6,000-LITER FIRE FIGHTING TRUCK

Mitsubishi 6D16-3AT2

Powerful yet Economical Diesel Engine4-Stroke Cycle, Water Cooled, Turbocharged and Intercooled Direct Injection Diesel

Strong, Reliable and Durable ChassisEasy handling and enhanced suspension with passive safety feature include structural reinforcements for a highly rigid cab and impact-absorbing steering wheel.

Full Power PTO (FM 657H only)This full power PTO has an output speed ratio of 1:1.195

(Engine Speed : PTO Speed)Ideal for �retruck, sludge extraction or concrete pumping application.

* Mitsubishi Motors Philippines Corporation reserves the right to alter any specification without prior notice. • Decals shown are optional.

2nd to 6th Synchromesh, 1st and Rev. range Constantmesh 6.7484.1122.4151.5141.0000.7316.748

Single Reduction, Hypoid Gear6.666

Model

FUSO FIRETRUCKWheelbase (mm)Overall Length (mm)Overall Width (mm)Overall Height (mm)Tread (Front / Rear) (mm)Cab to Rear Axle (C.A.) (mm)Cab to End Frame (C.E.) (mm)Frame Width (mm)Front Overhang (F.O.H.) (mm)Rear Overhang (R.O.H.) (mm)Crew (persons)Fuel Tank Capacity (liters) Kerb Weight (kg)Payload (kg)Maximum G.V.W. (kg)

No. of CylindersPiston Displacement (cc)Bore x Stroke (mm)Max. Output (ECE) (Ps / rpm)Max. Torque (ECE) (N-m / rpm)Air Cleaner

ModelType

Spring TypeControl

Model

Gear Ratio

1st2nd3rd4th5th6th

Reverse

4-Stroke Cycle, Water Cooled with Turbocharged and Intercooled Direct Injection Diesel

6 In-line7,545

118 x 115220.32 / 2,800

637 / 1,400Dry Paper Element Type

Final Reduction GearFinal Gear RatioFull Power Take-Off (PTO)CHASSIS

ELECTRICAL SYSTEM

CAB

MISCELLANEOUS

ENGINE

DRIVELINE

WEIGHT

CALCULATED PERFORMANCE

TRANSMISSION

GENERAL SPECIFICATIONS

4,3958,605

13,000

Maximum Speed (Km/h)Maximum Gradeability (tan 0)Maximum Turning Radius (m)

11840.07.3

Type

Mitsubishi 6D16-3AT2

Clutch

C6W35Single Dry Plate

Coil SpringHydraulic-Controlled

M060S6-OD6 Forward, 1 Reverse M/T

Axle Reverse Elliot “I” BeamFully Floating

Single, 11R22.5 148 / 145MDual, 11R22.5 148 / 145M

22.5 x 7.50 - 162 - 13t, 8 StudsBall and Nut with Integral-Type Hydraulic Power Booster

EquippedEquippedEquippedEquipped

Laminated Leaf SpringsLaminated Leaf Springs

Hydraulic Double Acting TelescopicEquipped

Not EquippedAir Over Hydraulic with Dual Circuit

Internal Expanding Type on Propeller ShaftExhaust Brake

Suspension

TypeTilt Function

Telescopic FunctionSteering LockPower Assist

FrontRearTypeFrontRear

ServiceParkingAuxiliary

BatteriesAlternator Amp Rating

Construction

12V x 2, 52Ah @ 5 Hr. Rate (65D23R)24V, AC, 50 Amp

All-Steel with Tilt-Type

5-Position with Heater FunctionEquipped

1-DIN CD / Tuner

BlowerReverse Warning BuzzerRadio

FrontRear

ShockAbsorbers

Steering

Tire

Brakes

4,2807,5352,4552,680

3,5355,465

1,930

FM657H

Type

Wheels (Rim)

1,920 / 1,850

8401,245

3200

FrontRear

Equipped - 1.195 x Engine Speed

MITSUBISHI FUSO authorized distributor

MITSUBISHI MOTORS PHILIPPINES CORPORATIONPhotos shown in this flyer may vary from actual unit.© April 2011-Fuso FM657 Firetruck Brochure

BF03004001 © Mitsubishi Motors Philippines Corporation

Morita ME-5Two-Staged Balance Turbine Pump

Material : Casted Bronze Body, Impeller and Stainless Steel ShaftDischarge Pressure / Capacity:

Primary - 1,500 L/min (396 gpm) at total head of 2.0 Mpa (290 psi)Secondary - 3,000 L/min (792 gpm) at total head of 0.8 Mpa (116 psi)

Pump Connections:• One Suction inlet for 100mmø with blank cap

• Two discharge outlet for 63mmø �re hose with valve and cap• One discharge line for turret

• Water tank discharge line (tank to pump) with valve• Water tank supply line (pump to tank) with valve

