Upload
phungnhu
View
216
Download
1
Embed Size (px)
Citation preview
PARTS MANUALSECTION 22
Published 06/11 MATERIAL HANDLING PARTS MANUAL
DFWR1225/DFWR1428/
DFWR1631/DFWR1833
DUAL-FOLD
WHEEL V-RAKE
©2009 Alamo Group Inc.
PARTS ORDERING GUIDE
The following instructions are offered to help eliminate needless delay and error in pro-cessing purchase orders for the equipment in this section.
1. The Parts Section is prepared in logical sequence and grouping of parts that belong to the basic machine featured in this manual. Part Numbers and Descriptions are given to help locate the parts and quantities required.
2. The Purchase Order must include the name and address of the person or organiza-tion ordering the parts, who should be charged, and if possible, the serial number of the machine for which the parts are ordered.
3. The Purchase Order must clearly list the quantity of each part, the complete and correct part number (be sure to include all periods), and the basic name of the part.
4. The Manufacturer reserves the right to substitute parts where applicable.
5. Some parts are unlisted items which are special production items not normally stocked and are subject to special handling. Request a quotation for such parts before sending a Purchase Order.
6. The Manufacturer reserves the right to change prices without prior notice.
For maximum safety and to guarantee optimum product reliability, always use genuine BUSH HOG Parts. The use of inferior replacement parts may causepremature or catastrophic failure which could result in serious injury or death.Direct any questions regarding parts to:
BUSH HOG2501 Griffin Ave. Selma, AL 36703www.bushhog.comContact Us800-304-2836
To the Owner/Operator/Dealer
All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-mindedoperator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer hasdesigned this implement to be used with all its safety equipment properly attached to minimize the chance ofaccidents.
BEFORE YOU START! Read the safety messages on the implement and shown in your manual. Observe the rulesof safety and common sense!
WARRANTY INFORMATION:Read and understand the complete Warranty Statement found in this Manual. Fill out the Warranty RegistrationForm in full and return it to within 30 Days. Make certain the Serial Number of the Machine is recorded on theWarranty Card and on the Warranty Form that you retain.
LIMITED WARRANTY
Bush Hog warrants to the original purchaser of any new Bush Hog equipment, purchased from an authorized BushHog dealer, that the equipment be free from defects in material and workmanship for a period of one (1) year fornon-commercial, state and municipalities’ use and ninety (90) days for commercial use from date of retail sale. Theobligation of Bush Hog to the purchaser under this warranty is limited to the repair or replacement of defectiveparts.
Replacement or repair parts installed in the equipment covered by this limited warranty are warranted for ninety(90) days from the date of purchase of such part or to the expiration of the applicable new equipment warrantyperiod, whichever occurs later. Warranted parts shall be provided at no cost to the user at an authorized Bush Hogdealer during regular working hours. Bush Hog reserves the right to inspect any equipment or parts which areclaimed to have been defective in material or workmanship.
DISCLAIMER OF IMPLIED WARRANTIES & CONSEQUENTIAL DAMAGESBush Hog’s obligation under this limited warranty, to the extent allowed by law, is in lieu of all warranties, implied orexpressed, INCLUDING IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR APARTICULAR PURPOSE and any liability for incidental and consequential damages with respect to the sale oruse of the items warranted. Such incidental and consequential damages shall include but not be limited to:transportation charges other than normal freight charges; cost of installation other than cost approved by BushHog; duty; taxes; charges for normal service or adjustment; loss of crops or any other loss of income; rental ofsubstitute equipment, expenses due to loss, damage, detention or delay in the delivery of equipment or partsresulting from acts beyond the control of Bush Hog.
THIS LIMITED WARRANTY SHALL NOT APPLY:1. To vendor items which carry their own warranties, such as engines, tires, and tubes.
2. If the unit has been subjected to misapplication, abuse, misuse, negligence, fire or other accident.
3. If parts not made or supplied by Bush Hog have been used in connection with the unit, if, in the sole judgementof Bush Hog such use affects its performance, stability or reliability.
4. If the unit has been altered or repaired outside of an authorized Bush Hog dealership in a manner which, in thesole judgement of Bush Hog, affects its performance, stability or reliability.
5. To normal maintenance service and normal replacement items such as gearbox lubricant, hydraulic fluid, wornblades, or to normal deterioration of such things as belts and exterior finish due to use or exposure.
6. To expendable or wear items such as teeth, chains, sprockets, belts, springs and any other items that in thecompany’s sole judgement is a wear item.
NO EMPLOYEE OR REPRESENTATIVE OF BUSH HOG IS AUTHORIZED TO CHANGE THIS LIMITEDWARRANTY IN ANY WAY OR GRANT ANY OTHER WARRANTY UNLESS SUCH CHANGE IS MADE INWRITING AND SIGNED BY BUSH HOG’S SERVICE MANAGER, 2501 GRIFFIN AVE., SELMA, ALABAMA36703.
Record the model number, serial number and date
purchased. This information will be helpful to your
dealer if parts or service are required.
MAKE CERTAIN THE WARRANTY
HAS BEEN FILED WITH BUSH HOG
SELMA, ALABAMA
MODEL NUMBER ________________________________
SERIAL NUMBER ________________________________
DATE OF RETAIL SALE ___________________________
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL
ALPHABETICAL TABLE OF CONTENTS
DFWR FOLDING WHEEL RAKES
ITEM PAGE NUMBER
Articulation - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-5
Articulation - DFWR1428/DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-26, 22-1-27
Center Section - DFWR1428 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-14, 22-1-15
Center Section - DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-22, 22-1-23
Center Section - DFWR1833 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-34, 22-1-35
Center Wheel Lift Cylinder (Opt) - DFWR1225/DFWR1428/DFWR1631 . . . . . . . . . . . . .22-1-42
Decals - Bush Hog Marking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-50, 22-1-51
Front Section - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-6, 22-1-7
Front Section - DFWR1428 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-12, 22-1-13
Front Section - DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-20, 22-1-21
Front Section - DFWR1833 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-32, 22-1-33
Hydraulic Kit - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-8, 22-1-9
Hydraulic Kit - DFWR1428 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-16, 22-1-17
Hydraulic Kit - DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-24, 22-1-25
Hydraulic Kit - DFWR1833 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-36, 22-1-37
Hydraulic Lift - Center Wheel Kit (Opt) - DFWR1225/DFWR1428/DFWR1631 . .22-1-40, 22-1-41
Kit, Hose Conversion (Opt) - All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-39
Light Kit - All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-48, 22-1-49
Ratchet Link Assembly - All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-46, 22-1-47
Rear Hydraulic Kit (Opt) - (To Open One Side Only) - All Models . . . . . . . . . . . . . . . . . . .22-1-43
Rear Hydraulic Opening Kit (Opt) - All Models . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-44, 22-1-45
Rear Section Hydraulic Cylinder Repair Kit - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-4
Rear Section Hydraulic Cylinder Repair Kit - DFWR1428/DFWR1631/DFWR1833 . . . . .22-1-38
Rear Section - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-2, 22-1-3
Rear Section - DFWR1428 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-10, 22-1-11
Rear Section - DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-18, 22-1-19
Rear Section - DFWR1833 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-30, 22-1-31
Rear Tandem Wheel kit (Opt) - All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-1
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Inside Back Cover
Wheel & Arm Assembly - DFWR1428/DFWR1631 . . . . . . . . . . . . . . . . . . . . . . .22-1-28, 22-1-29
22-1-1
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
REAR TANDEM WHEEL KIT (OPTION)
REF. PART
NO. NO. DESCRIPTION QTY.
1 3690302 Wdmt,Tandem Support 2
2 3690303 Wdmt,RH Tandem Wheel Support 1
3 3690304 Wdmt,LH Tandem Wheel Support 1
4 3690305 Wdmt,Support Pin 2
5 3668438 Spacer 4
6 3668429 Washer 2
7 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 2
8 2568438 90 Dg Grease Zerk, M8 2
9 3630103 Assy,Tire & Wheel 2
10 3638406 Nut, Spherical Cap Hex, M16x1.5 10
11 3666801 Seal, Grease 56 X 80 X 8 (Not Shown) 4
12 3666000 Bearing, Inner (Not Shown) 4
13 700139C Nut, Low Hex M30 X 3.5 (Not Shown) 4
22-1-2
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1225
REAR SECTION
RIGHT SIDE
LEFT SIDE
22-1-3
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1225
REAR SECTION
REF. PART
NO. NO. DESCRIPTION QTY.
1 3660200 Wdmt,Outer Crosspiece 12 3668425 Nut,Self Locking Ring M30 X1.5 2
3 3690219 Wdmt,Sliding Support 4
4 3667584 Plate,Drawbar Counter 1
5 3660119 Assy,Ratchet Link 1
6 3667594 Plate,Cylinder Support 1
8 3667557 Plate,Sliding Spacer 8
9 3667552 Plate,Sliding 4
10 3637521 Wheel Fork Bushing 8
11 3668400 Washer 2
12 3660204 Wdmt,Pin 2
13 3660205 Wdmt,RH Rear Wheel Support 1
14 3660206 Wdmt,LH Rear Wheel Support 1
15 3690277 Wdmt,LH 2-Whl Section 1
16 3690276 Wdmt,RH 2-Whl Section 1
17 3660106 Assy,Hub 2
18 3667504 Spindle,Weld-On 2
19 3666800 Seal 2
20 3666000 Bearing,Inner 2
21 3667505 Hub,Wheel 2
22 3666001 Bearing,Outer 2
23 3668408 Nut,Spindle 2
24 70487 Cotter Pin, M4x40 2
25 3666700 Cap,Hub 2
26 3660107 Assy,Hub & Spindle 2
27 3667567 Bushing 4
28 3667568 Tube,Main Lift 2
29 3667569 Clamp,Chain Bushing 12
30 3637422 Extension Arm Spring 12
31 3660209 Wdmt,LH Wheel Arm 6
32 3630226 Wdmt,RH Wheel Arm 6
33 3637509 Weld-On Spindle 12
34 3736800 Seal, 25 X 52.. 12
35 3736000 Inner Tapered Bearing Set 12
36 3637504 Wheel Hub 12
37 3736001 Outer Tapered Bearing Set 12
38 700728C Nut, Low Hex Castle M18x1.5 12
39 70477 Cotter Pin, M3.2x32 12
40 3736700 Hub Cap 12
41 3630100 Assy,Hub & Spindle 12
42 3637520 Arm Bushing 24
43 3667585 Pin 2
44 3638403 Washer 24
45 703516W Roll Pin, M8 X 50 16
46 3630102 Assy,LH Wheel 6
47 3630101 Assy,RH Wheel 6
48 70631C4 Carr Bolt, M10x1.5x25 Gr.4.6 240
49 3637508 Tine Clamp 120
50 3737507 Tine,7MM Dia 480
51 3637506 Rim 12
52 3637505 Flange 12
53 00765676 Nut Metric 10MM Self-Locking 240
54 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 92
55 00755954 Lockwasher M10 7256 00755949 Nut Metric 10MM-P1.5 PL 76
REF. PART
NO. NO. DESCRIPTION QTY.
