View
225
Download
1
Category
Preview:
Citation preview
PNEUMATIC EQUIPMENTActuators
Miniature HI-ROTOR/PRN SeriesStandard Type,Variable Oscillation Angle Type
Miniature HI-PAL HI-ROTOR/PRH SeriesCubic Mount HI-ROTOR/QR Series
Standard Type,Variable Oscillation Angle Type
Step HI-ROTOR/SH SeriesHI-ROTOR/PRN SeriesHydro-cushion/CRN SeriesHydraulic HI-ROTOR/HRN SeriesRotary Actuator
2-stop Position Type/RPM SeriesMulti-stop Position Type/SRP Series
Rotary Table2-stop Position Type/TRP,TRPJ SeriesMulti-stop Position Type/TSR,TSRJ Series
Miniture Cylinder/Z3 SeriesStandard Type, Double rod Type,Cutstom Made
Miniature Cylinder/J1 SeriesStandard Type, Double rod Type,Direct Mount Type, Custom Made
Air Cylinder/K1 SeriesStandard Type, Double Rod Type,Custom Made
Air cylinder/A1 SeriesStandard Type, Double Rod Type,Custom Made
Cubic Mount Cylinder/Q1 SeriesStandard Type,Non-rotating Piston Rod Type
Flat Cylinder/X1 SeriesStandard Type, Double Rod Type,Custom Made
HI-PAL CylinderAir Cylinder With Lock MechanismHybrid-armFloat CouplerShock AbsorberParallel Gripper/GPR SeriesGrip & Rotated Parallel Gripper/GTS SeriesParallel Gripper With Cross Roller/GPCR SeriesParallel Gripper With Linear Guide/GPCL SeriesExtremely Thin Parallel Gripper/GPDL SeriesA Synchronous Type Parallel Gripper/GPEL SeriesCrab Type Parallel Gripper/GPK SeriesRotating Gripper/GVC SeriesRotating Gripper 180°Finger Opening/GVH SeriesMechanical Type Parallel Gripper/GPML SeriesMechanical Type Parallel Gripper/GPM SeriesSolenoid Valve for Vacuum VA01SeriesMulti-function Vacuum Unit/KPV SeriesVacuum Unit With Built-in Ejector/KEV SeriesVacuum SensorVacuum PadHigh Accuracy Single Axis Module/SG SeriesLight Duty Single Axis Module/KZG Series
Directional Control Valves
2 Port Solenoid Valve/AS Series2,3,4 Port Solenoid Valve/SS Series3,4 Port Miniature Solenoid Valve/SS Series4 Port Miniature Solenoid Valve/PC1B,RC1B Series3,5 Port Miniature Solenoid Valve/PC2,RC2 Series3,5 Port Solenoid Valve/PC5,RC5 Series3,5 Port Solenoid Valve/PC13,RC13 Series4,5 Port Latched Type Solenoid Valve5 Port Solenoid Valve/PC06,RC06 Series5 Port Solenoid Valve/PC08,RC08 Series5 Port Solenoid Valve/PC15 Series3 Port Miniature Solenoid Valve/A00 Series5 Port Solenoid Valve/A05,12,20 Series5 Port Solenoid Valve/K20 Series3,5 Port Solenoid Valve/PM Series3,5 Port Solenoid Valve/A SeriesManual Control Valve/HV SeriesMicro ValveManual Valve/M SeriesMechanical Valve/M Series3,5 Port Air Operated Valve/VC Series3,5 Port Air Operated Valve/YC Series5 Port Air Operated Valve/VM Series3,5 Port Air Operated Valve/V SeriesAir Operated Ball Valve/Gemini Valve
Other Equipment
Speed controller With Push-in FittingSpeed ControllerMetering ValveAir MufflerCleanup MufferMiniature In-line Filter For VacuumRotary JointQuick Exhaust ValveShuttle ValveCheck ValvePerma-stopPush-in FittingMiniature FittingTubeSpiral TubeMulti Straight Tube
Air Cleaning Equipment
QUBE Series Air Combination UnitQUBE Series Air Combination UnitQUBE Series Air FilterQUBE Series Coalescing FilterQUBE Series Sludge FilterQUBE Series Air RegulatorQUBE Series Air LubricatorQUBE Series Integral Filter-RegulatorQUBE Series Shut-off ValveAir Combination Unit
Miniature TypeAir Combination Unit
Miniature TypeAir Filter Miniature TypeSludge Filter Miniature TypeMicro Mist Filter Miniature TypeAir Regulator Miniature TypeAir Lubricator Miniature TypeIntegral Filter-Regulator
Miniature TypeRelief ValvePressure GageAir Dryer/KAD SeriesMembrane type Air Dryer Q-Fit Dryer/KMD Series
INDEX
Actuators Page 3Page 23Page 33Page 39Page 45
DirectionalControl Valves
Other Equipment
Air CleaningEquipment
Introduction ofKURODA CADLIBRARY
3
Actuators
Model No.
PRNA1S
PRNA3S
PRNA10S
PRNA20S
PRN30S
PRNA1D
PRNA3D
PRNA10D
PRNA20D
PRN30D
Vane type Oscillation angle Oscillationstarting point
Output torque(N・cm)
Pressure range(MPa)
Single vane
Double vane
90˚
90˚
90˚
90˚
90˚
45˚
45˚
45˚
45˚
45˚
28.6
71
211
388
770
0.2~0.7
0.2~1
90˚180˚270˚90˚
180˚270˚90˚
180˚270˚90˚
180˚270˚90˚
180˚270˚
45˚、90˚
45˚
45˚、90˚
45˚
45˚、90˚
45˚
45˚、90˚
45˚
45˚
12.9
31
98
170
319
0.2~1
0.2~0.7
MINIATURE HI-ROTORPRN SeriesVane type rotary actuator
● Proximity switch unit mountable.(Note)Output torque is the value at 0.5 MPa.
Model No.
PROA3S
PROA10S
PROA20S
PRO30S
PROA3D
PROA10D
PROA20D
PRO30D
Vane type Oscillation angle Oscillationstarting point
Output torque(N・cm)
Pressure range(MPa)
Single vane
Double vane
30~180˚
30~270˚
30~90˚
90˚
45˚
45˚
31
98
170
319
71
211
388
770
0.2~0.7
0.2~1
0.2~0.7
0.2~1
MINIATURE HI-ROTORVARIABLE OSCILLATIONANGLE TYPEPRO Series
● Proximity switch unit mountable.(Note)Output torque is the value at 0.5 MPa.
4
Model No.
PRHA10S
PRHA20S
PRH30S
PRHA10D
PRHA20D
PRH30D
Vane type Oscillation angle Oscillationstarting point
Output torque(N・cm)
Pressure range(MPa) Valve model
Single vane
Double vane
90˚180˚270˚90˚
180˚270˚90˚
180˚270˚
90˚
90˚
90˚
45˚、90˚
45˚
45˚、90˚
45˚
45˚
45˚
45˚
45˚
98
170
319
211
388
770
0.2~0.7
PCS245
0.2~0.8
0.2~0.7
0.2~0.8
MINIATUREHI-PAL HI-ROTORPRH SeriesValve combined HI-ROTOR
CUBIC MOUNT HI-ROTORQR Series
● Proximity switch unit mountable.(Note)Output torque is the value at 0.5 MPa.
Model No.
QR3S
QR10S
QR20S
QR30S
Vane type Oscillation angle Oscillationstarting point
Output torque(N・cm)
Pressure range(MPa)
Single vane
90˚180˚90˚
180˚270˚90˚
180˚90˚
180˚270˚
90˚
90˚
45˚
90˚
45˚
27.9
319
159
86
0.3~0.7
0.2~0.7
● Proximity switch unit mountable.(Note)Output torque is the value at 0.5 MPa.
CUBIC MOUNT HI-ROTORVARIABLE OSCILLATIONANGLE TYPEQRO Series
Model No.
QRO3S
QRO10S
QRO20S
QRO30S
Vane type Oscillation angle Oscillationstarting point
Output torque(N・cm)
Pressure range(MPa)
Single vane30~180˚
30~270˚
90˚
45˚
27.9
86
159
319
0.3~0.7
0.2~0.7
● Proximity switch unit mountable.(Note)Output torque is the value at 0.5 MPa.
STEP HI-ROTORSH SeriesUnique vane type oscillatingactuator consisting of acombination of two HI-ROTORsdesigned for 2 and 3-step feeds.
Model No.
SH5S
SH20S
SH5D
SH20D
Vane typeOscillation angle
Internal HI-ROTOR External HI-ROTOROscillationstarting point
Output torque(N・cm)Internal HI-ROTOR External HI-ROTOR
Single vane
Double vane
30~180˚
30~180˚
30~90˚
30~90˚
30~180˚
30~180˚
30~180˚
30~180˚
90˚
90˚
90˚
90˚
47.9
195
96
390
227
575
231
575
● Proximity switch unit mountable.(Note)Output torque is the value at 0.5 MPa.
5
Model No.
PRN50S
PRN150S
PRN300S
PRN800S
PRN50D
PRN150D
PRN300D
PRN800D
Vane type Oscillation angle Oscillationstarting point
Output torque(N・cm)
Pressure range(MPa)
Single vane
Double vane
1040
3500
6800
20600
0.2~1
90˚180˚270˚280˚90˚
180˚270˚280˚90˚
180˚270˚280˚90˚
180˚270˚280˚90˚
100˚90˚
100˚90˚
100˚90˚
100˚
45˚40˚、45˚
45˚40˚45˚
40˚、45˚45˚40˚45˚
40˚、45˚45˚40˚45˚
40˚、45˚45˚40˚
40˚、45˚40˚
40˚、45˚40˚
40˚、45˚40˚
40˚、45˚40˚
479
1500
2850
10200
0.2~1
HI-ROTORPRN SeriesVane type rotary actuator
●M type switch(reed type, proximity type)mountable.(Note)Output torque is the value at 0.5 MPa.
HI-PAL HI-ROTORPRH SeriesValve combined HI-ROTOR
Model No.
PRH50S
PRH150S
PRH300S
PRH800S
PRH50D
PRH150D
PRH300D
PRH800D
Vane type Oscillation angle Oscillationstarting point
Output torque(N・cm)
Pressure range(MPa) Valve model
Single vane
Double vane
90˚180˚270˚280˚90˚
180˚270˚280˚90˚
180˚270˚280˚90˚
180˚270˚280˚90˚
100˚90˚
100˚90˚
100˚90˚
100˚
45˚40˚、45˚
45˚40˚45˚
40˚、45˚45˚40˚45˚
40˚、45˚45˚40˚45˚
40˚、45˚45˚40˚
40˚、45˚40˚
40˚、45˚40˚
40˚、45˚40˚
40˚、45˚40˚
479
1500
2850
10200
1040
3500
6800
20600
0.2~0.8
PCS245
PCS2413
PCS2408
PCS245
PCS2413
PCS2408
0.2~0.8
●M type switch(reed type, proximity type)mountable.(Note)Output torque is the value at 0.5 MPa.
6
Model No.
CRN50
CRN150
CRN300
CRN800
Oscillation angle Oscillationstarting point
Range of load(N・cm)
Max.absorbed energy(mJ) Applicable HI-ROTOR
90˚100˚180˚270˚280˚90˚
100˚180˚270˚280˚90˚
100˚180˚270˚280˚90˚
100˚180˚270˚280˚
45˚40˚45˚45˚40˚45˚40˚45˚45˚40˚45˚40˚45˚45˚40˚45˚40˚45˚45˚40˚
2942
9807
19613
58840
981
2942
5884
19613
PRN50PRH50
PRN150PRH150
PRN300PRH300
PRN800PRH800
HYDRO-CUSHIONCRN SeriesShock absorber for HI-ROTOR
Model No.
HRN10SHRN10DHRN15SHRN15DHRN20SHRN20DHRN30SHRN30DHRN100SHRN100DHRN200SHRN200DHRN400SHRN400DHRN700SHRN700D
Max.oscillation angle
Min.operating pressure(MPa)
Allowable load(N)Radial Thrust
270˚90˚
270˚90˚
270˚90˚
270˚90˚
270˚90˚
270˚90˚
270˚90˚
270˚90˚
7 1
9.8
19.6
49
78.4
147
294
343
343
4.9
9.8
24.5
39.2
68.6
137.2
186.6
166.8
HYDRAULIC HI-ROTORHRN SeriesHydraulic vane type rotary actuator.
