Upload
hdierke
View
231
Download
0
Embed Size (px)
Citation preview
7/25/2019 Eleven Five
1/12
3 48
Elevenfive
Elevenfive08
ELEVENFIVE-ELEVENFIVE 08 Bruno FattoriniInterior Innovation Award
Imm Cologne, 2005
Best of Best category
Best System
2004 - 2008
AUTUMNPlease, always check the availability with our Sales Department
system with
extendable arm
(see on page 3.59)
system with
flush-mounted TV(see on page 3.60)
A wall system which incorporates panels,cabinets and shelves.
Available in two versions: Elevenfive andElevenfive 08.Through the combination of these differentelements the system is available in manydifferent configurations characterized byfunctionality and aesthetical impact.Shelves can be easily attached to the panel,which is self-supporting.Thanks to adjusting devices, a correctinstallation is assured even in case walls arenot completely flat. The panel is pre-arrangedto provide access to the wires at differentpoints.
The shelves can be easily fixed to the panelsand can bear heavy loads.Max. capacity per linear meter with distributedload is: 32 kg for a 30 cm deep shelf 28 kg for a 43 cm deep shelf same bearing capacity for tops and
bottoms of cabinets
You can have both open or closed offcompartments, with doors, drawers or witha large drawer, by means of special cabinetswith shelves.
The Elevenfive08 version is characterized
by a fully white visual impact (AlpineWhite).
WALL PANELS
Available lengths: 80 (intermediate and singlepanel only),100, and 120 cm, thickness30 mm, always in height 216.3 cm. Withadjustable feet. Depending on the breadth ofthe panel composition, a wall bar and sideclosing panels are provided, in anodizedaluminium or lacquered in the same finish ofthe panel. With a grey oak wall panel, the sideclosing panel is in anthracite grey.TV sets can always be housed in the panels,either with the extandable arm or the flush-
mounting system.
Wall panels for Elevenfive
Made of MD wood fibreboards in the followingfinishes: matt micro goffered lacquering in white
and anthracite grey matt veneered in ash grey oak:
multilaminar wood in grey oak finish (pre-composed)
clad with a natural anodized aluminiumsheet.
Wall panels for Elevenfive 08
Made of MD wood fibreboards in Alpine Whitelacquer, soft touch.
SHELVING UNITS
The shelves are 80,100,120 cm long, in twodepths: 30 and 43 cm, always 11 mm thick.Easy to install thanks to panel slots madeaccording to the drawing and the grid. If sideby side, the shelves have concealed joints soas to assure a perfect flatness.
Shelvings for Elevenfive
Made from laminate* clad with naturalanodized or polished aluminium. The shelvesin polished aluminium may have a differentchromatic reflectance**.
Shelvings for Elevenfive 08
Made of LG HI-MACS*** compound ofpolyesther resins, mass pigmented, colour
Alpine White.
7/25/2019 Eleven Five
2/12
3 49
Eelevenfive/Elevenfiv
e
08
ELEVENFIVE-ELEVENFIVE 08
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
note*Laminate , in kraft papers of true cellulose impregnatedin thermosetting resin, atoxic and free of asbestos andchlorine, is in full compliance with the EU provisionsrelated to the emission of free formaldehyde (FiraInstitute certification). It is also self-extinguishing andantistatic.
**This type of aluminium, used in the lightingengineering industry, features high-definition technicalcharacteristics. The particular industrial process ofoxidation on minimal thicknesses (micron) definesthe quality of reflectance (DIN 5063/3) and of gloss(ISO7668), and can produce surface conditions whichresult in the optical phenomenon of iridescence. Basedon the features of the light source and of the incidenceon the surface, reflectance can result in differenttonalities, sometimes pink, sometimes light blue. Thesame surface may have differences in reflectance.
***75% of LG HI-Macs is composed of natural mineralsand very fine acrylic, mass-pigmented in white. Themost advanced production process ensures the highestquality of the surface and high technical performance.Technical specs: It does not absorb: it is non-porous and extremely
resistant to stains Its colour does not change over years It is ecological and hygienic thanks to the acrylic
resin Easy to clean: no special care is required. For
everyday cleaning, simply use a damp cloth and asoft cleanser.
