Embed Size (px)
Citation preview
COOKING
SLIDE OUT KITCHEN
SKL101
EN Slide out kitchen
Installation Manual
SKL101
2 EN
Explanation of symbols
Please read this instruction manual carefully before installation and first use, and
store it in a safe place. If you pass on the product to another person, hand over
this instruction manual along with it.
Table of contents 1 Explanation of symbols ...................................................................................... 2
2 Safety and installation instructions .................................................................... 3
3 Scope of delivery ................................................................................................ 4
4 Intended use ...................................................................................................... 5
5 Preparing the installation ................................................................................... 5
6 Technical data .................................................................................................. 12
1 Explanation of symbols
!
!
WARNING! Safety instruction: Failure to observe this instruction can cause fatal or serious injury.
CAUTION! Safety instruction: Failure to observe this instruction can lead to injury.
SKL101
EN 3
A
I
Safety and installation instructions
2 Safety and installation instructions Please observe the prescribed safety instructions and stipulations from the
vehicle manufacturer and service workshops.
The manufacturer accepts no liability for damage in the following cases:
• Faulty assembly or connection
• Damage to the product resulting from mechanical influences
• Alterations to the product without the express permission of the manufacturer
• Usage for purposes other than those described in this manual
WARNING!
• If the slide out kitchen has visible damage, contact the manufacturer.
NOTICE!
• Hose and gas lines must not be kinked.
• Hose lines must be installed in such a way that they are accessible at all times
and that they are not kinked or twisted when being pushed in or out.
• Hose lines must be protected from mechanical, chemical and thermal influences.
2.1 Safety when handling liquefied petroleum gas
WARNING!
• Keep flammable substances away from heating and cooking devices,
and other light and heat sources.
• Compare the pressure information on the type plate with the
pressure information on the propane gas cylinder.
• Never store liquefied petroleum gas cylinders in unventilated areas.
NOTICE! Failure to observe this instruction can cause material damage and impair the function of the product.
NOTE Supplementary information for operating the product.
!
A
!
SKL101
4 EN
• Keep liquefied petroleum gas cylinders away from direct sunlight. The
temperature may not exceed 50 °C.
• If you smell gas:
– Do not operate any electrical devices or switches, and avoid using
open flames that can ignite the gas.
– Close the valve on the gas cylinder and keep it closed until the fault
has been rectified.
• Never attempt to find a gas leak with an open flame.
Scope of delivery
3 Scope of delivery
No. in fig. 1 Description
1 Slide out kitchen
2 Bottle opener
3 Cup holder
4 Cutting board
5 Serving tray
6 Accessory adapter
– Tap with flexible water hose
SKL101
EN 5
– Installation manual
– Operating manual
– Cooktop manual (MO9923) and sink components
Intended use
4 Intended use The slide out kitchen for the outside area is intended for installation in trailers and
mobile homes. It is solely for the preparation of food in the outside area of the trailer or mobile home.
The slide out kitchen has to be connected to gas via an external gas bottle or a quick
connector on the external wall of the vehicle. The slide out kitchen has to be
disconnected from gas each time it is stowed. A permanent gas connection to the
slide out kitchen is prohibited!
5 Preparing the installation
I
➤
Remove
the packing of the slide out kitchen.
➤ Check whether the slide out kitchen has been damaged.
➤ Contact the manufacturer in case of damage.
NOTE The slide out kitchen is pre-assembled with extendable slides and delivered with mounting brackets. The individual elements of the slide out kitchen are covered with a protective film. This is only to be removed by the end customer.
SKL101
6 EN
5.1 Installation
SKL101 Preparing the installation
EN 7
➤ Create a drilling template to mark-up and drill holes to suit M8 bolts (fig. 2 to fig.
3).
➤ Mount the device as shown (fig. 4).
➤ Fit M8 bolts with locking washers from underneath (not supplied) (fig. 4). The length of the bolts should be at least 30 mm longer than the floor thickness.
SKL101
8 EN
➤ Adjust the height as needed by using the height adjustment (fig. 5 1).
SKL101 Preparing the installation
EN 9
➤ Verify the smooth sliding of the slide out kitchen (fig. 6). Ensure that slider locks are fully engaged when kitchen is extended and locking release tabs (fig. 6 1)
are releasing the slider locks correctly.
I
NOTE • Slider locks are working correctly if the kitchen does not slide back
into cavity when you give it a light push. • If the slider locks on one or both sides do not engage, fully extend
the kitchen. Pull it outwards until a click is heard when the slider locks engage.
