TAG SUSPENSION

Pusher / Tag Hubs (449)........................................................................................................................ NO PUSHER OR TAG HUBS

Pusher/Tag Disc Wheels (509) ...................................................................................................... NO PUSHER/TAG DISC WHEELS

Pusher / Tag Tires (095) ............................................................................................................................. NO PUSHER/TAG TIRES

Pusher / Tag Brakes (456) ...................................................................................................................... NO PUSHER/TAG BRAKES



WHITTIER, CA 90601



Page 26 of 40

TABLE SUMMARY - GVWR




WHITTIER, CA 90601



Page 27 of 40

T R A C T O R W E I G H T

VEHICLE SPECIFICATIONS SUMMARY - TRACTOR WEIGHT

Model ....................................................................................................................................................................................... M2112






Expected GVW (lbs) .................................................................................................................................................................. 52000

Expected GCW (lbs) ............................................................................................................................................................... 80000.0


Pusher / Tag Axle (443) ......................................................................................................................... NO PUSHER OR TAG AXLE









WHITTIER, CA 90601



Page 28 of 40


Driver Weight (lbs) ...................................................................................................................................................................... 200.0

Driver Horizontal CG from Front Axle (in) ...................................................................................................................................... 40.2

Trailer Configuration (AA2) ........................................................................................................................................... VAN TRAILER

Trailer Tare Weight (lbs) ................................................................................................................................................... 11600.0

Trailer Length (ft) .................................................................................................................................................................... 53.0

Trailer CG from Front of Trailer (ft) .......................................................................................................................................... 31.0

Trailer Front to Kingpin (in) ..................................................................................................................................................... 36.0

Axle Position from Trailer Rear (in) ......................................................................................................................................... 48.0

Left-Hand Fuel Tank (204) .................................................................................................................................... NO LH FUEL TANK

Left Fuel Tank Horizontal CG (in) ................................................................................................................................................. 0

Right-Hand Fuel Tank (206) ...................................................................................................................... CUSTOM RH FUEL TANK

Right Fuel Tank Horizontal CG (in) .............................................................................................................................................. 0

TABLE SUMMARY - TRACTOR WEIGHT



WHITTIER, CA 90601



Page 29 of 40




WHITTIER, CA 90601



Page 30 of 40

T U R N I N G R A D I U S

VEHICLE SPECIFICATIONS SUMMARY - TURNING RADIUS

Model ....................................................................................................................................................................................... M2112



Front Tires (093) .................. GOODYEAR G662 RSA FUEL MAX 295/75R22.5 14 PLY RADIAL FRONT TIRES (MATCH MARKED)

Width (in) ................................................................................................................................................................................ 11.3

Front Axle (400) ........................................................................ AF-12.0-3 12,000# FF1 71.5 KPI/3.74 DROP SINGLE FRONT AXLE

Kingpin Intersection (in) .......................................................................................................................................................... 71.5

Bumper (556) ................................................... THREE-PIECE 14 INCH CHROMED STEEL BUMPER WITH COLLAPSIBLE ENDS

Width (in) ................................................................................................................................................................................ 92.5

Bumper Miter to Front Axle (in) ............................................................................................................................................. 27.35

Primary Steering Location (003) .............................................................................................. LH PRIMARY STEERING LOCATION

Steering Gear (536) .......................................................................................................................TRW THP-60 POWER STEERING

Dual Steering Gear .............................................................................................................................................................. NONE

Ram ..................................................................................................................................................................................... NONE


Axle Spacing (624) ...................................................................................................................................... 51 INCH AXLE SPACING



WHITTIER, CA 90601



Page 31 of 40




WHITTIER, CA 90601



Page 32 of 40

O P E R A T I N G S P E E D

VEHICLE SPECIFICATIONS SUMMARY - OPERATING SPEED

Model ....................................................................................................................................................................................... M2112


Top Speed (mph) .......................................................................................................................................................................... 65.1

Engine RPM ............................................................................................................................................................................. 2200.0



WHITTIER, CA 90601



Page 33 of 40



Governed RPM ...................................................................................................................................................................... 2200



Number of Speeds ....................................................................................................................................................................... 1





Low Gear Ratio ........................................................................................................................................................................ N/A



Low Gear Ratio ........................................................................................................................................................................ N/A

TABLE SUMMARY - OPERATING SPEED




WHITTIER, CA 90601



Page 34 of 40

G R A D E A B I L I T Y

VEHICLE SPECIFICATIONS SUMMARY - GRADEABILITY

Model ....................................................................................................................................................................................... M2112


Desired Gradeability at Peak Torque (%) ........................................................................................................................................ 0.5

Desired Gradeability at Cruise Speed(%) ........................................................................................................................................ 0.3



WHITTIER, CA 90601



Page 35 of 40






Expected GVW (lbs) .................................................................................................................................................................. 52000

Expected GCW (lbs) ............................................................................................................................................................... 80000.0


Peak Torque (lbs-ft) ............................................................................................................................................................... 1000


Peak Torque (Multi-torque High) (lbs-ft) ................................................................................................................................. 1000

RPM at Peak Torque (Multi-torque High) ............................................................................................................................... 1300

Multi-torque .............................................................................................................................................................................. NO



Number of Speeds ....................................................................................................................................................................... 1




Trailer Width (in) ................................................................................................................................................................... 102.0

