3 PFR Shiv Narain - environmentclearance.nic.inenvironmentclearance.nic.in/writereaddata/Online/TOR/0_0_06_Jan_2016... · Shri Shiv Narain S/o Shri Khachera Page no.3 Adult Education

Masonry Stone (Cheja Pathar) Mining Project, M.L. No. 66/2011, ML Area 1.0 ha. Near Village:

Gangora, Tehsil: Pahari, District: Bharatapur (Rajasthan)

Pre-feasibility Report

Shri Shiv Narain S/o Shri Khachera Page no.1

PRE – FEASIBILITY REPORT

1.0 EXECUTIVE SUMMARY

The proposal for Masonry Stone (Cheja Pathar) Mining Project, M.L. No. 66/2011, ML Area 1.0

ha. Near Village: Gangora, Tehsil: Pahari, District: Bharatapur (Rajasthan).

This is new mining lease and letter of Intent for the same has been issued by Superintendent

Mining Engineer Bharatpur Circle, Bharatpur vide letter no. SME/Bharat./Ri.Sha./

MM/Rehabi./Applicant/66/11/2012/6515 dated 20.11.2012 and Environmental Clearance is

required as per EIA Notification dated 2006, as amended time to time, this project is comes

under A Category. Table-1

Salient features of the Project

S. No. Particulars Details

A. Mining Lease Details

1. Name of the Project Masonry Stone (Cheja Pathar) Mining Project, M.L. No.

66/2011, ML Area 1.0 ha

2. Mineral Masonry Stone (Cheja Pathar)

3. Mining Lease Number M.L. No.66/2011

4. Mining Lease Area 1.0 ha

5. Lease Holder Shri Shiv Narian S/o Shri Khachera

B Location

6. Village Gangora

7. Tehsil Pahari

8. District Bharatpur

9. State Rajasthan

10. Latitude & Longitude Pillars Latitude Longitude

A 27°42'23.26"N 77°00'48.74"E

B 27°42'19.92"N 77°00'55.00"E

C 27°42'18.52"N 77°00'54.06"E

D 27°42'21.86"N 77°00'47.8"E

C. Other details

11. Cost of the project Rs. 10 Lakh

12. Cost for Environmental

Protection Measures

Rs. 0.50 lakh per annum

13. Seismic Zone II

ENVIRONMENTAL MANAGEMENT PLAN

AIR POLLUTION CONTROL

�� Plantation will be developed within ML areas and will also be developed

outside the ML area equal to 33% of the lease area.





�� Periodical water spraying on the roads will be done.

�� Proper maintenance of all machines will be carried out that will control

emission of gaseous pollutant.

WATER MANAGEMENT

�� There is no surface water body in and around the mining lease area.

�� The rain water collected in mining pit will be used in plantation and

dust suppression.

NOISE POLLUTION CONTROL

�� Proper maintenance of all machines will be carried out which will

reduce noise generation during operations.

LAND RECLAMATION

At the end of five year of mine, total excavated area will be about 0.77 ha,

which will be converted in to water reservoir, 0.01 ha area will be used

for storage of top soil which will be used for plantation, 0.01 ha area for

overburden dump, 0.01 ha area used as roads and 0.10 ha will be

covered under greenbelt.

SOLID WASTE MANAGEMENT

� The generated solid waste will be used for construction and

maintenances of kucha approach road time to time. There will no waste

dump at the end of life of the mine.

GREEN BELT DEVELOPMENT

Green Belt/plantation will be developed equal to 33% of total lease area.

The trees will be planted at suitable spacing to encourage proper growth

around the lease boundary. The dead plants will be replaced by fresh

plants. Native Plant species will be planted

SOCIO ECONOMIC IMPROVEMENT

�� As the mining activities will increase, better employment opportunity.

�� Semi skilled & unskilled workers will be recruited from the nearby

villages.





�� Adult Education programme are proposed for up-gradation of literacy

level.

�� The leesee will associate awarness programe.

HEALTH & SAFETY

�� Protective respiratory devices will be provided to personnel working in

dusty areas with adequate training.

�� The lessee will associate in various health and safety awarness program

in nearby villages.

