Kore EX3 IP65 4” Monopoint Direct Mount Module

Downlight & GemsRemote Power Supply, 0-10V Dimming

teganlighting.com • info@teganlighting.com • (415) 504-3536 • TG500 7-8-20 1 LIGHTING

Exton Monopoint - SPA - Steam RoomCATALOG NUMBER LOGIC

EX3 – K – 4MP – SPA – DL – 25 – EX3-SOL – BLK

Exton 3-Watt Model

Finish: Black

SPA4" Monopoint Mounting

Kore LED Module2700K

NEW

25°Beam

ø 4 -5/16”(110mm)

2 -15/16”(74mm)

ø 1 -5/8”(41mm)

Kore EX3 4” Direct Mount SPA Steam Room Monopoint Downlight, Aluminum or Black Finish. Catalog Numbers For use with Remote Power Supply(s) - See page 3 for details, ordered separately.EX3-K-4MP-SPA-DL-XX1-AL or BLK

1 Replace “XX” with 15, 25 or 35 for choice of degree beam spread.

Exton Kore EX3 LED 4” SPA Sauna Monopoint with Downlight

Exton - Kore EX3 LED Downlight - Accessories

Downlight

ø 1.3” (33.5mm) ø 1.3” (33.5mm) ø 1.3” (33.5mm)

Exton Honeycomb Louver

Exton Sandblasted Lens

Exton Solite Lens

Exton Honeycomb Louver, Black (EX3-HCL-BLK)1/8” Hexcell black metal. Controls spill illumination and glare.

Exton Sandblasted Lens(EX3-SBL)Creates an uniform beam pattern that is useful for wall washing. Tempered glass.

Exton Solite Lens(EX3-SOL)Tempered glass with a stipple effect that that provides obscurity while retaining high transmission values. This low-iron optically clear glass offers maximum trans-mission and minimal absorption.

Exton Solite Lens

Exton Snoot (EX3-SNT-BLK)

Exton Snoot accessory for additional glare control. Black Finish. Installed with the standard Media Holder that accommodates two Media.

1 -7/8”(48mm)

1 -9/16”(40mm) NEW

Kore EX3 IP65 4” Monopoint Direct Mount Module

Downlight & GemsRemote Power Supply, 0-10V Dimming

teganlighting.com • info@teganlighting.com • (415) 504-3536 • TG500 7-8-20 2 LIGHTING

Exton Monopoint - SPA - Steam Room

Kore EX3 4” Direct Mount SPA Steam Room Monopoint with Frosted Sphere Gem, Aluminum or Black Finish.Catalog Numbers For use with a Remote Power Supply(s) - See page 3 for details, ordered separately.EX3-K-4MP-SPA-FSG-AL or BLK

3”(76mm)

5 -15/16”(151mm)

ø 4 -5/16”(110mm)

Exton Kore EX3 LED 4” SPA Steam Room Monopoint with Gem - Combinations

Kore EX3 4” Direct Mount SPA Steam Room Monopoint with Frosted Cylinder Gem, Aluminum or Black Finish.Catalog Numbers For use with a Remote Power Supply(s) - See page 3 for details, ordered separately.EX3-K-4MP-SPA-FCG-AL or BLK

Kore EX3 4” Direct Mount SPA Steam Room Monopoint with Flat Gem, Aluminum or Black Finish. Catalog Numbers For use with a Remote Power Supply(s) - See page 3 for details, ordered separately.EX3-K-4MP-SPA-FG-AL or BLK

2 -7/8”(73mm)

ø 1 -5/8”(41mm)

ø 4 -5/16”(110mm)

5 -7/16”(138mm)

ø 4 -5/16”(110mm)

ø 3 -1/8”(79mm)

Exton Kore EX3 LED 4” SPA Sauna Monopoint with Cylinder Gem & NIKTO Shade - Combinations

Kore EX3 4” Direct Mount SPA Steam Room Monopoint with Frosted Cylinder Gem, & NIKTO Shade, Aluminum Finish.Catalog Numbers For use with a Remote Power Supply(s) - See page 3 for details, ordered separately.EX3-K-4MP-SPA-FCG-AL-NKS-AL

Kore EX3 4” Direct Mount SPA Steam Room Monopoint with Frosted Cylinder Gem & NIKTO Shade, Black Finish.Catalog Numbers For use with a Remote Power Supply(s) - See page 3 for details, ordered separately.EX3-K-4MP-SPA-FCG-BLK-NKS-BLK

5 -7/16”(138mm)

ø 4 -5/16”(110mm)

ø 3 -1/8”(79mm)

5 -7/16”(138mm)

