Embed Size (px)
Citation preview
Document CopyrightsCopyright 2006 by Kenwood Corporation. All rights reserved.No part of this manual may be reproduced, translated, distributed, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, for any purpose without the prior written permission of Kenwood.
DisclaimerWhile every precaution has been taken in the preparation of this manual, Kenwood assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Kenwood reserves the right to make changes to any products herein at any time for improvement purposes.
VHF FM TRANSCEIVER
TK-2200L© 2006-11 PRINTED IN JAPANB51-8776-00 (S) 578
SERVICE MANUAL
GENERAL ............................................................. 2
REALIGNMENT .................................................... 3
CIRCUIT DESCRIPTION ....................................... 5
PARTS LIST .......................................................... 6
EXPLODED VIEW............................................... 13
PACKING ............................................................ 14
ADJUSTMENT ................................................... 15
PC BOARD
TX-RX UNIT (X57-6880-XX) ......................... 20
SCHEMATIC DIAGRAM..................................... 24
BLOCK DIAGRAM .............................................. 28
LEVEL DIAGRAM ............................................... 30
OPTIONAL ACCESSORIES
KSC-35 (RAPID CHARGER) .......................... 31
KNB-45L (Li-ion BATTERY PACK) ............... 31
SPECIFICATIONS ............................BACK COVER
CONTENTS
Helical antenna(T90-1036-05)
Knob (Volume)(K29-9309-03)
Button knob(PTT)(K29-9308-23)
Knob (CH)(K29-9318-03)
Plastic cabinet assy(A02-3983-03)(2CH): K(A02-3984-03)(8CH): K2
Photo is TK-2200L (K2 type).
This product uses Lead Free solder.
Refer to the TK-2200 service manual (B51-8694-00) forany information which has not been covered in this TK-2200L service manual.
Button knob(Side1/Side2)(K29-9364-03)
TK-2200L
2
GENERAL
INTRODUCTION
SCOPE OF THIS MANUAL
This manual is intended for use by experienced techniciansfamiliar with similar types of commercial grade communicationsequipment. It contains all required service information for theequipment and is current as of the publication date. Changeswhich may occur after publication are covered by either ServiceBulletins or Manual Revisions. These are issued as required.
ORDERING REPLACEMENT PARTS
When ordering replacement parts or equipment information,the full part identification number should be included. Thisapplies to all parts, components, kits, or chassis. If the partnumber is not known, include the chassis or kit number ofwhich it is a part, and a sufficient description of the requiredcomponent for proper identification.
PERSONAL SAFETY
The following precautions are recommended for personalsafety: DO NOT transmit until all RF connectors are verified secure
and any open connectors are properly terminated. SHUT OFF and DO NOT operate this equipment near
electrical blasting caps or in an explosive atmosphere. This equipment should be serviced by a qualified technician
only.
SERVICE
This transceiver is designed for easy servicing. Refer tothe schematic diagrams, printed circuit board views, andalignment procedures contained within.
Destination Number of CH Frequency No. / Frequency Default CH setting RF power output
CH1 151.6250MHz CH15 151.7750MHz
K 2-channelCH2 151.9550MHz CH16 151.8650MHz CH1: 154.5700MHz / QT 67.0HzCH3 154.5700MHz CH17 151.8950MHz CH2: 154.6000MHz / QT 67.0HzCH4 154.6000MHz CH18 151.9250MHzCH5 151.7000MHz CH19 152.7000MHzCH6 151.7600MHz CH20 154.4900MHz CH1: 154.5700MHz / QT 67.0Hz
∗CH7 151.8200MHz CH21 154.5150MHz CH2: 154.6000MHz / QT 67.0Hz2W∗CH8 151.8800MHz CH22 154.5275MHz CH3: 151.7000MHz / QT 67.0Hz
K2 8-channel∗CH9 151.9400MHz CH23 154.5400MHz CH4: 151.7600MHz / QT 67.0HzCH10 151.5125MHz CH24 154.6000MHz CH5: 151.8200MHz / QT 67.0HzCH11 151.6550MHz CH25 154.6550MHz CH6: 151.8800MHz / QT 67.0HzCH12 151.6850MHz CH26 158.4000MHz CH7: 151.9400MHz / QT 67.0HzCH13 151.7150MHz CH27 158.4075MHz CH8: 151.5125MHz / QT 67.0HzCH14 151.7450MHz
TK-2200L (ProTalk)
∗Note : Due to FCC regulations, these frequencies transmit at only 1 watt
TK-2200L
3
2. How to Enter Each Mode
Mode Operation
User mode Power ONPC mode Received commands from PCClone mode [PTT]+[Side2]+Power ON (Two seconds)
Mode Function
User mode For normal use.PC mode Used for communication between the
transceiver and PC (IBM compatible).Data programming Used to read and write frequency datamode and other features to and from the
transceiver.PC test mode Used to check the transceiver using the
PC. This feature is included in the FPU.Clone mode Used to transfer programming data
from one transceiver to another.
REALIGNMENT
1. Modes 4. PC Mode
4-1. Preface
The transceiver is programmed using a personal computer,a programming interface (KPG-22/22A), USB adapter (KCT-53U)and programming software (KPG-88D).
The programming software can be used with an IBM PCor compatible. Figure 1 shows the setup of an IBM PC forprogramming.
4-2. Connection procedure
1. Connect the transceiver to the personal computer with theinterface cable and USB adapter (When the interface cableis KPG-22A, the KCT-53U can be used.).
Notes:
• You must install the KCT-53U driver in the computer to usethe USB adapter (KCT-53U).
• When using the USB adapter (KCT-53U) for the first time,plug the KCT-53U into a USB port on the computer with thecomputer power ON.
2. When the POWER is switched on, user mode can beentered immediately. When the PC sends a command,the transceiver enters PC mode.When data is transmitting from the transceiver, the redLED lights.When data is received by the transceiver, the green LEDlights.
Notes:
• The data stored in the computer must match the modeltype when it is written into the EEPROM.
• Change the transceiver to PC mode, then attach theinterface cable.
4-3. KPG-22/KPG-22A description
(PC programming interface cable: Option)
The KPG-22/22A is required to interface the transceiver withthe computer. It has a circuit in its D-sub connector (KPG-22 :25-pin, KPG-22A : 9-pin) case that converts the RS-232C logiclevel to the TTL level.
The KPG-22/22A connects the SP/MIC connector of thetransceiver to the RS-232C serial port of the computer.
4-4. KCT-53U description (USB adapter : Option)
The KCT-53U is a cable which connects the KPG-22A to aUSB port on a computer.
When using the KCT-53U, install the supplied CD-ROM(with driver software) in the computer. The KCT-53U driverruns under Windows 2000 or XP.
Antenna
LED indicatorIndicates the transceiver status. Lights red whiletransmitting, green whilereceiving, and flashes red while the batterypower is low whiletransmitting.
PTT (Push to Talk) switchPress and hold, then speak into the microphone to transmit.
Side 1 key
Side 2 key
Speaker/ microphone jacks
Battery pack(KNB-45L)
Channel selectorRotate to change theoperating channel.
Power switch/Volume controlTurn clockwise to switch the power ON and counterclockwiseto switch the powerOFF. Rotate to adjustthe volume.
3. Getting Acquainted
User mode
PC mode
PC test mode
Data programmingmode
PC tuning modeClone mode
TK-2200L
4
4-5. Programming software KPG-88D description
KPG-88D is the programming software for the transceiversupplied on a CD-ROM. This software runs under Windows 98,ME, Windows 2000 or XP on an IBM-PC or compatible machine.
The data can be input to or read from the transceiver andedited on the screen. The programmed or edited data can beprinted out. It is also possible to tune the transceiver.
5. Clone Mode
5-1. Outline
"Clone Mode" copies the transceiver data to anothertransceiver.
The dealer can copy the transceiver data to anothertransceiver even without the use of a personal computer.
5-2. Example
The transceiver can copy the programming data to one ormore transceivers via RF communication.
The clone source and clone target/s must be in Clone mode.
5-3. Operation
1. To switch the clone target/s to Clone mode, press and hold the[PTT] and [Side2] keys while turning the transceiver power ON.
2. Wait for 2 seconds. The LED will light orange and thetransceiver will announce "Clone".
3. Select a channel table number using Side1(incrementchannel table) and Side2(decrement channnel table) keys.
4. To switch the clone source to Clone mode, press and hold the[PTT] and [Side2] keys while turning the transceiver power ON.
5. Wait for 2 seconds. The LED will light orange and thetransceiver will announce "Clone".
6. Select the same channel table number as the clone target/s.7. Press [PTT] on the clone source to begin data transmission. When
the clone target starts to receive data, the LED will light green.When the clone source finishes sending data, a"confirmation" tone will sound.
REALIGNMENT
If data transmission fails while cloning, an "error" tone willsound from the Target unit.
8. If the cloning fails, no data will be available in the Targetunit when it is returned to User mode.
9. When the cloning is successful, the Target unit's "Scan"function will return to its default value (Scan = OFF).
Notes:
• The dealer can clone data to two or more transceivers byrepeating the above procedures.
• If the transceivers Clone Mode is configured as "Disabled",the transceiver cannot enter Clone mode.
• The table shown below will cover the frequency tables usedfor wireless cloning.
• A unit cannot be a "Source Unit" if it is unprogrammed. If[PTT] is pressed, an "error" tone will sound.
• Once a unit is set to be the Source, it cannot be a targetafter the data has been transmitted. This protects the datain the Source unit.
• If the Target unit is cloned successfully, it will return toUser Mode.
• If the Target unit is not cloned successfully, the led willremain Orange.
• The Source Unit and Target Unit must be of the same modeltype and destination in order for Clone to operate.
• Clone mode cannot be accessed if “Super Lock” is activated.• Electronic interface may cause a failure in data transfer
during Wireless Clone, such as when waveforms orelectromagnetics are being performed at the workbench.
• Clone mode can be used ONLY by the authorized servicepersonnel.
• The Clone mode setting must be configured as "Disable"before being delivered to the end-user.
• To clone, replace the antenna from both the sourcetransceiver and the target transceiver with a dummy load.
• The transmit output power is automatically set to Lowin Clone mode.
Tuning cable(E30-3216-05)
RF Power meteror SSG
Gray +Gray/Black –1.5D-XV Lead wire +1.5D-XV Shield wire –
SP
MIC
KPG-22 or KPG-22A or KPG-22A + KCT-53UIllustration is KPG-22.
KPG-88D
IBM-PC
KPG-22
Transceiver
PC
D-SUB(25-pin)
Transceiver
PC
KPG-22A
D-SUB(9-pin)
Transceiver
PC
KPG-22A
KCT-53U
USB
Fig. 1
Clone Frequency Table
Table Frequency Table FrequencyNumber (MHz) Number (MHz)
1 151.6250 15 151.77502 151.9550 16 151.86503 154.5700 17 151.89504 154.6000 18 151.92505 151.7000 19 152.70006 151.7600 20 154.49007 151.8200 21 154.51508 151.8800 22 154.52759 151.9400 23 154.540010 151.5125 24 154.600011 151.6550 25 154.655012 151.6850 26 158.400013 151.7150 27 158.407514 151.7450
TK-2200L
5
CIRCUIT DESCRIPTION
1. Control Circuit
The control circuit consists of a microprocessor (IC405) andits peripheral circuits. It controls the TX-RX unit. IC405 mainlyperforms the following:
(1) Switching between transmission and reception by thePTT signal input.
(2) Reading system, group, frequency, and program datafrom the memory circuit.
(3) Sending frequency program data to the PLL.(4) Controlling squelch on/off by the DC voltage from the
squelch circuit.(5) Controlling the audio mute circuit by the decode data input.(6) Transmitting tone and encode data.
1) Frequency Shift Circuit
The microprocessor (IC405) operates at a clock of7.3728MHz. This oscillator has a circuit that shifts thefrequency by BEAT SHIFT SW (Q407,Q408).A beat sound may be able to be evaded from generation if“Beat Shift” is set to ON when it is generated in the internalspurious transmission modulated sound of a transceiver.
2) Memory Circuit
Memory circuit consists of the CPU (IC405) and an EEPROM(IC406). An EEPROM has a capacity of 8k bits that containsthe transceiver control program for the CPU and data suchas transceiver channels and operating features.
3) Low Battery Warning
The battery voltage is checked using by the microprocessor.The transceiver generates a warning tone when the batteryvoltage falls below the warning voltage (2) shown in the table.
(1) The red LED blinks when the battery voltage falls belowthe voltage (1) shown in the table during transmission.
Note:
During reception, transceiver constantly checks the batterylevel. When the battery level drops near to 5.9V, the redLED blinks and low battery warning tone is generated.
IC405
CPU
IC406
EEPROM
Fig. 2 Memory circuit
X2
XINXOUT
IC405
Q407H : OFFL : ON
Q408H : OFFL : ON
BSHIFT
Fig. 1 Frequency shift circuit
SB R404
R406
BATT88
IC405
CPU
Fig. 3 Low battery warning
Ni-MH Battery Li-ion Battery
(1) 6.2V 6.2V
(2) 5.9V 5.9V
(2) The transceiver immediately stops transmission whenthe battery voltage falls below the voltage (2) shown inthe table. The warning tone sounds while the PTTswitch is pressed.
TK-2200L
6
PARTS LIST
CAPACITORS
1 = Type ... ceramic, electrolytic, etc.
2 = Shape ... round, square, ect.
3 = Temp. coefficient
4 = Voltage rating
5 = Value
6 = Tolerance
Color*CC45
Capacitor value
010 = 1pF
100 = 10pF
101 = 100pF
102 = 1000pF = 0.001µF
103 = 0.01µF
2 2
Multiplier
2nd number
1st number
0 = 22pF
CC 45 TH 1H J2201 2 3 4 65
Temperature coefficient
Tolerance (More than 10pF)
Voltage rating
Chip capacitors
1
1st Word
Color*
Code D G J K M X Z P No code
LC P R S T U
Black Red Orange Yellow Green Blue Violet
0 -80 -150 -220
+ 40
- 40
+ 80
- 20
+ 100
-0
-330 -470 -750
C(%)
ppm/
0.25 0.5 2 5 10 20 More than 10µF -10 +50
Less than 4.7µF -10 +75
2nd Word HG
Example : CC45TH = -470
J K L
ppm/ 30 60
0.1 0.25 0.5 1 2
120 250 500
60ppm/
Gode C D F GB
(pF)
(Less than 10pF)
1st word2nd word A
0 2.0 2.5 3.15
20 25 31.5
200 250 315
2000 2500 3150
1.0 1.25 1.6
10 12.5 16
100 125 160
1000 1250 1600
1
2
3
B C D E F
4.0
40
400
4000
G
5.0
50
500
5000
H
6.3
63
630
6300
J
8.0
80
800
8000
K
-
35
-
-
V
(EX) C C 7 3 F S L 1 H 0 0 0 JRefer to the table above.
1 = Type
2 = Shape
5 = Voltage rating
4 = Temp. coefficient
3 = Dimension
6 = Value
7 = Tolerance
7654321
(EX) C K 7 3 F F 1 H 0 0 0 Z
7654321
(Chip)(CH,RH,UJ,SL)
(Chip)(B,F)
Chip resistor (Carbon)
(EX) R D 7 3 E B 2 B 0 0 0 J
7654321
RESISTORS
(Chip)(B,F)
Carbon resistor (Normal type)
(EX) R D 1 4 B B 2 C 0 0 0 J
7654321
1 = Type
2 = Shape
5 = Rating wattage
4 = Temp. coefficient
3 = Dimension
6 = Value
7 = Tolerance
Dimension code L W T
Empty
A
B
C
D
E
F
G
H
L
W
T
0.55.0
0.43.2
0.32.0
0.21.25
0.21.6
0.21.25
0.20.8
0.050.5 0.050.5
0.32.5
0.55.6
0.54.5
0.54.5
0.54.5
0.23.0
0.32.0
0.21.6
0.051.0
0.43.2
Less than 2.0
Less than 2.0
Less than 2.0
Less than 1.25
Less than 1.5
Less than 1.25
Less than 1.25
Less than 1.0
Dimension (Chip capacitors)
Dimension (Chip resistor)
Rating wattage
Dimension
Dimension code L W T
E
F
G
H
0.21.6
0.21.25
0.20.8
0.050.5
0.10.5
0.050.35
0.23.2
0.32.0
0.21.6
0.051.0
1.0
1.0
Code
2C
2H2E
Wattage
1/6W
1/2W1/4W
Code
1J
2B2A
Wattage
1/16W
1/8W1/10W
Code
3A
3D
Wattage
1W
2W
∗ New Parts. indicates safety critical components.Parts without Parts No. are not supplied.Les articles non mentionnes dans le Parts No. ne sont pas fournis.Teile ohne Parts No. werden nicht geliefert.
L: Scandinavia K: USA P: CanadaY: PX (Far East, Hawaii) T: England E: EuropeY: AAFES (Europe) X: Australia M: Other Areas
Parts No. DescriptionAddressNewpartsDestination Destination
TK-2200L
Ref. No. Parts No. DescriptionAddressNewparts
TK-2200L (Y50-6190-XX)TX-RX UNIT (X57-6880-XX)
Ref. No.
