Upload
others
View
1
Download
0
Embed Size (px)
Citation preview
^
ENCLOSURE B OTHER 2 2 ^
Solvents Recovery Service of New England 104(e) Information Request Form for Generators
1 Name of Respondent Costar Corporation (Morningstar) ^^=
2 Date Information Request Completed November 12 1992
For each transaction listed on Form 1 (attached) shy ^ identify by chemical naune the type of waste material that the ^ S Respondent sent for treatment or disposal to the Site or sent ^ s with a transporter for treatment or disposal to the Site If ^ the chemical name is not known please state the trade name and the name of the manufacturer Also identify the transporter of each waste volume and identify who made the decision to bring the waste to the Site mdash the transporter generator or broker Attach copies of all documents consulted examined or referred to in the preparation of answers to these questions
At the end of Form 1 and consistent with the format of Form 1 identify and provide complete information on any additional transactions which do not appear on Form 1 or transactions which are in some manner incorrectlv recorded on Form 1 Attach copies of all documents which provide information on these transactions
^ B raquo raquo ^
If you are not the generator of any of the wastes attributed to you in the listing of transactions on Form 1 (ie you sent waste materials to the Site for disposal or treatment that were generated by a person other than you) please complete steps a through d below
a) Provide the information requested for that transaction on Form 1
b) Highlight the transaction by placing an asterisk () to the left of the appropriate transaction date on Form 1 and
c) Provide the information requested on Form 2 (attached) d) Attach copies of all documents consulted examined or
referred in to the preparation of answers to these questions
Please identify all persons consulted in the preparation of the answers to these questions Indicate their relationship to the Respondent (eg current employee - environmental manager past employee - maintenance department etc) Attach extra pages if necessary
6 ( c o n t i n u e d )
Name Ddeg^ ^^^^
A d d r e s s 684 E 6th S t r e e t
South Boston MA 02127
P h o n e NO 617-268-0401
R e l a t i o n t o R e s p o n d e n t Former Employee shy Tooling Supervisor
Name Sam A u t i e l l o
A d d r e s s 14 Union S t Unit 1
Nat ick MA
Phone No 508-653-0841
R e l a t i o n t o R e s p o n d e n t Former Employee shy Molding Tech
-laquo Name Gregory Mathus
Address 49 Deer Grass Lane
Concord MA 01742
Phone No 617-868-6200
R e l a t i o n t o R e s p o n d e n t Employee shy v p Engineering
Name Bobby J Shrader
Address Co Costar Corporation
Alewive Rd Kennebunk ME
Phone No 207-985-3111
R e l a t i o n t o R e s p o n d e n t Employee shy Manufacturing Supervisor
Please identify the person(s) completing this questionnaire and identify the relationship to the Respondent Attach extra pages if necessary
Theodore Morse Name
Costar Corporation A d d r e s s
One Alewife Center Cambridge MA 02140
617-868-6200 Phone No
R e l a t i o n t o R e s p o n d e n t Employee - D i rec to r of F inanc ia l Services
Name bull degtrade OBrien
A d d r e s s Costar Corporation
One Alewife Center Cambridge MA 02140
P h o n e No 617-868-6200
R e l a t i o n t o R e s p o n d e n t Employee - D i rec to r of Manufacturing
Name
Address
Phone No
Relation to Respondent
FORM 1 Page 1
So lven t s Recovery Se rv i ce of New England Mornings tar
T r a n s a c t i o n Gal lon Waste Type (3) NameAddress NsuneDescription of Who Date (1) Volume (2) of T r a n s p o r t e r S e l e c t e d t h e S i t e (4)
Hydraulic Oil 061660 82500 Not Known Transpor te r
II II II II II II II
112662 66000 II II II II II II II
112662 88000
Through in t e rv iews with cur ren t amp former employees we have concluded t h a t the above shipments were a l l for the Hydraulic Oil used in our molding machines The t r a n s p o r t e r may have been loca ted in Waltham MA but we are not s u r e For your r e f e r e n c e I have a t t ached a copy of the m a t e r i a l s a fe ty da ta s h e e t
Notes (1) The transaction date refers to the date the waste was delivered to SRSNE This