Tougher stains can be removed using bleachingagent (apply just for 5 minutes and then rinsewith a domestic all-purpose cleanser and water);stubborn stains, scratches and small cigaretteburns can be removed with an abrasive creamy
detergent.LG HI-Macs is manufactured under the bestenvironmental and quality certifications (ISO 9001 and14001).
CABINETS
In lengths 80,100 and 120 cm they can be: closed off with retractable drop-front
door, with drawers or large drawer indepth 43 cm
closed off with retractable drop-front dooronly in depth 30 cm
Single cabinets are 30.1 cm high, doublecabinets are 59.1 cm high.The cabinet with a large drawer is availableonly in height 30.1 cm.The Elevenfive08 version does not providedouble cabinets, so cabinets standard heightis 30.1 cm.
Cabinets with shelves for Elevenfive
The sides of the storage units are madefrom birch multiply wood, in thickness 13mm, doors and drawers are made from MDwood fibreboards, in thickness 13 mm, glosslacquered white, black, grey, anthracite grey,red, green, yellow and orange.The cabinets always come with upper andbottom shelves from natural anodized orpolished aluminium.
Cabinets for Elevenfive 08
Frame made of of LG HI-MACS*** compoundof polyesther resins, mass pigmented, colour
Alpine White.
The fronts, doors and drawers are made fromMD wood fibreboards in Alpine White lacquer,soft touch.
In no way can the Elevenfive units be used
together with the Elevenfive 08.
FLUSH-MOUNTED EQUIPMENT
Flush-mounted CD and DVD holders inanodized aluminium.
ACCESSORIES
The system is provided with a wide range ofsimple and very functional accessories. Decoder racks, Videorecorder/DVD
racks, inner CD/DVD racks in anodizedaluminium (for cabinets with largedrawer)
Shelves in the various finishes of thecabinet with large drawer.
Top closing panel, in aluminium finish orlacquered in the same finish of the wallpanel. With a grey oak wall panel, theclosing panel is in anthracite grey.
CONFIGURATIONS BY DRAWING
Thanks to the simple method of installation,the panels are extremely adaptable and cancreate different wall systems of variousdimensions which can incorporate cabinetsand shelving units, thus offering veryfunctional solutions of strong image on thebasis of a pre-configured grid.The system is provided with three simple andfunctional adjusting mechanisms: one in depth by means of an adjusting
screw located between the panel andthe bar of galvanized sheet iron, fixed tothe wall, plus an adjustment device 5 cmabove the ground;
one in height (+25mm) with adjustingfeet; these are concealed by means of asmall shim element at the lower side ofthe panel;
one for alignment by means of a T-shaped
connecting device for panels.The wall bar comes with pre-drilled holesso as to match the boards used to makeplasterboard walls (for example, every 60 cmin the EU).In this way, you have a 10 cm large hollowspace off the wall (which added to the 3 cmthickness of the panel gives a depth of 13 cm)to provide access to the wires through pre-drilled holes, which can be also not at sight.The side closing panel is provided with a smallshim element to be used when the walls arenot completely flat.The adjustment mechanisms comprising thevertical fixing system and the wall spacer
allow the unit to be perfectly flush and upright,and panels to be functional, strong and stiff atthe same time.The panels come with slots (for shelves, forcabinets with shelves and for the flush-mountinstallation of the small opening for plugs)according to the drawing and the grid pre-configured by MDF Italia. Upon request thepanels can be provided with a small openingwith removable door in anodized aluminiumwhere to locate TV and PC-plugs and outlets.
The cabinets are shipped assembled to theshelvings.
ATTENTION:
to obtain a proper configuration, please follow the rules as per the diagrams on
page 3.53 and 3.54. always use the MDF Italia grid you
can download from the websitewww.mdfitalia.it
In the event of unit installation into niches,please contact our Sales Department todouble-check dimensions and usablespace.
For further information about specs,
please refer to pricelist, section 8 tables of
materials/colours.