Trailer Height (ground to top) (ft) ................................................................................................................................................... 13.5

Body Width (in) ............................................................................................................................................................................... 0.0

Body Height (ground to top) (ft) ....................................................................................................................................................... 0.0

Roof Mounted Aero Device (784) ............ AIRSHIELD ROOF FAIRING WITH TRIM TABS; FAIRING AND TRIM TABS SHIPPED TO DEALER UNLESS ADVISED OTHERWISE; DEALER PAINTED AND INSTALLED

Road Surface (AB5). SMOOTH CONCRETE OR ASPHALT PAVEMENT - MOST SEVERE IN-TRANSIT (BETWEEN SITES) ROAD SURFACE


Low Gear Ratio ........................................................................................................................................................................ N/A



Low Gear Ratio ........................................................................................................................................................................ N/A


TABLE SUMMARY - GRADEABILITY



WHITTIER, CA 90601



Page 36 of 40




WHITTIER, CA 90601



Page 37 of 40

F R A M E R B M

VEHICLE SPECIFICATIONS SUMMARY - FRAME RBM


Frame Rails (546) ....................... 11/32X3-1/2X10-3/16 INCH STEEL FRAME (8.73MMX258.8MM/0.344X10.19 INCH) 120KSI(546)

Yield Strength (psi) ............................................................................................................................................................ 120000

Section Modulus (per rail) (cu in) ........................................................................................................................................ 15.069

RBM (per rail) (lbf-in) ....................................................................................................................................................... 1810000

Inner Frame Reinforcement (547) .......................................................................................... NO INNER FRAME REINFORCEMENT

Outer Frame Reinforcement (548) ....................................................................................... NO OUTER FRAME REINFORCEMENT

TABLE SUMMARY - FRAME RBM




WHITTIER, CA 90601



Page 38 of 40

T R A I L E R C L E A R A N C E

VEHICLE SPECIFICATIONS SUMMARY - TRAILER CLEARANCE


Front Axle to Bumper (in) ............................................................................................................................................................ 46.85

Front Axle to Back of Cab (in) ................................................................................................................................................... 65.551



Fifth Wheel Leg Height (582) ................................................................................... 197MM (7.75 INCH) FIFTH WHEEL HEIGHT







Trailer Length (ft) .................................................................................................................................................................... 53.0

Trailer Width (in) ................................................................................................................................................................... 102.0

Corner Radius (in) .................................................................................................................................................................... 0.0

Trailer Front to Kingpin (in) ..................................................................................................................................................... 36.0

Kingpin to Landing Gear (in) ................................................................................................................................................... 96.0

Axle Position from Trailer Rear (in) ......................................................................................................................................... 48.0

Max Expected Dip Angle (deg).................................................................................................................................................. 4.0



WHITTIER, CA 90601



Page 39 of 40

Wheelbase (in) .......................................................................................................................................................................... 46

Trailer Swing ..............................................................................................................................................


Aerodynamic Roof Device (784) ............. AIRSHIELD ROOF FAIRING WITH TRIM TABS; FAIRING AND TRIM TABS SHIPPED TO DEALER UNLESS ADVISED OTHERWISE; DEALER PAINTED AND INSTALLED

Side Extenders (783) ................................................................................................................... CAB/SLEEPER SIDE EXTENDERS

Air Hose Support (476) ............ 36 INCH STAINLESS STEEL SLIDE BAR WITH (2) 16 INCH SPRING TYPE AIR HOSE HANGERS

Exhaust System (016) ......................SINGLE HORIZONTAL MUFFLER WITH HORIZONTAL TAILPIPE EXHAUST, RH MOUNTED

Battery Box (290) ........................................................................................................................ BATTERY BOX FRAME MOUNTED

Air Intake (014) ....................................... SIDE OF HOOD AIR INTAKE WITH FIREWALL MOUNTED DONALDSON AIR CLEANER

Primary Cable Receptacle (297) .... SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE BRACKET MOUNTED LH DECK BACK OF CAB

Deckplate (592) ................................................................... 21 INCH (525MM) DECK PLATE FLUSH MOUNTED BETWEEN RAILS

Positioning System (GPS) (786) .......................................................................................... NO POSITIONING/LOCATING SYSTEM

Landing Gear Clearance ..................................................................................................................................


Axle Spacing (624) ...................................................................................................................................... 51 INCH AXLE SPACING

Rear Suspension (622) ....................................................................................................... AIRLINER 40,000# REAR SUSPENSION

Frame Stress ...............................................................................................................................................


Frame Rails (546) ....................... 11/32X3-1/2X10-3/16 INCH STEEL FRAME (8.73MMX258.8MM/0.344X10.19 INCH) 120KSI(546)

Inner Frame Reinforcement (547) .......................................................................................... NO INNER FRAME REINFORCEMENT

Outer Frame Reinforcement (548) ....................................................................................... NO OUTER FRAME REINFORCEMENT

TABLE SUMMARY - TRAILER CLEARANCE



WHITTIER, CA 90601



Page 40 of 40


Documents

S P E C I F I C A T I O N P R O P O S A L - Alt Fuel …altfueltrucks.com/files/StockCNG TRACTORS.pdf003 -001 LH PRIMARY STEERING LOCATION General Service AA1-001 TRACTOR/TRAILER CONFIGURATION