• Ensure the correct disengaging of slider locks as follows: – Check if the locking release tabs can be pushed down easily
with no resistance. – Push back the kitchen into the cavity with a light push.
SKL101
10 EN
Preparing the installation
5.2 Connecting the gas supply
The gas supply may only be installed by a tested and certified gas plumber.
!
I
➤ Observe the following:
– Use the opening at the rear of the slide out kitchen to route and service all
external plumbing and wiring.
WARNING! The female gas connection provided can only be connected to a rigid connection. For use with a flexible hose, install a copper pipe to the base plate of the slide out kitchen and fix it rigidly (fig. 7, page 10).
NOTE
• For the gas connection the following additional parts are required: – male gas adaptor
– copper piping
– pipe mount
– hose fitting
– flexible gas hose at required length, depending on the mounting application
• Make sure that the hose line
– is not crushed or kinked
– is a safe distance from the burner.
SKL101 Preparing the installation
EN 11
– Connect the slide out kitchen to LPG only.
– Ensure that the connection to the gas supply is serviceable by the user. It
must allow detachment before closing the slide out kitchen.
➤ Connect the rigid pipe as shown (fig. 7 1, page 10).
➤ Connect the flexible hose as shown (fig. 7 2, page 10).
5.3 Connecting the water supply
I
fig. 8
➤ Install the tap (4) to the sink using a rubber seal either side.
➤ Attach the flexible water hose (3) to the tap.
➤ Connect an additional extension hose (2) to the flexible water hose using male
fittings (1).
NOTE The water supply can be permanently connected.
SKL101
12 EN
5.4 Connecting to a 12 Vg power supply
For the electrical connection, wires are attached to the inner wall of the slide out
kitchen.
➤ Connect the cooktop igniter wires via a joiner or a plug to a 12 Vg power source.
Technical data
6 Technical data
SKL101
Ref. no.: 9600006441
Nominal gas consumption: 16 MJ/h
Gas category: Category l3, universal LPG
Connection pressure: AT, DE, EE, LT, LV, MT, PL: 30 mbar
BE, CH, ES, FR, GB, GR, IE, IT, LU: 28 – 30/37 mbar
CY, CZ, DK, FI, HU, IS, NL, NO, SE, SI, SK: 28 – 30 mbar AUS, NZ: 27.5 mbar
Number of burners: 3
Burner output in total: 16.9 MJ/h
Burner 1: 3.8 MJ/h
Burner 2: 5.9 MJ/h
Burner 3: 7.2 MJ/h
Cooking time for 1 l of water: approx. 10 min (depending on the ambient conditions and pot used)
Dimensions: fig. 9, page 13
Weight (excluding accessories):
44 kg
Inspection/certification:
SKL101
EN 13
Technical
data
No. in fig. 9 Description
1 Slide out kitchen and sliding rails: 597 mm
Including fixation brackets and nuts: 640 mm
2 Slide out kitchen only: 1515 mm
Including fixation bracket and rails (closed): 1667 mm
Including fixation bracket and rails (extended): 3267 mm
3 Slide out kitchen only: 288 mm
Height adjustments including fixation and bracket:
First height adjustment: 314 mm (A)
Second height adjustment: 334 mm (B)
Third height adjustment: 354 mm (C)
Access doors Door opening
Dometic 658 x 364 mm
Coast2Coast 612 x 346 mm
SKL101
EN 14
Thetford 630 x 330 mm
AUSTRALIA dometic.com Dometic Australia Pty. Ltd. 1 John Duncan Court · Varsity Lakes QLD 4227 1800 212121 · +61 7 55076001 Mail: [email protected]
AUSTRIA Dometic Austria GmbH Neudorferstraße 108 A-2353 Guntramsdorf +43 2236 908070 +43 2236 90807060 Mail: [email protected]
BENELUX Dometic Branch Office Belgium Lourdesstraat 84 B-
8940 Geluwe +32 2 3598040 +32 2 3598050 Mail: [email protected]
BRAZIL Dometic DO Brasil LTDA Avenida Paulista 1754, conj. 111 SP 01310-920 Sao Paulo +55 11 3251 3352 +55 11 3251 3362 Mail: [email protected]
DENMARK Dometic Denmark A/S Nordensvej 15, Taulov DK-7000 Fredericia +45 75585966 +45 75586307 Mail: [email protected]
FINLAND Dometic Finland OY Mestarintie 4 FIN-01730 Vantaa +358 20 7413220 +358 9 7593700 Mail: [email protected]
FRANCE Dometic SAS ZA du Pré de la Dame Jeanne B.P. 5 F-60128 Plailly +33 3 44633525 +33 3 44633518 Mail : [email protected]
GERMANY Dometic WAECO International GmbH
Hollefeldstraße 63 · D-48282 Emsdetten +49 (0) 2572 879-0 +49 (0) 2572 879-300 Mail: [email protected]
HONG KONG Dometic Group Asia Pacific Suites 2207-11 · 22/F · Tower 1 The Gateway · 25 Canton Road,
Tsim Sha Tsui · Kowloon +852 2 4611386 +852 2 4665553 Mail: [email protected]
HUNGARY Dometic Zrt. Sales Office
Kerékgyártó u. 5. H-1147
Budapest +36 1 468 4400
+36 1 468 4401
Mail: [email protected]
ITALY Dometic Italy S.r.l.
