Embed Size (px)
Citation preview
888 SELF- AS5EM13LY
44
v The main shipping module, including v Hydraulic cylinders raise the gxn[ry 10
carhody, ulll~l,l wot~s. ~;<IIIhy, mdsl. and worl. irl~: posiiion and Iill [he mast 10 vcrli
boonvhoisl reeving, arrwes as a uni[. r)p- cal. The boom hois[ rigging [hen lowers the
tional hydraulic jacks mounted on the car- mast so it can be rigged wilh the s@-up load
body raise the unil off its [ransport trailer. block, Wire rope !!,.IIN -IIC O( the hoist drumsis reeved through sheaves in [he mast to rigthe block.
v The gantry is lowered and pinned to theassembled counierweighL Hydraulic cylin-
ders raise the gantry and counterweight toworking posi~ion. The counterweight is thenconnected LO the back or the upperworks bypower-activated pins.
I
wT’w%--V lbe mast is used 10 insldll the crawlers,
handle boom seclions. stack the counter-weights. and lift other componen~s Crawl-
ers attach using FACT alignment surfacesand powered pins.
v The mast is used to lay out boom sec~ionsand install the boom bu[L power-ac[ivated
pins simplify installation of the butt.V.
Boom inserts and top are pinned 10 the
v
The assembled 888 booms up and
boom butt. Boom-support pcndan(s are is ready to work.
pinned to the mast and boom lop Mainand auxiliary load lines are reeved.
I Ziro
43,71/~
(13.30m)
// //11
I L19°103/40W36m]-JRetracted
1-~81/f
[1.12d
-!-
.,. e“
ENGINE: Cummins Ml 1 diesel engine rated 330 HP at~ *ROTATING BED: High-strength fabricated steel rotating bedis mounted on 108%’’diameter turntable bearing.
HOIST DRUMS: Two full-width hoist drums are standard.Both drums are 37” wide and 19!4”in diameter. Each isantifriction bearing mounted and driven independently by avariable-displacement hydraulic motor coupled to a plane-tary reduction. External contracting brakes mounted to thedrum shafts are air applied and equipped with spring-setair-released parking brakes. A hi-directional redundantbrake mounted between the hydraulic motor and planetatydrive is standard for each hoist, and each drum is equippedwith ratchet and pawl. A freefall clutch, [aggings, and otheroptions are available.
BOOM HOISfi Independent boom hoist is powered by avariable-displacement hydraulic motor coupled to a plane-tary reduction. It is equipped with a hi-directional brakeand a ratchet-and-pawl. The boom hoist drum is groovedand measures 13%”wide by 18%”in diameter.
SWING SYSTEM:Independent swing is powered by a ftxed-displacement hydraulic motor coupled to an internal brakeand planetary reduction. System includes swing lock.
OPERATOR’S STATION: Fully enclosed and insulated steelmodule mounted to the left front corner of the rotating bed,Module is equipped with sliding door, large safety glasswindows on all sides and in roof, Standard equipment in-cludes electric horn, cab space heater, dome light, fire ex-tinguisher, air-circulating fan, and windshield wipers forupper front window, lower front window, and roof window.
2,100 RPM provides independent power for all machineoperations through the multi-hydraulic-pump transmis-sion. Power system includes engine block heater (120v),ether starting aid, transmission disconnect clutch, high-silencing muffler, alcohol injector in air line, hydraulic oilcooler, radiator, and fan.
CONTROLS: Modulating electronic-over-hydraulic con-trols provide infinite speed response directly proportionalto control lever movement. Controls include Manitowoc’sexclusive EPIC@control system providing microprocessordriven control logic, pump control, on-board diagnosticsand service information. Block up limit control and drum-rotation indicator are standard for hoist and whip falls.
CARBODV Connects rotating bed to crawlers. High-strength fabricated steel assembly with patented. FACTT~connection system for fast removal of crawler assemblies.Optional self-assembly system includes four hydraulicjacks that raise entire upperworks-and-carbody unit offthe transport trailer. Hydraulic jacks support this unit dur-ing crawler installation and removal.CRAWLERS: Crawlers are 28’2W’ long steel fabricationwith 48” wide cast steel crawler tread and sealed low-maintenance intermediate rollers. Each crawler is pow-ered independently by a variable-displacement hydraulicmotor. Crawlers provide ample tractive effort to counterrotate with full rated Iiftcrane capacities. Each crawlerincludes two hydraulically powered pins for fast installa-tion and removal from carbody.
a
EASY NieBfLilaN’!oN
* (: , ~=~m’-l,;m~~
1 I
-. .- E?- 11.12ml
~T
Crawler assembly (2), each 41,300 lb.Main shipping module (carbody, upperworks, operator’s cab, gantry, mast,boom-hoist wire rope, and optional self-assembly jacks): 84,500 lb. Formaximum hoist and whip lines, add 6,OOOlb. Maximum trailer height for selfassembly: 42”. Space between jacks will accommodate trailers up to 10’wide.
ylu’+1
r
ISI
t-(JKl-
17’11.
[241 ml
rm)
!_. lx
883
~ 4,9,,-,,.74., ~
Boom top with seven-sheave lower point, upper wire-rope guide, and basic Boom butt with lower wire-rope guide and air-cush-
pendants: 11,090lb. ioned physical boom stop: 10,260lb.
WeightComponent (Lb) I Length I Width I Height I,Uppmvorks counteriveight tray 21,050 13’0” 7’4” I ‘o;!”
Upper\vorks center counterivei~ht 18,000 7’6X” 4’1!L- 5’0’<. .
Upperworks side counterweight (6 for Series-1; 8 (or Series-2) each 17,500 7’4” 3’6” 2’3”
Carbody counterlveight (2) (used only On Series-2) each 22,000 9’10’I’ 4’10Z” 2’4”
10’ NO,22 boom insert with pendants 1,935 10’6” 7’11” 7“11”
20’ No. 22 boom insert with pendants 3,130’ 20’6” 7’11” 7,,,.. *
40’ W. 22 boom insert \vith Dendants 5,300’ 40’6” 7’1[” 7’11”*I 1
40<NO.22C open-throat boom top with pendants and \vire-rope guide 11,795 45’9” 7’11” 10,6!/:
30’ basic No, 123jib \vith strut and pendants 2,095 3[’6” 2’6” 3’0”
30<basic No, 134jib tvith strut and pendants 3,443 31‘6” 2’6” 3’0’”
10’ insert (with pendants] [or No. 123or No. 134jib 480 1046” 2’6’8 2’6”
20’ NO. 134jib insert with pendants 750 20’3” 2’7” 2’7”
27’ No, 135lut’tin:-jibbutt 2,285 27’7” 5’0” 4’1”
23’ NO. 135lulling-jib top with pendants 3,150 25’7” 5’0” 4’10”
Main strut [or No. 135luffing-jib 3,400 24’11” 5’1” 2,3.,
Jib strut (or No. 135luffing-jib 4,500 28’5” 5’0<’ 2’3”
10’ No. 135 Iu(ting-jib insert tvith pendants 845 10’4” 5’0” 4’1”
20’ No, 135 ILlt”fing-jibinsert with pendants 1,350 20’4” 5’0” 4’1”
40’ No. 135Iut’ling-jibinsert \vith pendants 2,320 40’4” 5’0” 4’1”
501 ot’miscellaneous parts 4,700 7’6” 3’4” --2’ [0”
“ 100 lb heavier and 8’4” height for inserts with lugs ior jib backstay.
CAPACITY: 230-ton maximum capacity. Outlifts many 275- RELIABILIN The 888 is designed and manufactured toton lattice-boom cranes and 400-ton telescopic-boom deliver the same performance and lon life that havecranes at useful boom lengths and normal working radii. fearned other Manitowoccranes a wor dwide reputation for
@ILITY: Complete 888 Series-1 with 260’ of boom ships reliability and high resale value.
Otrucks. 888 Series-2 with 290’ of boom ships on 11 CODE COMPLIANCE: Manitowoc is preparing the 888 totrucks. comply with all major operating codes, including the
OSHA/ANSl,DIN,Keboma, British, and French standards.
MANITOWOC ENGINEERING CO. Because of Continuing Improvements. Marwowoc Engmeenn: Co.Divfsion of The Mcrni[owoc Company, inc. resetves the rgh( [o change spec{jcooorts at any time,wdrour
P.O.Box 70 + 2401 S, 30th St. + Manitowoc, WI54221-0070 notice.
Telephone: 414-684-6621 + Telefax 414-683-6277 FormAdv 9624 @1996Mamtowoc LKhoin U5 A ).1EC
Wire Rope Specifications
Breaking
Application Dia. Description Strength Weight Length
Lift 26 mm 2[60Grade, Rotation Resistant [47,500lb 2.13lb/ft 1,625’Hoist
1,0[0’\vhlp
Boom Hoist 22 mm 1960 Grade, Right Regular Lay 97,OOO lb 1.46 lb/lt 1,060’
Line Pull vs. Line Speed”
Line Puii(Infinitely Variable) 1st Layer 4th Layer 7th Layer
O lb 4 270 fpm 350 ipm 430 tpm
5,OOOlb 265 fpm 345 fpm 420 [pIll
10,000lb 260 fpm 335 fpm 405 fpm
15,000lb 255 fprn 325 fpm 395 tpnl
20,000 lb 250 tj)lll 315 Ipln 325 tpfll
25,000 lb 245 fprn 260 fplll 260 (pIll
30,000 lb 215 fpm 220 [pm 220 t’pnl
‘Bwxl UII i9ti’”diameler SIIWX1l M-ml.
SWING SPEED: 2.0 RPM. GRADEABILITY: 30%TRAVEL SPEED: 1.0 MPH. BOOM HOISTSPEED:290’ boom, 0° to 82°, 2 minutes, 50 seconds.
BASIC BOOM: The liftcrane is equipped with 70’ No.22EL basic boom consisting of 30’butt and 40’ No.22L top with seven 30” diameter sheaves (eighthsheave optional). Includes rope guides, boom-hoistwire rope, boom-angle indicator, and hook andweight ball. Boom inserts available in 10’,20’,and40’lengths,poweredboom-hingepinsarestandard.MASR The 32’ long moving mast connects the boom-hoist reeving to the boom pendants. The mast facili-tates self assembly and disassembly of the Model 888.It is capable of handling the crawlers, stacking thecounterweights, and assembling the boom and jib.GANTRV Gantry includes hydraulic gantry-raisingcylinders capable of lifting the entire upperworkscounterweight for self-removal and installation.
BOOM STOP: Air-cushioned physical boom stop andautomatic boom stop,
COUNTERWEIGH-H3The eight-piece counterweightassembly for the 888 Series-l weighs 144,100lb. [tconsists of a counterweight tray (21,050lb), a centercounterweight [18,000lb), and six upper side counter-weights (17,500lb each). The Series-2 counterweightoption includes two additional upper side counter-we~ghts (17,500lb each) and two carbody counter-weights (22,000 lb each), for a total counterweight of223,100lb.
BOOM AND JIB:Boom No. 22E or 22EL10’Insertwith pendants10’Insertwith pendants (used with auxiliary drum)20’ Insert with pendants40’ Insert with pendants
40’No.22Copen-throatboomtop30’Taperedinsert with pendants
(used with light tapered top)50’ Light tapered topJib No. 12330’ Jib with mounting partsIO’Insert with pendantsJib No. 13430’ Jib with mounting parts10’Insert with pendants20’ Insert with pendants
ATI’ACHMENTS:Load blocksSingle-sheave upper boom point (whipline)--Series-2packageNo. 135luffing-jibattachmentRINGER@attachmentother attachments on request
BASIC CRANE OPTIONS:Airconditionerin operator’scabFootcontrol for travelSpecialpaint—enamel in
color other than Manitowoc standardSelf-assembly system with jacksGrooved laggings for IiftcraneGrooved Iaggings for clamshellLoad-moment indicator (LMI)High-speed third drum with 20,000-lb. line pullFree-fall clutch
—-.... —...
REFERENCE CAPACITY CHARTLI!=TCRANECAPACITIES
.—___... . . . .. . . . ... .. . . .... ...... . .. . .. .. . .. . . . .. . . . -—— _
@
hL4NiT0 WOC#8. Model 888 Series I
144,100-LB COUNTERWEIGHT 4
e
Boom No 22EL360 DEGREE FWnm
tiftcrane capacitiescomply with ANSI 930.5 requirements and do not ~ 75% of Machine ewipped tiza’i- ks-qtultyexltndedcm wkm. 4a-
static tipp@ load. Capacities based on structural competence denofed by an asterisk treads,lr3-gantry,xrm, zrLpartbeorrrhofstllne,fourl-(-). m-boin padantsand144,1OOA uppmwks counterwmghf
Weight of all load bfocks. hcds, weight balls, slings, heist lines, etc.. beneath brxwr~.
point sheaves is wnsidered part of load. Where no ca~ ~ =.kwi PM is notinten&d or approved.
Liftcrane Capactiies (Thousands of Pounds)Radius I + Boom Lengths (Feet)
(Feet)
16 404.8”18 362.2* 361,9’
20 327.4* 327.1* 326.3*
22 298.4* 298.1” 297.4* 296.3*
24 273.9* 273.6* 272.9* 271.8-26 244.3 245.1 .246.0 246.4 246.728 215.6 216.2 217.0 217.3 217.5 217.6 1
30 “192.6 -193.2 193.8 194.1 194.2 194.1 194.0 I34 .158.1 158.6 159.1 159.2 159.2 159.0 158.7 158.4 147.3*
38 133.4 133.8 134.2 134.2 134.2 133.9 133.6 133.2 132.7 121.2”42 114.9 115.3 :15.6 115.5
109.7’115.4 115.0 114.7 114.2 113.7 113.2 109.1”
46 100.5 100.8 101.1 100.9 100.8 100.4 100.0 99.5 98.9 98-3 981
50 88.9 89.2 89.5 89.3 89.1 88.7 88.2 87.7 8.
