View
1
Download
0
Category
Preview:
Citation preview
The
2020 EPA Automotive Trends Report
Greenhouse Gas Emissions,
Executive Summary
Fuel Economy, and Technology since 1975
EPA-420-S-21-001 January 2021
ES-2
Executive Summary This annual report is part of the U.S. Environmental Protection Agency’s (EPA) commitment to provide the public with information about new light-duty vehicle greenhouse gas (GHG) emissions, fuel economy, technology data, and auto manufacturers’ performance in meet-ing the agency’s GHG emissions standards.
EPA has collected data on every new light-duty vehicle model sold in the United States since 1975, either from testing performed by EPA at the National Vehicle and Fuel Emissions Laboratory in Ann Arbor, Michigan, or directly from manufacturers using official EPA test procedures. These data are collected to support several important national programs, in-cluding EPA criteria pollutant and GHG standards, the U.S. Department of Transportation’s National Highway Traffic Safety Administration (NHTSA) Corporate Average Fuel Economy (CAFE) standards, and vehicle Fuel Economy and Environment labels. This expansive data set allows EPA to provide a uniquely comprehensive analysis of the automotive industry over the last 45 years.
The carbon dioxide (CO2) emissions and fuel economy data in this report fall into one of two categories. The first is compliance data, which are measured using laboratory tests required by law for CAFE and adopted by EPA for GHG compliance. The second is estimated real-world data, which are measured using additional laboratory tests to capture a wider range of operating conditions (including hot and cold weather, higher speeds, and faster accelerations) encountered by an average driver. This report shows real-world data, except for discussions specific to GHG compliance on pages ES-9 to ES-12 in this summary and Section 5 of the report.
All data in this report for model years 1975 through 2019 are final and based on official data submitted to EPA and NHTSA as part of the regulatory process. In some cases, this report will show data for model year 2020, which are preliminary and based on data provided to EPA by automakers prior to the model year, including projected production volumes. However, the preliminary model year 2020 data included in this report were generally reported to EPA before the outbreak of COVID-19, and any associated impacts on the automobile industry. Therefore, the projected model year 2020 data may change significantly before being finalized.
This report has been updated to reflect recent regulatory changes, including the Safer Affordable Fuel-Efficient (SAFE) Vehicles rule finalized by EPA and NHTSA in April of 2020. The SAFE rule established new light-duty GHG standards for model years 2021-2026, which are generally beyond the scope of this report. To download the full report, or to explore the data using EPA’s interactive data tools, visit the report webpage at www.epa.gov/automotive-trends.
https://www.epa.gov/automotive-trends
ES-3
•
New vehicle estimated real-world CO2 emissions increased slightly from last year’s record low In model year 2019, the average estimated Figure ES-1. Estimated Real-World Fuel real-world CO2 emission rate for all new Economy and CO2 vehicles increased slightly (less than 1%) from the record low achieved in model year 2018. The new vehicle emission rate increased 3 g/mi to 356 g/mi. Fuel economy decreased by 0.2 miles per gallon to 24.9 mpg, or slightly below the record high achieved in model year 2018.
Since 2004, CO2 emissions have decreased 23%, or 105 g/mi, and fuel economy has increased 29%, or 5.6 mpg. Over that time, CO2 emissions and fuel economy have improved in twelve out of fifteen years. The trends in CO2 emissions and fuel economy since 1975 are shown in Figure ES-1.
Preliminary data suggest improvements in model year 2020. Average estimated real-world CO2 emissions are projected to fall 12 g/mi to 344 g/mi, and fuel economy is Re
al-W
orld
CO
2 Em
issi
ons
(g/m
i) R
eal-W
orld
Fue
l Eco
nom
y (M
PG)
24
20
16
700
600
500
400
projected to increase 0.8 mpg to 25.7 mpg. 1975 1985 1995 2005 2015 2025 Projected data are shown in Figure ES-1 as a Model Year dot because the values are based on manu-facturer projections rather than final data.
All vehicle types are at or near record low CO2 emissions; however, market shifts away from carsand towards sport utility vehicles (SUVs) and pickupshave offset some of the fleetwide benefits In this report, vehicles are disaggregated into five vehicle types: sedan/wagon, car SUV, truck SUV, pickup truck, and minivan/van. The distinction between car and truck SUVs is based on regulatory definitions where SUVs that are 4WD or above a weight threshold
24.9MY
MPG 2019
356MY
g/mi 2019
ES-4
l ------- ·1
l ~ l ___ _ ··· l ,___, ·I
l _____ _____,•I
l ......----___~-I '---r-------r--~--------------- I I I I I I I I I I
(6,000 pounds gross vehicle weight) are generally regulated as trucks and classified at truck SUVs for this report. The remaining 2WD SUVs are subject to car standards and classified as car SUVs.