Rated pressure(MPa)
● Shaft/Double end(keyway and square)●Mounting/Flange mounting
Model No.
HRN10S-C
HRN15S-C
HRN20S-C
HRN30S-C
HRN100S-C
HRN200S-C
HRN400S-C
HRN700S-C
Max.oscillation angle
Min.operating pressure(MPa)
Allowable load(N)Radial Thrust
180˚90˚
180˚90˚
180˚90˚
180˚90˚
180˚90˚
180˚90˚
180˚90˚
180˚90˚
7 1
9.8
19.6
49
78.4
147
294
343
343
4.9
9.8
24.5
39.2
68.6
137.2
186.6
166.8
HYDRAULIC HI-ROTORWITH CUSHIONHRN SeriesHydraulic vane type rotaryactuator with cushion mechanism.
Rated pressure(MPa)
● Shaft/Double end(keyway and square)●Mounting/Flange mounting
7
2-STOP POSITION TYPEROTARY ACTUATORRPM SeriesUse of double piston system hassuccessfully realized compactdesign and high torque.
Model No.
RPM-14
RPM-16
RPM-18
RPM-22
Cylinder ID Oscillationangle
Adjustableangle range
Output torque(N・m)
Pressure range(MPa)
φ14、φ20
φ16、φ24
φ18、φ26
φ22、φ30
90˚180˚90˚
180˚90˚
180˚90˚
180˚
70˚~ 95˚160˚~185˚70˚~ 95˚
160˚~185˚70˚~ 95˚
160˚~185˚70˚~ 95˚
160˚~185˚
1.4
2.6
4.3
7.0
0.1~0.7
● RC, ZC type switch(reed type, proximity type)mountable.(Note)Output torque(theoretical output)is the value at 0.5 MPa.
2-STOP POSITION TYPEROTARY TABLETRP,TRPJ SeriesIn addition to compactly designedstandard type, a series of rotarytables with swivel joint areavailable realizing neat pipearrangement.
Model No.
TRP-16
TRP-18TRPJ-18TRP-22TRPJ-22
Cylinder ID Oscillationangle
Adjustableangle range
Output torque(N・m)
Pressure range(MPa)
φ16、φ24
φ18、φ26
φ22、φ30
90˚180˚90˚
180˚90˚
180˚
70˚~ 95˚160˚~185˚70˚~ 95˚
160˚~185˚70˚~ 95˚
160˚~185˚
2.6
4.3
7.0
0.1~0.7
● RC, ZC type switch(reed type, proximity type)mountable.(Note)Output torque(theoretical output)is the value at 0.5 MPa.
MULTI-STOP POSITION TYPEROTARY TABLETSR,TSRJ SeriesIn addition to compactly designedstandard type, a series of rotarytables with swivel joint areavailable, realizing neat pipearrangement.
Model No.
TSR-16
TSR-18TSRJ-18TSR-22TSRJ-22
Cylinder ID Oscillationangle
Adjustableangle range
Output torque(N・m)
Pressure range(MPa)
φ16、φ24
φ18、φ26
φ22、φ30
max.180˚ 120˚~185˚
0.8
1.4
2.1
0.2~0.7
● RC, ZC type switch(reed type, proximity type)mountable.(Note)Output torque(theoretical output)is the value at 0.5 MPa.
MULTI-STOP POSITION TYPEROTARY ACTUATORSRP SeriesUse of double piston system hassuccessfully realized compactdesign and high torque.
Model No.
SRP-13SRP-14SRP-16SRP-18SRP-22
Cylinder ID Oscillationangle
Adjustableangle range
Output torque(N・m)
Pressure range(MPa)
φ13、φ18φ14、φ22φ16、φ24φ18、φ26φ22、φ30
max.180˚ 120˚~185˚
0.240.450.81.42.1
0.3~0.7
0.2~0.7
● RC, ZC type switch(reed type, proximity type)mountable.(Note)Output torque(theoretical output)is the value at 0.5 MPa.
8
MINIATURE CYLINDERZ3 SeriesNon-lubricated air applicable.
Series
Z3○1
Z3○0
Z3○2
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Single acting(Retracted)
Single acting(Extended)
Doubleacting
φ2.5φ4φ6φ10φ16φ6φ10φ16φ6φ10φ16
5、05、10、15、20
15、30、45、60
15、30
15、30、45、60
0.35~0.7
0.3~0.7
0.15~0.7
0.35~0.7
0.15~0.7
0.12~0.70.08~0.70.06~0.7
●Mounting/Boreφ2.5~φ4:Nose mounting onlyBoreφ6,φ10,φ16:Nose, Foot, Flange and Female clevis mounting
● Switch/Boreφ6,φ10,φ16:M type switch(reed type, proximity type)mountable.●Cushion/Boreφ2.5,φ4:Non-cushion Bore φ6,φ10,φ16:Rubber cushion
MINIATURE CYLINDERDOUBLE ROD TYPEZ3○7 Series
Series
Z3○7
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Double actingφ10φ16
15、30、45、60 0.1~0.7
●Mounting/Nose, Foot and Flange mounting● Switch/M type switch(reed type, proximity type)mountable.●Cushion/Rubber cushion
Acting Bore size(mm)
Pressure range(MPa)
φ10φ16φ10φ16φ10φ16
0.15~0.7
0.2~0.7
0.1~0.7
CUSTOM MADECYLINDER
Non rotating piston rod cylinder/Z3○U
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ10、φ16
0.1~0.7
Cylinder built-in speed controller/Z3GP2A miniature speed controller(Meter-out type)is built-in
Single acting(Retracted)Single acting(Extended)
Double acting
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ10、φ16
φ10:0.2~0.7φ16:0.1~0.7
Cylinder with air cushion/Z3G2
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ10、φ16
φ10:0.12~0.7φ16:0.10~0.7
Cylinder built-in linear bearing/Z3GB2
9
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ10、φ16
0.1~0.7
CUSTOM MADECYLINDER
Dual stroke cylinder/Z3○D2This cylinder consists of two cylindersconnected in series and united as one unit.The stroke is controlled in two steps.
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ10、φ16
φ10:0.08~0.7φ16:0.06~0.7
Dual stroke cylinder/Z3○D7This cylinder consists of two cylinders connectedon both head cover side form one unit.The stroke is controlled in three steps.
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ10、φ16
0.1~0.7
Adjustable stroke cylinder/Z3○A7On the end where the rod is extended, the stroke isadjustable with stopper within a range of 0 to 15mm.
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ10、φ16
φ10:0.08~0.7φ16:0.06~0.7
Adjustable stroke cylinder/Z3○A2On the rod retracted end, the stroke is adjustablewith a adjustable bolt within a range of 0 to 15mm.
Air-hydro cylinder/Z3○OCylinders of this series are for Air-hydrosystems and are suitable for use at low speedsof 50mm/s or less.
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ6、φ10、φ16
φ 6:0.3 ~0.7φ10:0.2 ~0.7φ16:0.15~0.7
High-temperature resistant cylinder/Z3○ZSince cylinders of this series use packings etc.made of heat-resistant materials, they canoperate at high temperatures up to 150℃
Acting
Double acting
Single acting(Retracted)
Bore size(mm)
Pressure range(MPa)
φ 6φ10φ16φ 6φ10φ16
0.35~0.7
0.15~0.7
0.15~0.70.1~0.70.08~0.8
Cylinder for use in clean room/CFZ3
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ6、φ10、φ16
φ 6:0.3 ~0.7φ10:0.2 ~0.7φ16:0.15~0.7
10
Series
J1○1
J1○0
J1○2
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Single acting(Retracted)
Single acting(Extended)
Double acting
φ20
φ25
φ32
φ40
φ50
φ63
φ20φ25φ32φ40φ20φ25φ32φ40
0.15~1
0.15~1
0.05~1
0.02~1
MINIATURE CYLINDERJ1 SeriesNon-lubricated air applicable.
Series
J1○7
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Double acting
φ20
φ25
φ32
φ40
φ50
φ63
25、50、75、100、125、150
25、50、75、100、125、150、175、200
25、50、75、100、125、150
25、50、75、100、125、150、175、200
15、25、30、50、75、100、125、150、175、200
15、25、30、50、75、100、125、150、175、200、250、300
15、25、30、50、75、100、125、150175、200、250、300、350、400
15、25、30、50、75、100、125、150、175200、250、300、350、400、450、500
25、50、75、100、150、200、250300、350、400、450、500
15、25、30、50、75、100、125、150、175、200
15、25、30、50、75、100、125、150、175、200、250、300
15、25、30、50、75、100、125、150175、200、250、300、350、400
15、25、30、50、75、100、125、150、175200、250、300、350、400、450、500
25、50、75、100、150、200、250300、350、400、450、500
0.05~1
0.02~1
MINIATURE CYLINDERDOUBLE ROD TYPEJ1○7 Series
●Mounting/Nose, Foot and Flange mounting● Switch/AX, ZC type switch(reed type, proximity type)mountable.●Cushion/Boreφ20~φ40:Rubber cushion Boreφ50,φ63:Air cushion● Specific type/Bellows
●Mounting/Nose, Foot and Flange mounting● Switch/AX, ZC type switch(reed type, proximity type)mountable.●Cushion/Boreφ20~φ40:Rubber cushion Boreφ50,φ63:Air cushion● Specific type/Bellows
11
DIRECT MOUNT CYLINDERJ1○E SeriesThe rectangular rod cover of thecylinder is directly mountable onthe unit to be mated.Using this cylinder will result notonly in saving space but alsoimproving the mounting strengthand accuracy.
Series
J1○E1
J1○E0
J1○E2J1○E7
Acting Bore size(mm) Standard stroke(mm) Pressure range
(MPa)
Single acting(Retracted)
Single acting(Extended)
Double acting
φ20
φ25
φ32
φ40
φ50
φ63
φ20φ25φ32φ40φ20φ25φ32φ40
25、50、75、100、125、150
25、50、75、100、125、150、175、200
25、50、75、100、125、150
25、50、75、100、125、150、175、200
15、25、30、50、75、100125、150、175、200
15、25、30、50、75、100125、150、175、200、250、300
15、25、30、50、75、100、125、150175、200、250、300、350、400
15、25、30、50、75、125、150、175200、250、300、350、400、450、500
25、50、75、100、150、200、250300、350、400、450、(500)
0.15~1
0.15~1
0.05~1
0.02~1
● Supporting type/Front mount type, side mount type● Switch/AX, ZC type switch(reed type, proximity type)mountable.●Cushion/Boreφ20~φ40:Rubber cushion Bore φ50,φ63:Air cushion
Acting Bore size(mm)
Pressure range(MPa)
φ25φ40φ25φ40φ25φ40φ50φ63φ25φ40φ50φ63
0.15~1
0.15~1
0.1~1
0.05~1
0.1~1
0.05~1
CUSTOM MADECYLINDER
Non-rotating piston rod cylinder/J1○U
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ20、φ25、φ32、φ40
φ50、φ63φ20~φ40:0.05~1φ50、φ63:0.02~1
Short length cylinder/J○NDCylinders short in overall length:The nose screw portion on the head cover hasbeen cut off.
Single acting(Retracted)Single acting(Extended)
Double acting
Double acting(Double rod)
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ20、φ25、φ32、φ40
0.1~1
Stainless steel cylinder/J1○SThe cylinder tube, rod cover and head cover,piston rod are made of stainless steel.
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ20、φ25、φ32、φ40
0.1~1
High-temperature resistant cylinder/J1○XSince cylinders of this series use packings etc.made of heat-resistant materials, they canoperate at high temperatures up to 120℃
12
CUSTOM MADECYLINDER
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ20、φ25、φ32、φ40
φ50、φ63φ20~φ40:0.05~1φ50、φ63:0.02~1
Port position in direction ofpiston axis/J1GNB
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ20、φ25、φ32、φ40
φ50、φ63
0.1~1
Dual stroke cylinder/J1○D2This cylinder consists of two cylindersconnected in series and united as one unit.The stroke is controlled in two steps.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ20、φ25、φ32、φ40
φ50、φ63
0.1~1
Dual stroke cylinder/J1○D7This cylinder consists of two cylinders connectedon both head cover sides from one unit.The stroke is controlled in three steps.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ20、φ25、φ32、φ40
φ50、φ63
0.1~1
Adjustable stroke cylinder/J1○A7On the end where the rod is extended, thestroke is adjustable with a stopper within arange of 0 to 50 mm.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ20、φ25、φ32、φ40
φ50、φ63
0.1~1
Adjustable stroke cylinder/J1○A2On the rod retracted end, the stroke is adjustablewith a adjustable bolt within a range of 0 to 50 mm.