57 3638406 Nut, Spherical Cap Hex M16x1.5 2058 3630103 Assy,Tire & Wheel 4
59 3637800 Tire, 205/75 SR15 4
60 3637600 Rim-15 4
61 3667421 Spring 2
62 3667509 Rod,Tie 2
63 3660382 Wdmt,Pin 2
64 3660211 Wdmt,RH Support 1
65 3660383 Wdmt,LH Support 1
66 3637523 Cylinder Pin 4
67 3668409 Fitting,Grease M6 X 1 45dg 12
68 3697110 Cylinder,Hydraulic 2
69 70502 Cotter Pin, M6.3x36 8
70 2568408 Grease Zerk, M8 12
71 3638400 Hairpin Cotter, M3 13
72 61056C8 Capscrew, Hex M8x1.25x60 Gr.8.8 20
73 70093C Nut, Hex Toplock M8x1.25 22
74 9313087 Capsc, M16-P2.0 - 40MM Gr.8 39
75 3038445 Nut,Toplock M16-P2.0 Pl5 57
76 00762395 Capsc, M12-P1.75- 20MM Gr.8 18
77 3668405 Washer,Flat 12 X 40 X 4 14
78 3667586 Plate,Sliding 8
79 71554C8 Fscs Metric 8-P1.25 - 16MM Gr.8 32
80 3667587 Plate,Linking 4
81 6W235 Capsc, M22 X 2.5 X 50 Gr.10.9 2
82 2558466 Capsc, M16 X 50 6
83 3668407 Washer,Flat 12 X 36 X 2.5 2
84 610915C8 Capsc, M16-P2 160MM Gr.8.8 8
85 701618C Lockwasher, M22 2
86 3660213 Wdmt,RH Inner Crosspiece 1
87 3660214 Wdmt,LH Inner Crosspiece 1
88 3660215 Wdmt,Pin 2
89 3668414 Stud,Wheel Hub Gr.8.8 10
90 3660122 Assy,Tie Rod - Complete 2
91 3690220 Wdmt,Tie Rod Tube 2
92 3668625 End,Tie Rod Head 2
93 701512C Flatwasher, M10 8
94 3690221 Wdmt,Tie Rod Pin 2
95 6W238 Nut, Hex M22 X 2.5 2
96 700219C Nut, High Hex, M12x1.75 2
97 3660216 Wdmt,Handle 2
98 3668601 Knob 2
99 708119C8 Shcs Metric 12 P1.75 100MM Gr.8.8 2
100 3660100 Assy,Handle 2
101 700139C Nut,Low Hex M30 X 3.5 2
102 3660384 Wdmt,Rear Drawbar 1
103 3667198 Cylinder,Hydraulic 2
104 3660232 Wdmt,Pin 2
105 3668415 Yoke,Clevis-Complete 12
106 613510C8 Capsc, Hex M8x1.25x30 Gr.8.8-Ft 6
107 701611C Lockwasher, M8 4
108 001465 Grease Fitting,Straight,M6 2
109 3667424 Spring 1
3660420 Kit, Ratchet Link - Complete 1
110 70093C Nut, Toplock M8x1.25 4111 61057C8 Capsc, M8-P1.25 X 65MM Gr.8.8 4
22-1-4
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1225
REAR SECTION HYDRAULIC CYLINDER REPAIR KIT
REF. PART
NO. NO. DESCRIPTION QTY.
3667198 Cylinder,Hydraulic 1
1 3667173 Rod,Cylinder 1
2 3667174 Tube,Cylinder 1
3 3667178 Locknut,Cylinder M27 X 2 1
4 3667177 Piston,Cylinder 2
5 -------- Piston Seal 1
6 -------- Piston O-Ring 1
7 3667176 Spacer,Cylinder 1
8 3667175 Head,Cylinder 1
9 -------- Rod Wiper 1
10 ------- Rod Seal 1
11 ------- Head O-Ring 1
3667179 Kit,Seal 1
22-1-5
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1225
ARTICULATION
REF. PART
NO. NO. DESCRIPTION QTY.
1 3660252 Wdmt,Front Drawbar 1
2 3660227 Wdmt.Center Drawbar 1
3 3660228 Wdmt,Rear Drawbar 1
4 3660322 Wdmt,RH Fixed Arm 1
5 3660323 Wdmt,LH Fixed Arm 1
6 3667518 Plate 4
7 3610400 Kit,Hydraulic Cylinder 2
8 3660231 Wdmt,Pin 2
9 3660232 Wdmt,Pin 2
10 3668405 Washer,Flat 12 X 40 X 4 2
11 00762395 Capsc, M12-P1.75- 20MM Pl5 4
12 2568408 Grease Zerk, M8 4
13 610716C8 Capsc, M12-P1.75-140MM Pl5 16
14 00772648 Nut Metric 12MM-P1.75 Gr.8.8 16
15 9313087 Capsc, M16-P2.0 - 40MM Gr.8.8 15
16 3038445 Nut,Toplock Metric 16-P2.0 Gr.8.8 15
22-1-6
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1225
FRONT SECTION
RIGHT SIDE
LEFT SIDE
22-1-7
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1225
FRONT SECTION
REF. PART
NO. NO. DESCRIPTION QTY.
1 3660385 Wdmt,RH 3-Whl Section 1
2 3660386 Wdmt,LH 3-Whl Section 1
3 3660387 Wdmt,RH 1-Whl Section 1
4 3660388 Wdmt,LH 1-Whl Section 1
5 3667570 Tube,Center Lift 2
6 3667571 Tube,Front Lift 2
7 3667198 Cylinder,Hydraulic 2
8 3667567 Bushing 2
9 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 20
10 3660221 Wdmt,RH Hitch Transport Arm 1
11 3660222 Wdmt,LH Hitch Transport Arm 1
12 3637521 Wheel Fork Bushing 4
13 3667516 Plate,Brake Counter 2
14 3630229 Clutch Bushing Weldment 2
15 3660223 Wdmt,Brake 2
16 3637423 Compression Spring 2
17 3660224 Wdmt,Front Wheel Support 2
18 3660225 Wdmt,Pin 2
19 3636003 Bearing,Ball Two Rubber Seals 4
20 3637526 Wheel Spacer 2
21 3637527 Wheel Hub 2
22 3638409 Washer 2
23 700910C Nut, Toplock M22x2.5 Hex 2
24 3660108 Assy,Hub 2
25 3667517 Spacer 4
26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 10
27 3638406 Nut, Spherical Cap Hex M16x1.5 20
28 3637800 Tire, 205/75 SR15 4
29 3637600 Rim-15 4
30 3630103 Assy,Tire & Wheel 4
31 3660267 Wdmt,Tractor Hitch 1
32 3660235 Wdmt,Hitch Pin 1
33 3668624 Stand,Parking 1
34 3638602 Frame Pin 1
REF. PART
NO. NO. DESCRIPTION QTY.
35 3667519 Bushing 2
36 3660236 Wdmt,Inner Arm 2
37 3660237 Wdmt,Outer Arm 2
38 3660238 Wdmt,Pin 6
39 3660239 Wdmt,Bushing 2
40 3660252 Wdmt,Front Drawbar 1
41 3660227 Wdmt.Center Drawbar 1
42 3660322 Wdmt,RH Fixed Arm 1
43 3660323 Wdmt,LH Fixed Arm 1
44 3667518 Plate 4
45 3668407 Washer,Flat 12 X 36 X 2.5 5
46 00762395 Capsc, M12-P1.75- 20MM Gr.5 18
47 3638400 Hairpin Cotter, M3 13
48 00772648 Nut Metric 12MM-P1.75 Gr.8.8 23
49 61075C8 Capsc, M12-P1.75-60MM Gr.5 1
50 3660231 Wdmt,Pin 2
51 3668405 Washer,Flat 12 X 40 X 4 14
52 703519W Pin,Roll M8 X 70MM Pl 2
53 3668401 Washer 2
54 610711C8 Capsc, M12 P1.75 90MM Gr.5 2
55 61054C8 Capsc, Hex M8x1.25x50 Gr.8.8 20
56 00755934 Nut Met 8MM-P1.25 22
57 00765901 Capsc, M16-P2.0 - 45MM Gr.8 39
58 3038445 Nut,Toplock Metric 16-P2.0 PL5 57
59 3668409 Grease Fitting 12
60 00756934 Pin,Roll 10 X 80 2
61 2568408 Grease Zerk, M8 12
62 3660326 Wdmt,Brake Counter Plate 2
63 3667577 Plug 1
64 3668430 Ring,External Snap 24
65 3668431 Ring,Internal Elastic 24
66 3666776 Bushing,Nylon 24
67 3667572 Bushing 12
68 3668409 Fitting,Grease M6 X 1 45dg 14
69 00775032 Grease Fitting, 8MMx1x45 2
22-1-9
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1225
HYDRAULIC KIT
REF. PART
NO. NO. DESCRIPTION QTY.
1 3637102 Male Coupling Tip 3
2 3638408 Copper Washer, 1/2 ID 3
3 3667200 Assy,Hose 1
4 3667201 Assy,Hose 1
5 3667202 Assy,Hose 1
6 3668402 Collar,Double Hose 1
7 3668403 Collar,Hose 7
8 3668404 Collar,Hose 7
9 3667198 Cylinder,Hydraulic 2
10 3638404 Copper Washer, 17 X 22 X 1.4 23
11 3637100 Hydraulic Fitting 6
12 3667102 Line,Hydraulic 2
13 3697114 Fitting,Hydraulic Line 4
14 3667109 Valve,Lock 2
15 613313C8 Capsc, M6-P1-40MM Gr.8.8 2
16 70092C Nut Met Tln M6-P1 PL5 4
17 3667103 Line,Hydraulic 2
18 3667105 Fitting,Hydraulic 6
19 3667203 Assy,Hose 2
20 3667204 Assy,Hose 2
21 3667106 Fitting,Hydraulic 2
22 3667107 Fitting,Hydraulic Tee 1
23 3667110 Divider,Flow 1
24 3660246 Wdmt,Plate 1
25 613317C8 Capsc, M6-P1 -60MM Gr.8.8 2
26 3667108 Fitting,Hydraulic Tee 1
27 3667205 Assy,Hose 2
28 3697110 Cylinder,Hydraulic 2
29 3667111 Rod,Cylinder 2
30 3667112 Tube,Cylinder 2
31 3667113 Head,Cylinder 2
32 3667114 Piston,Cylinder 2
33 3667115 Nut,Cylinder 2
34 -------- Seal 2
35 -------- O-Ring 2
36 -------- Seal 2
37 3667116 Kit,Seal 2
38 3667173 Rod,Cylinder 2
39 3667174 Tube,Cylinder 2
40 3667175 Head,Cylinder 2
41 3667176 Spacer,Cylinder 2
42 3667177 Piston,Cylinder 2
43 3667178 Locknut,Cylinder 2
44 -------- Seal 2
45 -------- Seal 2
46 -------- O - Ring 2
47 -------- O - Ring 2
48 -------- Seal 2
49 3667179 Kit,Seal 2
50 3667247 Assy,Hyd. Hose 1
51 3660240 Wdmt,Bushing Plate 1
52 3667521 Plate 1
53 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 4
54 00772648 Nut Metric 12MM-P1.75 Gr.8.8 23
55 3668433 Collar,Hose 1
22-1-10
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1428
REAR SECTION
RIGHT SIDE
LEFT SIDE
22-1-11
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1428
REAR SECTION
REF. PART
NO. NO. DESCRIPTION QTY.1 3660200 Wdmt,Outer Crosspiece 12 3668425 Nut,Self Locking Ring M30 X1.5 23 3690219 Wdmt,Sliding Support 44 3667584 Plate,Drawbar Counter 15 3660119 Assy,Ratchet Link 16 3667594 Plate,Cylinder Support 1
8 3667557 Plate,Sliding Spacer 89 3667552 Plate,Sliding 410 3637521 Wheel Fork Bushing 12
