G D L B Y IT N U M O C - Indiana University Bloomingtonsustain/programs/green-building... · the heat pump controls shall also monitor the room lighting level and shall switch stages

1/8"=1’-0"

TAB RJT

SCHEDULES

MECHANICAL

M5-10D

TAG:

P-1 P-2

CAPACITY

GPM

MFR:

BELL & GOSSETT BELL & GOSSETT

AREA SERVED

WSHP LOOP WSHP LOOP

TOTAL

DYNAMIC

HEAD, FT

80 80

VOLTAGE

208-230/60/3 208-230/60/3

HP

INLET /

OUTLET

SIZE, IN.

HYDRONIC PUMP SCHEDULE

3"

3"

TAG

LOCATION

MFR & MODEL

AIR FLOW

CFM

STATIC

PRESSURE

IN, W.G.

ELECTRICAL

SIZE,

HP

NOTES:

AIR DEVICE SCHEDULE

TAG MANUF MODEL TYPE FINISH NOTES

WHITE BAKED ENAM

HE2XINV

S-1 TITUS

WHITE BAKED ENAMS-2 TITUS

WHITE BAKED ENAMR-1 TITUS

--

MECHANICAL ROOM 1500

0.50 1,2, 3,

R-2 TITUS WHITE BAKED ENAM

E-1 TITUS WHITE BAKED ENAM

SIDE WALL SUPPLY DIFFUSER

CEILING SUPPLY DIFFUSER

CEILING RETURN GRILLE

RUSKIN

--

TMS

EXHAUST CEILING GRILLE

EXTERIOR WALL INTAKE LOUVERL-1

--

--

--

FLOOR MOUNTPRIMARY PUMP

ENERGY RECOVERY UNIT SCHEDULE

ERU-1 RENEWAIR

MODEL

208-60-3PH (2) 2 HP

WEIGHT

420 LB

ENERGY RECOVERY UNIT SCHEDULE NOTES:

FLOOR MOUNTSECONDARY PUMP

TAG

LOCATION

MFR & MODEL

AIR FLOW

CFM

STATIC

PRESSURE

IN, W.G.

ELECTRICAL

SIZE,

NOTES:

200

MODEL

120-60-1PH

WEIGHT

EXHAUST FAN SCHEDULE

EF-1 COOK 1

WATER SOURCE HEAT PUMP SCHEDULE

MFR. DESCRIPTIONTAGVOLTAGE

REMARKS AMPS

FULL LOAD

BTU/HR

COOLING

BTU/HR

HEATING

FT. HD.

WPD

CFM

AIRFLOW

--

208/60/1 208/60/1

WSHP-1

WSHP-2

--

208/60/1 208/60/1

WSHP-3

WSHP-4

WATER FURNACE

GPM

FLOW

WATER FURNACE

WATER FURNACE

WATER FURNACE

--208/60/1WSHP-5 WATER FURNACE

--

MODEL

--

208/60/1 208/60/1

WSHP-6

WSHP-7

--

208/60/1 208/60/1

WSHP-8

WSHP-9

35,800

WATER FURNACE

WATER FURNACE

WATER FURNACE

WATER FURNACE

--208/60/1WATER FURNACE

--

--

208/60/1 208/60/1

WATER FURNACE

WATER FURNACE

WSHP-10

WSHP-11

WSHP-12

12,100

35,800

35,800

9,600

14,400

14,400

12,100

3.0

5.0600

600

350

350

VXH-024

VXH-036

VXH-0018

VXH-0018

VXH-012

VXH-012

VXH-036

VXH-036

VXH-036

VXH-012

VXH-012

VXH-012

12,100

12,100

12,100 9,600350

9,600

9,600

9,600

3.0

3.0

3.0

3.0

350

350

6.0 25,100 16,800800

1150 9.0 24,300

35,800

24,300

24,300

24,300

18,800

18,800

5.0

1150

1150

9.0

9.0

9.01150

15.0

10.0

20.0

30.0

30.0

30.0

30.0

10.0

10.0

10.0

15.0

10.0

----8350TOTAL 266,400 190,800

GC-340 0.250 135

HP/ WATTS

25 LB.

200 120-60-1PHEF-2 COOK 1GC-340 0.250 135 25 LB.

