FLEXOVIT USA, INC.

MATERIAL SAFETY DATA SHEET Flammability Rating

Used to comply with OSHA's Hazard

Communication Standard, 29 CFR 1910.1200

Health 0 Reactivity

SECTION I - NAME AND PRODUCT Rating Rating

Company Name: Flexovit Abrasives 0 0

Address: 1305 Eden-Evans Road

Angola, NY 14006 0

Phone: 800-689-3539

Date Updated: Hazard Rating

Product: Cartridge Rolls, Spiral Band Sleeves,

Cross Pads, Square Pads NFPA HAZARD RATING CODE

SECTION II - COMPOSITION

% By OSHA OSHA Other Carcin-

Ingredient Weight Regulate Cas # PEL TLV Limits ogen

Silicon Carbide N/A N/A N/A 15 mg/m3 10 mg/m3 N/A No

Aluminum Oxide N/A N/A N/A 15 mg/m3 10 mg/m3 N/A No

Garnet N/A N/A N/A 15 mg/m3 10 mg/m3 N/A No

Zirconium Oxide N/A N/A N/A 15 mg/m3 10 mg/m3 N/A No

SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS

Boiling Point N/A Specific Gravity (H20=1) N/A

Vapor Pressure (mm Hg.) N/A Melting Point N/A

Vapor Density (AIR=1) N/A Evaporation Rate (Butyl Acetate=1) N/A

Solubility in Water N/A Appearance/Odor Color of paper/coated w/abrasive material

SECTION IV - FIRE AND EXPLOSION DATA

Flash Point N/A Lower EL N/A

Flammable Limits N/A Upper EL N/A

Special Fire Fighting Procedures N/A Unusual Fire or Explosion Hazards N/A

Extinguishing Media: Water, CO2, water, foam dry chemical

11/1/2011

AGGIH

Flexovit Cartidge Rolls, Spiral Bands, Pads pg 1 of 2

FLEXOVIT USA, INC.

SECTION V - REACTIVITY DATA

Stability: Stable Conditions to Avoid: N/A

Incompability (Materials to Avoid): N/A

Hazardous Decomposition or Byproducts:

In use, dust and decomposing resin system fumes are generated. In most cases the material removed from the work piece will be

significantly greater than the coated abrasive product components.

Hazardous Polymerization: Will not occur Conditions to Avoid: N/A

SECTION VI - HEALTH HAZARD DATA

Routes of Entry Inhalation Skin Ingestion

Dust during use Not absorbed in skin Dust

Health Hazards (Acute and Chronic)

Carcinogenicity NTP? IARC Monographs OSHA Regulated

N/A N/A N/A N/A

Signs and Symptoms of Exposure:

Coughing, shortness of breath, irritation of the eyes. During use on some materials elevated sound levels may be created which effect

hearing.

Medical Conditions Generally Aggravated by Exposure: N/A

Emergency and First Aid Procedures:

Remove to fresh air, apply artificial respiration as needed. For eyes-wash with large amounts of water. OBTAIN FIRST AID OR MEDICAL

ASSISTANCE IF NEEDED.

SECTION VII- STORAGE HANDLING AND USE PROCEDURES

Steps to be Taken In Case Material is Released or Spilled: Normal clean up procedures

Waste Disposal Method: Standard landfill methods consistent with applicable Fed., State and local laws.

Precautions to be Taken in Handling and Storing:

Handle with adequate ventilation. See OSHA 29CFR1910.94 (Ventilation) and OSHA 29CFR1910.1000 (Air Contaminates)

Other precautions

Normal use: Handle with adequate ventilation. See OSHA 29CFR1910.94 (Ventilation) and OSHA 29CFR1910.1000 (Air Contaminates),

OSHA CFR1910.213 (P) Sanding Machines.

SECTION VIII- CONTROL MEASURES

Protection Requirements and Referrals

Respiratory As needed, approved dust respirator OSHA 24 CFR 1910-134

Ventilation Local and mechanical exhaust recommended.

Protective Gloves Not required but use if desired.

Eye Protection N/A

Hearing Protection As needed. Refer to OSHA 29 CFR 1910.215

Hygienic Practices N/A

COMPANY USE

The information and recommendations set forth herein are taken from sources and references believed to be accurate and complete as of

the date hereof. However, Flexovit® USA Inc. makes no expressed or implied warranty with respect to the accuracy of the information or the

suitability of the recommendations, and assumes no liability to any user thereof.

Flexovit Cartidge Rolls, Spiral Bands, Pads pg 2 of 2