date may differ from the date the waste left the generators facility (particularly if the transaction was brokered by another party) and therefore may not match exactly with your records EPA expects you to make your best efforts to correlate your records with EPAs documents This is to prevent double-counting of shipments in EPAs volumetric ranking
(2) All gallon volumes are waste-in transactions to SRSNE
(3) Please state waste type by chemical name If the chemical name is not known please state the trade name and the manufacturers name
(4) eg XYZ Chemical Company - generator ABC Waste Trucking - transporter EFG Waste Disposal Service - broker
( ]FORM 1 ADDITIONAL TRT^SACTIONS Page
Solvents Recovery Service of New England Morningstar
rransaotion Gallon Waste Type (3) NameAddress NameDescription of Who Date (1) Volume (2) of Transporter selected the Site (4)
NONE
( )
FORM 2
Solvents Recovery Service of New England Transactions Involving Waste Not Generated by Respondent
TransactionDate
NONE
Gallon Volvune
Npoundune and Address of Generator
bull~ [
Solvents Recovery ScTict of Ne Enqlind Transicticnil SccuMfltition Suiiiry
Sincrator
Pate i
Etrttritsr TrarMction h t f SiUon Vokie
loniient RiferenH(t)
Ibraittfstv
nnua
iuun7
CSN
HtM
8SIN
I1HI7Y shy SKSK Logbook - Crltier t 23raquo
t i n m - iksn lojtiooit - omir 13i)3i
llllin shy SRSNE Logbook bull Order I 3827
2U]H
A
A U iitigntd voluet art calculated fro naite-in iranMctiont to tht Solvtnti Rtcovtry Strvlei of Xtlaquo CngUnd facility Oecuttntatioii las provided by tht olaquoneri cl Soivtnct Recovery Service of Mew (ngUnd and the Connecticut Dtpartiint of LivlrwMAtal rotiction
bull bull V
I_ ISRP003 m i m i l J
n ^ r ^ - - shy
gjg=a^^r^^j^^gyen^^^ ^ gt^ 019073
77 COjIFDEIJllL
cty cr^4^ |V^
y z
A~y Z t - bull r - j bullgt
bullZ s y y^-zzpound ^ bull bull IS i r)i^jUry^ty lt^7a A bullbull t
t
y
3
i i j ^ gth W [ ^
1^
9 0
z w ^
^ 4 ^ lt 7 - ^ ^ ^ ^ r 7 ^ ^ ^ ^ ^ ^A-raquolaquoy ^Z^y-shyA
rshy
6Cgt 6 C4
^gtvlt---Mlt^ ^v^ 3 7o v
- j
^ ^ j - u r c v ^62-
bull - 9 - ^ ^ Z bull Z ^
Z bull7^ 7-ltfrCM j ^
tat raquo3
Ji SRP003 n[iJi TI
1
Ul T llbA Ky - i i
SSI 2 _ j ^ ^ c ^ ^ J ^ ai K
3^2^ fiyit^iyjC^y)^
iii 3^2
bull - ^ - ^ ^ K r y7j^ -^
11
Ill
3^^ 3 bullraquo
091 pound8
TlJ^ZLicn itAc^
su^rd(Sy^fyr 9yJLai
f^Z^y^ijLZT shy
- ^ a M ^ ^ ^A7iJ^
c7udzr^ ^Z
^ f
vL^r^
^ ) ^ ^
bull L SRP003 l l e W l J
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
6 ( c o n t i n u e d )
Name Ddeg^ ^^^^
A d d r e s s 684 E 6th S t r e e t
South Boston MA 02127
P h o n e NO 617-268-0401
R e l a t i o n t o R e s p o n d e n t Former Employee shy Tooling Supervisor
Name Sam A u t i e l l o
A d d r e s s 14 Union S t Unit 1
Nat ick MA
Phone No 508-653-0841
R e l a t i o n t o R e s p o n d e n t Former Employee shy Molding Tech
-laquo Name Gregory Mathus
Address 49 Deer Grass Lane
Concord MA 01742
Phone No 617-868-6200
R e l a t i o n t o R e s p o n d e n t Employee shy v p Engineering
Name Bobby J Shrader
Address Co Costar Corporation
Alewive Rd Kennebunk ME
Phone No 207-985-3111
R e l a t i o n t o R e s p o n d e n t Employee shy Manufacturing Supervisor
Please identify the person(s) completing this questionnaire and identify the relationship to the Respondent Attach extra pages if necessary
Theodore Morse Name
Costar Corporation A d d r e s s
One Alewife Center Cambridge MA 02140
617-868-6200 Phone No
R e l a t i o n t o R e s p o n d e n t Employee - D i rec to r of F inanc ia l Services
Name bull degtrade OBrien
A d d r e s s Costar Corporation
One Alewife Center Cambridge MA 02140
P h o n e No 617-868-6200
R e l a t i o n t o R e s p o n d e n t Employee - D i rec to r of Manufacturing
Name
Address
Phone No
Relation to Respondent
FORM 1 Page 1
So lven t s Recovery Se rv i ce of New England Mornings tar
T r a n s a c t i o n Gal lon Waste Type (3) NameAddress NsuneDescription of Who Date (1) Volume (2) of T r a n s p o r t e r S e l e c t e d t h e S i t e (4)
Hydraulic Oil 061660 82500 Not Known Transpor te r
II II II II II II II
112662 66000 II II II II II II II
112662 88000
Through in t e rv iews with cur ren t amp former employees we have concluded t h a t the above shipments were a l l for the Hydraulic Oil used in our molding machines The t r a n s p o r t e r may have been loca ted in Waltham MA but we are not s u r e For your r e f e r e n c e I have a t t ached a copy of the m a t e r i a l s a fe ty da ta s h e e t
