Upload
abbe-cche-dhe
View
215
Download
1
Embed Size (px)
DESCRIPTION
hajj
Citation preview
Issue no 1, 02 Juni 2011
Authority, EMS Representative, B Dyer
EMS-P13, Page 1 of 7
ENVIRONMENTAL MANAGEMENT SYSTEM EMS – PROCEDURES
EMS-P13 Dated:
Replaces:
Greenhouse Gases Mitigation 02 June 2011
1. Introduction.
Greenhouse Gases Mitigation is the process of
attempting various preventive measures to
minimize/reduce greenhouse gases emissions
caused by the activities of business. While
energy efficiency is one way to keep improving
productivity and minimizing the use of energy
especially un renewable energy, and substitute
with renewable energy. This is an effort in
reducing greenhouse gases emissions.
Greenhouse gases are gases that exist in the
atmosphere that cause the greenhouse effect.
These gases actually appear naturally in the
environment, but can also arise due to human
activities.
Greenhouse gases that most of the water vapor
that reaches the atmosphere due to
evaporation of water from the sea, lakes and
rivers. Carbon dioxide is the second largest
gas. He arose from natural processes such as
volcanic eruptions, breathing animals and
humans (who inhale oxygen and exhale carbon
dioxide), and combustion of organic material
(such as plants).
2. Types of Greenhouse Gases.
The gases cause the greenhouse effect is
Carbon Dioxide (CO2), methane (CH4), Nitrous
Oxide (N2O), hydro fluorocarbons (HFCs), Per
fluorocarbons (PFCs), Sulfur Hexafluoride (SF6).
Measurement of greenhouse gas levels
presented in the following table:
1 Pendahuluan.
Mitigasi Gas Rumah Kaca adalah proses
mengupayakan berbagai tindakan preventif untuk
meminimalisir/mereduksi emisi gas rumah kaca
yang ditimbulkan akibat dari kegiatan usaha.
Sedangkan effisiensi energi merupakan salah
satu upaya untuk tetap meningkatkan
produktivitas dan meminimalisasi penggunaan
energi terutama energy tak terbaharukan dengan
mensubtitusikan dengan energi terbaharukan.
Upaya ini merupakan salah satu upaya dalam
penurunan emisi gas rumah kaca.
Gas Rumah Kaca adalah gas-gas yang ada di
atmosfer yang menyebabkan efek rumah kaca.
Gas-gas tersebut sebenarnya muncul secara
alami di lingkungan, tetapi dapat juga timbul
akibat aktivitas manusia.
Gas rumah kaca yang paling banyak adalah uap
air yang mencapai atmosfer akibat penguapan air
dari laut, danau dan sungai. Karbondioksida
adalah gas terbanyak kedua. Ia timbul dari
berbagai proses alami seperti: letusan vulkanik;
pernapasan hewan dan manusia (yang
menghirup oksigen dan menghembuskan
karbondioksida); dan pembakaran material
organik (seperti tumbuhan).
2 Jenis Jenis Gas Rumah Kaca
Gas yang menimbulkan efek rumah kaca adalah
Carbon Dioksida (CO2), Methane (CH4), Nitrous
Oxide (N2O), Hydro fluorocarbons (HFC),
Perfluorocarbons (PFC), Sulfur Hexafluoride (SF6).
Pengukuran tingkat gas rumah kaca tersaji dalam
tabel berikut :
Table 1. The content of Green House Gases
Gases Recommended GWP (UNFCC,
2002), Applicable through 2012
IPCC Revised GWP (IPCC’s
third assessment report, 2001),
likely to be applicable after 2012
Carbon Dioxide (CO2) 1 1
Methane (CH4) 21 23
Nitrous Oxide (N20) 310 296
Hydro fluorocarbons (HFC) 140 – 11.900 120 – 12.000
Per Fluorocarbons (PFC) 6.500 – 9.200 5.700 – 11.900
Sulfur Hexafluoride (SF6) 23.900 22.200
Issue no 1, 02 Juni 2011
Authority, EMS Representative, B Dyer
EMS-P13, Page 2 of 7
3. The cause of Greenhouse Gases
The greenhouse effect caused by rising
concentrations of carbon dioxide (CO2) and
other gases in the atmosphere. The increase in
CO2 concentration is caused by several things:
a. The burning of fuel oil, coal and other
organic fuels which exceed the ability of
plants and sea to absorb them.
