General Disclaimer

One or more of the Following Statements may affect this Document

This document has been reproduced from the best copy furnished by the

organizational source. It is being released in the interest of making available as

much information as possible.

This document may contain data, which exceeds the sheet parameters. It was

furnished in this condition by the organizational source and is the best copy

available.

This document may contain tone-on-tone or color graphs, charts and/or pictures,

which have been reproduced in black and white.

This document is paginated as submitted by the original source.

Portions of this document are not fully legible due to the historical nature of some

of the material. However, it is the best reproduction available from the original

submission.

Produced by the NASA Center for Aerospace Information (CASI)

1s ,^ r

N78-11293

(I,ASA-CIt-1504E2) JAN IRANSIS'TOR ANDDIODE

c^HAhACTENI"AT ION ZEST pFCGFAr,Unclas

1N5619 ,Final RPt IDCA Reliability Labs.,

HC A02/Mf AOSunnyvalpa Calif.) 15 P CSCL 09C G3/33 53541

JAN TRANSISTOR AND DIODE

CHARACTERIZATION TEST PROGRAM

FINAL REPORT

FOR

JANTX DIODE

1N5619

FEBRUARY 1977Prepared

for

GLORGE C MARSHALL SPACE FLIGHT CENTERNATIONAL AERONAUTICS AND SPACE ADMINISTRATION

Mlershall Spec. Flight Canter, Alatama 35812

MSFCINASA CONTRACT No NAS3-31014

by

HIRO TAKEDA

DCA RELIABILITY LABORATORYSPECIAL PRODUCTS DIVISION

975 BENICIA AVE.SUNNYVALE, CALIFORNIA A086

1114DCA RELIABILITY LABORATORY

t

A^

J^ t

3

JAN TRANSISTOR AND DIODE

CHARACTERIZATION TEST PROGRAM

FINAL REPORT

FOR

JANTX DIODE

1N5619

FEBRUARY 1977Prepared

for

GEORGE C. MARSHALL SPACE FLIGHT CENTERNATIONAL AERONAUTICS AND SPACE ADMINISTRATION

Marshall Space Flight Canter, Alabama 35811

MSFC!NASA CONTRACT No NASS 31944

by

HIRO TAKEDA

DCA RELIABILITY LABORATORYSPECIAL PRODUCTS DIVISION

975 BENICIA AVE.SUNNYVALE, CALIFORNIA 94088

aft-

FORUARD

This report is it statistical summary of the electrical

characterization performed on NASA Contract NA8-31944.

This is one of a group of thirty-nine (39) such reports

prepared on selected JAN and JANTX Transistors and Diodes

for the George C. Marshall Space Flight Center, Huntsville,

Alabama. The Contracting Officer's Technical Representative

was Mr. Howard B. Meeks.

This work was performed by DCA Reliability Laboratory,

Special Products Division, Sunnyvale, California under the

management of Mr. Robert Starr with the special assistance

of Mr. harry Lorenzo , Mr. Kenneth Radford and Mr. Iiiroharu

Takeda.

ii

rA

CONTENTS

1.0 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . 1-1

1.1 Sample Selection . . . . . . . . . . . . . . . . . . 1-1

1.2 Procure , ,ent Guidelines . . . . . . . . . . . 1-1

2.0 TECHNICAL SUMMARY . . . . . . . . . . . . . . . . . . . . 2-1

2.1 Test Parameters and Conditions . . . . . . . . . . . 2-1

2.1.1 Reverse Current (I R ) . . . . . . . . . . . . . 2-1

2.1.2 Forward Current (V F j . . . . . . . . . . . . . 2-1

2.1.5 output Capacitance (C ) . . . . . . . . . . . 2-10

2.1. 7Reverse Recovery Time ( t rr ) . . . . . . . . . 2-1

2.2 Unit Definitions . . . . . . . . . . . . . . . . . . 2-2

3.0 STATISTICAL SUMMARY . . . . . . . . . . . . . . . . . . . 3-1

4.0 HISTOGRAM DATA . . . . . . . . . . . . . . . . . . . . . . 4- 1

4.1 1 . . . . . . . . . . . . . . . . . . . . . . . . . 4-24.2 V F I . . . . . . . . . . . . . . . . . . . . . . . . . 4-94.3 V F2 . . . . . . . .. . . . . . . . . . . . . . . . . 4-164.4 V F3 . . . . . . . . . . . . . . . . . . . . . . . . . 4-234 . 5 Co I . . . . . . . . . . . . 4-30

