Pathfinder Air Cooled Chiller Screw Compressor Three Circuitlit.daikinapplied.com/bizlit/DocumentStorage/AirCooledChiller/... · Air Cooled Chiller Screw Compressor Three Circuit

Replacement Parts List No. 700014300Revision K 05/2017

Daikin McQuay

Pathfinder®

Air Cooled ChillerScrew Compressor

Three Circuit

AWS375 - 530Vintage A

To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.DaikinApplied.com

For units built after 8/1/11, contact Daikin Applied for part number identification of Compressors, Check Valves, Economizers, Evaporators and Suction Piping Components.

Air Cooled Screw Comp. Chiller, AWS 375-530, 3-Ckt, 60Hz Vint. A Rev. K 05/17 RPL 7000143 / Page 2

ContentsParts List Revision History.................................................................................................................................. 3Nomenclature Serial Number .............................................................................................................................................. 4 Unit Model Number- Dataplate .................................................................................................................... 4 Unit Model Number- Complete ............................................................................................................... 5 - 6Electrical Legend - Units with Wye Delta or SS Starter ................................................................................. 7 - 9Electrical Legend - Units with VFD Starter .................................................................................................10 - 11Unit Layout ....................................................................................................................................................... 12Refrigeration Section ........................................................................................................................................ 13 Compressor Charts .................................................................................................................................... 13 Compressors .............................................................................................................................................. 14 Compressor Components .......................................................................................................................... 15 Suction Lines, Liquid Injection Lines ................................................................................................... 16 - 17 Discharge Lines .................................................................................................................................. 18 - 19 Liquid Lines- Standard Efficiency Units ..................................................................................................... 20 Liquid Lines with Economizer- High Efficiency Units ......................................................................... 21 - 23 Condenser Coils and Fans ........................................................................................................................ 24 Fan Totals per Unit ..................................................................................................................................... 25 Evaporator Diagram ................................................................................................................................... 26 Evaporator Components ..................................................................................................................... 27 - 28Coil and Base Frame Grilles............................................................................................................................. 29Coil Louvers...................................................................................................................................................... 30Base Frame Louvers ................................................................................................................................. 31 - 33Controls ............................................................................................................................................................ 34 Units with Wye-Delta or Solid State Starter (Code 9 = WD, SS) ............................................................... 34 Box Locations and Label Detail ........................................................................................................... 34 Control Panel Detail ............................................................................................................................. 35 Power Panel Detail ....................................................................................................................... 36 - 37 Solid State Starter Panel .............................................................................................................. 38 - 40 Wye-Delta Starter Panel ............................................................................................................... 40 - 41 Units with VFD Starters (Code 9 = VE or VF) ............................................................................................ 42 Box Locations and Label Detail ........................................................................................................... 42 Control Side .................................................................................................................................. 43 - 45 Power Side ................................................................................................................................... 46 - 50 Control Box Exhaust and Intake Fans ................................................................................................. 51Terminal Box ..................................................................................................................................................... 52Accessories ...................................................................................................................................................... 53 Units with Wye-Delta or Solid State Starter (Code 9 = WD or SS) ........................................................... 53 Isolator Kits - Rubber-In-Shear ............................................................................................................ 53 Isolator Kits - Spring ............................................................................................................................ 54 Units with VFD Starter (Code 9 = VF or VE) ............................................................................................. 55 Isolator Kits - Rubber-In-Shear ............................................................................................................ 55 Isolator Kits - Spring ............................................................................................................................ 56 Flow Switch ................................................................................................................................................ 57 Sound Enclosure Kit .................................................................................................................................. 57 Alarm Bell ................................................................................................................................................... 57 Inlet Strainer ............................................................................................................................................... 57 Field-Installed Fan VFD Kits ...................................................................................................................... 58 High Ambient Exhaust Fan Kit ................................................................................................................... 58 Rapid Restore ............................................................................................................................................ 58 Base and Coil - Grille and Louver Kits ....................................................................................................... 59 Base Grille Kits - Units with Wye-Delta or SS Starter (Code 8 = WD, SS) ................................................ 59 Base Grille Kits - Units with VFD Starter (Code 8 = VF, VE) ...................................................................... 59 Coil Louver Kits .......................................................................................................................................... 59 Base & Coil Louver Kits - Units with Wye-Delta or SS Starter (Code 8 = WD, SS) ................................... 59 Base & Coil Louver Kits - Units with VFD Starter (Code 8 = VF, VE) ........................................................ 59 BACnet MS/TP Communications Module .................................................................................................. 60 BACnet with IP/Ethernet ............................................................................................................................ 60 MODBUS Communications Module ........................................................................................................... 60 LonMark Communications Module ............................................................................................................ 60 Remote Display Kit .................................................................................................................................... 60


Revision Date Description NEW 07/10 New A 11/11 Page 17 - Corrected part number for Ref. 702 from 703062104 to 073062104. Page 21 - Added Ref. Bubble 209 to drawing. Page 22 - Added Ref. 209 O-Ring. Added Check Valve Gasket. Page 38 - Changed footnote 1 to "see next page" for Contactor KM1-1,2,3. Page 39 - Added new page for components of Contactor KM1-1,2,3. Page 42 - Added new page for Box Location& Label of units with VFD Starters. Page 52 - Added Motor Terminal Plate Gasket. Page 57 - Added information to description of Sound Enclosure Kit. Page 58 - Added new page for Field-Installed Fan VFD Kits, Hi Ambient Exhaust Fan Kit and Rapid Restore Kit. Page 60 - Corrected part number information for Ref. 650, 700 and 827. B 04/12 Page 17- Changed ST1,2,3 Sensor-Suct Temp. to two choices, Straight and Bent. Page 19- Added length description "20 ft." to WD1,2,3 Sensor- Discharge Temp. Pages 20 & 22- Changed part # for Ref. 113 Filter Drier Core, was 070339101. Page 24- Added length description "20 ft." to WAA Sensor- Outdoor Air. Changed Motor part #s, were 10000108802, 03, 04. Added info for Condenser Coil location and identification. Page 28 - Added length description "60 ft." to WIE & WOE Sensor- Evap. Changed part number for Ref. 7 Evap Flow Switch, was 331796201. Page 57- Changed part number for Ref. 7 Evap Flow Switch, was 331796201. C 07/12 Multiple pages: Added Note: For units built after 8/1/11, contact McQuay Parts for part number identification of Compressors, Check Valves, Economizers, Evaporators and Suction Piping Components. Page 6 - Corrected Code 29 nomenclature to SL= SD + LL Solenoid, was DS + LL Solenoid. Page 15 - Changed part # for Ref. 14 Slide Indicator from 330591102 to 330591103. Page 19 - Added Gasket- Discharge Shut-Off Valve to all circuits. Pages 31-33 - Corrected title to Code 28= B, was Code 28= B, C, L. Page 35 - Added Advanced Web Module and footnote 2. Page 44 - Added Advanced Web Module and footnote 2. Page 47 - Corrected description for CT4,5,6 to Current Transformer, was Current Sensor. Page 52 - Expanded Terminal Plate information to include Type A and Type B. Page 53 - Corrected Group # for 30 Fan- Copper Fin to 11, was 1. Page 55 - Corrected Group # for 30 Fan- Alum Fin to 42, was 41. Corrected Group# for 28 Fan- Copper Fin to 41, was 42. Corrected Group# for 30 Fan- Copper Fin to 41, was 42. Page 58 - Corrected Rapid Restore (without VFD starter) to 333930501, was 333930601. Page 60 - Corrected part number for Ref. 827 MODBUS to 350147413, was 3501474131. Removed LonMark Comm. Module Only from Ref. 920. D 09/12 Page 15 - Corrected descriptions for Liq Injection Fittings. Added Liq Inj Fitting- Rotolock to Copper and Liq Inj O-Ring. E 03/13 Page 15 - Added Bubble Ref. 55 to drawing. Page 17 - Corrected descriptions of Ref 104, 204, 304. "Bent" & "Straight" were reversed. Page 45 - Re-arranged page to better group components. F 06/13 Pages 15, 16, 18, 30-33, 60: Replaced diagrams that were difficult to read. Page 24: Replaced diagrams for clearer information. Page 28: Corrected part no. for Ref. 5 Sensor Well to E44070058, was 070716307. G 08/14 Pages 5, 8, 15: Added "Linear Transducer" to description for "Slide Indicator". Page 38: Corrected chart alignment. H 05/2016 Page 15: Added Oil Filter Gasket Kit. Page 44: Updated part# for EEXV1,2,3, was 193441201. J 10/2016 Page 15: Added Ref. 14A Cables for Linear Transducer. Page 41: Corrected heading, was Compressor Circuit Breakers. K 05/2017 Pages 7 and 10: For F0-1,2,3; added "MMP" to description. Page 47: Updated description for F0-1,2,3; was Crankcase Heater MSP.

Parts List Revision History

Daikin Applied, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330


Nomenclature

AWS 375 A T S 27Unit Model Number- Dataplate

Unit Type: AWS= Air- Cooled Screw Compressor Chiller

Nominal Tonnageex. 375= 375 Tons

Vintage

Number of Compressors (circuits)T= 3

STN U 08 05 038

Plant IdentificationSTN = Staunton, VA

Year of Manufacture09= 200910= 201011= 2011

etc.

