76
COMMERCIAL GAS WATER HEATERS Instruction Manual PRINTED IN THE U.S.A. 0310 197373-005 PLACE THESE INSTRUCTIONS ADJACENT TO HEATER AND NOTIFY OWNER TO KEEP FOR FUTURE REFERENCE. Read and understand this instruction manual and the safety messages herein before installing, operating or servicing this water heater. Failure to follow these instructions and safety messages could result in death or serious injury. This manual must remain with the water heater. MODELS BTH-300A/400A/500A SERIES 100 & 101 INSTALLATION - OPERATION - SERVICE - MAINTENANCE - LIMITED WARRANTY ANSI / NSF 5 ASME CRN WARNING: If the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. WHAT TO DO IF YOU SMELL GAS: Do not try to light any appliance. Do not touch any electrical switch; do not use any phone in your building. Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. If you cannot reach your gas supplier, call the fire department. Installation and service must be performed by a qualified installer, service agency or the gas supplier.

COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

  • Upload
    others

  • View
    1

  • Download
    0

Embed Size (px)

Citation preview

Page 1: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

COMMERCIAL GAS WATER HEATERSInstruction Manual

PRINTED IN THE U.S.A. 0310 197373-005

PLACE THESE INSTRUCTIONS ADJACENT TO HEATER AND NOTIFY OWNER TO KEEP FOR FUTURE REFERENCE.

����������� ������������������������������������������������������������������������������

Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.

Failure to follow these instructions andsafety messages could result in deathor serious injury.

This manual must remain with thewater heater.

MODELS BTH-300A/400A/500A SERIES 100 & 101

INSTALLATION - OPERATION - SERVICE - MAINTENANCE - LIMITED WARRANTY

�����������������������������������!���"��#�$%�&�

ANSI / NSF 5ASME CRN

WARNING: If the information in theseinstructions is not followed exactly, a fireor explosion may result causing propertydamage, personal injury or death.

Do not store or use gasoline or otherflammable vapors and liquids in thevicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

Do not try to light any appliance.

Do not touch any electrical switch; donot use any phone in your building.

Immediately call your gas supplierfrom a neighbor’s phone. Follow thegas supplier’s instructions.

If you cannot reach your gas supplier,call the fire department.

Installation and service must beperformed by a qualified installer,service agency or the gas supplier.

��

Page 2: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

2

Supply Gas Line Installation ............................................................ 37Supply Gas Regulator Installation ................................................... 38'���������������� ............................................................................... 39

�����(�����!�������� ......................................................................39

'�� ��)*��� ���!����� ..............................................................................39

������+����!�������� .................................................................. 40�/��6��:��*������������� ............................................................... 40

TEMPERATURE REGULATION .......................................................... 41;������<��������+�<���!�����='!>? ............................................ 41����<�����!���� .......................................................................... 41

!>#�@>+�(B(�'C�>�'@��J># ...................................................... 42!�����(����<�#�:������ .............................................................. 42

����*������(����� .................................................................................42

(�����J��� ..............................................................................................43

K����(��������/�!�����(����<�C��� .......................................... 45Temperatures Menu ..................................................................................45

Heater Status Menu ..................................................................................46

Display Settings ........................................................................................47

Heater Information ....................................................................................47

!������V��� .............................................................................................48

V����;����� .............................................................................................48

V����>�������� ......................................................................................48

@������V������*������ ..........................................................................48

(��:����!������J���<���� .....................................................................49

START UP ............................................................................................ 50Initial Start Up .................................................................................. 50

(�����W�������������X��<��� .............................................................51

C�������W�������������X��<��� ..........................................................51

!������������V������@��� ................................................................ 52;������������J����������� ................................................................ 52

LIGHTING THE WATER HEATER ....................................................... 53Lighting & Operation Label .............................................................. 53

TROUBLESHOOTING ......................................................................... 54J�����������!�������� ........................................................................ 54(�\�����>��>������� ................................................................... 54(�\�����>��>��������V���!���� ................................................ 55Operational Problems ...................................................................... 56

@���(�������"�@���>������� ............................................................56

Momentary Ignition ...................................................................................56

Not Enough Or No Hot Water ...................................................................56

V��������������!������� ............................................................... 57V����!������� ........................................................................................57

������!������� ........................................................................................57

@���������!�����(����<�+���>�� ........................................................57

*���������!����� ....................................................................................57

V��������������C������� .........................................................................58

C�J#�'#�#!' ................................................................................... 60C�����������(������ .................................................................... 60

DIAGRAMS .......................................................................................... 63!!]�^�!�������!�����]����+��� ............................................... 63BTH 300 Wiring Diagram ................................................................. 64]�;�_��"������������*�����< ......................................................... 65!����������<���������*�����<� .................................................. 66Water Piping Diagrams .................................................................... 67

+JCJ�'*���@@�#�B .......................................................................... 74

TABLE OF CONTENTS(�V'�J#(��++��J>#"�K('��#*�('@6J!'.......................................... 3W'#'@�+�(�V'�B�J#V>@C��J># ...................................................... 4

��������� ........................................................................................ 4J#�@>*K!�J># .................................................................................... 6

`���������� ..................................................................................... 6�!>CCk�/�]�!����!<���� �� ....................................................... 6����������V������J���������� ........................................................... 6

V'��K@'(��#*�!>C�>#'#�( ......................................................... 7]�����>������� ................................................................................. 7���6��� ............................................................................................ 8(����6���� ......................................................................................... 9

J#(��++��J>#�!>#(J*'@��J>#( ................................................... 10Rough In Dimensions ...................................................................... 10@��:����!��������� ........................................................................ 10+�����������������;����� ...............................................................11

!�����������!< ��� ���C�������� ........................................................11

(��:����!�������� ....................................................................................11

Insulation Blankets .......................................................................... 12INSTALLATION REQUIREMENTS ...................................................... 13

Gas Pressure Requirements ........................................................... 13Supply Gas Line .............................................................................. 13Supply Gas Regulator ..................................................................... 13�����(���� .................................................................................. 13Mixing Valves ................................................................................... 14*�����������C������� .................................................................... 14!�����������(����<� .................................................................... 14Thermal Expansion .......................................................................... 14Temperature-Pressure Relief Valve ................................................. 15!���������*���� ............................................................................ 16Air Requirements ............................................................................. 17!<<����������C����������� ................................................... 20

VENTING INSTALLATION ................................................................... 21General Venting Information ............................................................ 21

!�������J6���������� ..............................................................................21

�����6����!�������� .........................................................................21

*������6����!�������� ..........................................................................21

W�������6�������J��������� ........................................................... 21Venting Requirements ..................................................................... 22

Maximum Equivalent Lengths ..................................................................22

Minimum Equivalent Lengths ...................................................................22

C�}�<<�#< ���>��'� �� ...................................................................22

6�������J�����������(�\���� ......................................................... 23�����6����J���������� .................................................................... 23*������6����J���������� ..................................................................... 236�����������<�������J���������� ....................................................... 24(�����������<�������J����������...................................................... 26!������������<�������J���������� .................................................. 27

C�������!������������<�������!���������� ...........................................30

C�������!������������<��������������<���� ........................................31

Venting Arrangements ..................................................................... 32���<�������!����������(�������������6��� ................................. 34���<�������!����������(��������*������6��� .................................. 35

WATER HEATER INSTALLATION ........................................................ 36!���������*�����J���������� ......................................................... 36

Page 3: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

3

SAFE INSTALLATION, USE AND SERVICE

���������������������"�����������:������������������������������}���<�����<������������������������������������������C����������^��������<�������������������������:�� ������:�������������<����������������������������������������������������������������X������������@�������� ��������������<�����������������������������������<�������J�����:�����<����������������<���������������������<������������������ ������������������������"���"������:����������������������

�����������<������������������������������� �������������������"�������������������������������������������<������"�����������:����������������X�������!���������(����*�������������������}���'�����<����������\���������W:�������!������������ ��������������� ������������� �� ����(�������!��������� �������������"� ������������"�������� ��������:�����<"����� ��\����� ��������� �������������������}������������ ��������������������������������<����������������(�������!����������������������"� ������������"����������������:�����<�������������������������������:����}��������<��������� ��������������������������

DANGER

WARNING

CAUTION

CAUTION

DANGER indicates an imminentlyhazardous situation which, if not avoided,will result in injury or death.

This is the safety alert symbol. It is used to alert you topotential personal injury hazards. Obey all safetymessages that follow this symbol to avoid possibleinjury or death.

WARNING indicates a potentially hazardoussituation which, if not avoided, could resultin injury or death.

CAUTION indicates a potentially hazardoussituation which, if not avoided, could result inminor or moderate injury.

CAUTION used without the safety alertsymbol indicates a potentially hazardoussituation which, if not avoided, could result inproperty damage.

ASME CRN ANSI / NSF 5

APPROVALS

Page 4: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

4

PRECAUTIONS*>�#>��K('��;J(����+J�#!'� JV��#B���@��;�(�]''#�K#*'@����'@��J<<����������������\����������:�����������������������������������������<�����������<������������������������� ����������}��J��������������}������������������"������������������������� ���� �������:�� ������ ��:�� ���� <���� �� �� \�����������:�����������

1. '}�����������

2. Damage.

3. V������������������

GROUNDING INSTRUCTIONS

����� ������ ������� <��� �� ������� ��� ���������� ����� ����#������� '���������� !��� ���)�� ����� ������ ������ <��� �����������������������V���������������������������������������<�������������������������������<��������������� ������ ������� <��� �� ��������� �� �� ������� <����"����<������������������<��������\��<�������������������<��� �� �������� ���� ������� ��������������������� �� �����\��<���������������<�������������������������������

HYDROGEN GAS FLAMMABLE

;��������������� ��������� �������������������<����:��� �� ��������������� ������������ �������� ����� ��������������<��=���������������������<��?��;���������������}���<������<<� �������������������������X����������������������"����������<<�������������������������������:��� ����������������� �� ������ ��� ��:����� <������ ����� ����� ���� ��������������������� ��������� �� ���� ��� ������ �����<�� J�� �������� ����������� ������ ����� �� � ��� �� ��� ����� ���� ���� ��� ����������������������������������������� ������������THERE (;>K+*� ]'� #>� (C>�J#W� >@� >�'#� V+�C'� #'�@� �;'�V�K!'������;'��JC'�J��J(�>�'#��

GENERAL SAFETY INFORMATION

Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.

Failure to follow these instructions andsafety messages could result in deathor serious injury.

This manual must remain with thewater heater.

Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.

Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.

Feel water before bathing orshowering.

Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.

Explosion Hazard

Overheated water can causewater tank explosion.

Properly sized temperature andpressure relief valve must beinstalled in the opening provided.

Verify the power to the water heater is turned off before performing any service procedures.

Improper installation, use and service may resultin property damage.

Do not operate water heater if flood damaged.Inspect and anode rods regularly, replace if damaged.Install in location with drainage.Fill tank with water before operation.Properly sized thermal expansion tanks are required on allclosed water systems.

Refer to this manual for installation and service.

CAUTION

Explosion Hazard

Flammable hydrogen gasesmay be present.

Keep all ignition sources awayfrom faucet when turning onhot water.

Page 5: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

5

GENERAL SAFETY INFORMATION

Fire Hazard

Do not install water heater oncarpeted floor.Do not operate water heater ifflood damaged.

For continued protection againstrisk of fire:

Fire or Explosion Hazard

Read instruction manual beforeinstalling, using or servicing

water heater.

Avoid all ignition sources if you smell gas.

Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.

Use only the gas shown on the water heater rating label.

Keep ignition sources away from faucets after extendedperiods of non-use.

Maintain required clearances to combustibles.

Do not expose water heater controls to excessive gaspressure.

Do not obstruct water heater air intakewith insulating blanket.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Breathing Hazard - Carbon Monoxide Gas

Property Damage Hazard

All water heaters eventually leak.

Do not install without adequate drainage.

CAUTION

Fire and Explosion Hazard

Leak test before placing thewater heater in operation.Disconnect gas piping and maingas shutoff valve before leaktesting.Install sediment trap inaccordance with NFPA 54.

Use joint compound or Teflon tapecompatible with propane gas.

Fire and Explosion Hazard

Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.

Excessive gas pressure to gas valve cancause serious injury or death.

Do not use water heater with any gasother than the gas shown on the ratinglabel.

Turn off power to the water heaterbefore performing any service.

Electrical Shock Hazard

Label all wires prior to disconnectingwhen performing service. Wiring errorscan cause improper and dangerousoperation.

Verify proper operation after servicing.

Failure to follow these instructions canresult in personal injury or death.

Jumping out control circuits or components canresult in property damage, personal injury or death.

Service should only be performed by a qualified serviceagent using proper test equipment.Altering the water heater controls and/or wiring in any waycould result in permanent damage to the controls or waterheater and is not covered under the limited warranty.

Any bypass or alteration of the waterheater controls and/or wiring will result

in voiding the appliance warranty.

Altering the water heater controls and/or wiring in any waycould result in altering the ignition sequence allowing gas toflow to the main burner before the hot surface igniter is atignition temperature causing delayed ignition which cancause a fire or explosion.

Page 6: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

6

������B� ��� ���������� ����� ������ �������� �������� ��������������<���������"�����������:�������������� �����������:����

ABBREVIATIONS USED

� ��:�������������������J���������C��������������� �#(J�^��<�������#�������(���������J��������� �(C'�^��<�������(��������C����������'���������� W�C��^�W�������������C����������������������� #'!�^�#�������'����������!���� #V���^�#�������V������������������������ K+�^�K������������+� ������� !(��^�!��������(������������������

QUALIFICATIONS

QUALIFIED INSTALLER OR SERVICE AGENCYJ����������� ���� ���:���� �� ����� ������ ������� ��\����� � �������\�:������ �� ����� �� �� `�������������� =��� ������� ���#(J� ���?���������������:�:����J���������������������������< ���"����������"�:������"��������������������������������������\������������������������������������������������������<�������:����ANSI Z223.1 2006 Sec. 3.3.83:� �`������� �������� ^� ���������:����"���<"�������������<������������������������������������������������:������������������������������ ������=�?����� �����������"� ���������� �������<������������������� = ?� ������������"������������"��������"�������������:������������������������\��<��������������}��������������������������������<���������������������������\��������������������<���������������������\���<���������������������:����X�����������J�����������\�������=���������� ���#(J�� :�?���������������� ��������� ��� ��\����� �� ���� �������� ��:���� X������������ �����<� �� ��:��� ����� �� ��� ����<��� �� �����<� ���� �� ������������������� ��� ��� �����<������ J����������������������� �������������:��� ��� �����<��������������<��� �������<�����������������������������<�����

ICOMM™ & BACNET COMPATIBLE

����� ������ ������� ��� �<���� ��� ����� ���� �!>CCk� ��<���<�������� �����<�� ���� �!>CCk� �����<� ��������� ����<�������� � ���:���� ������������������������ J�� ����������� ��<����� ��������� ���������"� ���������� ���� ������� ����� �������<����������� ����������� �!>CCk� �����<� ���� ��<��������� ������ ������������������ :��� �<���� ���)�� �������� ����� ��}�� <�������� ��������������� ��<���������������������!�������������!>CCk������<��������������<���� ��������]�!�����<�����������:����� ������� ���� ������� <�����<���� �����<��� V��<�������<�����������������^$%���

PREPARING FOR THE INSTALLATION

1. @���������������<����� ���������<�������������������������������������������������������������������W�������(������J���<������������_�������� J��������� ����� ���������������"������������������<���������������������J���������������������<���"���X������)������������� <����� �������� ����������� ��� ���� �����������"��������"� ���� <����������� �� ���� ������ �������� J�� ������������ ��������� ������� ���� <����� ����� �� <������������ �������������������������������� �����������������������������������������������������������������������safety.

INTRODUCTION*��������������������������<����������������������<������������ ������<�� ����� ���:�� �� ��:���� ���� ���������� ����� ������������� J�� ��� ���������� ����� ���� :������"� ������ ������"� ���������������������� ������������������������������ ��������� ����� �� ��:��� �� ���� �������������� ����<<������ ��� ���� �������� ���������� ��� ���� �������������<�����������������������������������������������������������������������������������<�������������������������������������������V�����������!<��������������%���������<������K���������������������������������������:������<��������������������������(�������J�����������!��������������� �����������������_��]������������������������������<��� ��� �����<����<�������������� ��X��<����� ���� �:��� ����������� ���:����������� ;��:��"� ���:���� ���� ���������� ��������� ��������� �������<��� ����`�������(��:�����������NOTE:� !���� �� ������� ������������ ������ ���� ��� �:����������������<��������������

2. ]�� ���� �� ���� ��� ����� ����� ������� �� �� ����� ��������������������<���������������������#�:�������������������<�����������������������������������������������

3. ����������������<�������<�����������������������������������<��������������������������������:����X����������������� ������ �� ��������� ������� ��� ���� ������� ������������:���� X���������� ����� �� �������� ����� ������������ �����������������������\������������������<�����������������"����������������������J�� ����� �������� ���������"� ���� ������������<����<����������������������������������#�������V���W���!��"��#(J����$�&)#V����_���������#�������'����������!��"�#V���%����!�#)!(�^]&_��&"�����#������W��������������J�����������!��� ���� !(�� !���&"� ���� !�������� '���������� !���� ������<����� ���� �:���� ��� ��<� ���� !�������� (������������������"����&�'�������������6������@��"�!��:�����"�>;�__&$&��#V�����<��������������:���� �����<�����#�������V���� ��������� ���������"� &� ]������<����� ����"� `����"�MA 02269.

4. J�� ������ �������� ����� <����� �� ��:�� ���� \������� �� ����� ���������� ���� ������ �� ���� ����������"� ����� ���� ����������< ��������� �����:����� �����<����� ��� ����������������������J����������}������������\���"����������:����������C���"�(����������(�������< �����������������������������������������:���� �������������������������������<��������������������������������������������� ���

5. !������������� ���������<������ ������������������'}�<��������������������������������<�����������������\���<��������+�����������������;�������������&&���������@���J��Dimensions on page 10.

6. V�����������������!���������������������������<��� �� �������������������:�������������<:������������������\�����(��� ����������� ��� ������� ������������ ����������J���������� <��� �� ������� ��<� !��������� >����� �� ����(��������������"�&&���`�(�����"�(�����&��"�(����<���"�!��95811.

7. C������������ !��� ��\����� ����� ������ ������� �� ������������������������������C�������������_�^!C@�������(�������< ����!��������_�^!C@����(���!<<����������C����������������������

Page 7: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

7

BASIC OPERATION

���� ������ �������� �:����� ��� ����� <����� ��:�� �� �������� �����������������}�������� ����� ���� <������ ��� ��������������������� ������ ��������� C���� ]����� ��� �� ������� ������� ����"� ������ <����� �� ���� ��� ���� ����� �������� ������ ���� ������}������������������������������� ��������� ���������������������� ������ ���� ����� �}�������� ����� �������� ���� �}��������������}����):��������������������������� ��<���������������������(���V�����&�����V�������

FEATURES AND COMPONENTS

BLOWERBURNERASSEMBLY

MAINBURNER(radial design)

HEATEXCHANGER

INTAKE AIR(combustion air)CONNECTION4 INCH PVC

HELICALCOIL

VENT (exhaust)OUTLET

Figure 1

BLOWER/BURNER ASSEMBLY DETAIL

HOT SURFACEIGNITER

COMBUSTIONBLOWER

FLAMESENSOR

MAINBURNER(radial design)

BLOWERFLANGE

INTAKE AIR(combustion air)CONNECTION4 INCH PVC

Figure 2

Hot Surface Igniter���������������<����������� ����;��(������ J������������&���6�!� ������ ���� �������� ���<� �� ������� ����� ���� �������� ������������������������������������"��&����V�=�����!?"����������the Main Burner. NOTE:�!����<��� ���������������������������������������:����breakage.*����� ���� �������� ���<� �� ������ ����� �� �������� ���� �����������<�<�����������������������������<�����������<���<<��������!��<������]�;�$���/�_���<�����������%��!��<������]�;�����<������(�������(�\�����>��>����������������_�Flame Sensor���������������<�����<������������<��������������<�����<��������������������C����]������J������<��������:�������������������������������������=$^��������?����������������<������ �<<��������� ��^��������� ���� �_� 6�!� W��� 6��:��� (��� ����(�\�����>��>��������V���!���������������

Page 8: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

8

]����� ��� ��������� ��������� ���� ������ �����<� <������������������������������� ������������������� ��� ���������������� ������ ����� ���� !< ����� ]����� ��� ���������� ������ ���� ��<�� ������ �� �������� ������� (��� (�\����� >��Operation on page 54.

11. 6�������������=�}������� �?�^�_�������6!�12. !< �����]�����13. ]������'}�����=:���?���������#�<������������������������

��������������������������������������������������������'}����� =:���?����������������� �� ����������������� ���������������������������������<�<������ ������������������������� ��� �������� �������� ��� ���� �������� ���� ���� ������ ����������������

14. 6V*�=:���� ������\��������:�?� �����<������:���K������]�;�_�������]�;�����<���������

15. Temperature-Pressure Relief Valve. See Temperature-Pressure Relief Valve on page 15.

16. K�������<���������� �"�&����� ��<���������� ����������������������������������<�<������������� �������������������<�������������������������������������������������K�������<���������� ���������������'!>�=���������� �?� ������������� ��� �� ��� ��X��� ��� ����� ��<����������<��� ������������ '!>� ������� �������� ���� ��<����� �������������������������<��������������(���;������<��������+�<���!�����='!>?��������_&�

17. ��������������������&�&)���#���18. KJC�=���� ����������<���?������KJC� �������� ������������

������� ���"� ���� ������ �����<��� +!*� �������� �������������� ������K��������X���:����������������������:������������������<������(���!�����(����<�>��������on page 42.

TOP VIEW

3

2

4

5

6

7 9

11

13

12

2

14

15

17118

16

108

FRONT

TOP VIEW COMPONENTS1. ������;��������&���6�!��)����������2. ������� ����� ����� ���� ������ ��������� �:����� ��� �����

<����� ���� �\������ ����� ��� ������� =��� ����������?������������������:��������� ��� ���� �����������������<�������������<�������������������������������������������������� ���� ������ ���������� �� ����������:�����������������������������������������<�����������������:���������=������?������������������<������������������������

3. !������� !����� ]���� =!!]?� ��������� ����� ������������� ���� ������ �����<��� <���� ������� ����� ���� !!]���������� ������ ��<�������� ���� ������� ���� ������ ��������������"�����!�����(����<�>���������������_��

4. &���6�!� X������ }�� J��<��������������������������������������<����������(��������(������������&$�

5. J�������������������^�_�������6!�6. ]������ J������ ���� �������� #�<����� ������ �������� �����

���������������������������������������������������������=�< ����?� ���� �� ���� ������ ������� ��� ��� ������������ ���������������<�<������������������������������� ����������������������������������������������������������������

7. ����������������_�6�!�W���6��:��8. (����� ���� ����� ���������� (��� ���� ��\���<����� ��� ����

Supply Gas Line on page 13.9. +��W�������������������#�<���������������������������

���� ����� ������������������������ ������� �� ������������������������ ���� :��<���<<� ��\���<���������������������<�<������������������������������� ���������������������� �������������������������������������������(����� ���_���������W�����������@�\���<������������&$�

10. ]�������:�����������#�<�������������������������������������������������������������������������������!< �����

Figure 3

Page 9: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

9

���������� ������K��������X���:����������������������:������������������<������(���!�����(����<�>��������on page 42.

11. Temperature-Pressure Relief Valve. See Temperature-Pressure Relief Valve on page 15.

12. ��<�������^��������@������6��:�����������������^������/��6��:��*��������������@�\���<�������������&��

13. +������<���������� �"�&����� ��<���������� ����������������������������������<�<������������� �������������������<��������������������������������������������

14. �����������������^�&�&)���#������������15. �������������������:��:��16. !< �����]�����17. 6�������������=�}������� �?�^�_�������6!�18. !��������� ����� ����� &)�� ����� �6!� ������ ���������� (���

V��������������&������!���������*����� J�������������page 36.

SIDE VIEWS

1. !������ ������� �����"� �:���� ������ ������� �������opening.

2. !!]���������^�����V�����$������������������������3. &���6�!� X������ }�� J��<������������������������

���������� ���� <���� ����� ^� ���� ��\���<����� ��� �����Supply on page 13.

4. J�������������������^�_�������6!�5. (������������������������(���(�����W���+�����������&$�6. +��W�����������������"���������������������V�����$���

��������(����� ���_���������W�����������@�\���<�������page 13.

7. ��������������_�6�!�W���6��:��8. ����������������^�&�&)���#������������9. 6V*� =:���� ��� ���\����� ���:�?� ����� <��� ���:�� ^� ^� ����

V�����$������������������������10. KJC�=���� ����������<���?������KJC� �������� ������������

������� ���"� ���� ������ �����<��� +!*� �������� ����

10

8 162 76

5

11

12

17

18 13

14

15

RIGHT SIDE

11

12

14

15

13

3

2

1

4

56

7

89

10

LEFT SIDE

Figure 4 Figure 5

Page 10: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

10

STORAGE CAPACITIESTABLE 2

MODEL U. S. GALLONS LITERS

BTH 300 130 492

BTH 400 130 492

BTH 500 130 492

Figure 6

���������������<����������������������������������<�������#�������(�����������W���������;������"�6�<��JJJ"��#(J���&�&��$�)�!(��_�$���������<���������������������������������"�������<��������������������������

ROUGH IN DIMENSIONS

GAS LINE CONNECTION SIZETABLE 1

MODEL SERIES NATURAL GAS PROPANE GAS

BTH 300 100/101 &�&)_��#�� &�&)_��#��

BTH 400 100/101 &�&)_��#�� &�&)_��#��

† BTH 500 100/101 &�&)_��#�� &�&)_��#����������� �����������������������������]�;����������������<�������\����

��&�&)���<���<<����������������^������� ������������&$����<���<<���\���������������������������*��������������������������\�:������������"����)�������< ������������������������"�������������������������<�����:���� ������������ ���������<���<<���\�����������̂ �����W���+����(�������������$%�

TABLE 3U. S. GALLONS/HR & LITERS/HR AT TEMPERATURE RISE INDICATED

C��� Type ofGas

Input �V ���V $��V _��V ���V ���V %��V ���V ���V &���V &&��V &���V &$��V &_��V

Btu/hr kW �! &&�! &%�! ���! ���! $$�! $��! __�! ���! ���! �&�! �%�! %��! %��!

BTH 300Natural

$��"��� 88GPH 1746 1164 873 699 582 499 436 388 349 318 291 269 250

Propane LPH 6610 4406 3304 2644 2203 1888 1652 1469 1322 1201 1102 1017 945

BTH 400Natural

$��"��� 117GPH 2328 1552 1164 931 776 665 582 517 466 423 388 359 332

Propane LPH 8813 5875 4406 3525 2938 2518 2203 1958 1763 1602 1469 1356 1259

BTH 500Natural

_��"��� 146GPH 2878 1919 1439 1151 959 822 720 640 576 523 480 443 411

Propane LPH 10894 7263 5447 4358 3631 3113 2724 2421 2179 1981 1816 1676 1556

@��:������������������� ���������������<����������������]�;�$��"�]�;�_���������������<����������������]�;�����

INSTALLATION CONSIDERATIONS

35°

20°

70°

18°

45°

45°

CLEANOUT

T &P

VALVE

GAS

*1 1/2” NPTWATEROUTLET

FRONT

TOP

DR

AIN

V

ALVE

INTAKE AIR4 INCH PVC

VENT

4 IN

CHPV

C

FRONTBACK

CLEANOUT

T & P

3/4” NPTDRAIN

1 1/2” NPTWATER INLET

4” PVCVENT CONNECTION

(exhaust elbow)

4” PVCINTAKE AIR

CONNECTION1 1/4” SUPPLY GAS

CONNECTION

33.12” (84.1 cm)OUTSIDE

DIAMETER

4.86”(12.34 cm)

50.77”(129 cm)

75.50”(191.8 cm)

69”(175.3 cm)

69”(175.3 cm)

12”(30.5 cm)

* Center line of water outlet on top of the water heater is 7 inches from the front edge of the water heater.

WATEROUTLETHEIGHT

63 INCHES(160 cm)

CONDENSATEDRAIN CONNECTION

1/2 INCH PVC

RECOVERY CAPACITIES

Page 11: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

11

LOCATING THE WATER HEATER

!�������� ����� �� ������� ��� ���� ���� ������ �������� ���������<���������:�����<������������������������������������������������������ ������������������<������<�������������������������

Property Damage Hazard

All water heaters eventually leak.

Do not install without adequate drainage.