7/25/2019 Eleven Five
3/12
3 50
ELEVENFIVE-ELEVENFIVE 08
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
units forcomposition
End, intermediate or
single wall panels
With adjustable feetheight 216.3 cm
thickness 3 cmlength 80 (single orintermediate only),100 and 120 cm
Shelving units
depth 30 or 43 cmthickness 11 mm.length 80, 100, 120 cm
depth 30 cm
height 30.1 with doorlength 80, 100 and 120 cm
depth 43 cmheight 30.1 with door with two drawers with large drawerlength 80, 100 and 120 cm
depth 43 cmheight 59.1 with 2 doors with 1 door and two drawerslength 80, 100 and 120 cm
depth 30 cm
height 59.1 with 2 doorslength 80, 100 and 120 cm
ACCESSORIES for panels ACCESSORIES FOR CABINETS WITH FLUSH-MOUNTED EQUIPMENT
LARGE DRAWER, DEPTH 43
small opening for outlets and PC plugs shelf CD case top closing panel decoder rack DVD case
LCD/Plasma Television System: video recorder/DVD rack - flush-mounted TV
- pre-arranged for TV extendable arm - extendable arm
Elevenfive cabinets
Elevenfive 08 cabinets
depth 43 cmheight 30.1 with door with two drawers
with large drawerlength 80, 100 and 120 cm
depth 30 cmheight 30.1 with doorlength 80, 100 and 120 cm
7/25/2019 Eleven Five
4/12
3 51
Eelevenfive/Elevenfiv
e
08
112
33
45
67
8
10
11
1112
13
14
17
18
15
16
9
ELEVENFIVE-ELEVENFIVE 08
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
units forcomposition
depth 13 cm
depth 13 cm
1 Bars for TV frame brackets2 TV frame3 TV-supporting brackets and/or
adapter4 Wall bar5 Depth adjustment device to fix to the
panel6 Panel7 Connecting bar among panels8 Side closing panel9 Depth adjustment screw10 Holes for foot height adjustment11 Shelving units12 Slots to receive shelving units13 Door cabinet with shelves14 1 door + 2 drawer-cabinet with
shelves15 Door cabinet for Elevenfive 0816 2 drawer-cabinet for Elevenfive 0817 Niche for Tv extendable arm
18 Tv extendable arm
Please note:
2 TV framesee page 3.60
17 Niche for Tv extendable arm18 Tv extendable arm
see page 3.59
7/25/2019 Eleven Five
5/12
3 52
quote
mm
ELEVENFIVE-ELEVENFIVE 08
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
diagram grid to beattached to thepurchase order
Thediagram,
beingintegralpartofthepurch
aseorder,mustbemade
mostprecisely.
Itdefinesthefollowing:atwhichheighttopositionth
eshelvings
andcabinetsslots,
thepositioningoftheflu
sh-mountedLCD/plasmaTV(dimsandheightfromt
heground),thepositioningofthesmallo
penings
to
letwiresin(atsightorinsidethecabinets)a
ndoftheflush-mountedCDandDVDcases.Th
egridhorizontallinescorrespondtothedistancebetween
centersoftheshelvingunits,
i.e.
oftheslots
.Toobtaintheusabledistancebetweentheshe
lvingunits,
youmustsubtract11mmc
orrespon
dingtothe
thicknessoftheshelf.
MDFItaliaacceptsnoresponsibilityfora
co
mpositionmadewithwrongsizesgiven.
dealer
date
reference
signature
Panel
height2163mm
height
mm
SCALE1
:20
Laterallimitband:
200mm
ontheendpanel
(left/rig
ht)
7/25/2019 Eleven Five
6/12
3 53
Elevenfive/Elevenfive
08
55 55200
ELEVENFIVE-ELEVENFIVE 08
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
INTERMEDIATE PANELS
All cabinets and shelves must be in the samesize of the panel.CD/DVD holders must be centred, and 20 cmsmaller than the panel.For example, 80cm panel 80 cm cabinet / shelf
60 cm CD/DVD holders 100cm panel 100 cm cabinet / shelf
80 cm CD/DVD holders 120cm panel 120 cm cabinet / shelf
100 cm CD/DVD holders
The openings for outlets inside the cabinetsare positioned in the middle of the cabinet,one slot above its bottom (see diagrams 1).
