View
228
Download
0
Category
Preview:
Citation preview
SAFETY DATA SHEET – NTD-04 Issue 02
According to Regulation (EC) No 1907/2006 (REACH)
Version 2.1 Revision date: 22/02/2013
Page 1 of 8
Section 1 IDENTIFICATION OF THE SUBSTANCE AND OF THE COMPANY/UNDERTAKING
1.1 Product identifier:
Identification on the label/Trade name: Bumper Prep Pad
CAS No.: See section 3
EC No.: See section 3
Index Number: None
Product Number: None
REACH Pre-registration No.: None
Additional identification: DC-BPP-K12
1.2 Relevant identified uses of the substance and uses advised against:
1.2.1 Identified uses:
Preparation of unprimed plastic prior to paint
1.2.2 Uses advised against:
No data available
1.3 Details of the supplier of the safety data sheet:
Finishing Brands UK Ltd
Ringwood Road
Bournemouth
Dorset. BH11 9LH
Tel: 0044 (0) 1202 571111
Fax: 0044 (0) 1202 573488
Email: tech-enquiry@carlisleft.eu
1.4 Emergency telephone Number:
0044 (0) 1865 407333 (24/7 English speaking only)
Section 2 HAZARDS IDENTIFICATION
2.1 Classification of the substance or mixture
2.1.1 Classification according to Regulation (EC) No 1272/2008 [CLP] (see section 2.2 for full text of
H phrases)
Serious eye irritation (category 2), H319 Specific target organ toxicity — single exposure (category 3), H335
2.1.2 Classification according to Directive 67/548/EEC (see section 16 for full text of risk phrases)
Xi Irritant to eyes/respiratory system R36/37
2.1.2.1 The most important adverse physicochemical effects:
No data available
2.1.2.2 The most important adverse human health effects:
Causes serious eye irritation
May cause respiratory irritation
2.1.2.3 The most important adverse environmental effects:
No data available
SAFETY DATA SHEET – NTD-04 Issue 02
According to Regulation (EC) No 1907/2006 (REACH)
Version 2.1 Revision date: 22/02/2013
Page 2 of 8
2.2 Label elements
Signal Word (S):
Warning
Hazard Statement:
H319: Causes serious eye irritation
H335: May cause respiratory irritation
Precautionary Statement:
P261: Avoid breathing dust/fume/gas/mist/vapours/spray
P264: Wash hands thoroughly after handling
P271: Use only outdoors or in a well-ventilated area
P280: Wear protective gloves/protective clothing/eye protection/face protection
P304 + P340: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable
for breathing
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water for several minutes; Remove
contact lenses, if present and easy to do. Continue rinsing
P312: Call a POISON CENTER or doctor/physician if you feel unwell
P337 + P313: If eye irritation persists: Get medical advice/attention
P403 + P233: Store in a well-ventilated place. Keep container tightly closed
P405: Store locked up
P501: Dispose of contents/container in according with local regulation
2.3 Other hazards
None
Section 3 COMPOSITION/INFORMATION ON INGREDIENTS
3.1 Substances
Product identifier type in accordance with Article 18(2) of Regulation (EC) No 1272/2008
Substance/Mixture: Mixture
Substance Name CAS No. EC No. REACH
Registration
No.
Weight %
content
Classification
Feldspar 68476-25-5 270-666-7 - 38.30 H319, H335
Silicon Carbide 409-21-2 206-991-8 - 25.00 None Poly/Nylon backing None None - 15.00 None Cured Phenol-
formaldehyde resin
9003-35-4 None - 10.00 None
Quartz 14808-60-7 215-684-8 - 4.30 None Polyethylene Glycol 400 25322-68-3 203-473-3 - 3.60 None Glycerin (Glycerol)
99.5% Technical Grade
56-81-5 200-289-5 - 1.40 None
Triethanolamine (TEA)
Industrial Grade
102-71-6 203-049-8 - 0.90 None
C12-15 PARETH-2 68131-39-5 None - 0.70 H318, H400
Mica 12001-26-2 215-479-3 - 0.40 None
Sodiumsulfosuccinate 577-11-7 209-406-4 - 0.40 H315, H318
SAFETY DATA SHEET – NTD-04 Issue 02
According to Regulation (EC) No 1907/2006 (REACH)
Version 2.1 Revision date: 22/02/2013
Page 3 of 8
Section 4 FIRST AID MEASURES
4.1 Description of first aid measures:
4.1.1 In case of inhalation:
Not a likely route of entry. Move affected person to fresh air. If irritation or difficulty breathing
develops or persists, get immediate medical attention.
4.1.2 In case of skin contact:
Flush skin and hair with running water (and soap if available). Seek medical attention in event of
irritation.
4.1.3 In case of eyes contact:
In case of contact, immediately flush eyes with copious amounts of water for at least 15 minutes.
Seek medical attention if irritation develops or persists.
4.1.4 In case of ingestion:
Not an expected route of exposure. If swallowed, get immediate medical attention or advice. Do
not induce vomiting.
4.2 Most important symptoms and effects, both acute and delayed
Causes serious eye irritation
May cause respiratory irritation
4.3 Indication of any immediate medical attention and special treatment needed
Immediately call a POISON CENTER or doctor/physician.
Section 5 FIRE-FIGHTING MEASURES
5.1 Extinguishing media:
Suitable extinguishing media: Use extinguishing media suitable for surrounding area.
Unsuitable extinguishing media: No data available
5.2 Special hazards arising from the substance or mixture Thermal decomposition products include carbon monoxide and carbon dioxide. When exposed to
high temperatures, free quartz can change crystal structure to form tridymite (above 870°C) or
crystobalite (1470°C) which have greater health hazards than quartz.
5.3 Advice for fire-fighters:
As in any fire, wear self-contained breathing apparatus pressure-demand.
MSHA/NIOSH (approved or equivalent) and full protective gear
Section 6 ACCIDENTAL RELEASE MEASURES
6.1 Personal precautions, protective equipment and emergency procedures:
Refer to section 8 of SDS for personal protection details.
6.2 Environmental precautions:
To avoid possible contamination of the environment, do not discharge into any drains, surface
waters or ground waters.
SAFETY DATA SHEET – NTD-04 Issue 02
According to Regulation (EC) No 1907/2006 (REACH)
Version 2.1 Revision date: 22/02/2013
Page 4 of 8
6.3 Methods for containment and cleaning up:
Wear appropriate protective equipment and clothing during clean-up. Wipe up any effluent with
water, clean area thoroughly.
6.4 Reference to other sections:
Refer to section 8 of the SDS
6.5 Additional information: No data available
Section 7 HANDLING AND STORAGE
7.1 Precautions for safe handling:
7.1.1 Protective measures:
Avoid contact with skin and eyes. Use this product with adequate ventilation for nuisance dust.
Wash thoroughly after handling.
7.1.2 Advice on general occupational hygiene:
Do not eat, drink or smoke when using this product. Wash hands thoroughly after handling.
Remove contaminated clothing and protective equipment before entering eating areas.
7.2 Conditions for safe storage, including any incompatibilities:
Keep product in package until ready for use
Store in a cool dry place
7.3 Specific end use(s):
No data available
Section 8 EXPOSURE CONTROL/PERSONAL PROTECTION
8.1 Control parameters:
8.1.1 Occupational exposure limits:
Substance
CAS No.
Occupational Exposure
Limit Value (8-hour
reference period)
Occupational Exposure Limit
Value (15-minute reference
period)
Ppm mg/ m3 ppm mg/ m
3
Quartz, respirable
dust, (see
crystalline
silica)
14808-60-7 - 0.1 - -
Mica
total inhalable dust
respirable dust
12001-26-2
-
-
10
0.8
-
-
-
-
Glycerol, mist 56-81-5 - 10 - -
Triethanolamine 102-71-6 - 5 - -
Silicon carbide
total inhalable dust
respirable dust
409-21-2
-
-
10
4
-
-
-
-
SAFETY DATA SHEET – NTD-04 Issue 02
According to Regulation (EC) No 1907/2006 (REACH)
Version 2.1 Revision date: 22/02/2013
Page 5 of 8
8.1.2 Additional exposure limits under the conditions of use:
No data available
8.1.3 DNEL/DMEL and PNEC-Values:
No data available
8.2 Exposure controls
8.2.1Appropriate engineering controls:
Provide local and general exhaust ventilation to effectively remove and prevent buildup of any
vapors or dust generated from the handling of this product.
8.2.2 Individual protection measures, such as personal protective equipment:
Eye/face protection: Safety glasses with side shields are recommended.
Hand protection: Wear impervious gloves.
Body protection: Normal work clothing (long sleeved shirts and long pants) is recommended.
Respiratory protection: None required for normal recommended use.
8.2.3 Environmental exposure controls:
Avoid discharge into the environment.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
9.1 Information on basic physical and chemical properties
Appearance: Pre-saturated nylon-backed coated
abrasive material(Solid)
Colour: No data available
Odour: No data available
Odour threshold: No data available
pH: No data available
Melting point/range : 165-170 °C(CAS#577-11-7)
Boiling point/range (°C) : > 200°C(CAS#577-11-7)
Flash point (°C) : No data available
Evaporation rate: No data available
Flammability (solid, gas): This product is combustible at
high temperatures.
Ignition temperature (°C) : No data available
Upper/lower flammability/explosive limits: No data available
Vapour pressure (20°C) : No data available
Vapour density: No data available
Relative Density: 1.146 g/cm³(27.4 °C)
(CAS#577-11-7)
Water solubility (g/l) at 20°C : 8.17 g/L(PH=5) (CAS#577-11-7)
n-Octanol/Water (log Po/w) : No data available
Auto-ignition temperature: No data available
Decomposition temperature: No data available
Viscosity, dynamic (20 °C) : No data available
SAFETY DATA SHEET – NTD-04 Issue 02
According to Regulation (EC) No 1907/2006 (REACH)
Version 2.1 Revision date: 22/02/2013
Page 6 of 8
9.2 Physical hazards:
Not classified
9.3 Other information:
Fat solubility(solvent– oil to be specified) etc No data available
Bulk Density: No data available
Dissociation constant in water( pKa): No data available
Oxidation-reduction Potential: No data available
Section 10 STABILITY AND RELIABILITY
10.1 Reactivity:
Stable under recommended transport or storage conditions
10.2 Chemical stability:
Stable under normal temperatures and pressures
10.3 Possibility of hazardous reactions:
No dangerous reactions known
10.4 Conditions to avoid:
Incompatible materials
Avoid open flames and sources of ignition
10.5 Incompatible materials:
Strong oxidizers and acids
10.6 Hazardous decomposition products: Thermal decomposition products include carbon monoxide and carbon dioxide. When exposed to
high temperatures, free quartz can change crystal structure to form tridymite (above 870°C) or
crystobalite (1470°C) which have greater health hazards than quartz.
Section 11 TOXICOLOGICAL INFORMATION
11.1 Toxicokinetics, metabolism and distribution
No data available
11.2 Information on toxicological effects
Acute toxicity:
Polyethylene Glycol 400 (CAS# 25322-68-3):
LD50 (Oral, Rat): 28 g/kg
LD50 (Dermal, Rabbit): No data available
LC50 (Inhalation, Rat): >20 g/kg
Glycerin (Glycerol) 99.5% Technical Grade (CAS#56-81-5):
LD50 (Oral, Rat): 12600 mg/kg
LD50 (Dermal, Rabbit) : >10 g/kg
LC50 (Inhalation, Rat) : >570 mg/m3/1H
Skin corrosion/Irritation: No data available
Serious eye damage/irritation: Causes serious eye irritation.
Respiratory or skin sensitization: No data available
Germ cell mutagenicity: No data available
SAFETY DATA SHEET – NTD-04 Issue 02
According to Regulation (EC) No 1907/2006 (REACH)
Version 2.1 Revision date: 22/02/2013
Page 7 of 8
Carcinogenicity: No data available
Reproductive toxicity: No data available
STOT- single exposure: May cause respiratory irritation.