Series
K1○2
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Double acting
φ32φ40φ50φ63φ80φ100φ125
50、75、100、125、150、200、250300、350、400、450、500
0.05~1
AIR CYLINDERK1 SeriesNon-lubricated air applicable.
●Mounting/Nose, Foot, Flange, Male clevis, Femals clevis and Trunion mounting● Switch/AX, SR type switch(reed type, proximity type)mountable.●Cushion/Air cushion● Specific type/Bellows
13
Series
K1○7
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Double acting
φ32φ40φ50φ63φ80φ100φ125
50、75、100、125、150、200、250300、350、400、450、500
0.1~1
AIR CYLINDERDOUBLE ROD TYPEK1○7 Series
●Mounting/Nose, Foot, Flange, mounting● Switch/AX, SR type switch(reed type, proximity type)mountable.●Cushion/Air cushion● Specific type/Bellows
CUSTOM MADECYLINDER
Acting
Single acting(Retracted)
Bore size(mm)
Pressure range(MPa)
φ40φ50φ63φ80φ100
0.1~1
Non-rotating piston rod cylinder/K1○U
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ32、φ40、φ50、φ63、φ80
0.05~1
Cylinder with hollow rod/K1○RPThe hollow piston rod allows the passage of airpressure, etc.
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ40、φ50、φ63、φ80、φ100
0.1~0.7
Dual stroke cylinder/K1○D2This cylinder consists of two cylindersconnected in series and united as one unit.The stroke is controlled in two steps.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ32、φ40、φ50、φ63φ80、φ100、φ125
0.05~0.7
Dual stroke cylinder/K1○D7This cylinder consists of two cylinders connectedon both head cover sides from one unit.The stroke is controlled in three steps.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ32、φ40、φ50、φ63φ80、φ100、φ125
0.1~1
Adjustable stroke cylinder/K1○A7On the end where the rod is extended, thestroke is adjustable with a stopper within arange of 0 to 50 mm.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ32、φ40、φ50、φ63φ80、φ100、φ125
0.05~1
Adjustable stroke cylinder/K1○A2On the rod retracted end, the stroke isadjustable with a adjustable bolt within a rangeof 0 to 50 mm.
14
CUSTOM MADECYLINDER
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ40、φ50、φ63、φ80、φ100
0.05~1
High-temperature resistant cylinder/K1○XSince cylinders of this series use packingsmade of special materials, they can operate athigh temperatures up to 120℃
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ32、φ40、φ50、φ63
φ80、φ100
0.2~1
Air-hydro cylinder/K1○OCylinders of this series are for Air-hydrosystems and are suitable for use at low speedsof 50 mm/s or less.
Series
A1○2
Acting Bore size(mm)
Maximum stroke(mm)
Pressure range(MPa)
Double acting
φ125φ140φ160φ180φ200φ250
2000 0.1~1
AIR CYLINDERA1 SeriesHeavy duty type cylinder.
●Mounting/Nose, Foot, Flange, Male clevis, Female clevis and Trunion mounting● Switch/AX, SR type switch(reed type, proximity type)mountable.●Cushion/Air cushion● Specific type/Bellows
Series
A1○7
Acting Bore size(mm)
Maximum stroke(mm)
Pressure range(MPa)
Double acting
φ125φ140φ160φ180φ200φ250
1200 0.1~1
AIR CYLINDERDOUBLE ROD TYPEA1○7 Series
●Mounting/Nose, Foot and Flange mounting● Switch/AX, SR type switch(reed type, proximity type)mountable.●Cushion/Air cushion● Specific type/Bellows
CUSTOM MADECYLINDER
Acting
Pressure range(MPa)
Bore size(mm)
Double acting
φ125、φ140、φ160
0.1~1
Adjustable stroke cylinder/A1○A2On the rod retracted end, the stroke is adjustablewith a adjustable bolt within a range of 0 to 50 mm.
15
Series
Q1○1
Q1○0
Q1○2
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Single acting(Retracted)
Single acting(Extended)
Double acting
φ6φ10φ16φ20φ25φ32φ6φ10φ16φ20φ25φ32φ6φ10φ16φ20φ25φ32
5、10、15
5、10、15
5、10、15、20、25、30
5、10、15、20、25、30、40、50
0.3~0.7
0.15~0.7
0.2~0.7
0.35~0.7
0.15~0.7
0.2~0.7
0.15~0.7
0.1~0.7
COMPACT CUBIC MOUNTCYLINDERQ1 SeriesRigidly desidned cubical bodyimproves design flexibility andaccuracy.
● Supporting type/Rod side mount type, Head side mount type and Solid mount type● Switch/K type switch(reed type, proximity type)mountable.●Cushion/Rubber cushion
Series
Q1○U2
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Double acting
φ6φ10φ16φ20φ25φ32
5、10、15、20、25、30
5、10、15、20、25、30、40、50
0.15~0.7
0.1~0.7
NON-ROTATING PISTON ROD TYPECOMPACT CUBIC MOUNTCYLINDERQ1○U Series
● Supporting type/Head side mount type● Switch/K type switch(reed type, proximity type)mountable.●Cushion/Rubber cushion
Series
X1○1
X1○0
X1○2
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Single acting(Retracted)
Single acting(Extended)
Double acting
φ12φ16φ20φ25φ32φ40φ50φ12φ16φ20φ25φ32φ40φ50φ12φ16φ20φ25φ32φ40φ50φ63φ80φ100φ125φ140φ160
5、10、15、20、25、30
5、10、15、20、25、30、35、40、45、5010、15、20、25、30、35、40、45、50
5、10
10、20
5、10、15、20、25、30
5、10、15、20、25、30、3540、45、50、55、60、65、70
5、10、15、20、25、30、35、40、4550、55、60、65、70、75、80、90、100
10、15、20、25、30、35、40、45、5055、60、65、70、75、80、90、100
10、20、30、40、50、75、100、125150、175、200、250、300
5、10、15、20 0.2~1
0.18~1
0.12~1
0.2~1
0.18~1
0.12~1
0.1~1
0.05~1
FLAT CYLINDERX1 SeriesSlim and space-saving designsuitable for clamping work.
● Rod end screw/Female screw(Standard), Male screw●Mounting/Nose, Both sides tap, Foot, Flange, Female clevis and Male clevis mounting● Switch/ZE, AX, AZ type switch(reed type, proximity type)mountable.●Cushion/Rubber cushion
16
Series
X1○7
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Double acting
φ12φ16φ20φ25φ32φ40φ50φ63φ80φ100φ125φ140φ160
5、10、15、20、25
5、10、15、20、25、30
5、10、15、20、25、30、35、40、45、50
10、15、20、25、30、35、40、45、50
10、20、30、40、50、75、100、125150、175、200、250、300
0.1~1
0.05~1
FLAT CYLINDERDOUBLE ROD TYPEX1○7 Series
● Rod end serew/Female screw(Standard), Male screw●Mounting/Nose, Both sides tap, Foot and Flange mounting● Switch/ZE, AX type switch(reed type, proximity type)mountable.●Cushion/Rubber cushion
CUSTOM MADECYLINDER
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ20、φ25、φ32、φ40φ50、φ63、φ80、φ100φ20~φ50:0.1~1φ63~φ100:0.05~1
Non-rotating piston rod Flat CylinderX1○U2
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ12、φ16、φ20、φ25、φ32φ40、φ50、φ63、φ80、φ100
φ12~φ32:0.1~7φ40~φ100:0.05~0.7
Flat Cylinder with hollow rodX1○RPThe hollow piston rod allows the passage of airpressure, etc.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ12、φ16、φ20、φ25、φ32φ40、φ50、φ63、φ80、φ100
φ12~φ32:0.1~1φ40~φ100:0.05~1
Dual stroke Flat CylinderX1○D2This cylinder consists of two cylinders connectedin series and united as one unit. The stroke iscontrolled in two steps.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ12、φ16、φ20、φ25、φ32φ40、φ50、φ63、φ80、φ100
φ12~φ32:0.1~1φ40~φ100:0.05~1
Dual stroke Flat CylinderX1○D7This cylinder consists of two cylinders connectedon both head cover sides from one unit. Thestroke is controlled in tree steps.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ12、φ16、φ20、φ25、φ32φ40、φ50、φ63、φ80、φ100
φ12~φ32:0.1~1φ40~φ100:0.05~1
Adjustable stroke Flat CylinderX1○A7On the end where the rod is extended, the strokeis adjustable with a stopper within a range of 0 to10 mm.
Acting
Pressure range(MPa)
Bore size(mm)
Double actingφ12、φ16、φ20、φ25、φ32φ40、φ50、φ63、φ80、φ100
φ12~φ32:0.1~1φ40~φ100:0.05~1
Adjustable stroke Flat CylinderX1○A2On the rod retracted end, the stroke is adjustablewith a adjustable bolt within a range of 0 to 10 mm.
17
Series
J1○HA2
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Double acting
φ20
φ25
φ32
φ40
15、25、30、50、75、100125、150、175、200
15、25、30、50、75、100125、150、175、200、250、300
15、25、30、50、75、100、125、150175、200、250、300、350、400
15、25、30、50、75、100、125、150、175200、250、300、350、400、450、500
0.2~0.7
HI-PAL CYLINDERJ1○HA SeriesValve combined cylinder.
●Mounting/Nose, Foot, Flange and Trunion mounting● Switch/AX, SR, ZC type switch(reed type, proximity type)mountable.●Cushion/Rubber cushion(Standard)● Specific type/Bellows
Series
K1○HA2
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Double acting
φ40φ50φ63φ80φ100
100、125、150、200、250300、350、400、450、500
0.2~0.8
HI-PAL CYLINDERK1○HA SeriesValve combined cylinder.
●Mounting/Nose, Foot, Flange, Male clevis, Female clevis and Trunion mounting● Switch/AX, SR type switch(reed type, proximity type)mountable.●Cushion/Air cushion● Specific type/Bellows
Series
J1○L2
Acting Bore size(mm)
Standard stroke(mm)
Pressure range(MPa)
Double acting
φ20
φ25
φ32
φ40
15、25、30、50、75、100125、150、175、200
15、25、30、50、75、100125、150、175、200、250、300
15、25、30、50、75、100、125、150175、200、250、300、350、400
15、25、30、50、75、100、125、150、175200、250、300、350、400、450、500
0.2~1
MINIATURE CYLINDERWITH LOCK MECHANISMJ1○L SeriesBuilt-in drop prevention anddesigned to lock at stroke end.
●Mounting/Nose, Foot, Flange and Trunion mounting● Switch/AX, SR, ZC type switch(reed type, proximity type)mountable.●Cushion/Rubber cushion(Standard)● Specific type/Bellows
Series
K1○L2
Acting Bore size(mm)
Maximum stroke(mm)
Pressure range(MPa)
Double acting
φ40φ50φ63φ80φ100
1000
15000.15~1
AIR CYLINDERWITH LOCK MECHANISMK1○L SeriesBuilt-in drop prevention anddesigned to lock at stroke end.
●Mounting/Nose, Foot, Flange, Male clevis, Female clevis and Trunion mounting● Switch/AX, SR type switch(reed type, proximity type)mountable.●Cushion/Air cushion● Specific type/Bellows
SeriesCylinder HI-ROTOR
HA-25HA-32HA-40
Acting Bore size(mm)
Standard stroke(mm) Oscillation angle Output torque
(N・cm)
Pressure range(MPa)
Double actingφ25φ32φ40
25、50、75、100 90˚、180˚95.1
161.8337.3
0.3~0.7
HYBRID-ARM EXCELHA SeriesCombination of cylinder and HI-ROTOR realizes linear andoscillation motion with 0.8 degreebacklash.
●Mounting/Through holes(Standard), Flange mounting● Switch/Cylinder:M type switch(reed type, proximity type)mountable.
HI-ROTOR:Proximity switch unit mountable.●Cushion/Cylinder:Rubber custion(φ20,φ25), Air cushion(φ32,φ40)(Note)Output torque is the value at 0.5 MPa.
18
Model No.