The openings for outlets outside the cabinetsare positioned above the cabinet, one slotabove its top with three options:- on the left or on the right leaving a
minimum gap of 5.5 cm off the edge- in the middle of the panel(see diagram 2)
Scale 1:20
diagram 1 diagram 2
OUTLETS OPENING
END PANELS
All cabinets and shelves must be 20 cmsmaller than the panel.CD/DVD holders must be centred withrespect to the cabinet/shelf or with respectto the panel, and 40 cmsmaller in size thanthe panel.For example, 100cm panel 80 cm cabinet / shelf
60 cm CD/DVD holders 120cm panel 100 cm cabinet / shelf
80 cm CD/DVD holders
The openings for outlets inside the cabinetsare positioned in the middle of the cabinet,one slot above its bottom (see diagrams3,4).The openings for outlets outside the cabinetsare positioned above the cabinet, one slotabove its top with three options:- on the left or on the right leaving a
minimum gap of 5.5 cmoff the edge oroff the lateral limit band
- in the middle of the panel(see diagram 3) Scale 1:20
limit band
OUTLETS OPENING
OUTLETS OPENING
OUTLETS OPENING
OUTLETS OPENING OUTLETS OPENING
diagram 3 diagram 4
OUTLETS OPENING
OUTLETS OPENING
OUTLETS OPENING
how to installpanels
7/25/2019 Eleven Five
7/12
3 54
80 0
1000 1000
PANSING
ELEVENFIVE-ELEVENFIVE 08
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
SINGLE PANELS
Cabinets and shelves cannot be larger thanthe panel.CD/DVD holders must be centred to thecabinet/shelf, and 40 cm smaller in sizethan the panel.For example, 80cm panels
80 cm cabinets and shelves only 100cm panels
80 or 100 cm cabinets and shelves60 cm CD/DVD holders
120cm panels80 100 and 120 cm cabinets andshelves80 cm CD/DVD holders
The openings for outlets inside the cabinetsare positioned in the middle of the cabinet,
one slot above its bottom. (see diagrams5,7,8)The openings for outlets outside thecabinets are positioned above the cabinet,one slot above its top with three options:- on the left or on the right leaving a
minimum gap of 5.5 cm off the edge- in the middle of the panel(see diagram 6)
Scale 1:20
Scale 1:20
OUTLETS OPENING
OUTLETS OPENING
OUTLETS OPENING
OUTLETS OPENING
OUTLETS OPENING OUTLETS OPENING
diagram 5 diagram 6
diagram 7 diagram 8
how to installpanels
7/25/2019 Eleven Five
8/12
3 59
Elevenfive/Elevenfive
08
74,2 cm
46,1cm
1000 12000
11000
0
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
ELEVENFIVE-ELEVENFIVE 08 accessories
A
B
element dims code
Niche L75 H57 P8 F021599-0004
Extendable TV arm for TV from 31 to 42 F021599-0005for TV from 42 to 65 F021599-0006
Tv extendable arm system
The MDF Italia Project Team have developeda Tv-supporting system capable of meetingthe growing demand for innovation with LCD/plasma TVs.This system can be used on all panels ofElevenfive, LCD/Plasma Panel and Highboard.It is composed of a niche to house a TV, insize 75x57cm and 8 cm in depth, made ofblack chipboard melamine-coated wood,thickness 2 cm. The panels sides are framedin anodized aluminium.The niche is screwed to L-shaped bracketsmounted on the rear of the panel.Both the Tv arm specified in the Price List andany kind of similar systems you find on themarket can be installed easily on the backof the niche with smaller dimensions thanthe usable ones (height 46.1 cm and length74.2 cm) as shown in fig. A.
How to apply the extendable tv arm to the
Elevenfive panels
The niche is always positioned in between twopanels.
The vertical position must match the slotsprovided for the shelvings (please see grid onpage 3.52 of the Price List).Shelvings and cabinets are to be positioned ata minimum distance from the cutout on theniche:- no. 2 slots with TVs in height to 80 cm- no. 3 slots with TVs in height from 81 to
100 cm- no. 4 slots with TVs in height over 100 cmHorizontally, the niche is always in themiddle in-between two panels (no matter if ofdifferent size) so as to maintain an identicallateral limit band on both left and right (fig.B).For customized positioning, please contactwith the Sales Department.