2.0 INTRODUCTION OF THE PROJECT/ BACKGROUND INFORMATION

(i) Identification of Project and Project Proponent

Masonry Stone (Cheja Pathar) Mining Project, M.L. No. 66/2011, ML Area 1.0

ha. near Village: Gangora, Tehsil: Pahari, District: Bharatapur (Rajasthan).

letter of Intent has been issued by Superintendent Mining Engineer Bharatpur

Circle, Bharatpur vide letter no. SME/Bharat./Ri.Sha./

MM/Rehabi./Applicant/66/11/2012/6515 dated 20.11.2012

(ii) Brief Description of the Nature of Project

This proposal for Masonry Stone (Cheja Pathar) Mining Project, M.L. No.

66/2011, ML Area 1.0 ha. Near Village: Gangora, Tehsil: Pahari, District:

Bharatapur (Rajasthan).

This is new mining lease and letter of Intent for the same has been issued by

Superintendent Mining Engineer Bharatpur Circle, Bharatpur vide letter no.

SME/Bharat./Ri.Sha./MM/Rehabi./Applicant/66/11/2012/6515 dated

20.11.2012 and Environmental Clearance is required as per EIA Notification

dated 2006, as amended time to time, this project is comes under B Category.

(iii) Need for the Project & Its Importance to the Country/ Region

The mineral Masonry stone (Cheja Pathar) is used in various construction

activities and will be sold to nearby markets to fulfill the requirements of the

local people.

(iv) Demand – Supply Gap

Considering the demand of mineral sufficient availability of the mineral in the

area, it is essential to have Masonry stone (Cheja Pathar) mine to sustain the

supply of mineral for construction purpose.





(v) Imports vs. Indigenous Production

It is a cheap mineral used in construction activities in rural areas therefore

export is not possible

(vi) Export Possibility

There is no export possibility as these mineral is quite cheap and locally

available in abundance and used in rural areas.

(vii) Domestic/Export Markets

These minerals have only domestic market and will fulfill the requirement of

local. The stone may also be supplied to stone crusher proposed to be installed

outside the lease area.

(viii) Employment Generation (Direct and Indirect) due to the Project

The total 29 skilled and unskilled manpower needed to run the mine

3.0 PROJECT DESCRIPTION

(i) Type of Project Including Interlinked And Independent Projects, If Any

This is opencast semi-mechanized mining project. There is no interlinked or

interdependent project based on mineral produced. The mineral will be sold

directly.

(ii) Location (map showing general location, specific location, and project

boundary & project site layout) with coordinates





Figure1: Location Map





(iii) Details of Alternate Sites Considered

No alternative site has been taken into consideration due to availability of

mineral resources in the area and.

(iv) Size and magnitude of operation

The Production of Masonry stone (Cheja Pathar) will be 84530 TPA from the

mine located near Village: Gangora, Tehsil: Pahari, District: Bharatapur

(Rajasthan)

(v) Project Description with Process Detail

(1) Salient features along with project vicinity details of the Mining

project is given below:

Table - 2

Salient Features of the Project

S. No. Particulars Details

1. Name of the Project Masonry Stone (Cheja Pathar) Mining Project, M.L.

No. 66/2011, ML Area 1.0 ha.

2. Mineral Masonry stone (Cheja Pathar)

3. Mining Lease Number M.L. No. 66/2011

4. Mining Lease Area 1.0 ha

5. Lease Holder Shri Shiv Narain S/o Shri Khachera

6. Method of mining Opencast Semi-Mechanized

7. Mineable Reserves 3,10,000 Tonnes

8. Life of the Mine 5 Years

9. Bench Height & Width 6 m

10. Ultimate Pit Slope angle 45°

11. Ultimate working depth 25 meter

12. Elevation Range 276 mRL to 270 mRL

13. General Ground Level 180 mRL

14. Ground Water table 25 meter bgl

15. Total excavated area at the

conceptual stage

0.77 ha

16. Total area converted into

water reservoir at the

conceptual stage

0.77 ha

(2) GEOLOGY OF THE AREA

Regional Geology





The regional stratigraphic succession of rocks is as follows

REGIONAL STRATIGRAPHIC SUCCESSION

Recent Soil

Post Delhi Pegmatite, Granite, Albetite

Delhi Super group Ajabgarh Group Phylite inter-banded with

quartzite, quartzite, ,

Carbonaceous phyllite,

Carbonaceous shale,

Conglomerate Spongy

quartzite

Alwar group Flaky quartzite, Massive

quartzite, schist Phylite

Local Geology

Recent Soil

Post delhi Absent

Delhi

Super

Group

Ajabgarh Group Gritty Quartzite and quartzite

(3) Method of Mining

The mining will be done by opencast method thus the working area proposed in

slices of 1.5 meters hieght each. Four slices are considered in a bench. The height &

width of bench will be 6 meters at a time. Hydraulic excavator/loader and tippers

are proposed for removal and loading of mineral in tippers/trucks.