60 68.0 68.3 68.5 68.3 68.1 67.5 67.1 66.4 65.8 I 651 I 648 i
70 53.8 54.3 I 54.5 54.2 54.0 53.4 53.0 52.2 5“Ml I Ufl 4.&4 44.2 44.0 43.3 42.9 42.1 41.5 I 40.7 403 I
7.1- i 86.5 I 86.2 ]---1.6 i ;0:8 i ‘“:-
1 1505 I
1 . ..- . . , . ..- ----
iiil 36.8 36:6 36.4 35.8 35.3 34.5“-- 33.8 ‘-”33.0 32.7100 30.8 30.7 30.5 29.9 29.4 28.6 27.9 27.1 26.7
110 25.9 25.8 25.1 24.6 23.8 23.2 22.3 22.0
120 21.9 21.9 21.2 20.7 19.9 19.3 18.4 18.1130 18.6 18.0 17.5 16.7 16.0 15.1 14.8140 15.7 15.2 14.7 13.9 13.3 12.4 12.0150 12.8 12.3 11.5 10.9 10.0 9.7160 10.6 10.3 9.5 8.8 7.9 7.6170 8.4 7.6 7.0 6.1 5.8180 6.0 5.4 4.5 4.2190 I 4.5 4.0 A
$ MANITOWOC ENGINEERING CO.Division of the Manifowoc Company, inc.
P.O. Box 70 +Manitowoc, VW 54221-0070
Telephone: 414-684-6621 + Fax: 414-683-6277
NOTICE: This capacdy chart !s for reference use only and mustnot be used for lifting purposes. Regular capacty charfs for a
sFific Crone can be purchased from an authorized Manfi~Distributor.
(31996 Manitowoc Sales Form R-781 1-A 2-19-96
— .. . --- ---- ----------------------- -----.---. —. . . ... .. . . ..... .. ........ ...4- ---- .A --.=— ----------- ——-
O-.
REFERENCE CAPACHY CHART
@
MAMTO W(3CLIFTCRANEJIB CAPACITIES t Model 888 Series 1No. 134 JIB-5 DEGREEOFFSET - ~” ‘“
....-,.- t*
144, 100-LB COUNTERWEIGHTBoom No. 22EL
360 DEGREE RATING
IJftcmne capacities comply with ANSI 630.5 requirements and do not =* . Machine equipped with 28’ T long fulty m@nded crawlers, 43- Waos.
75% of static tipping toad. Capacities based on structural competence lU4-~@, W-. ~ti-tit*~, fwr 13-*denoted by an asterisk ~). pendants, 12& jib strut, 144,100-ib uppemw’ks counterweigh
Weight of all load blocks. hooks, weight balls, slings, hoisl tines, etc., beneathassembks.
boom and jib point sheaves is considered part of jib load. Where no capadtyis shown operation is not intended or approwxf.
30 Foot #134 Jib -5° O#fset
Liftcrane Jib Capacities (Thousands of Pounds)
Radius I Boom Lenoths IFeet)—
L ,
(Feet]
30 59.0” 59.0” I40 59.0” 59.0” 59.0” 59.08 59.0”50 59.0” 59.0’ 59.0” 59.0” 59.0’ 59.0* 59.0” 59.0’ 59.0”60 58.1- “ 59.0” 59.0” 59.0* 59.0” 59.0” 59.0” 59.0” 59.0”70 56.1* 57.0” 56S 55.9 55.1 54.4 53.6 52.9 52.580 47.4 47.1 46.4 45.8 45.0 44.3 43.4 42.7 42.290 39.8 39.6 38.8 38.2 37.4 36.7 sJ 35.8 35.0 34.6100 33.9 33.7 32.9 32.3 ~~3~.5 30.8 29.8 29.1 28.6110 29.1 28.9 28.2 27.6 26.7 26.0 25.1 24.3 23.8120 25.0 24.3 23.7 22.8 22.1 21.2 20.4 19.9130 21.0 20.5 19.6 18.9 17.9 17.1 16.6140 18.2 17.7 16.8 16.1 15.2 14.4 13.9150 15.3 14.4 13.7 12.8 12.0 11.5160 13.2 12.3 11.7 10.7 9.9 9.4170 10.5 9.8 8.9 8.1 7.6180 8.9 8.2 7.3 6.5 6.0190 6.8 5.9 5.1 4.6200 5.5 4.6205 4.0
_.
—. .—--- -—--
mMANITOWOC ENGINEERING CO. NOTICE: This capacity chart is for reference use only and must
Division of the Manitowoc Company, Inc.not be used for IiRing PUWO=S. Regular C=IIMCIWchafis for a
P.O. Box 70 + Manitowoc, WI 54221-0070SpeCifiCcrone can be purchased from an authorized Manto..vocDistributor.
Telephone: 414-684-6621 + Fax: 414-683-6277
01996 Manitowoc Page 1 of6 Sales Form R-781 2-A 2-19-96—.
REFERENCE CAPACITY CHARTLIHCIU$JE JIB CAPACITIES
. .. . .. .
MANITO WOC- Model 888 Series 1
No. 134 JIB -5 DEGREE OFFSET - ~ -‘ “Boom No. 22EL
144,10O+EICOUNTERWEIGHT
360 DEGREE RATING aMtcrane capacities comply with ANSI E30.5 requirements and do notexceed Machine equipped with 28 T long fully extended crawlers. W treads.75% of static tipping load. Capacities based on structural competence 10’4- gantry, 30 mast. Z&part bmm hoist reeving, four 1-WY kerndenoted by an asterisk (.). pendants, 12’ & jib strut, 144,1 CO-lbuppervwks countenvAght
Weight of all load blocks, hooks, weight balls, slings, hoist lines, etc., beneathassemblies.
tmom and jib point sheaves is considered part of jib load. Where no capacityis shown ooeration is not intended or aooroved.
40 Foot#134 Jib 5° Offset
I * Liftcrane Jib Capacities (Thousands of Pounds) 1Eloom Lenaths (Feet) I
I..——.——,
,----at-t I G2FP I I I I I I I I“. I -“. ” 1 ,
40 50.5’ 51.1- 52.3” 53-2’ I I I50 47.8” 48.5” 49.8* 50.9* 51.8* 52.6” 53.3” 53.9*60 45.4* 46.2* 47.7* 48.9” 49.9” 50.8” I 51.6* 52.3* 52.6*70 43.4* 44.2* 45.7* 47.0” 48.1” 49.1* 50.0” t 50.7* 51.1*80 41.7* 42.5* 44.0” 45.4* I 45.7 45.0 I 44.2 43.4 43.090 40.2’ 40.4 39.6 39.0 38.1 37.4 36.5 I 35.7 35.3100 I 34.7 34.5 33.7 33.0 I 32.1 31.4 I 30.5 29.7 29.2
1- 110 1- 30.0 [ 29.7 ! 28.9 I 28.3 I 27.4 I 26.6 I 25.7 I :--- -. - -,-- ---
24.3 ‘ ‘-” ‘ ‘-- 1 ‘“n ( “
I <1. / I 21.1 I LLr.L I18.9 18.3 17.4 I
1Zu Zb.u Z3.U130 22.4140150 I160170 I
t
4C0
t -#-4---
t icn 1
t t13.811.9
24.9 I 24.4 ILA f dl.o 21.0 20.519.4 18.5 17.7 17.216.7 15.7 14.9 14.414.3 13.3 12.5
12.9 12.2 11.2 10.4 9.911.1 I 10.4 9.4 8.6 8.1
1 ! , . ..-
180,
I 9.4 8.8 I 7.8 I 7.0 I 6.5190 I I 8.0 I 7.3 6.4 5.6 5.0
1--- I I I , !
200 I I 6:0 I 5.1 I 4.3 I-Am 1 I I I Ao 1
.
MANITOWOC ENGINEERING CO.Division of the Manitowoc Company, )nc.P.O. Box 70 + Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
..-
NOTICE: This capacity chart is fOr reference use Oflly and must onot be used for lifting purposes. Regular capacty charts for aspemfic crone can be purchas&d from an authorized ManikmvccDistnbufor.
01996 Manitowoc Page 2 of 6 Sales Form R-781 2-A 2-19-96
REFERENCE CAPACITYLHCWE h CAPACITIESNo. 134 JIB-5 DEGREE OFFSET
*
144,1 00-LB COUNTERWEIGHT
360 DEGREE RATING
.,-.
. .
@ ‘),,
CHART
-B”
MANITO WOC1 Mode! 888 Series 1#. .
I Boom No. 22EL
L.iftcrane-capacities comply wittr ANSI B30.5 requirements and do rid exceed Machine equipped wth 28’ ~ long fully extended udw+ers, W treads.75% of static tipping load. Capacities based on structural competence lU4gan@, Win*, ~ti*MtiW, fwrl=-h
denoted by an asterisk ~). pendants, 12 ~ jib sfrut, 144,1 W4b uppworks counterweightassemblies.
Weight of ail load blocks, hooks, weight balls, slings, hoist lines, etc., beneathboom and jib point sheaves is considered part of jib load. Where no WX@Yis shown operation is not intended or approvwi
50 Foot #i 34 Jib 5° OffsetLiftcrane Jib Capacities (Thousands of Pounds)
Radius I Boom Lengths (Feet)
(Feet)35 42.9*
40 41.7* 42.2* 43.0” 43.7” ;50 39.4* 40.0’ 41.0” 41.9” 42.6* 43.2* 43.7*
60 37.5* 38.1* 39.2* 40.2” 41.0” 41.7* 42.39 42.8*
70 35.8* 36.4* 37.6* 38.6* 39.5* 40.3” 40.9” 41.5”80 . 34.2* 34.9* 36.2* 37.2* 38.2* I 39.0” 39.7* 40.3”90 32.9* 33.6* 34.9* 36.0” 36.~* 37.8’ 37.0 36.2
100 31.8* 32.4* 33.7* 33.5 32.6 “ 31.9 31.0 30.2 i
110 29.4* 30.3 29.4 28.7 27.8 27.1 26.1 ;“25.3 ,120 26.7 26.4 25.5 24.8 23.9 23.1 22.2 21.4130 23.3 23.1 22.2 21.6 20.6 19.9 18.9 18.1140 20.2 19.4 18.8 17.8 17.1 16.1 15.3150 17.0 16.4 15.5 14.7 13.7 12.9160 I 14.9 14.3’ 13.4 12.6 11.6 10.8170 12.5 11.5 10.8 9.8 9.0180 I 10.8 9.9 9.2 8.2 7.4190 8.4 7.7 6.8 5.9200 7.1 6.4 5.5 4.6210 5.2 4.3220 I I 1 4.1 I
. .
0 MANITOWOC ENGINEERING CO.Division of the rUanitowoc Company, Inc.P.O. Box 70 + Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
___
NOTICE. This capac~ charl IS for reference usa only and mustnot bs used for lifting purposes, Regular capacity charts for aspecific crane can be purchased from an authorized MamtowocDktnbutor.
@l 996 Manitowoc Page 3 of 6 Sales Form F?-781 2-A 2-19-96
.
REFERENCE CAPACITY CHART
&
MAPJITQ WOCIJFTCWE JIBCAPACITIES t Model 888 Series 1No. 134 JIB-5 DEGREE OFFSET
8#
144, 100-LB COUNTERWEIGHTBoom No. 22
%360 DEGREE RATING
Liftcrane capacities compiy with ANSI B30.5 requirements and do not exceed Machine equipped wth 26’ T long fully extendti crawlers, 43- treads,
75% of static tipping load. Capacities based on structuml competence 10’ & gant~, 30 mast, 20-part boom hoist reeving, four 1-W& boom
denoted by an asterisk (0). pendants, 12’ W jib strut, 144,1 CO-/b upperworks rxxrnterweighl
Weight of all load blocks, hooks. weight balls. slings, hoist fines, etc,, &neathassemblies.
boom and jib point sheaves is considered part of jib load. Where no capacityis shovm opemtion is not intended or approved.
L
60 Foot #134 Jib 5“ Offset ,
Liftcrane Jib Capacities [Thousands of Pounds)Radius I Boom Lenaths (Feet] 1
I (..——.——9
Feet)
35 36.1* 36.4*
40 35.1* 35,5* 36.1*50 33.3* 33.8” 34.5’ 35.1* 35.7* 36.1*60 31.7* 32.2* 33.1* 33.8* 34.4* 34.9* 35.4* 35.8”70 30.2” 30.8= 31.8” 32.5* 33.2* 33.8* 34.3* 34.8*
80 28.7* 29.3” 30.4” 31 .4* 32.1* 32.8” I 33.3” 33.8”
90 27.4* 28.1’ 29.2* 30.2” 31.1* 31 .8* 32.4” 32.9*
100 26.3” 26.9* 28.1” 29.1” 30.0” 30.8” t 31.3 30.5
110 25.3* 25.9* I 27.0” 28.1* 28.2 27.4 26.5 25.6. ---- -n . . I -. -. -. ,-, I -r -1 I -A -1 O* c I -1.1 z -)4 7 II Lu I La.a- L3.u- L3,Y La.L I L9.L La. a I U.2 I L1.1
130 21.5* 23.0’ 22.6 21.9 21.0 20.2 19.2 18.4lAn i lQQ* 7n 7 -tQQ 1C)7 I ‘If! 7 17A I lf14 t 156
I150 i I 18.3 17.5 I 16.8 I 15.8 I 15.0 I 14.0 I 13.2. -m i .-. .,9 Am7 Ann “.-! * .4.
