140 Hydrostatic L&G S/n 30,001 & Up

JD-P-PC1245

http://www.jensales.com/products/john-deere-140-lawn-garden-tractor-parts-manual-sn-30-001-up.html

TRACTOR, HYDROSTATIC - 140 (30,001-

ALPHABETICAL INDEX

A

AIR CLEANER. ALTERNATOR AMMETER............ . ............. . AMMETER. . .................................... . ARM, STEERING............. . ........... . AXLE AND DIFFERENTIAL, COMPLETE ........... . AXLE, FRONT. . ............... . AXLE, REAR ... ............... . AXLE, REAR (INBOARD SEALS) AXLE, REAR (OUTBOARD SEALS) ..

B

BAFFLE, AIR ........................................ . BATTERY, CABLES AND BASE BEARINGS, FRONT WHEEL .... . ............. . BLOCK, CYLINDER.. . ........ . BRAKE DRUM. BRAKE LINKAGE ... BRAKE PEDAL. . . . . . . . . . . .. . .................... . BRAKE PEDAL .... . BRAKE PEDAL ............ . BRAKE SHOES ............ . BRAKE, PARKING .. BREAKER, CIRCUIT. BREAKER, CiRCUiT ......................... . BREAKER, POINTS, IGNITION BREATHER, ENGINE ........ . BUMPER PLATE ........... .

c

CABLES, BATTERY AND STARTER. CABLES, CHOKE AND THROTTLE ............... . CAMSHAFT ....................................... .. CHOKE LEVER ............ . CLUTCH, ELECTROMAGNETIC (FRONT PTO) .... . CLUTCH, ENGINE DISCONNECT ............... . CLUTCH, ENGINE DISCONNECT.. . ........ . COIL, IGNITION .. . ........... . CONDENSER. CONTROL LEVER, SINGLE (H-1) ................... .. CONTROL LEVER, TRIPLE (H-3). CONTROL LINES, OIL (H-1) .. CONTROL LINES, OIL (H-3) CONTROL VALVE (H-3) .... . ........... . CONTROL VALVES (H-1) ... . .............. .. CONTROL VALVES (H-3) .. . ............... . COUPLERS, HYDRAULIC (FRONT AND REAR). COWL.. . ....... .. COWL.. . ............ . CRANKSHAFT, ENGINE. CYLINDER, ENGINE BLOCK ..................... . CYLINDER, ENGIN!= HEAD . CYLINDER, ROCKS HAFT ........................ .

D

DECALS ..... . DECK, FENDER ........... . DIFFERENTIAL AND AXLE, COMPLETE ............. . DIFFERENTIAL ASSEMBLY . . ........... .

PAGE

30 22 18 19 12 45 12 48 47 46

28 17 13 23 37 37 34 35 36 37 38 18 19 22 24

5

17 16 26 16 33 34 40 22 22 51 53 52 55 54 51 54 50

7 8

23 23 24 38

56 6

45 49

TRACTOR, HYDROSTATIC - 140 (30,001- ) PC-1245 (25-FEB-77) LITHO IN U.S.A.

DIPSTICK, ENGINE ............. . DIPSTICK, TRANSMiSSiON ..... . DISCONNECT ENGINE ... DISCONNECT. ENGINE .. DRIVE SHAFT, ENGINE . . ................. . DRIVE SHAFT, ENGINE ................... . DRIVE, STARTER ...