U= Unit

Serial Number (build sequence)Month of Manufacture01= January02= February03= March04= April05= May06= June

07= July08= August09= September10= October11= November12= December

Serial Number

PlatformS= Standard Efficiency H= High Efficiency

Voltage27= 460/60/346= 380/60/337= 575/60/3


AWS 375A T SE NN ST S A WD Y 27 WN V N N N LM N G Y N N VL S RCode 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25

L F G ND YNNNNNNN0000000N N NNYNNNNNNNN0000000000000000000Code 26 27 28 29 30- 36 37 38- 45

02 Size (in nominal tons)

03 Number of Compressors T= 3

04 Platform SE= Standard Package- Standard Efficiency HE= Standard Package- High Efficiency

05 Construction NN= Standard

06 Sound ST= Standard Sound LN= Low Noise- Sound Enclosure

07 Unit Operation S= Standard (40° - 60° F LWT) A= Lower Operation (34° - 39° F LWT) B= Brine Operation (20° - 33° F LWT)

08 Condenser Coil Fins A= Aluminum Fin (Standard) C= Copper Fin B= Aluminum Fin w/Prefab Black Fin Coating E= Aluminum Fin w/Electro Fin Coating F= Copper Fin w/Electro Fin Coating

09 Compressor Starter WD= Wye- Delta w/Compressor Overloads SS= Solid State VF= VFD without EMI Filter VE= VFD with EMI Filter

10 Always Y

11 Voltage 27= 460/60/3 37= 575/60/3 46= 380/60/3

12 Power Connection PC= Single Point Power Block & Circuit Breakers DC= Single Point Disconnect & Circuit Breakers DH= High Short Circuit Current Rating + DC WN= Multiple Point Disconnect- No Circuit Breaker WH= High Short Circuit Current Rating + WN

13 Phase Voltage V= Phase & Under/Over Voltage Protection w/LED N= None

NomenclatureUnit Model Number- Complete

ENDSUDPLYNNNNNNNNNNNRA1D00 NN M 6 NN Y S 00Code 46-55 56 57 58 59 60 61 62

14 Meters N= None A= Meters: Unit Amp & Volt

15 Control Box Ambient N= None H= With Exhaust Fans

16 Compressor Capacitor N= None

17 Communication NN= None LM= LonMark MB= Mod Bus BN= BACnet w/ MSTP BE= BACnet w/ Ethernet

18 Display Options N= On Controller Only U= Unit Remote Display

19 Ground Fault N= None G= Ground Fault Protection for the Unit

20 Always Y

21 Unit Options N= None C= 115V Convenience Outlet L= Slide Indicator/ Linear Transducer B= C + L

22 Water Flow N= None A= Water Flow Indication on Evaporator Only

23 Evaporator Connection VL= Victaulic/ Left Hand VR= Victaulic/ Right Hand

24 Evaporator Insulation S= Standard Evaporator- Single Layer D= Standard Evaporator- Double Insulation

25 Relief Valve R= Single Valve

26 Fans L= Standard Low Noise Fan Motors

27 Head Pressure F= Fantrol Only (35° F Minimum) V= VFD (First Fans/ Circuit)

375A= 375 Tons 'A' Vintage 445A= 445 Tons 'A' Vintage 400A= 400 Tons 'A' Vintage 470A= 470 Tons 'A' Vintage 425A= 425 Tons 'A' Vintage 500A= 500 Tons 'A' Vintage 530A= 530 Tons 'A' Vintage


28 Guards G= Condenser Coil Grilles Only F= Condenser Coil & Base Frame Grilles L= Condenser Coil Louvers B= Condenser Coil Louvers & Base Guard Louvers C= Condenser Coil Louvers and Base Frame Grilles

29 Tubing Options ND= With Discharge Shut-Off Valve SD= With Suction and Discharge Shut-Off Valve LD= ND + Liquid Line Solenoid SL= SD + Liquid Line Solenoid

30 Always Y

31 Water Pump NN= None

32 Pump Type NNNN= No Pump Package PPSS= Pump Package Air- Cooled Screw Single Pump PPSD= Pump Package Air- Cooled Screw Dual Pump

33 Pump Connection N= No Pump Package 6= 6" 8= 8" T= 10"

34 Pump Flow Actual 4 digit number based on conditions

35 Total Head Actual 3 digit number based on conditions

36 Pump Starter N= No Pump Package S= Pump Package Starter

37 Pump Gauges N= None G= Pressure Gauges

38 Pump Suction Valve N= None

39 Pump Discharge Valve N= None

40 Always Y

41 Impeller Trim NNNN= No Pumps 0000= Impeller Size

42 Expansion Tank NN= None

43 Buffer Tank NN= None

44 % of Glycol 000= None E**= Ethylene; **= % P**= Propylene; **= %

45 Pump Number All 0's= None 16 digit number= With Pumps

NomenclatureUnit Model Number- Complete, Continued

46 Approvals E= ETL/CETL Approval & ARI T= ETL/CETL Approval & No ARI

47 CRN- Evaporator 1= CRN- BC 2= CRN- Alberta 3= CRN- Saskatchewan 4= CRN- Manitoba 5= CRN- Ontario 6= CRN- Quebec 7= CRN- New Brunswick 8= CRN- Nova Scotia 9= CRN- P.E.I. U= CRN- Yukon 0= CRN- NewFoundland N= None

48 Unit Start DSU= Domestic Start Up CPL= Canadian Start Up ISU= International- No Start Up Provided

49 Standard Warranty DPL= Domestic 1st Year Standard CPL= Canadian 1st Year Standard Warranty TPN= International 1st Year Standard Warranty

50 Always Y

51 Extended Compressor Warranty NNNN= No Extended Compressor Warranty CPE*= Compressor Only- Parts Only (*= no. of years) CBE*= Compressor Only- Parts & Labor (*= no. of years)

52 Always NNN

53 Extended Unit Warranty NNNN= None EPE*= Ext. Unit- Parts Only (*= no. of years) EBE*= Ext. Unit- Parts & Labor (*= no. of years) DPE*= Ext. Unit w/Dual Pumps- Parts Only (*= no. of years) DBE*= Ext. Unit w/Dual Pumps- Parts & Labor (*= no. of years) SPE*= Ext. Unit w/Single Pump- Parts Only (*= no. of years) SBE*= Ext. Unit w/Single Pump- Parts & Labor (*= no. of years)

54 Refrigerant Warranty NNN= None RA*= Refrigerant 134a Warranty (*= no. of years)

55 Delayed Warranty Start D00= 0 months D**= Delayed Warranty Start (**= number of months)

56 Always NN

57 Brand Name D= DaikinMcQuay M= McQuay

58 Hertz 6= 60 Hertz

59 & 60 Always YY

61 Misc. S= Standard Unit X= Special

62 Major Unit Change Revision 00= No Revision


Electrical Legend - Units with Wye Delta or SS Starter Sch. Sym. Description Location AC Alarm Control Control Panel AM1 Ammeter Switch Box Door C10 EXV-1 Connector Starter Panel- Compressor 1 C20 EXV-2 Connector Starter Panel- Compressor 2 C30 EXV-3 Connector Starter Panel- Compressor 3 C101- 112 Fan Harness Connector Condenser Fan Section C201- 212 Fan Harness Connector Condenser Fan Section C301- 310 Fan Harness Connector Condneser Fan Section CC1, 2, 3 Control Compressor Cir. 1, 2, 3 Starter Panel- Compressor 1, 2, 3 DP-1, 2, 3 Condenser Pressure Cir. 1, 2, 3 Discharge Line- Circuit 1, 2, 3 EEXV1, 2, 3 Expansion Valve Controller Cir. 1, 2, 3 Starter Panel- Compressor 1, 2, 3 ESV-1, 2, 3 Economizer Solenoid Valve Cir. 1, 2, 3 Liquid Line- Circuit 1, 2, 3 EXV-1, 2, 3 Electronic Expansion Valve Cir. 1, 2, 3 Liquid Line- Circuit 1, 2, 3 F0-1, 2, 3 Crankcase Heater Fuses/ MSP/ MMP Starter Panel- Compressor 1, 2, 3 F1, 2, 3 Compressor 1, 2, 3 Circuit Breaker Power Panel- Right F5-1, 2, 3 Thermal Relay Starter Panel- Compressor 1, 2, 3 F12 Outlet Fuse Power Panel- Left F13 High Pressure Switch Cir. 1 Compressor 1 F23 High Pressure Switch Cir. 2 Compressor 2 F33 High Pressure Switch Cir. 3 Compressor 3 F59 Evaporator Heater Fuse Control Panel F90 Thermostat Control Panel F100 Fan Circuit Breaker Cir. 1 Power Panel- Left F112 Phase Volt Monitor Cir. 1 Power Panel- Left F116 Evaporator Flow Switch Evaporator Outlet F120 Transformer T1 Protection Power Panel- Left F130 Phase Volt Monitor Fuse Power Panel- Left F200 Fan Circuit Breaker 2 Power Panel- Left F212 Phase Voltage Monitor Cir. 2 Power Panel- Left F230 Phase Volt Monitor Fuse Cir. 2 Power Panel- Left F300 Fan Circuit Breaker 3 Power Panel- Left F312 Phase Voltage Monitor Cir. 3 Power Panel- Left F330 Phase Voltage Monitor Fuse Cir. 3 Power Panel- Left FC Fan Control Control Panel FTB107 Fan Terminal Block Cir. 1 Power Panel- Left FTB110 Fan Terminal Block Cir. 1 Power Panel- Left FTB207 Fan Terminal Block Cir. 2 Power Panel- Left FTB210 Fan Terminal Block Cir. 2 Power Panel- Left FTB307 Fan Terminal Block Cir. 3 Power Panel- Left GFR1, 2, 3 Ground Fault Relay Cir. 1, 2, 3 Power Panel- Left K11 Emergency Stop Contactor Control Panel K16 Fan Stage 1 Power Panel- Left K26 Fan Stage 2 Power Panel- Left K36 Fan Stage 3 Power Panel- Left K2B-1, 2, 3 Contactor Starter Panel- Compr 1, 2, 3 KLJ-1, 2, 3 Liquid Injection Relay 1, 2, 3 Starter Panel- Compr 1, 2, 3 KM1-1 Compressor Contactor Starter Panel- Compressor 1 KM1-2 Compressor Contactor Starter Panel- Compressor 1 KM1-3 Compressor Contactor Starter Panel- Compressor 1 KM2-1 Compressor Contactor Starter Panel- Compressor 2 KM2-2 Compressor Contactor Starter Panel- Compressor 2 KM2-3 Compressor Contactor Starter Panel- Compressor 2 KM3-1 Compressor Contactor Starter Panel- Compressor 3