I ,-” 1 ,“. ” I -“. , I ,w. - ! ,--- [ ---- 1 . . . . I.-. . 1 ----
1 O(J 13.4 14. / Id. / IL. Y IL. U 11.1
170 13.5 12.9 11.9 11.1 10.1 9.3180 11.2 10.3 9.5 8.5 7.7190 9.7 8.8 8.1 7.1 6.2200 I 7.5 6.8 5.8 4.9
210 6.3 5.6 4.6
t
220 I I I I I I 4,5 I I225 4.0 I
MANITOWOC ENGINEERING CO.Division of the Manito woc Company, Inc.
P.O. Box 70 + Manitowoc, WI 54221-0070
Telephone: 414-684-6621 + Fax: 414-683-6277
aNOTICE: This capacity chart is for reference use only and mustnot be used for lifting purposes. Regular c-apac~ charts for aspecific cfane can be purchased from an authorued MantiovmcOistnbutor.
@l 996 Manitowoc Page 4 of 6 Sales Form R-7812-A 2-19-96
... . . . . .... . .. . . .. .
REFERENCE CAPACITY CHART
.. . . ...+. . ... ----- .. . .. . . .. . . ..... .. . -----
LIFfCRANE JIBCAPACITIES
No. 134 JIB-5 DEGREE OFFSET. ---- ....—. ..
144, 100-LB COUNTERWEIGHT @
MA?JiTOWOC* Model 888 Series 1b
6 Boom No. 22EL
360 DEGREE RATING
LiRcran;&pcitii comply with ANSI B30.5 requirements and do not exceed Machine quippd with 28 2? long fulty extended crawlers, 48” Ireaas
75% of static tipping load. Capacities based on structural competence 104- gantry, 30’ mast, 20-parf boom hoist reeving, four 1-W ~
denoted by an asterisk ~). pendants, 12 F jib stint, 144,100-lb upperworks counterweight
Weight of all load blccks, hooks, weight balls, sJings, hoisf lines, etc., lx?neathassemblies.
boom and jib point sheaves is considered part of jib load. Where no capacityis shown operation is not intended or approved.
70 Foot #l 34 Jib 5° Of&et
Liftcrane Jib Capacities (Thousands of Pounds)
Radius I(Feet)
40 27.2* 27.3* 27.4”50 26.2” 26.5* 27.1* 27.2* 27.3* 27.4”60 25.0’ 25.3” 26.0” 26.5* 27.0” 27.2* 27.3* 27.4”70 23.8* 24.2* 24.9* I 25.5” 26.0” I 26.5* 26.9* 27.1”80 22.8* 23.2* 24.0” 24.6* 25.2* 25.7” 26.1”90 21.8* 22.2* 23.1*
26.5* ,23.7* 24.3* 24.9” 25.3*
. #S- [ -6 “* m. **25.8* ~
m- -* mmn. -.-I e. -. 4* 0s. -. I -------
170 I t 14.1 13.4 12.4 11.6 I 10.6 9.7180 12.4 11.7 10.8 10.0 9.0 8.1 /190 1 I 10.3 9.3 8.5 7.5 6.7 I200 I 9.0 8.0 7.2 6.2 5.4 /210 6.8 6.1 5.1 4.2 I220 I I I 5.8 5.0 4.0
@ MANITOVVOC ENGINEERING CO.>
Division of the Manitowoc Company, Inc.P.O. Box 70 +Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
-..
NOTICE: This capac~ chart is for reference use only and must
not be used for lifting purposes. Regular capacity charts for a
specific crane can be purchased from an authorized MamtowocDistributor.
C)1996 Manitowoc Page 5 of 6 Sales Form R-7812-A 2-19-95
REFERENCE CAPAC/TY CHART
@
IWAIWTOWOCLUTCRANEJIB CAPACITIES 4 Model 888 Series INo. 134 JIB -5 DEGREEOFFSET
4---- .1
144,100-LBCOUNTERWEIGHTBoom No. 22EL
360 DEGREERATING m
Liftcrane c+aeities compty with ANSI B30.5 requirements and do not exceed Machine equipped with 28% long fully extended crzw+em. 48- treaos,75% of static tipping load. Capacities based on structural urm@ence 10’4 ganbyo30’ mast, 2Uparf txxm hoist reeving, four 1-3/W boomdenoted by an asterisk ~). pendants, 12’ W jib strut, 144,100-lb upperworks sounterweght.
Weight of all load blocks, hmks, weight balls, slings, hoist fines, etc.. beneathassemblies.
boom and jib point sheaves ~, considered part of jib had. Where no capacityis shown opmtion is not intended or approved.
80Foot #134Jib 5° OffsetQ Liftcrane Jib Capacities (Thousands of Pounds)
Radius I Boom Lenaths (Feet] I
, ---- , . . . .1%0
1 1
1 12.7 “-:-.-. . .- .-—.
120 ‘-:-110 “-”-10.1 9.1 8.7190 I 11.3 10.5 9.5 8.7 7.7 7.3200 9.2 8.2 7.4 6.4 6.0210 8.0 7.1 6,3 5.2 4.8220 6.0 5.2 4.2230 5.0 4.2235 4.6
-.
MANITOWOC ENGINEERING CO.Division of the Manitowoc Company, Inc.P.O. BOX 70 + Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
@1996 Manitowoc
NOTICE: This capacity chart is for reference use only and must anot be used for lifting purposes. Regular capacity charts for aspecific crone can be purchased from an authorized ManitcrvmcDistributor.
Page 6 of 6 Sales Form R-7812-A 2-19-96
... . . ... . ..2 . . ..--. .--L .-— —. . . . . . . . . . . .. . . . . . . . . . . . . . . ,------ ------ ------ ~. . . .. . .
REFERENCE CAPACITY CHART
- .@
MAN17U WOLIFI’CRANE CAPACITIES
II Model 888 Series
14,1 ()()-LBCOUNTERWEIGHT1
BOOM NO. 22360 DEGREE RAmr43 ODen Throat Tc
Mtcrane capacities comply with ANSIB30.5 requiremerNs and do not Machine equipped with 28 ~ IcOg My exterxkl crawlers, 4& treacS. 10.3
exceed 75% of static tipping load. Capacities based on structural gantry, Xl’ mast, 20.part horn hoistline, four I-W& tmorn pendank and
competence denoted by an asterisk (“). 144,1 O&lb uppenwrks @unterwwght assembty.
Weight of hoisting line and rigging are considered part of load. Where 260’ boom requires removal of upper boom point .
no capacity is shown opeiatiin is not intended or approved.
Liftcrane Capacities (Thousands of Pounds)
Radius 1 Q Boom Lenaths fFeet).. ——.—-
15
,“ I -r” ”.- r 1 I , I I 1 1 1 1
.-l -#la G* -)Oc O* I I II .lOo. a I .xJa.o
;;
I I I I 1 1 I I I
366.3* ?lfi5 6“I ----- ! r r , r I , 1 1
n* =$7.4” 346.2* t I,n O* I -on C* I I I 1 I I
19 I 348.LI [ 0420 33?.5” 33U.O .aLY.Q I22 302.4” 301.8” 300.6” 299.1”
24 277.9” 277.3* 276.1* 274.5” I26 242.7 243.0 243.4 243.2 243.2
28 214.5 214.7 215.0 214.7 214.6 214.2
30 191.9 192.0 192.2 191.9 191.7 191.3 190.834 158.0 158.1 158.1 157.6 157.4~ 156.3 155.7
I 38 I 133.8 133.8 133.7 -133.2 132.9” 132.2 ‘[ -131.7 I 131.0- [ “130.3 [ tI A7 115.7 115.6 115.4 114.8 114.5 112.8 113.2 1125 111.8 111.2 I 101 o*
.5 101.4 101.2 100.5 100.2 9!mI In(-t i
90.169.655.945.9
89.769.255.545.638.232.3
89.1 I 88.7
=E68.554.844.937.531.7
68.154.344.537.131.3
---- ..-. — 1 ----- . . ..— 1 . ..— 1
9.4 98.8 98.0 97.3 96.787.9 87.3 86.5 85.8 85.167.3 66.6 65.7 65.0 64.253.5 52.8 51.9 51.1 50.343.6 42.9 42.0 41.2 40.336.2 35.5 34.5 33.7 32.9.30.4 29.7 28.7 28.0 27.0
-----—.95.984.363.4—.49.439.532.026.2
r. ---
110 27:0 26.7 I 25.8 25.1 24.1 23.3 22.4 ! 21.5
120 23.1 22.8 22.0 21.3 20.3 19.5 18.6 17.7
130 19.6 18.8 18.1 17.1 16.3 15.4 14.5
140 16.9 16.1 15.4 14.4 13.7 12.7 11.8
150 13.7 13.1 12.1 11.3 10.4 9.5
160 11.1 10.1 9.3 8.4 7.5170 I I 9.3 8.3 7.6 6.6 5.8 i
180, t
6.8 6;0 5;1 4.2 I
190 5.3 4.6 /195 4.7 4.0 1
e; MANITOWOC ENGINEERING CO.Division of the Manito woc Company, Inc.P.O. Box 70 + Manitowoc, Wi 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
NOTICE: This capacity chart is for reference use only and mustnot be used for lifting purposes. Regular mpac~ charts for a
specific crone can be purchased from an authorized Mantowuc
Distribukw.
01995 Manitowoc .qalpq I=nm-n D-777C A c 7 n’=
. ...-. ——-.. ------ . . . . . . ... . .. . ... .. .. . . ..... .. . . .. . .—z -—
REFERENCE CAPACITY CHART
@
MANITO WOCLHCR.ANE CAPACMES
8... . . ... ... . 8 Model 888 series 1
144,100-LBCOUNTERWEIGHT I
e
BOOM NO. 22E360 DEGREE RATING Open Throat Top
With 4%0 Offset..... - Lif?ctane capacities compiy with ANSI B30.5 requirements and do ncl Machine equipped Mth 28’% kmg fully extended crawiem, 4S treads. 10.3
exceed 75% of static tipping &ad. Capacities based on structural ganby, 30’ mast, ZO-partbmm hc+stline, four 1= boom pendants and
competence denoted by an asterisk ~). 144,1 00-lb upperworks counterweight assembiy.
Weight O( hoisting line and rigging are considered part of load. Where 260’ boom requires remowl of upper boom point. 250’ beam must be rw4s4cno capacity is shown opemtiomis not intended or approw+. over the hunt of bfmked cmwlers if upper bcmrn@nt is attached.
o
Liftcrane Capacities (Thousands of Pounds)
Radius [w
(Feet)
17 386.4*18 366.3* 343.9*
19 348.0” 338.4*20 331 .4* 330.8*
22 302.4” 301.8” 279.7* I24 277.9* 277.3* 271.1* 249-7-26 242.7 242.9 ~243.4 242.0” 228.4*
28 214.5 214.6 214.9 214.7 214.6 208.4”
30 191.9 192.0 192.2 191.9 191.7 191.2
34 158.0 158.1 .158.1 157.6 157.4 156.8 156,3 155.7
38 133.8 133.8 133.7 133.2 132.8 132.2 131.6 131.0 130.3
42 115.7 115.6 115.4 114.8 114.5 113.8 113.2 112.4 111.8 111.1 96.3*
46 101.5 101.4 101.1 100.5 100.1 99.4 98.8 98.0 97.3 96.7 95.7*
50 90.2 90.1 89.7 89.1 I 88.7 87.9 87.3 86.5 85.8 85.1 84.3
60 69.7 69.6 69.2 I 68.5 68.1 67.2 66.6 65.7 65.0 64.2 63.4
70 55.9 55.9 I 55.5 54.8 [ 54.3 53.4 52.8 51.9 51.1 50.3 49.480 45.9 45.6 44.9 44.5 43.6 42.9 42.0 41.2 40.3 39.590 I 38.2 37.5 1 37.1 I 36.2 35.5 34.5 33.7 32.8 32.0
1.00 32.3 31.7 31.3 30.4 29.7 28.7 27.9 27.0 26.2 !44n. I 97 n I -7C E I ‘5.8 25.1 24.1 23.3 22.4
I120
21.5 i
1 I I I 23.1 I ZZ.B I 21.9 21.3 20.3 19.5 18.6 17,7 t13(I 19.6 18.8 18.1 17.1 16.3 15.4 14.5 /
I Ilu I ( I I .GI. u ! LV. u I &--- --- -- -
--- , ! ,
140 16.9 16.1 15:4 14;4 13:6 12:7 11.8 ‘““-150 13.7 13.1 12.1 11.3 10.4 9.5
160 11.6 11.1 10.1 9.3 8.4 7.5170 9.3 8.3 7.6 6.6 5.8 I
}180 I I I I I I 6.8 I 6.0 5.1 I 4.2190 I 5.3 4.6 I
.-
0“”,1 MANITOWOC ENGINEERING CO.
Division of the Manitowoc Company, Inc.P.O. Box 70 + Manitowoc, WI 54221-0070
Telephone: 414-684-6621 + Fax: 414-683-6277
NOTICE: This capacrty chart is for reference use only and mustnot be used for Iift;ng purposes. Regular capacity charts for a
specific c~fle can be purchased from an authorized ManrtowocDistributor.