The haul/ approach roads will be provided up to the proposed working, site

services, site of dump and site of stock from the nearest tar road.

The mineral is proposed to transport by tractor trolley and tippers.

Table-3

EXTENT OF MECHANIZATION

S. Machinery Number

1. Hydraulic Excavator/Loader with rock breaker

arrangement

1

2. Air compressor tractor mounted or wheel

mounted

1

3. Jack hammer 2

4. Drill roads as required

5. Water tank trroley munted 1

6. Tippers 2





7. Hand tools as required

Source: Draft mining plan

(4) PROPOSED YEAR WISE PRODUCTION DETAILS OF THE NEXT FIRST FIVE YEARS

The proposed Year-wise production plan for next five years is mentioned in the

table given below:

Table – 4

Year Wise Production for Next Five Years

Year Quartzite (Masonry Stone)

(tones)

I 72800

II 82990

III 84530

IV 66150

V 30880

Source: Source: Draft mining plan

(5) LOADING & TRANSPORT

Tyre mounted Hydraulic machinaries will be deployed from time to time as and

when required. Trucks and tracor troley will be deployed for transportation of

masonry stone from working to consumer.

(6) WASTE GENERATION & DISPOSAL

Around 33720 tonnes of waste will be come across during period of mining

plan. The waste will be used in construction and maintenance of approach

roads, construction of site services. The waste also lifted by local habitants for

constructing the walls along the agriculture field.

(7) CONCEPTUAL PLAN

At the end of the five years of mine 3, 10,000 tonnes of Masonry stone (Cheja

Pathar) mineral will be excavated from the lease area . At the five year of life of

mine, total excavated area will be about 0.77 ha, which will be converted in to

water reservoir, 0.01 ha area will be used for storage of top soil which will be

used for plantation, 0.01 ha area for overburden dump, 0.01 ha area used as

roads and 0.10 ha will be covered under greenbelt.

(vi) Raw Material Required Along With Estimated Quantity, Likely Source,

Marketing Area of Final Products, Mode of Transport of Raw Material and

Finished Product

This is Masonry stone (Cheja Patthar) Mining Lease. The mineral will be used

for construction purposes. No raw material will be required to dependent

industries.

(vii) Resources Optimization/ Recycling and Reuse Envisaged in the Project, if

any, should be briefly Outlined

� No waste water will be generated from mining operation





� Domestic sewage water generated from office toilet will be disposed in soak

pits via septic tank.

(viii) Availability of Water Its Source, Energy /Power Requirement and Source

A. Water requirement:

Total water requirement for the project will be 3.0 KLD which will be sourced

from nearby villages.

B. Power requirement:

The electric power will not be use for the process of mining. Only HSD Fuel will

be required for operating machineries.

(ix) Quantity of Waste to Be Generated (Liquid and Solid) And Scheme for

Their Management/Disposal:

Domestic sewage water generated from office toilet will be disposed in soak

pits via septic tank.

4.0 SITE ANALYSIS

(i) Connectivity

The lease area about 6.5 km. in East direction from Pahari. Dispensary is available at

Chhapra at distance of 2.5 km. in NE direction and Senior Secondary school is

available at Pahari at distance of 6.5 km. in East direction. Nearest Railway station

is Alwar Railway Station at a distance of ~42.0 km. in SW direction from Mining Lease

area. Nearest Airport is Indra Ghandi International Air Port, New Delhi at a distance of

around ~95 km. in North direction from Mining Lease area.

(ii) Land Form, Land Use and Land Ownership

Existing Land Use Pattern

The total ML area of 1.0 ha comprises of Government Waste Land (Gair Mumkin Pahar).

(iii) Topography

The lease area comprises part of a mount trending north-south. The highest contour is

276 mRL and lowest is 270 mRL. The mining lease area is 1.0 ha which a Government

land (Gair Mumkin Pahar).