11 3668400 Washer 2
12 3660247 Wdmt,Pin 213 3660248 Wdmt,RH Rear Wheel Support 1
14 3660249 Wdmt,LH Rear Wheel Support 1
15 3690277 Wdmt,LH 2-Whl Section 1
16 3690276 Wdmt,RH 2-Whl Section 1
17 3660106 Assy,Hub 2
18 3667504 Spindle,Weld-On 2
19 3666800 Seal 2
20 3666000 Bearing,Inner 2
21 3667505 Hub,Wheel 2
22 3666001 Bearing,Outer 2
23 3668408 Nut,Spindle 2
24 70487 Cotter Pin, M4x40 2
25 3666700 Cap,Hub 2
26 3660107 Assy,Hub & Spindle 2
27 3667567 Bushing 4
28 3667568 Tube,Main Lift 2
29 3667569 Clamp,Chain Bushing 14
30 3637422 Extension Arm Spring 14
31 3660209 Wdmt,LH Wheel Arm 6
32 3630226 Wdmt,RH Wheel Arm 6
33 3637509 Weld-On Spindle 14
34 3736800 Seal, 25 X 52.. 14
35 3736000 Inner Tapered Bearing Set 14
36 3637504 Wheel Hub 14
37 3736001 Outer Tapered Bearing Set 4
38 700728C Nut, Low Hex Castle M18x1.5 4
39 70477 Cotter Pin, M3.2x32 4
40 3736700 Hub Cap 4
41 3630100 Assy,Hub & Spindle 4
42 3637520 Arm Bushing 8
43 3667585 Pin 244 3638403 Washer 14
45 703516W Roll Pin, M8 X 50 14
46 3630102 Assy,LH Wheel 6
47 3630101 Assy,RH Wheel 6
48 70631C4 Carr Bolt, M10x1.5x25 Gr.4.6 280
49 3637508 Tine Clamp 140
50 3737507 Tine,7MM Dia 560
51 3637506 Rim 14
52 3637505 Flange 14
53 00765676 Nut Metric 10MM Self-Locking 280
54 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 114
55 00755954 Lockwasher M10 92
56 00755949 Nut Metric 10MM-P1.5 Pl 88
57 3638406 Nut, Spherical Cap Hex M16x1.5 20
58 3630103 Assy,Tire & Wheel 6
59 3637800 Tire, 205/75 SR15 660 3637600 Rim-15 6
REF. PARTNO. NO. DESCRIPTION QTY.61 3667421 Spring 262 3667509 Rod,Tie 263 3660382 Wdmt,Pin 264 3660391 Wdmt,RH Support 165 3660383 Wdmt,LH Support 166 3637523 Cylinder Pin 467 3668409 Fitting,Grease M6 X 1 45dg 2868 3697110 Cylinder,Hydraulic 269 70502 Cotter Pin, M6.3x36 870 2568408 Grease Zerk, M8 1671 3638400 Hairpin Cotter, M3 272 61056C8 Capsc, Hex M8x1.25x60 Gr.8.8 20
73 70093C Nut, Toplock M8x1.25 20
74 9313087 Capsc, M16-P2.0 - 40MM Gr.8.8 56
75 3038445 Nut,Toplock Metric 16-P2.0 Pl5 78
76 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 18
77 3668405 Washer,Flat 12 X 40 X 4 14
78 3667586 Plate,Sliding 1
79 71554C8 Fscs Metric 8-P1.25 - 16MM 32
80 3667587 Plate,Linking 481 6W235 Capsc, M22 X 2.5 X 50 Gr.10.9 2
82 2558466 Capsc, M16 X 50 6
83 3668407 Washer,Flat 12 X 36 X 2.5 4
84 610915C8 Capsc, M16-P2 160MM Pl5 8
85 701618C Lockwasher, M22 2
86 3660213 Wdmt,RH Inner Crosspiece 1
87 3660214 Wdmt,LH Inner Crosspiece 1
88 3660215 Wdmt,Pin 2
89 3668414 Stud,Wheel Hub 10
90 3660122 Assy,Tie Rod - Complete 2
91 3690220 Wdmt,Tie Rod Tube 2
92 3668625 End,Tie Rod Head 2
93 701512C Flatwasher, M10 8
94 3690221 Wdmt,Tie Rod Pin 2
95 6W238 Nut, Hex M22 X 2.5 2
96 700219C Nut, High Hex M12x1.75 2
97 3660216 Wdmt,Handle 2
98 3668601 Knob 2
99 708119C8 Shcs Metric 12 P1.75 100MM Gr.8.8 2
100 3660100 Assy,Handle 2
101 700139C Nut,Low Hex M30 X 3.5 4
102 3660313 Wdmt,LH 2-Whl Section 1
103 3667199 Cylinder,Hydraulic 2
104 3660232 Wdmt,Pin 2
105 3668415 Yoke,Clevis-Complete 14
106 613510C8 Capsc, Hex M8x1.25x30 Gr.8.8-Ft 4
107 701611C Lockwasher, M8 4
108 3660316 Wdmt,LH Reinforcement Tube 1
109 3660315 Wdmt,RH Reinforcement Tube 1
110 70096C Nut, Toplock M14x2 24
111 3660314 Wdmt,RH 2-Whl Section 1
112 61081C8 Capsc, M14-P2.0 - 45MM Gr.8.8 16
113 3660394 Wdmt,Drawbar 1114 3660395 Wdmt,RH 2-Whl Section 1
115 3667573 Tube,Lift 2
116 001465 Grease Fitting,Straight,M6 2117 3667424 Spring 1
3660420 Kit,Ratchet Link - Complete 1
118 70093C Nut, Top Lock M8x1.25 Hex 4
119 61057C8 Capsc, M8-P1.25 X 65MM Pl5 4
22-1-12
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1428
FRONT SECTION
RIGHT SIDE
LEFT SIDE
22-1-13
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1428
FRONT SECTION
REF. PART
NO. NO. DESCRIPTION QTY.
3 3660397 Wdmt,RH 3-Whl Section 1
4 3660398 Wdmt,LH 3-Whl Section 1
5 3667570 Tube,Center Lift 4
6 3667574 Tube,Front Lift 2
7 3668415 Yoke,Clevis-Complete 18
8 3667567 Bushing 6
9 703611W Pin,Roll 10MM X 32MM 2
10 3660329 Wdmt,RH Support Tube 1
11 3660330 Wdmt,LH Support Tube 1
12 3637521 Wheel Fork Bushing 12
13 3667516 Plate,Brake Counter 4
14 3630229 Clutch Bushing Weldment 4
15 3660223 Wdmt,Brake 4
16 3637423 Compression Spring 4
17 3660224 Wdmt,Front Wheel Support 4
18 3660225 Wdmt,Pin 4
19 3636003 Bearing,Ball Two Rubber Seals 8
20 3637526 Wheel Spacer 4
21 3637527 Wheel Hub 4
22 3638409 Washer 4
23 700910C Nut,Toplock M22x2.5 Hex 4
24 3660108 Assy,Hub 4
25 3667517 Spacer 8
26 61895C8 Capsc,Hex M16x1.5x40 Gr.8.8-Ft 20
27 3638406 Nut, Spherical Cap Hex M16x1.5 20
28 3637800 Tire, 205/75 SR15 6
29 3637600 Rim-15 6
30 3630103 Assy,Tire & Wheel 6
31 3660267 Wdmt,Tractor Hitch 1
32 3660235 Wdmt,Hitch Pin 1
33 3668624 Stand,Parking 1
34 3638602 Frame Pin 1
35 3667519 Bushing 4
36 3660236 Wdmt,Inner Arm 2
37 3660237 Wdmt,Outer Arm 2
38 3660238 Wdmt,Pin 6
39 3637520 Arm Bushing 36
REF. PART
NO. NO. DESCRIPTION QTY.
40 3660252 Wdmt,Front Drawbar 1
41 3660227 Wdmt.Center Drawbar 1
42 3630226 Wdmt,RH Wheel Arm 7
43 3660209 Wdmt,LH Wheel Arm 7
44 3638403 Washer 36
45 3668407 Washer,Flat 12 X 36 X 2.5 7
46 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 18
47 3638400 Hairpin Cotter, M3 13
48 00772648 Nut Metric 12MM-P1.75 Gr.8.8 25
49 61075C8 Capsc, M12-P1.75-60MM Gr.8.8 1
50 3630101 Assy,RH Wheel 7
51 3630102 Assy,LH Wheel 7
52 3667569 Clamp,Chain Bushing 14
53 3668401 Washer 4
54 610711C8 Capsc, M12 P1.75 90MM Gr.8.8 4
55 61056C8 Capsc, Hex M8x1.25x60 Gr.8.8 28
56 00755934 Nut Met 8MM-P1.25 30
57 00765901 Capsc, M16-P2.0 - 45MM Gr.8.8 56
58 3038445 Nut,Toplock Metric 16-P2.0 Pl5 78
59 3668409 Fitting,Grease M6 X 1 45dg 28
60 00756934 Pin,Roll 10 X 80 4
61 2568408 Grease Zerk, M8 16
62 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 122
63 00755954 Lockwasher M10 80
64 00755949 Nut Metric 10MM-P1.5 Pl 76
65 703516W Pin,Roll 22
66 3637422 Extension Arm Spring 14
67 3660326 Wdmt,Brake Counter Plate 4
68 3690202 Wdmt,RH Front Tube Support 1
69 3690203 Wdmt,LH Front Tube Support 1
70 3667576 Bushing 2
71 3667577 Plug 1
72 61364C8 Capsc, Hex M10x1.5x16 Gr.8.8-Ft 4
73 61053C10 Capsc, Hex M8x1.25x45 Gr.10.9 2
74 701512C Flatwasher, M10 4
75 3690208 Wdmt,Extension 2
76 61097C8 Capsc, Hex M16x2x80 Gr.8.8 2
77 00775032 Grease Fitting, 8MMx1x45 4
22-1-14
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1428
CENTER SECTION
RIGHT SIDE
LEFT SIDE
22-1-15
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1428
CENTER SECTION
REF. PART
NO. NO. DESCRIPTION QTY.
1 3660397 Wdmt,RH 3-Whl Section 1
2 3660398 Wdmt,LH 3-Whl Section 1
5 3667570 Tube,Center Lift 2
6 3667574 Tube,Front Lift 2
7 3667199 Cylinder,Hydraulic 2
8 3667567 Bushing 4
9 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 16
10 3668430 Ring,External Snap 28
11 3668431 Ring,Internal Elastic 28
12 3637521 Wheel Fork Bushing 12
13 3667516 Plate,Brake Counter 4
14 3630229 Clutch Bushing Weldment 4
15 3660223 Wdmt,Brake 4
16 3637423 Compression Spring 4
17 3660224 Wdmt,Front Wheel Support 4
18 3660225 Wdmt,Pin 4
19 3636003 Bearing,Ball Two Rubber Seals 8
20 3637526 Wheel Spacer 4
21 3637527 Wheel Hub 4
22 3638409 Washer 4
23 700910C Nut, Toplock M22x2.5 Hex 4
24 3660108 Assy,Hub 4
25 3667517 Spacer 8
26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 20
27 3638406 Nut, Spherical Cap Hex, M16x1.5 20
28 3637800 Tire, 205/75 SR15 6
29 3637600 Rim-15 6
30 3630103 Assy,Tire & Wheel 6
31 3660267 Wdmt,Tractor Hitch 1
32 3660235 Wdmt,Hitch Pin 1
33 3668624 Stand,Parking 1
34 3638602 Frame Pin 1
35 3667519 Bushing 2
36 3660236 Wdmt,Inner Arm 2
37 3660237 Wdmt,Outer Arm 2
REF. PART
NO. NO. DESCRIPTION QTY.