01995 Manitowocc2. I.. c.— n -777. n P . . .
——-—-- ---- .. .. . -. ... .-- ... ... . . . .. . .. . .... .. . . .. . . .— ...- .-— _
REFERENCE CAPACITY CHART
@-
lMAkViTOWO[LHCRANE CWACmES 8
* Model 888 Seriesla, 1~ COUNTERWEIGHT #
o
BOOM NO. Z:360 DEGREE RATING Light Tapered To
Liftcrane capaciks complywithANSI B30.5 requirements and do nd Machine equipped with 28’ T kmg fully extended cmw+em, 48- lreads.
exceed 75% of statk tipping load. Capcities based on structural 10.3” gantry, 30’ mast. Z-part lmorn hoist line. four 1-3/8- boom pendants..-
com@enc@ denoted by an asterisk ~). and 144,10&tb upperwwks munleweight =s’@mti.
IWeight of hoisting line and rigging are considered part of load. Where no 2B0’ !mxrr requires remowi of upper &mrrr @nt .
caDacitv is shown ooeration is ncd intended or ammved.
Liftctane Capacities (Thousands of Pounds)Boom Lenaths (Feet)
24 265.5* 265.5* I I I26 246.3 246.828 217.9 218.3 218.0 I [--30 195.2 ?95.5 195.1 194.6
32 176.7 176.8 176.4 175.9
34 161.2 161.2 160.8 160.2 159.7
36 148.1 “ 148.1 147.6 147.0 I 146.4 I
I 38 I 136.8 I 136.8 I 136.2 I 135.6 I 135.0 I 134.4 I I 1—,
I 48 I .984 I 98.2 I 97.5 I 96.8 t
1 I I 1 1
) 10; I ““””35.9 I ‘--- I ‘-:35.5 347 i 3;:8
40 127.1 127.0 126.4 125.8 125.2 124.5 123.8 I
42 118.6 118.5 117.9 117.2 116.6 115.9 115.1 !
44 111.1 110.9 110.3 109.6 109.0 108.2 107.5 106.846 104.4 104.2 I 103.5 102.8 102.2 101.4 100.7 99.9 99.3
I-—.— 96.1 95.4 94.6 93.8 93.250 9;:0 92.8 92:; 91.3 90.7 89.9 89.1 88.4 87.7 82.8*60 72.5 72.2 71.5 70.6 70.0 69.1 68.3 67.5 66.8 I 65.9
70 58.8 58.5 57-7 t 56.8 56.2 55.3 54.5 53.6 52,8 51.980 49.0 48.6 47.9 47.0 46.3 45.4 44.6 43.6 42.9 41.990 43 7 &4 ? 40.4 I 396 38.9 37.9 37.1 36.2 35.4 34.4
33.1 32.1 31.3 30.4 29.6 28.6110 31.2 30.8 30.0 I 29.1 28.5 27.5 26.7 25.7 24.9 23.9120 26.9 26.2 25.3 24.7 23.7 22.9 21.9 21.1 20.1130 23.0 22.2 21.5 20.5 19.7 18.7 17.9 16.9140 20.2 19.5 18.8 17.8 17.0 16.0 15.2 14.2150 17.1 16.5 155 t IL7 I 127 I 17a I lla I160 14.5 13.U 1<./ 11. /170 I 12.7 11.7 10.9 9.9
180 10.2 9.4 8.4
190 8.7 8.0 7.0 U.L a.L
200 6.7 5.7 5.0
210 5.6 4.6 1
..- ! ,.. , I ,“. , I ,&. - ! ,,.4
>C a~7 .4 -r 10.9 9.9 I?i=M
] MANITOWOC ENGINEERING CO.Division of the Manitowoc Company, Inc.
P.O. Box 70 + Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
NOTICE: Thtscapactychart is for reference use only and must
not be used for lifting purposes. Regular capacity charts for aspecific Crane can Ix purchased from an authofued [email protected].
@1995 Manitowoc .S21PC F=nrm a.777n h c 7 nc
.. . .. ..- ..... ..- . . . . . . . . ... . . .. ... . .. . . .. . .. . .. .. . . . . _______ ._
. .
0,.-./’
REFERENCE CAPACITY CHART
@
MAMTOWOCLImCRANE CAPACMES
1* Model 888 Series 2.-. .
223,100-u COUNTERWEIGHT I360 DEGREE RATING
Boom No. 22EL
ILiftcmwcqaciti= compiy with ANSI 830.5 requirements and do not Machine equipped Ah 28’ ~ kmg fully extended crawlem. 48” treads. 10
exceed 7’5% of static tipping load. Capacitks based on structural X gantry, W mast, ZO-part twmrn hoist line, four 1-38- boom pendants
competence denoted by an ast~”sk (“). and 179,1 CC-Jb uppeworks and 44,00Wb carbcdy counterweight
Weight of all load block, hooks, weight MIs, slings, hoist lines, etc.,assembly.
beneath boom ~“nt sheaves K considered part of load. Where no capacity Uppr boom point can nd be used on 290’ &m.
is shown operation is not intended or approval.
I Liftcrane Capacities (Thousands of Pounds)1-
Radius I w
(Feet)16 [ 441.0”
18 I 385.3* 385.0*
20 1348.3” 348.0” 347.3*
22 [ 317.6* 317.3” 316.6” 309.9’
24 291.6* 291.3* 290.6” 289.5”
26 269.3* 269.0- 268.3” 267.3” 266.5* I28 250.0” 249.7” 249.0” 248.0” 247.2* 228.4-30 233.1* 232.8” 232.2* 231.2” 230.4” Z?3.4* 198.8*34 199.2 199.7 200.2 200.3 200.3 200.1 191.3* 167.8” 147.3”
38 168.7 169.1 169.5 169.4 169.4 169.1 168.8 162.2* 144.1” 121.2* 142 145.7 146.1 146.4 146.3 146.2 145.9 145.5 145.0 139.8” 120.5° 99.7” 82.5”
46 127.9 128.2 128.5 128.3 128.2 127.8 127.4 126.9 126.3 119.8” 99.1” 81.9* 75.1 *
50 113.6 113.9 114.1 113.9 113.8 113.3 112.9 112.3 111.8 111.1 98.4* 81.4” 74.5”
60 87.7 88.0 88.2 88.0 87.8 87.3 86.8 86.1 85.5 84.8 84.2 79.5* 71.5”
70 70.3 70.7 70.9 70.7 70.5 69.9 69.4 68.7 68.1 67.3 66.6 65.8 65.4
80 58.1 58.5 58.3 58.1 57.4 57.0 I 56.2 55.6 54.8 54.0 53.2 52.8
90 49.2 48.9 48.8 48.1 47.6 46.8 46.2 45.3 44.6 43.7 43.4
100 41.7 41.6 41.5 40.8 40.3 39.5 38.9 38.0 37.3 36.4 36.0
110 35.8 35.6 35.0 34.5 33.7 33.0 32.2 31.4 30.5 30.1
i 20 30.8 30.8 30.2 29.7 28.9 28.2 27.4 26.6 25.7 25.3
i 30 26.8 26.2 25.7 24.9 24.2 23.3 22.6 21.7 21.3
140 23.3 22.8 .1 22.3 21.5 20.8 19.9 19,2 18.3 17.9
150 19.8 19.4 18.6 17.9 17.0 16.3 15.3 15.0
160 17.2 16.8 16.0 15.’4 14.5 13.7 12.8 12.4
170 I 14.6 13.8 13.2 12.3 11.5 10.6 10.2180 I I 11 R 117 10.3 9.6 ‘t 8.6 8.2\ , 1
. ..- . ..-
190 10.0 9.4 8.6 7.8 6.9 6.5
200 7.9 7,0 I 6.2 5.3 4,9210 6,4 5,6 4.8
220 I I t 4.2
. .
J MANITOWOC ENGINEERING CO.Division of the Manifowoc Company, Inc.P.O. Box 70 ● Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
01996 Manitowoc
NOTICE: This capacrty chart is for reference use only and must
nOt be used for lifting purposes. Regular capacty charts for a
specific Crone can be purchased from an authorized ManrtcrvwcDistributor.
-.—
... . . . . . . . . . ---- . ... .. . . . . .. . . -—— .% .
(lb‘!
--
REFERENCE CAPA CITY CHARTLImCRANE CAPACITIES
223, 1(30-m COUNTERWEIGHT. . .
@
MANITO WOLI* Model 888 Series 1
tBoom No. 22EL
OVER FRONT OF BLOCKED CRAWLERRATINGLiftcra;e capacities compty with ANSI B30.5 requirements and do not fb4achineequipped with 28’ T long fulfy extended cinders, 4& treaas.exceed 75% of static tipping load. Capacities based on structural lo’4-garrtry,30’mast,20-partboomholstline,four I-?.la -boomcompeknce denoted by an asterisk (“). pendants and 179,1 00-lb uppeworks and 44,0004b cartx.dy
Weigh! of all load blocks, hmks, weight balls, slings, hoist lines, &c.,munterwght assembly.
beneath boom point skves is considered part of load. Where no CSpScity Upper krcrrn~”nt cannot beusedon290’kOorn.is shown oprmtion is not intended or approved.
Q
Liftcrane Capacities (Thousands of Pounds)Radius i Boom Lenoths (Feet)
P-pp..——.—— -..
Feet) I :1 II I .1 .1 ;f II * JI .1 ;1 .1
16 441.0”
---- ----- ! , , !
nn C* ‘ ‘79.5”:67.3” 266.5*.,” m* -’7 -“ 228.4*
223.4* ] 198.8” I I I I Ian. .* I .4nA 6* I .4 L.70*1 *<75*
L18 1385.3* 385.0” \ I I I I20 I 348.3* 348.0? I 347.3* [22 317:6” 317.3” 346 ~“ I ~~~ ~“ I I I24 291.6* 291.3* 2SU.U La26 269.3* 269.0” 268.3” 2’28 250.0” 249:7* 249.0” 2+0.u L41 .L I
30 233.1” 232.8* 232.2* 231.2* 230.4”34 204.9” 204.7” 204.1” 203.1” 202.4” Lul. i”” IYI.J I 10/.0 I38
i4f. a
182.4” 182.2* 181.6* 180.7* 179.9” ~78.7* 177.7* ! 162.2* 144.1” 121.2”42 164.0” 163.8* 163.3* 162.3* 161.6* 160.3” 159.4” 156.6* 139.8* 120.5” 99.7* 82.5”46 148.6” 148.5” 147.9* 147.0” 146.3” 145.1* 144.1” 142.7” 135.3* 119.8* 99.1* 81 .9* 75.1”
50 135.6* 135.5* 135.0” 134,1* 133.4” 132.1* 131.2* 129.8” 128.7* 116.8* 98.4* 81.4” 74.5”60 108.7 109.1 109.4 109.0” 108.3* 107.1* 106.2” 104.8” 103.8” 102.4” 94.3” 79.5” 71.5”70 75.3* 87.4 87.7 87.6 87.4 86.9 86.5 85.8 85.2 84.3 , - ___80 I 65.2* 72.4 72.2 72.1 71.5 71.1 70.4 69.8 69.0 68.3 I 67;6 I90 61.0
63:7* I60.8 60.7 60.1 59.6 58.9 58.3 I 57.5 I 56.8 56.0 55.6 i
I* I 83.2* i 74.7” 67.5*
[ “-- l---- !---!100- 49.0= I 52.0 I 51.9 I 51.3 I 50.8 I 50.0 ! 49.4 ! 48.6 I 47.9 I 47.0 46.7 i
---I -.. —-- . .
140 27.0” I 29.6 ii
A- 150 25.8* 25., I 4
I 160 I I I I I 19.5* I 22.7 I 2170 I 18.9* I 1
I+#H==44.9 44.8 44.2 43.7 I 43.0 42.3 41.5 40.8 39.9 39.636.1* 39.0 38.5 38.0 37.2 36.6 35.7 35.0 34.1 33.8
34.2 337 33.2 32.4 31.8 30.9 30.2 29.3 28.91
3.2 28.4 27.7 26.9 26.1 25.2 24.9:7 ?4.9 24.3 23.4 22.7 21.8 21.4
!1.9 21.3 20.4 19.7 18.7 18.49.3 18.7 17.8 17.0 16.1 15.7
L
180 16.7* 16.3 15.5 14.7 13.8 13.4190 12.8” 14.3 13.4 12.7 11.7 11 .2*200 11 .2* 11.5 10.8 9.7* 9.1*210 8.0” 8.9* 9.1* 7.8” 7.2”220 6.2* 6.8* 6.0” 5.3”225 4.9* 5.6* 5.2* 4.2” J
1 230 I 1 1 I I I 4.4* I 4.4* I I
~ MANITOWOC ENGINEERING CO.Division of the .Manitowoc Company, Inc.P.O. Box 70 +Manitowoc, WI 54221-0070
Telephone: 414-684-8621 + Fax: 414-683-6277
NOTICE: This capacity chart is for referenceuseonlyand mustnot be used for lifting purposes. Regular capacity charts fw aspeafic crane can be purchased from an authorizti ManrlowocDistributor
@l 996 Manitowoc c- l-- ----- ------- - ----
. .. . . . .. . . . . --- ., ---- .. . .-. .-. . . .. . . . .-.-.-t- ------------ ---—
.-.
REFERENCE CAPACITY CHART MANITOVVC)[LIFTCRANEJIB CwAcmEs - - -—.. .. ...
e
I Model 888 Series :No. 134 JIB -5 DEGREE OFFSET
IBoom No. 22EI
223, 100+s COUNTERWEIGHTe
360 DEGREE RATING
Liftcranecapad- complyvdhANSI B30.5 requir~ts and do not MacMe equipped with 28’7 longfuityextendedcmvkm, W beads. lCf
exceed 75% of static fippir!q load. Capadies based on structural 4“gantry,30’ mast.20-partboomhoisfreeving, four 138- boom
competence denoted by an asterisk ~). pendants. 12’ 6_jib strut. 179,11304b upp%wwks and 44,000-Ib carb@
Weight of all load blocks, hooks, wighf balls, siings, hokt lines, etc.,counterwdght assemblies.
kneath boom and jib pint sheaves is considered part of jib load. Whereno capacity is shown opemfion is not intended or approved. .
