LD/LL PARTS MANUAL

LD/LL PARTS MANUAL

Manual Part Number 31 393 .. 002 J-\Kri\.~u.i..A I·E.u,Ll)AUER & tURKLIFT. LD~50

LL-40

LULL:

WARNING: Read and observe all warnings on the unit before operating it. Do not operate this equipment unless all factory installed guard and shields are properly secure in place.

For Models: Lull - LD SO/LL40

ISSUED JUNE 1985 Mahto - LD SO/LL40 Prime-Mover - LD50/LL40

'.,. ); TS":ASS'EMBLY S······A·ND·PAR ' .. :. i <DEC.Ab,' ;'FIG URE .. #,1

.1 3~_O

4

2

PRIM~DVER 5

6

7

10

8

LD/LL P-6 JUNE 1985

)It ,

),

)

~,....

:.6:·~~'TI·~~t ·::~:~~~~~:~~t~"·:})t!;0.~~'· '" ' :" ~.; i: J.U.

t , PART , NAME

1 1 52-212-3 Stripping 1 2 B -049993 94 4qCJo ~-ofDecal, Prim e-Mover 1 1 1 1 1 1 1 1 1 1 1 1 1

I

3 :~

5 6 6 6 6 6 6 7 8 9

10

~ ::... . . ~". .. ~. :.

',"

JUNE 1985

B-31128-01 B,-, ~~ 11 ~ 8·-:::: A--30832 52-210 52-214 52-215 52-211 52-213 52-224 A 21253 D-30519 D-30527 D-30518

Decal, LD-50 Decal, LL-40 Decal, caution Paint, gold Can, spray gold Paint, black Paint, burnt orange C8n) sprC'cY burnt orange Can, spray black Decal , warning Decal, left side Decal, LL-40 right side Decal , LD-50 right side

Assy. Unit

As Req'd ~ '-\LJ " 2 2 2 2

As Req'd As Req'd As Req'd As Req'd As Req'd As Req'd

1 1 1 1

LD/LL P-7

FIGURE: i2,; PAIRT:S:, LIST; A:N,D SB'RVIClr<RE'FRR'~NC'E'{mDBX . ,. ..-,.i

)

)

'\ j

LD/LL P-8 JUNE 1985

FIG ~:'i lTt.lmlx1 ,:, J:';l:'r/~('} F'I( .. '~· T, pIt:&;,· setJie(e'~~' ,t. ",(,", I }4f"" PART #''-,>' <:,J," NAME' # Page Reference

2 1 Decal and parts assembly 1 6 2 Part list and service reference index 2 8

'\ 2 2 Shielding Assembly 3 12 } 2 A-30928 Liquid cooled engine cab heater 4 14

2 Heater unit 5 16 2 3 0-30810 Cab ass em bly 6 18 2 3 Rear window ass em bly 7 20 2 4 A-30812 Pressurizer ass em bly 8 22 '2 " ";'1 lIl~hj,.:;;;~",: a:..~;;;eri; ~ly 3 24 v

2 3 Cab side ass em bly 10 26 2 3 Upper door assembly 11 28 2 3 Lower door ass em bly 12 30 2 5 Over head guard 13 32 2 6 Dash assembly 14 34 2 7 Fertilizer protection package 15 36 2 8 ..4>eere 31640 diesel engine installation 16 38 2 8 Deere engine installation 17 40 2 8 ~eutz 3FL912 diesel engine installation 18 42 2 8 Deutz engine installation 19 44 2 8 Deutz engine alternator installation 20 46 2 8 <-Continental TM27 gas engine installation 21 48 2 8 Continental engine installation 22 50 2 9 0-30741 Air cleaner ass em bly (gasoline) 23 52 2 9 A-31067 Air cleaner assembly (diesel ) 23 52 2 10 Fuel tank ass em bly 24 54 2 A-14824 Diesel starting aid (ether injection) assembly 25 56 2 11 Battery support ass em bly 26 58 2 12 Seat mounting ass em bly 27 60

) 2 Valve control shield:;' and guards 28 62 ; 2 13 Foot pedal control ass em bly 29 64

2 Choke and fuel shut off control assembly 30 66 2 3rd and 4th spool control assembly 31 68 2 Valve control assembly 32 70 2 Throttle control assembly 33 72 2 14 Steering control column ass em bly 34 74 2 15 Single caliper brake pedal control assy. 35 76 2 15 Double caliper brake pedal control assy. 36 78 2 15 A-31097 Master cylinder assembly 37 80 2 15 B-31179 Single cylinder brake caliper assembly 38 82 2 15 B-31088 Double caliper brake pedal control assy. 39 84 2 15 Single cylinder brake caliper hand brake

lever control ass em bly 40 86 2 15 Double cylinder brake caliper hand brake 2 lever control ass em bly 41 88 2 Transmission shaft control assel1\bly 42 90 2 Drive train assembly 43 92 2 16 W heel ass em bly 44 94 35000-00 2 17 C-30060 Axle assembly 45 96 2 18 C-30014 Front axle drive shaft assembly 46 98 2 19 Transmission cover and adapter assembly 47 100 2 19 Transmission input shaft assembly 48 102 2 19 Transmission idler shaft ass em bly 49 104 2 19 Transmission output shaft assembly 50 106

) 2 20 A-30016 Rear axle drive shaft ass em bly 51 108 2 Cradle installation assembly 52 110 2 21 Deere wiring ass em bly schematic 53 113 2 21 Deutz wiring assembly schematic 54 114

JUNE 1985 LD/LL P-9

~ r"'; ii, __

':"~FIG~ ITEM .. Fig • Service # # PART # NAME # Page Reference

2 21 Continental wiring ass em bly schematic 55 115 - \ 2 21 Deere wiring harness assembly 56 116 J 2 21 D eutz wiring harness ass em bly 57 118 2 21 Continental wiring harness assembly 58 120 2 21 Working and tail lights 59 122 2 21 Power component wiring 60 124 2 22 LL- 40 hydraulic control s~h em R tl C 61 1.26 2 22 LO-50 hydraulic control schematic 62 127 2 22 Hydraulic power schematic 63 128 2 22 Hydraulic schematic symbols 64 129 2 22 Reservoir ass em bly 65 130 2 22 B-30305 Filter assembly 66 132 2 22 Hydraulic pump and motor hose assembly 67 134 2 22 A-30976 Hydraulic pump assembly part #1 68 136 2 22 A-30976 Hydraulic pump ass em bly part # 2 69 138 2 22 Neutral control assembly 70 140 2 22 A-30001 Hydraulic motor ass em bly 71 142 30000-01 2 22 Pump and reservoir assembly 72 144 2 22 D-30318 Steering control valve assembly 73 146 2 22 D-30927 Hydraulic pump ass em bly 74 148 30310-11 2 22 Steering cylinder and hose assembly 75 150 2 22 D-30343-01 Steering cylinder assembly 76 152 2 22 LL-40 valve and reservoir assembly 77 154 2 22 D-30689 LL-40 control valve assembly 78 156 2 22 LD-50 valve and reservoir assembly 79 158 2 22 B-30353 LD-50 Hydraulic control valve 80 160 2 22 Inlet cover assembly 81 162 -,.

2 22 Boom valve assembly 82 164 J 2 22 Bucket valve assembly 83 166 2 22 A-30504 Optional valve assembly 84 168 2 22 Pump and cooler assembly 85 170 2 22 Bucket cylinder and hose assembly 86 172 2 22 C-30334-01 Loader bucket cylinder assembly 87 174 2 22 Loader boom lift cylinder &. hose assy. 88 176 2 22 C-30333 Loader boom lift cylinder ass em bly 89 178 2 22 Mast tilt cylinder and hose assembly 90 180 2 22 C-30333 Mast tilt cylinder ass em bly 91 182 2 22 Hydraulic system for grapple bucket 92 184 2 22 D-30343-02 Grapple bucket cylinder ass em bly 93 186 2 2 &: 3 stage mast lift cylinder &: hose assy. 94 188 2 22 0-30603 Cylinder ass em bly 95 190 2 22 Full free lift 3 stage mast cylinders

hose assembly 96 192 2 22 D-28150-20 3 stage freelift cylinder ass em bly 97 194 2 22 0-28131-02 3 stage staging cylinder ass em bly 98 196 2 23 Boom ass em bly 99 198 2 23 2 stage mast assembly 100 200 2 23 Lift fram e ass em bly 101 202 2 23 2 stage inner column assembly 102 204 2 23 2 stage outer column assembly 103 206 2 23 3 stage mast ass em bly 104 208 2 23 3 stage outer column ass em bly 105 210 2 23 3 stage intermediate column assembly 106 212 -)~ 2 23 3 stage inner column ass em bly 107 214 2 23 3 stage full free lift mast ass em bly 108 216 2 23 3 stage full free lift outer column assy. 109 218

LD/LL P-10 JUNE 1985

;> •• -",~""""" .... -.,,,- •• --:~.

FIG. ITEM # # PART #

2 23

~t· 2 23 2 23 2 24 2 25 2 25

2

)

JUNE 1985

NAME -~. /' :;~. :r~' ;'1~(.} :' Fig f':7:r~::"i"'\'1~~/;~·Se'rvlce

# Page Reference

3 stage full free lift intermediate· column assembly

3 stage full free lift inner column assy. 3 stage free lift cylinder ass em bly Frame assembly LD-50 attachment assembly Loader fork attachment

Grapple fork assembly

"

',-' .