All five vehicle types are at or near record high fuel economy and record low CO2 emissions in model year 2019. Truck SUVs had the largest improvement in fuel economy (0.4 mpg) and CO2 emissions (6 g/mi), followed by car SUVs and sedans/wagons. Pickups and mini-vans had a small drop in fuel economy and increase in CO2 emissions, but remain close to record high fuel economy and record low CO2 emissions set in model year 2018.
The overall new vehicle market continues to move away from the sedan/wagon vehicle type towards a combination of truck SUVs, car SUVs, and pickups. Sedans and wagons fell to 33% of the market, well below the 50% market share they held as recently as model year 2013, and far below the 80% market share they held in 1975. Conversely, truck SUVs reached a record 37% of the market in model year 2019, car SUVs reached a record 12% of the market, and pickups have increased in recent years to 16% of the market.
The trend away from sedans/wagons, which remain the vehicle type with the highest fuel economy and lowest CO2 emissions, and towards vehicle types with lower fuel economy and higher CO2 emissions has offset some of the fleetwide benefits that otherwise would have been achieved from the improvements within each vehicle type.
Figure ES-2. Production Share and Fuel Economy by Vehicle Type
Seda
Ca
n/Wagon
r SUV
Car
s
Truck SUV
Truc
ks
Miniv
Pi
an/Van
ckup
30
20
10 30
20
30.9
27.5
23.5
22.4
19.0
100%
75%
50%
25%
Sedan/Wagon
Car SUV
Rea
l-Wor
ld M
PG
10 30
Truck 20 SUV
Minivan/Van
10 30
20
10 30
20 Pickup 0%
10 1975 1985 1995 2005 2015 1975 1985 1995 2005 2015
Model Year Model Year
Prod
uctio
n Sh
are
Truc
ks
Car
s
ES-5
Most manufacturers have improved CO2 emissions and fuel economy over the last 5 years Manufacturer trends over the last five years are shown in Figure ES-3. This span covers the approximate length of a vehicle redesign cycle, and it is likely that most vehicles have undergone design changes in this period, resulting in a more accurate depiction of recent manufacturer trends than focusing on a single year. Changes over this time period can be attributed to both vehicle design and changing vehicle production trends.
Over the last five years, ten of the fourteen largest manufacturers selling vehicles in the U.S. decreased new vehicle estimated real-world CO2 emission rates. Between model years 2014 and 2019, Kia achieved the largest reduction in CO2 emissions, at 31 g/mi, followed by Honda and Hyundai. Tesla was unchanged because their all-electric fleet produces no tail-pipe CO2 emissions. Three manufacturers increased new vehicle CO2 emission rates; Mazda had the largest increase, at 13 g/mi, followed by General Motors (GM) and Ford.
Eleven of the fourteen largest manufacturers increased fuel economy over the same period. Tesla had the largest increase in fuel economy (measured in miles per gallon of gasoline equivalent), due to the introduction of the Model 3 in model year 2017. The Model 3 is now Tesla’s most efficient and highest production vehicle. Of the remaining manufacturers, Kia had the largest increase in fuel economy, again followed by Honda and Hyundai. Fuel economy fell for three manufacturers; Mazda had the largest drop in fuel economy, fol-lowed by GM and Ford.
For model year 2019 alone, Tesla’s all-electric fleet had by far the lowest tailpipe CO2 emissions and highest fuel economy of all large manufacturers. Tesla was followed by Honda and Hyundai. Fiat Chrysler Automobiles (FCA) had the highest new vehicle average CO2 emissions and lowest fuel economy of the large manufacturers in model year 2019, followed by GM and Ford.
Average new vehicle horsepower continues toincrease rapidly, while weight is increasing slowly Vehicle weight and horsepower are two fundamental vehicle attributes that influence a vehicle’s CO2 emissions and fuel economy. For vehicles with internal combustion engines, increased weight or horsepower generally results in higher CO2 emissions and lower fuel economy, all else being equal. Weight is also an important metric for electric vehicles, as increased vehicle weight will generally result in lower fuel economy. However, electric vehicles produce zero tailpipe emissions regardless of weight or horsepower. Over time, automotive technology innovation has been applied to vehicle design with differing emphasis between vehicle weight, power, CO2 emissions and fuel economy (Figure ES-4).