Notes (1) The transaction date refers to the date the waste was delivered to SRSNE This
date may differ from the date the waste left the generators facility (particularly if the transaction was brokered by another party) and therefore may not match exactly with your records EPA expects you to make your best efforts to correlate your records with EPAs documents This is to prevent double-counting of shipments in EPAs volumetric ranking
(2) All gallon volumes are waste-in transactions to SRSNE
(3) Please state waste type by chemical name If the chemical name is not known please state the trade name and the manufacturers name
(4) eg XYZ Chemical Company - generator ABC Waste Trucking - transporter EFG Waste Disposal Service - broker
( ]FORM 1 ADDITIONAL TRT^SACTIONS Page
Solvents Recovery Service of New England Morningstar
rransaotion Gallon Waste Type (3) NameAddress NameDescription of Who Date (1) Volume (2) of Transporter selected the Site (4)
NONE
( )
FORM 2
Solvents Recovery Service of New England Transactions Involving Waste Not Generated by Respondent
TransactionDate
NONE
Gallon Volvune
Npoundune and Address of Generator
bull~ [
Solvents Recovery ScTict of Ne Enqlind Transicticnil SccuMfltition Suiiiry
Sincrator
Pate i
Etrttritsr TrarMction h t f SiUon Vokie
loniient RiferenH(t)
Ibraittfstv
nnua
iuun7
CSN
HtM
8SIN
I1HI7Y shy SKSK Logbook - Crltier t 23raquo
t i n m - iksn lojtiooit - omir 13i)3i
llllin shy SRSNE Logbook bull Order I 3827
2U]H
A
A U iitigntd voluet art calculated fro naite-in iranMctiont to tht Solvtnti Rtcovtry Strvlei of Xtlaquo CngUnd facility Oecuttntatioii las provided by tht olaquoneri cl Soivtnct Recovery Service of Mew (ngUnd and the Connecticut Dtpartiint of LivlrwMAtal rotiction
bull bull V
I_ ISRP003 m i m i l J
n ^ r ^ - - shy
gjg=a^^r^^j^^gyen^^^ ^ gt^ 019073
77 COjIFDEIJllL
cty cr^4^ |V^
y z
A~y Z t - bull r - j bullgt
bullZ s y y^-zzpound ^ bull bull IS i r)i^jUry^ty lt^7a A bullbull t
t
y
3
i i j ^ gth W [ ^
1^
9 0
z w ^
^ 4 ^ lt 7 - ^ ^ ^ ^ r 7 ^ ^ ^ ^ ^ ^A-raquolaquoy ^Z^y-shyA
rshy
6Cgt 6 C4
^gtvlt---Mlt^ ^v^ 3 7o v
- j
^ ^ j - u r c v ^62-
bull - 9 - ^ ^ Z bull Z ^
Z bull7^ 7-ltfrCM j ^
tat raquo3
Ji SRP003 n[iJi TI
1
Ul T llbA Ky - i i
SSI 2 _ j ^ ^ c ^ ^ J ^ ai K
3^2^ fiyit^iyjC^y)^
iii 3^2
bull - ^ - ^ ^ K r y7j^ -^
11
Ill
3^^ 3 bullraquo
091 pound8
TlJ^ZLicn itAc^
su^rd(Sy^fyr 9yJLai
f^Z^y^ijLZT shy
- ^ a M ^ ^ ^A7iJ^
c7udzr^ ^Z
^ f
vL^r^
^ ) ^ ^
bull L SRP003 l l e W l J
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
Please identify the person(s) completing this questionnaire and identify the relationship to the Respondent Attach extra pages if necessary
Theodore Morse Name
Costar Corporation A d d r e s s
One Alewife Center Cambridge MA 02140
617-868-6200 Phone No
R e l a t i o n t o R e s p o n d e n t Employee - D i rec to r of F inanc ia l Services
Name bull degtrade OBrien
A d d r e s s Costar Corporation
One Alewife Center Cambridge MA 02140
P h o n e No 617-868-6200
R e l a t i o n t o R e s p o n d e n t Employee - D i rec to r of Manufacturing
Name
Address
Phone No
Relation to Respondent
FORM 1 Page 1
So lven t s Recovery Se rv i ce of New England Mornings tar
T r a n s a c t i o n Gal lon Waste Type (3) NameAddress NsuneDescription of Who Date (1) Volume (2) of T r a n s p o r t e r S e l e c t e d t h e S i t e (4)
Hydraulic Oil 061660 82500 Not Known Transpor te r
II II II II II II II
112662 66000 II II II II II II II
112662 88000
Through in t e rv iews with cur ren t amp former employees we have concluded t h a t the above shipments were a l l for the Hydraulic Oil used in our molding machines The t r a n s p o r t e r may have been loca ted in Waltham MA but we are not s u r e For your r e f e r e n c e I have a t t ached a copy of the m a t e r i a l s a fe ty da ta s h e e t
Notes (1) The transaction date refers to the date the waste was delivered to SRSNE This
date may differ from the date the waste left the generators facility (particularly if the transaction was brokered by another party) and therefore may not match exactly with your records EPA expects you to make your best efforts to correlate your records with EPAs documents This is to prevent double-counting of shipments in EPAs volumetric ranking
(2) All gallon volumes are waste-in transactions to SRSNE