ACCESSORIES
TV arm
by Vogels, models EFW 6445 and EFW 6345.The bracket, thanks to flexibility and freedomof movement, lets the screen tilt and turn foran optimal viewing experience.Brackets in anthracite.Specifications: By means of an adapter, it is suitable
for any TV from 42 to 65 (EFW 6445model). With TVs from 31 to 42, themodel EFW 6345 is to be used
Max. weight LCD/Plasma Tvs : 55kg Turn: 120 Tilt: 30To check the compatibility of your TV with themodels of extendable arm specified in ourPricelist, it is highly recommended to checkdirectly under www.vogels.com
Attention: we kindly ask you to make certainthat the TV is compatible with the diagramconfiguration (distance with shelvings andcabinets) and the specified extendable arm.If this is not done, MDF Italia will reject anyresponsibility.
74.2 cm
46
.1cm
7/25/2019 Eleven Five
9/12
3 60
100
74
100
100
26
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
A B
The flush-mounted LCD/Plasma TelevisionSystem offers innovative advantages: the TV is fixed and flush-mounted into
the panel with no need of breaking thewall.
Please note: to be flush with the paneland not protruding, the TV must have amax. depth of 10 cm.
the LCD/PTV system makes use of all theElevenfive wall panels in their varioussizes and finishes.
How to install on Elevenfive panels
The MDF Italia fixing system is suitablefor almost any type of LCD/Plasma TV. Insome cases (for ex: with LCDs) it might benecessary to buy an adapter for the chosenTV set to add to the brackets ot the MDF Italiasystem. According to the TV sizes and theheight chosen, the panels are pre-arrangedfor the flush-mount installation of the TV, forthe installation of the closing frame in black
aluminium (at each side 4 cm larger than theTV), and the fixing system.
The system must always be placed betweentwo panels. Once the TV-set is installed, theoverall length of the two panels must allowto have a lateral limit band of at least 15 cm,including the 8 cm (4+4) of the closing frame.Just to give an example: for a 50 Sony PlasmaTV (code KEP50MRX1), in the following size:W157xH85.6xD10.8, the usable size is157+4+4=165 cm, so you need either two100 cm long panels, or one of 120 and oneof 80 cm.
Both in the purchase order and in the diagramyou must always indicate the model of theLCD/Plasma TV and its code, the exact sizes(height, width and depth) and at whichheight on the panel you want it to be placed.The slots in the panels, the closing frame andthe fixing system are made according to thesizes given.MDF Italia accepts no responsibility for acomposition made with wrong sizes given.MDF Italia reserves the right to test thecompatibility of the chosen model (LCD andPlasma) with the fixing system of the LCD/Plasma Television System.