E

ELECTRICAL WiRING.... . ................ . ELECTRICAL WiRING........... . ......... . ENGINE, BALANCE GEARS.. . ............. . ENGINE, BEARINGS.. . .............. .. ENGINE, BREATHER ................. . ENGINE, CAMSHAFT ........... . ENGINE, CARBURETOR ..... . ENGINE, CONNECTING ROD .. . ENGINE, CRANKSHAFT......... . ........ . ENGINE, CYLINDER BLOCK..... . ............. . ENGINE, CYLINDER HEAD .................. . ENGINE, DIPSTICK.. . .............. . ENGINE, DiSCONNECT .................... . ENGINE, DiSCONNECT .................... . ENGINE, DRIVE SHAFT .. . ................ . ENGINE, DRIVE SHAFT.. . ..................... . ENGINE, FLyWHEEL ........ . ENGINE, GASKET AND SEAL KIT ........... . ENGINE, GOVERNOR ......... . ENGINE, HEAT SHIELD ................... .. ENGINE, HOUSING, BLOWER .............. . ENGINE, MUFFLER ......... , ....... : ....... . ENGINE, OIL PAN .. , , ................... . ENGINE, PiSTON .................................... . ENGINE, VALVE INSERTS..... .." ................ . ENGINE, VALVES.......... , ..................... .

F

FENDER DECK ............................ . FILTERS, AIR .......... . FILTERS, FUEL . FILTERS, TRANSMISSION ..... , ............ . FLYWHEEL, ENGINE ................... , ............ . FRAME .. . . , . . . . . . . . . . . , , , , , ............ . FUEL LINE, ............ .. FUEL TANK ............................ ..

G

GASKETS, ENGINE ....... . GEAR, STEERING.,............ . ........... . GEARS, DIFFERENTIAL ....... . GEARS, ENGINE BALANCE ................ . GOVERNOR AND LINKAGE ............... . GRILLE............. . ............. . GRILLE ................... , .. , ............. .

H

HARNESS, WIRING (MAIN) .. HARNESS, WIRING (MAIN) .. HEAD, CYLINDER ...

PAGE 24

40 34 40 41 21

18 19 31 23 24 26 29 25 23 23 24 24 34 40 40 41 23 32 27 28 28 28 24 25 23 26

6 30 15 43 23

5 15 15

32 11 49 30 27

7 8

18 19. 24

3

4

TRACTOR. HYDROSTATIC - 140. (30,001-

ALPHABETICAL INDEX - CONTINUED

HEADLIGHTS ........................................ . HITCH .............................................. . HOOD ............................................... . HOSES, ROCKSHAFT CYLINDER .................... . HOUSING, AXLE .................................... . HUB, REAL WHEEL ................................. . HUB, REAL WHEEL (INBOARD SEALS) .............. . HUB, REAR WHEEL (OUTBOARD SEALS) ............ . HYDRAULIC LIFT LEVER ............................ . HYDRAULIC LIFT LEVER ............................ .

IGNITION SYSTEM .................................. . INSERTS, VALVE .................................... .

K

KIT, BRUSH AND SPRING, STARTER ................ . KIT, CARBURETOR REPAIR ......................... . KIT, FOOT-TREAD ................................... . KIT, GASKET AND SEAL, ENGINE ................... . KIT, REAR HYDRAULIC OUTLET ..................... .

L

LATCH, SEAT RELEASE ............................. . L1~,rua ......................................... . LINKAGE, BRAKE ................................... . LINKAGE, ENGINE DISCONNECT .................... . LINKAGE, GOVERNOR ............................... . LINKAGE, HyDROSTATiC ............................ . LINKAGE, LIFT SHAFT (ROCKSHAFT) ................ .

M

MOTOR, STARTER .................................. . MUFFLER ........................................... .

p

PAN, OIL. ........................................... . PARKING BRAKE .................................... . PEDALS, ENGINE DISCONNECT & BRAKE ........... . PEDALS, ENGINE DISCONNECT & BRAKE ........... . PEDESTAL .......................................... . PISTON, ENGINE .................................... . PLUG, SPARK ....................................... . POINTS, BREAKER .................................. . PTO, ELECTROMAGNETIC CLUTCH (FRONT) ........ .

A

REFLECTOR, RED ................................... . REGULATOR - RECTIFIER ........................... . REGULATOR - RECTIFIER ........................... . RODS, CONNECTING, ENGINE ...................... . RODS, STEERING TIE ............................... .