Sch. Sym. Description Location KM3-2 Compressor Contactor Starter Panel- Compressor 3 KM3-3 Compressor Contactor Starter Panel- Compressor 3 KM10-1, 2 , 3 Contactor Starter Panel- Compr 1, 2 ,3 KM101- 110 Fan Motor Contactor Power Panel- Left KM201- 210 Fan Motor Contactor Power Panel- Left KM301- 310 Fan Motor Contactor Power Panel- Left KT13 Time Delay Relay 1 Starter Panel- Compressor 1 KT23 Time Delay Relay 2 Starter Panel- Compressor 2 KT33 Time Delay Relay 3 Starter Panel- Compressor 3 KT-1, 2, 3 Auxilliary Relay Cir. 1, 2, 3 Starter Panel- Compr 1, 2, 3 KT1-1, 2, 3 Delay Relay Starter Panel- Compr 1, 2, 3 LJV-1, 2, 3 Liquid Injection Solenoid Cir. 1, 2, 3 Liquid Line/Starter Panel LP1, 2, 3 Low Pressure Switch 1, 2, 3 Compressor 1, 2, 3 LR1, 2, 3 Line Reactor Cir. 1, 2, 3 Power Panel- Left LSV-1, 2, 3 Liquid Line Solenoid Cir. 1, 2, 3 Liquid Line- Circuit 1, 2, 3 M1, 2, 3 Compressor Cir. 1, 2, 3 Base M10 Forced Ventilation Switch Box End M101- 112 Fan Motor Power Panel- Left M201- 212 Fan Motor Power Panel- Left M301- 310 Fan Motor Power Panel- Left MP1, 2, 3 Motor Thermal Protection Starter Panel- Compr 1, 2, 3 MPR1, 2, 3 Motor Protection Relay Cir. 1, 2, 3 Starter Panel- Compr 1, 2, 3 OP-1, 2, 3 Oil Pressure Cir. Cir. 1, 2, 3 Compressor 1, 2, 3 Q0 Unit ON - OFF Switch Control Panel Q1 Pump Down Switch Cir. 1 Control Panel Q2 Pump Down Switch Cir. 2 Control Panel Q3 Pump Down Switch Cir. 3 Control Panel Q10 Main Power Block or Disconnect Switch 1 Power Panel- Right Q11 Emergency Stop Switch Control Box Door Q12 Automatic Circuit Breaker Control Panel Q20 Main Power Block or Disconnect Switch 2 Power Panel- Right Q30 Main Power Block or Disconnect Switch 3 Power Panel- Right Q101- 110 Fan MSP Power Panel- Left Q201- 210 Fan MSP Power Panel- Left Q301-310 Fan MSP Power Panel- Left R1, 2, 3 Compressor Crankcase Heater Cir. 1, 2, 3 Compressor 1, 2, 3 R5 Evaporator Heater Evaporator Shell REC 1 115V Outlet Control Panel SL-1, 2, 3 Slide Indicator/ Linear Transducer Cir. 1,2,3 Compressor 1, 2, 3 SP-1, 2, 3 Evap. Pressure Circuit 1, 2, 3 Suction Line- Circuit 1, 2, 3 SS1 Selection Switch Voltmeter SS2 Selection Switch Ammeter ST-1, 2, 3 Suction Temperature Cir. 1, 2, 3 Suction Line- Circuit 1, 2, 3 T1 115V Transformer Power Panel- Left T2 24V Transformer Power Panel- Left T20-1, 2, 3 Transformer Cir. 1, 2, 3 Starter Panel- Compr 1, 2, 3 TC Thermostat- Evaporator Heater Evaporator TXV-1, 2, 3 Thermal Expansion Valve Cir. 1, 2, 3 Economizer Liquid Line UC Unit Control- MicroTech III Control Panel VFD1, 2, 3 Fan VFD / SpeedTrol Near front of evaporator VM1 Volt Meter Switch Box Door W1, 2, 3 Compressor Thermistor Cir. 1, 2, 3 Compressor 1, 2, 3 WAA Air Ambient Sensor Condenser Coil Header

Electrical Legend - Units with Wye Delta or SS Starter


Sch. Sym. Description Location WD-1, 2, 3 Oil Discharge Temp. Sensor Cir. 1, 2, 3 Discharge Line- Circuit 1, 2, 3 WIE Evaporator Entering Water Temperature Evaporator Inlet WOE Evaporator Leaving Water Temperature Evaporator Outlet Y2A-1 Non-Modulating Slide Load Sol. Valve Cir. 1 Compressor 1 Y2A-2 Non-Modulating Slide Load Sol. Valve Cir. 2 Compressor 2 Y2A-3 Non-Modulating Slide Load Sol. Valve Cir. 3 Compressor 3 Y2B-1 Modulating Slide Load Solenoid Valve Cir. 1 Compressor 1 Y2B-2 Modulating Slide Load Solenoid Valve Cir. 2 Compressor 2 Y2B-3 Modulating Slide Load Solenoid Valve Cir. 3 Compressor 3 Y3A-1 Non-Mod. Slide Unload Sol. Valve Cir. 1 Compressor 1 Y3A-2 Non-Mod. Slide Unload Sol. Valve Cir. 2 Compressor 2 Y3A-3 Non-Mod. Slide Unload Sol. Valve Cir. 3 Compressor 3 Y3B-1 Mod. Slide Unload Solenoid Valve Cir. 1 Compressor 1 Y3B-2 Mod. Slide Unload Solenoid Valve Cir. 2 Compressor 2 Y3B-3 Mod. Slide Unload Solenoid Valve Cir. 3 Compressor 3 YT-1, 2, 3 Turbo Solenoid Valve Cir. 1, 2, 3 Compressor 1, 2, 3

Electrical Legend - Units with Wye Delta or SS Starter


Electrical Legend - Units with VFD Starter Sch. Sym. Description Location AC Alarm Control Control Side AM1 Ammeter Control Box Door C10 EXV-1 Connector Outside Back of Control Side C20 EXV-2 Connector Outside Back of Control Side C30 EXV-3 Connector Outside Back of Control Side C101- 112 Fan Harness Connector Condenser Fan Section C201- 212 Fan Harness Connector Condenser Fan Section C301- 310 Fan Harness Connector Condenser Fan Section CC1, 2, 3 Control Compressor Cir. 1, 2, 3 Control Side DP-1, 2, 3 Condenser Pressure Cir. 1, 2, 3 Discharge Line- Circuit 1, 2, 3 EEXV1, 2, 3 Expansion Valve Controller Cir. 1, 2, 3 Control Side EMI-1, 2, 3 Electromagnetic Interference Filter 1, 2, 3 Power Side ESV-1, 2, 3 Economizer Solenoid Valve Cir. 1, 2, 3 Liquid Line- Circuit 1, 2, 3 EXV-1, 2, 3 Electronic Expansion Valve Cir. 1, 2, 3 Liquid Line- Circuit 1, 2, 3 F0-1, 2, 3 Crankcase Heater Fuses/ MSP/ MMP Power Side F1, 2, 3 Compressor 1, 2, 3 Circuit Breaker Power Side F10 Exhaust Fan Fuse Control Side F11 Unit Controller Fuse Control Side F12 Outlet Fuse Control Side F13 High Pressure Switch Cir. 1 Compressor 1 F23 High Pressure Switch Cir. 2 Compressor 2 F33 High Pressure Switch Cir. 3 Compressor 3 F59 Evaporator Heater Fuse Control Side F90 Thermostat Control Side F100 Fan Circuit Breaker Cir. 1 Control Side F116 Evaporator Flow Switch Evaporator Outlet F120 Transformer T1 Protection Power Side F130 Phase Volt Monitor Fuse Control Side F200 Fan Circuit Breaker Cir. 2 Control Side F300 Fan Circuit Breaker Cir. 3 Control Side FC Fans Control Control Side FTB107 Fan Terminal Block Cir. 1 Control Side FTB110 Fan Terminal Block Cir. 1 Control Side FTB207 Fan Terminal Block Cir. 2 Control Side FTB210 Fan Terminal Block Cir. 2 Control Side FTB307 Fan Terminal Block Cir. 3 Control Side GFR1, 2, 3 Ground Fault Relay Cir. 1, 2, 3 Control Side JFU1, 2, 3 HSCR Fuse 1, 2, 3 Control Side K1, 2, 3 Compressor VFD Run Relay 1, 2, 3 Power Side K11 Emergency Stop Contactor Control Side K13 Mechanical Hi Pressure Relay & Contactor Control Side K16 Fan Stage Cir. 1 Control Side K23 Mechanical Hi Pressure Relay & Contactor Control Side K26 Fan Stage Cir. 2 Control Side K33 Mechanical Hi Pressure Relay & Contactor Control Side K36 Fan Stage Cir. 3 Control Side KLJ-1, 2, 3 Liquid Injection Relay 1, 2, 3 Control Side KM101- 110 Fan Motor Contactor Control Side KM201- 210 Fan Motor Contactor Control Side KM301- 310 Fan Motor Contactor Control Side LJV-1, 2, 3 Liquid Injection Solenoid Cir. 1, 2, 3 Liquid Injection Line 1, 2, 3 LP1, 2, 3 Low Pressure Switch 1, 2, 3 Compressor 1, 2, 3 LR1, 2, 3 Line Reactor Cir. 1, 2, 3 Control Side