110 111 112 113 114 115 l.i0

117

220 222 224 226 228 230 ~J~

234

. LD/LL P-l1

~~~()C)~.~ '3l :;l-"ll-O 0

)

)


FI G.~~' ]rf EMi} if·~i~ '#r¥dt:_i('~;' <,

# # PART # NAME Assy. Unit

3 1 C-31089 Mat, floor 1 -, 3 2 D-30358 Panel, top 1

~

) 3 3 A-30409-02 Cover 2 3 4 A-30402 Latch 2 3 5 A-30401 Spring 2 3 6 P-11261-05 Nut As Req'd 3 7 C-30403-02 Hood, Deere 1 Deere ~ 7 c-"nJn~-n3 q"'t"'\d. n o,,~ '7 1 De"t7 3 7 C-30403-04 Hood, Continental 1 Coot. 3 8 A-30400 Hinge 2 3 9 P-11016-02 Washer, flat As Req'd 3 10 P-11009-05 Lockwasher As Req'd 3 11 A-14802 Washer As Req'd 3 12 P-11009-06 Lockwasher As Req'd 3 13 P-11261-06 Nut As Req'd 3 14 P-11045-03 Screw, cap As Req'd 3 15 B-30787 Angle 1 3 15 B-30792 Angle 1 Deutz 3 16 P-11143-04 Screw, cap 6 3 17 Frame, rear (see fig. #114) 1 3 18 8-30243 Hinge 2 3 19 A-30465 Fastener 4 3 20 0-30994 Grill 1 3 21 P-11016-01 Washer, flat 8 3 22 P-11009-04 Lockwasher 8 3 23 P-11261-04 Nut 8 3 24 A-30382-01 Prop, telescoping 2

"

-) 3 25 8-30387-01 Door, L.H. 1 3 25 0-30685-01 Door, L.H. 1 Deutz 3 25 8-30387-02 Door, R.H. 1 3 25 0-30685-02 Door, R.H. 1 Deutz 3 26 A-30466 Bracket 4 3 27 P-11176-01 Screw, machine 4 3 28 P-11129-03 Nut 4 3 29 P-11009-03 Lockwasher 4 3 30 C-30713-03 Counterweight, L.H. (weight is 410 100.) 1 LL-40 3 30 C-30713-04 Counterweight, R.H. (weight is 410 100. ) 1 LL-40 3 31 8-30779 Counterweight (weight is 136 100.) 2 LL-40 3 32 P-I1016-04 Washer, flat 8 3 33 P-11009-08 Lockwasher 8 3 34 P-14994-08 Screw, cap 8 3 35 0-30365-04 Panel, L.H. side 1 3 35 0-30365-03 Panel, R.H. side 1 3 36 P-11016-03 Washer, flat 2 3 37 A-30440 Plate 1 3 38 A-31099 Mat, cover 1

JUNE 1985 .~., ~

(of) --__ --, ,..t\ \III.,

)


-FIG. ITEM"'" # # PART # NAME

:'Y~¥,';'i ;

)

JUNE 1985

i·~rr6~;'~:~~"'·>~-::~; ;", -,.

Assy. Unit

As Req'd 2 1 1 1 1 3 4 2 1 2 1 1 1

LD/LL P-15

Fl:GU:RBi'"lSi' H;EA'FER" UNlIT" :fQB'~6'On*U1l58;1

3()q ;;2 t: --0 0

5

LD/LL, ,P-16

1

/ 2

4

)

JUNE 1985

FIG ,IT·EM1··;·'···.:~,; >_. -~ .:.;i;,. ' .. '-. ' ,}. -.~.:~?~_: .. :

f f PART #

5 1 QE-SOO-0858-SS 5 2 QE-SOO-0858-S7

) 5 3 QE-SOO-0858-S1 5 4 QE-SOO-0858-S10 5 5 QE-SOO-0858-S5 5 6 P-11813-04 5 7 NSS 5 8 P-II009-03 ;: 9 P--11129-D3 5 10 NA

:)

JUNE 1985

." ..

NAME

Cover Screw Pan J {)D~~D Motor ?-o ()~g I Coil, heat Grommet Box Washer, flat Nut Relief, strain

1 4 1 1 1 2 1 2 2 1

Unit

LD/LL P-17

9

)


" ~. "

fIG. lii;1f£· " . ~~~:;!. t~,t~·~· ~:.~ .. ~~~ _ ' . ;.J f~;" 'F~~~, f6r: . ..


6 1 Rear panel assembly (see fig. #7) 1 6 2 " QE-1400-8985 Dripedge, right hand 1 6 2 QE-1400-8984 Dripedge, left hand 1 6 3 P-11261-04 Nut As Req'd 6 4 P-I1009-04 Lockwasher As Req'd 6 5 P-11045-03 Screw, cap As Req'd 6 6 Windshield assembly· (see fig. #9) 1 6 7 Right side assembly (see fig. #10 ) 1 6 7 Left side assembly (see. fig .:#10 ) 1 6 8 Right upper door (see fig. #11 ) 1 6 8 Left upper door (see fig. #11 ) 1 6 9 Right lower door (see fig. #12) 1 6 9 Left lower door (see fig. #12) 1 6 10 QE-1400-8993 Bracket ;l.ooq1 f;;, 2 6 11 P-I1016-01. Washer, flat ... " _ .... -"'" ..... ---. '.' . 4

)

)

JUNE. 1985 LD/LL P-19

FIGt1RB.·~;;7: REAR; WINDOW· ASSBMB£Y .. ::H6' ?

LD/LL P-20

)

JUNE 1985.

)

~)

'FIG.';:!ITEM::'f; S;Ji,f ~. " -;. l :

# # PART # NAME

I

7 7 7 7 7 7 7 7 7

1

2 3 4 5 6 7 8 9

JUNE 1985

NA Glass, panel Laminated safety sheet glass (secure this part locally) 52-325 Edge, rubber (J.Q,~.to ut2-~ P-I1045-03 Screw, cap P-II016-01 Washer, flat QE-1400-9005 Cover, blower P~11009-04 Lockwasher P-11261-04 Nut QE-1300-1499 Panel, rear QE-933-0260 Seal

Assy. Unit

1

As Req'd 4 4 1 4 4 1 1

LD/LL P-21

""'FIGURE ··,g;l:'PRESSURlZER ASSBMBDY( A -30812 )

. j'

'. - ~'; {

)

LD/LLP-22 JUNE 1985

'.FIG. ITEM':'<~ - " ~:---p';J~plrj"~t: '''~'')e:r,:;,'''' , .. ,' or # # PART # NAME Assy. Unit

8 1 QE-1300-1508 . Bracket, left hand 1

) 8 2 QE-1300-1509 Bracket, right hand 1 8 3 QE-SOO-1665 Filter 1 8 4 QE-919-0190 Seal 2 8 5 QE-919-0080 Seal 2 8 6 QE-1300-150S Hood 1 8 7 P-11261-04 Nut 8 8 8 P~11009-04 Lockwasher 8 8 9 OE-SOO-1693 Blower 1 8 10 QE-SOO-0656 Grommet 1 8 11 P-11045-03 Screw, cap 8 8 12 QE-SOO-1699 Deflector, air 4 8 13 QE-1300-1499 Panel, rear 1 8 14 QE-SOO-16'9'2 Switch 1 8 15 P-11211-04 Nut, wing 2 8 16 P-11016-01 Washer, flat 2

)

)

JUNE 1985 LD/LL P-23

LD/LL P-24

o .,...

)

)

JUNE 1985

)

FI G ~.; Ia'EMt' .;; '{;~:., ~,it, i:'i6r ;- :;.\ . # # PART ,.- NAME Assy.

9 1 QE-90S":0344 Seal 31810 d 0 ~

9 2 QE-1400-9001 Shim ..., //4-0 00 9 3 QE-SOO-lS90 Motor, wiper ~e0#- :>00, D - 0

9 4 QE-919-0054 Seal 3 /31900 t/ : ~ ~~=i!~~~~~~2 ~e:;~JJd11~ 3 1375'tJtJO 9 7 QE-902-1240 Gasket 9.60~9 3 . 9 8 NA ' Glass, panel 9 Laminated safety sheet glass (secure .this._part loc~y) 9 9 QE-SOO-224 Arm, wiper ~~() t~! 9 10 QE-SOO-lS91 Blade, w~per ?.-6 0 1>'6'1

f

1 2 2 2 1 1 1 2

1

~ ~t~'" UJ\'nd o\ti·eJ& WI'p~r rvto-+or

~crv.... ~ ~ 'r<\.O\J..'\v-\. '( e~ -e. &......>; ~ . --1- +- ~··5 no1- b'0-( If- \ n. .,

• ; • ~ • 'i. ~ .. ; l

J': ".;. L

Unit


1

· ,

20

u

Secure This , Part LocallY'i

FIG. IT EM'>" "I~f~r , r;- :~1f'

" ...,r·. . ~

, . ' . # 4# PART # NAME Assy. Unit

10 1 QE-1300-1504 Side, left hand 1 -) 10 1 QE-1300-1505 Side, right hand 1

10 2 QE-90S-0075 Seal 2 10 3 QE;..90S-020S Seal 2 10 4 QE-SOO-S5S Grommet 4 10 5 QE-600-1S89 Plug, cap 4 10 6 QE-939-0S70 Seal, door 2 10 7 QE-908-0504 Weatherstrip 2 10 8 52-325 Edge, rubber" As Req'd 10 9 QE-90S-0290 Seal 2 10 10 Glass, panel 1 10 Laminated safety sheet glass (secure -this' part locally) 10 11 P-1117S-02 Screw, machine 2 10 12 QE-SOO-04S3 Bumper,:1o o~'1 tj 4 10 13 QE-SOO;;'0283 Spring":).'do~'1~ .... ~ 2 10 14 P-1124S-03 Nut 2 10 15 P-11170-0S Nut . ".-,/

2 ~ ~./ .. I~ •• ·'"

10 16 QE-SOO-0029 Holder, door:/ 2 10 17 'P-11143-04 Screw, cap 2 10 18 QE-90S-0114 Seal 2 10 19 .QE-906-0024 Seal 2 10 20 . QE-90S-019S Seal 2 10 21 QE-90S-0100 Seal 2

)


, :.,

."';,,'

: > .::. t

~)

LD/LL p-2S

'(. '

. If'for "-:L'H.J:.'i.L Ln:1~'"


11 1 Q E ~- 2S - 0 2 - 0 4 -71 Scrt:w RH 100~$;)

4 11 2 QE-600-1247 Latch, 1

) 11 2 QE-600-1246 Latch, LH ~60'69/)- 1 11 3 QE-1300-1501 Door, RH upper 1 11 3 QE-1300-1500 Door, LH upper 1 11 4 QE-902-0786 Gasket, window ~O () g q "- 1 11 5 NA Glass , upper door 1

Laminated saftey sheet glass (secure this part locally)

)


LD/LLo, P-30

:,'. '. ~{' .

5~

4---4

~--6

9

~10 )

)

JUNE 1985

FIG. ITEM,':)'F I·~. , • ~:- ~~ '::'J'?'lor"YJlr ."". ~~~.~} ~ .. :

# It PART i NAME Assy • Unit

12 1 QE-906-0243 . Seal 3 I 3 7 J. () t t 1

') 12 2 QE-25-02-04-71 Screw 4 12 3 QE-600-1247 Latch, RH~(}O'J~3 1 12 3 QE-600-1246 Latch, LH ?-DO s9?- 1 12 4 QE-60-400-12 Pin, cotter 1 12 5 P-11016-02 Washer, flat 1 12 6 QE~908-0232 Weatherstrip B181?J60f 1 12 7 QE-1300-1497 Holdout, door ';100<615" 1 12 8 QE-600-1687 Spring ~ob9~5 1 12 9 QE-1300-1503 Door, RH lower 1 12 9 QE-1300-1502 Door~. LH lower 3/31400"d- 1 12 10 QE-600-1095 Rivet 2 12 11 QE-600-1583 Handle ;;2.0 () g 8<f 1

.~

)


O'FIGURE·~'t13,;OVBR·'BBAD GUARD

.q',. -~,

• _' : . c'" .:'

_. r:, r;'

) .~

~. \ \

J -" .

\.

) \ \

\

LD/~l;··· ~~32 JUNE 1985

)

)

FIG'f ,'ITEM " .~

# # PART #

13 13 13 13 13 13 13 13 13 13 13

13

1 1

* 2 3 4 5 6 7 8 9

10

D~ 0-30109 VTI-7102-74 P-11170-0B P-14994-11 52-5009 C-30106 A-14851-03 C-30099 A-14892-01 NA

* Not shown

JUNE 1985

.,~, "h ~·":A····.~f· "o{'" r .:. ~ A: ".~ . _.".

NAME

R.O.P.S. D.O.H.G. Grommet ;2.0 I tJ 11-Nut Screw, cap Guard Dash (see fig. #14)' Nut, clip Panel Screw ,:cap i~,::~<;:'::~. '". Window,:' (secure thiS"'part locally) 13! x 14 x .25 poJycEirbonate sheet Weatherstripping., ~ ~

Assy.

1 1 8 4 4

As Req'd 1

10 1

10 1

As Req'd

Unit

LD-50 LL-40

LD/LL P-33

FIGUR'E #14 DASH ASSEMBLY

)

)


FIG. ITEM'" ,.!

~ '. ,~; ,,' '/)".1' .-. ".,'~. f.o: ~-i '~":'':. ~'1-~' - , ~.:: f-'r4f ':tc)'r' ~' ... jf~;· ;.! . .r~


14 1 A-14878 Temp, water 1

-) 14 1 NSS Temp, head (secure this part locally) 1 Deutz 14 2 A-14877 Pressure, oil 1 14 3 A-14880 Met.er, volt 1 14 4 B-30842 Tachometer 1 14 4 A-14828 Tachometer 1 Deutz 14 5 P-26204 Hourmeter 1 14 6 A-14881 Fuel, level 1 14 7 A-~~'l~O/E Temp. hydraulic oil 1 14 7 A-~ Q'/5g-o£1-<Jremp. hydraulic.oil 1 Deutz 14 8 P-11306 Screw, drive 4 14 9 NA Nameplate,.LL-40 1 14 10 C-30106 Deash; upper 1 14 11 C-30099 Dash, lower 1 14 12 A-14826 Switch, ether 1 14 13 A-14872 Switch, ignition 1 14 14 A-14874 Switch, light 1 14 15 P-11157-05 Pin, cotter 1 14 16 A-30111 Nut 1 14 17 A-30820 Bumper 1 14 18 A-14868 Flasher 1 14 19 A-14826 Switch, hom 1 14 20 A-30111 .Pin, cover;~~ 1

)

)


t:-t 0 ? t"4

~ I

c,..) 0)

Enter through the back of the Bell housing

7

Power Wire from Light Switch

Either wire from Pulse Generator

(0 <'"\\ ~~ \ (\~~ \\ \.\ \ \~ \~ )

\ ~ ~/ , .... J

Either wire· fr"9m Pulse Generator:

v

a d

fJ .... ""'Ii. CI'I . ~~~

toij t9 ~

~ ~ N tt:2 ~

."

~ ~ tt:2 ()

::i 0 z

5 .J- . > Q ~ .• ,,; >,< 0'-t1j ->. I

W 0 <C W CIO

'""

l:\ !~ .:

.~

i

' .. FiG:~~TrIT £i{ijF~:~~~.? : ~:". :. ! ;". ~ ,~1 . j ~}! f':r -:' '):;,,",.., ... r'~''f;'t~. "'{". 'o, •• c:,.,' r: .. · .. .' ~ .. ~, "J 1 ?~.. •


15 1 A-30935 Al ternator, sealed I . 1 15 2 l\1S5-c&~ \.q Regulator assemb~ ;)..D O~Lf 1 -) 15 3 MS2-26 Capacitor, tlooSlf 1 15 4 A-30934 Bar 1 15 * A-30982 Bushing 4 15 5 A-49947-1 Belt (Deere) 1 15 6 A-30939 Tachometer (Deere). 1 15 7 A-30936 Generator, pulse (Deere) 1 15 8 52-7901-04 Wire, #16 (Deere) 1 15 9 P-15677-2 Clamp (Deere) 1 15 10 A-30937 Cable (Deere) 1 15 * A-49931 Air restrict gauge 1 15 * A-49930 Filter, indicator 1

) . ".

)

JUNE .1985 LD/LL P-37

" "~'FlGURE 'i16':OEERE 31'640 DIESEL ENGINE INSTALL~TION

40

39'i /' ~42~

41/

LD/LL' P-38

I 7

I I f8 9", ~

10~

~~ " ~.

~13 r--r=_~ • I,.!..! ~-:=r. ~ ..

2.:8\/,- '. 31~ r!28~'

30 29 38

)

2

JUNE 1985

-:FIG. 'IT'E~f-· .... '.".'~.""' . .-:. ,,' ... '.

# for # # PART # NAME Assy. Unit

16 1 B-14859-08 Clamp 2

) 16 2 :~'~(;£J=J1t-3c: i ~J-I-L .,~ H(.;(;. ~, air' 1 16 3 A-14858 .... 02 Cap, weather 1 16 4 D-30741 Cleener, air (see fig., #23) 1 10 5 P-11816-01 Plug 2 16 6 A-30906-01 Pipetail 1 16 7 C-30691 Muffler 1 16 8 P-11143-04 Screw J cap 8 16 9 B-14857-03 Clamp 3 16 10 B-30972 Pipe 1 16 11 C-30973 Channel 1 16 12 P-11170-06 Nut 10 16 13 A-30969-01 Tube, flex 1 16 14 C-30846 Hose, upper radiator 1 16 15 B-14859-01 Clamp 4 16 16 C-31018 Hose J lower radiator 1 16 17 Deere engine installation ( see fig. # 1 7 ) 1 16 18 D-31116 Shroud ~

3Ij~3-o0 1

16 19 D-31017 Radiator - ~Q--e. e.. 1 16 20 P-11016-03 Washer J flat 4 16 21 A-14820-01 Spacer 4 16 22 P-11143-08 Screw J cap 4 16 23 B-30450 Bracket, mounting 2 16 24 A-3052g02 Foam, stripping 1 16 25 C-31009-02 Baffle 1 16 26 A-30520-01 Foam, stripping 2 16 27 A-14851-02 Nut, clip 4

"-.. 16 28 P-11016-02 Washer, flat 6 /) 16 29 P-11009-05 Lockwasher 6 16 30 P-11854~04 Screw, cap 6 16 31 P-11170-05 Nut 6 16 32 A-30361 Kit, mounting 2 16 33 A-31016 Cooler, oil 1 16 34 A-31025 Mount 2 16 35 B-31002 Bracket 2 16 36 P-11009-06 Lockwasher 4 16 37 P-14935-02 Washer, flat 2 16 38 C-31009-01 Baffle 1 16 39 P-11016-04 Washer, flat 4 16 40 P-14994-12 Screw, cap 4 16 41 P-11261-08 Nut 2 16 42 P-11009-08 Lock washer 1


P'lFIGURE "'17' "DEERE'· ENGINE INSTAL:G'A TION

---


-)

)

\ ./

FIG. ITEM , # ;for' ~,'-".


17 1 17 2 17 3

t .J. • '1:

17 5 17 6 17 7 J7 7 11 8 17 9 17 lO .Ll .1..1.

17 12 17 13 17 14 17 15 17 16 17 17 17 18 17 19 17 20 17 21 17 22 17 23 17 24 17 25

A-30976 P-14994-06 P-II009-08

- ,,.. .. .c.-.i.J.u.J.u-u4

P-11143-06 P-II009-06 C-30703 (;-30 ~{)n A-3075i-02 P-II016-05 P-1 t!qa :·,-o~

.u-0.llvw-Ul.

B-31188-02 A-30819 P--11261-06 A 3017631 ;)H-oO B-31148-00 A-31147 P-11143-04 B-31151-00 B-30712 P-11170-08

Pump, hydrostatic (see fig. # 69,70,71) Screw, cap Lockwasher i ~ asHe!', rHit Screw, cap Lockwasher Plate, coupling Plo+e 00nr-1ino

Uisc assembly ___ ,~,~-r i

Washer, flat

.c'l.Jle;lc, leI' Jia.nd Angle, right hand Mount, engine Nut Engine, Oeere (see Engine Manual) Adaptor Coupler (Lovejoy) Screw, cap Shaft I."Jf 7/3 [t~1 P-O Collar, coupler I.J (J 11) (),}Il-fID Nut

1 4

12 6

20 32

1 J 1 4

1 1 4 8 1 1 1

12 1 1 2

0-30732 Brack et, mounting 71 1 0-30927 P-14994-08 A-49774

Pump, hydraulic (see fig. Screw, cap Mount, engine

#Q ) ht 7tJtli J./~ 1 2 2

'\\Q_LL.~> ~ '''\CLc:..~~_lJ'C_,_'0 \_..J~c.,-.,;-,-, d rrt \JLo..".Jc. ~ '"'rno-\-o r 'lY'ou.-0s

() tc\~r ho.-u-€.- tf at ~ ~~ {0 0 \ 1- t (T{ 3 I I 4 1 '00 C () Ll P L £ Q..

S C) 0 I 0 ~ ? ~ 1A ~ Y\'I 11

JUNE 1985 LO/LL P-41

FIGURE ,lS'DEUTZ 3FL912 DIESEL ENGINE INSTALLATION

\~

6

)

25

30~ /

29~/

28


)

)

FIG. -:ITEM "; # # PART #

18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 Jq 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18

1 2 3 4 5 6 7 8 9

10 11 12 13 14 15 16 17 , ~ 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

JUNE 1985

A-30906-01 C-30691 B-14857-03 B-30972 P-11143-04 C-30973 P-11170-06 A-30969-02 C-30997 B-14859-08 A-14858-02 C-30739 0-30741 P-11816-01 P-I1016-03 A-14820-01 P-11143-08

A-3uo);G-U2

P-11261-06 A-30666-2 0-30622 A-14851-02 A-30520-01 B-30359 A-30361 P-11143-03 A-14843-01 P-I1016-04 P-14994-12 P-11261-08 P-I1009-08

NAME

Pipe, tail Muffler Clamp Pipe Screw Channel Nut Tube, flex Tube, manifold Clamp Cap, weather Hose, air in take Cleaner, air (see fig. #23) Plug Washer, flat Spacer Screw, cap

Foam, stripping Nut Foam, ring Shroud Nut clip Foam, stripping Cooler Kit, mounting Screw, cap Edging Washer, flat Screw, cap Nut Lockwasher Engine installation, Oeutz (see fig. # 19 )

,-for" Assy. Unit

1 1 3 1 4 1 8 1 1 2 1 1 1 2 7 4 4 ~ 1 3 1 1 4 2 1 2 4 2 4 4 2 2 1

LD/LL P-43

~f~~ f~~~: ?_?}~~~ ,"~ :;- ~ .. > ~., .• -:"~'l:'~\;'';~:~ :?·~~:~}~~~;\~~3~~}~tf'·fi~f+~~~.;~/::-'~ ~f:.~. < ",'-> ~;~~'- ~ -", ,~,-:~.<:.~.; ;~;;~~;r.iir{_f,~$~ .j'~:;!~~~,,;-" .

. ·:,.~t"FIGURE;:!'19'.DE;UTZ':f;ENGINE INSTA:LLA TION .

LD/LL P-44

)

JUNE 1985

';.:,

'<':~for<' 'i'/ A •. ~

FIG. IT EM','~ J,' .... , ... , ..... ')1; "J"


19 1 A-3097S Pump, hydrostatic (see fig. < #69,70,71) 1 ~ 19 2 C-30703 Plate, coupling 1

) 19 3 A-30751-01 Disc assembly -+/~'Jl tolcJ~ 1 19 4 Oeutz alternator installation(see fig.#20) 1 19 5 B-31159 Adapter 1 19 S A-31147 Coupling, lovejoy 1 19 7 B-31151-01 Shaft 1 19 8 B-30712 Collar, coupler 1 19 9 A-50001-14 Lockwasher 4 19 10 A-30709 Stud 4 19 11 A-5000S-12 Nut 4 19 12 P-11143-04 Screw, cap 8 19 13 0-30848 Bracket, mounting 1 19 14 0-30927 Pump, hydraulic (see fig. #75) 1 19 15 P-14994-0S Screw, cap S 19 16 Ae SOO18 Mount, engine pm 71 0/0110 (( 4 19 1'"1 P-11009-06 Lockwasher 30 19 18 P-112S1-0S Nut 8 19 19 P-1101S-04 Washer, fiat S 19 20 P-11170-08 Nut 2 19 21 A-50011-0S Screw, cap 4 19 22 A-30814-03 Angle 2 19 23 A-50005-05 Screw, cap 8 19 24 A-50001-13 Lockwasher 8 19 25 A-14820-01 Spacer 8 19 2S A-50001-12 Lockwasher 8 19 27 A-50009-03 Screw, cap 8 :) 19 28 P-11143-0S Screw, cap 12 19 29 P-11009-08 Lockwasher 4

)


/

FIGURE 120""DEUTZ ENGINE ALTERNATOR INSTALLATION

)


------- - --- ---------

FIG. ITEM; ,: ( . f:~~~'· . ".r' .):'. ;. !'~"~:.:: ' ~,~. : .. :;::. -:. " ~ .' - "~'~I':' ".~'F?"S: ~:~1':~J 1iet br ' ,'" i" :" ..


20 1 A-30684 Engine, Deutz (see Engine Manual ) 1 20 2 A-5000B-10 Nut 1

~) 20 3 A-50001-12 Lockwasher 1 20 4 P-11261-8 Nut 1 20 5 P-11009-8 Lockwasher 1 20 6 A-14806-2 Spacer (9/16 ID x 15/16 ) 1 20 7 A-14820-3 Spacer (.438 ID x 21/32 ) 1 20 8 A-14805-1 Spacer ( .357 ID x 1/2 ) 1 20 9 C-30850 Bracket 1 20 10 P-14994-14 Screw, cap 1 20 11 A-50004-17 Screw, cap 1 20 12 A-50003-15 Screw, cap 1 20 13 A-50001-11 Lockwasher 2 20 14 A-14805-2 Spacer ( .357 ID x 1) 1 20 15 B-30854 Arm 1 20 16 P-llOO9-5 Lockw8sher 1 20 17 A-50003-1S Screw, cap 1 20 18 P-11854-3 Screw, cap 1 20 19 A-30849-01 V-Belt 1 20 20 A-14817-1 Pulley 1 20 21 A-30742 Alternator 4 1 20 22 MSRA35N12B Kit, alternator 1DO~ 'J.., 1

)


2

25

23

26

34135

3\~ /~ ... fI35

33


FIG. ITE'M .;-

"# for, "


21 1 B-14859-7 Clamp, hose 2

-) 21 2 A-30441-1 Hose, air 1 21 3 A-39859 Hose, valve cover 1 21 4 B-14859-3 Clamp, hose 2 21 5 0-30741 Cleaner, air (see fig. #23) 1 21 6 A-14858-1 Cap, weather 1 21 7 P-11143-16 Screw, cap , 1 21 8 A-~9 Spacer ~\05"l-Oo-L- 1 21 9 P-11016-3 Washer, flat 1 21 10 P-11170-06 Nut 3 21 11 A-31027 Gasket 1 21 12 A-50004-5 Screw, cap 2 21 13 B-31004 Pipe, exhaust 1 21 14 B-14857-3 Clamp, muffler 1 21 15 C-30691 Muffler 1 21 16 A-30906-1 Pipe, tail 1 21 17 B-14859-5 Clamp, hose 4 21 18 A-30494-3 Hose, upper radiator 1 21 19 C-31018 Hose, lower radiator 1 21 20 0-31008 Shroud 1 21 21 A-30520-2 Foam 1 21 22 0-31017 Radiator 1 21 23 A-30361 Kit, mounting 2 21 24 A-31016 Cooler, oil 1 21 25 C-31009-2 Baffle 1 21 26 A-30520-1 Foam, stripping 2 21 27 A-31025 Mount 2 -) 21 28 P-14935-02 Washer 2 21 29 B-31002 Bracket 2 21 30 P-11143-04 Screw, cap 4 21 31 P-11009-06 Lockwasher 4 21 32 C-31009-1 Baffle 1 21 33 P-11854-4 Screw, cap 6 21 34 P-11009-5 Lockwasher 6 21 35 P-11016-2 Washer, flat 6 21 36 P-11170-5 Nut 6 21 37 Continental engine installation(see fig .#22) 1 21 38 A-14851-02 Nut, clip 4

30QCi9- 0 0 ~. Q.\.>.L(s -\-C;f J,."x~,-,&J-' J-,


FIGURE #22 CONTINENTAL ENGINE INSTALLATION

)

/ / ~w /~

1.0

o ,...

,..-~

)


)

)

FIG. ITEM ' "):-, . ~l ",.-" i-for :-#

22 22 22 22 22 22 22 22 22 22 22 22 22 22 22 ?~ 22 22 22 22 22 22 22 22 22 22 22 22 22

# PART # NAME Assy. Unit

1 A-30976 Pump, hydrostatic (see fig. W69 ,70,71 ) 1 2 P-14994-6 Screw, cap 4 3 P-11009-8 Lockwasher 4 4 P-11016-04 Washer, flat 6 5 P-11143-4 Screw, cap 30 6 P-11009-6 Lockwasher 34 7 C-30703 Plate, COUPling,,-\ - I 8 A-30751-3 Disc assembly ~ \-M- plo-h Q..ov.-p l.-tL~ 1 9 A-50001-14 Lockwasher 8

10 A-50007-03 Screw, cap 4 11 C-31013-1 Angle 1 12 C-31013-2 Angle 1 13 A-30819 Mount, engine 4 14 P-11261-6 Nut 8 15 A-30932 Engine, Continental (see Engine Manual) 1 1~ A-310?? Sppn~r 1 17 A-50007-05 Screw, cap 4 18 B-31160 Adapter 1 19 A-31147 Coupling· (Lovejoy) 1 20 B-31151-02 Shaft 1 21 A-50001-12 Lockwasher 3 22 A-50004-03 Screw, cap 3 23 B-30712 Collar, coupler 1 24 P-11143-07 Screw, cap 4 25 B-31133 Bar 1 26 D-31014 Bracket, mounting 1 27 D-30927 Pump, hydraulic (see fig. #75 ) 1 28 P-14994-8 Screw, cap 2 29 P-11170-8 Nut 2

AR f l..[OD 80D d.J5d-. - 0:1 W)r~~ Pluj - L/lb/6~ ft-Il 'f.-IL/5"83 - Oil r~ bask-d- - Y/t:,/a<!

JUNE 1985

,>{\J~t;)-;~~,o\~\\.\cJ --:;:.:.;~:};;:.:.~.~- :r FIGURE 123 :·AIR'CLEANER ASSEMBLY (A-31067, D-307~il)

~~l' ,31 06 'l-~

JUVfo ;90141- (}tI

LD/LL P-52

~)

)

JUNE 1985

FlG. ITEM' I .. t f: r'~""" ," ...., ~ .;

"

23 1 NSS

-) 23 2 NSS 23 3 MDV250C126

r}"" 'ry -,-~'" :" " ,~,!, P"

23 4 NS6 23 5 NSS 23 6 MDV250C724 23 6 M DV250Citt I~~

)

,)

JUNE 1985

Drain, dw;t Body, cleaner _ Element, safety ;).00 83 '-/ '"':" -',f'" '",~' \; ~:"; ft;',+:~,1'} r,/' (' "3 i_

ri&.3~,er, Ga.:;KBt Nut, wing Element, main ~o6 ~ -~ 3 Element, main ;;)00 S'35

.r~"-''"' .' -;,':::',::';1'

# for -Assy. Unit

1 1 1 Gasoline 1 Diesel 2 2 1 Gasoline 1 Diesel

LD/LL P-53

FIGURE-,'24 '-PUELTANK ASSEMBLY

20

1 t:---. J ) I

4

10

I

~~ 2 ~ I ~9

~7


FIG;~"ITEM:~' ':;'j. , ';';'~ {' ",:'(or


24 1 P-11143-04 'Screw, cap 2

~) 24 2 P-II016-03 Washer, flat 4 24 3 A-14831.;..01 Clamp, hose 2 24 4 52-5054 Hose As Req'd 24 5 A-30649 Fitting 1 24 6 A-30659-01 Tubing 1 24 7 P-II009-06 Lockwasher 2 24 8 P-11261-06 Nut 2 24 9 P-II016-02 Plug, pipe 1 24 10 D-30645 Tank, fuel 1 24 11 A-30294 Cap, fuel 1 24 12 ~&-14aI5 Sendor, fuel Yqq·S8'-OC) 1 Gasoline 24 12 <- A-S06atS Sendor, fuel 4 qq Sy-c 0 1 Diesel 24 13 P-II009-2 Lockwasher 5 24 14 P-11885-05 ' Screw, machine 5 24 15 B-30355-08 Hose 1 Deere 24 16 A-30661-04 Hose 1 Deutz 24 17 A-14831-05 Clamp, hose 2 Deutz 24 18 A-14832-06 Fitting 1 Deutz 24 19 A-14892-01 Screw, cap 4 24 20 A-49884 Filter, fuel 1 Gasoline

