Amm 20mm Cannon Cartridges

An introduction to collecting 20 mm cannon cartridg es

© Anthony G Williams

This article first appeared in The Cartridge Researcher, the monthly bulletin of the European CartridgeResearch Association, in January and February 2007

The 20 mm automatic cannon first saw service during World War 1 but achieved its peak of success inWorld War 2, mainly as an aircraft and short-range anti-aircraft weapon, but also in some light armouredvehicles and small naval craft. Since the 1950s the popularity of this calibre has declined, as it has beenreplaced in most of its roles either by larger-calibre cannon or by guided missiles. However, 20 mm cannoncontinue to equip US fighter planes, remain popular for the short-range defence of warships and havefound new roles in arming helicopters.

A wide range of different cartridges was developed for 20 mm cannon, varying greatly in size and power.Only one saw service in WW1, but by WW2 some seventeen different rounds were in use; no less than fiveof them in Japan and four in Germany.Many of these disappeared soon after WW2, and today only four cartridges from that period remain inproduction. However, another four were introduced in the 1950s and these also remain in service today.

This basic guide is concerned only with identifying, and providing some brief historical notes about, thosecartridges which have seen service in the armed forces of at least one country. All of them have beenmade in different loadings – in some cases, in a very wide variety of them – so there is plenty of scope forcollectors. There are also some experimental rounds to search for, but these are much less common.

When collecting cannon ammunition it is of course necessary to ensure that you comply with the laws ofyour country. Projectiles containing explosives are banned in almost all circumstances, and there may alsobe restrictions concerning those with incendiary or tracer elements. The great majority of rounds whichbecome available to collectors have inert projectiles and most also have the propellant removed, but it isadvisable to check this. Projectiles are usually very firmly crimped into the cases, so rather than riskdamaging the case necks it is common practice to drill a hole in the side of the case to remove thepropellant. However, this process carries some risk and safety precautions are required, so do not attemptit unless you know what you are doing.

20x70RB

An introduction to collecting 20 mm cannon cartridges The 20 mm au... http://www.quarry.nildram.co.uk/an_introduction_to_collecting_20.htm

1 of 7 21/02/2013 22:36

This is the "granddad" of all 20 mm cannon cartridges, being used in the German Becker, developed duringWW1. About 360 guns had been delivered by the end of the war, with about a third of them fitted to aircraftand the rest issued to troops for anti-aircraft and anti-tank purposes. As well as the solid AP shot shown,an HE shell with a very prominent plunger-type nose fuze may be found.

A very similar cartridge is often confused with the Becker; this is for the German Ehrhardt, which enteredproduction by the end of WW1 but did not make it into service. It has a slightly wider case (see item494-17). 20x72RB

After WW1 the development of the Becker was continued, first by SEMAG of Switzerland and, at the end ofthe 1920s, by Oerlikon. The cartridge case was slightly enlarged and used in Oerlikon's Type F, or FF,which saw service in various air forces during the 1930s. The gun was most famous for its adoption by theJapanese Navy air force under the designation 20mm Type 99-1. Among other planes, this equipped theinitial marks of the Mitsubishi A6M "Zero" fighter.

20x80RB

The German Luftwaffe decided in the late 1930s to adopt a light cannon to equip its fighters and selectedthe Oerlikon FF, which they made under licence as the MG-FF. However, they made some changes to thegun and ammunition, including lengthening the cartridge case. During 1940 they introduced the"Minengeschoss" (mine shell), which was made by drawing the projectile body in the same way as acartridge case rather than drilling a cavity for explosives. This enabled very thin projectile walls to be made,doubling their HE/I capacity while also reducing their weight. The recoil characteristics were different,causing the gun to be modified and subsequently given the designation "MG-FFM" 20x82