CAUTION

����������������������}������������������������������������������������������������������ ���:�����������������������������1. �����������������<��� ���������������2. �����������������<������ ����������������������������������

��� X�����������������<���������3. +����������������������������������������������� X������

�����������<���� ����<:����:�������4. +����������������������������:����������5. +��������������������������������������������������������

����� �� ������� ����������������� ���������� ���� ���������������������� ��� ������ �����<���� �� �����������X���������������������������������������������������������������������������� ���:����"����������<<�������������<��������������"����\�������������"� �������������������������������

6. +����������������������������������������<�X�����������usage.

7. +����� ���������������������� ����&���6�!�������������(��������(������������&$������\���<�����

8. +����������������������������������\���������������������� ����< ���������:�������������� �� ��������(�������Requirements on page 17.

9. +��������������������������������:�������������������������"������ ���������"� ����� ��<���� ������� ���� <�}�<<� �\�:����������������������(���6�������@�\���<���������������

10. *� ��� ������ ���� ������ ������� ������ ����� =���� ������� !< ����� ]����?� ������ ��<��� �������� ����� �� X������ ��������X������������

11. *� ��� ������ ���� ������ ������� ������ ���� � ��\���������������� �� ���� :���� =�}����?� �� ������� ���� ���<������������ �� X������ ��� ��� �� ����� ��� ���� ���<������=�?����������������������������������������<�����������������(���6�������J�������������������&�

Fire or Explosion Hazard

Read instruction manual beforeinstalling, using or servicing

water heater.

Avoid all ignition sources if you smell gas.

Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.

Use only the gas shown on the water heater rating label.

Keep ignition sources away from faucets after extendedperiods of non-use.

Maintain required clearances to combustibles.

Do not expose water heater controls to excessive gaspressure.

���������������������������� ����������������������������������������������<�"�����������������������������������"��������<<� ��� ��\���� �� ������� ���:��� �\��<���� �� :�������� ���������"���������������������V��<<� ���:������������:���������:�������������������<��� ���������� �������������������������������C����]�������<�����������������}������V��<<� ������<�"���������������������������������������������������������������<�����:��� ���������������X������������������heater.

CLEARANCE TO COMBUSTIBLE MATERIALS���� ������ �������� �:����� ��� ����� <����� ���� ����:��� ������������������< ��� ���������������������������< ��� �����������< ��� �������������<��������� ����� ��������� ���� ������������������������������������������������������������������:���������������������������:��NOTE:����\��������������������:����������� ��<������������������������������(���(��:����!��������� ����

TOP VIEW

0

00

ALCOVE

FRONT VIEW

CLEARANCES TO COMBUSTIBLEAND NON COMBUSTIBLE

CONSTRUCTION MATERIALS

WATERHEATERFRONT

TOP COVER

FRONT

Figure 7

SERVICE CLEARANCE�����:�����������������_��������=�&��<?������ ��<������������<� ���:���� ��� ������ ���� ��� �����/�� :��:�"� ������ �����<��<������"�����:��:�"���������������"�������:��:�"������:�������������=�}������� �?��������������������������+��:�����<��� �<� ��� ���� ��� � :�� ���� ������ ������� ���� ����� �����}������� �����������������(���V��������������&��INTAKE AIR AND VENT PIPE CLEARANCES����<���<<�������������<��< ��� ���<����������������:����=�}����?����������������������������� ������������6�����������������������������������������< ��� ������������������<��� ��������������=��X����?�

Page 12: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

12

EXTENDED VENT TERMINATIONS

�������������������:����� �������<��������� �����������������_��������������������������������)��:�����������������<�}�<<���%���\�:�����������=�&�$�<?���������������������)��:��������������� ���}�����������&����\�:�����������=$����<?� ��������������������������(�������6�������@�\���<�������������������� ������ ������� ������ ��<� ���� ������� ����� ��� =�?� _� ��������<�������� ����� ���� _��� �6!� �� ��� ����� �� �� ���� �������������������������������������������:���������������������"��������������������������<��������<��� �������!�������������������� ��������������������������<����������< ���������������� �����:����������<����������������������<������=�?�

OPTIONAL CONCENTRIC TERMINATIONS

�������������������:����� �������<��������� �����������������*������6���������������������������������������<���������]�;� $��� <����� ���������� ����� _� ����� :���)������� ���� ��������������_�������������������<��������]�;�$���<�������������������� �� ����� :���)������� ���� ������� ��� ���� �� ����� �������������<�������� ]�;� _��� ���� ���� <����� <��� ��� ���� �� ��������������� ���<������� �� ���� �������������� (��� ���� 6�������@�\���<�������������������!������������<�������J�����������on page 27.!��������� ���<�������� <��� �� ������� ������������ !�������������������� ��������������������������<����������< ���������������� �����:����������<������������

�� _��!������������<������������������$������� ���!������������<������������������&__���

HARD WATER

������ ����� ������ ��������� �}���"� ������ ��������� �� ������������� ����� �� ������ �����<���� ��� ���<<������� ����� ���������������������������"����������"��������������"������������������������\��<����(���C����������������������������<����������<����������<:������������

CIRCULATION PUMPS

��������������<���������������������<���\�������������������������������������������������������X���������������������heater. See the Water Piping Diagrams beginning on page 67 for ���������������������������������<����(���!����������<���������*�����<����������������������������������<������J��������������������������������������������� ���� #������� '���������� !��"� #V��� %�� �� ���� !��������'����������!��"�!(��!���&����^ ����������������������<<�������������������<<���������������������(<��������������<�������<���������������������� ����������������� ��\���� ������� � ���������(<��������������<���<��� �� ������������ ������ @����� �� ���� �<�� <��������������������������� ����������\���<������

INSULATION BLANKETS

Do not obstruct water heater air intakewith insulating blanket.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Breathing Hazard - Carbon Monoxide Gas

J�������� �������������:���� ������������������ ��������}���������� �� ���� ������ �������� �� ���� ��� ���������� ����� �������������������������������������� ��������������������������� ������� �������������������������� ���������������������������������:����� �������<�����<�������}���������'����������������������������������������������������������� �������������\���<����"�<������������������ ������������������(���� �� ����� �� ������ ��� ��������� ������� �� �����������"� ������� ����� ������ ������������(��� ����V����������� !<������� ������� �� ����� <����� ��� ������������� ���<�������<�������� �����V��������������������������������������������������������\���������������< ����"���������������������������"������}�����"�����������������X�����������

�� DO NOT�������������������������������������������"������������������������������������������������ ���������< ���

�� DO NOT��:������������������<�+!*������������������heater.

�� DO NOT��:���������<�������^��������@������6��:���� DO NOT��:�����������������<���������������������������

����������������������� ���������������������� DO� ��������������������������������� ������<�����

<������������������<���������� ����������������:�������existing labels.

�� DO���������������������� ����������\��������<�������������������������"������ �� ����������< ������������

Page 13: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

13

POWER SUPPLY

�������������������:����� ��� �����<����� ��\������&���6�!"�&��=������������?"���;�"�&���<�����������������<������� ���������������������������������������������������"��������� �����������������"����������#�������'����������!��"��#(J)#V���%��������!��������'����������!��"�!(��!���&�POWER FLUCTUATIONS AND ELECTRICAL NOISE���������� ��������� ������ �����<� ��\������� ������� ��� ���������������������������������������!������������������������������ ���������������������� X������������������:��������:���������������������������������'CJ�=�������<��������������������?���@VJ�=��������\�����������������?�<���������������������������<�������������<�����������������\����������������������)��������������������������+���� <���� ('+V)�^&�� (������ (!^+� �� �\�:������ <��� �������������������� :������������}�����!������������������������������< ���������������� �����:����������<��������<���information. NOTE:�C���������������� �������������������������������� ����������������������������������:�������������� ��<��������������DEDICATED POWER WIRING AND BREAKERS*��������� ����� ������ �����"� ����� ������� ���� ����������������� ����������������:���������������������������������� ���������������������������������������������POLARITY SENSITIVE���������������<����������������������:�������������<�������� �������� �������:��� ���������� ��<�� �������� ��\����� ���������������� ���� ������ �����<� ��� �����<<��� �� <����� �������<����������������J������;������#�������������������&���6�!������������������:�����"����������������<����������������V���������������������"���������������������� ������ ����������������������������������������������������������<��������������������!�@�:�������V����<�������������+!*�(���'������������������������$����������������������������

TABLE 4

MODEL�C�#JV>+*��@'((K@' �CJ#JCKC�(K��+B��@'((K@' �C� JCKC�(K��+B��@'((K@'

NATURAL GAS PROPANE GAS NATURAL GAS PROPANE GAS NATURAL GAS PROPANE GAS

BTH 300 _�����!��=&������? &������!��=��_�����? ��������!��=&�������? &&�����!��=��%_����? &������!��=��_�����? &������!��=��������?

BTH 400 _�����!��=&������? &������!��=��_�����? ��������!��=&�������? &&�����!��=��%_����? &������!��=��_�����? &������!��=��������?

BTH 500 _�����!��=&������? &������!��=��_�����? ��������!��=&�������? &&�����!��=��%_����? &������!��=��_�����? &������!��=��������?

��C������������������������������������ ����������������������������@������������������ ��¡���$�����!���������������:��������������������������������������������������<�������������������������&�"����������V�����:������� :��&�"���������=$"�_��<�����?�����;������������J����������������������

��C���<<�������������������������������������������������������������=��������������?��#*��������������������=����<����������?��(�������������<�����:�������� ��������<���<<�:������(����������������������� ��<��������������������������������������������������<<��<���������������������������J���������������������<��������&�������!��������� ������������������������������<�=��������)�������?�<��� ��������������������������(����� �������������(�����W���@���������\���<����� �����(���(�����W���+����J������������������$%�����(�����W���@�������J������������������$���������������������������������������also.

��C�}�<<������������������������������������������������������������=��������������?��#*��������������������=����<����������?��(�������������<�����:����}����������<�}�<<�:����

SUPPLY GAS LINE

����������������������������������:�������������<�������\����������\����:�<���� ���������������������������� ���������������:�<������ ����� �� �������� ������"� ��������������������� ��������� J���������� ���� ������ ���� �������� DOES NOT� ������������ ��������� ���� :�<�� �� ���� �������� �� ���������������������<�����<���� ��������<�}�<<������������������������������ ���_������<���<<����������� ���������������� ����� �����<��� �� ���:�����������������������������������������\����:�<�����������������:������DO NOT������}� ���������������(������������������:����<���������������������<�����\���������������������������������������� ������(���W���+����(������on page 37.MINIMUM SUPPLY GAS LINE SIZETABLE 5

MODEL *NATURAL GAS PROPANE GASBTH 300 &�&)_��#�� &�&)_��#��BTH 400 &�&)_��#�� &�&)_��#��† BTH 500 &�&)���#�� &�&)_��#����#��������]�;����������������<�������\������&�&)���<���<<�����������

�����������*��������������������������\�:������������"����)�������< ������������������������"�������������������������<�����:���� ������������ ���������<���<<���\�������������������������� ���^�����W���+����(������on page 37.

SUPPLY GAS REGULATOR

����������������������������������:����� �������<�������\�������������������������� �������������������������������������:���������������������������������������(������������������������\������������������������������������������<���NOTE:�>��<�����������������������������������������������������������:������������������������������������������������������������������������:����������������������(������������������<��� �������������� :�����������]�)�����������������������������������������(��������������������������:��������������������������������������������<���<<�������������������������������������������������:��������������� ����������C�}�����$��^%+����\�:������������<<������See Supply Gas Regulator Installation on page 38.

INSTALLATION REQUIREMENTSGAS PRESSURE REQUIREMENTS

Page 14: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

14

HOT WATEROUTLET

TO TANKINLET

CHECKVALVE

MIXINGVALVE

COLDWATERINLET

TEMPERED WATEROUTLET

12” TO 15”(30-38 cm)

CHECKVALVE

Figure 8

����#�������(���������V��������������<<�����������������&���V�=���!?�������������������������"�������������������� �� :���� ������� �� ����� ��� ���� ��� ����� ���� ������������� �������������������������������������������������� ��X������������:����&���V�=���!?�������������������������^���������������������<����������X��� ��� �� ���������� �� ���� ���� ���� :��:�� ���������� ��� �������������������������������������������<���#�:������������������������������������<���(��������������������*�����<��beginning on page 67.NOTE:����<���������#(V�(������������������������\���<��������� ��<��������������������<��� ��������������������������������� ������������������:��������������� :���������

CLOSED WATER SYSTEMS

������ ������ �����<�� <��"� ������ �� ���� ��\���<������� ���� ��������� ��� ����� ����� �������"� �<��� �����"� ��:������������ ��:����� ���� ��� �������� �������� :��:��"� ������:��:��"����� ����������:��������*�:��������������������������������������<��� ���������������<�

THERMAL EXPANSION

������������������"�����}������=����<����}������?��J���������������<�����:�<��������������������������� ������������������:�<��������������� ����������� ���� ������������ �����������������������������������<����}������������<����}�������������������<�����������������=�������?������������������������ ��� �:����� ����� ���� ��<����� ���������� ����<��� �}�������������������� �����<���������<�������^��������@������6��:����������� ������ ����������� ��<� ���� :��:�� ��� �� �}�����:���������� ���������������������������:����������������<���������������������<�������^��������@������6��:���������������������������������������������<����}��������� �������� ������ ����<��� �}������� ����� <��� �� ���������� ������ ������ �����<�� �� ������ ���� ���<��� �������� �� ����<����}��������!�������� �������< �������:����������� ����:��������<����}����������������������(���������+����!����������������_�����������������������Diagrams beginning on page 67.

MIXING VALVES

Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.

Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.

Feel water before bathing orshowering.

Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.

�������������������<�����������������������������������������"�������������"�������������������������������������������������<������ ��X��� ��� �������� (���� ��������� �������� ������������� ���<����������������������������<�����������������������������}��������������������������<���������������� ���������V�=&&�!?�(<�� ������ ���� <��� ������� �� �� ���<�������� ��X���� ����� ������ ����� ������������� ������� ���� �������"� ��������"� ��������<� ���� ���� ����������)<�������� ���� ������� ��� �� ����� ��������}�<���� ��<�^�^ ��� ������������ ��� ��<��� ����� ������J�� ������ ����� ��� ������ ��:����� �� ���� ������ ������� ������������������������������������������������������������������������������\������������������������<������������������������"������������������������<��� ��������J������������������������������� �����<������������������������������������<�����������������������C�}����6��:������� ��������������� �����������������=����V������?������ ��������������������������������������<���������<��������C�}����:��:��������:���� ��������< �����������������!������� `������� J��������� �� (��:���� �������� V���� <�}���� :��:��<��������������������������������������������:��:���TABLE 6

Water Temperature ��<��������������/�$��*������]�����������(���

&���V�=���!? Nearly instantaneous&%��V�=%%�!? Nearly instantaneous&���V�=%&�!? � ��&)�������&���V�=���!? � ��&^&)��������&_��V�=���!? +�����������������&$��V�=�_�!? � ��$��������&���V�=_��!? More than 5 minutes

DISHWASHING MACHINES

���� ������������ <�������� <������� ���� #������� (���������V���������\���<�������������������������������������������������� �������&�������������������\���������=&�$���������&%$����?��V������������� :���������������\���������=&%$����?"��� ����&������������\���������=&�$����?"����������������<�������������������������������������������������"����������������������������������������������:��:������� �� ���� ��� ���� &���V� =���!?� ����� �� ���� ������������ <���������������� ����X�����������:����������������� �������������limits.

Page 15: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

15

Water Damage Hazard

Temperature-Pressure Relief Valve dischargepipe must terminate at adequate drain.

CAUTION

T&P Valve Discharge Pipe Requirements:�� Shall not be smaller in size than the outlet pipe size of the

:��:�"�����:������������������������������������������� (�������� ����������� �������� (�������� ���}������������������<����������� (����� ����<��������������������������������� ������ (����� �������������������������<����������������� ���

������<�������^��������@������6��:��������������������pipe.

�� C������<��������<�}�<<�����}��������� :����������������}������������� ��������J���������<����"����������<<������������������������������ �����<����������������\��������������������� �������

�� (����������:������:��:��������� �������� ������������������:��:����������������

Burn hazard.

Hot water discharge.

Keep clear of Temperature-Pressure Relief Valvedischarge outlet.

The Temperature-Pressure Relief Valve must be manually �������� ��� ������ ������ �� ������ !����� ����� �� ������ �������������=&?��������� ��� ������������������������� ������<�������^�������� @������ 6��:�� ���������� ����"� ���� =�?� ���������� <������� ����������� ����� ��� ����� ���� ����� ��X��� ���������� ��<���� ������ ���� ������ <��� �� �}���<���� ���� J�������� <������� ��������� ���� :��:�"� ��� ������ �� �<�������� ���������������������������������"��<<���������������������������������� �� ����������������"� ����� ������������� ����������� ��� �����<����"�������������������<�������^��������@������6��:����������������������)�������������NOTE: The purpose of a Temperature-Pressure Relief Valve is �����:�����}�����:����<������������������������������������������ ���� �/�� :��:�� ��� ��� ��������� ��� ���� �������� ������� ������<����}����������������������������<����}������������<��� �����������������������������<��������������<����}������"�����!�����������(����<����������<���'}��������������&_�J����������������������������������������:������\�����������������������<�������^��������@������6��:���������������������< ��� ������� �� ���� ���� �:��� �� ����� <����� ��� ���������������������

TEMPERATURE-PRESSURE RELIEF VALVE

Explosion Hazard

Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.

Properly sized temperature-pressure relief valve must beinstalled in opening provided.

Can result in overheating andexcessive tank pressure.

Can cause serious injury or death.

����� ������ ������� ��� ��:����� ����� �� �������� �����)������ ������������� �< ������� ��<�������^�������� @������ 6��:�� =�/��:��:�?� ������<���������������:��:�������������� ���������������������������������� �����������<����������������������������� �������� �� ������� �\��<���� �� <��������� ��� <������� ������\���<����� ���@������6��:��� ���;��������(�����(����<�"��#(J���&������!(��_�_"���������������\���<��������(C'�J�� ��������"� ���� ���� �/�� :��:�� <��� <���� ���� ��\���<������� ����� ����"� �� ��� ����� ����� �� �< ������� ��<�������^�������� @������ 6��:�� �����)������ ���� ��������� ��� ���������� ������� � :�� ����������� ���� ���� :��:�� <��� �� <������ ����� ��<�}�<<� ���� �������� ��� �� �}����� ���� <������ ���������������������������������������������=&�������£�&"�$�����?��������������������������������������������������������]�)�����������������������������������������������<������������� ���NOTE:�J�����������������������������������<�������^��������@������6��:��������������������"��������<��������������������<��� ��������������������������������������������������<���������:�� ��������������������"� ��������������:�����<�������^�������� @������ 6��:�� ����������� !���� ���� ���� ����� ����������������������< ��� ������������� �����:����� �����<�������������������������������������������<�������^��������@������Valve for remote storage tanks.V���������������������������������"�������<�������^��������@������6��:��<������ ����<:�����<�������������������������� �������� ���� ��<�������^�������� @������ 6��:�� <��� ������������������������������������������������������������������������������:��:���J���������������������������������������������������}����������������������������=&�����<?�� :��������\������������"����}������� �� ���� �������� J���������<����� ��� ��� ���<<�������������� �����<����������������\��������������������� ��������]���������������������������<���������������:����������������������������������������<������ �� ������������������������������������<���������'}�����:��������"�:���$�������=��&_�<?"��������<������������� ��������������������������������������������������������������:��:��#� :��:�� �� ����� �������� ��� �� �� ������� ������� ������<�������^��������@������6��:����������������*��������������������� ������� ��������� �� ���� ������ ������ �� ��� =&���� �<?����� ���� ��� ��:������ �� ���:���� ����� ��X��"� ������� �� ����"� ������������<���"������������:��:��<��� ��������������������������� ������\����\��������� ����� ����<����������<����� J��������������������������������������������������������� ���<����"��������������<������������������<����

Page 16: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

16

CONDENSATE DRAIN

���� ������ �������� �:����� ��� ����� <����� ���� ��������������������� ���� ��\���� �� ������� ������ �� �� ������� ��� �������}�<�����������������������������������������!������������������<��������������������������}������� ������������ ���� ��<����������� �������������������������� �����<��� ��� �� ���:����� � :�� ���� ���������� ������ �����������������������������"�����V�������� � J�� ��������������������� ������ �������� ��� ����� ���� �� ��� ���� �}����� =:���?� �� ������������� ��������� ��������� ������������������ ����]������'}������������������������������������������������������<�<������ ���� �������� ��������"� ��� ���� ]������ '}����� (���������������������� ���������������<������ �������������� ����������� ��������� ���� �]������ '}������ V���� <������� ����� �����������������������������<���+!*"�����V��������������!�������� �����������������%�NOTE: J�������]������'}�������V����<�����������:������������������������������<�+!*"��������������������������������������������������� ������

CONDENSATE DRAINLINE - FIELD INSTALLED

CONDENSATE DRAINLINE CONNECTION

EXHAUST (VENT)ELBOW

BUILDINGDRAIN

FACTORY INSTALLEDCONDENSATE TRAP

CLEANOUTPLUG ISREMOVEDTO CLEARDRAIN

Figure 9

CONDENSATE DRAIN WATER TRAP

Ensure a functioning water trap isinstalled in the condensate drain.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Breathing Hazard - Carbon Monoxide Gas

*� ��� ��<:�� ���� ������� ���������� ���������� ����� ��� ���������"� ���� V����� ��� ���� ������ ��������� :���� ����� ��� ������� ������� �����:�� ������������� ������ ����� ���:����� ��� ��������<���������� ���� ���� �����������������(���!���������*�����Installation on page 36.CONDENSATE PH LEVEL���� ���������� ������� ��<� ���� ������ ��������� �:����� �������� <����� ��:�� �;� ��:���� ������� _�$� ���� ����� J������� ���<<����������:���� ������������������������\����� ������������NOTE:�+�����;���:����������������*�������������<���������������"� ���� ��� �����"� �� ���� ������ ������� ��� ����� ������� (���!���������*�����J������������������$��

COMBUSTIBLE MATERIAL STORAGE

Fire or Explosion Hazard

Read instruction manual beforeinstalling, using or servicing

water heater.

Avoid all ignition sources if you smell gas.

Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.

Use only the gas shown on the water heater rating label.

Keep ignition sources away from faucets after extendedperiods of non-use.

Maintain required clearances to combustibles.

Do not expose water heater controls to excessive gaspressure.

����� ���������� ����� ������ ���� ����� �� �< ��� ��� <��������"��������������������<<� ���:�����������\����

CONTAMINATED AIR

Breathing Hazard - Carbon Monoxide GasInstall water heater in accordance withthe Instruction Manual and NFPA 54 orCAN/CSA-B149.1.To avoid injury, combustion and ventilationair must be taken from outdoors.Do not place chemical vapor emittingproducts near water heater.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

!������������������������:���������<�<������������������< ����� �������� �������� ���<����� :������ (��� �������<�����������������������������������}������!< ����� ���� ����� ��� ����<������� ���� �������� ��<������ ��������� ����� �� ���� ������ ������� ���� ������ ������� �<������������������������������������� ��������������������������������"� ����� ���� �������"� ������ �������� ���<������ �������<������������������������������������������������������������< ����"�:�������������< ������������������������<����*��������������������������������������������������������������� �������������������������������������������������������������������<�������J�����������"������<���������������� �� ���������<���<����������������������<����������������� :����� ����� ������� �� ������ ������� ��� ��� �� �� �����:����<�������� =(��� ��<����� ��������� ��� �<������ ���<�� ������������?�J������������������������ ��������� ���������"� �� �������"���������� ���� ����<����"� �� ����^���:���� ��������� ����� ��������������\��<���"���� ����<������:�����������������������=�?� �����������������*������6���������������������������������< ������������:��������������<�����������<����������������������intake air pipe. See Venting Installation on page 21.

Page 17: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

17

UNUSUALLY TIGHT CONSTRUCTIONJ����������������� ��� �������"� �����������<��� �����\������ ��:���� ���� ��� �< ����"� :���������� ���� ������� �� ����������;��:��"���� ���������������������������������=����}�<���"� �������� ���������"� ���:���� ��������"� ������"� :���� ������"�����?���������������<��� ����:��������������<������������ ����������!������(�����������������������

CONFINED SPACE

��!������(����������������:�<��IS LESS THAN����� ������������&"����]�)���=_����<�������?����������������������������������������������������������������>��������<��� ����������������:������������������< ����"�:���������������������������������������������\��������������������������������������������<�������������:���������������������������������AND the total Btu/hr input rating of all ����������������������������������DIRECT VENT APPLIANCES��������������������������*������6�����������������������:��������������< �������<�����������<��������������������������������������������������������������������������������]�)�������������������������<�������������������������:����������������������������������EXHAUST FANS�������}�����������������������"��������������������� ����:������� �������� �����}���������������������}����� ���� ��� ������������� ���� ��<�� ������ ����� �� ������ ������"� ��������� �������� ����:���� ������ ���� <��� �� ��:����� ����� ���<<����� ������\���<�������������������������������<����������}����������K����������������������� ��������� �� �������� ���� ���� �<��������������������������:���������<������������< ������(����"���������<���������������������������������������������}������<����������J�������������������������������}������LOUVERS AND GRILLES��������������������������������������������������������������������������������������������������������:���"�������������������������������������� ��\����� ����� �� �������� ��� �< ����"� :���������� ��������������������� �� ��������������������������������������������������������������������������������:������������������������ ����"� ��� ������ �� ���� ��� ����������� ���� ����� �� ���������\���������:���������������������������������������:����������������������������������������������"� ��������� �����<������������:�����������:��������������������<������:�����������������������:��%��������������#��<��������:���������������������� ���}���������������������

AIR REQUIREMENTS

Breathing Hazard - Carbon Monoxide GasInstall water heater in accordance withthe Instruction Manual and NFPA 54 orCAN/CSA-B149.1.To avoid injury, combustion and ventilationair must be taken from outdoors.Do not place chemical vapor emittingproducts near water heater.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

V���������������������\�����������������������<���������������< ���������:����������<��� ����:�������������������������������������������������������< ������������ ��������� ��� ����<������� ����� <��� �� �������� ��������(���������������������������������������"��<���� �������<�"���������������������< ��������< ��"� �������������� �����������������������������}������*� ��� �������� ���� ������ ������� ��� �� ������� ������ ������ ������\��������������������< ���������:������������� �������� �� ����� ������ ����� ���� <������ ������ ��� ��� ���� !������(������������������������#�:��� ���������������:���������������J������:������� �����\�������������"����������������������V����������:���������������<������< �������������������������������}�������������������������<���"������� �������X�����������

UNCONFINED SPACE

���K��������(����������������:�<��IS NOT LESS THAN ���� ������������&"����]�)���=_���� ���<������������?�����������������������������������������������������������������@<���<<��������������������������������"����������������������������� ���������"� ������ �������� ��� ��������� ����� ���"� �����������������������������������������C����� ���� ��\���<����� ��� ���� �������� �� �}����� ����"���������:���������������<�"��������������������������������������� ������������ ��������<������ �������\�������������� ����:�����< ����"�:�������������������������

Page 18: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

18

���������:����������������<������������"��<<��������������&���������=$���<<?�����������������������"������� ����:������(��� V����� &&�� ���� ������ ������� ������ ��:�� ����������� �� ���������&������=���<<?���<��������������� �����������������=����<<?���<������������������������������������������������������<<������������������������������<<���������������:����������������������� �� ����������������������� ��������<<���������������������������������:����<���<<�������������������������1. &��\�������������$����]�)���=%���<<��������?������������

��������������������������������������������������"����2. #�����������������<�������������������:����������������

����������

OUTDOOR AIR THROUGH TWO HORIZONTAL DUCTS

Figure 12

���� ������� ������ ������ �� ��:����� ����� ��� ���<�������������������"�����<<��������������&���������=$���<<?������������������<<��������������&���������=$���<<?������� ��<�����������������������������������������<<�������������������������������(���V�����&��'�����������������������:����<���<<�������������&��\��������������"����]�)���=&&���<<��������?����������������������������������������������������������������������������������������"������������ ����������<��������������������� ��� ���� ����� ����� �� ���� �������� �� ������ ����� ������������<���<<���<���������������������������������� ���������������$���������

FRESH AIR OPENINGS FOR CONFINED SPACES

���� �������� ����������� ������ �� ���� �� ��������� ���� ����"��< ��� ���� �����<���� �� �������� ��:������ ������ ���� ����< ����"� :���������� ���� ������� ��� ������� �������� ������������������������������������������<������������������������ ���� �������� ����� ��:���� ������ ���� ���� ������� �������only. DO NOT refer to these illustrations for the purpose of vent ������������� (��� 6������� J����������� �� ����� �&� ��� �<������:������������������������������

OUTDOOR AIR THROUGH TWO OPENINGS

Figure 10

���� ������� ������ ������ �� ��:����� ����� ��� ���<�������������"�����<<��������������&���������=$���<<?������������������<<��������������&���������=$���<<?������� ��<�����������������������������������<<�������������������������������(���V�����&��'�������������������:����<���<<�������������&��\�������������_"����]�)���=����<<��������?���������������������������������������������� ���������� ��� �������������'�������������������� ������������&����\�����������=�_���<�?��

OUTDOOR AIR THROUGH ONE OPENING

Figure 11

Page 19: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

19

AIR FROM OTHER INDOOR SPACES

Figure 14

���� ������� ������ ������ �� ��:����� ����� ��� ���<�������������"�����<<��������������&���������=$���<<?������������������<<��������������&���������=$���<<?������� ��<����������������(���V�����&_�'���� ������� ������ �<<������� ��������� ����� ��� �����������<=�?������������:�<��������������< �����:�<���������������<������������������������K��������(�����'�������������������:����<���<<�������������&��\������������� &"���� ]�)��� =&&��� <<�� ���� ��?� �� ���� ���������� �������������������������������������������������������'�������������������� ������������&����\�����������=�_���<�?��

OUTDOOR AIR THROUGH TWO VERTICAL DUCTS

���� ������������ ����� ��� ����� ������� �� ���� <����� ���� ������������ ��� ���� �������� ����� ��:���� ������ ���� ���� ������������������DO NOT refer to these illustrations for the purpose of vent ������������� (��� 6������� J����������� �� ����� �&� ��� �<������:������������������������������

Figure 13

����������������������� ����:����������������<������:������������"�����<<��������������&���������=$���<<?������������������<<��������������&���������=$���<<?������� ��<��������������������:��������������������<<�������������������������������(���V�����&$�'�����������������������:����<���<<�������������&��\�������������_"����]�)���=����<<��������?�����������������������������������������������������������������������������������������"������������ ����������<��������������������� ��� ���� ����� ����� �� ���� �������� �� ������ ����� ������������<���<<���<���������������������������������� ���������������$��������

Page 20: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

20

COMMONWEALTH OF MASSACHUSETTS

V�������������������<������"������������:�����������:���"��������:���"�����������������:������������������������������������������:������������"� ������������������������������������������������������������"������������������������������ ������!<<���������������������������������}�����:�������<���������� ����� �������:���=%?� ������ :���������������� ��� ���������������:������"���������� �������<�����������������������"���������������\���<����������� �����������

INSTALLATION OF CARBON MONOXIDE DETECTORS

��� ���� ��<�� �� ������������ �� ���� ����� ����� ��������� :���������� �������\��<���"� ���� �������������< �������������������� ���:�� ����� �� ����� ������ ��� �� <�}���� �������� ����� �������<����� ������� ���^��������������������������:������������������\��<��������� �������������J���������"������������������< ��� �� ��������� ������ ���:�� ����� �� ������� �������� ���������������� ��<�}������������������������<���������������� ����� ���������� ��:��� �� ���� ��������"� ������� �� �����������:��� ������������������������:�����������������\��<�����J�������� ������������� ����������������������������������������:�������\��������������������������������������������������������������� ��<�}�������������

J�� ���� �:���� ����� ���� ����� ����� ����������� :������ ���� �������\��<��������������������������������������������"������������������� ��<�}���������������������<����� ������� ���^��<��� ��������������������}����X�����������:���

J�� ���� �:���� ����� ���� ��\���<����� �� ����� � ��:����� ���� ��� ��<������������<�����<��������������������"������������������:�� �� ������ �� ������� =$�?� ����� �� �<���� ����� ���� � :����\���<�������:����������������������������=$�?����������"��� ������������������ ��<�}������������������������<������� ������������

APPROVED CARBON MONOXIDE DETECTORS

'������� ��<�}�����������������\���������������������������� :����:�������������<���������#V���%������� ���#(J)K+���$_������������!(�����������

SIGNAGE

�� <����� �� �������� ������������� ������ ������ �� ���<��������<����� �� �����}�������� ���� ������������<���<<����������������=�?������� :�����������������������������������}�����:�������<�����������������������:�������������������������������������\��<������������������������"�����������������������������^�����=&)�?�������������"�“GAS VENT DIRECTLY BELOW. KEEP CLEAR OF ALL OBSTRUCTIONS.”