STOT-repeated exposure: No data available
Aspiration hazard: No data available
Section 12 ECOLOGICAL INFORMATION
Toxicity:
Acute toxicity Time Species Method Evaluation Remarks
LC50 None 96h Fish OECD 203 None None
EC50 None 48h Daphnia OECD 202 None None
EC50 None 72h Algae OECD 201 None None
Persistence and degradability:
No data available
Bioaccumulative potential:
No data available
Mobility in soil:
No data available
Results of PBT&vPvB assessment: No data available
Other adverse effects: No data available
Section 13 DISPOSAL CONSIDERATIONS
13.1 Waste treatment methods
Contact a licensed professional waste disposal service. Dissolve or mix the material with a
combustible solvent and burn in a chemical incinerator equipped with an afterburner and scrubber.
Contaminated packing must be emptied of all residues and, following appropriate cleaning, may
be sent to a recycling plant. Unclean packaging must be disposed of in the same manner.
Section 14. TRANSPORT INFORMATION
Land transport
(ADR/RID)
Sea transport
(IMDG)
Air transport
(ICAO/IATA)
UN-Number: Not regulated Not regulated Not regulated
UN Proper
shipping name: Not regulated Not regulated Not regulated
Transport hazard Class: Not regulated Not regulated Not regulated
Packaging group: Not regulated Not regulated Not regulated
SAFETY DATA SHEET – NTD-04 Issue 02
According to Regulation (EC) No 1907/2006 (REACH)
Version 2.1 Revision date: 22/02/2013
Page 8 of 8
Section 15 REGULATORY INFORMATION
This safety datasheet complies with the requirements of Regulation (EC) No. 1907/2006
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
No data available
15.1 Chemical Safety Assessment
For this product a chemical safety report was not carried out.
Section 16 OTHER INFORMATION
Full text of H-statement referred to under section 2 and 3
H319: Causes serious eye irritation
H335: May cause respiratory irritation
Full text of R-phrases referred to under section 2 and 3
Xi: Irritant
R36 Irritating to eyes
R37 Irritating to respiratory system
16.1 Indication of changes
None
The above information is believed to be correct but does not purport to be all inclusive and shall be used
only as a guide. The information in this document is based on the present state of our knowledge and is
applicable to the product with regard to appropriate safety precautions. It does not represent any guarantee
of the properties of the product. Finishing Brands shall not be held liable for any damage resulting from
handling or from contact with the above product.
- End -
Environmental hazards: No No No
Special precautions for user: See section 2.2 See section 2.2 See section 2.2
Transport in bulk according to
Annex II of MARPOL 73/78
and the IBC Code
Not regulated Not regulated Not regulated
SICHERHEITSDATENBLATT – NTD-04 Issue 02
Gemäß Verordnung (EG) Nr. 1907/2006 (REACH)
Version 2.1 Überarbeitungsdatum: 22.02.2013
Seite 1 von 9
Abschnitt 1 BEZEICHNUNG DES STOFFES UND DES UNTERNEHMENS
1.1 Produktidentifikator:
Bezeichnung auf dem Kennzeichnungsschild/Handelsname: Bumper Prep Pad
CAS-Nr.: Siehe Abschnitt 3
EG-Nr.: Siehe Abschnitt 3
Indexnummer: Keine
Produktnummer: Keine
REACH Vorregistrierungs-Nr.: Keine
Zusätzliche Bezeichnung: DC-BPP-K12
1.2 Relevante identifizierte Verwendungen des Stoffes und Verwendungen, von denen abgeraten wird:
1.2.1 Identifizierte Verwendungen:
Vorbereitung von nicht grundiertem Kunststoff vor dem Lackieren
1.2.2 Verwendungen, von denen abgeraten wird:
Keine Daten verfügbar
1.3 Einzelheiten zum Lieferanten, der das Sicherheitsdatenblatt bereitstellt:
Finishing Brands UK Ltd
Ringwood Road
Bournemouth
Dorset. BH11 9LH
Tel: 0044 (0) 1202 571111
Fax: 0044 (0) 1202 573488
E-Mail: tech-enquiry@carlisleft.eu
1.4 Notrufnummer:
0044 (0) 1865 407333 (24/7 Englisch sprech nur)
Abschnitt 2 MÖGLICHE GEFAHREN
2.1 Einstufung des Stoffes oder Gemischs:
2.1.1 Einstufung gemäß Verordnung (EG) Nr. 1272/2008 [CLP] (siehe Abschnitt 2.2 für vollen
Wortlaut H-Sätze):
Schwere Augenreizung (Kategorie 2), H319
Spezifische Zielorgan-Toxizität — einmalige Exposition (Kategorie 3), H335
2.1.2 Einstufung gemäß Richtlinie 67/548/EWG (siehe Abschnitt 16 für vollen Wortlaut der
Gefahrensätze):
Xi reizt die Augen/Atemwege R36/37
2.1.2.1 Die wichtigsten schädlichen physikalisch-chemischen Wirkungen:
Keine Daten verfügbar
2.1.2.2 Die wichtigsten schädlichen Wirkungen auf die menschliche Gesundheit:
Verursacht schwere Augenreizung
Kann die Atemwege reizen
2.1.2.3 Die wichtigsten schädlichen Wirkungen auf die Umwelt:
Keine Daten verfügbar
SICHERHEITSDATENBLATT – NTD-04 Issue 02
Gemäß Verordnung (EG) Nr. 1907/2006 (REACH)
Version 2.1 Überarbeitungsdatum: 22.02.2013
Seite 2 von 9
2.2 Kennzeichnungselemente:
Signalwörter:
Achtung
Gefahrenhinweis:
H319: Verursacht schwere Augenreizung
H335: Kann die Atemwege reizen
Sicherheitshinweis:
P261: Einatmen von Staub/Rauch/Gas/Nebel/Dampf/Aerosol vermeiden
P264: Nach Gebrauch Hände gründlich waschen
P271: Nur im Freien oder in gut belüfteten Räumen verwenden
P280: Schutzhandschuhe/Schutzkleidung/Augenschutz/Gesichtsschutz tragen
P304 + P340: BEI EINATMEN: Die betroffene Person an die frische Luft bringen und in einer
Position ruhigstellen, in der sie leicht atmet
P305 + P351 + P338: BEI BERÜHRUNG MIT DEN AUGEN: Einige Minuten lang behutsam mit
Wasser ausspülen. Eventuell vorhandene Kontaktlinsen nach Möglichkeit entfernen. Weiter
ausspülen.
P312: Bei Unwohlsein GIFTINFORMATIONSZENTRUM oder Arzt anrufen
P337 + P313: Bei anhaltender Augenreizung: Ärztlichen Rat einholen/ärztliche Hilfe hinzuziehen
P403 + P233: Behälter dicht verschlossen an einem gut belüfteten Ort aufbewahren
P405: Unter Verschluss aufbewahren
P501: Inhalt/Behälter gemäß lokalen Vorschriften der Entsorgung zuführen
2.3 Sonstige Gefahren:
Keine
Abschnitt 3 ZUSAMMENSETZUNG/ANGABEN ZU BESTANDTEILEN
3.1 Stoffe:
Produktidentifikator gemäß Artikel 18(2) von Verordnung (EG) Nr. 1272/2008
Stoff/Gemisch: Gemisch
Name des Stoffes CAS-Nr. EG-Nr. REACH
Registrierungs-
Nr.
Gewichtsanteil
in %
Klassifizierung
Feldspar 68476-25-5 270-666-7 - 38,30 H319, H335
Siliciumcarbid 409-21-2 206-991-8 - 25,00 Keine Poly-/Nylon-Rückseite Keine Keine - 15,00 Keine Gehärtetes Phenol-
Formaldehydharz
9003-35-4 Keine - 10,00 Keine
Quarz 14808-60-7 215-684-8 - 4,30 Keine Polyethylenglycol 400 25322-68-3 203-473-3 - 3,60 Keine Glycerin (Glycerol)
99,5 % technischer
Qualität
56-81-5 200-289-5 - 1,40 Keine
Triethanolamin (TEA)
Industriequalität
102-71-6 203-049-8 - 0,90 Keine
C12-15 PARETH-2 68131-39-5 Keine - 0,70 H318, H400
Glimmer 12001-26-2 215-479-3 - 0,40 Keine
Natriumsulfosuccinat 577-11-7 209-406-4 - 0,40 H315, H318
SICHERHEITSDATENBLATT – NTD-04 Issue 02
Gemäß Verordnung (EG) Nr. 1907/2006 (REACH)
Version 2.1 Überarbeitungsdatum: 22.02.2013
Seite 3 von 9
Abschnitt 4 ERSTE-HILFE-MASSNAHMEN
4.1 Beschreibung der Erste-Hilfe-Maßnahmen:
4.1.1 Bei Einatmen:
Als Aufnahmeweg nicht wahrscheinlich. Betroffene Person an die frische Luft bringen. Bei
auftretenden oder anhaltenden Reizungen oder Atembeschwerden sofort einen Arzt aufsuchen.
4.1.2 Bei Hautkontakt:
Haut und Haare mit fließendem Wasser (und Seife, falls vorhanden) spülen. Bei Reizung
ärztlichen Rat einholen.
4.1.3 Bei Augenkontakt:
Bei Berührung die Augen sofort mindestens 15 Minuten lang mit viel Wasser spülen. Bei
auftretenden oder anhaltenden Beschwerden, Augenarzt aufsuchen.
4.1.4 Bei Einnahme:
Als Aufnahmeweg nicht zu erwarten. Bei Einnahme sofort einen Arzt aufsuchen oder ärztlichen
Rat einholen. Kein Erbrechen herbeiführen.
4.2 Wichtigste akute oder verzögert auftretende Symptome und Wirkungen:
Verursacht schwere Augenreizung
Kann die Atemwege reizen
4.3 Hinweise auf ärztliche Soforthilfe oder Spezialbehandlung:
Sofort GIFTINFORMATIONSZENTRUM oder Arzt anrufen.
Abschnitt 5 MASSNAHMEN ZUR BRANDBEKÄMPFUNG
5.1 Löschmittel:
Geeignete Löschmittel: Für Umgebung geeignete Löschmittel verwenden.
Nicht geeignete Löschmittel. Keine Daten verfügbar
5.2 Besondere vom Stoff oder Gemisch ausgehende Gefahren:
Zu den thermischen Zersetzungsprodukten gehören Kohlenstoffmonoxid und Kohlenstoffdioxid.
Unter Einwirkung hoher Temperaturen kann freies Quarz die Kristallstruktur so verändern, dass
sich Tridymit (über 870 °C) oder Cristobalit (1470 °C) bilden, welche eine größere
Gesundheitsgefährdung aufweisen als Quarz.
5.3 Hinweise für die Brandbekämpfung:
Wie bei jedem Brandfall von MSHA/NIOSH (oder gleichwertig) zugelassenes,
umluftunabhängiges Atemgerät mit Druckausrüstung und vollständige Schutzkleidung tragen.
Abschnitt 6 MASSNAHMEN BEI UNBEABSICHTIGTER FREISETZUNG
6.1 Personenbezogene Vorsichtsmaßnahmen, Schutzausrüstungen und in Notfällen anzuwendende
Verfahren:
Hinweise zum personenbezogenen Schutz in Abschnitt 8 des Sicherheitsdatenblatts beachten.
6.2 Umweltschutzmaßnahmen:
Um einer möglichen Kontaminierung der Umwelt vorzubeugen, nicht in Kanalisation,
SICHERHEITSDATENBLATT – NTD-04 Issue 02
Gemäß Verordnung (EG) Nr. 1907/2006 (REACH)
Version 2.1 Überarbeitungsdatum: 22.02.2013
Seite 4 von 9
Oberflächenwasser oder Grundwasser gelangen lassen.
6.3 Methoden und Material für Rückhaltung und Reinigung:
Bei der Reinigung geeignete Schutzausrüstung und Schutzkleidung tragen. Abwasser mit Wasser
aufwischen, Bereich gründlich reinigen.
6.4 Verweis auf andere Abschnitte:
Siehe Abschnitt 8 des Sicherheitsdatenblatts
6.5 Zusätzliche Informationen:
Keine Daten verfügbar
Abschnitt 7 HANDHABUNG UND LAGERUNG
7.1 Schutzmaßnahmen zur sicheren Handhabung:
7.1.1 Schutzmaßnahmen:
Kontakt mit Haut und Augen vermeiden. Dieses Produkt mit geeigneter Belüftung für Staub
verwenden. Nach der Handhabung gründlich waschen.