TK-2200LPARTS LIST
7
B 2B N14-0832-04 CIRCULAR NUT(CH KNOB)C 2A,2B N30-2604-48 PAN HEAD MACHINE SCREW(SMA)D 3A N30-2606-48 PAN HEAD MACHINE SCREW(CHASSIS)E 2A,2B,3B N83-2005-48 PAN HEAD TAPTITE SCREW(PCB)
54 2C N99-2046-05 SCREW SET ACCESSORY55 2B R31-0661-05 VARIABLE RESISTOR(POWER SW/VOL)56 2B S60-0435-05 ROTARY SWITCH(8CH)57 1B ∗ T07-0760-25 SPEAKER58 3D T90-1036-05 HELICAL ANTENNA ACCESSORY
59 1C W08-0988-05 CHARGER ACCESSORY60 1D W08-0989-05 AC ADAPTER(AC120V) ACCESSORY
D403 B30-2156-05 LED(RED)D404 B30-2157-05 LED(YELLOW)
C1 CK73HB1H332K CHIP C 3300PF KC2 CK73HB1C682K CHIP C 6800PF KC3 CK73GB1A105K CHIP C 1.0UF KC4 CK73HB1C103K CHIP C 0.010UF KC5 CK73HB1H102K CHIP C 1000PF K
C6 CK73HB1A104K CHIP C 0.10UF KC7 ,8 CC73HCH1H101J CHIP C 100PF JC9 CC73HCH1H100C CHIP C 10PF CC10 CS77CP0J100M CHIP TNTL 10UF 6.3WVC11 CC73HCH1H101J CHIP C 100PF J
C12 CK73HB1H102K CHIP C 1000PF KC13 CK73HB1A104K CHIP C 0.10UF KC14 CK73HB1C103K CHIP C 0.010UF KC15 CC73HCH1H100C CHIP C 10PF CC16 CK73HB1H102K CHIP C 1000PF K
C17 CC73HCH1H470J CHIP C 47PF JC18 CC73HCH1H180J CHIP C 18PF JC19 CK73HB1A104K CHIP C 0.10UF KC21 CS77CP0J100M CHIP TNTL 10UF 6.3WVC22 CS77AA1VR33M CHIP TNTL 0.33UF 35WV
C24 CK73HB1H102K CHIP C 1000PF KC25 CC73HCH1H020B CHIP C 2.0PF BC26 CC73HCH1H300J CHIP C 30PF JC27 CS77CA1C3R3M CHIP TNTL 3.3UF 16WVC29 ,30 CK73HB1H471K CHIP C 470PF K
C32 CS77CA1V0R1M CHIP TNTL 0.1UF 35WVC33 ,34 CK73HB1H102K CHIP C 1000PF KC35 CC73HCH1H270J CHIP C 27PF JC38 CC73HCH1H060B CHIP C 6.0PF BC39 CK73GB1H332K CHIP C 3300PF K
C40 CC73HCH1H040B CHIP C 4.0PF BC41 CK73GB1H682K CHIP C 6800PF KC42 CC73HCH1H060B CHIP C 6.0PF BC43 CC73HCH1H150J CHIP C 15PF JC44 CK73HB1H471K CHIP C 470PF K
C45 CK73GB1A105K CHIP C 1.0UF KC47 CC73HCH1H101J CHIP C 100PF JC48 CK73HB1H471K CHIP C 470PF KC49 CC73HCH1H101J CHIP C 100PF J
TX-RX UNIT (X57-6880-XX) -12 :K -13 :K2
1 1A ∗ A02-3983-03 PLASTIC CABINET ASSY(2CH) K1 1A ∗ A02-3984-03 PLASTIC CABINET ASSY(8CH) K22 3A ∗ A10-4094-43 CHASSIS3 1B A21-1645-23 DRESSING PANEL(8CH) K23 1B A21-1646-13 DRESSING PANEL(2CH) K
4 2C B09-0680-03 CAP(SP/MIC) ACCESSORY5 2B B11-1817-04 ILLUMINATION GUIDE6 1B B43-1156-04 BADGE(KENWOOD)7 1A ∗ B43-1603-04 BADGE(TK-2200L)8 1C ∗ B62-1978-00 INSTRUCTION MANUAL
9 1A D10-0649-03 LEVER10 1A D21-0863-04 SHAFT11 1A D32-0441-03 STOPPER12 1B D32-0443-04 STOPPER(2CH) K14 2A E04-0465-05 RF COAXIAL RECEPTACLE(SMA)
15 3B E23-1253-04 TERMINAL(BATT-)16 2B E37-1175-05 PROCESSED LEAD WIRE(BROWN:SP+)17 2B E37-1176-05 PROCESSED LEAD WIRE(GREEN:SP-)18 3A F20-3353-14 INSULATING SHEET(CHASSIS BATT+)19 2A G01-4542-04 COIL SPRING(LEVER)
20 1A G01-4543-04 COIL SPRING(STOPPER)21 2B G10-1330-04 FIBROUS SHEET(IC302:AUDIO IC)22 3A G11-4283-04 RUBBER SHEET(Q103:FINAL FET)23 2A G11-4313-04 SHEET(MIC ELEMENT)24 3B G13-2009-04 CUSHION(CHASSIS)
25 3A G13-2033-04 CUSHION(TERMINAL BATT-)26 3B G13-2034-14 CUSHION(TERMINAL BATT-)28 3A G13-2038-24 CUSHION(CHASSIS-CERAMIC FILTER)29 2A G13-2039-14 CUSHION(PCB-CERAMIC FILTER)30 2B G13-2076-04 CUSHION(SP)
31 2B G13-2088-04 CUSHION(CHASSIS VOL/CH)32 3A G53-1604-03 PACKING(CHASSIS)33 3A G53-1605-03 PACKING(TERMINAL BATT+)34 2B G53-1606-13 PACKING(VOL/CH/LED)35 1B G53-1607-03 PACKING(SP/MIC)
36 2B G53-1608-03 PACKING(SP)37 2A G53-1609-14 PACKING(MIC ELEMENT)38 2B G53-1610-04 PACKING(SMA)40 2C ∗ H12-4221-05 PACKING FIXTURE42 1C H25-0085-04 PROTECTION BAG (100/200/0.07)
43 3D ∗ H52-2180-02 ITEM CARTON CASE44 2C J19-5472-03 HOLDER(SP/MIC) ACCESSORY45 2A J19-5473-03 HOLDER ASSY(TERMINAL BATT+)46 2B J21-8478-04 HARDWARE FIXTURE(SP/MIC)47 2B J21-8525-03 MOUNTING HARDWARE(VOL/CH)
48 2D J29-0734-05 BELT CLIP ACCESSORY49 2B J82-0092-05 FPC50 1A K29-9308-23 BUTTON KNOB(PTT)51 1B K29-9309-03 KNOB(VOL)52 1B K29-9318-03 KNOB(CH)
53 1A K29-9364-03 BUTTON KNOB(SIDE1/SIDE2)
A 2B N14-0819-04 CIRCULAR NUT(VOL KNOB)
TK-2200LPARTS LIST
8
Ref. No. Parts No. DescriptionAddressNewpartsRef. No. Parts No. DescriptionAddress
Newparts Destination Destination
TX-RX UNIT (X57-6880-XX)
C50 CC73HCH1H100C CHIP C 10PF C
C51 CK73HB1H102K CHIP C 1000PF KC52 CC73HCH1H181J CHIP C 180PF JC53 CC73HCH1H0R5B CHIP C 0.5PF BC54 CC73HCH1H060B CHIP C 6.0PF BC55 CC73HCH1H121J CHIP C 120PF J
C57 CC73HCH1H1R5B CHIP C 1.5PF BC58 CC73HCH1H090B CHIP C 9.0PF BC59 CC73HCH1H1R5B CHIP C 1.5PF BC60 CC73HCH1H010B CHIP C 1.0PF BC61 CC73HCH1H040B CHIP C 4.0PF B
C62 CC73HCH1H050B CHIP C 5.0PF BC63 CC73HCH1H101J CHIP C 100PF JC64 CC73HCH1H040B CHIP C 4.0PF BC65 -67 CC73HCH1H050B CHIP C 5.0PF BC68 -70 CK73HB1H471K CHIP C 470PF K
C71 ,72 CK73HB1A104K CHIP C 0.10UF KC73 ,74 CC73HCH1H0R5B CHIP C 0.5PF BC75 ,76 CK73HB1H102K CHIP C 1000PF KC77 CK73HB1H471K CHIP C 470PF KC78 CC73HCH1H330J CHIP C 33PF J
C79 CS77CP0J100M CHIP TNTL 10UF 6.3WVC80 CK73HB1H471K CHIP C 470PF KC81 CC73HCH1H150J CHIP C 15PF JC82 -86 CK73HB1H102K CHIP C 1000PF KC87 CC73HCH1H100C CHIP C 10PF C
C90 CK73HB1H102K CHIP C 1000PF KC101 CK73HB1H102K CHIP C 1000PF KC104 CC73GCH1H390J CHIP C 39PF JC105 CK73HB1H102K CHIP C 1000PF KC107 CK73HB1H102K CHIP C 1000PF K
C108 CC73GCH1H390J CHIP C 39PF JC109 CK73GB1C104K CHIP C 0.10UF KC110,111 CK73HB1H102K CHIP C 1000PF KC115 CK73HB1H102K CHIP C 1000PF KC116 CC73GCH1H220J CHIP C 22PF J
C117 CC73GCH1H100C CHIP C 10PF CC118 CC73GCH1H101J CHIP C 100PF JC119 CC73GCH1H270J CHIP C 27PF JC120 CK73GB1H102K CHIP C 1000PF KC121 CC73GCH1H100C CHIP C 10PF C
C123 CK73GB1A105K CHIP C 1.0UF KC124,125 CK73HB1H102K CHIP C 1000PF KC126 CS77AA1E010M CHIP TNTL 1.0UF 25WVC128 CK73HB1H102K CHIP C 1000PF KC130 CC73GCH1H100C CHIP C 10PF C
C132 CK73HB1H102K CHIP C 1000PF KC133 CK73GB1H103K CHIP C 0.010UF KC134 CK73GB1C104K CHIP C 0.10UF KC135 CK73GB1A105K CHIP C 1.0UF KC136 CC73GCH1H270J CHIP C 27PF J
C137 CK73GB1H103K CHIP C 0.010UF KC138 CK73GB1H102K CHIP C 1000PF KC139 CC73GCH1H680J CHIP C 68PF JC140 CC73GCH1H101J CHIP C 100PF JC141 CC73GCH1H200G CHIP C 20PF G
C142 CC73GCH1H150J CHIP C 15PF JC143 CC73GCH1H100C CHIP C 10PF CC144 CC73GCH1H820J CHIP C 82PF J
C146 CK73GB1H102K CHIP C 1000PF KC147 CK73HB1H102K CHIP C 1000PF K
C148 CK73GB1H102K CHIP C 1000PF KC149 CC73GCH1H240J CHIP C 24PF JC150 CC73GCH1H220J CHIP C 22PF JC151 CK73GB1H102K CHIP C 1000PF KC153,154 CC73GCH1H100C CHIP C 10PF C
C155 CC73GCH1H180J CHIP C 18PF JC156 CC73GCH1H120J CHIP C 12PF JC157 CC73GCH1H150J CHIP C 15PF JC158 CC73GCH1H220J CHIP C 22PF JC159 CC73GCH1H070D CHIP C 7.0PF D
C160 CC73GCH1H330J CHIP C 33PF JC201 CK73GB1A224K CHIP C 0.22UF KC205 CK73HB1H102K CHIP C 1000PF KC207 CK73HB1H182K CHIP C 1800PF KC208 CK73HB1H471K CHIP C 470PF K
C209 CS77CP0J100M CHIP TNTL 10UF 6.3WVC210 CK73HB1H471K CHIP C 470PF KC211 CK73HB1C103K CHIP C 0.010UF KC213 CK73HB1A104K CHIP C 0.10UF KC214 CC73HCH1H680J CHIP C 68PF J
C215 CK73HB1H102K CHIP C 1000PF KC216 CK73GB1C104K CHIP C 0.10UF KC217 CK73HB1A104K CHIP C 0.10UF KC218 CK73GB1C104K CHIP C 0.10UF KC219 CC73HCH1H330J CHIP C 33PF J
C220 CK73HB1H102K CHIP C 1000PF KC221 CK73GB1C104K CHIP C 0.10UF KC222 CK73HB1H102K CHIP C 1000PF KC224,225 CK73HB1C103K CHIP C 0.010UF KC227 CK73HB1H102K CHIP C 1000PF K
C228 CC73GCH1H100C CHIP C 10PF CC230 CC73HCH1H080B CHIP C 8.0PF BC231,232 CK73GB1H103K CHIP C 0.010UF KC233 CC73HCH1H020B CHIP C 2.0PF BC234 CK73HB1C103K CHIP C 0.010UF K
C235 CC73HCH1H090B CHIP C 9.0PF BC236 CK73GB1H102K CHIP C 1000PF KC237 CC73HCH1H050B CHIP C 5.0PF BC238 CC73GCH1H120J CHIP C 12PF JC239 CC73HCH1H060B CHIP C 6.0PF B
C241 CK73HB1H102K CHIP C 1000PF KC242 CK73GB1C104K CHIP C 0.10UF KC243 CK73HB1H102K CHIP C 1000PF KC244 CC73HCH1H040B CHIP C 4.0PF BC245 CK73HB1H471K CHIP C 470PF K
C247 CC73GCH1H040B CHIP C 4.0PF BC248 CC73GCH1H270J CHIP C 27PF JC249 CK73HB1H102K CHIP C 1000PF KC250 CC73GCH1H040B CHIP C 4.0PF BC251 CS77CP0J4R7M CHIP TNTL 4.7UF 6.3WV
C252 CK73HB1H102K CHIP C 1000PF KC253 CC73GCH1H4R5B CHIP C 4.5PF BC254 CC73GCH1H270J CHIP C 27PF JC255 CC73GCH1H4R5B CHIP C 4.5PF BC256 CK73HB1H102K CHIP C 1000PF K
C258 CK73HB1H102K CHIP C 1000PF KC260 CK73HB1H102K CHIP C 1000PF K
TK-2200LPARTS LIST
Ref. No. Parts No. DescriptionAddressNewpartsRef. No. Parts No. DescriptionAddress
Newparts Destination Destination
TX-RX UNIT (X57-6880-XX)
9
C262 CK73HB1H102K CHIP C 1000PF KC263 CC73GCH1H100C CHIP C 10PF CC264 CC73GCH1H040B CHIP C 4.0PF B
C265 CC73GCH1H330J CHIP C 33PF JC266 CK73HB1H102K CHIP C 1000PF KC267,268 CC73GCH1H030B CHIP C 3.0PF BC269 CC73GCH1H330J CHIP C 33PF JC270 CC73GCH1H040B CHIP C 4.0PF B
C271 CC73GCH1H110J CHIP C 11PF JC280 CK73HB1H102K CHIP C 1000PF KC302 CK73HB1C103K CHIP C 0.010UF KC304 CK73GB1A224K CHIP C 0.22UF KC306 CS77CP0J4R7M CHIP TNTL 4.7UF 6.3WV
C307,308 CK73HB1A104K CHIP C 0.10UF KC309 CC73GCH1H820J CHIP C 82PF JC310 CK73HB1A683K CHIP C 0.068UF KC311 CK73GB1A105K CHIP C 1.0UF KC312 CC73GCH1H120J CHIP C 12PF J
C313 CC73GCH1H121J CHIP C 120PF JC314 CK73HB1A104K CHIP C 0.10UF KC315 CK73GB1A105K CHIP C 1.0UF KC316 CK73GB1C473K CHIP C 0.047UF KC317 CK73HB1A104K CHIP C 0.10UF K
C318 CS77CP0J4R7M CHIP TNTL 4.7UF 6.3WVC319 CC73GCH1H271J CHIP C 270PF JC320 CK73HB1C103K CHIP C 0.010UF KC321 CK73GB1A105K CHIP C 1.0UF KC322 CK73HB1C153K CHIP C 0.015UF K
C323 CC73GCH1H820J CHIP C 82PF JC324 CC73HCH1H820J CHIP C 82PF JC325 CK73HB1A104K CHIP C 0.10UF KC326 CK73HB1H102K CHIP C 1000PF KC327 CC73HCH1H101J CHIP C 100PF J
C328 CK73HB1H391K CHIP C 390PF KC329,330 CK73GB1A105K CHIP C 1.0UF KC331 CK73HB1A104K CHIP C 0.10UF KC332 CK73HB1H471K CHIP C 470PF KC333,334 CK73GB1C104K CHIP C 0.10UF K
C335 CC73GCH1H221J CHIP C 220PF JC336 CK73FB1C474K CHIP C 0.47UF KC338 CC73GCH1H101J CHIP C 100PF JC339 CS77AA0J100M CHIP TNTL 10UF 6.3WVC340 CK73GB1C104K CHIP C 0.10UF K
C341 CK73GB1C473K CHIP C 0.047UF KC342 CS77AA0J100M CHIP TNTL 10UF 6.3WVC343 CK73GB1C473K CHIP C 0.047UF KC344 CC73GCH1H221J CHIP C 220PF JC345 CS77CC0J101M CHIP TNTL 100UF 6.3WV
C346 CK73GB1H102K CHIP C 1000PF KC348 CK73HB1H471K CHIP C 470PF KC351,352 CK73HB1C103K CHIP C 0.010UF KC354 CK73HB1A104K CHIP C 0.10UF KC355 CK73GB1C104K CHIP C 0.10UF K
C401 CC73GCH1H471J CHIP C 470PF JC402 CK73HB1H102K CHIP C 1000PF KC403 CK73GB1C104K CHIP C 0.10UF KC405 CC73GCH1H101J CHIP C 100PF JC407 CK73HB1H102K CHIP C 1000PF K
C409,410 CK73GB1A105K CHIP C 1.0UF K
C411 CK73HB1H102K CHIP C 1000PF KC415 CK73HB1H471K CHIP C 470PF KC417 CK73GB1A105K CHIP C 1.0UF KC418,419 CK73HB1H102K CHIP C 1000PF K
C421 CK73GB1A105K CHIP C 1.0UF KC426,427 CK73GB1A105K CHIP C 1.0UF KC428,429 CK73HB1H102K CHIP C 1000PF KC430 CK73GB1H103K CHIP C 0.010UF KC431 CK73HB1C103K CHIP C 0.010UF K
C432 CC73HCH1H050B CHIP C 5.0PF BC433,434 CC73HCH1H030B CHIP C 3.0PF BC435 CC73HCH1H050B CHIP C 5.0PF BC440 CC73GCH1H1R5B CHIP C 1.5PF BC443 CK73GB1A474K CHIP C 0.47UF K
C901,902 CK73GB1A105K CHIP C 1.0UF K
TC1 ,2 C05-0384-05 CERAMIC TRIMMER CAPACITOR(10PF)
CN201 E23-1278-05 TERMINALCN401 E40-6573-05 FLAT CABLE CONNECTOR
J301 E11-0707-05 PHONE JACK(2.5/3.5)
F401 F53-0324-05 FUSE(2.5A)
101 2A J30-1282-14 SPACER(MIC ELEMENT)
CD201 L79-1582-05 TUNING COIL
CF201 2A L72-0973-05 CERAMIC FILTER
L1 L40-4791-37 SMALL FIXED INDUCTOR(4.700UH)L3 L40-5681-86 SMALL FIXED INDUCTOR(0.56UH)L5 L40-5681-86 SMALL FIXED INDUCTOR(0.56UH)L6 ,7 L92-0138-05 CHIP FERRITEL8 L41-1875-06 SMALL FIXED INDUCTOR(18NH)
L9 L41-3375-06 SMALL FIXED INDUCTOR(33NH)L10 ∗ L41-1885-06 SMALL FIXED INDUCTOR(180NH)L11 L41-1085-06 SMALL FIXED INDUCTOR(100NH)L12 L92-0138-05 CHIP FERRITEL13 ,14 ∗ L41-2285-06 SMALL FIXED INDUCTOR(220NH)
L16 L40-3978-67 SMALL FIXED INDUCTOR(39NH)L17 L40-2778-67 SMALL FIXED INDUCTOR(27NH)L18 ,19 L41-2285-03 SMALL FIXED INDUCTOR(220NH)L20 ,21 L40-3391-86 SMALL FIXED INDUCTOR(3.3UH)L22 L92-0138-05 CHIP FERRITE
L23 ∗ L41-3975-06 SMALL FIXED INDUCTOR(39NH)L24 L92-0470-05 CHIP FERRITEL25 ∗ L41-8275-06 SMALL FIXED INDUCTOR(82NH)L50 L92-0138-05 CHIP FERRITEL102 L41-1085-06 SMALL FIXED INDUCTOR(100NH)
L103 L92-0138-05 CHIP FERRITEL104 L40-2775-92 SMALL FIXED INDUCTOR(27NH)L105 L40-1585-54 SMALL FIXED INDUCTOR(150NH)L106 L92-0149-05 CHIP FERRITEL107 L40-2775-54 SMALL FIXED INDUCTOR(27NH)
L108 L92-0149-05 CHIP FERRITEL109 L41-2295-39 SMALL FIXED INDUCTOR(2.2UH)L110 L40-5675-92 SMALL FIXED INDUCTOR(56NH)L111 L41-1092-44 SMALL FIXED INDUCTOR(1UH)L112 L34-4577-05 AIR-CORE COIL
L113 L34-4563-05 AIR-CORE COIL
If a part reference number is listed in a shaded box, that part does not come with the PCB.