38 3660238 Wdmt,Pin 6
39 3666776 Bushing,Nylon 28
40 3660252 Wdmt,Front Drawbar 1
41 3660227 Wdmt.Center Drawbar 1
42 3660322 Wdmt,RH Fixed Arm 1
43 3660323 Wdmt,LH Fixed Arm 1
44 3667518 Plate 4
45 3668407 Washer,Flat 12 X 36 X 2.5 6
46 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 18
47 3638400 Hairpin Cotter, M3 13
48 00772648 Nut Metric 12MM-P1.75 Gr.8.8 25
49 61075C8 Capsc, M12-P1.75-60MM Gr.8.8 1
50 3660231 Wdmt,Pin 2
51 3668405 Washer,Flat 12 X 40 X 4 14
52 3667572 Bushing 14
53 3668401 Washer 4
54 610711C8 Capsc, M12 P1.75 90MM Gr.8.8 4
55 61056C8 Capsc, Hex M8x1.25x60 Gr.8.8 20
56 00755934 Nut Met 8MM-P1.25 20
57 00765901 Capsc, M16-P2.0 - 45MM Gr.8.8 56
58 3038445 Nut,Toplock Metric 16-P2.0 PL5 78
59 3668409 Fitting,Grease M6 X 1 45dg 28
60 00756934 Pin,Roll 10 X 80 4
61 2568408 Grease Zerk, M8 16
62 3660324 Wdmt,RH Reinforcement Tube 1
63 610714C8 Capsc, M14-P2.0 -160MM Gr.8.8 8
65 3660694 Wdmt,Drawbar 1
66 3660325 Wdmt,LH Reinforcement Tube 1
67 3660396 Wdmt,LH 2-Whl Section 1
68 61081C8 Capsc, M14-P2.0 - 45MM PL5 16
69 70096C Nut, Toplock M14x2 Hex 24
70 00755940 Washer M14 8
72 3660326 Wdmt,Brake Counter Plate 4
73 3667577 Plug 1
74 00775032 Grease Fitting, 8MMx1x45 4
22-1-17
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1428
HYDRAULIC KIT
REF. PART
NO. NO. DESCRIPTION QTY.
1 3637102 Male Coupling Tip 3
2 3638408 Copper Washer, 1/2 ID 3
3 3667245 Assy,Hose 1
4 3667246 Assy,Hose 1
5 3667208 Assy,Hose 1
6 3668402 Collar,Double Hose 1
7 3668403 Collar,Hose 9
8 3668404 Collar,Hose 9
9 3667199 Cylinder,Hydraulic 2
10 3638404 Copper Washer, 17 X 22 X 1.4 23
11 3637100 Hydraulic Fitting 6
12 3667125 Line,Hydraulic 2
13 3697114 Fitting,Hydraulic Line 4
14 3667109 Valve,Lock 2
15 613313C8 Capsc, M6-P1-40MM Gr.8.8 5
16 70092C Nut Met Tln M6-P1 PL5 5
17 3667103 Line,Hydraulic 2
18 3667105 Fitting,Hydraulic 6
19 3667203 Assy,Hose 2
20 3667204 Assy,Hose 2
21 3667106 Fitting,Hydraulic 2
22 3667107 Fitting,Hydraulic Tee 1
23 3667110 Divider,Flow 1
24 3660246 Wdmt,Plate 1
25 613317C8 Capsc, M6-P1 -60MM Gr.8.8 2
26 3667108 Fitting,Hydraulic Tee 1
27 3667205 Assy,Hose 2
28 3697110 Cylinder,Hydraulic 2
29 3667111 Rod,Cylinder 2
30 3667112 Tube,Cylinder 2
31 3667113 Head,Cylinder 2
32 3667114 Piston,Cylinder 2
33 3667115 Nut,Cylinder 2
34 -------- Seal 2
35 -------- O-Ring 2
36 -------- Seal 2
37 3667116 Kit,Seal 2
38 3667180 Rod,Cylinder 2
39 3667181 Tube,Cylinder 2
40 3667182 Head,Cylinder 2
41 3667183 Spacer,Cylinder 2
42 3667184 Piston,Cylinder 2
43 3667185 Locknut,Cylinder 2
44 -------- Seal 2
45 -------- Seal 2
46 -------- O - Ring 2
47 -------- O - Ring 2
48 -------- Seal 2
49 3667186 Kit,Seal 2
50 3667244 Assy,Hyd. Hose 1
51 3660240 Wdmt,Bushing Plate 1
52 3667521 Plate 1
53 610718C8 Capsc, M12-P1.75-160MM PL5 4
54 00772648 Nut Metric 12MM-P1.75 Gr.10.9 25
55 3668433 Collar,Hose 2
22-1-18
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1631
REAR SECTION
RIGHT SIDE
LEFT SIDE
22-1-19
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1631
REAR SECTION
REF. PART
NO. NO. DESCRIPTION QTY.1 3660200 Wdmt,Outer Crosspiece 12 3668425 Nut,Self Locking Ring M30 X1.5 23 3690219 Wdmt,Sliding Support 44 3667584 Plate,Drawbar Counter 15 3660119 Assy,Ratchet Link 16 3667594 Plate,Cylinder Support 1
8 3667557 Plate,Sliding Spacer 89 3667552 Plate,Sliding 410 3637521 Wheel Fork Bushing 12
11 3668400 Washer 2
12 3660247 Wdmt,Pin 213 3660248 Wdmt,RH Rear Wheel Support 1
14 3660249 Wdmt,LH Rear Wheel Support 1
15 3690277 Wdmt,LH 2-Whl Section 1
16 3690276 Wdmt,RH 2-Whl Section 1
17 3660106 Assy,Hub 2
18 3667504 Spindle,Weld-On 2
19 3666800 Seal 2
20 3666000 Bearing,Inner 2
21 3667505 Hub,Wheel 2
22 3666001 Bearing,Outer 2
23 3668408 Nut,Spindle 2
24 70487 Cotter Pin, M4x40 2
25 3666700 Cap,Hub 2
26 3660107 Assy,Hub & Spindle 2
27 3667567 Bushing 6
28 3667568 Tube,Main Lift 2
29 3667569 Clamp,Chain Bushing 16
30 3637422 Extension Arm Spring 16
31 3660209 Wdmt,LH Wheel Arm 7
32 3630226 Wdmt,RH Wheel Arm 7
33 3637509 Weld-On Spindle 16
34 3736800 Seal, 25 X 52.. 16
35 3736000 Inner Tapered Bearing Set 16
36 3637504 Wheel Hub 16
37 3736001 Outer Tapered Bearing Set 4
38 700728C Nut, Low Hex Castle M18x1.5 4
39 70477 Cotter Pin, M3.2x32 4
40 3736700 Hub Cap 4
41 3630100 Assy,Hub & Spindle 4
42 3637520 Arm Bushing 8
43 3667585 Pin 244 3638403 Washer 16
45 703516W Roll Pin, M8 X 50 16
46 3630102 Assy,LH Wheel 7
47 3630101 Assy,RH Wheel 7
48 70631C4 Carr Bolt, M10x1.5x25 Gr.4.6 280
49 3637508 Tine Clamp 160
50 3737507 Tine,7MM Dia 640
51 3637506 Rim 16
52 3637505 Flange 16
53 00765676 Nut Metric 10MM Self-Locking 320
54 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 128
55 00755954 Lockwasher M10 104
56 00755949 Nut Metric 10MM-P1.5 Pl 100
57 3638406 Nut, Spherical Cap Hex M16x1.5 20
58 3630103 Assy,Tire & Wheel 6
59 3637800 Tire, 205/75 SR15 660 3637600 Rim-15 6
REF. PARTNO. NO. DESCRIPTION QTY.61 3667421 Spring 262 3667509 Rod,Tie 263 3660382 Wdmt,Pin 264 3660391 Wdmt,RH Support 165 3660383 Wdmt,LH Support 166 3637523 Cylinder Pin 467 3668409 Fitting,Grease M6 X 1 45dg 3268 3697110 Cylinder,Hydraulic 269 70502 Cotter Pin, M6.3x36 870 2568408 Grease Zerk, M8 1671 3638400 Hairpin Cotter, M3 272 61056C8 Capsc, Hex M8x1.25x60 Gr.8.8 28
73 70093C Nut, Toplock M8x1.25 28
74 9313087 Capsc, M16-P2.0 - 40MM Gr.8.8 64
75 3038445 Nut,Toplock Metric 16-P2.0 Pl5 84
76 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 18
77 3668405 Washer,Flat 12 X 40 X 4 14
78 3667586 Plate,Sliding 1
79 71554C8 Fscs Metric 8-P1.25 - 16MM 32
80 3667587 Plate,Linking 481 6W235 Capsc, M22 X 2.5 X 50 Gr.10.9 2
82 2558466 Capsc, M16 X 50 6
83 3668407 Washer,Flat 12 X 36 X 2.5 4
84 610915C8 Capsc, M16-P2 160MM Pl5 8
85 701618C Lockwasher, M22 2
86 3660213 Wdmt,RH Inner Crosspiece 1
87 3660214 Wdmt,LH Inner Crosspiece 1
88 3660215 Wdmt,Pin 2
89 3668414 Stud,Wheel Hub 10
90 3660122 Assy,Tie Rod - Complete 2
91 3690220 Wdmt,Tie Rod Tube 2
92 3668625 End,Tie Rod Head 2
93 701512C Flatwasher, M10 8
94 3690221 Wdmt,Tie Rod Pin 2
95 6W238 Nut, Hex M22 X 2.5 2
96 700219C Nut, High Hex M12x1.75 2
97 3660216 Wdmt,Handle 2
98 3668601 Knob 2
99 708119C8 Shcs Metric 12 P1.75 100MM Gr.8.8 2
100 3660100 Assy,Handle 2
101 700139C Nut,Low Hex M30 X 3.5 4
102 3660313 Wdmt,LH 2-Whl Section 1
103 3667199 Cylinder,Hydraulic 2
104 3660232 Wdmt,Pin 2
105 3668415 Yoke,Clevis-Complete 16
106 613510C8 Capsc, Hex M8x1.25x30 Gr.8.8-Ft 4
107 701611C Lockwasher, M8 4
108 3660316 Wdmt,LH Reinforcement Tube 1
109 3660315 Wdmt,RH Reinforcement Tube 1
110 70096C Nut, Toplock M14x2 24
111 3660314 Wdmt,RH 2-Whl Section 1
112 61081C8 Capsc, M14-P2.0 - 45MM Gr.8.8 16
113 3660394 Wdmt,Drawbar 1114 3660395 Wdmt,RH 2-Whl Section 1
115 3667573 Tube,Lift 2
116 001465 Grease Fitting,Straight,M6 2117 3667424 Spring 1
3660420 Kit,Ratchet Link - Complete 1
118 70093C Nut, Top Lock M8x1.25 Hex 4
119 61057C8 Capsc, M8-P1.25 X 65MM Pl5 4
22-1-20
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1631
FRONT SECTION
RIGHT SIDE
LEFT SIDE
22-1-21
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1631
FRONT SECTION
REF. PART
NO. NO. DESCRIPTION QTY.
1 3660399 Wdmt,RH 1-Whl Section 1
2 3690200 Wdmt,LH 1-Whl Section 1
3 3660397 Wdmt,RH 3-Whl Section 1
4 3660398 Wdmt,LH 3-Whl Section 1
5 3667570 Tube,Center Lift 4
6 3667575 Tube,Front Lift 2
7 3668415 Yoke,Clevis-Complete 20
8 3667567 Bushing 8
9 703611W Pin,Roll 10MM X 32MM 2
10 3660329 Wdmt,RH Support Tube 1
11 3660330 Wdmt,LH Support Tube 1
12 3637521 Wheel Fork Bushing 12
13 3667516 Plate,Brake Counter 4
14 3630229 Clutch Bushing Weldment 4
15 3660223 Wdmt,Brake 4
16 3637423 Compression Spring 4
17 3660224 Wdmt,Front Wheel Support 4
18 3660225 Wdmt,Pin 4
19 3636003 Bearing,Ball Two Rubber Seals 8
20 3637526 Wheel Spacer 4
21 3637527 Wheel Hub 4
22 3638409 Washer 4
23 700910C Nut,Toplock M22x2.5 4
24 3660108 Assy,Hub 4
25 3667517 Spacer 8
26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 20
27 3638406 Nut, Spherical Cap Hex M16x1.5 20
28 3637800 Tire, 205/75 SR15 6
29 3637600 Rim-15 6
30 3630103 Assy,Tire & Wheel 6
31 3660267 Wdmt,Tractor Hitch 1
32 3660235 Wdmt,Hitch Pin 1
33 3668624 Stand,Parking 1
34 3638602 Frame Pin 1
35 3667519 Bushing 4
36 3660236 Wdmt,Inner Arm 2
37 3660237 Wdmt,Outer Arm 2
REF. PART
NO. NO. DESCRIPTION QTY.