. . . . . . . . . . . . 4-344. 6 C ot4. 7 t . . . . . . . . . . . . . . . . . . . . . . . . . 4-38

r ;,

r

I ^

1__

I ^l 'T

CONTENTS (CONTINUED)

5.0 NUMERICAL DATA T A 250C

(!look 2 EC 43 & EC 02 MSFC only) . . . . . 5-1

6.0 NUM-RI CAL DATA T A = +150oC

(Book 2 EC 43 & EC 02 MSFC only) . . . . . 6-1

7.0 NUMERICAL DATA T A w -650C

(Book 2 EC 43 & EC 02 MSFC only) . . . . . 7-1

A

iv

II `1 I

LIS'r OF ILLUSTRATIONS

FIGURE

2-1 Internal Construction Seintech . . . •

2-2 Internal Construction Semtech . . . .

2-3 Internal Construction Micro Semiconduc

11

t

7'

I

1.0 INTRODUCTION

1

The objective of this characterization program is to

pravidv the neces.,ary data to create a new class of

19500 detail specification~ "JAN A CLASS".

1.1 SAMPLE SELECTION

Sample selection was made according to the following

criteria:

1. Manufacturer or qualified distributor.

2. Two vendors.

3. Two date codes.

1.2 PROCUREMENT GUIDELINES

The general guidelines for procurement ware:

1. Two QPL vendors

2. JAN or JANTX

3. Two (2) manufacturing lots (Date Codes), Lwenty-

seven (27) from each lot.

fl

................_.^ ! —i _

1-1

2.0 TECHNICAL SUMMARY

The devices used in this report were JANTX 1N5619 Silicon

Diodes manufactured by Micro Semiconductor and Se-ntech.

All data was acquired with three (3) digit accuracy. The

data processing and calculation of statistical p a•ieters

was performed by the Te t trunix S-3260 computer system using

four (4) digit display.

I'

2.1 TEST PARAMETERS AND CONDITIONS

2.1.1 1Rv =

(Max. Rated V R ) - 600V T A - 250C & 1500C

2.1.2Vri

I F - (10% of Rated I F ) - 300mA T A - 250C & -650C

2.1.3 V F2 I F= (50% of Rated I l.) = 1.5mA T A - 250C & -650C

2.1.4 V w3 I F- (100 of Rated I F ) - 3.0mA T A - 250C & -650C

2.1.5 C olV - OV F = 100KIlZ T A = 250C

2.1.6 C ot V = OV F = 1MHZ TA = 250C

2.1.7 t rr 7'A =25oC

2-2

ORIGINAL PAGE AOF POOR QUAUTV

2 UNIT DEFINITIONS

NAME SYM40L MULTIPLIER

Kilo

M1111MicroNanoPico

K

MUN1'

1033

?0_6

10-g10_ 1210

EIxample using a statistical summary section:

.r.-

] H 1 N AMPS Al 15 DKGHE KSAl VN=2.64 VUh•rs

-- - -- --- -- - -

rAllI'll/ 7603: %.5 I q P ' I1 ^1 ^1) 2.01 01.1 2.W4QfA j. )HOhi^al^lr.t/ /ti5u: ?.47{r., ' 1l 9t1 2.01014 i.11 2.I80M

:SIhM/ 750 l..`>47M 42b.50 I.H[UM h()M

Milli Micro

Example using a histogram:

JR6 a

1.13M 1.61M 2.89M 2.37M 3. am 3.3319

1.37M 1.855 2.3311 2.81M 3.29M J.77OUT 0 \

+-M8 OIID

Milli

4

' a

I`•r

ii

A^^►

FIGURE 1Device Number: IN5619 'Typical Overall Cross-27 Diameters Sectional ViewD/C 7631 MFR: Semtech SIN EO27681

FIGURE 2 - -.- ---- -^--Device Number: IN5619 Typical Overall Cross-27 Diameters Sectional ViewD/C 7531 MFR: Semtech SIN EO27708

2-3

I

10Y.

r

FIGURP 3 —Device Number: IN5619

Typical Overall Cross-2'I Diameters Sectional ViewD/C 7633 MFR: MSC SIN E027736

w n

2 -

1

3.0 STATISTICAL SUMMARY

The Ste`.lstical Summary, pages 3-2 to 3-4, are a

consolidated presentation of the data acquired for-

matted for easy Vendor to Vendor and date code to

date code analysis. Each parameter is presented with

Test Conditions, Mean, Standard Deviation. Lowest

Reading, 107. Point (where 10% of all readings are

equal to or less than the indicated reading), 90%

Point (where 90% of all readings are equal to or less

than indicated reading) and the 11igliest heading.