TK-2200LPARTS LIST
10
Ref. No. Parts No. DescriptionAddressNewpartsRef. No. Parts No. DescriptionAddress
Newparts Destination Destination
TX-RX UNIT (X57-6880-XX)
L114,115 L34-4573-05 AIR-CORE COILL116 L34-4576-05 AIR-CORE COILL117 L34-4575-05 AIR-CORE COILL118 L34-4567-05 AIR-CORE COIL
L119 L34-4566-05 AIR-CORE COILL201 L40-1091-37 SMALL FIXED INDUCTOR(1.000UH)L202 ∗ L41-3975-06 SMALL FIXED INDUCTOR(39NH)L203 L92-0138-05 CHIP FERRITEL204 L41-5685-39 SMALL FIXED INDUCTOR(0.56UH)
L205 ∗ L41-6875-06 SMALL FIXED INDUCTOR(68NH)L206 ∗ L41-1885-06 SMALL FIXED INDUCTOR(180NH)L207 L40-1585-92 SMALL FIXED INDUCTOR(150NH)L209 L41-5678-14 SMALL FIXED INDUCTOR(56NH)L210 L92-0138-05 CHIP FERRITE
L211 L41-5678-14 SMALL FIXED INDUCTOR(56NH)L213 L41-5678-14 SMALL FIXED INDUCTOR(56NH)L214 L41-4778-14 SMALL FIXED INDUCTOR(47NH)L301 L92-0140-05 CHIP FERRITEL302 L92-0149-05 CHIP FERRITE
L401 L92-0149-05 CHIP FERRITEL402-404 L92-0138-05 CHIP FERRITE
X1 L77-1931-05 TCXO(12.8MHZ)X2 L78-1414-05 RESONATOR(7.37MHZ)
XF201 L71-0619-05 MCF(38.85MHZ)
CP404 RK75HA1J473J CHIP-COM 47K J 1/16WCP405 RK75HA1J102J CHIP-COM 1.0K J 1/16W
R1 RK73HB1J223J CHIP R 22K J 1/16WR2 RK73HB1J103J CHIP R 10K J 1/16WR3 RK73HB1J333J CHIP R 33K J 1/16WR4 RK73HB1J563J CHIP R 56K J 1/16WR5 ,6 RK73HB1J104J CHIP R 100K J 1/16W
R7 RK73HB1J101J CHIP R 100 J 1/16WR8 -11 RK73HB1J000J CHIP R 0.0 J 1/16WR12 RK73HB1J222J CHIP R 2.2K J 1/16WR13 RK73GB2A000J CHIP R 0.0 J 1/10WR14 RK73HB1J334J CHIP R 330K J 1/16W
R15 RK73GB2A221J CHIP R 220 J 1/10WR16 RK73GB2A561J CHIP R 560 J 1/10WR17 RK73HB1J101J CHIP R 100 J 1/16WR18 RK73GB2A000J CHIP R 0.0 J 1/10WR19 RK73GB2A152J CHIP R 1.5K J 1/10W
R20 RK73HB1J100J CHIP R 10 J 1/16WR21 RK73GB2A681J CHIP R 680 J 1/10WR22 RK73GB2A000J CHIP R 0.0 J 1/10WR23 RK73GB2A103J CHIP R 10K J 1/10WR25 RK73HB1J223J CHIP R 22K J 1/16W
R26 RK73HB1J103J CHIP R 10K J 1/16WR27 RK73HB1J220J CHIP R 22 J 1/16WR30 RK73HB1J123J CHIP R 12K J 1/16WR31 RK73HB1J564J CHIP R 560K J 1/16WR32 RK73HB1J102J CHIP R 1.0K J 1/16W
R33 RK73HB1J154J CHIP R 150K J 1/16WR34 RK73HB1J472J CHIP R 4.7K J 1/16WR35 ,36 RK73HB1J274J CHIP R 270K J 1/16WR37 RK73HB1J101J CHIP R 100 J 1/16WR38 RK73HB1J181J CHIP R 180 J 1/16W
R39 RK73HB1J151J CHIP R 150 J 1/16W
R40 RK73HB1J101J CHIP R 100 J 1/16WR41 RK73HB1J154J CHIP R 150K J 1/16WR42 RK73HB1J472J CHIP R 4.7K J 1/16WR43 RK73HB1J101J CHIP R 100 J 1/16W
R44 RK73HB1J102J CHIP R 1.0K J 1/16WR45 ,46 RK73HB1J332J CHIP R 3.3K J 1/16WR47 RK73HB1J470J CHIP R 47 J 1/16WR48 RK73HB1J331J CHIP R 330 J 1/16WR49 RK73HB1J222J CHIP R 2.2K J 1/16W
R50 RK73HB1J472J CHIP R 4.7K J 1/16WR51 RK73HB1J100J CHIP R 10 J 1/16WR101 RK73HB1J123J CHIP R 12K J 1/16WR103 RK73GB2A000J CHIP R 0.0 J 1/10WR107 RK73GB2A561J CHIP R 560 J 1/10W
R108 RK73GB2A152J CHIP R 1.5K J 1/10WR109 RK73GB2A150J CHIP R 15 J 1/10WR110,111 RK73GB2A331J CHIP R 330 J 1/10WR112 RK73GB2A180J CHIP R 18 J 1/10WR113 RK73GB2A331J CHIP R 330 J 1/10W
R114 RK73GB2A683J CHIP R 68K J 1/10WR115 RK73GB2A822J CHIP R 8.2K J 1/10WR116 RK73GB2A150J CHIP R 15 J 1/10WR117 RK73GB2A224J CHIP R 220K J 1/10WR119 RK73GB2A331J CHIP R 330 J 1/10W
R121 RK73GB2A561J CHIP R 560 J 1/10WR122 RK73GB2A473J CHIP R 47K J 1/10WR123 RK73GB2A820J CHIP R 82 J 1/10WR124 RK73GB2A823J CHIP R 82K J 1/10WR126 RK73GB2A222J CHIP R 2.2K J 1/10W
R127-129 RK73EB2ER39K CHIP R 0.39 K 1/4WR130-135 RK73GH2A154D CHIP R 150K D 1/10WR136,137 RK73GB2A271J CHIP R 270 J 1/10WR138 RK73GB2A105J CHIP R 1.0M J 1/10WR139 RK73GB2A473J CHIP R 47K J 1/10W
R140 RK73GB2A563J CHIP R 56K J 1/10WR141 RK73GB2A104J CHIP R 100K J 1/10WR142 RK73GB2A000J CHIP R 0.0 J 1/10WR143 RK73GB2A104J CHIP R 100K J 1/10WR144,145 RK73GB2A000J CHIP R 0.0 J 1/10W
R203 RK73HB1J184J CHIP R 180K J 1/16WR206 RK73GB2A100J CHIP R 10 J 1/10WR207 RK73HB1J472J CHIP R 4.7K J 1/16WR208 RK73HB1J823J CHIP R 82K J 1/16WR209 RK73HB1J272J CHIP R 2.7K J 1/16W
R210,211 RK73HB1J332J CHIP R 3.3K J 1/16WR212 RK73HB1J823J CHIP R 82K J 1/16WR213 RK73HB1J392J CHIP R 3.9K J 1/16WR215 RK73HB1J101J CHIP R 100 J 1/16WR216 RK73HB1J124J CHIP R 120K J 1/16W
R217 RK73HB1J472J CHIP R 4.7K J 1/16WR218 RK73HB1J561J CHIP R 560 J 1/16WR219,220 RK73GB2A561J CHIP R 560 J 1/10WR221 RK73GB2A102J CHIP R 1.0K J 1/10WR222 RK73GB2A221J CHIP R 220 J 1/10W
R223-226 RK73HB1J823J CHIP R 82K J 1/16WR227 RK73GB2A000J CHIP R 0.0 J 1/10WR228,229 RK73HB1J105J CHIP R 1.0M J 1/16WR230 RK73GB2A222J CHIP R 2.2K J 1/10WR231 RK73GB2A470J CHIP R 47 J 1/10W
TK-2200LPARTS LIST
Ref. No. Parts No. DescriptionAddressNewpartsRef. No. Parts No. DescriptionAddress
Newparts Destination Destination
TX-RX UNIT (X57-6880-XX)
11
R233 RK73GB2A221J CHIP R 220 J 1/10WR234 RK73GB2A104J CHIP R 100K J 1/10WR237 RK73GB2A184J CHIP R 180K J 1/10WR238 RK73GB2A104J CHIP R 100K J 1/10WR239 RK73GB2A470J CHIP R 47 J 1/10W
R240 RK73GB2A000J CHIP R 0.0 J 1/10WR241,242 RK73HB1J105J CHIP R 1.0M J 1/16WR243 RK73FB2B000J CHIP R 0.0 J 1/8WR291 RK73GB2A000J CHIP R 0.0 J 1/10WR299 RK73HB1J000J CHIP R 0.0 J 1/16W
R301 RK73HB1J473J CHIP R 47K J 1/16WR304 RK73HB1J564J CHIP R 560K J 1/16WR305 RK73HB1J104J CHIP R 100K J 1/16WR306 RK73HB1J102J CHIP R 1.0K J 1/16WR307,308 RK73HB1J000J CHIP R 0.0 J 1/16W
R310 RK73GB2A394J CHIP R 390K J 1/10WR311 RK73HB1J123J CHIP R 12K J 1/16WR312 RK73GB2A334J CHIP R 330K J 1/10WR313 RK73GB2A104J CHIP R 100K J 1/10WR314 RK73GB2A103J CHIP R 10K J 1/10W
R315 RK73GB2A334J CHIP R 330K J 1/10WR316 RK73GB2A124J CHIP R 120K J 1/10WR317 RK73GB2A474J CHIP R 470K J 1/10WR318 RK73GB2A122J CHIP R 1.2K J 1/10WR319 RK73HB1J563J CHIP R 56K J 1/16W
R320 RK73HB1J332J CHIP R 3.3K J 1/16WR321 RK73HB1J224J CHIP R 220K J 1/16WR322 RK73HB1J184J CHIP R 180K J 1/16WR323 RK73HB1J563J CHIP R 56K J 1/16WR324,325 RK73GB2A104J CHIP R 100K J 1/10W
R326 RK73GB2A000J CHIP R 0.0 J 1/10WR327 RK73GB2A184J CHIP R 180K J 1/10WR328 RK73GB2A103J CHIP R 10K J 1/10WR329 RK73GB2A823J CHIP R 82K J 1/10WR330 RK73HB1J332J CHIP R 3.3K J 1/16W
R331 RK73GB2A393J CHIP R 39K J 1/10WR332 RK73GB2A153J CHIP R 15K J 1/10WR334 RK73GB2A473J CHIP R 47K J 1/10WR335 RK73GB2A222J CHIP R 2.2K J 1/10WR336 RK73GB2A102J CHIP R 1.0K J 1/10W
R337 RK73GB2A151J CHIP R 150 J 1/10WR338 RK73HB1J222J CHIP R 2.2K J 1/16WR339 RK73GB2A471J CHIP R 470 J 1/10WR340 RK73GB2A182J CHIP R 1.8K J 1/10WR341 RK73GB2A103J CHIP R 10K J 1/10W
R342 RK73GB2A100J CHIP R 10 J 1/10WR343 RK73GB2A474J CHIP R 470K J 1/10WR344 RK73GB2A102J CHIP R 1.0K J 1/10WR345,346 RK73GB2A101J CHIP R 100 J 1/10WR347 RK73GB2A104J CHIP R 100K J 1/10W
R348 RK73GB2A563J CHIP R 56K J 1/10WR349 RK73GB2A333J CHIP R 33K J 1/10WR350 RK73HB1J000J CHIP R 0.0 J 1/16WR354,355 RK73HB1J103J CHIP R 10K J 1/16WR357 RK73HB1J000J CHIP R 0.0 J 1/16W
R360 RK73HB1J000J CHIP R 0.0 J 1/16WR365 RK73HB1J473J CHIP R 47K J 1/16WR388 RK73HB1J000J CHIP R 0.0 J 1/16WR403 RK73GB2A101J CHIP R 100 J 1/10WR404 RK73HH1J474D CHIP R 470K D 1/16W
R405 RK73GB2A334J CHIP R 330K J 1/10WR406 RK73HH1J474D CHIP R 470K D 1/16WR407 RK73HB1J334J CHIP R 330K J 1/16WR408-412 RK73HB1J473J CHIP R 47K J 1/16WR413,414 RK73GB2A331J CHIP R 330 J 1/10W
R416-420 RK73HB1J473J CHIP R 47K J 1/16W KR417-420 RK73HB1J473J CHIP R 47K J 1/16W K2R421,422 RK73HB1J102J CHIP R 1.0K J 1/16WR423 RK73HB1J000J CHIP R 0.0 J 1/16WR424,425 RK73HB1J473J CHIP R 47K J 1/16W
R426 RK73HB1J000J CHIP R 0.0 J 1/16WR435 RK73HB1J473J CHIP R 47K J 1/16WR436 RK73GB2A000J CHIP R 0.0 J 1/10WR437,438 RK73HB1J473J CHIP R 47K J 1/16WR445,446 RK73GB2A000J CHIP R 0.0 J 1/10W
R447 RK73HB1J472J CHIP R 4.7K J 1/16WR450 RK73GB2A000J CHIP R 0.0 J 1/10WR453,454 RK73HB1J473J CHIP R 47K J 1/16W K2R454 RK73HB1J473J CHIP R 47K J 1/16W KR901,902 RK73GB2A472J CHIP R 4.7K J 1/10W
VR1 R32-0736-05 SEMI FIXED VARIABLE RESISTOR(68K)
S401-403 S70-0414-05 TACT SWITCH
MIC301 2A T91-0651-15 MIC ELEMENT
D1 MA2S111-F DIODED4 ,5 1SV325F VARIABLE CAPACITANCE DIODED7 1SV325F VARIABLE CAPACITANCE DIODED9 1SV325F VARIABLE CAPACITANCE DIODED10 1SV278F VARIABLE CAPACITANCE DIODE
D11 MA2S111-F DIODED101 HSC277 DIODED102 HZU5CLL ZENER DIODED103-106 HVC131 DIODED202 HSC277 DIODE
D203-206 1SV305F VARIABLE CAPACITANCE DIODED301,302 RB706F-40 DIODED303 DAN222 DIODED401 RB521S-30 DIODED402 1SR154-400 DIODE
D405 KDZ3.3V ZENER DIODE
IC1 MB15A02PFV2E1 MOS-ICIC2 UPB1509GV BI-POLAR ICIC101 TA75W01FUF MOS-ICIC201 TA31136FNG MOS-ICIC301 AQUA-L MOS-IC
IC302 TA7368FG MOS-ICIC401,402 XC6204B502MR MOS-ICIC403 BD4840FVE MOS-ICIC404 BD4845FVE MOS-ICIC405 ∗ 30622MAPA49GU MICROCONTROLLER IC
IC406 BR24L08F-W ROM IC
Q1 KTC4082 TRANSISTORQ2 2SC5108(Y)F TRANSISTORQ3 ,4 2SK508NV(K52) FETQ5 RT1P430U TRANSISTORQ6 2SC5108(Y)F TRANSISTOR
Q7 RT1P430U TRANSISTOR
TK-2200LPARTS LIST
12
Ref. No. Parts No. DescriptionAddressNewpartsRef. No. Parts No. DescriptionAddress
Newparts Destination Destination
TX-RX UNIT (X57-6880-XX)
Q8 2SC5383-T111 TRANSISTORQ9 2SC5108(Y)F TRANSISTORQ102 2SC4926YD TRANSISTORQ103 2SK2596 FET
Q104 RT1N141U TRANSISTORQ105 2SK879(Y)F FETQ106 2SK2595-E FETQ107 RT1N141U TRANSISTORQ108 2SK1824-A FET
Q109 RT1P441U TRANSISTORQ202 RT1P441U TRANSISTORQ203 2SC4649(N,P) TRANSISTORQ204,205 3SK318 FETQ301 RT1P141U TRANSISTOR
Q302 2SC4919 TRANSISTORQ303 RT1N441U TRANSISTORQ304 2SA1362-F(GR) TRANSISTORQ305 RT1N441U TRANSISTORQ306 2SK3577-A FET
Q316 2SK3577-A FETQ317,318 2SK1824-A FETQ401,402 RT1N141U TRANSISTORQ403,404 CPH3317 FETQ405 RT1P237U-T111 TRANSISTOR
Q407,408 2SK1830F FETQ901 2SK1824-A FET
TH101 B57331V2104J THERMISTORTH203 B57331V2104J THERMISTOR
TK-2200L
13
A B
1
2
3
MIC301
101X57
X57
Parts with the exploded numbers larger than 700 are not supplied.
