Upload
nazareno-roca
View
216
Download
0
Embed Size (px)
Citation preview
8/17/2019 LG-857 Grasa Lithium.pdf
http://slidepdf.com/reader/full/lg-857-grasa-lithiumpdf 1/2
NA – Not Applicable
MATERIAL SAFETY DATA SHEET
ADDRESS:
3580 Blackthorn Court
South Bend, IN 46628
PRODUCT NAME
ABRO Lithium Grease LG-857Code No.
60,099-2Emergency Phone Number(s)
Business: (574)232-8289
Fax #: (574)232-8295 CHEMICAL NAME (All Grades)
Lubricating Grease
Date Sent:
5/08 P R O D
U C T
I D E N T I F
I C A T I O
SYNONYMS
Multi-Purpose GreaseChemical Family
Hydrocarbon
MATERIALS OR COMPONENTS %W CAS NUMBER CARCINOGEOSHA OR IAR
Lithium 12 Hydroxystearate 3-12 7620-77-1 No
Mineral Oil 45-55 64742-65-0 No
Zinc Alkyldithiophosphate 1-2 68649-42-3 No
Mineral Oil 40-45 64742-62-7 No I N G R E D I E N T S
S H I P P I N
G
I N F O R M A T I O N
Not Restricted
Boiling Point/Range
C 700 F Melting Point
C 350 F Freezing Point
C 0 F Molecular weight (Calculated)
NASpecific Gravity (H2O=1)
0.89 @ / 16 C Vapor Pressure (mm Hg)
NA C FVapor Density (Air=1)
NASolubility in H2O
Nil% Volatiles by Volume
0Evaporation Rate
NA Either = 1 Water = 1 Butyl acetate =1 P
H Y S I C A L
P R O P E R T I E S
Appearance and Odor Amber Semi-Solid-Bland
Other
Flash Point Test Method
C 440 F D-92
Flammable Limits
Lower NA % Upper %
Aut oignit ion Temperatur e/Fire Poi nt
C 490 EXTINGUISHING MEDIA
Water- Water- Water- Dry Alcoho l Foam Earth orspray fog stream CO2 chemical foam sand
SPECIAL FIRE FIGHTING PROCEDURES Do not enter Allow fire Water may Do not use
Building to burn cause frothing water
F I R E A N D
E X P L O S I O
N
D A T A
UNUSUAL FIRE AND EXPLOSION HAZARDSDust explosion Sensitiver
Hazard to shoc k Contaminati on Temperature (Specify): None
STABILITY
Stable Unstable
CONDITIONS CONTRIBUTING TO INSTABILITY
Thermal Photo Polymerization Contaminationdecomposition degradation
INCOMPATIBILITY – Avoid contact with
Strong Strong Strong Other Aci ds Alkal is Oxidizers (Specify):
HAZARDOUS DECOMPOSITION PRODUCTS – THERMAL AND OTHER (list)
CO & CO2 IF INCOMPLETE COMBUSTION. R E A C T I
V I T Y D A T A
CONDITIONS TO AVOIDHeat Open Igniti on Other Flames Sparks sources (specify):
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED
Keep upw indFlush with Absorb with sand Neutralize Sweep or scoop Evacuate enclosed Prevent Spre
Water or inert material up and remove spaces. or spill
Dispose of OtherImmediately (specify)
S P I L L O R
L E A K
WASTE DISPOSAL METHOD – Consult federal, state, or local authorities for proper disposal procedures.
ALL DISPOSALS MUST COMPLY WITHFEDERAL, STATE AND LOCAL REGULATIONS. CONTINUED ON
NEXT PAGE
X X X X X
X
X
X X
X
X
8/17/2019 LG-857 Grasa Lithium.pdf
http://slidepdf.com/reader/full/lg-857-grasa-lithiumpdf 2/2
Before using product, read and follow directions and precautions on product label and bulletins. 60099-2
CONDITIONS TO AVOID
None KnownPRIMARY ROUTES OF ENTRY
INHALATION SKIN CONTACT OTHER (Specif y)
This product has been used for years with no k nown ill effects. It contains no know n carcinogens or mut agens as defined by OSHA or IARC.