7.1.2 Hinweise zu allgemeinen Hygienemaßnahmen am Arbeitsplatz:
Während der Verwendung des Produkts nicht essen, trinken oder rauchen. Nach der Handhabung
Hände gründlich waschen. Kontaminierte Kleidung und Schutzausrüstung vor dem Betreten von
Bereichen, in denen gegessen wird, ablegen.
7.2 Bedingungen zur sicheren Lagerung unter Berücksichtigung von Unverträglichkeiten:
Produkt bis zur Verwendung in der Verpackung belassen
An einem kühlen und trockenen Ort lagern
7.3 Spezifische Endanwendung(en):
Keine Daten verfügbar
Abschnitt 8 BEGRENZUNG UND ÜBERWACHUNG DER EXPOSITION/PERSÖNLICHE
SCHUTZAUSRÜSTUNGEN
8.1 Zu überwachende Parameter:
8.1.1 Grenzwerte berufsbedingter Exposition:
Stoff
CAS-Nr.
Grenzwert berufsbedingter
Exposition (Bezugszeitraum
von 8 Stunden)
Grenzwerte berufsbedingter
Exposition
Wert (Bezugszeitraum von
15 Minuten)
ppm mg/ m3 ppm mg/ m
3
Quarz,
alveolengängiger
Staub, (siehe
kristalline
Kieselerde)
14808-60-7 - 0,1 - -
Glimmer
gesamt
einatembarer Staub
alveolengängiger
12001-26-2
-
-
10
0,8
-
-
-
-
SICHERHEITSDATENBLATT – NTD-04 Issue 02
Gemäß Verordnung (EG) Nr. 1907/2006 (REACH)
Version 2.1 Überarbeitungsdatum: 22.02.2013
Seite 5 von 9
Staub
Glycerol, Nebel 56-81-5 - 10 - -
Triethanolamin 102-71-6 - 5 - -
Siliciumcarbid
gesamt
einatembarer Staub
alveolengängiger
Staub
409-21-2
-
-
10
4
-
-
-
-
8.1.2 Zusätzliche Expositionsgrenzwerte unter Verarbeitungsbedingungen:
Keine Daten verfügbar
8.1.3 DNEL/DMEL- und PNEC-Werte:
Keine Daten verfügbar
8.2 Begrenzung und Überwachung der Exposition:
8.2.1Geeignete technische Steuerungseinrichtungen:
Lokale und allgemeine Belüftung vorsehen zur effektiven Entfernung und Verhinderung der
Entwicklung von durch die Handhabung dieses Produktes entstehenden Dämpfen oder Staub.
8.2.2 Individuelle Schutzmaßnahmen, zum Beispiel persönliche Schutzausrüstung:
Augen-/Gesichtsschutz: Schutzbrille mit Seitenschutz wird empfohlen.
Handschutz: Undurchlässige Handschuhe tragen.
Körperschutz: Normale Arbeitskleidung (langärmelige Hemden und lange Hose) wird empfohlen.
Atemschutz: Für normalen empfohlenen Gebrauch nicht erforderlich.
8.2.3 Begrenzung und Überwachung der Umweltexposition:
Freisetzung in die Umwelt vermeiden.
Abschnitt 9 PHYSIKALISCHE UND CHEMISCHE EIGENSCHAFTEN
9.1 Angaben zu den grundlegenden physikalischen und chemischen Eigenschaften:
Aussehen: Vorgetränktes Poliermaterial mit
Nylon-beschichteter Rückseite
(Feststoff)
Farbe: Keine Daten verfügbar
Geruch: Keine Daten verfügbar
Geruchsschwelle: Keine Daten verfügbar
pH-Wert: Keine Daten verfügbar
Schmelzpunkt/-bereich: 165-170 °C (CAS-Nr. 577-11-7)
Siedepunkt/-bereich (°C): > 200 °C (CAS-Nr. 577-11-7)
Flammpunkt (°C): Keine Daten verfügbar
Verdampfungsgeschwindigkeit: Keine Daten verfügbar
Entzündlichkeit (fest, gasförmig): Dieses Produkt ist bei hohen
Temperaturen brennbar.
Zündtemperatur (°C): Keine Daten verfügbar
Obere/untere Entzündlichkeits- oder
Explosionsgrenzen:
Keine Daten verfügbar
Dampfdruck (20 °C): Keine Daten verfügbar
SICHERHEITSDATENBLATT – NTD-04 Issue 02
Gemäß Verordnung (EG) Nr. 1907/2006 (REACH)
Version 2.1 Überarbeitungsdatum: 22.02.2013
Seite 6 von 9
Dampfdichte: Keine Daten verfügbar
Relative Dichte: 1,146 g/cm³ (27,4 °C)
(CAS-Nr. 577-11-7)
Löslichkeit (g/l) bei 20 °C: 8,17 g/L (PH=5) (CAS-Nr. 577-11-7)
n-Octanol/Wasser (log Po/w) : Keine Daten verfügbar
Selbstentzündungstemperatur: Keine Daten verfügbar
Zersetzungstemperatur: Keine Daten verfügbar
Viskosität, dynamisch (20 °C): Keine Daten verfügbar
9.2 Physikalische Gefahren:
Nicht klassifiziert
9.3 Sonstige Angaben:
Fettlöslichkeit (Lösungsmittel angeben) etc. Keine Daten verfügbar
Schüttdichte: Keine Daten verfügbar
Dissoziationskonstante in Wasser (pKa): Keine Daten verfügbar
Oxidations-Reduktionspotential: Keine Daten verfügbar
Abschnitt 10 STABILITÄT UND REAKTIVITÄT
10.1 Reaktivität:
Unter den empfohlenen Transport- und Lagerbedingungen stabil
10.2 Chemische Stabilität:
Unter normalen Temperaturen und Drücken stabil
10.3 Möglichkeit gefährlicher Reaktionen: Keine gefährlichen Reaktionen bekannt
10.4 Zu vermeidende Bedingungen:
Unverträgliche Materialien
Offenes Feuer und Zündquellen vermeiden
10.5 Unverträgliche Materialien:
Starke Oxidationsmittel und Säuren
10.6 Gefährliche Zersetzungsprodukte:
Zu den thermischen Zersetzungsprodukten gehören Kohlenstoffmonoxid und Kohlenstoffdioxid.
Unter Einwirkung hoher Temperaturen kann freies Quarz die Kristallstruktur so verändern, dass
sich Tridymit (über 870 °C) oder Cristobalit (1470 °C) bilden, welche eine größere
Gesundheitsgefährdung aufweisen als Quarz.
Abschnitt 11 TOXIKOLOGISCHE ANGABEN
11.1 Toxikokinetik, Stoffwechsel und Verteilung:
Keine Daten verfügbar
11.2 Angaben zu toxikologischen Wirkungen:
Akute Toxizität:
Polyethylenglycol 400 (CAS-Nr. 25322-68-3):
SICHERHEITSDATENBLATT – NTD-04 Issue 02
Gemäß Verordnung (EG) Nr. 1907/2006 (REACH)
Version 2.1 Überarbeitungsdatum: 22.02.2013
Seite 7 von 9
LD50 (oral, Ratte): 28 g/kg
LD50 (dermal, Kaninchen): Keine Daten verfügbar
LC50 (Einatmen, Ratte): >20 g/kg
Glycerin (Glycerol) 99,5 % technischer Qualität (CAS-Nr. 56-81-5):
LD50 (oral, Ratte): 12.600 mg/kg
LD50 (dermal, Kaninchen): >10 g/kg
LC50 (Einatmen, Ratte): >570 mg/m3/1H
Hautätzende/-reizende Wirkung: Keine Daten verfügbar
Schwere Augenschädigung/-reizung: Verursacht schwere Augenreizung.
Sensibilisierung der Atemwege oder Haut: Keine Daten verfügbar
Keimzellmutagenität: Keine Daten verfügbar
Karzinogenität: Keine Daten verfügbar
Reproduktionstoxizität: Keine Daten verfügbar
STOT- einmalige Exposition: Kann die Atemwege reizen.
STOT- wiederholte Exposition: Keine Daten verfügbar
Aspirationsgefahr: Keine Daten verfügbar
Abschnitt 12 UMWELTSPEZIFISCHE ANGABEN
Toxizität:
Akute Toxizität Zeit Spezies Methode Bewertung Anmerkungen
LC50 Keine 96 h Fische OECD 203 Keine Keine
EC50 Keine 48 h Daphnien OECD 202 Keine Keine
EC50 Keine 72 h Algen OECD 201 Keine Keine
Persistenz und Abbaubarkeit:
Keine Daten verfügbar
Bioakkumulationspotenzial:
Keine Daten verfügbar
Mobilität im Boden:
Keine Daten verfügbar
Ergebnisse der PBT- und vPvB-Beurteilung:
Keine Daten verfügbar
Andere schädliche Wirkungen:
Keine Daten verfügbar
Abschnitt 13 HINWEISE ZUR ENTSORGUNG
13.1 Verfahren der Abfallbehandlung:
Lizenzierten, professionellen Abfallentsorgungsdienst kontaktieren. Das Material mit einem
brennbaren Lösungsmittel auflösen oder vermischen und in einer mit einem Nachbrenner und
Wäscher ausgestatteten chemischen Verbrennungsanlage verbrennen. Kontaminierte
Verpackungen müssen von allen Rückständen befreit werden und können nach angemessener
Reinigung in eine Recyclinganlage verbracht werden. Nicht gereinigte Verpackungen müssen auf
die gleiche Weise entsorgt werden.
SICHERHEITSDATENBLATT – NTD-04 Issue 02
Gemäß Verordnung (EG) Nr. 1907/2006 (REACH)
Version 2.1 Überarbeitungsdatum: 22.02.2013
Seite 8 von 9
Abschnitt 14 ANGABEN ZUM TRANSPORT
Abschnitt 15 ANGABEN ZU RECHTSVORSCHRIFTEN
Dieses Sicherheitsdatenblatt erfüllt die Anforderungen von Verordnung (EG) Nr. 1907/2006
15.1 Vorschriften zu Sicherheit, Gesundheits- und Umweltschutz/spezifische Rechtsvorschriften für
den Stoff oder das Gemisch:
Keine Daten verfügbar
15.1 Stoffsicherheitsbeurteilung:
Für dieses Produkt wurde keine Stoffsicherheitsbeurteilung durchgeführt.
Abschnitt 16 SONSTIGE ANGABEN
Voller Wortlaut der in Abschnitt 2 und 3 genannten Gefahrenhinweise
H319: Verursacht schwere Augenreizung
H335: Kann die Atemwege reizen
Voller Wortlaut der in Abschnitt 2 und 3 genannten R-Sätze
Xi: Reizend
R36 Reizt die Augen
R37 Reizt die Atmungsorgane
16.1 Angabe etwaiger Änderungen:
Landtransport
(ADR/RID)
Seeschiffstransport
(IMDG)
Lufttransport
(ICAO/IATA)
UN-Nummer: Nicht reguliert Nicht reguliert Nicht reguliert
Ordnungsgemäße UN-
Versandbezeichnung (UN
Proper Shipping Name):
Nicht reguliert Nicht reguliert Nicht reguliert
Transportgefahrenklassen: Nicht reguliert Nicht reguliert Nicht reguliert
Verpackungsgruppe (Packing
Group): Nicht reguliert Nicht reguliert Nicht reguliert
Umweltgefahren: Nein Nein Nein
Besondere
Vorsichtsmaßnahmen für den
Verwender:
Siehe Abschnitt 2.2. Siehe Abschnitt 2.2. Siehe Abschnitt 2.2.