INSTALLATION REQUIREMENTS - COMMONWEALTH OF MASSACHUSETTSINSPECTION

���� ������ �� ����� ���� ��������� �� ���� ����� ����� �����������:���������� �������\��<�����������������:�� ���� �����������������"� ��� ���������"� ���� ��������� ���:��� ��� ��<�}�����������������������������������������������������������:���������_��!C@�����=�?=�?�&�������_�

EXEMPTIONS

���� ���������\��<���� ����}�<��� ��<��_��!C@�����=�?=�?&�������_�

1. �����\��<��������������!�������&������������'\��<����#��@�\�������]��6��������������<�������������������#V����_����������� ������]��������

2. ����������:��� ����� ����� ����������� :������ ���� �������\��<��������������������<����������������������<�������������"� ������"� �� ������������ ���������� ��� ����� ����������������������

MANUFACTURER REQUIREMENTS - GAS EQUIPMENT VENTING SYSTEM PROVIDED

����� ���� <���������� �� ������ ����:��� ����� ���������������� :������ ���� �\��<���� ��:����� �� :������� �����<����������:������������<��<������������ �����\��<���"� �����������������:����� ������<���������� ��� �������������� �����\��<������������:������������<��������������

1. *��������������������������������������������:������������<��������������:������������<��<�����������

2. ���<������������������������:������������<����������:�������system.

MANUFACTURER REQUIREMENTS - GAS EQUIPMENT VENTING SYSTEM NOT PROVIDED

����� ���� <���������� �� �� ������ ����:��� ����� ����������������:���������� �������\��<�������������:���� ���������� ��� :������� ���� ��� �����"� �� ���������� ��������� :������������<�"�� ���� �������� ��\���<����� ������ �� ��������� �� ����<����������

1. ���� ����������� ��������� :������� �����<�� ����������� ������ �� �������� ����� ���� ���������� �� �\��<���� ����������� �����������������

2. �������������:������������<��������� ������������:��� ������]���"���������������������������������<����������������������������������������������������������������

�� ���� �� ���� ������������ ����������� ��� ���� ����������:������������������������:���������� �������\��<���"����� :�����������������"� ���� ������ ������ ��� :������� ����������"� ���)�� ����:������� ������� ����������� ������ ��<���� ����� ���� ���������� �� �\��<������������<�������������������������

Page 21: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

21

��:���� ��� ���\���� ������ �� ������ ���� ���� ������ �������<��� �����������������*������6��������������

2. J�� ���� ������ ������� ��� �� �� ���������� ��� �� ����� ���"� �� ��� ���"� ��������� ���� ����<���"� �� ������� ����� ��������������\��<�������������������������<������������������<������:�� ����� ���� ������ ������=�?� �� ���������� ��� �� *������6���� ���������� �� ����� ���� ���� ��� �< ����� ��� ����:�����<�����������<�������

3. ����:��������������������������<������<�����������4. ����<���<<�������������<��< ��� ���<��������� ��� ����

:����=�}����?����������������������������� ������������6����������������������������< ��� ������������������<��� ��������������=��X����?�

5. �����������������<��� �������������<����������������������������������������

6. ����:����=�}����?������<������ ���< ���������������������������������������:���������<������<����

7. ���� ����������������<������ ���< ���������������� �����������������������������������������

8. +��������������������������������:����=�}����?������������������������������<���������������<�}�<<��\�:����������������������(���6�������@�\���<���������������

9. *����������������:�����������������������������<����������������������������� ������������������������

10. 6����������<��� ������������<���<<�����&)_������������� �����������������������=���������������������������?�

11. *��������������:������ ������������������������������<��������"����������������������� �������������������������������������:����:� �������������<� ����������<������

12. K�����������:���:���)��������������������������<����������See Venting Requirements on page 22.

13. K������� ���������������:�������� �����������������������terminations. See the Venting Requirements on page 22.

14. *� ��� ������ ���� :���� =�}����?� �� ������� ���� ���<�������������� ����� ���� �� X������ ��� ��� �� ����� ��� �������<������=�?����������������������������������������<����������������

15. *������:����������������������������������������"�����<�"����� ������� ������� ���� ����� ������������ �� ��� �������@����������� �� ��� ������ ����� ����� �����"� ���<������������ �� ���� ����� �}�������� ���� ������ �� ���� �< ��������� ������� ������ ��:���� ���� ��������� �� ���:���� ���������������� �� ��� �����"� <�������� ��� <��� ��������� ������� ��� ��������������������������:�������<��������

16. *��������������:�������<�������:������ ���������������������������:������������������������������������

17. '������������������������������������������<�����������������������������������:���� ��������������:���������<�

18. (��������:�����������)������������ ������������������������� ���<������ ������������� J�� ������ ����� ���<��� ���� ���� �� ���������������������"���������������������<:��������������������������������"����������<��� ����������"������������<������������<��� ����<������������������������������}�������J��������������������<���<�����������������

19. !�����������������6�������@�\���<�������������������������������������6�������J�����������(�\�������������$�

VENTING INSTALLATION

Breathing carbon monoxide can cause brain damage or death.Always read and understand the instruction manual.

Install vent system in accordance with codes. Do not operate water heater if flood damaged.Special consideration must be taken with installationsabove 10,000 feet (3,048 m) refer to high altitudesection of this manual.

Breathing Hazard - Carbon Monoxide Gas

Do not operate if soot buildup.

Do not obstruct water heater air intake with insulatingjacket or blanket.

Do not place chemical vapor emitting products nearwater heater.

Gas and carbon monoxide detectors are available.

Never operate the heater unless it is vented to theoutdoors and has adequate air supply to avoid risksof improper operation, fire, explosion or asphyxiation.

Analyze the entire vent system to make sure thatcondensate will not become trapped in a section ofvent pipe and therefore reduce the open crosssectional area of the vent.

#�:���������������������������������������:������������������������������������������������������<�����<��� ������������:����������< �������������������������������(������������ ����� ������ �� ���� �< ����� ���< ��"� �������������� �����������������������������}������

GENERAL VENTING INFORMATION

���� ������ �������� �:����� ��� ����� <����� ���� �������������\�:������ �� !������� J6� ����������� ���� <��� �� ���������� �����������������6������*������6��������������CATEGORY IV APPLIANCE!������� J6� ����������� ������� ����� �� �����:�� :���� =�}����?�������������������������:�������� ��<��������� �������� �������������������������:�����������POWER VENT CONFIGURATION����� 6���� ����������� ����:�� ���� �< ����� ���� ��<� �����<� ������ ����� ���� ���������� ���� ���������� ���� ��� ������ ������������<������� ���������������:���� =�}����?������������:�����������������:�����:����������������������������������������������� �����<������������:��������������������������<�����(���V�����_������V�����_&��������$��DIRECT VENT CONFIGURATION*������6�������������������:�������< ��������������������<����� ���� ��<������� ������ �� ������� ������� ���� ����� �������������� ���� ��� ������ �� ���� ���� ��<������� ������ ���������:����=�}����?�������*������6�����������������:����������� ��������� �� ���� ������ ������"� ��� :���� ����� ���� ���������� ���� ������ *������ 6���� ����������� ���� �� ���<�����������������}������������������<������(���V�����_���������$��������V�����_%��������$$�

GENERAL VENTING INSTRUCTIONS

�����������������<��� ����������������������������1. DO NOT������������������������������������6��������������

������ ������ ��� ���\���� ������ �� ������ ���"� ���� � ����@�\���<������������&%��J�������������������������������

Page 22: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

22

=�}����?����������������������������� ������������6�����������������������������������������< ��� ������������������<��� ��������������=��X����?�MINIMUM EQUIVALENT LENGTHSFour Inch Pipe���� ������ �������� �:����� ��� ����� <����� ���� ��������� ���� <���<<� ������� �� _� ����� ����� ��� ���� :���� =�}����?� �� &���\�:������ ����� =_��� <?�� ������ ��� �� <���<<� �\�:������ �����requirement for the intake air pipe.Six Inch Pipe���� ������ �������� �:����� ��� ����� <����� ���� ��������� ���� <���<<� ������� �� �� ����� ����� ��� ���� :���� =�}����?� �� %���\�:������ ����� =�&�$�<?�������� �����<���<<��\�:������ �����requirement for the intake air pipe.MAXIMUM NUMBER OF ELBOWS����:���������<�����:����<�}�<<�����}������� ������������������ ������� ���� ����� <��� ��:�� �� <�}�<<� �� ��}� ���� �� ��������������J'�������*������6������������������������������:��������}�=�?������� �����������������=�?�_����� ����\������=&?������� ���'���������� ������\�:���������������=&���<?��������������"�_����� ��������\�:�����������������=��%��<?���������������FACTORY SUPPLIED FITTINGS���� ������ ������� ������ ����� ��� =�?� ������� �������� _� ��������<�������� =�6!� _��� �� ��� ����� �� ���� ������?�� V�������������� :���� ���� ������� ���� ���<�������� �� �������������<�������� <��� �� ����� V������ �������� ���<�������� ����������������������=�}������� ������ �������������������?����������\�:�����������������:��������������������������NOTE:� $� ����� ������� ���� ���)�� :���� ���<�������� ���:��������������� �� ����� ]�;� $��)_��� <���� ������������� <��� ����������� ����� ������� �������� _� ����� �� �� ����� ���<�����������������������������������������TABLE 7

Number of 90° Elbows Installed

4 Inch Pipe 6 Inch PipeMaximum Feet (Meters) Maximum Feet (Meters)

>���=&? ��������=&����<�����? &&�������=$����<�����?

���=�? ��������=&����<�����? &&�������=$$���<�����?

������=$? ��������=&����<�����? &��������=$����<�����?

V��=_? ��������=&����<�����? &��������=$����<�����?

V�:��=�? _�������=&$�%�<�����? ��������=�����<�����?

(�}�=�? _�������=&����<�����? ��������=�%�_�<�����?

6 INCH EXTENDED VENT TERMINATIONS������� ����� �������������:��������� ��� ���������������������������<�������"��������������������������<��������<��� �������!�������������������� ��������������������������<����=������< ���������������� �����:����������<����?������������������<������=�?�OPTIONAL CONCENTRIC TERMINATIONS]�;� $��� <����� ���������� ����� _� ����� :���)������� ���� ��������������_�������������������<��������]�;�$���<�������������������� �� ����� :���)������� ���� ������� ��� ���� �� ����� �������������<�������� ]�;� _��� ���� ���� <����� <��� ��� ���� �� ������������������<���������������������������!�������������������� ��������������������������<����������< ���������������� �����:����������<������������

�� _��!������������<������������������$������� ���!������������<������������������&__���

VENTING REQUIREMENTS

APPROVED MATERIALS����:���:������������������������<��������������<��� �������������K������(������

�� �6!�(�������_��=�(�C�*���_&�)�!(��]&�&��"��(�C�*�&%���)�!(��]&$%�$

�� !�6!�(�������_��=�(�C�V^_&&�)�!(��]&$%��?�� �](�=�(�C�*^���&?

����:���:������������������������<��������������<��� ���������!������

�� K+!�(�$���6!�)�!�6!

FIELD SUPPLIED FITTINGSV�������������������������� ���\�:�������������������<�������� ����������������V��������������)��������������������������\�:�����������������:������ ��������������������� ���������� ���������������������)���������� �������� ���� ������� <��� �� �������� ���� �����\�:�����������������������

�� ������ ���=����������������?������\�:����������������������=&����<?���������

�� _����� ���=����������������?������\�:������������������������=%���<?��������

PRIMER AND CEMENT�������������� =�;V?� ���<��� ����� �� ���� �� �������� ������������������������������������:�������������J��!�6!����](�������������������������"������������������<����<��� ��������� ���� X����"� ��������� X������ ���� ����� �� ���� ������� ��:��������<�������� =�6!� <�������?�� �6!� C��������� ����� ����(�C�*^���_�W�����!�<�����!�6!�C������������������(�C�V^_�$�W����� !�<���� ���� �](� C��������� ����� ��� �(�C� *^��$��W�����!�<����PIPE SIZE REQUIREMENTS�������������������:�������������<������������������������������_������������������������:����=�}����?������������������������J�����������������\�:���������������������������������:���������������� ��%�������=�&�$�<?�������"�_�����������<��� �������J�����������������\�:������������������ ��<��������%�������=�&�$�<?"�������������<��� ������NOTE:�J�����������������������\�����������������������\�:���������������������������������������� J'��J�� ���� ��������������������� ��%���\�:��������������������������:��������������<��������%���\�:��������������������������������<��� �����������������_�������������������:����<��� �����������������������������MAXIMUM EQUIVALENT LENGTHSFour Inch Pipe���� ������ �������� �:����� ��� ����� <����� ���� ��������� ���� <�}�<<� ������� �� _� ����� ����� ��� ���� �}����� :��������������<���� �� %�� �\�:������ ����� =�&�$� <?�� ���� ���������<�}�<<� ���������_� ���������� ��� ������������������ �������%���\�:������ ����� =�&�$� <?�� J'�� >�� *������ 6���� ������������� ������������� ������%���\�:�����������=�&�$�<?��Six Inch Pipe���� ������ �������� �:����� ��� ����� <����� ���� ��������� ���� <�}�<<� ������� �� �� ����� ����� ��� ���� �}����� :��������������<���� �� &��� �\�:������ ����� =$���� <?�� ���� ���������<�}�<<��������������������������������������������������&����\�:������ ����� =$���� <?�� J'�� >�� *������ 6���� ������������� ������������� ������&����\�:�����������=$����<?�INTAKE AIR AND VENT PIPE CLEARANCES����<���<<�������������<��< ��� ���<����������������:����

Page 23: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

23

�}������� ���������������������11. J�������������������������������������_����������������������

V����� &������� ����� ���������� _�� ����� ������� ���� �}������� �������������}�_��������������������� ��&���������=_���<?������������������

DIRECT VENT INSTALLATION

1. @���� ���� W������� 6������� J���������� �� ����� �&� ����6�������@�\���<��������������� ������������������������������������� ��\���<�����<��� �� ������� ������������� ���� ����������� ���� ����� ���� �������� ��� *������ 6���������������

2. *����<���� ������ *������ 6���� �������<���� ����� �� ���� ������� ������������� ������ ���� ��}� =�?� *������ 6���� �������<���������"�����������$������$$�

3. *����<����:�������� ��������������������� �� ������ ��� ���������������������6�������@�\���<���������������

4. ��������������������:�������������������������� �����������<� ���� ���<������� ����� ����� �� ���� ������ ��������+���� ����:�������� ������������������ �������<���<<�������������� ���

5. J��������������<��������������J�� ��������� ���<�������� ���� ����� ���� ���� ���� ������� ������ :���� ������� ����� ���<������ :���������"� ������ �� ��"� ����6�����������<�������J�������������������_��J��������������<������������ ������������������������������:�������������������<����������������"�����������������"�����(�����������<�������J����������������������J�� �� ���������� ���<������=�?� ����� �� ���� ���� !���������Termination Installation on page 27.

6. ����� ������������ �� ���� ���<������=�?� ��� �<������ J�������������������������������������������������������������:����������� �����������������������

7. ���� ���������������:�����������<��� ���������������������:��� ��������� �������������������������<�������������<<��������������:�������������������������� �����������:�����������=&����<?���:����������������:����$������=�&��<?�of horizontal run.

8. *����������������:�����������������������������<����������������������������� ������������������������

9. ������������������������������������������������������� �����������������������������������������������������������������������<�������������:���������<������������������������� ��������� �}��������� ����� �<������� ���� ������ ��������� �� ����� ��������\���������������������� ��<����������������������������(���V�����&����������_�NOTE:�(��� ����������������������������������������������<�������������������}�����:���<���������������<������������<������������������<�����������<"��<�����������������������}�����:����������������������������������������������<���������<������������������<�������

10. ����:����=�}����?�������<��� ������������<���<<�����&)_������������� �����������������������=���������������������������?�

11. J�� ����������� _� ����� :���� ����� ������� ���� :���� ����� �� �����}������� ���������������������

12. J�� ������������� �����:��������� ���������� ��_� ������������� �����}������� ���� ������������������������� ���V�����&������������ ����������_������� ������� �����}������� �������������}�_��������������������� ��&���������=_���<?���less in length.

VENTING INSTALLATION SEQUENCE

1. @���� ���� W������� 6������� J���������� �� ����� �&� ����6�������@�\���<��������������� ��������������������������������� ���� ��\���<����� <��� �� ������� �� ����installations.

2. *����<���� �������� ���� ������ ������� ����� �� ���������� ����� ����� 6���� �� *������ 6���� ���������� ���� ������ :���������<��������<��������� ��������������������������(�������:�����:��������������<�������������$������$$�

3. �������������������� �������������������������������������������6����J�������������*������6����J�����������

POWER VENT INSTALLATION

1. @���� ���� W������� 6������� J���������� �� ����� �&� ����6�������@�\���<��������������� ������������������������������������� ��\���<�����<��� �� ������� ������������� ���� ����������� ���� ����� ���� �������� ��� ����� 6���������������

2. *����<���������������6�����������<��������� ������ ��������������������:����������������������<��������(���V�����_������V�����_&��������$��

3. *����<��������:��������������������������������"�����6�������Requirements on page 22.

4. ����� ���� ����� �� ���� :���� ������� ��������� ��<� �������<������� ����� ����� �� ���� ������ �������� +���� ����:������������������<���<<�������������� ���

5. J��������������<������������J������:�������������������<������:���������"�����������"�����6�����������<�������J�������������������_��J�� ���� :���� ������� ����� ���<������ ����������"� ������ ����������"�����(�����������<�������J���������������������

4” PIPE FIELDSUPPLIED

EXHAUST ELBOWVENT CONNECTIONFACTORY INSTALLED

6” PIPE FIELDSUPPLIED

6” x 4” REDUCERFIELD SUPPLIED

VENT (EXHAUST) CONNECTION

Figure 15

6. ����� ������������ �� ���� ���<������� ��� �<������ �����������������������������������������������:����������� �����������������������

7. ����:���������<��� ���������������������:��� ����������������������������������<�������������<<��������������:��������� �����������:�����������=&����<?���:����������������:����$������=�&��<?���������������

8. *����������������:����������������<����������������������������� ������������������������

9. ����:����=�}����?�������<��� ������������<���<<�����&)_������������� �����������������������=���������������������������?�

10. J�� ����������� _� ����� :���� ����� ������� ���� :���� ����� �� ����

Page 24: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

24

14. ]�;�����#��K@�+�W�(�C>*'+(�>#+B�������������� ������������� =��<:��� ��� ���� ���:��� ����?� �� ���� J������ �������<�������������������������\�:���������������������������������������� ������������������*����������� �������������������������<�������������������������\�:���������������������������������������� ��<�����������������(���V�����&%�

15. J�������������_����������������������������������������������������������������������������������������������

16. J��������������������������������������������_������������������������������������ ������������������������� ���V�����&����������������������_������� ������������������������������������������}�_��������������������� ��&���������=_���<?�or less in length.

3” PIPE FACTORYINSTALLED

6” PIPE FIELDSUPPLIED

4” PIPE FIELDSUPPLIED

6” x 4” REDUCERFIELD SUPPLIED

4” x 3” REDUCERFACTORY INSTALLEDINTAKE AIR CONNECTION

INTAKE AIR CONNECTION

INTAKE AIR

COMBUSTIONBLOWER

Figure 18

VERTICAL TERMINATION INSTALLATION

1. *����<�������������������������<������=�?�2. J�� ��������������� ����:���� =�}����?� ������� ����������6����

���������� :���������� ������ ���� ���� ������ ����� �����}������ :�������� ���������� ��\���<����� ����� ��� V�����&������V���������������������� �����<������������������������������������������� ������������������������<��� ��<����������NOTE:�>��������������������������:�������<�������<��� ����<���<<����_��������=����<?�� :�������������"�:������������������������������&�������=$�<?�������������(���V�����20 on page 25.

3. J�� ����������� ��� ���������������:����������� �����*������6�������������� :���������� ������ ���� ���� ������ ����� �����}������ :�������� ���������� ��\���<����� ����� ��� V�����&������V���������������������� �����<������������������������������������������� ������������������������<��� ��<����������NOTE:�>������ ��� ������������� ���� ��������������� ����:�������<��������<��� ����<���<<����_��������=����<?�� :������ �������"� :�������� ����� �� �������� ������� &�� ����� =$� <?�������������(���V������������������

4. J�� ����������� ���� :���� ������� ��� �� ����� 6���� ����������:����������������������������������������������<��� �������������:�������<�������<��� ������������������������������������V�����&������V���������������������� ��<������������:�������<�������<��� ����<���<<���&���������=$���<?"�&���������=_���<?����!�����"�� :�������:���������}�������������:��������������V�����&��on page 25.

5. J�� ����������� ��� ���������������:����������� �����*������6����

INSTALL TEE FITTING AS CLOSE TO WATER HEATERINTAKE AIR CONNECTION AS POSSIBLE

INTAKE AIR CONDENSATE TEE INSTALLATION

FIELD SUPPLIED3” x 3” x 1/2” TEEWITH HOSE BARBFITTING INSTALLED

FACTORYINTAKE AIRCONNECTION

INTAKEAIR

PIPING

CONNECT FIELDSUPPLIED FLEXIBLEDRAIN HOSE TO BARBFITTING AND FORM ALOOP WATER TRAP INDRAIN HOSE

RUN DRAIN HOSETO SUITABLE FLOORDRAIN SEPARATELYFROM OTHERCONDENSATE DRAINS

Figure 16

13. '���������]�����������������J����������(������������J���������� !�������� ���� ��� ��<:��� ����� ���������� ��������������������������������������"�����V�����&%��

Do not obstruct water heater air intake.

Gas and carbon monoxide detectorsare available.

Install water heater in accordance withthe instruction manual.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Breathing Hazard - Carbon Monoxide Gas

NOTE:� *� ��� ���:�� ���� ������� ������� ���� J������ ������������� ��� *������ 6���� �������������� >���� ���� ������� ��������� ��� ���������� ���� ������� ����� �� ������� ��<� :���� ����<��� ��<���������������� ����:�����<�������������������<�������< �����

INTAKE AIR CONNECTION DETAIL

4” x 3” REDUCERCOUPLING - FACTORY INSTALLED

BALANCE PLATE(remove for Direct Vent)

(reinstall on the Intake Air Termination of500,000 Btu/hr natural gas models with

50 equivalent feet or less of intake air pipe)

INTAKE AIR SCREEN(remove for Direct Vent)

Figure 17

Page 25: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

25

10. J����������������������������������������)��:�������<������=�?�������������������������������������������������� �������������V�����&��������������������������������������� ������������������������������ ����������������������������<������� <��� ��� �� �}�����:�� ��� ������������ �}������������� ���������������� ����<��� ������� �������=���<?"�����V�����&��

INTAKE AIR AND/OR VENTTERMINATION(S) MUST BE A MINIMUM OF 24 INCES (60 cm) ABOVE ANY PARAPET, VERTICALWALL OR STRUCTURE WITHIN10 FEET (3 m) HORIZONTALLY.

VERTICAL TERMINATION(S) FLAT ROOF CLEARANCEINTAKE AIR AND/OR VENT (EXHAUST)

24 INCHES (60 cm)MINIMUM HEIGHT ABOVE

IF LESS THAN

10 FEET (3 m)

Figure 20

11. @������������6����J�������������������$���*������6����J�������������������$����<��������������������������������������� ���)�� :���� ������� ������� ���� ���<������=�?� ���� �����������������

VERTICAL TERMINATION - DIRECT VENTSTANDARD TERMINATIONS

24 INCHES (61 cm) MINIMUM48 INCHES (122 cm) IN COLDER CLIMATES

FACTORY SUPPLIEDSTANDARD TERMINATIONSPOINTED DOWNWARD

FIELDSUPPLIED90° ELBOW

VENT (EXHAUST)TERMINATION

INTAKE AIRTERMINATION

FIELD SUPPLIEDPLUMBINGROOF BOOTSOR FLASHINGS

MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATED SNOW LEVEL.