Via Virgilio, 3 I-47122 Forlì (FC) +39 0543 754901 +39 0543 754983 Mail: [email protected] JAPAN Dometic KK Maekawa-Shibaura, Bldg. 2 2-13-9 Shibaura Minato-ku Tokyo 108-0023 +81 3 5445 3333 +81 3 5445 3339 Mail: [email protected]
MEXICO Dometic Mx, S. de R. L. de C. V.
Circuito Médicos No. 6 Local 1
Colonia Ciudad Satélite CP 53100 Naucalpan de Juárez Estado de México +52 55 5374 4108 +52 55 5393 4683 Mail: [email protected]
NETHERLANDS Dometic Benelux B.V.
Ecustraat 3 NL-4879 NP Etten-Leur +31 76 5029000 +31 76 5029019 Mail: [email protected]
NEW ZEALAND Dometic New Zealand Ltd.
PO Box 12011 Penrose Auckland 1642 +64 9 622 1490 +64 9 622 1573 Mail:
NORWAY Dometic Norway AS Østerøyveien 46 N-3232 Sandefjord +47 33428450 +47 33428459 Mail: [email protected]
POLAND Dometic Poland Sp. z o.o. Ul.
Puławska 435A PL-02-801 Warszawa +48 22 414 3200 +48 22 414 3201 Mail: [email protected]
PORTUGAL Dometic Spain, S.L. Branch Office em Portugal Rot. de São Gonçalo nº 1 – Esc. 12 2775-399 Carcavelos +351 219 244 173 +351 219 243 206 Mail: [email protected]
RUSSIA Dometic RUS LLC Komsomolskaya square 6-1 RU-107140 Moscow +7 495 780 79 39 +7 495 916 56 53 Mail: [email protected]
SINGAPORE Dometic Pte Ltd 18
Boon Lay Way 06–141 Trade Hub 21 Singapore 609966 +65 6795 3177 +65 6862 6620 Mail: [email protected] SLOVAKIA Dometic Slovakia s.r.o. Sales
Office Bratislava Nádražná 34/A 900 28 Ivánka pri Dunaji /+421 2 45 529 680 Mail: [email protected]
SOUTH AFRICA Dometic (Pty) Ltd. Regional
Office South Africa & Sub-Saharan Africa 2 Avalon Road West Lake View Ext 11 Modderfontein 1645 Johannesburg +27 87 3530380 Mail: [email protected]
SPAIN Dometic Spain S.L. Avda. Sierra del Guadarrama, 16 E-28691 Villanueva de la Cañada Madrid +34 902 111 042 +34 900 100 245 Mail: [email protected]
SWEDEN Dometic Scandinavia AB Gustaf Melins gata 7 SE-42131 Västra Frölunda +46 31 7341100 +46 31 7341101 Mail: [email protected]
SWITZERLAND Dometic Switzerland AG Riedackerstrasse 7a CH-8153 Rümlang +41 44 8187171 +41 44 8187191 Mail: [email protected]
UNITED ARAB EMIRATES Dometic Middle East FZCO P. O. Box 17860 S-D 6, Jebel Ali Freezone Dubai +971 4 883 3858 +971 4 883 3868 Mail: [email protected]
UNITED KINGDOM Dometic
UK Ltd.
Dometic House, The Brewery Blandford
St. Mary Dorset DT11 9LS +44 344 626 0133 +44 344 626 0143 Mail: [email protected]
USA Dometic RV Division 1120 North Main Street Elkhart, IN 46515 +1 574-264-2131
