BUZZERS, RELAYS & TIMERS - · PDF file2008 MAZDA MX-5 Miata BUZZERS, RELAYS & TIMERS BUZZERS, ... See Fig. 9. Power Retractable Hardtop Control Module Left side of ... Power Steering

2008 MAZDA

MX-5 Miata

BUZZERS, RELAYS & TIMERS

BUZZERS, RELAYS & TIMERS LOCATION

CIRCUIT PROTECTION DEVICES

CIRCUIT PROTECTION DEVICES LOCATION

CONTROL UNITS

CONTROL UNITS LOCATION

Component LocationA/C Relay (AIR COND) In relay & main fuse block. See Fig. 1.Blower Relay (HEATER) In relay & main fuse block. See Fig. 1.Cooling Fan Relay No. 1 (COOLING FAN1) In relay & main fuse block. See Fig. 1.Cooling Fan Relay No. 2 (COOLING FAN2) In relay & main fuse block. See Fig. 1.Cooling Fan Relay No. 3 (COOLING FAN3) In relay & main fuse block. See Fig. 1.Drive-By-Wire Relay (ETV) In relay & main fuse block. See Fig. 1.Front Fog Light Relay (FOG) In relay & main fuse block. See Fig. 1.Fuel Pump Relay (CIRCUIT) In relay & main fuse block. See Fig. 1.Headlight Relay (HEAD) In relay & main fuse block. See Fig. 1.Horn Relay (HORN) In relay & main fuse block. See Fig. 1.Ignition Relay (IGNITION) In relay & main fuse block. See Fig. 1.Keyless Buzzer Front of luggage compartment. See Fig. 35.Main Relay (EGI) In relay & main fuse block. See Fig. 1.Rear Window Defroster Relay (DEFOG) In relay & main fuse block. See Fig. 1.Starter Relay (ST) In relay & main fuse block. See Fig. 1.TNS Relay (TAIL) In relay & main fuse block. See Fig. 1.Trunk Lid Opener Relay Lower rear center of luggage compartment. See Fig. 38.

Component LocationFuse Block Behind left end of dash. See Fig. 9.Relay & Main Fuse Block Left side of engine compartment. See Fig. 4.

Component LocationABS HU/CM Right front of engine compartment. See Fig. 16.DRL Control Module Behind left side of dash. See Fig. 40.DSC HU/CM Right front of engine compartment. See Fig. 17.Flasher Control Module Behind left side of dash. See Fig. 41.

2008 Mazda MX-5 Miata Grand Touring

2008 MAZDA MX-5 Miata



Microsoft

Thursday, July 09, 2009 5:57:55 PM Page 1 © 2005 Mitchell Repair Information Company, LLC.

Microsoft


MOTORS

MOTORS LOCATION

SENDING UNITS & SENSORS

SENDING UNITS & SENSORS LOCATION

Keyless Control Module Behind left end of dash. See Fig. 32.PCM Left front corner of engine compartment. See Fig. 9.Power Retractable Hardtop Control Module Left side of retractable top storage compartment. See Fig. 57.SAS Control Module Under front of center console. See Fig. 24.Seat Weight Sensor Control Module Under passenger seat. See Fig. 27.TCM Behind left end of dash. See Fig. 19.

Component LocationAirflow Mode Actuator Behind center of dash. See Fig. 22.Air Intake Actuator Behind right side of dash. See Fig. 22.Blower Motor Integral to blower unit, behind right side of dash. See Fig. 21.Cooling Fan Motor Behind radiator. See Fig. 5.Deck Panel Motor (Left) Left side of retractable top storage compartment. See Fig. 54.Deck Panel Motor (Right) Right side of retractable top storage compartment. See Fig. 52.Evaporative System Leak Detection Pump Under rear center of vehicle. See Fig. 14.Front Door Lock Actuator (Left/Right) In respective front door. See Fig. 36.Fuel Pump Unit Under rear center of vehicle. See Fig. 6.Mix Air Actuator Behind right side of dash. See Fig. 22.Power Outer Mirror (Left/Right) On front respective door. See Fig. 30.Power Window Motor (Left/Right) In respective front door. See Fig. 29.Roof Motor (Left) Left side of retractable top storage compartment. See Fig. 58.Roof Motor (Right) Right side of retractable top storage compartment. See Fig. 50.Starter Lower left side of engine. See Fig. 8.Trunk Lid Opener Lower rear center of luggage compartment lid. See Fig. 38.Washer Motor On washer fluid reservoir. See Fig. 43.Wiper Motor On left side of firewall. See Fig. 43.