30 Foot #f 34 Jib -5° @ffsr’CL
Liftcrane Jib Capacities (Thousands of Pounds)
Radius ~
f Qn
I m n* I WI 0“ I 59.0” I 59.087. r “-. ., I I
----
50 I 59.0” I iii” I 59.0* I i 59-0” I 59.09 1 I
Uw
An
59.0” 59.0” I 59.0” I 59.0”, _—.—ii) 58.1* 59.0” 59.0” 59.09 59.0” 59.0” 59.0” 59.0” 59:0” I 59.0” 56.5”
70 56.1* 57.0* -58.7* 59.0” 59.0” 59.0” t 59.0” 59.0” 59.0” 59.0” 55.?80 54.5* 55.4* 57.0” 58.5* 59.0” 58.4 57.5 “56.8 55.9 55.1 54.790 52.1 51.9 51.2 50.6 49.7 49.0 48.1 47.4 46.4 45.6 45.2
100 44.9 44.6 .43.9 43.3 42.4 41.7 40.8 40.0 39.1 38.3 37.8
110 39.0 38.8 38.0 37.5 36.6 35.9 34.9
120 i 33.9 33.2 32.7 31.8 31.1 30.11 WI 79’2 I 28.7 27.8 27.1 26.1 25.3 [-- ‘-24.4- 23:5- ‘[““ 23.o14U La. u I C4..J 24.4 23.7 22.7 21.9 21.0 20.1 19.6
150 22.3 21.5 20.8 19.8 19.0 I 18.1 17.2 I 16:7iFwl I 19.8 18.9 I
I, ““ I I I ---- , ——. .
., .-) -c a I -c 9
I 34.2 I 33.2 I 32.4 I 31.929.3 28.4 27.6 27.1
18.2 I 17.3 I -16.5 I 15.5 i 14.7 I 14.21– 14:3- ‘1 13.3 I 12.4 I 11.9
.3 10.5 10.0
,-” I
170 16.7 I 16.0 15.1
180 I 14,7 d4.o 13.1 12.3 11
190 j I 12.3 11.3 10.6 9.6 I 8.7 8.2 I
200 t I 10.7 9.8 9.0 8.0 7.2 6.6 I
210 8.3 7.6 6.6 I 5.7 5.2 J220 7.0 6.3 5.3 4.5 I230 5.1 4.1 I240 I 4.0
_.
-.
*Y MANITOWOC ENGfNEERING CO.
u Division of the Manitowoc Company, hc.
NOTICE: This capacity chart is for reference use only and must
notbeused for lifting purposes. Regular capady charts for aspecifc crane can be purcha- from an authorized fdanftowcc
P.O. Box 70 + Manitowoc, WI 54221-0070 Dtibutor.
Telephone: 414-684-6621 + Fax: 414-683-6277
@31996Manitowoc Pm 1 of 6 ~a,,.-t—-_m- . . . . - ----
. ...- . . . ..... --------- -.--.-— -——.- ---
REFERENCE CAPACITY CHARTLIFTcRANE JIBCAPACMES
No. 1M JIB -5 DEGREE OFFSET
223, ~~ COUIW3?WEIGHTxx) IW-WFF RATfN(Z
MAIWTO WOC.—.
@
1 Model 888 Series 218 Boom No. 2
m—--— ------ .- .,...-
Liftcrane. capacities comply ”withANSI B30.5 requirements and do nd Machine quipped with 28’7 long fultyextended crwlers, W treads, 10exceed 75% of static tipping load. Capacities based M struchmil 4- gantry,30’ mast,20-partborn hoistreeving,four I-WY boomcompetence denoted by an asterisk ~). pendants, 12 F jib strut. 179,10Wb uppewmrks and 44,0004 cartmdy
Weight of all load bkks, hooks, weight balls, slings, hoist fines, etc.,countenveight assemblies.
beneath boom and jib point sheaves is considered part of jib foad. Whereno capacity is shown operation is not intended or approved.
40 Foot#134 Jib 5° Offset
Liftcrane Jib Capacities (Thousands of Pounds)Radius /(Feet)
13U I w.{ ZY. Y i
140 26.5 2___ L
150 23.5 22.9 LfLu
160 20,4 19.5
Luu I 1 I I,. & I I “.” I ---
210 9.7 8:; I 8.0 7.0 6‘220 1 ., 7.5 6.7 I 5.7 4 .- , . . .
230 6.3 5.5 4.69An 1 I AA I I 1
.-
MANITOWC)C ENGINEERING CO.Division of the Manitowoc Company, Inc.
aNOTICE: This capacity chart is for reference use oniy and mustnot be used for titling purposes. Regular capacity charts for asmcik crane can be purchased from an authorized Mamtowx L
P.O. Box 70 + Manitowoc, WI 54221-0070 Dkrixlor.Tel?phone: 414-684-6621 + Fax: 414-683-6277
C11996 Manitowoc Page 2 of 6 Sales Form R-7814-A 2-19-96
e.),
L ..”
REFERENCE CAPACITY CHART
@
MAfWTOVVOcLIFTCRANEJIBCAPACITIES * Model 888 Series :No. 1M JIE -5 DEGREEOFFSET
. . . 9Boom No. 22E:
223,1 (IOW COUNTERWEIGHT#
360 DEGREE RATING
Liftctan=capacities cwn@y with ANSI B30.5 rqhrnents and do not Machirw quippd with 28’ ~ bng fuItyCXWICIedIXIWIHS,a- trews,Ioexceed75% of static tipping load. Capacities based on structural 4“ ganby, 30’ mast, 20-part boom hoist reeving, four I-W& bcmrn
competence denoted by an asterisk (-). pendants, 12 F jib stnt, 179,1 CO-lbUfIfEW@6and44,DOBlb cart)ody
Weght of all load blocks, hookq weight balls, slings, heist lines, efc.,countefwight assemblii.
beneath boom and jib poht sheaves is considered parl of jib load. Whereno capacity is shown operzrfionis not intended or approved.
50 Foot#134 Jib 5° 0j7setI w.ran. ?ih ~aoac~es {Thousands of pounds)
[a-,, .-,-,,- “.- .
22.5 I 21.7 I 20.8 1 19.9 I 19.0 I 18.1 I
120 I . 26.9* I 28.7- 31.7* 32,130 1“ 24.8* 26.4* 29.8* 29.8 28.8 I 28.1 I 27.1 I 26.3 I 25.3 1 24.5140 24.6* 27.0 26.4 25.4 24.7 23.7 I 22.9 21.9 21.1 I150 24.1 23.4 ““- i ‘“- ‘ ‘--160 21.5 20.9 19.9 I 19.2 18.2 17.4 16.4 I 15.5 1170 18.6 17.7 17.0 16.0 15.2 14.2 13.3180 16.6 I 15.7 15.0 14.0 13.2 12.2 / 11.3 4190 13.9 13.2 1’m.. I i 499 I 44G 4
1L.& I I [.-? i W.-r I
4.JU IL. - I 11. u I 10.6 9.8 8.8 ;:;
210 10.2 9.2 8.4 7.4 6.5
220 I 8.8 I 7.9 7.1 6.1 5.27w-1 I I 6.7 5.9 4.9 4.1
I
--- I 1 1 r ,
240 I I I 5.6 / ‘:-48 I I.-)Ac I ( I i At! I
a’t MANITOVVOC ENGINEERING CO.,’ Division of the Man<owoc Company, Inc.
P.O. Box 70 +Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
NOTICE: This capacity chart is for reference USQonly and mudnot be used for lifting purposes. Regular capacity charts for aspecific crane can be purchased from an authorized ManitowocDistributor.
CM996 Manitowoc Page 3 of 6 Sales Form R-7814.A 2-19-96
----- .-.
REFERENCE CAPACITY CHARTLJ17CRANEJIBCAPACMES ; :No. 134 JIB-5 DEGREE OFFSET223, 100+B COUNTERWEIGHT @
MANITO WOCo Model 888 Series 2*
1 Boom No. 2a
360 DEGREE RATING—
tiftcrane capacitka comply with ANSI E330.5 requirements and do not Machine equipped with 28’ T bng MY extemded crawkrs, W treads, 10’exceed 75% of static tipping Imd. Capacities based on structural 4- ganb=y, 30’ mast, X)-part twom hoist reeving, four 138- bin-ncompetence denoted by an asterisk ~). pendants, 12 t7 jib strut, 179,10@lb uppervmrks and 44,00Wb carbcdy
Weight of all load blocks, hooks, weight balls, slings, hoist lines, etc.,counterweight assemblies.
beneath boom and jib point sheaves is considered part of jib load. Whereno capacity “mshown operation is not intended or approved.
1
60 Foot #i 34 Jib 5° ~Sf2(f
LiftcraneJib Capacities(Thousandsof PoundsRadius I Boom Lenoths (Feet)
I 35 I 36.1● t 36.4* i I I I I I t }c
40 I 35:1* 35:s’ 36.1● I I I I50 33.3* 33.8” 34.5* 35.1” 35.7* 36.1*
~ 60 1 31.7* 32.2* 33.1* 33.8* 34.4* 34.9* 35.4* 35.8* 36.2* 36.5*70 30.2” 30.8” 31.8” 32.5* 33.2’ 33.8* 34.3* 34.8* 35.2* 35.6*80 28.7* 29.3* 30.4” 31,4” 32.1* 32.8* 33.3* 33.8* 34.3* 34.7*90 27.4* 28.1* 29.2* 30.2” 31.1* 31.8* 32.4* 32.9* 33.4* 33.9*100 26.3* 26.9* 28.1* 29.1* 30.0’ 30.8* 31.5* 32.1* 32.6* 33.1*110 25.3* 25.9* 27.0” 28.1* i 29.0” 29.8* 30.6” 31.3” 31.8* 32.3”
I.-
S ---- ! —.. — I —-. .1
---- 1 ---- ! ----1 ---- 1 ---- 1 —.- 1 ----
4 cn I 4?’I 0* --l -I* .-!* 0 I -.-1 n .-I* 4 I -4 d I mn .l I .+nm am .
Ifv Iv. d 1 a.w Iu. ) lJ. d Iv. - 14.% I -.9 Id. u
180 17.0 16.1 15.3‘%
14.3 13.5 12.5 11.6190 15.2 14.3 13.5 12.5 11.7 10.7 9.8-nn 497 4*n 44 n 4n 4 n4 09
1 Luu I lL, r I 14. U 11. u lU, I I
210 11.2 10.5 9.5 8.7 ;:; ;:;220 9.2 8.2 7.4 6.4 5.5230 8.0 7.0 6,2 5.2 4.3240 I 5.9 5.1 4.1250 I 4.9 4.1 t
MANITOWOC ENGINEERING CO.Division of Me Manifowuc Company, Inc.P.O. Box 70 +Manitowoc, WI 54221-0070
Telephone: 414-684 -662~ + Fax: 414-683-6277
NOTICE: This capacity chart is for reference usa only and mustnot be used for lifting purposes. Regular capacrty charts for aspeClfK crane can be purchased from an authorized Manifcwm.c
‘L
Dls&ibutIx.
@l 996 Manitzwoc Page 4 of 6 Sales Form R-7814-A 2-19-96
.. . . ---- . ...-. . . . .. . . ..... . . ..... . .... .... . . . . ... . . . ... . .. ------- .—.
*)
REFERENCE CAPACITY CHART
&
MANm3wc)cLIHCRANE h CAPACMES I Model 888 Series 2No. 134JIB-5 DEGREEOFFSET
IBoom No. 22EL
223, 100-LB COUNTERWEIGHT1
360 DEGREE RATING
Liftcraneiapaciti= wmply with ANSI B30.5 requirements and do IK4 Machine equipped with 28’ ~ long futly extended crawi-, 48- treads, 10“
exceed 75% of static tipping bad. Capacitii based on structural #gan~,Wm~,*fimMtiW,fwl~*
competence denoted by an asterisk ~). ~dants, 1Z F jib strut, 179,1@Wb upperwxks and 44,0CWb carkdy
Weight of all load blocks, hcdcs, weight half% slings, hoist lines, etc.,counterweight assemblies.
I ben=th Mom and jib point sheaves is considered part of jib load. Whereno caoacitv is showm ooeration is not intended or approved.
70 Foot #134Jib 5° OffsetI v
Liftcnane Jib Capacities {Thousands of Pounds) 1
1 190 I I I I 15.8 I 14.8 I 14.0 I 13.0 1
J.U I 9.1 i 8.1 I 7.2,7 7.9 6.8 5.9
200 I 14.2 13.2 12.4 11.4 I210 11.8 11.0 lcn220 10.4 9.7 8.I230 8.5 7.5240 7.4 6.4 5:6 I 4.6 I?50 5.4 4.6 I
6.7 I 5.7 4.8 I
t—.. ,260 I I I I I I 4.5 I t I I
9 MANITOWOC ENGINEERING CO.) Division of the hfanifowoc Company, Inc.
P.O. Box 70 +Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
NOTICE: This capacity chart is for reference use only and mustnot be used for lifting purposes. Regular capacity charts for a
spcsific crane =n be purchasrd from an authorized ManitwocDistributor.
@l 996 Manitowoc Page 5 of 6 Sales Form R-7814-A 2-19-96—
—---- .-. ..