EXPLODED VIEW
A :N14-0819-04B :N14-0832-04C :N30-2604-48D :N30-2606-48E :N83-2005-48
TX-RX Unit
50
6
11
9
20
19
10
37
23 E
E
Ex2
Ex2E
E
21
Ex2
45
33
18
2
Dx2
25
15 E
26
32
28
22
14
31
31
55
C
C38
49B 5
A
34
36
57
46
35
51
52
1617
29
47
53
1
CF201
24
7
30
56
3
12(K)
Note: If a part reference number is listed in a box
on the exploded view of the PCB, that part
does not come with the PCB. These parts
must be ordered separately.
TK-2200L
14 Parts with the exploded numbers larger than 700 are not supplied.
PACKINGC D
1
2
343.ITEM CARTON CASE
(H52-2180-02)
48.BELT CLIP(J29-0734-05)
4. CAP(SP/MIC)(B09-0680-03)
42.PROTECTION BAG(H25-0085-04)
40.PACKING FIXTURE(H12-4221-05)
54.SCREW SET(N99-2046-05)
44.HOLDER(SP/MIC)(J19-5472-03)
59.CHARGER(W08-0988-05)
8. INSTRUCTION MANUAL(B62-1978-00)
700. KNB-45L(Li-ion BATTERY PACK)
60.AC ADAPTER(AC120V)(W08-0989-05)
701. WARRANTY CARD702. PAMPHLET
58.HELICAL ANTENNA(T90-1036-05)
TK-2200L
15
ADJUSTMENT
Connect the power cable properly between the battery jiginstalled in the transceiver and the power supply, and be sureoutput voltage and the power supply polarity prior to switchingthe power supply ON, otherwise over voltage and reverseconnection may damage the transceiver, or the power supplyor both.
Note: When using the battery jig, you must measure thevoltage at the terminals of the battery jig. Otherwise, a slightvoltage drop may occur within the power cable, between thepower supply and the battery jig, especially while thetransceiver transmits.
+ Terminal(Red)
– Terminal(Black)
C3
100µ
/25V
C2
470P
/25V
C1
100P
/25V
R1
1.8M
–
S
+
Powersupply
Power cable
SCHEMATIC DIAGRAM
Test Equipment Required for AlignmentTest Equipment Major Specifications
1. Standard Signal Generator Frequency Range 150 to 174MHz(SSG) Modulation Frequency modulation and external modulation
Output -127dBm/0.1µV to greater than -47dBm/1mV2. Power Meter Input Impedance 50Ω
Operation Frequency 150 to 174MHzMeasurement Range Vicinity of 10W
3. Deviation Meter Frequency Range 150 to 174MHz4. Digital Volt Meter Measuring Range 10mV to 10V DC
(DVM) Input Impedance High input impedance for minimum circuit loading5. Oscilloscope DC through 30MHz6. High Sensitivity Frequency Range 10Hz to 1000MHz
Frequency Counter Frequency Stability 0.2ppm or less7. Ammeter 5A8. AF Volt Meter Frequency Range 50Hz to 10kHz
(AF VTVM) Voltage Range 1mV to 10V9. Audio Generator (AG) Frequency Range 50Hz to 5kHz or more
Output 0 to 1V10. Distortion Meter Capability 3% or less at 1kHz
Input Level 50mV to 10Vrms11. Spectrum Analyzer Measuring Range DC to 1GHz or more12. Tracking Generator Center frequency 50kHz to 600MHz
Output Voltage 100mV or more13. 8Ω Dummy Load Approx. 8Ω, 3W14. Regulated Power Supply 5V to 10V, approx. 3A
Useful if ammeter equipped
The following parts are required for
adjustment
1. Antenna connector adapterThe antenna connector of this transceiver uses an SMA
terminal.Use an antenna connector adapter [SMA(f) – BNC(f) or
SMA(f) – N(f)] for adjustment. (The adapter is not provided asan option, so buy a commercially-available one.)
2. Repair Jig (Chassis)Use jig (part No.: A10-4086-03) for repairing the transceiver.
Place the TX-RX unit on the jig and fit it with screws.
The jig facilitates the voltage check and protects the finalamplifier FET when the voltage on the flow side of the TX-RXunit is checked during repairs.
3. Battery Jig (W05-1011-00)
+ Terminal (Red)
– Terminal (Black)
TK-2200L
16
Frequency and signaling
The transceiver has been adjusted for the frequenciesshown in the following table. When required, readjust themfollowing the adjustment procedure to obtain the frequenciesyou want in actual operation.
Frequency (MHz)
Channel No. RX Frequency TX Frequency1 162.050 162.1002 150.050 150.1003 173.950 173.9004 162.000 162.0005 162.200 162.2006 162.400 162.4007 156.550 156.6008 168.550 168.600
ADJUSTMENT
Adjustment points
VR1 : Frequency adjustmentBPF : Band-pass wave form test pointCV : VCO lock voltage adjustment terminal
TC1 : Transmit VCO lock voltage adjustmentTC2 : Receive VCO lock voltage adjustmentCV : VCO lock voltage adjustment terminal
Signaling
Signaling No. RX TX1 None None2 None 100Hz Square Wave3 QT 67.0Hz QT 67.0Hz4 QT 151.4Hz QT 151.4Hz5 QT 250.3Hz QT 250.3Hz6 DQT D023N DQT D023N7 DQT D754I DQT D754I8 DTMF 159D DTMF 159D9 None DTMF tone 9
• Preparations for tuning the transceiver
Before attempting to tune the transceiver, connect the unitto a suitable power supply.
Whenever the transmitter is tuned, the unit must beconnected to a suitable dummy load (i.e. power meter).
The speaker output connector must be terminated with a8Ω dummy load and connected to an AC voltmeter and anaudio distortion meter or a SINAD measurement meter at alltimes during tuning.
VR1
BATT+5M
5C
PCTV BPF
CV
B
SB
CN13ANT
SP+ SP–
TX-RX unit
Component side view
TC1 TC2
CV
TX-RX unit
Foil side view
S401PTT
S403SW1
S402SW2
J301EXT. SP/EXT. MIC
Adjustment Frequency
TEST CH RX TXLow 150.050MHz 150.100MHzLow’ 156.550MHz 156.600MHz
Center 162.050MHz 162.100MHzHigh’ 168.550MHz 168.600MHzHigh 173.950MHz 173.900MHz
Antenna
LED indicator
PTT (Push to Talk) switch
Side 1 key
Side 2 key
Speaker/ microphone jacks
Channel selector
Power switch/Volume control
TK-2200L
17
1.Frequency 1) CH:High Frequency counter ANT VR1 High frequency Note: After replacingAdjust 2) PTT:ON ±50Hz the TCXO (X1) align
frequency.2.High power TEST CH: Low Power meter Programming 2.0W ±0.1W
Adjust Low’ Ammeter Software:KPG-88D 1.15 A or lessCenterHigh’High(5 points)
BATT terminal voltage:7.5VPTT:ON
3.Low power TEST CH: Low 1.0W ±0.1WAdjust Low’ 0.9 A or less
CenterHigh’High(5 points)
BATT terminal voltage:7.5VPTT:ON
4.DQT TEST CH: Center Power meter Make thebalance Adjust Low Deviation meter demodulation[Wide] High Oscilloscope wave into
(3 points) AG square waves.LPF:3kHz AF VTVMHPF:OFFPTT:ON
[Narrow] TEST CH:CenterPTT:ON
ADJUSTMENT
Common Section
Item ConditionMeasurement Adjustment Specifications/
Test equipment Terminal Parts Method Remark
1.Setting 1) BATT terminal voltage:7.5V2) SSG standard modulation
[Wide] MOD:1kHz,DEV:3kHz[Narrow] MOD:1kHz,DEV:1.5kHz
2.VCO lock 1) CH:High Power meter ANT TC2 4.0V ±0.1Vvoltage 2) CH:Low DVM CV Check 0.6V or moreRX
3.VCO lock 3) CH:High TC1 4.2V ±0.1Vvoltage PTT:ONTX 4) CH:Low Check 0.6V or more
PTT:ON
Transmitter Section
Item ConditionMeasurement Adjustment Specifications/
Test equipment Terminal Parts Method Remark
TK-2200L
18
ADJUSTMENT
5.Max deviation TEST CH: Center Power meter ANT Programming 4.2kHz ±80HzAdjust Low Deviation meter SP/MIC connector Software:KPG-88D (According to[Wide] High Oscilloscope the larger +,–)
(3 points) AGAG:1kHz/150mV AF VTVMDeviation meter filterLPF:15kHzHPF:OFFPTT:ON
[Narrow] TEST CH:Center 2.2kHz ±80HzPTT:ON (According to
the larger +,–)6.VOX 1 TEST CH:Center
Writing AG:1KHz/45mV7.QT deviation TEST CH: Center ANT Programming 0.80kHz ±40Hz
Adjust Low Software:KPG-88D[Wide] High
(3 points)LPF:3kHzHPF:OFFPTT:ON
[Narrow] TEST CH: Center 0.40kHz ±40HzPTT:ON
8.DQT deviation TEST CH: Center 0.75kHz ±40HzAdjust Low[Wide] High
(3 points)LPF:3kHzHPF:OFFPTT:ON
[Narrow] TEST CH:Center 0.40kHz ±40HzPTT:ON
9.DTMF deviation TEST CH:Center 3.0kHz ±100HzAdjust LPF:15kHz[Wide] HPF:OFF
PTT:ON[Narrow] TEST CH:Center 1.5kHz ±100Hz
PTT:ON10.MSK deviation TEST CH: Center 3.0kHz ±100Hz
Adjust Low[Wide] High
(3 points)LPF:15kHzHPF:OFFPTT:ON
[Narrow] TEST CH:Center 1.5kHz ±100HzPTT:ON
Item ConditionMeasurement Adjustment Specifications/
Test equipment Terminal Parts Method Remark
TK-2200L
19
1.BPF Wave (1)Center frequency Spectrum ANT Programming Adjust theAdjust Spectrum analyzer setting analyzer BPF Software: waveform as
Center-f : 162MHz KPG-88D shown to theSpan : 100MHz right.RBW : 100kHzVBW : 10kHzATT : 5dB
(2)High-edge frequencySpectrum analyzer settingCenter-f : 174MHz
(3)Low-edge frequencySpectrum analyzer settingCenter-f : 150MHz
2.Sensitivity TEST CH: Low SSG ANT Check 12dB SINAD or moreCheck Center DVM[Wide] High Oscilloscope
SSG output:–117 dBm(0.3µV) AF VTVMSSG MOD:3.0kHz
[Narrow] TEST CH: CenterSSG output:–115 dBm(0.4µV)SSG MOD:1.5kHz
3.SQL1 TEST CH: Center Programming Write Squelch open(Threshold) Low Software:Writing High KPG-88D[Wide] SSG output:–123 dBm(0.16µV)
SSG MOD:3.0kHz[Narrow] TEST CH: Center
SSG output:–122 dBm(0.18µV)SSG MOD:1.5kHz
4.SQL9 TEST CH: Center(Tight) LowWriting High[Wide] SSG output:–117 dBm(0.3µV)
SSG MOD:3.0kHz[Narrow] TEST CH:Center
SSG output:–116 dBm(0.35µV)SSG MOD:1.5kHz
5.BATT BATT terminal voltage:5.9V DVM ANT Write BATT terminaldetection BATT terminal voltage:5.9VWriting
Receiver Section
Item ConditionMeasurement Adjustment Specifications/
Test equipment Terminal Parts Method Remark
ADJUSTMENT
REF -6.7 dBm
CENTER 162.0 MHz∗RBW 100 kHz ∗VBW 10 kHz ∗SWP 200ms ATT 5 dB
SPAN 100.0 MHz
10dB/ A_Write Norm B_Blank Norm
CENTER162.0 MHz
REF -6.7 dBm
CENTER 174.0 MHz∗RBW 100 kHz ∗VBW 10 kHz ∗SWP 200ms ATT 5 dB
SPAN 100.0 MHz
10dB/ A_Write Norm B_Blank Norm
CENTER174.0 MHz
REF -6.7 dBm
CENTER 150.0 MHz∗RBW 100 kHz ∗VBW 10 kHz ∗SWP 200ms ATT 5 dB
SPAN 100.0 MHz
10dB/ A_Write Norm B_Blank Norm
CENTER150.0 MHz
20
JIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
C21
C22
R404
R405
R406
R407
C27
C32
C33
R416
R419
C
R420
C41
R422
R423
R424R425
C45
C201
R435TH203
C401
C402
C405
C407
C409
C217
C410
C411
C415
C417
R453
C418
R454
C419
C77
C79 C80
C428
C429
C430
C431
C432
C433 C434
C435
C1
C2
C3
C4
C6
C7
C8
D1
D401
Q901
S
IC401
134 5
IC403
IC404
134 5
IC405
IC406
CP404
CP405
D11
R301
R304
L6
MIC301
+ –
L12
R338
C302
IC1
R10
R11
R354 R355 R15
R16
R357
R18
R19
R20
C901
R21
R22
R2
R365
R26
F401
Q8
R30
R31
R1
R2
R3
R4
R5
R6
R8
R9
R42
VR1
C351
C352
C354
C355
Q405
Q407
DG S
Q408
L401
L402
L403
L404
X2
C10
C11
C13
R203
C19
BATT+
1
100
25
26
50
5175
76
1
34
5
1
4 5
8
DG
S
5M
5C
1
1011
20
+
+
+
+ ++
PCTV
BPF
CV
TK-2200L PC BOARD
TX-RX UNIT (X57-6880-XX) -12 : K -13 : K2 Component side view (J79-0047-09)
Ref. No. Address
IC1 9G
IC101 4M
IC302 8P
IC401 4C
IC403 8A
IC404 9A
IC405 7C
IC406 9B
Ref. No. Address
Q8 9J
Q104 5L
Q105 4K
Q107 4L
Q108 4L
Q109 5L
Q303 7P
Q304 7P
Ref. No. Address
Q305 8O
Q306 9P
Q316 9O
Q401 8R
Q402 8R
Q405 5C
Q407 9C
Q408 10C
Ref. No. Address
Q901 9J
D1 8G
D11 9I
D102 4M
D401 4D
D403 8R
D404 8R
21
J K L M N O P Q R S
1
2
3
4
5
6
7
8
9
10
11
12
13
14
R403R
408
1 11
R409
R410
R411
R412
R413
R414
C39
CN401
R421
C41
C45
R436
R437
R438
C403
C80
Q104
Q105 S D
G
Q107
Q108
Q109
Q303
Q304
Q305
Q306
D403
D404
L301
Q316
L302
L111
Q901 D
GS
R121R126
R127
R128
R129
R130
R901
R131
R902
R132
R133
R134
MIC301
+ –
R135
R138
R139
L12
R334
R140
R335
R141
R336
R142
R143
R339 R340
R341
R342R
344
R345
R346 R347
R348
R349
R350
C126
C901
C902
R25R26
C138
Q8
C334
C140
R30
C335
R31
C336
C146
C148
C340
C341
C342
C343
C344
C345
C346
D102
Q401
Q402
IC101IC
302
156 10
BPF
DG
S
5MS OPTDET
PTT/RXD
+
+
MICIN MIC
TXD
AE
SPO
SPI
NC
B
1
45
8
+
SB
SS
DD
GG
CN13ANT
J79-0047-09
SP+SP–
EN5
EN4
EN3
GN
DEN
2EN
1G
ND
SP2
SP1
SB
B