PAGE

20 5 9

38 45 48 47 46 51 53

22 23

21 29

6 32 50

10 15 37 34 27 42 39

21 28

24 38 34 35

6 25 22 22 33

6 18 19 25 12

S

SEALS, ENGINE ..................................... . SEAT, TRACTOR SPRING ........................... . SEAT, TRACTOR, RELEASE LATCH ................. . SHAFT, AXLE ....................................... . SHAFT, AXLE (INBOARD SEALS) .................... . SHAFT, AXLE (OUTBOARD SEALS) .................. . SHAFT, DRiVE ...................................... . SHAFT, DRIVE ...................................... . SHIELD, HEAT, ENGINE ............................. . SHOES, BRAKE ..................................... . SOLENOID, STARTER ............................... . SOLENOID, STARTER ............................... . SPARK PLUG ....................................... . SPLASH TRAY ...................................... . STARTER CABLE ................................... . STARTER MOTOR ................................... . STATOR, ALTERNATOR ............................. . STEERING WHEEL .................................. . STEERING, ARM .................................... . STEERING, GEAR ................................... . STEERING, TIE RODS ............................... . STRAINER, FUEL .................................... . SWITCH, IGNITION .................................. . SWITCH, IGNITION .................................. . SWITCH, LIGHT ..................................... . SWITCH, LIGHT ..................................... . SWITCH, NEUTRAL-SAFETy ......................... . SWITCH, NEUTRAL-SAFETy ......................... . SWITCH, PTO ....................................... . SWITCH, PTO ....................................... .

T TAILLIGHTS ......................................... . TANK, FUEL ........................................ . THROTILE LEVER .................................. . TIE RODS, STEERING ............................... . TIRES, FRONT ...................................... . TIRES, REAR ....................................... . TRANSMISSION, CHARGE PUMP .................... . TRANSMISSION, CHECK VALVE ..................... . TRANSMISSION, CONTROL CAM .................... . TRANSMISSION, CONTROL LEVER .................. . TRANSMISSION, CONTROL LINKAGE ................ . TRANSMISSION, CYLINDER BLOCK .................. . TRANSMISSION, DRIVE SHAFT ...................... . TRANSMISSION, HOUSiNGS ......................... . TRANSMISSION, RELIEF VALVES .................... . TRANSMISSION, TRUNNION SHAFT ................. . TRAY, SPLASH ...................................... . TUBES, FRONT ..................................... . TUBES, REAR ....................................... .

V

PAGE

32 10 10 48 47 46 40 41 28 37 18 19 22 15 17 21 22 11 12 11 12 15 18 19 18 19 18 19 18 19

20 15 16 12 13 14 43 43 42 42 42 44 44 43 43 43 15 13 14

VALVES, ENGINE ..................................... 26

W WHEEL, FRONT ..................................... . WHEEL, REAR ...................................... . WHEEL, STEERING .................................. . WIRE, SPARK PLUG ................................ . WIRING, ELECTRiCAL ............................... . WIRING, ELECTRiCAL ............................... .

13 14 11 22 18 19

TRACTOR, HYDROSTATIC - 140 (30,001- ) PC-124S (25-FEB-77) LITHO IN U.S.A.

M12655

14

\ 15

\

~ 16

KEY PART NO. SERIAL NO.. DESCRIPTlo.N

1 M 42357 ) HITCH 2 19H 1833 ) SCREW, CAP, 5/8" X 1-1/4" (2 USED)

12H 294 • ) WASHER, LOCK, 5/8" (2 USED) 14H 760 ) NUT, 5/8" (2 USED)

3 19H 1905 ) SCREW, CAP, 5/16" X 1" (4 USED) 14H 785 ) NUT, 5/16" (4 USED) 12H 303 ) WASHER, LOCK, 5/16" (4 USED)