C:t t::Leere. .....

)

)


FIGURE #25 DIESEL STARTING AID (EITHER INJECTION) ASSEMBLY (A-148i4)~bo

C") ~~ ~ .~~

~::. a::

\ E-<~ co 0 Q)...::l t...

N % ::J+J

\,,(J} r-- 2 ~

rn~

"'0 ) -0 c.... .§ ~ c.-. 0

~\ Q)

.!:I:: aj

+J

S

\ ...;..

I

<.'>


( 'FIG. ITEM::::7:i""

# # PART #

25 1 D-30635

) 25 2 QG19401 25 3 QG13390 25 4 QG17224 25 5 A-14826 25 6 QG17223 ?~ 7 ~A

25 8 QG13087 flSS 25 9 QG17405 t)~ "1 n "''f":!1 '7,.,t"\~

25 11 QG21196 NS5 NA Not Available

)

)

JUNE 1985

NAME

Reservoir Solenoid assembly Screw, self tapping Spacer Switch Tubing, nylon Cr'''''\ ,. ~+Cl,'l"t,... .. (r; ~ "",~,,~ .. ,,;

Bail assembly Nozzle, atomizer

~ -~~. '" '

Extension, bail

t""~~ ...... ~",~ ''',!'"'>~1'l'··' . . .... -'-"-""'-..., i

1f:!or Assy.

1 1 2 2 1 1 1

1 1 '1

2

Unit

48"

LD/LL P-57

FIGURE ,2·S'''BATTERY SUPPORT ASSEMBLY

co

\

LD/LL P-58

,..

,.. ,..

JUNE 1985

)

FIG. ITEM"'-" - . " 'if'for-' # # PART # NAME Assy. Unit

26 1 0-30635 Reservoir 1

-) 26 2 B-30730 Cushion 2 26 3 Battery (secure this part locally) 1 26 3 Group #27 (70 AMP. HR.) Gas 26 3 Group # 30H (90 AMP. HR.) Diesel 26 4 B-14869 Angle 1 26 5 P-11016-02 Washer, flat 2 26 6 P-11170-05 Nut 2 26 7 B-14870-02 Hook, bolt 1 26 8 P-11143-03 Screw, cap 4 26 9 B-14870-01 Hook, bolt 1 26 10 P-11009-06 Lockwasher 4 26 11 P-11016-03 Washer, flat 4 26 12 B-30724 Bracket 1 26 13 P-11261-06 Nut 4

.)


· FIGURE' "27 SEAT'''MOUNTING ASSEMBLY

2

6

)

10-_-.11

)


~.",' ..... "~f';:"'·"'" ~~

FIG. ITEM ':'"")t~" "' f for # # PART # NAME Assy. Unit

27 1 P-11143-04 Screw, cap 4

) 27 2 A-30432 Seat 1 27 * A-3078S-00 Slide, seat <1d'1d.e~~ 1 27 3 A-30448 Belt , seat 1 27 4 D-30374 Cover 1 27 5 A-14892-01 Screw As Req'd 27 6 P-I101S-03 Washer t flat 8

:~ 1 ,~r ~" ,.. ,...

\,.;,~J.~ As Req:d iJt i i. .. ..... '";t <.,.; ,,} ...i. o;.;tj .. , ' .. -, 27 8 P-I1009-0S Lockwasher 4 ?7 9 P·-11 ,;un-o~ rut 4 27 10 NSS Control assembly (see fig. #28) 1

')

,)


,-,. , .. ~.:; .: .... ' ." ~ - ,,,,,-' .

2

!/

) 13

)


FIG.~ITEM It~ .~, .. ~1 ,'" ., Irot'

# I PART I NAME Assy. Unit

28 1 D-30425 Panel, seat mounting 1

) 28 2 A-14892-01 Screw, cap /l.S Req'd 28 3 C-30430 Panel 1 28 4 A-14851-03 Nut, clip As Req'd 28 5 Control assem bly (see fig. #3~) 1 28 6 B-30473-02 Cover, right hand 1 28 7 B-30491-04 Angle, right hand 1 ~'"

r' .·1.i.~:.D.i~<''') "\.~ . 1 ' .

(; ~ ..... >- ":J:

28 9 P-I1009 .... 06 Lockwasher 4 ?<3 "10 P-1101F;-03 W~she!" • flat 4 28 11 B-30491-03 Angle, left hand 1 28 12 B-31110 Support 1 28 13 A-27561-01 Edging 2 28 14 B-30473-01 Cover, left hand 1

.)


: .. e'FIGlJRE t29'~-FOOT PEDAL CONT,ROL ASSEMBLY

)


FIG. ITEM'" ',e"!"for # # PART # NAME Assy. Unit

29 1 B-30279-02 Pedal, backwards 1 29 2 P-II020-;W-r:~1 Bearing 6 29 3 P--11160-06 Fitting, grease 2 29 4 B-30279-01 Pedal, f orw ards 1 29 5 A-25246-04 Shaft 1 29 6 P-I1073-03 Pin, roll 1 29 7 P-22120 .-00 End, rod 4 29 8 P-11135-04 Pin with cotter pin 4 29 9 P-11486-~ CJ? Nut, jam 4 29 10 P-I1073-29 Pin, roll 2 29 11 B-30493 -DO Bracket 1 29 12 P-II009-06 Lockwasher 4 29 13 P-11806-06 Nut, jam 4 29 14 A:-l-4898 /t/36/-cl() Spring 1 29 15 P-I1016-05 Washer, flat 2 29 16 P-11143-14 ,Screw, cap 2 29 1!t'15 B-~e6-66 Rod, Forward.30~1O-o~ 1 29 ~'7 B-~77-G2 Rod, Reverse 3 / .:Lo~ - o-cJ 1 29 19 B-31167 Rod 1 29 20 P-I1045-04 Screw, cap 1 29 21 P-II016-01 Washer, flat 1 29 22 A-3981?«(t() Block, pillow 'I g 8 17 -() 0 1 29 23 A-31165-04 Plate .12 As Req'd 29 23 A-31165-05 Plate .06 As Req'd 29 24 P-11143-06 Screw, cap 2 29 25 P-II016-03 Washer, flat 2 29 26 P-11261-06 Nut 2

) 29 27 A-30976 -00 Pump, hydrostatic (see fig.#69,70,71) 1

)


",",~ ...... ~'ril ,t"~+ c, :1'-; '~::·r"'; H ,~ " ;, '''~.. ,,1\.'" -. ;,;l--" ~ 'u:-:;" ,. FIGURE #30";;C'HOKE";AN'O'PUErl'SHUTOFP"CONTROL ASSEMBLY"';-",:,··:·

1

f)

)


FIG: "ITEM - ~~

# for J;/ ...


30 1 C-30430 Panel jJ6 Lon1 er AJo.-lIeJJ/e..:. 1

-) 30 2 A-~ Spring 1 Deutz 30 3 P-11073-30 Pin, roll 1 Deutz 30 4 C-30673 Rod, fuel shut off 1 Deutz 30 5 P-11429-03 Pin, cotter 1 Deutz 30 6 P--l162 184 Nut I \\~C) -0<1- 1 Deutz 30 7 P-.ll0-a~ (t1- Knob / / d3 t/ -tTO 1 Deutz r ." '" :-"~:~~3:·3-04 Cable) choke 1 Continen tal ... ~ u 0

)


""' __ ...ao..-I

LD/LL P-68

o N

JUNE 1985

)

)

--~------- -- ------~~~~-~~---

",,' , ~"i,

FIG. ITEM , .... # for # # PART # NAME Assy. Unit

31 1 Control assembly (see fig. ~t"32 ) 1

) 31 2 A .. J4Q9g 9f/1qJ..O/~crew, cap 4 31 3 P-11234-DO Knob 2 31 4 A-30423-DD Plate 1 31 5 P-11020-27 Bearing 4 31 6 P-1101S-03 Washer, flat 4 31 7 P-11170-0S Nut 4 31 8 B-3D113-oD LeviSI' , 4th spool 1 LL-40 31 9 A-30410-01 Rod 1 31 10 P-11170-06 Nqt 1

.\ LL-~J ~

31 12 P-11073-04 Pin, roll 4 31 13 P-1101S-0S Washer 4 31 14 A-30419-60 Tube 1 31 15 B-30422-02 Rod, 300 spool 1 LO-50 31 15 B-30422-01 Rod, 4th spool 1 LL-40 31 16 A-30S51-01 Pin with R ring 1 LO-50 31 17 B-30S57 -oD Rod, valve 1 LO-50 31 18 P-11129-0S Nut 1 LO-50 31 19 P-22120 -00 End, yoke 1 LO-50 31 20 P-11135-04 Pin with cotter pin 1 LO-50

)

)


ASSEMBLY FIGURE 132,VALVB CONTROL

31~3\ r 2. '\ / 29~\ ~~-----. 27~~ · : I , ,. ~~ 2. ~~ ~28 i ~,.

22 19

24 20

23

LD/LL P-70

~)

~)

-)

JUNE 1985

Fig. "Item ' # # PART # NAME Assy. Unit

32 1 A-14864-CO Knob 1 32 2 B-30857 -DD Lever 1

-), 32 3 P-11020-27 Bearing 2 32 4 P-11160-14 Fitting, grease 1 32 5 A-30508 - 00 Pin 1 32 6 P-11025-15 Ring, retainer 2 32 7 A -14861-() U Spring 1 32 8 P-I1016-06 Washer, flat 1 " ,." - . ~ ~'~' . .,.,.~ -ry - '

lJ Hi t roll 1 t.J ~I .... :: .L . 1 .... ", ,,.) ':"v

32 10 A-30510 -bD Tube 1 '"If') J 1, D-11160-11 p;ttlr"~ ::~?,\'~p

• 1 '. ~ J. ~:.

32 12 A-11057-02 Key 1 32 13 B-30727-60 Rod 1 32 14 P-11020-16 Bearing 2 32 15 0-30371-00 Bracket 1 32 16 P-11261-06 Nut 1 LL-40 32 17 P-11009-06 Lockwasher 1 LL-40 32 18 A-14813 -D 0 Link 1 LL-40 32 19 B-30731-DO Crank, bell 1 LL-40 32 20 P-II020-21 BearIng 1 LL-40 32 21 A-30652 Adapter 1 LL-40 32 22 P-·I101S-03 ~v t1.4:>def J.. LL--:tO 32 23 P-11143-10 Screw, cap 1 LL-40 32 24 P-11025-12 Ring, retainer 1 LO-50 32 25 P-11857-03 Washer, flat 2 LO-50 32 26 A-11936-04 Shim .030" As Req'd 32 26 A-11936-05 Shim .092" As Req'd 32 26 A-11936-08 Shim .060" As Req'd

-) 32 27 B-30771- W Arm 1 LO-50 32 28 A-30289-DU Link 2 LO-50 32 29 P-11025-12 Ring, retainer 1 LO-50 32 30 P-11857-03 Washer, flat 1 LD-50 32 31 A-30729-D 0 Cam 1 LO-50 32 32 P-11890-05 Pin, dowel 1 LO-50 32 33 P-11857-03 Washer, flat 1 LO-50 32 34 P-11936-08 Bearing, thrust 1 LO-50 32 35 A-14814-02 Spacer 1 LO-50 32 36 P-11020-17 Bearing 1 LO-50 32 37 A-30288-01 Crank, bell 1 LO-50 32 38 P-11016-05 Washer flat 1 LO-50 32 39 P-11429-03 Pin, cotter 1 LO-50 32 40 P-11135-04 Pin with cotter pin 2 LO-50 32 41 P-22120 -cD End, rod 2 LO-50 32 42 P-11486-06 Nut 2 LO-50 32 43 A-30416 -co Rod 1 LO-50 32 44 A-14814-01 Spacer 1 LL-40 32 45 A-30651-01 Pin with R rings 2 LL-40 32 46 A-30653 -00 Link 2 LL-40 32 . 47 P-11020-17 Bearing 1 LL-40 32 48 A-30288-02 Crank, bell 1 LL-40 32 49 P-11016-05 Washer, flat 1 LL-40 32 50 P-11429-03 Pin, cotter 1 LL-40 32 51 P-11135-04 Pin with cotter pin 2 LL-40

) 32 52 P-22120'-OD End, rod 2 LL-40 32 53 P-11486-06 Nut 2 LL-40 32 54 A-14811-01 Rod 1 LL-40


-. ~

C')

,....

~

~)

ll) ~

~

~ t1

~

/ fJ

",j ,/, ~~. ~«)

~~ ! ~

~~ "\ 'tl

M4 I ~

~ ~ \) ~ ~ ~~

N E\ ) ~ 0/ n


Fig. Iten,",' ' '. '" ~ V_'\ ~-.,[.'~ ,.,

- .. , - t.J~" ... ~: :. - ;.: ~ -


33 1 0-30371 Bracket 1 33 2 B-30390-02 Handle 1 Continental

) 33 3 P-11135-04 Pin with cotter pin 2 Con tinen tal 33 4 P-22120 End, rod 2 Continental 33 5 P-11486-06 Nut 2 Continental 33 6 A-..dQ4l:6 Rod 3/ c)'7:l -0 d 1 Continental 33 7 A-14862 Swivel 2 Deere 'II) 8 ~" .. ..,~n\ ~ ~ .. ~ "'.1 H"'.l':l.~,) 1 Deere ~ . .:,; ' .. J ;'J _~

33 9 A-14860-02 Cable.. 1 Deere 33 10 P-11234 Knoh 1 3J 11 P-200o'l Spring 1 33 12 P-11016-13 Washer, flat 1 33 13 P-11009-06 Lockwasher 1 33 14 P-11170-06 Nut 2 33 15 A-30668 Handle 1 Oeutz 33 16 P-11339 Pin with cotter pin 2 Oeutz 33 17 P-11310 End, rod 2 Oeutz 33 18 P-11486-04 Nut 2 Oeutz 33 19 B-30672 Rod 1 Oeutz 33 20 A-49951 Washer 1 33 21 P-11143-09 Screw, cap 1

nttr n.. Xun -Jlq 0° 111~9-tJ6

) ~~~~t;cd~~

)


"

'FIG'URE 134+"STEERING CONTROL COLUMN ASSEMBLY

3

)

5


"W' •• '

Fig. ·Ite'nf" # # PART # NAME Assy. Unit

34 1 P-14946 Cap 1

-) 34 2 A-30434 Nut 1 34 3 A-30433 Wheel, steering 1 34 4 P-30319 Col umn, steering 1 34 5 0-30318 Valve, steering control (see fig. # 74) 1

)

)


~?' Lt~\.~·.r·~::" t '._JI' }-:: - ··,A'';;''J;'~<}.V2'·, u, .• -_';' "' ..... - .'"'7 .... , .:~:/.~.

'-<~::.P·"FIGURE';'#35 SINGLE CALIPER BRAKE PEDAL CONTROL ASSEMBLY . .

)

)


Fig. Item '.' .,'

,;"; .J"~ •


35 1 A-31162 Pad, rubber 1

) 35 2 A-31164 Pedal 1 35 3 P-I1073-03 Pin, roll 1 35 4 P-11020-16 Bearing 2 35 5 P-11261-06 Nut 2 35 6 B-31094 Pedal 1 35 7 P-11160-06 Fitting, grease 1 35 n A-25246-05 Shaft 1 0

35 9 P-11135-06 Pin, cotter pin with 1 .,.-..... '" 10 P-1~.128 : .... :J :~: '2 1 35 11 P-11486-08 Nut 1 35 12 A-49858 Spring 1 35 13 A-31091 Shaft 1 35 14 A-31169 Seal 1 35 Ie; P-l1009-('~ L(jf' '<: '," ~:..S h er 3 35 16 A-11143-05 Screw, cap 3 35 17 A-31097 Cylinder, master (see fig. #37) 1 35 18 A-49875-01 Elbow 90 0 1 35 19 A-49879-01 Tube, 12 inch 1 35 20 A-49880-01 Connector 2 35 21 B-30355-12 Hose - ~J(303S"S/tl. 0 1 35 22 P-11261-06 Nut 1 35 23 P-15677-02 Clamp 1 35 24 B-31179 Caliper ass em bly (see fig. #38) 1 35 25 A-49754-01 Tube, 20 inch 1

)

)


FIGURE 136 DOUBLE CALIPER BRAKE PEDAL CONTROL ASSEMBLY

)

)


Fig. Item , # PART # NAME Assy. Unit

36 1 A-49875-1 Elbow, 90 0 1

~) 36 2 A-31097 Cylinder, master (see fig. #37 ) 1 36 3 A-31091 Rod 1 36 4 P-11896-5 Nut 1 36 5 P-11128 Yoke 1 36 6 P-II073-3 Pin, roll 1 36 7 P-I1020-16 Bushing 2 .-.,,/"11 8 B-31094 Pedal, foot 1 ";;0

36 9 A-11160-6 Fi tting, grease 1 3q 1!') t\ ~.?e:;4')Af)-S ~}.,Qft 1 36 11 P-11819 Pin, cotter pin with 1 36 12 A-49858 Spring 1 36 13 P-11261-6 Nut 1 36 14 A-49880-1 Connector 2 36 15 A-49879-2 Tube, 30 inch 1 36 16 B-31088 Caliper, double (see fig. #39) 1 36 17 NA Stud, weld 1 36 18 P-15677-2 Clamp 1 36 19 B-30355-12 Hose 1 36 20 A .39879 1- Tube, 12 inch J/qr/19 -tJ/ 1 36 21 A-I1009-6 Lockwasher 3 36 22 A-11143-5 Screw, cap 3

)


: FIGURE #37 MASTER C·YLINDER ASSEMBLY (A-31097)'

LO ""'"

)

co

It)-~V

\

)

,..----4>/


_ r ,t Fig. Item . "


37 1 MA30-170-008 Retainer 1

') 37 2 MA32-660-034 Spring, return 1 37 3 MA32-660-033 Spring, return 1 37 4K NSS Cup 1 37 5 MA30-010-030 Piston 1 37 6K NSS Cup 1 37 7 NA Housing 1 37 8 MA20-080-006 Valve, relief d.- D 0 g I Cf 1 37 9K NSS Gasket, relief valve 1 0,7 1 n ~( ~!~~ n° --,,.., ,...-·~tCi' " 3'1 11K NSS Spring 1 37 12K NSS Disc, relief 1 37 13 NA Valve, relief 1 37 14K NSS Gasket 2 37 15 MA30-(\30-028 Pli' filler 4. P ( Uj) 1 37 16 MA28-030-002 PI , filler J. ()O~:J.O 1 37 17K NSS Boo 1 37 18K NSS Cup 1 37 19 MA30-010-291 Piston 1 37 20K NSS Ring, retaining 1 37 21K NSS Retainer 1 37 22K NSS Seal 1 37 23K NSS o ring 1 37 24 MA30-170-069 Retainer 1 37 25 NSS Spring No? I Jj K'I' 1 37 26K NSS Seal _ 1 37 27 NSS Valve, check N b, I tJ Kt I 1

) 37 28 NSS Seal N 6 T uS I<. ( T 1 37 29 MA30-030-1S4 Plug, end 1 37 K MA02-001-076 Kit, repair dOD ~ t l 1

(contains parts indicated by letter "K")

)


~ , I

FIGUR'E:' 4f38 SINGLE CYLINDER BRAKE CALIPER ASSEMBLY (B-31179)

)

co-~ ..-

)


. , .. ,. ,~-" ... -.. -.. .. ..

Fig. Item # # PART # NAME ASsy. Unit

r;- c 1 LAG:i -07 4,)9 ,...,. /-~. ,I). (', ,.""''/ ()

1 o,)U ~crt;W, cap ,J..,V v I,

) 38 2 LA98-08637 . Lever ~()D 1t1) 1 38 3 LA09-07457 Seal ~OOI~~ 1 38 4 LA98-07462 Retainer ~o;J,. / t/Ip 1 38 5 LA08-07461 o ring Qpo,,}lQ 1 38 6 LA19-07463 Bearing ;;DD1~1 1 38 7 LA98-07472 Shaft, actuator ~()D ("q D 1 38 8 LA98-07466 Balls 10Dl&4 . 3 38 9 LA98-07470 Screw, thrust de) ~ \LlI 1 ~q Tn LA 0 t.) - r. 7 ,1. t; Q Pi n ,;> C)';) I '-4 ~ '1

38 11 LA08-07460 o ring j ()6119 1 38 12 LC98-08626 Mount 1 38 13 LA01-08635 Screw 1D0111 2 38 14 LA09-08632 Boot !lb011J?J 2 38 15 LA11-08634 Bushing!) 6D 7~ ~ 2 38 16 LA08-08631 o ring ~{)o1~ 0 2 38 17 LC10-06438 Screw, bleeder ~()O t3 16 2 38 18 LA01-03620 Screw, cap 4 38 19 LA03-03621 Lockwasher 4 38 20 LB08-07337 o ring dDO?ll ~ 1 38 21 LA08-07453 Seal ~DO'1LJ 1 38 22 LA98-07484 Piston ')..0 D '7 q I 1 38 23 LA98-07637 Insulator ~o 0 7 q A 1 38 24 LB98-08622 Extender, piston 5)0 a 3 &J'O :2 () ;1 /1/1 1 38 ·25 LC10-06409 Insert 1 38 26 bI)12 08624- Caliper no'i a.\J~i la..'ol e -0 rd-e r" (LS!;. <j 1 38 27 LB99-08628 Pad, brake.;2DO g 14 2 ,

-) 38 28 LA05-08629 Pin ')..{) 0 /1 ~ , __ 2 38 29 LA05-08630 Pin, hair pin ~O D 17~ 2 38 30 LA05-04467 Pin, cotter 2 38 31 LB09~07452 Boot ~()6~ I;' 1·

Y'f cLt,-,-c\-( ()~ ~~JIJL~~ 14.~~/-oo ~

"-

-~~ ~~~ ~~~ .. /,~.-~ -t.

/ /

/:

)


Torque to 75/125 ft. Ibs.

12

----

29

Torque to 75/

k125 ft. Ib;~

21 ~Torque to

~ 16/22 ft. /bs

16

20 22 . 19 . ()

15A~ ~A25 .

o 23

31

)

)

Fig. Item # # PART #

39 39 39 39 39 39 39 39 39

39 39 39 39 39 39 39 39 39 39 39 39 39 39 39 39 39 39 39 39 39

1 2 3 4 5 6 7 8 9

11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31

JUNE 1985

LA06-07975 LB98-07965 LAI0-07721 LAI0-07333 LE12-07624 LA98-07637 LB98-07629. LA98-07484 LA08-07453 'T - .... , .,...., f',-'

...... n..-- ' •• ' v" '-, 10 _' ,"" ~

LC98-07446 LAOI-03620 LA08-07460 LA05-07458 LA98-07470 LA98-07469 LA98-07466 LA98-07472 LA98-07471 LA19-07463 LA08-07461 LA98-07462 LA09-07457 LA98-07631 LA98-07630 LAOI-07459 LA03-03621 LC99-07493 LA09-07452 LB05-07252 LA05-07638

NAME

Spring ~DO 11~ Bracket 7 S SScrew, bleeder;' (j 0 .

Insert, tube seat }c{: '7 i'Lf . Cas ting, caliper ~9£r J-oo 1q2 ~ ~ < ffis~rJ.u()S'(C ? &x~~7 Piston :J ()O '79 L o ring l)Jyo111 C',! ,:j-o ~("u b' ~ Cap, end Screw, cap o ring 10017 g Pin Screw, L. H. thrust Screw, R. H. thrust Ball .l£ () 789 Shaft, L. H. actuator Jt6 79'0 Shaft, R.H. actuator Bearing, thrw;t )66711 o ring )..DO 171 Retainer Seal ~o1tg~ Lever, L.H. Lever, R.H. Screw, cap 206770 Lockwasher Pad assem bly ;).D 0 8" l ~ Boot 2tJ01g / Pin, cotter :;ZO 051 I ( Pin, pad ~()o 7 73

Assy.

2 2 3 4 1 2 2 2 2

2 8 2 2 1 1 6 1 1 2 2 2 2 1 1 2 4 2 2 4 2

Unit

LD/LL P-85

FIGURE #40 SINGLE CYLINDER BRAKE CALIPER HAND BRAKE LEVER CONTROL ASSEMBLY

Front

,/ 2

3

7

Transmission

LD/LL P-86

Part of Forward Frame

/ 12

!. ~. To Differential

\ .. ~ \\ \\_ ~ Assembly

_________ ~ Ii ~--. "" i,'

\ /J ,,,~

11

Front

~

JUNE 1985

)

) ~.

r

Fig. Item # # PART # NAME Assy. Unit

40 1 P-11143-10 Screw, cap 2

) 40 2 NSS Spacer (part of handle) 1 40 3 P-12078 Handle 1 40 4 A-31108 Shim 1 40 5 8-31110 Support 1 40 6 P-11170-05 Nut

~~713110700 2

40 7 P-31107-00 Cable 1 40 8 P-11261-06 Nut 1 40 9 P-15677-02 Clamp 1 M) 10 1'-132~1.. Pin. CDtter pin with

II 8-3117' Ca.J/per"'single (see fig. #38. 4U 12 B-31106 -oj Disc 1

)


FIGURE #41 DOUBLE CYLINDER BRAKE CALIPER HAND BRAKE LEVER CONTROL ASSEMBLY

)

5

6 Front

20

/1 17 16

Front


Fig. Item ,. .~~1 ~


41 1 P-11143-10 Screw, cap 2 ~) 41 2 NSS Spacer (part of handle) 1

41 3 P-12078 Handle 1 41 4 A-31108 Shim 1 41 5 B-31110 Support 1 41 6 P-11170-05 Nut 2 41 7 P-13282 Pin, cotter pin with 4 41 8 P-11016-08 Washer 1 41 9 P-11869-08 Pin, cotter 1 41 10 B-31144 Bar 1 41 11 B-31106-01 Disc 1 41 12 B-31082 Bell crank 1 41 13 P-11020-16 Bushing 1 41 14 P-11314 Yoke 2 41 15 B-31088 Caliper double (see fig. #39) 1 41 16 P-11009-10 Lockwasher 4 41 17 P-11894-06 Screw, cap 4 41 18 NA Stud, weld 1 41 19 P~15677-02 Clamp 1 41 20 B-31107 Cable, brake 1 41 21 P-11261-06 Nut 1

NSS Not Sold Separately NA Not Available

)

)


FIGURE '#42 TRANSMISSION SHIFT CONTROL' ASSEMBLY

; ,

)

co

\~\/ "\


Fig. Item' , # # PART # NAME Assy. Unit

42 1 P-11234 Knob 1

) 42 2 B-30408 Lever 1 42 3 A-30302 Shaft 1 42 4 P-II020-17 Bearing 1 42 5 P-11135-03 Pin with cotter pin 2 42 6 P-11314 Yoke 2 42 7 P-11806-10 Nut 4 42 8 A-14863-02 Cable, shift 1 42 9 B-31110 Support 1 42 10 P-11073-21 Pin, roll 1 42 11 A-30001 Motor assembly (see fig. #72) 1 42 12 P-14994-06 Screw, cap 4 42 13 P-II009-08 Lockwasher 4 42 14 P-I1016-04 Washer 4 42 15 8-30381 Bracket 1 42 16 A-30321 Angle 1 42 17 Transmission ass em bly (see fig. #47-50) 1

)

)

JUNE 1985 LD/LLP-91

FIGURE 143" DRIVE TRAIN ASS:EMBLY

)

'\

" }'


. f·.·.···,~~·,-.. ' .. · -,,- •. ,-~ •• --.-... - -"-~- ..

)

Fig. Item # #

43 1 43 2 43 3 43 4 43 5 43 6 43 6

43 7

43 8 43 9 43 10 43 11 43 12 43 13 43 14 43 15 43 15 43 17 43 18 43 18

',..':' 0'

PART # NAME Assy.

A-14891 Nut, wheel 20 Wheel assembly (see fig. #44)

A-30057 -f}{j ~;Bolt P-II016-06 Washer, flat A~i4ga8!~ Nut r4'\:t(~ C- 30 0 60-;M 6 t5 Axle assem ly (see fig. #45) C-30060-03 Axle assembly (see fig. #45)

A-31153 Adapter, daul

P-11872-02 NSS Hub P-11801 Nut B-31106-0 1 Disc Z-30275 Washer Z-30271 Nut A-30018 Bolt, u· C-30014 Shaft, drive (see fig. #46)

'~-i'i:ij,.::> •• u.:;v~vn cw3ei&i~ ... j \6«;;.;;; i.'ig.ti'4,-Jiv} A-30016 Universal assembly (see fig. #51) C-30060-02 -\<. ~I Axle assembly (see fig. #45) - LD C-30060-04 Axle assembly (see fig. #45) - LI-

V-.) I d.Ov--~~-t~ LA -Go L r 3 [) 0 (Q () --05 l CJ . .l. y r -e. Y'.t j

~ ~\..'\iS f'\\ \$S 10 r"\ \'0~l\'-{ \\\C' 60 1+ ?J) ~J

) L/q Cjt/- () !

4 4 8 8 1 1

2

16 1

32 1 1 1 8 1 1 1 1 1

Unit

Narrow 5(;' i/

Wide 3 7St! stage mast Wide 3 stage mast

Narrow 5(; 1/

Wide 75 //


FIGURE 144 WHEEL ASSEMBLY

)

1----.....--.......


Fig. -;Jtem ; ... ' ~ .. , # # PART # NAME Assy. Unit'

Sure Grip Lug F. 44 1 A-30463 Wheel assembly 12 x 16.5, ~' PR 4' L~_

~

) 44 1 A-30463 Wheel assembly 12 x 16.5, 1 PR 2 LL-40 ~.1 ? A- ~n'_ ()5 "...~ /f -'. lre, 12 x : = .;) ~/ ' 1 44 3 A-30201 Valve, rim (:J~(u) J. pef J ~ 44 4 B-30197 Rim, wheel

LL-' Un (e55 ducJ

XTRTG (SOD Tire) 44 1 A-30875-01 Wheel assembly 31 x 16.5-15, 8PR 4 44 2 A-30487-01 Tire, 31 x 16.5 -15 1 44 3 A-30201 Valve, rim 1 44 4 C-30865 _ Rim, wheel 1

SUPTG (Sand Tire) LL 44 1 A-30875:-.02 Wheel assembly 31 x 15.50 - 15 4 44 2 A-30487-02 Tire, 31 x 15.50 - 15 1 44 3 A-30201 Valve, rim 1 44 4 A-30865 _____ Rim, wheel 1

Loader Service Tire 44 1 A-31489 Wheel Assembly 8.25 xIS, 6PR 4 44 2 A-31486 Tire, 8.25 x 15 1 44 3 A-30201 Valve, rim 1 44 4 C-30481 Rim, wheel 1

XTRTG (S(01> Tire) ~ 44 1 A-30490-01 Wheel assembly 31 x 15.50 - 15, 8PR 4

) 44 2 A-30487-01 Tire, 31 x 15.50 - 15 1 44 3 A-30201 Valve, rim 1 44 4 C-30479 Rim, wheel 1

SUPTG (Sand Tire) LD 44 1 A-30490-02 Wheel assembly 31 x 15.50 - 15, 8PR 4 44 2 A-30487-02 Tire, 31 x 15.50 -15 1 44 3 A-30201 Valve, rim 1 44 4 C-30479- Rim, valve 1

Sure Grip Lug 44 1 A-31158 ~ Wheel assembly 12 x 16.5, 8 PR 4 LL-40 Only 44 2 A-30195 Tire, 12 x 16.5 1 44 3 A-30201 Valve, rim

-Pron+ (4 Pe~) 1

44 4 8-31154 Rim, wheel ~ 1

/ /-~:~~~-~\ ".;-/ - ({\ \

/~' . Y \ I

-:~ "\ :

: / '., ~ llUJ ~ / 0 \ / (\2 Ld: . \ C\ S 1" I., . t?JC. 6 ~

\G'

.)


FIGURE '45 AXLE ASSEMBLY (C-30060) 2

\I

-~~

9

43

\ p,'n rAOlL\ c., ,

'V +\L~ 5 .-r ~oY '-t... C

'~ )' 3 D I S~: '

4\~41 42 '@ 39

39 41

38~ !~40

28

Fig. Item # # PART # NAME

# for Assy. Unit

45 1 45 2 45 3 45 3 45 3 45 4 45 5 45 6 45 7 45 8 45 9 45 10 45 11 45 12 45 13 45 14 45 15 45 16 45 17 45 18 45 19 45 20 45 21