T O X I C I T Y
I N F O R M A T I O N
This product cont ains the following toxic ch emicals subject to the reporting requirements of Section 313of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372):
CAS# Chemical Name Percent by Weight68649-42-3 Zinc Alkyldithiophosphate 1-2
N F P A
R a t i n g
Health 0 NFPA HAZARD RATING CODES Flammabil ity 1 Least 0 High 3Reactivity 0 Slight 1 Extreme 4Protective Equipment B Moderate 2
PERMISSIBLE EXPOSURE LIMIT (Specify if TLV/TWA or Ceiling [c])
ACGIH 2008 5mg/m 3 For Mineral Oil OSHA 2008
I N F O R M A T I O N
IRRITATION Skin Severe Moderate Mild (Transient)
Eye Severe Moderate Mild (Transient)
CORROSITIVITY Skin 4 hrs. (DOT) 24 hrs (CPSC)
Eye May cause blindness Not Corrosive
SENSITIZATION
Skin Respirator y None
INHALATION EFFECTS
Narcotic Cyanosis Asphyxianteffect
LUNG EFFECTS (Specify):
NA
E f f e c t s o f E x p o s u r e
OTHER (Specify):
Repeated contact - Otherskin defatter (Specify
NA
INGESTION DO NOTInduce induc e Give plenty Get medical Other
vomiting vomiting of water attention (Specify):
DERMAL ContaminatedFlush with soap Get medical clothing- Contaminated Other
and water attentio n remove & launder shoes – destroy (Specify)EYE CONTACTFlush with plenty of water for Get medical Otherat least 15 minut es attentio n (Specify):
H E A L T H
H A Z A R D
E m e r g e n c y
F i r s t A i d
INHALATION If not breathingRemove to give artific ial Give Get medical Otherfresh air respiration oxygen attention (Specify): NA
VENTILATION REQUIREMENTS - Always m aint ain exposur e below per mis sib le exposu re li mit s
Consult an industrial hygienist Local exhaust Use with adequate Check for air contaminationor environmental health specialist ventilation and oxygen deficiency
Other (Specify):
EYE FaceShield
Safetyglasses Goggles
HAND (GLOVE TYPE) Butyl Polyvin yl OtherRubber alcohol (Specify):
Polyvinylchlo ride Neoprene Natural rubber Polyethyl ene
RESPIRATOR TYPE – Use only NIOSH / MESA approved equipmentSelf- Supplied Can or cartrid ge Filter-dus t, Othercontained air gas or vapor fume, mist (Specify):
NA
S P E C I A L P R O T E C T I O N
I N F O R M A T I O N
OTHER PROTECTIVE EQUIPMENT
Rubber Apron Otherboots (specify): None
PRECAUTIONARY NOTES Wash Thorough ly Do not get in eyes, Do not breathe Keep contain er Keep away from
after handling or on clothing dust, vapor, mist, gas closed sparks, and store in tightlyopen flames closed containe
Do not store near Keep from contact with Empty container Use explosionCombustibles clothing and other may contain proof Other
combustible materials hazardous residues equipment (Specify): S P E C I A L
P R E C A U T I O N S
Other handling and storage conditions
Normal Precautions Common To Good Manufacturing Practices Should Be FollowedPrepared by Date
SKS 5/08
Add ress
3580 Blackthorn Court South Bend, IN 46628
Phone
(574)232-8289
“The above information is accurate to the best of our knowledge. However, since data, safety standards and government regulations are subject to ch ange and the conditions of handling and
use, o r mi suse are beyond our contr ol, AB RO Indust ries MAKES NO WARRANTY, EITHER EXPRESS OR IMPLIED, WITH RESPECT TO THE COMPLETENESS OR CONTINUING ACCURACY OFTHE INFORMATION CONTAINED HEREIN AND DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. User shoul d satis fy him self t hat he has all cu rrent d ata relevant to h is part icular u se.”
X
X
X X
X
X
PLEASE
X X
X
X X
X X
X X
X
X X X X
X Nitrile
X