b. Changes in land cover
c. Opening area of peat
d. The use of Freon or materials that emit
greenhouse gases
e. Energy Generation
Energy into the Earth:
a. 25% reflected by clouds or other particles
in the atmosphere
b. 25% absorbed by clouds
c. 45% absorbed by the earth's surface
d. 5% reflected back by the earth's surface
The absorbed energy reflected back in the form
of infrared radiation by the clouds and the
earth's surface. But most of the infrared emitted
by the clouds and the earth retained CO2 and
other gases, to be returned to the earth's
surface. Under normal circumstances, the
greenhouse effect is required; with the
greenhouse effect temperature difference
between day and night on earths is not too
much different.
3 Penyebab Gas Rumah Kaca
Efek rumah kaca disebabkan karena naiknya
konsentrasi gas karbon dioksida (CO2) dan gas-
gas lainnya di atmosfer. Kenaikan konsentrasi gas
CO2 ini disebabkan oleh beberapa hal yaitu :
a. Pembakaran bahan bakar minyak, batu bara
dan bahan bakar organik lainnya yang
melampaui kemampuan tumbuhan-
tumbuhan dan laut untuk menyerapnya.
b. Perubahan tutupan lahan
c. Pembukaan areal gambut
d. Penggunaan material yang mengeluarkan
Freon atau GRK.
e. Pembangkit Energi
Energi yang masuk ke Bumi:
a. 25% dipantulkan oleh awan atau partikel lain
di atmosfer
b. 25% diserap awan
c. 45% diserap permukaan bumi
d. 5% dipantulkan kembali oleh permukaan
bumi
Energi yang diserap dipantulkan kembali dalam
bentuk radiasi inframerah oleh awan dan
permukaan bumi. Namun sebagian besar
inframerah yang dipancarkan bumi tertahan oleh
awan dan gas CO2 dan gas lainnya, untuk
dikembalikan ke permukaan bumi. Dalam
keadaan normal, efek rumah kaca diperlukan,
dengan adanya efek rumah kaca perbedaan suhu
antara siang dan malam di bumi tidak terlalu jauh
berbeda.
Picture 1. Illustration of greenhouse gases
Issue no 1, 02 Juni 2011
Authority, EMS Representative, B Dyer
EMS-P13, Page 3 of 7
4. The impact of Greenhouse Gases
Increasing the temperature of the earth's
surface will result in a very extreme climate
changes on earth. This can lead to disruption of
forests and other ecosystems, thereby reducing
its ability to absorb carbon dioxide in the
atmosphere. Global warming caused the
melting of icebergs in the polar regions that
could lead to rising sea levels. The greenhouse
effect will also lead to rising sea temperatures
that occur sea water expands and sea level rise
which resulted in the island nation will get a very
big influence.
According to the simulation calculation, the
greenhouse effect has increased the Earth's
average temperature 1-5 °C. If the trend of
increased greenhouse gases remain as it is
now global warming will cause an increase
between 1.5 up 4.5 °C around the year 2030.
With increasing concentration of CO2 in the
atmosphere, the more heat waves reflected
from the surface of the earth's atmosphere is
absorbed. This will cause the earth's surface
temperature to rise.
5. Efforts of Greenhouse gases mitigation.
Greenhouse gas mitigation is required to
maintain the natural balance and prevent or
reduce global warming. Mitigation efforts can
be made as follows:
a. Preventive actions
b. Corrective actions
Preventive actions
In an effort to prevent greenhouse gas
emissions can be done:
1. Compliance with the applicable legislation:
a. Not open Peat soil area with a depth of
more than 3 meters and as required by
Regulation of Agricultural of Ministry No
14 of 2009
b. Not open area that has been
designated as protected areas local
(Riparian Strip, spring catchment areas
and other protected areas). Details can
be viewed in the EMS Procedure P15-
P17 of High Conservation Value.
c. Land clearing on new planting or
replanting without fuel (Zero Burning) is
replaced with windrowing system.