Figure 21

���������� :���������� ������ ���� ��� ���� �������������������<��� ����������������������������:����������<�������������������<���������������������������V������&������������������������������:�������<��������<��� ��������������������������������������<����������������������V������&�on page 25.�������������������:�������<��������<�����:����<���<<��������������_��=�&��<?�<��������������������������������V������&������������ J�����������<������������������������� �����������������������_���������=&����<?����� ��<� ����� �� ���� ������� ���� ���� :���� ���<��������<��� ����<���<<���&���������=$���<?"�&���������=_���<?���� !�����"� � :�� ���� �:������ �� �}������� ���� ��:��� �����������V�����&������V������&�����������

6. ����� ���� ������� ���� ���)�� :���� ������� ��<� <������������� �������� ����� ���<������ ��� ���� ��<�� ������� ���� :�������<�������� ���� �� ������ �������� ��� ����� ��}�<���� ��������)��������J�������������<���������������� ��������������������������}�<������������)������������ ��������� ������� ���� ������� :���� ���� ������� �������<�������� <��� �� �� <���<<� �� �_� ������� =�&� �<?� �����������V������&��J�����������<������������������������� �����������������������_���������=&����<?�

7. !�����������=&$��<?����<������������_�������������%������=&���<?����<��������������������������������������=�?������pass through the roof.NOTE:�]�����������������������������������������������through the roof.

8. (������ ���� ����=�?� ������ ������� �� ���� ����� �������������<������������������\�:������������<��������������������V�����&��

2” (5 cm)MAXIMUM FACTORY SUPPLIED

STANDARD TERMINATIONPOINTED DOWN TOWARDS

THE GROUND

VERTICAL TERMINATION(S) INSTALLATIONINTAKE AIR AND/OR VENT (EXHAUST)

FIELDSUPPLIED90° ELBOW

FIELDSUPPLIEDSTRAP/SUPPORT

FIELD SUPPLIEDPLUMBINGROOF BOOTOR FLASHING

MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL.

Figure 19

9. (����� �� ��� �� �� �\�:������ �������� :��� ���� ����� ������������� �����\�:�������������������=����V�����&�?���������������������������

Page 26: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

26

SIDEWALL TERMINATION INSTALLATION

1. *����<�������������������������<������=�?�2. J�� ����������� ���� :���� =�}����?� ������� ��� �� ����� 6����

���������� ������ �� ���������� ������ ����� ���� �}���������������������������\���<����� ��� ���� ���<������"��������� V����� _�� �� ����� $_"� ���� ����� <����������� �������������������������������� ������������������������<��� ��<����������

3. J�� ����������� ��� ���������������:����������� �����*������6�������������� ������ �� ���������� ������ ����� ���� �}���������������������������\���<���������������<�������"���������V�����_���������$�"��������:����������������������<����������� �����<������������������������������������������� ������������������������<��� ��<�����������

4. J�� ����������� ��� ��� ������� ���� ���� :���� ���<������� ��� ��*������ 6���� ���������� ������ �� ��������� ������ <��� ����<���<<����_� ������� =�&��<?����������"�<��������� :�������� ������� ����"� ������� ���� ������� ���� ���� :�������<�������"�����V��������NOTE:�J�����������<������������������������� �������������� ��� ������ _�� ������� =&��� �<?� ������� ���� ������� ���� ����:�������<����������������������������:��������������������<�����^���������� �������������������������������� ���������� ������ �� ����� :��� ��<� ����� ������ ������ �}�����:�������������������������<�����������������<<���������!���������������������

5. J�� ����������� ������������������:�������<�������������*������6���� ���������� ������ �� ��������� ���� ������� ���� ����:���� ���<�������� <��� �� ���������� ��� ���� ��<�� ���:�����<������������������������������^�����V��������

VENT (EXHAUST)TERMINATION

INTAKE AIRTERMINATION

INSTALL ONELEVATION

CENTERLINE

24 INCHES (61 cm) MINIMUM

48 INCHES (122 cm) IN COLDER CLIMATES

KEEP INTAKE AND VENTTERMINATION SCREENS

CLEAR OF DEBRIS

SIDEWALL TERMINATION - DIRECT VENTSTANDARD TERMINATIONS

Figure 22

6. ����� ���� ��������������)��:����������� ��<�<�����������������������������<���������������<�������������������������"����� :���� ���<�������� ���� �� ������ �������� ��� �������}�<���� ^� �� ������)�������� ���� ������� ���� ���<���������������� ��������������������������}�<����^���������)��������;��:��"�������������� ������������������:������������������� ���<��������<��� ����<���<<����_� ������� =�&��<?��J�����������<������������������������� �����������������������_���������=&����<?��(���V��������

7. !�����������=&$��<?����<������������_�������������%������=&���<?����<��������������������������������������=�?��������������������������NOTE:�]��������������������������������������������������������������

8. !�� �� ������=�?� �� ����� ����� ����������$��� ������� =���� �<?��������������=�_�&��<?����������������������������������������������(���V������$�NOTE:� 6���� ���<������� ¤� �}����� ������ �� ����� ����������������� ����������&_��V�� J���������<�����������:���� ��������}������������������������������������:��������������:�����}�������� �������������:�������������������������}������ ������� ��������� ���� :���� ���<������� ����� ��������� ������ ����� :���� ���� ���� ��������� �����������������������������'}�������������}�����:�����������������<�}�<<�������������=&�����<?����<����������������:������<� ����� �������� ����� �� ��������� ������ �� �:��� ������� ��<"�����:������������ �����<�������:����������������������"�����6�����������<�������J�������������������_�

9. !�<����������������������)��:�������<�������������������=�?���������������������������� :��(����

10. (�����������������<���������������=�?�:�����������=�?��������������� ���� ������� ���� ���)�� :���� ���<�������� ������ �<���������� �������� =����� �������?� �� ���� ���� �� ���� ����������=�?�����������������������

11. ������� ��<� �����"� ������ ���� ����� ���� ���<������=�?�����< ������������ :������������������������'������������<������=�?� ��� ������� ���� ������� ���� ������ (���V������$�

INTERIOR WALL EXTERIOR WALL

FROMWATERHEATER

COUPLING

SIDEWALL TERMINATION INSTALLATION INTAKE AIR AND/OR VENT (EXHAUST)

METAL PLATESINSTALL INSIDEAND/OR OUTSIDE

FACTORY SUPPLIEDSTANDARD TERMINATIONPOINTED DOWN TOWARDS THE GROUND

INCREASE EXPOSED VENTPIPING UP TO A MAXIMUMOF 6 INCHES (15.2 cm) FROM WALL TO HELP PREVENT VAPORFROM DISCOLORING THE WALLSURFACE IN COLDER CLIMATES

Figure 23

12. �������� ����������������������=������������?�������������� �������������������������=�?���������������������������������������� ���������������=�?����������

13. ������������������������������������������������14. ������� ��<� ���� ������������������������������������

���� ������ ���� ������������������=�?� ������ ��� ����������������������������������:���������������������=�?�

15. J������������������������������������=�?������������ ��������]����� ���� �������� �������� ���� ��<�� �� �<�������� ���� �������� ���� ������� ���� ������ ���� ���<������=�?� ��� �����������������������������������(���V������$�

16. @������������6����J�������������������$���*������6����J�������������������$����<��������������������������������������� ���)�� :���� ������� ������� ���� ���<������=�?� ���� �����������������

Page 27: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

27

���<��������K�������(�������_���6!����}�����������������������������<������������ ���������� ���� ������� �� ���� ���<������� ���������<������ ���� ��� ���� ������� =������� ���?� ����� ������ !�� ������<���<��������������������<������=:���?������

10. *��������������������<������=�?���� �������������������_�J����!������������<�������J��������������������������J����!������������<�������J���������������������

CONCENTRIC TERMINATION(S)MUST BE A MINIMUM OF 10 FEET(3 m) AWAY FROM ANY PARAPET,VERTICAL WALL OR STRUCTURE.

4 INCH CONCENTRIC TERMINATIONFLAT ROOF CLEARANCE

Figure 24

6 INCH CONCENTRIC TERMINATIONFLAT ROOF CLEARANCE

CONCENTRIC TERMINATION(S)MUST BE A MINIMUM OF 10 FEET(3 m) AWAY FROM ANY PARAPET,VERTICAL WALL ORSTRUCTURE.

Figure 25

CONCENTRIC TERMINATION INSTALLATION

1. *����<�����������������������<������������ �������������]�;�$���<��������������������_������:���)�������������������������_�������������������<��������]�;�$���<���������������������������:���)���������������������������������������������<��������]�;�_�����������<�����<��������������������������� ���<������� �� ���� ������������"� ���� 6�������Requirements on page 22

2. *����<�������������������������<�������NOTE:�@�����<�������������������������������������������� �������<���"���������������������������������<�����������vent vapors are less visible.

3. �������������������������������<�������:����������������������������������������}������:��������������������\���<�������� �������������� ���<������"���������V������%���������������V�����$�����������"����� �����<������������������������������������������� ������������������������<��� ��<����������

4. �������������������������������<�������:������������������������"��������<���������:��������<��� ����<���<<���&�������=$�<?��������<������������"�:����������������������������������V������_�����V���������NOTE:�J���������\�������������������������"�:����������������������������� ��<���������"�������������<��������<��� �������(���6�����������<�������J�������������������_

5. �������������������������������<������������������������������� ����������}���������������������������\���<����� ������� ���<������"������ ���V�����_���������$�"����� �����<������������������������������������������� ������������������������<��� ��<����������

6. ����� ����������� <������� ���������� ���<�������� :���������������������������������������������������������������\���������������� ����������<����������������������<����������<������������<�����������(���������$������$&����more information.

7. !�� �� �� ����� =&$� �<?� ���<����� ���� ��� _� ����� �������������<�������� � �� %� ����� =&�� �<?� ���<����� ���� ��� �� ������������������<��������������������������������������������or roof.NOTE:�]�������������������������������������������������������������������

8. ����� ����������� <������� ���������� ���<�������� :���������������� ���� ��� ��� ������<�� ������� ���� ���<��������������� ���� ���������� ���<�������� <��� �� ��� ���� ��<�� �������<���������<�������(���C�������!������������<�������Arrangements on page 31.

9. *����<���� ��� ���� ���������� ���<������� ����� ����� �� ����������� �� ����������� �� ���<<����� ��\������������������������������:����������������������<�������������� ����������� <������� ���<�������� :���������� ������ ����������������<���������(���V����������������������V�������������������������<�}�<<�����<���<<�����������������������_������������������������������<������������� �}�������� ���� ������� �� �� ���������� ���<�������DO NOT� ��� ��������� ���� ��� �� �������� ����� ������������ ������ ���� ���<������� ���� <��� ����� �<�������< �������������<������������������������:����������<��� ���������������� ���������������� ������<�������<��������������}����������������������������<�������K��� ���� (*@^��� ����� �� �}����� ���� _� ����� ����������

Page 28: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

28

4 INCH CONCENTRIC TERMINATION INSTALLATION

4 INCH CONCENTRIC TERMINATION KITFOUR PIECE KIT - FIELD ASSEMBLY REQUIRED

VENT PIPE

INTAKE AIR CONNECTION3 INCH PVC

VENT CONNECTION - 3 INCH PVC

INTAKE AIR PIPEY FITTING ASSEMBLY

VENT CAPVENT PIPE ASSEMBLY

VENT PIPE IS 2 1/2 INCH SDR-26 PIPESUPPLIED LENGTH 37 INCHES (94 cm)MAXIMUM ALLOWABLE LENGTH 73 INCHES (185 cm)MINIMUM ALLOWABLE LENGTH 25 INCHES (64 cm)

INTAKE AIR PIPE IS 4 INCH SDR-26 PIPESUPPLIED LENGTH 24 INCHES (60 cm)MAXIMUM ALLOWABLE LENGTH 60 INCHES (152 cm)MINIMUM ALLOWABLE LENGTH 12 INCHES (30 cm)

VENT CAP

INTAKE AIR PIPE

3” x 3” x 4”Y FITTING

Figure 26

����< �������������������_�������������������<��������@�������V�������"�V������%�����V����������������������������1. !�<��������B������������������������<���������������������2. (�����������������������������B������������< �����<������������

������� ������ ����������� ��� ���� ���<������� ��� �������������������'������� �������<���������������� ������������<��������������������< ���

3. (��������������������B������������< ���������������������metal strapping or equivalent support materials.

4. >�� ������������� ���������� ������ ���� ��� ������ �� ���������������< ���� ���������������:������������������B������������< �������������������������

5. (���������������< ���� ���������������6. !�<��������:���������������:����������������������������^

������������������������������<��� ���������������������<������� �������������������������< ��� ����������� ������������������������<��� ����������������������������:������<���)���������������:�����������)��:���������

7. J�����������:�������):�������������< ����������������������B������������< ��"�'������<�������<�����:��������������<���������� ��<����������B��������

8. !�������������������������:�������������<������������������������_�������������������<�������������������������_��}�$���������������������������

9. @�������*������6����J�������������������$����<���������������������� �� ���� ������� ���� ���� :���� ������� ������� �����������������<����������������������������

NOTE: SECURING STRAP MUST BE FIELD INSTALLED TO PREVENT MOVEMENT OF TERMINATION KIT

MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL. MAXIMUM OF24” (60 cm) ABOVE ROOF.

ROOF FLASHING(field supplied)

STRAP(field supplied)

VENTPIPE

INTAKEAIR PIPE

COMBUSTIONAIR

VENT

4 INCH CONCENTRIC TERMINATIONVERTICAL INSTALLATION

Figure 27

NOTE: SECURING STRAP MUST BEFIELD INSTALLED TO PREVENTMOVEMENT OF TERMINATION KITIN SIDEWALL.

STRAP(field supplied)

VENTPIPE

INTAKEAIR PIPE

COMBUSTIONAIR

VENT

1 INCHMAXIMUM

4 INCH CONCENTRIC TERMINATIONSIDEWALL INSTALLATION

Figure 28

Page 29: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

29

11. ��������:�������):�������������< ��� ���� ���� �����������B������������< ������������:�������������������������������������<����� �����������������'���������:��������� �����<�������� ���� �� ���^���� ������� ������ ���:����� ���������� �������B���������(���������:�������������������������������������������� ���������� ������ �������� J������� ���� ������� �������������^��������������������:�������� ���������������������������������<��� ���������� ��� ���� ���������������� �����:������<���)���������

NOTE: SECURING STRAP MUST BE FIELD INSTALLED TO PREVENT MOVEMENT OF TERMINATION KIT

MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL. MAXIMUM OF24” (60 cm) ABOVE ROOF.

ROOF FLASHING(field supplied)

STRAP(field supplied)

VENTPIPE

INTAKEAIR PIPE

COMBUSTIONAIR

VENT

6 INCH CONCENTRIC TERMINATIONVERTICAL INSTALLATION

Figure 30

NOTE: SECURING STRAP MUST BEFIELD INSTALLED TO PREVENTMOVEMENT OF TERMINATION KITIN SIDEWALL.

STRAP(field supplied)VENT

PIPE

INTAKEAIR PIPE

COMBUSTIONAIR

VENT

1 INCHMAXIMUM

6 INCH CONCENTRIC TERMINATIONSIDEWALL INSTALLATION

Figure 31

12. !�������������������������:�������������<��������������������������������������������<��������K����������������_�������������������}�_���������������������������

13. @�������*������6����J�������������������$����<���������������������� �� ���� ������� ���� ���� :���� ������� ������� �����������������<����������������������������

6 INCH CONCENTRIC TERMINATION INSTALLATION

6 INCH CONCENTRIC TERMINATION KITSEVEN PIECE KIT - FIELD ASSEMBLY REQUIRED

VENT PIPE

VENT PIPE IS 4 INCH SCHEDULE 40 PVCSUPPLIED LENGTH 46 1/2 INCHES (118 cm)MAXIMUM ALLOWABLE LENGTH 66 1/2 INCHES (169 cm)MINIMUM ALLOWABLE LENGTH 33 1/8 INCHES (84 cm)

INTAKE AIR PIPE IS 6 INCH SCHEDULE 40 PVCSUPPLIED LENGTH 25 3/8 INCHES (64 cm)MAXIMUM ALLOWABLE LENGTH 45 3/8 INCHES (115 cm)MINIMUM ALLOWABLE LENGTH 12 INCHES (30 cm)

VENT CAPSTAINLESS STEEL

VENT TERMINALWITH SCREEN

INTAKE AIR PIPEINTAKE AIR CONNECTION6” or 4” PVC

VENTCONNECTION4” PVC

6” x 4” STANDARDREDUCER BUSHING

6” x 6” x 6”Y FITTING

6” x 4” NO STOP-LIPREDUCER BUSHING

INTAKE AIR PIPEY FITTING ASSEMBLY

VENT CAPVENT PIPE ASSEMBLY

Figure 29

����< ���������������������������������������<��������@�������V�������"�V�����$������V�����$&���������������������1. !�<��������B������������������������<���������������������2. !�<���� ���� ��� }� _�� �� ���^���� ������� ������ ���� ����

���������=:���?�����������B��������3. J������������������������ ������������������_����������"���<����

�������}�_������������������ ������ ���� ����������=����������?�����������B�������������������V��������

4. J������������������������ ���������������������������������������������}�_������������������ ������������� ������������������������������������������������������������������B��������

5. (��������������������B������������< �����<������������ ����������������������������������<�����������������������������'������� �������<���������������� ������������<��������������������< ���

6. (��������������������B������������< ���������������������metal strapping or equivalent support materials.

7. >�� ������������� ���������� ������ ���� ��� ������ �� ���������������< ���� ���������������:������������������B������������< �������������������������

8. (���������������< ���� ���������������9. (���������������:���������������_������:���������������<����

����:�������<���������������������:���������10. (���������:�������� ����������:���������������������������

:�������<������(���������:��������������:������������������������������������������� ������������� �����<��� �����������������������������:������<���)���������������:������������������������������������������ �����������:������������the terminal.

Page 30: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

30

Four Concentric Terminations1. ��������������������������������<���������������������

���������������������������}�<���������<��� �������������������������������������������V�����$_�������������������������������V�����$��

2. V���������<�}�<<��< ������������������<�������������<��� �� ���������� ��� �� ���� ������ ���� ���<�������� ���� ����������}�<���������������V�����$_�

A

A

A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY

CONCENTRICTERMINATION

CAPS END VIEW

FOUR CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

V�����$_

A B A

FOUR CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY

B = 24 INCHES (61 cm)OR GREATER

CONCENTRICTERMINATION

CAPS END VIEW

V�����$�Groups Of Terminations1. ����� ����������� <������� ����� �� ���������� ���<��������

������������������������������ ����������}�<������������� �� ���������� ���� �������� ����� �� ��� ��� ����� ���V�����$���+����������������������������V�����$��<��� ����<�����:������� �������������������<���� ���<�������������������������:���� ���������

A

A B

A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY

CONCENTRICTERMINATION

CAPS END VIEW

EIGHT CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

B = 24 INCHES (61 cm)OR GREATER BETWEEN

GROUPS OF FOUR

V�����$�

MULTIPLE CONCENTRIC TERMINATION CLEARANCES ����������������<��������������������<��������:������������������ ��� �� ����������� ������ �� ��������� ������ ���� ��\���������������� =���������?� ������� ���<�������� ���� <�����������'����� <������� ���<�������� ���� ��������� �� ������ �����\�����NOTE:� ������ ����������� <��� �� <���������� �� ���:���� ������������������:����=�}����?�������������������������!��������������<������� ������������������������������������<����������������� �����������<����������������� ���<�������� �������� ����� ����������������� �������������������� ���V�����$��<��� ��<�����������(���C�������!������������<��������������<������������$&�Close Proximity & Standard Clearance1. �������������� �������<����������<������������<��� ����

�������=������?�����<�}�<<������������=���<?"���<��������̂ �V�����$�"������������������������������<������������������}�<�����(���V�����$%��������$&�

2. ���� ���������� ������� <������� ���<������� ����� <��� ����������������<���<<����_��������=�&��<?"���<������]�^�V�����$�"����������������������������}�<����=� :�?����������� �����������������������������������

A

OR

B

A = 0 - 2 INCHES (0 - 5 cm)

CONCENTRICTERMINATION CAPS

END VIEW

TWO CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

B = 24 INCHES (61 cm)OR GREATER

CLOSE PROXIMITY STANDARD CLEARANCE

Figure 32

Three Concentric Terminations1. �����������������������������������<�������������������

������������������� �������������<�������<��� ����������������������}�<����������������� ����<�����������V�����$$��

2. J�� ����� ��}�<���� ������������ �� ���� ������ ���<������� ��� ������� ��� �������������<�������<��� �� ������������� ���������� ����<������]����V�����$$�

A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY

CONCENTRICTERMINATION

CAPS END VIEW

THIRDTERMINATION

THREE CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

A

A B

B = 24 INCHES (61 cm)OR GREATER

V�����$$

Page 31: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

31

Four Concentric TerminationsV���������������<��������<��� ����������������������}�<���������������V�����$���(���V�����$_�����V�����$���������$�������������� ����<���������������������������������������<����options.

SIDEWALL

ROOF

Figure 38

Eight Concentric Terminations'����� ���������� ���<�������� <��� �� ���������� ��� ��� ��������������� ��"� ��� �������}�<���"��������� ���V�����$���(���V�����$���������$������������������<�������������������+����������������������������V�����$���������$��<��� ����<�����:������� �������������������<�������<�������������������������:���� ���������

SIDEWALL

ROOF

Figure 39

MULTIPLE CONCENTRIC TERMINATION ARRANGEMENTS���� ������������ �� ����� ����� ���� �<�� �� ���� �������������������<����� ��� <������� ���������� ���<�������� ����� �����������(���C�������!������������<�������!�����������������$�������������� ����<���������������������������������������<����options.NOTE:� ����� <������� ���������� ���<�������� ���� ������������������������������<����������������<������������<��� �����������<���������<���������<�����������Two Concentric Terminations����������������<��������<��� ����������������������}�<������� ����� ��� V����� $%� �� ����� ��������� ����������� ����� ������������<�������������� ����(���V�����$���������$������������������<����� �� ������������ (��� V����� $$� �� ����� $�� �����������������������������������<��������

SIDEWALL

ROOF

Figure 37

Page 32: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

32

VENTING ARRANGEMENTS

Power Vent VerticalFigure 40

Direct Vent VerticalFigure 42

Power Vent HorizontalFigure 41

Direct Vent HorizontalFigure 43

Page 33: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

33

VENTING ARRANGEMENTS

Direct Vent Vertical Vent Horizontal IntakeFigure 44

Direct Vent Vertical ConcentricFigure 46

Direct Vent Horizontal Vent Vertical IntakeFigure 45

Direct Vent Horizontal ConcentricFigure 47

Page 34: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

34

TERMINATION CLEARANCES SIDEWALL POWER VENT

V XVENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED

v

v

A

GV

FIXEDCLOSED

FIXEDCLOSED

OPERABLE

OPERABLEV

C B B

BBF

B

V

V

A J

V

H

MX

XV

VK

B

E

D

L

POWER VENT(using room air for combustion)

EXTERIOR CLEARANCES FOR SIDEWALL VENT TERMINATION

Figure 48

������������ ������ �������������������������������������������� ��������������������������� ��������

CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2 CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2

A!���������� :�������"�:������"�����"�������� �����

&���������=$���<? &���������=$���<? H!������������������������������������}�������above meter/regulator assembly

$������=�&��<?�����������������&�������=_���<?�� :������<����) regulator assembly

$������=�&��<?�����������������&�������=_���<?�above the meter/regulator assembly*

B!���������������������������<��� �������

���������=&���<?�������������������&�"����]�)���=$���?"�&���������=$���<?��������������� �������&�"����]�)���=$���?�����&��"����]�)���=$����?"�$���������=�&��<?���������������� :��&��"����]�)���=$����?

_������=&���<?� �����������������������&����=$���<?�� :��opening

I!��������������:����regulator vent outlet

$������=�&��<? $������=�&��<?�

C!��������������<�������������������

&���������=$���<?� &���������=$���<?� J!����������������<������������������������������ ����������< �����������������������������������

���������=&���<?�������������������&�"����]�)���=$���?"�&���������=$���<?��������������� �������&�"����]�)���=$���?�����&��"����]�)���=$���?"�$���������=�&�<?���������������� :��&��"����]�)���=$����?

_������=&���<?� �����������������������&���� =$���<?�� :���������

D

6��������������������:����������������������above the terminal ������������������������������������=�&��<?���<�����������������of the terminal

&���������=$���<?� &���������=$���<?� K!�������������<��������������������inlet

�������=&��$�<?

$������=�&��<?�� :������������&�������=$�<?�����������

E !������������:�������������� &���������=$���<?� &���������=$���<?� L

!���������� :����:����������������:������:��������������� �����������

%������=��&$�<?� %�������=��&$�<?

F !���������������������� �������=����<?� �������=����<?� M

!��������������:������"�����"�����"��� �����

&���������=$���<?�� &���������=$���<?��

G !����������������������� &���������=_���<?� &���������=_���<?�

&�J����������������������������!(��]&_��&"�#������W��������������J�����������!���

��J�����������������������������#(J����$�&)#V����_"�#�������V���W���!���

����:����������������<���������������� :�����������������:������:�������������������� �������������������<���������������������:��� �������������

�����<�������������:������"�����"�����"��� ����������������������<���<<������������ ��������������

��!�����������������������������������������������������������\���<�������������������������������<�����������������������������������

Page 35: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

35

TERMINATION CLEARANCES SIDEWALL DIRECT VENT

V XVENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED

v

v

A

GV

FIXEDCLOSED

FIXEDCLOSED

OPERABLE

OPERABLEV

C B B

BBF

B

V

V

A J

V

H

MX

XV

VK

B

E

D

L

DIRECT VENT(using outdoor air for combustion)

EXTERIOR CLEARANCES FOR SIDEWALL VENT TERMINATION

Figure 49

������������ ������ ����������� ������������������������ ������� ������������������������������� ��������

CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2 CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2

A!���������� :�������"�:������"�����"�������� �����

&���������=$���<? &���������=$���<? H!������������������������������������}�������above meter/regulator assembly

$������=�&��<?�����������������&�������=_���<?�� :������<����) regulator assembly

$������=�&��<?�����������������&�������=_���<?�� :������meter/regulator assembly*

B !���������������������������<��� �������

���������=&���<?�������������������&�"����]�)���=$���?"�&���������=$���<?��������������� �������&�"����]�)���=$���?�����&��"����]�)���=$����?"�$���������=�&��<?���������������� :��&��"����]�)���=$����?

���������=&���<?�������������������&�"����]�)���=$���?"����������=�$��<?��������������� �������&�"����]�)���=$���?�������"����]�)���=&����?"�&���������=$���<?���������������� :����"����]�)���=&����?

I !��������������:����regulator vent outlet $������=�&��<? $������=�&��<?�

C!��������������<�������������������

���������=&���<?� ���������=&���<?� J!����������������<������������������������������ ����������< �����������������������������������

���������=&���<?�������������������&�"����]�)���=$���?"�&��������� =$���<?��������������� �������&�"����]�)���=$���?�����&��"����]�)���=$����?"�$���������=�&��<?� ��������������� :��&��"����]�)���=$����?

���������=&���<?�������������������&�"����]�)���=$���?"����������=�$��<?��������������� �������&�"����]�)���=$���?�������"����]�)���=&����?"�&���������=$���<?���������������� :����"����]�)���=&����?

D

6��������������������:����������������������� :���������<�����������������������������������������=�&��<?���<��������������������������<����

&���������=$���<?� &���������=$���<?� K!�������������<��������������������inlet

�������=&��$�<? $������=�&��<?�� :������������&�������=$�<?�����������

E !������������:�������������� &���������=$���<?� &���������=$���<?� L

!���������� :����:����������������:������:��������������� �����������

%������=��&$�<?� %������=��&$�<?��

F !���������������������� �������=����<?� �������=����<?� M

!��������������:������"�����"�����"��� �����

&���������=$���<?�� &���������=$���<?���

G !����������������������� &���������=_���<?� &���������=_���<?�

&�J����������������������������!(��]&_��&"�#������W��������������J�����������!���

��J�����������������������������#(J����$�&)#V����_"�#�������V���W���!���

����:����������������<���������������� :�����������������:������:�������������������� �������������������<���������������������:��� �������������

�����<�������������:������"�����"�����"��� ����������������������<���<<������������ ��������������

��!�����������������������������������������������������������\���<�������������������������������<�����������������������������������

Page 36: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

36

�����&)��������6!���������3. DO NOT���<:�"�<���������������������������������������INSTALLATION INSTRUCTIONS1. '�������������������������)��������������������������������2. J������� �� &)�� ����� �6!� ���������� ������ ����� ������� ����

�������������������������������!���������*�������������������� ��� ������������"�����V������������V������&�

3. ���<������������������������������������������� ��� :�������������'������������������������������}������������������������������<�����������������=&�����<?�� :�������� ��� ������������"����}������������� ������"�����V��������NOTE:� J���������<����� ��� ��� ���<<�������������������������� �����<���������������� �������������������� �������

4. '���������������������������������������:������ :�����������������������������������������"�����V������&�

5. ]��������������������������������������<��������������every three feet.