LCD/Plasma television system with fl ush-mounted TV
element code
Closing frame with fixing system
The price comprises the panels slots andmachinings, the fixing system and the blackaluminium closing frame
F021599-0007
ELEVENFIVE-ELEVENFIVE 08 accessories
Please note:
to be flush withthe panel and notprotruding, theTV must have amax. depth of 10cm and a suitableshape (please seefig.A e B)
Transverse sectionof frame
7/25/2019 Eleven Five
10/12
3 61
Elevenfive/Elevenfive
08
100 80 80 120
120 100 100 120
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
ELEVENFIVE-ELEVENFIVE 08 examples of compositionA - 440 x 216 x 13/43/56 cm with niche for extendable arm
2 End wall panels 120 cm2 Intermediate wall panels 100 cm2 Shelvings, 100 cm, depth 438 Shelvings, 100 cm, depth 301 Cabinet with door, 100 cm, depth 302 Cabinets with large drawer, 100 cm, depth 432 Non-equipped drawers, 100 cm, for large drawer1 Two-drawer cabinet, 100 cm, depth 431 Niche for extendable arm
Elevenfive version with aluminium panels and aluminium anodized shelvings TOTAL
Elevenfive 08 version, Alpine White finish TOTAL
B - 380 x 216 x 13/43/56 cm with niche for extendable arm
1 End wall panel 120 cm1 End wall panel 100 cm2 Intermediate wall panels 80 cm4 Shelvings, 80 cm, depth 304 Shelvings, 100 cm, depth 302 Cabinets with door, 80 cm, depth 302 Cabinets with door, 80 cm, depth 431 Cabinet with large drawer, 80 cm, depth 431 Non-equipped drawer, 80 cm, for large drawer1 Two-drawer cabinet, 100 cm, depth 43
1 Niche for extendable arm
Elevenfive version with aluminium panels and aluminium anodized shelvings TOTAL
Elevenfive 08 version, Alpine White finish TOTAL
7/25/2019 Eleven Five
11/12
3 62
100 100 100 100
120 100 100 120
DVD
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
ELEVENFIVE-ELEVENFIVE 08 examples of compositionC - 400 x 216 x 13/43/56 cm with flush-mounted TV
2 End wall panels 100 cm
2 Intermediate wall panels 100 cm5 Shelvings, 100 cm, depth 303 Shelvings, 80 cm, depth 301 Cabinet with door, 80 cm, depth 302 Shelvings, 100 cm, depth 431 Cabinet with large drawer, 100 cm, depth 431 Cabinet with large drawer, 80 cm, depth 431 Non-equipped drawer, 100 cm, for large drawer1 Non-equipped drawer, 80 cm, for large drawer1 Two-drawer cabinet, 80 cm, depth 431 Frame for LCD/plasma tv2 Small openings for plugs
Elevenfive version with aluminium panels and aluminium anodized shelvings TOTAL
Elevenfive 08 version, Alpine White finish TOTAL
D - 440 x 216 x 13/43/56 cm with flush-mounted TV
2 End wall panels 120 cm2 Intermediate wall panels 100 cm8 Shelvings, 100 cm, depth 302 Cabinets with door, 100 cm, depth 302 Shelvings, anodized aluminium, 100 cm, depth 432 Cabinets with large drawer, 100 cm, depth 432 Non-equipped drawers, 100 cm, for large drawer1 Two-drawer cabinet, 100 cm, depth 431 Frame for LCD/plasma tv
1 Small opening for plugs1 DVD holder 60 cm
Elevenfive version with aluminium panels and aluminium anodized shelvings TOTAL
Elevenfive 08 version, Alpine White finish TOTAL
7/25/2019 Eleven Five
12/12
3 63
Elevenfive/Elevenfive
08
120 80 120 120
120 120 120
AUTUMN + SPECIAL PRICEPlease, always check the availability with our Sales Department
ELEVENFIVE-ELEVENFIVE 08 examples of compositionE - 360 x 216 x 13/43/56 cm with standing TV
2 End wall panels 120 cm
1 Intermediate wall panel 120 cm3 Shelvings, 100 cm, depth 301 Shelving, 120 cm, depth 302 Cabinets with door, 100 cm, depth 301 Cabinet with door, 120 cm, depth 302 Two-drawer cabinets, 100 cm, depth 431 Cabinet with door, 120 cm, depth 43
Elevenfive version with aluminium panels and aluminium anodized shelvings TOTAL
Elevenfive 08 version, Alpine White finish TOTAL
F - 440 x 216 x 13/43/56 cm with standing TV
2 End wall panels 120 cm1 Intermediate wall panel 80 cm1 Intermediate wall panel 120 cm2 Shelvings, 120 cm, depth 302 Shelvings, 100cm, depth 302 Cabinets with door, 100 cm, depth 301 Cabinet with door, 80 cm, depth 301 Cabinet with door, 120 cm, depth 302 Cabinets with large drawer, 100 cm, depth 432 Non-equipped drawers, 100cm, for large drawer1 Two-drawer cabinet, 80 cm, depth 431 Cabinet with large drawer, 120 cm, depth 43
1 Non-equipped drawer, 120 cm, for large drawer
Elevenfive version with aluminium panels and aluminium anodized shelvings TOTAL
Elevenfive 08 version, Alpine White finish TOTAL