Further information can be viewed on
Palm Oil SOP OP 2.8 about land
preparation.
d. Not using banned pesticides for the
operations.
4. Akibat Gas Rumah Kaca
Meningkatnya suhu permukaan bumi akan
mengakibatkan adanya perubahan iklim yang
sangat ekstrem di bumi. Hal ini dapat
mengakibatkan terganggunya hutan dan
ekosistem lainnya, sehingga mengurangi
kemampuannya untuk menyerap karbon dioksida
di atmosfer. Pemanasan global mengakibatkan
mencairnya gunung-gunung es di daerah kutub
yang dapat menimbulkan naiknya permukaan air
laut. Efek rumah kaca juga akan mengakibatkan
meningkatnya suhu air laut sehingga air laut
mengembang dan terjadi kenaikan permukaan
laut yang mengakibatkan negara kepulauan akan
mendapatkan pengaruh yang sangat besar.
Menurut perhitungan simulasi, efek rumah kaca
telah meningkatkan suhu rata-rata bumi 1-5 °C.
Bila kecenderungan peningkatan gas rumah kaca
tetap seperti sekarang akan menyebabkan
peningkatan pemanasan global antara 1,5-4,5 °C
sekitar tahun 2030. Dengan meningkatnya
konsentrasi gas CO2 di atmosfer, maka akan
semakin banyak gelombang panas yang
dipantulkan dari permukaan bumi diserap
atmosfer. Hal ini akan mengakibatkan suhu
permukaan bumi menjadi meningkat.
5. Upaya mitigasi gas rumah kaca
Mitigasi gas rumah kaca diperlukan untuk
menjaga keseimbangan alam dan mencegah atau
mengurangi pemanasan global. Upaya mitigasi
dapat dilakukan sebagai berikut :
a. Tindakan pencegahan
b. Tindakan perbaikan
Tindakan Pencegahan
Dalam upaya pencegahan emisi gas rumah kaca
dapat dilakukan :
1. Pentaatan Peraturan perundangan yang
berlaku :
a. TIdak membuka areal gambut dengan
kedalaman lebih dari 3 meter dan yang
disyaratkan oleh Permentan No 14 tahun
2009
b. Tidak membuka areal yang telah
ditetapkan sebagai kawasan lindung
setempat (sempadan sungai, daerah
resapan mata air serta kawasan lindung
lainnya). keterangan lengkap dapat di
lihat pada EMS Prosedur P15-P17
tentang Nilai Konservasi Tinggi.
c. Melakukan pembukaan lahan atau
peremajaan tanpa bakar (Zero Burning)
digantikan dengan system windrowing.
Keterangan lebih lanjut dapat di lihat
pada SOP Oil Palm OP 2.8 tentang
persiapan lahan.
d. Tidak menggunakan pestisida yang
dilarang untuk operasional.
Issue no 1, 02 Juni 2011
Authority, EMS Representative, B Dyer
EMS-P13, Page 4 of 7
2. Intensification (increase productivity of oil
palm. superior oil palm seedlings are
expected to lower emissions, high
productivity, resistance to pests and
diseases and does not require large areas)
3. Planting cover crops to restore the
absorption of carbon and accelerate the
decomposition of the palm / rubber /
cocoa that has been windrowing. Further
details can be found in SOP OP 2.9
Legumes Establishment.
4. Reduce or minimize use of pesticides,
insecticides, synthetic herbicides. The
reduction can be done by:
a. Performing an early warning system to
control pests and diseases (detection,
census, and examination).
b. Carrying out a system of integrated
pest management (use of natural
enemies, the used of beneficial weeds,
use of biological insecticides (fungi,
viruses or bacteria).
Further details can be found in SOP OP
5.1-5.2 on the weeds management, pests
and diseases.
5. The installation of Boiler / air heater fueled
biomass to replace fossil fuels.
6. Perform waste treatment plant by
minimizing emissions. This can be done by
using activated sludge system, the system
equipped with Land Application with
digester at the Methane pool, or a
composting system.