TX-RX UNIT (X57-6880-XX) -12 : K -13 : K2 Component side view (J79-0047-09)
PC BOARD TK-2200L
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
J K L M N O P Q R SIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
C21
C22
R403
R404
R405
R406
R407
C27
R408
1 11
R409
R410
R411
R412
C32
R413
C33
R414
R416
R419
C39
CN401
R420
R421
C41
R422
R423
R424R425
C45
C201
R435
R436
R437
TH203
R438
C401
C402C403
C405
C407
C409
C217
C410
C411
C415
C417
R453
C418
R454
C419
C77
C79 C80
C428
C429
C430
C431
C432
C433 C434
C435
C1
C2
C3
C4
C6
C7
C8
D1
Q104
Q105 S D
G
Q107
Q108
Q109
Q303
Q304
Q305
Q306
D401
D403
D404
L301
Q316
L302
L111
Q901 D
GS
IC401
134 5
IC403
IC404
134 5
IC405
IC406
CP404
CP405
D11
R301
R304
R121R126
L6
R127
R128
R129
R130
R901
R131
R902
R132
R133
R134
MIC301
+ –
R135
R138
R139
L12
R334
R140
R335
R141
R336
R142
R143
R338
R339C302
R340
IC1
R341
R342R
344
R345
R346 R347
R348
R349
R10R350
R11
R354 R355 R15
R16
C126
R357
R18
R19
R20
C901
R21
C902
R22
R25
R365
R26
C138
F401
Q8
C334
C140
R30
C335
R31
C336
R1
R2
C146
R3
R4
C148
R5
R6
R8
C340
R9
C341
C342
C343
C344
C345
C346
R42
VR1
C351
C352
C354
C355
D102
Q401
Q402
Q405
Q407
DG S
Q408
IC101L401
L402
L403
L404
IC302
156 10
X2
C10
C11
C13
R203
C19
BATT+
1
100
25
26
50
5175
76
1
34
5
1
4 5
8
DG
S
5M
5C
1
1011
20
+
+
+
+ ++
PCTV
BPF
CV
DG
S
5MS OPTDET
PTT/RXD
+
+
MICIN MIC
TXD
AE
SPO
SPI
NC
B
1
45
8
+
SB
SS
DD
GG
CN13ANT
J79-0047-09
SP+SP–
EN5
EN4
EN3
GN
DEN
2EN
1G
ND
SP2
SP1
SB
B
TK-2200L PC BOARD
TX-RX UNIT (X57-6880-XX) -12 : K -13 : K2 Component side view (J79-0047-09) TX-RX UNIT (X57-6880-XX) -12 : K -13 : K2 Component side view (J79-0047-09)
PC BOARD TK-2200L
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
Ref. No. Address
IC1 9G
IC101 4M
IC302 8P
IC401 4C
IC403 8A
IC404 9A
IC405 7C
IC406 9B
Ref. No. Address
Q8 9J
Q104 5L
Q105 4K
Q107 4L
Q108 4L
Q109 5L
Q303 7P
Q304 7P
Ref. No. Address
Q305 8O
Q306 9P
Q316 9O
Q401 8R
Q402 8R
Q405 5C
Q407 9C
Q408 10C
Ref. No. Address
Q901 9J
D1 8G
D11 9I
D102 4M
D401 4D
D403 8R
D404 8R
20 21
22
JIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
R221
R222
R223R224
R225
R226
R227
R228
R229
R230
R231
R233
R234
R237 R238
R239
C52C53
C54
R240
R241
R242
R243
C57
C59
C60
C62
C64
C69
C70
R450
C72
C75
C227
C2
S401PTT
S402SW2
S403SW1
C233
C2
C86
C237
C87
C239
C241C242
C243 C
244
C245C
247
C248
C249
TC1
C250
C251C252
C253
C254
R291
C255
C256
C258
Q102
1 234
Q103
D S GQ106
D7
C260
D202C
262
D203
C263
C264
D204
D205
C265
D206
C266
C267
C268
C269
L102
L103
C270
L104
L105
C271
L106
L107
L108
L109
L110
L112
L113L114
C280
L115
L116
L117
L118
L119
R101R103
R107
D10
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R119
R122
R123
R124
R136
R137
L13
C101
L16
C104
TH101
L19
C105
C107
R337
+
C108
R144
C109
L22
C110
C111
L25
R343
C115
C116
C117
C118
C119
C120
C121
C123
C124
C125
C128
C130
C132
C133
C134
C135
C136
C137
Q4
G
D
Q5
C139
C141
R32
C142
C143
C338
R34
C144
C339
R35
R36
C147
C149
R40
C150
C151
C153
C154
C348
C155
C156
C157
R47
C158C
159
C160
R50
D101R
145
D103
D104
D105
D106
Q204
1 234
Q205
L202
L205
L207
L209
L210
L211
L213
L214
J79-0047-09
GD
S
S
+
1
3
4
2
PTT/RXD
J301EXT. SP/EXT. MIC
TXD
AE
SPI
SPO
NC
5MSOPTDETMIC MICIN
TK-2200L PC BOARD
TX-RX UNIT (X57-6880-XX) -12 : K -13 : K2 Foil side view (J79-0047-09)
Ref. No. Address
IC2 7L
IC201 5N
IC301 8P
IC402 4Q
Q1 7O
Q2 8L
Q3 9M
Q4 8J
Q5 8I
Ref. No. Address
Q6 8K
Q7 10L
Q9 6K
Q102 7H
Q103 7H
Q106 7F
Q202 6O
Q203 4N
Q204 4J
Ref. No. Address
Q205 3F
Q301 6P
Q302 9R
Q317 7P
Q318 7P
Q403 4Q
Q404 3Q
D4 9K
D5 10L
Ref. No. Address
D7 10J
D9 10L
D10 9J
D101 7J
D103 4C
D104 4C
D105 3C
D106 3C
D202 6J
Ref. No. Address
D203 5G
D204 5G
D205 4E
D206 4E
D301 10P
D302 10Q
D303 9R
D402 4R
D405 9R
23
J K L M N O P Q R S
1
2
3
4
5
6
7
8
9
10
11
12
13
14
R210
C24
XF201
R211
C25
R212
C26
R213
R215
C29
R216
R217R
218
R219
C30
CN201
C34
R220
C35
R221
R417
C38
R418
R224
C40
C42
C43
C44
R426
C47C
48
C49
C50
C51
C53
C54
C205
C55
C207
C57
C208
C58
CD201
C209
C59
C210
C60
C211
C61
C62
C213
C63
C214
C64
R445
C215
C65
R446
C216
C66
R447
C67
C218
C68
C219
C220
C70
C221
C71
C222
C73
C224
C74
C225
C76
C227
C228
CF201
C78
C421
C230
C231
C81
S402SW2
C426
C232
C82
C233
C427
C83
C234
C84
C85
C235
C236
C86
C237
C87
C238
C239
C90
C244
C440
TC1
C5
TC2
C443
C9
D4
R299
D5D7
D9
D202
Q301
Q302
D402
D405
Q317
Q318
DSG
IC201
1 8916
IC4021 3
45
R101103
D10
R305
R306
R307
R308
R310
R311
R312
R313
R314
L1
R315
R316
L3
R317
R318
L5
R319
L7
L8L9
R320
R321
R322
R323
R324
R325
R326
R327
R328
R329
L10
L11
L13L14
R330
C101
R331
R332
L17
L18
L19
L20
L21
L22
L23
C304L24
L25
C306
IC2 C307
C308
C309
C310
C311
C312
C313
C314
C315
R12
C316
R13
C317
R14 C318
C319
R17
C320
C321
C322
C323
C324
R360
C325
C326
C327
R23
C328
Q1
C329
Q2
Q3 G
S
D
R27
Q4
G
D S
Q6
Q7
L50
C330
Q9
C331
C332C333
R32
R33
R34
R35
R36
R37
R38
R39
R7
R41
R43
C348
R44
R45
R46
R47
R48
R388
R49
R50
D101
R51
Q202
Q203
Q204
23
D301
D302
D303
Q403
DD
S
SG
GQ
404
L201
L202
L203
L204
L205
L206
IC301
1910
1617 25
26
32
X1
C12
C14
C15
C16
C17
C18
R206
R207
R208
R209
1
43
8
+
+ S
GD
+
CV
TX-RX UNIT (X57-6880-XX) -12 : K -13 : K2 Foil side view (J79-0047-09)
PC BOARD TK-2200L
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
J K L M N O P Q R SIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
R210
C24
XF201
R211
C25
R212
C26
R213
R215
C29
R216
R217R
218
R219
C30
CN201
C34
R220
C35
R221
R222
R417
R223
C38
R418
R224
R225
R226
R227
R228
R229
C40
C42
C43
C44
R230
R231
R426
R233
C47C
48
R234
C49
R237 R238
R239
C50
C51
C52C53
C54
R240
C205
R241
C55
R242
C207
R243
C57
C208
C58
CD201
C209
C59
C210
C60
C211
C61
C62
C213
C63
C214
C64
R445
C215
C65
R446
C216
C66
R447
C67
C218
C68
C219
C69
C220
C70
R450
C221
C71
C222
C72
C73
C224
C74
C75
C225
C76
C227
C228
CF201
C78
C421
C230
S401PTT
C231
C81
S402SW2
C426
C232
C82
S403SW1
C233
C427
C83
C234
C84
C85
C235
C236
C86
C237
C87
C238
C239
C90
C241C242
C243 C
244
C245
C247
C248
C249
C440
TC1
C5
TC2
C443
C250
C9
C251C252
C253
C254
R291
C255
C256
C258
Q102
1 234
Q103
D S G
D4
R299
D5
Q106
D7
C260
D9
D202
C262
D203
C263
C264
D204
D205
Q301
C265
D206
Q302
C266
C267
C268
C269
D402
L102
L103
C270
L104
L105
C271
D405
L106
L107
L108
L109
Q317
L110
Q318
DSG
L112
L113
L114
C280
IC201
1 8916
L115
L116
L117
L118
L119
IC4021 3
45
R101R103
R107
D10
R108
R109
R110
R305
R111
R112
R306
R307
R113
R308
R114
R115
R116
R117
R119
R310
R311
R312
R313
R314
L1
R315
R316
R122
L3
R123
R317
R318
R124
L5
R319
L7
L8L9
R320
R321
R322
R323
R324
R325
R326
R327
R328
R329
R136
R137
L10
L11
L13L14
R330
C101
R331
R332
L16
L17
L18
C104
TH101
L19
C105
C107
R337
+
C108
R144
C109
L20
L21
L22
L23
C110
C304L24
C111
L25
C306
IC2 C307
R343
C308
C309
C115
C116
C117
C118
C119
C310
C311
C312
C313
C314
C120
C315
C121
R12
C316
R13
C317
C123
R14 C318
C124
C319
C125
R17
C128
C320
C321
C322
C323
C324
C130
R360
C325
C326
C132
C327
C133
R23
C328
C134
C135
Q1
C329
C136
Q2
C137
Q3 G
S
D
R27
Q4
G
D S
Q5
C139
Q6
Q7
L50
C330
Q9
C331
C332C333
C141
R32
C142
R33
C143
C338
R34
C144
C339
R35
R36
R37
C147
R38
R39
C149
R7
R40
C150
C151
R41
R43
C153
C154
C348
R44
R45
C155
C156
R46
C157
R47
C158
R48
R388
C159
R49
C160
R50
D101
R51
R145
D103
D104
D105
Q202
D106
Q203
Q204
1 234
Q205
D301
D302
D303
Q403
DD
S
SG
GQ
404
L201
L202
L203
L204
L205
L206
L207
L209
L210
L211
L213
L214
IC301
1910
1617 25
26
32
X1
C12
C14
C15
C16
C17
C18
R206
R207
R208
R209
J79-0047-09
GD
S
S
+
1
3
4
2
1
43
8
+
+ S
GD
+
PTT/RXD
J301EXT. SP/EXT. MIC
TXD
AE
SPI
SPO
NC
5MSOPTDETMIC MICIN
CV
TK-2200L PC BOARD
TX-RX UNIT (X57-6880-XX) -12 : K -13 : K2 Foil side view (J79-0047-09) TX-RX UNIT (X57-6880-XX) -12 : K -13 : K2 Foil side view (J79-0047-09)
PC BOARD TK-2200L
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
Ref. No. Address
IC2 7L
IC201 5N
IC301 8P
IC402 4Q
Q1 7O
Q2 8L
Q3 9M
Q4 8J
Q5 8I
Ref. No. Address
Q6 8K
Q7 10L
Q9 6K
Q102 7H
Q103 7H
Q106 7F
Q202 6O
Q203 4N
Q204 4J
Ref. No. Address
Q205 3F
Q301 6P
Q302 9R
Q317 7P
Q318 7P
Q403 4Q
Q404 3Q
D4 9K
D5 10L
Ref. No. Address
D7 10J
D9 10L
D10 9J
D101 7J
D103 4C
D104 4C
D105 3C
D106 3C
D202 6J
Ref. No. Address
D203 5G
D204 5G
D205 4E
D206 4E
D301 10P
D302 10Q
D303 9R
D402 4R
D405 9R
22 23
24
TK-2200L SCHEMATIC DIAGRAM
A B C D E
1
2
3
4
5
6
7
X57-688 1/4
C41
1
1000
p
C41
9
1000
p
C42
9
1000
p
D401RB521S-30
R407
330k
C42
6
1u
C40
7
1000
p
C42
1
1u
C21
10u6
.3
C18
18p
C22
0.33
u35
C26
30p
C12
1000
p
R16
560
R20
10
C11
100p
R15
220
R32 1k
R5
100k
R17
100
L6
R7
100
C9
10p
C14
0.01
u
C34
1000p
C5
1000
p
L3 560n
C25
2p
C6
0.1u
C8
100p
R12
2.2k
R13 0
C17
47p
C16
1000
p
C15
10p
R33
150k
C19
0.1u
R21
680
C7
100p
C24
1000
pC
35
27p
R19
1.5k
C33
1000
p
C50
10p
R14
330k
C13
0.1u
R41
4
330
R1
22k
R41
3
330
L401F4012.5A
C40
3
0.1u
C40
1
470p
D40
2
1SR
154-
400
C40
5
100p
C430
0.01u
L402
C4
0.01u
C29
470p
C40
9
1u
C42
7
1u
R6
100k
R4
56k
C1
3300
p
C2
6800
p
R2
10k
R3
33k
C27
3.3u
16
C10
10u6
.3
D403 D404B30-2157-05
C3
1u
R403
100
R404
470k(D)
R40
6
470k
(D)
R405
330k
R8
0
D1
MA2S111-F
C41
0
1u
C41
7
1u
R41
247
k
R40
947
k
R40
847
k
C42
8
1000
p
S40
1
S40
2
S40
3
C40
2
1000
p
C44
470p
R27 22
C48
470p
C42 6pC38 6p
C40
4pC43
15p
1O
SC
IN2
NC
13
OS
CO
UT
4V
P5
VC
C6
DO
7G
ND
8LD
9N
C2
10F
IN11121314151617181920
R41
047
k
R41
147
k
C30
470p
X1
12.8MHz
L77-1931-05
1VC
2GND
3oUTPUT
4VCC
R18 0
R436
0R
437
47k
R43
8
47k
VR168k
R32-0736-05
CP404
47Kx2
CN4011 B
2 SB
3 SP1
4 SP2
5 GND
6 EN1
7 EN2
8 GND
EN3
EN4
EN5
IC403 BD4840FVE
1VoUT
2SUB
3NC
4GND
5VDD
IC404BD4845FVE
1VoUT
2SUB
3NC
4GND
5VDD
IC402XC6204B502MR
1VIN
2VSS
3CE
4NC
5VoUT
IC401XC6204B502MR
1VIN
2VSS
3CE
4NC
5VoUT
C41
5
470p
KTC4082Q1
L5 560n
CPH3317Q403
C44
3
0.47
u
L1
4.7u
L7
CPH3317Q404
2SC5108(Y)FQ2
C41
8
1000
p
Q402Q401
Q405RT1P237U-T111
L8
18n
L9
33n
SW1 SW2PTT
BATT
TX-RX UNIT (X57-6880-XX) -12:K -13:K2
TXCO
LED/GREEN
LED SW/GREEN
LED SW/RED
5C SW
VOLTAGE DETECTOR/RESET
VOLTAGEDETECTOR/INT
5T SW
5R SW
LEDTX
LEDRX
LOCK
SCAN
REVERSEPROTECTION
TRIPLER
RIPPLEFILTER
PLL IC F_IN AMP
BATT
5V PROTECTION
5M
5C_C5R_C5T_CBATT
RESETINT
PTT
SB
VCC
VSS
VCCVSS
X57-6880-XX
-12
-13
K
K2
47k
47k
R416 R453
NO
NO
PLL_CLK
PLL_DAT
PLL_STB
0
0
0
R9
R10
R11
CLO
CK
NC
3
DAT
ALEFC
NC
4
FO
UTP
NC
5R
QTTCXO
OSCIN
EN1
EN5
PLL_UL
5RSP2
EN4
PLL_STB
5T
EN3
PLL_DAT
5C
EN2
PLL_CLKB
SP1
B30-2156-05
LED/RED
RT1N141URT1N141U
9
10
11
IC1MB15A02PFV2E1
PLL SYSTEM
VOLTAGEREGULATOR/5V
IC401,402
ON:4.92VOFF:0.01V
ON:4.92VOFF:0.01V
4.96V
5.00V
R:7.28VT:6.80V
R:7.56VT:7.26V
R:3.70VT:3.57V
R:5.01V
T:4.99V
R:4.83V
4.72V
4.84V
4.76V
4.95V
2.73V
0.7V
4.83V
SCHEMATIC DIAGRAM TK-2200L
L22
C32
0.1u
35
TC
2
10p
C74
0.5p
C54 6p
C73
0.5p(B)
R40
100
D5
1SV
325F
C66 5p
C76
1000
pC
79
10u6
.3
C57
1.5p
C67 5p
C80
470p
C55
120p
R39
150
R22
0
R34
4.7k
R42
4.7k
D9
1SV325F
D7
1SV325F
R36
270k
C59
1.5p
TC
1
10p
C61 4p
C49
100p C58 9p
C47
100p
R23
10k
C78
33p
R38
180
D10
1SV
278F
2SK508NV(K52)Q4
C52
180p
R43
100
D4
1SV
325F
L24
C69
470p
D11
MA
2S11
1-F
R30
12k
C45
1u
C30
4
0.22
u
R308
0
D301RB706F-40
R30
5
100k
R31
560k
C302
0.01u
R301
47k
C39
3300
p
C41
6800
p
L404
L403
C431
0.01u
C43
3
3p
2SK1830FQ408
C432
5p
R422
1k R423
0
C435
5p
R33
82.