Component LocationABS Wheel-Speed Sensor (Left Front) At left front wheel. See Fig. 16.ABS Wheel-Speed Sensor (Left Rear) At left rear wheel. See Fig. 16.ABS Wheel-Speed Sensor (Right Front) At right front wheel. See Fig. 16.ABS Wheel-Speed Sensor (Right Rear) At right rear wheel. See Fig. 16.Accelerator Pedal Position Sensor Top of accelerator pedal assembly. See Fig. 11.Brake Fluid Level Sensor In brake fluid reservoir. See Fig. 46.Camshaft Position Sensor Right rear of engine. See Fig. 12.



Microsoft


SOLENOIDS & SOLENOID VALVES

SOLENOIDS & SOLENOID VALVES LOCATION

SWITCHES

SWITCHES LOCATION

Combined Sensor Under rear of center console. See Fig. 18.Crankshaft Position Sensor On front of engine. See Fig. 12.Crash Zone Sensor At front center of engine compartment. See Fig. 24.Driver-Side Side Air Bag Sensor Near base of left "B" pillar. See Fig. 25.Engine Coolant Temperature Sensor Top rear of engine. See Fig. 13.Evaporator Temperature Sensor Behind right side of dash. See Fig. 22.Heated Oxygen Sensor (Front) Upstream side of catalytic converter. See Fig. 10.Heated Oxygen Sensor (Rear) Downstream side of catalytic converter. See Fig. 10.Knock Sensor Left front of engine. See Fig. 10.Manifold Absolute Pressure Sensor Left rear of engine. See Fig. 13.Mass Air Flow Sensor Near left front corner of engine. See Fig. 11.Passenger-Side Side Air Bag Sensor Near base of right "B" pillar. See Fig. 25.Seat Track Position Sensor Under driver's seat. See Fig. 26.Seat Weight Sensor (Left/Right) Under respective side of passenger seat. See Fig. 27.Steering Angle Sensor In steering column. See Fig. 17.Throttle Position Sensor Left front of engine. See Fig. 12.Transmission Fluid Temperature Sensor Inside valve control body on transmission. See Fig. 20.Turbine Sensor On transmission. See Fig. 19.Vehicle Speedometer Sensor On transmission or transaxle. See Fig. 13.

Component LocationEGR Valve Rear of engine. See Fig. 12.Fuel Injectors No. 1, 2, 3 & 4 Top of engine. See Fig. 13.Line Pressure Control Solenoid Inside valve control body on transmission. See Fig. 20.Magnetic Clutch Left front of engine, on A/C compressor. See Fig. 23.Oil Control Valve Right front of engine. See Fig. 12.Purge Solenoid Valve Left side of engine compartment. See Fig. 12.Shift Solenoids A, B, C, D, E, F & G Inside valve control body on transmission. See Fig. 20.TCC Control Solenoid Inside valve control body on transmission. See Fig. 20.Variable Intake Air Solenoid Valve Left side of engine. See Fig. 12.

Component LocationBack-Up Light Switch On transmission. See Fig. 42.Brake Switch Top of brake pedal assembly. See Fig. 14.Buckle Switch (Left/Right) On respective seat belt buckle. See Fig. 26.