SA-0805AA1SA-0805AA2SA-1005AA1SA-1005AA2SA-1008AA1SA-1008AA2SA-1210AA1SA-1210AA2SA-1412AC1SA-1412AC2SA-1008BB1SA-1210BB1SA-1410BB1SA-1612BB1SA-2016BB1SA-2530BB1SA-2540BB1SA-2725BB1SA-1008CC1SA-1210CC1SA-1410CC1SA-1612CC1SA-2016CC1SA-2530CC1SA-2540CC1SA-2725CC1SA-3035CC1SA-3650CC1SA-4250CC1SA-4280CC1SA-1008CD1SA-1210CD1SA-1410CD1SA-1612CD1SA-2016CD1SA-2530CD1SA-2540CD1SA-2725CD1SA-3035CD1SA-3650CD1SA-4250CD1SA-4280CD1SAE-2010SAE-3020SAR-1415AC1SAR-1415AC2
Adjustment Stroke absorption(mm)
Max. absorbed energy(J) Option
Fixed type
Analogadjustingtype
Analogfine adjustingtype
Analogfine adjustingtype
Fixed type
Fixed type
5
5
8
10
12
8101012163040258
10101216304025355050808
101012163040253550508010201515
0.3920.6860.6860.980.981.471.962.453.925.881.472.943.929.8
29.44963.779.41.474.95.889.8
29.44963.779.4
196392441720
1.764.95.889.8
29.44963.779.4
19639244172019.69811.7619.6
Max. collision speed(m/s)
1
1
1
1
1.5
121.5211113333333333332222222222222222
Stopper nutDeflection angleadapter
Stopper nutDeflection angleadapter
Stopper nutDeflection angleadapter
Stopper nutDeflection angleadapter
Stopper nutDeflection angleadapter
Stopper nut
Stopper nutDeflection angleadapter
───
───
───
Stopper nut
Stopper nut
Stopper nut
Stopper nutDeflection angle adapter
SHOCK ABSORBERSA,SAE SeriesCompact design and large absorbingcapacity. Various types are availableaccording to your load and speedrequirements.
● SA:Spring return SAE:For emergency purpose SAR:Air return
Model No.
FCM3-0.5FCM4-0.7FCM5-0.8FCM6-1FCM8-1.25FCM10-1.25FCM10-1.5FCM12A-1.25FCM12A-1.5FCM14A-1.5FCM18A-1.5FCM22A-1.5FCM26A-1.5FCM30-1.5FCM40-1.5FCM45-1.5
Applicable cylinder bore size Oscillation angle Allowable eccentricity(mm) Mounting
Z3φ6、Q1φ6Z3φ10、Q1φ10Z3φ16、Q1φ16
Q1φ20J1φ20、Q1φ25K1φ32、Q1φ32
J1φ25J1φ32
JGBCφ40J1φ40、K1φ40
J1φ50、φ63、K1φ50、φ63K1φ80K1φ100
K1φ125、A1φ125、φ140A1φ160、φ180
A1φ200
±5˚
0.5
0.75
1.01.52.0
3.0
4.0
Direct mounting
Dirct mountingFlange mounting
Foot mounting
FLOAT COUPLERFC SeriesAbsorbs inclination and eccentricitybetween cylinder and piston rodand aligns shaft center.
19
Model No.
GPR1AGPR3AGPR10A
Acting Gripping force(N)
Max.stroke(mm)
Pressure range(MPa)
Double acting17.733.372.5
101420
0.3~0.60.2~0.6
PARALLEL GRIPPERGPR,SeriesHI-ROTOR generates stronggripping force and large stroke.
●Mounting/Through holes and Tap mounting● Switch/PA type switch(proximity type)mountable.(Note)Gripping force is the value at 0.5 MPa
Model No.
GTS5SGTS2O
Acting Gripping force(N)
Max.stroke(mm)
Pressure range(MPa)
Double acting45
1372024
0.3~0.6
GRIP & ROTATEDPARALLEL GRIPPERGTS SeriesCombing gripping with rotatemotion. Rotate angle is adjustableby external stopper.
●Mounting/Tap and Flange mounting● Switch/PB type switch(proximity type)mountable.(Note)Gripping force is the value at 0.5 MPa
Model No.
GPCR-10CGPCR-16CGPCR-20CGPCR-25CGPCR-10AGPCR-16AGPCR-20AGPCR-25A
Acting Gripping force(N)
Max.stroke(mm)
Pressure range(MPa)
Double acting
Normally opensingle acting
9.425.545.7674.9
2136.454
48
121448
1214
0.18~0.70.12~0.7
0.1~0.7
0.35~0.7
0.25~0.7
PARALLEL GRIPPERWITH CROSS ROLLERGPCR SeriesHigh degree of gripping accuracyand rigidity.Dustproof cover and adaptor
●Mounting/Through holes, Tap and Mounting adapter● Switch/ZE type switch(proximity type)mountable.(Note)Gripping force is the value at 0.5 MPa
Model No.
GPCL-8CGPCL-10CGPCL-16CGPCL-20CGPCL-32CGPCL-50CGPCL-8AGPCL-10AGPCL-16AGPCL-20A
Acting Gripping force(N)
Max.stroke(mm)
Pressure range(MPa)
Double acting
Normally opensingle acting
5.789.4
2645
157.8347.9
4.16.8
2034
46.5
1014223646.5
1014
0.22~0.70.2~0.70.12~0.7
0.1~0.7
0.4~0.70.35~0.7
0.25~0.7
PARALLEL GRIPPERWITH LINEAR GUIDEGPCL SeriesHigh degree of repeatability:±0.01 mm or lessHigh degree of centering accuracy:±0.07 mm or less
●Mounting/Through holes, Tap and Mounting adapter● Switch/ZE type switch(proximity type)mountable.(Note)Gripping force is the value at 0.5 MPa
Model No.
GPDL-8GPDL-12GPDL-14GPDL-18
Acting Gripping force(N)
Max.stroke(mm)
Pressure range(MPa)
Double acting
16.74458.8
107.8
1622
30、6040、80
0.2~0.7
0.15~0.7
EXTREMELY THIN PARALLELGRIPPER WITH LINEAR GUIDEGPDL SeriesHigh degree of gripping accuracyand rigiclity.Adjustable stroke in both openingand closing directions. ●Mounting/Through holes and Tap mounting
● Switch/ZE type switch(proximity type)mountable.(Note)Gripping force is the value at 0.5 MPa
20
Model No.
GPEL-8JAGPEL-8JBGPEL-12JAGPEL-12JB
Acting Gripping force(N)
Max.stroke(mm)
Pressure range(MPa)
Double acting16.8
44.2
16
22
0.2~0.7
0.15~0.7
ASYNCHRONOUS TYPEPARALLEL GRIPPERWITH LINEAR GUIDEGPEL SeriesAsynchronous type designed togrip work based on the stopposition of the single side finger.The stop position of the singleside finger can be easily adjustedwith a screw.
●Mounting/Tap mounting● Switch/ZE type switch(proximity type)mountable.(Note)Gripping force is the value at 0.5 MPa
Model No.
GPK-12GPK-16GPK-20GPK-25
Acting Gripping force(N)
Max.stroke(mm)
Pressure range(MPa)
Double acting
27.852.282.1
143.3
24324050
0.2~0.7
CRAB TYPE PARALLELGRIPPERGPK SeriesHigh gripping force and high rigidity.Long gripping stroke, lightweightand compact body.
●Mounting/Through holes and Tap mounting● Switch/ZE type switch(proximity type)mountable.(Note)Gripping force is the value at 0.5 MPa
Model No.
GVH-12GVH-16GVH-20GVH-25
Acting Gripping force(N)
Max.stroke(mm)
Pressure range(MPa)
Double acting
0.71.83.27.3
-6~+180 0.2~0.7
ROTATING GRIPPER WITH180° FINGER OPENINGGVH SeriesHigh gripping force and high degreeof gripping accuracy.Finger opening angle of 180°
●Mounting/Through holes, Tap and Mounting adapter● Switch/ZE type switch(proximity type)mountable.(Note)Gripping force is the value at 0.5 MPa
Model No.
GVC-8CGVC-10CGVC-16CGVC-20CGVC-25CGVC-8AGVC-10AGVC-16AGVC-20AGVC-25A
Acting Gripping force(N)
Max.stroke(mm)
Pressure range(MPa)
Double acting
Normally opensingle acting
22.5
12.824481.41.4
101838
-10~+30
0.22~0.7
0.1~0.7
0.36~0.70.3~0.7
0.2~0.7
ROTATING GRIPPERGVC SeriesThe finger is made of chromiummolybdenum steel and the mainpart is hardened, assuring longservice.
●Mounting/Through holes, Tap and Mounting adapter● Switch/ZE type switch(proximity type)mountable.(Note)Gripping force is the value at 0.5 MPa
21
Model No.
GPML-8-LGPML-8-MGPML-10-LGPML-10-MGPML-16-LGPML-16-MGPML-20-LGPML-20-M
Acting Gripping force(N)
Max.stroke(mm)
Single acting
1.62.53.44.54.46.46.58.3
4.0
6.5
10
14
MECHANICAL TYPEPARALLEL GRIPPERWITH LINEAR GUIDEGPML Series・Mechanical type without air line.・Gripping by spring force.
Outside dia gripping by spring force.Selecting spring force by work.
・External force is used for opening.・High accuracy, long life.
Model No.
GPM-10-LGPM-10-MGPM-16-LGPM-16-MGPM-20-LGPM-20-M
Acting Gripping force(N)
Max.stroke(mm)
Single acting
3.44.54.46.46.58.3
4
8
12
MECHANICAL TYPEPARALLEL GRIPPERGPM Series・Mechanical type without air line.・Variation of spring tension.・Using external force for operation.・NC/NO type
Model No.
VA01PSV23
VA01PSP23
Mounting Port Solenoid Positions Port size Flow rate(R/min(ANR))
Sub-basemountingSub-basemounting
3
3
Single
Single
2
2
M5
M5
22(at–100kPa)
40(at0.5MPa)
SOLENOID VALVEFOR VACUUMVA01 SeriesMost suitable for vacuum andvacuum break control・Compact and lightweight・Minimized vacuum leak・Quick response time・Mountable on manifold・Usable for air blow
Direct Operate/Rubber Seal/Poppet
● Voltage/DC24V●Wiring/Lead wire, Connector with lead wire
Model No.
VA01RDP33
VA01PEP34
Mounting Port Solenoid Positions Port size Flow rate(R/min(ANR))
In-linemountingSub-basemounting
3
4
Double
Double
3
3
M5
M5
10 (at–90kPa)8 (at 0.2MPa)
10 (at–100kPa)8 (at 0.5MPa)
SOLENOID VALVEFOR VACUUMVA01 SeriesMost suitable for attraction andconveyance of very small work・Lightweight and compact・One unit works for both
Vacuum control and vacuumBreak controls.・Quick response time・Throttle valve for vacuum
Break flow control・Atmospheric release mechanism・Manifolding
Direct Operate/Rubber Seal/Poppet
● Voltage/DC24V●Wiring/Lead wire (VA01RDP33 only), Connector with lead wire
22
Model No.
KPV
Port size Degree of attainable vacuum(kPa)
Operating pressure range(MPa)
Port V:M5、Rc¹⁄₈
Port P、VP:Rc¹⁄₈-93.3 0.3~0.5
MULTI-FUNCTIONVACUUM UNITKPV SeriesMost suitable for conveyorsystems using vacuum pumps. ● Voltage/DC12, 24V AC100, 200V(50/60Hz)
●Wiring/Plug-in connector
Model No.
KEV-□05HKEV-□07HKEV-□10HKEV-□05LKEV-□07L
Port size Degree of attainable vacuum(kPa)
Operating pressure range(MPa)
Port P:Rc¹⁄₈
Port V:M5
-86.6
-53.3
0.15~0.6
VACUUM UNITWITH BUILT-IN EJECTORKEV SeriesEjector, evacuator control valve,vacuum release valve, vacuumfilter, vacuum sensor and silencerare united into one body.
● Voltage/DC12, 24V AC100, 200V(50/60Hz)●Wiring/Plug-in connector
Model No.
NAPFNAPUNAPJNAPAPFPU
Buffer function Pad type
Spring type
Fixed type
Standard padGooseneck pad
Bellows padThin pad
Standard padGooseneck pad
Pad diameter(mm)
φ2~φ200φ10~φ200φ6~φ80φ10~φ50φ2~φ200φ10~φ200
VACUUM PADVacuum pad is a device forgripping workpiece directly byvacuum(sucking force)and iswidely used for conveyingworkpiece.
● Pad material/Nitril rubber, silicon rubber, Urethane rubber and Fluoric rubber
Model No.