LD/LL P-96

Z-30137 Z-36280 Z - 3-5--ffi» -trAZ-35103-7A Z-35103-1 Z-36848 Z-36025 Z-36027 Z-36026 Z-706076X Z-37602-- NLf:... Z-92534 Z-706075X Z-36277 Z-38553 AA _. Z-706045X 1'. "

Z-35725 Z-3-4-5711X Z-30275 Z-30271 ~ "

O\d

Nut 2JJ I q'J-q 16 Adapter lt PI If II L "r/ I / 16 Axle, R:H. n'ta1row':J.-OiQ30- O,n~j-Q<, {VI

Axle, L.H. narrow- ~(; I 13 '1- 5 no "'-1-- ..25 YJ 'I Axle, wide J 0 It:; 38 ___ LL U)/..J-v I p I.e. m (C;1- 2 Stud d () ;),/15 16 Nut 1-c I q Lf 0 2 Lockwasher J () () C( 4l 2 Nut J-(j ( Cj £.11 2 BearingJ,0/(.j{UG ,., ,/~ 2 Hub, wheel rJ;.: u:)~ t Jt',' U Lit. ( Ilt L t..- 2 Bolt, wheel;) {' I ct d 3 10 Bearing 'j-O ( q61 2 Seal ') C ( q ~ ') 2 Gasket )..0 I L'It.! ~ 2 Shim ) 0 I Y O(!)..{)D 0 As Req'd Bearing ~l) ( q I) ~ .< 1 Slinger .~ u 1 ~ D.?- - 6[,(.; 1 Seal ). (; ! cr '_~cl 1 Yoke, end 3 / i uS -Dc· 1 Was her ~ (; ( q 3 J.- 1 Nut r.?O{Cfj I 1 Baffle 30 (401-000 1

)

\ J

45 22 NA Shim As Req'd 45 23 Z-706060X Bearing dO \~~lo 1 45 24 NA Gear and pinion set 1 45 25 NA Shim As Req'd

--) 45 26 Z-706070X Bearing dO I <=15 ~ 2 45 27 NA Spacer 2 45 28 Z-706059X Kit, gear cover ~61 955 1 45 29 Z-18432X Cover assembly 1 45 30 Z-36472 Plug 20 '{ if5 1 45 31 Z-34822 BOlt.:2-o { 3 S- 10 45 32 -Z-34687 Gasket,9-o I CJ 54 . 1 45 33 Z-500400-20 Bolt )"CJ ( q 5{ 4 45 34 NA Cap, bearing 2 45 35 Z-500598-22 Pin :J--(j I q 5~ 2 45 36 Z-36660 Case ~ /q4? 1 45 37 Z-30266 Bolt d...O I q 30 12 45 38 NA Shaft 1 45 39 NA Washer, thrust 2 45 40 NA Washer, thrust 2 45 41 NA Gear 2 45 42 NA Pinion 2 45 43 Z"'2969-81rX Housing, axle ~6.~ t-o ~ a 1

~~?l~ S0-Q -45 1K Z-706061-4X Kit, drive gear and pinion dO IQeol 1 45 14 NSS Shim As Req'd 45 15 NSS Bearing 1 45 16 NSS Slinger 1 45 17 NSS Seal 1 45 19 NSS Washer 1 45 20 NSS Nut 1

-) 45 21 NSS Baffle 1 45 22 NSS Shim As Req'd 45 23 NSS Bearing 1 45 24 NSS Gear and pinion set 1 45 25 NSS Shim As Req'd 45 27. NSS Spacer 2 45 32· NSS Gasket 1 45 35 NSS Pin 2 45 2K Z-706065X Kit, differential case :2 t I q 57 1 45 25 NSS, Shim As Req'd 45 26 NSS Bearing 2 45 27 NSS Spacer 2 45 32 NSS Gasket 1 45 35 NSS Pin 2 45 36 NSS Case 1 45 37 NSS Bolt 12 45 38 NSS Shaft 1 45 39 NSS Washer, thrust 2 45 40 NSS Washer, thrust 2 45 41 NSS Gear 2 45 42 NSS Pinion 2 45 3K Z-706058X Kit, differential parts 2..0 I q 5 + 1 45 32 NSS Gasket 1 45 35 NSS Pin 2 45 37 NSS Bolt 12

) 45 38 NSS Shaft 1 45 39 NSS Washer, thrust 2 45 40 NSS Washer, thrust 2 45 41 NSS Gear 2 45 42 NSS Pinion 2


FIGURE ii6 FRONT AXLE DRIVE SHAFT ASSEMBLY (C-30014)

)


Fig. ' Item . 07 ~ 1 ~o \qg,# for i # PART # NAME /y \ p< _Assy. Unit

46 1 Z5-160X Kit, U-joint lor CJ50·. 2

) 46 2 NSS Fitting, grease 1 46 3 NSS Yoke and tube 1 46 4 NSS Washer, felt 1 46 5 NSS Washer, retainer 1 46 6 NSS Cap, dust 1 46 7 NSS Yoke 1

~)


FIGURE #47 TRANSMISSION COVER AND ADAPTER ASSEMBLY

II) .,...

\

.,... N

co

)

LD/LL P-IOO JUNE 1985

Fig. Item"" . "1 for # # PART # NAME Assy. Unit

47 1 P-11143-03 . Screw, cap to

) 47 2 P-ll009-0S Lockwasher 10 47 3 P-11016-03 Washer, flat 10 47 4 C-30052 Cover, case 1 47 5 P-12459 Vent, air 1 47 6 A-30081 Cap 1 47 7 P-11242-43 Pipe 1 47 8 P-11867-04 Pin, cotter 1 47 9 P-11806-10 Nut, jam 1 47 10 8-30051 Fork, shaft 1 47 11 P-12318-05 Plug, 0 ring 1 47 12 P-12391-05 o ring 1 47 13 A-14903-01 PI Wlger, ball 1 47 14 B-30053 Rod, shift 1 47 15 P-I1039-26 Seal, oil 1 47 16 P-14994-12 Screw, cap 4 47 17 P-11009-08 Lockwasher 4 47 18 P-11,016-27 Washer. flat 4 47 19 C-300S4 Adapter 1 47 20 P-11890-06 Pin, dowel

(see fig. , .. ) '-I-!5 ? 2 47 21 Case assem bly 1

~ ~nV ~ 8i3J40()1

)

)

JUNE 1985 LD/LL P-I01

- - ASSEMBLY T SHAFT E 148· TRANSMISSION INPU FIGUR

4

LD/LL P-I02

)

)

)

JUNE 1985

, .>' /.;

Fig. Item ~ . -{ , for t'-# # PART # NAME Assy. Unit

48 1 P-11143-04 Screw, cap 4

) 48 2 P-11009-06 Lockwasher 4 48 3 P-11016-03 Washer, flat 4 48 4 B-30037 Cap, top 1 48 5 B-30041-01 Shim, .005 As Req'd 48 5 B-30041-02 Shim, .010 As Req'd 48 5 B-30041-03 Shim, .020 As Req'd 48 6 P-II025-07 Ring, retaining 1 48 7 P-11205-11 Bearing 1 48 [) P·w11205-G7 B(;;u.dl1g 1 48 9 P-11039-25 Seal, oil 1 48 10 A-30036-02 Spacer 1 48 11 P-II05'1-11 Key 2 48 12 B-30006 Gear 1 48 13 A-30036-01 Spacer 1 48 14 B-30008 Gear 1

t'-~ ~,'" ~ ! C' . (! '. ' , '::' ..... .:.. ~ , :..~~;.. :

48 16 Case assem bly (see fig. #49) 1

)

)


FIGURE '49 TRANSMISSION IDLER SHAFT ASSEMBLY

LD/LL P-104

(\ I

)

)

JUNE 1985

Fig. Item i for # # PART # NAME Assy. Unit

49 1 P-11143-04 . Screw, cap 4

) 49 2 P-11009-06 Lockwasher 4 49 3 P-11016-03 Washer, fiat 4 49 4 P-11039-23 Seal, oil 1 49 5 8-30044 Cap, center 1 49 6 8-30043-01 Shim, .005 As Req'd 49 6 8-30043-02 Shim, .010 As Req'd AQ ~ 'P.,I)"n ~ ~-n~ ~'"'~':"'" fVH'I .,.. p,::(~'~

49 Yl P-11205-0S Bearing 2 49 8 P-11898-06 Ring, retaining 2 49 9 8-30010 Gear 1 49 10 C-30007 Gear 1 49 11 A-14897 Bearing, needle 2 49 12 C-30045 Shaft 1 49 13 A-14902-01 Rmg, retaining. : 2 49 14 8-30012 Gear 1 ~g ,~ ?-?nn,,, r ",11 "'" , ; .... '"'~t ..

.....

49 16 C-30009 Gear 1 49 17 P-11936-11 Bearing, thrust 1 49 18 P-11832-03 Plug 1 49 19 Case assembly (see fig. #50 ) 1

)


FIGURE 150.TRANSMISSION OUTPUT SHAFT ASSEMBLY

)

)

LD/LL P-I06 JUNE 1985

Fig. Item # # PART # NAME Unit

50 1 A-14900-01 Locknut 1

) 50 2 A-14898 Washer 1 50 3 A-14899 Seal 1 50 4 0-30015 Yoke, end 1 50 5 P-11039-24 Seal, oil 1 50 6 P-11143-04 Screw, cap 4 50 7 P-11009-06 Lockwasher 4 50 8 P-11016-03 Washer, flat 4 50 9 B-30050 Cap, bottom 1 50 10 B-30043-01 Shim, .005 As Req'd 50 10 B-30043-02 Shim, .010 As Req'd 50 10 B-30043-03 Shim, .020 As Req'd 50 11 P-11205-09 Bearing 1 50 12 C-30011 Gear 1 50 13 P-11205-10 Bearing· 1 50 14 0-30035 Case 1 50 15 B-30042 Shaft 1 50 16 P-11039-22 Seal, oil 1 50 17 0-30017 Yoke, end 1

-)


FIGURE .51 R'EAR AXLE DRIVE SHAFT ASSEMBLY (A-30016)

1

. 1

)

5

~)

LD/LL P-I08 JUNE 1985

# ~:for PART # NAME Assy. Unit

51 1 Z5-160X Kit, U-joing 2-D I CJ So 2 51 2 NSS Coupler 2

) 51 3 NSS Nut 4 51 4 NSS Lockwasher 4 51 5 NSS Screw, cap 4

)


FIGURE '52 "CRADLE INSTALLATION ASSEMBLY

)


Fig. Item ,,~ # for' # # PART # NAME Assy. Unit

52 1 P-14994-05 Screw, cap 6

-) 52 2 P-11009-08 Lockwasher 6 52 3 P-11016-04 Washer, flat 6 52 4 A-30165 Pin 1 52 5 P-11015-44 o ring 1 52 6 A-30160 Washer 1 52 7 A-30158-02 Bearing 1 52 8 D-30151 Cradle 1 52 9 P-11898-10 Ring, retainer 1 52 10 P-11015-41 o ring, .139 2 52 10 P-11015-42 o ring, .210 2 52 10 P-11015-43 o ring, .275 2 52 11 A-30161-01 Washer, .125 flat 2 52 11 A-30161-02 Washer, .• 187 flat 2 52 11 A-30161~03 Washer, .250 flat 2

·52 12 P-11160-01 Fitting, grease 2 52 13 A-14842-01 Connector 2 52 14 A-14840-01 Tube 2 52 15 A-14841-01 Elbow, 900 2 52 16 A-30158-01 Bearing 1 52 17 A-30162-02 Pin 1


)


Wtule/PurP"e

PUl~

Grdy

""&~f@; 11 \6

7 7.-'

-:;:'" -;-

Deere Engine J ---------17 0;,,' Olu'" I

L ___ " __________ l~

.... co 00 t.T1

G,., c::\r~ ~--=--~~J:L

~ -:r t:.n9lne 0.1 PresSure

GdUQ'

I---Ae~,y~

I le" _~"V\."'*"_

I

I I

I --~ I

I

I 17 I I

17 D ... Blu,· I L _____________ l~

'/Iolel 27

Blown

Cyhnoe' He'" Tel"np4!Ialu/e Se""",

-'j !i

Ii} E"'J''''' 0.1 I !. P'~"u,. 50,,,,... I I

I

....,. co 00 c.n

L

Gray

!

j

L'9""ng I

HydrauloC ()I Volimetet' TKhc>l'Mief Houfmet... Fu.t Le"- T~.,Uf.

Gaug. G_ G.ouve Gaug. ,G.ouve

12

Spa,. Pluo

I

'., I "

I:" I'

___ ~o~a~Engjne J, ,~

, . .... ,.

FIGURE'5~6 DE ,'" " ' ERE WIR ... . ~G HARNESS " ( ASSEMBLY

':J - ~OL')O 0 'cw. ")

)

)


I·,

Fig. Item " 'for # # PART # NAME Assy. Unit

56 1 A-49733 Bulb, light 6 ~) 56 2 A-14879 Temp. hydraulic oil 1

56 3 A-14881 Fuel, level 1 56 4 P-26204 Hourmeter 1 56 5 B-30842 Tachometer 1 56 6 A-14880 Meter, volt 1 56 7 A-14877 Pressure, oil 1 56 8 A-14878 Temp. water 1 56 9 A-14826 Switch, ether 1 ,..,..

.~~.' ki. ~.:~;2 3wL~:;';li) 19Hhlon 1 56 11 A-14874 Switch, light 1 56 12 A-14868 Flasher 1 56 13 A-14826 Switch, horn 1 56 14 P-11885-04 Screw, machine 2 56 * P-11009-02 Lockwasher 2 56 15 P-11621-02 Nut 2 56 16 A-25275-04 Fuse, 20 AMP As Req'd 56 17 A-30515 Block, fuse 1 56 18 P-25427-02 Hom -r--' ~ 1 56 19 P-11261-05 Nut 2 56 20 P-I1009-05 Lockwasher 2 56 21 P-11S54-04 Screw, cap 2 56 22 F9700S24 Switch neutral dO 0 s ~ 7 , 1 56 23 A-26363 81 Switch, back-up:;J D l/"l 9 . CJ 0 1 56 24 P-11176-01 Screw, machine 2 56 * P-II009-03 Lockwasher 2

) 56 25 A-30S00 Plate 1 56 26 02676015 Sendor, hydraulic oil 1 56 27 A-14911-04 Screw. machine 2 56 ~8 h.--49957 Breaker, circuit (40 AfyiP) 1 56 29 A-11419-03 Nut ? 56 30 04195013 Sendor, oil pressure, 1

56 31 04-l-9-41H-&- Sendor, water temp. 31;;" 'It/ i-lO 3 1 56 32 A-30648 Sendor, fuel L/gq:5 f"-D L) 1 56 33 QG19401 Solenoid ass em bly (see fig. #25 ) 1 56 34 P-II009-06 Lockwasher 2 56 35 P-/1143-04 Screw, cap 2 56 36 A-~ Alarm, back-up 0 5 3 c., I - 0 c) 1 56 37 NA Fuel,shut off(secure this part locally) 1 56 38 NA Alternator (secure this part locally) 1 56 * A-14827 Tap, A. c. 1 56 38 A-30935 Alternator, sealed (see fig. #15) 1 56 39 NA Starter (secure this part locally) 1 56 40 0-30692 Harness, wiring 1 56 41 Lighting (see fig. #$)5C( 1

)


FIGURE #57- DEUTZ WIRING HARNESS ASSEMBLY

)

-)


~)

.)

,

Fig. Item # # PART #

57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57 57

~,

57 57 f'"'"

57 57 57 57 57 57 57 57 57 57 57

1 2 3 4 5 6 7 8 9

10 11 12 13 14 15 16 17 18 19 •

20 21 22 23 •

24 25 26 27

2g 29 30

A-49733 A-30648 A-1-4'&Si P-26204 A-14828 A~14880

A-14877 NA A-14.8?6 F9700S24 A-14874 A-14872 A-14868 A-14826 P-11854-04 P-I1009-05 P-11261-05 P-25427-02 P-11885-04 P-II009-02 P-11261-02 A-25275-04 A-30515 P-11176-01 P-11009-03 A-26363-01 A-30800 02676015 NA

ui;i19~ulj

A-14911-04 A-49957

32 <...Ao 3084e 33 QG19401 34~ 35 P-11009-06 36 P-11143-04 37 A-30796 38 A-30742 * A-14827

39 NA 40 D-30693 41

JUNE 1985

NAME

Bulb, light Temp. hydraulic Fuel, level /IJ- & 71 D10-HOl.lrmetp'l" Tachometer Meter, volt Press ure, oil Temp, Head (secure this part locally) S'Ni~'"'~) pthn'1"

Swi tch, ~~'~tral dOO.5 ~ 7 Switch, light Switch, ignition Flasher Switch, horn Screw, cap' Lockwasher Nut Horn Screw, machine Lockwasher Nut Fuse, 20 AMP Block, fuse Screw, machine Lockwasher Switch, back-up Plate Sendor, hydraulic oil Sendor, head tern p. (~,e"l11"e t.his "'-B.rt l()""'p lJv)

benoo£', 011 pi.'essure Screw, machine Breaker, circuit (40 AMP)

Sendor, fuel tl995fS -() '0 Solenoid assem bly (see fig. # 25 ) Switch, neutral ~D6 5~'1 Lockwasher Screw, cap Alarm, back-up Alternator Tap, A. C. Starter (secure this part locally) Harness, wiring Lighting (see fig. # 60 )

# for Assy.

6 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 2 1 2 2 2

As Req'd 1 2 2 1 1 1 1

1 2 1

1 1 1 2 2 1 1 1 1 1 1

Unit

LD/LL P-119

'FIGURE'ISS CONTINENTAL WIRING HARNESS ASSEMBLY

;:~\ ,

;:;

LO/LL P-120

C7'I M

CD I')

,.... I')

JUNE 1985

\

)

)

Fig. Item-"" -# for # # PART # NA."·'fF i.~.r~y • Uilit

58 1 A-49733 Bulb, li~ht 6

-) 58 2 A-14879 Temp. hydraulic 1 58 3 A-14881 Fuel, level 1 58 4 P-26204 Hourmeter 1 58 5 E-.. 30842 Tachometer 1 58 6 A-14880 Meter, volt 1 58 7 A-14877 Pressure, oil 1 58 8 A-14878 Temp, Water 1 58 9 A-14826 Switch; horn 1 58 10 A-148"l2 Switch, ignition 1 58 11 A-14874 Switch, light 1 58 12 A-14868 Flasher 1 58 13 P-11854"""04 Screw, cap 2 58 14 P-II009-05 Lockwasher 2 58 15 P-11261-05 Nut ? 2 58 16 P-25427-02 Horn- J 1 58 17 P-11885-04 Screw, machine 2 58 18 A-30515 Block, fuse 1 58 19 A-25275-04 Fuse, 20 AMP As Req'd 58 * P-II009-02 Lockwasher 2 58 20 P-11261-02 Nut 2 58 21 P-11176-01 Screw, machine 2 58 * P-II009-03 Lockwasher 2 58 22 A .... gSS89 61 SrN1tch, back-up ~o~7q-O 0 1 58 23 A-30800 Plate 1 58 24 A-14911-04 Screw, machine 2 58 25 A-49957 Breaker, circuit (40 AMP) 1

) 58 26 A-11419-03 Nut 2 58 27 02676015 Sendor, hydraulic oil 1 58 28 04195013 Sendor, oil pressure 1 58 29 A-14875 Sendor, fuel 1 58 30 04194015 Sendor, water temp. 1 58 31 NA Coil (secure this part locally) 1 58 32 ~ Swi tch, neutral 2tJa 5) 7 1 58 33 P-1I009-06 Lockwasher 2 58 34 P-11143-04 Screw, cap 2 58 35 A-30796 Alarm, back-up 1 58 36 NA Starter (secure this part locally) 1 58 37 N A0...on+i f\..ev\. ~ A.f Alterna tor (secure this part locally) 1 58 38 A-30935D-e...-e(~ Alternator, sealed (see fig. #15) 1 58 39 0-31023 Harness, WIrIng 1 58 Lighting (see fig. #--) 59 1

)

JUNE 1985 LD/LL P~121

FIGURE #59 'WORKING AND TAIL LIGHTS Y -:;'6000 - O~

)

)


Fig. Item # ·;foi~· # # PART # NAME Assy. Unit

59 1 B-14867-01 Light, rear 2 59 2 NSS Retainer 1

) 59 3 NSS Light #4409 seal 1 59 • NSS Light, red 2 Cf) ..::.J 4 NSS Shall 1 59 5 NSS Bushing 1 59 6 NSS Washer 1 59 7 P-11129-08 Nut 1 59 • P-II009-08 Lockwasher 1 ~~ 8 b-14865-01 Llgtrt, flashing 2 59 9 P-11129-08 Nut 1 59 10 P-II009-08 Lockwasher 1 59 11 NSS Washer 1 59 12 NSS Washer '00 rubber 1 59 13 NSS Socket 1 59 14 NSS Bulb, #1156 light 1 59 15 NSS Screw 1 59 16 NSS Body, lens 1 59 17 A-14868 Flasher 1 59 18 A-14874 Switch, light 1 59 19 B-14866-01 Light, head 2 59 20 NSS Retainer 1 59 21 NSS Light, #4406 seal 1 59 22 NSS Shall 1 59 23 NSS Bushing 1 59 24 NSS Washer 1 59 25 P-11129-08 Nut 1

~) 59 * P-II009-08 Lockwasher 1 59 26 D-30692 Harness, wiring 1 Deere 59 26 D-30693 Harness, wiring 1 Deutz 59 26 D-31023 Harness , wiring 1 Continental

\ JUNE 1985 LD/LL P-123

. FIGURE 160'POWER COMPONENT WIRING

. --.'-.. --.. i

qo-l

Suppli ed wi th Engine

)


Fig. Item\'':';' # #

60 1 en n

-) 60 3 60 4

)

JUN E 1985

PART #

B-49808-08 "1 C'~'

B-49807-08 }r f..

.J-

NAME

Cable, positive

Cable, negative 8~' '~r'" .! ') . "~1 t

(secure 'tills part locally) 27 group, 70 AMP 30H group, 90 AMP .

if;for ,.:.~. :.:::-t·

Assy. Unit

1 1

1

Gas Diesel

LD/LL P-125

FIGURE 161 LL-40 HYDRAULIC CONTROL SCHEMATIC

Ir=---

'-----1 tlD ........ 1

.S 21 e....+J Q) C <l.> 0

U) 0 I

LD/LL P-126

I

tIDe.... C Q) ._ "0 t... C Q).Q)+J>a r:nO

,- ----,

I 0 -:=: I I 0

~I :E ::l I

0... '------4 L __ _

)

JUNE 1985

~~:'~·f~~{~~~~~1~t~~ ~R~"~l.t§f~~!~::·;.·f~\;;··):~;t:~~~~Wj~r;i~~{%r.~f~~t~? 1:::~~;;~ ~ .".' . ~,~ i"::.i:!~~,~:' ;,),~ .. &~@tf;>: ~"";;i':'Ff; ;,,';!~~;;o~~,:,~;(~ ;'*;:;'~:;} ",((,,;';i;:;:i,;i"'~¥"L:};:':f'~;>'~:"'<; " . ,r" ',' '" ' ,,:"<i(:f~~\~v:,;H;: ,i'e' ;:\};,::;::,r;;"~;";iL::'.

,~'. "';~"FIG-URE,,·~t 62"LD~50' ' HYDRA,ULIC:' CONTROl; &J'-' "'&·;&.JU&~'&

)

)

JUNE 1985

rr---I

~--~~+--~

-o c.. cv ~>

§~ 0>

I

I

!

r' I

1.......-

I

[~ l ---- - --

I

~I ::Sl o.c ~--

I

--1 I

I

l

'"' <l> ~

E.S o~ o~ coo

LD/LL P-121

CJ

~ I

181 '", <: 1

x~ i I

I

I

I

l ___ _

r----

I LL

I

I Z a:

~ I

~ Q, I {j E ~::::l ::co...l

I

I

____ J

,I

----l I

I

~----- ............. .....--~

LD/LL P-128

)

JUNE 1985

)

FIGURE '64 HYDRAULIC SCHEMATIC SYMBOLS

<!> Cooler

Filter

Check Valve

Female Coupler

> Male Coupler

1----1 Component Enclosure

1 ____ J

Pump

Control Lever

JUNE 1985

o

Hydraulic Lines Crossing

Hydraulic Lines Joining

Reservoir

Cylinder

Engine Enclosure

LD/LL P-129

FIGURE '65 RESERVOIR ASSEMBLY

t ---+---...;..--

LD/LL P-130

.1 V

)

)

JUNE 1985

Fig. ;,Item~

# #

65 1 "5 2

)~ 3 4

65 5 65 6 65 7 65 8 65 9 V,I

65 11 65 12 65 13 65 14 65 15 65 16 65 17 65 18 65 19 65 20 65 21

)

JUNE 1985

PART # l-oQ1SCf -CO ~ A-30306 QQ-7312-009

D-30635 P-15680-07 P-11677-07 B-30305 .L ... 11 ~~, ,,'" v"- ~ 0/:'"

A-30532 A-14885-01 P-14972-08 B-14859-06 A-M8l0 G2 P-11143-04 P-11009-06 P-11016-03 B-30311 B-30307 B-30304

) I

NAME Assy. Unit

Gauge, sight 1 Valve, relief 1 Element, filterdL'IOtfLJ 1 o ring 1 Valve, reli2f 1 Reservoir 1 Cap 1 Elbow, 90° 1 Filter assembly (see lif" .. ~(dp 1 J.: .d .. ;.g J t--'ly'-- . lit'; 1 Elbow, 90° 1 Reducer 1 Adapter 1 Clamp, hose 2 Hose 3J.270-- 00 1 Screw, cap 5 Lockwasher 5 Washer 5 Coupler 1 Gasket 1 Strainer 1

LD/LL P-131

FIGURE 166 FIL'TER ASSEMBLY (B-30305)

3

7

-)


Fig. Item: ":for It # PART # NAME Assy. Unit

66 1 NA Head 1 ')6 2 K-1576-001 Gasket C).OO(oL/5 1

~) ,6 3 K-23036A Element, filter dO() (0<..00 1 / 66 4 NSS Gasket 2

66 5 NSS Element 1 66 6 NA Spring 1 66 7 NA Case i 1 66 8 K-1575-001 Gasket dOD c.oY 1 1''' e \. r A

I' Pc'1~n~n""

)

)


FIGURE #67 HYDROSTATIC PUMP AND MOTOR HOSE ASSEMBLY

\ \

\

LD/LL P-134

\

\ o

JUNE 1985

)

Fig. Item # for # # PART # NAME ASsy. Unit

67 1 P-22012-05 Fitting, 90° 2 )~7 2 P-12391-07 o ring 1

.: 7 3 A-30001 Motor, hydrostatic (see fig. ~'ll 1 67 4 A -30356-01 Hose assem~ + 5- MP-2553-16

, 67 Kit, flang 67 6 P-11015-40 o ring 67 7 8-30355-02 Hose 1 67 8 A-30976 Pump, hydrostatic (see fig. #69,98,71) 1

(/3, "q, 7~ y\.Q..e.d s b r Q c../G-c-r Ct S S Lj

3 (j 3 ~ (;, - 0:3 '-,- :) p ex

S/N-ALQS'Clf3IL)('/{) - ID()/3 4- foo/7 - IOOIC{ (1 rY1ac/tllneS)

LL 5 ~(.J I ~Q / of hc.s e, 3/ 4:;21 (J 0 / ci-- 311-:2D CC_3 ~ i I"t sf- e (L d Q +=- 2> ()?,J t6 to - 0 I ~ '303 S (;, -0 3

) sl Ol I h r. ;) GU I I Ii SIAl A L q S G I r3 I 0 () :2 6

N 0 Lt) LL S e - 3 / 4- ~ :J. 0 a q C ~ per j - rep I ("-t C. (:' ~/

36 350, -() ( HC>5e_ 2> D:3 50 -0'3 c I C'--I~l~) 5 e f-- ,

)

JUN E 1985 LD/LL P-135

FIGURE #68 HYDROSTATIC PUMP ASSEMBLY PART #1

)

)

)


Fig. ltemi~


68 1 F9221184 Kit, cylinde.r 20 C L/ (j ') 1 S8 2 F92'20739 Plate ,? D 0 4 qo 1

'~,38 3 F9220633 Pilot J L c·Lf '6 S 1 ,IS8 4 F9006250-0231 R i n g .? 0 () '-I (; 7 1

, "',. .... 0 'I') r"l.., , ") ~ •

~ I ) ""1.:.'/ ...... ··'-.1

68 6 F9221066 Spring 1 68 7 F9220042 Seat, spring 1 68 8 F9240217 Pin dW 195 1 68 9 F9221102 Block 1 RR 10 F9?,21105 Spring .2(1 04 q ~ 6 68 11 F9220500 Guide 2. () 6 L/ S S-- 1 68 12 F9220628 Retainer 1 68 13 F9510408-0001 Kit, piston )Do S I 7 '3 68 14 F9220015 Guide, spring 2. 0 01,9' () 1 68 15 F9220626 Plate :J-061S1 1 68 16 Housing (see fig. #43--) &q 1 68 17 F9009610-4069 Washer ~co tf7,5" 12 68 18 F9007200-3722 Screw 12 68 19 F9510189 Kit, seal ~()C 5() 4 1 68 20 F90067201-0334 Ring, retaining 1 68 21 F9210168 Retainer, seal 1 68 22 F9004100-2340 o ring .~ c () 40 S 1 68 23 F9004610-1212 Pin 1 68 24 F9220242 Spring J. t () '-lSi 6 68 25 F9004101-1290 o ring .160 J-f-f.) 2 68 26 F9210329 Kit, seal 2-C>DJ.-j7Cj 1 68 27 F9330418 Cover 1

)~~ 28 F9004800-3708 Pin ,-~L:d 19 l.D 4 29 F9220427 Gasket :1-t c 4'~ t1 1

68 30 F9510256 Bearing d...OC "'-;c8 ~

1 68 31 F9220944 Shaft ~"i't7 i q" 1 68 32 F9220990 Plate !l00Q ~ 1 68 33 F9510255 Bearing JJ:;t S () 7 1 68 34 F9004800-3100 Pin 1 68 35 F9220425 Gask e t :l (" L' '~i .,' ~ 1 68 36 F9510423-0003 Ki t, shim .-=2 tc ::;2. C 1 68 37 F9220996 End, cap pump 1 68 38 F9009610-4069 Washer. fla t .2 C- e,:' Lj. ; C; 9 68 39 F9007200-3736 Screw 5 68 40 F9007200-3728 Screw 3 68 41 F9800648 Val ve. check.1c c' .C;.2 '-( 2 68 .:12 F9004101-150 o ring2C{;1-/1/ 1 68 43 NSS Valve 1 68 44 F9510365-0003 Kit I pump " 1 68 45 F9007200-2536 Screw 4 68 46 F9009610-2850 Washer 4 68 47 NSS Pump (not repairable) 1 68 48 F9801235 Gasket .)( ~·C S :3 7 1 , -< ,j/ F q c C 110 I - [ /4' C C l'Jvv. '~l JCC4/l;


FIGURE #69 HYDROSTATIC PUMP ASSEMBLY PART #2


Fig. ; !tenl> ~#,~for # # PART # NAME Assy. Unit

69 1 F9007200-3712 Screw, cap 6 69 2 F9009610-4069 Washer 1.000/15 6

~)~~ 3 F9220018 Trunnion 2 4 F9510422-0003 Kit, trunnion shim 1

69 5 F9004100-2300 o ring 1oofo7 2 69 6 F9510257 Bearing {lo 0 50 q 2 69 7 F9221250 Housing 1 69 8 F9006300-0062 Ring 4 69 9 F9220570 Plate:Lo () L{-S /P 1 69 10 F9004830-0002 Pin aoo 43<l 2

," -'j r ,., ,-" ".