Microsoft


MISCELLANEOUS

MISCELLANEOUS LOCATION

Clutch Pedal Position Switch Top of clutch pedal assembly. See Fig. 14.Deck Panel Limit Switch Right side of retractable top storage compartment. See Fig. 53.Door Lock-Link Switch (Left) In driver's door. See Fig. 34.Door Lock-Link Switch (Right) In passenger door. See Fig. 36.Door Switch (Left/Right) On respective "B" pillar. See Fig. 48.Hood Latch Switch Center front of engine compartment. See Fig. 36.Key Reminder Switch On steering column. See Fig. 45.Neutral Switch On transmission. See Fig. 14.Oil Pressure Switch On left side of engine. See Fig. 47.Parking Brake Switch At base of parking brake lever. See Fig. 47.Power Retractable Hardtop Limit Switch Right side of retractable top storage compartment. See Fig. 51.Power Steering Pressure Switch Left front of engine. See Fig. 13.Refrigerant Pressure Switch Right front of engine compartment. See Fig. 21.Starter Interlock Switch Behind left side of dash. See Fig. 8.Transmission Range Switch On transmission. See Fig. 8.Trunk Compartment Light Switch Right rear of luggage compartment. See Fig. 39.Trunk Lid Opener Cancel Switch Lower center rear of luggage compartment. See Fig. 38.

Component Location

Audio AmplifierRight side of luggage compartment. See Fig.

44.Check Connector In relay & main fuse block. See Fig. 1.Clock Spring In steering column. See Fig. 24.Coil Antenna (Immobilizer) In steering column. See Fig. 37.Condenser (Ignition) Right rear of engine. See Fig. 10.Condenser (Rear Window Defogger) At left "B" pillar. See Fig. 28.Data Link Connector 2 Under lower left side of dash. See Fig. 4.Driver-Side Air Bag Module In steering wheel. See Fig. 24.Driver-Side Pre-Tensioner Seat Belt Near base of left "B" pillar. See Fig. 25.Driver-Side Side Air Bag Module In driver's seat. See Fig. 25.Filament (Rear Window Defogger) Left side of rear window. See Fig. 28.Generator Right front of engine. See Fig. 7.Horn Behind left side of front bumper. See Fig. 49.Ignition Coils No. 1, 2, 3 & 4 Top of engine. See Fig. 10.Joint Connector (C-18) Behind left end of dash. See Fig. 15.Joint Connector (C-19) Behind left end of dash. See Fig. 15.Joint Connector (C-20) Behind center of dash. See Fig. 15.

Right front of luggage compartment. See Fig.



Microsoft


CONNECTORS

CONNECTORS LOCATION

Joint Connector (C-21) 44.

Joint Connector (C-22)Left side of retractable top storage

compartment. See Fig. 56.Keyless Antenna (Center) Under center console. See Fig. 33.Keyless Antenna (Instrument Panel) Behind right end of dash. See Fig. 35.Keyless Antenna (Left/Right) In respective door. See Fig. 34.

Keyless Antenna (Rear)Center rear of luggage compartment. See Fig.

34.Keyless Antenna (Rear No. 2) Rear of center console. See Fig. 33.Keyless Antenna (Trunk) Front of luggage compartment. See Fig. 33.Keyless Receiver Behind right side of dash. See Fig. 35.Keyless Receiver (Rear) Front of luggage compartment. See Fig. 32.Passenger-Side Air Bag Module Behind right side of dash. See Fig. 24.Passenger-Side Pre-Tensioner Seat Belt Near base of right "B" pillar. See Fig. 25.Passenger-Side Side Air Bag Module In passenger's seat. See Fig. 25.Power Metal Oxide Semiconductor Field Effect Transistor (Power MOS FET)

Behind right end of dash. See Fig. 21.

Seat Warmer (Left/Right) In respective seat cushion. See Fig. 31.Selector Lever Component Under center console. See Fig. 19.Transmission Fluid Temperature Connector Behind left side of dash. See Fig. 19.

Component LocationC-02 (14 Pin) Left side of engine. See Fig. 10.C-03 (56 Pin) Behind left side of dash. See Fig. 4.C-04 (14 Pin) Behind left side of dash. See Fig. 4.C-05 (Except M/T) (Gray, 56 Pin) Behind left kick panel. See Fig. 9.C-05 (M/T) (Gray, 14 Pin) Behind left kick panel. See Fig. 9.C-06 (12 Pin) Behind left kick panel. See Fig. 4.C-08 (Except M/T) (56 Pin) Behind left kick panel. See Fig. 6.C-08 (M/T) (14 Pin) Behind left kick panel. See Fig. 6.C-10 (A/T) (Blue, 40 Pin) Left side of engine compartment. See Fig. 8.C-10 (M/T) (Gray, 14 Pin) Left side of engine compartment. See Fig. 8.C-11 (56 Pin) Behind center of dash. See Fig. 4.C-12 (Yellow, 4 Pin) Behind center of dash. See Fig. 24.C-13 (Yellow, 4 Pin) Behind right kick panel. See Fig. 24.C-14 (56 Pin) Behind right end of dash. See Fig. 44.C-15 (32 Pin) Behind right kick panel. See Fig. 29.C-16 (32 Pin) Behind left kick panel. See Fig. 29.