MVS-030ABMVS-035GMVS-070PMVS-SGNMVS-SCNMPS-V2CMPS-R2C
Pressure setting range(kPa)
Power supply voltage(V) Output
-10.1~-101.2-2.7~-101.20~-999hPa
-4 or less~18±2(Differential pressure)
-101~0-101~500
DC12~24
DC10.8~30
NPN open collectoroutput:1 point
NPN open collectoroutput:2 points
VACUUM SENSORChoose optional type from amongwide variations to meet yourapplication.
23
Directional Control Valves
3・4 PORT MINIATURESOLENOID VALVESS Series Model No.
SS23FSS23JSS231
Type Port Positions Port size Effective area(mm2)
Pressure range(MPa)
Direct 3 2M3M5
M5、Rc¹⁄₈
0.10.350.6
0~0.70~0.80~1
● Voltage/DC12, 24───SS23FAC100/110, 200/220V(50/60Hz), DC12, 24V───SS23JAC100/110, 200/220V(50/60Hz), DC24V───SS231
●Wiring/Lead wire, Connector with lead wire───SS23F, SS23JLead wire, Terminal grommet, Termminal conduit───SS231
Poppet
4 PORT MINIATURESOLENOID VALVEPC1B, RC1B SeriesCompact design with 10mm width,Latch type double solenoid.Low vacuum applicable.
Model No.
PCS241BPCL241BRCS241BRCL241B
Mounting Solenoid Positions Port size Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
In-linemounting
SingleLatch type
SingleLatch type
2M5
M31.0 -0.1~0.8
● Voltage/DC12, 24V●Wiring/Lead wire, Connector with lead wire
Direct Operate/Rubber Seal/Poppet
24
3・5 PORT MINIATURESOLENOID VALVEPC2,RC2 SeriesCompact design with 10mm width.Low power consumption of 0.5W.
Pilot Operate/Rubber Seal
Model No.
PCC232PCO232PCS242PCD242PCD342PCE342PCO342RCC232RCO232RCS242RCD242RCD342RCE342RCO342
Mounting Port Positions Port size Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
In-linemounting
3
5
3
5
Solenoid
Single
Double
Single
Double
2・NC2・NO
2
3・Closed center3・Exhaust center3・Pressure center
2・NC2・NO
2
3・Closed center3・Exhaust center3・Pressure center
M5
M3
1.8
0.8
2
0.8
0.4
0.2~0.7
0.2~0.7
0.4
● Voltage/DC12, 24V●Wiring/Lead wire, Connector with lead wire
3・5 PORTSOLENOID VALVEPC5,RC5 SeriesCompact design with 15mm width.Flap type solenoid is mounted toassure long service life.
Pilot Operate/Rubber Seal
Model No.
PCC235PCO235PCS245PCD245PCD345PCE345PCO345RCC235RCO235RCS245RCD245RCD345RCE345RCO345
Mounting Port Positions Port size Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
In-linemounting
3
5
3
5
Solenoid
Single
Double
Single
Double
2・NC2・NO
2
3・Closed center3・Exhaust center3・Pressure center
2・NC2・NO
2
3・Closed center3・Exhaust center3・Pressure center
M5Rc¹⁄₈
M5
3.7(M5)4(Rc¹⁄₈)
2.2(M5)2.5(Rc¹⁄₈)
4
2.2
0.2~0.80.2~0.7
(0.5W type)
0.2~0.80.2~0.7
(0.5W type)
● Voltage/AC100/110, 200/220V(50/60Hz), DC12, 24V───Standard typeDC24V───0.5W type
●Wiring/Lead wire, Connector with lead wire
5 PORTSOLENOID VALVEPC13,RC13 SeriesCompact design with 18mm width.Flap type solenoid is mounted toassure long service life.
Pilot Operate/Rubber Seal
Model No.
PCS2413PCD2413PCD3413PCE3413PCO3413RCS2413RCD2413RCD3413RCE3413RCO3413
Mounting Port Positions Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
In-linemounting
5
5
Solenoid
Single
Double
Single
Double
2
3・Closed center3・Exhaust center3・Pressure center
2
3・Closed center3・Exhaust center3・Pressure center
Rc¹⁄₄
Rc¹⁄₈
12
7.5
5
12.5
8
5● Voltage/AC100/110, 200/220V(50/60Hz), DC12, 24V───Standard type
DC24V───0.5W type●Wiring/Lead wire, Connector with lead wire
0.2~0.80.2~0.7
(0.5W type)
0.2~0.80.2~0.7
(0.5W type)
25
4・5 PORTLATCHED TYPESOLENOID VALVE
Rubber seal
Model No.
PCL245PCL2413RCL245RCL2413
Mounting Port Position Port size Effective area(mm2)
Pressure range(MPa)
Sub-baseIn-line
5
Solenoid
Latched type 2
M5、Rc¹⁄₈
Rc¹⁄₄
M5Rc¹⁄₈
3.5(M5)3.8(Rc¹⁄₈)
123.7
12.5
0.2~0.7
● Voltage/DC24●Wiring/Lead wire, connector with lead wire
5 PORTSOLENOID VALVEPC06,RC06 Series
Pilot Operate/Rubber Seal
Model No.
PCS2406PCD2406PCD3406PCE3406PCO3406RCS2406RCD2406RCD3406RCE3406RCO3406
Mounting Port Positions Port size Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
In-linemounting
5
5
Solenoid
Single
Double
Single
Double
2
3・Closed center3・Exhaust center3・Pressure center
2
3・Closed center3・Exhaust center3・Pressure center
Rc¹⁄₄
Rc¹⁄₄
10
11
12
90.2~0.8
0.2~0.8
● Voltage/AC100/110, 200/220V(50/60Hz), DC24V●Wiring/Lead wire, Terminal grommet, Terminal conduit, DIN connector
5 PORTSOLENOID VALVEPC08,RC08 Series
Pilot Operate/Rubber Seal
Model No.
PCS2408PCD2408PCD3408PCE3408PCO3408RCS2408RCD2408RCD3408RCE3408RCO3408
Mounting Port Positions Port size Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
In-linemounting
5
5
Solenoid
Single
Double
Single
Double
2
3・Closed center3・Exhaust center3・Pressure center
2
3・Closed center3・Exhaust center3・Pressure center
Rc³⁄₈
Rc³⁄₈
30
25
14
0.2~0.8
0.2~0.8
30
25
14● Voltage/AC100/110, 200/220V(50 60Hz), DC24V●Wiring/Lead wire, Terminal grommet, Terminal conduit, DIN connector
5 PORTSOLENOID VALVEPC15 Series
Pilot Operate/Rubber Seal
Model No.
PCS2415PCD2415PCD3415PCE3415PCO3415
Mounting Port Position Port size Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
5
Solenoid
Single
Single
2
3・Closed center3・Exhaust center3・Pressure center
Rc¹⁄₂
70
60
0.2~0.8
0.25~0.8
● Voltage/AC100/110, 200/220V(50/60Hz), DC24V●Wiring/Lead wire, Terminal grommet, Terminal conduit, DIN connector
26
3 PORT MINITURESOLENOID VALVEA00 Series
Direct Operate/Poppet
Model No.
A00SC23A00SC23JA00SO23A00SO23J
Mounting Port Port size Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
3
Positions
2・NC
2・NOM3
0.140.220.140.22
0~0.7
0~0.5
● Voltage/DC24, 12, 5V AC100/110V(50/60Hz)AC200/220V version of AC100/110V with voltage convertor respectively.
●Wiring/Plug-in connector
®
5 PORTSOLENOID VALVEA05,12,20 SeriesBody width remains the same, butthe flow rate 1.5 to 3 times morethan conventional valves.
Pilot Operate/Rubber Seal
Model No.
A05PS25A05PD25A05PD35A05PE35A05PO35A05RS25A05RD25A05RD35A05RE35A05RO35A12PS25A12PD25A12PD35A12PE35A12PO35A12RS25A12RD25A12RD35A12RE35A12RO35A20PS25A20PD25A20PD35A20PE35A20PO35A20RS25A20RD25A20RD35A20RE35A20RO35
Mounting Port Positions Port size Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
In-linemounting
Sub-basemounting
In-linemounting
Sub-basemounting
In-linemounting
5
5
5
5
5
5
Solenoid
Single
Double
Single
Single
Single
Single
Single
Double
Double
Double
Double
Double
2
3・Closed center3・Exhaust center3・Pressure center
2
2
2
2
2
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
Rc¹⁄₈
M5、C4、C6
Rc¹⁄₄
Rc¹⁄₈、C6、C8
Rc¹⁄₄、³⁄₈
Rc¹⁄₄、C8、C10
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
5.8
4.5
4
3.7
11.1
7.6
8.8
8.5
20.6
15.9
17.6
15.7
6.7
4.5
14.1
12
20.5
18.1● Voltage/DC24, 12, 5V AC100/110V(50/60Hz)
AC200/220V version of AC100/110V with voltage convertor respectively.●Wiring/Plug-in connector
27
Pilot Operate/Rubber Seal
Model No.
A05GS25A05GD25A05GD35A05GE35A05GO35A05FS25A05FD25A05FD35A05FE35A05FO35A12GS25A12GD25A12GD35A12GE35A12GO35A12FS25A12FD25A12FD35A12FE35A12FO35A20GS25A20GD25A20GD35A20GE35A20GO35A20FS25A20FD25A20FD35A20FE35A20FO35A05ES25A05ED25A05ED35A05EE35A05EO35A12ES25A12ED25A12ED35A12EE35A12EO35
Mounting Port Positions Port size Effective area(mm2)
Pressure range(MPa)
Sub-basemounting
In-linemounting
Sub-basemounting
In-linemounting
Sub-basemounting
In-linemounting
UNI-WIREmanifoldmounting
UNI-WIREmanifoldmounting
───
───
5
5
5
5
5
5
5
5
Solenoid
Single
Double
Single
Single
Single
Single
Single
Single
Single
Double
Double
Double
Double
Double
Double
Double
2
3・Closed center3・Exhaust center3・Pressure center
2
2
2
2
2
2
2
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
Rc¹⁄₈
M5、C4、C6
Rc¹⁄₄
Rc¹⁄₈、C6、C8
Rc¹⁄₄、³⁄₈
Rc¹⁄₄、C8、C10
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
0.15~0.70.1~0.7
0.2~0.7
5.8
4.5
4
3.7
11.1
7.6
8.8
8.5
20.6
15.9
17.6
15.7
5.8
4.5
11.1
7.6
6.7
4.5
14.1
12
20.5
18.1
6.7
14.1● Voltage/A※※G, A※※F:DC24, 12, 5V A※※E:DC24V●Wiring/Plug-in connector
28
5 PORTSOLENOID VALVEK20 SeriesReliable design combination oflapped sleeve & spool and flappertype pilot operator.Excellent for critical applicationwith high protection grade of IP65,flame resistance plastic materialenvelop and standard groundterminal connection.High pressure model up to 1.6 MPasupply pressure available.
Pilot Operate/Metal Seal
Model No.
K20GS25K20GO25K20GD35K20GE35K20GO35K20PS25K20PO25K20PD35K20PE35K20PO35K20RS25K20RO25K20RD35K20RE35K20RO35
Mounting Port Positions Port size Effective area(mm2)
Pressure range(MPa)
Manifoldmounting
In-linemounting
Sub-basemounting
5
5
5
Solenoid
Single
Double
Single
Single
Double
Double
2
3・Closed center3・Exhaust center3・Pressure center
2
2
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
───
Rc¹⁄₄
G¹⁄₄
Rc¹⁄₄
G¹⁄₄
0.15~0.8
0.15~0.8
0.15~0.8
18
18
15
● Voltage/AC100/110V, 200/220V(50/60Hz), DC24V●Wiring/Plug-in, DIN connector
K20 SERIES MANIFOLDThe 5 basic manifold models meet broad range of applications.In terms of wiring, individual, integrated connector and serial interface(UNI-WIRE)come with IP65 protection grade.Common auxiliary pilot version(except MFU manifold)is available.
3・5 PORTSOLENOID VALVEPM SeriesMain valve is of sleeve spool typewith metal seal.Interface between sub-base andbody is common to direct actingtype solenoid valve A series.
Pilot Operate/Metal Seal/Sub-base Mounting
Model No.