It should he noted the Mean p r esented in the surnmary

may vary slightly from that presented on the histograms

due to a slight variation in the data base used for

calculation.

EXAMPLE:

Semtech:I VR = 600V '1.A - 250C

Summary: ?LEAN 65.43nA

Histogram: MEAN 65.59nA

3-1rti

1

1)C'A I • rLI A ►, I I 1 11 LAk(11•AIUt+i

t , PAk I Nl; VvN N: I N%t) 1 4

VF.ti0t11• IMIC'hl l sl MICIIr.II

VF' N IrUF :.tit. M I F CH

OQIGMAL PAGE IS

OF POUR QUALI VY

UA l t CoUt : 7o! 3

I ► A'10: CoOk : 7h 31

VF NDI + : St ht 'l t.CH IIA I K CI I I ► F: 75 31

•-----•----------------------------- ----- ---

-------- --- — ----------------------

:VoND / 1'C : +'t.A ^1 : til'i,. [ . I.V.: Loo, P1' 11 ► 'k I'f v(A I'f HIGH PT.

1H 114 A'APS A f i5 I)F (;NF F 5A I v w z"o1) yk11' 1 ti

yyI----------:___-_--_--:-- _--_-_-- :---.-_-----:---------- ----------.

:l+s 1 / /w7 3 i s 345. 11v t I .o4ult ; vn.00N ; 1 I 1 .4N 2 it) N ; J00.0ll:St M i 5. it i t, 1 4% 2r1.Hofq L9.4t)N 4h.UON 15h.ON:5F u 1'/ 1531: ^.y41. ti'1.o1N /+.NON 714.1W4 129. 0I, 219o0N1 1 1 1 1

fi

AI 15 1 ) 14t;NE:P.SA 1 U V OL

--------- ------- - -- -------------------------r r-r_r__.-_ _ ---------------------

4 :1A ;;1 / !rli: 7i5.`► 11 : li.iltl : 4tl 19.oU ; 1; ►,,0Uh: 30. 1 ut1 : 51.4UII : 1 30.0ll 1 v ► ,.01)

7tij1: 17n. 111 ti.,,l^;l 12 ►+.11[I 1 z l. 2n9.0U ' 151.UII,^1

0 1 1 N VM.,1 S A f l5 I)F G.wF H'S1 A I I M= 00 ;•1A

•-----------------------------------------------------------------•------------1 ^ 1 1 1 1

:M IS 1 it• 33: 9S14. 4M lti.tilr.^ n4y.1)ti1 al'1.1)"^ : 9 '/.O ti1 : 1.0'!Uf ;1"p NI T / 1t)31: H/l.r ..4: v.ti5 y '' ; 1^)d.1 ► at MU4. ; 811 0 OM H3ti.UMI :S, .MI/ 1531: t4lh.0A : 12.51 N 0 4 . 0 M : HU6.l A42.Ur-i H54.Or.

1 1 1 1

3

" 3-2t

^M

I ► 1.^,A I-f LIA1411.11 t I.AmWATOm i

I R AN I NUMrt,k t 1 N5P) 1 ` ►

•----------------------------------- ----------------------------- ------------

VFtit) / l)C A 1 S11), O) V.! I ' M% 1'1 101 N'! : 40* N'l : HIGH PT.

Uh 1 I N 401, 1 S A I' -nti U1• .Gkh:t 5AT lf'=30U hA

------ ------------------ --- - ------ —

: ? 'S1 / 7t+3,i: 1.' ! 54 30.'11'd : +40. 0M : 944, ()M ! 1 .ONO : I .1311;5t' M1'/ 1631: 4un.tm : 1 3.74"A l '411. 1) IV, 911.Uhi 1 .1130 !