REFERENCE CAPACITY CHART
R
MANITO W(3CbFrCRANE JIBCAPACITIES # Model 888 Series 2No. 134 JIB -5 DEGREE OFFSET I
Boom No. 22223, 100+s COUNTERWEIGHT :
Im
360 DEGREE FWmm2~ -
/
Liftcrane ca&&ties compiy with ANSI B30.5 requirements and do not Machine equipped with Z&~ long fultyextended crawlers, 48- treads, 10’exceed 75% of static tipping load. Capacities based on structural 4- gantry, 30’ mast, Z&fmrt fxwm hoist reewng, four I-W& boomcompetence denoted by an asterisk ~), pendank, 12’& jib strut, 179,1004b upperwwks and 44, CC0-lb carbody
Weight of all load blocks, hmks, w“ght bails, slings, hoist lines, etc..counterweight assembks.
beneath &mm and jib point sheaves is considered part of jib load. Whereno capacity is show operation is not intended or approved.
80 Foot#134 Jib 5“ Offsetv
Liftcrane Capacities (Thousands of Pounds)Radius I(Feet)
40 20.7” 20.8”50 20.4” 20.5” I 20.6” 20.7” 20.88 I 20.9*60 20.1” 20 2* 20.3” 20.5” 20.6” 20.7* 20.79 20.8* ?0 9*
I, —-.. r ---- , ---- 1 ---- , —--- , —-. . , —-. . 1 —---
1 ---- 1
7n I 4n0* 4r’in* I on 4* -In ** 1 .7n ** 1 ~n C* I -m C* w-i e* On -7* I -n 7* i
19.2’ i
I =.3 I Lu. I [
19.6* 19.8*
LU.L
70 O* t%H-1 J ---- 1
---- 1 ---- 1 -“, ,[
l-%-l- 18.3’47C* l-4%-+-%4-19.8*4C12* M%4-
Lu. iJ I Lu. a I Lu.o A). 1 fu. I
20.2’ 20.4” 20.4” 20.5* 20,6”20.0’ 20.2” 20.3” 20.4” 20.4”400* I m iw I 9n4* -m 7* [ m 7*
1 Uv It, d tr. ~ I IU. I 1=.0 I 12.1 #=.s I &u. Ll &u. & &u..&
1?0 16.6* 17.7* 17.9* 18,6” d9.2* 19.7* 19.8” ;:;” 20.0” 20.1”
120 15.9* ~ 16.3” 17.2* 17.9* 18.5” 19.1” 19.6” 19.8* 19.9- 19.9”
730 15.1- 15.6* 16.5- 17.3* 17.9* 18.5” 19.0” 19.5* 19.7* 19.8*
140 14.5* 15.0* 15.8* 16.6” 17.3* 17.9” 18.5* 19.0” 19.4” 19.6”
150 13.9* 44.4* 15.2* ‘16.0* 16.7* 17.4* 17.9* 18.5” 18.9” 19.2*
160 13.4* 13.8* 14.7* 15.5” I 16.2* 16.8* 17.4* 18.0” 17.2 16.8
170 13.3* 14.1* 14.9* 15.7* 16.3* 16.9 I 16.0 I 15.0 14.6
MANITOWOC ENGINEERING CO.Division of the Manitowoc Company, inc.P.O. Box 70 + Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
‘. -
1 1 ---- .—. - , . ..—
GO 10.7 9.9 8.9 8.0 7.0 6.6230 I 9,5 8.7 7.7 6.8 5.8 5.4240 7.6 6.6 5.8 4.7 4.3250 6.6 5.6 I 4.8260 I I I 4.7 I t
NOTICE: TM capacity chart is for reference use only and must –not be used for lifting purposes. Regular capacity charts for aspecific crane can be purchased from an authorized Manrtovmc \
Distibutof.
CM 996 Manitowoc Page 6 of 6 Sales Form R-7814-A 2-19-96
. . . . ... .. .. . . ... . . . .. .----- ..... ... . ------- .... . . ... --’- ..~. ——-- —---
. . REFERENCE CAPA CiTY WART MAIWTO WOCLIFTCRANE CAPACITIES —..
H
4 Model 888 Series 2
9
223, f 00-LBCOUNTERWEIGHT8
BOOM NO. 22E360 DEGREE RATING
I
Open Throat ToP
Liftcrane capacities comply wth ANSI B30.5 requirements and do not MacMe quipped with 28” T long fuify eklend~ Cra*, W treads..4.- exceed 75% of statictipping load. Capacities based on structural 10.3’ gantry, 20’ mast, ZO-part bcom hoist line, four 1-WY bcom pendan=
competence denoted by an asterisk (.). and 179,1 (M-fb uppemwks and 44.000-fb carbcdy counteiweght
Weight of hoisting line and rigging are considered part of bad. Where noassembly.
caoacitv is shown ooeration is not intended or armroved. 2S0 boom rquires removal of upper boom point.
Liftcrane Capacities (Thousands of Pounds)Radius I 4 Boom Lengths (Feet) /
15 460.0-16 434.6*17 41O.8* 41O.1*18 389.3* 388.7*19 370.0” 369.3* 364.0”20 352.4* 351 .8* 350.6”22 321 .6* 321.0” 319.8” 305.9”
5* ] 270.0- ] 260.3 *-I I I I I I I. . ----- I A,--. I A--n. I I
. I -. ”.. , ,“T. - 1 I I 1 1 I
c “fi79’1 190.8*1 168.0* Ir dO.4n i4e E #*14.400* I I 1 t I
70 72.4 72.3 71.9 71.2 70.8 69.9 I 69.2 68.3 67.580 60.0 I 59.7 59.0 58.6 57.7 57.0 56.1 55.3 54.4 I 53.6 I 52.6 I 52.290 50.5 49.8 49.4 48.5 I 47.8 46.9 46.1 45.2 44.3 43.4 [ 43.0100 I I 43.2 42.74110 I 36.9120 32.1.#lm I
42.3 41.4 40.7 39.7 38.9 38.0 37.2 I 36.2 35.836.5 35.6 34.9 34.0 33.2 32.3 31.4 30.4 30.031.8 30.9 30.2 29.3 28.5 27.5 26.7 25.7 25.3“- . .7 * .-le.mr~ 24.6 23.6 22.8 21.7 21.3 ,I 3U I 1 .41.Y Lf. u LO. J d3.4
140 24.4 23.7 23.0 22.0 ;1.2 20.3 19.4 18.4 18.0150 20.8 20.1 19.2 18.4 17.4 16.6 15.6 15.1160 17.6 16.7 15.9 15.0 14.1 13.1 12.7
170 15.4 14.5 13.7 12.8 11.9 10.9 10.5180 12.6 11.8 10.9 10.0 9.0 8.6190 10.8 10.1 9.2 8.3 7.3 6.9200 8.6 7.6 6.8 5.7 5.3210 7.1 6.2 5.4 4.4220 I 5.0 4.1225 44 i
MANITOWOC ENGINEERING CO.Division of the Manitowoc Company, Inc.
P.O. Box 70 +Manitowoc,WI 54221-0070
NOTICE: TNs capacrty chart is for reference use only and mustnot be used for Iit’fing purposes. Regular capacrty charts for aspeciiic crane can be purchased from an authorized Manitowc
Distributor.
Telephone: 414-684-6621+ Fax: 414-683-6277
. ..-. . . . . . ... . . . . . . . .. .... . . . . .. .... . . ------ .. ..... ..—..
LRCIUNE JIB @PACITIES
@
o Model 888 Series 2No. 123 JIB -10 DEGREE OFFSET
*
e
# BOOM NO. 22E223, 10(MB COUNTERWEIGHT Open Throat Top360 DEGREE RATING
Liftcram-pacities comply with ANSIB30.5rquirements”and do not exceed 75%of static Machine equipped with 28’ T IcOg fulty ex%ended cmw?ers.....4tipping load. Capac&s based on structural qwnpetence derwhxt by an astertsk ~). 4& treads, 103 gantry, 30’ mast, 20-part boom hoist line.
Weght of hoisting line and rigging are considered part of load. Where no capacity is shownkwl-3/&boompe n&mfs12’rY jibstrut, 179,1 C0-ib
uppworks and 44,000-lb carbody camtervwightopetation is not intended or approval assemblies.
)
9
a ..-
L_xQ
iius
* I 40.0● t 40.0*.- -. ‘n 9* I 40.0” I I ! ,,
I 04. J I .2.3.9 I 4L. d I
30.; 30.3 29.3 28.5 27.5 I 26.7 I :
I I I 18.2 I 17.5 I 16.5 15.6 14.7 13.8 13.3_16.2 15.5 14.5 I 13.7 12.7 11.8 11.3
190 13.7 12.7 11.9 11.0 10.1 9.5200 11.2 10.3 9.4 8.5 8.0210 9.7 8.9 8.0 7.1 6.5220 7.6 6.7 5.8 5.2230 6.4 5,5 4.6 4.1240 4.4
40 Foot #123 Jib 10° Offset
(Feet)
40 30.0” 30.0* 30.0- 1 I I I50 30.0” 30.0- -n ‘“ ‘ ‘n ‘“ WI n. -m n. .-
60 30.0” 30.0” 30.0* I 30.70 I 30.0” 30.o* 30.o“ 30.
t
80 I 30.0”90 30.0*1nn I 90 1- =430.0”
30.0”an n+
30.0”3~ .-1.
-Z). o“
au. LJ t d“. ” ! 1 ./”. ”
.O* I x:;”1 ! 1 I
30.0” 30,0” 30,0” 30.0-o* 30.0” 30.0” 30.0” 30.0” 30.0” 30.0”
-130.0- I 30.0” 30.0” 30.0” 30,0” 30.0” 30.o*-fI n. -Yn rw I 2n n. i 30.0’ 30.0’ 30.0” 30,0”
1 .- n* 1 .Ynn. I ‘0.0” I 30.0” I 30,0” 30.0” 30.0”1 Uu La. I I 1 I LJu. u 1 au. u I
110 26.8* [ ;;:;” 30.0* 30.0” 30.0” :;.0” I 30.0” 30.0” 30.0” 30.0”120 24.9” 26.4” 29.1” 30.0’ 30.0” 30.0” 30.0” 30,0° 30.0” 29.5130 I 24.7“ 27.2“ 29.8* 29.9 29.1 28.1 27,3 26.3 25,5
t140 25.6” 27.4 26.5 25.7 24,7 23.8 22.9 22.0150 “ 24.3* 24.5 I 23.5 22,7 21.7 20.9 “- 20.0 19.1160 21.9 21.0 20.2 19.2 18.3 17,4 16,5170 19.6 18.7 17,9 16.9 16.1 15.1 14.3180 16.7 16,0 15.0 14.1 13.2 12.3 1
190 14.2 13,2 12.4 11,4 10.5200 12.6 11.6 10.8 9.a 8,9210 10.2 9.3 8.4 7,5220 I 8.8 8,0 7.1 6,2230 1 I 6,8 5.9 5.0-)An I I C7 1 AO I
) MANITOWOC ENGINEERING CO. NOTICE:This c+acity chart is for reference us only and must not be
Division of the Manitow@c Company, Inc.used for lifting purposes. Regular capacity charts (or a specific crane can
be purchased from an authorized Manitowoc Distributor.
P.O. Box 70 +Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
fi <(-lnr ,9--.:4 -------
-----
LII=TCRANEJIB CAPACITIES
No. 123 JIB -10 DEGREE OFFSET223, 700-IE COUNTERWEIGH
360 DEGREE RATIPJG
@
& I Modei 888 Series 28 BOOM NO. 2
aOpen Throat T
Liftcrane captr%ities cmmpfy with ANSI B30.5 requirements and do not exceed 75% of static MachIne equipped wth 28’ ~ long Mly extended CJZWIers, ‘tipping foad. Capacities based on strucwraI comp.elence denoted by an asterisk (-). 48- beads, 10.3 gantry, 30’ mast, ZO+arl bmm hast line, I
Weight of hoisting line and rigging are considered part of load. where na capacity K shownfourl-3/8_ ba0mpmdants12’G jibsfrut. 179,1 C0-ib ‘
upperwwks and 44.000-lb carbody ccwrterwe!ghtoperation is nof intended or approved., . assemblies.