The Lufwaffe only adopted the MG-FF as an interim measure while a more effective gun was beingdeveloped. This emerged in late 1940 as the Mauser MG 151 in 15x96 calibre. However, the advantagesof the high-capacity M-geschoss shell were soon realised, so the cartridge case was necked out andshortened to take the same shells as the MG-FFM. The gun designation was changed to MG 151/20, andthis remained the Luftwaffe's standard aircraft cannon from 1941 to the end of WW2. It was also used byFrance (latterly as a helicopter gun) until at least the 1970s. It was unusual in being offered with twodifferent priming systems: electric (for synchronised guns) and percussion. The yellow with green bandcolouring on the projectile shown (and that of the 20x80RB) indicate an HE shell with a self-destruct fuze,as typically used for home defence. 20x94

This cartridge was developed during WW2 for the Japanese Army air force's Ho-5 cannon, also known asthe 20mm Type 2. The gun was based on a slightly enlarged Browning M2. As designed, it offered animpressive combination of high performance and light weight, but the lack of high-quality steels forgun-making meant that the ammunition had to be significantly downloaded to reduce the stress on the gunmechanism. Despite this, the Ho-5 was the Army's standard aircraft cannon at the end of WW2. 20x99R

This cartridge was developed in the late 1930s for the Soviet ShVAK aircraft cannon. In fact, the gun wasfirst produced in 12.7x107R calibre, using a rimmed case which was quite different from the later (and stillcurrent) 12.7x108. However, that saw very little use, the cartridge soon being necked out to 20 mm calibre. The gun had a good rate of fire, but the performance of the cartridge was not impressive, as the light shellsheld little HE.As well as being extensively used in Soviet aircraft during WW2, the gun was also fitted tosome light tanks. At the end of the war, the Berezin B-20 appeared, a lighter gun chambered for the same


2 of 7 21/02/2013 22:36

cartridge. The cartridge has survived to this day because it is used in sub-calibre training devices. 20x101RB

When SEMAG took over the development of the Becker, they also introduced a more powerful versionusing a longer-cased 20x100RB cartridge. Oerlikon continued its developed as the Type L (later the FFL).This saw very limited use, except for its adoption by the Japanese Navy air force as the Type 99-2, with afractionally longer cartridge case. This supplemented the smaller Type 99-1, replacing it in service in latermarks of the A6M Zero, and was the Navy's standard aircraft cannon at the end of WW2. 20x105B

This cartridge was developed in the interwar years by Solothurn, a Swiss company closely associated withRheinmetall (Germany being banned from developing certain armaments by the Treaty of Versailles). As itis the smaller of the two 20 mm rounds developed by Solothurn it is commonly known as the "ShortSolothurn". It was developed in conjunction with the Lb 204 aircraft cannon, which saw little if any use, butsaw service in various armies in the Solothurn S18-100 series anti-tank rifles. It is therefore generally foundloaded with AP projectiles, of which there are various types. Rather bizarrely, one variant (the S18-350)was used as an aircraft gun by the Dutch air force, despite offering only semi-automatic fire. 20x105This Rheinmetall-Borsig development was the successor to the 20x105B, the change apparently beingmade to improve the reliability of ammunition feeding. It was used in the MG 204 aircraft gun of the late1930s, which saw only very limited service in some Luftwaffe seaplanes. 20x110RB

After Oerlikon took over the development of the SEMAG guns in the late 1920s, they developed an evenlarger version of the gun around this cartridge. It was known as the Oerlikon Type S (or FFS in its aircraftversion) and is probably the mostly widely used 20mm cannon ever made. As an aircraft gun it saw onlylimited use with the French air force in the 1930s, but it was adopted by the RN and USN and became theirstandard light AA gun in WW2. It lasted in RN service certainly until the late 1980s if not later, and remainsin use around the world to this day. 20x110

This cartridge was developed in France in the mid-1930s for use in the Hispano-Suiza HS 404 aircraft gun.It is similar to the 20x110RB described above, except that the rim is the same diameter as the body and theshoulder is sharper. The gun was adopted by the RAF as the 20mm Hispano, remaining in service untilreplaced by the 30mm Aden in the mid-1950s, and was also used by US aircraft in and after WW2. Thelast version of the USAF's gun, the M24, had electric rather than percussion priming. This gun and thepostwar HS 804 have been widely used as aircraft and AA guns, and the ammunition remains inproduction. The cartridge was also used in the postwar Bofors m/45 and m/49 aircraft guns. The thirdphoto shows a postwar Swiss API round.