38 3660238 Wdmt,Pin 6
39 3637520 Arm Bushing 40
40 3660252 Wdmt,Front Drawbar 1
41 3660227 Wdmt.Center Drawbar 1
42 3630226 Wdmt,RH Wheel Arm 8
43 3660209 Wdmt,LH Wheel Arm 8
44 3638403 Washer 36
45 3668407 Washer,Flat 12 X 36 X 2.5 7
46 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 18
47 3638400 Hairpin Cotter, M3 13
48 00772648 Nut Metric 12MM-P1.75 Gr.8.8 39
49 61075C8 Capsc, M12-P1.75-60MM Gr.8.8 1
50 3630101 Assy,RH Wheel 8
51 3630102 Assy,LH Wheel 8
52 3667569 Clamp,Chain Bushing 16
53 3668401 Washer 4
54 610711C8 Capsc, M12 P1.75 90MM Gr.8.8 4
55 61056C8 Capsc, Hex M8x1.25x60 Gr.8.8 36
56 00755934 Nut Met 8MM-P1.25 34
57 00765901 Capsc, M16-P2.0 - 45MM Gr.8.8 64
58 3038445 Nut,Toplock Metric 16-P2.0 PL5 82
59 3668409 Fitting,Grease M6 X 1 45dg 32
60 00756934 Pin,Roll 10 X 80 4
61 2568408 Grease Zerk, M8 16
62 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 136
63 00755954 Lockwasher M10 92
64 00755949 Nut Metric 10MM-P1.5 Pl 88
65 703516W Pin,Roll 22
66 3637422 Extension Arm Spring 16
67 3660326 Wdmt,Brake Counter Plate 4
68 3690202 Wdmt,RH Front Tube Support 1
69 3690203 Wdmt,LH Front Tube Support 1
70 3667576 Bushing 2
71 3667577 Plug 1
72 61364C8 Capsc, Hex M10x1.5x16 Gr.8.8-Ft 4
74 701512C Flatwasher, M10 4
77 00775032 Grease Fitting, 8MMx1x45 4
22-1-22
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1631
CENTER SECTION
RIGHT SIDE
LEFT SIDE
22-1-23
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1631
CENTER SECTION
REF. PART
NO. NO. DESCRIPTION QTY.
1 3660397 Wdmt,RH 3-Whl Section 1
2 3660398 Wdmt,LH 3-Whl Section 1
3 3660399 Wdmt,RH 1-Whl Section 1
4 3690200 Wdmt,LH 1-Whl Section 1
5 3667570 Tube,Center Lift 2
6 3667575 Tube,Front Lift 2
7 3667199 Cylinder,Hydraulic 2
8 3667567 Bushing 6
9 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 24
10 3668430 Ring,External Snap 32
11 3668431 Ring,Internal Elastic 32
12 3637521 Wheel Fork Bushing 12
13 3667516 Plate,Brake Counter 4
14 3630229 Clutch Bushing Weldment 4
15 3660223 Wdmt,Brake 4
16 3637423 Compression Spring 4
17 3660224 Wdmt,Front Wheel Support 4
18 3660225 Wdmt,Pin 4
19 3636003 Bearing,Ball Two Rubber Seals 8
20 3637526 Wheel Spacer 4
21 3637527 Wheel Hub 4
22 3638409 Washer 4
23 700910C Nut, Toplock M22x2.5 Hex 4
24 3660108 Assy,Hub 4
25 3667517 Spacer 8
26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 20
27 3638406 Nut, Spherical Cap Hex, M16x1.5 20
28 3637800 Tire, 205/75 SR15 6
29 3637600 Rim-15 6
30 3630103 Assy,Tire & Wheel 6
31 3660267 Wdmt,Tractor Hitch 1
32 3660235 Wdmt,Hitch Pin 1
33 3668624 Stand,Parking 1
34 3638602 Frame Pin 1
35 3667519 Bushing 2
36 3660236 Wdmt,Inner Arm 2
37 3660237 Wdmt,Outer Arm 2
REF. PART
NO. NO. DESCRIPTION QTY.
38 3660238 Wdmt,Pin 6
39 3666776 Bushing,Nylon 32
40 3660252 Wdmt,Front Drawbar 1
41 3660227 Wdmt.Center Drawbar 1
42 3660322 Wdmt,RH Fixed Arm 1
43 3660323 Wdmt,LH Fixed Arm 1
44 3667518 Plate 6
45 3668407 Washer,Flat 12 X 36 X 2.5 6
46 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 18
47 3638400 Hairpin Cotter, M3 13
48 00772648 Nut Metric 12MM-P1.75 Gr.8.8 39
49 61075C8 Capsc, M12-P1.75-60MM Gr.8.8 1
50 3660231 Wdmt,Pin 2
51 3668405 Washer,Flat 12 X 40 X 4 14
52 3667572 Bushing 16
53 3668401 Washer 4
54 610711C8 Capsc, M12 P1.75 90MM Gr.8.8 4
55 61056C8 Capsc, Hex M8x1.25x60 Gr.8.8 28
56 00755934 Nut Met 8MM-P1.25 28
57 00765901 Capsc, M16-P2.0 - 45MM Gr.8.8 64
58 3038445 Nut,Toplock Metric 16-P2.0 PL5 84
59 3668409 Fitting,Grease M6 X 1 45dg 32
60 00756934 Pin,Roll 10 X 80 4
61 2568408 Grease Zerk, M8 16
62 3660324 Wdmt,RH Reinforcement Tube 1
63 610817C8 Capsc, M14-P2.0 -160MM Gr.8.8 8
64 610714C8 Capsc, Hex M12x1.75x120 Gr.8.8 6
65 3660394 Wdmt,Drawbar 1
66 3660325 Wdmt,LH Reinforcement Tube 1
67 3660396 Wdmt,LH 2-Whl Section 1
68 61081C8 Capsc, M14-P2.0 - 45MM PL5 16
69 70096C Nut, Toplock M14x2 24
70 00755940 Washer M14 8
71 3690201 Wdmt,Reinforcement 2
72 3660326 Wdmt,Brake Counter Plate 4
73 3667577 Plug 1
74 00775032 Grease Fitting, 8MMx1x45 4
22-1-25
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1631
HYDRAULIC KIT
REF. PART
NO. NO. DESCRIPTION QTY.
1 3637102 Male Coupling Tip 3
2 3638408 Copper Washer, 1/2 ID 3
3 3667245 Assy,Hose 1
4 3667246 Assy,Hose 1
5 3667208 Assy,Hose 1
6 3668402 Collar,Double Hose 1
7 3668403 Collar,Hose 9
8 3668404 Collar,Hose 9
9 3667199 Cylinder,Hydraulic 2
10 3638404 Copper Washer, 17 X 22 X 1.4 23
11 3637100 Hydraulic Fitting 6
12 3667125 Line,Hydraulic 2
13 3697114 Fitting,Hydraulic Line 4
14 3667109 Valve,Lock 2
15 613313C8 Capsc, M6-P1-40MM Gr.8.8 5
16 70092C Nut Met Tln M6-P1 PL5 5
17 3667103 Line,Hydraulic 2
18 3667105 Fitting,Hydraulic 6
19 3667203 Assy,Hose 2
20 3667204 Assy,Hose 2
21 3667106 Fitting,Hydraulic 2
22 3667107 Fitting,Hydraulic Tee 1
23 3667110 Divider,Flow 1
24 3660246 Wdmt,Plate 1
25 613317C8 Capsc, M6-P1 -60MM Gr.8.8 2
26 3667108 Fitting,Hydraulic Tee 1
27 3667205 Assy,Hose 2
28 3697110 Cylinder,Hydraulic 2
29 3667111 Rod,Cylinder 2
30 3667112 Tube,Cylinder 2
31 3667113 Head,Cylinder 2
32 3667114 Piston,Cylinder 2
33 3667115 Nut,Cylinder 2
34 -------- Seal 2
35 -------- O-Ring 2
36 -------- Seal 2
37 3667116 Kit,Seal 2
38 3667180 Rod,Cylinder 2
39 3667181 Tube,Cylinder 2
40 3667182 Head,Cylinder 2
41 3667183 Spacer,Cylinder 2
42 3667184 Piston,Cylinder 2
43 3667185 Locknut,Cylinder 2
44 -------- Seal 2
45 -------- Seal 2
46 -------- O - Ring 2
47 -------- O - Ring 2
48 -------- Seal 2
49 3667186 Kit,Seal 2
50 3667244 Assy,Hyd. Hose 1
51 3660240 Wdmt,Bushing Plate 1
52 3667521 Plate 1
53 610718C8 Capsc, M12-P1.75-160MM PL5 4
54 00772648 Nut Metric 12MM-P1.75 Gr.10.9 39
55 3668433 Collar,Hose 2
22-1-26
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1428, DFWR1631
ARTICULATION
RIGHT SIDE
LEFT SIDE
22-1-27
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1428, DFWR1631
ARTICULATION
REF. PART
NO. NO. DESCRIPTION QTY.
1 3660252 Wdmt,Front Drawbar 1
2 3660227 Wdmt.Center Drawbar 1
3 3660393 Wdmt,Rear Drawbar 1
4 3660322 Wdmt,RH Fixed Arm 1
5 3660323 Wdmt,LH Fixed Arm 1
6 3667518 Plate 6
7 3610401 Kit,Hydraulic Cylinder 2
8 3660231 Wdmt,Pin 2
9 3660232 Wdmt,Pin 2
10 3668405 Washer,Flat 12 X 40 X 4 2
11 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 4
12 2568408 Grease Zerk, M8 6
13 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 24
14 00772648 Nut Metric 12MM-P1.75 Gr.8.8 34
15 9313087 Capsc, M16-P2.0 - 40MM PL5 24
16 3038445 Nut,Toplock Metric 16-P2.0 Gr.8.8 24
17 3660394 Wdmt,Drawbar 1
18 3660255 Wdmt,RH Reinforcement Tube 1
19 3660256 Wdmt,LH Reinforcement Tube 1
20 701613C Lockwasher, M12 8
21 00762462 Capsc, M12-P1.75- 25MM PL5 8
22 61379C8 Capsc, Hex M12x1.75x40 Gr.8.8-Ft 8
23 3668407 Washer,Flat 12 X 36 X 2.5 2
24 3637423 Compression Spring 2
25 3660223 Wdmt,Brake 2
26 3630229 Clutch Bushing Weldment 2
27 3667516 Plate,Brake Counter 2
28 00756934 Pin, Roll 10 X 80 2
29 610711C8 Capsc, M12 P1.75 90MM PL5 2
30 3637521 Wheel Fork Bushing 4
31 3660257 Wdmt,Support Tube 2
32 3668401 Washer 2
33 3660224 Wdmt,Front Wheel Support 2
34 3667517 Spacer 4
35 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 10
36 3638406 Nut, Spherical Cap Hex, M16x1.5 10
37 3660225 Wdmt,Pin 2
38 3636003 Bearing,Ball Two Rubber Seals 4
39 3637526 Wheel Spacer 2
40 3637527 Wheel Hub 2
41 3638409 Washer 2
42 700910C Nut, Toplock M22x2.5 Hex 2
43 3660108 Assy,Hub 2
44 3637600 Rim-15 2
45 3637800 Tire, 205/75 SR15 2
46 3630103 Assy,Tire & Wheel 2
47 3660395 Wdmt,RH 2-Whl Section 1
48 3660259 Wdmt,LH 2-Whl Section 1
22-1-28
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1428, DFWR1631
WHEEL & ARM ASSEMBLY
22-1-29
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1428, DFWR1631
WHEEL & ARM ASSEMBLY
REF. PART
NO. NO. DESCRIPTION QTY.