ø 4 -5/16”(110mm)

IP65 J-Box by others IP65 J-Box by others

IP65 J-Box by others

IP65 J-Box by others IP65 J-Box by others

Kore EX3 IP65 4” Monopoint Direct Mount Module

Downlight & GemsRemote Power Supply, 0-10V Dimming

teganlighting.com • info@teganlighting.com • (415) 504-3536 • TG500 7-8-20 3 LIGHTING

Exton Monopoint - SPA - Steam Room

SPA Enclosure with Power Supply -

13"

8"

3 14 "

3 -1/4” (83mm)

13” (332mm)

8” (204mm)

Tegan’s SPA IP20 Interior Remote Power Supply Enclosure is suitable for LED drivers. Available with top and bottom knock-outs for wire connections.Powder coated grey finish (GY). Enclosure ships with Module PCB(s) and Master Drivers installed.

IP20 INTERIOR MOUNTING ONLY 1, 2

40W - Will operate 1 - 10, 3W Kore-EX3 Modules SPA 40W Non-Dimming Driver (D-SPA-40W-X-120/277V-IP20-LRPSE-GY) SPA 40W 0-10V Dimming Driver (D-SPA-DM-40W-X-120/277V-IP20-LRPSE-GY)* Replace “X” with the number of Monopoints powered, between 1 and 10.

Large Remote Power Supply IP20 Enclosure

Qty of LED Modules per Driver CapacityIP65 Kore EX3 Wattage Guidelines for SPA Power Supplies

1. Due to the rapidly evolving technology for Semiconductor products, Tegan driver options are subject to change at any time, without notice. In addition, if any of the standard drivers are out of stock or discontinued, Tegan Lighting will supply an equal as needed. Tegan can also supply alternative drivers upon request; contact the factory for details.2. We have listed the maximum number of Kore-EX3 Modules for each Driver option above based on the following common practice: Recommended De-Rating: Like all electronic power supplies, life is significantly increased when loads are 75/80% or less of the nominal power capacity. Best life is in climate controlled conditions, or when the power supply stays below 70C/158F. The type of enclosure and ambient environment can affect the operating temperature, and therefore the lifetime of the power supply. For all Tegan Lighting enclosures, load power supplies to only 75/80% of their nominal. These are general suggestions to increase the life of the supply in moderate climates; the actual operating lifetime of the power supply depends on the actual environment and use. Do not operate the power supplies during the day with direct sunlight with extreme hot temperatures. 3. Do not exceed a maximum of 10 Exton LED Spa Monopoint fixtures per run/circuit.4. Due to heat considerations, do not use greater than 40W Drivers for Kore EX3 SPA Monopoints.5. VOLTAGE DROP: To calculate the maximum wiring distance of an Exton Monopoint circuit, you have to consider the wiring from the power supply to the first Monopoint, as well as the wiring from the first Monopoint to the last. Added together, these distances are the “total circuit run length”. The voltage should not drop below 21V. Since an Exton circuit is low voltage and higher current, maximum circuit run length is achieved with thicker (e.g. 18AWG) wire. Each Exton module draws about 0.5 A, so use 18 AWG Exton Circuit, 100W total: 50’ Total circuit Run Length. This assumes a roughly even spacing of modules along the circuit run, and good electrical connections. Poor or numerous “pigtailed” connections that interrupt the circuit, or grouping modules towards the end of a run, can increase the voltage drop and cause improper LED output for these examples.6. Use Tegan Lighting Power Enclosures and Drivers only. If supplied “by others” the warranty and listing are void.

Exton Kore EX3 - Gems & Shade TypesFlat Gem

Frosted Sphere Gem

Contact Factory for a custom design Gem.

ø 1 -5/8”(41mm)

ø 1 -5/8”(41mm)

2 -1/2”(64mm)

ø 3”(76mm)

7/16”(11mm)

Frosted Cylinder Gem

NIKTO Shade

ø 3 -1/8”(79mm)

3 -1/8”(80mm)

Description Max # of Kore-EX3 SPA Fixtures Typical Driver Links

40W Non-Dimming Driver 10 40W Non-Dimming Driver

40W 0-10V Dimming Driver 10 40W Driver & Dimming Module

Kore EX3 IP65 4” Monopoint Direct Mount Module

Downlight & GemsRemote Power Supply, 0-10V Dimming

teganlighting.com • info@teganlighting.com • (415) 504-3536 • TG500 7-8-20 4 LIGHTING

Exton Monopoint - SPA - Steam RoomEx

ton

SPA

Mon

opoi

nt W

iring

Ins

talll

atio

n

1. Each Kore EX3 LED SPA Module is wired back directly to the power supply. Do not hook up multiple units together. 2. Use 18 AWG minimum wire for 50’ (15.25m) maximum remote distance.3. Each Module gets hooked up to a mini-driver per wiring diagram.4. Do not mount the driver box in any space that exceeds temperatures above 110F (40C) max. It will cause failure of the electronics.