PMS246PMD246PMD346PME346PMS2306PMS2406PMD2406PMD3406PME3406PMS2308PMS2408PMD2408PMD3408PME3408PMS2310PMS2410PMD2410PMD3410PME3410PMS2315PMS2415PMD2415PMD3415PME3415PMS2325PMS2425PMD2425PMD3425PME3425
Port Positions Port size Effective area(mm2)
Pressure range(MPa)
5
5
5
5
5
5
3
3
3
3
3
Solenoid
Single
Single
Single
Single
Single
Single
Double
Double
Double
Double
Double
Double
2
2
2
2
2
2
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
Rc¹⁄₈、¹⁄₄
Rc¹⁄₄、³⁄₈
Rc³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc³⁄₄、1
Rc³⁄₄、1
Rc¹⁄₈ 6.5
11
22
38
80
190
12.5
12
30
25
50
75
170(Rc³⁄₄)200(Rc1)
165(Rc³⁄₄)190(Rc1)
0.15~1
0.2~0.8
0.2~0.8
0.2~0.8
0.2~0.8
0.2~0.8
0.2~0.7
0.2~0.7
0.2~0.7
0.2~0.7
0.2~0.7
● Voltage/AC100/110, 200/220V(50/60Hz), DC24V●Wiring/Lead wire, Terminal grommet, Terminal conduit, DIN connector
29
3・5 PORTSOLENOID VALVEA SeriesMain valve is of sleeve spool typewith metal seal.Heavy duty type solenoid valvemade of aluminium alloy.Usable in low vaccum application.
Direct Operate/Metal Seal/Sub-base Mounting
Model No.
AS2306AS2406AD2406AD3406ADE3406AS2308AS2408AD2408AD3408ADE3408AS2310AS2410AD2410AD3410ADE3410AS2315AS2415AD2415AD3415ADE3415
Port Positions Port size Effective area(mm2)
Pressure range(MPa)
5
5
5
5
3
3
3
3
Solenoid
Single
Single
Single
Single
Double
Double
Double
Double
2
2
2
2
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
Rc¹⁄₈、¹⁄₄
Rc¹⁄₄、³⁄₈
Rc¹⁄₄、³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
22
9
38Rc³⁄₈、¹⁄₂
80
10
9
30
25
50
75
-0.1~1
-0.1~1
-0.1~1
-0.1~1
● Voltage/AC100, 110, 200, 220V(50/60Hz)●Wiring/Lead wire conduit(06 type only)
Terminal conduit(08~15 type)
30
MANUALCONTROL VALVEMR SeriesRotary type selector valve withmetal seal.
Model No.
MR3400MR340MMR3401MR3402MR3403MRE3400MRE340MMRE3401MRE3402MRE3403
Port Positions Port size Effective area(mm2)
Pressure range(MPa)
4
4
3Closed center
3Exhaust center
Rc¹⁄₈
Rc¹⁄₄
Rc³⁄₈
Rc¹⁄₂
Rc³⁄₄
Rc¹⁄₈
Rc¹⁄₄
Rc³⁄₈
Rc¹⁄₂
Rc³⁄₄
203665
110230203665
110230
0~1
0~1
Metal Seal
MICRO VALVECompact hand-operated valveand mechanical operated valvesuitable for sequence controlsignals.
Actuator
Roller leverPush buttonToggle
Model No. Port Port size Orifice(mm)
Prassure range(MPa)
MMS232A-RLHMS232A-PHMH232A-T
3 M5 φ2 0~1
Metal Seal
Actuator
Adjustment rod
Rolleradjustment
Roller arm
Roller plunger
Plunger
Model No. Port Port size Effective area(mm2)
Prassure range(MPa)
MSV2306-VRMSV2406-VRMSV2306-VAMSV2406-VAMSV2306-RAMSV2406-RAMSV2306-RPMSV2406-RPMSV2306-PGMSV2406-PG
3535353535
Rc¹⁄₈、¹⁄₄10(Rc¹⁄₈)11(Rc¹⁄₄)
0~1
MANUAL VALVEM SeriesHand-operated valve with largeeffective sectional area designedfor direct control of actuator.
Actuator
Selector
Long leverselector
Flat type push buttonMedium-sizeflat typepush buttonLarge-sizeflat typepush button
Model No. Port Port size Effective area(mm2)
Prassure range(MPa)
HHV2306-SHHV2406-SHHV2306-SLHHV2406-SLHSV2306-FHSV2406-FHSV2306-MHSV2406-MHSV2306-LHSV2406-L
3535353535
Rc¹⁄₈、¹⁄₄10(Rc¹⁄₈)11(Rc¹⁄₄)
0~1
Metal Seal/In-line Mounting
MECHANICAL VALVEM SeriesMechanical valve with largeeffective sectional area.Direct control of actuator at fixedsequence is possible.
Metal Seal/In-line Mounting
31
3・5 PORTAIR OPERATED VALVEVC Series
Rubber Seal/Sub-base mounting
Model No.
VCC232VCO232VCS242VCD242VCD342VCE342VCO342VCC235VCO235VCS245VCD245VCD345VCE345VCO345VCS2413VCD2413VCD3413VCE3413VCO3413VCS2408VCD2408VCD3408VCE3408VCO3408VCS2415VCD2415VCD3415VCE3415VCO3415
Port Position Port size Effective area(mm2)
Pressure range(MPa)
Pilot pressure(MPa)
3
5
3
5
5
5
5
2
2・NC2・NO
2・NC2・NO
3・Closed center3・Exhaust center3・Pressure center
2
3・Closed center3・Exhaust center3・Pressure center
M5
M5、Rc¹⁄₈
Rc¹⁄₄
Rc³⁄₈
Rc¹⁄₂
1.8
0.8
3.7(M5)4(Rc¹⁄₈)
2.2(M5)2.5(Rc¹⁄₈)
12
30
70
7.5
25
60
0.2~0.7
0.2~0.7
0.2~0.8
0.2~0.8
0.2~0.8
0.2~0.8
0.25~0.8
0.2~0.8
0~0.7
0~0.8
0.2~0.8
0~0.8
0~0.8
0~0.8
2
2
2
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・Closed center3・Exhaust center3・Pressure center
3・5 PORTAIR OPERATED VALVEYC Series
Rubber Seal/In-line mounting
Model No.
YCC232YCO232YCS242YCD242YCD342YCE342YCO342YCC235YCO235YCS245YCD245YCD345YCE345YCO345YCS2413YCD2413YCD3413YCE3413YCO3413
Port Position Port size Effective area(mm2)
Pressure range(MPa)
Pilot pressure(MPa)
3
5
3
5
2
3・Closed center3・Exhaust center3・Pressure center
2
2・NC2・NO
2・NC2・NO
3・Closed center3・Exhaust center3・Pressure center
M5
M5、Rc¹⁄₈
Rc¹⁄₈
1.8
0.8
4
2.2
12.5
8
0.2~0.7
0.2~0.7
0.2~0.8
0.2~0.8
0.2~0.8
0~0.7
0~0.8
0.2~0.8
0~0.8
2
3・Closed center3・Exhaust center3・Pressure center
32
5 PORTAIR OPELATED VALVEVM Series
Metal Seal/Sub-base Mounting
Model No.
VMS246VMD246VMD346VME346VMS2406VMD2406VMD3406VME3406VMS2408VMD2408VMD3408VME3408VMS2410VMD2410VMD3410VME3410VMS2415VMD2415VMD3415VME3415VMS2425VMD2425VMD3425VME3425
Port Positions Port size Effective area(mm2)
Pilot pressure(MPa)
Pressure range(MPa)
5
5
5
5
5
5
2
2
2
2
2
2
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
3・Closed center3・Exhaust center
Rc¹⁄₈
Rc¹⁄₈、¹⁄₄
Rc¹⁄₄、³⁄₈
Rc³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc³⁄₄、1
12.5
6.5 -0.1~1
-0.1~1
-0.1~1
-0.1~1
-0.1~1
-0.1~1
12
30
25
50
75
0.15~1
0.2~0.8
0.2~0.8
0.2~0.8
0.2~0.8
0.2~0.8
3・5 PORTAIR OPERATED VALVEV Series Model No.
VS2306VP2306VS2406VP2406VS2410VP2410
Port Positions Port size Effective area(mm2)
Pressure range(MPa)
3
5
5
2
2
Rc¹⁄₈、¹⁄₄
Rc¹⁄₄、³⁄₈、¹⁄₂
10(Rc¹⁄₈)11(Rc¹⁄₄)
40
-0.1~1
-0.1~1
Pilot pressure(MPa)
0.15~1
0.15~1
Metal Seal/In-line Mounting
170(Rc³⁄₄)200(Rc1)
165(Rc³⁄₄)190(Rc1)
33
Other Equipment
SPEED CONTROLLERWITH PUSH-IN FITTINGFor nylon and polyurethane tubes.Sealant is coated on threadedportion, eliminating need forsealing tape.
Model No.Universal type Elbow type
MB4R-M3MB4R-M5MB4R-01MB6R-M5MB6R-01B6R-M5SCB6R-01SCB6R-02SCB8R-01SCB8R-02SCB8R-03SCB10R-02SCB10R-03SCB10R-04SCB12R-03SCB12R-04SC
M4R-M3M4R-M5M4R-01M6R-M5M6R-016R-M5SC6R-01SC6R-02SC8R-01SC8R-02SC8R-03SC10R-02SC10R-03SC10R-04SC12R-03SC12R-04SC
Screw size Applicable tube No. Pressure range(MPa)
M3M5
Rc¹⁄₈
M5Rc¹⁄₈
M5Rc¹⁄₈
Rc¹⁄₄
Rc¹⁄₈
Rc¹⁄₄
Rc³⁄₈
Rc¹⁄₄
Rc³⁄₈
Rc¹⁄₂
Rc³⁄₈
Rc¹⁄₂
TP-4、TN-4
TP-6、TN-6
TP-8、TN-8
TP-10、TN-10
TP-12、TN-12
MAX.0.7
●Meter-out type and meter-in type availabe
SPEED CONTROLLEROutstanding controllabilityattainable in low flow rate region.
Model No. Type
SP-Z-M3SPER-Z-M3SPSR-Z-M3SPR-Z-M3SP-H-M5SPE-H-M5SPF-H-M5SPER-H-M5SPSR-H-M5SPR-H-M5SP-2H-1、2SPE-2H-1、2SP-06-1、2SPE-06-1、2SPE-10-3SPE-10-34SP-15-3、4、6SP-20-6、8
StraightUniversal elbow
Universal
StraightElbowFlatUniversal elbow
Universal
StraightElbowStraightElbow
Elbow
StraightStraight
Port size(Screw size)
Effective area(mm2)
Pressure range(MPa)
M5
Rc¹⁄₈、¹⁄₄
R、Rc¹⁄₈、¹⁄₄
Rc¹⁄₈、¹⁄₄
R、Rc¹⁄₈、¹⁄₄
R、Rc³⁄₈
External R¹⁄₂、Internal Rc³⁄₈
Rc³⁄₈、¹⁄₂、³⁄₄
Rc³⁄₄、1
M3 0.4
1.0
2.7
14、179、12
3945
64、69、70155、174
0~0.8
0~1
METERING VALVE Model No. Type
MV-M5MV-1MV-2MV-3MV-4MV-6MV-8
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
R³⁄₄
R1
34
AIR MUFFLER Model No.
SL-M5SL-1SL-2LSL-6SL-8AS-6AS-8AS-10AS-15
Screw size Effective area(mm2)
Exhaust noise reduction(dB)
M5R¹⁄₈
R¹⁄₄
R³⁄₄
R1R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
4123080
150164080
106
Min.20
Min.25
Min.30
CLEANUP MUFFLERRemoves exhaust noise and oilmist to prevent deterioration ofworking environment.
Model No.
CM-03CM-06CM-08
Port size Max.flow(m3/min(ANR))
Pressure range(MPa)
Rc³⁄₈
Rc³⁄₄
Rc1
45016003000
0~1
Oil mist removal(%)
99.9
MINIATURE IN-LINEFILTER FOR VACUUM
Model No.
LF-M5ALF-M5AALF-M5SMFL-M5S
Port size Pressure range(kPa)
filter element(μm)
M5-100~0
-100~400
6040
ROTARY JOINTLiquid supply to the rotatingobjects is easy even in a highpressure or a high speed.
Model No.
RJC-061H
RJC-062L
RJH-062M
RJC-122L
RJH-122M
Port size Rated pressure(MPa)
Max.revolution(rpm)
Pass dia.(mm) Numbers of pass
Rc³⁄₈
Rc³⁄₈
Rc¹⁄₄
Rc¹⁄₄
Rc¹⁄₄
Fluid
HydraulicAir
HydraulicAir
HydraulicHydraulic
AirHydraulic
21131
1431
14
3000
3000
φ6
φ6
1
2
3000 φ6 2
2000 φ12 2
2000 φ12 2
35
Model No.
