STORY AND PHOTOS BY JOSH KIMBALL

It all gelled for me sometime in the middle of week four, right at the end of September. I was clamping

hundreds of feet of hoses together, from which thousands of pounds of grapes would soon flow. It was the first chilly morning of fall—that Paso Robles inland cold that requires several layers of clothing—and a brisk wind had set in. Bodies would streak by periodically: one going to find the forklift, another going to hook up the steam generator, one heading to help offload new barrels from a massive delivery truck, one covered in grape shit from having just dug out a tank, one heading back to check on a pumpover. All did so with a brisk sense of urgency. There’s music playing on the radio, but it’s muffled by the hum of various propane, diesel, and 480-volt industrial machinery. When it was Lady Gaga on the radio, dear god, I loved those machines. A massive 21-wheeler rolled in and stopped with a hydraulic grunt, shouldering 50 tons of grapes on the bed. The winemaker headed over to greet the driver, virtually hop-scotching the spaghetti farm of hoses while en route. I got the hoses all hooked up, and began cleaning them and the pump with (in very specific order) soda ash, then citric acid, then iodine, then fresh water. This is a harvest in full swing at a winery that produces roughly one million bottles of high quality wine a year. And all of a sudden, it clicked for me. I’d found the hard-to-explain flow of it, and the dynamism of it all—which until then was confusing and sometimes intimidating—became embraceable. These images are a glimpse into some of the integral parts of this season’s winemaking process at Peachy Canyon Winery, while others are simply a suite of the good, bad, and ugly that naturally go down in an occasionally pressurized, frantic, but ultimately rewarding and fun environment. Thirteen-hour workdays, cumulating in 75-hour work weeks, are commonplace. ∆

Freelance photographer Josh Kimball can be reached through the editor at econnolly@newtimesslo.com.

Crushcourse

An insider’s view of winemaking, from vineyard to barrel

OVERSEEING THE HARVEST

In the chaos of the annual wine-grape crush at Peachy Canyon Winery,

“Gnome Chomsky” provides a friendly face.

HERE COMES THE WINE Peachy Canyon winemaker Josh Beckett (above

right) follows the grapes all the way through the busy and sometimes frantic process, from sorting to stomping to pumping to

fermenting. Intern Liz Hysell (below) crushes the grapes the old-fashioned way, mixing the juice with the skins as a first step in

creating a flavorful red blend.

Crushcourse

An insider’s view of winemaking, from vineyard to barrel

Crush course

ORGANIZED CHAOS Daily tasks for the harvest are carefully orchestrated for each wine-grape varietal,

including cleaning out the grape skins after initial fermentation in tanks and pressure cleaning the huge bladder press where all the grape skins are filtered

out. The “winery Olympics” at the end of the process give the staff a chance to relax with sporting events such as a mouth-and-spoon egg carrying contest.

Crush course

GO, GO, GO Crush workers like intern Chris Jarrott (bottom left) put in long days during the busy harvest period, 15 hours and 45 minutes on the clock on one especially long workday. Once the fermentation tanks are emptied and cleaned of all the remnant grape skins, the wine finishes fermentation in new oak barrels.