Exton Kore EX3 LED 4” SPA Steam Room Monopoint - Installation Overview

Note: Refer to the Exton SPA installation sheet for more details.

EXTON IP65 DIRECT MOUNT SPA MONOPOINT

Jbox

WHITE OR RED to +

BLACK to -

IP65 J-Box(by others)

Kore EX3 IP65 4” Monopoint Direct Mount Module

Downlight & GemsRemote Power Supply, 0-10V Dimming

teganlighting.com • info@teganlighting.com • (415) 504-3536 • TG500 7-8-20 5 LIGHTING

Exton Monopoint - SPA - Steam Room Category: Exton SPA Steam Room 4” Monopoint features an LED Module with Downlight, Flat, Cylinder or

Sphere Gems, or Cylinder Gem with NIKTO Shade, ceiling or wall mounted. Designed for use with a remote Power Supply Enclosure with Driver. Optional 0-10V Dimming.

Material: Monopoint: Powdercoated or anodized aluminum. Kore EX3 LED Module: UV stable exterior anodized aluminum, UV stable polycarbonate, rubber

o-rings. Note: Anodizing is an electrochemical process that results in superior corrosion resistance. This

process can result in a variance of finish from batch-to-batch. Gems: Gem: 100% machined, clear/frosted acrylic. NIKTO Shade: Aluminum.

Finish: Kore EX3 LED Module: Exterior rated, brushed, two-step electrolytic color anodizing. Anodized Black (BLK) or Anodized Aluminum (AL). Gem: Clear/Frosted acrylic. Shade: Powder-Coated Black (BLK) or Aluminum (AL); contact factory for additional colors.

Gems: Flat Gem (FG), Frosted Cylinder Gem (FCG), Frosted Sphere Gem (FSG).

Shade: NIKTO (NKS).

Accessories: DL: Exton Sandblasted Lens (EX3-SBL), Exton Solite Lens (EX3-SOL), Exton Honeycomb Louver 16 - Black (EX3-HCL-BLK). Exton Snoot - Black Finish (EX3-SNT-BLK)

LED: High Wattage Array Cree LED, 2-Step Macadam. 3W @ 300 Lumen Output with 2700K 82-85 CRI typical. All values are initial lumens. For exact lumen output and wattage consumption data, please consult IES reports. Online power consumption does not include driver losses. Contact factory for 3000K, 3500K, 4000K or 90 CRI.

Optics: 15° | 25° | 35° Reflector for Kore-EX3 Downlight. Refer to photometric report for details. A 15° reflector is supplied in all decorative options to maximize decorative element illumination.

Electrical: 24VDC. Total input watts: 4.5W per LED module. 300W max. per circuit.

Remote Power Supply: Refer to page 3 for SPA-Specific IP20 Power Supply details. Use of Tegan Lighting Power Enclosures

and Drivers only. If supplied “by others” the warranty and listing are void. .

Installation: Refer to Installation Instructions for details. For system layout, and specification assistance, refer to the Exton IP65 Application Guide for details. EX3-SPA Monopoint rated for a maximum temperature of 105C/221F. If mounted in any environment that exceeds the maximum factory rated temperature, the listing and warranty are void.

Labels: ETL Listed; Tested to UL 2108 Low Voltage Lighting Systems. In a continuing effort to offer the best product possible we reserve the right to change, without notice, specifications or materials. Technical specification sheets that appear on teganlighting.com are the most recent version and supersede all other versions that exist in any other printed or electronic form. Kore EX3 Module, Monopoint Mounting - 3 year warranty. Refer to Exton IP65 Application Guide for details.

300WMAX

0-10VDimming

LED24VDC

IP65

Kore EX3 IP65 4” Monopoint Direct Mount Module

Downlight & GemsRemote Power Supply, 0-10V Dimming

teganlighting.com • info@teganlighting.com • (415) 504-3536 • TG500 7-8-20 6 LIGHTING

Exton Monopoint - SPA - Steam RoomClick on the linked images below to visit the Exton IP65 Gallery.

Exton Kore EX3 LED 4” SPA Steam Room Monopoint

Flat Gem, Black

Exton Kore EX3 LED 4” SPA Steam Room Monopoint

Frosted Cylinder Gem,Black

Click on the image below to visit the Exton IP65 Application Guide.