1 3660395 Wdmt,RH 2-Whl Section 1
2 3660259 Wdmt,LH 2-Whl Section 1
3 3660260 Wdmt,RH Reinforcement Tube 1
4 3660261 Wdmt,LH Reinforcement Tube 1
5 2568408 Grease Zerk, M8 2
6 3667524 Tube,Lift 2
7 3667506 Bushing 2
8 3667508 Clamp,Chain Bushing 4
9 3637422 Extension Arm Spring 4
10 3668409 Fitting,Grease M6 X 1 45dg 4
11 3637520 Arm Bushing 8
12 3638403 Washer 4
13 703516W Roll Pin, M8 X 50 4
14 3637509 Weld-On Spindle 4
15 3736800 Seal, 25 X 52.. 4
16 3736000 Inner Tapered Bearing Set 4
17 3637504 Wheel Hub 4
18 3736001 Outer Tapered Bearing Set 4
19 700728C Nut, Low Hex Castle M18x1.5 4
20 70477 Cotter Pin, M3.2x32 4
21 3736700 Hub Cap 4
22 3630100 Assy,Hub & Spindle 4
23 3660209 Wdmt,LH Wheel Arm 2
24 3630226 Wdmt,RH Wheel Arm 2
25 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 28
26 00755954 Lockwasher M10 24
27 00755949 Nut Metric 10MM-P1.5 PL 24
28 70631C4 Carr Bolt, M10x1.5x25 Gr.4.6 80
29 3637508 Tine Clamp 40
30 3737507 Tine, 7MM Dia. 160
31 3637506 Rim 4
32 3637505 Flange 4
33 00765676 Nut Metric 10MM Self-Locking 80
34 3630102 Assy,LH Wheel 2
35 3630101 Assy,RH Wheel 2
36 61054C8 Capsc, Hex M8x1.25x50 Gr.8.8 8
37 70093C Nut, Toplock M8x1.25 8
38 61379C8 Capsc, Hex M12x1.75x40 Gr.8.8-Ft 16
39 00772648 Nut Metric 12MM-P1.75 Gr.10.9 16
40 3638400 Hairpin Cotter, M3 4
41 9313087 Capsc, M16-P2.0 - 40MM Gr.8.8 8
42 3038445 Nut,Toplock Metric 16-P2.0 PL5 8
22-1-30
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1833
REAR SECTION
RIGHT SIDE
LEFT SIDE
22-1-31
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1833
REAR SECTION
REF. PART
NO. NO. DESCRIPTION QTY.1 3660200 Wdmt,Outer Crosspiece 12 3668425 Nut,Self Locking Ring M30 X1.5 23 3667501 Bar, Angle 44 3667584 Plate,Drawbar Counter 15 3660119 Assy,Ratchet Link 16 3667594 Plate,Cylinder Support 1
8 3667557 Plate,Sliding Spacer 89 3667552 Plate,Sliding 410 3637521 Wheel Fork Bushing 12
11 3668400 Washer 2
12 3660247 Wdmt,Pin 213 3660248 Wdmt,RH Rear Wheel Support 1
14 3660249 Wdmt,LH Rear Wheel Support 1
15 3690277 Wdmt,LH 2-Whl Section 1
16 3690276 Wdmt,RH 2-Whl Section 1
17 3660106 Assy,Hub 2
18 3667504 Spindle,Weld-On 2
19 3666800 Seal 2
20 3666000 Bearing,Inner 2
21 3667505 Hub,Wheel 2
22 3666001 Bearing,Outer 2
23 3668408 Nut,Spindle 2
24 70487 Cotter Pin, M4x40 2
25 3666700 Cap,Hub 2
26 3660107 Assy,Hub & Spindle 2
27 3667567 Bushing 4
28 3667568 Tube,Main Lift 2
29 3667569 Clamp,Chain Bushing 18
30 3637422 Extension Arm Spring 18
31 3660209 Wdmt,LH Wheel Arm 9
32 3630226 Wdmt,RH Wheel Arm 9
33 3637509 Weld-On Spindle 18
34 3736800 Seal, 25 X 52.. 18
35 3736000 Inner Tapered Bearing Set 18
36 3637504 Wheel Hub 18
37 3736001 Outer Tapered Bearing Set 18
38 700728C Nut, Low Hex Castle M18x1.5 18
39 70477 Cotter Pin, M3.2x32 18
40 3736700 Hub Cap 18
41 3630100 Assy,Hub & Spindle 18
42 3637520 Arm Bushing 36
43 3667585 Pin 244 3638403 Washer 36
45 703516W Roll Pin, M8 X 50 18
46 3630102 Assy,LH Wheel 9
47 3630101 Assy,RH Wheel 9
48 70631C4 Carr Bolt, M10x1.5x25 Gr.4.6 360
49 3637508 Tine Clamp 180
50 3737507 Tine,7MM Dia 720
51 3637506 Rim 18
52 3637505 Flange 18
53 00765676 Nut Metric 10MM Self-Locking 360
54 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 134
55 00755954 Lockwasher M10 104
56 00755949 Nut Metric 10MM-P1.5 Pl 100
57 3638406 Nut, Spherical Cap Hex M16x1.5 30
58 3630103 Assy,Tire & Wheel 6
59 3637800 Tire, 205/75 SR15 660 3637600 Rim-15 6
REF. PARTNO. NO. DESCRIPTION QTY.61 3667421 Spring 262 3667509 Rod,Tie 263 3660382 Wdmt,Pin 264 3660391 Wdmt,RH Support 165 3660383 Wdmt,LH Support 166 3637523 Cylinder Pin 467 3668409 Fitting,Grease M6 X 1 45dg 3668 3697110 Cylinder,Hydraulic 269 70502 Cotter Pin, M6.3x36 870 2568408 Grease Zerk, M8 1671 3638400 Hairpin Cotter, M3 1372 61056C8 Capsc, Hex M8x1.25x60 Gr.8.8 28
73 70093C Nut, Toplock M8x1.25 30
74 00765901 Capsc, M16-P2.0 - 45MM Gr.8.8 56
75 3038445 Nut,Toplock Metric 16-P2.0 Pl5 78
76 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 18
77 3668405 Washer,Flat 12 X 40 X 4 14
78 3667586 Plate,Sliding 8
79 71554C8 Fscs Metric 8-P1.25 - 16MM 32
80 3667587 Plate,Linking 481 6W235 Capsc, M22 X 2.5 X 50 Gr.10.9 2
82 2558466 Capsc, M16 X 50 6
83 3668407 Washer,Flat 12 X 36 X 2.5 2
84 610915C8 Capsc, M16-P2 160MM Pl5 16
85 701618C Lockwasher, M22 2
86 3660213 Wdmt,RH Inner Crosspiece 1
87 3660214 Wdmt,LH Inner Crosspiece 1
88 3660215 Wdmt,Pin 2
89 3668414 Stud,Wheel Hub 10
90 3660122 Assy,Tie Rod - Complete 2
91 3690220 Wdmt,Tie Rod Tube 2
92 3668625 End,Tie Rod Head 2
93 701512C Flatwasher, M10 8
94 3690221 Wdmt,Tie Rod Pin 2
95 6W238 Nut, Hex M22 X 2.5 2
96 700219C Nut, High Hex M12x1.75 2
97 3660216 Wdmt,Handle 2
98 3668601 Knob 2
99 708119C8 Shcs Metric 12 P1.75 100MM Gr.8.8 2
100 3660100 Assy,Handle 2
101 700139C Nut,Low Hex M30 X 3.5 2
102 3660393 Wdmt,Rear Drawbar 1
103 3667199 Cylinder,Hydraulic 2
104 3660232 Wdmt,Pin 2
105 3668415 Yoke,Clevis-Complete 18
106 613510C8 Capsc, Hex M8x1.25x30 Gr.8.8-Ft 4
107 701611C Lockwasher, M8 4
108 3660316 Wdmt,LH Reinforcement Tube 1
109 3660315 Wdmt,RH Reinforcement Tube 1
110 70096C Nut, Toplock M14x2 24
111 3660396 Wdmt,LH 2-Whl Section 1
112 61081C8 Capsc, M14-P2.0 - 45MM Gr.8.8 16
113 3660394 Wdmt,Drawbar 28114 3660395 Wdmt,RH 2-Whl Section 1
115 3667573 Tube,Lift 4
116 001465 Grease Fitting,Straight,M6 2117 3667424 Spring 1
3660420 Kit,Ratchet Link - Complete 1
118 70093C Nut, Top Lock M8x1.25 Hex 4
119 61057C8 Capsc, M8-P1.25 X 65MM Pl5 4
22-1-32
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1833
FRONT SECTION
RIGHT SIDE
LEFT SIDE
22-1-33
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1833
FRONT SECTION
REF. PART
NO. NO. DESCRIPTION QTY.
3 3690204 Wdmt,RH 2-Whl Section 1
4 3690205 Wdmt,LH 2-Whl Section 1
5 3667524 Tube,Lift 4
6 3667574 Tube,Front Lift 2
7 3668415 Yoke,Clevis-Complete 18
8 3667567 Bushing 6
9 3667533 Bushing 2
10 3660329 Wdmt,RH Support Tube 1
11 3660330 Wdmt,LH Support Tube 1
12 3637521 Wheel Fork Bushing 12
13 3667516 Plate,Brake Counter 4
14 3630229 Clutch Bushing Weldment 4
15 3660223 Wdmt,Brake 4
16 3637423 Compression Spring 4
17 3660224 Wdmt,Front Wheel Support 4
18 3660225 Wdmt,Pin 4
19 3636003 Bearing,Ball Two Rubber Seals 8
20 3637526 Wheel Spacer 4
21 3637527 Wheel Hub 4
22 3638409 Washer 4
23 700910C Nut, Toplock M22x2.5 4
24 3660108 Assy,Hub 4
25 3667517 Spacer 8
26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 20
27 3638406 Nut, Spherical Cap Hex, M16x1.5 20
28 3637800 Tire, 205/75 SR15 6
29 3637600 Rim-15 6
30 3630103 Assy,Tire & Wheel 6
31 3660267 Wdmt,Tractor Hitch 1
32 3660235 Wdmt,Hitch Pin 1
33 3668624 Stand,Parking 1
34 3638602 Frame Pin 1
35 3667519 Bushing 4
36 3660236 Wdmt,Inner Arm 2
37 3660237 Wdmt,Outer Arm 2
38 3660238 Wdmt,Pin 6
39 3637520 Arm Bushing 36
40 3660252 Wdmt,Front Drawbar 1
41 3660227 Wdmt.Center Drawbar 1
REF. PART
NO. NO. DESCRIPTION QTY.