(iv) Existing Land Use Pattern {Agriculture, Non-Agriculture, Forest, Water Bodies

(Including Area Under CRZ)}, Shortest Distances From The Periphery Of The

Project To Periphery Of The Forests, National Park, Wild Life Sanctuary, Eco

Sensitive Areas, Water Bodies (Distance From The HFL Of The River), CRZ. In Case

Of Notified Industrial Area, A Copy Of The Gazette Notification

Table – 5

Environmental Settings

S. No. Particular Details

1. Nearest Village Village Gangora at a distance of 1.0 km. in NE

direction from the Mining lease area.

2. Nearest city/ town Pahari at a distance of 6.5 km. in East direction





from the Mining lease area.

3.

National Highway/State Highway SH-22 is approx 7.0 km in SE direction from the

mine site.

4. Nearest Railway Station Alwar Railway Station at a distance of ~42.0 km. in

SW direction from Mining Lease area.

5.

Nearest Airport Indra Ghandi International Air Port, New Delhi at a

distance of around ~95 km. in North direction from

Mining Lease area.

6. Archaeological Important Place None, within 10 km radius area of mine site.

7. Ecological Sensitive Areas

(National Park, Wildlife

Sanctuary, Biosphere Reserve

etc.)

There is no National Park, Wild Life Sanctuaries,

Biosphere Reserves, Tiger Reserves, Wildlife Corridors,

etc. within 10 km radius

8. Reserved/Protected Forest

within 10 km radius

There is no reserve/protected forest are present within

10 km radius area.

9. Nearest River / water body There is no reserve/protected forest are present within

10 km radius area.

Source: preliminary site visit

Masonry Stone (Cheja Pathar) Mining Project, M.L. No. 66/2011, ML Area 1.0 ha. Near Village: Gangora, Tehsil: Pahari, District: Bharatapur (Rajasthan)


Shri Shiv Narainr S/o Shri Khachera page no 11

Figure 2: Key plan




Shri Shiv Narain S/o Shri Khachera page no 12

(v) Existing Infrastructure:

There is no building & structure within mining lease area except some

vegetations existing on the lease area which will be cleared when required.

Total lease area is Government Land (Gair Mumkin Pahar).

The lease area about 6.5 km. in East direction from Pahari. Dispensary is

available at Chhapra at distance of 2.5 km. in NE direction and Senior

Secondary school is available at Pahari at distance of 6.5 km. in East direction.

Nearest Railway station is Alwar Railway Station at a distance of ~42.0 km. in

SW direction from Mining Lease area. Nearest Airport is Indra Ghandi

International Air Port, New Delhi at a distance of around ~95 km. in North

direction from Mining Lease area.

5.0 PLANNING BRIEF

(i) Planning Concept (Type of Industries, Facilities, and Transportation etc.)

Town and Country Planning/Development Authority Classification

This is a mining Project

(ii) Population Projection

Manpower required will be engaged from nearby areas. No significant influx of

people is anticipated in the area.

(iii) Land Use Planning

The extent of proposed mining lease area is 1.0 ha. The area comprises of

Government Land (Gair Mumkin Pahar). At the five year of life of mine, total

excavated area will be about 0.77 ha, which will be converted in to water

reservoir, 0.01 ha area will be used for storage of top soil which will be used

for plantation, 0.01 ha area for overburden dump, 0.01 ha area used as roads

and 0.10 ha will be covered under greenbelt.

(iv) Assessment of Infrastructure Demand (Physical & Social)

Lessee will assess the demand of infrastructure (Physical & Social) in nearby

area of the mine site and same will be developed under social work

(v) Amenities/Facilities

Mining Management will develop the Amenities/Facilities in the nearby area of

the mine site as per requirement of local people of the nearby area under

corporate social responsibility programs.





6.0 PROPOSED INFRASTRUCTURE

(i) Residential Area (Non Processing Area)

This is not required as mine workers comes from nearby villages. Rest

shelter to the workers will be provided outside the lease area.

(ii) Green Belt

Green Belt/plantation will be developed equal to 33% of total Mining lease

area. The dead plants will be replaced by fresh plants. Native Plant species

will be planted.