T70C3800S/511HS/513S/514
Port size Effective area(mm2)
Pressure range(MPa) Note
A port G³⁄₈、BC port G³⁄₈
A port G¹⁄₂、BC port G³⁄₄
A port G¹⁄₄、B port G³⁄₈
A port G¹⁄₂、B port G³⁄₄
A→B70 B→C101A→B73 B→C200A→B33 B→C70A→B71 B→C155
0.05~10.07~1
0.07~0.7
-
With muffler
QUICK EXHAUSTVALVE
Model No.
T65C1800T65C2800
Port size Effective area(mm2)
Pressure range(MPa)
G¹⁄₈
G¹⁄₄
7.711.8
0.07~0.98
SHUTTLE VALVE
Model No.
ST-10ST-15ST-25
Port size Effective area(mm2)
Pressure range(MPa)
Rc¹⁄₄、³⁄₈
Rc¹⁄₂
Rc³⁄₄、1
4570
1900.15~1
PERMA-STOPConnects cylinder and valve tostop cylinder halfway, preventingadverse effect by leak in valve.
Model No.
T55C1800T55C2800T55C4800TS/523TS/524
Port size Effective area(mm2)
Pressure range(MPa)
Cracking pressure(MPa)
G¹⁄₈
G¹⁄₄
G¹⁄₂
G³⁄₄
G1
141890
195317
0.01~1
0.07~1
0.005
0.03
CHECK VALVE
36
Type
Male connector
Female connector
Male elbow
Long male elbow
Male branch tee
Male run tee
UnionUnion elbowUnion teeBulk head union
Model ConnectionApplicable tube 0.D.φ4 φ6 φ8 φ10 φ12
M
○○○
○○
○○○
○○
○○○
○○○
○○○○
○○○○
○○○
○○○○
○○
○○○○
○○○○
○○○○
○○○
○○
○○○
○○○
○○○
○○○
○○○○
○○○○
○○○
○○○○
○○○
○○○○
○○○○○○○○
○○○
○○○
○○○
○○○
○○○
○○○○○○○
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
F
R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
ML
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
M2L
R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
MT
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
RT
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
UULUTBU
----
Type
Female bulk
Branch Y
Union Y ofdefferent dia.
Y connector
Reducer
L connector
Tee connector
Model ConnectionApplicable tube 0.D.φ4 φ6 φ8 φ10 φ12
FB○
○○○
○
○
○○○
○
○
○
○○○○
○○
○
○○○
○
○
○
○○○
○
○
○
○○
○
○
○
○○○○○
○
○
○
○
○
○
○○○○
○
○
○
○
R¹⁄₈
R¹⁄₄
R³⁄₈
BY
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
Union Y UY -
UY
φ4φ6φ8φ10
Y
φ4φ6φ8φ10φ12
RC
φ6φ8φ10φ12
LC
φ4φ6φ8φ10φ12
TC
φ4φ6φ8φ10φ12
Type
Single banjo
Single banjo
Double banjo
Double banjo
Double banjo
Triple banjo
Triple banjo
Model ConnectionApplicable tube 0.D.φ4 φ6 φ8 φ10 φ12
S1
○○○
○○○
○○
○○
○○
○
○
○
○
○○○○
○○○○
○○
○○
○○
○○
○○
○○
○○
○○○
○○○
○○○
○○○
○○○
○○○
○○○
○○○
○○○
○○○○
○○○○
○○
○○
○○
○○
○○
○○
○○
○○○
○○○
○○
○○
○○
○○
○○
○○
○○
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
D1
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
S2
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
S1D1
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
D2
M5R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
S3
R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
S2D1
R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
Triple banjo S1D2
R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
Triple banjo D3
R¹⁄₈
R¹⁄₄
R³⁄₈
R¹⁄₂
PUSH-IN FITTINGFor nylon and polyurethane tubes.Sealant is coated on threadedportion, eliminating need forsealing tape.
37
MINIATURE FITTINGFor nylon and polyrethane tubes.
Type Applicable tube material
Tubenipple
Barbconnector
Barbnipple
universalbarb elbow
Barb tee
Barb joint
TN-04-M5TN-06-M5TU-04-M5TU-06-M5BC-03-M3BC-04-M3BC-03-M5BC-03-M3BC-04-M3BC-03-M5
BN-03
BE-03-M3
BT-03
BJ-03
M5
M5
M3○
○
○
○
○
○
○
○
○
○
○
○
○
○
○
○
○
○
M5
M3
M5
-
M3
-
φ4
Nylon
Polyurethan
Nylon
Polyurethan
NylonPolyurethanNylonPolyurethanNylonPolyurethanNylonPolyurethan
Model No. ConnectionApplicable tube O.D.
φ3.2 φ3.5 φ4 φ6
Type Model No.
Universal elbow
Universal tee
Bushing
Nipple
Plug
Extension fittingPanel fittingTerminal
Gasket
M5M3M5
M5-M3R¹⁄₈-M5
M3M5M3M5M3M3
Rc¹⁄₈-M3For M3For M5
UE-M5UT-M3UT-M5B-M3B-M5N-M3N-M5P-M3P-M5LN-M3PJ-M3TM-M3G-M3G-M5
Connection
38
TUBE
Model O. D.(mm)
TN
○
○
○
○
○○○○○○○
○○○○○○○○
○○○○○○○
3.2
4
6
81012
I. D.(mm)
2.22.5344.567.59
Applicable fitting Length
Barbfitting
Miniaturefitting
Instantfitting 20m 100m
Nylon tube
●Color/Black, White, Yellow, Red, Green
SPIRAL TUBE Model O. D.(mm)
TPS
○○○○○
468
1012
I. D.(mm)
2456.58
Number of turns15
○○○○○
30○○○○○
45
MULTI STRAIGHT TUBE Model O. D.(mm)
MP
○○○○○
468
1012
I. D.(mm)
2456.58
Cores2
○○○○○
4○○○○○
○○○○○
6 8
Model O. D.(mm)
TP
△
○○
○
○○○○○○
○○○○○○○
○
○○○○○○
33.5
4
68
1012
I. D.(mm)
1.8222.5456.58
Applicable fitting Length
Barbfitting
Miniaturefitting
Instantfitting 20m 25m 100m
Polyurethane tube
●Color/Black, White, Yellow, Red, Green, Blue, Clear, Light green
39
Air Cleaning Equipment
Model No.
C45-01、02、03C45D-01、02、03C45W-01、02、03C45L-01、02、03C45LD-01、02、03C45LW-01、02、03C65-02、03、04C65L-02、03、04C105-04、06C105D-04、06C105W-04、06C105L-04、06C105LD-04、06C105LW-04、06C55-2、3、4C55-2、3、4DC55-2、3、4WC55-2、3、4LC55-2、3、4DLC55-2、3、4WL
Port sizeComponents
Air Filter Air Regulator Air LubricatorFilter element(μm)
Reduced pressure range(MPa) Option
Rc¹⁄₈、¹⁄₄、³⁄₈
Rc¹⁄₄、³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc¹⁄₄、³⁄₈、¹⁄₂
F45-01、02、03F45D-01、02、03F45W-01、02、03F45-01、02、03F45D-01、02、03F45W-01、02、03
R45-01、02、03
R45L-01、02、03
R65-02、03、04R65L-02、03、04
R105-04、06
R105L-04、06
R55-2、3、4
R55-2、3、4L
F65-02、03、04
F105-04、06F105D-04、06F105W-04、06F105、04、06F105D-04、06F105W-04、06
L45-01、02、03L45D-01、02、03L45W-01、02、03L45-01、02、03L45D-01、02、03L45W-01、02、03
5(Standard)20
0.03~0.8
0.02~0.42
0.03~0.8
0.02~0.42
0.03~0.80.02~0.42
0.03~0.8
0.02~0.42 BracketManual drainOnepush drainCombination drainDrainmaster(45)Automatic drain
(65,105)
BracktPressure gaugeAutomatic drainSpring drain
55(Standard)40
55(Standard)40
L65-02、03、04
L105-04、06L105D-04、06L105W-04、06L105-04、06L105D-04、06L105W-04、06
F55-2、3、4F55-2、3、4DF55-2、3、4WF55-2、3、4F55-2、3、4DF55-2、3、4W
L55-2、3、4L55-2、3、4DL55-2、3、4WL55-2、3、4L55-2、3、4DL55-2、3、4W
QUBE SeriesAIR COMBINATIONUNITModular type FRL unit consistingof air filter, air regulator and airlubricator.
(Note)W:Metal bowl encircled with sight glassD:Metal bowl without sight glass
Model No.
U45-01、02、03U45D-01、02、03U45W-01、02、03U45L-01、02、03U45LD-01、02、03U45LW-01、02、03U65-02、03、04U65L-02、03、04U105-04、06U105D-04、06U105W-04、06U105L-04、06U105LD-04、06U105LW-04、06U55-2、3、4U55-2、3、4DU55-2、3、4WU55-2、3、4LU55-2、3、4DLU55-2、3、4WL
Port sizeComponents
Intergal Filter Regulator Air LubricatorFilter element(μm)
Reduced pressure range(MPa) Option
Rc¹⁄₈、¹⁄₄、³⁄₈
Rc¹⁄₄、³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc¹⁄₄、³⁄₈、¹⁄₂
B45-01、02、03B45D-01、02、03B45W-01、02、03B45L-01、02、03B45LD-01、02、03B45LW-01、02、03B65-02、03、04B65L-02、03、04B105-04、06B105D-04、06B105W-04、06B105L-04、06B105LD-04、06B105LW-04、06B55-2、3、4B55-2、3、4DB55-2、3、4WB55-2、3、4LB55-2、3、4DLB55-2、3、4WL
L45-01、02、03L45D-01、02、03L45W-01、02、03L45-01、02、03L45D-01、02、03L45W-01、02、03
5(Standard)20
0.03~0.8
0.02~0.42
0.03~0.8
0.02~0.42
0.03~0.80.02~0.42
0.03~0.8
0.02~0.42BracketManual drainSpring drainOnepush drainCombination drainDrainmaster(45)Automatic drain
(65,105)
BracketPressure gaugeAutomatic drainSpring drain
55(Standard)40
55(Standard)40
L65-02、03、04
L105-04、06L105D-04、06L105W-04、06L105-04、06L105D-04、06L105W-04、06L55-2、3、4L55-2、3、4DL55-2、3、4WL55-2、3、4L55-2、3、4DL55-2、3、4W
QUBE SeriesAIR COMBINATIONUNITFRL unit consisting to integralFilter-Regulator and Air Lubricator.
(Note)W:Metal bowl encircled with sight glassD:Metal bowl without sight glass
40
QUBE SeriesAIR FILTERSeparates and removes waterand dust in compressed air.
Model No.
F45-01、02、03F45D-01、02、03F45W-01、02、03F65-02、03、04F105-04、06F105D-04、06F105W-04、06F55-2、3、4F55-2、3、4DF55-2、3、4W
Port size Filter element(μm) OptionBowl capacity
(cm3)
Rc¹⁄₈、¹⁄₄、³⁄₈
Rc¹⁄₄、³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc¹⁄₄、³⁄₈、¹⁄₂
22
45
140
47
5(Standard)20
05(Standard)40
BracketManual drainSpring drainOnepush drainCombination drainDrainmaster(45)Automatic drain(65,105)
BracketAutomatic drainSpring drain
QUBE SeriesCOALESCING FILTERHigh-performance air filter capableof removing more than 99.99998%of aerosol consisting of water andoil of more than 0.01μm.
Model No.
M45-01、02、03M45D-01、02、03M45W-01、02、03M65-02、03、04M105-04、06M105D-04、06M105W-04、06M55-2、3、4M55-2、3、4DM55-2、3、4W
Port size Filter element(μm) OptionBowl capacity
(cm3)
Rc¹⁄₈、¹⁄₄、³⁄₈
Rc¹⁄₄、³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc¹⁄₄、³⁄₈、¹⁄₂
22
45
140
45
0.01
BracketManual drainSpring drainOnepush drainCombination drainDrainmaster(45)Automatic drain(65,105)
BracketAutomatic drainSpring drain
Recommeded max.flow(R/min(ANR))
250
340
750
340
(Note)W:Metal bowl encircled with sight glassD:Metal bowl without sight glass
(Note)W:Metal bowl encircled with sight glassD:Metal bowl without sight glass
QUBE SeriesSLUDGE FILTERSeparates and removes sludgeand drain produced by compressor.