6. '����� ���� ���������� ������� ������� ������ ������ �"� ����Start Up on page 50.

WATER HEATER INSTALLATIONCONDENSATE DRAIN INSTALLATION

J����������� <��� ����<� ����� ������ ����������� ���� ����� ������������V�������������<�����������\���������������������������

�� ����:����6!���<���������6!����<����� &)��������6!������^�<���<<�����������\�����������������

���������������������������������� ��� ��������������� &)��������6!���������=�� ��������������?�������������

������������������������������� �����������!���������*��������������< ������������� ��� �������������

�� V���<���������������� ��������������������INSTALLATION NOTES1. ��������������������� ��<���������������������:����� ��

����� ������������:���;���:���� �������_�$���������� J����������<<����������:���� ������������������� �����\����� �������������+�����;���:����������������*�������������<��������������� ������ ����"� ���� ��� ������ ����"� �� ���� ������heater for this reason.

2. ���� ����� ���������� ���������� ������ ����� <��� ��� �� �����

CONDENSATE DRAINLINE - FIELD INSTALLED

DRAIN LINE TOTERMINATE NOMORE THAN 6INCHES (15.2 cm)ABOVE DRAIN

BUILDINGDRAIN

FACTORY INSTALLEDCONDENSATE TRAP

CLEANOUT PLUG SHOULDFACE TOWARDS THE FRONTOF THE WATER HEATER FORSERVICE ACCESS

EXHAUST (VENT)ELBOW

CONDENSATE TRAP DETAIL

PVC PIPE PLUG1 ¼” NPT

CLEANOUT PIPEPLUG SHOULDBE ORIENTED TOTHE FRONT OF THEWATER HEATER FORSERVICE ACCESS

PVC BUSHING1 ½” SLIP x 1 ¼” NPT

PVC BUSHING1 ½” SLIP x ½” SLIP

PVC TEE FITTING1 ½” SLIP x 1 ½” SLIP x ½” NPT

PVC PIPE NIPPLE½” NPT

½” PVC 90° ELBOWCONDENSATE DRAINCONNECTION. FIELDINSTALLED DRAINLINE CONNECTS HERE

½” PVC 90° STREET ELBOW

½” PVC PIPE NIPPLE

Figure 50

Figure 51

Page 37: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

37

SUPPLY GAS LINE INSTALLATION

!��������������������������<���������������������\�������� ���:���� ��� �:���� ��� ���� �� ��:���� ������� ��� ����������������������������]�������������������<������������������������������������������������������������������������������������������\���<������� ���� ����� ���� ����� �\��<���� �������� �� ���� <������ J�� ��������<�����������������"����������<������������:��������������������������������<�����

Fire and Explosion Hazard

Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.

Excessive gas pressure to gas valve cancause serious injury or death.

Do not use water heater with any gasother than the gas shown on the ratinglabel.

C�������������������������<�����������������������������������rating label.�������������������:����� ��� �����<������������ ��������� ��������������������������&��������!��=��_�����?������������������� &����� ��� !�� =����� ���?� ��� ������� ���� ������ �������"������� ���_��������&$���������������������:�������������<�������\���� ������ ���� ��������� �� <�������� ��\����� ������ ������������� '}����� �� ������� ���� ������ �������� <��� �������<�����������������������������������������������}�������J��:�����������������������������������<����������������������������<��������������������������<������������������������ :��:�� <��� �� �������� ��� ����� �������� �� �� `�������(��:������������'�������������������:�������������������������:����:��:������������������������ �������������������<��������� �������������������<"���� ������������������6���� �������<��������������������<��J�� ��� �<������� �� ����� �������� ���� :��:�� ������ ��<�����<������������������������(���������<���������<�������������"��������}�������J���������������������������������<��� �������������������������������������������:����

REGULATED GASSUPPLY LINE

MAIN GASSHUTOFF VALVE

TEE FITTING

PIPE CAP

SEDIMENT TRAP(DIRT LEG)

Figure 52

'���������������������������������������� �������������������������������������������<������������������������������������<���������=��������?�<��� �����������������������V�����������������<��������� <��� �� �������� ������� ��� ���� ��� � X���� �� ������������������� J������� ��� ���������� ����� ���� ���<<��������� �����������������������<�����

GAS LINE SIZINGDO NOT������}� ���������������C���<<���\���������������������������������������� ������������&$��*�����������������:�������\�:����������������)�������< ������������������������������<<��<���"����������������������������<�����:���� ������������(���� ���������)<�������� ����=�?� �������������������� ��������� ����������:��������:�������� ����������� ����������������������������������������������¦����!��=&�����?������������"����������������������<����������������������<���#������������������������� ��������������������������������������������SUPPLY GAS LINE SIZING U. S. UNITSTABLE 8

LENGTHIN

V''�

#>@C�+��J@>#��J�'�(J�'(�=J#!;'(?INPUT IN THOUSANDS BTU/HR

&�&)_� &�&)�� �� ��&)�� $� _�10 1400 2100 3960 6300 11000 2300020 950 1460 2750 4360 7700 1580030 770 1180 2200 3520 6250 1280040 660 990 1900 3000 5300 1090050 580 900 1680 2650 4750 970060 530 810 1520 2400 4300 880070 490 750 1400 2250 3900 810080 460 690 1300 2050 3700 750090 430 650 1220 1950 3450 7200100 400 620 1150 1850 3250 6700125 360 550 1020 1650 2950 6000150 325 500 950 1500 2650 5500175 300 460 850 1370 2450 5000200 N/A 430 800 1280 2280 4600

SUPPLY GAS LINE SIZING METRIC UNITSTABLE 9LENGTH

INMETERS

#>@C�+��J@>#��J�'�(J�'(�=J#!;'(?INPUT IN kW

&�&)_� &�&)�� �� ��&)�� $� _�3.0 410 615 1160 1845 3221 67356.1 278 428 805 1277 2255 46269.1 225 346 644 1031 1830 374812.2 193 290 556 878 1552 319215.2 170 264 492 776 1391 284018.3 155 237 445 703 1259 257721.3 143 220 410 659 1142 237224.4 135 202 381 600 1083 219627.4 126 190 357 571 1010 210830.5 117 182 337 542 952 196238.1 105 161 299 483 864 175745.7 95 146 278 439 776 161053.3 88 135 249 401 717 146461.0 N/A 126 234 375 688 1347

Page 38: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

38

GAS LINE CONNECTION1. �������������������:����� �������<�������������������<�

���� ��������������&�&)_�� ������������������"� ������ ���&��������&���(���������������������������������������������������������������������������������������������������_�6�!�W���6��:�������"�����V������$��!�����������������������������������������������_�6�!�W���6��:������������������������������� ��������������������������\���<������DO NOT������}� ���������������

2. ]�;����������������<����� =(������&��?� ��\������&�&)���<���<<�����������������������������������������:����� �������<�������\������&�&)_��<���<<����������� ������(���Table 5 on page 13.J����������������������&�&)���}�&�&)_��������������������&� &)_¦� ����� ������� �� ���<<����� ���� <���<<� ��\�����&�&)��� ���������� ������������� ���V������$���]�;����������������<�����=(������&��?�(���������������� ������������������������:�������������������Series number.

FACTORY INSTALLED1 1/4” x 1” REDUCERCOUPLING AND NIPPLE

SUPPLY GASCONNECTION

SUPPLY GAS LINE CONNECTION(500,000 BTU/HR MODEL SHOWN)

FIELD SUPPLIED 1 1/2” x 1 1/4”REDUCER COUPLING AND 1 1/4”PIPE NIPPLE INSTALLED ON 500,000 BTU/HR NATURALGAS MODELS

LOW GASPRESSURESWITCH

24 VACGAS VALVE

TO MAINBURNER

FLOW

Figure 53

3. ������ ������� �������� �<����� =����� ���)� ����� ����?�������������������������<�����������������������X������*�������������������<���������������������������K������������������������<��������� �������������������������������\���������<�=+�)������?�������

4. K����������<���X�����X��� ����������=���������<�����������?������ ������������ ����������_�6�!�W���6��:����������������������������������������������� ���������:��:���DO NOT���������������������������=(�������������?������<���������X������������<������<����������<��������:��:��

5. K��� �� ��������� ����� ������� =(������� ������?� ��� �� ���������������������������������������� :��������������������������������������� ��� �������������� ����� �����:���� �����_�6�!�W���6��:�����������������������<����������������installation.

6. �� ���:���� ��<���"� ����� <��� �� ������ ��� �� ������ ��<��� ��\�� ����� ���������� ���� ������ ���� ����� �� ������������������

7. J������� �� ����<���� ����� =����� ���?� ��� ����� ���V����������page 37.

8. Install a Main Gas Shutoff valve in the supply gas line as ��������V���������������$%�

NOTE:�(����:����������������������������������� ��������"������������C����W���(�����:��:���������������������

GAS LINE LEAK TESTING

Fire and Explosion Hazard

Leak test before placing thewater heater in operation.Disconnect gas piping and maingas shutoff valve before leaktesting.Install sediment trap inaccordance with NFPA 54.

Use joint compound or Teflon tapecompatible with propane gas.

������<����������������������������������<������<����������������:����������� ���������������}������1. V�����������������}��������&)������=$�_�����?�����������

�������������������������C����W���(�����6��:����<���������������������������<��������������"�����V���������������$%���������������������<��� ����������������������������<������������������

2. V������������������&)������=$�_�����?�������"�������������������� ��� �� �����������"� �� <��� �� �������� ��<� ������������������� �������������C����W���(�����6��:��������testing.

3. �������������������������X�������������������������<����������������������������������������������������������������������] �������������������������*�������<������"��������"���<����������������������������������������

4. @���������������� �����������������������������������������

SUPPLY GAS REGULATOR INSTALLATION

�������������������:����� ��� �����<�����<�����:�������������� �������� ���������� ��� �������������� �������������� �� ������������������(�������J�����������@�\���<������������&$�1. �������������������������� ���������������������������������

��<����������������������������������2. (��������� ���������<��� �� ������������ :�� ���� �����

]�)�����������������������������������������3. (��������������������������:���������������������������

�����������������<���<<����������������������������������heater they supply. See Table 5 on page 13.The Maxitrol 325-7L supply gas regulator or equivalent is ���<<������

4. (����� ���� �������=�?� ������ �� ���������� �� ������ ����� $������=&�<����?��������������������&�������=$�<�����?���<�������������������������������������������

Page 39: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

39

���������������:����������������<��������������Connecting An External Supervisory Control������� ��)���� ���������� ������������ ��<�����!!]���§�����������������!!]��������"�����V�����$����������������������!!]����������V�<����������������������������= ����?�X<������������������� ������������������&&�������§�����"�����V������&���������$�������������§������J���������������������������� ��)���� ����������1. ���� ��� ����� ��� ���� ������ ��������� �)��� ������� ���� ����

�����������������������������������������2. +���������!!]���������3. @�<:�� ���� ������� ��<� ���� !!]� �������� �:��� ����

�����������������!!]����������#���������������������������������������:����� ������������:����������������������������

4. ����:����������� ��)���� ���������������������(&�����������������!!]"�����V������&���������$���� ������(&��������������������������������� ������(&������������$������������������

5. +����� ���� ����� X<��������� �����������������&&�������!!]�§�����"�����V������&���������$�����V���������������64.

6. !������ �����X<����������������<������7. (���������}�<������&)��������������������<�������������

������ �����X<���������8. K��������������������� ���������������������������� ��

������������������ �����X<����������������������������������������������������������

9. �������������������������������!!]�������������������������������������������������������!!]����������:����'��������������������������������������������������:�����������������������'����������������� �������������

10. @�������������!!]����������:����������������������11. @������������������������������X������ }������������

����������������"�����V�����$����������������������X������ }��K�������:���� �������^�����������������������������X������ }�

12. J������� ����� ������������������������������� ��� ��\����� �� �������� ���� ����� ����� ������� ���� ������ ���������X������ }����� �����}������� ����:����� �������!�������������������<������}������������������������������������������X������ }�����������������������������������

13. !������ ���� ������ ������� �� �� ���� �� ���� �������� �� �����}��������������V��������������<�������������������������<����������������

14. @������������������������������NOTE:� �����:��� ���� �}������� ������ ����� ���� ���� �� ������������ ���"� �������� �������� ����� �� ���� ����� �����:��������}��������������������������������������������"����������������� ����� �� ��� ����� �� �������� ����� ���� ������� ��������:�����������<<��������������������������<��������������������������������������� �����(�������(�����J����������������in Table 11 on page 43.NOTE:� '����� ���� ������ ������� ��� ��������� ��<� �����������<��������� ����� �������� �������� ��� ���� ����� *�<���� ������������������������� �������������<����������������:����������������<��������������

ELECTRICAL WIRING

���� ����������� ���� <��� �� ���������� ��� ���������� ����� ����#������� '���������� !��"� �#(J)#V��� %�� �� ���� !��������'����������!��"�!(��!���&������������\���<�������������������"������������������<��� ���������������������������������������������������"��������� �����������������"����������#�������'����������!��"��#(J)#V���%��������!��������'����������!��"�!(��!���&�J����������������������������������������������������������<��� ����������"� ���<��� ����������������&���!���������������� �����\�:�����"��}������������ ������������J�������������������!������������<��� ������POWER SUPPLY CONNECTIONS@����������\���<�����������������(������������&$� ��������������������Correct Polarity:���� ������ ��������� ������ �����<� ��� �������� �������:�� ��������� �������������� ������������������� ��� �������������� ��������� ������ ��� ��:������� ���� ������ �����<� ����� �������� ������!� @�:������� V���� <������� �� ���� +!*������ &��� 6�!� ����������<����������������<���������������� �����������������X������ }���������&���6�!�������������<����������������������������������X������ }����������������������������������������<��� ��<��������������1. '����� ���� ����� ������ ��� ������ ��� ��� ���� ������� ��

�����������������2. @�<:������X������ }��:����(���V�����$�������������

X������ }���������3. !����������&���6�!�����������<����������������������

�����������������X������ }�����������������������������������������������������������������������������������������������������������(����������������<��V����������������_�����V������$�����������

4. !����������&���6�!���������������<����������������������������������������X������ }������������������������������������������������������(����������������<��V����������������_�����V������$�����������

5. !������ ���� ����� ����� ��<� ���� ����� ������ �� ������������ ��� ������� ���� X������ }��(����������������<��V����������������_�����V������$�����������

6. @������� ���� X������ }� �:��� ����� ���������� �����<������

NOTE:�*���������������������������������� ���������������������<�����������������������������������������������ENABLE/DISABLE CIRCUIT���� ������ �������� �:����� ��� ����� <����� ���� �\������ �������� ��� ��)���� ��� ������� ��� ��� ����� ����� �������� �}�����������:����� ������� ���� ��� ��<�� ������ �� ������� ]�������C�����<����(����<���������� ��)���� ����������<��� ������������ ����������������������������������������� ���������������������������������<������������������ ��� ���� ��� ��)���� ��� ������� ��� <��� ����� �� ����:����� ���������������(&��������������������������������!!]�=�������������� ���?"�����V������&���������$��V����������������������� ����� ���������� ������� �������������������!!]���������������������������=��:�����������?���������������������}��������������NOTE:����������������������� ��)���� ���������� ���������������������������*�����������}�������:������������������� ����=J'�� ������ ���?� �� ����� ������������������ ��<���� ����!!]��������

Page 40: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

40

T&P VALVE DISCHARGE PIPE

Explosion Hazard

Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.

Properly sized temperature-pressure relief valve must beinstalled in opening provided.

Can result in overheating andexcessive tank pressure.

Can cause serious injury or death.

����� ������ ������� ��� ��:����� ����� �� �������� �����)������ ��������������< ������� ��<�������� ^��������� =�/�?� �������:��:�� ������<�����������(�����<�������^��������@������6��:���������&���������<��������������<���������������\���<�����

Water Damage Hazard

Temperature-Pressure Relief Valve dischargepipe must terminate at adequate drain.

CAUTION

J������������������������ ������������/��:��:����������������������� �� ���� ��� ��� ������� *� ��� ������� ���������� ���������������� �� ��������������������� =&�����<?��������� �����:�����������:���� �������X��"��������������"�������������<���"������������ :��:�� <��� �� ������� �� ���������� ������ ��� ���\����\������������������<����������<�����J��������������������������������������������������������� ���<����"��������������<������������������<����T&P Valve Discharge Pipe Requirements:

�� Shall not be smaller in size than the outlet pipe size of the :��:�"�����:�����������������������������������������

�� (�������� ����������� �������� (�������� ���}������������������<����������� (����� ����<��������������������������������� ������ (����� �������������������������<����������������� ���

������<�������^��������@������6��:��������������������pipe.

�� C������<��������<�}�<<�����}��������� :����������������}������������� ��������J���������<����"����������<<������������������������������ �����<����������������\��������������������� �������

�� (����������:������:��:��������� �������� ������������������:��:����������������

WATER LINE CONNECTIONS

�����������������������������<�������<������������������������ ������ ����������������� ��������������:���� X�����������W�������������\�����������������:��������� ����������@���� ���� ���:�� ���� ��\���<����� ��� ���� �������� �������� ������������������������������������ ������1. Mixing Valves on page 14.2. *�����������C���������������&_�3. Temperature-Pressure Relief Valve on page 15.4. !�����(����<����������<���'}��������������&_�5. V�� <������� ������ ������� ������������� ���� ������ �������

Diagrams beginning on page 67.WATER PIPING DIAGRAMS�����<�������:���������������������������������<�������������<���������������������������������������"������������������Diagrams beginning 67.�����������������<��� �� ���������� �� ������"�������������������������� ������ ����� ���� ����� �� ��������� ������� ����"� ��������������<��� ��������� �����:������ ��<������� ������������<����������������������<��������"� ��� ��� �<����������������������������������� ������������������������ ����<���<<����� ��������������������������������������������X��� ��� �� ���������� �� ���� ���� ���� :��:�� ���������� ��� �������������������������������������������<���#�:������������������������������������<���(��������������������*�����<��beginning on page 67.NOTE:�J�����������������������������������<�������^��������@������ 6��:�� =�/�� :��:�?� �� ���� ������ ������"� ����� ��<��������������������<��� �������������������������������������������������� <��� ���� ��:�� ���� ��� �������� �����"� ������ ��������:�����<�������^��������@������6��:�������������!���� ���� ���� ����� ����������������������< ��� ��������� ���� �����:����������<���������������������������������������/��valve for remote storage tanks.THERMOMETERS (NOT SUPPLIED)����<<������ ���� ���������� ��� ���� ������ ������� �����<� ��� ��<����������������� ���� ��<���������� �������������������������������������������������<��V�����������������<<����������� �� ����������������������(����������������*�����<����������%�WATER (POTABLE) HEATING AND SPACE HEATING1. ������������������<�����������������������������������

�������������������������������������������� ������ ��� �������������� ���������

2. �}��� ���<�����"� ���� ��� ����� ���� ��� ����� �����<���"�<���#'6'@� �������������������������<�

3. ���� ������ �������� �:����� ��� ����� <����� <��� ��:��� ����������� �������}��������������������<����<�����=�?����:����������������^��� ���������������������������

4. ����� ���� �����<� ��\����� ������ ��� ������ �������� ������}����� ����� ��<��������� ��� �<������ ������ �}����� ��<�}����:��:��<��� �����������"�����C�}����6��:����������&_�

Page 41: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

41

(�����������>���������(�����������&���V�=_��!?��������������������� �� �������� (<�� (������ ��\���� ��������� ��� �������� �����temperatures.TABLE 10

Water Temperature ��<��������������/�$��*������]�����������(���

&���V�=���!? Nearly instantaneous&%��V�=%%�!? Nearly instantaneous&���V�=%&�!? � ��&)�������&���V�=���!? � ��&^&)��������&_��V�=���!? +�����������������&$��V�=�_�!? � ��$��������&���V�=_��!? More than 5 minutes

���� ������ �������� �:����� ��� ����� <����� ���� �\������ �����������������������������<��� �������� ���������� ��<�����������������������������������������������<����������<����������<� ��� ������� ���������� ��<���������� ��"���� ���������� ������� ����� ����������� ������������ ��������������� ���� ��<"�(���V�����$��������������V�����_������������������������ �>��������� (��� ������ ��� ��X����� �� �������� ��������<���������������������������������������������X��� ��������������� ��� ���������� �����<��� ���<���������C������������������ ������ �����<�<����������������� ������ ����KJC� =��������������<���?� ��������� ���� ������� ����������������"�����V������_�����>���������(�������������X��� �����<����V�=_��!?���&���V�=���!?������������������������&���V�=_��!?��(���>���������(������������*��������������X��<�����������_�������������������������X�������>���������(������������������������������(�������>���������(���������������������������������������������������� ��������������������������������������:��������<���������������������������HIGH TEMPERATURE APPLICATIONS;������ ��������� ��<��������� ����� <��� ����� �� ���� ���������������������������������������������������������������!������������������ �� �<���� ����� ������ ������� ��� ����� ��<�������������������"���������<<������������������"��������������������<����������<���������������<�������������������������������point of use temperature.!�������������������� ������������������������������������< ��� ������� �� ���� ���� �:��� �� ����� <����� ��� ����������������������������

Tank Temperature 103°FOperating Set Point 120°FStatus: Heating

MENU HELP

UP

DNGAS

OFFON

MANUFACTURER / MODEL INFORMATION

Figure 54

HIGH TEMPERATURE LIMIT CONTROL (ECO)

����������������������\��������������'!>�=������������?������X��� ����������<����������<���������������'!>��������<����������������������������=����:����?���������������<������������ '!>� ��� ������� ������� ���� K����� ��<�������� �� ��=������������?"�����V�����$������������� ������������'!>���������������������������������������� ��<��������������������}�<����������V� =�_�!?�����������������}�<������&_��V�=_��!?��J�� ���� '!>� ����:����� =�������� ���?� ��� �� � ��<����� ����������� ��<��������� ��� ����������� ����� ���������� �����<�������<<��������� ��^��������� ���� �_� 6�!� W��� 6��:�� ���� ���� �����������������������������������������<������¦�����¦����� ������������ �������� ��������� ���� ������ �����<� ����� �������� ����¦'������ !�� >�� ='!>?¦� V���� <������� �� ���� +!*� ��������J�� ��� �<������� ����� �� `������� (��:���������� �� ��������� �������<���������������������'!>�����:����� �������������������'!>��>������������������ ���������<����������������������'!>����� �����������������(��������'!>�����:���"�������������<��������<������� ����&_��V�=_��!?� ��������������������<����� ���������>����������������<����������������� ������������������������������������������������<��� ����������������������������������������������<�

THERMOSTAT CONTROL

Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.

Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.

Feel water before bathing orshowering.

Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.

;����������<�����������\����������<��������������������������������������������� ��������������������������������X��� ���)�� ������� �� ��� &�� ����� ���� ����}�<���� ��<�^�^ ��������������������<�������������������<�������������������X��������:��������������������������� ���� ������� �� �}������ ���� ������ �������� ��<�� ����������"������������������� ��������������������������������������<��J������������������������:����� ������������������� ������������������������������������������������������������������ ������ ���� ��\�������� �������������� ��<����������� �������������"������������������������<��� ��������J������������������������������� �����<������������������������������ ���� ��<���� �� ���� ����������� �� <�}���� :��:�� ���� ��������������������������������=����V��������������&_?��������������������������������������������<���������<��������#�:���������<������������������������������������������������� �����������#�:������:���������������� ������������������������� ���� �������������������������������� ��������������������������������������� �������������:�����������������<���������

TEMPERATURE REGULATION

Page 42: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

42

THE DESKTOP SCREEN*����� ��<��� �������� ���� ������ �����<� ����� �������� ����¦*�����¦���������� ����+!*������� ��� ����������������������������������<������������������*����������������������������������:��V���� �������� ���������������� ���������� ������user input for several minutes.

�� C���������������������������<��������<���������������������������]�������������������*��������������C�������������������������������������]����������:�����������������������<�<����

�� �����������<�������������������*������������"��������<�������"����������<�����������������������������������������������������������

�� ������������<�������������������*�������������is the Operating Set Point. The Operating Set Point is the ��<��������������������������������<������<������������������������������������������

�� Beneath the Operating Set Point is the "Status" line. The (�����������������������������������������������������������<�����������<�"������� ���&���������__�����������������of the various operational states.

�� ����*�����������������������������<�����¦(�����J���¦�����:�����������������<����"������� ���&&��������_$����������������������(�����J����

OVERVIEW

�������������������:�������������<����������\�����������������������������������<�����������������������<������������������� ������� ������;������� ����������� ������������<������� ������ ������ �����<�� ���� '!>� =������� ��� �?"� ��<�� �����"������������������������<���������� �������<������� ������������ �����<�� ���� !< ����� ]����"� �������"� �_� 6�!� W���6��:������������������������������ �����������������<������ <���� �<������� �� ���� ������ �����<� ���� �� KJC� =��������������<���?�������!!]�=�������������� ���?������KJC������������������������������������������������������!!]����<���������������������������������������������:�����������(���V�����������!<��������������%�����������������������������������������<�������

CONTROL SYSTEM NAVIGATION

�������������� ����<������������������������������������������������� ��<� ����KJC������KJC������ ���������� �����<���+!*� =��\��� �������� �������?� ���� �:�� ����� ������� =<<������?����� ����� ������ ��� �"� ���� ���� ������ =$?� <���� ������������������� ����� ��������+!*"�����V��������User Input Buttons

�� �������������� �����������������:������<����������X�����������������

�� �������������� ��������������������)�}���<���"��������<������<�"�����:������X��<����<������������<������������������������������������������ ���������<�����������"������������������������������� ��������}������������������������� :������� ����������+!*���������

CONTROL SYSTEM OPERATION

Tank Temperature 103°FOperating Set Point 120°FStatus: Heating

MENU HELP

GAS

OFFON

MANUFACTURER / MODEL INFORMATIONLCD ScreenInformationDisplay

Status Icons

3 Operational buttons:enter/exit menus,select menu items,activate adjustment modes,confirm/cancel changes.

Up & Down buttons:navigate menus,adjust user settings

Title Bar

Operational buttons are multi functional. Their current function is defined bythe text that appears directly above each button on the LCD screen.

UIM (user interface module)Desktop Screen Shown

UP

DN

Figure 55

Page 43: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

43

STATUS ICONS����(�����J������������������������*�������������������:�������������������������������<������������������������� ������������ ��� �����(���V���������������_����������(�\�����>��>����������������_��TABLE 11

Icon Description��������<��������������������������������(��������������������<���������<<�������������������������������������������������<���������������������������������������<�����K���������+������<���������� ����(���V�����$��������������V�����_������������������������<���������� ���

��������<������������������������������������>���������(������������������������<������������(���� ��<���

��������������� �����������������������������������������������������:�����V������������������������ �����������������<������������'�� ��)*��� ����������������������������V��<�������<���������'�� ��)*��� ���!�������������$��

����!< �����]�������� ���������������

����]�������:����������������������������:�������������������<�����������:���������<���������������������(���V�����$�������������]�������:���(�������������

����;��(������J���������� ����������������(���V��������������%����;��(������J��������������

���������������� ���������������������������������<������������������\�����<���<<���������������������������<�����������:���������<�������<���<<�����������������(�������(�\�����>��>����������������_����<���<<��������=�!��<��?�����<�����

GAS

OFFON

�����_�6�!�W���6��:����� ���������������

���������������<��������������<���������C����]�������<�������<���������(�������(�\�����>��>��������V���!�������������������V��������������%�

���������� �����<����������������V���� ������������<��� �� ���������)���:����� ����`�������(��:�����������V����<������������������� ��:�������������!������V����<����;���������������������� ����=�����?���������������������������������V�����������������������������������������<��� �����������������������������������������<��NOTE:�!�����������������������������������������<�������������������������������V����������� �������������

���������������<�����������������������������������<��� �����������)���:����� ����`�������(��:������������������������������������������������������������������������

Page 44: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

44

OPERATING STATES�����������������������������������������������������������������*��������������������¦(�����¦������<<����������������������������� ������������ ��� ������(���V���������������_����������(�\�����>��>����������������_�TABLE 12

State Description(���� � ���������������������������������:�����������������J'�������������<����������������� :������>���������(��������

J����6��������� ���������������<�������������������������������������� ���������������������������

(����!�����*���� ���������������<��������������������^���������<�����������}����� �����������������������������������������:�����¦����^�������¦��������������������������������������<������������������;��(������J�����������!< �����]������NOTE:�J�����������������<�����������������������������������������*�����������������������������<���������<�����������������������������

Pre-Purge ����!< �����]�������������������������������������������<������< ��������< ������������������

Igniter Warm Up ����;��(������J���������������������������������������<����������������������������(�������(�\�����>��>����������������_����<���<<��������=�!��<��?�����<�����

J�����������:���� �����_�6�!�W���6��:��������������������������������������������������C����]�����

J�������6��������� ���������������<����<��������������<�����������������\�����<���<<���<�����������������(�������(�\�����>��>����������������_����<���<<���<�����������������=*!�<�����<��?�����<�����

Inter-Purge ����!< �����]������������������������������������������<������< ��������< ������������������������������<���

Heating J�������������������"���<��������������������� �������� ���������������������������������������� ������������

Post-Purge ����!< �����]�������������������������������������������<������< ��������< ��������������������������������

V��� ���������������<����������������V�������������;���������������������� �������������V�������������������������������������������������<��� �����������������������������������������<��NOTE:�!�����������������������������������������<�������������������������������V����������� �������������

CONTROL SYSTEM MENUSV�<�����*��������������������������>������������������� ����¦C��¦�������+!*������������������¦C����C��¦������������������������������<�<���������������������� ��� ���������� ������������������<�<����TABLE 13

Menu DescriptionTemperatures C����<<�������������<����!�����������>���������(������������*�������������������������

Heater Status �����<�������������������������������������������������������������'!>�=���)�����?�������)����������� ����!< �����]����"�����:��:�"��������"���<�����������������<���������������������<������������������������this menu.