(3) Please state waste type by chemical name If the chemical name is not known please state the trade name and the manufacturers name
(4) eg XYZ Chemical Company - generator ABC Waste Trucking - transporter EFG Waste Disposal Service - broker
( ]FORM 1 ADDITIONAL TRT^SACTIONS Page
Solvents Recovery Service of New England Morningstar
rransaotion Gallon Waste Type (3) NameAddress NameDescription of Who Date (1) Volume (2) of Transporter selected the Site (4)
NONE
( )
FORM 2
Solvents Recovery Service of New England Transactions Involving Waste Not Generated by Respondent
TransactionDate
NONE
Gallon Volvune
Npoundune and Address of Generator
bull~ [
Solvents Recovery ScTict of Ne Enqlind Transicticnil SccuMfltition Suiiiry
Sincrator
Pate i
Etrttritsr TrarMction h t f SiUon Vokie
loniient RiferenH(t)
Ibraittfstv
nnua
iuun7
CSN
HtM
8SIN
I1HI7Y shy SKSK Logbook - Crltier t 23raquo
t i n m - iksn lojtiooit - omir 13i)3i
llllin shy SRSNE Logbook bull Order I 3827
2U]H
A
A U iitigntd voluet art calculated fro naite-in iranMctiont to tht Solvtnti Rtcovtry Strvlei of Xtlaquo CngUnd facility Oecuttntatioii las provided by tht olaquoneri cl Soivtnct Recovery Service of Mew (ngUnd and the Connecticut Dtpartiint of LivlrwMAtal rotiction
bull bull V
I_ ISRP003 m i m i l J
n ^ r ^ - - shy
gjg=a^^r^^j^^gyen^^^ ^ gt^ 019073
77 COjIFDEIJllL
cty cr^4^ |V^
y z
A~y Z t - bull r - j bullgt
bullZ s y y^-zzpound ^ bull bull IS i r)i^jUry^ty lt^7a A bullbull t
t
y
3
i i j ^ gth W [ ^
1^
9 0
z w ^
^ 4 ^ lt 7 - ^ ^ ^ ^ r 7 ^ ^ ^ ^ ^ ^A-raquolaquoy ^Z^y-shyA
rshy
6Cgt 6 C4
^gtvlt---Mlt^ ^v^ 3 7o v
- j
^ ^ j - u r c v ^62-
bull - 9 - ^ ^ Z bull Z ^
Z bull7^ 7-ltfrCM j ^
tat raquo3
Ji SRP003 n[iJi TI
1
Ul T llbA Ky - i i
SSI 2 _ j ^ ^ c ^ ^ J ^ ai K
3^2^ fiyit^iyjC^y)^
iii 3^2
bull - ^ - ^ ^ K r y7j^ -^
11
Ill
3^^ 3 bullraquo
091 pound8
TlJ^ZLicn itAc^
su^rd(Sy^fyr 9yJLai
f^Z^y^ijLZT shy
- ^ a M ^ ^ ^A7iJ^
c7udzr^ ^Z
^ f
vL^r^
^ ) ^ ^
bull L SRP003 l l e W l J
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
FORM 1 Page 1
So lven t s Recovery Se rv i ce of New England Mornings tar
T r a n s a c t i o n Gal lon Waste Type (3) NameAddress NsuneDescription of Who Date (1) Volume (2) of T r a n s p o r t e r S e l e c t e d t h e S i t e (4)
Hydraulic Oil 061660 82500 Not Known Transpor te r
II II II II II II II
112662 66000 II II II II II II II
112662 88000
Through in t e rv iews with cur ren t amp former employees we have concluded t h a t the above shipments were a l l for the Hydraulic Oil used in our molding machines The t r a n s p o r t e r may have been loca ted in Waltham MA but we are not s u r e For your r e f e r e n c e I have a t t ached a copy of the m a t e r i a l s a fe ty da ta s h e e t
Notes (1) The transaction date refers to the date the waste was delivered to SRSNE This
date may differ from the date the waste left the generators facility (particularly if the transaction was brokered by another party) and therefore may not match exactly with your records EPA expects you to make your best efforts to correlate your records with EPAs documents This is to prevent double-counting of shipments in EPAs volumetric ranking
(2) All gallon volumes are waste-in transactions to SRSNE
(3) Please state waste type by chemical name If the chemical name is not known please state the trade name and the manufacturers name
(4) eg XYZ Chemical Company - generator ABC Waste Trucking - transporter EFG Waste Disposal Service - broker
( ]FORM 1 ADDITIONAL TRT^SACTIONS Page
Solvents Recovery Service of New England Morningstar
rransaotion Gallon Waste Type (3) NameAddress NameDescription of Who Date (1) Volume (2) of Transporter selected the Site (4)
NONE
( )
FORM 2
Solvents Recovery Service of New England Transactions Involving Waste Not Generated by Respondent
TransactionDate
NONE
Gallon Volvune
Npoundune and Address of Generator
bull~ [
Solvents Recovery ScTict of Ne Enqlind Transicticnil SccuMfltition Suiiiry
Sincrator
Pate i
Etrttritsr TrarMction h t f SiUon Vokie
loniient RiferenH(t)
Ibraittfstv
nnua
iuun7
CSN
HtM
8SIN
I1HI7Y shy SKSK Logbook - Crltier t 23raquo
t i n m - iksn lojtiooit - omir 13i)3i
llllin shy SRSNE Logbook bull Order I 3827
2U]H
A
A U iitigntd voluet art calculated fro naite-in iranMctiont to tht Solvtnti Rtcovtry Strvlei of Xtlaquo CngUnd facility Oecuttntatioii las provided by tht olaquoneri cl Soivtnct Recovery Service of Mew (ngUnd and the Connecticut Dtpartiint of LivlrwMAtal rotiction