2k
R25
22k
R26
10k
R421
1k
R420
47k
R419
47k
R41
150k
R35
270k
C62 5p
R42447k
R42547k
L12
L16
39n
C60 1p
C77
470p
L21
3.3u
C644p
C70
470p
C72
0.1u
L19
220n
C75
1000
p
L17
27n
C655p
L20
3.3u
C71
0.1u
L18
220n
C68
470p
C63
100p
R37
100
2SK1830FQ407
C43
4
3p
R416*R354
10k
R357
0
R41
8
47k
R41
7
47k
R43
5
47k
IC406BR24L08F-W
1A0
2A1
3A2
4GND
5SDA
6SCL
7WP
8VCC
C53
0.5p
X2
7.37MHzL78-1414-05
R44 1k
C51
1000
p
C83
1000p
C84
1000
p
C8115p
R45
3.3k
R51 10
R46
3.3k
IC2UPB1509GV
1VCC1
2IN
3IN
4GND
5SW1
6SW2
7OUT
8VCC2
R47 47
C82
1000p
C90
1000
p
R447
4.7k
L50
CP
405
1Kx2
R36
5
47k
2SC5108(Y)FQ6
R426
0
R901
4.7k
R45
3* R
454
47k
C902
1u
2SK1824-AQ901
C90
1
1u
R90
2
4.7k
Q5RT1P430U
Q7RT1P430U
2SC5383-T111Q8
1PCTV
2DTMF
3
4EEPDAT
5EEPCLK
6BYTE
7GND
8BSHIFT
9
10RESET
11XOUT
12VSS
13XIN
14VCC
15VCC
16INT
17TCLK/DTRDO
18RDF/FD
19SCLK
20DI/O
21TDATA/DTRCLK
22
23
24
QTVCO
25
DTRLOADN
261/
2OS
C
27P
TT
28Q
TT
CX
O
29T
XD
30R
XD
31G
ND
32A
PC
SW
333435D
CS
W
36T
X_W
/N
37R
X_S
W
38T
X_S
W
39G
ND
40P
LL_U
L
41P
LL_S
TB
42P
LL_D
AT
43P
LL_C
LK
44V
CC
45R
X_W
/N
46E
N5
47E
N4
48E
N3
49E
N2
50E
N1
51OPTDET52AF_CONT
53CALLING ALERT SW
54DTMF SW
55
56
5758
59
60 VCC6162
VSS63 GND64 GND65
66
67
6869
7071
72 LEDTX73 LEDRX74
PF175
PF2
76S
IM1
77S
IM2
78 79 805T
_C81
5R_C
825C
_C83 84 85 86 87 88
BAT
T89
RS
SI
90B
US
Y91
VO
X92
QT
/DQ
T_I
N93
TH
_DE
T94
AV
SS
95 96V
RE
F97
AV
CC
98 99M
IC_M
UT
E10
0
L10
180n
L13
220n
L11
100n
L14
220n
L23
39n
CV
3.6864 MHz CLK
VCO OSCILLATION (TX)
VCO OSCILLATION (RX)
TX MODULATION
VCO 1/2 DIVIDER
EEPROM
BEAT SHIFT SW
LOCK
LEDTX
LEDRX
SCAN
TDATA/DTRCLK
TCLK/DTRDO
MOD
PLL_CLKPLL_DATPLL_STBPLL_ULQTTCXO
OSCIN
5T
SP2
EN1
EN2
EN3
EN4
EN5
VCC
OSCIN
5T
5R5R
BATT5T_C5R_C5C_C
RDF/FD
XIN
DIR
SCLK
DTRLOADN
STD
DI/O
DETECTOR
AF_CONT
OPTDET
VCO/TX
FREQUENCYCONTROL/RX VCO
D5,9
VCO/RX
RF BUFFER AMP
DC SW/TX VCO
DC SW/RX VCO
RIPPLE FILTER
BUSY
PTTOPTDET
RSSI
QT/DQT_INMIC_MUTE
5M
TXDPCTV
SBAF_CONT
FREQUENCYCONTROL/TX VCO
D4,7
MODULATOR
CURRENTSTEERING
5C
B
5C
5M
B
RESETINT
AMP3O
APCSW
TH_DET
PTT
SB
SP1
SP2
SP1
DCSW
RX_W/NTX_W/N
VSS
VSSVCC
BEAT SHIFT SW
DTMF SWCALLING ALERT SW
W/N SW/TX
2SK508NV(K52)Q3
DIRSTD
C35
1
0.01
u
C35
2
0.01
u
C354
0.1u
R355
10k
IC40530622MAPA49GU
MICROPROCESSOR
4.96V
R:3.46V
T:3.42V
0.72V
3.74V
R:4.97VT:0.59V
4.74V
R:0.60VT:4.95V
BSHIFT ON:4.95VOFF:0V
F G H I J
TX-RX UNIT (X57-6880-XX) -12:K -13:K2
X57-688 2/4
TK-2200L SCHEMATIC DIAGRAM
-t
-t
C32
1
1u
C20
9
10u6
.3
C12
6
1u25
R130
150k(D)
R21
3
3.9k
R21
8
560
R14
0
56k
C22
4
0.01
u
R13
9
47k
R13
3
150k
(D)
R13
8
1M
R21
2
82k
C20
7
1800
p
TH
101
100k
R216
120k
C219
33p
C13
8
1000
p
C317
0.1u
C140
100p
R131
150k(D)
D10
2
HZ
U5C
LL
R14
3
100k
C210
470p
C22
0
1000
p
C231
0.01u
C21
5
1000
p
R12
7
0.39
R12
9
0.39
R12
8
0.39
R21
5
100
R141
100k
R135150k (D)
C213
0.1u
C14
8
1000
p
C22
5
0.01
u
IC201TA31136FNG
1O
SC
IN
2O
SC
OU
T
3M
IXO
UT
4V
CC
5IF
IN
6D
EC
7F
ILO
UT
8F
ILIN
9A
FO
UT
10Q
UA
D
11IF
OU
T
12R
SS
I
13N
-DE
T
14N
-RE
C
15G
ND
16M
IXIN
C20
1
0.22
u
R134
150k (D)
C21
7
0.1u
C20
8
470p
R210
3.3k
R13
2
150k
(D)
R12
6
2.2k
R11
5
8.2k
C21
4
68p
R20
74.
7k
R208
82k
2SC4649(N,P)Q203
2SK1824-AQ108
C146
1000p
C22
1
0.1u
C21
1
0.01
u
R20
9
2.7k
C326
1000p
R31
2
330k R316
120k
C309
82p
R324
100k
C30
80.
1u
R32
7
180k
R31
5
330k
C312
12p
C325
0.1uC331
0.1u
C30
64.
7u6.
3
C322
0.015u
R329
82k
C328
390p
R325
100k
C32
4
82p
C3200.01u
C30
7
0.1u
C310
0.068u
R332
15k
C31
9
270p
C32
3
82p
C316
0.047u
C333
0.1u
C311
1u
C313
120p
R314
10k
R304
560k
R318
1.2kR328
10k
R313
100k
R311
12k
R211
3.3k
R310
390k
C330
1u
1A
GN
DIN
2T
XIN
3T
XIN
O
4LI
MLV
5E
XT
LIM
IN
6M
OD
7V
DD
8
DTRLOADN
9
STD
10TCLK/DTRDO
11TDATA/DTRCLK
12DI/O
13RDF/FD
14SCLK
15DIR
16XOUT
17X
IN18
VS
S
19A
MP
3P
20A
MP
3N
21A
MP
3O
22A
MP
4P
23A
MP
4N
24A
MP
4O
25D
TR
AIN
26RXAF
27RXAFIN
28EXPOUT
29FILTERO
30RXINO
31RXIN
32AGND
R20
3
180k
CD
201
C21
6
0.1u
C21
8
0.1u
C329
1u
2SK879(Y)FQ105
R326
0
R321
220k
R331
39k
R12
156
0
R30
7
0
R330
3.3k
2SC4919Q302
L201 1u
C315
1u
IC101TA75W01FUF
1OUT1
2IN1-
3IN1+
4VEE
5IN2+
6IN2-
7OUT-B
8VCC
R14
2
0
C44
0
1.5p
C22
810
p
R306
1k
R31
7
470k
Q301RT1P141U
R319
56k
R32
03.
3k
R32356k C
327
100p
R322
180k
D302RB706F-40
D303DAN222
TH
203
100k
XF201L71-0619-05
1
IN
2
OUT
6543
C31
8
4.7u
6.3
R445
0
R446
0
R360
0
C33
2
470p
R219
560
R103
0
R48
330 C10
7
1000
p
L105
150n
L104
27n
R50
4.7k
C86
1000
p
L103
R11
0
330
C101
1000p
L107
27n
C22
7
1000
p
C10
510
00p
C11
6
22p
D20
2
HS
C27
7 C11
5
1000
p
C11
8
100p
R11
7
220k
C104
39p
C12
4
1000
p
R49
2.2k
C11
7
10pD101
HSC277
L106
R144
0
C108
39p
R11
3
330C87
10p R12
382
R12
2
47k
2SC5108(Y)FQ9
R10
915
C11
9
27p
R10
7
560
R11
4
68k
C85
1000
p
C120
1000p
C110
1000p
R10
1
12k
R12
4
82k
R11
1
330
R112
18
C11
1
1000
p
R11
9
330
R11
6
15
R108
1.5k
C10
9
0.1u
R21
7
4.7k
C22
2
1000
p
C233
2p(B)
C23
0
8p
C23
5
9p
C237
5p(B)
C23
9
6p(B
)
2SC4926YDQ102
CF201L72-0973-05
R20
6
10
MICO MICI
RXAFIRXAFO
2SK1824-AQ317
Q3182SK1824-AC355
0.1u
Q104RT1N141U
2SK2596Q103 R450
0
Q107RT1N141U
D40
5
KD
Z3.
3V
R388 0
Q202RT1P441U
C20
5
1000
p
R29
9
0
L102
100n
L205
68n
R145
0L2
5
82n
L202
39n
38.4
MH
z
TX DRIVE AMP
W/N SW/RX
TDATA/DTRCLK
TCLK/DTRDO
DI/O
RDF/FD
SCLK
DIR
XIN
STD
DTRLOADN
MOD
OSCIN
5T
5R
SB
DETECTOR
OPTDET
AF_CONT
TXD
5M
RSSI
PTT
FM IFSYSTEM
MIC AGCISOLATION
IF AMP
PCTV
5R
APC SW
APC SW
RF AMP
RF AMP
APC SW
QT/DQT_INMIC_MUTEBUSY
PTT5M
TXD
PCTV
SB
TX FINAL AMP
APC SW
TX/RXRF SW
APC PROTECT
5C
B
D101,202
5T
AMP3O
APCSW
TH_DETSP2
SP1
SP2
DCSW
RX_W/NTX_W/N
AF_CONT
OPTDET
RX LO1
DTMF SWCALLING ALERT SW
LIMITER
RSSIBUSY
PCTV
AUDIO SW
Q317,318
C31
40.