Microsoft


GROUNDS

GROUNDS LOCATION

COMPONENT LOCATION GRAPHICS

C-17 (4 Pin) Left side of luggage compartment. See Fig. 34.

Component LocationG1 Left rear corner of engine compartment. See Fig. 2.G2 Behind left kick panel. See Fig. 2.G3 Left rear corner of engine compartment. See Fig. 2.G4 Right rear corner of engine compartment. See Fig. 2.G5 Behind left headlight assembly. See Fig. 2.G6 Behind right headlight assembly. See Fig. 2.G7 Center rear of engine compartment. See Fig. 2.G8 Behind right side of dash. See Fig. 3.G9 Behind left side of dash. See Fig. 3.G10 Behind center of dash. See Fig. 3.G11 Behind right kick panel. See Fig. 3.G12 Under passenger's seat. See Fig. 3.G13 Under front of center console. See Fig. 3.G14 Under driver's seat. See Fig. 3.G15 Under rear of center console. See Fig. 3.G16 Base of left "B" pillar. See Fig. 3.G17 Center rear of luggage compartment. See Fig. 3.G18 Base of right "B" pillar. See Fig. 2.G19 Left side of retractable top storage compartment. See Fig. 59.G20 Left side of retractable top storage compartment. See Fig. 55.

NOTE: Figures may show multiple component locations. Refer to appropriate table for proper figure references.



Microsoft


Fig. 1: Relay & Main Fuse Block Courtesy of MAZDA MOTORS CORP.



Microsoft


Fig. 2: Ground System Courtesy of MAZDA MOTORS CORP.



Microsoft


Fig. 3: Ground System Courtesy of MAZDA MOTORS CORP.



Microsoft


Fig. 4: Vehicle Overview Courtesy of MAZDA MOTORS CORP.



Microsoft


Fig. 5: Engine Compartment Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft





Microsoft


Fig. 8: Dash & Engine Compartment Courtesy of MAZDA MOTORS CORP.



Microsoft


Fig. 9: Engine Control System Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft





Microsoft





Microsoft





Microsoft


Fig. 14: Engine Control System Courtesy of MAZDA MOTORS CORP.



Microsoft


Fig. 15: Dash & Vehicle Overview Courtesy of MAZDA MOTORS CORP.



Microsoft


Fig. 16: Engine Compartment & Rear Of Vehicle Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft





Microsoft


Fig. 19: Automatic Transmission Control System Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft





Microsoft


Fig. 22: Dash Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft


Fig. 24: Air Bag System Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft


Fig. 26: Seats Courtesy of MAZDA MOTORS CORP.



Microsoft


Fig. 27: Passenger Seat Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft





Microsoft





Microsoft





Microsoft





Microsoft





Microsoft






Microsoft


Fig. 36: Engine Compartment & Vehicle Overview Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft


Fig. 38: Rear Of Vehicle Courtesy of MAZDA MOTORS CORP.



Microsoft


Fig. 39: Rear Of Vehicle Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft





Microsoft





Microsoft





Microsoft





Microsoft





Microsoft





Microsoft


Fig. 47: Engine Compartment & Vehicle Overview Courtesy of MAZDA MOTORS CORP.



Microsoft





Microsoft





Microsoft


Fig. 50: Retractable Top Storage CompartmentCourtesy of MAZDA MOTORS CORP.

Fig. 51: Retractable Top Storage Compartment Courtesy of MAZDA MOTORS CORP.




Microsoft






Microsoft





Microsoft






Microsoft






Microsoft


Documents

BUZZERS, RELAYS & TIMERS - · PDF file2008 MAZDA MX-5 Miata BUZZERS, RELAYS & TIMERS BUZZERS, ... See Fig. 9. Power Retractable Hardtop Control Module Left side of ... Power Steering