42 3630226 Wdmt,RH Wheel Arm 18
43 3660209 Wdmt,LH Wheel Arm 18
44 3638403 Washer 36
45 3668407 Washer,Flat 12 X 36 X 2.5 7
46 00762395 Capsc, M12-P1.75- 20MM Gr.8.8 18
47 3638400 Hairpin Cotter, M3 13
48 00772648 Nut Metric 12MM-P1.75 Gr.8.8 45
49 61075C8 Capsc, M12-P1.75-60MM Gr.8.8 1
50 3630101 Assy,RH Wheel 9
51 3630102 Assy,LH Wheel 9
52 3667569 Clamp,Chain Bushing 18
53 3668401 Washer 4
54 610711C8 Capsc, M12 P1.75 90MM Gr.8.8 4
55 61056C8 Capsc, Hex M8x1.25x60 Gr.8.8 28
56 70093C Nut,Toplock M8x1.25 Hex 30
57 00765901 Capsc, M16-P2.0 - 45MM PL5 56
58 3038445 Nut,Toplock Metric 16-P2.0 Gr.8.8 76
59 3668409 Fitting,Grease M6 X 1 45dg 36
60 00756934 Pin,Roll 10 X 80 2
61 2568408 Grease Zerk, M8 16
62 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 142
63 00755954 Lockwasher M10 104
64 00755949 Nut Metric 10MM-P1.5 PL 100
65 703516W Roll Pin, M8 X 50 22
66 3637422 Extension Arm Spring 18
67 3660326 Wdmt,Brake Counter Plate 4
68 61097C8 Capsc, Hex M16x2x80 Gr.8.8 2
69 3690208 Wdmt,Extension 2
70 3667578 Bushing 2
71 3667577 Plug 1
72 3690202 Wdmt,RH Front Tube Support 1
73 3690203 Wdmt,LH Front Tube Support 1
74 61364C8 Capsc, Hex M10x1.5x16 Gr.8.8-Ft 4
75 61053C10 Capsc, Hex M8x1.25x45 Gr.10.9 2
76 701512C Flatwasher, M10 4
77 00775032 Grease Fitting, 8MMx1x45 4
78 3690207 Wdmt,Reinforcement 2
79 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 32
80 3667518 Plate 4
22-1-34
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1833
CENTER SECTION
RIGHT SIDE
LEFT SIDE
22-1-35
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1833
CENTER SECTION
REF. PART
NO. NO. DESCRIPTION QTY.
1 3660397 Wdmt,RH 3-Whl Section 1
2 3660398 Wdmt,LH 3-Whl Section 1
3 3690204 Wdmt,RH 2-Whl Section 1
4 3690205 Wdmt,LH 2-Whl Section 1
5 3667570 Tube,Center Lift 2
6 3667573 Tube,Lift 4
7 3667199 Cylinder,Hydraulic 2
8 3667567 Bushing 6
9 610716C8 Capsc, M12-P1.75-140MM PL5 32
10 3630226 Wdmt,RH Wheel Arm 9
11 3660209 Wdmt,LH Wheel Arm 9
12 3637521 Wheel Fork Bushing 12
13 3667516 Plate,Brake Counter 4
14 3630229 Clutch Bushing Weldment 4
15 3660223 Wdmt,Brake 4
16 3637423 Compression Spring 4
17 3660224 Wdmt,Front Wheel Support 4
18 3660225 Wdmt,Pin 4
19 3636003 Bearing,Ball Two Rubber Seals 8
20 3637526 Wheel Spacer 4
21 3637527 Wheel Hub 4
22 3638409 Washer 4
23 700910C Nut, Toplock M22x2.5 4
24 3660108 Assy,Hub 4
25 3667517 Spacer 8
26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 20
27 3638406 Nut, Spherical Cap Hex, M16x1.5 20
28 3637800 Tire, 205/75 SR15 6
29 3637600 Rim-15 6
30 3630103 Assy,Tire & Wheel 6
31 3660227 Wdmt.Center Drawbar 1
32 3630101 Assy,RH Wheel 9
33 3630102 Assy,LH Wheel 9
34 3637422 Extension Arm Spring 18
35 3668415 Yoke,Clevis-Complete 18
36 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 142
37 00755954 Lockwasher M10 104
38 00755949 Nut Metric 10MM-P1.5 PL 100
39 3667569 Clamp,Chain Bushing 18
REF. PART
NO. NO. DESCRIPTION QTY.
40 3660252 Wdmt,Front Drawbar 1
41 3690206 Wdmt,Drawbar 1
42 3660322 Wdmt,RH Fixed Arm 1
43 3660323 Wdmt,LH Fixed Arm 1
44 3667518 Plate 4
45 3668407 Washer,Flat 12 X 36 X 2.5 7
46 00762395 Capsc, M12-P1.75- 20MM PL5 18
47 3638400 Hairpin Cotter, M3 13
48 00772648 Nut Metric 12MM-P1.75 Gr.8.8 45
49 00765672 Capsc, M14-P2.0-35MM Gr.8.8 8
50 3660231 Wdmt,Pin 2
51 3668405 Washer,Flat 12 X 40 X 4 2
52 3637520 Arm Bushing 36
53 3668401 Washer 4
54 610711C8 Capsc, M12 P1.75 90MM Gr.8.8 4
55 61056C8 Capsc, Hex M8x1.25x60 Gr.8.8 28
56 70093C Nut, Toplock M8x1.25 Hex 30
57 00765901 Capsc, M16-P2.0 - 45MM Gr.8.8 56
58 3038445 Nut,Toplock Metric 16-P2.0 PL5 78
59 3668409 Fitting,Grease M6 X 1 45dg 36
60 00756934 Pin,Roll 10 X 80 4
61 2568408 Grease Zerk, M8 16
62 3660324 Wdmt,RH Reinforcement Tube 1
63 3660325 Wdmt,LH Reinforcement Tube 1
64 610714C8 Capsc, Hex M12x1.75x120 Gr.8.8 6
65 3660393 Wdmt,Rear Drawbar 1
66 3660395 Wdmt,RH 2-Whl Section 1
67 3660396 Wdmt,LH 2-Whl Section 1
68 61081C8 Capsc, M14-P2.0 - 45MM PL5 16
69 70096C Nut, Toplock M14x2 Hex 24
70 00755940 Washer M14 8
71 3638403 Washer 36
72 703516W Roll Pin, M8 X 50 22
73 3660326 Wdmt,Brake Counter Plate 2
74 3668430 Ring,External Snap 36
75 3668431 Ring,Internal Elastic 36
76 3666776 Bushing,Nylon 36
77 3667572 Bushing 18
78 3690207 Wdmt,Reinforcement 2
79 00775032 Grease Fitting, 8MMx1x45 4
22-1-37
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODEL DFWR1833
HYDRAULIC KIT
REF. PART
NO. NO. DESCRIPTION QTY.
1 3637102 Male Coupling Tip 3
2 3638408 Copper Washer, 1/2 ID 3
3 3667225 Assy,Hose 1
4 3667226 Assy,Hose 1
5 3667221 Assy,Hose 1
6 3668402 Collar,Double Hose 1
7 3668403 Collar,Hose 10
8 3668404 Collar,Hose 11
9 3667199 Cylinder,Hydraulic 2
10 3638404 Copper Washer, 17 X 22 X 1.4 23
11 3637100 Hydraulic Fitting 6
12 3667125 Line,Hydraulic 2
13 3697114 Fitting,Hydraulic Line 4
14 3667109 Valve,Lock 2
15 613313C8 Capsc, M6-P1-40MM Gr.8.8 2
16 70092C Nut Met Tln M6-P1 PL5 5
17 3667103 Line,Hydraulic 2
18 3667105 Fitting,Hydraulic 6
19 3667203 Assy,Hose 2
20 3667204 Assy,Hose 2
21 3667106 Fitting,Hydraulic 2
22 3667107 Fitting,Hydraulic Tee 1
23 3667110 Divider,Flow 1
24 3660246 Wdmt,Plate 1
25 613317C8 Capsc, M6-P1 -60MM Gr.8.8 2
26 3667108 Fitting,Hydraulic Tee 1
27 3667205 Assy,Hose 2
28 3697110 Cylinder,Hydraulic 2
29 3667111 Rod,Cylinder 2
30 3667112 Tube,Cylinder 2
31 3667113 Head,Cylinder 2
32 3667114 Piston,Cylinder 2
33 3667115 Nut,Cylinder 2
34 -------- Seal 2
35 -------- O-Ring 2
36 -------- Seal 2
37 3667116 Kit,Seal 2
38 3667180 Rod,Cylinder 2
39 3667181 Tube,Cylinder 2
40 3667182 Head,Cylinder 2
41 3667183 Spacer,Cylinder 2
42 3667184 Piston,Cylinder 2
43 3667185 Locknut,Cylinder 2
44 -------- Seal 2
45 -------- Seal 2
46 -------- O - Ring 2
47 -------- O - Ring 2
48 -------- Seal 2
49 3667186 Kit,Seal 2
50 3667227 Assy,Hyd. Hose 1
51 3660240 Wdmt,Bushing Plate 1
52 3667521 Plate 1
53 610718C8 Capsc, M12-P1.75-160MM PL5 4
54 00772648 Nut Metric 12MM-P1.75 Gr.10.9 4
55 3668433 Collar,Hose 2
22-1-38
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1428, DFWR1631, DFWR1833
REAR SECTION HYDRAULIC CYLINDER REPAIR KIT
REF. PART
NO. NO. DESCRIPTION QTY.
3667199 Cylinder,Hydraulic 1
1 3667180 Rod,Cylinder 1
2 3667181 Tube,Cylinder 1
3 3667185 Locknut,Cylinder M30 X 2 1
4 3667184 Piston,Cylinder 2
5 -------- Piston Seal 1
6 -------- Piston O-Ring 1
7 3667183 Spacer,Cylinder 1
8 3667182 Head,Cylinder 1
9 -------- Rod Wiper 1
10 ------- Rod Seal 1
11 ------- Head O-Ring 1
3667186 Kit,Seal 1
22-1-39
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
KIT, HOSE CONVERSION (OPTION)
REF. PART
NO. NO. DESCRIPTION QTY.
1 3638404 Copper Washer, 17 X 22 X 1.4 2
2 3667143 Fitting,Hydraulic 2
3 3667248 Assy,Hyd. Hose 2
4 3668626 Wrap,Hose Tie 10
5 3667108 Fitting,Hydraulic Tee 1
6 3667247 Assy,Hyd. Hose 3600MM - 141 3/4" (DFWR1225) 1
3667244 Assy,Hyd. Hose 6000MM - 238 1/4" (DFWR1428/DFWR1631) 1
3667250 Assy,Hyd. Hose 7720MM - 304" (DFWR1833) 1
7 3667242 Assy,Hyd. Hose 4960MM - 195 1/4" (DFWR1225,DFWR1833) 1
3667230 Assy,Hyd. Hose 5360MM - 211" (DFWR1428/DFWR1631) 1
8 3668424 Collar,Hose (DFWR1225) 12
3668424 Collar,Hose (DFWR1428/DFWR1631) 15
3668424 Collar,Hose (DFWR1833) 20
9 707815C8 Shcs Metric 6P-1.0 - 90MM PL5 (DFWR1225) 12
707815C8 Shcs Metric 6P-1.0 - 90MM PL5 (DFWR1428/DFWR1631) 16
707815C8 Shcs Metric 6P-1.0 - 90MM PL5 (DFWR1833) 20
10 3638408 Copper Washer, 1/2 ID 1
11 3637102 Male Coupling Tip 1
12 3690279 Wdmt,Cylinder Lock 2
13 3697541 Shim,Cylinder Lock - Nylon 4
14 3697542 Shim,Cylinder Lock - Nylon 4
15 3697543 Shim,Cylinder Lock 2
16 00754091 Capsc, M8-P1.25- 70MM 8 2
17 70093C Nut, Toplock M8x1.25 Hex 2
18 613314C8 Capsc, M6-P1 -45MM PL5 2
19 70092C Nut Met Tln M6-P1 PL5 1
22-1-40
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631
HYDRAULIC LIFT CENTER WHEEL KIT (OPTION)
22-1-41
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631
HYDRAULIC LIFT CENTER WHEEL KIT (OPTION)
REF. PART
NO. NO. DESCRIPTION QTY.