Massengutbeförderung gemäß
Anhang II des MARPOL-
Übereinkommens 73/78 und
gemäß IBC-Code
Nicht reguliert Nicht reguliert Nicht reguliert
SICHERHEITSDATENBLATT – NTD-04 Issue 02
Gemäß Verordnung (EG) Nr. 1907/2006 (REACH)
Version 2.1 Überarbeitungsdatum: 22.02.2013
Seite 9 von 9
Keine
Die vorgenannten Angaben sind nach unserem besten Wissen korrekt, erheben jedoch keinen Anspruch auf
Vollständigkeit und dienen nur als Orientierungshilfe. Die Informationen in diesem Dokument beruhen auf
dem gegenwärtigen Stand unseres Wissens und gelten für das Produkt in Bezug auf die geeigneten
Sicherheitsvorkehrungen. Sie stellen keine Zusicherung von Produkteigenschaften dar. Finishing Brands
übernimmt keine Haftung für Schäden, die sich aus dem Umgang oder Kontakt mit dem vorgenannten
Produkt ergeben.
- Ende -
FICHE DE DONNÉES DE SÉCURITÉ – NTD-04 Issue 02
Conformément au réglement (CE) Nº 1907/2006 (REACH)
Version 2.1 Date de révision : 22/02/2013
Page 1 de 9
Section 1 IDENTIFICATION DE LA SUBSTANCE ET DE LA SOCIÉTÉ/ENTREPRISE
1.1 Identificateur de produit :
Identification sur l'étiquette/Nom commercial : Bumper Prep Pad
N° CAS : Voir section 3
N° CE : Voir section 3
Numéro index : Aucun
Numéro de produit : Aucun
Nº de pré-enregistrement REACH : Aucun
Identification complémentaire : DC-BPP-K12
1.2 Utilisations identifiées pertinentes de la substance ou du mélange et utilisations déconseillées :
1.2.1 Utilisations identifiées :
Préparation de plastique non apprêté avant peinture
1.2.2 Utilisations déconseillées :
Pas de données disponibles
1.3 Renseignements concernant le fournisseur de la fiche de données de sécurité :
Finishing Brands UK Ltd
Ringwood Road
Bournemouth
Dorset BH11 9LH
Tél : 0044 (0) 1202 571111
Fax : 0044 (0) 1202 573488
Email : tech-enquiry@carlisleft.eu
1.4 Numéro d'appel d'urgence :
0044 (0) 1865 407333 (24/7 Parlant anglais seulement)
Section 2 IDENTIFICATION DES DANGERS
2.1 Classification de la substance ou du mélange
2.1.1 Classification conformément au règlement (CE) n° 1272/2008 [CLP] (voir section 2.2 pour
obtenir le texte complet des phrases de danger)
Irritation grave des yeux (catégorie 2), H319
Toxicité spécifique pour certains organes cibles — exposition unique (catégorie 3), H335
2.1.2 Classification conformément à la directive 67/548/CEE (voir section 16 pour obtenir le texte
complet des phrases de risque)
Xi Irritant pour les yeux / les voies respiratoire R36/37
2.1.2.1 Principaux effets néfastes physicochimiques :
Pas de données disponibles
2.1.2.2 Principaux effets néfastes pour la santé humaine :
Provoque une sévère irritation des yeux
Peut irriter les voies respiratoires
2.1.2.3 Principaux effets néfastes pour l'environnement :
Pas de données disponibles
FICHE DE DONNÉES DE SÉCURITÉ – NTD-04 Issue 02
Conformément au réglement (CE) Nº 1907/2006 (REACH)
Version 2.1 Date de révision : 22/02/2013
Page 2 de 9
2.2 Éléments d'étiquetage
Mention(s) d'avertissement :
Attention
Mention(s) de danger :
H319 : Provoque une sévère irritation des yeux
H335 : Peut irriter les voies respiratoires
Mention(s) de mise en garde :
P261 : Éviter de respirer les poussières/fumées/gaz/brouillards/vapeurs/aérosols
P264 : Se laver les mains soigneusement après manipulation
P271 : Utiliser seulement en plein air ou dans un endroit bien ventilé
P280 : Porter des gants de protection/des vêtements de protection/un équipement de protection des
yeux/du visage
P304 + P340 : EN CAS D'INHALATION : transporter la personne à l'extérieur et la maintenir au
repos dans une position où elle peut confortablement respirer
P305 + P351 + P338 : EN CAS DE CONTACT AVEC LES YEUX : rincer avec précaution à l'eau
pendant plusieurs minutes. Enlever les lentilles de contact si la victime en porte et si elles peuvent
être facilement enlevées. Continuer à rincer
P312 : Appeler un CENTRE ANTIPOISON ou un médecin en cas de malaise
P337 + P313 : Si l'irritation oculaire persiste : consulter un médecin
P403 + P233 : Stocker dans un endroit bien ventilé. Maintenir le récipient fermé de manière
étanche
P405 : Garder sous clef
P501 : Éliminer le contenu/récipient conformément à la réglementation locale
2.3 Autres dangers
Aucune
Section 3 COMPOSITION/INFORMATIONS SUR LES COMPOSANTS
3.1 Substances Type d'identificateur de produit selon l'article 18(2) du règlement (CE) n° 1272/2008
Substance/Mélange : Mélange
Nom de la substance N° CAS N° CE N°
d'enregistrement
REACH :
Teneur
en % du
poids
Classification
Feldspath 68476-25-5 270-666-7 - 38,30 H319, H335
Carbure de silicium 409-21-2 206-991-8 - 25,00 Aucune Fond en poly/nylon Aucun Aucun - 15,00 Aucune Résine de
phénolformaldéhyde
durcie
9003-35-4 Aucun - 10,00 Aucune
Quartz 14808-60-7 215-684-8 - 4,30 Aucune Polyéthylène Glycol 400 25322-68-3 203-473-3 - 3,60 Aucune Glycérine (Glycérol)
99,5 % Qualité technique
56-81-5 200-289-5 - 1,40 Aucune
Triéthanolamine (TEA)
Qualité industrielle
102-71-6 203-049-8 - 0,90 Aucune
FICHE DE DONNÉES DE SÉCURITÉ – NTD-04 Issue 02
Conformément au réglement (CE) Nº 1907/2006 (REACH)
Version 2.1 Date de révision : 22/02/2013
Page 3 de 9
C12-15 PARETH-2 68131-39-5 Aucun - 0,70 H318, H400
Mica 12001-26-2 215-479-3 - 0,40 Aucune
Sulfosuccinate de sodium 577-11-7 209-406-4 - 0,40 H315, H318
Section 4 PREMIERS SECOURS
4.1 Description des premiers secours :
4.1.1 En cas d'inhalation :
Voie de pénétration peu probable. Transporter la victime à l'extérieur. Si une irritation ou une
difficulté respiratoire se développe ou persiste, consulter immédiatement un médecin.
4.1.2 En cas de contact avec la peau :
Rincer la peau et les cheveux à l'eau courante (et au savon si possible). Consulter un médecin en
cas d'irritation.
4.1.3 En cas de contact avec les yeux :
En cas de contact, rincer immédiatement les yeux à grande eau pendant au moins 15 minutes.
Consulter un médecin si une irritation se développe ou persiste.
4.1.4 En cas d'ingestion :
Voie de pénétration peu probable. En cas d'ingestion, consulter immédiatement un médecin. Ne
pas faire vomir.
4.2 Principaux symptômes et effets, aigus et différés
Provoque une sévère irritation des yeux
Peut irriter les voies respiratoires
4.3 Indication des éventuels soins médicaux immédiats et traitements particuliers nécessaires
Appeler immédiatement un CENTRE ANTIPOISON/un médecin.
Section 5 MESURES DE LUTTE CONTRE L’INCENDIE
5.1 Moyens d'extinction :
Moyens d'extinction convenables : Adapter les moyens d'extinction au milieu environnant.
Moyens d'extinction inappropriés : Aucune donnée disponible
5.2 Dangers particuliers résultant de la substance ou du mélange
Parmi les produits de décomposition thermique figurent le monoxyde de carbone et le dioxyde de
carbone. Exposé à des températures élevées, le quartz libre peut changer de structure cristalline
pour former de la tridymite (au-dessus de 870°C) ou de la cristobalite (1470°C), qui sont plus
dangereux pour la santé que le quartz.
5.3 Conseils aux pompiers : Comme dans tout incendie, porter un appareil respiratoire autonome à la demande.
MSHA/NIOSH (approuvé ou équivalent) et un équipement de protection complet
Section 6 MESURES À PRENDRE EN CAS DE REJET ACCIDENTEL
6.1 Précautions individuelles, équipement de protection et procédures d'urgence :
Consulter la section 8 de la FDS pour obtenir des informations sur la protection individuelle.
FICHE DE DONNÉES DE SÉCURITÉ – NTD-04 Issue 02
Conformément au réglement (CE) Nº 1907/2006 (REACH)
Version 2.1 Date de révision : 22/02/2013
Page 4 de 9
6.2 Précautions pour la protection de l'environnement :
Afin d'éviter une possible contamination de l'environnement, ne pas rejeter dans les égouts, les
eaux de surface ou les eaux souterraines.
6.3 Méthodes et matériel de confinement et de nettoyage :
Porter un équipement et des vêtements de protection appropriés lors du nettoyage. Éliminer tout
effluent avec de l'eau, nettoyer soigneusement la surface.
6.4 Référence à d'autres sections :
Consulter la section 8 de la FDS
6.5 Informations complémentaires :
Pas de données disponibles
Section 7 MANIPULATION ET STOCKAGE
7.1 Précautions à prendre pour une manipulation sans danger :
7.1.1 Mesures de protection :
Éviter le contact avec la peau et les yeux. Utiliser ce produit dans des conditions d'aération
adéquates contre les nuisances dues à la poussière. Se laver soigneusement après manipulation.
7.1.2 Conseil en matière d'hygiène du travail:
Ne pas manger, boire ou fumer lors de l'utilisation de ce produit. Se laver les mains soigneusement
après manipulation. Retirer les vêtements et l'équipement de protection contaminés avant d'entrer
dans des espaces de restauration.
7.2 Conditions d'un stockage sûr, y compris d'éventuelles incompatibilités :
Conserver le produit dans son emballage jusqu'au moment de l'utilisation
Stocker dans un endroit frais et sec
7.3 Utilisation(s) finale(s) particulière(s) :
Pas de données disponibles
Section 8 CONTRÔLE DE L'EXPOSITION/PROTECTION INDIVIDUELLE
8.1 Paramètres de contrôle :
8.1.1 Limites d'exposition professionnelle :
Substance
N° CAS
Valeur limite d'exposition
professionnelle (période de
référence de 8 heures)
Valeur limite d'exposition
professionnelle (période de
référence
de 15 minutes)
Ppm mg/ m3 ppm mg/ m
3
Quartz, poussière
respirable, (voir
silice
cristalline)
14808-60-7 - 0,1 - -
Mica
poussière inhalable
totale
poussière
12001-26-2
-
-
10
0,8
-
-
-
-
FICHE DE DONNÉES DE SÉCURITÉ – NTD-04 Issue 02
Conformément au réglement (CE) Nº 1907/2006 (REACH)
Version 2.1 Date de révision : 22/02/2013
Page 5 de 9
respirable
Glycérol, brouillard 56-81-5 - 10 - -
Triéthanolamine 102-71-6 - 5 - -
Carbure de silicium
poussière inhalable
totale
poussière
respirable
409-21-2
-
-
10
4
-
-
-
-
8.1.2 Limites d'exposition supplémentaires dans les conditions d'utilisation :
Pas de données disponibles
8.1.3 Valeurs DNEL/DMEL et PNEC :
Pas de données disponibles
8.2 Contrôles de l'exposition
8.2.1 Contrôles techniques appropriés :
Fournir un système de ventilation par aération local et général afin d'éliminer et de prévenir
efficacement toute accumulation des vapeurs ou poussières générées par la manipulation de ce
produit.
8.2.2 Mesures de protection individuelle, comme équipement de protection personnelle:
Protection des yeux/du visage : Il est recommandé de porter des lunettes de protection avec écrans
latéraux.
Protection des mains : Porter des gants imperméables.
Protection du corps : Il est recommandé de porter des vêtements de travail normaux (chemise à
manches longues et long pantalon).
Protection respiratoire : N'est pas nécessaire pour l'utilisation recommandée.
8.2.3 Contrôles d’exposition liés à la protection de l’environnement :
Éviter de rejeter dans l'environnement.