Display Settings ��<�������������=�V����!?"�����+!*������������= ���������)�������?����� ���������������������X��� �������������������������������<���

Heater Information '������� ��<�����������"� ������������������� ��<�"������������������"����������� ��<������������KJC�����!!]�����������:���������� ��:��������������<���

!������V��� *���������������������������V����<��������

V����;����� ����������������<�<����������������������������������=�?�V��������������<�����������������<�����<���������������:���������������������������

V����>�������� ����������������<�<������������������������������<������<��������V�����������������������������������������������������������������

@������V������*������ ����������� �����<� ������������� �������� �� ������������� �����<�������������� �� ������ �������������� ����������*�������(���������������������@'�#>������������������������������������������

;����(������ ��}�� ���������������������������<������}���������������������������������"���:���������������������<�<������������������������

Page 45: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

45

USER SETTINGS & CONTROL SYSTEM MENUSTEMPERATURES MENUOperating Set Point And Differential Adjustment����>���������(�������� �����X��� ��� ��<����V�=_��!?� ��&���V�=���!?������ ��������������� ���&���V�=_��!?������*������������ �����X��� �����<�����������������������������������������������������������������������<�������<���������<���������������������������������}�������������X������������������������:���������������������<�<���������������������<��������������� �����������������<���<��������=�������������?���<���������� ���������������>���������(�����������������������<�������������������������������������������������� ������:�����������������������������������<������������� ��������>���������(��������<��������*��������������������NOTE:� +���� *������������ ��������� <��� ����� �}�����:�� �������� ������� =����^�������?� ������ ���� ����� ���<����� ������� ���<�������������� ����;��(������ J��������(��� ����*��������������� ������������������������������������������� �������������������(�������>���������(��������������������������������������������������� ���������������������<���������������

DESCRIPTION/ACTION DISPLAYV�<�����*������������"�����������>����������]���������C'#K������¦C����C��¦������������� ������������

Tank Temperature 120°FOperating Set Point 120°FStatus: Standby

MENU HELP

MANUFACTURER / MODEL INFORMATION

����C����C���������������������������<�<��������������"������� ���&$��������__�������<���������������������������������������<�<�����K�������K������*���]�������:�������������������<�<������<�����C����C���

�������<���������<������������=��������������� ����?��������C����C���������"�����������>����������]����������('+'!�����������������<���������<���

J��������<���������<�������������������������K������*���]�������������������<������<�

TemperaturesHeater StatusDisplay SettingsHeater InformationCurrent Fault

SELECT BACK HELP

Main Menu

���������>���������(��������������������������<���������<��"�����������>����������]���������������!;�#W'��������:����������X��<����<�����������<������<�

J��>���������(������������������������������K������*���]�������������������<������<�

NOTE:�;��������<��������������������������������������������������(�������>���������(��������������������������������������������������� ��������������������������������������:��������<�������������������������������longer life.

Operating Set Point 120°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F

CHANGE BACK HELP

Temperatures

�����������X��<����<����������>���������(������������:������������������ �����������������<��� ������������� �����������

K�������K������*���]���������������������������������

����������>����������]���������¦K�*��'¦�����:�����������������������������>����������]���������¦!�#!'+¦��������������������������������������:�������:�����������

NOTE:�K����������<�����������������������*�������������������������������X��� ����������������������������������<�menus.

Operating Set Point 140°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F

UPDATE CANCEL

Temperatures

Page 46: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

46

TEMPERATURES MENU (CONT)

DESCRIPTION/ACTION DISPLAY�� Tank Temperature�^������X��� ���^������������<�

���������<��������=�:���������<�����������������<���������� ��?�

�� Upper Temperature�^������X��� ���^������������<����������<����������<�����K�������<���������� ��

�� Lower Temperature�^������X��� ���^������������<����������<����������<�����+������<���������� ��

�� (Heater Regulated to Tank)�^������X��� ���^���������������<�����

�� Upper Probe & Lower Probe Offset�^���X��� ��������������"�������^�����©���=�����������������?��NOTE:������������������������� ����������������������supply temperature varies greatly from the Operating Set Point setting. ����K���������+������ ��>��������������� ������ ����������������<���<�������������������������� �<��:�� �����������������<�������������� ���������������������������������������������������������� ���������<����������� ������� ������������ ���� =��� ������ ��������� �� ���������������?������<��������������������������������<������prematurely.'}�<����� J�� ���� ������� ������� ��<�������� ��<� ����<���������� �����&���V�=_��!?���������>������������������������ �������X���������:����������������"����������������<��������� ������� �������� ����������� ��<����������<������� �����������:��������������<���������;�������������� ���� �� ����:����� ���� ������:����� ����� �� �������� ������=�����?���<�����������������������������X��������������<������������ ����������>���������(������������*��������������X��<�����������45.

Top of Menu

Operating Set Point 140°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F

CHANGE BACK HELP

Temperatures

Bottom of Menu

Differential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°FLower Probe Offset 0°F

CHANGE BACK HELP

Temperatures

HEATER STATUS MENU

DESCRIPTION/ACTION DISPLAY(������ ;������ (����� ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<������K�������K��/�*���]���������:����������<���

�� Status�^���������������������>���������(����"������� ���&��on page 44.

�� ECO Contact"�Low Gas PS"�Blocked Inlet PS"�Blocked Outlet PS"�Blower Prover PS�^�������������������������������������������������������������

�� Blower On"�Igniter On"�Gas Valve On�^��������������������������������������<��������������������������������������������<������������£����������"���£���^����������

�� Igniter Current�^��������������������������������������<��������������������\�����<���<<�������"�����(�\�����>��>����������������_�

�� Flame Detected�^��������������������������������������<��������������C����]�������<������������������<�������<��������

�� External Input Enable�^���������������������������(&���������������:�� ������������������:����������� ��)���� ���������"�����'�� ��)*��� ���!�������������$��

�� Ignition Trials�^���������������������������(&���������������:�� �������������������&���$������������������� ������������������¦J�������V�����¦�V�����������"���������!!]�^�!�������!�����]����+������������$�

Top of Menu

Status StandbyECO Contact ClosedLow Gas PS ClosedBlocked Inlet PS ClosedBlocked Outlet PS ClosedBlower Prover PS OpenBlower On No

BACK HELP

Heater Status

Bottom of Menu

Blower On NoIgniter On NoIgniter Current NoGas Valve On NoFlame Detected NoExternal Input Enable NoIgnition Trials 3

BACK HELP

Heater Status

Page 47: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

47

DISPLAY SETTINGS

DESCRIPTION/ACTION DISPLAY(������ *������� (�������� ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<�������������X��� ��������������������:�����������<������� ���� KJC��� +!*� �������� K��� ���� K�� /� *��� ]����� ��navigate the menu.

�� Temperature Units�^���X��� ������������������������������<�����������������������!�������!���V�����������V�

�� Backlight Delay�^���X��� �������������������������<����������������KJC���+!*� �����������<��������<����������������������� ��������������:���� ������������������������>��"�&�"�$�������������������������>��

�� Contrast�^���X��� �������������������X�������KJC���+!*���������������� ���������}������ ��������NOTE: ������ ��������� ���� ��X����� ��� ���� ��<�� ���������� ��� ��� ���� >��������� (��� ����� ���� *��������������X��<�����������_��

Temperature Units °FBacklight Delay 30sContrast 60%

CHANGE BACK HELP

Display Settings

HEATER INFORMATION

DESCRIPTION/ACTION DISPLAY(������;������ J���<����� ��<� ����C����C������������� ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<�����

�� Elapsed Time�^���������<��������<�����������������<�=������������?����� ��������������

�� Burner On Time�^���������<��������<�����������������<����� ����������������������������������� ��������time.

�� Cycle Count ^���������<����������������������������� CCB Version ^�(�������:����������������������� ������ UIM Version ^�(�������:�����������������������<����

NOTE: ;������������������������������!!]���<�<����J�������!!]����������������������:�������������������������������!!]� ������������������� ���������������������������������������� ��������� �� ������ ������� ����������� ������� �� ���������������������'���������<�"�]�����>����<������!�����!���������������"���������������J�� ���� !����� !��� ���� ���� ��� ����� =��:���� ������ ���� ������� �������<������������������?��� ����������������� ��������=�����<���� ���������<�������<�����"���:���� ������� ��<�� ����� <������ �� ������ ���?� �������� ������� ����*������������ �������� �� �:��� ����� �������� ���� �}�����:���<����������"�����>���������(������������*��������������X��<�����������_������� ���������� ����� ���� ���� �� ���� �� ������� �����������<�������������������������������������<�������\��<������������:������������������������������������������������

Elapsed Time 10 day 0 hrs 0 minsBurner On Time 5 hrs 22 minsCycle Count 00000035CCB Version X.XXUIM Version X.XX

CHANGE BACK HELP

Heater Information

Page 48: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

48

CURRENT FAULT

DESCRIPTION/ACTION DISPLAY(������ !������ V���� ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<������K�������K��/�*���]���������:����������<�������� <��� �������� ���� ������� V���� �������� ����� <��������������<������V������������<������������������������������� ������� �������������������������������������������V������������ �������� �������� ���� ������ ��������� ���� >����������]���� ����� ¦�*6�#!'*¦� ����� ��:�� <��� ��������� ���:��������<����������� ����������� ��������� ��� ����V���������������������(���V��������������C���������������������<����������������<����������������������������J�� ������ �����V������������ ������������:�� �����<��������������������������<����"�¦=���?¦������ ���������}����!������V�����������C����<���

CHANGE BACK ADVANCED

Blocked ExhaustFault occurred 2 mins ago

The exhaust is blocked orrestricted. Ensurecondensate hose is draining.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

FAULT HISTORY

DESCRIPTION/ACTION DISPLAY(������ V���� ;������ ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<������K�������K��/�*���]���������:����������<�������� <��� �������� �� ����� �� ���� ����� ����� =�?� V���� ����������<�����������������<�����<���������������:�������������������������������������>����������]���������¦6J'�¦���:������������ ��������V������������<�������������

1: Blocked Air Intake (A7) 51 mins ago2: Blocked Exhaust (A8) 54 mins ago3: Low Gas Pressure (A6) 57 mins ago4: Blower Prover Failure (AC)

VIEW BACK HELP

Fault History

FAULT OCCURRENCE

DESCRIPTION/ACTION DISPLAY(������ V���� >��������� ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<������K�������K��/�*���]���������:����������<�������� <��� �������� �� ������� ����� �� ��� <���� ��<��� �����V���� �������� ���� ������� ������ ���� ������ ������� ���� ���������������NOTE: ;��������� ����� ��� ������ ��� ���� !!]��� <�<���� J�� �����!!]����������������������:�������������������������������!!]� ����� �������������� �� �������������������� ��� ��������������� �������������������������������������������������������������

Ignition Failure 10ECO 0Low Gas Pressure 10Blocked Intake Air 0Blocked Exhaust 0Thermostat Input 4 0Blower Prover 3

BACK HELP

Fault Occurrence

RESTORE FACTORY DEFAULTS

DESCRIPTION/ACTION DISPLAY(������@������V������*���������<�����C����C�����������������>����������]���������¦('+'!�¦��������������<����� ������� ���� ��X��� ��� ���� ��������� �� ������ ������� ���������������� ������ ���� >���������� ]���� ���������� �B'(��������������� ����� ���� ��}�� ����<���� ���� ������� ������� �����������:�� ������������������ ���� >���������� ]���� ���������� �]�!��� �� �}��� ����@������V������*�������<���

YES NO

Restore Factory Defaults

Are you sure you want torestore the system to factorydefaults?

Page 49: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

49

SERVICE CONTACT INFORMATION���������������<����������������<��������J�����������������������)�����:�����������������������������������������<�����������������<���������������������<���������� ���������������������V��������������<��������

DESCRIPTION/ACTION DISPLAYV�<�����*������(������=����V���������������_�?��������������� ���� ���� <������ =�<�����?� >���������� ]���� ��� $���������������������������������� ����� ������ �� ��������� <��� ������ ������������ �����������<��������� ����������K���������K������*>�#� ������������=��������������� ����?�����¦(���!������J���<����¦�<������<�

����������>����������]���������¦!;�#W'¦�������:����������X��<����<���������������<�����

Show Contact Information NoChange Contact NameChange Contact PhoneCurrent Contact Info:

(000) 000-0000Access Code

CHANGE BACK HELP

Service Contact Information

�����������X��<����<������¦(���!������J���<����¦�����:������������������ �����������������<��� ������������� �����������

K�������K������*���]����������������������������<�¦#¦���¦B��¦���������������>����������]��������������¦K�*��'¦�����:������������������

NOTE:������������!���������� ��<�������(��:����!������J���<������������������<������������������������������������������������������������������<��������������through this menu item.

Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:

(000) 000-0000Access Code

UPDATE CANCEL

Service Contact Information

K���������K������*>�#� ������������=��������������� ����?�����¦!������!������#�<�¦�<������<�

����������>����������]���������¦('+'!�¦�����������!������!������#�<��<���

Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:

(000) 000-0000Access Code

SELECT BACK HELP

Service Contact Information

V�����������������������������������������<����������<��������<�����������������<�}�<<�������������������������������������

�����������������������>����������]����¦K�*��'¦�����:����������!������#�<������������������<���������������������������<���

Enter the service contact below:

NAME: _

Use the > and < keys to move betweencharacters. Use the UP and DOWN keys tochange the character.

- -

< > UPDATE- -K���������K������*>�#� ������������=��������������� ����?�����¦!������!����������¦�<������<���������������>����������]���������¦('+'!�¦�

V������������������������������������������!������������< �����������������>����������]���������¦K�*��'¦�����:����������������< ����

�������������!������#�<������!������������< �����:�� ��� ����������"�����������>����������]���������¦]�!�¦���������������*������������� BACK HELP

Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:YOUR COMPANY NAME HERE(123) 456-7890Access Code

Service Contact Information

Page 50: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

50

PRIOR TO START UP

J����������� ���� ������ �� �� ����� ������ ������� ��\����� � ��������������������\�:��������������������������������<�����������������:�:��"�����`��������������������*������������������������������������������������������ ��������� ������� J<<��������� ����� �� \������� ���:���� ����������� ���������� ������������������������������������������ ���������������<����������������������������� ����������������+����� ���� ������ ������� ��� ���������� ����� ���� +�������� ����>��������J����������� ����������������������������������<�����on page 53.���� ������ �������� �:����� �� ����� <����� ���� �\������ �����������������������������<�=����������_�?���������<�����������\������ ���� !< ����� ]����"� ���� ���� ���� ������� ������ �< ����� ���< ��"� ���� ;�� (������ J������"� ���� �_� 6�!�W���6��:�"�C����]������������"�������<��������������������������<����������������������������������������������<����]����� ����<������ ������ �"� �������� ����� ���� ��<��������������������������}����(�\�����>��>�������"�����������������(�\����� >�� >�������� �� ����� �_� ���� ���� (�\����� >��>��������V���!���������������]����������������������������������������������"���������������������<��������������������������������������������������������������������������������'���������������������:��:�����������FILLING THE WATER HEATERV������������������������������������������������������1. !���������������������:��:��2. >���������� ����������������������<�����������������������<�

���������3. V����������������������������:��:�������������������������

������������������������������4. !��������������������������������(����������������������

�����SUPPLY GAS LINE PURGING

Fire or Explosion Hazard

Read instruction manual beforeinstalling, using or servicing

water heater.

To avoid risk of fire or explosion purge discharge must notenter into confined areas or spaces where ignition can occur.

The area must be well ventilated and all sources of ignitionmust be deactivated or removed.

Gas line purging is required with new piping or systems inwhich air has entered.

Use only the gas shown on the water heater rating label.

Keep ignition sources away from faucets after extendedperiods of non-use.

1. !��������C����W���(�����6��:�"�����V���������������$%�2. ���������������<�������������������������������������������

Main Gas Shutoff Valve.

3. ����� ���� ���� ���� ���� ������ ��<� ���� ������ ���� ����"���������������������������������������

4. !�����������������"�����W���+����+�������������������$�"��������������������������

INITIAL START UP

REQUIRED TEST EQUIPMENT�� ���K^� ��<��<�����"����<<���������������^&_����!��

=�^$������?������^$�����!��=�^��%����?�������������������� �����������<��<���������� �����������������K^� ��

<��<�����������������������@��<<��������������^&_������©&_�������!��=�^$������?������������&����!�������^$�����!��=�^��%����?�����������&�����!�

NOTE:� ���� ����� �\��<���� <��� �� �����<����� �� �< �������<�������� ��������� �������������PREPARATION1. K��������������������<�<���"������������>���������(���

����� �� ���� ������ ��<���������������"�����>���������(������������*��������������X��<�����������_��

2. ������������������������)����������������������������3. !��������C����W���(���>���6��:�"�����V���������������$%�4. ���� ��� ���� ���� ������ �� � ��������� ���� ���� �� ����

����������"�����V������������V������%����������&���������5. ������:��=�?�<���������������������������������6. !���������<��<�����=������������?�������:���� ��������

������ �������������� �������� ������������������������ �����&)�¦�#�����������������������������������������������+��W������������������������ ������������� �����_�6�!�W���6��:���������&)�¦�#���������������������

7. !���������<��<�����=����������?� ������<������������������� ���� ��� ���� ����� �� ���� �_� 6�!� W��� 6��:�"� ����V����������������&�����V������%���������������������

8. Open the Main Gas Shutoff Valve.9. C�������������������������������������"��������������������

������������������ ��������������� ����������������� ���������������X���������������������������������"�����(�����W�������������X��<������������&�

LIGHTING THE WATER HEATER1. ���� ��� ���� ���� ������ �� � ��������� ���� ���� �� ���� ����

������"�����V������������V������%����������&��������2. ������������������������)���������������������������3. �����������������������<����<���������� ������\������

���� *������ ������� ������� ���� ������� >��������� (�������������������<������������� �����������������������������<���+!*���������� ������\���������<������

4. K����� ���� ������ �����<� <���� ���� KJC� =���� ����������<���?"������������>���������(�������������������������������� ����������� ����� ��<�������������������� ���������������<�+!*���������*��������������������������:�����������������������(���!�����(����<�>���������������_��

5. @����� ���� <������� ���� �������� ����� ���� �_� 6�!� W���6��:�� ��� ���������� ���� ���� C���� ]����� ��� �������"� �������<����� ���� :��:�� ���� ����� �� ���������� �� ���� *������������������������������<���+!*���������������������<����������������_�6�!�W���6��:�"������<�������<������������������ ����� C���� ]����� �������� ��� ��������"� ���� ����(�����J��������������������� ���&&��������_$�

START UP

Page 51: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

51

�����<<������<��������������������������NOTE:�����������������<��������&�������!��=��$%����?����������C����]���������������������������������������\���������������������������������������������"���������������)���������������J����������<��������&�������!��=��$%����?�������������� �������� ����� ����� ���� C���� ]����� �������"� ���������� ������ ���� ������ ���� �������=�?� ���� �������� ������ ���������������(��� ���� ��\���<����� ���(�����W���@������� ����Supply Gas Line on page 13. See Supply Gas Line Installation on �����$%�����(�����W���@�������J������������������$���'�����������\���<������������������������������������<����������MANIFOLD GAS PRESSURE ADJUSTMENT

Fire and Explosion Hazard

Gas and carbon monoxide detectors areavailable.

Overfiring could result in fire orexplosion.

Under no circumstances should the input exceed the rate shown on the water heater’s rating label.

Breathing Hazard - Carbon Monoxide Gas

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Under no circumstances shouldthe input exceed the rate shownon the water heater’s rating label.

Overfiring could result in damage tothe water heater and sooting.

Gas and carbon monoxide detectorsare available.

'���������¦����<��¦����������������������� :������<���<<���\���<���������� ���_��������&$� �����������X��<���������<����������<������������������������<��������X���<���������������������������������� ������������������������������� ��� :�������� ����� ���� ������ ���� �������� ������� ����<����(���(�����W�������������X��<����������������J�����������"���X�������<����������������������������1. V����������������������J�������(�����K���������������������

<��<������ �� ��������������<������������������� ����������������������������������

2. @�<:�� ���� <������� ���� �������� �������� �:��� �����"�����V������������������������V������%�����������

3. K��������<���������������������:�������������X��<������������������� �� ��������� <������� ���� �������� ���� ��������������������������<�������������������NOTE:� ���� ���� <������� ���� �������� ��X��<���� ��������� �<���� �����<����� =�� <��� ����� &)_� ���?� ���� ����� ����<������������������������ �����������:�����<������ �����<���������������X��<�����

4. @��������������������������������:���������5. !��������� ����������������:�������<�������������������

6. !<���������������<������������������������������������� :�� �� ���� ��\����� <���<<)<�}�<<� :����� ��:��� ����� ���_��������&$����X���<�������������������������������"������������������������������

7. @����� ���� ������ ���� �������� ����� ���� �_� 6�!� W���6��:�����������������������C����]��������������������������������<���� ���� �������� ��������� ������ ���� ������ ������� ���������

8. !<����� ���������� ������������������ �������� ���������� :�� �� ���� ��\����� <���<<)<�}�<<� :����� ��:��� ����� ���_��������&$����X���������������������������������"������������������������������

ON

OFF

HONEYWELL

MANIFOLD GASPRESSURE REGULATORCOVER SCREW

ALL 300,000 & 400,000 BTU/HR MODELS AND 500,000 BTU/HR PROPANE MODELS24 VAC GAS VALVE TOP VIEW

MANIFOLD GASPRESSURE TAP1/8’ NPT PLUG

INLET OUTLET

GAS CONTROLKNOB

Figure 56

SUPPLY GAS PRESSURE ADJUSTMENT

Fire and Explosion Hazard

Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.

Excessive gas pressure to gas valve cancause serious injury or death.

Do not use water heater with any gasother than the gas shown on the ratinglabel.

(����������������������� ��<������������������������������������������=��������������?�AND�������������������������������������������������=����<����������?��J������������������������������������������������� �������������\�����<���<<�����<�}�<<�:�������:�������� ���_��������&$���X�����������������������������������������X������������������������=�?�����������������<������������������������������:��������\�����������������������<����������������������Multiple Appliance Installations:J�� <������� ������ ������� ������������� �� ��� ������������� ��������������������������������=�?����������<<������������<���������������������������������������������������������������� ��<�����������������������������������������������������������������������<<��<��������������������������>��<������������������������������������������������������������������� ����X���������:�����������������������������������������������<���<<�����<�}�<<�����������������\���<����������������� ���_��������&$���������������������������������������

Page 52: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

52

ON OFF

MANIFOLD GAS PRESSUREREGULATOR COVER SCREW

500,000 BTU/HR NATURAL GAS MODELS 24 VAC GAS VALVE TOP VIEW

MANIFOLD GASPRESSURE TAP1/8’ NPT PLUG

INLET

OUTLET

GAS CONTROLKNOB

Figure 57

CHECKING THE FIRING RATE

J�� ������ �������X��<���� ��� ��\����� ����� ������ ����������� �������<��������������������������������������������1. '�����������������������������������������������������

��������<���������������������������2. !���������������������� �������<����������������:���"� ���

]������� �����"�����������������3. !������ �� <��<����� �� ���� <������� ���� �������� �����

V����������������������J�������(�����K������������4. (��������������������������������������������5. !���������<������������������"����������� ���_��������&$�

�������������������(���C�������W�������������X��<������������&������X��<�����������������

6. +�������������<��������:���������������������7. ��<���������=���������?����������������� ������������

�� �������������������������������������������������������8. K���������<��� ���������������������<��������������<����

���������������������������������������� �������������������:����=]������� �����?�����������������

x H = Btu/hr3600T

x 1050 = 300,000 Btu/hr (87.9 kW)360012.6

Example:

�� $����£������������������� ��£���<�"����������"��� ������� �������������� ;�£���������:�������������]������� ��������� ]�)���£�������������������������������������

NOTE:�&����]������� ��������������������:�������������������(�������������������]�����������������]������� �������]��:�����<������������������������������������������:�������!�������������������������������<�����

TO TURN OFF GAS1. !������ ����>���������(�������� �� ���� ������ ��<��������

�������"�����>���������(������������*��������������X��<����on page 45.

2. ���������������������������<���������������������\������������������������� ��<��"�������������������������)����������������������������

3. ���� ��� ���� ���� ������ �� � ��������� ���� ���� �� ���� �����������"�����V����������������&�����V������%�������������

4. !��������C����W���(�����6��:�"�����V���������������$%�

HIGH ALTITUDE INSTALLATIONS

Fire and Explosion Hazard

Gas and carbon monoxide detectors areavailable.

Overfiring could result in fire orexplosion.

Under no circumstances should the input exceed the rate shown on the water heater’s rating label.

Breathing Hazard - Carbon Monoxide Gas

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Under no circumstances shouldthe input exceed the rate shownon the water heater’s rating label.

Overfiring could result in damage tothe water heater and sooting.

Gas and carbon monoxide detectorsare available.

�������������������:����� �������<������������������������������<�������������������������&�"���������C�������������� �<���������^����� ���������� ����������������"�<���������������������������������������������������V�� ������������� � :�� &�"���� ����� ����� ���� ���������� ������������< ���������������� �����:����������<�������������������������������������!���������������������������<�������:������]������� ������������� �������������������������������������������:�����������<������:���� ���NOTE:�����������������������������������������<�������}��������� ����� ������� �� ���� ������ ��������� ������� �� ��� ����� ��������<��������NOTE:� *�� �� ���� ����� ������� �������� ��� ����� ��������"� �������� ������� �� ���� ���������� ��� ���� ������� ���� ����� ���<���������������������������������\��<�������������������

Page 53: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

53

LIGHTING THE WATER HEATER

ON

OFF

Honeywell

IN1/2 PSI

GASCONTROLKNOB

FOR YOUR SAFETY READ BEFORE OPERATING

TO TURN OFF GAS TO APPLIANCE

OPERATING INSTRUCTIONS

Wait five (5) minutes to clear out any gas. If you thensmell gas, STOP! Follow “B” in the safety informationabove on this label. If you don’t smell gas, go on tothe next step.

IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY A FIRE OR EXPLOSIONMAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.

A.

B.

1.

2.

C.

D.

This appliance does not have a pilot. It is equipped withan ignition device which automatically lights the burner.Do not try to light the burner by hand.

STOP! Read the safety information above on thislabel.

Do not try to light any appliance.

Do not touch any electrical switch; do not use any telephonein your building.

Immediately call your gas supplier from a neighbor’s

telephone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the firedepartment.

Use only your hand to push in or turn the gas controlknob. Never use tools. If the knob will not push in orturn by hand, don’t try to repair it, call a qualified servicetechnician. Force or attempted repair may result in fireor explosion.

Do not use this appliance if any part has been under water.Immediately call a qualified service technician to inspectthe appliance and to replace any part of the control systemand any gas control which has been under water.

BEFORE OPERATING smell all around the appliance areafor gas. Be sure to smell next to the floor because somegas is heavier than air and will settle on the floor.

Set thermostat to lowest setting.

1. Set the thermostat to lowest setting.

9. Set thermostat to desired setting.

10. If the appliance will not operate, follow the instructions“To Turn Off Gas To Appliance” and call your servicetechnician or gas supplier.3. Turn off all electrical power to the appliance.

2. Turn off all electrical power to the appliance if service is to be performed.

8. Turn on all electrical power to the appliance.

7. Turn gas control knob counterclockwise to “ON”.

3. Push in gas control knob slightly and turn clockwise to “OFF”. Do not force.

4. This appliance is equipped with an ignition device whichautomatically lights the burner. Do not try to light theburner by hand.