bull bull V
I_ ISRP003 m i m i l J
n ^ r ^ - - shy
gjg=a^^r^^j^^gyen^^^ ^ gt^ 019073
77 COjIFDEIJllL
cty cr^4^ |V^
y z
A~y Z t - bull r - j bullgt
bullZ s y y^-zzpound ^ bull bull IS i r)i^jUry^ty lt^7a A bullbull t
t
y
3
i i j ^ gth W [ ^
1^
9 0
z w ^
^ 4 ^ lt 7 - ^ ^ ^ ^ r 7 ^ ^ ^ ^ ^ ^A-raquolaquoy ^Z^y-shyA
rshy
6Cgt 6 C4
^gtvlt---Mlt^ ^v^ 3 7o v
- j
^ ^ j - u r c v ^62-
bull - 9 - ^ ^ Z bull Z ^
Z bull7^ 7-ltfrCM j ^
tat raquo3
Ji SRP003 n[iJi TI
1
Ul T llbA Ky - i i
SSI 2 _ j ^ ^ c ^ ^ J ^ ai K
3^2^ fiyit^iyjC^y)^
iii 3^2
bull - ^ - ^ ^ K r y7j^ -^
11
Ill
3^^ 3 bullraquo
091 pound8
TlJ^ZLicn itAc^
su^rd(Sy^fyr 9yJLai
f^Z^y^ijLZT shy
- ^ a M ^ ^ ^A7iJ^
c7udzr^ ^Z
^ f
vL^r^
^ ) ^ ^
bull L SRP003 l l e W l J
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
( ]FORM 1 ADDITIONAL TRT^SACTIONS Page
Solvents Recovery Service of New England Morningstar
rransaotion Gallon Waste Type (3) NameAddress NameDescription of Who Date (1) Volume (2) of Transporter selected the Site (4)
NONE
( )
FORM 2
Solvents Recovery Service of New England Transactions Involving Waste Not Generated by Respondent
TransactionDate
NONE
Gallon Volvune
Npoundune and Address of Generator
bull~ [
Solvents Recovery ScTict of Ne Enqlind Transicticnil SccuMfltition Suiiiry
Sincrator
Pate i
Etrttritsr TrarMction h t f SiUon Vokie
loniient RiferenH(t)
Ibraittfstv
nnua
iuun7
CSN
HtM
8SIN
I1HI7Y shy SKSK Logbook - Crltier t 23raquo
t i n m - iksn lojtiooit - omir 13i)3i
llllin shy SRSNE Logbook bull Order I 3827
2U]H
A
A U iitigntd voluet art calculated fro naite-in iranMctiont to tht Solvtnti Rtcovtry Strvlei of Xtlaquo CngUnd facility Oecuttntatioii las provided by tht olaquoneri cl Soivtnct Recovery Service of Mew (ngUnd and the Connecticut Dtpartiint of LivlrwMAtal rotiction
bull bull V
I_ ISRP003 m i m i l J
n ^ r ^ - - shy
gjg=a^^r^^j^^gyen^^^ ^ gt^ 019073
77 COjIFDEIJllL
cty cr^4^ |V^
y z
A~y Z t - bull r - j bullgt
bullZ s y y^-zzpound ^ bull bull IS i r)i^jUry^ty lt^7a A bullbull t
t
y
3
i i j ^ gth W [ ^
1^
9 0
z w ^
^ 4 ^ lt 7 - ^ ^ ^ ^ r 7 ^ ^ ^ ^ ^ ^A-raquolaquoy ^Z^y-shyA
rshy
6Cgt 6 C4
^gtvlt---Mlt^ ^v^ 3 7o v
- j
^ ^ j - u r c v ^62-
bull - 9 - ^ ^ Z bull Z ^
Z bull7^ 7-ltfrCM j ^
tat raquo3
Ji SRP003 n[iJi TI
1
Ul T llbA Ky - i i
SSI 2 _ j ^ ^ c ^ ^ J ^ ai K
3^2^ fiyit^iyjC^y)^
iii 3^2
bull - ^ - ^ ^ K r y7j^ -^
11
Ill
3^^ 3 bullraquo
091 pound8
TlJ^ZLicn itAc^
su^rd(Sy^fyr 9yJLai
f^Z^y^ijLZT shy
- ^ a M ^ ^ ^A7iJ^
c7udzr^ ^Z
^ f
vL^r^
^ ) ^ ^
bull L SRP003 l l e W l J
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
( )
FORM 2
Solvents Recovery Service of New England Transactions Involving Waste Not Generated by Respondent
TransactionDate
NONE
Gallon Volvune
Npoundune and Address of Generator
bull~ [
Solvents Recovery ScTict of Ne Enqlind Transicticnil SccuMfltition Suiiiry
Sincrator
Pate i
Etrttritsr TrarMction h t f SiUon Vokie
loniient RiferenH(t)
Ibraittfstv
nnua
iuun7
CSN
HtM
8SIN
I1HI7Y shy SKSK Logbook - Crltier t 23raquo
t i n m - iksn lojtiooit - omir 13i)3i
llllin shy SRSNE Logbook bull Order I 3827
2U]H
A
A U iitigntd voluet art calculated fro naite-in iranMctiont to tht Solvtnti Rtcovtry Strvlei of Xtlaquo CngUnd facility Oecuttntatioii las provided by tht olaquoneri cl Soivtnct Recovery Service of Mew (ngUnd and the Connecticut Dtpartiint of LivlrwMAtal rotiction
bull bull V
I_ ISRP003 m i m i l J
n ^ r ^ - - shy
gjg=a^^r^^j^^gyen^^^ ^ gt^ 019073
77 COjIFDEIJllL
cty cr^4^ |V^
y z
A~y Z t - bull r - j bullgt
bullZ s y y^-zzpound ^ bull bull IS i r)i^jUry^ty lt^7a A bullbull t
t
y
3
i i j ^ gth W [ ^
1^
9 0
z w ^
^ 4 ^ lt 7 - ^ ^ ^ ^ r 7 ^ ^ ^ ^ ^ ^A-raquolaquoy ^Z^y-shyA
rshy
6Cgt 6 C4
^gtvlt---Mlt^ ^v^ 3 7o v
- j
^ ^ j - u r c v ^62-
bull - 9 - ^ ^ Z bull Z ^
Z bull7^ 7-ltfrCM j ^
tat raquo3
Ji SRP003 n[iJi TI
1
Ul T llbA Ky - i i
SSI 2 _ j ^ ^ c ^ ^ J ^ ai K
3^2^ fiyit^iyjC^y)^
iii 3^2
bull - ^ - ^ ^ K r y7j^ -^
11
Ill
3^^ 3 bullraquo
091 pound8
TlJ^ZLicn itAc^
su^rd(Sy^fyr 9yJLai
f^Z^y^ijLZT shy
- ^ a M ^ ^ ^A7iJ^
c7udzr^ ^Z
^ f
vL^r^
^ ) ^ ^
bull L SRP003 l l e W l J
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
bull~ [
Solvents Recovery ScTict of Ne Enqlind Transicticnil SccuMfltition Suiiiry
Sincrator
Pate i
Etrttritsr TrarMction h t f SiUon Vokie