Model No.
S45-01、02、03S45D-01、02、03S45W-01、02、03S65-02、03、04S105-04、06S105D-04、06S105W-04、06S55-2、3、4S55-2、3、4DS55-2、3、4W
Port size Filter element(μm) OptionBowl capacity
(cm3)
Rc¹⁄₈、¹⁄₄、³⁄₈
Rc¹⁄₄、³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc¹⁄₄、³⁄₈、¹⁄₂
22
45
100
45
0.3
BracketManual drainSpring drainOnepush drainCombination drainDrainmaster(45)Automatic drain(65,105)
BracketAutomatic drainSpring drain
Recommeded max.flow(R/min(ANR))
250
340
750
340
(Note)W:Metal bowl encircled with sight glassD:Metal bowl without sight glass
QUBE SeriesAIR REGULATOREasy-to-use and high-performanceregulator with one-touch lockingadjust knob.
Model No.
R45-01、02、03R45L-01、02、03R65-02、03、04R65L-02、03、04R105-04、06R105L-04、06R55-2、3、4R55-2、3、4L
Port size Max. supply pressure(MPa) OptionReduced pressure range
(MPa)
Rc¹⁄₈、¹⁄₄、³⁄₈
Rc¹⁄₄、³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc¹⁄₄、³⁄₈、¹⁄₂
0.03~0.80.02~0.420.03~0.80.02~0.420.03~0.80.02~0.420.03~0.80.02~0.42
1
BracketPressure gaugeRing for Panel-mounting
41
(Note)W:Metal bowl encircled with sight glassD:Metal bowl without sight glass
QUBE SeriesAIR LUBRICATORSprays lubricating oil intocompressed air.
Model No.
L45-01、02、03L45D-01、02、03L45W-01、02、03L65-02、03、04L105-04、06L105D-04、06L105W-04、06L55-2、3、4L55-2、3、4DL55-2、3、4W
Port size Min air flow for oil dropping(R/min(ANR)) OptionBowl capacity
(cm3)
Rc¹⁄₈、¹⁄₄、³⁄₈
Rc¹⁄₄、³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc¹⁄₄、³⁄₈、¹⁄₂
43
75
240
78
50
80
50
Bracket
QUBE SeriesINTEGRALFILTER-REGULATORCompact design with united airfilter and air regulator.
Model No.
B45-01、02、03B45D-01、02、03B45W-01、02、03B45L-01、02、03B45LD-01、02、03B45LW-01、02、03B65-02、03 04B65L-02、03、04B105-04、06B105D-04、06B105W-04、06B105L-04、06B105LD-04、06B105LW-04、06B55-2、3、4B55-2、3、4DB55-2、3、4WB55-2、3、4LB55-2、3、4DLB55-2、3、4WL
Port size Reduced pressure range(MPa) OptionFilter element
(μm)
Rc¹⁄₈、¹⁄₄、³⁄₈
Rc¹⁄₄、³⁄₈、¹⁄₂
Rc¹⁄₂、³⁄₄
Rc¹⁄₄、³⁄₈、¹⁄₂
22
047
140
47
0.03~0.8
0.02~0.42
0.03~0.80.02~0.42
0.03~0.8
0.02~0.42
0.03~0.8
0.02~0.42
BracketManual drainSpring drainOnepush drainCombination drainDrainmaster(45)Automatic drain(65,105)
BracketPressure gaugeAutomatic drainSpring drainRing for panel-monuting
Bowl capacity(cm3)
5(Standard)20
5(Standard)40
5(Standard)20
(Note)W:Metal bowl encircled with sight glassD:Metal bowl without sight glass
Model No.
SV35-01SV35-02SV35-03SV75-02SV75-03SV75-04SV105-04SV105-06
Port size Applicable unit
Rc¹⁄₈
Rc¹⁄₄
Rc³⁄₈
Rc¹⁄₄
Rc³⁄₈
Rc¹⁄₂
Rc¹⁄₂
Rc³⁄₄
QUBE45 series
QUBE65 series
QUBE105 series
QUBE SeriesSHUT-OFF VALVE3-way valve provided to stopmain pressure and exhaustremaining pressure in pipesconnecting to shut-off valve.
42
Model No.
C528(D)-02
Port sizeComponents
Air Filter Air Regulator Air LubricatorFilter element(μm)
Reduced pressure range(MPa) Option
Rc¹⁄₄ F504(D)-02 R364-02 L508(D)-025
20(Standard) 0.02~0.75BracketPressure gaugeDrainmasterSpring drain
(Note)C528:Plastic bowlC528D:Metal bowl without sight glass
Model No.
U558(D)-02
Port sizeComponents
Intergal Filter Regulator Air LubricatorFilter element(μm)
Reduced pressure range(MPa) Option
Rc¹⁄₄ B549(D)-02 L508(D)-025
20(Standard) 0.02~0.75BracketPressure gaugeDrainmasterSpring drain
AIR COMBINATIONUNITMINIATURE TYPEFRL unit consisting to integralFilter-Regulator and Air Lubricator. (Note)U558:Plastic bowl
U558D:Metal bowl without sight glass
(Note)F504:Plastic bowlF504D:Metal bowl without sight glass
AIR FILTERMINIATURE TYPESeparates and removes waterand dust in compressed air.
Model No.
F504-01、02F504D-01、02
Port size Filter element(μm) OptionBowl capacity
(cm3)
Rc¹⁄₈、¹⁄₄
Rc¹⁄₈、¹⁄₄10 5(Standard)
20DrainmasterSpring drain
(Note)S504:Plastic bowlS504D:Metal bowl without sight glass
SLUDGE FILTERSeparates and removes sludgeand drain produced bycompressor.
Model No.
S504-01、02S504D-01、02
Port size Filter element(μm) OptionRecommended max. flow
(R/min(ANR))
Rc¹⁄₈、¹⁄₄
Rc¹⁄₈、¹⁄₄250 0.3
DrainmasterSpring drain
(Note)M500:Plastic bowlM500D:Metal bowl without sight glass
MICRO MIST FILTERHigh-performance air filter capableof removing more than 99.99998%of aerosol consisting of water andoil of more than 0.01μm.
Model No.
M500-01、02M500D-01、02
Port size Filter element(μm) OptionRecommended max. flow
(R/min(ANR))
Rc¹⁄₈、¹⁄₄
Rc¹⁄₈、¹⁄₄250 0.01
Oil mist removal(%)
99.99998DrainmasterSpring drain
AIR COMBINATIONUNITMINIATURE TYPEModular type FRL unit consistingof air filter, air regulator and airlubricator.
43
(Note)L508:Plastic bowlL508D:Metal bowl without sight glass
AIR LUBRICATORMINIATURE TYPE
Model No.
L508-02L508D-02
Port size Max.supply pressure(MPa) OptionBowl capacity
(cm3)
Rc¹⁄₄ 3011.2
Bracket
(Note)B549:Plastic bowlB549D:Metal bowl without sight glass
INTEGRALFILTER-REGULATORMINIATURE TYPE
Model No.
B549-01、02B549D-01、02
Port size Filter element(μm) OptionBowl capacity
(cm3)
Rc¹⁄₈、¹⁄₄5(Standard)
2010
Reduced pressure range(MPa)
0.02~0.75BracketSpring drainDrainmasterPressure gauge
(Note)Direct mount pressure gauge for QUBE-45, 65 and 105 series is attached mounting screws.
PRESSURE GAUGEFor air regulators
Model No.
G25-52G10-52G10-51G10-41G10-21G10-41AG10-21AG10-3DG06-41G06-3DG04-52G04-51G04-41G025-41G01-41
Pressureindicating range
Mounting positionScrew at behind Screw at bottom Direct
Screw size
2.5MPa
1MPa
0.6MPa
0.4MPa
0.25MPa0.1MPa
R¹⁄₄
R¹⁄₄
R¹⁄₈
R¹⁄₈
-R¹⁄₈
-R¹⁄₄
R¹⁄₈
R¹⁄₈
R¹⁄₈
○○
○
-
-○-○
○
○○
--
-
○
----
-
--
--
-
-
○-○-
-
--
Model No.
P130-02
Port size(Screw size)
Redured pressure range(MPa)
Rc¹⁄₄(R¹⁄₄) 0~0.07
RELIEF VALVE
AIR REGULATORMINIATURE TYPE
Model No.
R364-01、02R364L-01、02
Port size Max.supply pressure(MPa) OptionReduced pressure range
(MPa)
Rc¹⁄₈、¹⁄₄0.02~0.750.01~0.3
1.4BracketPressure gauge
44
Model No.
KAD-3EKAD-5GKAD-10GKAD-15EKAD-30EKAD-50E
Air flow(m3/min(ANR))
Applicable compressor(HP)
Inlet aircondition
Max.pressure(MPa)
Outlet airdew point(℃)
Power voltage(V Hz) Connection
0.30.51.11.53.76.3
35
10153050
Pressure 0.7MPaInlet airtemperature 35℃Ambienttemperature 32℃
110underpressure
1 phase 10050/60
1 phase 20050/60
3 phase 20050/60
Rc³⁄₈
Rc¹⁄₂
Rc³⁄₄
R³⁄₄
1B union1¹⁄₂B union
AIR DRYERKAD SeriesThis is the air dryer which isozone safety with R-134a(Ozonerupture modulus 0)as refrigerant.
●Standard type
Model No.
KAD-5SGKAD-10SGKAD-15SEKAD-20SE IIKAD-30SEKAD-50SEKAD-100SE
Air flow(m3/min(ANR))
Applicable compressor(HP)
Inlet aircondition
Max.pressure(MPa)
Outlet airdew point(℃)
Power voltage(V Hz) Connection
0.51.11.52.23.76.312.3
51015203050
100
Inlet air conditionPressure 0.7MPaInlet airtemperature 55℃Ambienttemperature 30℃
15~14underpressure
1 phase 20050/60
1 phase 10050/60
3 phase 20050/60
Rc¹⁄₂
Rc³⁄₄
R³⁄₄
R11B union1¹⁄₂B union2B union
●Higher temperature(max.80℃)inlet type
MEMBRANE TYPEAIR DRYERQ-FIT DRYERKMD SeriesNo external power sourcerequired.Freon free, environmentallyfriendly air dryer.
Model No.
KMD2KMD5
Port size Inlet air temperature(℃)
Purge air flow rate(m3/min(ANR))
Pressure range(MPa)
Rc¹⁄₄、³⁄₈
Rc¹⁄₂0.2~0.8 5~50
Outlet air flow rate(m3/min(ANR))
20~20050~500
24(Std.)、1050(Std.)、24
http://www.kuroda-precision.co.jp/e-top
Access KURODA Home Page
FA Internet Service
Download Service
User Registration
Download
CD-ROM(CAD DATA LIBRARY)
CAD DATA LIBRARYLatest data is contained.
Customer
KURODA Sales Rep
KURODA Home Page Internet
http://www.kuroda-precision.co.jp/e-top
45
INTRODUCTION OF KURODA CAD DATA LIBRARY
KURODA CAD DATA LIBRARY contains CAD data of pneumatic equipment, ball screws,support units andsingle-axis modules.In addition, various tools for selecting pneumatic equipment and ball screws are listed in it. Please use thislibrary to improve the design performance of your FA related equipment.
CAD Data Library is available from CD-ROM supplied by our company or our company's Home Page viaInternet. For a CD-ROM, please ask KURODA sales representative in charge of your company.
How to Obtain CAD Data Library
How to Download from Home Page CAD Data of Main Pneumatic Equipment①Pneumatic Actuators
Series of air cylinders and rotary actuators are listed inCAD DAT LIBRARY.
②Pneumatic Grippers/Vacuum EquipmentSeries of parallel grippers, rotary opening/closinggrippers, vacuum units and pads are listed in it.
③Control ValvesSeries of solenoid valves such as ADEX VALVEs arelisted in it.
④Other EquipmentSeries of speed controllers, joints, etc. are listed in it.⑤Air Cleaning Equipment
Series of FRL combination QUBE are listed in it.
Kind of CAD data
Type of data CD-ROM
○
○
Home Page
○*2○*2
DXF
DWG(AUTO CAD)*1
r12
r12
※1:Name of CAD software is our company's registered trademark.※2:Some of DWG type product data are not contained
(Note) CAD data is classified by each product andcontained in a self-extracting exectable file format(.exe).
Recommended