MEN’S TOILET ROOM # 195

WOMEN’S TOILET ROOM # 196

REMARKS

67

82 (67+15)

82 (67+15)

*

*

5.0

5.0

MODEL

1510 SERIES

1510 SERIES

NOTES:

3.9

3.5

2.8

2.8

3.9

3.9

3.9

3.9

3.9

3.9

3.9

3.9

300FL

355FL

50F

350ZFL

HORIZONTAL HEAT PUMP












HEAT (KW)

ELECTRIC

AUXILIARY

10.0

10.0

5.0

ELF-6375DX

L-2 ROOF EXHAUST CAP 2 SQ. FT FREE AREA WITH ROOF CURB

PROVIDE FOUR EXTRA MERV-8, 2" PLATED FILTER3.

PRE WIRED FOR VFD DRIVE, UNIT TO BE SUPPLIED WITH VFD WIRED BY ELECTRICAL CONTRACTOR.2.

UNIT TO BE SUPPLIED WITH DISCONNECT SWITCH WIRED BY EC.1.

WALL RETURN GRILLE

COLOR TO MATCH ROOF

COLOR TO MATCH EXTERIOR WITH BIRD SCREEN.

AIR DEVICE NOTES:

ï»¿WATER PRESSURE DROP BASED ON 50î�� F EWT.C.

PROVIDE AUTO FLOW CONTROL VALVE AT EACH HEAT PUMP.B.

ï»¿ALL WATER TO AIR WATER SOURCE HEAT PUMP TO BE EXTENDED RANGE 25î�� F EWT UP TO 110î��F EWTA.

WATER SOURCE HEAT PUMP NOTES:

W/ AUX. HEAT

W/ AUX. HEAT

W/ AUX. HEAT

PENN BARRY AEGR- 22x35

SEQUENCE OF OPERATION

EXHAUST FAN SCHEDULE NOTES:

ALL SUPPLY GRILLES TO HAVE VOLUME DAMPER IN NECK.3.

MAKE ALL NECESSARY TRANSITION FROM GRILLE NECK TO BRANCH DUCT.2.

ALL REFER TO DRAWINGS FOR DEVICE SIZE, QUANTITY AND AIR FLOW CFM.1.

200 120-60-1PHEF-3 COOK 2GC-340 0.250 135 25 LB.IT ROOM 197

ï»¿FAN TO BE CONTROLLED BY REVERSE ACTING T-STAT, SET AT 75î��F.2.

DISCONNECT SWITCH BY EC.1.

GP-1

AND SUCTION DIFFUSER MODEL NO. "BD-3".

PUMP SUPPLIED WITH BELL AND GOSSETT CIRCUIT SETTER MODEL NO."CB-3F"3.

PUMP SIZED BASED ON 15% PROPYLENE GLYCOL.2.

ESTIMATED 15 GPM FOR FUTURE ADDITION.*

PRESSURE CONTROL. 77 WATTS MOTOR, 60 HZ

FULLY AUTOMATED AND AUTONOMOUS, COMPLETE WITH 110V. PRESSURIZATION PUMP WITH INTEGRAL

GLYMATIC GLYCOL MAKE-UP PUMP PACKAGE MODEL G-15 BY WESSELS COMPANY, 15 GALLON "G" SERIES. HEAT PUMPS IN THE COMMON AREAS AND PUBLIC SPACES SHALL BE CONTROLLED THRU THE DDC SYSTEM VIA ZONE

THERMOSTATS AND SENSORS:

TEMPERATURE (THERMOSTAT INTEGRAL TO CABINET HEATER).

THE ELECTRIC CABINET HEATER FAN SHALL CYCLE AND THE HEATING CIRCUIT SHALL BE ENERGIZED TO MAINTAIN SETPOINT

ELECTRIC CABINET HEATERS:

SYSTEM.

PROVIDE INTERFACE TO WATER HEATER CONTROLLERS FOR MONITORING OF TROUBLE MODE AND ALARMING THROUGH DDC.

POINT SOURCE WATER HEATERS:

RATE AND TEMPERATURES SHALL BE PROVIDED.