5. Push in gas control knob slightly and turn clockwiseto “OFF”.

6.

“WHAT TO DO IF YOU SMELL GAS”

WARNING

LIGHTING & OPERATION LABEL

���������������� ��� ����������}�������������������������:����� �������<�����������������������<��� �����������������������������������������������������

Page 54: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

54

SEQUENCE OF OPERATION

@���� ���� (�\����� �� >�������� ���� ����� ����<������ ��������� ���� ���������� �� ��<��� @����� �� ���� V������� ����!<������� ������� ��������� �� ����� %� ��� ���� ������� ��:����� ������ ������� �<������� ������ ��� ����� (��� ����(�\�����>��>��������V���!�������������������1. ��������������������<���������������"������� ���"���������

���������������������<���� ����<����������� ����������������������� ����<<����� ���������������<�+!*������� ���������� ���� KJC� =���� ���������� <���?� ����� �������� ���� ��������������������������¦*�����¦��������

2. J�� ���� ������ �����<� �����<����� ����� ���� ������ ��������<�������� ������� ���� ����� ��� ���� ���� �����<<���>���������(��������<��������*�������������������"������������������������:�����

3. ���������������<�����������<��������������������������<��������� ����� �������� ����<���� ���� ��� ���� �������"� ������ �}����"� ������ ������� ���� '!>� =������� ����?�������������������������������]�������:���(����������������������<�������

4. J��������������������������������������������"����������������<���������������!< �����]�����������^�����

5. ���������������<�<�������<�����]�������:���(�����������������������������!< �����]������������������

6. J�� ����]�������:���(������ ������������ ����<������������������������<���������������;��(������J�������������������������<^��������

7. ���� ������ �����<� <������ ���� �������� ������� ���� <�����������<���<<��������!��<������]�;�$���/�_���<�����������%��!��<������]�;�����<��������������������������<���������=&�^&%�������?�

8. J�� �������� �<������� ��� ����<��� ��� �� � :�� ���� ��\�����<���<<� ���� ������ �����<� ���������� ���� �_� 6�!� W���6��:�������������������������C����]������

9. ���������������<���^��������������;��(������J�������10. ���������������<�<������������<��������������<���

��<��������������������C����]������J������<��������:����������������� �����������������������������������<������ ���� ������������������<�����<����J����<��������� ��:������������������� ������� ��� �������"� ���������������<������ �����������������������J�������V�������V����<�������

11. J�� �� ��<�� ��� :������"� ���� ������ �����<� ����� ������ ������������<��������� �������� ��������������� �������������������>���������(��������������������������������"����������������<��������^��������������_�6�!�W���6��:�������������������^�����������=����}�<������$��������?�

12. ����!< �����]������������������������������������^����� ������ �� ����� ���� ������ ������� �� ���� �< �������������������������^���������������<�����"����� ����������^��������������������������������

13. ���� ������ �����<� ��� ������� ���� ����� �� <��� ��������������� �� <����� ���� ��������� ������� ����� ��������<�������� ���� ���� ������ �� ����� �����<� ��:������ J�� �����������<������������� ��������>���������(��������<��������*�������������������"������������������<�����������������(������������������������������������

TROUBLESHOOTINGINSTALLATION CHECKLIST

���� ����� ���� ������������<���� ����<��� ��������� ��������������\���<���������"������:������"������������ ��������������� ��<�"� ���� ��<�� ���� ��������� ������ �������<����� �������� ��� �� �<������ ������ ]����� �����<���� ���� �� ������������������ ��� ���� ����� ���� �� ������ ��� ������������ �������!���� �� ������� ������������ ������ ���� ��� �:����� ����� ������<����� ���������� '����� ���� ������������ ��\���<����� �����������������������<�������:�� ����<���������������������WATER HEATER LOCATION1. '����� ������ ����������� �� �< ��� ���� ���� <����������

�����������������������<������:����������������������(���!�����������������&&�

2. '�����������������������������:�����<�����������<<� ���<����������(������������������������&��

VENTING3. '�����������������������)��:����=�}����?����������������������

����� ��� ���� ���������� ��������(���6�������@�\���<�������page 22.

4. Ensure the maximum equivalent feet of pipe has not been �}����������������������������)��:����������(����� ���%���page 22.

5. '����� ���� <�}�<<� �< ��� �� �� ��� ���� ��� �����}������� ��� ���� ������� ���� ���)�� :���� ������ (��� 6�������Requirements on page 22.

6. '��������� �����������������������������������������<:�����<� ���� ������� ���� ��������� �� ���� ������ ������� ��������������������������������������*������6���������������(���V�����&%���������_�

7. '����� ���� �}������ ����������� ��� ���� ������� ���"� :���� �������������� ���<�������� ���� <����������� (��� 6�����������<������� J����������� �� ����� �_"� (�������� ���<�������J�������������������������!������������<�������J�������������������%���������������������������������� ������������������������<��� ��<����������

GAS SUPPLY AND PIPING8. '����������������� ������������ ���� ���������� ��������

������ �������� (��� ���� ��\���<����� ��� �� (����� W���@��������������&$�����(�����W���@�������J�����������on page 38.

9. '����� ���� ������ ���� ����� �� ����� ������ ������� <�����the minimum supply gas line size requirements. See the ��\���<����� ��� ����(�����W���+�����������&$����� ����������������������������������$%�����$��

CONDENSATE DRAIN10. '����� ���� ���������� ������ ��� �������� ��������� �� ����

�}����� �� �� �� ���� ������ ������� ����� �� ������ ����� �����:���� :���� ������ ��<� ��������� ���� ���� ���������� ���������������������������������� �������������(���V��������������&������!���������*�����J������������������$��

ELECTRICAL CONNECTIONS11. '�����������������������������������������������������

����������������(���������\���<�����������������(������������&$�����'������������������������$��

12. '�����������������������������������������V��<������������\�����������\����������������J�����������������������������������������������������J�������V������

Page 55: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

55

SEQUENCE OF OPERATION FLOW CHART

YES NO

Water is heated to set point

24 VAC Gas Valvede-energized

30 secondInter-Purge cycle

24 VAC Gas Valvede-energized

Retries up totwo more times

30 secondPost-Purge cycle

Control System Locks Out

“Ignition Failure” Fault Msg is displayed

Water heater goes into standby mode

If tank temperature drops below Operating Set Point minus Differential setting a heating cycle is activated

Blower Prover switch contacts confirmed closed by control system

Igniter is energized for warm up period

24 VAC Gas Valve is energizedgas flows to Main Burner

Is flame sensed at the Main Burner?(control system monitors the flame sensor)

Control System Locks OutDisplays Fault MsgNO

Control System Locks Out“Blower Prover Open”Fault Msg is displayed

NO

Control System Locks Out “Low Igniter Current”

Fault Msg is displayedNO

Combustion Blower is energizedPre-Purge cycle

Does Control System sense minimum Igniter amps?

Control System performs diagnostic checksNormal State of all pressure switches and ECO are checked

Blower Prover pressure switch verified openAll other pressure switches and ECO are verified closed

2.0 minimum AC amps300,000 & 400,000 Btu/hr Models

2.7 minimum AC amps500,000 Btu/hr Models

Figure 58

Page 56: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

56

�� '}�����:��<�������������������^������� ���_��������&$�����C�������W�������������X��<������������&�

�� 6����=�}����?������������������������:���������������������������<����������*������6�����������������^�����*������Vent Installation on page 23.

�� '}�����:���\�:������������������������������)��:����=�}����?������������������^�����6�������@�\���<�������page 22.

�� *� �����������) ����������������������������=�?�^�����V�����&%���������_�����V������������������

�� *� �����������) �����������C����]�����^�����V���������page 7.

MOMENTARY IGNITION

Burn Hazard

Do not reach into the burner housing orcombustion chamber if the water heateris still hot.

Allow the water heater to cool and always usegloves when handling the main burner.

The combustion chamber and burner sleeve and housing become very hot during operation.

CAUTION

J�� ���� C���� ]����� �������� <<��������� �� ���� ��� ��������������� ����� ���� ������ ������� �� ���� �� ������� �� �� ��� <�����<�������������������<����������������J�������V������V����<�������������������������������������<���+!*��J�����������������������}����������������������^�����@���(�������"�@���>���������������������V��<<����������������� ��<���������������������������������������

�� J��������<�������������������̂ ������� ���_��������&$�����C�������W�������������X��<������������&�

�� K�������������������������=���:�<�������������?�^�����Supply Gas Line on page 13.

�� (���������������������������������������������������\���<�����=������������������:�<�)��������?�^�����Supply Gas Regulator on page 13.

�� (������������������ ����������������������������������������������J�������V������V����<�����������������

�� *� �����������) ����������������������������=�?�^�����V�����&%���������_�����V������������������

�� *� �����������) �����������C����]�����^�����V���������page 7.

NOT ENOUGH OR NO HOT WATER�� #������������������������"������� ������"��������������

��������������)������������ ;��������������:��:�=�?����}������������� >���������(�������������������"�*���������������������������

��������(���!�����(����<�>���������������_���� K��������)��+������ ��>������������������������������

��������������������<���������<�������^�������<���������C���=���?��������_��

�� '����������������������}�����������:�����������=������������ ��)���� ���������?����� ����������������������(���'�� ��)*��� ���!�������������$��

�� �������������������������������������������� �����}������"����������������������� �����<������<����

OPERATIONAL PROBLEMS

Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.

Failure to follow these instructions andsafety messages could result in deathor serious injury.

This manual must remain with thewater heater.

������������������<������������������� �����������������������<<�������������� ��<�"��������������������:�����������������<��� �� � ��� �� ���:�� ���� ������� �������� �� ��<�� ������<���������������� ����������������� ����������� ������������������� ��� ��� ��^����� ������ �� �������� �������� ;��:��"� ����\����������:����������"��������������`�������������������"������ ����������� ����� �\��<���"� ����� �����<� ���� ���:���������������������������������NOTE:� !���� ���� ���������� ������ ����� �< ��� ������� �� ���� �����:����������<������������������������������������������������\����������:���������������������INSTALLATION ERRORS>������������ ��<��������������������������������������������������������\���<������������:�� ����:�������������������������� �<�������� J'�� �� ¦+�� W��� �������¦� V���� �����������<�������������� ��������������������������������������������:��+��W�������������������@���������������� ��������������������������� �������������������������������)������� ����������������������������������������������������� �� �����<���� ���� ���������� ������� �������� ���� ������������� ������������ �� ������ ���� ������������ ��\���<����� ��������������� ��:�� ���� <���������� ���� �������� (��� ����J�����������!�����������������_NOTE:�!���������������������������������������:����������������<��������������ROUGH STARTING, ROUGH OPERATION

Fire and Explosion Hazard

Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.

Excessive gas pressure to gas valve cancause serious injury or death.

Do not use water heater with any gasother than the gas shown on the ratinglabel.

�� K�������������������������=���:�<�������������?�^�����Supply Gas Line on page 13.

�� (���������������������������������������������������\���<�����=������������������:�<�)��������?�^�����Supply Gas Regulator on page 13.

�� '}�����:��������������������^������� ���_��������&$�����(�����W�������������X��<������������&�

Page 57: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

57

ALERT CONDITIONS��������������������<����������������������������������������������������<������������������������<���+!*��������\������¦¶¦�<������������������������������������������������������������������ �� �����������������<��� �����:����� ����\����������:����������������������� ���RESETTING CONTROL SYSTEM LOCK OUTS�� ������ ���������������<� ��<��� ��������������� ���� �������������������������}�<������������������������� ���������������<�����������������������������������V����������� ������������"����������������<���������������������DIAGNOSTIC CHECKS

Turn off power to the water heaterbefore performing any service.

Electrical Shock Hazard

Label all wires prior to disconnectingwhen performing service. Wiring errorscan cause improper and dangerousoperation.

Verify proper operation after servicing.

Failure to follow these instructions canresult in personal injury or death.

������������������"�V��������������C�����������������"��������<��������<�����������������������<��������������������+!*���������������������������� ��<�����������������<���������������������������������V��������������<�������������� �������������� ��������������� ���������������������������������������>���� \������� ���:���� ������"� ��� ������� ��� `����������� ��������"����������������� ������\��<���"� ����������<��������:���������������������������������NOTE:� J�� �� ���� ��� \������� ���� ��������� �� ��������� �����\����� �� ��������������:���� X���������� �������<�����:�����������������<����������<��������������������������:������������������� ��������������������������J�����������������������������������������������������������������<����������<��������������!������������������������������< ���������������� �����:����� ����� <����� ��� ������� ���������� ����������� �� �� ������ ��\����������:���������������������

Jumping out control circuits or components canresult in property damage, personal injury or death.

Service should only be performed by a qualified serviceagent using proper test equipment.Altering the water heater controls and/or wiring in any waycould result in permanent damage to the controls or waterheater and is not covered under the limited warranty.

Any bypass or alteration of the waterheater controls and/or wiring will result

in voiding the appliance warranty.

Altering the water heater controls and/or wiring in any waycould result in altering the ignition sequence allowing gas toflow to the main burner before the hot surface igniter is atignition temperature causing delayed ignition which cancause a fire or explosion.

�� !��������<������������<��������������������������<����\������������������������������<��������

�� ;��������������������"�����������"��������������������valve leaking or open.

�� (���<��������<�����������<������<��� ����������������������������������(���C����������������������������<����������<����������<:������������

�� ������������������������������������������!�����<������������������"������������������������&��!����������������������������������������"��������������������������

WATER IS TOO HOT�� Operating Set Point is set too high. See Operating Set Point

����*��������������X��<�����������_���� K��������)��+������ ��>����������������<������������^�

������<���������C���=���?��������_���� J<�������������������^�����������<�� �����������������%�

NOISY OPERATION�� (���<��������<�����������<�����������������< �����

���������������������������������������(�������C�������������������������<����� ��������������������������<����������<����������<:������������

�� #�<�������������������������������<��������!< �����]����"��������<����<"��������������������

WATER LEAKAGE IS SUSPECTED�� '����������������������������:��:��������������������� !����������������������������^�����V�����_������������ !����������)������������������������������<���������� !�����������<�������^��������@������6��:��

�� '}�����:����������<���������� '}�����:������������������ *������:����<�������^��������@������6��:��

NOTE:�'}�����:�����������������������<����<<�����������<�������^�������� @������ 6��:�� ��������� '}�����:�� �����������<��������� ���<�������������� �� ¦����<����}������¦������¦�����������<�¦�(�������<���'}�����������!�����������Systems on page 14. The Temperature-Pressure Relief Valve is ����������������������������������������<����}���������<�������^��������@������6��:����������������������� ����������������������<���������������:��������<����}�����������������������������:����������������<�������������������<����}�������������<��� �����������������������������������<��REPLACEMENT PARTS@������<���� ������ <��� �� ������� ��<� ���� <���������"�������������:��������������������� ������������������������ ����������:�������<�������������������C����#< ��"�(������#< �������(������#< ����:���� ��������� ����<��������� ��������������������� ������}����������������������@����� �� ���� ������ ����� �������� ����� ���� ������ ������� ��<� ����������� ��� <��� ����<����� �� ����� ���� ������ ������<���� ������������������������< ���������������� �����:����������<��������������������������

FAULT AND ALERT CONDITIONS

FAULT CONDITIONS��������������������<������������V������������������������������V����<������������������������<���+!*����������}���<�����¦·¦� <��������� ������ �����<� ����� ���� �� ���� ���� ��� ���������������������������������������������������������������<��� �����:����� ����\����������:���������� ����������������� ����������

Page 58: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

58

FAULT AND ALERT MESSAGES!������������������������������< ���������������� �����:����������������������������������������������\����������:����������in your area.

POSSIBLE CAUSES - CHECK/REPAIR DISPLAYED FAULT/ALERT MESSAGE�� ������������������������������<�������������������:���������������

���������� ��������������������������������������������������������:����������������������<��������������������!�@�:�������V����<�������������+!*������������������(��������(�����!����������������$�����������������������������������������������������NOTE:�'�����������<������������\��������������������������������#*�����������������������������������������������C����]���������������������<��������:����������������� ������������ ���������������������������������������(�������J�������V������V����<�����������<����� ���� CHANGE BACK ADVANCED

AC ReversedFault occurred 2 mins ago

Power supply to water heaterhas reversed polarity.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������<�������������������������C����]������� ���������������������������������"���������������������

������C����]�����^����������(�����!����������������$���� *����)���������<�������"���������<�����������������������

���=�������������<����?�^�����V��������������%��� +������������������������<���������� +�����������������������_�6�!�W���6��:���� �_�6�!�W���6��:���������� ��������¦��¦��������^�����V��������

��������&�����V������%������������� (�����������������"��������:�<��^����������$%��� J�������������)��:����������������������������<������������������^�

see Venting Installation on page 21.�� +������<�������������������������C����]�����^�����J�������

Start Up on page 50.

CHANGE BACK ADVANCED

Ignition FailureFault occurred 2 mins ago

The water heater has failed toignite the burner.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������<������������������+��W�����������(����������������������

�� +����������������������+��W�����������(������^�����V�����$��������������������

�� (�������������������� ����������\�����<���<<���������^�����Table 4 on page 13.

�� (����������������������������C����(�����6��:���� (����������������������������������������������������������

�����<<�������������������������������� +��:�<��������������^�����(�����W���+����J�������������

�����$%�����������\���<������������(�����W���+�����������&$�����Supply Gas Regulator on page 13.

CHANGE BACK ADVANCED

Low Gas PressureFault occurred 2 mins ago

The supply gas pressure to thewater heater is low.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������<������������������������=�!��<��?���<�����;��(������J�����������������������<�<�������������������������������������������V�������������������������������������� :�����������<<���<���<<���\���<����^���������(�\�����>��Operation on page 54 for minimum igniter amp requirements.

�� +����������������������;��(������J�������^�����V��������������%�������������������

�� *�<����"������������������;��(������J�������NOTE:�;�����������������������������������������������������������������������������������;��������������������� ��:������in the Heater Information menu - see Heater Information on page _%��J��������������*���������������������������������������������^�����>���������(������������*��������������X��<�����������_��

CHANGE BACK ADVANCED

Low Igniter CurrentFault occurred 2 mins ago

Igniter current is low.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������<������������������]������'}�����(����������������������

�� ����������������������� ������������������}������� �������������^���������������������������^�����V��������������&��

�� +����������������������]������'}�����(������^�����V�����$���������������������������

�� @���������) ������:�����������^�������������������������������� '}�����:���\�:�����������������"��}�����������<�}�<<��< ���

�������� �������������������������������:����������������<�^�see Venting Requirements on page 22.

�� '}�����:����������������������������:���������<���������� '}�����:��������:�������������������������������������

CHANGE BACK ADVANCED

Blocked ExhaustFault occurred 2 mins ago

The exhaust is blocked orrestricted. Ensurecondensate hose is draining.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

Page 59: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

59

FAULT AND ALERT MESSAGES (CONT)!������������������������������< ���������������� �����:����������������������������������������������\����������:����������in your area.

POSSIBLE CAUSES - CHECK/REPAIR DISPLAYED FAULT/ALERT MESSAGE�� ���������������<������������������]�������:���(������

��������������������������������� ������������� ���������������������������^���������(�\�����>��>����������������_�

�� �������)�������]�������:���(�������������^�����V�����$���������������������������

�� §<������������������������]�������:���(������^���<:��X<����������§<����������<�����:��� �����"�������������������on page 57.

�� '}�����:����������������������������:���������<���������� '}�����:��������:������������������������������������� CHANGE BACK ADVANCED

Blower Prover FailureFault occurred 2 mins ago

The blower prover switch isclosed out of sequence.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������<������������������]�������:���(��������������������<��������������������������������<�������������������!< �����]�����^���������(�\�����>��Operation on page 54.

�� +����������������������]�������:���(������^�����V�����$���������������������������

�� ]�������:���(������������������� �������������"�������"��������������������"���<���������������^������������������� ��

�� !< �����]����������������������������������� +������������������!< �����]������� +��"����"�����������������������6V*���]�;�_�������]�;�����

<�����̂ �����V�����$�������������������������������<�����������

CHANGE BACK ADVANCED

Blower Prover OpenFault occurred 2 mins ago

The blower prover switch remainsopen after the blower has beenenergized.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������<������������������]������J����������(����������������������

�� +����������������������]������J����������(������^�����V�����$���������������������������

�� '}�����:���\�:�����������������"��}�����������<�}�<<��< ����������� �������������������������������������������������system - see Venting Requirements on page 22.

�� ]����������������)�����������������������������<:��������������������������������������������������������������������������) ������������� ����^�����V�����&%���������_�

�� '}�����:��������:������������������������������������� CHANGE BACK ADVANCED

Blocked Air IntakeFault occurred 2 mins ago

The combustion air intake isrestricted.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������<������������������'!>�=�����������?�(����������������������

�� ����'!>���������������<����������������������������������<������������������:�����}�����:����������<��������������������������������'!>����������������������K�������<���������� ��=������������?�^�����V�����$�������������K������� ���������

�� +����������������������'!>���������������K�������<���������� ��^��������������

�� J<�����������������<�����������)���}�����:���������������=�����������?������������<��������^����������������������Diagrams beginning on page 67.

CHANGE BACK ADVANCED

Energy Cut Out (ECO)Fault occurred 2 mins ago

Tank temperature is excessive.The water heater has beendisabled.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������<���������������������:��������<���������������������^�����V�����$��������������������

�� #���������������������������� +������������������������������������������������^�����

V�����$���������������������� �������������������������������������� ��������������������������������������^����������(�����

!����������������$���� +���������������������� ����������=$)_������ �����?����������������������������

��������������������������������������^��������������������������������������"������������<:��������������������� �����=�?�

CHANGE BACK ADVANCED

No Anode VoltageAlert:

Alert occurred 2 mins ago

No voltage detected fromPowered Anode(s).

Call a service professional:Your Company Name Here(press [DOWN] for more....)

Page 60: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

60

MAINTENANCE SCHEDULE

TABLE 14

COMPONENT OPERATION INTERVAL REQUIREDTank (���<����

RemovalSemi Annually V������

Tank +�<��(�����Removal

Semi Annually UN-LIME®

�����@�� J���������!�������

Annually !�����(�����Deposits

T&P Valve Test Operation Semi Annually Test

Vent System J�������� Annually Termination (�������!����Reseal/Repair

DRAINING AND FLUSHING

J��������<<���������������������������������������� �������������� ������ �:���� �� <����� �� ������ ����<���� ������ ���������������������� ������������� ������������������������������<����������(���V�����������!<��������������%�����������������������������������<������������� ��� ����

Burn harzard.

Hot water discharge.

Keep hands clear of drainvalve discharge.

To drain the water heater storage tank:1. �����������������������������������������������2. Turn off the gas supply at the Main Gas Shutoff Valve if the

����������������������� �����������������}��������������3. '�������������������������:��:���������4. >���������� �����������������������������������������������

��������������������5. !�������������������������������������:��:���������<������

�����������\����������6. !������������������������:��:��7. >���������������������������:��:���������������������������

��������<�����������������8. !���� ���� ������ ������� ������ :��:�� ����� ���� ������ ��� ����

������������������������9. !��������������������������������(����_�10. J����������������������������� �����������������}�������

�����"�����������:��:������� �����������To Flush the tank perform the following steps:1. �����������������������������������������������2. '�������������������������:��:���������3. >���������� ����������� ���������� ���� ���������� ��������

������������������������������������������������������4. !������ �� ���� �� ���� ������ :��:�� ���� ���<������ ��� �� ���

���\����������

MAINTENANCEGENERAL

�������������������������������������<��< ��� ���<��������"��������������������<<� ���:�����������\�����(���+�������The Water Heater on page 11.������ ������� <����������� �������� �������� ����� ������� ������������"�������<:�������<������������������������������� ������������������X�������<���������������< ������(���J�������(�����K���������������������������������������:������������<������ ��<��������������"�������������������<�=�?������ �����������������������<��<��������������<<���������PRECAUTIONS

Do not operate the water heater if it has been exposed to or exhibits the following:

Flooding at or above the level of the burner or controls.External damage.Firing without water.Sooting.

Do not operate the water heater until all corrective stepshave been made by a qualified service agent.

CAUTION

#�:��� ������� ���������� ������������� ����� ����� �������� ��� ��������� ����� ������ ���� �� �������� ������ ���� ������ ��<�������^��������@������6��:�����������������������������:��:��������������� ������ �������� (��� ��<�������^�������� @������ 6��:�� ��page 15.

Explosion Hazard

Overheated water can causewater tank explosion.

Properly sized temperature andpressure relief valve must beinstalled in the opening provided.

(����:�������������������������������������������"�����������C����W���(�����:��:���(���V���������������$%������� ������� <����������� �������� �������� ����� ������� ������������"�������<:�������<������������������������������� ������������������X�������<���������������< ������@����������� �������� �� �������������� ������������ ����:������������<������ ��<��������������"�����������������������<������� �����������������������<��<���������������<<���������

Page 61: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

61

TANKCLEANOUTOPENING

CLEANOUTCOVER

CLEANOUTGASKET

CLEANOUTACCESS PANEL

Figure 59

MANUAL LIME SCALE REMOVALNOTE:�!�������������������� ��������������������������<����������< ��������� �����:����������<���������������������������������;�:������������������:���� ��� �������<:����������������:������� ������� ������� ��� ����� ��� V����� ���� �� ��<:�� ��<��������<�����������������������������������������������1. �����������������������������������������������2. �����������������<��� ���������"�����*������������V�������

���������"��������������������������������������������heater.

3. @�<:����������������������������<������������������������������X������

4. @�<:��������������:�����<���������������5. @�<:�� ��<�"� ������ ���)�� ����<���� ����� ����� ��� ��

��<�������������^�������6. J��������������������������������\�����7. @���������������������:�����]���������������������������

����������������������������8. !���������������������������:��:��9. V���������������������̂ �����V�����������������;����������������10. ���������������������������������������������������� ����

in operation. See Initial Start Up on page 50.11. �������������������������<��������:����������������������

ensure it is operating properly.12. !����������������������13. @���������������������������������CHEMICAL LIME SCALE REMOVAL�������:��������<:��<����� �����<���������������"�K#^+JC'¹������������*���<�������� �������K#^+JC'¹������������*���<����������������������������������� ������ ����� ��<������ ������������ ��� ��<�� ������ ��<:�����<�������������������������\��<�����;���������� ����������<��� ��� �� ���� �� ����<�� ���� ������ �������� �:����� ��� �����manual.V���� ���� ����������� �� ���� K#^+JC'¹� �� ����<�� ���� ������heater.NOTE:� !���� ���� ������ ������<���� ����� �< ��� �� ���� �����:����� �����<����� �������K#^+JC'¹������������*���<����See TABLE 15 on page 62 for part numbers.

5. '����������������������������� ������������������������������������������V���������������<�������������<�������������������������������������������

6. >���������������������������:��:�������������������������7. V�������������������������������������<:������<��������

��������������������������������������8. !���������������������������:��:������������������<�������9. @�<:����������������10. V���������������������̂ �����V�����������������;����������������11. ���������������������������������������������������� ����

in operation. See Initial Start Up on page 50.12. �������������������������<��������:����������������������

ensure it is operating properly.

FILLING THE WATER HEATER

(���V�����������������;����������������

SEDIMENT REMOVAL

����� ���� �<����������������� ���������������� ���� ������������������������������<���������������<���������� ��<���the tank.V�� ��:�������"� ����<���� ��<:��� ���� ��<�� ������ ��<:�������� �������<������������<����<��

LIME SCALE REMOVAL

����������� ���������������:���<�������� ��� ����������������������<� ���� <������<� ��� ����� =��<�� �����?� ��<�� ������� ���� ��� ���� ������ ��<�������� ������ ������ <�������� ���������������������������������������� �<��� �� ��<�� ������ ��������� ��<� ������ ��� ��� �������������������������<�����������������������������������������<��������������������"�����<�����<�������������������������������������������������������������� ��<�����������<������������ ������<����������������� �����������<�"�������������������������<�����<�������������������������+�<������������������������������������ ������<������ ��������������� ��������;������� ��������� �������� ��<���������������<�� ������ �������� ������ ���������� ���� ����� �� ������� ���������� �������� +�<�� ������ �������� ���� ���� ����� �< �����������������������������<������������������������<����������������������������+�<�����������<������������������������������������������������V���������������������������������������<��������� ������������ ������ �� ��<�� ���<������ ��� ���� ��<� �� ���� ������������� ����� �� <������� ������������� J������� �� ��<:�������� ������� �:��� ���� �:���� �� <����� ��� ������ *���<����<����������� ����� ����� �� �����<��� ����� �� ���� ��<�� ������������&������=�����<?�����<�������<������������ ��<��������������������(���<����������<����������<:���<��� �����<��������<����������������������������������������������������������"�����V���������

Page 62: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

62

DISCHARGE PIPE

TEMPERATURE-PRESSURERELIEF VALVE

V�������J�� ���� ��<�������^�������� @������ 6��:�� �� ���� ������ ������������� �� ����������� �����������"� ����� <��� �� ��� �� ����<���expansion.NOTE:�'}�����:�����������������������<����<<�����������<�������^�������� @������ 6��:�� ��������� '}�����:�� �����������<��������� ���<�������������� �� ¦����<����}������¦������¦�����������<�¦�(�������<���'}�����������!�����������Systems on page 14. The Temperature-Pressure Relief Valve is ����������������������������������������<����}���������<�������^��������@������6��:����������������������� ����������������������<���������������:��������<����}�����������������������������:����������������<�������������������<����}�������������<��� �����������������������������������<��DO NOT PLUG THE TEMPERATURE-PRESSURE RELIEF VALVE OPENING. THIS CAN CAUSE PROPERTY DAMAGE, SERIOUS INJURY OR DEATH.