1u
IC301AQUA-L
AUDIO PROCESSOR
Q109RT1P441U
APC SW
C12
3
1u
C12
1
10p
C12
8
1000
p
C12
5
1000
p
C13
3
0.01
u
2SK2595-EQ106
COMPARATOR(APC)
W/N SW/TX
2.2V
4.6V
R:2.84V
T:1.13V
T:4.89VR:7.53VT:7.41V
T:2.7V(H)1.99V(L)
W:0.011VN:4.98V
R:0.29VT:3.09V
T:4.94V
R:5.0VT:0V
K L M N O
X57-688 3/4
TX-RX UNIT (X57-6880-XX) -12:K -13:K2
27
SCHEMATIC DIAGRAM TK-2200LTSRQP
1
2
3
4
5
6
7
R337
150
R345
100
R33
9
470
C34
4
220p
R334
47k
C34
2
10u6
.3
R33
5
2.2k
2SA1362-F(GR)Q304
C339
10u6.3
C33
6
0.47
u
R34
0
1.8k
J301
PTT/RXDMIC
MICINOPTDET
5MSAE
TXDNC
SPOSPI
C334
0.1u
R346 100
L301
C34
1
0.04
7u
C338 100p
R34
9
33kC33
5
220p
R34
2
10
R344 1k
L302
R336
1k
C340
0.1u
C345
100u6.3
R35
0
0
C34
3
0.04
7u
R34
8
56k
R343
470k
IC302TA7368FG
1NC1
2VCC
3NC2
4VIN
5RIPPLE
6NF
7PHASE
8PRE-GND
9PW-GND
10PoUT
MIC301
R34
7
100k
2SK3577-AQ306
R341 10k
C34
6
1000
pC
348
470p
C144
82p
C15
5
18p
L119
6T
L108
C15
7
15p
C14
9
24p
C13
2
1000
p
C15
0
22p
C14
2
15p
L109
2.2u
C159
7p
C14
3
10p
L112
9T
C13
0
10p
C14
1
20p
C13
4
0.1u
C15
3
10p
L116
8T
L113
3T
C13
9
68p
C13
7
0.01
u
L117
7T
D10
5
HV
C13
1
D10
6
HV
C13
1
C151
1000p
L114
5T
R13
7
270
L115
5T
C15
8
22p
D103
HVC131
L111
1u
D104
HVC131
C13
5
1u
C156
12p
C154
10p
L118
7T
C14
7
1000
p
C13
6
27p
C160
33p
R13
6
270
L209
56n
D20
6
1SV
305F
R22
9
1M
R220
560
C24
8
27p
R22
8
1M
D20
3
1SV
305F
L210
C24
9
1000
p
R240
0
L211
56n
R22
3
82k
C26
9
33p
C253
4.5p
R23
3
220
C250
4p
C24
1
1000
p R24
2
1M
L204
560n
R24
1
1M
C25
4
27p
C26
4
4p
C26
0
1000
p
R239
47
R22
1
1k
C23
2
0.01
u
C263
10p
C24
2
0.1u
R22
5
82k
L213
56n
C25
2
1000
p
R23
4
100k
C24
7
4p(B
)
C245
470p
C271
11p
C268
C26
5
33p
C27
0
4p
C238
12pC267
C23
6
1000
p
D20
5
1SV
305F
R231
47
R23
7
180k
L214
47n
C25
5
4.5p
(B)
3SK318Q205
C24
4
4p(B
)
R22
2
220
C25
1
4.7u
6.3
C2431000p
R23
8
100k
3SK318Q204
C23
4
0.01
u
C26
2
1000
p
D20
4
1SV
305F
R23
0
2.2k
C25
6
1000
p
R227
0C
266
1000
p
R24
3
0
R22
4
82k
BPF
R22
6
82k
C25
8
1000
p
R291
0
2SK3577-AQ316
C28
0
1000
p
CN201
L203
Q303RT1N441U
Q305RT1N441U
L207
150n
L206
180n
L110
56n
ANTCN13
ANT SW
DC SW
AF AMP
SP MUTE SW
SP MUTE SW
DC SW/SP MUTE
5R
MIXER
DC SW/SP MUTE
PTT5MSB
TXD
PCTV
RF AMP
ANT SW
ANT SW ANT SW
RF BPF TUNING
D203,204 D205,206
RF BPF TUNING
5T
SP2
OPTDET
AF_CONT
RX LO1
3p3p(B)(B)
(B)(B)
R:0.99V
R:4.98V
R:2.48V
R:2.48V
R:0.75V
R:4.8V R:4.92V
R:1.76V
R:7.52VT:7.31V
R:0.3V(MUTE ON)7.3V(MUTE OFF)
T:0.3V
R:7.3V(MUTE ON)0.3V(MUTE OFF)
T:7.3V
X57-688 4/4
TX-RX UNIT (X57-6880-XX) -12:K -13:K2Note : The components marked with a dot ( ) are parts of layer 1.
-t
-t
C41
1
1000
p
C41
9
1000
p
C42
9
1000
p
D401RB521S-30
R407
330k
C42
6
1u
C32
1
1u
C40
7
1000
p
C42
1
1u
C20
9
10u6
.3
C12
6
1u25
C21
10u6
.3
R130
150k(D)
L22
R21
3
3.9k
R21
8
560
C32
0.1u
35
TC
2
10p
C74
0.5p
C18
18p
C54 6p
R14
0
56k
C22
4
0.01
u
R13
9
47k
C73
0.5p(B)
R40
100
R13
3
150k
(D)
D5
1SV
325F
C22
0.33
u35
C66 5p
R13
8
1M
R21
2
82k
C26
30p
C12
1000
p
C76
1000
p
R16
560
C20
7
1800
p
TH
101
100k
C79
10u6
.3
R216
120k
R20
10
C11
100p
C57
1.5p
C67 5p
C219
33p
C13
8
1000
p
C80
470p
C317
0.1u
C140
100p
R15
220
R131
150k(D)
C55
120p
R39
150
D10
2
HZ
U5C
LL
R22
0
R32 1k
R34
4.7k
R42
4.7k
R14
3
100k
C210
470p
C22
0
1000
p
C231
0.01u
C21
5
1000
p
D9
1SV325F
R12
7
0.39
R12
9
0.39
R5
100k
R17
100
L6
R7
100
R12
8
0.39
R21
5
100
D7
1SV325F
C9
10p
R36
270k
R141
100k
C14
0.01
u
C59
1.5p
R135150k (D)
C213
0.1u
TC
1
10p
C14
8
1000
pC34
1000p C61 4p
C22
5
0.01
u
C5
1000
p
L3 560n
C25
2p
C49
100p
C6
0.1u
C8
100p
R12
2.2k
IC201TA31136FNG
1O
SC
IN
2O
SC
OU
T
3M
IXO
UT
4V
CC
5IF
IN
6D
EC
7F
ILO
UT
8F
ILIN
9A
FO
UT
10Q
UA
D
11IF
OU
T
12R
SS
I
13N
-DE
T
14N
-RE
C
15G
ND
16M
IXIN
C58 9p
C20
1
0.22
u
C47
100p
R13 0
R23
10k
R134
150k (D)
C21
7
0.1u
C20
8
470p
R210
3.3k
C78
33p
R13
2
150k
(D)
R38
180
D10
1SV
278F
R12
6
2.2k
2SK508NV(K52)Q4
C17
47p
R11
5
8.2k
C16
1000
p
C52
180p
C15
10p
R33
150k
C21
4
68p
R43
100
C19
0.1u
R21
680
R20
74.
7k
R208
82k
D4
1SV
325F
L24C7
100p
2SC4649(N,P)Q203
2SK1824-AQ108
C146
1000p
C22
1
0.1u
C69
470p
C21
1
0.01
u
C24
1000
p
D11
MA
2S11
1-F
C35
27p
R20
9
2.7k
R30
12kR19
1.5k
C33
1000
p
C50
10p
R14
330k
C326
1000p
R31
2
330k R316
120k
C45
1u
C13
0.1u
C309
82p
R324
100k
C30
80.
1u
R32
7
180k
R31
5
330k
C312
12p
C325
0.1uC331
0.1u
C30
64.
7u6.
3
C322
0.015u
R329
82k
C328
390p
R325
100k
C32
4
82p
C3200.01u
C30
7
0.1u
C310
0.068u
R332
15k
C31
9
270p
C32
3
82p
C316
0.047u
R337
150
C30
4
0.22
u
R345
100
R33
9
470
C34
4
220p
R334
47k
R308
0
C34
2
10u6
.3
R33
5
2.2k
2SA1362-F(GR)Q304
C339
10u6.3
R41
4
330
C33
6
0.47
u
R34
0
1.8k
J301
PTT/RXDMIC
MICINOPTDET
5MSAE
TXDNC
SPOSPI
C334
0.1u
D301RB706F-40
R346 100
C333
0.1u
L301
C34
1
0.04
7u
C338 100p
R34
9
33kC33
5
220p
R34
2
10
R344 1k
L302
R336
1k
C340
0.1u
C345
100u6.3
R35
0
0
C34
3
0.04
7u
C311
1u
R34
8
56k
R343
470k
R1
22k
IC302TA7368FG
1NC1
2VCC
3NC2
4VIN
5RIPPLE
6NF
7PHASE
8PRE-GND
9PW-GND
10PoUT
R30
5
100k
MIC301
R41
3
330
L401F4012.5A
C40
3
0.1u
C40
1
470p
D40
2
1SR
154-
400
C40
5
100p
R31
560k
C302
0.01u C313
120p
R314
10k
R304
560k
R301
47k
R318
1.2kR328
10k
C39
3300
p
C41
6800
p
R313
100k
L404
C430
0.01u
L402
R311
12k
L403
C431
0.01u
R211
3.3k
R310
390k
C4
0.01u
C330
1u
1A
GN
DIN
2T
XIN
3T
XIN
O
4LI
MLV
5E
XT
LIM
IN
6M
OD
7V
DD
8
DTRLOADN
9
STD
10TCLK/DTRDO
11TDATA/DTRCLK
12DI/O
13RDF/FD
14SCLK
15DIR
16XOUT
17X
IN18
VS
S
19A
MP
3P
20A
MP
3N
21A
MP
3O
22A
MP
4P
23A
MP
4N
24A
MP
4O
25D
TR
AIN
26RXAF
27RXAFIN
28EXPOUT
29FILTERO
30RXINO
31RXIN
32AGND
C29
470pC
409
1u
C42
7
1u
C43
3
3p
2SK1830FQ408
C432
5p
R422
1k R423
0
C435
5p
R6
100k
R4
56k
C1
3300
p
C2
6800
p
R2
10k
R3
33k
C27
3.3u
16
R20
3
180k
R33
82.
2k
CD
201
C10
10u6
.3
D403 D404B30-2157-05
C3
1u
C21
6
0.1u
C21
8
0.1u
C329
1u
2SK879(Y)FQ105
R403
100
R34
7
100k
R25
22k
R26
10k
R326
0
R321
220k
R331
39k
R404
470k(D)
R40
6
470k
(D)
R405
330k
R8
0
R421
1k
R12
156
0
R420
47k
D1
MA2S111-F
2SK3577-AQ306
C41
0
1u
R30
7
0
R330
3.3k
R341 10k
2SC4919Q302
L201 1u
C41
7
1u
C315
1u
IC101TA75W01FUF
1OUT1
2IN1-
3IN1+
4VEE
5IN2+
6IN2-
7OUT-B
8VCC
R14
2
0
R419
47k
R41
150k
R35
270k
C62 5p
R41
247
k
R40
947
k
R42447k
R40
847
k
R42547k
C42
8
1000
p
C44
0
1.5p
C22
810
p
S40
1
S40
2
S40
3
C40
2
1000
p
C34
6
1000
p
L12
L16
39n
C60 1p
C77
470p
L21
3.3u
C644p
C70
470p
C72
0.1u
L19
220n
C75
1000
p
L17
27n
C655p
L20
3.3u
C71
0.1u
L18
220n
C68
470p
C63
100p
R37
100
C44
470p
R27 22
C48
470p
C42 6pC38 6p
C40
4pC43
15p
2SK1830FQ407
C43
4
3p
R306
1k
R31
7
470k
Q301RT1P141U
R319
56k
R32
03.
3k
R32356k C
327
100p
R322
180k
D302RB706F-40
D303DAN222
TH
203
100k
1O
SC
IN2
NC
13
OS
CO
UT
4V
P5
VC
C6
DO
7G
ND
8LD
9N
C2
10F
IN11121314151617181920
XF201L71-0619-05
1
IN
2
OUT
6543
R41
047
k
R41
147
k
C31
8
4.7u
6.3
R416*
C30
470p
X1
12.8MHz
L77-1931-05
1VC
2GND
3oUTPUT
4VCC
R354
10k
R357
0
R41
8
47k
R41
7
47k
R18 0
R43
5
47k
R436
0
R43
7
47k
R43
8
47k
VR168k
R32-0736-05
R445
0
R446
0
CP404
47Kx2
CN4011 B
2 SB
3 SP1
4 SP2
5 GND
6 EN1
7 EN2
8 GND
EN3
EN4
EN5
R360
0
IC403 BD4840FVE
1VoUT
2SUB
3NC
4GND
5VDD
IC404BD4845FVE
1VoUT
2SUB
3NC
4GND
5VDD
IC402XC6204B502MR
1VIN
2VSS
3CE
4NC
5VoUT
IC401XC6204B502MR
1VIN
2VSS
3CE
4NC
5VoUT
IC406BR24L08F-W
1A0
2A1
3A2
4GND
5SDA
6SCL
7WP
8VCC
C41
5
470p
C33
2
470p
C34
8
470p
C53
0.5p
R219
560
X2
7.37MHzL78-1414-05
C144
82p
R103
0
R44 1k
R48
330 C10
7
1000
p
L105
150n
C15
5
18p
C51
1000
p
L104
27n
L119
6T
R50
4.7k
C83
1000p
L108
C15
7
15p
C86
1000
p
C14
9
24p
L103
R11
0
330
C13
2
1000
p
C15
0
22p
C14
2
15p
C84
1000
p
C101
1000p
L107
27n
C22
7
1000
p
C10
510
00p
L109
2.2uC81
15p
C159
7p
C14
3
10p
L112
9T
C13
0
10p
C11
6
22p
R45
3.3k
D20
2
HS
C27
7
C14
1
20p
C13
4
0.1u
C11
5
1000
p
C11
8
100p
C15
3
10p
R11
7
220k
R51 10
C104
39p
L116
8T
L113
3T
C13
9
68p
C13
7
0.01
u
L117
7T
C12
4
1000
p
R49
2.2k
C11
7
10pD101
HSC277
D10
5
HV
C13
1
D10
6
HV
C13
1
R46
3.3k
C151
1000p
L106
R144
0
L114
5T
R13
7
270
L115
5T
C108
39p
R11
3
330C87
10p
IC2UPB1509GV
1VCC1
2IN
3IN
4GND
5SW1
6SW2
7OUT
8VCC2
R47 47
C15
8
22p
R12
382
R12
2
47k
D103
HVC131
2SC5108(Y)FQ9
R10
915
L111
1uC11
9
27p
D104
HVC131
C13
5
1u
R10
7
560
R11
4
68k
C85
1000
p
C156
12p
C154
10p
L118
7T
C82
1000p
C120
1000p
C14
7
1000
p
C110
1000p
R10
1
12k
C13
6
27p
C160
33p
R12
4
82k
R11
1
330
R112
18
R13
6
270
C11
1
1000
p
R11
9
330
R11
6
15
R108
1.5k
C10
9
0.1u
R21
7
4.7k
C22
2
1000
p
C233
2p(B)
C23
0
8p
C23
5
9p
C237
5p(B)
C23
9
6p(B
)
L209
56n
D20
6
1SV
305F
R22
9
1M
R220
560
C24
8
27p
R22
8
1M
D20
3
1SV
305F
L210
C24
9
1000
p
R240
0
L211
56n
R22
3
82k
C26
9
33p
C253
4.5p
R23
3
220
C250
4p
C24
1
1000
p R24
2
1M
L204
560n
R24
1
1M
C25
4
27p
C26
4
4p
C26
0
1000
p
R239
47
R22
1
1k
C23
2
0.01
u
C263
10p
C24
2
0.1u
R22
5
82k
L213
56n
C25
2
1000
p
R23
4
100k
C24
7
4p(B
)
C245
470p
C271
11p
C268
C26
5
33p
C27
0
4p
C238
12pC267
C23
6
1000
p
D20
5
1SV
305F
R231
47
R23
7
180k
L214
47n
C25
5
4.5p
(B)
3SK318Q205
C24
4
4p(B
)
R22
2
220
C25
1
4.7u
6.3
C2431000p
R23
8
100k
3SK318Q204
C23
4
0.01
u
C26
2
1000
p
D20
4
1SV
305F
R23
0
2.2k
C25
6
1000
p
R227
0
C26
6
1000
p
R24
3
0
R22
4
82k
BPF
R22
6
82k
C25
8
1000
p
KTC4082Q1
2SC4926YDQ102
C90
1000
p
R447
4.7k
L5 560n
CPH3317Q403
R291
0
C44
3
0.47
u
L1
4.7u
L7
L50
CP
405
1Kx2
CPH3317Q404
2SK3577-AQ316
C28
0
1000
p
R36
5
47k
CF201L72-0973-05
CN201
R20
6
10
2SC5108(Y)FQ2
2SC5108(Y)FQ6
C41
8
1000
p
R426
0
MICO MICI
RXAFIRXAFO
L203R901
4.7k
Q402Q401
R45
3* R
454
47k
C902
1u
2SK1824-AQ901
C90
1
1u
R90
2
4.7k
2SK1824-AQ317
Q3182SK1824-AC355
0.1u
Q5RT1P430U
Q7RT1P430U
2SC5383-T111Q8
Q104RT1N141U
2SK2596Q103 R450
0
Q107RT1N141U
D40
5
KD
Z3.