Section 9 PROPRIÉTÉS PHYSIQUES ET CHIMIQUES
9.1 Informations sur les propriétés physiques et chimiques essentielles
Aspect : Matériau (solide) abrasif revêtu
préimprégné avec fond en nylon
Couleur : Pas de données disponibles
Odeur : Pas de données disponibles
Seuil olfactif : Pas de données disponibles
pH : Pas de données disponibles
Point/intervalle de fusion : 165-170 °C (n° CAS 577-11-7)
Point/intervalle d'ébullition (°C) : > 200°C (n° CAS 577-11-7)
Point d'éclair (°C) : Pas de données disponibles
Taux d'évaporation : Pas de données disponibles
Inflammabilité (solide, gaz) : Ce produit est combustible à haute
température.
Température d'inflammation (°C) : Pas de données disponibles
Limites supérieures/inférieures Pas de données disponibles
FICHE DE DONNÉES DE SÉCURITÉ – NTD-04 Issue 02
Conformément au réglement (CE) Nº 1907/2006 (REACH)
Version 2.1 Date de révision : 22/02/2013
Page 6 de 9
d'inflammabilité ou limites d'explosivité
Pression de vapeur (20°C) : Pas de données disponibles
Densité de vapeur : Pas de données disponibles
Densité relative : 1,146 g/cm³ (27,4 °C)
(n° CAS 577-11-7)
Solubilité dans l'eau (g/l) à 20°C : 8,17 g/L (PH=5) (n° CAS 577-11-7)
n-Octanol/eau (log Po/w) : Pas de données disponibles
Température d'auto-inflammabilité : Pas de données disponibles
Température de décomposition : Pas de données disponibles
Viscosité, dynamique (20 °C) : Pas de données disponibles
9.2 Dangers physiques :
Non classifiés
9.3 Autres informations :
Liposolubilité (solvant - huile à préciser) etc. Pas de données disponibles
Densité apparente : Pas de données disponibles
Constante de dissociation dans l'eau (pKa) : Pas de données disponibles
Potentiel d'oxydo-réduction : Pas de données disponibles
Section 10 STABILITÉ ET RÉACTIVITÉ
10.1 Réactivité :
Stable dans les conditions de transport ou de stockage recommandées
10.2 Stabilité chimique :
Stable à des températures et pressions normales
10.3 Possibilité de réactions dangereuses :
Aucune réaction dangereuse connue
10.4 Conditions à éviter :
Matières incompatibles
Éviter les flammes nues et les sources d'inflammation
10.5 Matières incompatibles :
Puissants agents oxydants et acides
10.6 Produits de décomposition dangereux :
Parmi les produits de décomposition thermique figurent le monoxyde de carbone et le dioxyde de
carbone. Exposé à des températures élevées, le quartz libre peut changer de structure cristalline
pour former de la tridymite (au-dessus de 870°C) ou de la cristobalite (1470°C), qui sont plus
dangereux pour la santé que le quartz.
Section 11 INFORMATIONS TOXICOLOGIQUES
11.1 Toxicocinétique, métabolismes et distribution
Pas de données disponibles
11.2 Informations sur les effets toxicologiques
Toxicité aiguë :
FICHE DE DONNÉES DE SÉCURITÉ – NTD-04 Issue 02
Conformément au réglement (CE) Nº 1907/2006 (REACH)
Version 2.1 Date de révision : 22/02/2013
Page 7 de 9
Polyéthylène Glycol 400 (n° CAS 25322-68-3) :
DL50 (orale, rat) : 28 g/kg
DL50 (voie cutanée, lapin) : Aucune donnée disponible
CL50 (inhalation, rat) : >20 g/kg
Glycérine (Glycérol) 99,5 % Qualité technique (n° CAS 56-81-5) :
DL50 (orale, rat) : 12 600 mg/kg
DL50 (dermique, lapin) : >10 g/kg
CL50 (inhalation, rat) : >570 mg/m3/1H
Corrosion/irritation cutanée : Aucune donnée disponible
Dommages/irritation grave des yeux : Provoque une sévère irritation des yeux.
Sensibilisation respiratoire ou cutanée : Aucune donnée disponible
Mutagénicité des cellules germinales : Aucune donnée disponible.
Carcinogénicité : Aucune donnée disponible
Toxicité pour la reproduction : Aucune donnée disponible
STOT - exposition unique : Peut irriter les voies respiratoires.
STOT - exposition répétée : Aucune donnée disponible
Danger en cas d'aspiration : Aucune donnée disponible
Section 12 INFORMATIONS ÉCOLOGIQUES
Toxicité :
Toxicité aiguë Durée Espèce Méthode Évaluation Remarques
CL50 Aucune 96h Poisson OCDE 203 Aucune Aucune
CE50 Aucune 48h Daphnie OCDE 202 Aucune Aucune
CE50 Aucune 72h Algue OCDE 201 Aucune Aucune
Persistance et dégradabilité :
Pas de données disponibles
Potentiel de bioaccumulation :
Pas de données disponibles
Mobilité dans le sol :
Pas de données disponibles
Résultats des évaluations PBT et vPvB :
Pas de données disponibles
Autres effets néfastes :
Pas de données disponibles
Section 13 CONSIDÉRATIONS RELATIVES À L'ÉLIMINATION
13.1 Méthodes de traitement des déchets
Contacter un service professionnel d'élimination des déchets agréé. Dissoudre ou mélanger la
matière avec un solvant combustible et brûler dans un incinérateur chimique équipé d'une chambre
de post-combustion et d'un laveur. L'emballage contaminé doit être vidé de tout résidu et, après un
nettoyage approprié, il peut être envoyé sur un site de recyclage. L'emballage non nettoyé doit être
FICHE DE DONNÉES DE SÉCURITÉ – NTD-04 Issue 02
Conformément au réglement (CE) Nº 1907/2006 (REACH)
Version 2.1 Date de révision : 22/02/2013
Page 8 de 9
éliminé de la même manière.
Section 14. INFORMATIONS RELATIVES AU TRANSPORT
Section 15 INFORMATIONS RÉGLEMENTAIRES
La présente fiche de données de sécurité est conforme aux exigences du règlement (CE) n° 1907/2006.
15.1 Réglementations/législation particulières à la substance ou au mélange en matière de sécurité, de
santé et d'environnement
Pas de données disponibles
15.1 Évaluation de la sécurité chimique
Aucun rapport de sécurité chimique n'a été émis pour ce produit.
Section 16 AUTRES DONNÉES
Texte complet des mentions de danger aux sections 2 et 3
H319 : Provoque une sévère irritation des yeux
H335 : Peut irriter les voies respiratoires
Texte complet des phrases de risque aux sections 2 et 3
Xi : Irritant
R36 Irritant pour les yeux
R37 Irritant pour les voies respiratoires
16.1 Indication de modifications
Aucune
Transport
terrestre
(ADR/RID)
Transport maritime
(IMDG)
Transport aérien
(OACI/IATA)
Numéro ONU : Non réglementé Non réglementé Non réglementé
Nom d'expédition des Nations
unies : Non réglementé Non réglementé Non réglementé
Classe(s) de danger pour le
transport : Non réglementé Non réglementé Non réglementé
Groupe d'emballage : Non réglementé Non réglementé Non réglementé
Dangers pour
l'environnement : N° N° N°
Précaution particulières à
prendre par l'utilisateur : Voir section 2.2 Voir section 2.2 Voir section 2.2
Transport en vrac
conformément à l'annexe II de
la convention Marpol 73/78 et
au recueil IBC
Non réglementé Non réglementé Non réglementé
FICHE DE DONNÉES DE SÉCURITÉ – NTD-04 Issue 02
Conformément au réglement (CE) Nº 1907/2006 (REACH)
Version 2.1 Date de révision : 22/02/2013
Page 9 de 9
Les informations ci-dessus sont jugées correctes mais ne prétendent pas être exhaustives et sont fournies à
titre indicatif seulement. Les informations du présent document sont basées sur l'état actuel des
connaissances et s'appliquent au produit eu égard aux précautions de sécurité adéquates. Elles ne
constituent aucune garantie quant aux propriétés du produit. Finishing Brands ne sera pas tenue responsable
de dommages résultant de la manipulation de ou d'un contact avec le produit susmentionné.
- Fin -
FICHA DE DATOS DE SEGURIDAD – NTD-04 Issue 02
Conforme con el Reglamento (CE) Nº 1907/2006 (REACH)
Versión 2.1 Fecha de revisión: 22/02/2013
Página 1 de 9
Sección 1 IDENTIFICACIÓN DE LA SUSTANCIA Y DE LA SOCIEDAD O EMPRESA
1.1 Identificador del producto:
Identificación que consta en la etiqueta Bumper Prep Pad
/Nombre comercial:
Nº CAS: Ver sección 3
Nº CE: Ver sección 3
Número de índice: Ninguno
Número de producto: Ninguno
Nº de registro previo REACH: Ninguno
Identificación adicional: DC-BPP-K12
1.2 Usos pertinentes identificados de la sustancia y usos desaconsejados:
1.2.1 Usos identificados:
Preparación del plástico no imprimado, antes de aplicar pintura
1.2.2 Usos desaconsejados:
No hay datos disponibles
1.3 Datos del proveedor de la ficha de datos de seguridad:
Finishing Brands UK Ltd
Ringwood Road
Bournemouth
Dorset. BH11 9LH - Reino Unido
Tel: 0044 (0) 1202 571111
Fax: 0044 (0) 1202 573488
Correo electrónico: tech-enquiry@carlisleft.eu
1.4 Teléfono de emergencia:
0044 (0) 1865 407333 (24/7 Inglés solamente hablar)
Sección 2 IDENTIFICACIÓN DE LOS PELIGROS
2.1 Clasificación de la sustancia o de la mezcla
2.1.1 Clasificación conforme al Reglamento (CE) Nº 1272/2008 (CLP) (para ver el texto completo de
las frases H, ver sección 2.2)
Irritación ocular grave (categoría 2), H319 Toxicidad específica en determinados órganos (STOT) - exposición única (categoría 3), H335
2.1.2 Clasificación conforme a la Directiva 67/548/CEE (para ver el texto completo de las frases sobre
riesgos, ver sección 16)
Xi Irrita los ojos/las vías respiratorias R36/37
2.1.2.1 Principales efectos adversos fisicoquímicos:
No hay datos disponibles
2.1.2.2 Principales efectos adversos para la salud humana:
Provoca irritación ocular grave
Puede irritar las vías respiratorias
2.1.2.3 Principales efectos adversos para el medio ambiente:
No hay datos disponibles
FICHA DE DATOS DE SEGURIDAD – NTD-04 Issue 02
Conforme con el Reglamento (CE) Nº 1907/2006 (REACH)
Versión 2.1 Fecha de revisión: 22/02/2013
Página 2 de 9
2.2 Elementos de la etiqueta
Palabras(s) de advertencia:
Atención
Indicación(es) de peligro:
H319: Provoca irritación ocular grave
H335: Puede irritar las vías respiratorias
Consejo(s) de prudencia:
P261: Evitar respirar el polvo/el humo/el gas/la niebla/los vapores/el aerosol
P264: Lavarse las manos concienzudamente tras la manipulación
P271: Utilizar únicamente en exteriores o en un lugar bien ventilado
P280: Llevar guantes/prendas/gafas/máscara de protección
P304 + P340: EN CASO DE INHALACIÓN: Transportar a la víctima al exterior y mantenerla en
reposo en una posición confortable para respirar
P305 + P351 + P338 EN CASO DE CONTACTO CON LOS OJOS: Aclarar cuidadosamente con
agua durante varios minutos; quitar las lentes de contacto, si lleva y resulta fácil. Seguir aclarando
P312: Llamar a un CENTRO DE INFORMACIÓN TOXICOLÓGICA o a un médico en caso de
malestar.
P337 + P313: Si persiste la irritación ocular: consultar a un médico.