FAN AND EXHAUST FAN STATUS AND SUPPLY AND EXHAUST FILTER DIFFERENTIAL PRESSURE. ENERGY TRACKING VIA AIR FLOW

AIR FLOW IS EQUAL TO FRESH (SUPPLY) AIR FLOW. THE DDC SYSTEM SHALL MONITOR AIRFLOW CFMS, SAT, AND OAT, FRESH AIR

MONITORING STATION TO TRACK AIRFLOW CFM ON BOTH THE EXHAUST AND FRESH AIR SIDE OF SYSTEM TO ENSURE THAT EXHAUST

FANS SHALL ENERGIZE THE ERV AND MODULATE THE AIRFLOW FROM MINIMUM TO MAXIMUM AS REQUIRED. PROVIDE AN AIRFLOW

CONTROL BY ZONE CO2 SENSOR MONITORING. DURING UNOCCIPIED HOURS THE CO2 SENSORS AND THE TOILET ROOM EXHAUST

700 CFM EXHAUST AND FRESH AIR VENTILATION. THE ERV SHALL HAVE A MAXIMUM VENTILATION RATE OF 1500 CFM BASED

THE ENERGY RECOVERY VENTILATION SYSTEM (ERV) SHALL OPERATE DURING OCCUPIED HOURS AND MAINTAIN A MINIMUM OF

ENERGY RECOVERY VENTILATION SYSTEM:

SHALL OPERATE WHEN LIGHTS ARE TURNED ON WITH AN OFF DELAY OF 15 MINUTES.

LIGHTS. THE TOILET ROOM EXHAUST FANS SHALL OPERATE DURING OCCIPIED HOURS. DURING UNOCCUPIED HOURS THE FANS

THE TOILET ROOM EXHAUST FANS SHALL BE CONTROLLED THRU THE DDC SYSTEM AS WELL AS VIA INTERLOCK TO TOILET ROOM

TOILET ROOM EXHAUST FANS:

ON AND OFF TO MAINTAIN LIGHTING WITHIN ACCEPTABLE LEVELS.

THE HEAT PUMP CONTROLS SHALL ALSO MONITOR THE ROOM LIGHTING LEVEL AND SHALL SWITCH STAGES OF ROOM LIGHTING

THE HEAT PUMP SHALL RETURN TO ITS UNOCCUPIED MODE OF OPERATION.

HEAT PUMP CONTROLS WILL AUTOMATICALLY RESET TO OCCUPIED MODE. FIFTEEN MINUTES AFTER NO OCCUPANCY IS SENSED,

HEAT PUMPS SHALL MONITOR ROOM OCCUPANCY. DURING THE UNOCCUPIED PERIODS, IF THE ROOM BECOMES OCCUPIED, THE

HEATING TEMPERATURE SET POINT.

WINTER SPACE TEMPERATURE SUCH THAT THE SPACE TEMPERATURE DROPS BELOW AN OWNER ESTABLISHED EMERGENCY

AUXILLARY ELECTRIC HEAT SHALL BE INITIATED INTO AUXILIARY HEAT MODE IF THE GEOTHERMAL SYSTEM FAILS TO MAINTAIN

SYSTEM SHALL MONITOR: FAN STATUS, LAT, EAT, COMPRESSOR STATUS, AND ZONE TEMPERATURE. THE HEAT PUMPS WITH

LOOP CIRCULATOR VFD SHALL MAINTAIN PRESSURE THEREBY MODULATING FLOW TO MATCH HEAT PUMP LOADING. THE DDC

VALVE WHICH OPENS TO ALLOW FLOW TO HEAT PUMP COMPRESSOR UPON CALL FOR HEATING OR COOLING. THE GEOTERMAL

CYCLE AS REQUIRED TO MAINTAIN ZONE SETPOINT TEMPERATURE. EACH HEAT PUMP (EXCEPT ONE) IS TO HAVE A SOLENOID

DURING OCCUPIED MODE THE HEAT PUMP FAN SHALL OPERATE CONTINUALLY AND THE COOLING AND HEATING MODE SHALL

TYPICAL HEAT PUMP:

A MEANS OF ENERGY TRACKING VIA FLOW RATE AND TEMPERATURE DIFFERENTIALS.

THE HEAT PUMP LOOP SYSTEM. ALSO A SUPPLY AND RETURN TEMPERATURE SENSOR SHALL BE INSTALLED SO AS TO PROVIDE

A WATER FLOW MONITORING DEVICE IS TO BE INSTALLED IN THE HEAT PUMP LOOP SO AS TO MONITOR THE FLOW RATE OF

AND THE STAND-BY PUMP SHALL BE AUTOMATICALLY ENERGIZED. THE GEOTHERMAL LOOP IS TO CIRCULATE CONTINUALLY.