1 3668424 Collar,Hose 4
2 707824C8 Shcs Metric 6P-1.0 - 125MM Gr.8.8 4
707815C8 Shcs Metric 6P-1.0 - 60MM Gr.8.8 4
3 3667523 Rim 2
4 00765676 Nut Metric 10MM Self-Locking 40
5 3637505 Flange 2
6 3637508 Tine Clamp 20
7 3667522 Tine,Center Wheel 80
8 70631C4 Carr Bolt, M10x1.5x25 Gr.4.6 40
9 3660103 Assy,LH Wheel 1
10 00755949 Nut Metric 10MM-P1.5 PL 12
11 00755954 Lockwasher M10 12
12 3667599 Block,Wheel Support Hitch 1
13 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 4
14 3667141 Cylinder,Hydraulic Lift 1
15 701513C Flatwasher, M12 12
16 00772648 Nut Metric 12MM-P1.75 Gr.8.8 12
17 3668415 Yoke,Clevis-Complete 6
18 703415W Pin,Roll 6MMx45MM 2
19 701615C Lockwasher, M16 2
20 3668418 U-Bolt 6
21 3660292 Wdmt,Pulley Bracket 1
22 3668614 Pulley 2
23 00772648 Nut Metric 12MM-P1.75 Gr.8.8 2
24 3667529 Bushing 2
25 3668419 Bolt W/Hole M12 X 70 Gr.8.8 2
26 3638400 Hairpin Cotter, M3 2
27 3666252 Chain 2
28 3660109 Assy,Hub 2
29 3736700 Hub Cap 2
30 700728C Nut, Low Hex Castle M18x1.5 2
31 3736001 Outer Tapered Bearing Set 2
32 3637504 Wheel Hub 2
33 3736000 Inner Tapered Bearing Set 2
REF. PART
NO. NO. DESCRIPTION QTY.
34 3736800 Seal, 25 X 52.. 2
35 70477 Cotter Pin, M3.2x32 2
36 3660245 Wdmt,Spindle 2
37 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 12
38 3660293 Wdmt,Arm 1
39 701516C Flatwasher M18 PL 2
40 61107C8 Capsc, M18-P2.5 100MM Gr.8.8 2
41 3660294 Wdmt,Bracket 1
42 70098C Nut, Toplock M18x2.5 Hex 2
43 3637520 Arm Bushing 4
44 61075C8 Capsc, M12-P1.75-60MM Gr.8.8 2
45 700219C Nut, High Hex M12x1.75 2
46 3638403 Washer 2
47 703516W Roll Pin, M8 X 50 2
48 3667422 Spring,Extension 2
49 3667415 Cable,Lift 1
50 3667416 Cable,Lift 1
51 3660295 Wmdt,Arm 1
52 3690209 Wdmt,Bracket 1
53 3660297 Wdmt,Bracket 1
54 3660298 Wdmt,Bracket 1
55 3660299 Wdmt,Pulley Bracket 1
56 3660102 Assy,RH Wheel 1
57 701613C Lockwasher, M12 4
58 3668409 Fitting,Grease M6 X 1 45dg 2
59 3667107 Fitting,Hydraulic Tee 1
60 3667241 Asy,Hyd. Hose 1
61 3667105 Fitting,Hydraulic 1
62 3638404 Copper Washer, 17 X 22 X 1.4 1
63 61377C8 Capsc, Hex M12x1.75x30 Gr.8.8-Ft 2
64 00762462 Capsc, M12-P1.75- 25MM PL5 8
65 3667588 Plate 1
66 3667589 Plate 1
67 708317C8 Shcs Metric 16-P2.0 -110MM Gr.8.8 2
22-1-42
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631
CENTER WHEEL LIFT CYLINDER (OPTION)
REF. PART
NO. NO. DESCRIPTION QTY.
1 3667148 Rod,Cylinder 1
2 3667149 Tube,Cylinder 1
3 3667150 Head,Cylinder 1
4 3667114 Piston,Cylinder 1
5 3667115 Nut,Cylinder M18 X 1.5 1
6 ------ Seal 1
7 ------ Seal 1
8 ------ Seal 1
9 ------ Seal 1
10 ------ Seal 1
11 3667142 Kit,Seal 1
12 3667141 Cylinder,Hydraulic Lift 1
22-1-43
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
REAR HYDRAULIC KIT (OPTION)-(TO OPEN ONE SIDE ONLY)
REF. PART
NO. NO. DESCRIPTION QTY.
5 3637100 Fitting,Hydraulic 4
6 3638404 Copper Washer, 17 X 22 X 1.4 12
8 3667144 Fitting,Hydraulic 2
9 3697109 Fitting,Hydraulic 4
10 3667350 Valve,Ball - Shut Off 4
12 3667593 Plate,Hydraulic Block 1
13 707820C8 Shcs, M6-P1.0 - 90MM 2
14 70092C Nut Met Tln M6-P1 PL5 2
15 3667351 Valve, Ball (Not Shown) 1
22-1-44
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
REAR HYDRAULIC OPENING KIT (OPTION)
22-1-45
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
REAR HYDRAULIC OPENING KIT (OPTION)
REF. PART
NO. NO. DESCRIPTION QTY.
1 3667193 Cylinder,Hydraulic 2
2 3638404 Copper Washer, 17 X 22 X 1.4 21
3 3667169 Line,Hydraulic 4
4 3697114 Fitting,Hydraulic Line 4
5 3667109 Valve,Lock 2
6 3637100 Hydraulic Fitting 6
7 3667170 Tube,Cylinder 1
8 3667171 Rod,Cylinder 2
9 --------- Seal 2
10 -------- O-Ring 2
11 -------- O-Ring 2
12 -------- O-Ring 2
13 -------- Seal 2
14 3667194 Head,Cylinder 2
15 3667195 Piston,Cylinder 2
16 3667196 Locknut Cylinder 2
17 3667197 Kit,Seal 2
18 3667105 Fitting,Hydraulic 5
19 3667236 Assy,Hose (DFWR1225) 2
3667255 Assy,Hose (DFWR1428 & DFWR1631) 2
3667238 Assy,Hose (DFWR1833) 2
20 3668424 Collar,Hose 26
21 707820C8 Shcs Metric 6P-1.0 - 90MM Gr.8.8 14
22 3638408 Copper Washer, 1/2 ID 2
23 3667105 Fitting,Hydraulic 2
24 3667239 Assy,Hose 2
25 3667240 Assy,Hose 2
26 3667108 Fitting,Hydraulic Tee 1
27 3668425 Nut,Self Locking Ring M30 X1.5 1
28 61358C8 Capsc, Hex M8x1.25x25 Gr.8.8-Ft 4
29 701511C Flatwasher, M8 4
30 70092C Nut Met Tln M6-P1 PL5 2
31 3660370 Wdmt,Cylinder Support 1
32 3660371 Wdmt,Hose Support 1
33 3667110 Divider,Flow 1
34 613317C8 Capsc, M6-P1 -60MM Gr.8.8 2
35 70788C8 Shcs Metric 6 X 1.0 X 25 Gr.8.8 2
36 3667578 Bar, Cylinder 1
37 02965816 Capsc, M16-P2.0-70MM Gr.8.8 4
38 3038445 Nut, Toplock M16-P2.0 PL4 4
22-1-46
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
RATCHET LINK ASSEMBLY (STANDARD)
22-1-47
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
RATCHET LINK ASSEMBLY (STANDARD)
REF. PART
NO. NO. DESCRIPTION QTY.
3660120 Assy,Ratchet Link 1
1 3668700 Cover,Lever 1
2 3667558 Lever,Ratchet 1
3 3660372 Wdmt,Ratchet Tube 1
4 3667423 Spring,Hook 1
5 00755934 Nut Met 8MM-P1.25 2
7 70502 Cotter Pin, M6.3x36 4
8 3637523 Cylinder Pin 2
9 3660378 Wdmt,RH Ratchet Screw 1
10 3667559 Ring,Clamp 2
11 3668701 Cover,Shield 2
12 3660375 Wdmt,RH Locking Tab 1
13 3667560 Plate,Lever Support 2
14 3667561 Plate,Locking Hook 1
15 613510C8 Capsc, Hex M8x1.25x30 Gr.8.8-Ft 2
16 3667566 Support,Ratchet Tube 2
17 3666775 Bushing,Nylon 2
18 3667563 Collar,Lock 2
19 70345 Pin,Roll 4
20 70038C Nut,Metric TLE 3
21 3660379 Wdmt,LH Ratchet Screw 1
22 001465 Grease Fitting,Straight,M6 2
23 613510C8 Capsc, Hex M8x1.25x30 Gr.8.8-Ft 2
24 701611C Lockwasher, M8 2
25 61383C8 Capsc, M14-P2.0 - 25MM 4
26 61339C8 Capsc, Hex M6x1x25 Gr.8.8-Ft 1
27 613113C8 Hexb Metric 3
28 3667564 Bushing 3
29 70092C Nut Met TLN M6-P1 PL5 1
30 701614C Lockwasher, M14 4
22-1-48
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
LIGHT KIT
22-1-49
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
LIGHT KIT
REF. PART
NO. NO. DESCRIPTION QTY.
1 9161600 Locknut 1/2 Gr C Cp 8
2 19100BH Capsc, 3/8-16 X 3/4 Gr.5 Zp 4
3 9131200 Locknut 3/8 Grc Cp 4
4 1160806 Capsc, 1/4 X 3/4 G5 Z 2
5 15918BH Flatwasher 1/4 Zp 4
6 00776031 Canister, Parts Manual 1
7 15608 Locknut 1/4 Gr C Cp 2
8 03200347 Emblem, SMV 1
9 1458392 Decal,Red Reflector 2
10 1458398 Decal,Orange Reflector 2
11 2467909 Harness,Main Wiring - 35’ 1
12 3660353 Wdmt,SMV Bracket 1
13 3661600 Bracket,Light Support 1
14 3668426 U-Bolt,1/2-13x3-15/16x5-7/16 4
15 3831611 Bracket,Light Housing 2
16 15608 Locknut 1/4 Gr C Cp 2
17 2438621 Spade Bracket,SMV Mounting 1
18 33105C Hex Jam Nut 1/2-20 4
19 370013C Int Tooth Lockwasher 1/2 4
20 2417903 Assy,8 Ground Wire 4
21 02816800 Nut 1/2 NF Hex 4
22 2467900 Assy,Dual Signal Lamp 2
23 2467910 Harness,Wishbone - 10' 1
24 2467901 Assy,Dual Signal Lamp 1
25 2467903 Holder,7-Way Connector Plug 1
26 50021775 Capsc, M16 X 2P X 60MM Gr 10.9 2
27 4140606 Phlp Screw Pn Hd 10-24 X 3/4 2
28 44520BH Locknut #10 Cp 2
29 3661880 Plate,Socket Mount 1
22-1-50
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
DECALS - BUSH HOG MARKING
FRONT
SECTION
REAR
SECTION
22-1-51
BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011
MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833
DECALS - BUSH HOG MARKING
REF. PART
NO. NO. DESCRIPTION QTY.
1 00725746 Decal, Peligro 1
2 999001 Decal, Warning - Tractor Weight 1
3 00786980 Decal, Genuine Bush Hog Parts 1
4 00763977 Decal, Important-Notice To Owner 1
5 50058089 Decal, Bush Hog 11.00" 4
6 5W119 Decal, Warning Speed Restriction 1
7 03200347 Emblem, SMV 1
8 02962765 Decal, Multiple Hazard 10
9 52740 Decal, Warning, Oil Leak 5
10 3668308 Decal, Warning Transport 2
11 1458392 Decal, Red Reflector 4
12 1458393 Decal, Yellow Reflector 6
13 1458398 Decal, Orange Reflector 2
14 999200 Decal, General Warning - All Unit 1
15 50068845 Decal, Model DFWR 2
16 2458315 Decal, Warning Stored Energy 2
18 00776031 Canister, Parts Manual 1
Note: For item 8, add 2 for model DFWR1631 and
4 for model DFWR1833