P403 + P233: Almacenar en un lugar bien ventilado. Mantener el recipiente cerrado
herméticamente
P405: Guardar bajo llave
P501: Eliminar el contenido/el recipiente con arreglo a las normativas locales
2.3 Otros peligros
Ninguno
Sección 3 COMPOSICIÓN/INFORMACIÓN SOBRE LOS COMPONENTES
3.1 Sustancias Tipo de identificador del producto de conformidad con el Artículo 18(2), del Reglamento (CE) Nº
1272/2008
Sustancia/Mezcla: Mezcla
Nombre de la sustancia Nº CAS Nº CE Nº de
registro
REACH
Contenido:
% en peso
Clasificación
Feldespato 68476-25-5 270-666-7 - 38,30 H319, H335
Carburo de silicio 409-21-2 206-991-8 - 25,00 Ninguno Revestimiento de
poli/nylon
Ninguno Ninguno - 15,00 Ninguno
Resina de fenol-
formaldehído curada
9003-35-4 Ninguno - 10,00 Ninguno
Cuarzo 14808-60-7 215-684-8 - 4,30 Ninguno Polietilenglicol 400 25322-68-3 203-473-3 - 3,60 Ninguno Glicerina (glicerol) 99,5%
de calidad técnica
56-81-5 200-289-5 - 1,40 Ninguno
Trietanolamina (TEA) de 102-71-6 203-049-8 - 0,90 Ninguno
FICHA DE DATOS DE SEGURIDAD – NTD-04 Issue 02
Conforme con el Reglamento (CE) Nº 1907/2006 (REACH)
Versión 2.1 Fecha de revisión: 22/02/2013
Página 3 de 9
calidad industrial
C12-15 PARETH-2 68131-39-5 Ninguno - 0,70 H318, H400
Mica 12001-26-2 215-479-3 - 0,40 Ninguno
Sulfosuccinato sódico 577-11-7 209-406-4 - 0,40 H315, H318
Sección 4 PRIMEROS AUXILIOS
4.1 Descripción de los primeros auxilios
4.1.1 En caso de inhalación:
No es una vía de entrada probable. Desplazar a la persona afectada al exterior. Si la irritación o la
dificultad respiratoria empeora o persiste, obtener atención médica de inmediato.
4.1.2 En caso de contacto con la piel:
Enjuagar la piel y el pelo con agua abundante (y con jabón, si lo hay). En caso de irritación,
obtener atención médica.
4.1.3 En caso de contacto con los ojos:
En caso de contacto, aclarar los ojos con grandes cantidades de agua durante al menos 15 minutos.
Si la irritación empeora o persiste, obtener atención médica.
4.1.4 En caso de ingestión:
No es una vía de exposición esperada. Si se traga, obtener atención o consejo médicos de
inmediato. No inducir el vómito.
4.2 Principales síntomas y efectos, agudos y retardados
Provoca irritación ocular grave
Puede irritar las vías respiratorias
4.3 Indicación de toda atención médica y de los tratamientos especiales que deban dispensarse
inmediatamente
Llamar inmediatamente a un CENTRO DE TOXICOLOGÍA o un médico.
Sección 5 - MEDIDAS DE LUCHA CONTRA INCENDIOS
5.1 Medios de extinción:
Medios de extinción apropiados: usar los medios de extinción apropiados para el área circundante.
Medios de extinción que no deben usarse: no hay datos disponibles
5.2 Peligros específicos derivados de la sustancia o la mezcla
Entre los productos de la descomposición térmica del producto están el monóxido de carbono y el
dióxido de carbono. Cuando se expone a temperaturas altas, el cuarzo libre puede cambiar su
estructura cristalina para formar tridimita (por encima de 870°C) o cristobalita (1470°C), que
presentan mayores riesgos para la salud que el cuarzo.
5.3 Recomendaciones para el personal de lucha contra incendios
Como en cualquier incendio, llevar puesto aparato respirador autónomo, con presión a demanda,
del tipo MSHA/NIOSH (autorizado o equivalente) y equipo protector completo
Sección 6 MEDIDAS EN CASO DE LIBERACIÓN ACCIDENTAL
6.1 Precauciones personales, equipo de protección y procedimientos de emergencia:
FICHA DE DATOS DE SEGURIDAD – NTD-04 Issue 02
Conforme con el Reglamento (CE) Nº 1907/2006 (REACH)
Versión 2.1 Fecha de revisión: 22/02/2013
Página 4 de 9
La sección 8 de la FDS contiene detalles sobre la protección personal.
6.2 Precauciones relativas al medio ambiente:
Para evitar una posible contaminación del medio ambiente, no verter en desagües, aguas
subterráneas ni cursos de agua.
6.3 Métodos y material de contención y de limpieza:
Llevar puesto equipo y ropa de protección adecuados durante la limpieza. Retirar con agua todos
los efluentes, limpiar la zona a fondo.
6.4 Referencia a otras secciones:
Ver la sección 8 de la FDS
6.5 Información adicional No hay datos disponibles
Sección 7 MANIPULACIÓN Y ALMACENAMIENTO
7.1 Precauciones para una manipulación segura:
7.1.1 Medidas de protección:
Evitar el contacto con la piel y con los ojos. Utilizar este producto con una ventilación adecuada
para evitar polvos molestos. Lavarse a fondo tras la manipulación.
7.1.2 Recomendaciones sobre medidas generales de higiene en el trabajo:
No comer, beber ni fumar al utilizar ese producto. Lavarse las manos concienzudamente tras la
manipulación. Quitarse la ropa y el equipo protector contaminados antes de entrar en zonas de
comedor.
7.2 Condiciones de almacenamiento seguro, incluidas posibles incompatibilidades:
Mantener el producto dentro del envase hasta el momento de utilizarlo
Conservar en lugar fresco y seco
7.3 Usos específicos finales:
No hay datos disponibles
Sección 8 CONTROLES DE EXPOSICIÓN/PROTECCIÓN PERSONAL
8.1 Parámetros de control:
8.1.1 Límites de exposición profesional:
Sustancia
Nº CAS
Valor límite de exposición
profesional (período de
referencia de 8 horas)
Límites de exposición profesional
Valor (período de referencia
de 15 minutos)
ppm mg/ m3 ppm mg/ m
3
Cuarzo, polvo
respirable, (ver sílice
cristalino)
14808-60-7 - 0,1 - -
Mica
polvo inhalable total
polvo respirable
12001-26-2
-
-
10
0,8
-
-
-
-
Glicerol, vahos 56-81-5 - 10 - -
FICHA DE DATOS DE SEGURIDAD – NTD-04 Issue 02
Conforme con el Reglamento (CE) Nº 1907/2006 (REACH)
Versión 2.1 Fecha de revisión: 22/02/2013
Página 5 de 9
Trietanolamina 102-71-6 - 5 - -
Carburo de silicio
polvo inhalable total
polvo respirable
409-21-2
-
-
10
4
-
-
-
-
8.1.2 Límites de exposición adicional en las condiciones de uso:
No hay datos disponibles
8.1.3 Valores DNEL (nivel sin efecto derivado) / DMEL (nivel con efecto mínimo derivado) y PNEC
(concentración prevista sin efecto):
No hay datos disponibles
8.2 Controles de la exposición
8.2.1 Controles técnicos apropiados:
Proporcionar ventilación por aspiración local y general para prevenir y eliminar eficazmente la
acumulación de vapores o polvo generados a raíz de la manipulación de este producto.
8.2.2 Medidas de protección individuales, tales como equipos de protección personal:
Protección ocular/facial: se recomienda usar gafas de seguridad con pantallas laterales.
Protección de las manos: llevar puestos guantes impermeables.
Protección del cuerpo: se recomienda llevar ropa de trabajo normal (camisas de mangas largas y
pantalones largos).
Protección respiratoria: no se requiere para el uso normal recomendado.
8.2.3 Controles de la exposición medioambiental:
Evitar liberar en el medio ambiente.
Sección 9 PROPIEDADES FÍSICAS Y QUÍMICAS
9.1 Información sobre propiedades físicas y químicas básicas
Aspecto: Material abrasivo (sólido) que viene
ya saturado, con revestimiento de
nylon
Color: No hay datos disponibles
Olor: No hay datos disponibles
Umbral olfativo: No hay datos disponibles
pH: No hay datos disponibles
Punto/intervalo de fusión: 165-170°C (Nº CAS 577-11-7)
Punto/intervalo de ebullición (°C): > 200°C (Nº CAS 577-11-7)
Punto de inflamación (°C): No hay datos disponibles
Tasa de evaporación: No hay datos disponibles
Inflamabilidad (sólido, gas): Este producto es combustible a
temperaturas altas.
Temperatura de ignición (°C): No hay datos disponibles
Límites superior/inferior de inflamabilidad o
de explosividad:
No hay datos disponibles
Presión de vapor (20°C): No hay datos disponibles
Densidad de vapor: No hay datos disponibles
FICHA DE DATOS DE SEGURIDAD – NTD-04 Issue 02
Conforme con el Reglamento (CE) Nº 1907/2006 (REACH)
Versión 2.1 Fecha de revisión: 22/02/2013
Página 6 de 9
Densidad relativa: 1,146 g/cm³ (27,4°C)
(Nº CAS 577-11-7)
Solubilidad en agua (g/l) a 20°C: 8,17 g/l (pH = 5) (Nº CAS 577-11-7)
n-Octanol/agua (coeficiente de reparto n-
octanol/agua) :
No hay datos disponibles
Temperatura de auto-inflamación: No hay datos disponibles
Temperatura de descomposición: No hay datos disponibles
Viscosidad dinámica (20 °C): No hay datos disponibles
9.2 Peligros físicos:
Sin clasificar
9.3 Información adicional
Solubilidad en grasas
(solvente-aceite a especificar), etc.
No hay datos disponibles
Densidad aparente: No hay datos disponibles
Constante de disociación en agua (pKa): No hay datos disponibles
Potencial de oxidorreducción: No hay datos disponibles
Sección 10 ESTABILIDAD Y REACTIVIDAD
10.1 Reactividad:
Estable en las condiciones de transporte/almacenamiento recomendadas
10.2 Estabilidad química:
Estable a las temperaturas y presiones normales
10.3 Posibilidad de reacciones peligrosas: Ninguna reacción peligrosa conocida
10.4 Condiciones que deben evitarse:
Materiales incompatibles
Evitar llamas desnudas y fuentes de ignición
10.5 Materiales incompatibles:
Ácidos y oxidantes intensos
10.6 Productos de descomposición peligrosos:
Entre los productos de la descomposición térmica del producto están el monóxido de carbono y el
dióxido de carbono. Cuando se expone a temperaturas altas, el cuarzo libre puede cambiar su
estructura cristalina para formar tridimita (por encima de 870°C) o cristobalita (1470°C), que
presentan mayores riesgos para la salud que el cuarzo.
Sección 11 INFORMACIÓN TOXICOLÓGICA
11.1 Toxicocinética, metabolismo y distribución
No hay datos disponibles
11.2 Información sobre los efectos toxicológicos
Toxicidad aguda:
Polietilenglicol 400 (Nº CAS 25322-68-3):
FICHA DE DATOS DE SEGURIDAD – NTD-04 Issue 02
Conforme con el Reglamento (CE) Nº 1907/2006 (REACH)
Versión 2.1 Fecha de revisión: 22/02/2013
Página 7 de 9
DL50 (vía oral en ratas): 28 g/kg
DL50 (vía dérmica en conejos): No hay datos
disponibles.
CL50 (inhalación en ratas): >20 g/kg
Glicerina (glicerol) 99,5% de calidad técnica (Nº CAS 56-81-5):
DL50 (vía oral en ratas): 12600 mg/kg
DL50 (vía dérmica en conejos): >10 g/kg
CL50 (inhalación en ratas): >570 mg/m3/1H
Corrosión/irritación cutánea: No hay datos disponibles
Lesiones/irritación oculares graves: Provoca irritación ocular grave.
Sensibilización respiratoria o cutánea: No hay datos disponibles
Mutagenicidad en células germinales: No hay datos disponibles
Carcinogenicidad: No hay datos disponibles
Toxicidad reproductiva: No hay datos disponibles
STOT - exposición única: Puede irritar las vías respiratorias.