Electrical Legend - Units with VFD Starter Sch. Sym. Description Location LSV-1, 2, 3 Liquid Line Solenoid Cir. 1, 2, 3 Liquid Line- Circuit 1, 2, 3 M1, 2, 3 Compressor Cir. 1, 2, 3 Base M10 Forced Ventilation Outside Wall of Power Side M11 Intake Fan Outside Wall of Control Side M12 Exhaust Fan Control Box Left Door M101- 112 Fan Motor Condenser Fan Section M201- 212 Fan Motor Condenser Fan Section M301- 310 Fan Motor Condenser Fan Section MP1, 2, 3 Motor Thermal Protection Control Side MPR1, 2, 3 Motor Protection Relay Cir. 1, 2, 3 Control Side OP-1, 2, 3 Oil Pressure Cir. Cir. 1, 2, 3 Compressor 1, 2, 3 Q0 Unit ON - OFF Switch Control Side Q1 Pump Down Switch Cir. 1 Control Side Q2 Pump Down Switch Cir. 2 Control Side Q3 Pump Down Switch Cir. 3 Control Side Q10 Main Power Block or Disconnect Switch Power Side Q11 Emergency Stop Switch Control Box Left Door Q12 Automatic Circuit Breaker T1 Transformer Q101- 110 Fan MSP Control Side Q201- 210 Fan MSP Control Side Q301 - 310 Fan MSP Control Side R1, 2, 3 Compressor Crankcase Heater Cir. 1, 2, 3 Compressor 1, 2, 3 R5 Evaporator Heater Evaporator Shell REC 1 115V Outlet Control Side SP-1, 2, 3 Evap. Pressure Circuit 1, 2, 3 Suction Line- Circuit 1, 2, 3 SS1 Selection Switch 1 Voltmeter SS2 Selection Switch 2 Ammeter ST-1, 2, 3 Suction Temperature Cir. 1, 2, 3 Suction Line- Circuit 1, 2, 3 T1 115V Transformer Power Side T2 24V Transformer Control Side T20-1, 2, 3 Transformer Cir. 1, 2, 3 Control Side TC Thermostat- Evaporator Heater Evaporator UC Unit Control- MicroTech III Control Side VFD1, 2, 3 Fan VFD / SpeedTrol Control Side Left Wall VFD-1 Compressor VFD 1 Power Side VFD-2 Compressor VFD 2 Power Side VFD-3 Compressor VFD 3 Power Side VFU1, 2, 3 Compressor VFD Fuse 1, 2, 3 Power Side VM1 Volt Meter Switch Box Door W1, 2, 3 Compressor Thermistor Cir. 1, 2, 3 Compressor 1, 2, 3 WAA Air Ambient Sensor Condenser Coil Header WD-1, 2, 3 Oil Discharge Temp. Sensor Cir. 1, 2, 3 Discharge Line- Circuit 1, 2, 3 WIE Evaporator Entering Water Temperature Evaporator Inlet WOE Evaporator Leaving Water Temperature Evaporator Outlet


Unit Layout(Unit Size 375ATS Shown)

10

1

8

2

Ref. No. Description Location 1 Compressors Refrigeration Section 2 Tubing (suction, discharge, liquid injection) Refrigeration Section 3 Liquid Line and Economizer Refrigeration Section 7 Evaporator Refrigeration Section 8 Condenser Coil Refrigeration Section 9 Condenser Fans Refrigeration Section 10 Unit Switch Box/Control Panel * Controls Section 11 Compressor Starter Panel (not on units with VFD Starters) Controls Section 12 Compressor Terminal Box Controls Section

9

7

9 9 9 99 9 9

11

12

* Control Panel for units with Wye-Delta or Solid State Starters is shown. Larger Panel used on units with VFD Starters.

99 9

3


Unit Size Std Eff. High Eff 375 B -- 400 B -- 425 E -- 445 E B 470 E B 500 D E 530 D E

Unit Size Std Eff. High Eff

375 B -- 400 B -- 425 E -- 445 E B 470 E B 500 D E 530 D E

Compressor, Circuit 1

Refrigeration SectionCompressor Charts


See next page for Compressor part numbers.

Standard Efficiency: Code 4 = S*High Efficiency: Code 4 = H*

Unit Size Std Eff. High Eff.

375 B -- 400 E -- 425 B -- 445 E B 470 D E 500 E B 530 D E


For units built after 8/1/11, contact Daikin Applied for part number identification of Compressors.


Compressor B 380V (units w/ VFD Starters) 332525382 380V (units w/o VFD Starters) 332525282 460V (units w/ VFD Starters) 332525362 460V (units w/o VFD Starters) 332525262 575V 332525267

Compressor D 380V (units w/ VFD Starters) 10000108984 380V (units w/o VFD Starters) 10000102384 460V (units w/ VFD Starters) 10000108964 460V (units w/o VFD Starters) 10000102364 575V 10000102369

Compressor E 380V (units w/ VFD Starters) 10000108983 380V (units w/o VFD Starters) 10000102383 460V (units w/ VFD Starters) 10000108963 460V (units w/o VFD Starters) 10000102363 575V 10000102368

Units with VFD Starters: Code 9 = VE, VFUnits without VFD Starters: Code 9 = WD or SS

Refrigeration SectionCompressors

See previous page for Compressor Charts.

For units built after 8/1/11, contact Daikin Applied for part number identification of Compressors.


Ref. Sch. Description Compressor Compressor Compressor Qty No. Sym. B D E per compr

2 R1,2,3 Compressor Heater, 380V 735041266 735041266 735041266 1 2 R1,2,3 Compressor Heater, 460V 735041267 735041267 735041267 1 2 R1,2,3 Compressor Heater, 575V 735041268 735041268 735041268 1 2A Well- Heater 300043894 300043894 300043894 1 2B Bushing- Heater 132010016 132010016 132010016 1 10 F13,23,33 Switch- High Pressure Control, 290 psi 073074009 073074009 073074009 1 11 OP1, 2, 3 Transducer- Oil Pressure, 0 to 30 bar 1000109562 10000109562 10000109562 1 13 Relief Valve 735045859 735045859 735045859 1 13A Elbow- Relief Valve 10000108772 10000108772 10000108772 1 14 SL1, 2, 3 Linear Transducer- Slide Indicator (C21= L, B) 330591103 330591103 330591103 1 14A Cable for Linear Transducer (16 ft) 331991702 331991702 331991702 1 14A Cable for Linear Transducer (32 ft) 331991703 331991703 331991703 1 15 Discharge Shut-Off Valve 10000107037 10000107037 10000107037 1 15A Screw, Hex 330821925 330821925 330821925 4 15B Washer, Lock 048164816 048164816 048164816 4 50 Isolator, Compr. Mounting 10000107142 10000107046 10000107046 4 51 Screw, M8 x 2.5 C101 330821929 330821929 330821929 8 52 Washer, Plain, .312 040500322 040500310 040500310 8 53 Washer, Lock, .500 048164814 048164814 048164814 4 54 Screw, M12 x 1.75 330821921 330821921 330821921 4 55 Washer, Lock, .312 048164810 048164810 048164810 8 60 Y2*1-1,2,3 Valve, Solenoid- Load 1 1 1

60A Y3*1-1,2,3 Valve, Solenoid- Unload 1 1 1

60B YT-1,2,3 Valve, Solenoid- Turbo 1 1 1

NS Suction Gasket 332115901 332115901 332115901 1 NS Oil Filter 332115201 332115201 332115201 1 NS Oil Filter Gasket Kit 128810988 128810988 128810988 1 NS Liq Injection Fitting- Compr (non-Economizer) 132010053 132010053 132010053 1 NS Liq Injection Fitting- Compr (with Economizer) 10000105095 10000105095 10000105095 1 NS Liq Injection Fitting- Rotolock to Copper 10000107074 10000107074 10000107074 1 NS Liq Injection O-Ring 070194971 070194971 070194971 1 NS Kit, O-Rings and Gaskets 128810919 128810921 128810921 1

Refrigeration SectionCompressor Components

1 Solenoids are comprised of: Valve Body & Adapter p/n 132010102; Valve Coil p/n 131066074; Valve Support Gasket p/n 332130201.NS = Not Shown

See Compressor Charts to identify compressor.

Circuit # 1 shown

10

11

213

14

5150

5352

13A

54

1515A

15B

60A60

60

60B

60A Y3B1

YT1

Y2B1

Y3A1

Y2A1

R1F13

SL1

2A 2B

55


Liquid InjectionCircuit #1

Refrigeration SectionSuction Lines, Liquid Injection Lines

Suction LineCircuit #1 with SuctionShut-off Valve

311

313

309

304302

303

411413 409

404 402403


LiquidInjection LJV2

LJV1

Suction

Suction LineCircuit #3 with SuctionShut-off Valve

Suction LineCircuit #2with SuctionShut-off Valve


811

813809

804

802

803

LJV3

702

700

704

Representation of piping is shown. Configuration may vary.

ST3

For units built after 8/1/11, contact Daikin Applied for part number identification of Suction Piping Components.

102

100

104ST1

202

200

204 ST2


Refrigeration SectionSuction Lines, Liquid Injection Lines

Ref Sch. Part Part No. Sym. Description Number Qty. Suction Line- Circuit #1 100 Valve- Relief 200 PSI 735045852 1 102 Valve- Suction Shutoff 073062104 1 104 ST1 Sensor- Suction Temperature, Bent, 30 ft. 332519703 1 Sensor- Suction Temperature, Straight, 30 ft. 193414603 1 N/S SP1 Transducer- Suction -1 to 7 bar 10000109563 1

Suction Line- Circuit #2 200 Valve- Relief 200 PSI 735045852 1 202 Valve- Suction Shutoff 073062104 1 204 ST2 Sensor- Suction Temperature, Bent, 30 ft. 332519703 1 Sensor- Suction Temperature, Straight, 30 ft. 193414603 1 N/S SP2 Transducer- Suction Pressure -1 to 7 bar 10000109563 1

Suction Line- Circuit #3 700 Valve- Relief 200 PSI 735045852 1 702 Valve- Suction Shutoff 073062104 1 704 ST3 Sensor- Suction Temperature, Bent, 30 ft. 332519703 1 Sensor- Suction Temperature, Straight, 30 ft. 193414603 1 N/S SP3 Transducer- Suction Pressure -1 to 7 bar 10000109563 1

Liquid Injection- Circuit #1 302 Fitting- Rotolock 10000107074 1 303 Valve- Schrader 071100801 1 304 LJV1 Valve- Solenoid 120V 331451002 1 309 Strainer 735030506 1 311 Valve- Ball 330286003 1 313 Cap- Valve 032943500 1



For units built after 8/1/11, contact Daikin Applied for part number identification of Suction Piping Components.


508

500501

505

504503

DischargeCkt. 1

509

DP1

WD1

Refrigeration SectionDischarge Lines

DischargeCkt. 3

908

900901

905

904903

909

DP3

WD3

Representation of piping is shown. Configuration may vary.