Pump Driver:• Driven by vehicle engine thru Power Take-Off (PTO)

is the exclusive distributor of MORITA Pumps in the Philippines

2 Pcs. Fire HoseNozzle for 1.5” øPistol Grip Type

Adjustable to StraightStream, Wide Dense Fog

and Shut-O� Valve

2 Pcs. Fire HoseNozzle for 2.5” øPistol Grip Type

Adjustable to StraightStream, Wide Dense Fog

and Shut-O� Valve

3 Sets 50’ 2.5” ø Fire Hose Rubber Lined

Double Jacketed withMale and Female NST

Coupling

6 Sets 50’ 1.5” ø Fire Hose Rubber Lined

Double Jacketed withMale and Female NST

Coupling

2 Pcs. 10’ 4”ø Rubber Suction Hose

Search Light withAdjustable Mounting

Bracket

Light Bar Set, PublicAnnouncement (PA) System

and Siren

Roof Mounted Turret with Straight Nozzle

6000-LITER TANK• 6000-liter primed steel material with partition and baffle plates with vents to permit movement of air and water. Clean out holes, manholes and drain plug included. • Independent tank and body construction.

• 1 Pc. Wye Connected Gated Type 1 - 2.5” x 2 - 1.5”• 1 Pc. Alloy Extension Ladder ( 2 Section Type, extended length up to 18’ )• 2 Pcs. Fire Extinguisher ( Dry Chemical, 6 - kgs. )• 1 Pc. 10’ Pike Pole with Fiberglass Handle• 1 Pc. Rubber Mallet• 1 Pc. Pick-Head Axe

• 1 Pc. Crowbar• 1 Pc. Hydrant Wrench Double Spanner Head, Ductile Iron with Holder• 2 Pcs. Universal Type Spanner Fits 3/4” to 6” Pin / Lugs Fittings, Aluminum Alloy with Holder• 2 Pcs. Wheel Chock• 1 Pc. Brass Bell

OTHERACCESSORIES

Superior Cabin and Interior • The all-new Fuso FM657 boasts of a very comfortable cabin with car-like features, more leg room, panoramic windshield

and low side windows for improved visibility • 1-DIN CD / Tuner Audio System

Rear Body by ALMAZORA MOTORS CORP.• Rigid Steel body design covering the tank with rear aluminum shutter door access pump enclosure. Four (4) side compartments with aluminum shutter doors for carrying various fire-fighting equipment.• Open crew cabin with a four person bench seat with grab-on handles at sides and front.• Stainless steel ladder installed at rear portion of body for ascending and descending from the top.• All exposed metal surfaces excluding chrome plated or stainless steel painted with polyurethane automotive paint. Cavity wax and undercoating included.• 38-mm diameter stainless steel tubular rails mounted on roof perimeter.

• Equipped with blower fordriving comfort

Morita ME-5Two-Staged Balance Turbine Pump

Material : Casted Bronze Body, Impeller and Stainless Steel ShaftDischarge Pressure / Capacity:

Primary - 1,500 L/min (396 gpm) at total head of 2.0 Mpa (290 psi)Secondary - 3,000 L/min (792 gpm) at total head of 0.8 Mpa (116 psi)

Pump Connections:• One Suction inlet for 100mmø with blank cap

• Two discharge outlet for 63mmø �re hose with valve and cap• One discharge line for turret

• Water tank discharge line (tank to pump) with valve• Water tank supply line (pump to tank) with valve

Pump Driver:• Driven by vehicle engine thru Power Take-Off (PTO)

is the exclusive distributor of MORITA Pumps in the Philippines

2 Pcs. Fire HoseNozzle for 1.5” øPistol Grip Type

Adjustable to StraightStream, Wide Dense Fog

and Shut-O� Valve

2 Pcs. Fire HoseNozzle for 2.5” øPistol Grip Type

Adjustable to StraightStream, Wide Dense Fog

and Shut-O� Valve

3 Sets 50’ 2.5” ø Fire Hose Rubber Lined

Double Jacketed withMale and Female NST

Coupling

6 Sets 50’ 1.5” ø Fire Hose Rubber Lined

Double Jacketed withMale and Female NST

Coupling

2 Pcs. 10’ 4”ø Rubber Suction Hose

Search Light withAdjustable Mounting

Bracket

Light Bar Set, PublicAnnouncement (PA) System

and Siren

Roof Mounted Turret with Straight Nozzle

6000-LITER TANK• 6000-liter primed steel material with partition and baffle plates with vents to permit movement of air and water. Clean out holes, manholes and drain plug included. • Independent tank and body construction.

• 1 Pc. Wye Connected Gated Type 1 - 2.5” x 2 - 1.5”• 1 Pc. Alloy Extension Ladder ( 2 Section Type, extended length up to 18’ )• 2 Pcs. Fire Extinguisher ( Dry Chemical, 6 - kgs. )• 1 Pc. 10’ Pike Pole with Fiberglass Handle• 1 Pc. Rubber Mallet• 1 Pc. Pick-Head Axe

• 1 Pc. Crowbar• 1 Pc. Hydrant Wrench Double Spanner Head, Ductile Iron with Holder• 2 Pcs. Universal Type Spanner Fits 3/4” to 6” Pin / Lugs Fittings, Aluminum Alloy with Holder• 2 Pcs. Wheel Chock• 1 Pc. Brass Bell