Figure ES-3. Changes in Estimated Real-World Fuel Economy1 and CO2 for Large Manufacturers
Fuel Economy (MPG), 2014 − 2019 CO2 Emissions (g/mi), 2014 − 2019
Tesla ~ ............. _ ____,, ____ ....,..........I t.___-----r--------r-------r----"'T"""""""
- • Ill( - • ~ - ____. ◄--
~ -,.. ...-
- +-- ____.. - .. ◄ - .. .. - ► ◄-- .. ◄-- .... ◄-.
◄ .. . ◄ .. . .. ◄--. I-♦ ~
a I I I I I I I
45 70 95 120 50 100 150 200
90.2 118 0
Honda
Hyundai
Subaru
Kia
Mazda
Nissan
BMW
VW
Toyota
Mercedes
Ford
GM
FCA
All Manufacturers
27.0 28.9 307 329
311 327
312 325
316
306 320
329 332
337 341
338
27.2 28.5
27.3 28.4
28.1
27.8 29.0
26.7 27.0
26.2
23.1 23.7
22.5 22.7
22.5 22.7
20.7 21.2
26.1
25.8
348
345 350
374 387
391 395
391 395
418 428
356 369
26.1
26.1
25.7
25.4
24.1 24.9
346
20 24 28 32 300 350 400 450
1Electric vehicles, including Tesla’s all-electric fleet, are measured in terms of miles per gallon of gasoline equivalent, or mpge.
ES-7
•
In the two decades before model year 2004, technology innovation was generally used to increase vehicle power, and weight increased due to changing vehicle design, increased vehicle size, and increased content. During this period, average new vehicle fuel economy steadily decreased and CO2 emissions correspondingly increased. However, since model year 2004, technology has been used to increase both fuel economy (up 29%) and power (up 16%), while reducing CO2 emissions (down 23%). Average vehicle weight in model year 2019 was only slightly above 2004 but has increased slowly Figure ES-4. Percent Change in Fuel Economy, over the last several years Horsepower, and Weight Since 1975 and is currently at the highest point on record. 100%
One additional vehicle metric 75% not shown in Figure ES-4 is vehicle footprint, or the area enclosed by the four tires. Footprint is the basis for determining regulatory standards under the GHG and CAFE regulations. Since C
hang
e Si
nce
1975
50%
25%
0% EPA began tracking footprint in model year 2008, average footprint has increased −25%
Real-World Fuel Economy
Horsepower
Weight
1975 1980 1985 1990 1995 2000 2005 2010 2015 2020about 4%, and is at the highest point on record at 50.8 square feet. Model Year
Manufacturers continue to adopt a wide array ofadvanced technologies Innovation in the automobile industry has led to a wide array of technology available to manufacturers to achieve CO2 emissions, fuel economy, and performance goals. Figure ES-5 illustrates projected manufacturer-specific technology adoption, with larger circles representing higher adoption rates, for model year 2020. The figure shows preliminary model year 2020 technology projections to provide insight on a quickly changing industry, even though there is some uncertainty in the preliminary data.
Engine technologies such as turbocharged engines (Turbo) and gasoline direct injection (GDI) allow for more efficient engine design and operation. Cylinder deactivation (CD) allows for use of only a portion of the engine when less power is needed, while stop/start
ES-8
·- • • • • • -·· • • • • ._ • --- • • • • • •· • • ♦ • ♦
• • - • .. • • • ♦ • ♦ • • • ♦ • • ♦ ·- • •
systems can turn off the engine entirely at idle to save fuel. Hybrid vehicles use a larger bat-tery to recapture braking energy and provide power when necessary, allowing for a smaller, more efficiently operated engine. The hybrid category includes “full” hybrid systems that can temporarily power the vehicle without engaging the engine and smaller “mild” hybrid systems that cannot propel the vehicle on their own. Transmissions that have more gear ratios, or speeds, allow the engine to more frequently operate near peak efficiency. Two categories of advanced transmissions are shown in Figure ES-5: transmission with seven or more discrete speeds (7+Gears), and continuously variable transmissions (CVTs). Many of the technologies in Figure ES-5 have been adopted rapidly by the industry. For example, GDI was used in fewer than 3% of vehicles as recently as model year 2008 but is projected to be in more than 55% of vehicles in model year 2020. Electric vehicles (EVs), plug-in hybrid vehicles (PHEVs), and fuel cell vehicles (FCVs) are a small but growing percentage of new vehicles.