DischargeCkt. 2

608605

604603

600 601

609DP2

WD2


Refrigeration SectionDischarge Lines

Ref Sch. Part Part No. Sym. Description Number Qty. Discharge Line- Circuit #1 500 Coupling 3.13 10000108703 1 501 Kit- Flange 4.12 735016406 1 503 Valve- Schrader 071100801 1 504 Core- Valve 026541100 1 505 DP1 Transducer- Discharge Pressure 0 to 30 bar 10000109562 1 508 Tube- Sensor 070228901 1 509 WD1 Sensor- Discharge Temperature, 20 ft. 193414602 1 NS Gasket- Discharge Shut-Off Valve 070199144 1

Discharge Line- Circuit #2 600 Coupling 3.13 10000108703 1 601 Kit- Flange 4.12 735016406 1 603 Valve- Schrader 071100801 1 604 Core- Valve 026541100 1 605 DP2 Transducer- Discharge Pressure 0 to 30 bar 10000109562 1 608 Tube- Sensor 070228901 1 609 WD2 Sensor- Discharge Temperature, 20 ft. 193414602 1 NS Gasket- Discharge Shut-Off Valve 070199144 1

Discharge Line- Circuit #3 900 Coupling 3.13 10000108703 1 901 Kit- Flange 4.12 735016406 1 903 Valve- Schrader 071100801 1 904 Core- Valve 026541100 1 905 DP3 Transducer- Discharge Pressure 0 to 30 bar 10000109562 1 908 Tube- Sensor 070228901 1 909 WD3 Sensor- Discharge Temperature, 20 ft. 193414602 1 NS Gasket- Discharge Shut-Off Valve 070199144 1


Refrigeration SectionLiquid Lines- Standard Efficiency Units

(Code 04= S*)

119

Ref Sch. Part Part Qty. No. Sym. Description Number per circuit 100 Valve- Schrader 071100801 3 101 Core- Valve 026541100 3 102 Cap- Valve 032943500 3 107 Valve- Charge .37 x .37 038689900 3 108 Valve- Ball 1.625 330286087 1 109 Bracket- Drier 10000101769 1 112 Shell- Filter Drier 071993505 1 113 Core- Filter Drier 330694401 4 114 Kit- Drier Gasket 074783601 2 115 Saddle- Sight Glass 330508705 1 116 Cap- Sight Glass 330508701 1 119 EXV1,2,3 Valve- Electronic Expansion 12V/6W 10000107041 1 124 LSV1,2,3 Valve- Liquid Line Solenoid C29= SD, SL 331451007 1

Evaporator

107 119107

124

Circuit #1

102101100

113

108

112114109

100

102

101

116115

LSV1EXV1

Representation of tubing is shown. Configuration may vary.

108

107

100102 101

109

113

112

114

116

115100

102

101

Circuit #2

109100

102101

116 115

107

124

113112

114

108

107

102101100

LSV2

EXV2119

124

107

100102 101

Circuit #3

LSV3

EXV3

For units built after 8/1/11, contact Daikin Applied for part number identification of Check Valves and Economizers.


Refrigeration SectionLiquid Lines with Economizer- High Efficiency Units

(Code 04= H*)

116115

From Economizer S4

109

112

204

101

201

200

100

102101

107

119

107

124

101

100102

21

102

101100

Line Between Economizer and

Compressor

ESV_

To Evaporator

From Economizer S2

S1S4

S2S3

Economizer

Connects To Evaporator

To S1

From Condenser

From Liquid Line Tee

Liquid

Line

Tee

To Compressor

From

Economizer

S4

To Compressor

Compressor Economizer Connection

102

101100

102

101100

From Condenser

Representation of Circuit 1 is shown.Configuration may vary.

(Circuits 2 & 3 have same components)

Condenser to Economizer

Economizer to Evaporator

Circuit 1

Circuit 2

From ESV

Equalization

Tube

Evaporator

6

100 102 114

108

113

TXV_

EXV_

LSV_

208 209




(Code 04= H*)

Ref Sch. Part Part Qty. No. Sym. Description Number per circuit 1 ESV1,2,3 Valve- Economizer Solenoid 331451003 1 2 TXV1,2,3 Valve- Thermal Expansion see next page 1 6 Economizer- Brazed Plate see next page 1 100 Valve- Schrader 071100801 4 101 Core- Valve 026541100 4 102 Cap- Valve 032943500 4 107 Valve- Charge .37 x .37 038689900 3 108 Valve- Ball 1.625 330286087 1 109 Bracket- Drier 10000101769 1 112 Shell- Filter Drier 071993505 1 113 Core- Filter Drier 330694401 4 114 Kit- Drier Gasket 074783601 2 115 Saddle- Sight Glass 330508705 1 116 Cap- Sight Glass 330508701 1 119 EXV1,2,3 Valve- Electronic Expansion 12V/6W 10000107041 1 124 LSV1,2,3 Valve- Liquid Line Solenoid C29= SD, SL 331451007 1 200 Connector- Economizer 10000105027 2 201 Fitting- Economizer 10000107073 2 204 Valve- Check 070300705 2 Gasket for Check Valve P292C-14 2 208 O-Ring 070194970 2 209 O-Ring 070199104 2



Part Qty. Ref. # Description Number per circuit

TXV/Economizer B 2 Thermal Expansion Valve 330692927 1 6 Economizer 10000107023 1

TXV/Economizer E 2 Thermal Expansion Valve 330692928 1 6 Economizer 10000107024 1


(Code 04= H*)

Used with Used with Used with Unit Size Compressor 1 Compressor 2 Compressor 3 375 -- -- -- 400 -- -- -- 425 -- -- -- 445 B B B 470 B B E 500 E E B 530 E E E

Use the chart above to determine the TXV / Economizer group . Use the chart below to identify the component part numbers.



Refrigeration SectionCondenser Coils and Fans

4

2

1

3

5

Fan Detail

50

1 Mounted to Condenser Coil tubesheet behind the switch box.***= Fan number 101 - 310.

Ref Sch. Part Part Quantity No. Sym. Description Number

1 Panel- Fan Deck 10000108765 1 per fan - see next page 2 Grille- Fan 10000107008 1 per fan 3 Bracket- Fan Motor 10000100048 1 per fan 4 Blade- Fan 10000107009 1 per fan 5 M*** Motor- Fan, 380V 1.4 HP 10000108872 1 per fan 5 M*** Motor- Fan, 460V 1.4 HP 10000108873 1 per fan 5 M*** Motor- Fan, 575V 1.4 HP 10000108874 1 per fan

50 WAA Sensor- Outdoor Air, 20 ft. 1 193414602 1 per unit

Coils- Condenser Identify from diagram and Contact Daikin Applied

F1C1

F1C2 F1C4 F1C3

F2C1

F2C2 F2C4 F2C3


Unit Std. Eff. High Eff. Size Ckt 1 Ckt 2 Ckt 3 Total Ckt1 Ckt 2 Ckt 3 Total 375 7 7 8 = 22 -- -- -- -- 400 7 7 8 = 22 -- -- -- -- 425 8 8 8 = 24 -- -- -- -- 445 8 8 8 = 24 8 8 8 = 24 470 8 8 10 = 26 8 8 10 = 26 500 10 10 8 = 28 10 10 8 = 28 530 10 10 10 = 30 10 10 10 = 30

Refrigeration SectionFan Totals per Unit

Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*


Refrigeration SectionEvaporator Diagram

1

5

4A 47

8

6

5

WOE WIE

F116

218

20

12

2A

109

Liquid Connection End

Suction Connection End

20

14

15 18

19

8A10

9

For units built after 8/1/11, contact Daikin Applied for part number identification of Evaporator Assemblies. All other Evaporator parts listed apply to all dates.


Description / Unit Sizes Left-Hand Evap Standard Efficiency Units (Code 4= S*) 375A 10000108730 400A 10000108732 425A 10000108733 445A 10000108733 470A 10000108733 500A 10000108733 530A 10000108733

High Efficiency Units (Code 4= H*) 445A 10000108732 470A 10000108733 500A 10000108733 530A 10000108733

See next page for Evaporator components.

Refrigeration SectionEvaporator Components

Ref. No. 1: Evaporator

For units built after 8/1/11, contact Daikin Applied for part number identification of Evaporator Assemblies. All other Evaporator parts listed apply to all dates.


Refrigeration SectionEvaporator Components

Ref Sch. Part Part No. Qty. No. Sym. Description

2 Ferrule- Liquid E44070043 3 2A Flange- Liquid E44060009 3

4 WIE Sensor- Evaporator Inlet, 60 ft. 193414606 1 4A WOE Sensor- Evaporator Outlet, 60 ft. 193414606 1

5 Well- Sensor E44070058 2

6 R5 Heater- Evaporator E44191111 1 7 F116 Switch- Evaporator Flow 331796201 1 Cable- for Evap Flow Switch 330571403 1

8 Gasket- Inlet Head E44136603 1 8A Gasket- Suction Head E44136603 1

9 Gasket- Distributor E44136604 2 9 Gasket- Distributor E44136605 1

10 O'Ring- Liquid E44130170 3

12 Bolt- Liquid Ferrule E10154000 12

14 Bolt- Suction Connection E14155000 12

15 O'Ring- Suction E44130201 3

18 Bolt- Head (M14- 16 x 1.5 x 130) E16151300 22 18 Bolt- Head (M16 x 1.5 x 145) E16151400 4 18 Bolt- Head (M16 x 1.5 x 70) E16157000 22

19 Valve- Mini Ball, 0.50 NPT 071596201 1

20 Pad- Vibration, 4" x 3.25" 735008725 4 NS Insulation 047662050 as needed

NS = Not Shown


Coil and Base Frame Grilles

Base Frame GrillesCode 28=F, C

22 Fan Unit shown

Ref Part Part Quantity No. Description Number 1 Grille- Base 1 10000108704 1 per fan 2 Grille- Left Hand Rear 2 10000108705 1 per unit 3 Grille- Right Hand Rear 2 10000108706 1 per unit 4 Grille- Front 2 10000108707 1 per unit

3

1

4

2

1 Each base grille is attached using four (4) screws p/n 331578401.2 Each front or rear grille is attached using six (6) screws p/n 331578401. Front Grille not used on units with VFD Starters.

Coil GrillesCode 28=G, F

Unit configuration will vary with number of fans.