4'-c 14H 785 ) NUT, 5/16" (4 USED) 5 M 43832 ) MOUNT, DECK REAR (2 USED) 6 12H 303 ) WASHER, LOCK, 5/16" (4 USED) 7 M 42814 ) MOUNT, DECK, FRONT (4 USED) 8 M 42813 ) GUIDE, RUBBER (2 USED) 9 M 42812 ) SPACER, GUIDE (2 USED)

10 03H 1413 ) BOLT, RD. HD., 5/16" X 1-3/4" (2 USED) 12H 334 ) WASHER, LOCK, INTERNAL-EXTERNAL TOOTH, 5/16" (2 USED) 14H 785 ) NUT, 5/16" (2 USED)

11 24H 1294 ) WASHER, 11/32" X 1-1/8" X 0.060" (2 USED) 12 19H 2648 ) SCREW, CAP, 3/8" X 1-3/4" (2 USED) 13 14H 732 ) NUT, JAM, 3/8" (2 USED) 14 M 43641 ) PLATE, BUMPER 15 19H 2020 ) SCREW, CAP, 5/16" X 1/2" (4 USED) 16 M 2291 T ) PLUG (2 USED) (H-1 ONLY) 17 19H 1792 ) SCREW, CAP, 1/2" X 1" (4 USED)

14H 809 ) NUT, 1/2" (4 USED) 12H 301 ) WASHER, LOCK, 1/2" (4 USED)

18 M 44420 ) BRACKET, TRANSMISSION MOUNTING (R.H. SIDE) 19 M 44421 ) BRACKET, TRANSMISSION MOUNTING (L.H. SIDE) 20 AM 33285 ) FRAME

TRACTOR, HYDROSTATIC - 140 (30,001- ) PC-1245 (25-FEB-77) Lli~iO'IN U.S.A. 5

M12656

6

KEY PART NO. 1 R 36590 2 AM 31432 3 37H 47 4 M 43048 5 AM 33659

AM 33661 AM 33879 AM 33902 AM 34503 AM 34502

6 M 7 M 8 AM

AM 9 19H

12H 14H

10 AM 11 M

42811 44391 33309 34276

1900 303 785

32376 43227

FENDER-DECK AND PEDESTAL ASSEMBLIES

SERIAL NO.

38001-38001-

-38000 -38000

38001-46500 38001-46500 46501-46501-

-46500 46501-

DESCRIPTION BUTTON, PLUG (2 USED) (H-3) PLATE, COVER (H-3) SCREW, SELF-TAPPING, NO.8 X 1/2" (H-1) (2 USED) REFLECTOR, RED (H-1) (2 USED) FENDER-DECK ASSEMBLY (H-l) (INCLUDES M43686 DECAL) FENDER-DECK ASSEMBLY (H-3) (INCLUDES M43691 DECAL) FENDER-DECK ASSEMBLY (H-l) (INCLUDES M47180 DECAL) FENDER-DECK ASSEMBLY (H-3) (INCLUDES M47181 DECAL) FENDER-DECK ASSEMBLY (H-1) (SUB. AM34502) FENDER-DECK ASSEMBLY (H-l) AND (H-3) (INCLUDES AM31432, M47180,

M47181 AND TWO M43227 PAD, RUBBER (2 USED) EDGING, VINYL, 10FT. (3.048 M) LONG (CUT TO LENGTH) PEDESTAL PEDESTAL SCREW, CAP, 5/16" X 3/4" (4 USED) WASHER, LOCK, 5/16" (4 USED) NUT, 5/16" (4 USED) KIT, FOOT-TREAD (CONSISTS OF ONE LARGE R.H. AND L.H. FOOT-TREAD) STRIP, ANTI-SKID (2 USED)

TRACTo.R, HYDRo.STATIC - 140 (30,001- ) PC-124S (25-FEB-77) LITHO. IN U .. S.A.

GRILLE AND COWL ASSEMBLY (SERIAL NO. -38,000)

M8166

9

KEY PART NO. SERIAL NO. DESCRIPTION

1 N 10011 J-CLAMP (2 USED) 2 M 40691 WASHER, SPRING (8 USED) 3 M 42412 RIVET, SHOULDER (8 USED) 4 M 42416 PLATE, HINGE, R.H.