loniient RiferenH(t)
Ibraittfstv
nnua
iuun7
CSN
HtM
8SIN
I1HI7Y shy SKSK Logbook - Crltier t 23raquo
t i n m - iksn lojtiooit - omir 13i)3i
llllin shy SRSNE Logbook bull Order I 3827
2U]H
A
A U iitigntd voluet art calculated fro naite-in iranMctiont to tht Solvtnti Rtcovtry Strvlei of Xtlaquo CngUnd facility Oecuttntatioii las provided by tht olaquoneri cl Soivtnct Recovery Service of Mew (ngUnd and the Connecticut Dtpartiint of LivlrwMAtal rotiction
bull bull V
I_ ISRP003 m i m i l J
n ^ r ^ - - shy
gjg=a^^r^^j^^gyen^^^ ^ gt^ 019073
77 COjIFDEIJllL
cty cr^4^ |V^
y z
A~y Z t - bull r - j bullgt
bullZ s y y^-zzpound ^ bull bull IS i r)i^jUry^ty lt^7a A bullbull t
t
y
3
i i j ^ gth W [ ^
1^
9 0
z w ^
^ 4 ^ lt 7 - ^ ^ ^ ^ r 7 ^ ^ ^ ^ ^ ^A-raquolaquoy ^Z^y-shyA
rshy
6Cgt 6 C4
^gtvlt---Mlt^ ^v^ 3 7o v
- j
^ ^ j - u r c v ^62-
bull - 9 - ^ ^ Z bull Z ^
Z bull7^ 7-ltfrCM j ^
tat raquo3
Ji SRP003 n[iJi TI
1
Ul T llbA Ky - i i
SSI 2 _ j ^ ^ c ^ ^ J ^ ai K
3^2^ fiyit^iyjC^y)^
iii 3^2
bull - ^ - ^ ^ K r y7j^ -^
11
Ill
3^^ 3 bullraquo
091 pound8
TlJ^ZLicn itAc^
su^rd(Sy^fyr 9yJLai
f^Z^y^ijLZT shy
- ^ a M ^ ^ ^A7iJ^
c7udzr^ ^Z
^ f
vL^r^
^ ) ^ ^
bull L SRP003 l l e W l J
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
n ^ r ^ - - shy
gjg=a^^r^^j^^gyen^^^ ^ gt^ 019073
77 COjIFDEIJllL
cty cr^4^ |V^
y z
A~y Z t - bull r - j bullgt
bullZ s y y^-zzpound ^ bull bull IS i r)i^jUry^ty lt^7a A bullbull t
t
y
3
i i j ^ gth W [ ^
1^
9 0
z w ^
^ 4 ^ lt 7 - ^ ^ ^ ^ r 7 ^ ^ ^ ^ ^ ^A-raquolaquoy ^Z^y-shyA
rshy
6Cgt 6 C4
^gtvlt---Mlt^ ^v^ 3 7o v
- j
^ ^ j - u r c v ^62-
bull - 9 - ^ ^ Z bull Z ^
Z bull7^ 7-ltfrCM j ^
tat raquo3
Ji SRP003 n[iJi TI
1
Ul T llbA Ky - i i
SSI 2 _ j ^ ^ c ^ ^ J ^ ai K
3^2^ fiyit^iyjC^y)^
iii 3^2
bull - ^ - ^ ^ K r y7j^ -^
11
Ill
3^^ 3 bullraquo
091 pound8
TlJ^ZLicn itAc^
su^rd(Sy^fyr 9yJLai
f^Z^y^ijLZT shy
- ^ a M ^ ^ ^A7iJ^
c7udzr^ ^Z
^ f
vL^r^
^ ) ^ ^
bull L SRP003 l l e W l J
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
1
Ul T llbA Ky - i i
SSI 2 _ j ^ ^ c ^ ^ J ^ ai K
3^2^ fiyit^iyjC^y)^
iii 3^2
bull - ^ - ^ ^ K r y7j^ -^
11
Ill
3^^ 3 bullraquo
091 pound8
TlJ^ZLicn itAc^
su^rd(Sy^fyr 9yJLai
f^Z^y^ijLZT shy
- ^ a M ^ ^ ^A7iJ^
c7udzr^ ^Z
^ f
vL^r^
^ ) ^ ^
bull L SRP003 l l e W l J
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
c 0 i t abull c O r p TO CObTtHR-CAMB P 07
Date Issued 120590 PRODUCT CODE OlSSS Supercedes 062169
r PRODUCT NAME RANDO OIL MD 4
16 PRODUCT LABEL
READ ANO UNDERSTAND MATERIAL SAFETY DATA SHEET BEFORE HANDLING OR DISPOSING OF PRODUCT
Oleuro58 RANOO OIL KD -16
WARNING STATEMENT bullNONE CONSIDERED NECESSARY
PRECAUTIONARY fUEASURES AVOID PROLONGED BREATHING OF MIST OR VAPOR WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY WITH SOAP AND WATER
FIRST AID INBESTIOM
I f more than $Qverampl mou^hfuis have been swellowetf give two glasses of water (1euro 02) Graquot medical ettention
INHALATION If irritation headache nausea or drowsiness occurs remove to fresh air Set ntadica) attention if breathing beconies difficult or symptoms persist
EYE CONTACT Flush eyes with plenty of water for several minytes Get medical attention If laquoyeuro irritation persists
SKIN CONTACT Wash sKin with plenty of soap and water for several minutes Get medical attention if skin irritation develops or persists
NOTE TO DOCTOR NOTE TO PHYSICIAN High pressure Injection of material Into skin If not jsroperly treatea can cause severe injury Most damage occurs duririg first few hours Failure to oebrlde tne wound of all residual material can result In disfigurement loss of function or even require amputation of the affected area The extent of the injury cannot be determined by examining the wound X-rey may reveal the presence of gas In tendon sheaths or soft
bull j f t t - ^ tissue FIRE
In case of fire use foam dry chemical or CC2 Use water spray to keep containers cool
Chemjjsa 1 common_Name CAS No Range in Solvent-oewaxed heavy pareffinic petroleum $4742650 S500 - 9999 disti1lates I Product is non-hazardous according to OSHA (19101200) Not classified as a hasaroouS material by DOT definition
HMIS National Fire Protection Association Health O Reactivity Health 0 Reactivity 0 Flammability 1 Special Flammability 1 Special shy