1

Ref Part Part Quantity No. Description Number 1 Grille- Coil 1 10000107007 1 per fan1 Each coil louver is attached using six (6) screws p/n 331578401.

Std. High Unit Eff. Eff. Size Total Total Fans Fans 375 22 -- 400 22 -- 425 24 -- 445 24 24 470 26 26 500 28 28 530 30 30



Coil LouversCode 28=L, B, C

Unit configuration will vary with number of fans.

Ref Part Part Quantity No. Description Number 2 Louvered Panel- Coil 1 10000101793 1 per fan

2

1 Each coil louver is attached using six (6) screws p/n 331578401.




6

4

5 64 5 3

2

4

46

5

5

6

Base Frame LouversCode 28= B

22-24 Fan Units

3

42

5 6

6

5

65

5

4

5

6

4

56

6

101110

101110

22 Fan Unit

24 Fan Unit

# of Fans screws Ref Part Part per No. Description Number 22 24 panel 2

2 Louvered Panel- Rear Bottom 10000101795 1 1 16 3 Louvered Panel- Rear Top 10000101796 1 1 10 4 Louvered Panel- Side 10000101797 9 14 6 5 Louvered Panel- Side 10000101798 6 5 10 6 Louvered Panel- Side 10000101799 6 5 10 7 Louvered Panel- Side 10000101792 1 14 10 Louvered Panel- Front Side 1 332527901 2 2 9 11 Louvered Panel- Front Center 1 332527902 1 1 10

1 Front Side and Front Center Panels not used on units with VFD Starters. 2 Screw part number 331578401.



7

56

4


6

45

64 5

3

2

4

46

5

5

6


26-28 Fan Units

3

4 2

4

5

6

5

65

6

5

4

45

6

1011

10

1011

10

26 Fan Unit

28 Fan Unit

# of Fans screws Ref Part Part per No. Description Number 26 28 panel 2

2 Louvered Panel- Rear Bottom 10000101795 1 1 16 3 Louvered Panel- Rear Top 10000101796 1 1 10 4 Louvered Panel- Side 10000101797 16 20 6 5 Louvered Panel- Side 10000101798 5 4 10 6 Louvered Panel- Side 10000101799 5 4 10 10 Louvered Panel- Front Side 1 332527901 2 2 9 11 Louvered Panel- Front Center 1 332527902 1 1 101 Front Side and Front Center Panels not used on units with VFD Starters. 2 Screw part number 331578401.



4

6

4

64 5


6

4 56 4

5

3

2

4

46 5

5

6


30 Fan Units

101110

30 Fan Unit

# of Fans screws Ref Part Part per No. Description Number 30 panel 2

2 Louvered Panel- Rear Bottom 10000101795 1 16 3 Louvered Panel- Rear Top 10000101796 1 10 4 Louvered Panel- Side 10000101797 20 6 5 Louvered Panel- Side 10000101798 5 10 6 Louvered Panel- Side 10000101799 5 10 10 Louvered Panel- Front Side 1 332527901 2 9 11 Louvered Panel- Front Center 1 332527902 1 101 Front Side and Front Center Panels not used on units with VFD Starters. 2 Screw part number 331578401.



4

64 5


ControlsUnits with Wye-Delta or Solid State Starter (Code 9 = WD, SS)

Box Locations and Label Detail

Control Panel Power Panel- Left Side Power Panel- Right Side

Solid State Starter Panel(one per compressor)

Circuit 2 shown

Wye- DeltaStarter Panel(one per compressor)

Circuit 2 shown

or

Terminal Box(one per compressor)

For all control components not detailed or for unit specific controls (i.e. main disconnect, solid state contactors), please contact Daikin Applied with the Control Box Serial Number and Control Box Part Number. These numbers are located on the Control box rating label (see example below). This label is found inside the panel.

Control Box Serial Number“S” + Year + ##### + detail#

Control Box Part Number

Label Detail

Circuit 2 Starter Box

Fan VFDlocation6

1

2

34

5


Sch. Part Part Sym. Description Number Qty. AC Expansion Controller- Alarms 193407501 1 AWM Advanced Web Module 2 193408502 1 F12 Fuse- Outlet 300046446 1 F59 Fuse- Evaporator Heater Protection 300046455 1 FC Expansion Controller- Fans 193407601 1 FC2 Expansion Controller- Fans 193407601 1 FC3 Expansion Controller- Fans 193407601 1 K11 Relay- Emergency Stop 300046445 1 Q0 Switch- Unit Shut Off 300046456 1 Q1 Switch- Pumpdown Circuit #1 300046456 1 Q2 Switch- Pumpdown Circuit #2 300046456 1 Q3 Switch- Pumpdown Circuit #3 300046456 1 Q11 Switch- Emergency Stop 1 300046448 1 Q12 Circuit Breaker 300046447 1 REC1 Receptacle 330472601 1 UC Controller- MicroTech III 193407301 11 Mounted through the door.2 This control board must be programmed in order to function correctly. When ordering a replacement, provide the unit model and serial number so that unit specific software code can be loaded before shipment.


Control Panel Detail



Power Panel Detail

Q101-Q107

Q301-Q310

Q201-Q207

KM102-107

KM202-207

KM302-310

F1 orQ20

P10 orQ10

F2 orQ30

F3

M10

Sch. Sym. Part Description F1, 2, 3 Circuit Breaker- Compressor 1, 2, 3 Only on Single Point units: C12= PC, DC, DH P10 Power Block- Main Units with Power Block: C12= PC Q10 Switch- Main Disconnect Units with Disc Switch: C12= DC, DH, WN, WH Q20 Switch- Main Disconnect Only on Multi-Point units: C12= WN, WH Q30 Switch-Main Disconnect Only on Multi-Point units: C12= WN, WH

To insure proper replacement part number for any of the items above, contact Daikin Applied with the Con-trol Box Serial Number and Control Box Part number. See earlier Controls page for Label example.

See next page for other Power Panel component part numbers.



Power Panel Detail

Sch. Part Part Sym. Description Number Qty. AM1 Ammeter: 0-1500A 1 Code 14= A 300046459 1 F100, 200, 300 Circuit Breaker- Circuit #1 Fans 600V/100A 300043195 3 F112, 212, 312 Phase Voltage Monitor 300040118 3 F120 Fuse- Control Transformer 208/230V 300046446 1 F120 Fuse- Control Transformer 380V 300046449 1 F120 Fuse- Control Transformer 460V, 575V 300046450 1 F130, 230, 330 Fuse- PVM 300046454 3 GFR1, 2, 3 Relay- Ground Fault 330315101 3 GFR1 CT Ground Fault Current Sensor 349937410 1 K16, 26, 36 Relay- Fan Motor 300046445 3 KM102- 107 Contactor- Fans Circuit #1 300046444 1/fan KM202- 207 Contactor- Fans Circuit #2 300046444 1/fan KM302- 310 Contactor- Fans Circuit #3 300046444 1/fan LR1, 2, 3 Line Reactor 460V 300046411 3 M10 Control Box Exhaust Fan 300047148 1 Q101- 107 MSP- Fans Circuit #1 300046443 1/fan Q201- 207 MSP- Fans Circuit #2 300046443 1/fan Q301- 310 MSP- Fans Circuit #3 300046443 1/fan T1 Transformer- Control 208/230/460V:120V 300046451 1 T1 Transformer- Control 380V:120V 300046453 1 T1 Transformer- Control 575V:120V 300046452 1 T2 Transformer 24V 300046472 1 VFD1, 2, 3 Fan VFD 2 208/230V 300046457 3 VFD1, 2, 3 Fan VFD 2 380V, 460V 300046412 3 VFD1, 2, 3 Fan VFD 2 575V 300046259 3 VM1 Volt Meter: 0- 600V 1 Code 14= A 300046460 11 Mounted on the outside of the power panel door.2 Not shown - The Fan VFDs are located on the cross rail near the front of the Evaporator.


ControlsSolid State Starter Panel

Code 09= SS

KM1-1

T20-1

MP1

CC1

EEXV1

F0-1

MPR-1

KT-1

LJV-1

K2B-1

Sch. Part Part Qty per Sym. Description Number Panel CC1, 2, 3 Controller- Circuit 193407501 1 EEXV1, 2, 3 Controller- Expansion Valve 300046465 1 F0-1, 2, 3 MSP- Heater 300044140 1 K2B-1, 2, 3 Contactor- Turbo 349934724 1 KLJ-1, 2, 3 Relay- Liquid Injection 300046470 1 KM1-1, 2, 3 Contactor- Solid State see next page 1 KT-1, 2, 3 Relay- Turbo Solenoid 300046470 1 MP1, 2, 3 Motor Protector 330343902 1 MPR-1, 2, 3 Relay- Motor Protection 330278110 1 T20-1, 2, 3 Transformer- 120V to 24V 300046466 1

Circuit 1 shown


KM1-1,2 Contactor Assy 300048732 used on: AWS 375-400, Std Eff, circuit 1 .......AWS 375-400, Std Eff, circuit 2 ...... AWS 375 & 425, Std Eff, circuit 3 AWS 445-470, High Eff, circuit 1 .....AWS 445-470, High Eff, circuit 2 .... AWS 445 & 500, High Eff, circuit 3

Sch. Part Part Qty per Sym. Description Number panel KM1-1, 2, 3 Contactor - Solid State, complete assembly 300048732 1 includes:' 1 MX2 Low Voltage Motor Starter Card 300048820 1 2 Contactor Bypass, 75A, 50HP, 120V 300040148 3 3 Surge Suppressor 300043749 3 5 SCR, 660A, 1800V 300042134 6 6 Current Transformer 300042127 3 7 Snubber Assembly 300043777 1

Sch. Part Part Qty per Sym. Description Number panel KM1-1, 2, 3 Contactor - Solid State, complete assembly 300047990 1 includes:' 1 MX2 Low Voltage Motor Starter Card 300048820 1 2 Contactor Bypass, 85A, 60HP, 120V 300043218 3 3 Surge Suppressor 300043749 3 5 SCR, 660A, 1800V 300042134 6 6 Current Transformer 300042127 3 7 Snubber Assembly 300043777 1