50 Foot #123 Jib 10° Offset
Boom Lenqths (Feet
4Q I 9n mt , r .1 w ! K LJ u 1 1 1 I t t [ I
) I 20.0” 20.0” 20.0” 20.0” 20.0* I (I m 1 w rv I cm w I 7n rr m-m* 1 cm IV I m m I i [
I 4J.u- 1 L
1 I au I 1=.1 I Lu. u I
u. u I
150Lu. u
I I 20.0” 20. o* I 20.0” 20. o* 20.0” 20.09 20.0” 196160 19.2* 20.0” 20.0” 20,0’ 19.7 18.9 17.9 17.1 i170 19. 9* 19.2 18.4 17.5 16.6 15.7 148?80 18.2 17.2 16.4 15.5 14.6 13.7 12.8190 15.4 14.7 13.7 12.8 11.9 110200 I 13.8 13.1 12.1 11,2 10.3 9.4210 11.6 10.6 1 9.8 8.8 80220 I 1 9.3 8.5 7.5 5.6230 8.1 7,3 6.3 5.5240 6.2 5.2 44250 I .,: 5.1 4.2 1
60 Foot #123 Jib 10” C)ffset
45 I ?0.0 ● I 10.0 * i50 10. O* 10.0- 10.0” 10. o*60 10.O* 10, O* 10.0* 10.0* 10. O* 10.0*70 10.0* 10. O* 10.0” 10. o“ 10. O* I 10.0”80 10.O* 10.0” 10. O* 10.0- 10.0” 10.0- 190 1O.0* 10.0* 1O.O+ I 10- ‘ ‘* ’-- ‘ ““n”
. 100 10.O* 10.0” 10.0” 10.0” 10.0- 10.O* IIll-l lrl n“ i In n* lnm 1 ion” I *(-I r-t” 1 inn”
J,U- 1 lu.u- 1 Iu. u I Iu. u I Iu. u I
I..- ---- . . ..- ,--- ---- ---- .-, - ---- ---- ----
4
1,”- 1 Iu, u I Iu. u I Iu. u I Iu, u I
120 1 10.0” I 10.0* 1o.o- 10.O* I 10.O* 10. o“ 10.0” 10.0” I 10,0” 1 10.0”130 10.0’ 10.0* 10.0* ,o, fi* I 4nn* 1 .,mn* ! “fin. ! .?’lh. 10.0” 100*140 I 10. O* 10.O* 10.0* 10.0” 10.0’ 10,O*” I 100” 10. O* 100* 10.0”150 10.08 10.0” 10. o* 10. O* 10.O* 10,0* 10, O* 10.OO 10,0”160 I 10.O* 4nn* 4nn* 4nn* I AI’!(-)* 40.0* 10,0” 10.0”170 inrv I inn* I 4nn& I +nm i in n* i 4nn* in n. *nn*
I Iu, u I Iu, u I Iu, u \ Iu, u I I
t- , 1 ,“. ” 1 }“. ” t ,“. ” ) ,“. ” 1 ,“. ” 1 ,“. ” 1 ,“. ” I I“CI 4
t180 I I I I 10, O* I 10, O* 10. o* I 10,O* 1 10,0” I 10.OO ! 100”i nn -I t-, n. 4P.F,* I .nn* .n n* ‘4nn* .nn. inn. !
t- 1 au ! I I I Iu. u I Iu. u I Iu. u I tu. u t Iu, u I
I lu.u- [ lu.u- 1 Iu. u I Iu. u I
1
200Iu. u Iu. u
10. O* / 10.0” I 10, O* I 10.0” 100” 97210 1 ---- .,. .-.. .,. ,-,. .n r,. I 9.1 82220
—10.0” J 9.6 8.8 78 69
230 I 8.4 7,6 66 57240 7.3 6.5 55 46250 5.4 45~60 45
MANITOWOC ENGINEERING CO. NOTICE: This capacrty chart is for reference use only and must not ba
Division of the Manitowoc Company, krc. usedfor lifting purpQses. Regular capacity charts for a spedic crone canbe purchased from an authorizd Manitovmc DisMtutor.
P.O. Box 70 +Nlanitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
01995 Manitowoc Page 2 of 2 Sales Form R-7778-A 6-7-q5
,..!---
REFERENCE CAPACITY CHART
“@
MANITO W(2(LIITCRANECAPACITIES o
t Model 888 Series 2223, 100-LE COUNTERWEIGHT 8 BOOM NO. 22=360 DEGREE RATING Light Tapered Tog
—
Liflcrane =pacities mmply with ANSI B30.5 requirements and do not Machine equipped with 28’ Z’ long fully extended crawlers, J$&treads, 10.3’exceed 75% of static tipping load. Capacitii based on structural gantry, W’ mast, ZO-partbmrrnhoist line, four I-Y& boom pendants andcompetence denoted by an asterisk (-). 179,100-lb uppmvorks and 44,0004b carbody counterweight assernbty.
Weight of hoisting line and rigging are considered part of load. Where 310 boom requim+iremoval of uoper boom pint.no capacity is shown operation is not intended or approved.
4 Liftcrane Capacities (Thousands of Pounds)Radius.
: K*
1 (Feet)2426 265.5* 265.2 I I ! I28 256.4* 255.7* 251.6*30 239.6* 238.9- =7.3* 218.7” I I I 1, I , t 1 I 1 I
16 I 771 7 I 714 5*’ I I I i32 M.5 221.. —..- ..... 1 1 I I J34 202.3 202.3 201.9 201.3 189.8* j36 186.0 186.0 185.5 184.9 184.4 I38 172.1 172.0 f71 .5 170.8 170.3 162.6*40 160.0 159.9 159.3 158.7 158.1 157.442
143.3*149.4 149.3 1487 1480 1474 _lA6 7 3AI ~’
44 140.1 139.9 7: 120.1*.—.. ., -._. . . . . . ,_ .,. . . . .
t
39.3 138.6 I 138.0 I 137.2 136.546 i 131.8 I 131.6 I 130.9 130.2 129.6 128.8 128.1 I 119.7* I 100.O* ~ I I I
130 31.2 30.4 29.7 I 28.8 27.9 26.9 26.2 25.1 24.3 23.7140 27.8 27.0 26.4 25.4 24.6 23.6 22.8 21.8 20.9 20.4150 24.1 23.5 22.6 21.8 20.8 20.0 19.0 18.1 17.5160 21.0 20.1 19.3 18.3 17.5 16.5 15.6 15.0170 18.8 17.9 17.1 16.1 15.3 14.3 13.4 12.9180 16.0 15.2 14.2 13.4 12.4 11.5 10.9190 14.2 13.5 12.5 11.7 10.7 9.8 9.22C0 11.9 10.9 10.2 9.1 8.2 7.7210 10.5 9.5 8.8 7.8 6.9 6.3220 8.3 7.5 6.5 5.6 5.1230 7.1 6.4 5.4 4.5240 5.3 4.3250 4.3 I
MANITOWOC ENGINEERING CO.Division of the Manitowoc Company, Inc.P.O. BOX 70 + Manitowoc, WI 54221-0070
Telephone: 414-684-6621 + Fax: 414-683-6277
NOTICE: This capacity chart is for reference use only and mustnot be used for lifting purposes. Regular capacity charts for aSpeCifiC crane can be purchased from an authorized Manfi~Distributor.
@1995 Manitnwnc
Pt?ELIMINAR Y CAPACITY CHART
-m
MANITO WOCLIt=fCRANELUFFING JIB CwAcmEs 9
* Model 888 Series 2LUFFING JIB No. 135 1 Boom No. 22EL223, 100-LE COUNTERWEIGHT 83 Degree Boom Angie360 DEGREE RATING
Liftcrm? capcitks are calculated to be within the scope ofANSI B30.5 requirements Machine quipped with 28’ 2?long fulty extended crawlers, Wand do not exceed 75% of static tippirrgload.Capacities based on structural treads, 104- gantry, 30’ mast, 20-part boom hoist rea@, hwrcompetence denoted by an asterisk ~). 1-MY boom pendants, &part luffing jib hoist reeving,two1-
Weight of all loadblocks,hooks, weght balls, sfings, hoist lines, etc., beneath boomlLT luffing jib pendank, 179,1 004b upperwwks and 44, MD-ii
and luffing jib point sheaves is considered part of Iuftlng jib load. Where no capacity iscarbody counterweight assemblies.
shown ooet%tion is not intended or anornv&t.
70 Foot Boom No. 22Eb at 83 degrees
ina Jib Capacities {Thousands of Pounds)Liftcrane Lufft ..
(Feet)
45 -.. —50 91:8* I 84.0+ 75.8* 69.3”60 88.7” 81.8* 71.5” 66.5* 63.2* 58.2* 44.3”70 “ 77.5* I 75.5* 66.0” 60.9” I 58.6* 53.9* 42.7* 40.2” 37.7* 35.1”80 57.8” 63.8* 61.3* 56.2* 54.1” 49.9* 41.3” 38.9* 36.0” 32.8* 30.2”90 50.0” 54.3* 52.1” 50.2” 46.1* 39.4” 36.0” 33.1* 30.0” 27.5*100 43.3* 46.5* 46.6* 42.7* 36.5* 33.1” 30.3” 27.4* 25.0”110 38.2* 40.5” 39.6* 33.8* 30.6” 27.9* 24.9* 22,7*
7.5* I 14.8” 1
%-l-%-i
100 Foot Boom No. 22EL at 83 degrees
I Radius I Jib Len”aths (Feet)-.— ——..= ... —..-— ., .
50
60 ‘---87.5” i;:;* “‘“-*! ! ,
72.0 66.3” 61.2* 56.0” ..
70 80.0 77.6* 67.6” 62.6* 59.7* 54.8* 42.2* 39.7* 37.2*80 67.8 67.6 62.9* 57.8* 55.5* 50.9” 40.9” 38.5* 36.1* 33.5* 30.8”90 58.4 58.3 53.6* 51.5* 47.3* 39.8* 36.9* 33.9* 30.8” 28.3*100 50.5” 50.0” 48.1* 43.9* 37.5* 34.1* 31.2* 28.2* 25.8*110 44.1” 44.5* 40.8” 34,8* 31.5” 28.7* 25.8* 23,5*120 38.9* 38.1” 32.4” 29.1* 26.4” 23.6” 21.3”130 33.5* 29.7* 27.0” 24.2* .21.4* 18.5*140 26.7* 24.6* 21.2* 18.6* 15.8*150 21.9* 18.6” 16.0- 13.4*160 16.4* 13.7* 11.3*170 11 .5* 9.5*180 I 7.7*
MANITOWOC ENGINEERING CO.Division of the Manitowoc Company, inc.
P.O. Box 70 +Manitowoc, WI 54221-0070Telephone: 414-684-6621 + Fax: 414-683-6277
@ 1996 Ivlanitowoc - ‘ Paae
NOTICE: This capacily chart is for reference use only and must
not be used for Iifflng purposes. Regular capac~ charts for a
SpeClfICCLNIe can be purchasal from an authotied Manfi~Distributor.
lof2
.. ..— . .
PRELIMINARY CAPACITY CHART
-m
IUIANITOWOCLFTCRANE LUFFINGJIBCAPACtTfES t
# Model888 Series2LUFFINGJIBNo. 135 # Boom No. 22E223, 100-LB COUNTERWEIGHT. 83 Degree Boom Angl360 DEGREE RATING
B—
Liftcrane @pacitles are calculated to be within the scope of ANSI 830.5 requirements---
Machine quipped ~ 28’% bng fully extended crawlem, Wand do not exceed 75% of static tipping bad. Capacities based on structural treads, 10’.$ gantrf, W mast, 20-part tmorn hoist reeving, fourcompetence denoted by an asterisk ~). l~& bcorn pendants, &part Iuf’ringjib hoist reeving, two 1-
Weight of all load blocks, hcoks, w“ght balls, slings, hoist lines, etc., beneathboomlr2” luffing jib pendants,179,100-fb uppermrks and44@O04bcarbodycourrteweight assemblks.
and luffing jib ~“nt sheaves is considered part of Iufringjib load. Where nompacity isshownooerationis notintendedor amroved. .
180 Foot Boom No. 22ELat~3 degrees
Liftcrane Luf7ing Jib capacities (Thousands of Pounds)
Radius [ Jib Lengths (Feet
{Feet)
65 71 .6* 66.1” I 60.5” I 55.9* 44.8* I I I70 71.6” 66.1” 60.5” 55.9” 44.1● 41.7*80 64.6 64.3 60.5’ 55.9* 42.9* 40.7” 38.3* 35.9* 33.7*90 55.8 55.6 55.4 55.1 41.8* 39.7” 37.5” 35.2* 32.9* 30.6” 26.5”100 48.7 48.6 48.3 40.7” 38.8” 36.7” 34.4* 32,2* 29.8* 24.6”110 43.2 42.9 39.7* 37.9* 36.0” 33.6* 30.7” 27.7” 22.7*
}120 37.5” 36.9* 36.0” 34.7* 31.3* I 28.5* 25.6* 20.8”..lfi I } -m** I -. ** *“m* lam-* I“fit-. l”fi -. ‘-.9*
.4*tI Ju I I I I I &&>- 1 S1. o”” I 3 I .L- 1 LY.d- 1 O-m.Lr- 1 L3.0- f “1U
,. 140 28.0” 27.7* 27.1* 24.5” 21.6* i 16
I 19.1* / 14.2”. . . . -- -j* I
\150 24:5* I 24:2* 21 .8*
‘ 160 21 .5* 19.1* lo.a- Iz.170 I 16.8* 14.2* 10.%180 i I 12.1* 8.7” q –190 I I I I 1’ I I I I 1 I 7.2*200 6.0” 1
/
200 Foot Boom No. 22EL at 83 degrees
Liftcrane Luffina Jib Capacities (Thousands of Pounds] [
70 67.0” I 61.6* 56.7” 44.8” 42.7* I I80 63.2* 61.5” 56.7* 43.5” 41 ,6* 39.4” 37.1* 34.8*
90 55.2 55.0 53.5* 42.2* 40.6” 38.5* 36.3* 34.1* 31.9* 29.7* 26.6*100 48.4 48.2 47.3* 41.1* 39.6* 37.7* I 35.6* 33.4” 31.3- 29.1* 24.8*
?7.9* 22.9”?Cn* 04 -*
MANITOWOC ENGINEERING CO. NOTICE: This capacity chart is for reference usc only and must
Division of the Manitowoc Company, /nc.not be used for lifting purposes. Regular capacity charts for aspecific crane can be purchased from an authorized Manitowcc
P.O. Box 70 + Manitowoc, WI 54221-0070 Distributor.
Telephone: 414-684-6621 + Fax: 414-683-6277
01996 Manitowoc Page 2 of 2 Sales Form 16822-14-96
.. . .. . . .. . . . . . . . .... . . . ... . . . .. . ., .>-.... ~.—.