TO GET EQUAL RUN TIME ON EACH CIRCULATOR PUMP. SHOULD THE PRIMARY PUMP FAIL AN ALARM SHALL BE INITIATED

AS MONITORED BY LOOP DIFFERENTIAL PRESSURE SENSOR. AN ALTERNATING SCHEDULE SHALL BE ESTABLISHED SO AS

THE PRIMARY PUMP WILL OPERATE THRU A VARIABLE FREQUENCY DRIVE TO MAINTAIN SYSTEM DIFFERENTIAL PRESSURE

GEOTHERMAL CIRCULATOR PUMP SYSTEM:

COMBINATION TEMPERATURE AND CO2 SENSOR DEVICE IS PREFERRED OVER TWO SEPARATE DEVICES.

MODULATE THE ENERGY RECOVERY VENTILATION SYSTEM FROM LOW AIR FLOW MODE TO FULL CAPCITY MODE. A

THERMOSTATS. CO2 SENSORS WILL BE PROVIDED TO MONITOR THE INDOOR ENVIRONMENTAL AIR QUALITY AND TO

HEAT PUMPS IN THE OFFICE AREAS SHALL BE CONTROLLED THRU THE DDC SYSTEM AS WELL AS VIA ADJUSTABLE ZONE

TEMPERATURE SENSORS.

3/1

6/2

010

9:4

8:3

0 A

MG:\

Arc

hives A-L\I

U\0

3170-0

3\d

esig

n\s

heets\M

5-0

01

D.d

gn

SHEET

MA

RK

DA

TE

ISS

UE

D F

OR

aja

DRAWN BY: CHECKED BY:

SCALE:

SHEET TITLE

PROJECT

NUMBER

ALL I

DE

AS,

DE

SIG

NS,

AN

D P

LA

NS I

NDIC

AT

ED O

R R

EP

RE

SE

NT

ED B

Y T

HE D

RA

WIN

GS A

RE O

WN

ED B

Y A

ND A

RE T

HE P

RO

PE

RT

Y O

F T

HE T

RO

YE

R G

RO

UP

AN

D A

RE C

RE

AT

ED A

ND D

EV

EL

OP

ED F

OR U

SE I

N C

ON

NE

CTIO

N W

ITH T

HE S

PE

CIFIC P

ROJE

CT. N

ON

E O

F T

HE I

DE

AS,

DE

SIG

NS,

OR P

LA

NS S

HA

LL B

E

US

ED B

Y O

R DIS

CL

OS

ED T

O A

NY P

ER

SO

N, FIR

M,

OR C

OR

PO

RA

TIO

N F

OR A

NY P

UR

PO

SE W

ITH

OU

T T

HE W

RIT

TE

N P

ER

MIS

SIO

N O

F T

HE T

RO

YE

R G

RO

UP.

WRIT

TE

N DIM

EN

SIO

NS S

HA

LL T

AK

E P

RE

CE

DE

NC

E O

VE

R S

CA

LE

D DIM

EN

SIO

NS. C

ON

TR

AC

TO

RS S

HA

LL V

ERIF

Y A

ND B

E R

ES

PO

NSIB

LE F

OR A

LL

DIM

EN

SIO

NS A

ND C

ON

DITIO

NS O

N T

HE J

OB A

ND S

HA

LL N

OTIF

Y T

HIS O

FFIC

E O

F A

NY V

ARIA

TIO

N F

RO

M T

HE DIM

EN

SIO

NS A

ND C

ON

DITIO

NS S

HO

WN B

Y

TH

ES

E D

RA

WIN

GS. IF T

HE

RE A

RE

DIS

CR

EP

AN

CIE

S B

ET

WE

EN A

NY E

LE

CT

RO

NIC FIL

E A

ND T

HE O

RIGIN

AL, T

HE S

EA

LE

D O

RIGIN

AL S

HA

LL G

OV

ER

N.

Copyright ' 2007

03170-03

ww

w.tro

yergro

up.c

om

Fax N

um

ber (5

74) 259-9

982

Phone N

um

ber (5

74) 259-9

976

Misha

waka, In

dia

na 4

6544

550 U

nio

n Street

Pla

nnin

g � D

esig

n � C

onstruction

NE

W F

ACILIT

Y F

OR:

CO

MM

UNIT

Y B

LD

G.

IU P

ROJE

CT #: 20063567

INDIA

NA U

NIV

ER

SIT

Y S

OU

TH B

EN

DS

OU

TH B

EN

D, IN

DIA

NA

OW

NE

R R

EVIE

W04/1

2/0

7

ISS

UE

D F

OR

04/2

4/0

7

CO

NS

TR

UC

TIO

N

Documents

G D L B Y IT N U M O C - Indiana University Bloomingtonsustain/programs/green-building... · the heat pump controls shall also monitor the room lighting level and shall switch stages