7. Performing an inventory of the carbon
footprint in operational areas with the
cooperation of the expert team (internal or
external)
Corrective Action
Improvement measures implemented on the
estate or factory that has been operating to
reduce greenhouse gas emissions that is
issued. Such measures can be implemented as
follows:
1. Use the environmentally friendly material
(marked with a green label on the
packaging of products) such as air
conditioning, freezer, etc.
2. Make efforts the efficiency of energy usage
with to change energy saving lamps.
Turning off the lamps or lighting when not
2. Melakukan intensifikasi (meningkatkan
produktivitas kelapa sawit. Bibit kelapa sawit
yang unggul diharapkan dapat lebih rendah
mengeluarkan emisi, produktivitas tinggi,
tahan hama dan tidak membutuhkan areal
yang luas)
3. Melakukan penanaman tanaman penutup
tanah untuk mengembalikan penyerapan
karbon dan mempercepat dekomposisi
batang sawit/karet/coklat yang telah
dirumpuk. Keterangan lebih lanjut dapat
dilihat pada SOP OP 2.9 Legume
Establishment
4. Mengurangi atau meminimalisasi penggunan
pestisida, insektisida, herbisida sintetis.
Pengurangan tersebut dapat dilakukan
dengan :
a. Melakukan sistem peringatan dini
terhadap hama dan penyakit (Deteksi,
sensus, dan eksaminasi).
b. Melakukan system pengendalian hama
terpadu (memanfaatkan musuh alami,
memanfaatkan gulma yang
menguntungkan, penggunaan insektisida
biologis (cendawan, virus atau bakteri).
Keterangan lebih lanjut dapat dilihat pada
SOP OP 5.1-5.2 tentang pengelolaan gulma,
hama dan penyakit.
5. Melakukan instalasi Boiler / Air heater
berbahan bakar biomassa untuk
menggantikan bahan bakar fosil.
6. Melakukan instalasi pengolahan limbah
dengan meminimalisasi emisi yang
dikeluarkan. Hal ini dapat dilakukan dengan
menggunakan system lumpur aktif, system
Land Aplikasi dengan dilengkapi digester
pada kolam metanasi, atau system
composting.
7. Melakukan inventarisasi jejak karbon di
wilayah operasional dengan kerjasama
dengan team ahli (internal ataupun external)
Tindakan Perbaikan
Langkah perbaikan dilaksanakan pada kebun
atau pabrik yang telah beroperasi untuk
menurunkan emisi gas rumah kaca yang di
keluarkan. Tindakan tersebut dapat dilaksanakan
sebagai berikut :
1. Menggunakan material yang ramah
lingkungan (ditandai dengan label ramah
lingkungan pada kemasan produk) seperti
AC, Freezer, dll.
2. Melakukan upaya penghematan energy
dengan menganti lampu dengan lampu
hemat energy. Mematikan lampu atau
Issue no 1, 02 Juni 2011
Authority, EMS Representative, B Dyer
EMS-P13, Page 5 of 7
required (or equipped with automatic
sensors).
3. Minimize emissions of methane gas in
sewage pond system with the application
of biogas digester for wastewater
treatment system or change the system to
minimize methane gas emissions, such as
composting activity or aerobic wastewater
treatment system
4. Perform application of liquid waste (LA) and
solid waste (empty fruit bunches or
compost) to replace inorganic fertilizers
(synthetic) so as to reduce the level of
emissions generated.
5. Rehabilitation / enrichment of the riparian
strip and high conservation value areas
with a plant that is able to absorb more
carbon.
6. Optimizing the use of renewable resources
and minimize the use of un renewable
resources.
7. Perform the balancing of carbon emissions
by making carbon neutral.
8. Perform maintenance and repair of
emission sources in order to minimize the
emissions produced.
9. Perform greening factory area with
radiation and anti-pollution plants such as
plant species Sansevieria (Lidah Mertua).