69 12 F9006375-0026 Ri~g";;;; 6 '0: :¥ 7:J 11 2 69 13 F9800210 Link 1 69 14 F9004201-2500 o ring Jooi.f20 1 69 15 F9005100-4400 Plug {)6 D 44Lf 1 69 16 F9005001-1200 Plug, pipe;2.QoLfLf3 1 69 17 F9510482-2001 Neutral control assembt[: (see fig. #70»)CJ6§~ 69 18 F9221049 Piston assembly ~()O ct, 2 69 19 F9221017 Link 1 69 20 F9006300-0062 Ring, retaining 2 69 21 F9004830-0002 Pin ~ 0 Lf- ~<6 1 69 22 F9221012 Piston 1 6'] 23 F9~~F')583 c::1)riqo' .:2. c C 50 ()

'--',' .•. b .. 1 69 24 F9220479 Guide 1 69 25 F9009625-0034 Washer, flat 1 69 26 F9007276-0056 Screw" 1 69 27 F9510207 - Sleeve assembly;ZO() 505 2 39 28 F9004100-1420 o ring d-.6o L{ 05 1

)69 29 F9004100-1440 o ring :l. 00 Lf 0 b 1 -~ 69 30 NSS Sleeve 1

69 31 F9220419 Retainer ). 6 u 4- 8 :J- 2 69 32 F900726-0011 Screw ~ 0 6 4-0 4 4

~ <16 01 'J 7 ~ - 00 II

)


FIGURE 170 NEUTRAL CONTROL ASSEMBLY (F9510482-2001)

N

LD/LL P-140

(0 ("')--

cn~_ ("')

8~ \ ~ co N

l() ("')

N

JUNE 1985

Fig. Item # for # # PART # NAME Assy. Unit

70 1 F98-2472 Gasket d0054 :3 1 )ry~ 2 F9801721 Link assembly 3 ( 3alC-)(' S- 1

3 F9004875-0055 Pin 10044- J- 1 70 4 F9004100-0100 o ring ?- c c 3q <X 1 70 5 F9802586 PI ug ~ (; () 53<1 1 70 6 F9004201-5000 o ring ~cc 41. d-- .. 1 70 7 F9009625-0081 Washer, back-up .Jool-f7~ - 1 70 8 F9802587 Nut :)(;6640 1 70 9 F9003575-0049 Locknut :>--603"-] 1 1 70 10 F9700824 Switch, neutral 00 S~ 7 -- / 1 70 11 F9800905 Link

!to¢tI ~ 70 12 F9800908 Stop ~0o~3 I 70 13 F9800909 Link ? J 30 () 0 OJ 70 14 F9006375-0026 Ring, retaining.· 02 Ie 3 - I . ~~ ~ 70 15 F9Q04100-0230 o .. ! r g ~,.. 0 II C 3 p\. 1 l J. I .;/ V I

70 16 F9800997 Bushing dDo 58i!- 1 70 17 F9004101-0120 o ring /)00 L/ oq ( {l 70 18 F9800204 Shaftd(~c:.~~~, ~ ,I (}k~ 1 :' u 19 LJ30G; .c7 S9d.eer (> cJ .. -' -,' ,-,. . I tj~ ~ 70 20 F90'09 660 - 2500 Washer, tooth,;Loo '-II ;I 70 21 F9003560-2500 Nut ;;;"00.3 1 (,P 70 22 F9006320-0050 Ring, retaining d 00- oSc~ / 1 70 23 F9801931 Spring d C)Z2 33 0

I ~ 70 24 F9801930 Sleeve 70 25 F9802589 Actuator 106 ~~c{ I 70 26 F9004700-1216 Pin, roll :1..0 () 4-:29 I 1

)~ 27 F9007200-2530 Screw 9 28 F9009610-2850 Washer 9

,0 29 F9802585 Housing 1 70 30 F9004101-0140 o . ring c.l.cO 41 0 3 70 31 F9801094 Plug ;}.oO'535 1 70 32 F9005100-4400 Plug ;;"001+4 2 70 33 NA o ring 1 70 34 F9803333 Spool 1 70 35 F9009625-2502 Washer 2 70 36 F9801036 Spring 1 70 37 F9801035 Sleeve 1 70 38 F900 6326-.. 0025 Ring, retaining 1 70 39 F9003575-0001 Locknut 1 70 40 F9004100':'0190 o ring :).6041)- 1 70 41 F9800214 Housing 1 70 42 F9004101-0140 o ring:) VL.- Li I .... 1 70 43 F9803304 Screw 1 70 44 F9003561-7500 Nut t jam 1 70 45 F099883 Cover 1

)


FIGURE #71 HYDROSTATIC MOTOR ASSEMBLY (A-3000l)

J

Fig. Item :± for :; # PART # NAME .-\ssy. Uni t

71 F9220416 Housing 1 ;1 .) F9004800-3112 Pin f}C},\CIJ L.

71 :3 F9005001-1200 Pl ug J, () 6 Lt ~ ~l -t F9510189 f\: it, seal d.-o(J So~ 71 5 F9006201-0334 !ting, reta.ining ).bo4c?3 71 t3 f9210168 Seal. retalnmg ;1 - f9004100-2340 l) ring ,~CfOL~O~ I , 71 8 F9004610-1212 Pin 71 9 F9220242 Spri~g l()O~~ \ 71 10 F9004101-1290 o rmg i-()O ~ \~ ~1 11 F9210329 f(it, seai ~CC 1q 71 12 F9220992 Plate ~GC>-\G\C)

) 71 13 F9004800-3708 Pin 71 14 F9510256 Bearing 1- (" D '? Di

.)

71 15 F922097~ Shaft ').00 4Cl)


71,;' 16 F9 2 2 O~6'8,9·:': 71 17 :P9221i'84'; f}

71 18 F9220739 71 19 F9220633 71 20 F9006250-0231 11 21 F9220043

f ---)71 22 F9220015 71 23 F9221066 71 24 F9220042 71 25 F9240217 71 26 F9221102 71 27 F922110S 71 28 F9220500 71 29 F9220628 • J. vV F95..i..uL,tu b-OO(}1 71 31 F9005100-8700 71 32 F9004201-6200 71 33 F9510255 71 34 F9004800-3110 71 35 F9220425 71 36 F9510423-0003 71 37 F9220999 71 38 F9009610-4069 71 39 F9007200-3736 71 40 F9007200-3728 71 41 F9510083-50 71 42 F9009610-3459 71 43 F9007200-3142 71 44 ~lSS

71 45 NSS ,'I 46 NSS

')71 47 NSS ./ 71 48 NSS

71 49 NSS 71 50 F9510438-5000 71 51 F9006110-1170 71 52 F9006150-1190 71 53 F9004201-8700 71 54 NSS 71 55 NSS 71 56 NSS 71 57 NSS 71 58 NSS 71 59 NSS 71 60 F9510049 71 61 F9004101-1190 71 62 F9004100-0200 71 63 F9006150-1190

)

!-TUN E 1985

, Pl~ f:e/;;:Q;OQ;firg~;0~i':~f:j,r'~{~*;;~1:C,<t~~I{;~;';:~;~i>l~~'1";~J~;)h~'.;~~r:~~¥J;',:~·:\~\{

Kit, cyHnde'r blocR 1ootfqQ"'" , -, i

Plate, bearing J-cct-/qO Pilot :1. 0{; '-I S'b Ring, retaining J 00''-1-57 Retp,'ner-, spring ,/0

Guide, spring )60'loD

Sea t, spring Pin Block, cylinder Spring ~O()'-I4 ~ Guide ~ oot-/~S Retainer Kit, piston J 605 '? Plug o ring 1 cc·4.2 3 Bearing ~ co 561 Pin ;; 60 t.! ~6 , Gasket, end cap ~oo 4 S3 Kit, shim ~ Co S 1.0 End, cap loot.jq" Washer, flat :LOot/15 Screw, cap Screw, cap Kit, manual valveJOD603 Washer, flat 26041'-1 Screw, cap Cap Spring Shim Spool and body Plug o ring Kit, high pressure valve.2 t (. E).} d..-

Ring, back-up 9.. uot.!4)1 o ring ,? ~G4 i-fq o ring.)'GoLf.;lS Body, val ve Valve, relief Cap Shims S~ring Poppet Kit, seal.2 CC 5L~1.. o ring:2. c;.. ~ /4 o r in g ,,~ , I,' j i c .1. Ring, back-up l.1( Cl 1L/{1

1 1 1 1 1 1 6 1 1. 3 1 1 1 1 1 1 1 8 5 3 1 6 6 2 2

As Req'd 1 3 1 2 2 1 1 1 1 1

As Req'd 1 1 1 2 1 2

LD/LL P-143

FIGURE #72 PUMP AND RESERVOIR ASSEMBLY

1.0

M

)

o 1"-

",.---------------1- __ i_ ~1l / / ~~

/ I



72 1 P-25108-08 Adapter 2 )72 2 P-12391-06 o ring 1

~ 12 3 0-30318 Valve, steering (see fig. ~)73 1 ('2 4 8-30354-03 Hose assembly 1 72 5 8-30354-10 Hose assem bly 1 72 6 P-14884-06 Tube 1 72 7 P-25108-10 Adapter 1 72 8 P-12391-08 o ring 1 72 9 P-22012-05 Elbow, 90 0 1 72 10 P-12391-07 o ring

fig. ~14 1

72 11 0-30927 Pump assembly (see 1 72 12 P-14952-02 Insert, bleaded 1 72 13 P-12391-11 o ring 1 72 14 8-14859-06 Clamp, hose 2 72 15 A-14810-02 Hose 1 72 16 C-30660 Tube 1 72 17 P-22013-04 Tee 1 72 18 P-12391-08 o ring 1 72 19 A-14912-05 Reducer 1 72 20 8-30911 Diffuser 1 72 21 8-30355-01 Hose assem bly 1 72 22 Reservoir assem bly (see fig. Wt)6~ 1

)

)


FIGURE 173 STEERING CONTROL VALVE ASSEMBLY. (D-30318)

~)

~--~

I.l) .....

0')



73 1K NSS Seal 1 ~-, 7 '3 ~ G14317 ~.

(t::Ldiner :2 ou S 03 L.LJ~lg , -) 73 3 G7443 Bushing 9- 0 c Scr1 1 .~ 73 4K NSS Seal 1

73 5K NSS Seal, quad ring . 1 73 6 G64009 Kit, needle bearing ;).00 sq 3 1 73 7 NSS Race 2 73 8 NSS Bearing 1 73 9 G14380 Screw, set 1 73 10K NSS Seal 1 73 11 G8318 Seat, check ball j.06~ 6;1- I 73 12K NSS Seal 1 73 13 G18001 Ball d 0 ~ a L/ f! 1 73 14 G6862 Retainerc2Lbl. 3L/9 1 73 15 G8334 Control assembly 1 73 16 NSS Housing 1 73 17 NSS Sleeve 1 73 18 NSS Spool 1 73 19 G370 Spring 6 73 20 G15 Pin 1 73 21K NSS Seal 3 73 22 G7970 Plate~Ob(PDO 1 73 23 G5126 Drive 1 73 24 G8436-07 Gerotor 1 73 25 G20642 Spacer 1 73 26 G8438 Cap 1004;c5 1 73 27 G5389-6 Screw, cap 7

~) 73 K G64418 Kit, seal dOD 5 7 S 1 (contains parts indicated by letter 11K")

NSS-Not Sold Seperately

)


Torque to 40/50 ft .fIbs.

2

4

~=+-.---28

~27 Do Not ~ 25

Remove. ~5 From HOUSlng~

24 23

22

~'

Bronze Side of Plate Must Contact G~rs

-'=' I W o co t-.:)

-.:J -

Fig. Item It # PART # NAME - Unit

74 1 QY16119-634 Screw, cap J 0 I C; 1 Cj 4

) 7: 2 QY16119-632 Screw, cap ;) (; J ~ 1 'I 4 3K NSS Seal, oil 1

74 4 QY24500-501 Plate, fron t 2- [' I <£; D D 1 74 5K NSS o ring 2 74 6K NSS Ball 2 74 7K NSS Spring 2 74 8K NSS Secl, dinph:Lagm 1 74 9K NSS Gasket, protector 1 74 10K NSS Gasket, back-up 1 74 11K NSS Diaphragm 1 74 12 QY24504-311 Gear, drive;;) 0 \ lo 0 ~ 1 74 13 QY24504-307 Gear, idler~o \ lo (Y, 1 74 14 ~ Body&J @'-I50 '/ J6-l .~OIG()& 1 74 15 QY16028-722 Pin;" dowel ~o I ~50 2 74 16K NSS Plate, thrust 1 74 17 Q:l:24S30-24 NS 5 Plate, back ~ I I~ 0'+' 1 74 18 QY20500-45 Plug 1 74 19 NSS Ring, back-up 1 74 20 NSS o ring 1 74 21 QY24530-610 Spool 1 74 22 QY16224-013 Plug 1 74 23 NSS o ring 1 74 24 QY20500-9 Shim ).. 0 , '55)9 3 74 25 QY15439-9 Shim ~ C J 531 1 74 26 QY15439-7 Spring). 01 S 30 1 74 27 QY32015-71 Pop pe t "). 0 I /p 4' g 1

-) t! 28 NA Orifice 1 29 QY20500-33 Spring ~ 0 J c5~)~. 1

74 30K NSS o ring 1 74 31 QY16169-2160 Plug ~CJI 619 1 74 K A-30458 Kit, seal 1

( contains parts indicated by letter "K") NSS-Not Sold Separately NA-Not Available

)


FIGURE #75 STEERING CYLINDER AND HOSE ASSEMBLY

5


;"2,;;~kFig •


75 1 D-30318 -60 Valve, steering (see fig. ~) 73 1 "'5 2 P-25108-08 Adapter 2

)~ 3 P-12391-06 o ring 1 4 8-30354-04 Hose ass em bly 1

7C 5 P-22012-04 Elbow, 90° 2 75 6 P-12391-06 o ring 1 75 7 0-30343-01 Cylinder, steering (see fig. ~)7? 1 75 8 8-30354-05 Hose ass em bly 1

)

JUNE 1985 LD/LL P~151

FIGURE #76 STEERING CYLINDER ASSEMBLY (0-30343-01)

)

co


Fig. Ite,m- ;:ii" for # # PART # NAME Assy. Unit

76 1 P-11160-11 Fitting, grease 2 76 2 8-30349-01 Tube, cylinder 1

~) 76 3 A-14908-12 Nut 1 " 76 4K NSS Ring, wear 1

76 5 8-30350 Piston 1 76 6K NSS o ring 1 76 7K NSS o ring 1 76 8K NSS Ring, back-up 1 76 9 A-30126-06 Bushing 2 76 10 8-30347-01 Rod, cylinder 1 76 11K NSS Wiper) rod 1 76 12K NSS Seal, rod 1 76 13K NSS Ring, wear 1 76 14 C-30351 Head 1 76 15K NSS o ring 1 76 16K NSS Ring, back-up 1 76 K A-30397 Kit, seal 1

(contains parts with the letter "K")

~)


FIGURE #77 LL-40 VALVE AND RESERVOIR ASSEMBLY

)


Figr;'''Item;' ,. # # PART # NAME Assy. Unit

77 1 Resef'vrir Bssembly (see fig. #66) 1 "7 2 8-30354-10 Hose assembly 1

) 7~ 3 Pump assembly (see fig. #73) 1 4 P-25106-03 Adapter 2

77 5 P-12391-07 0 ring 2 77 6 D-30689 Valve, control (see fig. #79 ) 1 77 7 8-30355-04 Hose assembly 1

)

~)


Note: a ve S Control V 1 upplied Without Relief Val ve

11

9

14

':

~5 7

8 -o I

Co) o 0)

00 co -

•

Fig. IteJl!; ,1:'- ... /il;~:f~r'}3""iil\tL~;::i~t;, # # PART # NAME Assy. Unit

78 1 QY30501-17 Plug {). 6 I G I q 3 78 2K NSS. o ring 1

)78 3 QY30501-13 Spring :J. C (L: (~ 3 78 4 QY30501-12 Pltmger 1 c I f£ 17 3 78 5 QY16103-110 Plug Jc I ")-'lC 1 78 6K NSS 0 ring 1 78 7K NSS 0 ring 3 78 8 NA Body 1 78 9 NA Spool 1 78 10 NA Spool 1 78 11 NA Spool 1 78 12 QY30501-10 Washer, deep 'J- 0 I 01 (,0 3 78 13 QY16048-31 Spacer :).0 I 500 3 78 14 QY17125-10 Spring :J-o I SS,;f 3 78 15 QY15546-6 Washer, shallow:2.0 I ~ 3 '3 3 78 16 QY30501-390 Screw, spool ;2 0 I to f-~ , 2 78 17K NSS o ring 3 78 18 QY16048-1 Spacer ::L CIS £ 1 78 19K NSS Ring, retainer 1 78 20 C-30882 Valve, relief 1 2 stage 78 20 C-30883 Valve, relief 1 3 stage 78 21K NSS 0 ring 1 78 22K NSS Ring, back-up 1 78 23K NSS 0 ring 1 78 24 NA Valve, relief 1 78 K A-30781 Kit, seal 1

( contains parts indicated by letter "K")

) NSS-Not Sold Separately NA-Not Available

)


FIGURE #79 LD VALVE AND RESERVOIR ASSEMBLY

)


Fig. Item < II forr" It 1# PART # NAME Assy. Unit

79 1 Reservoir assembly (see 'rig. #..6lli (:"5 1 79 2 8-30354-10

) 79 3 79 4 8-30355-04

Hose assembly 1 Pump assembly (see fig. #1f..3.) 1d.- 1 Hose ass em bly 1

73 5 P-25108-09 Adapter 2 79 6 P-12391-07 79 7 B-31199- 00

o ring 2 Valve assembly (see fig. #&g) 80 1

j S poo I Val Cfe... -

add 5ed-i~h~ for- J-/ Sf{)O ( :5ed{~on~ /I:. 3l;)oO-O()

)

)


FIGURE #80 LD-50 HYDRAULIC CONTROL VALVE (B-M~ tfb 2\'~~-

LD/LL P-160

. £.13 C1)~_----::s • O'c::: r... 00 E-c~

)

JUNE 1985

Fig. Item';cfi , 'I ,e

# #. P'ART 41 tf'-1or Assy.

80 1 80 1

')30 1 / 80 2

20 ~ ,..I

80 4

80 5 80 6 80 7 80 8 80 9 80 10 80 11 80 12

.)

)

K-6105-A K-6106-A K-6107-A NSS

NAME

Stud and nut assembly Stud and nut assembly Stud and nut assembly Nut

:'SS Stud 1862-020-WC-2100 Cover, inlet (see fig. ~)g(

1 1 1 6 3 1

PSI-15GPM 6814-001 6815-001

A-31200 .... 0 0

6770-007-1727 K-6016 2709-001

o ring dC:"(,~ ~ S I As req'd o ring c"").L)O <0& ~ As req'd Boom valve assembly (see fig. #U1 <l J.- 1 Bucket valve assembly (see fig. #~)9'?2f 1 Optional valve assembly(see fig. #-if,) ~ 1 or 2 Cover, outlet 1 Plug 1 o ring 1

-

Unit

2 spool' 3 spool 4 spool


FIGURE "'81 INL'ET COVER ASSEMBLY (KIOSi-6781-014 )

) M .,...

)


Fig. Item #I ##

81 1 81 2

1 3K

),l 4 ,.31 5 81 b 81 5 81 6 81 7 81 S' 81 9 81 10K 81 11K 81 12K 81 13 81 K

)

)

JUN E 1985

PART;,'~F'·, ,

K5012-6136-003 NSS NSS

NSS K458-001 K458-UOI K462-001 K-19002 NSS NSS NSS NSS NSS NSS

NA K-6006-C

J O~ 1U ;)0

" ;~ , .,-'

NAME"'~

Valve, main relief ,~O 0 b b ~ Cap . o ring Spring Shim ,040 0 .. 0 rom) ~nim .020 (0.5 mm).1000{?( Shim .010 (0.3 mm) Kit, service poppet ~C()lv4q· Poppet o ring Body o ring Ring, back-up o ring Body Kit, mainrelief.seal.-(contains parts indicated by letter "K")

it ,for AssY.'

1 1 1 1

As Req'd As Req'd as Req'd

1 1 1 1 1 1 1 1 1

" unit " "

LD/LL P-163

~ (0

00 CJ1

40 42 4~. 44

'I 38 39 41

36 ,,7

, 35

~

~ C0' 0' ~

~ o. ,

FIG. ITEM':/i}i. '. c >

# # PART #

82 q2

\ J2 ) 82

[: L. 82 82 82 82 82 82 82 82 82 8'2 82 82 8'-

bL:

82 82 82 82 82 82 82 82

-2

)~~ 82 82 82 82 82 82 82 82 82 82 82 82 82 82 82 82 82 82 82 82 82 82 -2

),2

-1 2 3 4K

6K 7K 8K 9

10 ~11

12 13 14

--15 16 17 1 8

-18 20 21K 22K 23K 24K 25K 26 27 28 29 30 31 32 32 32 33 34

-35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52

JUNE 1985

K-6030-A NSS K-6032 NSS

NSS NSS NSS NSS NSS K-6033-A NSS NSS NSS K-IRl S-OOJ. NSS NSS NSS K -tiO 1 ~-3838-004 K-6005A NSS NSS NSS NSS NSS

NSS NSS NSS K-19002 NSS NSS K-0458-001 K-0459-001 K-0462-001 NSS NSS K-6063 NSS NSS NSS NSS NSS NSS NSS NSS NSS NSS NSS NSS NSS NSS NA NA NA

NAME

Plug, load check ,'1 (; b ~j 1" 3 Plug Kit, load check plug seaJ.1 {;()01 if o ring }ling, back-up o ring Ring, back-up o ring Spring Poppet

"i-for Assy.

1 1 1 1 2 1 1 1 1 1

Unit

Retainer, standard Lockwasher

seaJ.~b0076 1

Plate Screw Kit; s!:)oc1 C19ftl ~oO(p41 -Ring, back-up o ring

Relief, cylinder _).. OO~, I.e ~~ Kit, seal 1. () D ~'0~ o ring o ring Ring, back-up Ring, back-up o ring Poppet Spring Body, relief Kit, poppet:1 606.· t-f'1 o ring Poppet Shim .040 (1.0 m m )

2 . f 1 '/; v-5(d k {- -

. I -~.5 un (\lc.-', t) ~fZl-' .- 2 - 50...1

~ c .....--,-r I /} n rJ -t ell ~ " I ,r. i-{ ~rrl\ \ ... LL'- ,',) i 3 (3 c:/-l 06

1 1 2 1 1 2 1 1 1 1 1 1 1

Shim .020 (0.5 mm)J.C6b'-l1.Shim . 010 ( 0 . 3 m m )

As Req'd As Req'd As Req'd

Spring Cap Positional, float j c c (-, '"I -; Sleeve o ring o ring Sleeve Spring Follower Ball Bonnet Collar, stop Spring Ring, retainer REtainer, seal ring Lockwasher Screw Spool/body (matched set) Body Spool

1 1 1 1 1 1 1 1 1 4 1 2 1 1 1 2 2 1 1 1

LD/LL P-165

FIGURE 183 BUCKET VALVE ASSEMBLY

)

)


'FIG. (IT:EM # ;:# . b. c: ':-P ARTi:?#C;·JlA /j:§Sd

83 1 K5652-??45 664 83 2 K-6005A 83 3 NSS '"l3 4 NSS

)8~ 5 NSS 6 NSS

83 7 NSS 83 8 NSS 83 9 NSS 83 10 NSS 83 11 K458-001 83 11 K459-001 83 11 K462-001 83 12 K-19002 83 13 NSS 83 14 NSS Q1 1.5 NSS bj 16 NSS 83 17 NSS

1 P \!Q,~

83 l~ NSS 83 20 K-6033 83 21 NSS 83 22 NSS 83 23 NSS 83 24 K-6806-001 83 25 NSS 83 26 NSS 83 27 NSS

); 28 NA 29 NA

- 23 30 NA 83 31 K5012-3838-004 83 32 K-6005A 83 33 NSS 83 34 NSS 83 35 NSS 83 36 NSS 83 37 NSS 83 38 NSS 83 39 NSS 83 40 NSS 83 41 K-19002 83 42 NSS 83 43 NSS 83 44 K458-001 83 44 K459-001 83 44 K462-001 83 45 NSS 83 46 NSS 83 47 K-6020 83 48 NSS 83 49 NSS 83 50 NSS

1 51 NSS

J.3 52 NSS 83 53 NSS 83 54 NSS 83 55 NSS

JUNE 1985

. .. N AM K;)UvtE{~# ... ' ' . Check t lmit-cavitation ¥ ~{)O tt J.j Kit, seal 'it (~61' o ring Ring, back-u.p o ring Ring, back-up o ring Poppet Cap Spring Shim (.040) Shim (.020) Jcc ~Lf J Shim (.010) Kit, service poppet ,I) u {} Ie ~ q Poppet o ring

Req'd AS Req'd As Req'd

1 1 1

Poppet 1 Spring 1

Spring Retainer, standard seal.) CC 0-7 j Screw Lockwasher Plate , Kit, spool seal .1CO(: S L

Retainer, seal ring Ring, back-up o ring Body/spool (match set) Body Spool Relief, cylinder ~i ~ (. C~· ).. Kit, seal :)CCC:(:s o ring Ring, back-up o ring Ring, back-up o ring Poppet Spring Body Kit, service poppet.? L L C: LI9 o ring Poppet Shim .040 Shim .020 J~ (4::£./ 'j.

Shim .010 Spring Cap Positioner, spool 1 c [. l. " I Collar Spring Collar, spool Lockwasher Screw, cap Cap Lockwasher Screw, cap

1 1 2 2 1 2 1 1 1 1 1 1 1 1 2 2 1 1 1 1 1 1 1 1 1

As Req'd As Req'd As Req'd

1 1 1 2 1 1 1 1 1 2 2

LD/LL P-167

FIGURE #84 OPTIONAL VALVE ASSEMBLY (A-31200)

LD/LL P-168.

..... .....

... -4._.~

)

JUNE 1985

FIG. 'ITEM't£k:;"c:, ~ J; 4t'~6t


84 1 K-6030-A Plug, loadcheck 10 6 (.,~7 3 2

84 2 NSS Plug 1 ) d4 3 K-6032 Kit, load check plug seal :J t C (" '/L/ 1

84 4K NSS Ring, back-up 1 84 5K NSS 0 ring 1 84 6K NSS Ring, back-up 2 84 7K NSS o ring 1 84 8K NSS o ring 1 84 9 NSS Spring 1 ~4 ID ri~.S .c!OW,;;;! 1 84 11 K-6033-A Retainer, standard seal :JOO~?S - 1 84 12 NSS Screw 2 84 13 NSS Lockwasher 2 84 14 NSS Plate

,it-, J:0.l.0CtU 9,~' c .!

, [ rf 1 /':: 1. ~ .. -..:..:J..lL~._;. - --------------;,~ i i.:) , i 1 84 16 NSS Retainer, seal ring 1 84 17 NSS Ring, back-up 1 84 18 NS3 0 ring

spool ~ 00 0 ~) I 1

84 19 K-6020-B Positioner, 1 84 20 NSS Collar 2 84 21 NSS Spring 1 84 22 NSS Screw 2 84 23 NSS Collar, spool 1 84 24 NSS Lockwasher 1 84 25 NSS Screw 1 84 26 NSS Positioner 1 84 27 NSS Lockwasher 2

) ,4 28 NA Body/spool (matched set) 1 84 29 NA Spool 1

--' 84 30 NA Body 1


FIGURE #85 PUMP AND COOLER ASSEMBLY

)

/ /

I )

LD/LL P-170 JUN E 1985

# fof PART # NAME Assy. Unit

85 1 Reservoir assembly (see fig. #"")~5 1 '"'') 2 P-25108-10 Adapter 1

- J 3 P-12391-08 0 ring 1

~~ 4 8-30355.,.03 Hose assembly 1 5 8-30359 Cooler; oil 1

85 6 P-14972-09 Adapter 2 85 7 8-30355-06 Hose assembly 1 85 8 P-25377-04 Elbow, 90 0 1 85 9 P-12391-07 0 ring 1 pc; , " f\.-'H)q7~ n"~"n l-~"','" :.1,.,.""' ..... ~ -:'. :~. ~ :~. (:::::, :; fi6, . it}. C Sc-;"r{h-~-l--)' 1 . "'''p, •• .1 .... , .. ' ......... .;.., ......... "" ........

85 11 P-22012-05 Elbow, 90 0 b~ 09, 10 1 85 12 P-12391-07 0 ring 1 85 13 8-30355-05 Hose assembly 1


FIGURE '86 BUCKET CYLINDER AND HOSE ASSEMBLY

u")


FIG. ITEM # #

86 '. 86 ) 86

86 86 86 86 86 86

1 2 3 4 5 6 7 8 9

PART #

C-30360 P-22012-05 P-12391-07 C-30334-01 B-30354-09 B-30354-08 P-25108-09 P-12391-07 B-30353

NAME

Tube assem bly Elbow, 90 0

o ring Cylinder, bucket (f' rJ 1 see 19. #.i.i:-) ~ Hose assem bly Hose ass em bly Adapter o ring Valve, c rmtrol (s,pp fi~~ #,g~.)go

. #::.fbr Assy.

1 2 1 1 1 1 2 2 1.

Unit

:;imdL ~ HU ~W~ /!J677 -()Lj-~ ~ ~ ~ bnv4--erl~dv; /~Y59-/;;J.


FIGURE #87 LOADER BUCKET:CYLINDER ASSEMBLY (C-30334-01)

LD/LL P-174

~ .-4 ..........

o~ -+-'

Q)LO

::3~ 0' .......... t...o OLO E-oM

co

)

)

JUNE 1985

FIGURE #88 LOA.DER BOOM LIFT CYLINDER AND HOSE ASSEMBLY

)

)


iFIG. '-ITEM # for # # PART # NAME Assy. Unit

87 1 P-11160-11 Fitting, grease 2 q7 2 B-30342 Tube, cylinder 1 ) 87 3 A-14908-26 Nut 1 87 4K NSS Ring, wear 1 87 5 8-30336 Piston 1 87 6K NSS o ring 1 87 7K NSS o ring 1 87 8K NSS Ring, bac k .... up 1 87 9 1\-3.0126-03 Bl}rhing 2 8(' 10 B-30340 Rod, cylinder 1 87 11K NSS Wiper, rod 1 87 12K NSS Seal, rod 1 87 13K NSS Ring, wear 1 87 14 C· .. 30335 Head 1 87 15K NSS o ring 1 87 16K NSS Ring, back-up 1 87 K A-30395 Kit, seal 1

( con tains parts with the letter "K")

)

)


FIG. ITEM ;:~ i tor, o of';


89 1 P-11160-11 Fitting, grease 2 89 2 B-30327-01 Tube, right hand cylinder 1

) 39 3 B-30327-02 Tube, left hand cylinder 1 89 4 A-14908-22 Nut 1 &J 5I~ ~·JS3 Ring, WedC 1 89 6 B-30326 Piston 1 89 7K NSS o ring 1 89 8K NSS o ring 1 89 9K NSS Riner ' be.cl,(:-\1.T) 1 89 10 A-30126-04 Bushing 2 89 11 B-30331-01 Rod, cylinder 1 89 12K NSS Wiper, rod 1 89 13K NSS Seal, rod 1 89 1·1K l-TQQ 1, ...., ..... Ring, Vi..:;ar 1 89 15 C-30332 Head 1 89 16K NSS o ring 1 89 17K NSS Ring, back-up 1 89 K A-3039B Kit,seal 1

)


FIGURE 190 MAST TILT CYLINDER AND HOSE ASSEMBLY .,

)

)


IT~~":"": # for ~ .~-., ~., ,~y"- ~~::'~'

FIG. : ~.? ~ ~ :" ~ .. . .. ~ .. ". :

","

# # PART 4# NAME Assy. Unit

88 1 B-30354-02 Hose assembly 4 ~ 88 2 P-22012-04 Elbow, 90 0 4 ) "-88 3 P-12391-06 0 ring 1