3V
R388 0
Q202RT1P441U
C20
5
1000
p
R29
9
0
Q303RT1N441U
Q305RT1N441U
Q405RT1P237U-T111
1PCTV
2DTMF
3
4EEPDAT
5EEPCLK
6BYTE
7GND
8BSHIFT
9
10RESET
11XOUT
12VSS
13XIN
14VCC
15VCC
16INT
17TCLK/DTRDO
18RDF/FD
19SCLK
20DI/O
21TDATA/DTRCLK
22
23
24
QTVCO
25
DTRLOADN
261/
2OS
C
27P
TT
28Q
TT
CX
O
29T
XD
30R
XD
31G
ND
32A
PC
SW
333435D
CS
W
36T
X_W
/N
37R
X_S
W
38T
X_S
W
39G
ND
40P
LL_U
L
41P
LL_S
TB
42P
LL_D
AT
43P
LL_C
LK
44V
CC
45R
X_W
/N
46E
N5
47E
N4
48E
N3
49E
N2
50E
N1
51OPTDET52AF_CONT
53CALLING ALERT SW
54DTMF SW
55
56
5758
59
60 VCC6162
VSS63 GND64 GND65
66
67
6869
7071
72 LEDTX73 LEDRX74
PF175
PF2
76S
IM1
77S
IM2
78 79 805T
_C81
5R_C
825C
_C83 84 85 86 87 88
BAT
T89
RS
SI
90B
US
Y91
VO
X92
QT
/DQ
T_I
N93
TH
_DE
T94
AV
SS
95 96V
RE
F97
AV
CC
98 99M
IC_M
UT
E10
0
L8
18n
L9
33n
L10
180n
L13
220n
L11
100n
L14
220n
L23
39n
L102
100n
L207
150n
L206
180n
L205
68n
L110
56n
R145
0
L25
82n
L202
39n
ANTCV
SW1 SW2PTT
BATT
TX-RX UNIT (X57-6880-XX) -12:K -13:K2
CN13
TXCO
3.6864 MHz CLK
38.4
MH
z
VCO OSCILLATION (TX)
VCO OSCILLATION (RX)
TX MODULATION
TX DRIVE AMP
VCO 1/2 DIVIDER
EEPROM
W/N SW/RX
ANT SW
LED/GREEN
LED SW/GREEN
LED SW/RED
5C SW
VOLTAGE DETECTOR/RESET
VOLTAGEDETECTOR/INT
5T SW
5R SW
BEAT SHIFT SW
LEDTX
LEDRX
LOCK
SCAN
REVERSEPROTECTION
LOCK
LEDTX
LEDRX
SCAN
TRIPLER
RIPPLEFILTER
PLL IC F_IN AMP
TDATA/DTRCLKTDATA/DTRCLK
TCLK/DTRDOTCLK/DTRDO
DI/O
RDF/FD
SCLK
DIR
XIN
STD
DTRLOADN
MODMOD
PLL_CLKPLL_DATPLL_STBPLL_ULQTTCXO
OSCIN
5T
SP2
EN1
EN2
EN3
EN4
EN5
VCC
BATT
OSCIN OSCIN
5T 5T
5R5R5R
BATT5T_C5R_C5C_C
SB
DETECTOR
RDF/FD
XIN
DIR
SCLK
DTRLOADN
STD
DI/O
DETECTOR
AF_CONT
OPTDET OPTDET
AF_CONT
TXD
5M
RSSI
PTT
DC SW
FM IFSYSTEM
MIC AGCISOLATION
IF AMP
AF AMP
SP MUTE SW
SP MUTE SW
DC SW/SP MUTE
PCTV
5R 5R
VCO/TX
FREQUENCYCONTROL/RX VCO
D5,9
VCO/RX
APC SW
MIXER
APC SW
RF AMP
RF BUFFER AMP
DC SW/TX VCO
DC SW/RX VCO
RIPPLE FILTER
RF AMP
APC SW
DC SW/SP MUTE
PTT5MSB
TXDQT/DQT_INMIC_MUTEBUSYBUSY
PTTOPTDET
RSSI
QT/DQT_INMIC_MUTE
5M
TXDPCTV
SBAF_CONT
PTT5M
TXD
PCTV
SB
PCTV
TX FINAL AMP
APC SW
RF AMP
FREQUENCYCONTROL/TX VCO
D4,7
MODULATOR
CURRENTSTEERING
TX/RXRF SW
APC PROTECT
5C 5C
BB
5C
ANT SW
ANT SW ANT SW
D101,202
RF BPF TUNING
D203,204 D205,206
RF BPF TUNING
5V PROTECTION
5T5T
5M 5M
5C_C5R_C5T_CBATT
B
RESETRESETINTINT
AMP3O AMP3O
APCSWAPCSW
TH_DET TH_DET
PTTPTT
SB SB
SP1
SP2
SP1
SP2
SP1
SP2SP2
DCSW DCSW
RX_W/NRX_W/NTX_W/N TX_W/N
VCC
VSS VSS
VCCVSS VSS
VCC
AF_CONT
OPTDET OPTDET
AF_CONT
RX LO1 RX LO1
X57-6880-XX
-12
-13
K
K2
47k
47k
R416 R453
NO
NO
BEAT SHIFT SW
DTMF SW DTMF SWCALLING ALERT SW CALLING ALERT SW
LIMITER
RSSIBUSY
PCTV
PLL_CLK
PLL_DAT
PLL_STB
W/N SW/TX
AUDIO SW
Q317,318
0
0
0
R9
R10
R11
CLO
CK
NC
3
DAT
ALEFC
NC
4
FO
UTP
NC
5R
QTTCXO
OSCIN
EN1
EN5
PLL_UL
5RSP2
EN4
PLL_STB
5T
EN3
PLL_DAT
5C
EN2
PLL_CLKB
SP1
B30-2156-05
LED/RED
RT1N141URT1N141U
9
10
11
2SK508NV(K52)Q3
DIRSTD
C35
1
0.01
u
C35
2
0.01
u
C354
0.1u
R355
10k
C31
40.
1u
IC301AQUA-L
AUDIO PROCESSOR
Q109RT1P441U
APC SW
C12
3
1u
C12
1
10p
C12
8
1000
p
C12
5
1000
p
C13
3
0.01
u
2SK2595-EQ106
3p3p(B)(B)
(B)(B)
IC1MB15A02PFV2E1
PLL SYSTEM
VOLTAGEREGULATOR/5V
IC401,402
IC40530622MAPA49GU
MICROPROCESSOR
COMPARATOR(APC)
W/N SW/TX
ON:4.92VOFF:0.01V
ON:4.92VOFF:0.01V
4.96V
5.00V
R:7.28VT:6.80V
R:7.56VT:7.26V
R:3.70VT:3.57V
R:5.01V
T:4.99V
R:4.83V
4.72V
4.84V
4.76V
4.95V
4.96V
R:3.46V
R:0.99V
R:4.98V
R:2.48V
R:2.48V
R:0.75V
R:4.8V R:4.92V
R:1.76V
T:3.42V
2.73V
0.72V
3.74V
R:4.97VT:0.59V
0.7V
4.83V
4.74V
2.2V
4.6V
R:2.84V
T:1.13V
T:4.89VR:7.53VT:7.41V
T:2.7V(H)1.99V(L)
R:7.52VT:7.31V
R:0.3V(MUTE ON)7.3V(MUTE OFF)
T:0.3V
R:7.3V(MUTE ON)0.3V(MUTE OFF)
T:7.3V
R:0.60VT:4.95V
W:0.011VN:4.98V
BSHIFT ON:4.95VOFF:0V
R:0.29VT:3.09V
T:4.94V
R:5.0VT:0V
Note : The components marked with a dot ( ) are parts of layer 1.
TK-2200L SCHEMATIC DIAGRAM
TK-2200L
28
BLOCK DIAGRAM
TXVCO
RXVCO
DCSW
DCSW
Q4 2SK508NV(K52)D4,D7 1SV325FD10 1SV278F
Q5 RT1P430U
Q7 RT1P430U
Q3 2SK508NV(K52)D5,D9 1SV325F
RX
TX
PLL
IC1 MB15A02PFV2E1
X1 L77-1931-05
12.8MHz
38.4MHz
Q1 KTC4082
5R
PLL_DATPLL_CLK
RX_W/N
5C
FM IFSYSTEM
CD201 L79-1582-05
450kHz
SW
5C
IC201 TA31136FNG
RSSI
BUSY
IC301 AQUA-L
AUDIO
PROCESSOR
AFAMP
MUTESW
DCSW
DCSW
DCSW
SBSB
AFCONT
SB
Q306, Q316 2SK3577-A IC302 TA7368FG
Q305 RT1N441U Q304 2SA1362-F(GR)
Q303 RT1N441U
AGC
DET
Q302 2SC4919D303 DAN222D302 RB706F-40
D301 RB706F-40
VOX
MOD
DTRLOADNTDATA/DTRCLK
STD
TCLK/DTRDO
DI/O
RDF/FDSCLKDIR
5M
EN1
EN2
EN3
EN4
LPF
QTVCO
LPFQTTCXO
Q202 RT1P441U
5C
INT
IC404 BD4845FVE
INT
PROTECT
D402 1SR154-400
SB PROTECT
D401 RB521S-30
RESETRESET
AVR
X57-688
IC401 XC6204B502MR
5CDCSW
Q405 RT1P237U-T111
AVR
DC5R
SW
5R_C
X2 L78-1414-057.37MHz
EEPROM
SW
Q407,Q408 2SK1830F
IC406 BR24L08F-W
PLL_STB
5C
5C
EN5
IC403 BD4840FVE
5C_C
IC402 XC6204B502MR
Q403 CPH3317
5T
5T_C
DCSW
Q404 CPH3317
5M
TRIPLER
LoopFilter
BATTDET
BATT
RX_W/NWIDE/NARROWSW
Q901 2SK1824-A
DTMFRXAF0XIN
CH SW
PWR SW
/ VOL
SP
MIC
BATT +-
TK-2200L
29
BLOCK DIAGRAM
LPF
BPFBPFRFAMP
1stMIXER
5RPCTV PCTV5R
MCF
XF201 L71-0619-05
38.85MHz
AMPIF
5R
D205,D206 1SV305FD203,D204 1SV305FQ204 3SK318Q2032SC4649(N,P)
BUFFAMP
Q6 2SC5108(Y)F
5C
5C
RIPPLEFILTER
Q8 2SC5383-T111
Q2 2SC5108(Y)F
CF
CF201 L72-0973-05
450kHz
PLL_CLKPLL_DAT
APCSWDCSW TX_SW
QTTCXOQTVCO
1/2OSC5T_C5C_C5R_C
EN1
EN4EN3EN2
QT/DQT INRSSI
VOX
DIRSCLK
DI/O
TCLK/DTRDO
TDATA/DTRCLKDTRLOADN
DTMFMIC MUTE
AFCONT
INTRESET
SW1
SW2
EEPDAT
EEPCLK
PF2PF1PTT
BSHIFT
LEDTXLEDRXCALLING ALERT SWDTMF SW
BATT
XIN
XOUT
PF2
PF1
PTT
5M
MICROPROCESSOR
IC405 30622MAPXXXGU
LED(GREEN)
LED(RED)
SBSB
SWDC
SWDC
D404 B30-2157-05D403 B30-2156-05
Q401 RT1N141U
LEDTX LEDRX
TH_DET
D11 MA2S111-F
APCSW
Q103 2SK2596D101,D202 HSC277
SW
SW
Q105 2SK879(Y)F
PCTV
AMP AMP
SW
Q108 2SK1824-A
SW
5C
IC101 TA75W01FUF
CURRENT
Q9 2SC5108(Y)FD103,D104,D105,D106HVC131
DC
AMP
Q107 RT1N141U
AMPANT
5T
DCSW
DET
Q109 RT1P441U
TXDRIVE FINAL SW
Q102 2SC4926YD
SW
Q106 2SK2595-E
RF
5T
APCSW
Q104 RT1N141U
T/R
DC
B
RF TX
DC DC
5C
Q205 3SK318
5C
Q402 RT1N141U
RXD
RX_SW
TXDTX_W/N
PLL_STB
RX_W/N
EN5BUSY
5R
RFAMP
PTT
DIVIDER
5C
IC2 UPB1509GV
RDF/FDOPT DET
STD
PLL_UL
PCTV
ANT
TX/RX:150.00~174.00MHz
TK-2200L
30
RF
(Cen
ter
Freq
uen
cy)
IF1
(38.
85M
Hz)
AF
(1kH
z)
AF
(1kH
z)R
F (C
ente
r Fr
equ
ency
)
IF2
(450
kHz) FM
IFS
YS
TE
MA
QU
A-L
AQ
UA
-L
IC30
2
500m
WC
330
IC30
1C
329
IC20
1C
219
C22
4X
F201
C24
5B
PF
C26
3B
PF
C15
1LP
FQ
205
Q20
4
IC30
1C
902
VC
O
PLL
C81
IC2
Q9
C87
D10
1
RX
LO
C10
1Q
102
C10
8Q
103
Q10
6C
151
D202
MIC
SP
EA
KE
R
-119
.5d
Bm
-119
.5d
Bm
-120
.0d
Bm
-104
.0d
Bm
-110
.0d
Bm
-104
.0d
Bm
290m
V29
mV
16m
Vrm
s
102m
Vrm
s3.
9dB
m14
.8d
Bm
31.4
dB
m2.
0W3.
7dB
m
Q20
3
LPF
Receiv
er
Secti
on
Tra
nsm
itte
r S
ecti
on
LEVEL DIAGRAM
To m
ake
mea
sure
men
ts in
the
AF
sect
ion,
con
nect
the
AC
leve
l met
er. (
AN
T in
put:
-53d
Bm
, 1kH
z FM
,3k
Hz
DE
V (W
IDE
))In
the
RF
sect
ion,
use
1000
pF c
oupl
ing
capa
cito
r.(T
he d
ispl
ay s
how
s th
e S
SG
inpu
t val
ue re
quire
d to
obta
in 1
2dB
SIN
AD
with
out
loca
l lev
el.)
AG
is s
et t
o th
e M
IC in
put
beco
mes
3kH
z D
EV
at
1kH
z M
OD
.(WID
E)
To m
ake
mea
sure
men
ts in
the
AF
sect
ion,
con
nect
the
AC
leve
l met
er.
In t
he R
F se
ctio
n, u
se 1
000p
F co
uplin
g ca
paci
tor.
TK-2200L
31
KSC-35 (RAPID CHARGER)
Charging time ..................... KNB-45L : Approx.180 minutesDimensions (Charger only) .... 86.3W x 43.2H x 100.0D (mm)
3-3/8W x 1-45/64 x 4D (inches)Weight (Charger only) ............ Approx. 90g / 0.2 lbs
Specifications
KNB-45L (Li-ion BATTERY PACK)
OPTIONAL ACCESSORIES
External View External View
Schematic Diagram
Thermistor
10kΩ±0.5%
Diode
PCBA
DISCHARGE TERMINAL SIDE
REAR CHARGE TERMINAL SIDE
Voltage ................ 7.4V (3.7V x 2)Battery capacity... 2000mAh
Specifications
TK-2200L
GeneralFrequency Range ............................................................. 150~174MHzNumber of Channels ........................................................ 2 (K) 8 (K2)Channel Spacing............................................................... 25kHz, 30kHz (Wide) 12.5kHz, 15kHz (Narrow)PLL Channel Stepping ...................................................... 2.5kHz, 5kHz, 6.25kHz, 7.5kHzOperating Voltage ............................................................ 7.5 V DC±20%Battery Life (5-5-90 duty cycle) with KNB-29N battery .................................................... Approx. 14 hours (Battery Saver off)
Approx. 18 hours (Battery Saver on) with KNB-45L battery ..................................................... Approx. 17 hours (Battery Saver off)
Approx. 22 hours (Battery Saver on)Operating Temperature Range......................................... –30˚C to +60˚C (–22 ˚F to +140 ˚F)Frequency Stability ........................................................... ±2.5ppm (–30˚C to +60˚C)Channel Frequency Spread .............................................. 24MHzDimensions and Weight (Dimensions not including protrusions) Radio Only ...................................................................... 54 (2-1/8) W x 122 (4-13/16) H x 21.1 (13/16) D mm (inches)
160g (0.35lbs) With KNB-29N (1500mAh battery) ................................. 54 (2-1/8) W x 122 (4-13/16) H x 33 (1-5/16) D mm (inches)
360g (0.79lbs) With KNB-45L (2000mAh battery) .................................. 54 (2-1/8) W x 122 (4-13/16) H x 33 (1-5/16) D mm (inches)
280g (0.62lbs)
Receiver (Measurements made per TIA/EIA-603)Sensitivity
EIA 12dB SINAD ........................................................... 0.25µV (Wide)/0.28µV (Narrow)Selectivity ......................................................................... 70dB (Wide)/60dB (Narrow)Intermodulation ................................................................ 65dB (Wide)/60dB (Narrow)Spurious Response .......................................................... 65dBAudio Power Output ........................................................ 500mW at 8Ω less than 10% distortion
Transmitter (Measurements made per TIA/EIA-603)RF Power Output ............................................................. 2W/1WSpurious and Harmonics .................................................. 65dBModulation ....................................................................... 16K0F3E (Wide)/11K0F3E (Narrow)FM Noise .......................................................................... 45dB (Wide)/40dB (Narrow)Audio Distortion ............................................................... Less than 5%
SPECIFICATIONS
2967-3, Ishikawa-machi, Hachioji-shi, Tokyo, 192-8525 Japan
P.O. BOX 22745, 2201 East Dominguez Street, Long Beach,
6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8
Rembrücker Str. 15, 63150 Heusenstamm, Germany
Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium
KENWOOD House, Dwight Road, Watford, Herts.,
Amsterdamseweg 37, 1422 AC Uithoorn, The Netherlands
Via G. Sirtori, 7/9 20129 Milano, Italy
Bolivia, 239-08020 Barcelona, Spain
(A.C.N. 001 499 074)16 Giffnock Avenue, Centrecourt Estate, North Ryde, N.S.W. 2113 Australia
Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road,
1 Ang Mo Kio Street 63, Singapore 569110
CA 90801-5745, U.S.A.
Kwai Fong, N.T., Hong Kong
WD18 9EB United Kingdom
L’Etoile Paris Nord 2, 50 Allée des Impressionnistes, Bp 58416 Villepinte, 95944 Roissy Ch De Gaulle Cedex