STOT - exposiciones repetidas: No hay datos disponibles
Peligro de aspiración: No hay datos disponibles
Sección 12 INFORMACIÓN ECOLÓGICA
Toxicidad:
Toxicidad aguda Tiempo Especie Método Evaluación Observaciones
CL50 Ninguno 96 h Peces OECD 203 Ninguno Ninguno
CE50 Ninguno 48 h Dáfnidos OECD 202 Ninguno Ninguno
CE50 Ninguno 72 h Algas OECD 201 Ninguno Ninguno
Persistencia y degradabilidad:
No hay datos disponibles
Potencial de bioacumulación:
No hay datos disponibles
Movilidad en el suelo:
No hay datos disponibles
Resultados de la valoración PBT y mPmB:
No hay datos disponibles
Otros efectos adversos:
No hay datos disponibles
Sección 13 CONSIDERACIONES RELATIVAS A LA ELIMINACIÓN
13.1 Métodos para el tratamiento de residuos
Póngase en contacto con un servicio de eliminación de residuos profesional autorizado. Disolver o
mezclar el material con un disolvente combustible e incinerar en una incineradora química dotada
de cámara de postcombustión y depurador. Los envases contaminados deben vaciarse de todo
residuo y, tras una limpieza adecuada, pueden enviarse a una planta de reciclaje. Los embalajes sin
FICHA DE DATOS DE SEGURIDAD – NTD-04 Issue 02
Conforme con el Reglamento (CE) Nº 1907/2006 (REACH)
Versión 2.1 Fecha de revisión: 22/02/2013
Página 8 de 9
limpiar deben desecharse de la misma manera.
Sección 14. INFORMACIÓN RELATIVA AL TRANSPORTE
Sección 15 INFORMACIÓN REGLAMENTARIA
Esta ficha de datos de seguridad cumple con los requisitos establecidos en el Reglamento (CE) Nº
1907/2006
15.1 Reglamentación y legislación en materia de seguridad, salud y medio ambiente específicas para
la sustancia o la mezcla
No hay datos disponibles
15.1 Evaluación de la seguridad química
No se ha realizado un informe sobre la seguridad química de este producto.
Sección 16 OTRA INFORMACIÓN
Texto completo de cada frase H mencionada en las secciones 2 y 3
H319: Provoca irritación ocular grave
H335: Puede irritar las vías respiratorias
Texto completo de cada frase R mencionada en las secciones 2 y 3
Xi: Irritante
R36 Irrita los ojos
R37 Irrita las vías respiratorias
Transporte
terrestre
(ADR/RID)
Transporte
marítimo
(IMDG)
Transporte aéreo
(ICAO/IATA)
Número ONU: Sin regular Sin regular Sin regular
Nombre propio de transporte
de las Naciones Unidas: Sin regular Sin regular Sin regular
Clase(s) de peligro para el
transporte: Sin regular Sin regular Sin regular
Grupo de clasificación: Sin regular Sin regular Sin regular
Peligros para el medio
ambiente: No No No
Precauciones particulares para
los usuarios: Ver sección 2.2 Ver sección 2.2 Ver sección 2.2
Transporte a granel con
arreglo al Anexo II del
Convenio Marpol 73/78 y del
Código IBC
Sin regular Sin regular Sin regular
FICHA DE DATOS DE SEGURIDAD – NTD-04 Issue 02
Conforme con el Reglamento (CE) Nº 1907/2006 (REACH)
Versión 2.1 Fecha de revisión: 22/02/2013
Página 9 de 9
16.1 Indicación de modificaciones
Ninguna
La información aquí contenida se considera correcta, pero no se puede afirmar que sea completa al 100%,
por lo que únicamente debe emplearse como guía. La información contenida en este documento se basa en
nuestros conocimientos actuales y es aplicable al producto en lo referente a las precauciones de seguridad
adecuadas. No representa garantía alguna respecto de las propiedades del producto. No se podrá
responsabilizar a Finishing Brands por los perjuicios que pudieran derivarse de la manipulación del
producto aquí descrito o del contacto con el mismo.
- Fin -
SCHEDA DATI DI SICUREZZA – NTD-04 Issue 02
In conformità con il regolamento (CE) n. 1907/2006 (REACH)
Versione 2.1 Data di revisione: 22/02/2013
pagina 1 di 9
Sezione 1 IDENTIFICAZIONE DELLA SOSTANZA E DELLA SOCIETÀ/IMPRESA
1.1 Identificatore del prodotto:
Identificativo sull'etichetta/
Nome commerciale: Panno per trattamento paraurti ‘Bumper Prep Pad’
N. CAS: Vedere la sezione 3
N. CE: Vedere la sezione 3
Numero di indice: Nessuno
Codice prodotto: Nessuno
Numero preregistrazione REACH: Nessuno
Identificazione aggiuntiva: DC-BPP-K12
1.2 Usi pertinenti identificati della sostanza e usi sconsigliati:
1.2.1 Usi identificati:
Preparazione di plastica priva di primer prima della verniciatura
1.2.2 Usi sconsigliati:
Nessun dato disponibile
1.3 Informazioni sul fornitore della scheda di dati di sicurezza:
Finishing Brands UK Ltd
Ringwood Road
Bournemouth
Dorset. BH11 9LH
Tel: 0044 (0) 1202 571111
Fax: 0044 (0) 1202 573488
Email: tech-enquiry@carlisleft.eu
1.4 Numero telefonico di emergenza:
0044 (0) 1865 407333 (24/7 Che parla solo in inglese)
Sezione 2 IDENTIFICAZIONE DEI PERICOLI
2.1 Classificazione della sostanza o della miscela
2.1.1 Classificazione in conformità con il regolamento (CE) n. 1272/2008 [CLP] (vedere la sezione 2.2
per il testo completo delle frasi H)
Grave irritazione oculare (categoria 2), H319.
Tossicità specifica per organi bersaglio (STOT) – esposizione singola (categoria 3), H335
2.1.2 Classificazione in conformità con la Direttiva 67/548/CEE (vedere la sezione 16 per il testo
completo delle frasi di rischio)
Xi Irritante per gli occhi/vie respiratorie R36/37
2.1.2.1 I principali effetti avversi fisicochimici: Nessun dato disponibile
2.1.2.2 I principali effetti avversi per la salute umana:
Provoca grave irritazione oculare
Può irritare le vie respiratorie
2.1.2.3 I principali effetti avversi per l’ambiente:
Nessun dato disponibile
SCHEDA DATI DI SICUREZZA – NTD-04 Issue 02
In conformità con il regolamento (CE) n. 1907/2006 (REACH)
Versione 2.1 Data di revisione: 22/02/2013
pagina 2 di 9
2.2 Elementi dell'etichetta
Avvertenze:
Attenzione
Indicazioni di pericolo:
H319: Provoca grave irritazione oculare
H335: Può irritare le vie respiratorie.
Consigli di prudenza:
P261: Evitare di respirare la polvere/i fumi/i gas/la nebbia/i vapori/gli aerosol
P264: Lavare accuratamente le mani dopo la manipolazione.
P271: Utilizzare soltanto all'aperto o in luogo ben ventilato
P280: Indossare guanti/indumenti protettivi/proteggere gli occhi/il viso
P304 + P340: IN CASO DI INALAZIONE: trasportare l'infortunato all'aria aperta e mantenerlo a
riposo in posizione che favorisca la respirazione
P305 + P351 + P338: IN CASO DI CONTATTO CON GLI OCCHI: sciacquare accuratamente per
parecchi minuti. Togliere le eventuali lenti a contatto se è agevole farlo. Continuare a sciacquare
P312: In caso di malessere, contattare un CENTRO ANTIVELENI o un medico
P337 + P313: Se l'irritazione degli occhi persiste, consultare un medico
P403 + P233: Tenere il recipiente ben chiuso e in luogo ben ventilato
P405: Conservare sotto chiave
P501: Smaltire il prodotto/recipiente in conformità con i regolamenti locali
2.3 Altri pericoli
Nessuna
Sezione 3 COMPOSIZIONE/INFORMAZIONI SUGLI INGREDIENTI
3.1 Sostanze
Tipo di identificatore del prodotto in conformità con l'articolo 18(2) del regolamento (CE) n. 1272/2008
Sostanza/Miscela: Miscela
Nome della sostanza N. CAS N. CE Numero
registrazione
REACH
Peso %
contenuto
Classificazione
Feldspato 68476-25-5 270-666-7 - 38,30 H319, H335
Carburo di silicio 409-21-2 206-991-8 - 25,00 Nessuna Strato in polietilene/nylon Nessuna Nessuna - 15,00 Nessuna Resina fenolo-
formaldeide indurita
9003-35-4 Nessuna - 10,00 Nessuna
Quarzo 14808-60-7 215-684-8 - 4,30 Nessuna Glicole polietilenico 400 25322-68-3 203-473-3 - 3,60 Nessuna Glicerina (Glicerolo)
99,5% Grado tecnico
56-81-5 200-289-5 - 1,40 Nessuna
Trietanolamina (TEA)
Grado industriale
102-71-6 203-049-8 - 0,90 Nessuna
C12-15 PARETH-2 68131-39-5 Nessuna - 0,70 H318, H400
Mica 12001-26-2 215-479-3 - 0,40 Nessuna
Sulfosuccinato di sodio 577-11-7 209-406-4 - 0,40 H315, H318
SCHEDA DATI DI SICUREZZA – NTD-04 Issue 02
In conformità con il regolamento (CE) n. 1907/2006 (REACH)
Versione 2.1 Data di revisione: 22/02/2013
pagina 3 di 9
Sezione 4 MISURE DI PRIMO SOCCORSO
4.1 Descrizione delle misure di primo soccorso:
4.1.1 In caso di inalazione:
Non è una via di accesso probabile. Spostare la persona colpita all'aria fresca. Se si sviluppa o
persiste irritazione o difficoltà respiratoria, consultare immediatamente un medico.
4.1.2 In caso di contatto con la pelle:
Risciacquare pelle e capelli con acqua corrente (e sapone se disponibile). Consultare un medico in
caso di irritazione.
4.1.3 In caso di contatto con gli occhi:
In caso di contatto, risciacquare immediatamente gli occhi con abbondante acqua per almeno 15
minuti. Consultare un medico se si sviluppa o persiste irritazione.
4.1.4 In caso di ingestione:
Non è una via di esposizione prevista. Se ingerito, consultare o rivolgersi immediatamente a un
medico. Non indurre il vomito.
4.2 Principali sintomi ed effetti, sia acuti che ritardati
Provoca grave irritazione oculare
Può irritare le vie respiratorie
4.3 Indicazione dell’eventuale necessità di consultare immediatamente un medico oppure di
trattamenti speciali
Contattare immediatamente un CENTRO ANTIVELENI o un medico.
Sezione 5 MISURE ANTINCENDIO
5.1 Mezzi di estinzione:
Mezzi di estinzione idonei: utilizzare mezzi di estinzione idonei per l'area circostante.
Mezzi di estinzione non idonei: nessun dato disponibile
5.2 Pericoli speciali derivanti dalla sostanza o dalla miscela
I prodotti della decomposizione termica includono il monossido di carbonio e il biossido di
carbonio. Se esposto a temperature elevate, il quarzo libero può cambiare la struttura cristallina per
formare tridimite (oltre 870 °C) o cristobalite (1470 °C) che presentano maggiori pericoli per la
salute rispetto al quarzo.
5.3 Raccomandazioni per gli addetti all’estinzione degli incendi:
Come per qualsiasi incendio, indossare un apparecchio autorespiratore a domanda di pressione.
MSHA/NIOSH (approvato o equivalente) ed equipaggiamento protettivo completo
Sezione 6 MISURE IN CASO DI RILASCIO ACCIDENTALE
6.1 Precauzioni personali, dispositivi di protezione e procedure in caso di emergenza:
Fare riferimento alla sezione 8 della scheda di dati di sicurezza per i dettagli di protezione
personale.
6.2 Precauzioni ambientali:
Per evitare una possibile contaminazione dell'ambiente, non scaricare in scarichi, acque di
SCHEDA DATI DI SICUREZZA – NTD-04 Issue 02
In conformità con il regolamento (CE) n. 1907/2006 (REACH)
Versione 2.1 Data di revisione: 22/02/2013
pagina 4 di 9
superficie o acque sotterranee di alcun tipo.