ControlsSolid State Starter Panel

Code 09= SS

1

23

5 5 5

6

7MX2 Card

KM1-1,2 Contactor Assy 300047990 used on: AWS 425-530, Std Eff, circuit 1 .....AWS 425-530, Std Eff, circuit 2 .... AWS 400 & 445-530, Std Eff, circuit 3 AWS 500-530, High Eff, circuit 1 ...AWS 500-530, High Eff, circuit 2 .. AWS 470 & 530, High Eff, circuit 3


T20-1

MP1

CC1

EEXV1

FO-1

MPR-1

KT-1

LJV-1

K2B-1

Sch. Part Part Qty per Sym. Description Number Panel CC1, 2, 3 Controller- Circuit 193407501 1 EEXV1, 2, 3 Controller- Expansion Valve 300046465 1 F0-1, 2, 3 Heater- MSP 300044140 1 F5-1, 2, 3 Overload- Thermal See next page K2B-1, 2, 3 Contactor- Turbo Relay 349934724 1 KLJ-1, 2, 3 Relay- Liquid Injection 300046470 1 KM1-1, 2, 3 Contactor- Wye Delta See next page KM2-1, 2, 3 Contactor- Wye Delta See next page KM3-1, 2, 3 Contactor- Wye Delta See next page KT-1, 2, 3 Relay- Turbo Solenoid 3000464701 KT1-1, 2, 3 Time Delay- Starter 300046469 1 MP1, 2, 3 Motor Protector 330343902 1 MPR-1, 2, 3 Relay- Motor Protection 330278110 1 T20-1, 2, 3 Transformer- 120V to 24V 300046466 1

KT1-1

KM3-1 KM2-1 KM1-1

F5-1

ControlsWye-Delta Starter Panel

Code 09= WD

Circuit 1 shown


200A all 150A 300042135 105A 300042917 130A 300046493 241A all 180A 300040787 180A 300040787 150A 300046494 275A all 250A 300042136 180A 300040787 150A 300046494 317A all 250A 300042136 180A 300040787 200A 300046495 413A 208V 300A 300042137 300A 300042137 250A 300046496 413A 230V 300A 300042137 180A 300040787 250A 300046496 413A 380V w/o Economizer 300A 300042137 300A 300042137 250A 300046496 413A 380V w/ Economizer 300A 300042137 180A 300040787 250A 300046496 551A all 400A 300042138 300A 300042137 350A 300046497

Starter Compressor Contactors Thermal Max Unit KM1-1, 2, 3 Overload RLA Voltage KM2-1, 2, 3 KM3-1,2, 3 F5-1, 2, 3

Refer to the Starter Label to identify the Starter Max RLA.

ControlsWye-Delta Starter Panel

Code 09= WD

Starter Label example.


ControlsUnits with VFD Starters (Code 9 = VE or VF)

Box Locations and Label Detail

Control Panel Power Panel

For all control components not detailed or for unit specific controls (i.e. main disconnect, solid state contactors), please contact Daikin Applied with the Control Box Serial Number and Control Box Part Number. These numbers are located on the Control box rating label (see example below). This label is found inside the panel.

Control Box Serial Number“S” + Year + ##### + detail#

Control Box Part Number

Label Detail

Fan VFDlocation



Control Side


Sch. Part Part Sym. Description Number Qty. AC Expansion Controller- Alarms 193407501 1 AWM Advanced Web Module 193408502 1 CC1,2,3 Controller- Circuit 193407501 3 EEXV1,2,3 Extension I/O for Electr. Exp. Valve 193407901 3 F11 Fuse- Unit Controller, 10A Rejection Type 349937131 1 F12 Fuse- Outlet 349937131 1 F59 Fuse- Evaporator Heater Protection 349937116 1 F120 Fuse- Control Transformer, 12A Rejection Type (380V & 460V) 349937132 3 FC, FC2,3 Expansion Controller- Fans 193407601 3 GFR1,2,3 Relay- Ground Fault 193432101 * K11 Relay- Emergency Stop 349934765 1 K13 Relay- Mechanical High Pressure, Circuit 1 349934764 1 K16 Relay- Fan Motor, Circuit 1 349934764 1 K23 Relay- Mechanical High Pressure, Circuit 2 349934764 1 K26 Relay- Fan Motor, Circuit 2 349934764 1 K33 Relay- Mechanical High Pressure, Circuit 3 349934764 1 K36 Relay- Fan Motor, Circuit 3 349934764 1 KLJ-1,2,3 Relay- Liquid Injection 193439901 3 MP1,2,3 Motor Thermal Protection 193445901 3 MPR1,2,3 Relay- Motor Protector 349934762 3 Q0 Switch- Unit Shut Off 001355000 1 Q1,2,3 Switch- Pumpdown 001355000 1 Q11 Switch- Emergency Stop (Not shown -mounted through the door) 193441101 1 REC1 Receptacle- Ground Fault Interrupter 039003600 1 T2 Transformer- 100VA, 115V-24V 330386105 1 T20-1,2,3 Transformer- 50VA, 115V-24V 349937203 3 UC Controller- MicroTech III 193407301 1 VFD1,2,3 Fan VFD 1 193445601 31 Not shown - Fan VFDs are located on the left wall of the Control Side on units with VFD Starters.2 This control board must be programmed in order to function correctly. When ordering a replacement, provide the unit model and serial number so that unit specific software code can be loaded before shipment. *Qty = 1 on Std Short Circuit units (Code 12 = PC,DC,WN); Qty = 3 High Short Circuit units (Code 12 = DH, WH)

Code 14=A Unit Size Efficiency Voltage Description Part Number Qty AM1 all all all Ammeter- 0-1200A 1 193446002 1

VM1 all all all Voltmeter- 0-600V 1 193446701 11 Mounted on the outside of the control box door.


Control Side


Sch. Sym. Part Description Part Number Qty

NS F10 Exhaust Fan Fuse, 10A 049759816 1 NS F100 Circuit Breaker- Circuit #1 Fans Contact Daikin Applied NS F200 Circuit Breaker- Circuit #2 Fans Contact Daikin Applied NS F300 Circuit Breaker- Circuit #3 Fans Contact Daikin Applied

NS F130 Fuse- PVM 349937120 1

NS KM101- 110 Contactor- Fans Circuit #1 349932123 1/fan NS KM201- 210 Contactor- Fans Circuit #2 349932123 1/fan NS KM301- 310 Contactor- Fans Circuit #3 349932123 1/fan

NS LR1, 2, 3 Line Reactor 349964902 3

NS SS1 Switch- Voltmeter 193446601 1 NS SS2 Switch- Ammeter 193446101 1

Sch. Part Part Sym. Description Number Qty. Units without Fan VFDs (Code 27 = F) Q101-110 MSP- Fans Circuit #1 349934055 1/fan Q201- 210 MSP- Fans Circuit #2 349934055 1/fan Q301- 310 MSP- Fans Circuit #3 349934055 1/fan

Units with Fan VFDs (Code 27 = V) Q101 Manual Mtr Starter- Fans Circuit #1 193439703 1/fan Q201 Manual Mtr Starter- Fans Circuit #2 193439703 1/fan Q301 Manual Mtr Starter- Fans Circuit #3 193439703 1/fan Q102- 110 MSP- Fans, Low Short Circuit Circuit #1 349934055 1/fan Q202- 210 MSP- Fans, Low Short Circuit Circuit #2 349934055 1/fan Q302- 310 MSP- Fans, Low Short Circuit Circuit #3 349934055 1/fan

Units with Standard Short Circuit Current Rating (Code 12 = PC, DC, WN)

Units with High Short Circuit Current Rating (Code 12=DH,WH)


Control Side

NS = Not Shown

Sch. Part Part Sym. Description Number Qty. Q101-110 MSP- Fans *

NS JFU1,2,3 High Short Circuit Fuse, 30A, 600V 193403108 ** 1 NS JFU1,2,3 High Short Circuit Fuse, 60A, 600V 193403113 ** 1 NS JFU1,2,3 High Short Circuit Fuse, 100A, 600V 193403117 ** 1 * Contact Daikin Applied. ** Contact Daikin Applied to determine which High Short Ckt Fuse is used in a specific unit.NS = Not Shown



Power Side

Q10or

PB1

Q12


Sch. Part Part Sym. Description Number Qty. CT 4,5,6 Current Transformer, 1200:5A 193432207 3

F0-1,2,3 Manual Motor Protector MMP/MSP, PB (Code 12= PC, DC or WN) 349934026 3 F0-1,2,3 Manual Motor Protector MMP/MSP, Rotary (Code 12= DH or WH) 349934006 3

K1,2,3 Relay- Crankcase Heater (Code 12= PC, DC or WN) 193454201 3 K1,2,3 Relay- Crankcase Heater (Code 12= DH or WH) 193454301 3

Q12 Fuse- Control Transformer, 20A Non-rejection Type 349937036 1

T1 Transformer- Control, 2000VA, 380V-115V 349992908 1 T1 Transformer- Control, 2000VA, 460V-115V 038253958 1 T1 Transformers include the following: Finger Safe Cover for T1 349955901 Fuse Puller Kit for T1 349955801

Sch. Part Sym. Number Qty Units with Single Point Pwr Blk or Disconnect (Code 12 = PC, DC or DH) GCT1 Ground Fault Current Sensor 193432205 1

Units with Multi Point Disconnect (Code 12 = WN or WH) GCT1,2,3 Ground Fault Current Sensor 193432203 3


Power Side


Unit Voltage Circuit 1 Circuit 2 Circuit 3 Size VFD-1 VFD-2 VFD-3 445A 460V 193439003 193439003 193439003 445A 380V 193439004 193439004 193439004 470A 460V 193439003 193439003 193439004 500A 460V 193439004 193439004 193439003 530A 460V 193439004 193439004 193439004

Used with 193439003 Compressor VFD (362A) VFU1,2,3 Fuse- Semi-Conductor, 800A 193439603 Fuse Block- Semi-Conductor 193439501 EMI1,2,3 EMI Filter (Code 9 = VE) 193445702

Used with 193439004 Compressor VFD (414A) VFU1,2,3 Fuse- Semi-Conductor, 800A 193439603 Fuse Block- Semi-Conductor 193439501 EMI1,2,3 EMI Filter (Code 9 = VE) 193445702