: SF M1 / 1' 31 : 9n i . H'+ : 11 .56ro 4•a 2. 0061 : 4h.OM : 4 14.0M : 1 .0`)0

VF2 1', v i ll,l'S A'1 ^'5 I r.,.kt. t SAI 1hs1.5 V.j)S

•------------ ----------------------------------------------------------------

;raSl 7633: I.if)" 53.I /tiff : 1.I1 u : 1.130 : 1 o y: 1.351)

7x,31: I.UiI l`+.11^ `+ 63.22~1 97Z. )^^ : 1.ObU : ► .0r>U

:sE'Mr/ 7511: 1. 0 51 50153M '3,061 9HH.OM I .100 : 1.14u

of ! 114 Vi11"I"S A I' -b5 1+(;PKr.:SAT I -1 .ti AN, NS

•_--_---------------- -----------------------------.--------------------

:P1tiI / )b3): 1.101 : `^ L.. H bM : I.I l.i : 1.LV0 ! 1.340 : 1.430

::iE. K I/ 7 06 31: 1.119 47,07N 1 I1ti 1.110 1.210 1.4hr)

:5 ► H1 / 1531: 1 . 14 1 ) ! 51,.4> •: : 1 . 1 1 11 : 1 . 1 20 : 1 .1e0 : 1 . 340

Vh'3 1N V 'TS A 217) P .G8EESIt 11'= s.^) 4ti'F'S

•----------- --------•------------------------------------ --- -----------------

:

Nis I / 7t,3.3 1.130 ! 1 .260 : 1 . , 30 ! 1 .540

: Sl M I / 7x; 1 1 ! I . I H9 ! 30. 00 14 ! 1 . 1 00 ! 1 . 1 10 ! 1 .220 ! I . L 30

: St.M1 / 75 31 : 1 . L24 ! 75.++ y N ! 1 . I'! ► ) : 1 . 140 ! 1 . 300 ! 1 .470

3-4

I

i

UCA ktL1AN It, I11 LAH(lkA'ftwY

1 1 41, 1 NUMI , t 1-: I N )h 14

•-----------7-----------------------•-----------------------------------------

: Vt.NI.) / 1)C : Mt.Ato S I U. oh V .: LrI;N P'I PA I I I 4u* P'I : H 1 GH P I .1 1

VI' 3 IN VUI• I s At - h5 ►► F GPEKSAI IF=3.O A - PS

-------------------------------------------------•-----------------------------

;M51 / 7h33! 1.414 : h`).51)'• : 1.1`!U : 1.34U : 1 .Su : 1 .5 ►su:S1' .► r/ It) 31 : I. 3',u ! 5h. ^^M ! 1.250 : 1 1 .400 ! 1.`30'Si,: ^1 I'/ 15 11: 1.3 1 11 : `37 .5 1'^ : 1 .1 i^, ! 1 . )w1 ► 1 1 • . 4t)11 ' 1 . h^^I

1 1 1 1 1

CI,1 FA14AI)s AI l5 I ► F.G41-ksA[ 100 KH7, ANU VL=U V(IL1.S

! M.Sl i -1b.13: -1.554N 4 11 31) n. 1 ouN h.40op 13.4011 1 H.4UH!SkM1/ 7631i bo Iv ! 1) om11• ih .v1h N : 5 5 . " h p : h S. Hop `).0'qI)

:SEMI/ / )31 : h1 . 111' : e S49P : 58.I4N ! )A.IVI' : hS.13F' : h1.4U1)

1 1

C(!7 .•ANA(1.S A I 215 hlF ):)'F F S

•---------------•--------------------------------------------------------- ------

!M^1 / 1o3s. b.`? ►)Ol' ! 1.)•)v^ ^.'If ► u1' : 1.40 ►11' : 1a.1)001' 11.5cIE':SE M1'/ 1t+31 ! 1, 414 t ) ! 1.' ►► )2V ! 5 y 1 . U 0 p ! h0.1 2(' ! ti1.34v',S^31 r/ l .il ! dim 00P ! ).14 441) ! ')4. 1 )1' ! 54. i)ir o .00P : ho.'48l'

1

I F p IN SFC.S AI eti 1)KGPKFS

•------------------------------------------------------------------------------

1 ! 7033! 1 1 1 . H N : 4.034N : 1 10.( ► N : I1 13S.ON : 14ti.0(1

M1'/ 7h 31! J03.h1'1 : 3).m0N .1 llti.^ ► N 1hU,))N : ltiu.UfJ 15(). ► )N

T/ 7531: 1ml. 44w ! 7/. 2N IV : 1')o.nw ! Ihu.ON : 210. or) : 71,.!11.,