3 of 7 21/02/2013 22:36

20x113

This rivals the 20x105 as being one of the least-used cannon rounds. It was developed in Finland in themid-1930s by Aimo Lahti for his L-34 "boat gun"; a light automatic cannon fitted to about a dozen patrolboats. Various experimental versions were developed, and belted cases may also be found. 20x120

This cartridge was developed in Denmark in the 1920s for the Madsen automatic cannon, offered invarious mountings for aircraft, AA and anti-tank use, although only successful in the AA role. It was neverthe primary armament of any major army, but was widely used in WW2 and remained in service fordecades afterwards. The ammunition for the gun was made in several countries, mostly notably in the UKby Kynoch, as was usually the case for Madsen ammunition as they had no ammunition productionfacilities of their own. 20x125

This Japanese Army cartridge was first used in the Type 97 anti-tank rifle introduced in the late 1930s, butduring WW2 the mechanism of this semi-automatic gun was adapted to create an automatic aircraftcannon. This saw limited use in two versions; the Ho-1 for flexible mountings and the Ho-3 for fixed use.The guns were too slow-firing to be considered successful and were replaced by the Ho-5, which waslighter and had twice the rate of fire. 20x138B

This was the second of the 20mm cannon cartridges developed by Solothurn in the 1930s, and is knownas the "Long Solothurn" round. It proved far more successful than the 20x105B, being primarily used in thehighly successful FlaK 30 and 38 AA guns which were extensively used by German forces in WW2 (andremained in service in some nations for decades after the war). It was also used in the KwK 30 and 38 lightAFV guns, and in the Solothurn S18-1000 series anti-tank rifles.As well as being used in these German and Swiss weapons, it was used in the Finnish Lahti L39 anti-tankrifle and L40 AA gun, and in the Italian Breda M35 and Scotti cannon. A very wide range of ammunitionwas developed for this gun, including M-geschoss shells and Pzgr 40 tungsten-cored AP.


4 of 7 21/02/2013 22:36

20x139 FMK

This was developed in Switzerland in the late 1930s for the FMK aircraft gun (which saw limited use) andthe Flab Kan 38 AA gun, which remained in use for some time after the war. This cartridge is very similar tothe postwar 20x139 cartridge for the Hispano-Suiza Hs 820, but the rim is thinner and the cases of brass.The example shown here is a drill round. 20x142

This was the ammunition used for the Japanese Army's Type 98, their standard light AA gun from the late1930s to the end of WW2. This powerful round was also credited with some anti-tank capability and socame with AP as well as HE projectiles. There was an earlier Type 94 AA gun which used even larger(20x158) ammunition, but this saw very little use before being replaced by the Type 98. 20x145R

This was a Bofors development for their m/40 AA and anti-tank gun. It was in effect a scaled-down versionof their famous 40 mm, but did not achieve anywhere near the same success and the cartridges are nowuncommon. This case is fitted with a non-standard dummy projectile.