M 42417 PLATE, HINGE, L.H. (ILI-USTRATED) 5 M 42419 HINGE, FRONT (2 USED) 6 M 42411 HINGE, REAR (2 USED) 7 AM 31217 COWL ASSEMBLY, L.H. 8 JD 5273 DECAL, "LEAPING DEER" 9 AM 32325 PANEL, HEADLIGHT AND GRILLE, INCLUDES DECAL

10 AM 32372 GRILLE 11 AM 31796 CLIP, SPRING (2 USED) 12 16H .166 RIVET, TRUSS HD., 5/32" X 1/4" (2 USED) 13 03H 1519 BOLT, RD. HD., 3/8" X 1" (4 USED)

12H 304 WASHER, LOCK, 3/8" (4 USED) 14H 812 NUT, 3/8" (4 USED)

14 AM 31216 COWL ASSEMBLY, R.H. 15 03H 1268 BOLT, RD. HD.,5/16" X 3/4" (4 US!,:D)

24H 1136 WASHER, 11/32" X 11/16" X 0.060" (4 USED) W 11955 NUT, LOCK, 5/16" (4 USED)

TRACTOR, HYOROSTATIC - 140 (30,001- ) PC-1245 (25-FEB-77) LITHO IN U.S.A. ..,

TRACTOR, HYDROSTATIC - 140 (30,001-

SEAT, SPRING AND RELEASE LATCH M12659

19 2o<!

~22 23 24

18 - 25 32~~~6 .

2331~~~ 24 26~ "" .. ~

/ -\ r 29 27 28 30

11

\ e ._12

~13 ---14

~-"15

KEY PART NO. SERIAL NO. DESCRIPTION

I 1 AM 37580 ( ) SEAT (SUB. FOR AM31614, AM34065 AND AM36845) 2 M 47182 ( ) CLIP, SEAT (SERVICE ONLY) 3 19H 1936 ( ) SCREW, CAP, 3/8" X 3/4" (4 USED)

12H 304 ( ) WASHER, lOCK, 3/8" (4 USED) 4 M 42442 ( -38000 ) SPRING, SEAT (2 USED)

M 46183 ( 38001- ) SPRING, SEAT (2 USED) 5 M 63440 ( 46501- ) NUT, lOCK, 3/8" (2 USED) 6 M 47123 ( 46501- ) KNOB, SEAT ADJUSTING (2 USED) (SUB. M48237) 7 24H 1305 ( 46501- ) WASHER, 13/32" X 13/16" X 0.060" (2 USED) 8 24H 1176 ( 46501- ) WASHER, 13/32" X 1-1/4" X 0.090" (4 USED) 9 M 47235 ( 46501- ) STRAP, SEAT (2 USED)

10 03H 1519 ( 46501- ) BOLT, RD. HD., 3/8" X 1" (4 USED) 11 14H 812 ( 38001-46500 ) NUT, 3/8" (4 USED) 12 12H 302 ( 38001-46500 ) WASHER, LOCK, 3/8" (4 USED) 13 M 46186 ( 38001-46500 ) GUIDE, LATCH (2 USED) 14 24H 1308 ( 38001-46500 ) WASHER, 7/16" X 1" X 0.134" (4 USED) 15 M 46470 ( 38001-46500 ) BOLT, SHOULDER (4 USED) 16 AM 33880 ( 38001-46500 ) LATCH 17 S 148 M ( 38001 - 46500 ) SPRING 18 34H 282 ( -38000 ) PIN, SPRING, 3/16" X 1" (2 USED) 19 11H 229 ( -38000 ) PIN, COTTER, 3/32" X 2" 20 14H 826 ( -38000 ) NUT, JAM, 1/2" (4 USED) 21 16H 292 ( -38000 ) RIVET, TRUSS HEAD, 3/16" X 7/8" 22 L 1142 C ! -38000 ) SPRING 23 AM 31321 -38000 ) LATCH (2 USED) 24 M 42654 ( -38000 ) LINK, LATCH (2 USED) 25 14H 812 ! -38000 ) NUT, 3/8" (2 USED) 26 12H 304 -38000 ) WASHER, lOCK, 3/8" (4 USED) 27 34H 331 ( -38000 ) PIN, SPRING, 5/16" X 1-1/2" (2 USED) 28 M 42647 ! -38000 ) STUD, FRONT MOUNT (2 USED) 29 M 42648 -38000 ) RELEASE, LATCH 30 11H 216 ( -38000 ) PIN, COTTER, 3/16" X 1" 31 M 42655 ( -38000 ) PIVOT, LATCH 32 AM 31463 ( -38000 ) ROD, MOUNT, REAR