VFD-1, VFD-2, VFD-3 Compressor VFD Starter


Power Side

VFU1,2,3 Fuse EMI1,2,3 EMI Filter

Note: EMI1,2,3 are not shown on diagram


Unit Efficiency Voltage Power Block Power Block Size Part Number Code 4 = H* 445-530 High 380V, 460V 1400A 193445001

PB1 - Single Point Power Block (Code 12 = PC)


Power Side

Unit Efficiency Voltage Disconnect Disconnect Handle Shaft Size Part Number Part Number Part Number Code 4 = H* 445-530 High 380V, 460V 1200A 193438202 349961206 349962238

Q10 - Main Disconnect (Code 12 = DC, DH, WN or WH)


F1, 2, 3 - Multi Point Main Disconnect with Standard Short Circuit Current Rating (Code 12 = WN)

Efficiency Voltage Code 12 Molded Case Part Circuit Breaker Number Code 4 = H* F1, 2, 3 High 380V, 460V WN 400A / 35KA 193454101

Handle for 400A Circuit Breaker 193437901

Shaft for 400A Circuit Breaker 349962236


Power Side

Unit Efficiency Voltage Code 12 Molded Case Part Size Circuit Breaker Number Code 4 = H* F1, 2, 3 High 380V, 460V WH 400A / 65KA 193454102

F1, 2, 3 - Multi Point Main Disconnect with High Short Circuit Current Rating (Code 12 = WH)

F1, 2, 3 - Compressor Circuit Breaker with Standard Short Circuit Current Rating (Code 12 = PC or DC)

Unit Efficiency Voltage Code 12 Molded Case Part Size Circuit Breaker Number Code 4 = H* F1, 2, 3 High 380V, 460V WN 400A / 30KA 193454001

Unit Efficiency Voltage Code 12 Molded Case Part Size Circuit Breaker Number Code 4 = H* F1, 2, 3 High 380V, 460V WH 400A / 65KA 193454102

F1, 2, 3 - Compressor Circuit Breaker with High Short Circuit Current Rating (Code 12 = DH)


Sch. Sym. Part Description Part Number Qty

M10 Control Box Exhaust Fan Unit sizes 445-500 193441002 1 M10 Control Box Exhaust Fan Unit sizes 530 193441003 1

M11 Control Box Intake Fan 193440803 1

M12 Control Box Exhaust Fan Unit sizes 445-500 193441002 1 M12 Control Box Exhaust Fan Unit size 530 193441003 1


Control Box Exhaust and Intake Fans

M12

M10

M11


ControlsTerminal Box

Ref. Part Part No. Description Number Qty. 50 Motor Terminal Plate 330875701 1 per compressor Motor Terminal Plate Gasket 300040078 1 per compressor Motor Terminal Bolt, M8 300040079 14 per compressor Bus Bar 300044004 3 per compressor Electrical Barrier 330719201 1 per compressor Terminal Box Mounting Screw, M6 330821902 4 per compressor

61

2

34

5

Ref. Part Part No. Description Number Qty. 50 Motor Terminal Plate 131073022 1 per compressor Motor Terminal Plate Gasket 300040078 1 per compressor P3 Terminal Plate Insulator 131083020 6 per compressor Motor Terminal Bolt, M10 (Starter side) 130306091 6 per compressor Lock Washer (Starter side) 130902028 6 per compressor P4 Mounting Bolt, M8 (Plate mounting) 300040079 14 per compressor P5 Terminal Box Screw, M6 330821902 4 per compressor

Type A Terminal Plate For more information, see Parts Bulletin PB-0512-01.

Type B Terminal Plate For more information, see Parts Bulletin PB-0512-01.

50

P3

P5

P450


AccessoriesUnits with Wye-Delta or Solid State Starter (Code 9 = WD or SS)

Isolator Kits - Rubber-In-Shear

Total # of Fans 22 24 26 28 30 Units with Aluminum Fin Condenser (Code 8 = A, B, E) Group # 7 8 8 9 9 Units with Copper Fin Condenser (Code 8 = C, F) Group # 10 11 11 11 11

Use the chart above to determine the Total # of Fans. Use the chart below to identify the corresponding Isolator Group #. Then, see the last chart for the Complete Kit and component part numbers.



Complete Group Kit 331481404 331481403 331481402 331481405 # Part # Charcoal Lime Brick Red Purple 7 332325809 2 4 2 8 332325810 2 4 2 2 9 332325811 4 2 2 2 10 332325812 2 4 11 332325815 2 2 2 4

RIS Isolator Part #s and Quantities



Complete Group Kit 332620800 332620600 332620400 332620900 332621000 026219800 # Part # Dark Green Dark Purple Gray Black White Housing CP4 21 332320810 8 24 8 22 332320811 16 8 8 8 10 23 332320812 16 16 8 10 24 332320813 8 8 16 8 10 27 332320816 16 16 8 28 332320817 8 8 8 16 10 29 332320818 16 8 16 10

AccessoriesUnits with Wye-Delta or Solid State Starter (Code 9 = WD or SS)

Isolator Kits - Spring



Total # of Fans 22 24 26 28 30 Units with Aluminum Fin Condenser (Code 8 = A, B, E) Group # 21 22 23 24 24 Units with Copper Fin Condenser (Code 8 = C, F) Group # 27 28 29 29 29

Spring Isolator Part #s and Quantities


AccessoriesUnits with VFD Starter (Code 9 = VF or VE)

Isolator Kits - Rubber-In-Shear

Complete RIS Isolator Part #s and Quantities Group Kit 331481403 331481404 # Part # Lime Charcoal 38 332325824 12 41 332325827 6 6 42 332325825 4 8


Std. High Unit Eff. Eff. Size Total Total Fans Fans 445 24 24 470 26 26 500 28 28 530 30 30


24 26 28 30 Units with Aluminum Fin Condenser (Code 8 = A, B, E) Group # 38 38 38 42 Units with Copper Fin Condenser (Code 8 = C, F) Group # 38 38 41 41

Total # of Fans


Complete Spring Isolator Part #s and Quantities Group Kit 332620800 332620600 332620900 026219800 # Part # Dark Green Dark Purple Gray Housing CP4 49 332320825 40 8 12 50 332320826 48 12 51 332320827 24 24 12

AccessoriesUnits with VFD Starter (Code 9 = VF or VE)

Isolator Kits - Spring


Std. High Unit Eff. Eff. Size Total Total Fans Fans 445 24 24 470 26 26 500 28 28 530 30 30


24 26 28 30 Units with Aluminum Fin Condenser (Code 8 = A, B, E) Group # 49 50 50 51 Units with Copper Fin Condenser (Code 8 = C, F) Group # 49 50 51 51

Total # of Fans


AccessoriesFlow Switch

Description Part No. Flow Switch- Paddle 017503300 Flow Switch Kit- Electronic 332688401 Flow Switch Only 331796201 Cable- Flow Switch 330571404

Sound Enclosure Kit Description Part No. Sound Enclosure Kit, 3 circuit (only available on units without VFD Starters) 332523853

Alarm Bell Description Part No. Alarm Bell Kit 332688502 Relay, SPDT, 30A, 120VAC 072937402 Alarm Bell 017809400 Transformer 330386102

Inlet Strainer Description Part No. Inlet Strainer, Stainless Steel, Field Kit (3-ckt units) 331758910


Accessories

High Ambient Exhaust Fan Kit Description Part No. High Ambient Exhaust Fan Kit for units without VFD Starters 333930401

Rapid Restore Description Part No. Rapid Restore Kit for units without VFD Starters 333930501 Rapid Restore Kit for units with VFD Starters 193503101

Field-Installed Fan VFD Kits

Description Part No. Field-Installed Fan VFD Kit for units without VFD Starters 460V / 60Hz 332688604 575V / 60Hz 332688606 Field-Installed Fan VFD Kit for units with VFD Starters 400V / 50Hz 193503007 460V / 60Hz 193503001


Base Grille Kits* - Units with Wye-Delta or SS Starter (Code 8 = WD, SS) Total # of Fans 22 24 26 28 30 332688126 332688128 332688130 332688132 332688134

Base Grille Kits* - Units with VFD Starter (Code 8 = VF, VE)

* Kit part numbers above include Grilles and hardware. For component details, see earlier pages concerning Coil and Base Frame Grilles and Louvers.

Total # of Fans 24 26 28 30 332688143 332688144 332688145 332688146

Coil Louver Kits**

Base & Coil Louver Kits**- Units with Wye-Delta or SS Starter (Code 8 = WD, SS)

Base & Coil Louver Kits** - Units with VFD Starter (Code 8 = VF, VE)

** Kit part numbers above include Louvers and hardware. For component details, see earlier pages concerning Coil and Base Frame Grilles and Louvers.

Standard Efficiency: Code 4 = S*, High Efficiency: Code 4 = H*

AccessoriesBase and Coil - Grille and Louver Kits


Total # of Fans 24 26 28 30 332688343 332688344 332688345 332688346

Total # of Fans 22 24 26 28 30 332688226 332688228 332688230 332688232 332688234

Total # of Fans 22 24 26 28 30 332688326 332688328 332688330 332688332 332688334


Ref. Description Part Qty. No. Number Remote Display Kit 350147416 1 950 Control- Remote Keypad 193408001 1

BACnet with IP/Ethernet

Ref. Description Part Qty. No. Number 827 MODBUS Installation Kit 350147413 1

MODBUS Communications Module

Ref. Description Part Qty. No. Number 920 LonMark Installation Kit 350147412 1

LonMark Communications Module

Accessories

Ref. Description Part Qty. No. Number 650 BACnet MS/TP Kit 350147414 1

BACnet MS/TP Communications Module

Remote Display Kit

Ref. Description Part Qty. No. Number 700 BACnet IP/Ethernet Kit 350147415 1

827

700

650

920

950

Documents

Pathfinder Air Cooled Chiller Screw Compressor Three Circuitlit.daikinapplied.com/bizlit/DocumentStorage/AirCooledChiller/... · Air Cooled Chiller Screw Compressor Three Circuit