CAUTION Misuse Of empty containers can be hazardous Empty containers can be hazardous if used to store toxic flammable or reactive materials Cutting or welding of empty containers might cause fire ejltplos1on or toxic fumes from residues Do not pressurise or expose to open flame or heat Keep container closed ond drum bungs in place
Manufacturers Name Texaco Lubricants Co Div of TRMI PO Sox S23S2 Houston TX 77052
TRANSPORTATION EMERGENCY Company (914) e31laquo3400 CHEMTREC (eOO) 424-9300
HEALTH EMERGENCY Company (914) 831-3400
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
NOU-09-199i 14=50 FROM costarcorp TO COSTflR-CAMB P 06
PRODUCT CODE C1658 ~ Date Issued 120590 PRODUCT NAME RANOO OIL HO 46 Supercedes 055189
r U REGULATORY INFORMATION
A SARA TITLE 111 T U I e 111 Sftction 302304 Extremely^Ha^ardous Substance
Component CAS No Percent RO Mbs) TPO (lbs) NONE
CERCLA Section 102(a) Hazardous Substance CompLOn^nt CAS No Percent RQ (Ibs) NONE
T m e 111 Section Sli Hazard Categorization Acute Chrome Fire Pressure Reactive Not Applicable
gt lt - bdquo - ^ ^
Title 111 section 313 Toxic Chemicals ^Component CAS No Percent NONE bull
B VHMIS CLASSIFICATION Not Regulated
C MICHIGAN CRITICAL MATERIALS 0C29y Zinc
15 OTHER INFORMATION bullpound
None
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE IT IS PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT FOR PURPOSE OF HAZARD COMMUNICATION AS PART OF TEXACOS PRODUCT SAFETY PROGRAM IT IS NOT INTENDED TO CONSTITUTE PERFORMANCE INFORMATION CONCERNING THE PRODUCT o NO EXPRESS WARRANTY OR IMPLIED WARSANTY OF MERCHANTABILTIY OR FITNESS FOR A PARTICULAR PURPOSE IS MADE WITH RESPECT TO THE PRODUCT OR THE INFORMATION CONTAINED HEREIN DATA SHEETS ARE AVAILABLE FOR ALL TEXACO PRODUCTS YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL TEXACO PRODUCTS YOU BUY PROCESS USE OR DISTRISUTE AND YOU ARE ENCOURAGED AND REQUESTED TOADVISE THOSE WHO MAY COME li i CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN
TO DETERMINE APPLICABILITY OR EFFECT OF ANY LAV OR REGULATION WITH RESPECTTO THE PRODUCT USER SHOULD CONSULT HIS LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENT AOENCY TEXACO DOES NOT UNDERTAKE TO FURNISK ADVICE ON SUCH MATTERS
Oate l2-OSr9Q New X Revised Supersedes 06-21-89 Date Printed 01-05-91
Inquiries regarding MSDS should be directed to Texaco Inc
Manager Product Safety PO Box 509
Beacon NY 12508
PLEASE SEE NEXT PAGE FOR PRODUCT LABEL
n Page 5
NO shy Not Determined NA shy Not Applicable NT shy Not Tested lt - Less Than gt - Greater Then
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
V
I I O - U I i-4U hKUIl c o s t s r corp TO COSTPlR-CfltIB P as
Date Issued 120590 PRODUCT CODE Oleuro58 Supercedes 052169
PRODUCT NAME RANOO OIL HO 46
9 PHYSICAL AND CHEMICAL PROPERTIES (CONT) 1 ^
pH of undiluted product NA Solubility in Water NO Vapor Pressure ND mmhg Viscosity 4425 CSt O 40C Other
10 STABILITY AND REACTIVITY
This Material Reacts Violently With (If others is checked below see comments for details) Air Water Heat Strong Oxidizers Others None of These _ ^ _ Y _
Comments None
Products Evolved When Subjected to Heat or Combustion Toxic levels of carbon monoxide carbon dioxide irritating aldehydes and Ketones
OCCUR DO NOT OCCUR Hazardous Polymerizations _ X
11 TCXICOLOQICAL INFORMATION
TOXICOLOGICAL INFORMATION(ANIMAL TOXICITY DATA) Median Lethal Dose (LDSO LC50) (Species)
Oral Similar product gt224 gkg (rat) oracticelly nontoxic inhalation NO Dermal Similar product gt30 gkg (rabbit) practically nontoxic
Irritation Index Estimation of Irritation (Species) Skin Similar product 07980 (rabbit) slightly irritating Eyes Similar product 80110 (rabbit) nc appreciable effect Sensitizations NO-
Other None
12 DISPOSAL CONSIDERATIONS
~ ~ bull bull
WASTE DISPOSAL METHODS This product has been evaluated for RCRA characteristics anc does not meet the criteria of a hasardous waste if discarded in its purchased form Under RCRA it 1s the responsibility of the user of the product to detershymine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because precJuct uses transformations mixtures processes etc may render the resulting materials hazaraous
REMARKS None
15 TRANSPORT INFORMATION
TRANSPORTATION NO
DOT PROPER SHIPPING NAME NO
IMDG PROPER SHIPPING NAME Nb
lATA PROPER SHIPPING NAME ND
TOO PROPER SHIPPING NAME
r 3 Pago 4 ND - Not Determined NA - Not Applicable Not Tested