88 4 C-30333-01 Cylinder, R .H. (see fig. ~'31 1 0'1 5 p_. :1485 '-14 Nut, jam 2 v'"';

88 6 A-14887-04 Tee, bulkhead 2 88 7 B-30354-07 Hose assem bly 1 88 8 B-30354-06 Hose assembly 1 88 9 P-25108-09 Ad80ter 2 88 10 P-12391-07 0 ring 2 88 11 B-30353 Valve, control (see fig. #-irJr) $0 1 88 12 C-30333-02 Cylinder, L.H. (see fig. ~)~q 1

)


FIGURE '89 LOADER BOOM LIFT CYLINDER ASSEMBLY (C-30333-01, C-30333-0'iY: ,~'\i:-,

co

LD/LL P-178

/ /

\ \

• ~ f

JUNE 1985

)

)

FIG. ITEM # ,for._ I # PART 1# NAME Assy. Unit

90 1 P .... 22012-04 Elbow 90° 2

) ~~ 2 P-12391-06 0 ring 1 3 C-30333-03 Cylinder, tilt (see fig. ~) 4j 2 10°/20°

0(1 3 S-3n3~1-r '~ Gy1jn.;'?" ; tq~ ('<(:i'? fl(~ ., ~) (7 I 2 10°/1Do 9U 4 rl-3LJ354-1~ Hose assembly 4 90 5 P-25108-08 Adapter 2 90 6 P-12391-06 0 ring 2 90 7 A-14887-04 Tee, bulkhead 2 90 8 P-11486-14 Nut. i8'"'1 .r.

/.

~0 9 B-3uJ~4-0ti Hose assembly 2 90 10 P-25108-09 Adapter 2 90 11 P-12391-07 0 ring 2 ,-. n

~. ? n-,:)f\fi'i,) V2J.V ",'-.,,,\ i- ,._,.' I ~- ,.. It' .,'1 • ...., ...... ..., ." r! t7 1 J ...... '\...'" ... " ... v ..... \ .... ~ ;,. ..... 6 (;j "Ij': .. -v'- i I ()

)

)


FIGURE '91 MAST TILT 'CYLINDER ASSEMBLY (C-30333~03, C-30333-04)

LD/LL P-182

1\ U)~ ;~

)

)

JUNE 1985

FIG. ITEM- - # for-# # PART # NAME ASsy· Unit

91 1 P-11160-11 Fitting, grease 2 - '),1 2 B-30327-03 Tube, cylinder 1

) '1 3 ,'. "'\

Nut 1 .... ........; ..... \.,. i. .,

91 4K NSS Ring, wear 1 91 5 B-30326 Piston 1 91 6K NSS o ring 1 91 7K N&C:; o ring 1 91 8K NSS Ring, back-up 1 91 9 A-30126-04 Bushing 2 91 10 B-30331-02 Rod, cylinder 1 91 11K NSS Wiper, rod 1 91 12K NSS Seal, rod 1 91 13K NSS Ring, wear 1 91 14 C-30332 Head 1 91 15K NSS o ring 1 91 16K NSS Ring, back-up 1 91 17 A-30881~01 Spacer, 100 /10 0 1 91 K A-30396 Kit, seal 1


FIGURE #92 HYO'RAULIC SYSTEM FOR GRAPP~E BUCKET

-)

16

--~--13

7 ) 19

23

)


FIG. ITE~M ' .'4r:for. # # PART # NAME Assy. Unit

92 1 P-11170-n Nut 4 _-.., 12 2 P-11009-6 ) )2 3 P-15677-3

92 4 P-11261-6

Lockwasher 6 Clam p, hose 4 N~ 2

92 5 P-15677-4 Clamp, hose 4 92 6 P-25108-9 Adapter t straight 2 92 7 P-15818-7 Hose as . _'.,/ ,t,

92 8 P-15898-2 Fitting, bulkhead 2 92 9 A-30962 Swivel, hydraulic 1 92 10 B-30961 Bracket, swivel 1 92 11 P-15818-8 Hose assembly 2 92 12 A-14887-2 Tee, bulkhead 2 92 13 B-30963 Hooe 1 92 14 P-15818-9 Hose assembly 1 92 15 P-15818-11 _ . Hose = assembly. .-' 1 92 16 P-15818-12 Hose assem bly 1 92 17 P-22012-4 Elbow adjustable 4 92 18 A-14807 Clamp, hose 2 92 19 8-30960 92 20 0-30343-2 92 21 A~

31J06-00

Tube assem bly 2 Cylinder assembly (see fig. ~ q3 2 Valve, section kit (see fig. ~) 'SCI 1

)

~----------

.)


FIGURE #93 GRAPPLE BUCKET CYLINDER ASSEMBLY (D-30343-02)

. ~ ~ .

LD/LL P-186

)

JUNE 1985

FIG. ITEM "for # # PART # NAME Assy. Unit

93 1 P-11160-11 Fitting, grease 2 ~) 93 2 B-30349-02 Tube, cylinder 1

93 3 A-14908-12 Nut 1 93 4K NSS Ring, wear 1 93 5 B-30350 Piston 1 93 6K NSS o ring 1 93 7K NSS o ring 1 93 8K NSS Ring, back-up 1 93 9 A-30126-06 Bushing 2 93 10 B-30347-02 Rod, cylinder 1 93 11K NSS Wiper 1 93 12K NSS Seal, rod 1 93 13K NSS Ring, wear 1 93 14 C-30351 Head 1 93 15K NSS o ring 1 93 16K NSS Ring, back-up 1 93 K A-30397 Kit, seal 1

(contains parts indicated by letter "K")


FIGURE '94 MAST LIFT CYLINDER AND HOSE ASSEMBLY

)


FIG. ITEM ~ .•.. ~ • ::.= : ';", for # # PART # NAME Assy. Unit

94 1 D-30603-03 Cylinder, lift (see fig. iaB-) q~ 1 2 stage

) 7'10"/10'6 ft

94 1 D-30603-08 Cylinder, lift (see fig. ~q6 1 2 stage

:: (>'<"') qJ~ 9'10"/14'6"

-I

~.~ .• ~0 Gv 3,"':) v C'ylinJ~r ) Hl~ {dee lAg' • 1 3 stage "" ..i.

.l. w~ -) 9'10"/21 '6"

94 2 A-30320-01 Control, now 1 94 3 P-25377-09 Elbow, 90 0 1 94 4 .c--12391-Ui:l 0 ring 1 94 5 B-30354-14' Hose 1 94 6 P-25108-09 Adapter 1 94 7 P-12391-07 0 ring 1 94 8 D-30689 Valve, control (see fig. ~)1g 1

)

)


FIGURE #95 CYLINDER ASSEMBLY (0-30603)

LD/LL P-190

. ~ ~ .

)

JUNE 1985

)

Item No.

2 3 4

5 6 7 8 9

10 11

12 13 14 15 16 17 18 19

Part Number

30603-03 30603-08 30603-09 11176-01 11897-03

30605-03 30605-08 30605-09 30555-00 30556-00 30612-01 13857-01 30586-00

N.S.S.

30606-03 30606-08 30903-08

N.S.S. N.S.S.

30589-00 N.S.S. N.S.S. N.S.S.

30396-00

3170/3175 3200/3210 3500/3510

Rev. 10/98

MAST CYLINDER ASSEMBLY --L\++) (3500/351 0)

Qty. Description Assembly, Mast Cylinder (Includes Items 2-18)

1 2 Stage, 7' 10" / 1 0' 6" 1 2 Stage, 9' 10" / 14' 6" 1 3 Stage, 9' 10" /21' 6" 1 Screw, Machine 1 Washer, Seal

Tube, Cylinder 1 10' 6" 1 14' 6" 1 21' 6" 1 Nut, Retainer 1 Pin 1 Spring 1 Bull, Steel 1 Piston 1 Ring, Wear (See Item 19)

Rod, Cylinder 1 10' 6" 1 14' 6" 1 Rod, Cylinder (21' 6") 1 O-Ring (See Item 19) 1 Ring, Backup (See Item 19) 1 Bearing 1 Ring, Wear (See Item 19) 1 Seal, Rod (See Item 19) 1 Wiper, Rod (See Item 19) 1 Kit, Seal (Includes Items 10, 13, 14, 16-18) r-; \ c: --' ~

\

Sell I /Ct'V' £VI {'II jCod 3//j!; If

Check ~v~r

4.24

( ,

(.

FIG. ITEM' , 'for # # PART # NAME Assy. Unit

<?: 1'-1'.17? .n.., ~ .... .,. C,~,li ~ .. ,.' ") f"\ ; ..... ~ ~ ,f"! 1 '. ~,' Jo h" t I , ~ ... ~-. -'_ ... -" .. ,.... -,

) 95 2 P-11897-03 Washer, seal 1 95 3 0-30605-03 tube , cylinder 1 10'6" 95 3 0-30605-08 Tube, cylinder 1 14'6" 95 3 0-30605-09 Tube, cylinder 1 21'6" 95 4 0-30555 Nut, retainer 1 95 5 B-30556 Pin 1 95 6 A-30612-01 Spring 1 ~5

F" ~"'~ 1 !rI\"'1-rJ 0'1 '1';-.... ", ,,~ .. ; 1 I .A ¥·"'..l.~_V iii -"'...L A-,..'¥o~t ...PrI.:"";~.i.

95 8 B-30686 Piston 1 95 9K NSS Ring, wear 1 95 10 0-30606-03 Rod, cylinder 1 10'6" 95 10 D-30606-08 Rod, cylinder 1 14 '6" 95 11 0-30903-08 Rod, cylinder 1 21'6" 95 12K NSS 0 ring 1 ~5 13K NSS Ring ~ h\C1ck.-uD l ~ • .1 1: ~. ~~vi.) ",.,/ ·....,v .L... -.:.~.".-). 111g' 1.

95 15K NSS Ring, wear 1 95 16K NSS Se~1 , rod 1 95 17K NSS Wiper, rod 1 95 K A-30624-bO Kit, seal 1

(contains parts indicated by letter"K") NSS-Not Sold Separately

)


FIGURE 196 FULL' FREE LIFT 3 STAGE MAST CYLINDERS AND HOSE ASSEMBLY:

..-

V""

~/~ .. ;:::::::==:::O)~rb!!!!!!!~ ) \

~

II')

)


FIG. ITEM ,I 'for # # PART # NAME Assy. Unit

96 1 0-28150-20 Cylinder ass em bly (see fig. is&') q7 1

) 96 2 P-12391-09 o ring 1 96 3 A-40108 Fuse 1 96 4 B-26646 Tube 1 96 5 C-30354-28 Hose assem bly

Ikti)t? f 1

96 6 0-28131-02 Cylinder assem bly (see Fig. 1 96 7 C-31168 Tube 1 96 8 P-15677-03 Clamp 2 96 9 P-I1016-03 Washer,· fiat 2

1 r. "" "'il,~ '! ~" r ":., -'-'}" t"~

96 11 P-11261-06 Nut 2 96 12 C-30354-27 Hose assem bly 1 96 13 P-25108-09 Adapt'er - " 4 96 14 P-12391-07 0, rmg 1 96 15 P-22012-04 Elbow, 90° 1 96 16 P-12391-07 o ring 1 96 17 P-25349-04 Tee 1 96 18 A-30320-01 Control, flow 1 96 19 B-30354-14 Hose assembly 1 96 20 P-12391-07 o ring 1 96 21 0-30689 Valve, control (see fig. US) 7g 1

)


FIGURE '97 - 3 STAGE FREE LIFT CYLINDER ASSEMBLY (D-28150-20)

)

)

LD/LL P"'194 JUNE 1985

FIG. ITEM • for # # PART # NAME Assy. Unit

97 1 P~176-01 Screw 1

) 97 2 A 992-01 Washer, seal 1 97 3K NSS Wiper 1 97 4K NSS Seal 1 S7 r::.I\ NSS Ring, wear 1 97 6 C-28142 Bearing, head 1 97 7K NSS Ring, back-up 1 97 8K NSS o ring 1 97 9 B-30555 Retainer, nut 1 (\1'? "'l -', -"".,0 r~.·" "!

97 11 A-30612-01 Spring 1 97 12 P-13857-01 Ball, steel 1 97 13 B-28137 Piston 1 97 14K NSS Ring, wear 1 97 15 C-28141-02 Rod, ,cylinder. 1 97 16 D-30980-02 Tube, cylinder 1 ril'q ',. 28182 Kit, seal 1

(contains parts indicated by letter "K") NSS-Not Sold Separately

)

)


FIGURE 198 - 3 STAGE STAGING CYLINDER ASSEMBLY (D-28131-02)

)


MAST CYLINDER ASSEMBLY I--l L+) (3500/351 0) 1\ \ i

Item No. Part Number aty. Description 1 Assembly, Mast Cylinder (Includes Items 2-18)

30603-03 1 2 Stage,?' 10" / 1 0' 6" 30603-08 1 2 Stage, 9' 10" / 14' 6" 30603-09 1 3 Stage, 9' 10" /21' 6"

2 11176-01 1 Screw, Machine 3 11897-03 1 Washer, Seal 4 Tube, Cylinder

30605-03 1 10' 6" 30605-08 1 14' 6" 30605-09 1 21' 6"

5 30555-00 1 Nut, Retainer 6 30556-00 1 Pin 7 30612-01 1 Spring 8 13857-01 1 Bull, Steel 9 30586-00 1 Piston

10 N.S.S. 1 Ring, Wear (See Item 19) 11 Rod, Cylinder

30606-03 1 10' 6" 30606-08 1 14' 6"

12 30903-08 1 Rod, Cylinder (21' 6") 13 N.S.S. 1 O-Ring (See Item 19) 14 N.S.S. 1 Ring, Backup (See Item 19) 15 30589-00 1 Bearing 16 N.S.S. 1 Ring, Wear (See Item 19) 17 N.S.S. 1 Seal, Rod (See Item 19) 18 N.S.S. 1 Wiper, Rod (See Item 19) 19 30396-00 1 Kit, Seal (Includes Items 10, 13, 14, 16-18) r-l ~ C '?'

.:, "./ .", -' ---- ':""':""

~ ': ' ~, \ l.l.. -;;c, ,-,.,,, .... \ ~\\ , ~~("\-U~ >-6. d4...Jtt-...1~ "\ , .. '~ ( 1 I __ 1 f I I \ ~ ...) _., _6- ~I -~---- _I '. . .... \ ~ __ :(.-_ .;-1 .

'-.~ \;'"5-_ 1

,; ~\. CL- ~.~ .

f'e ,,'1 --+-\ ~ <:::, ~ r I ' , --. _, ._... _' ' .... \ \...-./ _~ d·~b_. :.

- wi (c;! jeod 31/~ If

fJf( 71 30b2Y170 Sell I /c/v

Check hr;r

3170/31753200/32103500/3510 4.24 Rev. 10/98

(

t. tl

FIG. ITEM '-·for # # PART # NAME Assy. Unit

98 1 P-11176-01 Screw 1

-) 98 2 A-49992-01 Washer, seal 1 98 3K NSS Wiper 1 98 4K NSS Seal 1 98 5K NSS Ring, wear 1 98 6 C-28142 Bearing, head 1 98 7K NSS Ring, wear 1 98 8 P-11890-03 Pin, dowel 1 98 9K NSS o ring 1

" ....... c, c

.... ",' ""'" ,>_ •. " -' J ... 98 11 B-30556 Pin 1 98 12 A-30612-01 Spring 1 98 13 P-13857-01 Ball, steel 1 98 14 B-28137 Piston 1 98 15K NSS Ring, wear· 1 98 16 C-28139-02 Rod, cylinder 1 98 17 0-28130-12 Tube, cylinder 1 98 K A --z.8.l8.2 Kit, seal 1

d-&' d-oC>-00 (contains parts indicated by letter "K")

/1~71 )0' 2l(OO Self/I ,et7- ~ Ie, Cr l /?oc! 3 lIz- (f

Ch€clt F/fi7'

)


FIGURE 199 BOOM ASSEMBLY


FIG. ITEM ; ... ,." i . 'for # # PART # NAME Assy. Unit

99 1 D-30256 Frame, forward 1 ~) 99 2 B-30609-02 Pin 6

99 3 P-14994-04 Screw, cap 13 99 4 P-11009-08 Lockwasher 13 99 5 P-11016-04 Washer, flat 13 99 6 A-30126-02 Bushing 8 99 7 P-11160-01 Fitting, grease 7 99 8 B 3012=9 86 301~q-{Jl.opin 1 99 9 C-30333-02 Cylinder, left Mnd tnt (see fig.~) ~Cf 1

... ;"'v' .... - ;./ .. , ...... ' '" ,T' ._ .'-'.;i ... .u.'-".;~ I ........ 6.ti"~ ''''~~ ... ..\;.,~., ~ __ 'lr.or''''; .L..\6. i-i:'~';'~' J 0,.:7 1

99 11 D-30141 Boom 1 99 12 C-30334-01 Cylinder, bucket 1 99 13 P-11898-04 Ring, retaining 2 99 14 B-14859-12 Clam? 1 99 15 B-30497 Guide 1 99 16 B-30498 Indicator 1 99 17 B-30129 Crank, bell -71 30 I :A.9 (5() 1 99 18 B-30134 Link, bucket 1 99 19 A-30126~01 Bushing 6 99 20 B-30139-02 Pin 2 99 21 B-30139 94' Pin '3 () (q () q - 0 / 2 99 22 B-30139-05 Pin 1 99 23 B-30139-11 pin 1 99 24 P-11261-08 Nut

tJ,t$.){ (4 1

99 25 Attachment assembly (see fig. 1

)

)


FIGURE '100 - 2 STAGE MAST ASSEMBLY

)

)


FIG. ITEM ", ., # '~for ,


100 1 D-30869-01 Frame, forward 1 ~) 10C 4') B·~3C e09-02 Pin 2 "-

100 3 P-11016-04 Washer, flat 4 100 4 P-11009-08 Lockwasher 4 100 5 P-14994-04 Screw, cap 4 100 6 C-30333-03 Cylinder, tilt (see fig. iN) q ( 2 10°/20° 100 6 C-30333-04 Cylinder, tilt (see fig'. i#!) q{ 2 10°/10 0

100 7 A-30549 Stop, column 2 100 8 A-30553-02 Shim .215 As Req'd

". .'!"".:", -"

100 10 B-49994-01 Bearing 2 100 11 B-39993-£\2 Race qqqg::,-u ~ 2 100 12 P-11936-12 Race, washer 2 100 13 B-30576-01 Pin 2 luu 1'* P-l..t.J.60-:u~, rHting, grease. 2 100 15 P-11143-04 Screw, cap 2 100 16 P-11009-06 Lockwasher 2 100 17 A-30554 Pin 2 100 18 B-30609-01 Pin 2 100 19 Frame, lift (see fig. #102) 1 100 20 Inner column assembly (see fig. ~J.1 100 21 Outer column assembly (see fig. UN.)/631 100 22 P-11898-10 Ring, retainer 2 100 23 B-30591 Pin 2 100 24 P-11016-04 Washer, flat 2 100 25 P-11009-08 Lockwasher 2

') 100 26 P-14994-04 Screw, cap 2

~)


FIGURE 1101 LIF,T FRAME ASSEMBLY

12

'~ )

5


ITEM . ,! ~ .. r .•• .... : ..

I for .} <:

FIG. I # PART I NAME Assy. Unit

101 1 D-30597-01 Rest, load back 1 48" wide -) 101 1 D-30597-02 Rest, load back 1 60" wide

101 2 P-11009-08 Lock washer 4 101 3 P-14992-05 Screw, cap 4 101 4 A-30595 Bar. lock 4 101 5 C-30593-01 Fork, pallet 2 48" 101 5 C-30593-02 Fork, pellet 2 42" 101 5 C-30593-03 Fork, pallet 2 36" 101 5 C-30759-01 Fork, block 6 39"

...,J.I\I ... ..... ... -4 .... ,;"';" .. :. j 6 46" 101 5 C-30759-03 Fork. block 6 48" 101 6 A-13817-09 Spacer 1 101 7 B-30574-01 Bar,; fQrk 1 48" wide 101 7 B-30574-02 Bar,! ifork 1 60" wide 101 8 P-21089-02 Bearing ~

101 9 P-11857-05 Washer As Req'd 101 10 P-11419-14 Nut l' 2 101 11 A-14836-01 Cam. bearing 2 lCl .. , r, D-30596-01 Frame, lift 1 2 stage 1.."-

48" wide 101 12 0-30596-02 Frame, lift 1 2 stage



60" wide

:) 101 12 0-30979-01 Frame, lift 1 3FFL stage 48" wide

101 12 D-30979-02 Frame, lift 1 3FFL stage

)


" FIGURE" '102 - 2 STAGE INNER COLUMN ASSEMBLY .

LD/LL P-204

! . i _ i

1~_-IIo.......1

.. ~

2-__ ............

3

)

)

)

JUNE 1985

ITEM' t 'for· - .

FIG. t # PART' NAME Assy. Unit

102 1 D-30599-01 Column, inner 1 10'6"

-) 102 1 D-30599-02 Column, inner 1 14'6" 102 2 P-11857-05 Washer, '14 ga. As Req'd 102 3 P-21089-02 Bearing 2

)


FIGURE 1103 -··2' STAOE OUTER COLUMN ASSEMBLY

7 8

14

)

1~ 13

)


FIG. ITEM ,. for # # PART 4# NAME Assy. Unit

103 1 P-11857-05 Washer As Req'd

) ,103 2 P-21089-02 Bearing 2 103 3 C-14835-01 Chain, leaf 2 103 3 C-14835-02 Chain, lea! 2 103 4 A-30554 Pin and cotter pin 2 103 5 B-30558 Anchor 2 103 S A-14891 Nut, wheel 2 103 7 P ~12- Nut, jam (14~~-1 ~ 2 103 8 0-30603-03 Cylinder assembly (see fig. ,.)15 1 7'10"/10'Sft ",1"''' q T"»~n~0" -CHI ~<.lrlJ.~ r'-!i',~,q f'.~~~n"""tJ (~~,~ f~"", , ~·~1t)9~ 1 !)'If)"/' ':'6" 103 9 B-30600-02 Bar, cylinder 1 103 10 P-11009-0S Lockwasher 2 103 11 P-14994-0S Screw, cap 2 103 12 A-30158-03 Bushing 2

- 1", .... ,~" ... p, ("r"':! v: ~ ..~':'4 dh:.: ....

"l .k J .. v l..J1".it.J , "i.i . .i.J .0'_' :; J.

103 14 D-30598-01 Column, outer 1 '0~ 14 D-30598-0~ Ccl n '\"\1""'- ;' outer .,

.. ,,,-

)

.. )


FIGURE '104 - 3 STAGE MAST ASSEMBLY

)

/

~/

)


FIG. ITEM .... ,

f tor # # PART # NAME Assy. Unit

104 1 D .. 38 869~"O2 Fra.m~ , forward 1 -) 104 2 B-30609-02 Pin 2

104 3 P-11009-08 Lock washer 10 104 4 P-11016-04 Washer, flat 6 104 5 P-14994-04 Screw, cap 6 104 6 C-30333-03 Tilt cylinder assembly .(see fig. '*>91 2 100 /200

104 7 A-30549 Stop 2 104 8 Column, outer (see fig. i~/o5 1 104 9 Column, intermediate (see fig. t~/O(:, 1

-.'- -1' ~ , r' .. "!"""": J , ~ •

~ ~ ~ -J'.. ... ···..&.J.....i.u .... · \.J...J .t..i 1.1. ..... 0 J b .. .;... ......... ·'"

104 11 P-14994-03 Screw, cap 4 104 12 B-39994-02 Bearing 2 104 13 B-30902 pin 1 104 14 A-30905 Washer. ~ thrust. 4 104 15 B-30896 Sheave 1 104 16 B-49993-03 Race 2 104 17 P-11936~14 Washer, r·QC·A /07 4: .LV ~ .i.O 001wnn, Inner (see IJg. 1tTtirJ') 1 104 19 B-30558 Anchor, chain 2 104 20 A-30554 Pin with cotter pin 2 104 21 Frame, lift (see fig. f loQi..-) (6 I 1 104 22 P-11486-12 Nut, jam 2 104 23 A-14891 Nut, wheel 2 18 .~ 2;} /'..,-49995 Ph} vlith C0tt6f pin 2 104 25 B-30609-01 Pin 2 104 26 P-11898-10 Ring, retainer 2

--) 104 27 B-30591 Pin 2

)


FIGURE '105 -,·3 STAGE OUTER COLUMN ASSEMBLY

1

6 '''\r-.-J I 8

7~

14

12

10 9 <

J)J

Qy/13 )

LD/LL P~210 JUNE 1985

FIG. ITEM • or~' '''' .... ; for # # PART # NAME Assy. Unit

105 1 P-11857-05 Washer, .050 As Req'd ~) 105 1 P-11857-09 Washer, .075 As Req'd

105 2 P-21089-02 Bearing 2 105 3 C-14835-03 Chain, lift 2 105 4 B-30897 Anchor, chain 2 105 5 A-49995 Pin with cotter pin 2 105 6 A-49837 Nut, jam 2 105 7 P-11486-12 Nut, wheel

~~q~ 2

105 8 D-30S03-09 cylinder 8Ssem bly (see fig .. 1 3 stage .:..., : :

1/''; ...... ~' i ~.;,. ;,..;

105 9 P-14994-06 Screw, cap 2 105 10 P-11009-06 Lock washer 2 105 11 B-30600-02 Clamp 1 105 J.2 B-30557-02 CIA.mp',. 1 105 13 A-30158-03 Bushiilg 2 105 14 D-30598-03 Column, outer 1

)


FIGURE 106 -··,3· STAGE INTERMEDIATE COLU.MN ASSEMBLY

1

LD/LL P-212

L-.-_---"78

1

)

)

JUNE 1985

FIG. ITEM -# for # # PART # NAME Assy. Unit

106 1 P-11857-05 Washer, .050 As Req'd

-) 106 1 P-1185'i-09 Washer, .075 As Req'd 106 2 P-21089-02 Bearing 4 106 3 C-14835-04 Lift J chain 2 106 4 A-30554 Pin with cotter pin 2 106 5 B-30558 Anchor, chain 2 106 6 A-49837 Nut, wheel 2 106 7 P-11486-12 Nut J jam 2 106 8 D-30880 Column, intermediate 1

)


FIGURE '107 - 3 STAGE INNTER COLUMN ASSEMBLY

12 /

LD/LL P-214

7~ 8

.. -1-:fi""""':-.:<i.W",. ... ' •. "'~·, ~''''"=''''''···:_'--:r.'.~·.'''''''''·'T'·'''''.,,_· .. -

~. t f ; - ~ ,

" ,;'''' '.',-",~""" .

~--11

)

JUNE 1985

FIG. ITEM :, for # # PART 4# NAME Assy. Unit

lOi <I i- -i1936-12 Washer, race 2 .L

) 107 2 A-30553-02 Washer, shim As Req'd 107 3 A-49994-01 Bearing 2 107 4 B-39993-02 Race 2 IG ~. J D-30S7B·-02 Pin 2 107 6 P-11160-02 Fitting, grease 2 107 7 P-11009-08 Lock washer 4 107 8 P-14994-03 Screw, cap 4 107 9 P-11857-05 Washer, .050 As Req'd

~. "" ~ ""'t ...... " (''' ~~., " , "S:"'. ,~., r"~ .. .:..... ~'" .. '." .. \,.I ....

.. I _~"' •• ; •• '"'v'" ., ~ '. ,.!. "~ • .... "#1 ...... 'J, ,.,....

107 10 P-21089-02 Bearing 2 107 11 D-30879 Column, inner 1 107 12 B-30559 Sheave 2


FIGURE '108 - 3 STAGE FULL FREELIFT MAST -:::;::::::::::: ASSEMBLY

0> S!"'~~~~~~~~~ \.O:r~~ ~~~

/ r ,..... \

NM~ L~f'/~

LD/LL P-216

J

)

co ,.... 0) .,..

JUNE 1985

FIG. ITEM , for # # PART # NAME Assy. Unit

108 1 D-30869-02 frame, forward 1

') iDa L. D--30609-02 Pin 2 108 3 P-11016-04 Washer, flat 4 108 4 P-11009-08 Lockwasher 4 108 5 P-14994-04 Screw, cap ql - 4 108 6 C-30333-03 Cylinder, tilt (see fig. MJ,) 2 10°/200

108 7 A-30549 Stop, col umn 2 108 8 Outer column assembly (see fig. 'l4i-) 1 108 9 Screw, cap /oq 1 108 10 Intermediate column assembly 1

(see fig. J.l.H-) / / () 108 11 Inner column ~embly (see fig. t5a)/11 1 108 12 Frame, lift (see fig. tiM) 101 1 108 13 A-30554 Pin 4 108 14 13-30609-01 PiB 2 108 15 P-11898-10 Ring, retainer 2 108 16 8-30591 Pin 2 108 17 P-11016-04 Washer, flat 2 108 18 P-11009-08 Lockwasher 2 108 19 P-14994-04 Screw, cap 2


FIGURE '109 -' 3 STAGE FULL FREELIFT OUTER COLUMN ASSEMBLY -1

8

) 13

---------------

)


FIG. ITEM , for # # PART 4# NAME Assy. Unit

109 1 P-11857-05 Bearing 4 ~) 109 2 P-11857-05 Washer, #18 ga. As Req'd

109 2 P-11857-09 Washer, #14 ga. As Req'd 109 3 C-14835-26 Chain, leat 2 109 4 A-49995 Pin with cotter pin 2 109 5 B-30558 Anchor 2 109 6 A-49837 Nut 2 109 7 P-11486-12 Nut, jam 2 109 8 D-28131-02 Cylinder assem bly (see fig. .-) qg 1 109 9 B-30600-01 Bar 1 109 10 P-11009-06 Lockwasher 2 109 11 P-14994-06 Screw, cap 2 109 12 A-30158-03 Bushing 2 109 13 D-30981-01 Column, outer. 1

)


FIGURE '110 - 3 ~TAGE FULL FREE LIFT INTERMEDIATE COLUMN ASSEMBLY

)

)


FIG. ITEM 0. ~. 0:' . .' ' : # for . .


110 1 P-ll8J!f-OrP> I D81--O~Bearing 4 -') 110 2 P-11857-05 Washer, #18 ga. As Req'd

110 2 P-11857-09 Washer, #14 ga. As Req'd 110 3 P-11143-04 Screw, cap 4 110 4 P-11009-06 Lockwasher 4 110 5 P-11160-02 Fitting, grease 2 110 6 B-28159-01 Pin 1 110 7 A-30553-02 Washer, shim 4 110 8 B-39993-02 Race, inner 2 110 9 B-49994-01 Bearing; roller 2 110 10 B-30559 Sheave, chain 2 110 11 P-11898-04 Ring, retaining 1 110 12 A-36493'.:iOl . Bearing 1 110 13 B-26645~~>:;":: ~ ,.", Sheave, hose 1 110 14 B-28'159~O'2' Pin 1 110 15 D-30983":'01 Column, intermediate 1

)


FIGURE '111 -,3 STAGE PULL PREE LIFT INNER COLUMN ASSEMBLY

)

4

3~_~_

~1 LD/LL P-222 JUNE 1985

ITE"M ...... . ;, .- :.:." ~ .~ ~ ~ . "",'tor ..

FIG. "' . "

# # PART f NAME Assy. Unit

111 1 P-21089-02 Bearing 2

) 111 2 P-11857-05 Washer, '18 ga. As Req'd 111 2 P-11857-09 Washer, t14ga. As Req'd 111 3 P-14994-05 Screw. cap 4 111 4 P-11009-08 Lockwasher 4 111 5 Cylinder assembly (see fig. '~)I/:L 1 111 6 0-30984-01 Column, inner 1