Figure ES-5. Technology Share for Large Manufacturers, Model Year 2020
Tesla
Honda
Hyundai
Subaru
Kia
Mazda
Nissan
BMW
VW
Toyota
Mercedes
Ford
GM
FCA
All Manufacturers
Turbo GDI CVT 7+Gears CDStopStart Hybrid PHEV/ EV/FCV
99%
15%
66%
83%
73%
62%
67%
100%
100%
57%
98%
2%
97%
99%
18%
78%
45%
52%
15%
9%
20%
98%
7%
23%
3%
91%
24%
10%
44%
18%
60%
7%
2%
93%
53%
86%
69%
9%
22%
28%
83%
52%
13%
86%
1%
5%
8%
70%
30%
31%
86%
94%
31%
98%
91%
81%
62%
23%
42%
27%
100%
12%
42%
91%
20%
5%
6%
4%
2%
15%
12%
7%
4%
1%
1%
1%
1%
2%
2%
0%
2%
0%
100%
1%
4%
55%35% 14%42%28% 51% 7% 4%
ES-9
--I J I
II
All fourteen large manufacturers achieved compliancewith the GHG standards through model year 2019 EPA’s GHG program is an averaging, banking, and trading (ABT) program. An ABT program means that the standards may be met on a fleet average basis, manufacturers may earn and bank credits to use later, and manufacturers may trade credits with other manufac-turers. This provides manufacturers flexibility in meeting the standards while accounting for vehicle design cycles, introduction rates of new technologies and emission improve-ments, and evolving consumer preferences.
Within a model year, manu- Figure ES-6. GHG Credit Balance for Large facturers with average fleet Manufacturers, after Model Year 2019 emissions lower than the standards generate credits, and manufacturers with average fleet emissions higher than the standards generate deficits. Any manu-facturer with a deficit at the end of the model year has up to three years to offset the deficit with credits earned in future model years, or purchased from another manufacturer. Because credits may not be carried forward unless deficits from all prior model years have been resolved, a positive credit balance means compli-ance with the current and all
FCA
Honda
Toyota
Subaru
GM
Nissan
Hyundai
Ford
Mazda
BMW
VW
Kia
Mercedes
Tesla
Credits Expiring 2021 Credits Expiring 2022 Credits Expiring 2023 Credits Expiring 2024
0 10 20 30 40previous model years of the GHG Credits (Tg of CO2)program.
The fourteen largest manufacturers ended model year 2019 with a positive credit balance and are thus in compliance for model year 2019 and all previous years of the GHG program. The accumulated credits shown in Figure ES-6 will be carried forward for use in future model years. Total credits are shown in teragrams (one million Megagrams), and account for man-ufacturer performance compared to their standards, expected vehicle lifetime miles driven, and the number of vehicles produced by each manufacturer, for all years of the GHG program.
50
T Hond
aes
la
Suba
ru oy
ota
Nissa
n
Merce
des
Kia
Mazd
a
Hyun
dai
VW
BMW FC
A Fo
rd GM
T
Most large manufacturers used banked or purchasedcredits to maintain compliance in model year 2019 Manufacturers used different combinations of technology improvements, banked credits, and purchased credits to achieve compliance in 2019. Tesla, Honda, and Subaru achieved compliance based on the emission performance of their vehicles, without requiring additional banked credits. All other large manufacturers used banked or purchased credits, along with technology improvements, to achieve compliance in model year 2019.
Figure ES-7 illustrates the performance of individual large manufacturers in model year 2019 compared to their overall standard, in terms of an average vehicle grams per mile emission rate. This “snapshot” provides insight into how the large manufacturers per-formed against the standards in model year 2019. However, it does not account for the fact that all large manufacturers had credits available from previous years, or they were able to purchase credits to ensure their credit balance remained positive after model year 2019.
Figure ES-7. Performance and Standards by Manufacturer, Model Year 2019
Below Standard Above Standard
Standard Performance
212 222 235 234 226 280 247 241 282 242 223 303 282
−236
214 227 234 233 229 218
272 239 225
265
223 200
275
231
Com
plia
nce
GH
G (g
/mi) 200
0
−200
ES-10
ES-11
The regulations include an incentive multiplier that allowed each 2019 model year electric vehicle to be counted as two. The impact of this incentive is particularly evident for Tesla, because Tesla produces only electric vehicles. Before including the multiplier, Tesla’s model year 2019 performance value was -22 g/mi, due to their 0 g/mi tailpipe emissions and 22 g/mi of air conditioning and off-cycle credits. The multiplier lowered Tesla’s performance value another 214 g/mi, which is equivalent to the difference between Tesla’s standard and tailpipe emissions, resulting in a performance value of -236 g/mi, as shown in Figure ES-7.