OTHERACCESSORIES

Superior Cabin and Interior • The all-new Fuso FM657 boasts of a very comfortable cabin with car-like features, more leg room, panoramic windshield

and low side windows for improved visibility • 1-DIN CD / Tuner Audio System

Rear Body by ALMAZORA MOTORS CORP.• Rigid Steel body design covering the tank with rear aluminum shutter door access pump enclosure. Four (4) side compartments with aluminum shutter doors for carrying various fire-fighting equipment.• Open crew cabin with a four person bench seat with grab-on handles at sides and front.• Stainless steel ladder installed at rear portion of body for ascending and descending from the top.• All exposed metal surfaces excluding chrome plated or stainless steel painted with polyurethane automotive paint. Cavity wax and undercoating included.• 38-mm diameter stainless steel tubular rails mounted on roof perimeter.

• Equipped with blower fordriving comfort

6,000-LITER FIRE FIGHTING TRUCK

Mitsubishi 6D16-3AT2

Powerful yet Economical Diesel Engine4-Stroke Cycle, Water Cooled, Turbocharged and Intercooled Direct Injection Diesel

Strong, Reliable and Durable ChassisEasy handling and enhanced suspension with passive safety feature include structural reinforcements for a highly rigid cab and impact-absorbing steering wheel.

Full Power PTO (FM 657H only)This full power PTO has an output speed ratio of 1:1.195

(Engine Speed : PTO Speed)Ideal for �retruck, sludge extraction or concrete pumping application.

* Mitsubishi Motors Philippines Corporation reserves the right to alter any specification without prior notice. • Decals shown are optional.

2nd to 6th Synchromesh, 1st and Rev. range Constantmesh 6.7484.1122.4151.5141.0000.7316.748

Single Reduction, Hypoid Gear6.666

Model

FUSO FIRETRUCKWheelbase (mm)Overall Length (mm)Overall Width (mm)Overall Height (mm)Tread (Front / Rear) (mm)Cab to Rear Axle (C.A.) (mm)Cab to End Frame (C.E.) (mm)Frame Width (mm)Front Overhang (F.O.H.) (mm)Rear Overhang (R.O.H.) (mm)Crew (persons)Fuel Tank Capacity (liters) Kerb Weight (kg)Payload (kg)Maximum G.V.W. (kg)

No. of CylindersPiston Displacement (cc)Bore x Stroke (mm)Max. Output (ECE) (Ps / rpm)Max. Torque (ECE) (N-m / rpm)Air Cleaner

ModelType

Spring TypeControl

Model

Gear Ratio

1st2nd3rd4th5th6th

Reverse

4-Stroke Cycle, Water Cooled with Turbocharged and Intercooled Direct Injection Diesel

6 In-line7,545

118 x 115220.32 / 2,800

637 / 1,400Dry Paper Element Type

Final Reduction GearFinal Gear RatioFull Power Take-Off (PTO)CHASSIS

ELECTRICAL SYSTEM

CAB

MISCELLANEOUS

ENGINE

DRIVELINE

WEIGHT

CALCULATED PERFORMANCE

TRANSMISSION

GENERAL SPECIFICATIONS

4,3958,605

13,000

Maximum Speed (Km/h)Maximum Gradeability (tan 0)Maximum Turning Radius (m)

11840.07.3

Type

Mitsubishi 6D16-3AT2

Clutch

C6W35Single Dry Plate

Coil SpringHydraulic-Controlled

M060S6-OD6 Forward, 1 Reverse M/T

Axle Reverse Elliot “I” BeamFully Floating

Single, 11R22.5 148 / 145MDual, 11R22.5 148 / 145M

22.5 x 7.50 - 162 - 13t, 8 StudsBall and Nut with Integral-Type Hydraulic Power Booster

EquippedEquippedEquippedEquipped

Laminated Leaf SpringsLaminated Leaf Springs

Hydraulic Double Acting TelescopicEquipped

Not EquippedAir Over Hydraulic with Dual Circuit

Internal Expanding Type on Propeller ShaftExhaust Brake

Suspension

TypeTilt Function

Telescopic FunctionSteering LockPower Assist

FrontRearTypeFrontRear

ServiceParkingAuxiliary

BatteriesAlternator Amp Rating

Construction

12V x 2, 52Ah @ 5 Hr. Rate (65D23R)24V, AC, 50 Amp

All-Steel with Tilt-Type

5-Position with Heater FunctionEquipped

1-DIN CD / Tuner

BlowerReverse Warning BuzzerRadio

FrontRear

ShockAbsorbers

Steering

Tire

Brakes

4,2807,5352,4552,680

3,5355,465

1,930

FM657H

Type

Wheels (Rim)

1,920 / 1,850

8401,245

3200

FrontRear

Equipped - 1.195 x Engine Speed

MITSUBISHI FUSO authorized distributor

MITSUBISHI MOTORS PHILIPPINES CORPORATIONPhotos shown in this flyer may vary from actual unit.© April 2011-Fuso FM657 Firetruck Brochure

BF03004001 © Mitsubishi Motors Philippines Corporation