6. Types of plants absorbing large amounts of
carbon
Rehabilitation / enrichment / greening should be
done to reduce emissions can also choose
plants that have a large role in carbon
sequestration and anti-radiation. Some types of
plants that have a high absorption is as follows:
a. Trembesi, Samanea saman, absorptive
28,488.39 kg of CO2 / year
b. Cassia, Cassia sp., absorptive
52,95.47 kg of CO2 / year
c. Boxwood, Canangium odoratum,
absorptive 756.59 kg of CO2 / year
d. Pingku, Dyxoxylum excelsum, absorptive 720.49 kg of CO2 / year
e. Banyan, Ficus benyamina, absorptive
535.90 kg of CO2 / year
f. Krey Payung, Fellicium decipiens,
absorptive 404.83 kg of CO2 / year
g. Matoa, Pometia pinnata, absorptive
329.76 kg of CO2 / year
h. Mahogany, Swettiana mahagoni,
penerangan jika tidak diperlukan (atau
dilengkapi dengan sensor automatis).
3. Meminimalisasi emisi gas methane pada
kolam limbah dengan penerapan system
digester untuk biogas atau merubah system
pengolahan limbah untuk meminimalisasi
emisi gas methane seperti kegiatan
pengomposan atau pengolahan limbah
system aerobic.
4. Melakukan aplikasi limbah cair (LA) dan
limbah padat (tandan kosong atau kompos)
untuk menggantikan pupuk anorganik
(sintetik) sehingga dapat mengurangi tingkat
emisi yang ditimbulkan.
5. Melakukan rehabilitasi/pengkayaan daerah
sempadan sungai dan areal yang
mempunyai nilai konservasi tinggi dengan
tanaman yang mampu menyerap banyak
karbon.
6. Mengoptimalkan penggunaan sumberdaya
yang dapat diperbaharui dan meminimalisasi
penggunaan sumber daya yang tidak dapat
diperbaharui.
7. Melakukan penyeimbangan emisi karbon
dengan menjadikan netral carbon.
8. Melakukan perawatan dan perbaikan
sumber emisi sehingga dapat
meminimalisasi emisi yang dihasilkan.
9. Melakukan penghijauan areal pabrik dengan
tanaman anti radiasi dan polusi seperti jenis
tanaman Sansevieria (Lidah Mertua)
6. Jenis jenis tanaman penyerap karbon dalam
jumlah besar.
Rehabilisasi / Pengkayaan / penghijauan yang
dilakukan untuk mengurangi emisi hendaknya
juga dapat dipilih tanaman yang mempunyai
peran besar dalam penyerapan karbon dan anti
radiasi. Beberapa jenis tanaman yang mempunyai
daya serap tinggi adalah sebagai berikut:
a. Trembesi, Samanea saman, daya serap
28.488,39 kg CO2/tahun
b. Cassia, Cassia sp., daya serap 5.295,47 kg
CO2 /tahun
c. Kenanga, Canangium odoratum, daya serap
756,59 kg CO2 /tahun
d. Pingku, Dyxoxylum excelsum, daya serap
720,49 kg CO2 /tahun
e. Beringin, Ficus benyamina, daya serap
535,90 kg CO2 /tahun
f. Krey payung, Fellicium decipiens, daya serap
404,83 kg CO2 /tahun
g. Matoa, Pometia pinnata, daya serap 329,76
kg CO2 /tahun
Issue no 1, 02 Juni 2011
Authority, EMS Representative, B Dyer
EMS-P13, Page 6 of 7
absorptive 295.73 kg of CO2 / year
i. Saga, Adenanthera pavoniana,
absorptive 221.18 kg of CO2 / year
j. Bungur, Lagerstroemia speciosa,
absorptive 160.14 kg of CO2 / year
k. Teak, Tectona grandis, absorptive
135.27 kg of CO2 / year
l. Jackfruit, Arthocarpus heterophyllus,
absorptive 126.51 kg of CO2 / year
m. Johar, Cassia grandis, absorptive
116.25 kg of CO2 / year
n. Soursop, Annona muricata, absorptive
75.29 kg of CO2 / year
o. Puspa, Schima wallichii, absorptive
63.31 kg of CO2 / year
p. Acacia, Acacia auriculiformis,
absorptive 48.68 kg of CO2 / year
q. Flamboyant, Delonix regia, absorptive
42.20 kg of CO2 / year
r. Sapodilla kecik, Maniilkara kauki,
absorptive 36.19 kg of CO2 / year
s. Tanjung, Mimusops elengi, absorptive
34.29 kg of CO2 / year
t. Peacock flower, Caesalpinia pulcherrima, absorptive 30.95 kg of
CO2 / year
u. Sempur, Dilenia retusa, absorptive
24.24 kg of CO2 / year
v. Khaya, Khaya anthotheca, absorptive
21.90 kg of CO2 / year
w. Merbau beach, Intsia bijuga, absorptive
19.25 kg of CO2 / year
In addition to several types of plants, there are
plants that have been designated as plant
antipolusi and anti-radiation is the plant
Sansevieria (Lidah Mertua Flower).