The overall industry used credits for the fourth yearin a row to maintain compliance, but there remains alarge bank of credits for future years Under the GHG Program, manufacturers were able to accrue “early credits,” before the GHG standards took effect in model year 2012, for early deployment of efficient vehicles and technology. For the next four years, manufacturers continued to generate credits, as the industry GHG performance was below the industry-wide average standard. In the last four years, the industry GHG performance has been above the industry-wide average standard, resulting in net withdrawals from the bank of credits to maintain compliance. In model year 2019, the industry maintained overall GHG performance at 253 g/mi, while the standard fell from 252 g/mi to 246 g/mi. The gap between the standard and GHG perfor-mance grew from 1 g/mi in model year 2018 to 7 g/mi in model year 2019. To maintain compliance the industry drew down their industry-wide total credit bank by about 24 Tg, which was less than 10% of the total available credit balance. The overall industry emerged from model year 2019 with a bank of more than 229 teragrams (Tg) of GHG credits avail-able for future use, as seen in Figure ES-8.
In addition to the balance of the industry-wide bank, the expiration date and distribution of credits are also important factors. Credits earned in model year 2017 or beyond have a five-year life, while all prior credits (two-thirds of the current bank) will expire at the end of model year 2021. At the present time, an active credit market is enabling manufacturers to purchase credits to demonstrate compliance, with eight manufacturers selling credits, ten manufacturers purchasing credits, and approximately 70 credit trades since 2012. However, the availability of current or future credits is inherently uncertain.
1:
Figure ES-8. Industry Performance and Standards, Credit Generation and Use
260
240
280
300 C
ompl
ianc
e G
HG
(g/m
i) Standard Performance
299
292 287
274
263
258
252 246
287
278 273
267 271
262
253 253
2012 2013 2014 2015 2016 2017 2018 2019
158
33
42
43 25
-24-4 -16
-28
229
0
100
200
300
GH
G C
redi
ts (T
g of
CO
2 ) 250
150
50 Credits Earned Credits Used Total
Credits expiring in 2021
Early Credits 2012 2013 2014 2015 2016 2017 2018 2019 Carry to (2009−2011) 2020
Model Year
The automobile industry continues to innovate,improve, and meet the GHG standards The analysis here is a snapshot of the data collected by EPA in support of several important regulatory programs and is presented with the intent of providing as much transparency to the public as possible. The data show the change and innovation in the industry since model year 1975, and the manufacturers’ performance under EPA’s GHG standards.
To download the full report, or to explore the data using EPA’s interactive data tools, visit the report webpage at www.epa.gov/automotive-trends.
ES-12
https://www.epa.gov/automotive-trends
ES-13
This technical report does not necessarily represent final EPA decisions, positions, or validation of compliance data reported to EPA by manufacturers. It is intended to present technical analysis of issues using data that are currently available and that may be subject to change. The purpose of the release of such reports is to facilitate the exchange of technical information and to inform the public of technical developments.
These data reflect the most current available data. Historic data have been adjusted, when appropriate, to reflect the result of compliance investigations by EPA or any other corrections necessary to maintain data integrity. This edition of the report supersedes all previous versions.
The Department of Justice and EPA have reached a settlement with Mercedes based on the sale of certain diesel vehicles equipped with devices to defeat the vehicles’ emission control systems. This report includes the original fuel economy and GHG certification values of these vehicles, as EPA believes this is a reason-able representation of how these vehicles were expected to perform. The affected vehicles are certain model year 2009 to 2016 diesel vehicles from Mercedes, and account for less than 1% of production in all affected years. For more information about this settlement, please see www.epa.gov/enforcement/daimler-ag-and-mercedes-benz-usa-llc-clean-air-act-civil-settlement.
https://www.epa.gov/enforcement/daimler-ag-and-mercedes-benz-usa-llc-clean-air-act-civil-settlementhttps://www.epa.gov/enforcement/daimler-ag-and-mercedes-benz-usa-llc-clean-air-act-civil-settlement
Recommended