20x102

This American cartridge is probably the most widely used 20mm round in service today, due to the fact thatit is chambered in the M61 (Vulcan) "gatling" rotary cannon fitted to US fighters, the naval Phalanx close-inweapon system, and some AA vehicles. It is also chambered in the US M39 revolver cannon (as fitted tomany 1950s USAF fighters, and still used in the F-5), the current French GIAT 20M621, and the CzechZPL-20, a version of the Russian 23mm GSh-23 twin-barrel aircraft gun rechambered for the NATO round.The history of this cartridge goes back to WW2 when a very powerful .60 inch anti-tank rifle wasdeveloped. This never saw service but the 15.2x114 ammunition was used in various experimental aircraftguns developed during WW2, notably the T17 which was a modified Mauser MG 151. After the war the .60cartridge remained the USAAF's preferred basis for new aircraft guns, and the first versions of whatbecame the M39 and the M61 were chambered for it. However, the advantages of explosive shells werefinally accepted by the USAF and the case was necked out to 20mm and slightly shortened to keep theoverall length the same. Many different loadings in several countries have been developed for this round,including APDS (for the Phalanx). The original USAF ammunition was the M50 series; this was largely


5 of 7 21/02/2013 22:36

replaced by the more streamlined, multi-purpose PGU-28/B from the late 1980s, but the older rounds havebeen reinstated because of concerns over premature explosions in the barrel. All versions of the 20x102use electric priming.

20x110 USN

The USN did not initially share the USAAF/USAF's interest in new revolver and rotary guns. Instead, theyimproved the performance of the Hispano by speeding up its rate of fire and rechambering it for a powerfulnew round, the 20x110 USN. This was developed by taking the base dimensions of the 20x102, butstretching the case length to the maximum which the Hispano could handle. It hardly seemed worth theeffort as the performance is only marginally better than the 20x102. Like its smaller brother, it uses electricpriming. The modified Hispano was designated the Mk 12 and was the USN's standard aircraft cannonfrom the mid 1950s until the 1970s when it was finally replaced by the M61. As well as the Mk 12, the newround was chambered in a remarkable gun, the Mk 11. This is a twin-barrel eight-chamber revolver with amixture of recoil and gas operation and with partly smoothbored barrels. It was used only in the Mk 4gunpod. This round remains in production but is steadily going out of use as the planes which carry theguns are retired, and it is likely to become obsolete soon.

20x128

This is one of the two European 20mm rounds to have been introduced since WW2. It was developed byOerlikon in the 1950s for their KAA cannon, intended as a successor to the famous 20mm Type S. Thecartridge is far more powerful, and the gun fires twice as fast. It has not matched the level of success of theolder Oerlikon, although it has achieved numerous sales, primarily as a naval AA gun. It was rapidlyadopted by the RN, after the Falklands War revealed the inadequacy of close-in defence guns, in theGAM-B01 mounting. The cartridge has also been adopted, in electric rather than percussion-primed form,for the unusual Spanish Meroka volley gun, used as a naval close-in weapon system.

20x139

This is the other postwar European 20mm round, and a close rival for the 20x128. It was originallyintroduced by Hispano-Suiza in the 1950s for their HS 820 cannon, which they saw as the naturalsuccessor to the HS 804. Hispano-Suiza was taken over by Oerlikon in about 1970, after which the HS 820was renamed the Oerlikon KAD. The cartridge has been more successful than the 20x128, mainly becauseof its use in the popular Rheinmetall Rh 202 cannon. It is also chambered in the GIAT F2 / 20M693, whichis made in South Africa as the Vektor G1-2. These guns have seen various uses, as naval and land-basedAA, light AFV armament and in helicopters.

20x83.5

This little cartridge is in fact a slightly modified version of the 20x82, and is interchangeable with it. It ismade in South Africa, where the Mauser MG 151/20 cannon is still in production as the Vektor GA-1. Thelight weight, small size and low recoil of this gun make it popular for fitting to light vehicles and smallhelicopters. The cartridge is also chambered in the Mechem NTW-20 anti-materiel rifle.

METRICCALIBRE

RIMDIAM. MM

BODYDIAM.