Explosion Hazard

Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.

Properly sized temperature-pressure relief valve must beinstalled in opening provided.

Can result in overheating andexcessive tank pressure.

Can cause serious injury or death.

VENT SYSTEM

'}�<��������:���������<��������������������������������������������1. !�������� ������������)�������������������������������

���)��:����������������������������������:�������<���������@��������<<����������������������

2. ���� �� ���� �������� ��� ���� ������� ���� ���� :���� ���<������������� �� ����� �� �������� �� ������� <�������� ���� ����(���V������������������NOTE:�*���������������������:�����������������������is in operation.

3. !���������:���������<�������������������������������������������������������

TABLE 15

UN-LIME® PROFESSIONAL DELIMERPart Number Description9005416105 _�^�&�������=����?9005417105 1 - 5 gallon

POWERED ANODE RODS

�� ������ �� ���"� �� ��^����� ��������� ����"� ���� ������ ���������:����� ��� ����� <����� ���� ������� �\������ ����� �� �����������������<��������������� =�?������������<����������������� �� ��� ����� ���������� ������ ��<������ J��������� ������������������ �������<��������������NOTE:�V������������������������������������������������������������������������@�<:���������������������<�����������heater by loosening the 3/4" NPT bushing that forms the top �� ���� ������� *� ��� �������< ��� ���� ���������� ��� ���� ��������<����� ��<� ���� ��� ������ ���������� ��� ���� ������ ������"� ����������� ��������� <��� ����� ������� ���� ������ @�<:�� ���� ���������������� ��<����������������������� �� �����������!����� ��������������������������������������������V���������������������������������������������������������������������

DRAIN VALVE AND ACCESS PANELS

�������������������:����� ��� �����<����������\�������������������:��:�"�����V�����������!<��������������%�������������������������������:�������������<��������������\������������� ������� ������� ��� ����<���� ���� ��<�� ������ ��<:���� (���V����������������&�

TEMPERATURE-PRESSURE RELIEF VALVE TEST

Burn hazard.

Hot water discharge.

Keep clear of Temperature-Pressure Relief Valvedischarge outlet.

J�� ��� ���<<������ ����� ������<�������^��������@������6��:������� �� �������� �� ������ ����� ��� ��� ��� ��������� ��������every 6 months.��������������������<�������^��������@������6��:���������"�<�������������=&?�������������������������������������������<�������^��������@������6��:������������ ����"�����=�?� ����������������������������������������������������<���"��������������<��� ���}���<��������K����������������������:��:�����the valve may be hot.�� ������ ���� ������� :��:�"� ����� ���� ��:��� ��� ���� ���� �� ���� :��:����:�������<��"�����V�������������:��:������������������������operate freely.J��������<��������������������:��:�"�������������<������������������ �������� �� �������� �����"� �<<��������� ����� ���� ���������� ������ �� ��������������������������� ����������������"�����*������������ V������� �� ����� ���� @������� ������<�������^��������@������6��:����������������������)������������"�������<�������^��������@������6��:���������&�������������������������<����

Page 63: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

63

DIAGRAMSCCB - CENTRAL CONTROL BOARD LAYOUT

1 Retry

Use Yes

Type Tstat

Spare

ExtInput

3Retries

No

Vent

Spare

OPE

N

1

2 3

4

3

2

1

6

5

4

9

8

7

12

11

10

15

14

13

J6

J7 3 24 1

1

2

J15

84

5

6

7

1

2

3

J13

3

4

1

2

J10

1

3

5

2

4

J1

1

3

4

2

J2

1

4

2 1

2

J3 J5 J4

S1 DIPSWITCH

J16

J9

J11

S1 DIPSWITCH DETAIL

CCB (CENTRAL CONTROL BOARD)

1 Retry

Use Yes

Type Tstat

Spare

ExtInput

3Retries

No

Vent

Spare

OPE

N

1

2 3

4

Dipswitch Operation:Along one side of the dipswitch array there are numbers, 1-4. On the other side of the dipswitchis the word “OPEN.” The dipswitches are rocker type switches, if one side of the rocker is down the other side will be up. Pressing a rocker down on the side of the array labeled “OPEN,” opens the switch.Pressing a rocker down on the side of the array labeled with the numbers 1-4 closes the dipswitch.

CHANGING NUMBER OF IGNITION TRIALS BEFORE LOCK OUT

NOTE: Always turn off power to the water heater before changing dipswitch settings.

Set dipswitch #4 to the open position for 1 trial for ignition before Ignition Failure lock out. Set dipswitch#4 to the closed position for 3 trials for ignition before Ignition Failure lock out.

Figure 61

Page 64: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

64

BTH 300 WIRING DIAGRAM

2 GREEN

WHITE

RED BLACK

1

1

2

BLACK

3

WHITE

COMBUSTIONBLOWER

UPPER TEMPERATURE PROBE

1 RED (ECO)

4 RED (ECO)

2 BLACK3 BLACK

1 BLACK120 VAC HOT

3 WHITE 120 VAC NEUTRAL4 YEL 24 VAC

4 YEL 24 VAC

LOWER TEMPERATURE PROBE

HOT SURFACE IGNITER

FLAME SENSOR

BLOCKED AIR INTAKE

BLOCKED EXHAUST

BLOWER PROVER

24 VAC GAS VALVE

B (C

EN

TR

AL C

ON

TR

OL B

OA

RD

)C

C6J

5J4J

7J51

J

61J

01J

31J

2J3J

1J

TRANSFORMER INSIDE CCBENCLOSURE50VA

GROUND STRIPBURNER GROUND(BURNER BOLT)

ON/OFFSWITCH

GROUND

120 VAC NEUTRAL

120 VAC HOT

LOW GASPRESSURE SWITCH

1 BLACK2 WHITE

RED

1 BLACK

2 BLACK

1 BLACK

2 WHITE

MU

SE

R IN

TER

FAC

E M

OD

ULE

IU

1

21541451067

8

13

11

LN

ANODE 1

ANODE 2

1 GREEN

2 BLUE

2 RED

GREENWHITE

NOIT

CN

UJX

OB

GREEN

NE

ER

G

NE

ER

G

ENABLE/DISABLE CIRCUITJUMPER WIRE BETWEEN PINS8 AND 11 ON J6 PLUG

120 VAC 1 Ø POWER

Figure 62

Page 65: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

65

BTH 400, 500 WIRING DIAGRAM

12

56

WHITE

GREEN

BLACK

BLACK

WHITE

RED

COMBUSTIONBLOWER

NOTE: COMBUSTION BLOWER MOTORSON 400,000 & 500,000 Btu/hr MODELS ARETHREE PHASE (3Ø) MOTORS.

BLACK, WHITE AND RED WIRES MUST BEWIRED AS SHOWN OR THE MOTOR WILLTURN BACKWARDS. THIS MAY CAUSE THECONTROL SYSTEM TO LOCK OUT ON“BLOWER PROVER OPEN” FAULT.

WHITE/BLACK

WHITE/GREEN

WHITEWHITE/YELLOW

1T

2T

3T

LN

AI1

0V

+15V

L l1

2 GREEN

WHITE

RED BLACK

1

BLACK

3

WHITE

1 RED (ECO)

4 RED (ECO)

2 BLACK3 BLACK

BLOCKED INTAKE AIR

BLOCKED EXHAUST

BLOWER PROVER

24 VAC GAS VALVE

BC

C6J

5J4J

7J51

J

61J

01J

31J

2J3J

1J

TRANSFORMER50VA

GROUND STRIPBURNER GROUND(BURNER BOLT)

LOW GASPRESSURE SWITCH

1 BLACK

RED

2 WHITE

1 BLACK

2 BLACK

MIU

1

21541451067

8

13

11

LN

ANODE 1

ANODE 2

1 GREEN

2 BLUE

NOIT

CN

UJX

OB

RED

GREEN GREEN WHITE

NE

ER

G

NE

ER

G

NE

ER

G

GREEN

UPPER TEMPERATURE PROBE

1 BLACK120 VAC HOT

3 WHITE 120 VAC NEUTRAL4 YEL 24 VAC

4 YEL 24 VAC

LOWER TEMPERATURE PROBE

HOT SURFACE IGNITER

FLAME SENSOR

(CE

NT

RA

L CO

NT

RO

L BO

AR

D)

INSIDE CCBENCLOSURE

GROUND

120 VAC NEUTRAL

120 VAC HOTU

SE

R IN

TER

FAC

E M

OD

ULE

ENABLE/DISABLE CIRCUITJUMPER WIRE BETWEEN PINS8 AND 11 ON J6 PLUG

VFDVARIABLEFREQUENCYDRIVE

ON/OFFSWITCH

Figure 63

Page 66: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

66

CIRCULATION PUMP WIRING DIAGRAMS

Figure 64

Figure 65

CIRCULATING PUMP WIRING DIAGRAMSTORAGE TANK OR BUILDING RECIRCULATION

FIELD SUPPLIED TEMPERATURE CONTROLINSTALLED IN THE STORAGE TANKOR CIRCULATING LOOP RETURN LINE

CIRCPUMP

MOTOR

L1 HOT

L2 NEUTRAL

120 VACPOWER

NOTE: USE SEPARATE 120 VAC POWERSUPPLY FOR PUMP CIRCUIT. DO NOTSHARE POWER WITH APPLIANCE AS THISMAY CAUSE ELECTRICAL LINE NOISE ANDLEAD TO ERRATIC CONTROL SYSTEMOPERATION.

CIRCULATING PUMP WIRING DIAGRAMDISHWASHER LOOP WITH TOGGLE SWITCH

FIELD SUPPLIED TEMPERATURECONTROL INSTALLED IN THECIRCULATING LOOP RETURN LINE

DISHWASHERTOGGLESWITCH

CIRCPUMP

MOTOR

L1 HOT

L2 NEUTRAL

120 VACPOWER

NOTE: USE SEPARATE 120 VAC POWERSUPPLY FOR PUMP CIRCUIT. DO NOTSHARE POWER WITH APPLIANCE AS THISMAY CAUSE ELECTRICAL LINE NOISE ANDLEAD TO ERRATIC CONTROL SYSTEMOPERATION.

Page 67: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

67

4.

(��

�!�

����

(��

��<

����

����

��<

���'

}���

���

���

����

�&_

5.

(��

����

���+

����

!�

����

���

���

����

�_��

6.

J����

�<

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

�_�

����

����

���

7.

J����

�<

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�<

<��

����

����

����

�����

�����

���

����

���V

���

���_

���V

���

����

���

����

����

WAT

ER P

IPIN

G D

IAG

RA

MS

]��

���

����

����

����

���

����

����

����

��:�

�����

���

���

����

1.

See

Mix

ing

Valv

es o

n pa

ge 1

4.2.

(

���*

����

����

���C

����

����

���

����

&_�

3.

See

Tem

pera

ture

-Pre

ssur

e R

elie

f Val

ve o

n pa

ge 1

5.

ON

E W

AT

ER

HE

AT

ER

, SIN

GLE

TE

MP

ER

AT

UR

EW

ITH

BU

ILD

ING

RE

CIR

CU

LAT

ION

LEG

EN

DTE

MP

ER

ATU

RE

& P

RE

SS

UR

ER

ELI

EF

VALV

E

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

TAN

K O

R L

INE

TEM

PER

ATU

RE

CO

NTR

OL

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

EX

PAN

SIO

NTA

NK

HO

T W

ATE

R O

UTL

ET

PIP

E T

&P

TO

OP

EN

DR

AIN

CO

LDW

ATE

RS

UP

PLY

HO

T W

ATE

RR

ETU

RN

LIN

E T

EM

PE

RA

TUR

EC

ON

TRO

L

Page 68: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

68

4.

(��

�!�

����

(��

��<

����

����

��<

���'

}���

���

���

����

�&_

5.

(��

����

���+

����

!�

����

���

���

����

�_��

6.

J����

�<

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

�_�

����

����

���

7.

J����

�<

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�<

<��

����

����

����

�����

�����

���

����

���V

���

���_

���V

���

����

���

����

����

WAT

ER P

IPIN

G D

IAG

RA

MS

]��

���

����

����

����

���

����

����

����

��:�

�����

���

���

����

1.

See

Mix

ing

Valv

es o

n pa

ge 1

4.2.

(

���*

����

����

���C

����

����

���

����

&_�

3.

See

Tem

pera

ture

-Pre

ssur

e R

elie

f Val

ve o

n pa

ge 1

5.

ON

E W

AT

ER

HE

AT

ER

, TW

O T

EM

PE

RA

TU

RE

WIT

H H

IGH

TE

MP

ER

AU

RE

LO

OP

RE

CIR

CU

LAT

ION

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

N

LEG

EN

DTE

MP

ER

ATU

RE

& P

RE

SS

UR

ER

ELI

EF

VALV

E

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

E

MIX

ING

VA

LVE

WA

RN

ING

: TH

IS D

RAW

ING

SH

OW

S S

UG

GE

STE

DP

IPIN

G C

ON

FIG

UR

ATIO

N A

ND

OTH

ER

DE

VIC

ES

;C

HE

CK

WIT

H L

OC

AL

CO

DE

S A

ND

OR

DIN

AN

CE

SFO

R A

DD

ITIO

NA

L R

EQ

UIR

EM

EN

TS.

HO

T W

ATE

R

OU

TLET

HO

12” T

O 1

5”M

INIM

UM

T

CO

LD

TEM

PE

RE

DW

ATE

RTO

FIX

TUR

ES

CO

LD W

ATE

RS

UP

PLYTE

MP

ER

ED

WAT

ER

RE

TUR

N

HO

T W

ATE

RR

ETU

RN

EX

PA

NS

ION

TAN

K

PIP

E T

&P

TO

OP

EN

DR

AIN

LIN

E TE

MPE

RATU

RECO

NTR

OL

LIN

E TE

MPE

RATU

RECO

NTR

OL

TAN

K O

R L

INE

TE

MP

ER

ATU

RE

CO

NTR

OL

MIX

ING

VA

LVE

Page 69: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

69

4.

(��

�!�

����

(��

��<

����

����

��<

���'

}���

���

���

����

�&_

5.

(��

����

���+

����

!�

����

���

���

����

�_��

6.

J����

�<

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

�_�

����

����

���

7.

J����

�<

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�<

<��

����

����

����

�����

�����

���

����

���V

���

���_

���V

���

����

���

����

����

WAT

ER P

IPIN

G D

IAG

RA

MS

]��

���

����

����

����

���

����

����

����

��:�

�����

���

���

����

1.

See

Mix

ing

Valv

es o

n pa

ge 1

4.2.

(

���*

����

����

���C

����

����

���

����

&_�

3.

See

Tem

pera

ture

-Pre

ssur

e R

elie

f Val

ve o

n pa

ge 1

5.

ON

E W

AT

ER

HE

AT

ER

, SIN

GLE

TE

MP

ER

AT

UR

EW

ITH

VE

RT

ICA

L S

TOR

AG

E T

AN

K F

OR

CE

D R

EC

IRC

ULA

TIO

NW

ITH

BU

ILD

ING

RE

CIR

CU

LAT

ION

LEG

EN

DTE

MP

ER

ATU

RE

& P

RE

SS

UR

ER

ELI

EF

VALV

E

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

EX

PA

NS

ION

TAN

K

ALT

. CO

LD W

ATE

RC

ON

NE

CTI

ON

PIP

E T

&P

TO

OP

EN

DR

AIN

TAN

K O

R L

INE

TEM

PER

ATU

RE

CO

NTR

OL

LIN

E T

EM

PE

RA

TUR

EC

ON

TRO

L

TAN

K T

EM

PE

RA

TUR

EC

ON

TRO

L

NO

TE:

The

wat

er h

eate

r’s O

pera

ting

Set

Poi

nt s

houl

d be

set

high

er th

an th

e Ta

nk T

empe

ratu

re C

ontro

l in

the

auxi

liary

sto

rage

tank

.

AOSSTORAGE TANK

Page 70: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

70

4.

(��

�!�

����

(��

��<

����

����

��<

���'

}���

���

���

����

�&_

5.

(��

����

���+

����

!�

����

���

���

����

�_��

6.

J����

�<

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

�_�

����

����

���

7.

J����

�<

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�<

<��

����

����

����

�����

�����

���

����

���V

���

���_

���V

���

����

���

����

����

WAT

ER P

IPIN

G D

IAG

RA

MS

]��

���

����

����

����

���

����

����

����

��:�

�����

���

���

����

1.

See

Mix

ing

Valv

es o

n pa

ge 1

4.2.

(

���*

����

����

���C

����

����

���

����

&_�

3.

See

Tem

pera

ture

-Pre

ssur

e R

elie

f Val

ve o

n pa

ge 1

5.

ON

E W

AT

ER

HE

AT

ER

, SIN

GLE

TE

MP

ER

AT

UR

EW

ITH

HO

RIZ

ON

TA

L S

TO

RA

GE

TA

NK

FO

RC

ED

RE

CIR

CU

LAT

ION

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

N

LEG

EN

DTE

MP

ER

ATU

RE

& P

RE

SS

UR

ER

ELI

EF

VALV

E

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

E

MIX

ING

VA

LVE

WA

RN

ING

: TH

IS D

RAW

ING

SH

OW

S S

UG

GE

STE

DP

IPIN

G C

ON

FIG

UR

ATIO

N A

ND

OTH

ER

DE

VIC

ES

;C

HE

CK

WIT

H L

OC

AL

CO

DE

S A

ND

OR

DIN

AN

CE

SFO

R A

DD

ITIO

NA

L R

EQ

UIR

EM

EN

TS.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

ALT

ER

NA

TE T

AN

KTE

MP

ER

ATU

RE

CO

NTR

OL

LOC

ATI

ON

EX

PA

NS

ION

TAN

K

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

PIP

E T

&P

TO

OP

EN

DR

AIN

LIN

E T

EM

PE

RA

TUR

EC

ON

TRO

L

TAN

K T

EM

PE

RA

TUR

EC

ON

TRO

L

NO

TE:

The

wat

er h

eate

r’s O

pera

ting

Set

Poi

nt s

houl

d be

set

high

er th

an th

e Ta

nk T

empe

ratu

re C

ontro

l in

the

auxi

liary

sto

rage

tank

.

TAN

K O

R L

INE

TE

MP

ER

ATU

RE

CO

NTR

OL

AO

SS

TOR

AG

E T

AN

K

Page 71: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

71

4.

(��

�!�

����

(��

��<

����

����

��<

���'

}���

���

���

����

�&_

5.

(��

����

���+

����

!�

����

���

���

����

�_��

6.

J����

�<

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

�_�

����

����

���

7.

J����

�<

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�<

<��

����

����

����

�����

�����

���

����

���V

���

���_

���V

���

����

���

����

����

WAT

ER P

IPIN

G D

IAG

RA

MS

]��

���

����

����

����

���

����

����

����

��:�

�����

���

���

����

1.

See

Mix

ing

Valv

es o

n pa

ge 1

4.2.

(

���*

����

����

���C

����

����

���

����

&_�

3.

See

Tem

pera

ture

-Pre

ssur

e R

elie

f Val

ve o

n pa

ge 1

5.

TW

O W

AT

ER

HE

AT

ER

S, S

ING

LE T

EM

PE

RA

TU

RE

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

NLE

GE

ND

TEM

PE

RAT

UR

E &

PR

ES

SU

RE

RE

LIE

F VA

LVE

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

EX

PA

NS

ION

TAN

K

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

TAN

K O

R L

INE

TEM

PER

ATU

RE

CO

NTR

OL

LIN

E T

EM

PE

RA

TUR

EC

ON

TRO

L

Page 72: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

72

4.

(��

�!�

����

(��

��<

����

����

��<

���'

}���

���

���

����

�&_

5.

(��

����

���+

����

!�

����

���

���

����

�_��

6.

J����

�<

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

�_�

����

����

���

7.

J����

�<

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�<

<��

����

����

����

�����

�����

���

����

���V

���

���_

���V

���

����

���

����

����

WAT

ER P

IPIN

G D

IAG

RA

MS

]��

���

����

����

����

���

����

����

����

��:�

�����

���

���

����

1.

See

Mix

ing

Valv

es o

n pa

ge 1

4.2.

(

���*

����

����

���C

����

����

���

����

&_�

3.

See

Tem

pera

ture

-Pre

ssur

e R

elie

f Val

ve o

n pa

ge 1

5.

TH

RE

E W

AT

ER

HE

AT

ER

S, S

ING

LE T

EM

PE

RA

TU

RE

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

NLE

GE

ND

TEM

PE

RAT

UR

E &

PR

ES

SU

RE

RE

LIE

F VA

LVE

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

EX

PA

NS

ION

TAN

K

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

LIN

E TE

MPE

RATU

RECO

NTR

OL

TAN

K O

R L

INE

TE

MP

ER

ATU

RE

CO

NTR

OL

Page 73: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

73

4.

(��

�!�

����

(��

��<

����

����

��<

���'

}���

���

���

����

�&_

5.

(��

����

���+

����

!�

����

���

���

����

�_��

6.

J����

�<

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

�_�

����

����

���

7.

J����

�<

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�<

<��

����

����

����

�����

�����

���

����

���V

���

���_

���V

���

����

���

����

����

WAT

ER P

IPIN

G D

IAG

RA

MS

]��

���

����

����

����

���

����

����

����

��:�

�����

���

���

����

1.

See

Mix

ing

Valv

es o

n pa

ge 1

4.2.

(

���*

����

����

���C

����

����

���

����

&_�

3.

See

Tem

pera

ture

-Pre

ssur

e R

elie

f Val

ve o

n pa

ge 1

5.

FOU

R W

AT

ER

HE

AT

ER

S, S

ING

LE T

EM

PE

RA

TU

RE

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

NLE

GE

ND

TEM

PE

RAT

UR

E &

PR

ES

SU

RE

RE

LIE

F VA

LVE

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

EX

PA

NS

ION

TAN

K

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

LIN

E TE

MPE

RATU

RECO

NTR

OL

TAN

K O

R L

INE

TE

MP

ER

ATU

RE

CO

NTR

OL

Page 74: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

74

LIMITED WARRANTY���>��(<����!�������"�������������"��}������������������+JCJ�'*���@@�#�B��������������������������������1. THE TANKJ�����������^����������������������������������������:������}�<������� �������������������:������������������������������<���� ����������������"�����������������;@''��������������������������������"����������������������������������<�������������� ���������������������<�������������>��(<��������������������\�:����������������������<����������������������������(<���:���<�������������������\��������������������������������������������������J�������:������������������ ������������<�������\�:������������������������"�����>��(<�����������:������<�����������<����������������������������������"����������������������<�������� ���������������������������������� �����������������������<����������������������������<������\��������������������������������<���������������������� ����<�������������}���������<������������������������2. ALL OTHER PARTS

J���������>#'���������������������������������������������������"��������������������������:������}�<������� ����������������� ���������:�����<�������������<������"�����������������������������������������������������������������3. !>#*J�J>#(��#*�' !'��J>#(������������������������������������������������������������������������������������������< �������� �����������"������������������������"��������������������������:����������������������������������������J���������"�����<���������������������������:��:�"���������� ��!(����������:��� �������<�������(��������C����������'��������"�<�����:�� ��������������� ����������������������������������������������������������� � =&?������ ������������������������ � =�?����������<�������������}������������<�}�<<�������������������<������ � =$?��������������������������}���������������������������������������������� � =_?�������������������������������<����������������������������������<<���� � =�?������������������������ ��������"��������������������������<����� � =�?������������^�����:��������^����<���������<�������� � =%?���������������������:�������=�?������������ � =�?������������������������������������ � =�?��������K������(�����"���������������������������"�����!������� � =&�?��������������������������������������������\�������<<���������������������� � =&&?� ����������������������������������� �����������"�������������<:����}����������\����� ���������������� � =&�?����������������������������������������������������������������������� � =&$?�<����������������������������������������������������������<������������������������������������ ���������������������������������"�����<����"�� ���=�����������������?�����������������"�����������������������<��������<"�����������<���

�������������������������:������������������ ��������������������:����������:���������������� ���������:��������:����=������:��:�������?���������������������������������������������������

����������"�����������������:��<���������������������<����}�������������������������������������=�?������������������������<��� � � ������<���������������������������:��:����������������������������not����������� ���<����� 4. ('@6J!'��#*�@'��J@�' �'#('(K�����������<����������������������������������:�����������������<���������������������������������������������������� ���������������������(��������<���������� �����������<�������� ���+� ����������������:������<:��"��������������������������������������������������<������������ ��(�������"�����:���"���������"�������<���������:�����������������������������������������������<�����������<������������������� ���������������

������������<����������:���������������������������� ���� �����������������������������������������<�����������)�����<������\���������������������������������<����5. LIMITATIONS ON IMPLIED WARRANTIESJ<����������������"�������������������������<�������� �������<���������������������������������������������������<����������=&?����������������������������������������������(<���������������������<���������������������<��������������������"�������� :����<�������<����������������6. !+�JC��@>!'*K@'���� ����<� ����� ���� ��������� ����� �� ���������� ����� ���� ������� ��� ���� ���� ������ ������"� �� ����� ���� ����� ������� ��������� ���� ���������� ��������J��������������������� ��"���������������������� K�(��!��<��� !��������!��<���� � � � � ���>��(<����!�������� ���>��(<����'�����������+���� � � � � ���������������������������� ���>��]}"�$&��^�%���'����(������ � � � � ��������!���"��#�$%�&�� (��������=>�����?��#�����$� � � � � ����������&^=���?^$�$^��$�� ����������&^=���?����^����� ������������������������������������<�����������������������<�������������������������������������������<������������������ ���� ���������������� ��*�������������<���������<����� X��������^���������:��������� �����������7. *J(!+�JC'@(#>�>�;'@�' �@'((���@@�#�B�;�(�]''#�>@��J++�]'�C�*'�J#�]';�+V�>V��;'���@@�#�>@��J�;�@'(�'!���>��;'�C'@!;�#��]J+J�B�>V���;'��;'��'@��>@��;'�J#(��++��J>#"�>�'@��J>#"�@'��J@�>@�@'�+�!'C'#��>V��;'����'@��;'��'@���;'���@@�#�>@�(;�++�#>��]'�@'(�>#(J]+'�V>@����'@�*�C�W'"�+>((�>V�K('�>V��;'�K#J�"�J#!>#6'#J'#!'"�+>((�>@�*�C�W'��>��'@(>#�+��@>�'@�B�>@�>�;'@�!>#('`K'#�J�+�*�C�W'���;'���@@�#�>@�(;�++�#>��]'�+J�]+'�]B�6J@�K'�>V��;J(���@@�#�B�>@�>�;'@�J('�V>@�*�C�W'��>��#B��'@(>#(�>@��@>�'@�B"��;'�;'@�*J@'!��>@�J#*J@'!�"��#*��;'�;'@��@J(J#W�J#�!>#�@�!��>@��>@��� ���(<������������������������}����������<������������������������������\���������<���"�������� :����<�����������}�������<����������������� ������������������:�������������������������"�������<���������:��������������������:������<���������������

V����������������������������������������Keep it���@�������������������������������������������<����������������< ���������������������������������������

*����J��������¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾C����#�¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾Serial No.¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾

*��������#�<� ¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾�����#�¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾

*���������������¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾!��������(����¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾����!��¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾

FILL IN WARRANTY AND KEEP FOR FUTURE REFERENCE.

Page 75: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

75

Page 76: COMMERCIAL GAS WATER HEATERS - Hot Water from A. O. Smith · Do not expose water heater controls to excessive gas pressure. Do not obstruct water heater air intake with insulating

���������������������������"���������!���"��#�$%�&�����������(���������^��%^&��$���������������^_$$^��_������V�}�����^�__^�$��

�������������<