ER ASSEMBLY 'GE FREELIFT CYLIND "112 "':- 3 STA . FIGURE 1f •

W. 3

!1-------------1----

2 ______

\k; ~1

LD/LL P-224

------

11

20

------

22

)

8

~)

JUNE 1985

FIG. ITE;M '--. ::,·.:·for # # PART # NAME Assy. Unit

112 1 P-11486-12 Nut, jaw 2 112 2 A-49837 Nut 2

') 112 3 A-49995 Pin with cotter pin 2 112 4 C-14835-25 Chain, Uft 2 112 5 B-30558 Anchor 2 112 6 P-11170-10 Nut 2 112 7 P-11894-08 Screw, cap 2 112 8 B-28166-02 Bar 2 112 9 B-26519-01 Pin 1 112 10 A-26389 Nut, spacer 1 -,.' t';

.iJ.~ 11 A -498"*.1. -til Washer, belleville 6 112 12 P-11160-02 Fitting, grease 1 112 13 P-11831-02 Nut 1 112 14 A-30553-04 Washer J shim 2 112 15 B-30559 : . Sheave; . chain. 2 112 16 B-49993-02 Race, inner 2 112 17 B-49994-01 Bearing, roller 2 112 18 A-28156-02 Washer, special 2 112 19 P-11936-12 Race 2 112 20 P-11936-13 Race 2 112 21 B-28163 Pin 1 112 22 D-28150-20 Cylinder assem bly (see fig. N8'> ?7 1

)


FIGURE '113 FRAME ASSEMBLY

)

-\

)

)


.. ~ ,- ~ .-- - .

· ... t i.tor:~· .::: '

FIG. ITEM i , PART- # NAME Assy. Unit

~. 1~3 1 0-30265-05 Frame, rear 1 Oeere

)113 Continental 1 0-30265-06 Frame, rear 1 Oeutz

113 2 P-14994-03 Screw, cap 2 113 3 P-11009-08 Lockwasher 6 113 4 P-11016-04 Washer, flat 6 113 5 B-30139-l-6' 01 Pin 1 113 6 P-14994-04 Screw, cap 4 113 7 A-30162-03 Pin 1 113 S B-3013S-07 fin 1 113 9 A-30161-01 Shim, .125 As Req'd 113 9 A-30161-02 Shim, .187 As Req'd 113 9 A-30161-03 Shim, .250 As Req'd 113 lOT--- P-11039-Z;7 .Seal, . oil ::- II D39;; 70 I{/e (II 10 ?/iJ.-7 4 113 11 0-30256 .... -. ,-, .Frame', forward" ~ 1 LO-50 113 11 0-30869-01 Frame, forward 1 ~~-40 2 Stage 113 11 0-30869-02 Frame, forward 1 LL-40 3 stage 113 12 ~ A-30158-01 B~hing - 30/~'3oJO - 7/301$80( 2 113 13 P-11898-10 .. ~ 2 Rlng, retamer 113 14 A-30162-02 Pin' -- 30 J{P;). 01D 1

-)


FIGURE' '114 LD.-::.50 ,ATTACHMENT ASSEMBLY

5---...o...l

)

LD/LL. P-228 JUNE 1985

FIG.' ITEM" i # PART # NAME

· # for Assy. Unit

114 ".114

) 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114 114

_ 114 )11.14

-- 114 114

1 1 1 1 1 1 1 1

* * 2 2 2 2 2 2 3 3 3 3 3 3 4 5 6 6 6 6 6 6

JUNE 1985

0-30168-01 Bucket, 5/8 yard 601ft/II' 1 0-30837 Bucket, 5/8 yard &OJ heavy duty 1 D-30168-02.- Bu~ket 1 3/4 YB.rd 7?," 1 D-30168-03 Bucket, 1 ;YUAU b4d 64/1 1 0-30168-04 Bucket, 1-1/8 yard ~1 light material 1 0-30168-05 Bucket, 1-3/8 yard 72" light. material 1 C-30526-01 Bucket, 5/8 yard 60" tooth 1 C-30526-02 Bucket, 3/4 yard 72" tooth 1 B-30525 Tooth assembly As Req'd VO-3CH Tooth, replacement As Req'd B-30171-01 Edge, 5/8 yard 60" cutting 1 B-30836-01 Edge, 5/8 yard 60" heavy duty cutting 1 B-:-30896-02 301l1-D~ Edge, 3/4 yard 72" cutting 1 B-308-38 033 0 1/ / - 03Edge, 1 yard 84" cutting 1 B-3{)838'!!-Dl~PI-1I-c)/Edge, ·.~1~1/8 ~yard~:60f!·. cutting 1 B-30836-0230JJI-D~Edge, 1-3/8 yard 72" cutting 1 A-30173-01 Edge, 5/8 yard 60" side 2 A-30834 Edge, 5/8 yard 60" heavy duty side 2 A-30173-01 Edge, 3/4 yard 72" side 2 A-30173-02 Edge, 1 yard 84" side 2 A-30173-03 Edge, 1-1/8 yard 60" side 2 A-30173-03 Edge, 1-3/8 yard 72" side 2 W9010091 Bucket, grapple (see fig. M¥t=) II ~ 1 W9010092 Fork, grapple (see fig. ~ /17 1 W9010061 36" forks, 60" carriage (see fig. #~/5 1 W9010062 42" forks, 60" carriage (see fig.~)I/~l W9010063 48" forks, 60" carriage (see fig. -#H'6 )//51 W9010064 36" forks, 48" carriage (see fig. #-1:1:S)//51 W9010065 42" forks, 48" carriage (see fig. i-l-l6)1151 W9010066 48" forks, 48" carriage (see fig. #~)/L51

~4L~~r~ ,36 .2~(}IS-

~~t:L tf-a&.d 6~11-9~ 6-511 - J'~

,./Ld1u {ile2/) P~) 3 (:; c2? OC:< 3

LD/LL P-229

FIGURE '115 LOADER FORK ATTACHMENT

)


FIG. ITEM t for # # PART # NAME Assy. Unit

115 1 D-30829-01 Rest, load back 1 60" -') 115 1 D-30829-02 Rest, load back 1 48"

115 2 P-~115-02 Fork. 36" 2 115 2 P~1115-03 Fork, 42" 2 115 2 P-.?1115-04 Fork, 48" 2 115 3 B-30825-01 Rod, 60" 1 115 3 B-30825-02 Rod, 48" 1 115 4 P-11073-25 Pin, roll 2 115 5 P-14994-04 Screw, cap 1 '1.5 ~ 0-11009-08 Lo~!cw.!'l.,::her 1 115 7 P-11016-04 Washer, flat 1 115 8 B-30139-02 Pin 1 115 9 A-30126-01 Bushing 4 115 10 B-30830 Lir!k- ;. 1 115 11 P-11160~'01 Fitting; grease" 2


FIGURE 1116 GRAPPLE BUCKET ASSEMBLY

\A1 -e\c> \OCi1!

11

r1~ 1 3

---/ )

riZ15 /1\

1 2

JUNE 1985

~t -_ -: f'. ~,,~ >1 ~ ~~~ .;~. ~ f~ ~.' .. t:~ : .. "; ~. ~;- r'~ .. ", . ,. .. -~~ .•. :;; ;. :-. - ~"~~ • .i

FIG. ITEM " .,."tor J

Ii ,:,{.


116 1 £>-14994-03 Screw, cap 6

) 116 2 P-11009-08 Lock washer 8 116 3 P-11016-04 Washer, flat 8 116 4 B-30609-02 Pin 2 116 5 B-30139-01 Pin 2 116 6 P-11160-11 Fitting, grease 6 116 7 0-30343-02 Cylinder assembly 2 116 8 P-14994-06 Screw, cap 2 116 9 B-30955 Pin, shaft 2 11f)

" f) A-30l?'~-"()1 '~. '-''''''~''' ,'7 4 • 0< • ..:;.

116 11 0-30956-01 Arm, grapple 1 116 12 0-30956-02 Arm ~, grapple 1 116 13 B-30958 Edge ,\cuttin'g ."\ 1 116 14 0-30957 "- . ...... Bucket;,~grapple. ,' ..... 1 116 15 B-30139-02 Pin " . ' .. ~ .. 2

)


FIGURE '11'1 GRAPPLE FORK ASSEMBLY ! :.:. : ~~

. " .. :~ . ::

~'. /~ '-. to ; r' . .' :~

)

9

2

1 3


.. " '!'.' :;~_~~;·:-:':·':"~~··"-;"·:':":':-"''''':':::'!i''I:·.'f'~.o;,,· .. ' .

FIG. ITEM , for I # PART # NAME Assy. Unit

117 1 P-14994-US SCL'€W, cap 4

) 117 2 P-11009-08 Lockwasher 4 117 3 P-11016-04 Washer, flat 4 117 4 B-30139-01 Pin 2 117 5 A-30126-04 Bmhing 4 117 6 0-30956-02 Arm, grapple 1 117 7 0-30956-01 Arm, grapple 1 117 8 P-11160-11 Fitting, grease 4 117 9 B-30955 Pin, shaft 2 117 1(} 0-31060 Fork, grapple 1 117 11 0-30343-02 Cylinder assembly 2 117 12 P-14994-06 Screw, cap 2 117 13 B-30609-02 Pin 2 117 14 B-30139-02 Pin 2

-)

JUNE 1985 LDILL P-235

)

)

MODEL LD/LL ARTICULATED LOADER & FORKLIFTS

This numerical indpx criv<"')Q V"' -,-.,.:-t- r.1,--·h~.~c ;:-.nr1 fi011Y"'::-' ...-·,.'""':'::-'C\rf' or: \f':--i~.-::l-;

they Clre listed. .Ltem nwnDer nas also Deen listed for eaSler locations of part numbers.

PART #

P-11009-02 P-11009-02 P-11009-02 P-11009-03 P-11009-03 P-11009-03 P-11009-03 P-11009-03 P-11009-04 P-11009-04 P-11009-04 P-11009-04 P-11009-05 P--11009--0S P-.11009-05 P-11009-05 P-11009-05 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009--06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-06 P-11009-08 P-11009-08

JUNE 1989

FIGURE #

56 57 58 3 5 56 57 58 3 6 7 8 3 16 5 57 58 3 16 17 19 21 24 26 27 28 29 32 33 35 47 48 49 50 56 57 58 65 96 100 103 105 109 110 3 16

ITEM #

* * *

29 8 * * *

22 4 6 8

10 29 20 16 14 12 36 6 17 31 7 10 8 9 12 17 13 15 2 2 2 7 34 35 33 17 10 16 10 10 10 4 33 42

PART # FIGURE #

P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-II009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-08 P-11009-10 P-11009-2 P-I1009-5 P-11009-5 P-11009-6 A-11009-6 P-11009-6 P-11009-8 P-11009-8 P-11015-40 P-11015-41 P-11015-42 P-I1015-43 P-11015-44 P-11016-01 P-11016-01 P-11016-01 P-11016-01 P-11016-01 P-11016-02 P-11016-02 P-11016-02 P-11016-02 P-11016-02

17 18 19 42 47 52 59 59 59 99

100 100 101 104 107 108 108 111 113 115 116 117 41 24 20 21 22 36 92 20 22 67 52 52 52 52 3 6 7 8 29 3 12 16 24 26

PRIME-MOVER

ITEM #

3 32 29 13 17

2 * *

10 4

4 25

2 3 7 4

18 4 3 6 2 2 16 13 16 34 6 21 2 5 3 6 10 10 10 5 21 11 4 16 21 9 5 28 9 5

99. 1


PART # FIGURE # ITEM # PART # FIGURE # ITEM #

P-11016-03 3 36 P-11020-17 42 4 -)

P-11016-03 16 20 P-11020-21 32 20 P-11016-03 18 15 P-11020~27 31 5 P-11016-03 24 2 P-1.1020-27 32 3 P-11016-03 26 11 P-11025-07 48 6 P-11016-03 27 6 P-11025-12 32 24 P-11016-03 28 10 P-11025-12 32 29 P-11016-03 29 25 P-11025-15 32 6 P-11016-03 31 6 P-11039-22 50 16 P-11016-03 32 22 P-11039-23 49 4 P-11016-03 47 3 P-11039-24 50 5 P-11016-03 48 3 P-11039-25 48 9 P-11016-03 49 3 P-11039-26 47 15 P-11016-03 50 8 P-11039-27 113 10 P--1.1016-0] 65 ., r'J

i. ::..) r--l10<~5-03 3 14 P-11016-03 96 9 P-11045-03 6 5 P-11016-04 3 32 P-11045-03 7 3 P-I1016-04 16 39 P-11045-03 8 11 P-11016-04 17 4 P-11045-04 29 20 P-11016-04 18 29 A-11057-02 32 12 P-11016-04 19 19 P-11057-11 48 11 P-I1016-04 22 4 P-11073-03 29 6 P-11016-04 42 14 P-11073-03 3S 3 P-11016-04 52 3 P-11073-04 31 12 P-11016-04 99 5 P-11073-21 42 10

) P-11016-04 100 3 P-11073-23 32 9 P-11016-04 100 24 P-11073-2S 11S 4 P-11016-04 104 4 P-11073-29 29 10 P-11016-04 108 3 P-11073-3 36 6 P-11016-04 108 17 P-11073-30 30 3 P-11016-04 113 4 P-11115-02 11S 2 P-11016-04 11S 7 P-1111S-03 11S 2 P-11016-04 116 3 P-11115-04 11S 2 P-11016-04 117 3 P-11128 35 10 P-11016-0S 17 9 P-11128 36 5 P-11016-0S 29 15 P-11129-03 3 28 P-11016-0S 32 38 P-11129-03 5 9 P-11016-0S 32 49 P-11129-06 31 18 P-11016-06 31 13 P-11129-08 S9 7 P-11016-06 32 8 P-11129-08 S9 9 P-11016-06 43 4 P-11129-08 59 25 P - 11 0 1 6 - 0 '8 41 8 P-1113S-03 42 S P-11016-13 33 12 P-1113S-04 29 8 P-11016-2 21 35 P-1113S-04 31 20 P-11016-27 47 18 P-1113S-04 32 40 P-11016-3 21 9 P-1113S-04 32 51 P-11020-0S 29 2 P-1113S-04 33 3 P-11020-16 32 14 P-1113S-06 35 9 P-11020-16 3S 4 P-11143-03 18 27 P-11020-16 36 7 P-11143-03 26 8 P-11020-16 41 13 P-11143-03 47 1 ) P-11020-17 32 36 P-11143-04 3 16 P-11020-17 32 47 P-11143-04 10 17

99.2 PRIME-MOVER JUNE 1989

HODEL LD/LL ARTICULATED LOADER & FORKLIFTS

") PART # FIGURE # ITEM # PART # FIGURE # ITEM #

LP-11143-04 16 8 P-11170-05 16 31 P-11143-04 17 18 P-11170-05 26 6 P-11143-04 18 5 P-11170-05 40 6 P-11143-04 19 12 P-11170-05 41 6 P-11143-04 21 30 P-11170-06 10 15 P-11143-04 24 1 P-11170-06 16 12 P-11143-04 27 1 P-11170-06 18 7 P-11143-04 48 1 P-11170-06 21 10 P-11143-04 49 1 P-11170-06 31 7 P-11143-04 50 6 P-11170-06 31 10 P-11143-04 57 36 F-11170-06 33 14 P-11143-04 58 34 P-11170-08 13 2 P-11143-04 65 16 P-11170-08 17 21 1-"-11145-04 luU l~ P-111'IO-Ot5 19 20 P-11143-04 110 3 P-11170-10 112 6 A-11143-05 35 16 P-11170-5 21 36 P-11143-06 17 5 P-11170-6 92 1 P-11143-06 19 28 P-11170-8 22 29 P-11143-06 29 24 P-11176-01 3 27 P-11143-07 22 24 P-11176-01 56 24 P-·11143 - 0 8 16 22 P-11176-01 57 23 P-11143-08 18 17 P-11176-01 58 21 P-11143-09 33 21 P-11176-01 95 1

-) P-11143-10 32 23 P-11176-01 97 2 P-11143-10 40 1 P-11176-01 98 1 P-11143-10 41 1 P-11176-02 10 11 P-11143-14 29 16 P-11205-07 48 8 P-11143-16 21 7 P-11205-08 49 7 P-11143-4 22 5 P-11205-09 50 11 A-11143-5 36 22 P-11205-10 50 13 P-11157-05 14 15 P-11205-11 48 7 P-11160-01 52 12 P-11211-04 8 15 P-11160-01 99 7 P-11234 31 3 P-11160-01 115 11 P-11234 33 10 P-11160-02 100 14 P-11234 42 1 P-11160-02 104 10 P-11242-43 47 7 P-11160-02 107 6 P-11246-03 10 14 P-11160-02 110 5 P-11261-02 57 20 P-11160-02 112 12 P-11261-02 58 20 P-11160 -06 29 3 P-11261-04 3 23 P-11160-06 35 7 P-11261-04 6 3 P-11160-11 32 11 P-11261-04 7 7 P-11160-11 76 1 P-11261-04 8 7 P-11160-11 87 1 P-11261-05 3 6 P-11160-11 89 1 P-11261-05 56 19 P-11160-11 91 1 P-11261-05 57 17 P-11160-11 93 1 P-11261-05 58 15 P-11160-11 116 6 P-11261-06 3 13

) P-11160-11 117 8 P-11261-06 17 14 P-11160-14 32 4 P-11261-06 18 20 A-11160-6 36 9 P~11261-06 19 18 P-11170-04 4 7 P-11261-06 24 8

JUNE 1989 PRIME-MOVER 99.3

P-11261-06 26 13


]?ART # FIGURE # ITEM # PART # FIGURE # ITEH #

P-11261-06 27 9 P-11806-10 47 9 P-11261-06 28 8 P-11813-02 4 6 P-11261-06 29 26 P-11813-04 5 6 P-11261-06 32 16 P-11816-01 16 5 P-,-11261-06 35 5 P-11816-01 18 14 P-11261-06 35 72 P-11816-01 65 10 P--11261-06 40 8 P-11819 36 11 P-11261-06 41 21 P-11823-01 4 2 P-11261-06 96 11 P-11831-02 112 13 P-11261-08 16 41 P-11832-03 49 18 P-11261-08 18 31 P-11854-04 16 30 P-11261-08 99 24 P-11854-04 56 21 P-11261-6 22 14 P-11854-04 57 15 P-11261-6 36 13 P-11854-04 58 13 P-11261-6 92 4 P-11854-3 20 18 P-11261-8 20 4 P-11854-4 21 33 P-11306 14 8 P-11857-03 32 25 P-11310 33 17 P-11857-03 32 30 P-11314 41 14 P-11857-03 32 33 P-11314 42 6 P-11857-05 101 9 P-11339 33 16 P-11857-05 102 2 -) A-11419-03 56 29 P-11857-05 103 1 A-11419-03 57 31 P-11857-05 105 1 A-11419-03 58 26 P-11857-05 106 1 P-11419-14 101 10 P-11857-05 107 9 P-11429-03 30 5 P-11857-05 109 1 P-11429-03 32 39 P-11857-05 109 2 P-11429-03 32 50 P-11857-05 110 1 P-1143-04 56 35 P-11857-05 110 2 P-11486-02 29 9 P-11857-05 111 2 P-11486-04 33 18 P-11857-09 105 1 P-11486-06 32 42 P-11857-09 106 1 P-11486-06 32 53 P-11857-09 107 9 P-11486-06 33 5 P-11857-09 109 2 P-11486-08 35 11 P-11857-09 110 2 P-11486-12 104 22 P-11857-09 111 2 P-11486-12 105 7 P-11867-04 47 8 P-11486-12 106 7 P-11869-08 41 9 P-11486-12 109 7 P-11872-02 43 8 P-11486-12 112 1 P-11885-04 56 14 P-11486-14 88 5 P-11885-04 57 19 P-11486-14 90 8 P-11885-04 58 17 P-11586-12 103 7 P-11885-05 24 14 P-1162-104 30 6 P-11890-03 98 8 P-11621-02 56 15 P-11890-05 32 32 P-11677-07 65 8 P-11890-06 47 20 P-11801 43 10 P-11894-06 41 17 ) P-11806-06 29 13 P-11894-08 112 7

_/

P-11806-10 42 7 P-11896-5 36 4


.. -.-


~) PART # FIGURE # ITEM # ITEM # FIGURE # ITEM #

P-11897-03 95 2 ~-11o~cl-(;4 99 13 P-11898-04 110 11 P-11898-06 49 8 P-11898-10 52 9 P-I1AQ8-10 J.OO 22 P-11898-10 104 26 P-11898-10 108 15 P-13857-01 95 7 P-11898-10 113 13 P-13857-01 97 12 A-11936-04 32 26 P-13857-01 98 13 A-11936-05 32 26 P-14022-01 30 7 A -11·936 - 08 32 26 P-14338-04 30 8 P-11936-08 32 34 A-14802 3 11 P-11936-11 49 17 A-14805-1 20 8 P-11936-12 100 12 A-14805-2 20 14 P-11936-12 107 1 A-14806-2 20 6 P-11936-12 112 19 A~14807 92 18 P-11936-13 112 20 A-14810 -02,e.tPWW65 1> \;) 10- C)O 15 P-11936-14 104 17 A-14810 -02 ~i~10'~ 2 - 15 P-12078 40 3 A-14811-01 32 54 P-12078 41 3 A-14813 32 18 P-12318-05 47 11 A-14814-01 32 44 P-12391-05 47 12 A-14814-02 32 35 P-12391-06 72 2 A-14817-1 20 20 :) P-12391-06 75 3 A-14820-01 16 21 P~12391-06 75 6 A-14820-01 18 16 P-12391-06 88 3 A-14820-01 19 25 P-12391-06 90 2 A-14820-3 20 7 P-12391-06 90 6 A-14824 2 P-12391-07 67 2 A-14826 14 12 P-12391-07 72 10 A-14826 14 19 P-12391-07 77 5 A-14826 25 5 P-12391-07 79 6 A-14826 56 9 P-12391-07 85 9 A-14826 56 13 P-12391-07 85 12 A-14826 57 9 P-12391-07 86 3 A-14826 57 14 P-12391-07 86 8 A-14826 58 9 P-12391-07 88 10 A-14827 56 * P-12391-07 90 11 A-14827 57 * P-12391-07 94 7 A-14828 14 4 P-12391-07 96 14 A-14828 57 5 P-12391-07 96 16 A-14829 30 2 P-12391-07 96 20 A-14831-01 24 3 P-12391-08 72 8 A-14831-05 24 17 P-12391-08 72 18 A-14832-06 24 18 P-12391-08 85 3 C-14835-01 103 3 P-12391-09 94 4 C-14835-02 103 3 P-12391-09 96 2 C-14835-03 105 3 P-12391-11 72 13 C-14835-04 106 3

) P-12459 47 5 C-14835-25 112 4 \ P-13282 40 10 C-14835-26 109 3

P-13282 41 7 A-14836-01 101 11 A-13817-09 101 6 A-14838 29 14


MODEL LD/LL ARTICULATED LOADE.R & FORKLIFTS

PART # FIGURE # ITEM # PART # FIGURE # ITEM #

A-14840-01 52 14 A-14875. 24 12 A-14841-01 52 15 A-14875 58 21 A-14842-01 52 13 A-14877 14 2 A-14843-01 18 28 A-14877 56 7 A-14851-02 16 27 A-14877 57 7 A-14851-02 18 23 A-14877 58 7 A-14851-02 21 38 A-14878 14 1 A-14851-03 13 6 A-14878 56 8 A-14851-03 27 7 A-14878 58 8 A-14851-03 28 4 A-14879 14 7 B-14857-03 16 9 A-14879 56 2 B-14857-03 18 3 A-14879 58 2 B-14857-06 4 11 B-14857-3 21 14 A-14880 14 3 A-14858-02 16 3 A-14880 56 6 A-14858-02 18 11 A-14880 57 6 A-14858-1 21 6 A-14880 58 6 B-14859-01 16 15 A-148H1 14 6 B-14859-06 65 14 A-14881 56 3 B-14859-06 72 14 A-14881 57 3 B-14859-07 4 8 A-14881 58 3 B-14859-08 16 1 P-14884-06 72 6 B-14859-08 18 10 A-14885-01 65 12 B-14859-12 99 14 A-14887-04 88 6 ) B-14859-3 21 4 A-14887-04 90 7 B-14859-5 21 17 A-14887-2 92 12 B-14859-7 21 1 A-14891 43 1 A-14860-02 33 9 A-14891 103 6 A-14861 32 7 A-14891 104 23 A-14862 33 7 A-14892-01 13 8 A-14863-02 42 8 A-14892-01 24 19 A-14864 32 1 A-14892-01 27 5 B-14865-01 59 8 A-14892-01 28 2 B-14866-01 59 19 A-14892-01 31 2 B-14867-01 59 1 A-14897 49 11 A-14868 14 18 A-14898 50 2 A-14868 56 12 A-14899 50 3 A-14868 57 13 A-14900-01 50 1 A-14868 58 12 A-14902-01 49 13 A-14868 59 17 A-14903-01 47 13 B-14869 26 4 A-14908-12 43 5 B-14870-01 26 9 A-14908-12 76 3 B-14870-02 26 7 A-14908-12 93 3 A-14872 14 13 A-14908-22 89 4 A-14872 56 10 A-14908-22 91 3 A-14872 57 12 A-14908-26 87 3 A-14872 58 10 A-14911-04 56 27 A-14874 14 14 A-14911-04 57 29 A-14874 56 11 A-14911-04 58 24

/) A-14874 57 11 A-14912-05 72 19 A-14874 58 11 P-14935-02 16 37 A-14874 59 P-14935-02 21 28


. ,,-.~. -~. ~~-' .. -.-- .. --,._-- ..


-) PART # FIGURE # ITEM # PART # FIGURE # ITEM #

P-14946 34 1 P-14952-02 72 12 P-14972-08 65 13 P-14972-09 85 6 P-14992-05 101 3 P-14994-03 104 11 P-14994-03 107 8 P-14994-03 113 2 P-14994-03 116 1 P-14994-03 117 1 P-14994-04 99 3 P-14994-04 100 5 P-14994-04 100 26 P-14994-04 104 5 P-14994-04 108 5 P-14994-04 108 19 P-14994-04 113 6 P-14994-04 115 5 P-14994-05 17 10 P-14994-05 52 1 P-14994-05 111 3 P-14994-06 17 2 P-14994-06 19 15

) P-14994-06 42 12 P-14994-06 103 11 P-14994-06 105 9 P-14994-06 109 11 P-14994-06 116 8 P-14994-06 117 12 P-14994-08 3 34 P-14994-08 17 24 P-14994-11 13 3 P-14994-12 16 40 P-14994-12 18 30 P-14994-12 47 16 P-14994-14 20 10 P-14994-6 22 2 P-14994-8 22 28 P-15677-02 35 23 P-15677-02 40 9 P-15677-02 41 19 P-15677-03 96 8 P-15677-2 15 9 P-15677-2 36 18 P-15677-J 92 3 P-15677-4 92 5 P-15680-07 65 7 P-15818-11 92 15

/) P-15818-12 92 16 P-15818-7 92 7 P-15818-8 92 11


PART #

P-15818-9 P-15898-2 P-20067 P-21089-02 P-21089-02 P-21089-02 P-21089-02 P-21089-02 P-21089-02 P-21089-02 A-21253 P-22012-04 P-22012-04 P-22012-04 P-22012-04 P-22012-05 P-22012-05 P-22012-05 P-22012-05 P-22012-4 P-22013-04 P-22120 P-22120 P-22120 P-22120 P-22120 P-25106-03 P-25108-08 P-25108-08 P-25108-08 P-25108-09 P-25108-09 P-25108-09 P-25108-09 P-25108-09 P-25108-09 P-25108-10 P-25108-10 P-25108-9 A-25246-04 A-25246-05 A-25246-5 A-25275-04 A-25275-04 A-25275-04 P-25349-04 P-25377-04 P-25377-09 P-25427-02 P-25427-02 P-25427-02

99.8

NODEL LD/LL luqTICULJ'.TED LOADER £C. FORKLIFTS

FIGURE #

92 92 33 101 102 103 105 106 107 111 1 75 88 90 96 67 72 85 86 92 72 29 31 32 32 33 77 72 75 90 79 86 88 90 94 96 72 85 92 29 35 36 56 57 58 96 85 94 56 57 58

.. ·!l-~~:!.A<:~''!iZ:':''·:'.·,

ITEM #

1 8 11 8 3 2 2 2 10 1 7 5 2 1 15 1 9 11 2 17 17 7 19 41 52 4 4 1 2 5 5 7 9 10 6 13 7 2 6 5 8 10 16 21 19 17 8 3 18 18 16

PART # FIGURE

P-26204 14 P-26204 56 P-26204 57 P-26204 58 A-26363-01 56 A-26363-01 57 A-26363-01 58 A-26389 112 B-26519-01 112 B-26645 110 B-26646 96 A-27561-01 28 D-28130-12 98 D-28131-02 2 D-28131-02 96 D~28131-02 109 B-28137 97 B-28137 98 C-28139-02 98 C-28141-02 97 C-28142 97 C-28142 98 D-28150-20 2 D-28150-20 96 D-28150-20 112 A-28156-02 112 B-28159-01 110 B-28159-02 110 B-28163 112 B-28166-02 112 A-28182 97 A-28182 98 A-30001 2 A-30001 42 A-30001 67 B-30006 48 C-30007 49 B-30008 48 C-30009 49 B-30010 49 C-30011 50 B-30012 49 B-30013 49 C-30014 2 C-30014 43 D-30015 50 A-30016 2 A-30016 43 D-30017 50 A-30018 43 D-30035 50

PRIME-MOVER

# ITEM # ) 5 4 4 4 23 24 22 1)

9 13 4 B 17 22 6 8 13 14 16 15 6 6 22 1

) 22 18 6 14 21 8 K K 22 11 3 12 10 14 16 9 12 14 15 18 15 4 20 17 17 14 .) 14

JUNE 1989

" ... );", -.,., : .. D I' 1..; ;.J A~ -~, p~ --- - •• : ... ~~ •• ~ ~ ~~' "7 0, .... , "'r:".- F'J:::.:>~L I ?TS ---.

) PART # FIGURE # ITEM # PART # FIGURE # ITEM #

A-30036-01 48 13 B-30139-02 116 15 A-30036-02 48 10 B-30139-02 117 14 B-30037 48 4 B-3.0139-04 99 21 B-30041-01 48 5 B-30139-05 99 22 B-30041-02 48 5 B--30139-07 113 8 B-30041-03 48 5 B-30139-10 113 5 B-30042 50 15 B-30139-11 99 23 B-30043-01 49 6 D-30141 99 11 B-30043-01 50 10 D-30151 52 8 B-30043-02 49 6 A-30158-01 52 16 B-30043-02 50 10 A-30158-01 113 12 B-30043-03 49 6 A-30158-02 52 7 B-30043-03 50 10 A-30158-03 103 12 B-30044 49 5 A~30158-03 105 13 C-30045 49 12 A-30158-03 109 12 B-30050 50 9 A-30160 52 6 B-30051 47 10 A-30161-01 52 11 C-30052 47 4 A-30161-01 113 9 B-30053 47 14 A-30161-02 52 11 C-300S4 47 19 A-30151-02 113 9 A-30057 43 3 A-30161-03 52 11 C-30060 2 17 A-30161-03 113 9 C-30060-01 43 6 A-30162-02 52 17