gt - Greater Than lt - Less Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
N
-lt1raquoBN
PRODUCT CODE O1SS8 Date Issued 120690 PRODUCT NAME RANDO OIL HD 46 Supercedes 062189
S FIRE-FIGHTING MEASURES
Ignition Temp Degrees F _Np Flash Point Degrees F (Method) 400 F (coc) Flammable Limits () Lower _ND Upper ND
Recommended Fire Extinguishing Agents And Special Procedures According to NFPA Guide use water spray drychemical foam or carbon dioxide Water or foam may cause frothing Use water to cool fire-exposed containers If a leak or spill has not ignited use water spray to bull disperse the vapors end to provide protection for persons attempting to stop the leak
unusual or Explosive Hazards None
6 ACCIDENTAL RELEASE MEASURES (Transportation Spills Call CHEMTREC (BOO) 424-9300)
Procedures In Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Use self-contained breathing apparatus or supplied air for large spills or confined areas Contain spni If possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing
7 HANDLING AND STORAGE
Precautions to be Taken in Handling end Storage MinimuTi feasible handling temperatures should be maintained Periods of exposure to high temperatures should be minimized Water contamination should be avoided
8 EXPOSURE CONTROLSPERSONAL PROTECTION
Protective Equipment IType) EyeFace Protection
Chemical-type goggles or face shield recommended to prevent eye contact
Skin Protection workers Should wash exposed skin several times daily with soap and water Soiled work clothing should be laundered or dry-cleaned et least once a week
Respiratory Protection Airborne concentrations should be kept to lowest levels possible if vapor mist or dust Is generated use respirator approved by M$HA or NIOSH as epprobrlate Supplied air respiratory protection should oe used for cleaning large spills or upon entry into tanks vessels or other confined spaces see beiow for applicable permissible concentrations
Ventilation Adequate to meet component occupational exposure limits (see Section 2)
Exposure Limit or Total Product None established for this product refer to Section 2 for component permissible ooncentrotion
S PHYSICAL MD CHSMICAL PROPERTIES
Appearance and Odor pale liquid Boiling Point (Degrees F NO Percent VOC 100 Specific Gravity 0S73S (H20=1) Vapor Density ND A l r ^ i
Z^
Page 3 ND - Not D e t e r m i n e d NA - Not Applicable NT Not Tested lt - Less Than gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than
^ bull X S i
r Date Issued 120590 Superceoes 062 189
TEXACO MATERIAL SAFETY DATA SHEET
NOTE Read and understand Material Safety Oate Sheet before handling or disposing of product
1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MATERIAL IDENTITY Product Code end Name 016S8 RANDO OIL HD 46
Chemical Name endor Family or Description Mydraulic OiIs
Manufacturers Neme and Address Texaco Lubricants Co Div of TRMI PO Box 52332 Houston TX 77052
Telephone Numbers TRANSPORTATION EMERGENCY Company (914) 831-3400 CHEMTREC (800) 424-9300 HEJALTM EMERGENCY Company (914) 831-3400 GENERAL M^pSASSISTANCE (914) 838-7204 TECHNICAL INFORMATION Fuels (914) 838-7336 LubricantsAntifreezes (914) 838-7509
Chemicals (512) 459-6S43
2 COMPOSITIONIMFORMATJON ON INGREDIENTS
bull OSHA TARC NTP OTHER NONE Product anaor Coraponent(s) Carcinogenic According to _ _ _ _ X
Composition Ccbull ^bdquo^ ChemicalCommon Name CAS No Exposure Limit Range in laquo ( ^ SOI vent-dewaxedheavy pareffinic petroleum 64742650 5mgm3 OSHA (MIST) 9500 - 9999
distillates 5mgm3 ACGlH (MIST) 10mgta3 STEL (MIST)
Product is non-hazardous according to OSHA (19101200)
3 HAZARD IDENTIFICATION
EMERGENCY OVERVIEW
Appearance and Odor pale liquid
WARNING STATEMENT
NONE CONSIDERED NECESSARY
HMIS NFPA Health O Reactivity o Health 0 Reactivity Flammability 1 Special - Flammability 1 Special
POTENTIAL HEALTH EFFECTS EYE SKIN INHALATION INGESTION
Primary Route of Exposure X X X Effects of Overexposure ^ ~ ~
Acute Eyes May cause minimal irritation experienced as temporary discomfort
Skin No adverse effects expected from absorption of material through the skin
n Brief contect is not irritating Prolonged contact es with clothing wetted with material may cause defatting of Skin or irritation seen as local redness with possible mild discomfort
Page 1 ND - Not Determined NA - Not Applicable NT - Not Testeo lt - Less Then gt - Greater Than