10 TRACTOR, HYDROSTATIC - 140 (30,001- ) PC-1245 (23-OCT-78) LITHO IN U.S.A.

TRACTOR,

STEERING WHEEL AND GEAR ASSEMBLY M12660

M12660

KEY PART NO. SERIAL NO. DESCRIPTION

1-M--44205-~~ ) EMBLEM, STEERING WHEEL 2 T 11220 ( ) a-RING ~tl_~86j) ___ ~~ ____ ~:~. -c)f---cNi-;'U~T~,~JC'-A~M~,""5",/8",,",,,, ____________________ _ 4 M 43800 ( .) WHEEL, STEERING 5 M 42528 ( ) GROMMET, STEERING COLUMN ~6 M 43744 ( ) SEAL, BEARING 7 M 43743 ( ) BEARING 8 AM 33268 ( ) GEAR, STEERING, INCLUDES SEALS AND LEVER ARM 9 . 371j ~~_~ . __ ~ ___ C ___ ~~~~---.J~ SCREW, THREAD CUTTING, 5/16" X 3/4" (2 USED) (SUB. FOR M45755)

10 M 40704 ( ) CLAMP, STEERING COLUMN 11 19H 1731 ( ) SCREW, CAP, 3/8" X 1" (3 USED) __ 1~21j~_3-.lQ __ ~--.L. ___ -____ ~) WASHER, LOCK, INTERNAL TOOTH, 3/8" (3 USEDL ____ ~ __ ~_._._~.~ __ . __ .. _ 12 JD 7806 ( ) FITTING, GREASE, 90', 1/4" (6.35 MM) 13 R 26552 ( ) BALL, STEEL, 5/16" (7.938 MM) DIA. (16 USED) 1.:4n_~f\lLu_31924~ ( - .. ___ ~ BEARING (CONSfSTS OF BEARINGS, RETAINERS.AND CUPS) u_ u __ ~ __ _

15 M 43747 ( ) WASHER, SPRING 16 M 43745 ( ) PLUG, ADJUSTING ~~5. ___ ~ __ ~_-=-_~~ .. PIN, COTTER, 1/8" X 1/2" 18 M 45566 ( ) WASHER, 25/32" X 17/64" X 0.063" 19 14H 904 ( ) NUT, JAM, 3/4" (2 USED)

I 20_~ 45568~ ( ) SEAL, LEVER ARM (SUB. AM33331) 21 AM 33331 ( ) KIT, SEAL AND RETAINER 22 AM 33329 ( ) ARM, LEVER, INCLUDES 3/4" CROSS BOLT 2~~. _M_4..s~67 ___~ ___ -_. __ ~l ~S;.;-T~U ___ D~~~~ ______ _ 24 14H 832 ( ) NUT, JAM, 9/16"

TRACTOR, HYDROSTATIC - 140 (30,001- ) PC-1245 (23-0CT-78) LITHO IN U.S.A.

FRONT AXLE, TIE RODS AND M193131

7 13

14 \ I

~:~ 7-~

M19361

KEY PART NO. SERIAL NO. DESCRIPTION