-) C-30060-02 43 18 A-30~62-02 113 14 C-30060-03 43 6 A-30162-03 113 7 C-30060-04 43 18 A-30165 52 4 A-30081 47 6 0-30168-01 114 1 C-30099 13 7 0-30168-02 114 1 C-30099 14 11 0-30168-03 114 1 0-30101 13 1 0-30168-04 114 1 C-30106 13 5 D-30168-05 114 1 C-30106 14 10 B-30171-01 114 2 0-30109 13 1 A-30173-01 114 3 A-30111 14 16 A-30173-01 114 3 A-30111 14 20 A-30173-02 114 3 A-30126-01 99 19 A-30173-03 114 3 A-30126-01 115 9 A-30173-03 114 3 A-30126-02 99 6 A-30195 44 2 A-30126-03 87 9 A-30195 44 2 A-30126-04 89 10 B-30197 44 4 A-30126-04 91 9 A-30201 44 3 A-30126-04 116 10 A-30201 44 3 A-30126-04 117 5 A-30201 44 3 A-30126-06 76 9 A-30201 44 3 A-30126-06 93 9 A-30201 44 3 B-30129 99 17 A-30201 44 3 B-30129-06 99 8 A-30201 44 3 B-30134 99 18 B-30243 3 18 B-30139-01 116 5 0-30256 99 1

.) B-30139-01 117 4 0-30256 113 11 B-30139-02 99 20 0-30265-05 103 1 B-30139-02 115 8 0-30265-06 113 1

JUNE 1989 PRIME-MOVER 99,9

MODEL LD/LL ARTICULATED LOADED & FORKLIFTS

PART # FIGURE # ITEM # PART # FIGURE # ITEM # )

B-30277-02 29 18 D-30343-02 2 22 B-30279-01 29 4 D-30343,...02 116 7 B-30279-02 29 1 D-30343-02 117 11 A-30288-01 32 37 D-30343-2 92 20 A-30288-02 32 48 B-30347-01 76 10 A-30289 31 11 B-30347-02 93 10 A-30289 32 28 B-30349-01 76 2 A-30294 24 11 B-30349-02 93 2 A-30302 42 3 B-30350 76 5 B-30304 65 21 B-30350 93 5 B-30305 2 22 C-30351 76 14 B-30305 65 9 C-30351 93 14 A-30306 65 2 B-30353 2 22 B-30307 65 20 B-30353 86 9 B-30311 65 19 B-30353 88 11 D-30318 2 22 B-30354-02 88 1 D-30318 34 5 B-30354-03 72 4 D-30318 72 3 B-30354-04 75 4 D'-30318 75 1 B-30354-05 75 8 P-30319 34 4 B-30354-06 88 8 A-30320-01 94 2 B-30354-06 90 9 A-30320-01 96 18 B-30354-07 88 7 A-30321 42 16 B-30354-08 86 6 B-30326 89 6 B-30354-09 86 5 B-30326 91 5 B-30354-10 72 5 ) B-30327-01 89 2 B-30354-10 77 2 B-30327-02 89 3 B-30354-10 79 2 B-30327-03 91 2 B-30354-12 90 4 B-30331-01 89 11 B-30354-14 94 5 B-30331-02 91 10 B-30354-14 96 19 C-30332 89 15 C-30354-27 96 12 C-30332 91 14 C-30354-28 96 5 C-30333 2 22 B-30355-01 72 21 C-30333 2 22 B-30355-02 67 7 C-30333-01 88 4 B-30355-03 85 4 C-30333-01 99 10 B-30355-04 77 7 C-30333-02 88 12 B-30355-04 79 4 C-30333-02 99 9 B-30355-05 85 13 C-30333-03 90 3 B-30355-06 85 7 C-30333-03 100 6 B-30355-08 24 15 C-30333-0J 104 6 B-30355-12 35 21 C-30333-03 108 6 B-30355-12 36 19 C-30333-04 90 3 A-30356-01 67 4 C-30333-04 100 6 B-30359 18 25 C-30334-01 2 22 B-30359 85 5 C-30334-01 86 4 C-30360 86 1 C-30334-01 99 12 A-30361 16 32 C-30335 87 14 A-30361 18 26 B-30336 87 5 A-30361 21 23 B-30340 87 10 D-30365-03 3 35

) B-30342 87 2 D-30365-04 3 35 D-30343-01 2 22 D-30369 3 2 D-30343-01 75 7 D-30371 32 15


MODEL LD/LL ARTICULATED LOAD~R & FORKLIFT

PART. # FIGURE it ITE;M # PART # FIGURE # ITEM # ~)

D-30371 33 1 A-30487-01 44 2 D-30374 27 4 A-30487-02 44 2 B-30381 42 15 A-30487-02 44 2 A-30382-01 3 24 A-30489 44 1 B-30387-01 3 25 A-30490-01 44 1 8-30387-02 3 25 A-30490-02 44 1 B-30390-01 33 8 B-30491-03 28 11 B-30390-02 33 2 B-30491-04 28 7 A-30395 87 K B-30493 29 11 A-30396 89 K A-30494-3 21 18 A-30396 91 K B-30497 99 15 A-30397 76 K B-30498 99 16 A-30397 93 K A-30504 2 22 A-30400 3 8 A-30504 92 21 A-30401 3 5 A-30508 32 5 A-30402 3 4 A-30510 32 10 C-30403-02 3 7 A-30515 56 17 C-30403-03 3 7 A-30515 57 22 C-30403-04 3 7 A-30515 58 18 B-30408 42 2 D-30518 1 10 A-30409-02 3 3 D-30519 1 8 A-30410-01 31 9 A-3052-02 16 24 B-30413 31 8 A-3052-02 18 19 A-30416 32 43 A-30520-01 16 26

) A-30416 33 6 A-30520-01 18 24 A-30419 31 14 A-30520-1 21 26 8-30422-01 :51 15 A-30520-2 21 21 8-30422-02 31 15 B-30525 114 * A-30423 31 4 C-30526-01 114 1 D-30425 28 1 C-30526-02 114 1 C-30430 28 3 D-30527 1 9 C-30430 30 1 A-30532 65 11 A-30432 27 2 A-30549 100 7 A-30433 34 3 A-30549 104 7 A-30434 34 2 A-30549 108 7 A-30440 3 37 A-30553-02 100 8 A-30441-1 21 2 A-30553-02 107 2 A-30448 27 3 A-30553-02 110 7 8-30450 16 23 A-30553-04 112 14 8-30450 18 18 A-30554 100 17 A-30458 74 K A-30554 103 4 A-30463 44 1 A-30554 104 20 A-30463 44 1 A-30554 106 4 A-30465 3 19 A-30554 108 13 A-30466 3 26 D-30555 95 4 8-30473-01 28 14 B-30555 97 9 8-30473-02 28 6 B-30555 98 10 A-30476 17 15 B-30556 95 5 C-30479 44 4 P-30556 97 10

) C-30479 44 4 8-30556 98 11 C-30481 44 4 B-30557-02 103 13 A-30486 44 2 B-30557-02 105 12 A-30487-01 44 2 B-30558 103 5



PART # FIGURE # ITEM # PART 3 FIGURE # PART #

B-30558 104 19 B-30609-02 116 4 B-30558 106 5 B-30609~02 117 13 B-30558 109 5 A-30612-01 95 6 B-30558 112 5 A-30612-01 97 11 B-30559 100 9 A-30612-01 98 12 B-30559 107 12 D-30622 18 22 B-30559 110 10 A-30624 K B-30559 112 15 D-30635 25 1 B-30574-01 101 7 D-30635 26 1 B-30574-02 101 7 D-30635 65 6 B-30576-01 100 13 D-30645 24 10 B-30576-02 107 5 C-30647 48 15 C~30589 95 14 A-30648 14 7 B-30591 100 23 A-30648 24 12 B-30591 104 27 A-30648 56 32 B-30591 108 16 A-30648 57 2 C-30593-01 101 5 A-30648 57 32 C-30593-02 101 5 A-30649 24 5 C-30593-03 101 5 A-30651-01 31 16 A-30595 101 4 A-30651-01 32 45 D-30596-01 101 12 p.-30652 32 21 D-30596-02 101 12 A-30653 32 46 D-30596-03 101 12 B-30657 31 17 D-30596-04 101 12 A-30659-01 24 6 D-30597-01 101 1 C-30660 72 16 :) D-30597-02 101 1 A-30661-04 24 16 D-30598-01 103 14 A-30666-2 18 21 D-30598-02 103 14 A-30668 33 15 D-30598-03 105 14 B-30672 33 19 D-30599-01 102 1 C-30673 30 4 D-30599-02 102 1 A-30684 20 1 B-30600-01 109 D-30685-01 3 25 B-30600-02 103 9 D-30685-02 3 25 B-30600-02 105 11 B-30686 95 8 D-30603 2 22 D-30689 2 22 D-30603-03 94 1 D-30689 77 6 D-30603-03 103 8 D-30689 90 12 D-30603-08 94 1 D-30689 94 8 D-30603-08 103 8 D-30689 96 21 D-30603-09 94 1 C-30691 16 7 D- 3 06 0 3 - 0.9 105 8 C-30691 18 2 D-30605-03 95 3 C-30691 21 15 D-30605-08 95 3 D-30692 56 40 D-30605-09 95 3 D-30692 59 26 D-30606-03 95 10 D-30693 57 40 D-30606-08 95 10 D-30693 59 26 B-30609-01 100 18 C-30703 17 7 B-30609-01 104 25 C-30703 19 2 B-30609-01 108 14 C-30703 22 7 B-30609-02 99 2 A-30709 19 10 B-30609-02 100 2 B-30712 17 20 ~) B-30609-02 104 2 B-30712 . 19 8 B-30609-02 108 2 B-30712 22 23




B-30713-03 3 30 D-30837 114 1 C-30713-04 3 30 B~30842 . 14 4 B-30724 26 12 B-30842 56 5 B-30727 32 13 B-30842 58 5 A-30729 32 31 C-30846 16 14 B-30730 26 2 D-30848 19 13 B-30731 32 19 A-30849-01 20 19 D-30732 17 22 C-30850 20 9 C-30739 16 2 B-30854 20 15 C-30739 18 12 B-30857 32 2 D-30741 2 9 A-30865 44 4 D-30741 16 4 C-30865 44 4 D-30741 18 13 D-30869-01 100 1 D-30741 21 5 D-30869-01 113 11 A-30742 20 21 D-30869-02 104 1 A-30742 57 38 D-30869-02 108 1 A-30751-01 19 3 D-30869-02 113 11 A-30751-02 17 8 A-30875-01 44 1 A-30751-3 22 8 A-30875-02 44 1 C-30759-01 101 5 D-30879 107 11 C-30759-02 101 5 D-30880 106 8 C-30759-03 101 5 A-30881-01 91 17 B-30771 32 27 C-30882 78 20 B-'30779 3 31 C-30883 78 20

) A-30781 78 K C-30890 17 7 .... - r ~ ,.- ~. 'I ..,.... ~ r-.""', "", r- 104 15 :\ -....j v , 0 (; ~ I 1-> . .. :'.I..i ,_ .J C.

B-30787 3 15 B-30897 105 4 B-30792 3 15 B-30902 104 13 A-30796 56 36 D-30903-08 95 11 A-30796 57 37 A-30905 104 14 A-30796 58 35 A-30906-01 16 6 A-30800 56 25 A-10906-01 18 1 A-30800 57 25 A-30906-1 21 16 A-30800 58 23 B-30911 72 20 D-30810 2 3 D-30927 2 22 A-30812 2 4 D-30927 17 23 A-30814-03 19 22 D-30927 19 14 A-30819 17 13 D-30927 22 27 A-30819 19 16 D-30927 72 11 A-30819 22 13 A-30932 22 15 A-30820 14 17 A-30934 15 4 B-30825-01 115 3 A-30935 15 1 B-30825-02 115 3 A-30935 56 38 D-30829-01 115 1 A-30935 58 38 D-30829-02 115 1 A-30936 15 7 B-30830 115 10 A-30937 15 10 A-30832 1 5 A-30939 15 6 A-30834 114 3 B-30955 116 9 B-30836-01 114 2 B-30955 117 9 B-30836-01 114 2 D-30956-01 116 11 B-30836-02 114 2 D-30956-01 117 7

»

B-30836-02 114 2 D-30956-02 116 12 B-30836-03 114 2 D-30956-02 117 6


MODEL LO/LL ARTICULATED LOAPER & FORKLIFT

PART # FIGURE # ITEM # PART # FIGURE # PART # -) D-30957 116 14 p-31067 2 9 B-30958 116 13 B-31082 41 12 B-30960 92 19 B-31088 2 15 B-30961 92 10 B-31088 36 16 A-30962 92 9 B-31088 41 15 B-30963 92 13 C-31089 3 1 A-30969-01 16 13 A-31091 35 13 A-30969-02 18 8 A-31091 36 3 B-30972 16 10 B-31094 35 6 B-30972 18 4 B-31094 36 8 C-30973 16 11 A-31097 2 15 C-30973 18 6 A-31097 35 17 A-30976 2 22 A-31097 36 2 A-30976 2 22 A-31099 3 38 A-30976 17 1 B-31106 40 12 A-30976 19 1 B-31106 41 11 A-30976 22 1 B-31106 43 11 A-30976 29 27 B-31107 41 20 A-30976 67 8 P-31107-00 40 7 A-30976 85 10 A-31108 40 4 D-30979-01 101 12 A-31108 41 4 D-J097 9 -02 101 12 B"-31110 28 12 D-30980-02 97 16 B-31110 40 5 D-30981-01 109 13 B-31110 41 5 A-30982 15 * B-31110 42 9 ) 0-30983-01 110 15 D-31116 16 18 0-30984-01 111 6 B-31128-01 1 3 0-30994 3 20 B-31128-02 1 4 C-30997 18 9 B-31133 22 25 B-31002 16 35 B-31144 41 10 B-31002 21 29 A-31147 17 17 B-31004 21 13 A-31147 19 6 D-31008 21 20 A-31147 22 19 C-31009-01 16 38 B-31148-00 17 16 C-31009-02 16 25 B-31151 17 19 C-31009-1 21 32 B-31151-01 19 7 C-31009-2 21 25 B-31151-02 22 20 C-31013-1 22 11 A-31153 43 7 C-31013-2 22 12 B-31154 44 4 0-31014 22 26 A-31158 44 1 A-31016 16 33 B-31159 19 5 A-31016 21 24 B-31160 22 18 0-31017 16 19 A-31162 35 1 0-31017 21 22 A-31164 35 2 C-31018 16 16 A-31165-04 29 23 C-31018 21 19 A-31165-05 29 23 A-31022 22 16 B-31167 29 19 0-31023 58 39 C-31168 96 7 0-31023 59 26 A-31169 35 14 A-31025 16 34 B-31179 2 15

) A-31025 21 27 B-31179 35 24 A-31027 21 11 B-31179 40 11 0-31060 117 10 B-31188-01 17 11


".~"", •. , _" ~ .•• : ...... "0_. ~'J>:"

)

)

PART #

B-31199 A-31200 B-31206-00 A-31959 ]',.-35493--01 A-39817-00 A-39859 A-39879-1 A-39992-01 B-39993-02 B-39993-02 B-39993-02 B-39994-02

- -ic.:a V J.. U 0

B-49003-04 A-49733 A-49733 A-49733 A-49754-01 A-49774 8-49807-08 8-49808-08 A-49837 A-49837 A-4983? A-49837 .ll.-49858 A-49858 A-49875-01 A-49875-1 A-49879-01 A-49879-2 A-49880-01 A-49880-1 A-49884 A-49930 A-49931 A-49941-01 A-49947-1 A-49951 A-49957 A-49957 A-49957 A-49992-01 8-49993-02 8-49993-03 8-49994-01 A-49994-01 8-49994-01 8-49994-01 A-49995

JUNE 1989


FIGURE #

79 80 29 21 110 29 21 36 97 100 107 110 104 96 1 56 57 58 35 17 60 60 105 106 109 112 35 36 35 36 35 36 35 36 24 15 15 112 15 33 56 57 58 98 112 104 100 107 110 112 104

ITEM #

7 9 17 8 12 22 3 20 1 11 4 8 12 3 2 1 1 1 25 25 3 1 6 6 6 2 :1 ~

12 18 1 19 15 20 14 20 * * 11 5 20 28 30 25 2 16 16 10 3 9 17 24

PART # FIGURE #

.. -49995 105 A-49995 - 109 A-49995 112 A-50001-11 20 A~50001-12 19 l~ - 50 00 l -- 12 2 0 A-50001-12 22 A-50001-13 19 A-50001-14 19 A-50001-14 22 A-50003-15 20 A-50003-16 20 A-50004-03 22 Si-50004-17 20 A-50004-5 21 A-50005-05 19 A-50006-10 20 A-50006-12 19 A-50007-03 22 A-50007-05 22 A-50009-03 19 A-50011-06 19 F099883 70 F9003560-2500 70 F9003561-7500 70 F9003575-0001 70 F9003575-0049 70 F900410Q-0100 70 F9004100-0190 70 F9004100-02DO 71 F9004100-0230 70 F9004100-1420 69 F9004100-1440 69 F9004100-2300 69 F9004100-2340 68 F9004100-2340 71 F9004101-0120 70 F9004101-0140 70 F9004101-0140 70 F9004101-1190 71 F9004101-1290 68 F9004101-1290 71 F9004101-150 68 F9004201-2500 69 F9004201-5000 70 F9004201-6200 71 F9004201-8700 71 F9004610-1212 68 F9004610-1212 71 F9004700-1216 70 F9004800-3100 68 F9004800-3110 71

PRIME-MOVER

ITEM #

5 4 3 13 26 3 21 24 9 9 12 17 22 11 12 23 2 11 10 17 27 21 45 21 44 39 9 4 40 62 15 28 29 5 22 7 17 30 42 61 25 10 42 14 6 32 53 23 8 26 34 34

99. 15

MODEL LD/LL ARTICULATED LOAnER & FORKLIFTS

PA?,T # FIGURE # ITEM # PART # FIGURE # ITEM # ) F9004800-3112 71 2 F9220015 71 22 F9004800-3708 68 28 F92200i8 69 3 F9004800-3708 71 13 F9220042 68 7 F9004830-0002 69 10 F9220042 71 24 F9004830-0002 69 21 F9220043 68 5 F9004830-2501 69 11 F9220043 71 21 F9004875-0055 70 3 F9220242 68 24 F9005001-1200 69 16 F9220242 71 9 F9005001-1200 71 3 F9220416 71 1 F9005100-4400 69 15 F9220419 69 31 F9005100-4400 70 32 F9220425 68 35 F9005100-8700 71 31 F9220425 71 35 F9006110-1170 71 51 F9220427 68 29 F9006150-1190 71 52 F9220479 69 24 F9006150-1190 71 63 F9220500 68 11 F9006201-0334 71 5 F9220500 71 28 F9006250-0231 68 4 F9220570 69 9 F9006250-0231 71 20 F9220626 68 15 F9006300-0062 69 8 F9220628 68 12 F9006300-0062 69 20 F9220628 71 29 F9006320-0050 70 22 F9220633 68 3 F9006326-0025 70 38 F9220633 71 19 F9006375-0026 69 12 F9220689 71 16 F9006375-0026 70 14 F9220739 68 2 ) F90067201-0334 68 20 F9220739 71 18 F9007200-2530 70 27 F9220944 68 31 F9007200-2536 68 45 F9220976 71 15 F9007200-3142 71 43 F9220990 68 32 F9007200-3712 69 1 F9220992 71 12 F9007200-3722 68 18 F9220996 68 37 F9007200-3728 68 40 F9220999 71 37 F9007200-3728 71 40 F9221012 69 22 F9007200-3736 68 39 F9221017 69 19 F9007200-3736 71 39 F9221049 69 18 F900726-0011 69 32 F9221066 68 6 F9007276-0056 69 26 F9221066 71 23 F9009610-2850 68 46 F9221102 68 9 F9009610-2850 70 28 F9221102 71 26 F9009610-3459 71 42 F9221105 68 10 F9009610-:-4069 68 17 F9221105 71 27 F9009610-4069 68 38 F9221184 68 1 F9009610-4069 69 2 F9221184 71 17 F9009610-4069 71 38 F9221250 69 7 F9009625-0034 69 25 F9230583 69 23 F9009625-0081 70 7 F9240217 68 8 F9009625-2502 70 35 F9240217 71 25 F9009660-2500 70 20 F9330418 68 27 F9210168 68 21 F9510049 71 60 F9210168 71 6 F9510083-50 71 41 F9210329 68 26 F9510189 68 19 ) F9210329 71 11 F9510189 71 4 F9220015 68 14 F9510207 69 27

99. 16 PRIME-MOVER JUNE 1989

MODEL LD/LL ARTICULATED LOADER & fORKLIFTS

PARTS # FIGURE # ITEM # PART # FIGURE # ITEM #

F9510255 68 33 G7443 73 3 F9510255 71 33 G7970 73 22 F9510256 68 30 G8318 73 11 F9510256 71 14 G8334 73 15 F9510257 69 6 G8436-07 73 24 F9510365-0003 68 44 G8438 73 26 F9510408-0001 68 13 K-0458-001 82 32 F9510408-0001 71 30 K-0459-001 82 32 F9510422-0003 69 4 K-0462-001 82 32 F9510423-0003 68 36 K-1575-001 66 8 F9510423-0003 71 36 K-1576-001 66 2 F9510438-5000 71 50 K-1615-001 82 15 F9510482-2001 @9 17 K-1615-001 84 15 F9700824 56 22 K-19002 81 6 F9700824 57 10 K-19002 82 29 F9700824 57 34 K-19002 83 12 F9700824 58 32 K-19002 83 41 F9700824 70 10 K-23036A 66 3 F98-2472 70 1 K-5Q12-3838-004 82 19 F9800204 70 18 K-6005A 82 20 F9800210 69 13 K-6005A 83 2 F9800214 70 41 K-6005A 83 32 F9800648 68 41 K-6006-C 81 K

) F9800905 I U 11 K-b016 80 11 F9800908 70 12 K-6020 83 47 F9800909 70 13 K-6020-B 84 19 F9800917 70 19 K-6030-A 82 1 F9800997 70 16 K-6030-A 84 1 F9801035 70 37 K-6032 82 3 F9801036 70 36 K-6032 84 3 F9801094 70 31 K-6033 83 20 F9801235 68 48 K-6033-A 82 11 F9801721 70 2 K-6033-A 84 11 F9801930 70 24 K-6063 82 35 F9801931 70 23 K-6105-A 80 1 F9802585 70 29 K-6106-A 80 1 F9802586 70 5 K-6107-A 80 1 F9802587 70 8 K-6806-001 83 24 F9802589 70 25 K458-001 81 5 F9803304 70 43 K458-001 83 11 F9803333 70 34 K458-001 83 44 G14317 73 2 K459-001 81 5 G14380 73 9 K459-001 83 11 G15 73 20 K459-001 83 44 G18001 73 13 K462-001 81 5 G20642 73 25 K462-001 83 11 G370 73 19 K462-001 83 44 G5126 73 23 K5012-3838-004 83 31 G5389-6 73 27 K5012-6136-003 81 1

) G64009 73 6 K5052-7745-004 83 1 G64418 73 K LAOI-03620 38 18 G6862 73 14 LAOI-03620 39 12


MODEL LD/LL ARTICULATED LOADER & FORKLIFT

PART # FIGURE # ITEM # PART # FIGURE # ITEM # ~)

LAOI-07459 38 1 LB98-07965 39 2 LAOI-07459 ::. 9 26 LB9B-08622 38 24 LAOI-08635 38 13 LB99-08628 38 27 LA03-03621 38 19 LCIO-06409 38 25 LA03-03621 39 27 LCIO-06438 38 17 LA05-04467 38 30 LC98-07446 39 11 LA05-07458 38 10 LC98-08626 38 12 LA05-07458 39 14 LC99-07493 39 28 LA05-07638 39 31 LD12-08624 38 26 LA05-08629 38 28 LE12-0'l624 39 5 Ll'-.OS-08630 38 29 HA02-COI-076 37 K LA06-07975 39 1 MA20-080-006 37 8 LA08-07453 38 21 MA28-030-002 37 16 LA08-07453 39 9 MA30-010-030 37 5 LA08-07460 38 11 MA30-010-291 37 19 LA08-07460 39 13 MA30-030-028 37 15 LA08-07461 38 5 MA30-030-184 37 29 LA08-07461 39 21 MA30-170-008 37 1 LA08-08631 38 16 MA30-170-069 37 24 LA09-07452 39 29 MA32-660-033 37 3 LA09-07457 38 3 l-LZ\32 - 660 - 034 37 2 LA09-07457 39 23 MDV250CI02 23 3 LA09-08632 38 14 MDV250Cl19 23 6 ) LAIO-07333 39 4 MDV250C126 23 3 LAIO-07721 39 3 MDV250C724 23 6 LAII-08634 38 15 MP-2553-16 67 5 LA19-07463 38 6 MSRA35N12B 20 22 LA19-07463 39 20 MS2-26 15 3 LA98-07462 38 4 MS5-221 15 2 LA98-07462 39 22 OE-600-1693 8 9 LA98-07466 38 8 PSI-15GPM 80 4 LA98-07466 39 17 QE-1300-1497 12 7 LA98-07469 39 16 QE-1300-1498 4 5 LA98-07470 38 9 QE-1300-1499 7 8 LA98-07470 39 15 QE-1300-1499 8 13 LA98-07471 39 19 QE-1300-1500 11 3 LA98-07472 38 7 QE-1300-1501 11 3 LA98-07472 39 18 QE-1300-1502 12 9 LA98-07484 38 22 QE-1300-1503 12 9 LA98-07484 39 8 QE-1300-1504 10 1 LA98-07630 39 25 QE-1300-1505 10 1 LA98-07631 39 24 QE-1300-1506 8 6 LA98-07637 38 23 QE-1300~1508 8 1 LA98-07637 39 6 QE-1300-1509 8 2 LA98-08637 38 2 QE-1400-8984 6 2 LB05-07252 39 30 QE-1400-8985 6 2 LB08-07337 38 20 QE-1400-8993 6 10 LB08-07337 39 10 QE-1400-9001 9 2 LB09-07452 38 31 QE-1400-9002 ~. 6 ~) LB98-07629 39 7 QE-1400-9005 7 5


.. ;. •· ..... -:~:1n..;,··\'<",·,'···'" ·-,x.:C~··'\""'··':,",.,~-'::'···"I).."'r .. ""



QE-25-02-04-71 11 1 QE-939-0670 10 6 QE-25-02-04-71 12 2 QG13087 - 25 8 QE-60-400-12 12 4 QG13390 25 3 QE-600-,0029 10 16 QG17223 25 6 QE-600-0283 10 13 QG17224 25 4 QE-600-0463 10 12 QG17226 25 10 QE-600-0656 8 10 QG17405 25 9 c:: 5CO-<}858 4 4 QG19401 25 2 QE-600-0858-SI 5 3 QG19401 56 33 QE-600-0858-SIO 5 4 QG19401 57 33 QE-600-0858-S12 4 13 QG21196 25 11 QE-600-0858-S13 4 1.4 QQ-7312-009 65 3 QE-600-0858-S3 4 3 QY15439-7 74 26 QE-600-0858-S5 5 5 QY15439-9 74 25 QE-600-0858-S6 5 1 QY15546-6 78 15 QE-600-0858-S7 5 2 QY16028-722 74 15 QE-600-I095 12 10 QY16048-1 78 18 QE-600-1246 11 2 QY16048-31 78 13 QE-600-1246 12 3 QY16I03-110 78 5 QE-600-1247 11 2 QY16119-632 74 2 QE:-600-1247 12 3 QY16119-634 74 1 QE-600-1583 12 11 QY16169-2160 74 31 QE-600-1665 8 3 QY16224-013 74 22 QE-600-1687 12 8 QY17125-10 78 14 :) QE-600-1689 10 5 QY20500-33 74 29 QE-600-1690 9 3 QY20500-45 74 18 QE-600-169~ 9 10 QY20500-9 74 24 QE-600-1692 8 14 QY24500-501 74 4 QE--600-1696 4 12 QY24503-251 74 14 QE-600-1697 4 9 QY24504-307 74 13 QE-600-1699 8 12 QY24504-311 74 12 QE-600-224 9 9 QY24530-24 74 17 QE-600-656 10 4 QY24530-610 74 21 QE-902-0786 11 4 QY30501-10 78 12 QE-902-1240 9 7 QY30501-12 78 4 QE-906-0024 10 19 QY30501-13 78 3 QE-906-0075 10 2 QY30501-17 78 1 QE-906-0100 10 21 QY30501-390 78 16 QE-906-0114 10 18 QY32015-71 74 27 QE-906-0196 10 20 VD-3CH 114 * QE-906-0206 10 3 VTI-7102-74 13 * QE-906-0243 12 1 W9010061 114 6 QE-906--0290 10 9 W9010062 114 6 QE-906-0344 9 1 W9010063 114 6 QE-908-0232 12 6 W9010064 114 6 QE-908-0504 10 7 W9010065 114 6 QE-9109-034 4 10 . W9010066 114 6 QE-919-0054 9 4 W9010091 114 4 QE-919-0080 8 5 W9010092 114 5

) OE-919-0190 8 4 7-18432X 15 29 QE-919-0270 9 5 Z-29606AX 45 43 QE-933-0260 7 9 z-3-4-5711X 45 18



PART # FIGURE # ITEM # PART # FIGURE # ITEM # )

Z-30137 45 1 52-224 1 6 Z-30266 45 37 52-325 7 2 Z.,.30271 43 13 52-325 10 8 Z-30271 45 20 52...,'325 13 10 Z-30275 43 12 52-5009 13 4 Z-30275 45 19 52-5054 24 4 Z-34687 15 32 52-7901-01 4 1 Z-3:;822 l",,,) 31 52-7901-04 15 8 Z-35102-6A 45 3 6770-007-1727 80 10 Z-35103-1 45 3 6814-001' 80 5 Z-35103-7A 45 3 6815-001 80 6 Z-35725 45 17 Z-36025 45 5 Z-36026 45 7 Z-36027 45 6 Z-36277 45 12 Z-36280 45 2 Z-36472 45 30 Z-36660 45 36 Z-36848 45 4 Z-37602 45 9 Z-38553 45 13 Z-500400-20 45 33 Z-500598-22 45 35 Z-706045X 45 15 ) Z-706058X 45 3K Z-706059X 45 28 Z-706060X 45 23 Z-706061-4X 45 IK Z-706065X 45 2K Z-706070X 45 26 Z-706075X 45 11 Z-706076X 45 8 Z-92534 45 10 Z5-160X 46 1 Z5-160X 51 1 02676015 57 26 02676015 58 27 04194015 56 31 04194015 58 30 04195013 56 30 04195013 57 28 04195013 58 28 108759 65 1 1862-020-W7C-2100 8 04 2709-001 80 12 52-210 1 6 52-211 1 6 52-212-3 1 1 52-213 1 6

) 52-214 1 6 52-215 1 6


".

">",

Documents

LD/LL PARTS MANUAL