6.3 Metodi per il contenimento e per la bonifica:
Indossare l'attrezzatura e l'abbigliamento di protezione adeguati durante la bonifica. Eliminare
qualsiasi effluente sfregando con acqua e pulire accuratamente l'area.
6.4 Riferimento ad altre sezioni:
Fare riferimento alla sezione 8 della scheda di dati di sicurezza
6.5 Informazioni aggiuntive:
Nessun dato disponibile
Sezione 7 MANIPOLAZIONE E IMMAGAZZINAMENTO
7.1 Precauzioni per la manipolazione sicura:
7.1.1 Misure protettive:
Evitare il contatto con pelle e occhi. Utilizzare questo prodotto con adeguata ventilazione per la
polvere irritante. Lavare accuratamente dopo la manipolazione.
7.1.2 Raccomandazioni generiche sull’igiene professionale:
Non mangiare, bere o fumare durante l'utilizzo di questo prodotto. Lavare accuratamente le mani
dopo la manipolazione. Rimuovere gli indumenti e l'attrezzatura protettiva contaminati prima di
accedere alle aree adibite alla ristorazione.
7.2 Condizioni per l’immagazzinamento sicuro, comprese eventuali incompatibilità:
Tenere il prodotto nella confezione fino al momento dell'utilizzo
Conservare in un luogo fresco e asciutto
7.3 Usi finali specifici:
Nessun dato disponibile
Sezione 8 CONTROLLO DELL'ESPOSIZIONE/PROTEZIONE INDIVIDUALE
8.1 Parametri di controllo:
8.1.1 Limiti di esposizione professionale:
Sostanza
N. CAS
Valori limite di esposizione
professionale (periodo di
riferimento di 8 ore)
Limiti di esposizione
professionale
Valore (intervallo di riferimento
15 minuti)
ppm mg/m3 ppm mg/m
3
Quarzo, polvere
respirabile (vedere
silice cristallina)
14808-60-7 - 0,1 - -
Mica
polvere inalabile
totale
polvere respirabile
12001-26-2
-
-
10
0,8
-
-
-
-
Glicerolo, nebbia 56-81-5 - 10 - -
Trietanolamina 102-71-6 - 5 - -
Carburo di silicio 409-21-2
SCHEDA DATI DI SICUREZZA – NTD-04 Issue 02
In conformità con il regolamento (CE) n. 1907/2006 (REACH)
Versione 2.1 Data di revisione: 22/02/2013
pagina 5 di 9
polvere inalabile
totale
polvere respirabile
-
-
10
4
-
-
-
-
8.1.2 Limiti di esposizione aggiuntivi in base alle condizioni d'uso:
Nessun dato disponibile
8.1.3 DNEL/DMEL e valori PNEC:
Nessun dato disponibile
8.2 Controlli dell'esposizione
8.2.1 Controlli tecnici idonei:
Fornire un sistema di aspirazione locale e generale per rimuovere efficacemente ed evitare
l'accumulo di eventuali vapori o polveri generati dalla manipolazione di questo prodotto.
8.2.2 Misure di protezione individuale, quali dispositivi di protezione individuale:
Proteggere viso e occhi: si raccomanda l'uso di occhiali di sicurezza con ripari laterali.
Proteggere le mani: indossare guanti impermeabili.
Proteggere il corpo: si consiglia un normale abbigliamento da lavoro (maglie a maniche lunghe e
pantaloni lunghi).
Proteggere le vie respiratorie: non richiesto per il normale uso raccomandato.
8.2.3 Controlli dell'esposizione ambientale:
Evitare di scaricare nell'ambiente.
Sezione 9 PROPRIETÀ FISICHE E CHIMICHE
9.1 Informazioni sulle proprietà fisiche e chimiche fondamentali
Aspetto: Materiale abrasivo rivestito
presaturato con strato in nylon
(solido)
Colore: Nessun dato disponibile
Odore: Nessun dato disponibile
Soglia olfattiva: Nessun dato disponibile
pH: Nessun dato disponibile
Punto/intervallo di fusione: 165-170 °C (N. CAS 577-11-7)
Punto/intervallo di ebollizione (°C): > 200 °C (N. CAS 577-11-7)
Punto d'infiammabilità (°C): Nessun dato disponibile
Tasso di evaporazione: Nessun dato disponibile
Infiammabilità (solido, gas): Questo prodotto è combustibile a
temperature elevate.
Temperatura d'ignizione (°C): Nessun dato disponibile
Limiti superiore/inferiore di infiammabilità o
di esplosività:
Nessun dato disponibile
Tensione del vapore (20 °C): Nessun dato disponibile
Densità del vapore: Nessun dato disponibile
Densità relativa: 1,146 g/cm³ (27,4 °C)
(N. CAS 577-11-7)
Solubilità in acqua (g/l) a 20 °C: 8,17 g/l (pH=5) (N. CAS 577-11-7)
SCHEDA DATI DI SICUREZZA – NTD-04 Issue 02
In conformità con il regolamento (CE) n. 1907/2006 (REACH)
Versione 2.1 Data di revisione: 22/02/2013
pagina 6 di 9
n-ottanolo/acqua (log Po/w): Nessun dato disponibile
Temperatura di autoaccensione: Nessun dato disponibile
Temperatura di decomposizione: Nessun dato disponibile
Viscosità, dinamica (20 °C): Nessun dato disponibile
9.2 Pericoli fisici:
Non classificato
9.3 Altre informazioni:
Liposolubilità (solvente – grasso da
specificare) ecc.:
Nessun dato disponibile
Densità apparente: Nessun dato disponibile
Dissociazione costante in acqua (pKa): Nessun dato disponibile
Potenziale di ossidoriduzione: Nessun dato disponibile
Sezione 10 STABILITÀ E REATTIVITÀ
10.1 Reattività: Stabile in condizioni di trasporto o immagazzinamento raccomandate
10.2 Stabilità chimica:
Stabile in condizioni di temperatura e pressione normali
10.3 Possibilità di reazioni pericolose: Nessuna reazione pericolosa conosciuta
10.4 Condizioni da evitare:
Materiali incompatibili
Evitare fiamme aperte e fonti di ignizione
10.5 Materiali incompatibili:
Ossidanti e acidi forti
10.6 Prodotti di decomposizione pericolosi:
I prodotti della decomposizione termica includono il monossido di carbonio e il biossido di
carbonio . Se esposto a temperature elevate, il quarzo libero può cambiare la struttura cristallina
per formare tridimite (oltre 870 °C) o cristobalite (1470 °C) che presentano maggiori pericoli per
la salute rispetto al quarzo.
Sezione 11 INFORMAZIONI TOSSICOLOGICHE
11.1 Tossicocinetica, metabolismo e distribuzione
Nessun dato disponibile
11.2 Informazioni sugli effetti tossicologici
Tossicità acuta:
Glicole polietilenico 400 (N. CAS 25322-68-3):
DL50 (via orale, ratto): 28 g/kg
DL50 (via cutanea, coniglio): Nessun dato
disponibile
SCHEDA DATI DI SICUREZZA – NTD-04 Issue 02
In conformità con il regolamento (CE) n. 1907/2006 (REACH)
Versione 2.1 Data di revisione: 22/02/2013
pagina 7 di 9
CL50 (inalazione, ratto): > 20 g/kg
Glicerina (Glicerolo) 99,5% Grado tecnico (N. CAS 56-81-5):
DL50 (via orale, ratto): 12.600 mg/kg
DL50 (via cutanea, coniglio): > 10 g/kg
CL50 (inalazione, ratto): > 570 mg/m3/1H
Corrosione/irritazione cutanea: Nessun dato disponibile
Gravi danni/irritazioni oculari: Causa grave irritazione oculare.
Sensibilizzazione delle vie
respiratorie o cutanea: Nessun dato disponibile
Mutagenicità di cellule germinali: Nessun dato disponibile
Carcinogenicità: Nessun dato disponibile
Tossicità per la riproduzione: Nessun dato disponibile
Tossicità specifica per organi bersaglio
(STOT) – esposizione singola: Può irritare le vie respiratorie.
Tossicità specifica per organi bersaglio
(STOT) – esposizione ripetuta: Nessun dato disponibile
Pericolo in caso di aspirazione: Nessun dato disponibile
Sezione 12 INFORMAZIONI ECOLOGICHE
Tossicità:
Tossicità acuta Tempo Specie Metodo Valutazione Note
CL50 Nessuna 96h Pesci OCSE 203 Nessuna Nessuna
CE50 Nessuna 48h Dafnia OCSE 202 Nessuna Nessuna
CE50 Nessuna 72h Alghe OCSE 201 Nessuna Nessuna
Persistenza e degradabilità:
Nessun dato disponibile
Potenziale di bioaccumulo:
Nessun dato disponibile
Mobilità nel suolo:
Nessun dato disponibile
Risultati della valutazione PBT e vPvB:
Nessun dato disponibile
Altri effetti avversi: Nessun dato disponibile
Sezione 13 CONSIDERAZIONI SULLO SMALTIMENTO
13.1 Metodi di trattamento dei rifiuti
Contattare un servizio di smaltimento dei rifiuti professionale autorizzato. Sciogliere o miscelare il
materiale con un solvente combustibile e bruciarlo in un inceneritore per prodotti chimici dotato di
sistema di postcombustione e desolforatore. Gli imballaggi contaminati devono essere svuotati di
tutti i residui e, dopo un'adeguata pulizia, possono essere inviati a un impianto di riciclaggio. Gli
imballaggi non puliti devono essere smaltiti allo stesso modo.
SCHEDA DATI DI SICUREZZA – NTD-04 Issue 02
In conformità con il regolamento (CE) n. 1907/2006 (REACH)
Versione 2.1 Data di revisione: 22/02/2013
pagina 8 di 9
Sezione 14. INFORMAZIONI SUL TRASPORTO
Sezione 15 INFORMAZIONI SULLA REGOLAMENTAZIONE
La presente scheda dati di sicurezza è conforme al regolamento (CE) n. 1907/2006.
15.1 Norme e legislazione su salute, sicurezza e ambiente specifiche per la sostanza o la miscela
Nessun dato disponibile
15.1 Valutazione della sicurezza chimica
Non è stato redatto un report di sicurezza chimica per questo prodotto.
Sezione 16 ALTRE INFORMAZIONI
Il testo completo delle Frasi H viene riportato alle sezioni 2 e 3
H319: Provoca grave irritazione oculare
H335: Può irritare le vie respiratorie.
Il testo completo delle Frasi R viene riportato alle sezioni 2 e 3
Xi: Irritante
R36 Irritante per gli occhi
R37 Irritante per le vie respiratorie
16.1 Indicazioni delle modifiche
Nessuna
Le informazioni di cui sopra sono ritenute corrette, tuttavia non se ne pretende l'esaustività e devono essere
utilizzate solo come guida. Le informazioni riportate in questo documento sono basate sullo stato attuale
delle nostre conoscenze e sono applicabili al prodotto con riferimento alle adeguate precauzioni di
Trasporto terrestre
(ADR/RID)
Trasporto
marittimo
(IMDG)
Trasporto aereo
(ICAO/IATA)
Numero ONU: Non regolato Non regolato Non regolato
Nome di spedizione
dell'ONU: Non regolato Non regolato Non regolato
Classe di pericolo connesso
al trasporto: Non regolato Non regolato Non regolato
Gruppo d'imballaggio: Non regolato Non regolato Non regolato
Pericoli per l'ambiente: No No No
Precauzioni speciali per gli
utilizzatori: Vedere la sezione 2.2 Vedere la sezione 2.2 Vedere la sezione 2.2
Trasporto di rinfuse secondo
l’allegato II di MARPOL
73/78 e il codice IBC
Non regolato Non regolato Non regolato
SCHEDA DATI DI SICUREZZA – NTD-04 Issue 02
In conformità con il regolamento (CE) n. 1907/2006 (REACH)
Versione 2.1 Data di revisione: 22/02/2013
pagina 9 di 9
sicurezza. Esso non rappresenta alcuna garanzia in merito alle proprietà del prodotto. Finishing Brands non
può essere ritenuta responsabile per qualsiasi danno derivante dalla manipolazione o dal contatto con il
prodotto di cui sopra.
- Fine -
Recommended