h. Mahoni, Swettiana mahagoni, daya serap
295,73 kg CO2 /tahun
i. Saga, Adenanthera pavoniana, daya serap
221,18 kg CO2 /tahun
j. Bungur, Lagerstroemia speciosa, daya serap
160,14 kg CO2 /tahun
k. Jati, Tectona grandis, daya serap 135,27 kg
CO2 /tahun
l. Nangka, Arthocarpus heterophyllus, daya
serap 126,51 kg CO2 /tahun
m. Johar, Cassia grandis, daya serap 116,25 kg
CO2 /tahun
n. Sirsak, Annona muricata, daya serap 75,29
kg CO2 /tahun
o. Puspa, Schima wallichii, daya serap 63,31
kg CO2 /tahun
p. Akasia, Acacia auriculiformis, daya serap
48,68 kg CO2 /tahun
q. Flamboyan, Delonix regia, daya serap 42,20
kg CO2 /tahun
r. Sawo kecik, Maniilkara kauki, daya serap
36,19 kg CO2 /tahun
s. Tanjung, Mimusops elengi, daya serap 34,29
kg CO2 /tahun
t. Bunga merak, Caesalpinia pulcherrima, daya
serap 30,95 kg CO2 /tahun
u. Sempur, Dilenia retusa, daya serap 24,24 kg
CO2 /tahun
v. Khaya, Khaya anthotheca, daya serap 21,90
kg CO2 /tahun
w. Merbau pantai, Intsia bijuga, daya serap
19,25 kg CO2 /tahun
Selain beberapa jenis tanaman tersebut, terdapat
jenis tanaman yang telah ditetapkan sebagai
tanaman antipolusi dan anti radiasi yaitu tanaman
Sansevieria (Bunga Lidah Mertua).
Sansevieria (Lidah Mertua) Samanea saman (Trembesi)
- Responsibility
The Area Manager of Agronomy / Processing /
Head of Department / Mill / Estate Manager
- Ensure that mitigation of GHG emissions
running well and recorded.
- Maintaining records in the related
department.
7. Tanggung Jawab
Para Area Manager Agronomy/Processing/Head
of Department/ Mill/Estate Manager
Memastikan bahwa mitigasi Gas Rumah kaca
berjalan dan direkam.
Memelihara rekaman di departemen terkait.
Issue no 1, 02 Juni 2011
Authority, EMS Representative, B Dyer
EMS-P13, Page 7 of 7
Head of Environment and Corporate Social
Responsibility Coordination
- Carry out checks to ensure that GHG
mitigation activities have been implemented,
reviewed and recorded.
Supervisors
- Perform record and report the results of
greenhouse gas mitigation recordings.
8. References
- ISO14001 : 2004, ISO14001 : 2004,
requirement 4.4.6: Operational Control
- Environment Manual, section 4.4.6:
Operasional Control
- Sardi Duryatmo. “Para Jagoan Serap
Karbondioksida”; Trubus 459, February 2008
- id.wikipedia.org
Head of Environment and Corporate Social
Responsibility Coordination
Melaksanakan pemeriksaan untuk memastikan
kegiatan mitigasi gas rumah telah
dilaksanakan, dikaji dan direkam.
Supervisors
Melaksanakan, merekam dan melaporkan
hasil rekaman mitigasi gas rumah kaca.
8. Referensi
- ISO14001 : 2004, Persyaratan 4.4.6:
Pengendalian Operasional
- Environment Manual, section 4.4.6: Kontrol
Operasional
- Sardi Duryatmo. “Para Jagoan Serap
Karbondioksida”; Trubus 459, Februari 2008
- id.wikipedia.org