(iii) Connectivity

The lease area about 6.5 km. in East direction from Pahari. Dispensary is

available at Chhapra at distance of 2.5 km. in NE direction and Senior

Secondary school is available at Pahari at distance of 6.5 km. in East

direction. Nearest Railway station is Alwar Railway Station at a distance of

~42.0 km. in SW direction from Mining Lease area. Nearest Airport is Indra

Ghandi International Air Port, New Delhi at a distance of around ~95 km. in

North direction from Mining Lease area.

(iv) Water Management (Source & Supply of water)

Total water requirement for the project will be 3.0 KLD which will be used

for domestic as well as dust supression purpose and sourced from nearby

village .

(v) Sewerage System

Domestic sewage water generated from office toilet will be disposed in soak

pits via septic tank. Outside discharge is not envisaged.

(vi) Industrial Waste Management

No industrial waste water will be generated from this mine during mining

operation.

(vii) Solid Waste Management

Around 33720 tonnes of waste will be come across during period of mining

plan. The waste will be used in construction and maintenance of approach

roads, construction of site services. The waste also lifted by local habitants

for constructing the walls along the agriculture field.

(viii) Power Requirement & Supply/Source

Electric power will not be required in mining operations.





7.0 REHABILITATION AND RESETTLEMENT (R & R) PLAN

(i) Policy To Be Adopted (Central/State) In Respect Of The Project Affected

Persons Including Home Oustees, Land Oustees And Landless Laborers

(Brief Outline To Be Given)

Not Applicable as the lease area falls in government land (Gair Mumkin

Pahad).

8.0 PROJECT SCHEDULE & COST ESTIMATES

(i) Likely Date Of Start Of Construction And Likely Date Of Completion (Time

Schedule For The Project To Be Given)

The mining activity will be started after obtaining Environmental Clearance

from MoEF, New Delhi and acquiring the valid mining lease from Mines and

Geology Department of the State Government.

(ii) Estimated Project Cost Along With Analysis In Terms Of Economic

Viability of the Project

Cost of the project : Rs. 10 lakh

Cost for Environmental Protection Measures : Rs. 0.5 lakhs

9.0 ANALYSIS OF PROPOSAL

�� The Masonry Mining Lease will result in growth of the surrounding areas by

increasing direct and indirect employment opportunities in the region

including ancillary development and supporting infrastructure. Special

emphasis on Financial and Social benefits will be given to the local people

including tribal population, if any, in the area.

�� Development of social amenities will be in the form of medical facilities,

education to underprivileged and creation of self help groups.

�� No major adverse effect on environment is envisaged as the required

mitigation measures are inbuilt in the project.

10.0 ENVIRONMENTAL MANAGEMENT PLAN

10.1.1 AIR POLLUTION CONTROL

�� Wet drilling with sharp drill bits will be done for drilling to reduce generation

of dust.

�� Green Belt will be developed on periphery of the lease boundary and haul

roads,

�� Periodical water spraying on the haul roads will be done.





10.1.2 WATER MANAGEMENT

�� There is no surface water body in and around the mining lease area.

�� The rain water collected in mining pit will be diverted in the abandoned

existing and the area used in spraying.

�� Domestic waste water generated from office toilet will be disposed in soak pits

via septic tank.

10.1.3 NOISE POLLUTION CONTROL

�� Proper maintenance of all machines will be carried out which will reduce noise

generation during operations.

�� Workers exposed to high noise levels will be provided with ear defenders.

10.1.4 LAND RECLAMATION

�� Total mining lease area is 1.0 hectares.

�� At the five year of life of mine, total excavated area will be about 0.77 ha, which

will be converted in to water reservoir, 0.01 ha area will be used for storage of

top soil which will be used for plantation, 0.01 ha area for overburden dump,

0.01 ha area used as roads and 0.10 ha will be covered under greenbelt.

10.1.5 SOLID WASTE MANAGEMENT

Waste will be used as a second grade mineral and sold out by the lessee as well as

used for maintenance of roads and top soil will be used for plantation purpose.

10.1.6 GREEN BELT DEVELOPMENT

�� Local species will be preferred for plantation

�� Tree guards will be provided for production

�� Green Belt/plantation will be developed equal to 33% of total Mining lease

area. The dead plants will be replaced by fresh plants. Native Plant species will

be planted.

Documents

3 PFR Shiv Narain - environmentclearance.nic.inenvironmentclearance.nic.in/writereaddata/Online/TOR/0_0_06_Jan_2016... · Shri Shiv Narain S/o Shri Khachera Page no.3 Adult Education