MM

PROJ.TYPE/

WEIGHT GM

M.VEL.M/SEC

MUZZLEENERGYJOULES

NAME /WEAPONS CHAMBERED IN

20x70RB 20.2 21.9 AP/130 490 15,600 Becker aircraft, early Oerlikon F

20x72RB 19.0 21.9HE/128 550-600 19-23,000 Oerlikon FF, Japanese Navy Type 99-1,

Oerlikon SSG (550 m/s)

20x80RB

19.0 22.0HE/134HEI/115HE/92

600585700

24,10019,70022,500

MG-FF aircraftMG-FFM aircraft “ M-Geschoss

20x82 25.2 25.2HE/115

HE(M)/92HE/111

710800720

29,00029,40028,800

Mauser MG 151/20 (electric or percussion);HE(M) = M-Geschoss- Vektor GA-1, Mechem NTW-20 rifle (SA)


6 of 7 21/02/2013 22:36

20x94 24.9 25.0HEI/79

APT/120730700

21,00029,400

IJA 20mm Type 1 (Ho-5) aircraft (these arefinal loadings; earlier ones were c. 820 m/s,33,300 j)

20x99R 25.2 21.8HE/97 860 35,900 ShVAK, B-20 aircraft (+ subcalibre training),

Helenius rifle

20x101RB 19.0 21.9HE/127HE/128

675750

28,90036,000

Oerlikon L (675 m/s)/FFL (100mm caselength); IJN Type 99-2

20x102 29.5 29.1HE/101

APDS/1001,0301,100

53,60060,500

M39, M61 (Vulcan), M197, GIAT M 621,Ford Tigerclaws, (APDS is M149 Phalanxround). Electric primed.

20x105B 25.0 25.0AP/140 730 37,300 Solothurn (Short): S18-100 ATR & S18-350

aircraft, Lb 204

20x105 25 26.2 HE/134 750 37,700 MG 204 aircraft

20x110RB 21.9 24.9HE/122 830 42,000 Oerlikon FFS + S series, Polsten AA,

SSG-36 ATR (750 m/s)

20x110

24.8 24.8

HE/130"

HE/102

880850945

50,30046,90045,500

HS404/804; AN/M2+M3 (US), m/45+49 (S),M1955 (YU), G 360 (IS), RT20 rifle(Croatia).850 m/s = UK Mark V (short barrel)945 m/s = US M24 (electric primed),

20x110 USN 29.5 29.3110 1010 56,100 Mark 11 + Mark 12 aircraft.

(Mk 100 series ammunition - electric)

20x113 28.0 28.0136 800 43,500 20mm Lahti L34 naval (exp. belted version

also)

20x120 28.9 29.0AP/154

HE/126-112780

840-89046,80044,400

20mm Madsen AA/AT/aircraft

20x125 28.5 28.7AP/162HEI/127

790820

50,50042,700

IJA 20mm Type 97 AT rifleIJA 20mm Ho-1, Ho-3 aircraft

20x128 32.0 32.3HE/120

APCR/1021,0501,300

66,10086,200

Oerlikon KAA, KAB (+ 50m/s for KAB).APCR (electric) = Meroka CIWS

20x138B 27.0 27.0

HE/119AP/147AP/101HE/134

900795975950

47,00046,50048,00060,500

Solothurn (Long): Flak 30+38 AA, KwK30+38 AFV, MG C/30 L air, Breda M 35,Scotti + Lahti L40 AA, S18-1000/1100 andLahti ATRs. 134g load = MG C/30 L

20x139 FMK 28.5 28.5HE/131AP/147

1,010930

66,80063,800

WW2 FMK aircraft and WW2+postwarFlab Kan 38 AA. (Rim 2.6mm thick)

20x139

28.5 28.5

HE/120APDS/108

1,1001,250

72,60084,400

HS 820/Oerlikon KAD (US M139),Rheinmetall Rh 202, GIAT M 693, MauserMK20, HS 827 exp.(Rim 3.5mm thick)

20x142 33.4 33.5 HET/132 950 59,600 IJA 20mm Type 98 AA

20x145R 29.5 25.4AP/145 815 48,200 20mm Bofors m/40 AA/AT (+ subcalibre

training)

HOME


7 of 7 21/02/2013 22:36

Documents

Amm 20mm Cannon Cartridges