PRELIMINARY CAPACITY CHARTLIHCRANE LUFFINGJIB CAPAcmEs
*
LUFFINGJIBNo. 135223,1 00-LB COUNTERWEIGHT360 DEGREER.Antw
,
IWANITO WOCModel 888 Series 2
. Boom No. 22EL60Degree Boom Angie
—
Lifkmne capacitks are calculated to be within the scope of ANSI B30.5 “ Machine equip@ vfith2B’Zbng fulfyextended crawAem,4&requirements and do nd exceed 75% of static tipping load. Capacities txmect on trewb, lo’4-9rtry,3Crrnast,20-partboom hoist reeving, fourl -Structural competence danoted by an asterisk r). 3/& bmmpendan@ @artluffing jibhoistreeving, hw l-1/7
Weight of all load Mocks, hooks, w“ght balls, slings, hoist lines, etc., beneath boomluffing jib pedants, 179,1004b qy)mwks and 4400@3-lb
and luffing jib ~“nt sheaves is considered part of luffing jib ioad. Where rw capacity_ cwrrtehf assemblii.
is shown operation is not intended or approved.
70 Foot Boom No. 22* at 60 degrnn=
Liftcrane Luffing Jib Capacities (Thousands of Pounds)Radi[us I Jib Lenahts fFeet)
I‘i----i~,
Feet t :1 “1 II I I t .1 I .1 1
90 51.7 I100 45.3 45.0.-.-1 4A1 40.0 39.8 39.4 “ I
35.7 35.6 35.3 35.3Ilu WI. I
120130 32.1 31.9 31.9 I 31.5 31.3140 28.8 28.9 28.6 28.4 28.1150 26.4 26.1 25.9 25.6160 I I 23.9 23.8 23.4170 I I 21.8 21.5 19.2* 16.6* 14.09 ,180 19.8 16.9” 14.3* 11.8* I190 14.9* 12.0” 9.9- I200 I 10.09 8.2- 1210 6.5*
, 100 Foot Boom No. 22EL at 60 degrees
Liftcmne Lui7ing Jib Capacities (Thousands of Pounds)Radius I Jib Lengths (Feet) I(Feet)
105 38.9110 36.7 I120 32.9 32.5 32.3130 29.3 29.1 28.8140 26.4 26.1 26.1 25.7 “150 23.7 23.8 23.4 23.2160 21.8 21.4 21.2 20.8 20.7170 19.7 19.5 19.1 19.0 18.7180 17.9 17.6 17.5 17.2 15.3”190 16.2 16.2 15.6” 13.0*200 14.9 -13.4” 10.9*210 11.2* 9.1*220 7.4*225 6.6*
eMANITOWOC ENGINEERING CO. NOTICE: Thii capacity chart is for reference use only and must
Division of the hfanitowoc Company, Inc. not be used for lifting purposes. Regular capacrty charts for a
P.O. Box 70 +Manitowoc, WI 54221-0070specific uane can be purchased from an authorized ManitowccD&ibutor.
Telephone: 414-684-6621” + Fax: 414-683-6277
@ 1996 tdanitowo-c- --
PRELM4[NARY CAPACiTY CHARTLIHCIUiNE LUFFINGJIBCAPACITIES
LUFFING JIB No. 135..
223, 100-LB COUNTERWEIGHT360 DEGREE RATING
@
MANITO WOC*9 Model 888 Series 2
9 Boom No. 22EL60 Degree Boom Angie a
Itiftcmne capacities are calculated to be within the scope of ANSI B3U.5 Machine I?C/Ul~ wth 2B’ ~ long Mty @den&i wmdem., 4&
requirements and do not sxceed 75% of static tipping load. Capacities based on treads, t0’4- gantry, X’ mast, ZO-part boom hoist reewng, four 1-
structural competence denoted by an ast~”sk ~). 3W boom pxxfants, 8-part lufiing jib hoist reeving, tw 1-1~
IWeight of all load blocks, hooks, weight balls, slings, hoist lines, etc., beneath boomluffing jib perrdank, 179,100-lb up&fwwks and &V3004b
and luffing jib point sheavea is considered part of luffing jib load. Where no capacity~ti mntenwight assemblk%
I] is shcwm operation is not intended or approved. I
180 Foot Boom No. 22EL at+60 degrees
Liftcrane Luffing Jib Capacities (Thousands of Pounds)
Radius I
145 17.2150 16.3 1.160 14.8 14.4 14.2170 13.1 12.9 12.5
180 11.8 11.4 11.4 10.9i 90 10.3 10.4 10.0 9.7200 9.5 9.1 8.8 8.4 8.3210 8.3 8.0 7.6 7.5 7.1220 7.3 6.9 6.9 6.4 6.2230 6.3 6.2 5.8 5.6240 5.6 5.2 5.0250 I 4.7 4.5260 4.0
200 Foot Boom No. 22EL at 60 degreesLiftcrane Luffing Jib Capacities (Thousands of Pounds)
Radius I
155 13.9160 13.3 I I I I i I I t170 12.0 11.6 11.4180 10.6 10.3 9.9190 9.4 9.0 9.0 8,5200 8.1 8.2 7.7 ;.. 1 I !210 7.4 7.0 6.7 6.3 6.2 1220 I 6.3 6.1 5.7 5.6 5.1230 5.5 5.1 5.0 4.6240 4.5 4.5 4.1250 I I I 4.0
----- mMANITOWOC ENGINEERING CO. NOTICE: This capacity chart is for reference u= only and must
Division of the Manitowoc Company, Inc.not be used for lifting purposes. Regular capacity charis for a
P.O. Box 70 + Manitowoc, WI 54221-0070specific crane can be Wrchased from an authorized ManitovmcDistributor.
Telephone: 414-684-6621 + Fax: 414-683-6277
G 1996 Manitowoc Page 2 of 2 Sales FonTI 16852-14-96
160,000 PSI YIELD STRENGSTRAPS. BOOM SUSPENSIONAND BACKHITCH
TI
16 PARTS OF 1.00 ?N.=—--- .- .—- --—..
/-/// 1.25 IN. LOAD HOIST-
.
r
1./l1. 125’ iN:-RoPE”oPT.(SINGLE 13RuM REEVING) 7
~
i/
!2;FT. 49A MAST /(FACT CONNECTEO)
a.
AL-J t 1 . ur>a i b
425 FT. MAXIFIWI275 FT. SI-IOWN
_.
1,395.100 LEE, COUNTEF?WEIGI+T
(as SIDE BOXES)867,100 LBS. CIIUNTER14EIGHT
(14 SIDE BOXES)
.8
.
;
1
/ ‘1/ \
// \/ \
“.wv*—
s.-
1=
.—10.0s.%
k?m
<35 7
-Ith
9
.
PRELIMINARY CAPACITY CHARTLIFTCFWEBOOM CAPACITIESBOOM hJo.67B1,059,000-L8AUXILIARYCOUNTERWEIGHT
MAAVTOWOC
@
# Model 888 RINGER#9 Boom No B
a
.360DEGREE RIlmNGUftcrane capacities are caludated 10 compiy with ANSI 630.5 requirements and do Ringerequippedwith 45 diameter ring, 120 No. 49A mast.
not exceed 75% of statictippingload. Capacities based on structuralmnrpetenca 16-partboom hoistline, four 1-W4- boompendants anddenoted by an asterisk (“). l,059,0004b auxiliarycountemveightassembly. 888
Weight of all load blocks, hooks, weight balls, slings, hoist lines, etc.,equipped wfth 28’ ~ long crawfers, 48” treads, 10’4“ gantry.
‘neath - 30 mast, 20-part mast reeving, four I-W& mast selkrectingpointsheaves is consideredpartof load. Where no capacity is shownoperationis pendants,O-1bcrane and O-lbcarbodycounterweightnot intended or approvti. assemblies.
Radius:)
1.0*
I* I 1139.1* I 1029.7”/ I-. I 4~n?.4* ] qo26.9* I 917.6*
cY*l.4rin-YE*[ nn7 C* 7n?.9* 697.9*Q* cnn t-w cnn C* cci7 n* I
(Feet:4(I I 17QL_45 I 1173.C50 lo91.ff - IUU55 1021.O* 1011.0 Iuuo.a I Yul. a I YL
60 958.4* 949.6” 941 .6* I 896.1” 783.u I U~U.Z I UU3.d I &J I .V I I I
70 807,5 804,4 802,8t 800,6 765,8*I676.6*I598,6’I528.6*~460.4”I386.0*I324.4’II
97A 4 “! 80---1–667.9I 6~.9 I 663.1i 660.9i 658.6!655.9I587.3*I519.5*I460.4”‘1386.0”I324.4”/
!.9 I 490.0 I 488.0 I 485.7 I 4
I
.- 1 vu I r &&”. ” -,
190 201.3” 2LU.4 &u200 I 191.5 18-. # t ,“u.”210 178.9 176.6 174.0220 I 165.3 162.7230 155.0 152.5 149.’240 143.2 14” ‘250 134.6 13Z.I ILY.:260 I 126.7 124.2 121.5 I 10270 117.0 114.3 111.0 IUc).o IUC).i I 102.7280 110.3 107.6 104.9 102.0 99.1 96.1290 101.5 98.8 95.9 93.0 90.0300 95.7 93.0 90.1 87.3 84.3310 90.2 87.7 84.8 82.0 79.0320 82.6 79.8 77,0 74.0330 77.9 75.1 72.3 69.4340 I 1 70,7-’ 67.9 65.0350 I 66.5 63.8 60.9360 1 59.9 57.0370 56.2 53.3380 52.6 49.8390 46.5400 43.3
..
MANITOWOC ENGINEERING CO.Division of the Manitowoc Company, he.P.O. Box 70 +Manitowoc, Wl 54221-0070
Telephone: 414-684-6621 + Fax: 414-683-6277
—NOTICE: This capacity chart is for referenca use only andmust not be used for MtIng purposes. Regular capacitycharts for a specitic crane can be purchased from an authorizedManitowoc Distributor.
@1996Manitowm ... . .... . . Sales Fmm 171fI I-O QC CtI
- .“--
.
PRELIMINARY CAPACITY CHARTLImCRANEBOOMCwAcmEsBOOMNo. 67B1,323,000-LB AUXILIARYCOUNTERWEIGHT
MAIWOWOC
B
I Model 888 RINGER*# Boom No. 67B
360 D;GREE RATINGLiftcrane rx+pacifiis am =Iculated to amply with ANSI B30.5 requirements and do Ringer equipped with 45’ diameter ring, 120 No. 49A mast,
not exceed 75°% of static tipping load. Capacities based on structural competence Ifj-part boom hoist line, four 1-3/4” boom pendants and
denoted by an asterisk (“). 1,323,000-lb auxilia~ counteriveght assembly. 888
Weght of all load blocks, hooks. weght balls, slings, hoist lines, etc., beneath boomequipped with 28’2- long cravdem, 48” treads, 10’4- gantry.
30’ mast. 20-part mast reeving, four 1-W& mast setf-erectingpoint sheaves is considered part of load. Where no capacity is shown operation is pendants, O-fbcrane and O-lb carbody counterweightnot intended or approved. assemblies.
I Liftcrane Capacities{
Y r., I
MANITOWOC ENGINEERING CO.Division of the Manitowoc Company, Inc.P.O. Box 70 + Manitowoc, WI 54221-0070
NOTICE: This capacity ”chad is for reference use only andmust not be used for lifting purposes. Regular capacity
charts for a specific crane can be purchased from an authorizedManitowoc Distributor.
Telephone: 414-684-6621 + Fax 414-683-6277
m------
,
. .
—120C
1000
. .
800
. .
600
400
200
0
888 Ringer Capacity Comparis&.
. .
*
\
I -+- 888 Ringer 1,323K Ctwt 150’ Bm
++ Kobelco 7450 Special Super HeavyliftI
~ Demag CC2600 Superiift 250t ctwt
Liebherr LR 1550 Superlift 250t CM SLDB I-1 +41 OOW Ringer 368K Aux Ctwt
I + M-250 MAX-ER 225
+ .,
\
\ ,,
\
\
‘Y
-1
\
20 40 60 80 100 120 140 160
Radius (ft)
Comparative information is for reference use only and is
subject to change. Celected manufacturer should be
888 Ringer Capacity Comparisons
.
. .
. .
e ...
100
—
90(
80(
70C
60’0
500
400
300
200
100
0
0
2oo’.8oom
.
.
I+ 1
~ 888 Ringer 1,323K Clwt
1,
u Kobelco 7450 Special Super Heavyiift
~ Demag CC2600 Superlift 250t d’wl
Liebhem LR 1550 Sqxwlift 25Ct ctwt
+41 OOVVRinger 368K Aux Ctwt
~ M-250 MAX-ER 225I
II
--l-u
50 100
Ratius (Ft)
150 200
Comparative information is for reference use only and is
subject to change. Selected manufacturer should beCCC1712.XLS 200’ Boom consulted for current and accurate data.
250
1/17/96 SJJ
888 Ringer Capacity Comparisons
. .
“,
5C
45
40,
35(
30[
250
200
150
100
50
~.
5!
o
300’ Boom
~ ,
\’+888Ringer 1,323K CM
+ Kobelco 7450 Spea”al Super Heavylift
i Ii + Demag CC2600 Sup-lift 250t M
—
50
-+’-+\I \\
100 150
I
I
_-
8
I1- * -1? !,,, !,,
300200 250 350
Radius (Feet)
Comparative information is for reference use onlyand is subject to change. ” Selected manufacturer should be
CCC1712,.XLS-300’ Boo-m- - “---: C“ons.utte”dfor cutieni a-ridaI%I&tP Ada -- .,. -J,..--..
,.
.. 888 Ringer300
Capacity400’Boom
Comparison
I ~ 888 Ringer 1,323K CM1.
— + Kobelco 7450 Special Super Heavyiifl275-
250-
225I
200
175--
150
1oo- ,
,75- -
50
25
,1.
0,
0 50 100 150 200 250 300 350 400 450
Radius (Feet)
Comparative inforrnaiion is for reference use onlyand is subject to change. Selected manufacturer should be
CCC1712XLS 400’ Boom ““
